Manual 21005026

Manual 21005026
®
ITW CHEMTRONICS
MSDS #0311L
SECTION 1: CHEMICAL PRODUCT AND COMPANY INFORMATION
Company Address:
8125 Cobb Center Drive
Kennesaw, GA 30152
Product Information: 800-TECH-401
Customer Service:
800-645-5244
Emergency:
Revision Date:
(Chemtrec) 800-424-9300
April 15, 2010
Product Identification
FLUX-OFF® AQUEOUS (Liquid)
Product Code: ES132, ES832L
SECTION 2: COMPOSITION/INFORMATION ON INGREDIENTS
Chemical Name
Deionized water
Dipropylene glycol methyl ether
Propylene glycol butyl ether
Sodium xylene sulfonate
Sodium metasilicate
Benzyl alcohol
CAS#
7732-18-5
34590-94-8
5131-66-8/15821-83-7
1300-72-7
6834-92-0
100-51-6
Wt. % Range
50.0-75.0
10.0-20.0
5.0-10.0
5.0-10.0
1.0-5.0
0.5-2.0
SECTION 3: HAZARDS IDENTIFICATION
Emergency Overview: Clear, colorless liquid with mild solvent odor. Liquid will irritate eyes and skin under repeated or prolonged exposure. Breathing high
concentrations of product vapor may produce central nervous system depression. This product is not flammable.
Potential Health Effects:
Eyes: DO NOT get in eyes. This product is irritating and can cause pain, tearing, reddening and swelling accompanied by a stinging sensation.
Skin: Contact may cause skin irritation.
Ingestion: DO NOT take internally. Harmful if swallowed. Irritating to mouth, throat and stomach. May cause vomiting.
Inhalation: Excessive inhalation of vapors can cause nasal and respiratory irritation and central nervous system effects including dizziness, weakness, fatigue, nausea,
headache and unconsciousness.
Pre-Existing Medical Conditions Aggravated by Exposure: Lung, skin, eye and central nervous system.
SECTION 4: FIRST AID MEASURES
Eyes: Immediately flush with plenty of water. After initial flushing, remove any contact lenses and continue flushing for at least 15 minutes. Have eyes examined and
tested by medical personnel if irritation develops or persists.
Skin: Wash skin with soap and water immediately. Remove contaminated clothing. Get medical attention if irritation develops or persist. Wash clothing separately
before reuse.
Ingestion: Swallowing less than an ounce will not cause significant harm. For larger amounts, do not induce vomiting, but give one or two glasses of water to drink and
get immediate medical attention.
Inhalation: Remove to fresh air. If not breathing, give artificial respiration. If breathing is difficult, give oxygen. Get medical attention.
SECTION 5: FIRE FIGHTING MEASURES
Flash Point: >200°F (>100C)
LEL/UEL: Not established (% by volume in air)
Extinguishing Media: Use water fog, carbon dioxide, or dry chemical when fighting fires involving this material.
Fire Fighting Instructions: As in any fire, wear self-contained breathing apparatus (pressure-demand, MSHA/NIOSH approved or equivalent) and full protective gear.
SECTION 6: ACCIDENTAL RELEASE MEASURES
Large Spills: Shut off leak if possible and safe to do so. Wear self-contained breathing apparatus and appropriate personal protective equipment. Absorb spill with
inert material (e.g. dry sand or earth), then place in a chemical waste container for proper disposal. Do not flush to sewer. Avoid runoff into storm sewers and ditches
which lead to waterways.
Small Spills: Absorb spill with inert material (e.g. dry sand or earth), then place in a chemical waste container for proper disposal.
SECTION 7: HANDLING AND STORAGE
Avoid prolonged or repeated contact with eyes, skin, and clothing. Wash hands thoroughly after handling or contact. Use with adequate ventilation. Avoid breathing
product vapor or mist. Do not reuse this container. Store in a cool dry place away from heat, sparks and flame. Keep container closed when not in use. Do not store in
direct sunlight.
KEEP OUT OF REACH OF CHILDREN.
