GAS GRILL
GAS GRILL
Natural Gas Grill Owner’s Guide
ESNA
Guía del Propietario de la Barbacoa de Gas Natural - Pg. 27
Mode d’emploi du Grill à gaz naturel - Pg. 53
620
#56216
You must read this Owner’s Guide
before operating your gas grill.
m DANGER
If you smell gas:
1.Shut off gas to the appliance.
2.Extinguish any open flames.
3.Open lid.
4.If odor continues, keep away from the
appliance and immediately call your gas
supplier or your fire department.
Leaking gas may cause a fire or explosion
which can cause serious bodily injury,
death, or damage to property.
mWARNING: Follow all leak-check
procedures carefully in this manual prior
to barbecue operation. Do this even if the
barbecue was dealer-assembled.
NOTICE TO INSTALLER: These instructions
must be left with the owner and the owner
should keep them for future use.
THIS GAS APPLIANCE IS DESIGNED FOR
OUTDOOR USE ONLY.
mWARNING: Do not ignite this appliance
without first reading the BURNER
IGNITION sections of this manual.
m WARNING:
1.Do not store or use gasoline or other
flammable liquids or vapors in the
vicinity of this or any other appliance.
2.An LP cylinder not connected for use
shall not be stored in the vicinity of this
or any other appliance.
56216 02/28/11 NG
US - ENGLISH
WARNINGS
m DANGER
Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious bodily injury or
death, or in a fire or an explosion causing damage to property.
m WARNINGS
mDo not store a spare or disconnected liquid propane
cylinder under or near this barbecue.
mImproper assembly may be dangerous. Please follow the
assembly instructions carefully.
mAfter a period of storage, and/or nonuse, the Weber® gas
barbecue should be checked for gas leaks and burner
obstructions before use. See instructions in this manual for
correct procedures.
mDo not operate the Weber® gas barbecue if there is a gas
leak present.
mDo not use a flame to check for gas leaks.
m Combustible materials should never be within 24 inches (61
cm) of the back or sides of your Weber® gas barbecue.
mDo not put a barbecue cover or anything flammable on, or in
the storage area under the barbecue.
m Your Weber® gas barbecue should never be used by
children. Accessible parts of the barbecue may be very hot.
Keep young children away while it is in use.
m You should exercise reasonable care when operating your
Weber® gas barbecue. It will be hot during cooking or
cleaning and should never be left unattended, or moved
while in operation.
mShould the burners go out while in operation, turn all
gas valves off. Open the lid and wait five minutes before
attempting to relight, using the igniting instructions.
mDo not use charcoal or lava rock in your Weber® gas
barbecue.
mNever lean over open grill or place hands or fingers on the
front edge of the cookbox.
mShould a grease fire occur, turn off all burners and leave lid
closed until fire is out.
mDo not enlarge valve orifices or burner ports when cleaning
the valves or burners.
mThe Weber® gas barbecue should be thoroughly cleaned on
a regular basis.
mLiquid propane gas is not natural gas. The conversion or
attempted use of natural gas in a liquid propane unit or
liquid propane gas in a natural gas unit is dangerous and
will void your warranty.
2
mDo not attempt to disconnect any gas fitting while your
barbecue is in operation.
mUse heat-resistant barbecue mitts or gloves when operating
barbecue.
m Keep any electrical supply cord and the fuel supply hose
away from any heated surfaces.
m Combustion byproducts produced when using this product
contain chemicals known to the state of California to cause
cancer, birth defects, or other reproductive harm.
mDo not use this barbecue unless all parts are in place. The
unit must be properly assembled according to the assembly
instructions.
mDo not build this model of grill in any built-in or slide-in
construction. Ignoring this Warning could cause a fire or
an explosion that can damage property and cause serious
bodily injury or death.
mProposition 65 Warning: Handling the brass material on
this product exposes you to lead, a chemical known to the
state of California to cause cancer, birth defects or other
reproductive harm.
(Wash hands after handling this product.) ◆
LIQUID PROPANE GAS UNITS ONLY:
mUse the pressure regulator and hose assembly that is
supplied with your Weber® gas barbecue.
mDo not attempt to disconnect the gas regulator and hose
assembly or any gas fitting while your barbecue is in
operation.
mA dented or rusty liquid propane cylinder may be hazardous
and should be checked by your liquid propane supplier. Do
not use a liquid propane cylinder with a damaged valve.
mAlthough your liquid propane cylinder may appear to be
empty, gas may still be present, and the cylinder should be
transported and stored accordingly.
mIf you see, smell or hear the hiss of escaping gas from the
liquid propane cylinder:
1.Move away from liquid propane cylinder.
2.Do not attempt to correct the problem yourself.
3. Call your fire department. ◆
TABLE OF CONTENTS
WARNINGS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
TROUBLESHOOTING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
TABLE OF CONTENTS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
SIDE BURNER TROUBLESHOOTING. . . . . . . . . . . . . . . . . . . . 21
EXPLODED VIEW. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
GRILL OUT™ HANDLE LIGHT TROUBLESHOOTING . . . . . . . 21
EXPLODED VIEW LIST . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
MAINTENANCE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
CLEANING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
WARRANTY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
WEBER® SPIDER/INSECT SCREENS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
BURNER TUBE CLEANING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
GENERAL INSTRUCTIONS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
REPLACING MAIN BURNERS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
CANADIAN INSTALLATION. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
SIDE BURNER MAINTENANCE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
STORAGE AND/OR NONUSE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
ANNUAL MAINTENANCE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
OPERATING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
GAS SUPPLY TESTING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
GAS INSTRUCTIONS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
INSTALL GAS SUPPLY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
TYPE OF GAS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
WHAT IS NATURAL GAS?. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
PORTABLE INSTALLATION. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
LEAK CHECK PREPARATION. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
CHECK THE FLEXIBLE HOSE TO MANIFOLD CONNECTION . . . . . . . . . . . . . 11
CHECK FOR GAS LEAKS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
LIGHT FEATURES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
WEBER® GRILL OUT™ HANDLE LIGHT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
BEFORE USING YOUR GRILL. . . . . . . . . . . . . . . . . . . . . . . . . . 13
SLIDE OUT GREASE TRAY AND DISPOSABLE DRIP PAN. . . . . . . . . . . . . . . . . 13
HOSE INSPECTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
SNAP IGNITION OPERATION . . . . . . . . . . . . . . . . . . . . . . . . . . 14
MAIN BURNER IGNITION & USAGE. . . . . . . . . . . . . . . . . . . . . 15
MAIN BURNER IGNITION. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
TO EXTINGUISH. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
MAIN BURNER MANUAL IGNITION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
TO EXTINGUISH. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
GRILLING TIPS & HELPFUL HINTS. . . . . . . . . . . . . . . . . . . . . 17
PREHEATING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
COVERED COOKING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
DRIPPINGS AND GREASE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
FLAVORIZER® SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
COOKING METHODS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
DIRECT COOKING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
INDIRECT COOKING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
SIDE BURNER IGNITION & USAGE . . . . . . . . . . . . . . . . . . . . . 19
SIDE BURNER IGNITION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
TO EXTINGUISH. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
SIDE BURNER MANUAL IGNITION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
TO EXTINGUISH. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
www.weber.com®
3
EXPLODED VIEW
SUMMIT_620_NG_US_012011
1
2
3
4
5
6
7
8
9
10
11
12
13
27
14
28
15
16
17
29
30
31
18
19
32
20
21
22
33
34
35
23
36
37
24
38
25
26
39
40
41
4
EXPLODED VIEW LIST
1.
Shroud Hardware
15. Knob
29. Bulkhead
2.
Shroud
16. Knob Bezel
30. Manifold Hose
3.
Thermometer
17. Water Baffle / Heat Shield
31. Side Burner Lid
4.
Thermometer Bezel
18. Disposable Drip Pan
32. Side Burner Table
5.
Handle
19. Slide Out Grease Tray
33. Side Burner Hose
6.
Grill Out™ Handle Light
20. Catch Pan
34. Right Tool Holder
7.
Warming Rack
21. Catch Pan Holder
35. Frame Support
8.
Cooking Grate
22. Left Door
36. Back Panel
9.
Flavorizor® Bar
23. Door Handle
37. Right Frame Panel
10. Burner Tube
24. Right Door
38. Natural Gas Hose
11. Side Table
25. Left Frame Panel
39. Matchstick Holder
12. Left Tool Holder
26. Bottom Panel
40. Caster
13. Manifold
27. Side Burner
41. Locking Caster
14. Control Panel
28. Cookbox
www.weber.com®
5
WARRANTY
Weber-Stephen Products LLC (Weber) hereby warrants to the ORIGINAL PURCHASER of this
Weber® gas grill that it will be free of defects in material and workmanship from the date of purchase
as follows:
Aluminum castings:25 years (2 years on paint; excludes fading)
Stainless steel shroud:
25 years
Porcelain-enameled shroud:
25 years
Stainless steel burner tubes:10 years
Stainless steel cooking grates:
5 years no rust through or burn through
Stainless steel Flavorizer® bars:
5 years no rust through or burn through
Porcelain-enameled cast-iron cooking grates:5 years no rust through or burn through
Porcelain-enameled cooking grates:
3 years no rust through or burn through
Porcelain-enameled Flavorizer® bars:
2 years no rust through or burn through
Infrared rotisserie burner:
2 years
All remaining parts:
2 years
when assembled and operated in accordance with the printed instructions accompanying it. Weber
may require reasonable proof of your date of purchase. THEREFORE, YOU SHOULD RETAIN YOUR
SALES SLIP OR INVOICE.
This Limited Warranty shall be limited to the repair or replacement of parts that prove defective under
normal use and service and which on examination shall indicate, to Weber’s satisfaction, they are
defective. Before returning any parts, contact the Customer Service Representative in your area
using the contact information on our website. If Weber confirms the defect and approves the claim,
Weber will elect to replace such parts without charge. If you are required to return defective parts,
transportation charges must be prepaid. Weber will return parts to the purchaser, freight or postage
prepaid.
This Limited Warranty does not cover any failures or operating difficulties due to accident, abuse,
misuse, alteration, misapplication, vandalism, improper installation or improper maintenance or
service, or failure to perform normal and routine maintenance, including but not limited to damage
caused by insects within the burner tubes, as set out in this owner’s manual.
Deterioration or damage due to severe weather conditions such as hail, hurricanes, earthquakes
or tornadoes, discoloration due to exposure to chemicals either directly or in the atmosphere, is not
covered by this Limited Warranty.
There are no other express warrants except as set forth herein and any applicable implied warranties
of merchantability and fitness are limited in duration to the period of coverage of this express written
Limited Warranty. Some regions do not allow limitation on how long an implied warranty lasts, so this
limitation may not apply to you.
Weber is not liable for any special, indirect or consequential damages. Some regions do not allow the
exclusion or limitation of incidental or consequential damages, so this limitation or exclusion may not
apply to you.
Weber does not authorize any person or company to assume for it any other obligation or liability in
connection with the sale, installation, use, removal, return, or replacement of its equipment; and no
such representations are binding on Weber.
This Warranty applies only to products sold at retail.
WEBER-STEPHEN PRODUCTS LLC
Customer Service Center
1890 Roselle Road, Suite 308
Schaumburg, IL 60195
USA
For replacement parts call:
1-800-446-1071
Visit www.weber.com®, select your country of origin, and register your grill today. ◆
6
GENERAL INSTRUCTIONS
Your Weber® gas barbecue is a portable outdoor cooking appliance. With the Weber®
gas barbecue you can grill, barbecue, roast and bake with results that are difficult to
duplicate with indoor kitchen appliances. The closed lid and Flavorizer® bars produce
that “outdoor” flavor in the food.
The Weber® gas barbecue is portable so you can easily change its location in your yard
or on your patio. Portability means you can take your Weber® gas barbecue with you if
you move.
The natural gas supply is easy to use and gives you more cooking control than charcoal
fuel.
• These instructions will give you the minimum requirements for assembling your
Weber® gas barbecue. Please read the instructions carefully before using your
Weber® gas barbecue. Improper assembly can be dangerous.
• Not for use by children.
• If there are local codes that apply to portable gas grills, you will have to conform to
them. Installation must conform with local codes or, in the absence of local codes,
with either the National Fuel Gas Code, ANSI Z223.1/NFPA 54, Natural Gas and
Propane Installation Code, CSA B149.1, or Propane Storage and Handling Code,
B149.2, or the Standard for Recreational Vehicles, ANSI A 119.2/NFPA 1192, and
CSA Z240 RV Series, Recreational Vehicle Code, as applicable.
• This Weber® gas barbecue is designed for natural (piped in city) gas only. Do not use
liquid propane (LP) bottled gas. The valves, orifices and hose are for natural gas only.
• Do not use with charcoal fuel.
• Check that the area under the control panel and the grease tray are free from debris
that might obstruct the flow of combustion or ventilation air. ◆
CANADIAN INSTALLATION
These instructions, while generally acceptable, do not necessarily comply with the
Canadian Installation codes, particularly with piping above and below ground. In Canada
the installation of this appliance must comply with local codes and/or Standards CAN/
CGA-B149.1 (Installation Code for Natural Gas Burning Appliances and Equipment). ◆
STORAGE AND/OR NONUSE
• The gas must be turned off at the natural gas supply when the Weber® gas barbecue
is not in use.
• When the Weber® gas barbecue is stored indoors, the gas supply must be
disconnected.
• The Weber® gas barbecue should be checked for gas leaks and any obstructions
in the burner tubes before using. (Refer to: “MAINTENANCE/ANNUAL
MAINTENANCE”).
• Check that the areas under the control panel and the slide out grease tray are free
from debris that might obstruct the flow of combustion or ventilation air.
• The Spider/Insect screens should also be checked for any obstructions. (Refer to:
“MAINTENANCE/ANNUAL MAINTENANCE”). ◆
OPERATING
mWARNING: Only use this barbecue outdoors in a wellventilated area. Do not use in a garage, building, breezeway
or any other enclosed area.
mWARNING: Your Weber® gas barbecue shall not be used
under overhead combustible construction.
mWARNING: Your Weber® gas barbecue is not intended to be
installed in or on recreational vehicles and/or boats.
mWARNING: Do not use the barbecue within 24 inches of
combustible materials. This includes the top, bottom, back
or sides of the grill.
mWARNING: The entire cookbox gets hot when in use. Do not
leave unattended.
mWARNING: Keep any electrical supply cord and the fuel
supply hose away from any heated surface.
mWARNING: Keep the cooking area clear of flammable vapors
and liquids, such as gasoline, alcohol, etc., and combustible
materials. ◆
GAS SUPPLY TESTING
• Disconnect your Weber® gas barbecue when the gas supply is being tested at high
pressures. This appliance and its individual shutoff valve must be disconnected
from the gas supply piping system during any pressure testing of that system at test
pressures in excess of 1/2 psig (3.5 kPa).
• Turn off your Weber® gas barbecue when the gas supply is being tested at low
pressures. This appliance must be isolated from the gas supply piping system by
closing its individual manual shutoff valve during any pressure testing of the gas
supply piping system at the pressure equal to or less than 1/2 psig (3.5 kPa). ◆
www.weber.com®
7
GAS INSTRUCTIONS
INSTALL GAS SUPPLY
General Specifications for Piping
Note: Contact your local municipality for building codes regulating outdoor
gas barbecue installations. In absence of Local Codes, you must conform to
the latest edition of the National Fuel Gas Code: ANSI Z 223.1/NFPA 54, or CAN/
CGA-B149.1, Natural Gas and Propane Installation Code. WE RECOMMEND THAT THIS
INSTALLATION BE DONE BY A PROFESSIONAL.
Some of the following are general requirements taken from the latest edition of the
National Fuel Gas Code: ANSI Z 223.1/NFPA 54, or CAN/CGA-B149.1, Natural Gas and
Propane Installation Code for complete specifications.
• This barbecue is designed to operate at 4.5" of water column pressure (.163 psi).
• A manual shut-off valve must be installed outdoors, immediately ahead of the quick
disconnect.
• An additional manual shut-off valve indoors should be installed in the branch fuel line
in an accessible location near the supply line.
• The quick disconnect connects to a 1/2" NPT thread from the gas source. The quick
disconnect fitting is a hand-operated device that automatically shuts off the flow of
gas from the source when the barbecue is disconnected.
• The quick disconnect fitting can be installed horizontally, or pointing downward.
Installing the fitting with the open end pointing upward can result in collecting water
and debris.
• The dust covers (supplied plastic plugs) help keep the open ends of the quick
disconnect fitting clean while disconnected.
• Pipe compound should be used which is resistant to the action of natural gas when
connections are made.
• The outdoor connector must be firmly attached to rigid, permanent construction.
mWARNING: Do not route the 10 foot hose under a deck. The
hose must be visible.
Gas Line Piping
• For the correct size and length of gas line piping refer to the latest edition of the
National Fuel Gas Code: ANSI Z 223.1/NFPA 54, or CAN/CGA-B149.1, Natural Gas
and Propane Installation Code.
• Gas piping may be copper tubing, type K or L; polyethylene plastic tube, with a
minimum wall thickness of .062"; or standard weight (schedule 40) steel or wrought
iron pipe.
• Copper tubing must be tin-lined if the gas contains more than 0.3 grams of hydrogen
sulfide per 100 cubic feet of gas.
• Plastic tubing is suitable only for outdoor, underground use.
• Gas piping in contact with earth, or any other material which may corrode the piping,
must be protected against corrosion in an approved manner.
• Underground piping must have a minimum of 18" cover.
Test Connections
All connections and joints must be thoroughly tested for leaks in accordance with local
codes and all listed procedures in the latest edition of the National Fuel Gas Code: ANSI
Z 223.1/NFPA 54, or CAN/CGA-B149.1.
m DANGER
Do not use an open flame to check for gas leaks. Be sure
there are no sparks or open flames in the area while you
check for gas leaks. This will result in a fire or explosion
which can cause serious bodily injury or death and damage
to property. ◆
8
This is a typical installation of a Weber® natural gas barbecue.
Local codes may require different installations.
INSIDE WALL
1
2
Gas Supply
Shut Off
OUTSIDE WALL
3
Quick-Disconnect
4
1/2" Pipe Nipple
5
Locking Shut Off
6
Do Not Use
GAS INSTRUCTIONS
TYPE OF GAS
Your natural gas grill is factory built to operate using natural gas only. Never attempt to
operate your grill on gases other than the type specified on the grill rating plates.
Your grill operates at 4.5" of water column pressure. If replacement of the hose becomes
necessary, factory specified parts are required. See your local dealer.
For safety and design reasons, the conversion of a Weber® grill from operation using
Natural gas to operation using LP gas is not allowed. ◆
1
Swivel connection
2
Install covers when hose is disconnected
3
Shut-off valve
PORTABLE INSTALLATION
4
Coat this pipe nipple with gas-resistant pipe dope
Weber® recommends moving the grill at least two feet from the gas supply and any
combustible surfaces. After the gas supply has been run and checked for leaks in
accordance to the assembly instructions, you are ready to grill. To connect the hose
to the gas supply, pull back the outer fitting, insert the hose fitting all of the way, and
release the outer fitting. This process will produce a gas joint. ◆
5
Socket
6
Male connection
1
Socket
2
Sleeve
3
Push sleeve back
4
Plug
WHAT IS NATURAL GAS?
Natural gas, often called methane, is a safe modern fuel. Natural gas is supplied by your
local utility and should be readily available if your house is already heated with gas. ◆
Push plug until sleeve snaps forward, locking plug in socket.
(This turns on gas automatically.)
When properly assembled, the plug cannot be removed without pushing the sleeve back.
To disconnect, push sleeve back and pull out plug.
(This automatically shuts off gas.)
www.weber.com®
9
GAS INSTRUCTIONS
LEAK CHECK PREPARATION
Check That All Burner Valves Are Off
Valves are shipped in the OFF position, but you should check to be sure that they are
turned off. Check by pushing in and turning clockwise. If they do not turn, they are off. If
they do turn continue turning them clockwise until they stop, then they are off.
mWARNING: The gas connections of your Summit® gas grill
have been factory tested. We do however recommend that
you leak check all gas connections before operating your
Summit® gas grill.
Remove Control Panel
Parts required: Phillips screwdriver and a towel.
A) Remove the burner control knobs (1).
B) Open both doors and place a towel on top of the doors. This will protect the control
panel and tops of the doors from getting scratched on the next step.
C) Remove the screws from the underside of the control panel with a Phillips
screwdriver (2).
D) Tilt the control panel forward and lift up and away from the grill (3). (For Summit®
models with LED features: Be careful not to break or disconnect the wires for the
control panel LEDs.)
E) Place the control panel on the towel covering the door assemblies (4). ◆
1
The grill illustrated
may have slight
differences than the
model purchased.
2
3
4
10
GAS INSTRUCTIONS
CHECK THE FLEXIBLE HOSE TO MANIFOLD CONNECTION
The natural gas hose was attached during the manufacturing process. We do
recommend that the hose to gas manifold connection be leak tested, following
guidelines in this Owner’s Guide, prior to barbecue operation. ◆
1
CHECK FOR GAS LEAKS
m DANGER
Do not use an open flame to check for gas leaks. Be sure
there are no sparks or open flames in the area while you
check for leaks. Sparks or open flames will result in a fire
or explosion which can cause serious bodily injury or death
and damage to property.
2
Note: All factory-made connections have been thoroughly checked for gas leaks. The
burners have been flame-tested. As a safety precaution, however, you should recheck
all fittings for leaks before using your Weber® gas barbecue. Shipping and handling
may loosen or damage a gas fitting.
mWARNING: The gas connections of your gas grill have been
factory tested. We do however recommend that you leak
check all gas connections before operating your gas grill.
mWARNING: Perform these leak checks even if your barbecue
was dealer or store assembled.
3
If your grill has a side burner, make sure the side burner is turned off.
To perform leak checks: Slide back the collar of the quick disconnect (1). Push male
fitting of the hose into the quick disconnect, and maintain pressure. Slide the collar
closed (2). If it does not engage or lock, repeat procedure. Gas will not flow unless the
quick disconnect is properly engaged.
Turn on gas supply at source.
mWARNING: Do not ignite burners when leak checking.
You will need: A soap and water solution and a rag or brush to apply it.
A) Mix soap and water.
B) Turn on the gas supply (3).
C) Check for leaks by wetting the fitting with the soap and water solution and watching
for bubbles. If bubbles form, or if a bubble grows, there is a leak.
If there is a leak, turn off the gas and tighten the fitting. Turn the gas back on and
recheck with the soap and water solution. If leak does not stop do not use the
barbecue. Contact the customer service representative in your area using the
contact information on our web site. Log onto www.weber.com®.
D) When leak checking is complete, turn gas supply off at the source and rinse
connections with water.
Note: Since some leak test solutions, including soap and water, may be slightly
corrosive, all connections should be rinsed with water after checking for leaks.
mWARNING: You should check for gas leaks every time you
disconnect and reconnect a gas fitting.
www.weber.com®
11
GAS INSTRUCTIONS
Check
A)
B)
C)
D)
E)
Bulkhead and gas supply hose connection (1).
Bulkhead to regulator connection (2).
Regulator to hose connection (3).
Main gas line to manifold connections (4).
Side burner hose to bulkhead connection (5).
1
mWARNING: If there is a leak at connection (1, 2, 3, 4, or 5),
retighten the fitting with a wrench and recheck for leaks with
soap and water solution. If a leak persists after re-tightening
the fitting, turn off the gas. DO NOT OPERATE THE GRILL.
Contact the Customer Service Representative in your area
using the contact information on our web site. Log onto
www.weber.com®.
2
3
F) Side burner hose to quick disconnect connection, side burner valve and orifice
connections (6).
G) Hose to quick disconnect connection (7).
H) Valves to manifold connections (8).
mWARNING: If there is a leak at connections (6, 7, or 8), turn
off the gas. DO NOT OPERATE THE GRILL. Contact the
Customer Service Representative in your area using the
contact information on our web site.
Log onto www.weber.com®.
4
When leak checks are complete, turn gas supply off at the source and rinse connections
with water.
Reinstall Control Panel
Parts required: control panel, screws and burner control knobs.
A) Hook the top edge of the control panel onto the control panel brackets on either side
of the front of the cookbox.
B) Line up screws with screw holes on both the control panel bracket and the frame.
C) Tighten screws.
D) Place corresponding control knobs onto the valve stems. ◆
6
5
7
8
The grill illustrated may have slight
differences than the model purchased.
12
LIGHT FEATURES
WEBER® GRILL OUT™ HANDLE LIGHT
The Weber Grill Out™ Handle Light has a built-in “Tilt Sensor.” With the power button (1)
activated, the light will come on when the grill lid is open. The light will turn off when the
lid is closed. For daytime use, deactivate the sensor by pressing power button (1). ◆
1
BEFORE USING YOUR GRILL
SLIDE-OUT GREASE TRAY AND DISPOSABLE DRIP PAN
Your grill was built with a grease collection system. Check the slide-out grease tray and
disposable drip pan for grease build-up each time you use your grill.
The grill illustrated may
have slight differences
than the model purchased.
Remove excess grease with a plastic spatula; see illustration. When necessary, wash
the grease tray and drip pan with a soap and water solution, then rinse with clean water.
Replace the disposable drip pan as needed.
mWARNING: Check the slide-out grease tray and disposable
drip pan for grease build-up before each use. Remove
excess grease to avoid a grease fire. A grease fire can cause
serious bodily injury or damage to property.
m CAUTION: Do not line the slide-out grease tray with
aluminum foil. ◆
HOSE INSPECTION
The hose should be inspected for any signs of cracking.
mWARNING: Check hose before each use of barbecue for
nicks, cracking, abrasions or cuts. If the hose is found to
be damaged in any way, do not use the barbecue. Replace
using only Weber® authorized replacement hose. Contact
the Customer Service Representative in your area using the
contact information on our web site.
Log onto www.weber.com®. ◆
www.weber.com®
13
SNAP IGNITION OPERATION
mAlways open the lid before igniting the burners.
A) Each control knob has its own igniter electrode built in. To create a spark, you must
push the control knob in (1) and turn it to START/HI (2).
B) This action will generate gas flow and a spark to the burner lighting tube (3). You will
hear a “snap” from the igniter. You will also see a 3" – 5" orange flame coming from
the burner lighting tube at the left side of the burner (4).
C) Continue to hold the burner control knob in for two seconds after the “snap.”
This will allow gas to flow completely down the burner tube (5) and ensure ignition.
D) Check that the burner is lit by looking through the cooking grates. You should see
a flame. If burner does not light on first try, push control knob in and turn it to OFF.
Repeat lighting procedure a second time.
2
mWARNING: If the burner still does not light, turn the burner
control knob to OFF and wait five minutes to let the gas
clear before you try again or try to light with a match. ◆
1
4
3
5
14
MAIN BURNER IGNITION & USAGE
MAIN BURNER IGNITION
APAGADO
ARRÊTÉ
Summary lighting instructions are inside the left-hand cabinet door.
m DANGER
Failure to open the lid while igniting the barbecue’s burners,
or not waiting five minutes to allow the gas to clear if the
barbecue does not light, may result in an explosive flame-up
which can cause serious bodily injury or death.
Main Burner Snap Ignition
OFF
START/HI
LOW
1
Note: Each control knob snap igniter creates a spark from the igniter electrode to the
burner lighting tube. You generate the energy for the spark by pushing in the control
knob and turning it to START/HI. This will ignite each individual burner.
5
mWARNING: Check hose before each use of barbecue for
nicks, cracking, abrasions or cuts. If the hose is found to
be damaged in any way, do not use the barbecue. Replace
using only Weber® authorized replacement hose. Contact
the Customer Service Representative in your area using the
contact information on our web site.
Log onto www.weber.com®.
A) Open the lid (1).
B) Make sure all burner control knobs are turned to OFF (2). (Push control knob in and
turn it clockwise to ensure that it is in the OFF position.)
C) Turn on the gas supply at source (3).
MEDIUM
2 4
The grill illustrated may have slight
differences than the model purchased.
3
mWARNING: Do not lean over the open barbecue.
D) Push the control knob in and turn it to START/HI until you hear the igniter snap;
continue to hold control knob in for two seconds (4). This action will spark the
igniter, the burner lighting tube, and then main burner.
E) Check that the burner is lit by looking through the cooking grates (5). You should see
a flame. If burner does not light on first try, push control knob in and turn it to OFF.
Repeat lighting procedure a second time.
2
4
mWARNING: If the burner still does not light, turn the burner
control knob to OFF and wait five minutes to let the gas
clear before you try again or try to light with a match. ◆
TO EXTINGUISH
Push in and turn each burner control knob clockwise to OFF position. Turn gas supply off
at the source. ◆
www.weber.com®
15
MAIN BURNER IGNITION & USAGE
MAIN BURNER MANUAL IGNITION
m DANGER
1
Failure to open the lid while igniting the barbecue’s burners,
or not waiting five minutes to allow the gas to clear if the
barbecue does not light, may result in an explosive flare-up
which can cause serious bodily injury or death.
4
A) Open the lid (1).
B) Make sure all burner control knobs are turned to OFF (2). (Push each knob in and
turn it clockwise to ensure it is in the OFF position.)
C) Turn on the gas supply at source (3).
D) Put match in the matchstick holder and strike match.
mWARNING: Do not lean over open barbecue.
2 5
E) Insert matchstick holder and lit match down through cooking grates and Flavorizer®
bars to ignite the selected burner (4).
F) Push the control knob in and turn it to START/HI (5).
mWARNING: If the burner does not light, turn burner control
knob to OFF and wait five minutes to let the gas clear before
you try again. ◆
3
The grill illustrated may
have slight differences than
the model purchased.
TO EXTINGUISH
Push in and turn each burner control knob clockwise to OFF position. Turn gas supply off
at the source. ◆
16
2
5
GRILLING TIPS & HELPFUL HINTS
• Always preheat the grill before cooking. Set all burners on HI heat and close lid; heat
for 10 minutes, or until thermometer registers 500°-550° F (260°-288°C).
• Sear meats and cook with the lid down for perfectly grilled food every time.
• Grilling times in recipes are based on 70°F (20°C) weather and little or no wind. Allow
more cooking time on cold or windy days, or at higher altitudes. Allow less cooking
time in extremely hot weather.
• Grilling times can vary because of the weather, or the amount, size and shape of the
food being grilled.
• The temperature of your gas grill may run hotter than normal for the first few uses.
• Grilling conditions may require the adjustment of the burner controls to attain the
correct cooking temperatures.
• In general, large pieces of meat will require more cooking time per pound than small
pieces of meat. Foods on a crowded cooking grate will require more cooking time
than just a few foods. Foods grilled in containers, such as baked beans, will require
more time if grilled in a deep casserole rather than a shallow baking pan.
• Trim excess fat from steaks, chops and roasts, leaving no more than a scant ¼ inch
(6.4mm) of fat. Less fat makes cleanup easier, and is a virtual guarantee against
unwanted flare-ups.
• Foods placed on the cooking grate directly above burners may require turning or
moving to a less hot area.
• Use tongs rather than a fork for turning and handling meats to avoid losing natural
juices. Use two spatulas for handling large whole fish.
• If an unwanted flare-up should occur, turn all burners off and move food to another
area of the cooking grate. Any flames will quickly subside. After flames subside, relight
the grill. NEVER USE WATER TO EXTINGUISH FLAMES ON A GAS GRILL.
• Some foods, such as a casserole or thin fish fillets, will require a container for grilling.
Disposable foil pans are very convenient, but any metal pan with ovenproof handles
can also be used.
• Always be sure the slide out grease tray and catch pan are clean and free from debris.
• Do not line the slide out grease tray with foil. This could prevent the grease from
flowing into the catch pan.
• Using a timer will help to alert you when “well-done” is about to become “overdone.”
FLAVORIZER® SYSTEM
When meat juices drip from the food onto the specially angled Flavorizer® bars,
they create smoke that gives foods an irresistible barbecued flavor. Thanks to the
unique design of the burners, Flavorizer® bars and the flexible temperature controls,
uncontrolled flare-ups are virtually eliminated, because YOU control the flames. Because
of the special design of the Flavorizer® bars and burners, excess fats are directed
through the slide out grease tray into the grease catch pan. ◆
Note: If grill looses heat while cooking refer to the troubleshooting section of this
manual.
mWARNING: Do not move the Weber® gas barbecue when
operating or while barbecue is hot.
You can adjust the individual burners as desired. The control settings are OFF,
START/HI, MEDIUM, or LOW.
APAGADO
ARRÊTÉ
OFF
START/HI
MEDIUM
LOW
Note: The temperature inside your cookbox for the first few uses, while surfaces are still
very reflective, may be hotter than those shown in your cookbook. Cooking conditions,
such as wind and weather, may require the adjustment of the burner controls to obtain
the correct cooking temperatures.
If burners go out during cooking, turn off all burners and wait five minutes before
relighting. ◆
PREHEATING
Your Weber® gas barbecue is an energy-efficient appliance. It operates at an economical
low BTU rate. Preheating the grill before grilling is important. Light your grill according
to the instructions in this Owner’s Manual. To preheat: after lighting turn all burners to
START/HI, close the lid, and heat until the temperature reaches between 500° and 550°
F (260° and 290° C), the recommended broiling temperature. This will take 10 to 15
minutes depending on conditions such as air temperature and wind. ◆
COVERED COOKING
All grilling is done with the lid down to provide uniform, evenly circulated heat. With the
lid closed, the gas grill cooks much like a convection oven. The thermometer in the lid
indicates the cooking temperature inside the grill. All preheating and grilling is done with
the lid down. No peeking — heat is lost every time you lift the lid. ◆
DRIPPINGS AND GREASE
The Flavorizer® bars are designed to “smoke” the correct amount of drippings for
flavorful cooking. Excess drippings and grease will accumulate in the catch pan under
the slide out grease tray. Disposable foil drip pans are available that fit the catch pan.
mWARNING: Check the slide out grease tray and catch pan
for grease build-up before each use. Remove excess grease
to avoid a grease fire in the slide out grease tray. ◆
www.weber.com®
17
COOKING METHODS
The most important thing to know about grilling is which cooking method to use for a
specific food, direct or indirect. The difference is simple: place the food directly over the
fire, or arrange the fire on either side of it. Using the right method is the shortest route to
great results—and the best way to ensure doneness safety. ◆
6 BURNER
DIRECT COOKING
The direct method, similar to broiling, means the food is cooked directly over the heat
source. For even cooking, food should be turned once halfway through the grilling time.
Use the direct method for foods that take less than 25 minutes to cook: steaks, chops,
kabobs, sausages, vegetables, and more.
Direct cooking is also necessary to sear meats. Searing creates that wonderful crisp,
caramelized texture where the food touches the grate. It also adds great color and flavor
to the entire surface. Steaks, chops, chicken breasts, and larger cuts of meat all benefit
from searing.
To sear meats, place them over direct high heat for two to five minutes per side. Smaller
pieces require less searing time. Usually after searing the food, you finish cooking it at a
lower temperature. You can finish cooking fast-cooking foods by the direct method; use
the indirect method for longer-cooking foods.
To set up your gas grill for direct cooking, preheat the grill with all burners on HI. Place
food on the cooking grate, and then adjust all burners to the temperature noted in the
recipe. Close the lid of the grill and lift it only to turn food or to test for doneness at the
end of the recommended cooking time. ◆
DIRECT METHOD
Food is placed on the area of the cooking grates directly over the lit burners
6 BURNER
INDIRECT COOKING
The indirect method is similar to roasting, but with the added benefits of that grilled
texture, flavor, and appearance you can’t get from cooking with an oven. To set up for
indirect cooking, light gas burners on either side of the food but not directly beneath it.
Heat rises, reflects off the lid and inside surfaces of the grill, and circulates to slowly
cook the food evenly on all sides, much like a convection oven, so there’s no need to
turn the food.
Use the indirect method for foods that require 25 minutes or more of grilling time, or that
are so delicate that direct exposure to the flame would dry them out or scorch them.
Examples include roasts, ribs, whole chickens, turkeys, and other large cuts of meat, as
well as delicate fish fillets.
To set up your gas grill for indirect cooking, preheat the grill with all burners on HI. Then
adjust the burners on each side of the food to the temperature noted in the recipe, and
turn off the burner(s) directly below the food. For best results, place roasts, poultry, or
large cuts of meat on a roasting rack set inside a disposable, heavy-gauge foil pan.
For longer cooking times, add water to the foil pan to keep drippings from burning. The
drippings can be used to make gravies or sauces. ◆
18
INDIRECT METHOD
Food is placed on the area of the cooking grates between the lit burners
SIDE BURNER IGNITION & USAGE
SIDE BURNER IGNITION
OFF
Summary lighting instructions are inside the left hand cabinet door.
m DANGER
Failure to open the lid while igniting the side burner, or not
waiting five minutes to allow the gas to clear if the side
burner does not light, may result in an explosive flare-up
which can cause serious bodily injury or death.
START/HI
LOW
mWARNING: Check hose before each use of barbecue for
nicks, cracking, abrasions or cuts. If the hose is found to
be damaged in any way, do not use the barbecue. Replace
using only Weber® authorized replacement hose. Contact
the Customer Service Representative in your area using the
contact information on our web site.
Log onto www.weber.com®.
5
A) Open the side burner lid (1).
B) Check that the side burner valve is turned off (2) (Push control knob in and turn
clockwise to ensure that it is in the OFF position), turn all burners not being used to
the OFF position (push in and turn clockwise).
C) Turn the gas supply valve on (3).
D) Push down and turn the side burner control valve to START/HI (4).
E) Press the igniter button several times so it clicks each time until you see a flame (5).
m CAUTION: Side burner flame may be difficult to see on a
bright sunny day.
mWARNING: If the side burner does not light in five seconds:
a)Turn off the side burner control valve, main burners
and gas supply at source.
b)Wait five minutes to let the gas clear before you try
again, or try lighting with a match (refer to “SIDE
BURNER MANUAL IGNITION”). ◆
TO EXTINGUISH
Push down and turn side burner control knob to the OFF position. Be sure the burner is
off and cool before closing the side burner lid. ◆
1
2 4
2
3
www.weber.com®
19
SIDE BURNER IGNITION & USAGE
SIDE BURNER MANUAL IGNITION
m DANGER
4
1
Failure to open the lid while igniting the side burner, or not
waiting five minutes to allow the gas to clear if the side
burner does not light, may result in an explosive flare-up that
can cause serious bodily injury or death.
2 5
A) Open the side burner lid (1).
B) Check that the side burner valve is turned off (2) (Push control knob in and turn
clockwise to ensure that it is in the OFF position), turn all burners not being used to
the OFF position (push in and turn clockwise).
C) Turn the gas supply valve on (3).
D) Put match in a match holder and strike match.
E) Hold match holder and lit match by either side of the side burner (4).
F) Push down and turn the side burner control valve to START/HI (5).
m CAUTION: Side burner flame may be difficult to see on a
bright sunny day.
mWARNING: If the side burner does not light in five seconds:
a)Turn off the side burner control valve, main burners
and gas supply at source.
b)Wait five minutes to let the gas clear before you try
again. ◆
TO EXTINGUISH
Push down and turn side burner control knob to the OFF position. Be sure the burner is
off and cool before closing the side burner lid. ◆
20
2
3
TROUBLESHOOTING
PROBLEM
CHECK
Burners burn with a yellow or orange flame, in
conjunction with the smell of gas. (This is normal for
the burner lighting tube.)
Symptoms:
Burner does not light, or flame is low in HI position.
Inspect spider/insect screens for possible obstructions.
(Blockage of holes.)
SOLUTION
Clean spider/insect screens (refer to “ANNUAL
MAINTENANCE”).
Is fuel hose bent or kinked?
Straighten fuel hose.
Does burner light with a match?
Clean burners (refer to “MAINTENANCE”).
Did you use the snap igniter several times until the main
burner lit (refer to “MAIN BURNER IGNITION”)?
Make sure to hold the control knob in for two seconds
after snapping the igniter and seeing the orange flame
from the burner lighting tube.
Does the igniter work? Do you see a spark when you
repeatedly use the snap igniter?
Try manually lighting the burner (refer to “MAIN BURNER
MANUAL IGNITION”). Call Customer Service.
Experiencing flare-ups:
Are you preheating barbecue in the prescribed manner?
All burners on HI for 10 to 15 minutes for preheating.
m CAUTION: Do not line the slide out
grease tray with aluminum foil.
Are the cooking grates and Flavorizer® bars heavily
coated with burned-on grease?
Clean thoroughly (refer to “CLEANING”).
Is the bottom tray “dirty” and not allowing grease to flow
into catch pan?
Clean bottom tray.
Burner flame pattern is erratic. Flame is low when
burner is on HI. Flames do not run the whole length
of the burner tube.
Are burners clean?
Clean burners (refer to “MAINTENANCE”).
Inside of lid appears to be “peeling.” (Resembles
paint peeling.)
The lid is porcelain enamel or stainless steel, not paint.
It cannot “peel.” What you are seeing is baked-on grease
that has turned to carbon and is flaking off.
Clean thoroughly (refer to “CLEANING”).
THIS IS NOT A DEFECT.
Cabinet doors are not aligned.
Check the adjustment pin on the bottom of each door.
Loosen adjustment nut/s. Slide door/s until aligned.
Tighten nut/s.
If problems cannot be corrected by using these methods, please contact the Customer Service Representative in your area using the contact information on our
web site. Log onto www.weber.com®.
SIDE BURNER TROUBLESHOOTING
PROBLEM
CHECK
SOLUTION
Side burner does not light.
Is gas supply off?
Turn supply on.
Flame is low in HI position.
Is the fuel hose bent or kinked?
Straighten hose.
Push button ignition does not work.
Does burner light with a match?
If match lights burner, check igniter. Refer to “SIDE
BURNER MAINTENANCE”.
If problems cannot be corrected by using these methods, please contact the Customer Service Representative in your area using the contact information on our
web site. Log onto www.weber.com®.
GRILL OUT™ HANDLE LIGHT TROUBLESHOOTING
PROBLEM
Weber Grill Out™ Handle Light does not light.
CHECK
SOLUTION
Are the batteries old?
Replace batteries.
Are the batteries installed correctly?
Refer to assembly illustration.
Is the lid in the up position with the power button ON?
Light will activate when lid is open.
Is the Weber Grill Out™ Handle Light activated?
Press the power button.
Is the Weber® Grill Out™ Handle Light positioned
correctly on the handle?
Adjust position. Refer to assembly illustration.
®
If problems cannot be corrected by using these methods, please contact the Customer Service Representative in your area using the contact information on our
web site. Log onto www.weber.com®.
www.weber.com®
21
MAINTENANCE
CLEANING
WEBER® SPIDER/INSECT SCREENS
mWARNING: Turn your Weber® gas barbecue off and wait for
it to cool before cleaning.
m CAUTION: Do not clean your Flavorizer® bars or cooking
grates in a self-cleaning oven.
Your Weber® gas barbecue, as well as any outdoor gas appliance, is a target for spiders
and other insects. They can nest in the venturi section (1) of the burner tubes. This
blocks the normal gas flow, and can cause the gas to flow back out of the combustion air
opening. This could result in a fire in and around the combustion air openings, under the
control panel, causing serious damage to your barbecue.
Outside surfaces — Use a warm soapy water solution to clean, then rinse with water.
The burner tube combustion air opening is fitted with a stainless steel screen (2) to
prevent spiders and other insects access to the burner tubes through the combustion air
openings.
m CAUTION: Do not use oven cleaner, abrasive cleansers
(kitchen cleansers), cleaners that contain citrus products, or
abrasive cleaning pads on barbecue or cart surfaces.
Slide-out grease tray — Remove excess grease, wash with warm soapy water, then
rinse.
m CAUTION: Do not line the slide-out grease tray with
aluminum foil.
Flavorizer® bars and cooking grates — Clean with a suitable stainless steel bristle
brush. As needed, remove from grill and wash with warm soapy water, then rinse with
water.
For availability of replacement cooking grates and Flavorizer® bars, contact the
Customer Service Representative in your area using the contact information on
our website. Log onto www.weber.com®.
Catch pan — Disposable foil trays are available, or you can line the catch pan with
aluminum foil. To clean the catch pan, wash with warm soapy water, then rinse.
We recommend that you inspect the spider/insect screens at least once a year.
(Refer to “ANNUAL MAINTENANCE.”) Also inspect and clean the the spider/insect
screens if any of the following symptoms should ever occur:
A)
B)
C)
D)
Gas is smelled in conjunction with burner flames that appear yellow and lazy.
Barbecue does not reach temperature.
Barbecue heats unevenly.
One or more of the burners do not ignite.
m DANGER
Failure to correct the above mentioned symptoms may result
in a fire, which can cause serious bodily injury or death, and
cause damage to property. ◆
Thermometer — Wipe with warm soapy water; clean with plastic scrub ball.
1
Cookbox — Brush any debris off of burner tubes. DO NOT ENLARGE BURNER PORTS
(OPENINGS). Wash inside of cookbox with warm soapy water and a water rinse.
Inside lid — While lid is warm, wipe inside with paper towel to prevent grease build-up.
Flaking built-up grease resembles paint flakes.
Stainless steel surfaces — Wash with a soft cloth and a soap and water solution. Be
careful to scrub with the grain direction of the stainless steel.
Do not use cleaners that contain acid, mineral spirits, or xylene. Rinse well after
cleaning.
2
Preserve your stainless steel — Your grill or its cabinet, lid, and control panel may be
made from stainless steel. Keeping the stainless steel looking its best is a simple matter.
Clean it with soap and water, rinse with clear water, and wipe dry. For stubborn particles,
a non-metallic brush can be used.
mIMPORTANT: Do not use a wire brush or abrasive cleaners
on the stainless steel surfaces of your grill as this will cause
scratches.
mIMPORTANT: When cleaning surfaces be sure to rub/wipe
in the direction of the grain to preserve the look of your
stainless steel. ◆
BURNER TUBE CLEANING
A)
B)
C)
D)
Turn off the gas supply.
Remove the manifold. (Refer to “REPLACING MAIN BURNERS.”)
Look inside each burner with a flashlight.
Clean the inside of the burners with a wire (a straightened-out coat hanger will also
work). Check and clean the air shutter opening at the ends of the burners. Check
and clean the valve orifices at the base of the valves. Use a steel bristle brush to
clean outside of burners. This is to make sure all the burner ports are fully open.
m CAUTION: Do not enlarge the burner ports when cleaning. ◆
22
MAINTENANCE
REPLACING MAIN BURNERS
A)
B)
C)
D)
E)
F)
Your Summit® gas grill must be off and cool.
Turn gas off at source.
Disconnect gas supply.
Remove cooking grates.
Remove Flavorizer® bars.
Remove smoker box (if included in your model).
Remove Control Panel
Parts required: Phillips screwdriver and a towel.
A) Remove the burner control knobs (1).
B) Open both doors and place a towel on top of the doors.
This will protect the control panel and tops of the doors from getting scratched on
the next step.
C) Remove the screws from the underside of the control panel with a Phillips
screwdriver (2).
D) Tilt the conrol panel forward and lift up and away from the grill (3) (For Summit®
models with LED features: Be careful not to break or disconnect the wires for the
control panel LED’s).
E) Place the control panel on the towel covering the door assemblies (4).
1
The grill illustrated
may have slight
differences than the
model purchased.
4
2
3
F) Remove the two screws that secure the manifold to the cookbox. Pull manifold
assembly out from the manifold frame (5).
G) Pull the selected burner(s) tube(s) from manifold frame and replace with a new
burner tube (6).
7
6
6
5
www.weber.com®
23
MAINTENANCE
H) To reinstall the manifold assembly, reverse steps A through G.
m CAUTION: The burner openings (7) must be positioned
properly over the valve orifices (8). Make sure the opposite
end of the burner tubes (9) properly align into the slots on
the backside of the cookbox. Check proper assembly before
fastening manifold in place.
mWARNING: After reinstalling the gas lines, they should be
leak checked with a soap and water solution before using
the grill. (See “CHECK FOR GAS LEAKS”) ◆
1
7
2
8
3
9
SIDE BURNER MAINTENANCE
mWARNING: All gas controls and supply valves should be in
the OFF position.
3
Make sure black wire is connected between the igniter and electrode.
Make sure white wire is connected between the igniter and grounding clip.
Spark should be a white/blue color, not yellow.
2
A) Igniter wire (1)
B) Ground wire (2)
C)Burner (3) ◆
1
Side Burner Grate
Side Burner Cap
Side Burner Ring & Head
Igniter Electrode
Control Knob
Igniter
24
1
2
MAINTENANCE
ANNUAL MAINTENANCE
Inspection and Cleaning of the Spider/Insect Screens
To inspect the spider/insect screens, remove the control panel. If there is dust or dirt on
the screens, remove the burners to clean the screens.
Brush the spider/insect screens lightly with a soft bristle brush (i.e., an old toothbrush).
m CAUTION: Do not clean the spider/insect screens with hard
or sharp tools. Do not dislodge the spider/insect screens or
enlarge the screen openings.
Lightly tap the burner to get debris and dirt out of the burner tube. Once the spider/
insect screens and burners are clean, replace the burners.
If a spider/insect screen becomes damaged or cannot be cleaned, please contact the
Customer Service Representative in your area using the contact information on our web
site. Log onto www.weber.com®.
Burner Flame Pattern
The Weber® gas barbecue burners have been factory set for the correct air and gas
mixture. The correct flame pattern is shown in illustration and described below:
A)
B)
C)
D)
Burner tube (1)
Tips occasionally flicker yellow (2)
Light blue (3)
Dark blue (4)
1
2
3
4
If the flames do not appear to be uniform throughout the burner tube, follow the burner
cleaning procedures. ◆
www.weber.com®
25
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement