RV generator set Quiet Gasoline Series RV QG 4000

RV generator set Quiet Gasoline Series RV QG 4000
RV generator set
Quiet GasolineTM Series
RV QG 4000
Features and benefits
•
•
•
•
•
•
•
Weight, size and sound level
Microprocessor control with diagnostics.
Weight
172 lbs
(83.4 kg)
Exceptionally smooth, quiet operation.
Full housing with enclosed muffler.
Length
Width
Height
30.0 in
19.7 in
14.4 in
(762 mm)
(500.4 mm)
(353.1 mm)
3-year limited warranty.
Sound
68 dB(A)
Readings at 10 ft (3 m) half load
Lightweight, compact.
- Meets National Park Service sound level requirements (60 dB(A)
@ 50 ft) for use in national parks.
- Typical installation will further reduce sound level.
Sealed connectors.
OHV engine for efficiency, no decarboning.
Models and ratings
Model
Fuel
Hz
RPM
Watts
Voltage
Amps
Phase
Circuit breaker
4KYFR65697
4KYFA26100
4KYFA6747*
4KYFR11429
3.6KYFA26120
3.3KYFR4858
3.6KYFR4856
Gasoline
Gasoline
Gasoline
Gasoline
LP
LP
Gasoline
60
60
60
60
60
50
50
3600
3600
3600
3600
3600
3000
3000
4000
4000
4000
4000
3600
3300
3600
100 (1)
120
120
100 (2)
120
230 (2,4)
230 (2,4)
40.0
33.3
33.3
40.0
30.0
14.3
15.7
1
1
1
1
1
1
1
20 A, 2-pole
30 A, 1-pole
30 A, 1-pole
20 A, 2-pole
30 A, 1-pole
17 A, 1-pole
17 A,1-pole
(1) Isolated neutral, (2) Grounded neutral, (3) Adjustable 220-240, (4) Australia/New Zealand wire colors.
Ambient conditions for rated power output with muffler and RV enclosure, per ISO 8528-1:
- Temperature: 77° F (25° C)
- Altitude: 500 ft (152.4 m), (99 kPa dry)
Typical power output change based on ambient conditions:
- Temperature: Power output decreases 1% for every 10° F (5.5° C) increase
- Altitude: Power output decreases 3.5% for every 1000 ft (305 m) increase
Ratings represent minimums. Actual performance may be significantly higher based on installation and operating conditions.
* Evaporative spec: Effective January 1, 2011, gasoline generator sets on trailers, diesel chassis or any other non-motorized mobile apparatus
must have an EVAP generator set, approved tank, EVAP canister, hoses and fittings all meeting the CARB Tier 3 and EPA phase 3 standards
and specifications. This law applies in all 50 states.
Operating temperature range
Low
High
-20° F (-29° C)
120° F (49° C)
Gasoline
0°
F
(-18°
C)
120°
F (49° C)
LP
- Depends upon LP tank capacity, surface area and butane content of LPG.
©2011 Cummins Power Generation. All Rights Reserved. Cummins®, Onan®, the “C” logo, Performance you rely on.TM and Quiet Gasoline™ are servicemarks and/or
registered trademarks of Cummins Inc. Specifications are subject to change without notice.
A-1399m (2/11)
Standard features
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
Engine details
Microprocessor control with digital voltage regulator
Starter overcrank protection
Generator set field overload protection
Over/under frequency and voltage protection
Loss of AC sense protection
Mechanical fault protection
Detects starter faults
Reverse connections and high battery voltage
protection
4-point vibration isolator mounting system
Magnetic circuit breaker
Automatic resetting of DC circuit overcurrent protection
for set wiring and remote start wiring
Integral enclosure cover and stamped steel base
Stationary exhaust pipe attachment point
High stability mechanical governor
Sealed remote start connector
Fuel filter
USDA Forest Service-approved, spark-arresting
muffler
Cross-flow pressure cooling
Automatic choke
Electric fuel pump with positive fuel safety shutoff
(gasoline)
Electric fuel shutoff solenoid (LPG)
125 in (3.2 m) generator set output leads
Intake silencer, sound deadening material and baffles
reduce sound level
Start-stop/prime rocker switch on control with LED
status indicator light for set diagnostics
Average fuel consumption:
Model: Cummins Onan E095H
Design: 4-cycle, OHV, single horizontal cylinder
Displacement: 18.5 in3 (304 cm3)
Compression ratio: 8.5:1
Maximum power at 60 Hz:
LPG - 8.6 bhp (6.4 kW); Gasoline: - 9.5 bhp (7 kW)
Maximum power at 50 Hz:
LPG - 7.6 bhp (5.7 kW); Gasoline - 8.3 bhp (6.2 kW)
Cooling: Cross flow air - pressure type
Cooling air volume: Includes engine cooling air
volume
60 Hz: 300 ft3/min (8.5 m3/min)
50 Hz: 250 ft3/min (7.1 m3/min)
Combustion air volume:
60 Hz: 19 ft3/min (0.5 m3/min)
50 Hz: 16 ft3/min (0.45 m3/min)
Side draft carburetor: KY (gasoline)
Electric fuel pump: Positive fuel shutoff (3 psi), fuel
lift 3 ft (914 mm)
Air cleaner: Replaceable dry element; patented
automatic choke
Vapor withdrawal system with demand
regulator: KY (LPG)
Ignition system: Electronic magneto type
Starting system: Remote, 12 V, 3-wire negative
ground
Starter: Automotive type with environmentally
protected pinion; automatic start disconnect
Lubrication: Splash lubrication
Oil capacity: 1.6 qt (1.5 L)
Cylinder crankcase: Aluminum alloy with iron
cylinder liner cast into the block, aluminum alloy oil base
Cylinder head: Aluminum, valves in head, removable
Gasoline
60 Hz 4.0 KY
50 Hz 3.6 KY
No load
0.3 Gal/h (1.1 L/h)
0.2 Gal/h (0.8 L/h)
Half load
0.5 Gal/h (1.8 L/h)
0.4 Gal/h (1.4 L/h)
Full load
0.7 Gal/h (2.7 L/h)
0.6 Gal/h (2.2 L/h)
LPG
60 Hz 3.6 KY
50 Hz 3.3 KY
No load
0.4 Gal/h (1.5 lb/h) 0.7 kg/h
0.3 Gal/h (1.1 lb/h) 0.5 kg/h
Half load
0.6 Gal/h (2.4 lb/h) 1.1 kg/h
0.5 Gal/h (2.2 lb/h) 1.0 kg/h
Full load
0.7 Gal/h (3.1 lb/h) 1.4 kg/h
0.7 Gal/h (2.9 lb/h) 1.3 kg/h
Alternator details
Design: Cummins Onan revolving field, AC, 2-pole
self-excited; permanently aligned to engine by a tapered
shaft; drip-proof construction
Insulation system and temperature rise: Meets
ANSI/RVIA-EGS-1-1998, BS-4999 and CSA Electrical
Bulletin 946 standards
Cooling: Direct drive centrifugal blower, cast aluminum
housing for excellent heat transfer
Voltage regulation: Microprocessor control with
digital voltage regulator
Rotor: Laminated electrical steel assembly press fitted
to shaft, balanced; heavy insulated copper wire windings;
amortisseur windings for improved waveform and motor
starting
Stator: Laminated electrical steel assembly; heavy
insulated copper wire windings
DC brushes: Electrographite; long life
Bearing: Double-sealed, pre-lubricated ball bearing
Generator set performance
Air conditioner starting: (60 Hz - gasoline) one
13500 Btu air conditioner with 2000 W base load at
500 ft (152.4 m) and 100° F (38° C)
Frequency and voltage regulation: Exceeds
requirements of ANSI/RVIA EGS-1-1998
©2011 Cummins Power Generation. All Rights Reserved. Cummins®, Onan®, the “C” logo, Performance you rely on.TM and Quiet Gasoline™ are servicemarks and/or
registered trademarks of Cummins Inc. Specifications are subject to change without notice.
A-1399m (2/11)
Dimensions mm (in)
Basic dimensions
500-3297a1lin3
Note: This outline drawing is provided for general reference only and is not intended for design or installation. For more information see
Operation and Installation manuals or obtain 500-3297 drawing and wiring diagram from your distributor/dealer.
Accessories
• Standard under floor mounting kit (P/N 403-3670)
•
•
•
•
•
•
•
bolts through floor
Under floor mount template (P/N 539-1535) for use
with under floor kit (P/N 403-3670)
Template for compartment mount (P/N 539-1546)
Base adapter under floor mounting kit (P/N 403-3630)
allows unit to mount using RV QG 5500 mounting kit
and for use with RV QG 5500 housing kit
(P/N 405-4241) or equivalent
Housing kit for under floor mounting (P/N 405-4241)
requires base adapter (P/N 403-3630)
Battery, 12 V, minimum 460 cold cranking amps at
0° F (-18° C)
Remote control panel including start-stop/prime switch
with status indicator light (P/N 300-5331)
Remote control panel including start-stop/prime switch
with status indicator light and hour meter
(P/N 3005332)
• Remote control panel including start-stop/prime switch
•
•
•
•
•
•
•
•
with status indicator light and DC voltmeter (P/N 3005333)
Remote control pigtail adapter (P/N 300-4946)
Remote control plug and wire harness 10 ft
(P/N 338-3489-01), 30 ft (P/N 338-3489-02)
Exhaust tailpipe kit (P/N 155-2845) tailpipe and special
hanger
Exhaust kit 1.5 in (P/N 155-2847) 90° elbow
Exhaust kit adapter (P/N 155-2850) straight tube
adapter
Energy command auto generator start EC-30
(P/N 018-02030)
Energy command remote start/stop with diagnostics
EC-20 (P/N 018-02020)
Energy command wireless start/stop EC-15W
(P/N 018-02015)
©2011 Cummins Power Generation. All Rights Reserved. Cummins®, Onan®, the “C” logo, Performance you rely on.TM and Quiet Gasoline™ are servicemarks and/or
registered trademarks of Cummins Inc. Specifications are subject to change without notice.
A-1399m (2/11)
Testing for RV application
After sale support
- Tested at extremes of temperature -20° F (-29° C) to
120° F (49° C) for starting and operation
- Tested with RV loads, air conditioners, microwaves,
converter, TVs, VCRs
- Tested installed; Cummins owned RVs used for
product development testing
- Tested in high humidity conditions
- Tested in salt spray conditions
- Tested in heavy airborne dust conditions
- Field test program
- 60 Hz (120 V only) models listed by SGS United States
Testing Company, Inc. per ANSI/RVIA EGS-1 and
CSA-certified per Electrical Bulletin 946
Complete line of parts and accessories
Cummins Inc offers replacement and tune-up parts,
accessories, oil and maintenance chemicals - all specially
designed to help keep your
Cummins Onan generator set
running at peak performance.
Cummins Inc. also provides
genuine Onan Green Label
Parts™ that exactly match
generator set specifications
and will help maximize power
output and extend the life of
your generator set.
- This generator set was designed and manufactured in
facilities certified to ISO 9001
- 60 Hz models meet applicable U.S. EPA and California
emissions standards
Largest distributor/dealer support network
Cummins Onan generator sets are supported by the
largest and best trained worldwide certified
distributor/dealer network in the industry. This network of
knowledgeable Cummins Onan distributor/dealers will help
you select and install the right generator set and
accessories to meet the requirements of your specific
application. This same network offers a complete selection
of commonly used generator set maintenance parts,
accessories and products plus manuals and specification
sheets. Plus, they can answer your questions regarding
proper operation, maintenance schedules and more.
Warranty policy
This limited warranty covers virtually everything except
routine maintenance for the first two years you own your
RV generator set, and covers parts and labor on major
power train and generator set parts during the third year.
In addition, it also includes a free 90-day adjustment
policy, which provides that Cummins Inc. will make minor
adjustments during the first three months you own it free of charge! Please note: This 3-year limited warranty
applies to RV generator sets used in RV applications
only, and does not apply to RV generator sets used in
commercial mobile applications.
!
WARNING:
Do not use this generator set on a boat.
Such use may violate U.S. Coast Guard
regulations, and can result in severe
personal injury or death from fire,
explosion, electrocution, or carbon
monoxide poisoning.
!
WARNING:
Back feed to a utility system can cause
electrocution and/or property damage. Do
not connect to any building electrical
except through an approved device or
after building main breaker is open.
Manuals: Operation and installation manuals ship with
the generator set. To obtain additional copies or other
manuals for this model, see your Cummins Onan
distributor/dealer and request the following manual
numbers: Operation (981-0159), Installation (981-0621),
Parts (981-0246), Service (981-0530).
To easily locate the nearest Cummins Onan
distributor/dealer in your area, or for more information,
contact us at 1-800-888-6626 (or 763-574-5000), or visit
www.cumminsonan.com.
Contact your distributor/dealer for more information.
Cummins Power Generation
1400 73rd Ave. NE
Minneapolis, MN 55432 USA
Phone 1 763 574 5000
Toll-free 1 800 888 6626
Fax 1 763 574 5298
Email www.cumminsonan.com/contact
www.cumminsonan.com
©2011 Cummins Power Generation. All Rights Reserved. Cummins®, Onan®, the “C” logo, Performance you rely on.TM and Quiet Gasoline™ are servicemarks and/or
registered trademarks of Cummins Inc. Specifications are subject to change without notice.
A-1399m (2/11)
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement