R

INSTALLATION AND OPERATING INSTRUCTIONS

PUMP

Model: DTSE and LTSE

Please complete this information and retain this manual for the life of the equipment. For

Warranty Service and/or Parts, this information is required.

Model Number Serial Number Date Purchased

!

WARNING: Improper installation, operation, service or maintenance can cause property damage, injury or death. Read and understand these instructions thoroughly before positioning, installing, maintaining or servicing this equipment.

!

P/N 88751-50 9/05

APW WYOTT Foodservice Equipment Company

P.O. Box 1829

Cheyenne, WY 82003

+1 (307) 634-5801 Phone

+1(307) 637-8071 Fax

+1 (800) 752-0863 Toll Free www.apwwyott.com

1

1.

2.

3.

INSTALLATION

Clean the pump thoroughly before using it for the first time, according to the cleaning instructions below.

To install the lid, hold the pump upright, unscrew the two retaining nuts, and remove the piston rod and spout from the lower half of the pump.

For the LTSE lever action pump, mount the lever to the lid, and then place that assembly onto the lower half of the pump and hand-tighten the piston retaining nut. Replace the spout and handtighten the spout retaining nut. (Make certain you replace the stainless steel ball, O-ring and piston seal.)

4.

For the DTSE direct action pump, place the lid on the lower half of the pump, and replace the spout

(ensuring the O-ring and ball are in place), and hand-tighten the retaining nut. Replace the piston rod and hand tighten the retaining nut. (Make certain you replace the piston seal.)

OPERATION

To operate the pump, press the knob or lever down until it stops, then release it. A brisk, smooth stroke delivers the condiment uniformly.

CLEANING

4.

5.

NOTE: If the pump is used with a heated container, allow it to cool before disassembling or cleaning it.

Clean the pump daily. Note the way it comes apart so you can reassemble it In reverse order.

1.

2.

While holding the pump upright, unscrew the spout retaining nut and remove the spout, ball and Oring.

Unscrew the piston retaining nut and remove the piston rod, piston seal, spring and ball. (For the lTSE model, the lid is part of this assembly.)

3.

Clean all parts thoroughly in a detergent solution and then a sanitizing solution, using the brushes provided.

Rinse the parts in hot water and allow them to air dry.

Reassemble using reverse procedure.

2

ITEM

7

8

5

6

3

4

1

2

9

10

11

12

13

14

15

16

17

PART NUMBER

43689-58

21132-00

43680-64

86604-00

34680-70

43680-79

89507-10

43680-48

N/A

43680-63

87314-00

43680-78

43680-11

43680-75

43680-19

43680-82

43680-18

30254-00

30264-00

PARTS LIST & EXPLODED VIEW

DESCRIPTION

Spout

O-Ring 1.112x.103

Spout Nut

Ball ¾

Body

Piston Seal

Spring

Tube, Extension

Loctite, Purple

Cylinder Nut

DTSE PUMPS ONLY

Knob

Piston

LTSE PUMPS ONLY

Lever

Rod End

Link

Piston

Pivot Screw

Brush 1/2 Dia. X 3 X 16

Brush 1 Dia. X 3 X 16

3

1

1

1

1

1

1

1

1

QUANTITY

1

1

1

1

1

2

1

1

N/A

1

4 1/8

6 1/8

Tang End Down

21133-00 O-Ring

Available for extra security

3

APW WYOTT EQUIPMENT LIMITED WARRANTY

APW Wyott Foodservice Equipment Company warrants it's equipment against defects in materials and workmanship, subject to the following conditions:

This warranty applies to the original owner only and is not assignable.

Should any product fail to function in its intended manner under normal use within the limits defined in this warranty, at the option of

APW Wyott such product will be repaired or replaced by APW Wyott or its Authorized Service Agency. APW Wyott will only be responsible for charges incurred or service performed by its Authorized Service Agencies. The use of other than APW Wyott

Authorized Service Agencies will void this warranty and APW Wyott will not be responsible for such work or any charges associated with same. The closestAPW WyottAuthorized ServiceAgent must be used.

This warranty covers products shipped into the 48 contiguous United States, Hawaii, metropolitan areas of Alaska and Canada. There will be no labor coverage for equipment located on any island not connected by roadway to the mainland.

Warranty coverage on products used outside the 48 contiguous United States, Hawaii, and metropolitan areas of Alaska and Canada may vary. Contact the international APW Wyott distributor, dealer, or service agency for details.

Time Period

One year for parts and one year for labor, effective from the date of purchase by the original owner. The Authorized Service Agency may, at their option, require proof of purchase. Parts replaced under this warranty are warranted for the un-expired portion of the original product warranty only.

Exceptions

*Gas/Electric Cookline:

*Broiler Briquettes,

*Heat Strips:

Models GCB, GCRB, GF, GGM, GGT, CHP-H, EF, EG, EHP. Three (3) Year Warranty on all component parts, except switches and thermostats. (2 additional years on parts only. No labor on second or third year.)

Rock Grates, Cooking Grates, Burner Shields, Fireboxes: 90 Day Material Only. No Labor.

Models FD, FDL, FDD, FDDL. Two (2)Year Warranty on element only. No labor second year.

*Glass Windows, Doors, Seals, Rubber Seals, Light Bulbs: 90 Day Material Only. No Labor.

In all cases, parts covered by extended warranty will be shipped FOB the factory after the first year.

Portable Carry In Products

Equipment weighing over 70 pounds or permanently installed will be serviced on-site as per the terms of this warranty. Equipment weighing 70 pounds or under, and which is not permanently installed, i.e. with cord and plug, is considered portable and is subject to the following warranty handling limitations. If portable equipment fails to operate in its intended manner on the first day of connection, or use, atAPW Wyott's option or itsAuthorized ServiceAgency, it will be serviced on site or replaced.

From day two through the conclusion of this warranty period, portable units must be taken to or sent prepaid to the APW Wyott

Authorized ServiceAgency for in-warranty repairs. No mileage or travel charges are allowed on portable units after the first day of use.

If the customer wants on-site service, they may receive same by paying the travel and mileage charges. Exceptions to this rule: (1) countertop warmers and cookers, which are covered under the Enhanced Warranty Program, and (2) toasters or rollergrills which have in store service.

Exclusions

The following conditions are not covered by warranty:

*Equipment failure relating to improper installation, improper utility connection or supply and problems due to ventilation.

*Equipment that has not been properly maintained, calibration of controls, adjustments, damage from improper cleaning and water damage to controls.

*Equipment that has not been used in an appropriate manner, or has been subject to misuse or misapplication, neglect, abuse, accident, alteration, negligence, damage during transit, delivery or installation, fire, flood, riot or act of god.

*Equipment that has the model number or serial number removed or altered.

If the equipment has been changed, altered, modified or repaired by other than an Authorized Service Agency during or after the warranty period, then the manufacturer shall not be liable for any damages to any person or to any property, which may result from the use of the equipment thereafter.

This warranty does not cover services performed at overtime or premium labor rates. Should service be required at times which normally involve overtime or premium labor rates, the owner shall be charged for the difference between normal service rates and such premium rates.APW Wyott does not assume any liability for extended delays in replacing or repairing any items beyond its control.

In all cases, the use of other thanAPW WyottAuthorized OEM Replacement Parts will void this warranty.

This equipment is intended for commercial use only. Warranty is void if equipment is installed in other than commercial application.

Water Quality Requirements

Water supply intended for a unit that has in excess of 3.0 grains of hardness per gallon (GPG) must be treated or softened before being used. Water containing over 3.0 GPG will decrease the efficiency and reduce the operation life of the unit.

Note: Product failure caused by liming or sediment buildup is not covered under warranty.

“THE FOREGOING WARRANTY IS IN LIEU OF ANY AND ALL OTHER WARRANTIES EXPRESSED OR IMPLIED

INCLUDING ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR PARTICULAR PURPOSES

AND CONSTITUTES THE ENTIRE LIABILITY OF APW WYOTT. IN NO EVENT DOES THE LIMITED WARRANTY

EXTEND BEYOND THE TERMS STATED HEREIN.”

9/05

4