SECTION 8: EXPOSURE CONTROLS, PERSONAL PROTECTION
Exposure Guidelines:
CHEMICAL NAME
ACGIH TLV
OSHA PEL
ACGIH STEL
Dipropylene glycol methyl ether
100 ppm
100 ppm
150 ppm
Propylene glycol butyl ether
NA
NA
NA
Benzyl alcohol
NA
NA
NA
Work/Hygienic Practices: Good general ventilation should be sufficient to control airborne levels. If vapor concentration exceeds TLV, use NIOSH approved organic
vapor cartridge respirator. Wear safety glasses with side shields (or goggles) and rubber or other chemically resistant gloves when handling this material.
NFPA and HMIS Codes:
NFPA
HMIS
Health
1
1
Flammability
0
0
Reactivity
0
0
Personal Protection
B
Page 1 of 2
®
ITW CHEMTRONICS
SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES
Physical State: Clear, pale yellow liquid
Odor: Mild solvent
pH: 12 - 14
Vapor Pressure: 14 mm Hg @ 25C
Vapor Density: Not available
Boiling Point: 212 F (100C)
MSDS #0311L
Solubility in Water: Completely
Specific Gravity: (Water =1) 1.03
Evaporation Rate: <1 (Butyl acetate=1)
Melting Point: NA
Percent Volatile: 93%
SECTION 10: STABILITY AND REACTIVITY
Stability - This product is stable. Conditions to Avoid: Do not spray near open flames, red hot surfaces or other sources of ignition.
Incompatibility: Do not mix with aluminum, galvanized iron and zinc, powdered alkali and alkaline earth metals or strong oxidizing agents.
Products of Decomposition: Thermal decomposition may release carbon monoxide, carbon dioxide and incompletely burned hydrocarbons.
Hazardous Polymerization: Will not occur
Conditions to Avoid: NA
SECTION 11: TOXICOLOGICAL INFORMATION
Ingestion:
Sodium metasilicate
LD50/rats
1153 mg/kg
Dipropylene glycol
methyl ether
LD50/rat
5135 mg/kg
Propylene glycol butyl ether
LD50/rat
3300 mg/kg
Skin:
Dipropylene glycol
methyl ether
LD50/rats
9,500 mg/kg
Sodium metasilicate
Human
250 mg/24H SEV
Propylene glycol butyl ether
LD50/Rabbit
3100 mg/kg
Cancer Information: No ingredients listed as human carcinogens by NTP or IARC
Reproductive effects: none
Teratogenic effects: none
Inhalation: Not considered a hazard.
Eye:
Dipropylene glycol methyl ether
human
8 mg MLD
Mutagenic effects: none
SECTION 12: ECOLOGICAL INFORMATION
Environmental Impact Information
Avoid runoff into storm sewers and ditches which lead to waterways. Water runoff can cause environmental damage.
REPORTING
US regulations require reporting spills of this material that could reach any surface waters. The toll free number for the US Coast Guard National Response Center
is:1-800-424-8802
SECTION 13: DISPOSAL CONSIDERATIONS
Dispose of in accordance with all federal, state and local regulations. Water runoff can cause environmental damage.
SECTION 14: TRANSPORTATION INFORMATION
Proper
Shipping Name
Air and Ground:: Cleaning Compound
Not Regulated
SECTION 15: REGULATORY INFORMATION
SECTION 313 SUPPLIER NOTIFICATION
This product contains no toxic chemicals subject to the reporting requirements of Section 313 of the Emergency Planning and Community Right-To-Know Act of 1986
(40 CFR 372).
This information should be included on all MSDSs copied and distributed for this material.
TOXIC SUBSTANCES CONTROL ACT (TSCA).
All ingredients of this product are listed on the TSCA Inventory.
WHMIS: Class D2B
This product has been classified according to the hazard criteria of the CPR and the MSDS contains all of the information required by the CPR.
SECTION 16: OTHER INFORMATION Note: This MSDS is applicable to date codes of 1215 and later.
Normal ventilation for standard manufacturing practices is usually adequate. Local exhaust should be used when large amounts are released.
To the best of our knowledge, the information contained herein is accurate. However, all materials may present unknown hazards and should be used with caution. In
particular, improper use of our products and their inappropriate combination with other products and substances may produce harmful results which cannot be
anticipated. Final determination of the suitability of any material is the sole responsibility of the user. Although certain hazards are described herein, we cannot
guarantee that these are the only hazards that may exist.
Page 2 of 2
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement