ITW CHEMTRONICS MSDS # 2003L

ITW CHEMTRONICS  MSDS # 2003L
ITW CHEMTRONICS
MSDS # 2003L
SECTION 1: CHEMICAL PRODUCT AND COMPANY INFORMATION
Company Address:
8125 Cobb Center Drive
Kennesaw, GA 30152
Product Information: 800-TECH-401
Customer Service:
800-645-5244
Emergency:
Revision Date:
(Chemtrec) 800-424-9300
October 21, 2011
Product Identification
STATIC FREE! MAT & BENCHTOP RECONDITIONER
Product Code: ES1664T, ES3264, ES164
SECTION 2: COMPOSITION, INFORMATION ON INGREDIENTS
Product Ingredient Information
CAS#
Deionized water
7732-18-5
Propylene Glycol Methyl Ether
107-98-2
Dipropylene Glycol Methyl Ether
34590-94-8
Nonylphenoxypolyethoxy ethanol
9016-45-9
Propylene glycol n-butyl ether
5131-66-8
Quaternary ammonium compound
68308-67-8
Wt. % Range
90.0-95.0
0.1-5.0
1.0-5.0
0.1-1.0
0.5-1.5
0.1–2.0
SECTION 3: HAZARD IDENTIFICATION
Emergency Overview: Clear, colorless liquid with pleasant clean odor. Liquid will irritate eyes and skin under repeated or prolonged exposure. Breathing high
concentrations of product vapor may produce drowsiness and a headache. This product is not flammable.
Potential Health Effects:
Eyes:
Liquid and vapors of this product are irritating.
Skin:
Contact may cause skin irritation.
Ingestion: Harmful if swallowed. Irritating to mouth, throat and stomach. May cause vomiting.
Inhalation: No hazard in normal industrial use. Vapors or atomized particles may be irritating to eyes and respiratory tract.
Pre-Existing Medical Conditions Aggravated by Exposure: Skin and eye.
SECTION 4: FIRST AID MEASURES
Eyes:
Immediately flush with plenty of water. After initial flushing, remove any contact lenses and continue flushing for at least 15 minutes. Have eyes examined
and tested by medical personnel if irritation develops or persists.
Skin: Wash skin with soap and water. Remove contaminated clothing. Get medical attention if irritation develops or persist. Wash clothing separately before reuse.
Ingestion: Swallowing less than an ounce will not cause significant harm. For larger amounts, do not induce vomiting, but give one or two glasses of water to drink and
get immediate medical attention.
Inhalation: Remove to fresh air. If not breathing, give artificial respiration. If breathing is difficult, give oxygen. Get medical attention.
SECTION 5: FIRE FIGHTING MEASURES
Flash Point: None to boiling (TCC)
LEL/UEL: Not established (% by volume in air)
Extinguishing media: Use alcohol foam, carbon dioxide, or water spray when fighting fires involving this material.
Fire Fighting Instructions: As in any fire, wear self-contained breathing apparatus (pressure-demand, MSHA/NIOSH approved or equivalent) and full protective gear.
SECTION 6: ACCIDENTAL RELEASE MEASURES
Large Spills: Shut off leak if possible and safe to do so. Wear appropriate personal protective equipment. Absorb spill with inert material (e.g. dry sand or earth), then
place in a chemical waste container for proper disposal. Do not flush to sewer. Avoid runoff into storm sewers and ditches which lead to waterways.
Small Spills: Absorb spill with inert material (e.g. dry sand or earth), then place in a chemical waste container for proper disposal.
SECTION 7: HANDLING AND STORAGE
Avoid prolonged or repeated contact with eyes, skin, and clothing. Wash hands before eating. Use with adequate ventilation. Avoid breathing product vapor or mist.
Do not reuse this container. Store in a cool dry place away from heat, sparks and flame. Keep container closed when not in use. Do not store in direct sunlight.
KEEP OUT OF REACH OF CHILDREN.
SECTION 8: EXPOSURE CONTROLS, PERSONAL PROTECTION
Exposure Guidelines:
CHEMICAL NAME
ACGIH TLV
OSHA PEL
ACGIH STEL
Nonylphenoxypolyethoxy ethanol
NA
NA
NA
Dipropylene Glycol Methyl Ether
100 ppm
100 ppm
150 ppm
Propylene Glycol Methyl Ether
100 ppm
NA
150 ppm
Propylene glycol n-butyl ether
NA
NA
NA
Work/Hygienic Practices: Good general ventilation should be sufficient to control airborne levels. Local exhaust ventilation may be necessary to control any air
contaminants to within their TLVs during the use of this product. If vapor concentration exceeds TLV, use NIOSH approved organic vapor cartridge respirator.
