FMI (V)UM36(SR,SI,HR,HI) Indoor Fireplace User Manual

UNVENTED (VENT-FREE) UNIVERSAL FIREBOX
OWNER’S OPERATION AND INSTALLATION MANUAL
PFS
®
US
Models (V)Um36(Sr,SI,HR,HI), VCM-36U, (V)Um42(Sr,SI,HR,HI),
VCM-42U, (V)Um50(Sr,SI,HR,HI), VCM-50U
WARNING: If the information in this manual is not
followed exactly, a fire or explosion may result causing
property damage, personal injury or loss of life.
— Do not store or use gasoline or other ­flammable
vapors and liquids in the ­vicinity of this or any other
appliance.
— WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch; do not use any
phone in your building.
• Immediately call your gas supplier from a neighbor’s
phone. Follow the gas supplier’s instructions.
• If you cannot reach your gas supplier, call the fire
department.
— Installation and service must be performed by a qualified installer, service agency or the gas supplier.
INSTALLER: Leave this manual with the appliance.
CONSUMER: Retain this manual for future reference.
For more information, visit www.fmiproducts.com
WARNING: Improper installation, adjustment, alteration, service or maintenance can cause injury or
property damage. Refer to this manual for correct installation and operational procedures. For assistance
or additional information consult a qualified installer,
service agency or the gas supplier.
WARNING: Carefully review the instructions supplied with the decorative type unvented room heater for
the minimum fireplace size requirement.
Do not install the appliance in this firebox,
unless this firebox meets the minimum dimensions required for the installation.
WARNING: For use only with a listed, gasfired unvented decorative room heater not
to exceed 40,000 Btu/H.
Do not build a wood fire.
TABLE OF CONTENTS
Safety................................................................... 2
Local Codes......................................................... 4
Product Features.................................................. 4
Locating Firebox................................................... 4
Product Specifications.......................................... 5
Air For Combustion and Ventilation...................... 8
Installation.......................................................... 10
Technical Service............................................... 23
Replacement Parts............................................. 23
Parts................................................................... 24
Warranty...............................................Back Cover
Safety
This appliance may be installed
in an aftermarket,* permanently
located, manufactured (mobile)
home, where not prohibited by
local codes.
* Aftermarket: Completion of sale, not for
purpose of resale, from the manufacturer
This firebox has been tested
under Z21.91b-2004 for use
with approved ANSI Z21.11.2
decorative type unvented room
heater.
2
IMPORTANT: Read this owner’s
manual carefully and completely
before trying to assemble, operate or service this fireplace.
Improper use of this fireplace
can cause serious injury or
death from burns, fire, explosion, electrical shock and carbon
monoxide poisoning.
DANGER: Carbon monoxide
poisoning may lead to death!
www.fmiproducts.com
122274-01G
Safety
Continued
WARNING: Any change to
this firebox or its controls can
be dangerous.
WARNING: Do not allow fans
to blow directly into the firebox.
Avoid any drafts that alter burner
flame patterns. Ceiling fans can
create drafts that alter burner
flame patterns. Altered burner
patterns can cause sooting.
WARNING: Do not use a blower insert, heat exchanger insert
or other accessory not approved
for use with this firebox.
Due to high temperatures, the
appliance should be located out
of traffic and away from furniture
and draperies.
Do not place clothing or other
flammable material on or near
the appliance. Never place any
objects in the firebox or on
logs.
Firebox front and screen becomes very hot when running
firebox. Keep children and adults
away from hot surfaces to avoid
burns or clothing ignition. Firebox will remain hot for a time
after shutdown. Allow surfaces
to cool before touching.
Carefully supervise young children when they are in the room
with firebox.
Keep the fireplace area clear and
free from combustible materials,
gasoline, and other flammable
vapors and liquids.
122274-01G
You must operate this fireplace
with the provided fireplace
screen and hood in place.
Make sure these parts are in
place and screens are closed
before running installed gas
log heater. Replace hood with
FMI PRODUCTS, LLC model
109511-01 50", 109511-02 42",
or 109511-03 36" only. This hood
has been designed to keep the
operation of your fireplace safe
and efficient.
1. Do not use this firebox as a wood burning
fireplace. Use only decorative unvented
room heaters (log sets).
2. Do not add extra logs or ornaments such as
pine cones, vermiculite or rock wool. Using
these added items can cause sooting.
3. Use only the provided hood. See Parts,
page 30.
4. Vent-free gas log heaters installed in these
fireboxes require fresh air ventilation to
run properly. See Air for Combustion and
Ventilation, page 8.
5. Do not run vent-free heaters installed in
these fireboxes
•where flammable liquids or vapors are
used or stored
•under dusty conditions
6. Do not use this firebox to cook food or
burn paper or other objects.
7. Turn unit off and let cool before servicing.
Only a qualified service person should
service and repair firebox.
8. Operating vent-free heaters installed in
these fireboxes above elevations of 4,500
feet could cause pilot outage.
9. Do not use the firebox if it has been
under water.
10.Before using furniture polish, wax, carpet
cleaner or similar products, turn heater
off. If heated, the vapors from these products may create a white powder residue
within burner box or on adjacent walls
and furniture.
11.Provide adequate clearances around air
openings.
www.fmiproducts.com
3
Local Codes
Install and use firebox with care. Follow all
local codes. In the absence of local codes,
use the latest edition of The National Fuel Gas
Code ANSI Z223.1/NFPA 54*. Firebox must
be electrically grounded in accordance with
the National Electrical Code, ANSI/NFPA70
(latest edition).
*Available from:
American National Standards Institute, Inc.
1430 Broadway
New York, NY 10018
National Fire Protection Association, Inc.
Batterymarch Park
Quincy, MA 02269
Product Features
Operation
Sellers of unvented propane or natural
gas-fired supplemental room heaters
shall provide to each purchaser a copy of
527 CMR 30 upon sale of the unit.
Vent-free gas products are prohibited for
bedroom and bathroom installation in
the Commonwealth of Massachusetts.
Locating Firebox
Planning
This firebox is designed for use with approved
ANSI Z21.11.2 decorative type unvented room
heaters. (Physical size limitations apply. Refer
to minimum firebox requirements supplied
with log heater.) It requires no outside venting or chimney making installation easy and
inexpensive.
4
State of Massachusetts: The installation
must be made by a licensed plumber
or gas fitter in the Commonwealth of
Massachusetts.
Plan where you will install the firebox. This will
save time and money later when you install
the firebox. Before installation, consider the
following:
1. Where firebox will be located. Allow for
wall and ceiling clearances (see Installation Clearances, page 11).
2. Everything needed to complete installation.
3. These models CANNOT be installed in
a bedroom unless maximum Btu rating
of installed vent-free log set is less than
10,000 Btu/hr.
4. Proper air for combustion and ventilation
(page 8).
www.fmiproducts.com
122274-01G
Product Specifications
36" Models (V)UM36 Series and VCM-36U
29"
22"
18 3/8" 19 13/16"
(Ref.)
30 1/2"
4 7/8"
34 3/4"
3 3/4"
1 5/16"
36" HEARTH
11 1/8"
54 1/2"
50"
30"
365/16"
7 7/8"
7"
97/16"
35/16"
36"
45 1/8"
7 3/8"
111/8"
Figure 1 - 36" Models (V)UM36 Series and VCM-36U
122274-01G
www.fmiproducts.com
5
Product Specifications
Continued
42" Models (V)UM42 Series and VCM-42U
30 5/16"
25"
22 1/2"
23 13/16"
(Ref.)
32 3/8"
4 7/8"
40 3/4"
3 3/4"
42" HEARTH
1 5/16"
11 1 /8"
54 1/2"
50"
30"
36 /16"
5
7 7/8"
9 7/16"
3 5/16"
7"
42"
51 1/8"
8 3/4"
13"
Figure 2 - 42" Models (V)UM42 Series and VCM-42U
6
www.fmiproducts.com
122274-01G
Product Specifications
Continued
50" Models (V)UM50 Series and VCM-50U
38 5/16"
33"
22 1/2"
23 13/16"
(Ref.)
32 3/8"
4 7/8"
40 3/4"
3 3/4"
50" HEARTH
1 5/16"
11 1/8"
54 1/2"
50"
30"
365/16"
97/16"
35/16"
7 7/8" 7"
50"
59 1/8"
8 3/4"
13"
Figure 3 - 50" Models (V)UM50 Series and VCM-50U
122274-01G
www.fmiproducts.com
7
Air For Combustion and Ventilation
WARNING: This heater shall
not be installed in a room or space
unless the required volume of indoor combustion air is provided
by the method described in the
National Fuel Gas Code, ANSI
Z223.1/NFPA 54, the International
Fuel Gas Code, or applicable local codes. Read the following instructions to insure proper fresh
air for this and other fuel-burning
appliances in your home.
Today’s homes are built more energy efficient
than ever. New materials, increased insulation
and new construction methods help reduce
heat loss in homes. Home owners weather
strip and caulk around windows and doors to
keep the cold air out and the warm air in. During heating months, home owners want their
homes as airtight as possible.
While it is good to make your home energy
efficient, your home ne eds to breathe. Fresh
air must enter your home. All fuel-burning appliances need fresh air for proper combustion
and ventilation.
Exhaust fans, fireplaces, clothes dryers and
fuel burning appliances draw air from the house
to operate. You must provide adequate fresh
air for these appliances. This will insure proper
venting of vented fuel-burning appliances.
PROVIDING ADEQUATE
VENTILATION
The following are excerpts from National Fuel
Gas Code, ANSI Z223.1/NFPA 54, Air for
Combustion and Ventilation.
All spaces in homes fall into one of the three
following ventilation classifications:
1. Unusually Tight Construction
2. Unconfined Space
3. Confined Space
The information on pages 8 through 10 will help
you classify your space and provide adequate
ventilation.
Unusually Tight Construction
The air that leaks around doors and windows
may provide enough fresh air for combustion
and ventilation. However, in buildings of unusually tight construction, you must provide
additional fresh air.
8
Unusually tight construction is defined as
construction where:
a. walls and ceilings exposed to the outside atmosphere have a continuous
water vapor retarder with a rating of
one perm (6 x 10-11 kg per pa-sec-m2) or
less with openings gasketed or sealed
and
b. weather stripping has been added on
openable windows and doors and
c. caulking or sealants are applied to
areas such as joints around window
and door frames, between sole plates
and floors, between wall-ceiling joints,
between wall panels, at penetrations
for plumbing, electrical and gas lines
and at other openings.
If your home meets all of the three criteria
above, you must provide additional fresh
air. See Ventilation Air From Outdoors,
page 10.
If your home does not meet all of the three
criteria above, proceed to Determining
Fresh-Air Flow For Firebox Location.
Confined and Unconfined Space
The National Fuel Gas Code, ANSI Z223.1/
NFPA 54 defines a confined space as a space
whose volume is less than 50 cubic feet per
1,000 Btu per hour (4.8 m3 per kw) of the aggregate input rating of all appliances installed
in that space and an unconfined space as a
space whose volume is not less than 50 cubic
feet per 1,000 Btu per hour (4.8 m3 per kw)
of the aggregate input rating of all appliances
installed in that space. Rooms communicating
directly with the space in which the appliances
are installed*, through openings not furnished
with doors, are considered a part of the unconfined space.
* Adjoining rooms are communicating only if
there are doorless passageways or ventilation
grills between them.
determining fresh-air flow
for Firebox location
Determining if You Have a Confined or
Unconfined Space
Use this work sheet to determine if you have
a confined or unconfined space.
Space: Includes the room in which you will
install heater plus any adjoining rooms with
doorless passageways or ventilation grills
between the rooms.
www.fmiproducts.com
122274-01G
Air for combustion and ventilation
Continued
1. Determine the volume of the space (length
x width x height).
Length x Width x Height =__________cu. ft.
(volume of space)
Example: Space size 22 ft. (length) x 18 ft.
(width) x 8 ft. (ceiling height) = 3,168 cu. ft.
(volume of space)
If additional ventilation to adjoining room
is supplied with grills or openings, add the
volume of these rooms to the total volume
of the space.
2. Multiply the space volume by 20 to determine
the maximum Btu/Hr the space can support.
_ ________ (volume of space) x 20 = (Maximum Btu/Hr the space can support)
Example: 3,168 cu. ft. (volume of space) x 20 =
63,360 (maximum Btu/Hr space can support)
3. Add the Btu/Hr of all fuel burning appliances
in the space.
Vent-free fireplace __________ Btu/Hr
Gas water heater* __________ Btu/Hr
Gas furnace __________ Btu/Hr
Vented gas heater __________ Btu/Hr
Gas fireplace logs __________ Btu/Hr
Other gas appliances*+_ _________ Btu/Hr
Total
=__________ Btu/Hr
* Do not include direct-vent gas appliances.
Direct-vent draws combustion air from the
outdoors and vents to the outdoors.
Example:
Gas water heater __________
Btu/Hr
40,000
Vent-free fireplace +__________
Btu/Hr
39,000
Total
=__________
Btu/Hr
79,000
4. Compare the maximum Btu/Hr the space
can support with the actual amount of Btu/Hr
used.
_ _______ Btu/Hr (maximum the space can
support)
_ _______ Btu/Hr (actual amount of Btu/Hr
used)
Example: 63,360 Btu/Hr (maximum the
space can support)
79,000 Btu/Hr (actual amount of
Btu/Hr used)
The space in the example is a confined space
because the actual Btu/Hr used is more than the
maximum Btu/Hr the space can support. You
must provide additional fresh air. Your options
are as follows:
A. Rework worksheet, adding the space of an
adjoining room. If the extra space provides an
unconfined space, remove door to adjoining
room or add ventilation grills between rooms.
See Ventilation Air From Inside Building.
B. Vent room directly to the outdoors. See
Ventilation Air From Outdoors, page 10.
C. Install a lower Btu/Hr fireplace, if lower Btu/
Hr size makes room unconfined.
122274-01G
If the actual Btu/Hr used is less than the
maximum Btu/Hr the space can support, the
space is an unconfined space. You will need
no additional fresh air ventilation.
WARNING: If the area in which
the heater may be operated does
not meet the required volume for
indoor combustion air, combustion and ventilation air shall be
provided by one of the methods
described in the National Fuel
Gas Code, ANSI Z223.1/NFPA 54,
the International Fuel Gas Code,
or applicable local codes.
VENTILATION AIR
Ventilation Air From Inside Building
This fresh air would come from an adjoining
unconfined space. When ventilating to an
adjoining unconfined space, you must provide
two permanent openings: one within 12" of the
ceiling and one within 12" of the floor on the
wall connecting the two spaces (see options
1 and 2, Figure 4). You can also remove door
into adjoining room (see option 3, Figure 4 ).
Follow the National Fuel Gas Code, ANSI
Z223.1/NFPA 54, Air for Combustion and
Ventilation for required size of ventilation
grills or ducts.
12"
Ventilation
Grills Into
Adjoining
Room,
Option 1
Ventilation Grills
Into Adjoining Room,
Option 2
Or
Remove
Door into
Adjoining
Room,
Option
3
12"
Figure 4 - Ventilation Air from Inside
Building
www.fmiproducts.com
9
air for combustion and ventilation
Continued
Ventilation Air From Outdoors
Provide extra fresh air by using ventilation
grills or ducts. You must provide two permanent openings: one within 12" of the ceiling
and one within 12" of the floor. Connect these
items directly to the outdoors or spaces open
to the outdoors. These spaces include attics
and crawl spaces. Follow the National Fuel
Gas Code, ANSI Z223.1/NFPA 54, Air for
Combustion and Ventilation for required size
of ventilation grills or ducts.
IMPORTANT: Do not provide openings for
inlet or outlet air into attic if attic has a thermostat-controlled power vent. Heated air entering
the attic will activate the power vent.
Outlet
Air
Outlet
Air
Ventilated
Attic
To Attic
To
Crawl
Space
Inlet
Air
Inlet Air
Ventilated
Crawl Space
Figure 5 - Ventilation Air from Outdoors
Installation
WARNING: A qualified service person must install firebox.
Follow all local codes.
WARNING: Never install
firebox
• in a bedroom or bathroom*
• in a recreational vehicle
• where curtains, furniture,
clothing, or other flammable
objects are less than 36" from
front or 42" from top of firebox;
for side clearances see Figure
4, page 11
• in high traffic areas
• in windy or drafty areas
* Unless installed log set is rated
at 10,000 Btu/Hr or less.
CAUTION: Log heaters
installed in this firebox create
warm air currents. These currents
move heat to wall surfaces next
to firebox. Installing firebox next
to vinyl or cloth wall coverings or
operating firebox where impurities (such as, but not limited to, tobacco smoke, aromatic candles,
cleaning fluids, oil or kerosene
lamps, etc.) in the air exist, may
discolor walls or cause odors.
10
NOTICE: The firebox identification label (including model number, serial number, clearances,
etc.) is located on a chain under
the bottom refractory.
IMPORTANT: Vent-free gas log heaters add
moisture to the air. Although this is beneficial,
installing firebox in rooms without enough
ventilation air may cause mildew to form from
too much moisture. See, page 8.
IMPORTANT: Make sure the firebox is level.
If firebox is not level, log set will not work
properly.
Note: Your firebox is designed to be used in
zero clearance installations. Wall or framing
material can be placed against any exterior
surface on the rear, sides, top or bottom of
your firebox, except where standoff spacers
are integrally attached. If standoff spacers are
attached to your firebox, these spacers can
be placed directly against wall or framing materials. Use the dimensions shown for rough
opening to create the easiest installation.
Use dimensions shown for rough openings
to create the easiest installation (see Built-In
Firebox Installation, page 12).
www.fmiproducts.com
122274-01G
Installation
Continued
INSTALLATION CLEARANCES
WARNING: Maintain the
minimum clearances. If you
can, provide greater clearances
from floor, ceiling, and adjoining wall.
Carefully follow the instructions below. This
will ensure safe installation.
Minimum Wall and Ceiling Clearances
(see Figure 6)
A. Clearances from the side of the fireplace
cabinet to any combustible material and
wall should follow diagram in Figure 6.
Example: The face of a mantel, bookshelf,
etc. is made of combustible material and
protrudes 3 1/2" from the wall. This combustible material must be 4" from the side
of the fireplace cabinet (see Figure 4).
B. Clearances from the top of the firebox
opening to the ceiling should not be less
than 42".
C. When the firebox is installed directly on
carpeting, tile or other combustible material, other than wood flooring, the firebox
should be installed on a metal or wood
panel extending the full width and depth
of the enclosure.
D. Clearances from the bottom of firebox to
the floor is 0".
These fireboxes can be installed as freestanding units against a wall with approved
cabinet mantels that may be available from
your retailer or supplier, or as a built-in unit.
The clearances are the same for either installation method.
Mantel Clearances for Built-In
Installation
If placing custom mantel above built-in firebox, you must meet the minimum allowable
clearance between mantel shelf and top of
firebox opening shown in Figure 7. These are
the minimum allowable mantel clearances
for a safe installation. Use larger clearances
wherever possible to minimize the heating of
objects and materials placed on the mantel.
CAUTION: Do not allow the
vent-free gas log heater to touch
or extend beyond the fireplace
screen.
NOTICE: Surface temperatures
of adjacent walls and mantels
become hot during operation.
Walls and mantels above the
firebox may become hot to
the touch. If installed properly,
these temperatures meet the
requirement of the national
product standard. Follow all
minimum clearances shown in
this manual.
Wall board or facing
material (above
firebox) may be of
combustible material,
including decorative
mantel ornaments or
other similar projections off of the facing
material.
Framing
Material
Firebox
Example
Wire-mesh
Screen
*
*Minimum 16" from Side Wall
Figure 6 - Minimum Clearance for
Combustible to Wall
122274-01G
Mantel Shelf
Note: Any portion of the
mantel shelf must NOT
extend beyond this profile.
12"
6 3/4"
1 1/2"
Noncombustible
Material May
Project Off this 12" 16" 20"
Surface above
the Firebox Hood
Note: All vertical
measurements are
Supplied
from top of fireplace
Firebox Hood
hood opening to
Must Be Used
bottom of mantel shelf.
at All Times
These minimum
clearances replace any
other recommended
clearances supplied
with your ANSI Z21.11.2
approved gas logs.
Figure 7 - Minimum Mantel Clearances
for Built-In Installation
www.fmiproducts.com
11
Installation
Continued
NOTICE: If your installation does
not meet the minimum clearances shown, you must do one
of the following:
• raise the mantel to an acceptable height
• remove the mantel
Built-In Firebox Installation
Built-in installation of this firebox involves
installing firebox into a framed-in enclosure.
This makes the front of firebox flush with wall.
If installing a mantel above the firebox, you
must follow the clearances shown in Figure
7, page 11. Follow these instructions to install
the firebox in this manner.
1. Frame in rough opening. The firebox framing should be constructed of 2 x 4 lumber
or heavier. Use dimensions and rough
opening layout in Figure 8. Adjust framing
so that firebox flushes with finished wall
surface. If installing in a corner, use dimensions in Figure 9, for rough opening.
2. Install gas piping to firebox location. See
Installing Gas Line on page 14 and Connecting to Gas Supply in log set owner’s
manual.
54.625"
3. Carefully set firebox in front of rough
opening with back of firebox inside wall
opening.
4. Carefully insert firebox into rough opening.
5. Attach firebox to wall studs using nails
or wood screws through holes in nailing
flange (see Figure 10).
6. Install and properly test gas log heater.
Follow installation instructions included
with the vent-free gas log heater that is
being installed.
IMPORTANT: When finishing your firebox,
combustible materials such as wall board,
gypsum board, sheet rock, drywall, plywood,
etc. may be butted up next to the sides and top
of the firebox. Combustible materials should
never overlap the firebox front facing.
WARNING: Do not allow any
combustible materials to overlap
the firebox front facing.
IMPORTANT: Noncombustible materials such
as brick, tile, etc. may overlap the front facing, but should never cover any necessary
openings.
WARNING: Do not allow noncombustible materials to cover
any necessary openings.
Nails or
Wood
Screws
30.125"
28.250"
(36" Models)
45.375" (36" Models)
51.375" (42" Models)
59.375" (50" Models)
Figure 8 - Framing Dimensions
Maintain 1 1/2"
Clearance at Sides
and Back of Fireplace
61" (36" Models)
65" (42" Models)
71" (50" Models)
1 1/2" Clearance
Not Required at
Nailing Flanges
Nailing
Flanges
Figure 10 - Attaching Firebox to Wall
Studs
86.5" (36" Models)
92" (42" Models)
100" (50" Models)
Figure 9 - Corner Installation
12
www.fmiproducts.com
122274-01G
Installation
Continued
WARNING: Use only noncombustible mortar or adhesives when overlapping the front
facing with noncombustible
facing material.
Installing Firebox USING
OPTIONAL MANTELS available
from retailer or custom built
WARNING: A qualified service person must install firebox.
Follow all local codes.
This firebox may be installed using a cabinet
mantel against a wall in your home. The
firebox and cabinet mantel can be installed
directly on the floor. Mantels may be available from your retailer or custom built for
your home.
1. Assemble cabinet mantel as instructed.
2. Install gas piping to firebox location. See
Installing Gas Line, page 14. You may have
to cut an access hole in the floor or wall to
run gas line to firebox. Make sure to locate
access hole so cabinet mantel will cover it
when installed (see Figure 11).
3. Place firebox on floor in desired location.
Make sure mantel will be flush against
wall when installed.
4. Carefully slide cabinet mantel over firebox.
Be careful not to scratch firebox, cabinet
mantel, flooring, etc., when installing (see
Figure 12).
5. Install and properly test gas log heater.
Follow installation instructions included
with the vent-free gas log heater that is
being installed.
122274-01G
Cabinet
Mantel
Gas Line
Access Hole
(Either Side
of Firebox)
Gas
Piping
Figure 11 - Installing Cabinet Mantel
(Mantel May Vary From Illustration)
Figure 12 - Inserting Firebox Into Cabinet
Mantel (Mantel May Vary From Illustration)
www.fmiproducts.com
13
Installation
Continued
Installing gas line
WARNING: A qualified service person must connect heater
to gas supply. Follow all local
codes.
IMPORTANT: See Connecting to Gas Supply
in your log set owner’s manual for details on
gas hookup.
You may run the gas line from either side of
the firebox (see Figure 13). Decide which side
you want to run the gas line from.
Note: This is one option for installing shutoff
valve. Check local codes for equipment shutoff valve location requirements.
2. Install right side as left side in step 1 using
screws provided.
3. Install back panel and secure back to
sides and bottom of firebox with screws
provided.
4. Using self-tapping screws and a drill, place
screws into large holes in back and side
panels (see Parts, page 32), through wire
mesh and into firebox wrapper to secure.
Hole in
Side Panel
Figure 14 - Hole in Side Panel to Attach
to Firebox Wrapper
Brick Installation
IMPORTANT: Installation of brick
should be done after the fireplace is placed in a permanent
location.
Each brick housing is stamped with a number
(full size bricks are not stamped). These numbers will help identify the brick when installing.
It is important to install these bricks exactly as
instructed. Press brick firmly into brick housing
until it snaps. Groove line on side of brick will
come in contact with flange on the brick housing. This secures brick into housing (see Figure
15). Smaller bricks may require a small portion
of furnace cement applied to back of brick to
secure it until grouting has been completed.
Bricks are packaged in separate boxes. The
brick matrixes on pages 15 through 27 show
how bricks are packaged and placed for each
size fireplace and the number of bricks per
box. There are 2 extra full bricks included in
Hearth Brick package.
Install bricks one section at a time starting with
hearth panel followed by the rear panel, left
panel and right panel. It is important to install
the bricks in sequence. Please note, full size
bricks are NOT stamped.
The brick housings are already installed on
the panels. When installing brick housing
panels into fireplace, wear gloves as edges
may be sharp.
1. Beginning with left side panel, place
panel, bottom edge first, at an angle into
fireplace. Secure to bottom of fireplace
with screws provided.
Figure 15 - Installing Bricks into Brick
Housings
Equipment
Shutoff Valves
(Install One)
Gas Line Hole
Figure 13 - Installing Gas Line and
Equipment Shutoff Valve (Model May
Vary From Illustration)
Brick Panel Installation
14
www.fmiproducts.com
122274-01G
Installation
Continued
HEARTH BRICK MATRIX
FULL
F124
FULL
FULL
F126
FULL
FULL
FULL
F128
F126
FULL
120848
FULL
F125
F124
FULL
Ash Brick
F012
F012
F125
F128
36" Hearth
F133
F123
F011
FULL
FULL
F132
FULL
FULL
FULL
FULL
120848
FULL
F126
F059
F123
FULL
FULL
F124
F133
FULL
FULL
Ash Brick
F059
F124
F059
F126
F132
F059
42" Hearth
F135
FULL
F024
F126
F021
F134
FULL
FULL
FULL
FULL
120848
Ash Brick
F012
F012
50" Hearth
122274-01G
F135
FULL
FULL
FULL
FULL
F059
F011
F011
FULL
FULL
FULL
F025
F011
F024
F126
FULL
F021
FULL
FULL
F059
F134
F025
RED
IVORY
FULL
FULL
(112140-01) (112140-05)
ASH BRICK ASH BRICK
(120848-01) (120848-03)
F012R
F012W
F124R
F124W
F125R
F125W
F126R
F126W
F128R
F128W
* Includes 2 extra bricks.
QTY
11*
RED
IVORY
FULL
FULL
(112140-01) (112140-05)
ASH BRICK ASH BRICK
(120848-01) (120848-03)
F011R
F011W
F059R
F059W
F123R
F123W
F124R
F124W
F126R
F126W
F132R
F132W
F133R
F133W
* Includes 2 extra bricks.
QTY
13*
RED
IVORY
FULL
FULL
(112140-01) (112140-05)
ASH BRICK ASH BRICK
(120848-01) (120848-03)
F011R
F011W
F011R
F012W
F021R
F021W
F024R
F024W
F025R
F025W
F059R
F059W
F126R
F126W
F134R
F134W
F135R
F135W
* Includes 2 extra bricks.
QTY
17*
www.fmiproducts.com
1
2
2
2
2
2
1
1
4
2
2
2
2
2
1
3
2
2
2
2
2
2
2
2
15
Installation
Continued
36" FULL STACKED BRICK MATRIX
F147
FULL
FULL
F159
FULL
FULL
FULL
FULL
F143
F143
FULL
F143
F158
F143
F158
FULL
F144
F185 or
F191
F143
F036
FULL
FULL
F158
F144
F158
16
REAR REFRACTORY
RED
IVORY
QTY
FULL
FULL
8
(112140-01) (112140-05)
F148R
F150R
F152R
F153R
F159R
F160R
F148W
F150W
F152W
F153W
F159W
F160W
1
2
1
2
6
4
F153
F148
FULL
F158
F158
F185 or
F191
3
2
1
1
2
3
1
1
1
F147
F148
FULL
F144
F160
F152
F148
FULL
F144
F160
FULL
F160
F159
FULL
F159
F159
F160
F185 or
F191
F036R
F036W
F143R
F143W
FULL
F036
F144R
F144W
F147R FULL F147W
F148R
F148W
F158R
FULL
F036F158W
F185R
F185W
F191R F192 F191W
F192R
F192W
F150
F148
FULL
FULL
F158
F159
F150
F159
F158
F185 or
F191
F192
F148
LEFT
REFRACTORY
RED
QTY
FULL
F036IVORY
FULL
FULL
7
(112140-01)
(112140-05)
FULL
FULL
F158
F143
FULL
F036
F158
F158
FULL
FULL
LL
F158
FULL
F036
F147
F148
F143
FULL
LL
LL
FULL
F036
F153
F147
F148
F143
F148
F036
FULL
FULL
F036
F192
RIGHT REFRACTORY
RED
IVORY
QTY
FULL
FULL
7
(112140-01) (112140-05)
F036R
F143R
F144R
F147R
F148R
F158R
F185R
F191R
F192R
www.fmiproducts.com
F036W
F143W
F144W
F147W
F148W
F158W
F185W
F195W
F192W
3
2
1
1
2
3
1
1
1
122274-01G
Installation
Continued
42" FULL STACKED BRICK MATRIX
FULL
FULL
F032
F033
FULL
F032
FULL
F033
F154
F156
186
F143
F143
F143
F143
FULL
F151
FULL
FULL
F151
122274-01G
F033
F032
FULL
F033
F032
FULL
F190 or F186
FULL
F017R
F143
F032R
FULL
FULL
F033R
F143R
FULL
F158
F151R
F155R
FULL
FULL
F156R
F190F158R
or F186
F151
F186R
F190R
F032
F017W
F032W
F033
F033W
F143W
F032
F151W
F155W
F033
F156W
F158W
F032
F186W
F190W
1
3
3
3
1
1
1
2
1
1
REAR REFRACTORY
RED
IVORY
QTY
FULL
FULL
7
(112140-01) (112140-05)
F017R
F032R
F033R
F152R
F154R
F157R
F017W
F032W
F033W
F152W
F154W
F157W
2
6
4
2
2
2
F154
F155
FULL
FULL
F143
F143
FULL
F152
FULL
F158
F158
F032
F017
F158
F033
FULL
FULL
F156
F033
F032
F152
F158
FULL
FULL
FULL
LEFT REFRACTORY
F155
RED
IVORY
QTY
FULL
FULL
F033
FULL
FULL
8
(112140-01) (112140-05)
F017
F157
F032
FULL
F032
F151
F017
FULL
F032
FULL
FULL
F017
F033
F158
F190 or F186
F032
F157
FULL
FULL
F158
F158
F143
F033
FULL
F143
F032
F143
FULL
F156
F143
F033
F156
F017
F143
F155
F033
F032
RIGHT REFRACTORY
RED
IVORY
QTY
FULL
FULL
8
(112140-01) (112140-05)
F017R
F032R
F033R
F143R
F151R
F155R
F156R
F158R
F186R
F190R
www.fmiproducts.com
F017W
F032W
F033W
F143W
F151W
F155W
F156W
F158W
F186W
F190W
1
3
3
3
1
1
1
2
1
1
17
Installation
Continued
50" FULL STACKED BRICK MATRIX
F147
FULL
FULL
F159
F159
FULL
F145 or
F191
F144
F158
18
F148
F148
FULL
FULL
F145 or
F191
F143
F033
F032
FULL
FULL
F158
F149
F032
FULL
3
1
1
F143
F191
F033
REAR REFRACTORY
RED
IVORY
QTY
FULL
FULL
13
(112140-01) (112140-05)
F148R
F150R
F152R
F153R
F159R
F160R
F148W
F150W
F152W
F153W
F159W
F160W
2
2
2
2
6
4
F153
FULL
FULL
F158R F192 F158W
F191R
F191W
F192R
F191W
F144
F160
FULL
F152
3
3
2
1
1
1
1
2
1
F143
F143
FULL
F152
F158
F143
FULL
FULL
FULL
F158
F144
F143
F143
F158
F160
F147
F148
L
FULL
FULL
F032R
F032W
F033
F033RFULL F033W
F143R
F143W
FULL
F032
F158
F144R
F144W
F145R
F145W
FULL
FULL
F033
F146R
F146W
F147R
F147W
FULL
F032
F158
F148R
F148W
F145 or F149RF146 or F149W
FULL
F150
FULL
FULL
FULL
F153
FULL
FULL
FULL
F160
F158
F148
F159
FULL
F160
F147
F145 or
F191
F146 or
F192
F148
F159
F150
F158
F159
F032
F033
F158
FULL
FULL
F158
F159
F032
F033
F158
FULL
FULL
LEFT REFRACTORY
RED F148 IVORY
QTY
F149
FULL
FULL
7
FULL
F032
(112140-01)
(112140-05)
F148
F143
F033
F147
F148
FULL
F032
L
L
F148
F144
F149
F033
F032
F146 or
F192
F033
RIGHT REFRACTORY
RED
IVORY
QTY
FULL
FULL
7
(112140-01) (112140-05)
F032R
F033R
F143R
F144R
F145R
F146R
F147R
F148R
F149R
F158R
F191R
F192R
www.fmiproducts.com
F032W
F033W
F143W
F144W
F145W
F146W
F147W
F148W
F149W
F158W
F191W
F192W
3
3
2
1
1
1
1
2
1
3
1
1
122274-01G
Installation
Continued
36" FULL HERRINGBONE BRICK MATRIX
F074
F074
15
F1
F0
72
F0
FU
72
68
F0
LEFT REFRACTORY
RED
IVORY
FULL
FULL
(112140-01)
(112140-05)
F068R
F068W
F071R
F071W
F072R
F072W
F074R
F074W
F113R
F113W
F115R
F115W
F165R
F165W
F181R
F181W
F189R
F189W
S011R
S011W
QTY
6
FU
13
F1
LL
LL
F0
FU
72
FU
13
F1
LL
LL
LL
F0
FU
13
F1
FU
72
LL
F0
F1
72
89
F1
65
1
1
5
2
3
1
1
1
1
1
F181 or F071
S011
F074
F074
F117
F1
LL
FU
84
F0
08
68
F0
72
F0
F074
F074
07
LL
F1
FU
LL
FU
84
F0
F074
LL
07
F1
FU
84
F0
LL
FU
F074
7
LL
0
F1
FU
6
F1
8
68
F1
61
F1
79
F1
F187
REAR REFRACTORY
RED
IVORY
FULL
FULL
(112140-01)
(112140-05)
F068R
F068W
F072R
F072W
F074R
F074W
F084R
F084W
F107R
F107W
F108R
F108W
F117R
F117W
F161R
F161W
F168R
F168W
F179R
F179W
F187R
F187W
QTY
6
1
1
6
3
3
1
1
1
2
1
1
F074
68
F0
20
72
F1
F0
12
F1
F122
F0
68
10
F1
20
F1
LL
FU
F122
F0
68
10
F1
F1
20
FU
LL
F122
F0
68
10
F1
20
F1
LL
FU
F122
F1
0
88
8
F1
F074
RIGHT REFRACTORY
RED
IVORY
FULL
FULL
(112140-01)
(112140-05)
F068R
F068W
F071R
F071W
F072R
F072W
F074R
F074W
F110R
F110W
F112R
F112W
F120R
F120W
F122R
F122W
F180R
F180W
F181R
F181W
F188R
F188W
QTY
3
4
1
1
2
3
1
4
4
1
1
1
F181 or F071
122274-01G
www.fmiproducts.com
19
Installation
Continued
42" FULL HERRINGBONE BRICK MATRIX
F074
72
LL
FU
68
F0
64
F0
68
F0
72
F0
F0
F120
LEFT REFRACTORY
F074
LL
68
FU
F0
64
F0
LL
FU
F120
68
LL
F0
FU
64
F0
LL
FU
F120
63
69
F1
F1
F176
64
F0
LL
FU
F120
F175 or F182
F177
RED
FULL
(112140-01)
IVORY
FULL
(112140-05)
QTY
6
F064R
F068R
F072R
F074R
F120R
F163R
F169R
F175R
F176R
F177R
F182R
F064W
F068W
F072W
F074W
F120W
F163W
F169W
F175W
F176W
F177W
F182W
4
4
2
2
4
1
1
1
1
1
1
F074
F074
72
F0
68
F0
72
89
F0
F0
72
F0
LL
LL
FU
FU
63
F0
REAR REFRACTORY
RED
IVORY
FULL
FULL
(112140-01)
(112140-05)
QTY
9
LL
LL
FU
72
F0
LL
FU
FU
LL
63
F0
LL
FU
FU
72
F0
LL
FU
63
F0
FU
F0
72
1
6
F1
6
F1
LL
1
8
78
F1
6
F1
F063R
F068R
F072R
F074R
F089R
F161R
F063W
F068W
F072W
F074W
F089W
F161W
3
1
6
2
1
2
F168R
F168W
1
F171R
F171W
1
F178R
F178W
1
F171
F074
72
F0
8
6
F0
72
F0
1
0
F1
1
7
F0
LL
LL
FU
00
F1
LL
FU
FU
RIGHT REFRACTORY
RED
IVORY
FULL
FULL
(112140-01)
(112140-05)
1
7
F0
LL
FU
LL
FU
LL
FU
00
F1
1
7
F0
FU
LL
LL
FU
LL
FU
00
F1
71
F0
65
F1
64
F1
74
F1
F071R
F068R
F072R
F074R
F100R
F101R
F162R
F164R
F165R
F174R
F071W
F068W
F072W
F074W
F100W
F101W
F162W
F164W
F165W
F174W
QTY
9
4
1
2
1
3
1
1
1
1
1
F162 or F184
20
www.fmiproducts.com
122274-01G
Installation
Continued
50" FULL HERRINGBONE BRICK MATRIX
F074
72
F0
FU
68
F0
64
F0
68
F0
72
F0
F120
LEFT REFRACTORY
RED
IVORY
FULL
FULL
(112140-01)
(112140-05)
F074
LL
LL
FU
68
F0
64
F0
LL
FU
F120
LL
68
F0
FU
64
F0
LL
FU
F120
63
F1
69
F1
F176
64
F0
LL
FU
F120
F175 or F182
F177
F074
F074
82
68
F0
72
F0
F0
68
F0
72
F0
89
F0
F0
LL
65
FU
LL
FU
FU
LL
LL
FU
63
F0
F0
LL
65
FU
LL
FU
FU
LL
LL
FU
63
F0
F0
LL
LL
65
FU
FU
FU
LL
LL
FU
63
F0
F168
F178
F074
F093
F074
68
F0
68
F0
72
85
F0
F0
F0
84
FU
83
LL
F0
FU
LL
FU
84
F0
LL
LL
FU
83
F0
FU
F0
LL
LL
FU
84
FU
83
LL
F0
84
F0
LL
FU
or
72
F1 183
F
LL
FU
F1
73
122274-01G
F167
F166
70
61
F1
F1
61
F1
F168
QTY
6
F064R
F068R
F072R
F064W
F068W
F072W
4
4
2
F074R
F120R
F163R
F169R
F175R
F176R
F074W
F120W
F163W
F169W
F175W
F176W
2
4
1
1
1
1
F177R
F182R
F177W
F182W
1
1
REAR REFRACTORY
RED
IVORY
FULL
FULL
(112140-01)
(112140-05)
F063R
F063W
F065R
F065W
F068R
F068W
F072R
F072W
F074R
F074W
F082R
F082W
QTY
12
3
3
2
2
2
1
F089R
F089W
1
F161R
F161W
2
F168R
F168W
2
F170R
F170W
1
F178R
F178W
1
RIGHT REFRACTORY
RED
IVORY
FULL
FULL
(112140-01)
(112140-05)
F068R
F072R
F074R
F083R
F084R
F085R
F093R
F166R
F167R
F172R
F173R
F183R
www.fmiproducts.com
F068W
F072W
F074W
F083W
F084W
F085W
F093W
F166W
F167W
F172W
F173W
F183W
QTY
9
2
1
2
3
4
1
1
1
1
1
1
1
21
Installation
Continued
36" SPLIT STACKED BRICK MATRIX
FULL
S047
S046
FULL
FULL
FULL
S047
FULL
FULL
S047
FULL
FULL
FULL
FULL
S047
FULL
S044 or S095 S043
S045
FULL
S049
FULL
FULL
FULL
S049
FULL
S049
FULL
S049
FULL
S049
FULL
S051
S046
S050
FULL
FULL
S046
S050
FULL
FULL
S046
S050
FULL
FULL
S046
S047
S047
S047
FULL
FULL
S046
S047
FULL
FULL
S050
S048
FULL
FULL
S047
FULL
FULL
S054
REAR REFRACTORY
RED
IVORY
QTY
FULL
FULL
17
(112140-02) (112140-06)
S048R
S048W
12
S049R
S049W
10
S051R
S051W
1
S052R
S052W
2
S052
FULL
FULL
S046
S050
S048
FULL
FULL
S052
S048
FULL
FULL
S049
S048
FULL
FULL
S049
S048
FULL
FULL
S049
S048
S049
FULL
S049
S048
LEFT REFRACTORY
RED
IVORY QTY
FULL
FULL
16
(112140-02) (112140-06)
S043R
S043W
1
S044R
S044W
1
S045R
S045W
1
S046R
S046W
6
S047R
S047W
6
S050R
S050W
5
S095R
S095W
1
S046
FULL
S048
S050
FULL
S047
S048
S050
S046
FULL
S048
S050
S046
FULL
S048
S050
S046
FULL
S047
S048
S050
S046
S047
S045
RIGHT REFRACTORY
RED
IVORY
QTY
FULL
FULL
16
(112140-02) (112140-06)
S044R
S044W
1
S045R
S045W
1
S046R
S046W
6
S047R
S047W
6
S050R
S050W
5
S054R
S054W
1
S095R
S095W
1
S044 or S095
22
www.fmiproducts.com
122274-01G
Installation
Continued
42" SPLIT STACKED BRICK MATRIX
S077
S046
FULL
FULL
S077
S077
S046
FULL
S046
FULL
S077
S046
FULL
S077
S076
S046
FULL
S076
FULL
FULL
S077
S076
S077
FULL
FULL
S077
S076
S076
S076
FULL
S076
FULL
S050
FULL
FULL
FULL
S050
FULL
FULL
FULL
S050
FULL
FULL
FULL
S050
S082
122274-01G
S045 or S081
S077
S077
S076
FULL
FULL
S046
S077
S076
FULL
S046
S050
S077
S076
FULL
FULL
S046
S078
S076
FULL
S046
S050
S077
S051
FULL
S046
REAR REFRACTORY
RED
IVORY
QTY
FULL
FULL
16
(112140-02) (112140-06)
S051R
S051W
2
S076R
S076W
12
S077R
S077W
10
S078R
S078W
2
S076
FULL
S051
S078
S077
FULL
FULL
S076
S077
FULL
FULL
S077
S077
FULL
FULL
S076
S077
S076
FULL
FULL
S077
S080
S076
FULL
S076
LEFT REFRACTORY
RED
IVORY
QTY
FULL
FULL
17
(112140-02) (112140-06)
S045R
S045W
1
S046R
S046W
5
S050R
S050W
6
S076R
S076W
6
S077R
S077W
6
S080R
S080W
1
S081R
S081W
1
S050
FULL
S045
or S081
S076
S050
FULL
FULL
S077
S050
FULL
FULL
S076
S050
FULL
FULL
S076
S050
FULL
FULL
S076
S050
FULL
FULL
S076
S077
S076
FULL
S077
RIGHT REFRACTORY
RED
IVORY
QTY
FULL
FULL
17
(112140-02) (112140-06)
S045R
S045W
1
S046R
S046W
5
S050R
S050W
6
S076R
S076W
6
S077R
S077W
6
S081R
S081W
1
S082R
S082W
1
S076
www.fmiproducts.com
23
Installation
Continued
50" SPLIT STACKED BRICK MATRIX
S076
FULL
S076
S077
FULL
FULL
FULL
FULL
FULL
FULL
FULL
FULL
S052
S050
S050
FULL
S050
S054
24
S076
FULL
S076
S077
FULL
S076
FULL
FULL
S077
FULL
FULL
S095
S077
FULL
FULL
S046
S077
FULL
FULL
S046
S077
S076
FULL
S046
S050
FULL
FULL
S046
S052
S076
FULL
S046
S048
FULL
S051
FULL
REAR REFRACTORY
RED
IVORY
QTY
FULL
FULL
28
(112140-02) (112140-06)
S048R
S048W
12
S049R
S049W
10
S051R
S051W
2
S052R
S052W
2
S049
FULL
S046
S050
S048
FULL
FULL
S051
S048
S049
FULL
FULL
S048
FULL
FULL
FULL
S049
S048
S049
FULL
FULL
S048
FULL
FULL
FULL
S049
S048
S049
FULL
FULL
S048
S048
FULL
FULL
FULL
S049
LEFT REFRACTORY
RED
IVORY
QTY
FULL
FULL
16
(112140-02) (112140-06)
S043R
S043W
1
S045R
S045W
1
S046R
S046W
6
S050R
S050W
5
S076R
S076W
6
S077R
S077W
6
S095R
S095W
1
S096R
S096W
1
S049
FULL
FULL
FULL
S048
FULL
FULL
FULL
S049
S043
S095
S077 S045 or S096
S048
S050
S046
FULL
FULL
S050
S046
FULL
S076
S049
S050
S046
FULL
S076
S048
S046
FULL
S076
S077
S050
FULL
FULL
S077
S050
S046
FULL
S076
S077
S046
FULL
FULL
S077
S076
S045 or S096
S077
RIGHT REFRACTORY
RED
IVORY
QTY
FULL
FULL
16
(112140-02) (112140-06)
S045R
S045W
1
S046R
S046W
6
S050R
S050W
5
S054R
S054W
1
S076R
S076W
6
S077R
S077W
6
S095R
S095W
1
S096R
S096W
1
www.fmiproducts.com
122274-01G
Installation
Continued
36" SPLIT HERRINGBONE BRICK MATRIX
S003
S0
02
FU
LL
FU
LL
FU
LL
FU
LL
FU
LL
S0
72
69
S0
S0
74
69
S0
LL
2
FU
03 03
S1 r S
o
FU
LL
69
S0
LL
FU
S073
S003
90
02
S0
14
14
S0
14
14
S0
FU
FU
LL
S0
LL
S0
FU
FU
LL
14
LL
S0
FU
FU
LL
04
91
S0
S0
01
S0
01
S0
S0
F1
94
S0
58
S0
58
S0
58
S0
58
69
S0
LL
FU
S0
58
69
S0
LL
FU
S0
58
69
S0
LL
FU
S0
58
69
S0
LL
FU
S0
75
71
S0
01
S0
04
S0
F120
S003
LL
14
S0
S0
14
S0
FU
LL
S0
FU
FU
LL
14
S0
LL
FU
FU
LL
14
S0
14
FU
LL
14
62
61
S0
S0
S0
71
59
F0
S0
14
15
LL
S0
F129
FU
LL
S0
55
5
S0
S0
55
55
55
55
S0
66
S0
S0
or
67
68
S0
S0
56
S0
65
S0
63
58
LL
F129
S0
FU
55
FU
LL
LL
58
FU
S0
FU
LL
S0
LL
FU
58
S0
FU
LL
S0
8
LL
FU
5
S0
FU
LL
LL
FU
58
S0
FU
LL
8
LL
FU
S0
02
S0
55
04
S0
93
F1
57
S0
1
0
S0
122274-01G
F120
S003
S0
S064
F130
LEFT REFRACTORY
RED
IVORY
QTY
FULL
FULL
12
(112140-02) (112140-06)
S001R
S001W
1
S002R
S002W
1
S003R
S003W
1
S004R
S004W
1
S032R
S032W
1
S058R
S058W
7
S069R
S069W
7
S071R
S071W
1
S072R
S072W
1
S073R
S073W
1
S074R
S074W
1
S075R
S075W
1
S103R
S103W
1
F120R
F120W
1
F194R
F194W
1
REAR REFRACTORY
RED
IVORY
QTY
FULL
FULL
12
(112140-02) (112140-06)
S001R
S001W
2
S002R
S002W
1
S003R
S003W
2
S004R
S004W
1
S014R
S014W
12
S015R
S015W
1
S059R
S059W
1
S061R
S061W
1
S062R
S062W
1
S090R
S090W
1
S091R
S091W
1
F071R
F071W
1
F120R
F120W
1
F129R
F129W
1
RIGHT REFRACTORY
RED
IVORY
QTY
FULL
FULL
(112140-02) (112140-06)
12
S001R
S001W
1
S002R
S002W
1
S003R
S003W
1
S004R
S004W
1
S055R
S055W
7
S056R
S056W
1
S057R
S057W
1
S058R
S058W
6
S063R
S063W
1
S064R
S064W
1
S065R
S065W
1
S066R
S066W
1
S067R
S067W
1
S068R
S068W
1
F129R
F129W
1
F130R
F130W
1
F193R
F193W
1
www.fmiproducts.com
25
Installation
Continued
42" SPLIT HERRINGBONE BRICK MATRIX
S003
S0
02
LL
S085
FU
LL
LL
S085
FU
FU
FU
FU
LL
FU
74
S085
S0
31
75
F1
71
S0
F0
03
FU
S1
02
LL
LL
S0
S085
FU
FU
02
LL
S0
LL
FU
FU
02
LL
LL
S0
FU
FU
02
LL
LL
S0
FU
FU
02
LL
S0
S085
LL
FU
FU
02
LL
S0
S085
LL
FU
FU
02
LL
S0
S085
LL
S0
02
01
S0
04
S0
01
S0
S087
LL
S003
LEFT REFRACTORY
RED
IVORY
QTY
FULL
FULL
19
(112140-02) (112140-06)
S001R
S001W
2
S002R
S002W
9
S003R
S003W
2
S004R
S004W
1
S054R
S054W
1
S074R
S074W
1
S075R
S075W
1
S085R
S085W
7
S087R
S087W
1
S088R
S088W
1
S103R
S103W
1
F071R
F071W
1
F131R
F131W
1
F054 or S088
S003
S003
02
S0
02
74
S0
74
S0
74
S0
74
S0
S0
74
S0
FU
S0
F0 84
71
59
S0
61
S0
S0
LL
60
S0
62
FU
74
LL
LL
04
S0
FU
04
S0
FU
LL
LL
FU
04
S0
FU
LL
LL
FU
04
S0
FU
LL
LL
FU
04
S0
FU
LL
LL
FU
04
S0
FU
LL
04
S0
S0
01
S0
83
S0
01
S0
F129
F120
S0
86
02
S0
02
S0
S0
02
S0
02
LL
LL
LL
LL
S0
02
S0
02
LL
LL
FU
FU
FU
FU
04
S1
F054
S0
02
LL
FU
74
LL
FU
FU
LL
FU
FU
65
S0
S0
LL
FU
LL
FU
S092 or S093
01
LL
LL
FU
S094
26
FU
LL
S089
LL
FU
S089
FU
LL
S089
04
FU
S089
S0
LL
FU
S089
S0
LL
FU
S089
01
S0 04
S0
S089
S003
S0
02
S003
S089
REAR REFRACTORY
RED
IVORY
QTY
FULL
FULL
12
(112140-02) (112140-06)
S001R
S001W
2
S002R
S002W
2
S003R
S003W
2
S004R
S004W
7
S059R
S059W
1
S060R
S060W
1
S061R
S061W
1
S062R
S062W
1
S074R
S074W
6
S083R
S083W
1
S084R
S084W
1
F071R
F071W
1
F120R
F120W
1
F129R
F129W
1
RIGHT REFRACTORY
RED
IVORY
QTY
FULL
FULL
18
(112140-02) (112140-06)
S001R
S001W
2
S002R
S002W
8
S003R
S003W
2
S004R
S004W
2
S065R
S065W
1
S074R
S074W
1
S086R
S086W
1
S089R
S089W
8
S092R
S092W
1
S093R
S093W
1
S094R
S094W
1
S104R
S104W
1
F054R
F054W
2
F054
www.fmiproducts.com
122274-01G
Installation
Continued
50" SPLIT HERRINGBONE BRICK MATRIX
S003
S0
98
S0
02
S0
07
7
7
7
7
7
7
FU
7
7
7
S0
9
7
7
02
S0
LL
02
S0
LL
LL
FU
FU
LL
LL
FU
FU
LL
LL
FU
FU
LL
LL
FU
FU
06
LL
LL
FU
S0
S0
62
08
S0
59
59
S0
S0
60
LL
LL
60
06
FU
FU
S0
S0
FU
LL
S0
S0
LL
FU
FU
S003
02
S0
LL
FU
LL
S007
FU
2
S0
0
LL
FU
S007
LL
LL
FU
FU
LL
S007
S007
FU
S007
5
07
S1
S088 or F054
S0
6
LL
1
0
S1
LL
FU
S007
7
FU
LL
LL
FU
LL
FU
LL
S007
FU
1
0
S1
LL
FU
1
0
S1
LL
FU
01
S1
LL
FU
01
FU
S1
LL
FU
01
S0
67
S0
93
S1
LL
FU
01
FU
4
S1
LL
0
S0
01
S0
08
S1
F195
S0
7
00
FU
FU
LL
12
S0
06
S0
06
S0
06
S0
06
06
LL
S0
S0
LL
FU
FU
06
06
LL
S0
S0
LL
FU
FU
06
06
LL
S102
REAR REFRACTORY
RED
IVORY
QTY
FULL
FULL
(112140-02) (112140-06) 24
S001R
S001W
2
S002R
S002W
2
S003R
S003W
2
S004R
S004W
2
S006R
S006W
13
S008R
S008W
1
S012R
S012W
1
S059R
S059W
2
S060R
S060W
2
S062R
S062W
2
S100R
S100W
1
F129R
F129W
3
F136R
F136W
1
F129
F129
S003
122274-01G
S0
LL
FU
FU
S0
06
S0
LL
LL
S1
36
04
FU
FU
F129
F1
01
S0
04
06
7
5
S003
S0
S0
01
S0
S0
7
S0
9
F1
3
7
S0
6
6
F120
S003
62
7
0
S1
S0
0
0
S1
LL
FU
LL
S0
0
FU
LL
LL
S0
9
FU
LL
S0
0
FU
LL
LL
S0
9
FU
LL
S0
0
FU
LL
LL
FU
LL
S0
0
FU
LL
LL
S0
9
FU
LL
S0
0
FU
LL
LL
S0
9
FU
LL
S0
0
FU
LL
04
FU
01
S0
FU
S0
FU
01
S0
FU
04
S0
FU
S093 or S099
F130
LEFT REFRACTORY
RED
IVORY
QTY
FULL
FULL
(112140-02) (112140-06) 18
S001R
S001W
2
S002R
S002W
1
S003R
S003W
2
S004R
S004W
2
S007R
S007W
8
S067R
S067W
1
S093R
S093W
1
S097R
S097W
6
S098R
S098W
1
S099R
S099W
1
S105R
S105W
1
S106R
S106W
1
F120R
F120W
1
F130R
F130W
1
F137R
F137W
1
S003
F139
RIGHT REFRACTORY
RED
IVORY
QTY
FULL
FULL
(112140-02) (112140-06( 18
S001R
S001W
1
S002R
S002W
2
S003R
S003W
2
S004R
S004W
1
S007R
S007W
7
S067R
S067W
2
S075R
S075W
1
S088R
S088W
1
S093R
S093W
1
S101R
S101W
7
S102R
S102W
1
S107R
S107W
1
S108R
S108W
1
F054R
F054W
1
F139R
F139W
1
F195R
F195W
1
www.fmiproducts.com
27
Installation
Continued
Grouting instructions
Material provided:
1 or 2 - 10 lb. bags of cement (depending
on model)
1 or 2 - 10 lb. bags of sand (depending
on model)
Material required:
1 - Piping bag
1 - Joints striker
1 - Heavy duty mixing bucket
1 - Trowel
1. Moisten brick surface with damp sponge
or spray bottle just prior to application.
When bricks are wet, any excess grout
mixture on bricks will easily wipe off.
2. In a heavy duty mixing bucket, pour seven
(4-1/2) cups of water. Add 5 lbs. (half of a
bag) of sand and 5 lbs (half of a bag) of
cement. Mix together well using a power
drill with mixing wand attachment to a yogurt like consistency, not adding enough
water can lead to grout falling out after
burning.
3. The overall length of piping bag should be
about 16". If the bag is longer than 16",
cut it down to size by removing end with
larger opening. This will make the bag
easier to handle.
4. Put 2 to 3 cups of grout mixture into piping
bag making sure the smaller opening is
downward and over a moist towel to avoid
spilling. Place a wet towel over the bucket
making sure it is directly on the surface of
grout mixture. This will keep the mixture
moist and it will not dry out before use.
5. Begin grouting by first doing a “Filler
Pass”. This is done by filling the joint about
3/4 full with grout mixture. It is important
to work with only 6 bricks at a time so
grout doesn't have time to set up before
striking.
6. Complete a “Finishing Pass” around 6
bricks you just put filler pass around. This
is done by slowly filling in remainder of the
joint with a thick amount of grout mixture.
Mixture should be a little higher than the
brick surface.
7. Using a trowel, remove excess grout mix-
28
ture by moving trowel in the direction of the
joint. Grout mixture in the joint should now
be flush with brick surface. If not enough
grout is applied into each space, grout may
fall out after burning.
8. Using a joint striker, force grout mixture
into joint and sweep back and forth
until grout is smooth and round. If grout
becomes too shallow, add more grout
mixture with piping bag and strike again.
9. Continue procedure around each group of
6 bricks until an entire panel is finished.
10.Using trowel, scrape in direction of joints
to remove any grout that may have collected around bricks during striking. If
desired, take a moist sponge and lightly
sweep over bricks to remove any grout
that may have gotten on bricks. DO NO
PRESS HARD OR RUB IN A CIRCULAR
MOTION. This will press the grout into
brick and turn brick a different color.
Allow 72 hours before
operating fireplace.
Figure 16 - Grouting Brick
INSTALLING FIREPLACE HOOD
AND SCREEN
1. Attach hood to firebox using screws provided (see Figure 17, page 29).
2. Mount screen rod brackets on left and right
side of smoke shelf with #8 x 1/2" screws
provided (see Figure 18, page 29).
3. Slide round end of screen rod into rings
at top of screen. Attach one push-on nut
to end of rod before attaching last ring of
screen.
4. Insert round end of rod into rod bracket
on left side of fireplace.
www.fmiproducts.com
122274-01G
Installation
Continued
5. Mount flat end of screen rod with #10 x 5/8"
to center of smoke shelf (see Figure 18).
6. Install other screen rod in same manner.
Screen
Rod
Bracket
Fireplace Front
Smoke Shelf
Screen
Rod
Screws
Figure 17 - Screw and Hood Placement
Push
On Nut
Ring
Screen
Figure 18 - Installing Fireplace Screen
Technical Service
You may have further questions about
installation, operation, or troubleshooting.
If so, contact FMI PRODUCTS, LLC at
1-866-328-4537.
When calling, please have your model and
serial numbers of your firebox ready.
You can also visit FMI PRODUCTS, LLC’s
web site at www.fmiproducts.com.
Replacement Parts
Note: Use only original replacement parts.
This will protect your warranty coverage for
parts replaced under warranty.
Contact authorized dealers of this product.
If they can’t supply original replacement
part(s), call FMI PRODUCTS, LLC at
1-866-328-4537.
122274-01G
When calling FMI PRODUCTS, LLC, have
ready
• your name
• your address
• model and serial numbers of your firebox
• how firebox was malfunctioning
• type of gas used (propane/LP or natural
gas)
• purchase date
Usually, we will ask you to return the part to
the factory.
www.fmiproducts.com
29
Parts
Models (V)Um36(Sr,SI,HR,HI), VCM-36U, (V)Um42(Sr,SI,HR,HI), VCM-42U,
(V)Um50(Sr,SI,HR,HI), VCM-50U
11
10
13
12
9
14
8
17/18
16
7
15
6
13
5
24
1
19
19
22
21
4
13
3
23
14
26
15
16
2
17/18
26
16
25
20
30
www.fmiproducts.com
122274-01G
Parts
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
**
**
**
120826-01
120826-02
120826-03
**
**
**
**
**
110454-03
110454-02
110454-01
23490SA
**
109720-02
117891-01
20042
21171
109752-01
109752-02
20106
**
123298-01
**
**
109511-01
109511-02
109511-03
109457-01
109457-02
109457-03
20806
110146-02
110146-03
Face Assembly
Firebox Bottom Assembly
Firebox Bottom
Hearth Brick Panel, 36"
Hearth Brick Panel, 42"
Hearth Brick Panel, 50"
Firebox Surround
Firebox Top
Insulation Pan Support
Insulation Pan
Top Insulation
Fireplace Top, 36"
Fireplace Top, 42"
Fireplace Top, 50"
Standoff
Fireplace Surround Assembly
Clearance Spacer
Fireplace Handle Bracket
Outside Air Cover Plate
Gas Conduit Cover
Conduit One
Conduit Two
Nailing Strap
Heat Shield Support
Ash Box Assembly
Ash Box Ring
Hearth Support Brace
Hood
Hood
Hood
Screen
Screen
Screen
Screen Rod
Screen Rod
Screen Rod
PARTS AVAILABLE NOT SHOWN
see page 26 Brick Panel Assemblies with Brick
Housings (1 each, right, left, rear)
M42
M36
DESCRIPTION
(V)U
1
2
3
4
(V)U
KEY
NO. PART NO.
, VC
M-36
U
, VC
M-42
(V)U
U
M50
, VC
M-50
U
This list contains replaceable parts used in your firebox. When ordering parts, follow the
instructions listed under Replacement Parts on page 29 of this manual.
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
QTY.
•
1
1
1
1
1
1
1
1
1
1
1
1
1
1
4
1
6
4
2
4
2
2
6
1
1
1
1
1
1
1
2
2
2
2
2
2
•
1
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
** Not a field replaceable part.
122274-01G
www.fmiproducts.com
31
Parts
Models (V)Um36(Sr,SI,HR,HI), (V)Um42(Sr,SI,HR,HI), (V)Um50(Sr,SI,HR,HI),
MK-36(SS,SH)-(R)(I), MK-42(SH,SS)-(R)(I), MK-50(SH,SS)-(R)(I)
PART NO.
122317-02
122319-02
122321-02
122323-02
122327-02
122327-02
122317-01
122319-01
122321-01
122323-01
122325-01
122327-01
122354-01
122354-02
122354-03
122356-01
122356-02
122356-03
PART NO.
120842-01
120842-02
120842-03
120845-01
120845-02
120845-03
120843-01
120843-02
120843-03
120846-01
120846-02
120846-03
120844-01
120844-02
120844-03
120847-01
120847-02
120847-03
32
DESCRIPTION
36" Full Stack Left
42" Full Stack Left
50" Full Stack Left
36" Full Herringbone Left
42" Full Herringbone Left
50" Full Herringbone Left
36" Full Stack Right
42" Full Stack Right
50" Full Stack Right
36" Full Herringbone Right
42" Full Herringbone Right
50" Full Herringbone Right
36" Full Stack Rear
42" Full Stack Rear
50" Full Stack Rear
36" Full Herringbone Rear
42" Full Herringbone Rear
50" Full Herringbone Rear
DESCRIPTION
36" Split Stack Left
42" Split Stack Left
50" Split Stack Left
36" Split Herringbone Left
42" Split Herringbone Left
50" Split Herringbone Left
36" Split Stack Right
42" Split Stack Right
50" Split Stack Right
36" Split Herringbone Right
42" Split Herringbone Right
50" Split Herringbone Right
36" Split Stack Rear
42" Split Stack Rear
50" Split Stack Rear
36" Split Herringbone Rear
42" Split Herringbone Rear
50" Split Herringbone Rear
QTY.
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
MK36S
H-(R
)(I)
MK36S
S-(R
)(I)
MK42S
H-(R
)(I)
MK42S
S-(R
MK)(I)
50S
H-(R
)(I)
MK50S
S-(R
)(I)
All parts are Housing Panel Assemblies.
For Brick part numbers see pages 15 thru 27.
(V)U
M36
H(R
)(I)
(V)U
M36
S(R
)(I)
(V)U
M42
H(R
)(I)
(V)U
M42
S(R
)(I)
(V)U
M50
H(R
)(I)
(V)U
M50
S(R
)(I)
This list contains replaceable parts used in your firebox. When ordering parts, follow the
instructions listed under Replacement Parts on page 29 of this manual.
QTY.
•
•
•
•
•
•
www.fmiproducts.com
•
•
•
•
•
•
•
•
•
•
•
•
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
122274-01G
NOTES
_____________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
_____________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
_____________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
122274-01G
www.fmiproducts.com
33
NOTES
_____________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
_____________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
_____________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
34
www.fmiproducts.com
122274-01G
NOTES
_____________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
_____________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
_____________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
______________________________________________________
122274-01G
www.fmiproducts.com
35
Warranty
KEEP THIS WARRANTY
Model (located on product or identification tag)______________________________
Serial No. (located on product or identification tag)___________________________
Date Purchased ___________________________
Keep receipt for warranty verification.
FMI PRODUCTS, LLC LIMITED WARRANTIES
New Products
Standard Warranty: FMI PRODUCTS, LLC warrants this new product and any parts thereof to be free from defects
in material and workmanship for a period of four (4) years from the date of first purchase from an authorized dealer
provided the product has been installed, maintained and operated in accordance with FMI PRODUCTS, LLC’s
warnings and instructions.
For products purchased for commercial, industrial or rental usage, this warranty is limited to 90 days from the date
of first purchase.
Factory Reconditioned Products
Limited Warranty: FMI PRODUCTS, LLC warrants factory reconditioned products and any parts thereof to be
free from defects in material and workmanship for 30 days from the date of first purchase from an authorized dealer
provided the product has been installed, maintained and operated in accordance with FMI PRODUCTS, LLC’s
warnings and instructions.
Terms Common to All Warranties
The following terms apply to all of the above warranties:
Always specify model number and serial number when contacting the manufacturer. To make a claim under this
warranty the bill of sale or other proof of purchase must be presented.
This warranty is extended only to the original retail purchaser when purchased from an authorized dealer, and only
when installed by a qualified installer in accordance with all local codes and instructions furnished with this product.
This warranty covers the cost of part(s) required to restore this product to proper operating condition and an allowance for labor when provided by a FMI PRODUCTS, LLC Authorized Service Center or a provider approved by
FMI PRODUCTS, LLC. Warranty parts must be obtained through authorized dealers of this product and/or FMI
PRODUCTS, LLC who will provide original factory replacement parts. Failure to use original factory replacement
parts voids this warranty.
Travel, handling, transportation, diagnostic, material, labor and incidental costs associated with warranty repairs,
unless expressly covered by this warranty, are not reimbursable under this warranty and are the responsibility of
the owner.
Excluded from this warranty are products or parts that fail or become damaged due to misuse, accidents, improper
installation, lack of proper maintenance, tampering, or alteration(s).
This is FMI PRODUCTS, LLC’s exclusive warranty, and to the full extent allowed by law; this express warranty
excludes any and all other warranties, express or implied, written or verbal and limits the duration of any and all
implied warranties, including warranties of merchantability and fitness for a particular purpose to four (4) years on
new products and 30 days on factory reconditioned products from the date of first purchase. FMI PRODUCTS, LLC
makes no other warranties regarding this product.
FMI PRODUCTS, LLC’s liability is limited to the purchase price of the product, and FMI PRODUCTS, LLC shall not
be liable for any other damages whatsoever under any circumstances including indirect, incidental, or consequential
damages.
Some states do not allow limitations on how long an implied warranty lasts or the exclusion or limitation of incidental
or consequential damages, so the above limitation or exclusion may not apply to you.
This warranty gives you specific legal rights, and you may also have other rights which vary from state to state.
For information about this warranty contact:
2701 S. Harbor Blvd.
Santa Ana, CA 92704
1-866-328-4537
www.fmiproducts.com
122274-01
Rev. G
04/10