Wear safety glasses with side shields (or goggles) and rubber or other chemically resistant gloves when handling this material.
NFPA and HMIS Codes:
NFPA
HMIS
Health
1
1
Flammability
0
0
Reactivity
0
0
Personal Protection
B
Page 1 of 2
ITW CHEMTRONICS
MSDS # 2003L
SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES
Physical State: Clear, colorless liquid
Odor: Pleasant, clean
pH: 5.5-6.5
Vapor Pressure: 18 mm Hg @ 68F
Vapor Density: > 1
(Air =1)
Boiling Point: 212"F (100C)
Solubility in Water: Completely
Gravity: (Water =1) 0.997
Evaporation Rate: <1
(Butyl acetate=1):
Viscosity: 1 (Approx.)
(Water =1)
Percent Volatile: 100%
Melting Point: NA
SECTION 10: STABILITY AND REACTIVITY
Stability - This product is stable. Conditions to Avoid: Do not spray near open flames, red hot surfaces or other sources of ignition.
Incompatibility: Do not mix with strong acids or strong oxidizing agents.
Products of Decomposition: Thermal decomposition may release carbon monoxide, carbon dioxide and incompletely burned hydrocarbons.
Hazardous Polymerization: Will not occur
Conditions to Avoid: NA
SECTION 11: TOXICOLOGICAL INFORMATION
Inhalation:
Propylene glycol methyl ether Human TCLo 3000 ppm
Ingestion:
Propylene glycol methyl ether Rat LD50 5660 mg/kg
Dipropylene glycol methyl ether Rat LD50 5135 mg/kg
Propylene glycol n-butyl ether* Rat LD50 3300 mg/kg
Skin:
Propylene glycol methyl ether Rabbit 500 mg Open; MLD
Dipropylene glycol methyl ether Rabbit 500 mg Open; MLD
Propylene glycol n-butyl ether Rabbit LD50 3100 mg/kg
Eye:
Propylene glycol methyl ether Rabbit 230 mg; MLD
Dipropylene glycol methyl ether Rabbit 238 mg; MLD
* Information provided by manufacturer.
Cancer Information: No ingredients listed as human carcinogens by NTP or IARC
Reproductive effects: none
Teratogenic effects: none
Mutagenic effects: none
SECTION 12: ECOLOGICAL INFORMATION
Environmental Impact Information
Avoid runoff into storm sewers and ditches which lead to waterways. Water runoff can cause environmental damage.
REPORTING
US regulations require reporting spills of this material that could reach any surface waters. The toll free number for the US Coast Guard National Response Center is:
1-800-424-8802
SECTION 13: DISPOSAL CONSIDERATIONS
Dispose of in accordance with all federal, state and local regulations. Water runoff can cause environmental damage.
SECTION 14: TRANSPORTATION INFORMATION
For Ground and Air Transportation shipments:
Proper Shipping Name: Cleaning Compound
Not Regulated
SECTION 15: REGULATORY INFORMATION
SECTION 313 SUPPLIER NOTIFICATION
This product contains no toxic chemicals subject to the reporting requirements of Section 313 of the Emergency Planning and Community Right-To-Know Act of 1986
(40 CFR 372).
This information should be included on all MSDSs copied and distributed for this material.
TOXIC SUBSTANCES CONTROL ACT (TSCA).
All ingredients of this product are listed on the TSCA Inventory.
WHMIS: Class D2B
This product has been classified according to the hazard criteria of the CPR and the MSDS contains all of the information required by the CPR.
SECTION 16: OTHER INFORMATION
Normal ventilation for standard manufacturing practices is usually adequate. Local exhaust should be used when large amounts are released.
To the best of our knowledge, the information contained herein is accurate. However, all materials may present unknown hazards and should be used with caution. In
particular, improper use of our products and their inappropriate combination with other products and substances may produce harmful results which cannot be
anticipated. Final determination of the suitability of any material is the sole responsibility of the user. Although certain hazards are described herein, we cannot
guarantee that these are the only hazards that may exist.
Page 2 of 2
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement