2012 through 2014 Precedent Golf Car Owner`s Manual

2012 through 2014
Precedent Golf Car
Owner’s Manual
Gasoline Vehicle with Kawasaki FE350 Engine
Electric Vehicle with PowerDrive® Battery Charger
[Refer to back cover for applicable build code range]
NOTICE
This manual is valid for vehicles manufactured in the build code range provided on the back cover of this manual. If the
vehicle build code is different from that shown on the back cover of this manual, please contact your nearest dealer or go to
www.clubcar.com to retrieve the proper owner’s manual for the vehicle. See also Model Identification in this manual.
Warranty information appears at the end of this manual. No other warranties, expressed or implied, are contained herein.
Your authorized representative checked the vehicle before it was delivered to you and will provide you a copy of the
completed vehicle warranty registration form.
Club Car is not liable for errors in this manual or for incidental or consequential damages that result from the use of
the material in this manual.
The two-passenger golf vehicle conforms to the current American National Standards Institute’s Z130 Safety and
Performance Requirements for Golf Cars. This standard, which promotes safety in the design, application, and operation
of golf cars, defines a golf car as “a vehicle used to convey a person or persons and equipment to play the game of golf in
an area designated as a golf course.” Throughout this manual, the words “golf car” and “vehicle” are used interchangeably.
This manual contains proprietary information that is protected by copyright. All rights are reserved. No part of this manual
may be photocopied, reproduced, or translated to another language without the written consent of Club Car, LLC.
The information contained in this document is subject to change without notice.
Club Car reserves the right to make design changes to vehicles without obligation to make these changes on units
previously sold.
These vehicles do not conform to U.S. Federal Motor Vehicle Safety Standards (FMVSS) for automobiles or to FMVSS 500
for low-speed vehicles, and are not equipped for operation on public streets, roads, or highways.
If in English, this manual is the Original Instructions provided by the manufacturer. If in any language other than English,
this manual is a translation of the Original Instructions.
P.O. Box 204658
Augusta, Georgia 30917–4658 USA
Telephone 706–863–3000
Service Parts Fax 706–855–7413
www.clubcar.com
Copyright © 2008, 2009, 2010, 2011, 2013 Club Car, LLC
Club Car, Tranquility, and ArmorFlex
are registered trademarks of Club Car, LLC
This manual effective August 1, 2011
2012 through 2014 Precedent Golf Car Owner’s Manual
Page 1
FOREWORD
Thank you for choosing Club Car, the name most widely recognized as the industry leader in vehicle efficiency
and long-lasting value. You have chosen the finest golf car on the market. Please protect your investment and
ensure that your Club Car provides years of reliable, superior performance by reading and following the maintenance
instructions in this manual.
Your comfort and safety are important to us as well, so we urge you to read and follow the step-by-step operating
instructions and safety precautions in this manual. These instructions must be followed in order to avoid the risk of
severe personal injury. If you rent or loan your vehicle to others, we recommend that you ask them to read this manual
before they operate the vehicle.
Club Car products are backed by a customer support system designed to offer you fast, courteous service. In the event
that your golf car needs repairs or service, please contact your local authorized Club Car dealer or distributor, who
will be able to provide technical advice, perform warranty work, and sell parts and service manuals. For the name
and address of the authorized Club Car dealer or distributor nearest you, logon to our web site at www.clubcar.com
or call 1-800-ClubCar (258-2227). If you would prefer to write to us, direct your letter to: Club Car LLC, Attention:
Marketing Services, P.O. Box 204658, Augusta, Georgia 30917-4658 USA.
We hope you will consider this owner’s manual a permanent part of your golf car. If you sell the vehicle, please include
the manual so that the next owner will have the important operating, safety, and maintenance information it contains.
REGULAR MAINTENANCE ITEMS
PERIODIC MAINTENANCE ITEMS
Engine Oil Filter (286 cc and 351 cc)
Spark Plug O.H.V. (286 cc and 351 cc)
CC P/N 103887901
Either CC P/N AM1232301 or 101881101
Engine Air Filter (286 cc and 351 cc)
Spring Tune-Up Kit
CC P/N 102558201
CC P/N AM1262501
Fuse, 10 Amp, Starting Circuit (gasoline vehicle)
Engine Fuel Filter (286 cc and 351cc)
Fuse under Seat near Solenoid
CC P/N 102003201
CC P/N 1012295
Fuse, 15 Amp, Tow/Run Switch (electric vehicle)
Battery Terminal Protector Spray
Fuse under Seat beneath Electronics Module Cover
CC P/N 1014305
CC P/N 102538601
Fuse, 10 Amp, Headlight Circuit (if equipped)
Dry Moly Lube
Fuse under Seat beneath Electronics Module Cover
CC P/N 1012151
CC P/N 1012295
Fuse, 0.5 Amp, Brake Light Circuit (if equipped)
Fuse under Floormat beneath Floor Cover Plate
CC P/N AM1214301
Page 2
2012 through 2014 Precedent Golf Car Owner’s Manual
TABLE OF CONTENTS
Safety Decal and Feature Identification .................................................................................................................. 4
Practice Safety ..................................................................................................................................................... 9
Proposition 65 – State of California ...................................................................................................................... 10
Safety Details ......................................................................................................................................................11
General Warnings............................................................................................................................................... 12
General Information ............................................................................................................................................ 16
Model Identification............................................................................................................................................. 16
Safety Committee ............................................................................................................................................... 17
Controls and Indicators – Electric Vehicles ........................................................................................................... 18
Controls and Indicators – Gasoline Vehicles ......................................................................................................... 23
Pre-Operation and Daily Safety Checklist ............................................................................................................. 28
Driving Instructions ............................................................................................................................................. 30
Towing ............................................................................................................................................................... 32
Transporting on a Trailer ..................................................................................................................................... 32
Storage – Electric Vehicle.................................................................................................................................... 33
Storage – Gasoline Vehicle ................................................................................................................................. 35
Maintenance ...................................................................................................................................................... 38
Periodic Service Schedules ................................................................................................................................. 39
Periodic Lubrication Schedules............................................................................................................................ 43
Batteries – Electric Vehicles ................................................................................................................................ 45
Battery Charger – Electric Vehicles ...................................................................................................................... 49
Single Point Watering System (SPWS)................................................................................................................. 53
Battery – Gasoline Vehicles................................................................................................................................. 55
Engine Oil – Gasoline Vehicles ............................................................................................................................ 56
Fueling Instructions – Gasoline Vehicles .............................................................................................................. 59
Cleaning the Vehicle ........................................................................................................................................... 60
Accessories........................................................................................................................................................ 60
Subsequent Owner Registration .......................................................................................................................... 61
Precedent Four-Passenger Vehicle...................................................................................................................... 61
Vehicle Specifications ........................................................................................................................................ 63
Warranties.......................................................................................................................................................... 65
EC Declaration of Conformity .............................................................................................................................. 73
2012 through 2014 Precedent Golf Car Owner’s Manual
Page 3
Safety Decal and Feature Identification
SAFETY DECAL AND FEATURE IDENTIFICATION
The following pages contain safety decal and feature identification information. For detailed information on specific
features, read the appropriate section in this manual.
ELECTRIC PRECEDENT
3
1
4
5
6
7
8
2
2481
1
101825101
Decal, On/Off Key Switch (above key switch)
5
Battery Warning Light
2
102519301
Decal, Rollover Warning (on instrument panel)
6
Accelerator Pedal
3
102555901
7
Brake Pedal
4
103783001
8
Park Brake Pedal
Page 4
Decal, Private Speed Notice (below instrument
panel) (With Private Speed Notice optional)
Decal, Operating Instructions (on steering wheel)
2012 through 2014 Precedent Golf Car Owner’s Manual
Safety Decal and Feature Identification
ELECTRIC PRECEDENT
1
2
3
4
5
6
2482
1
103384601
Decal, Water Exposure Caution
5
Forward/Reverse Control
2
103384701
Decal, Battery Terminal Warning
6
Battery Charger Receptacle
3
103384801
Decal, Tow/Run Warning
4
Tow/Run Switch
2012 through 2014 Precedent Golf Car Owner’s Manual
Page 5
Safety Decal and Feature Identification
GASOLINE PRECEDENT
3
1
5
4
6
8
7
2
2546
1
101825101
Decal, On/Off Key Switch (above key switch)
5
Low Oil Warning Light
2
102519301
Decal, Rollover Warning (on instrument panel)
6
Accelerator Pedal
3
102555901
7
Brake Pedal
4
103783002
Page 6
Decal, Private Speed Notice (below instrument
panel) (With Private Speed Notice optional)
Decal, Operating Instructions (on steering wheel)
8
2012 through 2014 Precedent Golf Car Owner’s Manual
Park Brake Pedal
Safety Decal and Feature Identification
GASOLINE PRECEDENT
1
295
1
101960501
2
102517801
3
102517901
Decal, Rotating Parts/Hot Manifold Warning (on
engine, starter/generator, and transaxle)
Decal, Gas/Governor Warning (on fuel tank
hold-down bracket)
4
Choke
5
Forward/Reverse Control
Decal, Frame Ground Warning (on vehicle frame,
under seat)
2012 through 2014 Precedent Golf Car Owner’s Manual
Page 7
Safety Decal and Feature Identification
PRECEDENT VILLAGER 4
2
3
4
1
415
Decal, Falling Off Warning (on rear-facing seat
1
101705701
hand rail and/or on back side of forward-facing seat 4
backs)
2
Hand hold
3
Hand rail
Page 8
2012 through 2014 Precedent Golf Car Owner’s Manual
Foot rest
Practice Safety
PRACTICE SAFETY
399
Figure 1
Practice Safety
Safety signs like you see above may at first seem shocking, but their impact is mild compared with the reality
of severe personal injury.
Your safety and satisfaction are of the utmost importance to us. That is why before operating the vehicle, we urge
you to review the information in this manual. Understand and become familiar with the DANGER, WARNING, and
CAUTION statements and procedures it contains, along with the safety decals that are affixed to your vehicle.
Take time to understand the language of safety. It is a language that can save your life.
2012 through 2014 Precedent Golf Car Owner’s Manual
Page 9
Proposition 65 – State of California
PROPOSITION 65 – STATE OF CALIFORNIA
WARNING
• This product contains or emits chemicals or substances that have been determined by the state of
California to cause cancer and birth defects or other reproductive harm.
Page 10
2012 through 2014 Precedent Golf Car Owner’s Manual
Safety Details
SAFETY DETAILS
WARNING
• This owner’s manual should be read completely before attempting to drive or service the vehicle.
Failure to follow the instructions in this manual could result in property damage, severe personal
injury, or death.
It is important to note that some vital statements throughout this manual and on the decals affixed to the vehicle are
preceded by the words DANGER, WARNING, or CAUTION. For your protection, we recommend that you take special
notice of these safety precautions. Safety precautions are essential and must be followed.
Throughout this manual and on the operation and safety decals affixed to the vehicle, the words “golf car” and
“vehicle” are used interchangeably. “Golf car” is defined in the Notice of this manual and no other representation is
stated or implied.
If any of the operation or safety decals on the vehicle become damaged, have been removed or cannot be easily
read, they should be replaced immediately to avoid possible property damage, personal injury, or death. Contact your
distributor/dealer.
DANGER
• A DANGER indicates an immediate hazard that will result in severe personal injury or death.
WARNING
• A WARNING indicates an immediate hazard that could result in severe personal injury or death.
CAUTION
• A CAUTION with the safety alert symbol indicates a hazard or unsafe practice that could result in
minor personal injury.
CAUTION
• A CAUTION without the safety alert symbol indicates a potentially hazardous situation that could
result in property damage.
2012 through 2014 Precedent Golf Car Owner’s Manual
Page 11
General Warnings
GENERAL WARNINGS
The following safety statements must be heeded whenever the vehicle is being operated, repaired, or serviced. Vehicle
feature identification information is also included. See Safety Decal and Feature Identification on page 4. Other
specific safety statements appear throughout this manual and on the vehicle.
DANGER
• Battery – Explosive gases! Do not smoke. Keep sparks and flames away from the vehicle and service
area. Ventilate when charging or operating vehicle in an enclosed area. Wear a full face shield and
rubber gloves when working on or near batteries.
DANGER CONTINUED ON NEXT PAGE
Page 12
2012 through 2014 Precedent Golf Car Owner’s Manual
General Warnings
DANGER
• Gasoline – Flammable! Explosive! Do not smoke. Keep sparks and flames away from the vehicle and
service area. Service only in a well-ventilated area.
• Do not operate engine in an enclosed area without proper ventilation. The engine produces carbon
monoxide, which is an odorless, deadly poison.
• The vehicle will not provide protection from lightning, flying objects, or other storm-related hazards. If
caught in a storm while driving a Club Car vehicle, exit the vehicle and seek shelter in accordance with
applicable safety guidelines for your location.
WARNING
• Follow the procedures exactly as stated in this manual, and heed all DANGER, WARNING, and
CAUTION statements in this manual as well as those on the vehicle and battery charger.
• Do not leave children unattended on vehicle.
• Prior to leaving the vehicle unattended or servicing the vehicle, set the park brake, place the
Forward/Reverse handle or switch in the NEUTRAL position, turn the key switch to the OFF position,
and remove the key. Chock the wheels when servicing the vehicle.
• Improper use of the vehicle or failure to properly maintain it could result in decreased vehicle
performance, severe personal injury, or death.
• Any modification or change to the vehicle that affects the electrical system, stability or handling
of the vehicle, or increases maximum vehicle speed beyond factory specifications, could result in
severe personal injury or death.
• Check the vehicle for proper location of all vehicle safety and operation decals and make sure they are
in place and are easy to read. See Safety Decal and Feature Identification on page 4.
• Only trained technicians should service or repair the vehicle or battery charger. Anyone doing even
simple repairs or service should have knowledge and experience in electrical and mechanical repair.
The appropriate instructions must be used when performing maintenance, service, or accessory
installation.
• Wear safety glasses or approved eye protection when servicing the vehicle or battery charger. Wear a
full face shield and rubber gloves when working on or near batteries.
• Do not wear loose clothing or jewelry such as rings, watches, chains, etc., when servicing the
vehicle or battery charger.
• Use insulated tools when working near batteries or electrical connections. Use extreme caution to
avoid shorting of components or wiring.
Electric vehicles only:
• Place Tow/Run switch in the TOW position before disconnecting or connecting the batteries. Failure to
heed this warning could result in a battery explosion or severe personal injury.
• To avoid unintentionally starting an electric vehicle, disconnect the batteries and discharge the
controller. See Disconnecting the Batteries – Electric Vehicles on page 15.
Gasoline vehicles only:
• To avoid unintentionally starting a gasoline vehicle, disconnect the battery and spark plug wire. See
Disconnecting the Battery – Gasoline Vehicles on page 14.
• Frame ground – Do not allow tools or other metal objects to contact frame when disconnecting battery
cables or other electrical wiring. Do not allow a positive wire to touch the vehicle frame, engine, or
any other metal component.
2012 through 2014 Precedent Golf Car Owner’s Manual
Page 13
General Warnings
DISABLING THE VEHICLE
1.
Set the park brake.
2.
3.
Turn the key switch OFF and remove the key.
Place the Forward/Reverse control in the NEUTRAL position.
4.
In addition, chock the wheels if servicing or repairing the vehicle.
DISCONNECTING THE BATTERY – GASOLINE VEHICLES
1.
2.
Disable the vehicle. See Disabling the Vehicle on page 14.
Disconnect the battery cables, negative (–) cable first, as shown (Figure 3).
3.
Disconnect the spark plug wire(s) from the spark plug(s).
CONNECTING THE BATTERY – GASOLINE VEHICLES
1.
Connect the battery cables, positive (+) cable first.
2.
3.
Tighten battery terminals to 80 in-lb (9 N·m).
Coat terminals with Battery Terminal Protector Spray (CC P/N 1014305) to minimize corrosion.
4.
Connect the spark plug wire(s) to the spark plug(s).
1
3
TO W
R UN
(+)
1
+
(–)
2
2
6
3
2
4
5
(+)
1
(–)
(Viewed from driver side of vehicle)
(Viewed from driver side of vehicle)
1. Remove negative battery cable.
1. Place TOW/RUN Switch in TOW before disconnecting or connecting
battery cables.
2. Remove positive battery cable.
Connect battery cables in reverse order.
2. Remove negative battery cable.
3. Remove positive battery cable.
Connect battery cables in reverse order.
49A
50
Figure 2
Page 14
Battery Cable Removal – 6x8-Volt Battery
Configuration
Figure 3 Battery Cable Removal – Gasoline
2012 through 2014 Precedent Golf Car Owner’s Manual
General Warnings
DISCONNECTING THE BATTERIES – ELECTRIC VEHICLES
1.
Disable the vehicle. See Disabling the Vehicle on page 14.
2.
3.
Place Tow/Run switch in the TOW position before disconnecting or connecting the batteries. Failure to heed
this warning could result in a battery explosion or severe personal injury.
Disconnect the batteries, negative (–) cable first, as shown (Figure 2).
4.
After disconnecting the batteries, wait 90 seconds for the controller capacitors to discharge.
CONNECTING THE BATTERIES – ELECTRIC VEHICLES
1.
Ensure the Tow/Run switch is in the TOW position.
2.
Connect the battery cables, positive (+) cable first.
3.
Tighten battery terminals to 110 in-lb (12.4 N·m).
4.
Coat terminals with Battery Terminal Protector Spray (CC P/N 1014305) to minimize corrosion.
RECYCLING LEAD-ACID BATTERIES
WARNING
• Lead-acid batteries contain lead (Pb), other metals, acids and other compounds. If improperly handled,
they can contaminate both water and soil, causing environmental damage and personal injury.
Lead-acid batteries are identified by the symbol shown below and should be properly recycled (Figure 4). They cannot
be disposed as municipal waste and must be collected separately. Responsibility for environmental protection must be
shared, not only by the manufacturers of the batteries, but by people who use the batteries as well. Please contact
your nearest Club Car dealer or distributor for information on how to properly recycle your batteries.
1403
Figure 4 Dispose of Lead-acid Batteries Properly
2012 through 2014 Precedent Golf Car Owner’s Manual
Page 15
General Information
INTERNATIONAL SAFETY SYMBOLS ON BATTERIES
Anyone using, repairing, or servicing the vehicle must understand and heed the safety symbols on the vehicle battery
or batteries.
2
1
4
3
6
5
1. Shield eyes.
3. No smoking, no open flames, no sparks.
5. Battery acid hazard.
2. Read and follow operating instructions.
4. Keep away from children.
6. Explosive gas hazard.
Refer to General Warnings for more information.
1642
Figure 5
International Safety Symbols on Batteries
GENERAL INFORMATION
Precedent Golf Cars are available with either electric or gasoline power. Throughout this manual, important features
unique to each model are highlighted. We urge the owner/operator to read and understand this manual, and to pay
special attention to the features specific to his/her vehicle(s).
MODEL IDENTIFICATION
The serial number of each vehicle is printed on a bar code decal mounted either below the passenger side cup holder
or above the accelerator or brake pedal (Example: PH0901-583947) (Figure 6).
The two letters (1) at the beginning of the serial number indicate the vehicle model. The following four digits (2)
indicate the model year and production week during which the vehicle was built. The six digits (3) following the hyphen
represent the unique sequential number assigned to each vehicle built within a given model year. See following NOTE.
NOTE: Have the vehicle serial number available when ordering parts or making inquiries.
Build Code: The build code (4) is a five-digit number that appears on the vehicle serial number decal. The build code
exists to enable the user to identify the correct owner’s manual for a vehicle. This owner’s manual is valid for the build
code range indicated on the back cover of this owner’s manual.
Page 16
2012 through 2014 Precedent Golf Car Owner’s Manual
Safety Committee
4
1
2
3
SERIAL NUMBER
PH0901-123456
BC54679
ASSEMBLED IN USA
1400
Figure 6 Serial Number Decal
SAFETY COMMITTEE
If the golf car is to be rented or is part of a fleet, we strongly recommend that a safety committee be appointed. One of
the main concerns of this committee should be the safe operation of the golf cars. This should include at a minimum:
• Where golf cars should be driven.
• Ensuring that proper warnings of driving hazards are displayed and visible.
• Who should and who should not drive golf cars.
• Instructing first time drivers.
• Maintaining golf cars in a safe driving condition.
• How various rules are to be enforced.
The safety committee should include all these items and such others as the committee feels necessary or appropriate.
2012 through 2014 Precedent Golf Car Owner’s Manual
Page 17
Controls and Indicators – Electric Vehicles
CONTROLS AND INDICATORS – ELECTRIC VEHICLES
See General Warnings on page 12.
WARNING
• If renting or loaning the vehicle, make sure the driver is familiar with all controls and operating
procedures before allowing the vehicle to be driven.
• Do not shift the Forward/Reverse switch while the vehicle is moving. To avoid injury to an
unsuspecting passenger or damage to the vehicle, always bring the vehicle to a full stop before
shifting the Forward/Reverse switch.
• Release the accelerator pedal and then press the brake pedal firmly until the vehicle stops. To avoid
unintentionally starting or rolling the vehicle, set the park brake, place the Forward/Reverse switch in
the NEUTRAL position, turn the key switch to the OFF position, and remove the key when leaving
the vehicle.
KEY SWITCH
The key switch is mounted on the dash to the right of the steering column (Figure 7). It has two positions, OFF and
ON, which are clearly labeled. See following NOTE.
NOTE: When the key is turned to the OFF position, the main vehicle systems are disabled. The key switch may be
used as an emergency stop.
The key can be removed only when the key switch is in the OFF position.
52
6
Figure 7 Key Switch
Figure 8
Forward/Reverse Rocker Switch – Electric
Vehicle
FORWARD/REVERSE CONTROL
The Forward/Reverse rocker switch is located on the seat support panel, below and to the right of the driver’s right
knee (Figure 8). The F (FORWARD) and R (REVERSE) are clearly marked. Push down the FORWARD side of the
switch to operate the vehicle in the forward direction, or push down the REVERSE side of the switch to operate
the vehicle in reverse. When the rocker switch is positioned in the NEUTRAL position, with neither side down, the
Page 18
2012 through 2014 Precedent Golf Car Owner’s Manual
Controls and Indicators – Electric Vehicles
vehicle will not operate if the accelerator pedal is pressed. The reverse buzzer will sound as a warning when the
Forward/Reverse switch is in the REVERSE position.
ACCELERATOR PEDAL
The accelerator pedal is the pedal on the right, with the word GO molded into it (Figure 9). The operation of the
accelerator pedal differs from that of an automobile. When the key switch is the ON position, and the Forward/Reverse
switch is in either the FORWARD or REVERSE position, pressing the accelerator pedal will automatically release
the park brake and start the vehicle moving in the direction selected (forward or reverse). As the accelerator pedal
is pressed, speed will increase until full speed is reached. When the accelerator is released, power will be cut off
and the motor will stop running.
Electric vehicles use a special electrical system, which employs motor braking in some modes of operation. In
those modes, the vehicle operates as follows:
• Walk Away Braking: This feature prevents the vehicle from rolling away uncontrolled should the driver park on a
slope and leave the vehicle without locking the park brake. The vehicle will roll at about 1 to 3 mph (1.6 to 4.8 km/h).
If the away braking function remains engaged for two seconds or more, a warning buzzer will sound to alert the
driver that motor braking has been activated. See following WARNING.
WARNING
• Walk away braking will not limit vehicle speed to 3 mph (4.8 km/h) on very steep grades. Do not
operate vehicle on slopes exceeding 20% grades.
Excel System Vehicles
• Motor Braking:This feature helps to control vehicle downhill speed. When traveling downhill, motor braking
engages to maintain speeds proportional to the accelerator pedal position. For example, when the accelerator is
fully pressed, motor braking holds the vehicle at the programmed top speed. When the accelerator pedal is fully
released, motor braking slows the vehicle to a complete stop or allows the vehicle to coast freely, depending
upon the selected controller setting. This feature is selectable. Contact your local Club Car dealer/distributor to
inquire about this feature. See following WARNING.
WARNING
• When batteries are fully charged, a warning buzzer will sound during motor braking to alert the driver
that motor braking is operating at a reduced level of performance. When this occurs, use the brake
pedal to control vehicle speed.
IQ System Vehicles
• Pedal Up Motor Braking: When vehicle speed is above 11 mph (17.7 km/h), releasing the accelerator pedal will
activate motor braking, which slows the vehicle speed. Once vehicle speed slows to below approximately 11 mph
(17.7 km/h), with the accelerator pedal still released, motor braking will be deactivated and the vehicle will coast
freely. This feature is selectable. Contact your dealer/distributor to inquire about this selectable feature. See
preceding WARNING.
• Pedal Down Motor Braking: This feature helps to control vehicle downhill speed. Motor braking is activated when
the vehicle reaches the programmed top speed and holds the vehicle at that speed. Motor braking is automatically
disengaged when vehicle speed slows below the programmed top speed. See preceding WARNING.
2012 through 2014 Precedent Golf Car Owner’s Manual
Page 19
Controls and Indicators – Electric Vehicles
77
Figure 9 Accelerator Pedal
BRAKE PEDAL
The brake pedal is the large pedal on the left with the word STOP molded into it. To slow or stop the vehicle, press
the brake pedal with your foot (Figure 10).
79
78
Figure 10 Brake Pedal
Figure 11 Park Brake Pedal
PARK BRAKE PEDAL
The park brake pedal is the small raised portion in the upper left corner of the brake pedal. It has the word PARK
molded into it. To set the park brake, press the brake pedal firmly and tilt the park brake portion of the pedal forward
with your foot (Figure 11). See following WARNING and NOTE.
Page 20
2012 through 2014 Precedent Golf Car Owner’s Manual
Controls and Indicators – Electric Vehicles
WARNING
• The park brake will release automatically when either the accelerator or brake pedal is pressed. The
park brake has multiple locking positions and should be firmly engaged and locked to prevent the
vehicle from rolling.
BATTERY WARNING LIGHT
Precedent electric vehicles feature a dash-mounted warning light (below the steering column) that, when the vehicle is
in operation, indicates low battery voltage or, when the vehicle is being charged, indicates a charging problem (Figure
12). The battery warning light is controlled by the onboard computer.
56
Figure 12 Battery Warning Light
When the vehicle is in operation, the warning light is controlled by the onboard computer.
• Batteries’ voltage drops below 48 volts when there is no load on the batteries (the vehicle is stopped and there
are no accessories on).
• Batteries have discharged to less than 25% of rated capacity.
If the warning light illuminates when the vehicle is operating, there will be enough power remaining to drive the vehicle
for approximately 30 minutes. However, the vehicle should be charged at the first opportunity. If the warning light
illuminates and the vehicle is unable to operate for 30 minutes, have your Club Car distributor/dealer check the
vehicle for a possible battery or electrical system problem.
When the batteries receive an incomplete charge because 1) the DC power cord is disconnected, 2) AC power to the
charger is interrupted, 3) automatic charger shut-off occurs after 16 hours of operation, 4) the charger malfunctions,
or 5) the wrong charger is used, the warning light will indicate as follows:
• The warning light will not illuminate if the charge is 90% or more complete. The onboard computer will retain in
memory the amount of charge needed to fully replenish the batteries and will complete the charge during the
next charge cycle.
• When the charger is unplugged, the warning light will illuminate and remain illuminated for 10 seconds if the charge
is less than 90% complete but the vehicle has enough power for approximately 30 minutes of operation. This will
alert the operator that the vehicle may be used, but that it must be charged to completion as soon as possible.
2012 through 2014 Precedent Golf Car Owner’s Manual
Page 21
Controls and Indicators – Electric Vehicles
• The warning light will repeatedly illuminate for 10 seconds, with 4 second intervals if the charger times out at 16
hours and the batteries are not sufficiently charged. This indicates an abnormal charge cycle. The charger and
batteries should be checked by your Club Car distributor/dealer.
• The warning light will repeatedly illuminate for 10 seconds, with 4 second intervals during a charge cycle (DC plug is
still connected) if AC power to the charger is interrupted. The light will go out when AC power is restored.
NOTE: The battery warning light will flash quickly, after inserting the DC plug, if the charger relay/voltage suppressor
has failed in the closed position.
LED Light: In addition to the warning light, there is an infrared LED in the dash light assembly, which transmits an
infrared signal from the onboard computer (OBC). This signal is received by the optional Communication Display
Module, which provides information on the condition of the vehicle and batteries.
TOW/RUN SWITCH
WARNING
• Place Tow/Run switch in the TOW position before disconnecting or connecting the batteries. Failure to
heed this warning could result in a battery explosion or severe personal injury.
• When the Tow/Run switch is in the TOW position, all motor braking functions, including walk away
braking, are disabled.
The Precedent electric vehicles are equipped with a Tow/Run switch, located under the seat behind the batteries
(Figure 13). The switch must be in the RUN position in order to operate the vehicle. When the switch is in the TOW
position, power to the vehicle electrical components is turned off and the vehicle will not operate. See following NOTE.
NOTE: After placing the Tow/Run switch in the TOW position, allow 10 seconds to elapse before switching back to
the RUN position.
After placing the Tow/Run switch in the RUN position, allow 10 seconds to elapse before operating the vehicle.
RU
N
TO
W
1381
Figure 13 Tow/Run Switch
The Tow/Run switch should be placed in the TOW position under the following conditions:
Page 22
2012 through 2014 Precedent Golf Car Owner’s Manual
Controls and Indicators – Gasoline Vehicles
• Before Towing the Vehicle: Place the Tow/Run switch in the TOW position to disable all motor braking functions,
thus preventing possible damage that could occur to the vehicle or electrical components if the vehicle is towed
while the walk away braking motor braking function is operating.
• Before Disconnecting or Connecting Battery Cables: Place the Tow/Run switch in the TOW position to turn
off power to the vehicle electrical system, thus preventing severe arcing and possible battery explosion as the
battery cables are disconnected.
• For Long Term Storage: Place the Tow/Run switch in the TOW position to turn off power to the vehicle electrical
system, thus preventing vehicle electrical components from discharging the batteries.
CONTROLS AND INDICATORS – GASOLINE VEHICLES
See General Warnings on page 12.
WARNING
• If renting or loaning the vehicle, make sure the driver is familiar with all controls and operating
procedures before allowing the vehicle to be driven.
• Do not shift the Forward/Reverse handle while the vehicle is moving. To avoid injury to an
unsuspecting passenger or damage to the vehicle, always bring the vehicle to a full stop before
shifting the Forward/Reverse handle.
• Release the accelerator pedal and then press the brake pedal firmly until the vehicle stops. To avoid
unintentionally starting or rolling the vehicle, set the park brake, place the Forward/Reverse handle in
the NEUTRAL position, turn the key switch to the OFF position, and remove the key.
• Do not tamper with the governor. Doing so will void the warranty, as well as damage the engine and
other components, and could result in property damage, personal injury, or death due to unsafe speed.
KEY SWITCH
The key switch is mounted on the dash to the right of the steering column (Figure 14). It has two positions, OFF and
ON, which are clearly labeled. See following NOTE.
NOTE: When the key is turned to the OFF position, the main vehicle systems are disabled. The key switch may be
used as an emergency stop.
The key can be removed only when the key switch is in the OFF position.
2012 through 2014 Precedent Golf Car Owner’s Manual
Page 23
Controls and Indicators – Gasoline Vehicles
59
52
Figure 14 Key Switch
Figure 15 Forward/Reverse Handle
FORWARD/REVERSE CONTROL
The Forward/Reverse handle is located on the seat support panel, below and to the right of the driver’s right knee
(Figure 15). The handle has three distinct positions: F (FORWARD), N (NEUTRAL), and R (REVERSE). Rotate the
handle towards the driver (FORWARD) to operate the vehicle in the forward direction, or towards the passenger
(REVERSE) to operate the vehicle in reverse. When the handle is in the straight up position, (NEUTRAL), the vehicle
will not operate. The engine will stop if it is shifted to this position during operation. Club Car vehicles operate at
reduced speed in reverse. The reverse buzzer will sound as a warning when the Forward/Reverse handle is in
the REVERSE position.
ACCELERATOR PEDAL
The accelerator pedal is the pedal on the right, with the word GO molded into it (Figure 16). The operation of
the accelerator pedal differs from that of an automobile. When the key switch is in the ON position, and the
Forward/Reverse handle is in either the FORWARD or REVERSE position, pressing the accelerator pedal will
automatically release the park brake and start the vehicle moving in the direction selected (forward or reverse). As
the accelerator pedal is pressed, speed will increase until full speed is reached. When the accelerator is released,
power will be cut off and the motor will stop running.
Page 24
2012 through 2014 Precedent Golf Car Owner’s Manual
Controls and Indicators – Gasoline Vehicles
77
Figure 16 Accelerator Pedal
BRAKE PEDAL
The brake pedal is the large pedal on the left with the word STOP molded into it. To slow or stop the vehicle, press
the brake pedal with your foot (Figure 17).
79
78
Figure 17 Brake Pedal
Figure 18 Park Brake Pedal
PARK BRAKE PEDAL
The park brake pedal is the small raised portion in the upper left corner of the brake pedal. It has the word PARK
molded into it. To set the park brake, press the brake pedal firmly and tilt the park brake portion of the pedal forward
with your foot (Figure 18). See following WARNING and NOTE.
2012 through 2014 Precedent Golf Car Owner’s Manual
Page 25
Controls and Indicators – Gasoline Vehicles
WARNING
• The park brake will release automatically when either the accelerator or brake pedal is pressed. The
park brake has multiple locking positions and should be firmly pressed and locked to prevent the
vehicle from rolling.
NEUTRAL LOCKOUT
For the convenience of the trained technician, there is a neutral lockout cam located on the back of the
Forward/Reverse shifter. If the neutral lockout cam is pulled out approximately 3/8 inch (10 mm) and then rotated
one-half turn until it snaps into place, the cam will be in the MAINTENANCE position (Figure 19). This will allow the
technician to operate the engine in neutral for certain maintenance procedures. With the cam in this position, the
vehicle will not operate if the Forward/Reverse handle is placed in either the FORWARD or REVERSE position.
To put the cam back into the OPERATE position, pull the cam out approximately 3/8 inch (10 mm) and rotate it one-half
turn until it snaps into place (Figure 20). See following WARNING and NOTE.
WARNING
• With the cam in the MAINTENANCE position and the engine running, the vehicle may move suddenly if
the Forward/Reverse handle is shifted or accidentally bumped. To prevent this, chock the front and
rear wheels and firmly set the park brake before servicing or leaving the vehicle.
NOTE: Be sure to return the cam to the OPERATE position after servicing the vehicle, or it will not operate with the
Forward/Reverse handle in either the FORWARD or REVERSE position.
60
61
Figure 19 Neutral Lockout – Maintenance Position
Figure 20 Neutral Lockout – Operate Position
CHOKE
The choke is located on the seat support panel below and to the right of the driver’s right knee (Figure 21). If the
vehicle is hard to start in cool or cold temperatures, simply push in the choke cover to activate it. Hold it during start
up and release the choke cover after the engine starts and runs smoothly.
Page 26
2012 through 2014 Precedent Golf Car Owner’s Manual
Controls and Indicators – Gasoline Vehicles
62
63
Figure 21 Choke
Figure 22 Low Oil Warning Light
LOW OIL WARNING LIGHT
The gasoline golf car is equipped with a low oil warning light, located on the dash panel just below the steering column
(Figure 22). If the warning light comes on, oil should be checked and added to the engine as necessary before
continuing to use the vehicle. The vehicle should never be driven with the low oil warning light remaining on. If the
warning light goes on and off, you may proceed, but oil should be added at the first opportunity. If the oil level is correct
and the warning light stays on, have a trained technician check the vehicle. See following CAUTION.
CAUTION
• Failure to add oil immediately when the low oil warning light stays on may result in permanent
engine damage.
2012 through 2014 Precedent Golf Car Owner’s Manual
Page 27
Pre-Operation and Daily Safety Checklist
PRE-OPERATION AND DAILY SAFETY CHECKLIST
Each Club Car vehicle has been thoroughly inspected and adjusted at the factory; however, upon receiving your new
vehicle(s), you should become familiar with its controls, indicators, and operation. Carefully inspect each vehicle to
ensure that it is in proper working condition before accepting delivery.
Use the following checklist as a guide to inspect the vehicle. This checklist should be used daily to ensure that
the vehicle is in proper working condition and in conjunction with the Performance Inspection on page 28, and the
Periodic Service Schedules on page 39. Any problems should be corrected by a Club Car distributor/dealer or a
trained technician.
Any vehicle not functioning correctly should be removed from use until it is properly repaired. This will prevent further
damage to the vehicle and avoid the possibility of injury due to unsafe conditions.
All Vehicles
• General: All the parts should be in place and properly installed. Be sure that all nuts, bolts, and screws are tight.
• Safety and information decals: Check to ensure that all safety and information decals are in place. See Safety
Decal and Feature Identification on page 4.
• Tires: Visually inspect tires for wear, damage, and proper inflation on a daily basis. See Vehicle Specifications
on page 63.
• Performance Inspection: Inspect as instructed. See Performance Inspection on page 28.
Electric Vehicles
• Batteries: Check electrolyte to ensure that it is at its proper level (Figure 27, Page 49). Check battery posts. Wires
should be tight and free of corrosion. Charge batteries fully before first use of vehicle.
• Charger cord, plug, and receptacle: Visually inspect for cracks, loose connections, and frayed wiring. See Plug
and Receptacle on page 52.
Gasoline Vehicles
• Battery: Check electrolyte to ensure it is at the proper level (Figure 35, Page 56). Check battery posts. Wires
should be tight and free of corrosion and battery should be fully charged.
• Engine: Check for proper engine oil level. See Engine Oil – Gasoline Vehicles on page 56.
• Fuel: Check fuel level. See Fueling Instructions – Gasoline Vehicles on page 59. Check fuel tank, lines,
cap, pump, fuel filters, and carburetor for fuel leakage.
•
WARNING
• Be sure the plastic has been removed from the seat bottom before operating the vehicle. Failure to do
so may result in a fire, property damage, personal injury, or death.
PERFORMANCE INSPECTION
After you have familiarized yourself with the vehicle controls and have read and understood the driving instructions,
take the vehicle for a test drive.
Use the following checklist in conjunction with the Daily Pre-Operation and Safety Checklist as a guide to inspect the
vehicle and check daily for proper operation. Any problems should be corrected by a Club Car distributor/dealer or a
trained technician.
All Vehicles
• Forward/Reverse switch: Check for proper operation. See Controls and Indicators – Electric Vehicles on
page 18 or Controls and Indicators – Gasoline Vehicles on page 23.
• Brakes: Be sure the brakes function properly. When brake pedal is pressed using moderate pressure, the
vehicle should come to a smooth, straight stop. If the vehicle swerves or fails to stop, stops abruptly, or makes
Page 28
2012 through 2014 Precedent Golf Car Owner’s Manual
Pre-Operation and Daily Safety Checklist
a grinding or squeaking noise, have the brake system checked and adjusted as required. Continued, moderate
brake pedal pressure should be able to lock the wheels, but using lesser pressure should also permit a slow,
gradual deceleration.
• Park brake: When latched, the park brake should lock the wheels and hold the vehicle stationary (on an incline of
20% or less). It should release when either the accelerator or brake pedal is pressed.
• Reverse buzzer: The reverse buzzer will sound as a warning when the Forward/Reverse handle or switch is in
the REVERSE position.
• Steering: The vehicle should be easy to steer and should not have any play in the steering wheel.
• General: Listen for any unusual noises such as squeaks or rattles. Check the vehicle’s ride and performance.
Have a Club Car distributor/dealer or a trained technician investigate anything unusual.
Electric Vehicles
• Accelerator: With the key switch in the ON position and the Forward/Reverse switch in the FORWARD position, as
the accelerator pedal is pressed, the motor should start and the vehicle should accelerate smoothly to full speed.
When the pedal is released it should return to the original position. All Club Car vehicles operate at reduced
speed in reverse.
• Walk Away Braking: With the vehicle parked on level ground and the park brake disengaged, place the Tow/Run
switch in the RUN position and attempt to push the vehicle. Motor braking should engage and cause resistance to
rolling ((moving at no more than 1 to 3 mph) (1.6 to 4.8 km/h)) with the Forward/Reverse switch in any position.
When walk away motor braking is engaged, the reverse buzzer should emit a distinct pattern of beeps. See
following WARNING.
WARNING
• Walk Away Braking will not limit vehicle speed to 3 mph (4.8 km/h) on very steep grades. Do not
operate vehicle on slopes exceeding 20% grades.
Excel System Vehicles
• Motor Braking: Accelerate down an incline with the accelerator pedal fully pressed. When the vehicle reaches
maximum programmed speed, motor braking should engage and limit the vehicle to its maximum programmed
speed. On very steep grades, the vehicle may slightly exceed its maximum programmed speed, requiring the use of
the brake pedal. Also, travel downhill with the accelerator pedal partially pressed. Motor braking should limit speed
to less than top speed and maintain speeds proportional to the accelerator pedal position. On a level surface,
accelerate the vehicle to full speed and then release the accelerator pedal. Motor braking should smoothly slow the
vehicle to a complete stop or else allow the vehicle to coast freely, depending on the selected controller setting.
IQ System Vehicles
• Pedal Up Motor Braking: Accelerate the vehicle to full speed and then release the accelerator pedal. Motor
braking should quickly and smoothly slow the vehicle to approximately 11 mph (17.7 km/h). Motor braking will
disengage when vehicle slows to 11 mph (17.7 km/h).
• Pedal Down Motor Braking: Accelerate down an incline with the accelerator pedal pressed. When the vehicle
reaches maximum programmed speed, motor braking should engage and limit the vehicle to its maximum
programmed speed. On very steep grades, the vehicle may slightly exceed its maximum programmed speed,
requiring the use of the brake pedal.
Gasoline Vehicles
• Accelerator: With the key switch in the ON position and the Forward/Reverse switch in the FORWARD position,
as the accelerator pedal is pressed, the engine should start and the vehicle should accelerate smoothly to
full speed. When the pedal is released it should return to the original position. All Club Car vehicles operate at
reduced speed in reverse.
• Governor: Check maximum speed of the vehicle. The vehicle should operate at 12 to 15 mph (19 to 24 km/h)
on a level surface.
2012 through 2014 Precedent Golf Car Owner’s Manual
Page 29
Driving Instructions
DRIVING INSTRUCTIONS
WARNING
• Only licensed drivers should be allowed to drive the vehicle.
• If renting or loaning the vehicle, make sure the driver is familiar with all controls and operating
procedures before allowing the vehicle to be driven.
• No more than two persons per bench seat should be on the vehicle at one time. Do not allow
passenger to ride in the bag well.
• The vehicle is not specially equipped for handicapped persons. Be sure all persons can properly
operate the vehicle prior to allowing them to drive the vehicle.
• Be sure all passengers are capable of securing themselves in a vehicle before allowing them to
ride in one.
• For night use, the vehicle must be equipped with headlights and taillights.
• Stop the vehicle before shifting the Forward/Reverse switch. Failure to do so may result in injury to an
unsuspecting passenger and (or) damage to the vehicle.
• To help avoid being struck, do not stand in front of or behind the vehicle.
• Operate the vehicle from the driver seat only.
• To help prevent falls from the vehicle, remain seated in a moving vehicle and hold on to hand holds
or handrails at all times. Driver should keep both hands on the steering wheel when the vehicle is
in motion.
• To help prevent the possibility of serious injury, keep your entire body inside the vehicle.
• Do not leave children unattended on vehicle.
• To help prevent overturning the vehicle, drive slowly straight up and down slopes. Avoid driving
the vehicle on slopes exceeding 20% incline.
• To help avoid possible injury to an inattentive passenger and (or) damage to the vehicle, avoid sudden
starts, sudden stops, and abrupt turns.
• To help avoid the possibility of losing control of or overturning the vehicle, reduce speed for adverse
driving conditions such as wet grass or rough terrain.
• Do not use the vehicle on public roads. It is not designed or intended for street use and should not
be licensed for use on public roads.
• Obey all local rules concerning golf cars.
• The vehicle should be driven in only specified areas by trained drivers.
• Do not drive while under the influence of alcohol, drugs, or medications.
• To prevent overturning the vehicle, drive slowly in turns.
• Use brakes to reduce speed when coasting downhill.
• This vehicle is not intended to be used where risk of falling objects exists. If your vehicle will be used
in such an environment, contact your local dealer.
• Do not drive the vehicle under tree limbs, bridges, tunnels, or other objects that are less than 80
inches (203 cm) from the ground.
No one should drive the vehicle without first being instructed in the proper operation and use of the vehicle’s controls.
An experienced operator should accompany each first-time driver on a test drive before allowing him/her to operate
the vehicle alone.
To ensure safe operation of the vehicle, follow exactly and in order, all of the following procedures. Read and
understand all instructions prior to driving the vehicle.
Page 30
2012 through 2014 Precedent Golf Car Owner’s Manual
Driving Instructions
STARTING THE VEHICLE
1.
Study and understand controls.
2.
3.
Make sure everyone is seated and holding onto seat handles or handrails.
Read safety and information decals located on the vehicle.
4.
Make sure wheels are turned in desired direction.
5.
Turn the key to the ON position and make sure nothing is in your path.
6.
Select direction by placing Forward/Reverse handle or switch in desired position (F = forward or R = reverse). A
buzzer will sound as a warning when the Forward/Reverse handle or switch is in the REVERSE position.
7.
Slowly press accelerator pedal. The park brake will release automatically and the vehicle will start to move. As
the accelerator pedal is pressed, speed will increase until full speed is reached. See following WARNING.
WARNING
• Operator must control vehicle speed when going downhill.
Electric vehicles:
• Pedal down or pedal up motor braking may be used to help control speed when going downhill;
however, steep terrain or other conditions will require that pedal braking be used in conjunction with
motor braking.
Gasoline Vehicles:
• Do not shift the vehicle out of forward while going downhill. If you do, you will not be able to shift
into reverse or back into forward until stopped.
• Press the brake pedal as necessary and partially press the accelerator when descending a hill. With
the accelerator pedal partially pressed, the governor will cause the engine to assist the brakes in
controlling downhill speed.
NOTE: If the Forward/Reverse handle is shifted into the NEUTRAL position, power will be cut off and the engine
will stop running.
STOPPING THE VEHICLE
WARNING
• Driving through water may affect the brakes. After driving through water, check effectiveness of the
brakes by gently pressing the brake pedal. If the vehicle does not slow down at the normal rate,
continue to press the brake pedal until the brakes dry out and normal performance returns.
CAUTION
• When stopped on a hill, use the brake pedal to hold your position. Do not use the accelerator pedal
to hold position.
To stop the vehicle, release the accelerator pedal and press the brake pedal with your right foot until the vehicle
comes to a complete stop.
PARKING AND LEAVING THE VEHICLE
1.
After stopping the vehicle, firmly press the park brake pedal until it locks and prevents the vehicle from rolling.
2012 through 2014 Precedent Golf Car Owner’s Manual
Page 31
Towing
2.
Turn the key switch to the OFF position and place the Forward/Reverse handle or switch in the NEUTRAL
position. Remove the key when the vehicle is not in use. For gasoline vehicles, also turn off the fuel shut-off
valve (Figure 23).
3.
Electric vehicles only: When the Tow/Run switch is in the RUN position, (with the Forward/Reverse switch or
key switch in any position), the walk away braking function will prevent the vehicle from rolling at more than 1 to 3
mph (1.6 to 4.8 km/h) unless the accelerator is pressed. This prevents the possibility of a parked vehicle (with
the park brake disengaged) rolling away too fast to be overtaken on foot.
TOWING
WARNING
• Do not tow the vehicle on public streets or highways.
• Use only approved Club Car tow bars.
• Turn the key switch to OFF and place the Forward/Reverse handle or switch in the NEUTRAL position
before towing the vehicle.
• Electric vehicles only: Place the Tow/Run switch in the TOW position; otherwise, the vehicle will
not roll while being towed.
• Extreme caution should be used when towing any vehicle.
• Do not exceed 5 mph (8 km/h) towing speed.
• Do not allow people in the vehicles being towed.
• Avoid sudden starts, sudden stops, and tight turns when towing.
• Avoid stopping on a hill when towing. If you must stop on a hill, avoid sudden starts or rolling
backwards and stopping suddenly. Failure to heed this warning could cause the vehicle to overturn,
possibly resulting in severe personal injury.
• Do not tow more than one Club Car vehicle with another Club Car vehicle. If more than one vehicle
must be towed, an adequately powered vehicle (tractor or full sized truck) properly fitted, with a tow
hitch height of 11 inches (28 cm) should be used. Only heavy-duty tow bars should be used for
multi-vehicle towing. Never tow more than five vehicles at one time.
• Gasoline vehicles only: Turn the fuel shut-off valve to closed (OFF) position (Figure 23).
• Stay clear from the area between the tow vehicle and the towed vehicle or trailer.
A light duty tow bar is available for break-down towing and single vehicle towing. A heavy duty tow bar and an onboard
tow bar are available for multi-vehicle towing. Observe all of the previous WARNING statements when towing.
TRANSPORTING ON A TRAILER
WARNING
• For use on public roads, the trailer must meet all federal, state, and local requirements such as
taillights, brake lights, etc.
• Do not tow a Club Car vehicle behind a passenger vehicle or truck on a public road unless it is on an
approved trailer.
• The vehicle to be towed should be tied securely to the trailer, with the Forward/Reverse handle or
switch in the NEUTRAL position, the key switch the OFF position, and the park brake firmly pressed
and locked to prevent movement.
WARNING CONTINUED ON NEXT PAGE
Page 32
2012 through 2014 Precedent Golf Car Owner’s Manual
Storage – Electric Vehicle
WARNING
• Do not allow people in the trailer or vehicle being towed.
• Avoid sudden starts, sudden stops, and tight turns when towing.
• Avoid stopping on a hill when towing. If you must stop on a hill, avoid sudden starts or rolling
backwards and stopping suddenly. Failure to heed this warning could cause the vehicle to overturn,
possibly resulting in severe personal injury.
• When towing on a trailer, normal road speed of the tow vehicle should be reduced.
• Because of the added length of the trailer, use caution when making turns.
• Remove the vehicle windshield and secure the seat bottom before transporting on a trailer.
• Stay clear from the area between the tow vehicle and the towed vehicle or trailer.
• Gasoline vehicles only: Turn the fuel shut-off valve to the closed (OFF) position (Figure 23).
If the vehicle must be transported over long distances or on public highways, it should be transported on an approved
trailer that has the approved load rating of 1200 lb (544 kg) per vehicle being transported.
NOTE: A two-car trailer should be rated at 2 x 1200 = 2400 lb (2 x 544 = 1088 kg).
STORAGE – ELECTRIC VEHICLE
See General Warnings on page 12.
WARNING
• Turn the key switch to the OFF position, remove the key, and leave the Forward/Reverse switch in
the NEUTRAL position during storage. Place Tow/Run switch in the TOW position. This is to prevent
unintentionally starting the vehicle or a fire hazard.
• Do not attempt to charge frozen batteries or batteries with bulged cases. Discard the battery. Frozen
batteries can explode.
CAUTION
• Batteries in a low state of charge will freeze at low temperatures.
• To avoid exposing electrical components to moisture and subsequent damages, do not use any type
of pressure washing or steam cleaning equipment to wash the vehicle.
PREPARING THE ELECTRIC VEHICLE FOR EXTENDED STORAGE
Check Battery Water Levels Two Weeks Prior to Storage
Check water levels at least two weeks prior to winter storage to ensure proper mixing of water and electrolyte. Note
that it takes approximately five charge cycles with a minimum of 10 amp hours removed to properly mix the water with
electrolyte. Do NOT water batteries immediately prior to storage because this will not provide sufficient charge time to
mix the water with the electrolyte. Freezing can occur when batteries are stored in this condition.
1.
Check the water levels in each battery cell. If water is required, fill the cells to cover the plates, charge the
batteries, and then use distilled water to fill each cell to the correct level. Electrolyte level should be from 1/2 inch
(13 mm) above plates to 1/4 inch (6 mm) below the level indicator (Figure 27).
Immediately Prior to Storage, Perform the Following Steps
1.
Turn the key switch to the OFF position, remove the key, and leave the Forward/Reverse switch in the NEUTRAL
position during storage.
2012 through 2014 Precedent Golf Car Owner’s Manual
Page 33
Storage – Electric Vehicle
2.
If so installed, turn off all accessories, including GPS units, fans, etc.
3.
Place the tow/run switch in the TOW position. Because the battery warning light does not illuminate with the key
in the OFF position and the tow switch in TOW, do not use the warning light as an indication of the batteries’
state of charge.
NOTE: If Visage or Guardian units are installed on vehicles and remote monitoring will be used during the storage
period, make sure the Tow/Run Switch remains in the RUN position rather than in the TOW position required
for all other vehicles.
4.
Batteries should be clean and free of corrosion. Wash tops and terminals of batteries with a solution of baking
soda and water (1 cup (237 mL) baking soda per 1 gallon (3.8 L) of water). Rinse solution off batteries. Do not
allow this solution to enter the batteries. Let the terminals dry and then coat them with Battery Terminal Protector
Spray (CC P/N 1014305).
5.
Tighten all battery cable connections to 110 in-lb (12 N·m).
6.
Store vehicle in a cool, dry place. This will minimize battery self-discharge.
7.
Adjust tires to recommended tire pressure. See Vehicle Specifications on page 63.
8.
Perform all semiannual periodic lubrication. See Periodic Lubrication Schedules on page 43.
9.
Thoroughly clean front body, rear body, seats, battery compartment, and underside of vehicle.
10. Do not engage the park brake. Chock the wheels to prevent the vehicle from rolling.
NOTE: It is recommended that the vehicles be plugged in and the level maintained throughout the storage period.
If any of the following conditions exist, however, then disconnect the batteries for storage: 1) The charger
cannot remain plugged in, 2) AC power will not be available during extended storage, or 3) Electrolyte levels
will not be maintained. To disconnect batteries for storage, go to step 12.
11. To keep batteries fully charged during storage:
11.1. Plug the battery charger into the car. Leave battery chargers plugged in during storage. The onboard
computer (OBC) will automatically activate the charger when necessary.
11.2. Check the electrolyte level and charger function monthly to ensure that proper operation is maintained.
To check charger function, disconnect the DC cord (stationary charger) from the vehicle or the AC cord
(onboard charger) from the power source, wait five seconds, then reconnect it. The charger is functioning
properly if the ammeter indicates current.
NOTE: The OBC keeps track of the time spent in storage mode. When the OBC detects that the storage charge
cycles may have depleted the available electrolyte, it will stop the charger from further operation.
Disconnecting then reconnecting the DC cord (stationary charger) or AC cord (onboard charger) indicates the
electrolyte levels have been maintained and allows the OBC to resume operation.
11.3. If AC power is off for 7 days or longer, the OBC will not function or charge the vehicle again until it has
been restarted. To restart the computer, make sure AC power has been restored, disconnect the DC
cord (stationary charger) from the vehicle or the AC cord (onboard charger) from the power source, wait
five seconds, then reconnect it.
CAUTION
• Be sure to check the batteries and charger monthly to maintain correct battery water level and to
ensure the charger is operating correctly during storage.
12. To disconnect the batteries for storage:
12.1.Disconnect B- battery cable that comes from the OBC and secure it in a way that ensures the cable will not
come into contact with battery terminal.
Page 34
2012 through 2014 Precedent Golf Car Owner’s Manual
Storage – Gasoline Vehicle
RETURNING THE STORED ELECTRIC VEHICLE TO SERVICE
1.
If necessary, connect batteries. See Connecting the Batteries – Electric Vehicles on page 15.
2.
Fully charge batteries.
WARNING
3.
• Do not attempt to charge frozen batteries or batteries with bulged cases. Discard the battery. Frozen
batteries can explode.
Adjust tires to recommended tire pressure. See Vehicle Specifications on page 63.
4.
Perform the Pre-Operation and Daily Safety Checklist on page 28.
STORAGE – GASOLINE VEHICLE
See General Warnings on page 12.
DANGER
• Do not attempt to drain fuel when the engine is hot or while it is running.
• Be sure to clean up any spilled gasoline before operating the vehicle.
• Store fuel in an approved fuel container only. Store in a well-ventilated area away from sparks, open
flames, heaters, or heat sources.
• Keep fuel out of the reach of children.
• Do not siphon fuel from the vehicle.
WARNING
• Turn the key switch to the OFF position, remove the key, and leave the Forward/Reverse handle in
the NEUTRAL position during storage. This is to prevent unintentionally starting the vehicle or a
fire hazard.
• Turn the fuel shut-off valve to closed (OFF) position (Figure 23).
CAUTION
• Batteries in a low state of charge will freeze at low temperatures.
PREPARING THE GASOLINE VEHICLE FOR EXTENDED STORAGE
1.
Store vehicle in a cool, dry place. This will minimize battery self-discharge. If the battery appears to be weak,
have it charged by a trained technician. Use an automotive-type 12-volt battery charger rated at 10 amps or less.
2.
Drain carburetor and seal the fuel tank.
2.1. Place the Forward/Reverse handle in the NEUTRAL position and the neutral lockout cam in the
MAINTENANCE position. Turn the fuel shut-off valve to the closed (OFF) position (Figure 23) and run
the engine until fuel remaining in the carburetor and fuel lines is depleted and the engine stalls. Return
the neutral lockout cam to the OPERATE position.
2.2. Loosen, but do not remove, the carburetor drain screw and drain fuel remaining in bowl into a small, clean
container, then pour the fuel from the container into vehicle fuel tank. Tighten the carburetor drain screw.
2012 through 2014 Precedent Golf Car Owner’s Manual
Page 35
Storage – Gasoline Vehicle
2.3. Disconnect fuel vent line from fuel tank vent nipple.
2.4. Plug the fuel tank vent nipple so that it is air tight. We recommend using a slip-on vinyl cap.
3.
Disconnect battery and spark plug wire(s). See Disconnecting the Battery – Gasoline Vehicles on page 14.
4.
Battery should be clean and free of corrosion. Wash top and terminals of battery with a solution of baking soda
and water (1 cup (237 mL) baking soda per 1 gallon (3.8 L) of water). Rinse solution off battery. Do not allow
this solution to enter the battery. Let the terminals dry and then coat them with Battery Terminal Protector
Spray (CC P/N 1014305).
To protect the engine, remove spark plug and pour 0.5 ounce (14.2 mL) of SAE 10 weight oil into the engine
through the spark plug hole. Rotate engine crankshaft by hand several times and then install the spark plug.
5.
6.
Adjust tires to recommended tire pressure. See Vehicle Specifications on page 63.
7.
Perform semiannual periodic lubrication. See Periodic Lubrication Schedules on page 43.
8.
9.
Thoroughly clean front body, rear body, seats, engine compartment, and underside of vehicle.
Do not engage the park brake. Chock the wheels to prevent the vehicle from rolling.
1
3
1
2
1. Fuel Shut-off Valve 2. Closed (OFF) 3. Open (ON) NOTE: When
selecting valve position, ensure that it is fully opened or fully closed.
1. Fuel Shut-off Valve
614
63A
Figure 23 Fuel Shut-off Valve
Page 36
2012 through 2014 Precedent Golf Car Owner’s Manual
Figure 24 Fuel Tank
Storage – Gasoline Vehicle
RETURNING THE STORED GASOLINE VEHICLE TO SERVICE
1.
Restore the fuel systems to operation (Figure 24).
1.1. Remove the plug from the fuel tank vent.
1.2. Connect the vent tube to the fuel tank vent.
2.
Connect battery and spark plug wire(s). See Connecting the Battery – Gasoline Vehicles on page 14.
3.
Completely open the fuel shut-off valve (1) (Figure 23). Make sure the valve is fully open. A partially closed fuel
shut-off valve combined with the use of the choke can result in a fouled spark plug and engine failure.
4.
Place the Forward/Reverse handle in the NEUTRAL position and the neutral lockout cam in the MAINTENANCE
position. Crank the engine until fuel is pumped into the carburetor and fuel lines and the engine starts. Turn the
engine off and return the neutral lockout cam to the OPERATE position. See following NOTE.
NOTE: Due to the oil added to the engine in preparation for storage, engine may smoke excessively for a short
time when it is run for the first time after storage.
5.
6.
Adjust tires to recommended tire pressure. See Vehicle Specifications on page 63.
Perform the Pre-Operation and Daily Safety Checklist on page 28.
2012 through 2014 Precedent Golf Car Owner’s Manual
Page 37
Maintenance
MAINTENANCE
See General Warnings on page 12.
To ensure trouble-free vehicle performance, it is very important to follow an established preventive maintenance
program. Regular and consistent vehicle maintenance can prevent vehicle downtime and expensive repairs that can
result from neglect. Use the Pre-Operation and Daily Safety Checklist beginning on page 28, the Performance
Inspection, and the following Periodic Service Schedules and Periodic Lubrication Schedules to keep the vehicle in
proper working condition.
Any vehicle not functioning correctly should be removed from use until it is properly repaired. This will prevent further
damage to the vehicle and avoid the possibility of injury due to unsafe conditions.
Contact your local Club Car distributor/dealer to perform all repairs and semiannual and annual periodic service.
WARNING
• If any problems are found during scheduled inspection or service, do not operate the vehicle until
repairs are made. Failure to make necessary repairs could result in fire, property damage, severe
personal injury, or death.
• Only trained technicians should service or repair the vehicle or battery charger. Anyone doing even
simple repairs or service should have knowledge and experience in electrical and mechanical repair.
The appropriate instructions must be used when performing maintenance, service, or accessory
installation.
Electric vehicles:
• Hot! Do not attempt to service hot motor. Attempting to do so could cause severe burns.
• To avoid unintentionally starting the vehicle, disconnect the batteries and discharge the controller.
See Disconnecting the Batteries – Electric Vehicles on page 15.
Gasoline vehicles:
• Moving parts: Do not attempt to service gasoline vehicle while the engine is running.
• Hot! Do not attempt to service hot engine or exhaust system. Failure to heed this warning could
result in severe burns.
• Turn the fuel shut-off valve to the closed (OFF) position (Figure 23).
• To avoid unintentionally starting the vehicle, disconnect battery and spark plug wire(s). See
Disconnecting the Battery – Gasoline Vehicles on page 14.
• Frame ground – Do not allow tools or other metal objects to contact frame when disconnecting
batteries or other electrical wiring. Never allow a positive wire to touch the vehicle frame, engine,
or other metal component.
Page 38
2012 through 2014 Precedent Golf Car Owner’s Manual
Periodic Service Schedules
PERIODIC SERVICE SCHEDULES
WARNING
• Service, repairs, and adjustments must be made per instructions in the maintenance and service
manual.
NOTE: If the vehicle is constantly subjected to heavy use or severe operating conditions, the preventive maintenance
procedure should be performed more often than recommended in the periodic service and lubrication
schedules.
Both the Periodic Service Schedule and Periodic Lubrication Schedule must be followed to keep vehicle in
optimum operating condition.
PERIODIC SERVICE SCHEDULE – ELECTRIC VEHICLES
REGULAR INTERVAL
SERVICE
Daily service by owner
Pre-Operation and Daily Safety Checklist
See Pre-Operation and Daily Safety
Checklist on page 28.
Weekly service by owner
Performance Inspection
See Performance Inspection on page 28.
Batteries
Charge batteries (after each daily use only).
Batteries (For vehicles NOT equipped with the
Check electrolyte level. Add water if
necessary. See Battery Care – Vehicles
Single-Point Watering System)
Without the Single-Point Watering System
on page 48.
Monthly service by owner or trained
Batteries (For vehicles equipped with the
Water the batteries. Observe that water flow
technician
Single-Point Watering System). Water monthly
occurs and no water overflows from any cell.
or according to the established watering
See Battery Care – Vehicles Equipped with
interval.
the Single-Point Watering System on page
47.
Wash battery tops and clean terminals with
Batteries
baking soda/water solution. Apply Battery
Terminal Protector Spray (CC P/N 1014305) to
battery terminals.
Check air pressure and adjust if necessary.
See Vehicle Specifications on page 63.
Tires
General vehicles
Thoroughly wash vehicle including the
underside.
For vehicles newly equipped with the SPWS,
Initial (one-time) inspection by owner or
trained technician after six weeks of use
Batteries (For vehicles newly equipped with
the Single Point Watering System)
manually check battery electrolyte levels of
all cells to verify correct valve operation. See
page 45.
2012 through 2014 Precedent Golf Car Owner’s Manual
Page 39
Periodic Service Schedules
PERIODIC SERVICE SCHEDULE – ELECTRIC VEHICLES
REGULAR INTERVAL
SERVICE
Semiannual service by trained technician
Check brake shoes; replace if necessary.
only (every 50 hours of operation or 100
Lubricate brake system per Lubrication
rounds of golf)
Schedule.
Brake system
Check brake cables for damage; replace if
necessary.
Check brake cable equalizer adjustment;
adjust if necessary.
Electrical wiring and connections
Check for tightness and damage; replace if
necessary.
Check and adjust as required. See Section
Front wheel alignment and camber
7 – Steering and Front Suspension in
the appropriate maintenance and service
manual.
Batteries (For vehicles equipped with the
Annual service by owner or trained
Single Point Watering System)
technician (every 100 hours of operation or
200 rounds of golf)
Safety decals
Annual service by trained technician only
(every 100 hours of operation or 200 rounds
Manually check battery electrolyte levels of
all cells to verify correct valve operation. See
page 45.
Check safety decals. Replace if damaged or
illegible.
If batteries are not performing as expected,
Batteries
of golf)
see Batteries in the maintenance and service
manual.
Pedal group
Lubricate all rotating joints. See Periodic
Lubrication Schedules on page 43.
Check for loose hardware; tighten if necessary.
General vehicle
Refer to the appropriate maintenance and
service manual.
Page 40
2012 through 2014 Precedent Golf Car Owner’s Manual
Periodic Service Schedules
PERIODIC SERVICE SCHEDULE – GASOLINE VEHICLES
REGULAR INTERVAL
SERVICE
Pre-Operation and Daily Safety Checklist
Daily service by owner
Performance Inspection
See Pre-Operation and Daily Safety
Checklist on page 28.
See Performance Inspection on page 28.
Check engine oil level; change if necessary.
Properly dispose of used oil. See Periodic
Lubrication Schedules on page 43.
Engine
Check engine cooling air intake; clean if
necessary. Visually inspect the unshrouded
Monthly service by owner or trained
area around engine exhaust for grass and
technician
debris, and clean if necessary.
Check air pressure and adjust as necessary.
Tires
See Vehicle Specifications on page 63.
General vehicle
Wash engine compartment and underside of
vehicle. Do not wash engine when hot.
Clean terminals and wash dirt from casing;
Apply Battery Terminal Protector Spray (CC
Battery
P/N 1014305) to battery terminals; check
electrolyte level. See Battery – Gasoline
Vehicles on page 55.
Check and adjust if necessary. See Section
Front wheel alignment and camber
the appropriate maintenance and service
manual.
Semiannual service by trained technician
only (every 50 hours of operation or every
100 rounds of golf)
7 – Steering and Front Suspension in
Electrical wiring and connections
Check for tightness and damage; replace if
necessary.
Check brake shoes; replace if necessary.
Lubricate brake system per Lubrication
Schedule.
Brake system
Check brake cables for damage; replace if
necessary.
Check brake cable equalizer adjustment;
adjust if necessary.
Check for leaks around gaskets, fill plugs, etc.
Engine
Inspect, clean and regap spark plug; replace
if necessary.
Check air filter element; replace if necessary.
Annual service by trained technician only
(every 100 hours of operation or every 200
Engine air intake system
Check clamps for tightness; check hose for
cracks.
rounds of golf)
Pedal group
General vehicle
Lubricate all rotating joints. See Periodic
Lubrication Schedules on page 43.
Check for loose hardware; tighten if necessary.
Refer to the appropriate maintenance and
service manual.
2012 through 2014 Precedent Golf Car Owner’s Manual
Page 41
Periodic Service Schedules
PERIODIC SERVICE SCHEDULE – GASOLINE VEHICLES
REGULAR INTERVAL
SERVICE
Safety decals
Check safety decals. Replace if damaged or
illegible.
Two year service by trained technician only
(every 200 hours of operation or every 400
Fuel filters
Replace. Dispose of used filters properly.
rounds of golf)
WARNING
• If any problems are found during scheduled inspection or service, do not operate the vehicle until
repairs are made. Failure to make necessary repairs could result in fire, property damage, severe
personal injury, or death.
Page 42
2012 through 2014 Precedent Golf Car Owner’s Manual
Periodic Lubrication Schedules
PERIODIC LUBRICATION SCHEDULES
PERIODIC LUBRICATION SCHEDULE – ELECTRIC VEHICLES
REGULAR INTERVAL
Semiannually by owner or
LUBRICATION
SERVICE
1
Charger receptacle
trained technician (every 50
Brake system, per maintenance and
hours of operation or 100
service manual.
rounds of golf)
Annually by trained technician
2
WD-40®
Dry Moly Lube (CC P/N 1012151), white
lithium grease NLGI #2
Chassis Lube - EP NLGI Grade 2
Front suspension (two fittings)
22 oz (0.67 L) SAE 30 WT. API Class SE, SF,
Check/fill transaxle to plug level
or SG Oil (or higher)
only (every 100 hours of
operation or 200 rounds of
golf)
RECOMMENDED LUBRICANT
POINTS
Dupont™ Performance Dry Multi-Use
Pedal group (as required)
Lubricant
64
Figure 25
Lubrication Points – Electric Vehicles
2012 through 2014 Precedent Golf Car Owner’s Manual
Page 43
Periodic Lubrication Schedules
PERIODIC LUBRICATION SCHEDULE – GASOLINE VEHICLES
REGULAR INTERVAL
Semiannually by owner or
LUBRICATION
SERVICE
1
Shifter cable pivots
trained technician (every 50
Brake system, per maintenance and
hours of operation or every
service manual.
100 rounds of golf)
RECOMMENDED LUBRICANT
POINTS
2
Front suspension (two fittings)
Dry Moly Lube (CC P/N 1012151)
Dry Moly Lube (CC P/N 1012151), white
lithium grease NLGI #2
Chassis Lube - EP NLGI Grade 2
Annually by trained technician
Check/fill unitized transaxle to plug
27 oz (0.8 L) 80-90 WT. API Class GL-3 or
only (every 100 hours of
level
80-90 WT. AGMA Class EP Gear Lube
operation or every 200 rounds
Dupont™ Performance Dry Multi-Use
Pedal group (as required)
of golf)
Lubricant
First change 100 hours –
additional change every
200 hours of operation (or
Change engine oil and oil filter
32 oz (0.95 L) without filter; 38 oz (1.12 L)
every 400 rounds of golf), or
(dispose of properly)
with filter
annually, whichever comes
first
65
Figure 26
Page 44
Lubrication Points – Gasoline Vehicles
2012 through 2014 Precedent Golf Car Owner’s Manual
Batteries – Electric Vehicles
BATTERIES – ELECTRIC VEHICLES
See General Warnings on page 12.
DANGER
• Battery – Explosive gases! Do not smoke. Keep sparks and flames away from the vehicle and service
area. Ventilate when charging or operating vehicle in an enclosed area. Wear a full face shield and
rubber gloves when working on or near batteries.
• Charge batteries in a well-ventilated area only. Batteries emit hydrogen while being charged. Hydrogen
is an explosive gas and must never exceed a level of 2% of the air.
• Battery – Poison! Contains acid! Causes severe burns. Avoid contact with skin, eyes, or clothing.
Antidotes:
– External: Flush with water. Call a physician immediately.
– Internal: Drink large quantities of milk or water followed with milk of magnesia or vegetable
oil. Call a physician immediately.
– Eyes: Flush with water for 15 minutes. Call a physician immediately.
WARNING
•
Wear safety glasses or approved eye protection when servicing the vehicle or battery charger. Wear a
full face shield and rubber gloves when working on or near batteries.
•
Use insulated tools when working near batteries or electrical connections. Use extreme caution to
avoid shorting of components or wiring.
CAUTION
• On all vehicles, turn off all accessories before charging batteries.
NOTE: Recycle or dispose of discarded batteries in accordance with local, state, and federal regulations.
Club Car electric vehicles use deep-cycle batteries. Automotive batteries should never be used in electric vehicles.
New batteries will not deliver their full capabilities until they have been discharged and recharged 20 to 50 times. To
obtain the maximum service life from new batteries, restrict electric vehicles with new batteries to 36 holes of use
between charges in the first two months of operation. Batteries should be fully charged before first use of new vehicle,
before first use of a vehicle after storage, and before releasing vehicle for use each day.
WATER QUALITY
Water purity is the most important factor in the performance and lifespan of the vehicle batteries. Club Car has,
therefore, placed an increased importance on battery maintenance beginning with Model Year 2014 Precedent vehicles.
Outlined below are four battery watering procedures, grouped into two categories: Preferred and Alternate methods.
Club Car recommends the use of a deionizer or distilled water. Alternate methods of reverse osmosis or tap water
are allowable but should be avoided since water quality can change from day to day depending on additives, water
main leaks, etc.
Preferred Methods
• Distilled Water: Distilled water is the most common type of water used in batteries. Distilled water is created by
boiling water, collecting the steam from the boiling, and allowing the steam to condense back into water. The
distilling process results in a water source which is free of minerals that can lead to the degradation of battery
performance and life.
2012 through 2014 Precedent Golf Car Owner’s Manual
Page 45
Batteries – Electric Vehicles
• Deionized Water: Deionized water is created by inducing electrically charged resins that attract and bind to sodium,
calcium, iron, copper, chloride, and bromide ions. The result of this electrical filtering is a purified water, which
contains little to no mineral ions. To make sure the deionized water remains at a high quality, replace the filter in the
deionizer per the manufacturer’s recommendations.
The Service Parts Department at Club Car offers two different deionizer systems: one for vehicles equipped
with the Single Point Watering System (SPWS), CC P/N AM1240701 and the other for vehicles without SPWS,
CC P/N AM10974.
Alternate Methods
• Reverse Osmosis:Reverse osmosis involves forcing water through a membrane that allows the water to pass
while trapping the solids. The choice of membrane used determines the amount of solids or impurities which get
trapped and hence the purity quality of the filtered water. In addition, the usage frequency of the membrane can
also contribute to the filtered water quality. Due to the variance in water quality consistency, Club Car recommends
the use of the deionizer or distilled water.
• Tap Water: While the use of tap water without filtering is an alternate method of battery watering, its use should be
limited due to the levels of dissolved minerals and chemicals that can degrade battery performance and life. If
unfiltered tap water is used, regular water analyses must be conducted to check for impurities. The following chart
lists the maximum allowable minerals, solids, and contaminates in parts per million and their impact on battery
performance. Water testing, however, is expensive, and water quality can change from day to day depending on
additives, water main leaks, etc. Due to the cost and labor of performing water quality tests, Club Car recommends
the use of distilled water or a deionizer.
Page 46
IMPURITY
ALLOWABLE CONTENT (PARTS
PER MILLION)
EFFECTS OF IMPURITY
Suspended matter
Trace
-
Total solids
100.0
-
Organic and volatile matter
50.0
Corrosion of positive plates
Ammonia
8.0
Slight self-discharge of both plates
Antimony
5.0
Arsenic
0.5
Self-discharge, can form poisonous gas
Calcium
40.0
Increase of positive plate shedding
Chloride
5.0
Copper
5.0
Iron
3.0
Magnesium
40.0
Reduced life
Nickel
None allowed
Intense lowering of on-charge voltage
Nitrates
10.0
Increased sulfation of negative plate
Nitrites
5.0
Plate corrosion, loss of capacity,
reduced life
Platinum
None allowed
Violent self-discharge, lower
on-charge voltage
Selenium
2.0
Positive plate shedding
Zinc
4.0
Slight self-discharge of negative plates
2012 through 2014 Precedent Golf Car Owner’s Manual
Self-discharge, reduces life, lower
on-charge voltage
Loss of capacity in plates, greater
loss in positive plates
Increased self-discharge, lower
on-charge voltage
Increased self-discharge, lower
on-charge voltage
Batteries – Electric Vehicles
BATTERY CARE – VEHICLES EQUIPPED WITH THE SINGLE-POINT WATERING SYSTEM
To keep batteries in good working condition, follow this maintenance program on a regular basis:
1.
Keep the batteries clean and free of corrosion. Wash tops and terminals of batteries with a solution of baking
soda and water (1 cup (237 mL) baking soda per 1 gallon (3.8 L) of water). Rinse solution off of the batteries. Do
not allow this solution to enter the battery. Be sure terminals are tight. Let the terminals dry and then coat with
Battery Terminal Protector Spray (CC P/N 1014305). See following NOTE.
NOTE: Dispose of waste water properly.
2.
The battery hold-downs should be tight enough so that the batteries do not move while the vehicle is in motion,
but not so tight as to crack or buckle the battery case. For 8-volt batteries, tighten hold-down retaining nuts to
106 in-lb (12 N·m). The terminal connections should be clean and tight, and any worn insulation or frayed wires
should be replaced. Tighten battery terminals to proper torque. See Connecting the Batteries – Electric
Vehicles on page 15. See following WARNING.
WARNING
• If battery wire terminals are damaged or corroded, replace or clean them as necessary. Failure to
do so may cause them to overheat during operation and could result in fire, property damage, or
personal injury.
3.
After use, charge the batteries. The batteries should never be left discharged any longer than absolutely
necessary (do not leave discharged overnight).
4.
Water the batteries monthly or according to the watering interval. See Establishing the Watering Interval for
New Vehicles on page 47. See Watering Batteries with the SPWS on page 53.
CAUTION
• The watering interval must adequately maintain the electrolyte level above the top of the plates. See
Figure 27.
• Water the batteries only AFTER charging.
Establishing the Watering Interval for New Vehicles
If you do not already have a battery watering interval for your vehicles, manually check the battery water level weekly
to establish the correct watering interval. Thereafter, water batteries according to the established interval. During
periods of heavy use, add additional watering as required.
Single-Point Watering System Maintenance
1.
For vehicles newly equipped with the Single-Point Watering System, the initial electrolyte level check on all
battery cells verifies that all the valves in the SPWS are functioning correctly. See Periodic Service Schedules
on page 39. If a valve fails to open, the cell will eventually dry out. The initial one-time inspection of all cells
will identify any occurrence of a valve that fails to open. If a valve fails to close, it will become evident due to
the cell overflowing during routine watering. Either failure scenario is rare, but should be monitored in the initial
inspection and during routine watering sessions. Replace malfunctioning valves to ensure maximum battery
life. See following CAUTION.
CAUTION
• After checking the electrolyte, fully tighten the battery caps to prevent electrolyte leakage.
2.
After the initial six-week inspection, manually check the electrolyte level at least once per year, particularly after
long-term storage or any other period of vehicle inactivity. See preceding CAUTION.
2012 through 2014 Precedent Golf Car Owner’s Manual
Page 47
Batteries – Electric Vehicles
BATTERY CARE – VEHICLES WITHOUT THE SINGLE-POINT WATERING SYSTEM
To keep batteries in good working condition, follow this maintenance program on a regular basis:
1.
Keep the batteries clean and free of corrosion. Wash tops and terminals of batteries with a solution of baking
soda and water (1 cup (237 mL) baking soda per 1 gallon (3.8 L) of water). Rinse solution off of the batteries. Do
not allow this solution to enter the battery. Be sure terminals are tight. Let the terminals dry and then coat with
Battery Terminal Protector Spray (CC P/N 1014305). See following NOTE.
NOTE: Dispose of waste water properly.
2.
Check the electrolyte level weekly (Figure 27). Add water only after charging unless the electrolyte level is below
the top of the plates. In this case, add just enough water to cover the plates, charge, and then check the level
again. Never charge batteries if plates are exposed above electrolyte level. For best battery life, add only
distilled water. See following CAUTION and NOTE.
CAUTION
• Do not overfill the batteries.
NOTE: A battery watering gun or bottle is available from your authorized Club Car dealer.
3.
The battery hold-downs should be tight enough so that the batteries do not move while the vehicle is in motion,
but not so tight as to crack or buckle the battery case. For 8-volt batteries, tighten hold-down retaining nuts to
106 in-lb (12 N·m). The terminal connections should be clean and tight, and any worn insulation or frayed wires
should be replaced. Tighten battery terminals to proper torque. See Connecting the Batteries – Electric
Vehicles on page 15. See following WARNING.
WARNING
• If battery wire terminals are damaged or corroded, replace or clean them as necessary. Failure to
do so may cause them to overheat during operation and could result in fire, property damage, or
personal injury.
4.
After use, charge the batteries. The batteries should never be left discharged any longer than absolutely
necessary (do not leave discharged overnight).
Page 48
2012 through 2014 Precedent Golf Car Owner’s Manual
Battery Charger – Electric Vehicles
1
2
3
1. Level Indicator 2. Cap 3. Plates
Maintain electrolyte level from at least 1/2 inch (13 mm) above
plates to 1/4 inch (6 mm) below level indicator.
17
Figure 27 Battery Electrolyte Level
BATTERY CHARGER – ELECTRIC VEHICLES
DANGER
• The charging area must be ventilated. Hydrogen level in the air must never exceed 2%. The total
volume of air in the charging area must be changed at least five times per hour. Exhaust fans should
be located at the highest point of the roof. Contact a local HVAC engineer.
• Do not charge the vehicle batteries with the vehicle covered or enclosed. Any enclosure or cover
should be removed or unzipped and pulled back when batteries are being charged. An accumulation
of hydrogen gas could result in an explosion.
WARNING
• Only trained technicians should repair or service the charger. Contact your nearest Club Car
distributor/dealer.
• Each charger should have its own dedicated 15 or 20 ampere separately protected (circuit breaker or
fuse) single phase branch circuit, in accordance with all applicable electrical codes for the location.
• Connect the charger AC supply cord to a properly grounded, three-wire outlet of the proper voltage
and frequency as shown on the charger.
• Do not use an adapter to plug the charger with a three-prong plug into a two-prong outlet. Improper
connection of the equipment-grounding conductor can result in a fire or an electrical shock.
WARNING CONTINUED ON NEXT PAGE
2012 through 2014 Precedent Golf Car Owner’s Manual
Page 49
Battery Charger – Electric Vehicles
WARNING
• An extension cord or electrical outlet must accept a three-prong plug. Extension cord should be a
three-wire No. 12 AWG (American Wire Gauge) or no. 14 (British Standard Wire Gauge), and be as
short as possible (no more than 12 feet (3.7 m)). The use of improper extension cord could result
in fire or an electrical shock.
• Do not operate the charger if it has received a sharp blow, was dropped, or otherwise damaged
in any way.
• Have worn, cut, or damaged power cords or wires replaced immediately.
• Do not use near fuels, grain dust, solvents, thinners, or other flammables. Chargers can ignite
flammable materials and vapors.
• Do not expose to rain or any liquid. Keep the charger dry.
• Never push objects of any kind into the charger through cabinet slots. They may touch dangerous
voltage points or cause an electrical short circuit that could result in fire or electrical shock.
• Do not connect a stationary charger to the receptacle if the charger cord, plug, or the vehicle
receptacle is broken, damaged, or does not make a good electrical connection. Fire or personal injury
can result. Have a qualified technician replace the parts.
• When the charger is on, the charger DC cord may be disconnected from the vehicle receptacle slowly.
Jerking or pulling the DC cord out quickly could cause arcing and burning that could damage the plug
and receptacle and could cause batteries to explode.
• Do not block or cover the charger ventilation slots. The slots provide ventilation and protect the
charger from overheating.
• Do not allow clothing, blankets, or other material to cover the charger.
• Do not allow the charger to operate for more than 30 minutes at 19 or more amperes.
• Install surge arrestors on incoming AC power lines. Surge arrestors will help protect electrical
components in the charger and on the vehicle from all but direct or close lightning strikes.
NOTE: Because the vehicle’s onboard computer (OBC) has a storage charge feature that automatically checks
and recharges the batteries as necessary every 15 days, the charger can remain plugged to the vehicle
throughout the storage period.
At one hour and at two hours into the charge cycle, the charger will shut off in order to run a self-diagnostic
program (ammeter will drop to zero). Charging will resume in a few moments (ammeter returns to previous
rate of charge).
Each electric vehicle is supplied with a fully automatic battery charger as standard equipment. The AC cord to each
charger is to be connected to a source capable of supplying 15 amperes minimum per charger.
To reduce the risk of electric shock, the battery charger must be grounded. The charger is equipped with an AC electric
cord having an equipment-grounding conductor and a grounding type plug. The AC plug must be connected to an
appropriate receptacle that is properly installed and grounded in accordance with the National Electrical Code and all
local codes and ordinances. See the owner’s manual supplied with the charger for specific operating instructions
before using the charger.
The use of an extension cord with the charger should be avoided. If an extension cord must be used, use a
three-conductor no. 12 AWG (American Wire Gauge) or no. 14 SWG (British Standard Wire Gauge), heavy-duty cord
with ground, properly wired and in good electrical condition. Keep it as short as possible (no more than 12 feet (3.7
m)). Place all cords so they will not be stepped on, tripped over, or otherwise subject to damage or stress.
Ensure that the charger ventilation slots are unobstructed and that there is adequate ventilation.
Page 50
2012 through 2014 Precedent Golf Car Owner’s Manual
Battery Charger – Electric Vehicles
CHARGING BATTERIES
WARNING
• Be sure all wire connections at the receptacle and the fuse link are clean and tight.
• Do not rock or bend the plug. To connect the charger plug to the vehicle receptacle, grasp the plug
handle and push the plug straight into the receptacle (Figure 28, Page 52).
• Do not pull on the DC cord (Figure 29, Page 52). Do not twist, rock or bend the plug. To disconnect
the charger plug from the vehicle receptacle, grasp the plug by the handle and pull the plug straight
out of the receptacle.
• Do not connect a charger to the receptacle if the charger cord, plug, or the vehicle receptacle is
broken, damaged in any manner, or does not make a good electrical connection. Fire or personal
injury can result. Have it replaced by a qualified service person immediately.
• Failure to follow these instructions could result in damage to the charger cord, the plug, and (or)
the vehicle receptacle.
• Do not use a charger if:
– The plug is too loose or does not make a good connection.
– The plug and receptacle feel hotter than normal during charge.
– The plug pins or receptacle contacts are bent or corroded.
– The plug, receptacle, or cords are cut, worn, have any exposed wires or are damaged in any way.
• Using the charger with any of the above symptoms could result in a fire, property damage, personal
injury, or death.
NOTE: When temperatures fall below 65 °F (18.3 °C), batteries charged in unheated areas should be placed on
charge as soon as possible after use. Batteries are warmest immediately after use, and cold batteries
require more time to fully charge.
Insert the charger DC plug into the vehicle receptacle. The charger will turn on two to ten seconds later (Figure
28, Page 52).
When inserting the DC plug, align the raised guide on the plug with the guide slot in the receptacle and push
straight in slowly.
Club Car battery chargers interact with the vehicle onboard computer. The computer records the amount of energy
consumed during vehicle use. While the charger is plugged in, the vehicle’s control circuit is locked out, preventing
operation of the vehicle, as well as the possibility of consequent damage to the charger and the vehicle.
Once the lockout is actuated, the charger turns on. The onboard computer then records the amount of energy being
returned to the batteries. When the optimum amount of energy needed to replenish the batteries is returned, the
charger will shut off. The control circuit lockout remains activated until the charger plug is disconnected from the vehicle.
Only Club Car PowerDrive battery chargers are compatible with Precedent electric vehicles.
As long as the charger is allowed to shut off by itself, the batteries will be fully charged. Overcharging and
undercharging will normally be prevented.
Batteries should be put on charge even if they have been used for only a short period (9 holes of golf or 10 minutes).
The charger is automatic and will turn off when batteries are fully charged. If the charger does not seem to be operating
properly, or if the batteries seem weak, contact your local Club Car distributor/dealer.
2012 through 2014 Precedent Golf Car Owner’s Manual
Page 51
Battery Charger – Electric Vehicles
66
67
Figure 28 Correct Insertion of Charger DC Plug
Figure 29 Incorrect Removal of Charger DC Plug
PLUG AND RECEPTACLE
The charger cord, plug, and receptacle are wear items and should be inspected daily. Visually inspect them for cracks,
loose connections, and frayed wiring; they must be replaced when worn or damaged. If charger plug or receptacle
show signs of corrosion or the plug is difficult to insert or remove, the receptacle contacts and plug terminals should
be cleaned with a good electrical contact cleaner or lightly sprayed with WD-40® brand spray lubricant. The plug
should then be inserted and removed several times to ensure ease of insertion, ease of removal, and good electrical
contact. See following NOTE.
NOTE: If the warning tag has been damaged or removed from the DC cord, have it replaced immediately.
Page 52
2012 through 2014 Precedent Golf Car Owner’s Manual
Single Point Watering System (SPWS)
SINGLE POINT WATERING SYSTEM (SPWS)
WARNING
• When replacing batteries in the Single Point Watering System, place the battery cap from the new
replacement battery onto the used battery being removed from the car. Important safety warnings on
the battery cap must remain with the battery after it has been removed from the car.
CAUTION
• Water the batteries only AFTER charging.
• Use water that meets the quality standards shown on page 45. Maximize battery life by removing ion
and heavy metals from water with the use of a single point watering system deionizer. Deionizer,
Club Car Part Number AM1240701 (110/115 volt AC), is available from Service Parts. Replacement
cartridge: AM1240801. Bottled distilled water, with hand pump, Club Car Part Number AM1238501, is
recommended for private consumer applications.
WATERING BATTERIES WITH THE SPWS
Checking the Water Flow Rate
1.
Connect the water hose with the built-in screen filter (2) to the water faucet (1) (Figure 30). See following
CAUTION.
CAUTION
• Make sure the screen filter is clean.
• Do not use a longer garden hose than provided with the System (20 feet), as a decrease in water
pressure could overfill the batteries and damage the refill system.
2.
Before screwing the hose-end assembly (3) onto the opposite end of the water hose, check the screen filter (4)
inside the end of the assembly to make sure it is clean (Figure 30).
3.
Connect the purger (5) to the female coupler (8) on the end of the hose-end assembly (Figure 31).
8
7
3
1
5
5
3
6
4
2
68
69
Figure 30 Connecting Hose with Filter to Water Source
Figure 31 Checking the Water Flow Rate
2012 through 2014 Precedent Golf Car Owner’s Manual
Page 53
Single Point Watering System (SPWS)
4.
Completely open the water faucet until the water flows out of the hose-end assembly (3), and note the movement
of the red flow indicator balls (6). See following NOTE.
NOTE: The water flow rate must be at least 2 gallons per minute (gpm) (7.5 liters-per-minute (L/min)) for the SPWS to
function properly.
This step also eliminates any trapped air from the water hose.
5.
Check the water quality light on the deionizer to make sure the light is green in color, indicating acceptable water
quality. If the light indicates unacceptable water quality, the cartridge must be replaced.
6.
After ensuring adequate water flow rate and water quality, press the grey button (7) on the end of the female
coupler (8) to disconnect the purger from the pressure regulator.
Refilling the Batteries
1.
Locate the battery fill coupling (9) on the driver side of the battery compartment, remove the dust cover (10)
from the male connector (Figure 32), and connect the hose-end assembly (3) (Figure 33). The water flow
will begin immediately.
9
10
8
9
3
71
70
Figure 32 Dust Cap
2.
Figure 33 Connecting Hose-end Assembly to Battery Fill
Connector
The red flow indicator balls should swirl, indicating that the batteries are being filled. See following CAUTION.
CAUTION
• If at any time water overflows from the batteries, immediately stop the refill process, disconnect the
pressure regulator from the battery fill coupling, and call for service.
3.
When the red flow indicator balls stop moving, immediately press the grey button to disconnect the hose-end
assembly from the battery fill coupling (9), and squeeze the dust cover (10) to lightly secure it to the male
connector of the battery fill coupling (Figure 32).
4.
Place the battery fill coupling into the space between the battery bucket and the car body. Leaving the fill coupling
on top of the battery bank or tucked between the batteries and the battery bucket can result in coupling damage.
Turn the water faucet off when finished filling the vehicle(s).
5.
Page 54
2012 through 2014 Precedent Golf Car Owner’s Manual
Battery – Gasoline Vehicles
BATTERY – GASOLINE VEHICLES
See General Warnings on page 12.
DANGER
• Battery – Explosive gases! Do not smoke. Keep sparks and flames away from the vehicle and service
area. Ventilate when charging or operating vehicle in an enclosed area. Wear a full face shield and
rubber gloves when working on or near batteries.
• Tools, wires, and metal objects can cause sparks when shorted across a battery.
• Follow all instructions carefully when working with batteries.
• Charge battery in a well-ventilated area only.
• Battery – Poison! Contains acid! Causes severe burns. Avoid contact with skin, eyes, or clothing.
Antidotes:
– External: Flush with water. Call a physician immediately.
– Internal: Drink large quantities of milk or water followed with milk of magnesia or vegetable
oil. Call a physician immediately.
– Eyes: Flush with water for 15 minutes. Call a physician immediately.
WARNING
• Do not jump start a dead battery using another battery and jumper cables.
The battery in the Club Car gasoline vehicle is a 12-volt, low maintenance battery that requires infrequent watering
(Figure 34).
Any corrosion around the positive (+) or negative (–) terminals should be washed off with a solution of baking soda
and water (1 cup (237 mL) per 1 gallon (3.8 L) of water). Rinse solution off the battery. Do not allow this solution to
enter battery. Be sure terminals are tight. Let the terminals dry and then spray them with Battery Terminal Protector
Spray (CC P/N 1014305). See Connecting the Battery – Gasoline Vehicles on page 14. See preceding and
following WARNINGS.
WARNING
• If battery wire terminals are damaged or corroded, replace or clean them as necessary. Failure to
do so may cause them to overheat during operation and could result in fire, property damage, or
personal injury.
Be sure battery clamp is properly tightened. Tighten to 144 in-lb (16 N·m). A loose battery clamp may allow the
battery to become damaged from vibration or jarring.
If battery appears weak, have it charged by a trained technician. The battery should never be left discharged any
longer than absolutely necessary (do not leave discharged overnight).
2012 through 2014 Precedent Golf Car Owner’s Manual
Page 55
Engine Oil – Gasoline Vehicles
2
1
3
1. Level Indicator 2. Cap 3. Plates
Electrolyte level at least 1/2 inch (13 mm) above plates or to level
indicator.
72
22
Figure 34 Gasoline Vehicle Battery
Figure 35 Electrolyte Level for Battery
ENGINE OIL – GASOLINE VEHICLES
ENGINE OIL LEVEL CHECK
1.
Remove the oil level dipstick from the oil filler tube, and wipe oil off dipstick (1) (Figure 36). See following
CAUTION.
CAUTION
2.
• Do not remove dipstick while engine is running.
Check oil by fully inserting the dipstick into the oil filler tube (2) and immediately removing it.
3.
If the oil level is at or below the low level mark on the dipstick gauge, add oil until the level is between low
and full levels (safe level) (3).
4.
Insert the dipstick into the oil filler tube. See following NOTE.
NOTE: Properly recycle or dispose of used oil in accordance with the environmental laws and regulations for your area.
Even though the low oil warning light on the dash should warn you if your oil becomes low, engine oil level should be
checked monthly. Vehicle should be on a level surface when checking oil. Do not overfill with oil.
Page 56
2012 through 2014 Precedent Golf Car Owner’s Manual
Engine Oil – Gasoline Vehicles
1
2
3
1. Full level 2. Safe level 3. Low level
23
Figure 36 Engine Oil Level Check
ENGINE OIL AND FILTER CHANGE
Engine oil and oil filter should be changed after the first 100 hours of operation. After that, they should be changed
every 200 hours of operation or annually, whichever comes first.
1.
Turn the key switch to the OFF position, then remove the key. Place the Forward/Reverse handle in the
NEUTRAL position. Chock the front wheels.
2.
Access the engine compartment.
3.
Disconnect battery and spark plug wire(s). See Disconnecting the Battery – Gasoline Vehicles on page 14.
4.
Position a pan designed for oil changes under the front drain plug (Figure 37).
3
1
2
1. Drain pan 2. Drain plug 3. Oil filter
25
Figure 37
Engine Oil Drain Plug and Pan
2012 through 2014 Precedent Golf Car Owner’s Manual
Page 57
Engine Oil – Gasoline Vehicles
5.
Use a 14 mm socket or wrench to remove the drain plug, turning it counterclockwise, and allow the engine
oil to drain into the pan. See following WARNING.
WARNING
• Do not attempt to change engine oil when the engine is hot or even warm. Engine oil can cause
skin burns.
• Wear safety glasses or approved eye protection when servicing the vehicle. Wear rubber gloves when
handling oil drain plug, oil filter, and oil drain pan.
6.
Clean the oil drain plug threads with solvent to remove oil and oil residue. Make sure that the compression
washer remains on the drain plug.
7.
Use a 14 mm socket or wrench and replace the front oil drain plug, turning it clockwise, and tighten to 18 ft-lb
(24.4 N·m).
8.
9.
Relocate the oil drain pan to a position under the engine oil filter (Figure 37).
Remove the engine oil filter, turning it counterclockwise, allowing the residual oil in the filter port and filter to drain
into the oil drain pan (Figure 38). See following NOTE.
NOTE: An oil drip guard can be used to prevent excess oil from dripping into the engine base plate. Use an empty
quart (one liter) container and cut the bottom off at an angle, then slide the open area of the container up and
under the oil filter prior to removing. Position the port of the plastic container so oil will be directed into the oil
pan. Or, make a drip guard by folding a piece of cardboard, thin metal, or plastic under the oil filter forming a
channel to direct the filter port oil into the drain pan.
Dispose of used oil according to the environmental laws and regulations for your area.
26
Figure 38 Remove Engine Oil Filter
10. Use a clean rag and wipe the oil filter mounting bracket surface clean where the oil filter gasket seats.
11. Coat new oil filter gasket with clean engine oil, Install the oil filter onto the engine oil filter port (Figure 39).
NOTE: Use only Club Car oil filters (CC P/N 103887901) designed for this engine.
12. Hand tighten 2/3 to 3/4 turn after filter gasket contacts mounting surface.
13. Remove the dipstick and add engine oil into the dipstick port. With filter change, the engine requires 38 oz (1.12 L)
of oil per change. Refer to oil viscosity guidelines for selection of oil grade (Figure 40). See following Caution.
Page 58
2012 through 2014 Precedent Golf Car Owner’s Manual
Fueling Instructions – Gasoline Vehicles
CAUTION
• Do not exceed recommended oil capacity. Doing so will decrease engine performance or result in
damage to the engine.
14. Replace the dipstick.
15. Connect battery and spark plug wire(s). See Connecting the Battery – Gasoline Vehicles on page 14.
16. With the Forward/Reverse handle in the NEUTRAL position, run engine for 3 minutes and check for leaks.
Observe both the drain plug and the oil filter from under the vehicle and watch for oil leaks. If filter leaks, tighten
additional 1/4 turn and retest, if oil drain plug leaks, re-torque and retest.
17. Remove the dip stick and check the engine oil as a final step. Replace the dip stick.
NOTE: Gasoline Vehicles Only: Below 40 °F (4 °C), the use of SAE- 30 may result in hard starting.
Gasoline Vehicles Only: Above 80 °F (27 °C), the use of 10W-30 may cause increased oil consumption.
Check oil level more frequently.
SAE 40
SAE 30
SAE 10W-30/ SAE 10W-40
SAE 5 W-30
27
213
Figure 39 Coat Oil Filter Rubber Seal
Figure 40 Oil Viscosity Chart
FUELING INSTRUCTIONS – GASOLINE VEHICLES
See General Warnings on page 12.
DANGER
• Turn the key switch to the OFF position before fueling.
• Do not pour fuel into the fuel tank when the engine is hot or while it is running.
• Be sure the fuel tank ground wire, located next to the fuel shut-off valve, is properly connected before
fueling the vehicle.
• To avoid electric arc caused by static electricity, the fuel storage/pumping device must be grounded. If
the pump is not grounded, the vehicle must be grounded to the pump before and during the fueling
operation.
• If the vehicle has an all-weather enclosure installed, be sure the fuel tank is properly vented as shown
(Figure 24, Page 36).
• To avoid the possibility of fire, clean up any spilled fuel before operating the vehicle.
2012 through 2014 Precedent Golf Car Owner’s Manual
Page 59
Cleaning the Vehicle
CAUTION
• Use unleaded gasoline only.
• Whenever possible, avoid using oxygenated and blended fuels.
• Do not use any fuel with an alcohol content that exceeds 10% by volume (such as E15 and E85).
Ethanol is an alcohol that readily absorbs moisture, causing corrosion of fuel system components. It
also damages neoprene and other plastic and rubber components. Use of these fuels in this vehicle
will void the warranty.
• To allow for expansion, do not fill higher than one inch (2.54 cm) from the top of the fuel tank. Avoid
spilling fuel.
NOTE: Vehicles to be stored for extended periods should be prepared for storage as instructed. See Preparing the
Gasoline Vehicle for Extended Storage on page 35.
1.
Turn the key switch to the OFF position.
2.
Lift and remove seat bottom.
3.
The fuel tank is located on driver side of vehicle. Remove fuel cap and fill the fuel tank with fresh unleaded
gasoline only. See preceding DANGER and CAUTION.
4.
Replace fuel cap on tank. Ensure that cap is tightened securely (tighten until it clicks).
5.
Replace seat bottom.
CLEANING THE VEHICLE
Club Car Precedent vehicles are equipped with hand-washable front and rear bodies. Use only commercially
available automotive cleaners with a sponge or soft cloth for normal cleaning. A garden hose at normal residential
water pressure is adequate.
The manufacturer does not recommend any type of pressure washing or steam cleaning. Such a process will
expose electrical components to moisture. Moisture entering electrical components can result in water damage and
subsequent component failure.
Use non-abrasive wax products. Battery acid, fertilizers, tars, asphalt, creosote, paint, or chewing gum should be
removed immediately to prevent possible stains. See following CAUTION.
CAUTION
• Use of leveling or rubbing compounds will permanently dull finish of vehicle.
• Do not apply wax products to the black plastic material of the front and rear underbody, the front
bumper, or the textured area of the rear beauty panel marked “NO STEP.” Wax will cause these
surfaces to become discolored.
The seats of the vehicle will last longer with proper cleaning. Use a solution of 10% liquid soap and warm water applied
with a soft cloth. For imbedded dirt, a soft bristle brush may be used. For heavy soiling, difficult stains or scratches,
blemishes, or other body damage, see the appropriate maintenance and service manual.
NOTE: Dispose of waste water properly.
ACCESSORIES
There is a complete line of accessory equipment available from Club Car and our dealers/distributors. You can obtain
the name and phone number of your closest Club Car contact by visiting our web site at www.clubcar.com and
clicking the “Dealer Locator” link.
Page 60
2012 through 2014 Precedent Golf Car Owner’s Manual
Subsequent Owner Registration
Care should be taken that these accessories are properly installed by trained technicians, and that they are used in the
manner for which they were designed. See following WARNING.
WARNING
• Windshields and weather-proof enclosures will not protect occupants from flying objects (golf balls,
etc.).
SUBSEQUENT OWNER REGISTRATION
In the event a vehicle is bought as a used vehicle, we strongly urge the new owner to register the vehicle with Club Car.
This will enable us to contact you if the need arises. Please send your name, address, and serial number(s) of the
vehicle(s) to Club Car, LLC, P.O. Box 204658, Augusta, Georgia 30917-4658, Attention: Vehicle Registration.
PRECEDENT FOUR-PASSENGER VEHICLE
The Precedent four-passenger vehicle is designed to provide a smooth and comfortable ride for four passengers, and
is offered in both gasoline and electric power configurations. This owner’s manual should be read thoroughly prior
to operating the vehicle.
The Precedent four-passenger vehicle should be driven and maintained as stated in this owner’s manual with the
following additions:
WARNING
• Vehicle should be driven at slower speeds when four persons are in the vehicle.
• Passengers should hold on to hand holds or hand rails at all times. See page 8. Driver should keep
both hands on the steering wheel while vehicle is moving.
• Do not leave children unattended on the rear seat while vehicle is moving.
• No more than four persons should be on the vehicle at one time.
MAINTENANCE
Refer to pages 39 through 43 for Periodic Service and Lubrication Schedules. See following NOTE.
NOTE: If the vehicle is constantly hauling heavy loads, the preventive maintenance procedures should be performed
more often than recommended in the service and lubrication schedules.
ACCESSORY ONBOARD CHARGER
An onboard charger, which is installed under the rear seat, is available for the Precedent four-passenger electric
vehicle. The charger should be plugged into a properly grounded outlet. The AC line to which the charger is to be
connected must be of the proper AC input voltage for the charger and must be capable of supplying sufficient current.
See the battery charger owner’s manual supplied with the battery charger for specific operating instructions and
specifications before using the charger. See following WARNING and CAUTION.
2012 through 2014 Precedent Golf Car Owner’s Manual
Page 61
Precedent Four-Passenger Vehicle
WARNING
• Each charger should have its own dedicated 15 or 20 ampere separately protected (circuit breaker or
fuse) single phase branch circuit, in accordance with all applicable electrical codes for the location.
CAUTION
• Before charging batteries, turn off all accessories on all vehicles.
• If using an onboard charger, be sure the AC plug is unplugged from the outlet before attempting to
drive the vehicle.
• Be sure the AC cord is properly wound up on the reel before driving the vehicle.
• Study all general information and WARNING, CAUTION, and NOTE statements in the Battery Charger
section on page 49.
Page 62
2012 through 2014 Precedent Golf Car Owner’s Manual
Vehicle Specifications
VEHICLE SPECIFICATIONS
SPECIFICATIONS
TWOPASSENGER
ELECTRIC
VEHICLE
TWOPASSENGER
GASOLINE
VEHICLE
FOURPASSENGER
ELECTRIC
VEHICLE
FOURPASSENGER
GASOLINE
VEHICLE
POWER SOURCE
Drive motor: Direct drive, 48 volts DC, shunt-wound,
●
●
●
●
●
●
Batteries: High capacity, deep cycle
●
●
Charger: Automatic, 48-volt; UL and CSA listed
●
●
3.1 hp
Transaxle: Double reduction helical gear with 12.3:1
direct drive axle
Electrical system: 48- volts DC, reduced speed
reverse
Engine: Engine: 4-cycle OHV, 351 cc, 10.4 Engine
Horsepower (7.6 kW) rated @ 3600 RPM (per SAE
J1349), single-cylinder, air-cooled, with pressure
●
●
●
●
●
●
●
●
●
●
●
●
●
●
lubrication system.
Fuel system: Side-draft carburetor with float bowl,
fixed jets, fuel filters, and impulse fuel pump
Governor: Automatic ground-speed sensing,
internally geared in unitized transaxle
Ignition: Transistor electronic ignition with electronic
RPM limiter
Unitized transaxle: Fully synchronized forward and
reverse with neutral and reduced speed reverse
(11.8:1 forward, 17.1:1 reverse)
Torque converter: Automatic, variable-speed, dry
type
Electrical system: 12 volt, 500 cca at 0 °F (-17.8
°C), 650 at 32 °F (0 °C). 105-minute reserve capacity
and 35-amp charging capacity
STEERING/SUSPENSION/BRAKES
Steering: Self-adjusting rack and pinion
●
●
●
●
●
●
●
●
●
●
●
●
Frame/Chassis: Aluminum and composite
●
●
●
●
Front and rear body: Dupont Surlyn© Reflections
●
●
●
●
Body finish: High-gloss molded-in color
●
●
●
●
Suspension: Front and rear tapered mono-leaf
springs with dual hydraulic shocks
Brakes: Dual rear wheel self-adjusting brakes
with cast iron drums and single brake pedal with
automatic-release park brake
BODY/CHASSIS
2012 through 2014 Precedent Golf Car Owner’s Manual
Page 63
Vehicle Specifications
TWOPASSENGER
ELECTRIC
VEHICLE
TWOPASSENGER
GASOLINE
VEHICLE
FOURPASSENGER
ELECTRIC
VEHICLE
FOURPASSENGER
GASOLINE
VEHICLE
●
●
●
●
91.5 in. (232 cm)
91.5 in. (232 cm)
104 in. (264 cm)
104 in. (264 cm)
47.25 in.
47.25 in.
47.25 in.
47.25 in.
(120 cm)
(120 cm)
(120 cm)
(120 cm)
Overall height (with canopy)
68.5 in. (174 cm)
68.5 in. (174 cm)
71 in. (180 cm)
71 in. (180 cm)
Overall height (at steering wheel)
48.0 in. (122 cm)
48.0 in. (122 cm)
48.0 in. (122 cm)
48.0 in. (122 cm)
Wheelbase
65.5 in. (166 cm)
65.5 in. (166 cm)
65.5 in. (166 cm)
65.5 in. (166 cm)
Ground clearance
4.5 in. (11 cm)
4.5 in. (11 cm)
4.5 in. (11 cm)
4.5 in. (11 cm)
Front wheel tread
34.5 in. (88 cm)
34.5 (88 cm)
34.5 in. (88 cm)
34.5 (88 cm)
Rear wheel tread
38.6 in. (98 cm)
38.6 in. (98 cm)
38.6 in. (98 cm)
38.6 in. (98 cm)
SPECIFICATIONS
Tires: 18 x 8.5 – 8 tubeless, 4 ply rated
DIMENSIONS/WEIGHT
Overall length
Overall width
Weight (standard electric vehicle with canopy, with
batteries)
909 lb (412.5 kg)
Weight (standard gasoline vehicle with canopy, with
1024 lb (464.5 kg)
651 lb (295 kg)
battery, without fuel)
Forward speed
768 lb (348 kg)
12 to 15 mph (19 to 24 km/h)
Curb clearance circle (diameter)
Standard seating capacity
17 ft - 4 in. (528 cm)
17 ft - 4 in. (528 cm)
17 ft - 4 in. (528 cm)
17 ft - 4 in. (528 cm)
2
2
4
4
LIQUID CAPACITIES
22 oz
22 oz
(0.67 L)
(0.67 L)
Transaxle
Engine crankcase (without filter)
32 oz (0.95 L)
32 oz (0.95 L)
Engine crankcase (with filter)
38 oz (1.12 L)
38 oz (1.12 L)
Unitized transaxle
27 oz (0.8 L)
27 oz (0.8 L)
6.7 gallons (25.4 L)
6.7 gallons (25.4 L)
Fuel tank
TIRE PRESSURE
Front and rear
18 to 20 psig
12 to 14 psig
18 to 20 psig
18 to 20 psig
(124 to 138 kPa)
(83 to 96 kPa)
(124 to 138 kPa)
(124 to 138 kPa)
68.5 dBA
70.9 dBA
68.5 dBA
70.9 dBA
Uncertainty: 2 dBA
Uncertainty: 2 dBA
Uncertainty: 2 dBA
Uncertainty: 2 dBA
0.6 m/s2
0.8 m/s2
0.8 m/s2
0.8 m/s2
Uncertainty:
0.114 m/s2
Uncertainty:
0.096 m/s2
Uncertainty:
0.072 m/s2
Uncertainty:
0.087 m/s2
NOISE AND VIBRATION
Drive-by noise level to operator
Test method: EN 12053:2001
Vibration at driver’s seat
Test method:EN 13059:2002
Page 64
2012 through 2014 Precedent Golf Car Owner’s Manual
Warranties
WARRANTIES
CLUB CAR® LIMITED WARRANTY FOR PRECEDENT VEHICLES
WARRANTY
CLUB CAR, LLC (“CLUB CAR”) hereby warrants to the Original Purchaser or Lessee, as those terms are defined
herein, and subject to the provisions, limitations and exclusions in this limited warranty, that its new vehicle or new
component purchased from CLUB CAR or an Authorized Dealer or Distributor shall be free from defects in material
and workmanship under normal use and service for the periods stated below, subject to the provisions, limitations and
exclusions in this limited warranty.
This limited warranty covers material, workmanship and repair labor cost as to those items specifically listed below for
the periods specified. Such repair labor shall be performed only by CLUB CAR, its Authorized Dealers or Distributors,
or a service agency approved by CLUB CAR. For repairs made by qualified technicians other than CLUB CAR’s factory
technicians or an Authorized Dealer or Distributor, CLUB CAR will provide only the replacement parts or components.
IF THE WARRANTY REGISTRATION FORM IS NOT COMPLETED AND RETURNED TO CLUB CAR AT THE TIME
OF THE ORIGINAL RETAIL SALE, PURCHASER MUST PROVIDE PROOF OF DATE OF PURCHASE WITH
ANY WARRANTY CLAIM.
i2L
VEHICLE MAIN FRAME
i2
V4
LIMITED LIFETIME
SUSPENSION: Steering gearbox, steering column, shocks, and leaf springs.
4
4
4
MAJOR ELECTRONICS: Onboard computer (OBC) (if so equipped), solid state speed controller, and battery charger.
4
4
4
4
4
4
PEDAL GROUP: Pedal group mechanical assembly, brake cluster assemblies, and brake cables.
4
4
4
SEATS: Seat bottom, seat back, and armrests.
4
4
4
CANOPY SYSTEM: Canopy, rear canopy supports, drainage system and structural accessory module (SAM).
4
4
4
POWERTRAIN: Gasoline engine, electric motor, MCOR, gasoline and electric transaxle, starter generator, air intake,
exhaust system, and torque converter (drive and driven).
3
3
3
BODY GROUP: Beauty panels, and front and rear underbody.
3
3
3
2
2
2
DEEP CYCLE BATTERY: 20,000 amp hours as recorded by the OBC (if so equipped) or controller, or four years,
whichever first occurs.
ALL REMAINING COMPONENTS: Solenoid, GCOR, limit switches, voltage regulator, F&R switch, and options and
accessories supplied by CLUB CAR, including components not specified otherwise.
EXCLUSIONS
Excluded from any CLUB CAR warranty is damage to a vehicle or component resulting from a cause other than a
defect including poor maintenance, neglect, abuse, accident and collision, maintenance adjustments, unreasonable
or unintended strain or use, improper installation of accessories, installation of parts or accessories that are not
original equipment including Club Car approved or non-approved GPS systems, non-approved alteration and acts
of God. Also excluded from any CLUB CAR warranty are all fuses, filters, decals (except safety decals), lubricants,
routine wear items such as the charger plug and receptacle, engine mounts, mats, pads, spark plugs, light bulbs,
brake shoes, belts, brushes, bushings, drive buttons, cosmetic deterioration, and items that deteriorate, fade or fail
due to exposure or ordinary wear and tear.
The provisions of this limited warranty shall not apply to failure due to the following conditions:
1.
Abuse such as overcharging, undercharging, improper fluid levels, loose wiring and fasteners, or rusted or
corroded hardware.
2.
Use of water in batteries, including tap water, that contains impurities. Distilled water or a properly maintained,
Club Car approved battery water deionizer and filter system should be used to ensure water quality.
2012 through 2014 Precedent Golf Car Owner’s Manual
Page 65
Warranties
3.
Lack of proper maintenance such as preventive maintenance checks, proper rotation of vehicles in a fleet
application, maintaining proper tire pressure and alignment and tightening loose wire connections as outlined
in the owner’s manual.
4.
Damages caused by improper installation of the component.
5.
Neglect, breakage, freezing, fire, explosion, wreckage, melted terminal posts, the addition of any chemical, or the
operation of the battery in an uncharged condition (below half charge 1.200 specific gravity); the installation of
the batteries in reverse or recharging in reverse, breakage of containers, covers, or terminal post, or batteries
used in applications for which they were not designed.
6.
A battery damaged by a defective charger or batteries in vehicles that do not receive proper charging.
7.
A vehicle not having an operational charger on a circuit that has the parameters specified in the vehicle owner’s
manual. (Number of operational chargers must equal the number of operational vehicles.)
Improper charging of a vehicle due to the use of a battery charger model not approved by Club Car for use
with the vehicle.
8.
9.
Failed semiconductor parts such diodes and fuses that are vulnerable to electrical overloads (including lightning)
beyond the control of CLUB CAR.
10. Damaged charger DC cord set with plug, which is a wear item and subject to user abuse.
11. Use of gasoline containing more than 10% ethanol.
Without limiting the generality of the foregoing in any way, and as part of its limited warranty exclusion, CLUB CAR
does not warrant that its vehicle or components such as batteries, computer, controller or electrical device are suitable
for use in any application other than in its products. As in the use of any vehicle, batteries, computer, controller or
electrical device, a prudent owner will read and study the owner’s manual, the operator instructions and the warning
labels; and will exercise due care in working on or around vehicles, batteries or electrical devices.
Transportation expenses for warranty services are also excluded from this warranty.
VOIDING OF WARRANTY
THIS AND ANY OTHER WARRANTY SHALL BE VOID IF THE VEHICLE OR COMPONENT IS ABUSED OR
USED IN AN UNINTENDED MANNER OR SHOWS INDICATIONS THAT IT HAS BEEN ALTERED IN ANY WAY,
INCLUDING, BUT NOT LIMITED TO, MODIFICATION OF THE SPEED GOVERNOR, BRAKING SYSTEM,
STEERING, TRANSAXLE, OR OTHER OPERATING SYSTEMS OF THE CAR TO CAUSE IT TO PERFORM
OUTSIDE CLUB CAR SPECIFICATIONS. THE WARRANTY IS LIKEWISE VOID IF THE VEHICLE SHOWS
INDICATIONS THAT REASONABLE OR NECESSARY MAINTENANCE AS OUTLINED IN THE OWNER’S MANUAL
AND MAINTENANCE AND SERVICE MANUAL WAS NOT PERFORMED AT THE TIME AND IN THE MANNER
SPECIFIED IN SUCH MANUALS.
SOLE REMEDY
CLUB CAR’s liability under this limited warranty or in any action whether based upon warranty, contract, negligence,
strict product liability or otherwise, shall be the repair or replacement, at CLUB CAR’s option, of the vehicle or
component thereof that CLUB CAR deems to be defective. Replacement shall mean furnishing, during the applicable
limited warranty period, a new vehicle or factory-reconditioned vehicle or component thereof that is identical or
reasonably equivalent to the warranted product or component at no cost to the purchaser. Repair shall mean
remedying a defect in the vehicle or component thereof at no cost to the purchaser during the applicable limited
warranty period. CLUB CAR reserves the right to test and recharge any component returned for adjustment. If CLUB
CAR elects to repair the vehicle or component, it may provide factory-reconditioned parts or components. All parts and
components replaced under warranty shall become the property of CLUB CAR.
DISCLAIMER
THIS LIMITED WARRANTY IS EXCLUSIVE. CLUB CAR MAKES NO OTHER WARRANTY OF ANY KIND,
EXPRESSED OR IMPLIED. ANY IMPLIED WARRANTIES OF MERCHANTABILITY OR FITNESS FOR A
PARTICULAR PURPOSE ARE HEREBY DISCLAIMED BY CLUB CAR AND EXCLUDED FROM THIS WARRANTY.
THE PURCHASER AND CLUB CAR EXPRESSLY AGREE THAT THE SOLE REMEDY OF THE REPLACEMENT
OR REPAIR OF THE DEFECTIVE VEHICLE OR COMPONENT THEREOF IS THE SOLE REMEDY OF THE
PURCHASER. CLUB CAR MAKES NO OTHER REPRESENTATION OR WARRANTY OF ANY KIND, AND NO
REPRESENTATIVE, EMPLOYEE, DISTRIBUTOR OR DEALER OF CLUB CAR HAS THE AUTHORITY TO MAKE
OR IMPLY ANY REPRESENTATION, PROMISE OR AGREEMENT, WHICH IN ANY WAY VARIES THE TERMS OF
THIS WARRANTY.
In the event that another pre-printed warranty document, certificate or both offered by or through Club Car at the time
of sale of this vehicle (each an “Additional Warranty Document”) is deemed to conflict with the limitations or exclusions
Page 66
2012 through 2014 Precedent Golf Car Owner’s Manual
Warranties
contained herein, the limitations and exclusions contained herein shall continue to apply to both this limited warranty
statement and, to the maximum extent permitted by law, to each Additional Warranty Document.
NO CONSEQUENTIAL DAMAGES
IN NO EVENT SHALL CLUB CAR BE LIABLE FOR ANY INCIDENTAL OR CONSEQUENTIAL DAMAGES
INCLUDING, BUT NOT LIMITED TO, LOSS RELATED TO PROPERTY OTHER THAN THE VEHICLE, LOSS OF
USE, LOSS OF TIME, INCONVENIENCE, OR ANY OTHER ECONOMIC LOSS.
Some states allow neither limitation on the duration of an implied warranty nor exclusions or limitation of incidental or
consequential damages. Therefore, the above limitations or exclusions may not apply to you. This warranty gives you
specific legal rights, and you may also have other rights, which vary from state to state.
HOW TO MAKE A WARRANTY CLAIM
To make a warranty claim under this limited warranty, you must present the vehicle or defective component with
evidence of proof of purchase date and number of amp hours (if applicable) to an authorized CLUB CAR dealer.
For warranty-related communication, contact Warranty Services, Club Car, 4125 Washington Rd., Evans, GA 30809,
USA, 706.863.3000.
WARNING
Any modification or change to the vehicle that affects the electrical system, stability or handling of the vehicle, or
increases maximum vehicle speed beyond factory specifications, could result in severe personal injury or death.
2012 through 2014 Precedent Golf Car Owner’s Manual
Page 67
Warranties
FEDERAL EMISSIONS COMPONENT DEFECT WARRANTY
EMISSIONS COMPONENT DEFECT WARRANTY COVERAGE - This emission warranty is applicable in all States,
except the State of California.
Club Car, LLC (“CLUB CAR”) warrant(s) to the initial retail purchaser and each subsequent owner, that this Non-road
engine (“engine”) has been designed, built, and equipped to conform at the time of initial sale to all applicable
regulations of the U.S. Environmental Protection Agency (EPA), and that the engine is free of defects in materials and
workmanship which would cause this engine to fail to conform with EPA regulations during its warranty period.
For the components listed under PARTS COVERED, the service dealer authorized by CLUB CAR will, at no cost
to you, make the necessary diagnosis, repair, or replacement necessary to ensure that the engine complies with
applicable U.S. EPA regulations.
EMISSION COMPONENT DEFECT WARRANTY PERIOD
The warranty period for this engine begins on the date of sale to the initial purchaser and continues for a period of
three years.
PARTS COVERED
Listed below are the parts covered by the Emission Components Defect Warranty. Some of the parts listed below may
require scheduled maintenance and are warranted up to the first scheduled replacement point for that part.
EXHAUST EMISSIONS
1.
Fuel Metering System
1.1. Carburetor and internal parts (and/or pressure regulator or fuel injection system)
1.2. Air/fuel ratio feedback and control system, if applicable
2.
1.3. Cold start enrichment system, if applicable
Air Induction System
2.1. Intake manifold, if applicable
3.
2.2. Air filter
Ignition System
3.1. Spark plugs
3.2. Magneto or electronic ignition system
4.
3.3. Spark advance/retard system, if applicable
Catalyst or Thermal Reactor System
4.1. Exhaust Manifold, if applicable
5.
Miscellaneous Items Used in Above Systems
5.1. Electronic controls, if applicable
5.2. Hoses, belts, connectors, and assemblies
EVAPORATIVE EMISSIONS
1.
Fuel Line
2.
Fuel Line Fittings
3.
4.
Clamps
Fuel Tank
5.
Fuel Cap
6.
Vapor Hoses
Page 68
2012 through 2014 Precedent Golf Car Owner’s Manual
Warranties
7.
Carbon Canister
8.
Carbon Canister Mounting Brackets
9.
Air Cleaner Purge Port Connector
REPLACEMENT PARTS DISTRIBUTION CENTER
Replacement parts are provided to the market upon request by the customers. Replacement parts distribution
center is located at the Service Parts Department, Club Car, 4125 Washington Road, Evans, Georgia 30809,
U.S.A., 706-863-3000. If you have a question regarding your replacement part, you should contact CLUB CAR
at 706-863-3000.
OBTAINING WARRANTY SERVICE
To obtain warranty service, take your engine to the nearest authorized CLUB CAR service dealer. Bring your sales
receipts indicating date of purchase for this engine. The service dealer authorized by CLUB CAR will perform the
necessary repairs or adjustments within a reasonable amount of time and furnish you with a copy of the repair order.
All parts and accessories replaced under this warranty become the property of CLUB CAR.
For owners located more than 100 miles from an authorized service center, the following will be provided to those
applicable owners (excluding the states with high-altitude areas).
• CLUB CAR will either pay for the shipping costs of replacement parts to and from an authorized service center.
• Or CLUB CAR will provide for a service technician to come to the owner to make the warranty repair.
• Or CLUB CAR will pay for the repair to be made at a local non-authorized service center.
WHAT IS NOT COVERED
• Conditions resulting from tampering, misuse, improper adjustment (unless they were made by the service dealer
authorized by CLUB CAR during a warranty repair), alteration, accident, failure to use the recommended fuel and
oil, or not performing required maintenance services.
• The replacement parts used for required maintenance services.
• Consequential damages such as loss of time, inconvenience, loss of use of the engine or equipment, etc.
• Diagnosis and inspection charges that do not result in warranty-eligible service being performed.
• Any non-authorized replacement part, or malfunction of authorized parts due to use of non-authorized parts.
OWNER’S WARRANTY RESPONSIBILITIES
As the engine owner, you are responsible for the performance of the required maintenance listed in your owner’s
manual. CLUB CAR recommends that you retain all receipts covering maintenance on your engine, but CLUB CAR
cannot deny warranty solely for the lack of receipts or for your failure to ensure the performance of all scheduled
maintenance.
As the engine owner, you should however be aware that CLUB CAR may deny warranty coverage if your engine or a
part has failed due to abuse, neglect, improper maintenance or unapproved modifications.
You are responsible for presenting your engine to the nearest service dealer authorized by CLUB CAR when a
problem exists.
If you have any questions regarding your warranty rights and responsibilities, you should contact the CLUB CAR
customer service department at 706-863-3000 for the information.
THINGS YOU SHOULD KNOW ABOUT THE EMISSION CONTROL SYSTEM WARRANTY MAINTENANCE AND
REPAIRS
2012 through 2014 Precedent Golf Car Owner’s Manual
Page 69
Warranties
You are responsible for the proper maintenance of the engine. You should keep all receipts and maintenance records
covering the performance of regular maintenance in the event questions arise. These receipts and maintenance
records should be transferred to each subsequent owner of the engine. CLUB CAR reserves the right to deny warranty
coverage if the engine has not been properly maintained. Warranty claims will not be denied, however, solely because
of the lack of required maintenance or failure to keep maintenance records.
MAINTENANCE, REPLACEMENT OR REPAIR OF EMISSION CONTROL DEVICES AND SYSTEMS MAY
BE PERFORMED BY ANY REPAIR ESTABLISHMENT OR INDIVIDUAL; HOWEVER, WARRANTY REPAIRS
MUST BE PERFORMED BY A SERVICE DEALER AUTHORIZED BY CLUB CAR. THE USE OF PARTS THAT
ARE NOT EQUIVALENT IN PERFORMANCE AND DURABILITY TO AUTHORIZED PARTS MAY IMPAIR THE
EFFECTIVENESS OF THE EMISSION CONTROL SYSTEM AND MAY HAVE A BEARING ON THE OUTCOME OF
A WARRANTY CLAIM.
If other than the parts authorized by CLUB CAR are used for maintenance replacements or for the repair of components
affecting emission control, you should assure yourself that such parts are warranted by their manufacturer to be
equivalent to the parts authorized by CLUB CAR in their performance and durability.
HOW TO MAKE A CLAIM
All repairs qualifying under this limited warranty must be performed by a service dealer authorized by CLUB CAR. In
the event that any emission-related part is found to be defective during the warranty period, you shall notify CLUB CAR
customer service department at 706-863-3000 and you will be advised of the appropriate warranty service dealer or
service providers where the warranty repair can be performed.
CALIFORNIA EMISSION CONTROL WARRANTY STATEMENT
YOUR WARRANTY RIGHTS AND OBLIGATIONS:
The California Air Resources Board (“CARB”) and Club Car, LLC (“CLUB CAR”) are pleased to explain the emission
control system warranty on your 2014 or newer vehicle engine (the “emission warranty”). In California, new small
off-road engines (“SORE”) must be designed, built and equipped to meet the State’s stringent anti-smog standards.
CLUB CAR shall warrant the emission control system on the vehicle engine for the periods of time listed below
provided there has been no abuse, neglect or improper maintenance of your small off-road engine.
Your emission control system may include parts such as the carburetor or fuel-injection system, the ignition system, the
catalytic converter and related hoses, belts, connectors and other emission assemblies or components.
Where a warrantable condition exists, as defined herein, CLUB CAR will repair your vehicle engine at no cost to
you including diagnosis, parts and labor.
MANUFACTURER’S WARRANTY COVERAGE:
This emission control system is warranted for two years from the vehicles’ date of purchase. If any emission-related
part on your CLUB CAR SORE is defective, the part will be repaired or replaced by CLUB CAR.
OWNER’S WARRANTY RESPONSIBILITIES:
- As the vehicle engine owner, you are responsible for the performance of the required maintenance listed in your
owner’s manual. CLUB CAR recommends that you retain all receipts covering maintenance on your vehicle engine,
but CLUB CAR cannot deny warranty solely for the lack of receipts or for your failure to ensure the performance of all
scheduled maintenance.
- As the vehicle engine owner, you should however be aware that CLUB CAR may deny you warranty coverage if
vehicle engine or a part has failed due to abuse, neglect, improper maintenance or unapproved modifications.
- You are responsible for presenting vehicle engine to a CLUB CAR distribution center as soon as a problem exists.
The warranty repairs should be completed in a reasonable amount of time, not to exceed 30 days. If you have any
questions regarding your warranty rights and responsibilities, you should contact WARRANTY SERVICES, CLUB
CAR, LLC, P.O. Box 204658, Augusta, Georgia 30917-4658, U.S.A., 1-706-863-3000.
CLUB CAR EXPLANATION OF EMISSION CONTROL WARRANTY:
1. WARRANTY:
Page 70
2012 through 2014 Precedent Golf Car Owner’s Manual
Warranties
CLUB CAR warrants to the ultimate purchaser and each subsequent purchaser that the SORE and related emissions
equipment is designed, built and equipped so as to conform with all applicable California environmental emission
regulations; and free from defects in materials and workmanship that cause the failure of a warranted part to be
identical in all material respects to that part as described in CLUB CAR’s application for certification with CARB. The
warranty period begins on the date the engine or equipment is delivered to an ultimate purchaser or first placed into
service. The warranty period is two years from the date of purchase.
2. COVERAGE:
Subject to certain conditions and exclusions as stated below, the warranty on emission-related parts is as follows:
(1) Any warranted part that is not scheduled for replacement as required maintenance in the written instructions
supplied, is warranted for the warranty period stated above. If the part fails during the period of warranty coverage, the
part will be repaired or replaced by CLUB CAR according to subsection (4) below. Any such part repaired or replaced
under warranty will be warranted for the remainder of the original warranty period.
(2) Any warranted part that is scheduled only for regular inspection in the written instructions supplied is warranted
for the warranty period stated above. Any such part repaired or replaced under warranty will be warranted for the
remaining original warranty period.
(3) Any warranted part that is scheduled for replacement as required maintenance in the written instructions supplied is
warranted for the period of time before the first scheduled replacement date for that part. If the part fails before the
first scheduled replacement, the part will be repaired or replaced by CLUB CAR according to subsection (4) below.
Any such part repaired or replaced under warranty will be warranted for the remainder of the period prior to the first
scheduled replacement point for the part.
(4) Repair or replacement of any warranted part under the warranty provisions herein must be performed at a warranty
station* at no charge to the owner.
(5) Notwithstanding the provisions herein, warranty services or repairs will be provided at all of our distribution centers
that are franchised to service the subject engines or equipment.
(6) The engine or equipment owner will not be charged for diagnostic labor that is directly associated with diagnosis of
a defective, emission-related warranted part, provided that such diagnostic work is performed at a warranty station*.
(7) CLUB CAR is liable for damages to other engine or equipment components proximately caused by a covered
failure under warranty of any warranted part.
(8) Throughout the engine or equipment warranty period stated above, CLUB CAR will maintain a supply of warranted
parts sufficient to meet the expected demand for such parts.
(9) Any replacement part may be used in the performance of any warranty maintenance or repairs and must be
provided without charge to the owner. Such use will not reduce the warranty obligations of CLUB CAR.
(10) Add-on or modified parts that are not exempted by the Air Resources Board may not be used. The use of any
non-exempted add-on or modified parts by the ultimate purchaser will be grounds for disallowing a warranty claims.
CLUB CAR will not be liable to warrant failures of warranted parts caused by the use of a non-exempted add-on or
modified part.
*CLUB CAR, its authorized dealers, or a service agency approved by CLUB CAR.
ITEMS COVERED BY THIS WARRANTY:
The repair or replacement of any warranted part otherwise eligible for warranty coverage may be excluded from
such warranty coverage if CLUB CAR demonstrates that the engine or equipment has been abused, neglected, or
improperly maintained, and that such abuse, neglect, or improper maintenance was the direct cause of the need for
repair or replacement of the part. That notwithstanding, any adjustment of a component that has a factory installed,
and properly operating, adjustment limiting device is still eligible for warranty coverage. The following emission
warranty parts list are covered:
SYSTEMS COVERED PARTS DESCRIPTION
Fuel Metering Carburetor assembly, fuel injection pump, fuel injection nozzle, fuel regulator Exhaust Catalytic
Converter, Exhaust Manifold Air Induction Air filter housing, air filter*, crankcase breather tube Ignition Flywheel
magneto, ignition pulse generator, ignition coil assembly, ignition control module, spark plug cap, spark plug* Positive
Crankcase Ventilation (PCV) System PCV valve, oil filler cap Evaporative System Fuel Tank, Fuel Cap, Fuel Lines,
Fuel Line Fittings, Clamps, Pressure Relief Valves, Purge Valves, Vapor Hoses, Carbon Canister, Canister Mounting
Brackets, Carbon Canister Purge Port Connector Misc. Parts Belts, hosing, tubing, fittings, seals, gaskets, clamps, and
switches associated with the above systems.
Emission-related parts will vary between vehicles; therefore, certain vehicles may not include all of the listed parts
or may include equivalent parts.
2012 through 2014 Precedent Golf Car Owner’s Manual
Page 71
Warranties
3. VOIDING OF WARRANTY:
THIS AND ANY OTHER WARRANTY SHALL BE VOID IF THE VEHICLE IS ABUSED OR USED IN AN UNINTENDED
MANNER OR SHOWS INDICATIONS THAT IT HAS BEEN ALTERED IN ANY WAY, INCLUDING, BUT NOT LIMITED
TO, MODIFICATION OF THE SPEED GOVERNOR, BRAKING SYSTEM, STEERING, TRANSAXLE, OR OTHER
OPERATING SYSTEMS OF THE VEHICLE TO CAUSE IT TO PERFORM OUTSIDE CLUB CAR SPECIFICATIONS.
4. HOW TO MAKE A WARRANTY CLAIM:
To make a warranty claim under this limited warranty, you must present the vehicle or defective component to
an authorized CLUB CAR dealer.
Page 72
2012 through 2014 Precedent Golf Car Owner’s Manual
EC Declaration of Conformity
EC DECLARATION OF CONFORMITY
When properly configured, the vehicle complies with the listed Directives.
De clara tio n o f Co n fo rm ity
Mode l
Cod e
PH
PD
PJ
PU
PV
Mode l
Numbe r
103399101
103399201
103399301
103399501
103399601
Mode l Na me
P re ce de nt i2 Excel
P re ce de nt i2L Excel
P re ce de nt i2 4 P a s s e nge r Excel
P re ce de nt i2 S ignat ure
P re ce de nt i2 4 P a s s e nge r S igna ture
S er ia l numbe rs 1101000001 a nd gre a te r
Four whe e l e lec tric ve hicles in the a bove se ries which be a r the CE ma rk fulfill a ll the re le va nt
pro vis ion s of the following Direc tives
Ens pricht de n Be s timmunge n, Conforme Aux Dire ctive s , Conforme Con La s Dire ctiva s , Voldoe t a a n Richtlijne n, De Acordo com
Dire ctiva , Conforme Alla Dire ttiva , Opfylde r folge nde dire ktive r, Upptylle r folja nde dire ktiv
2006/42/EC Mac hine ry
2006/66/EC Bat terie s a nd Accum ulat ors a nd Wa s te Ba tte rie s a nd Acc umula tors
2004/108/EC Elec troma gne tic Compa tibility
S ta nda rds us ed for ver ifica tion
S ta nda rds fur Ube rprufung, S ta nda rd Utilis e e pour Ve rifica tion, Norma s Us a do por Comproba cion, Wa a rde n Aa nge we nd voor
Ve rifica tie , Mode los Utiliza do pa ra Ve rifca ca o, S ta nda rd pe r la Ve rifica , S ta nda rde r Anve ndte Ne mlig Efte rprovning, S ta nda rde n
Anva nd for Be kra fta nde n
EN 61000-6-2
EN 61000-6-4
Ma nufac turer
He rs te lle r, Fa brica nt, Fa brica nte , Fa brika nt, Fa brica nte , Fa bbrica nte , P roduce nt, Tillve rka re
Club Car , LLC
4125 Was hington Roa d
Eva ns , Ge orgia 308 09
US A
Autho rize d re pres e nta tive and pe rso n a uthorize d to compile the te chnica l file
Autoris ierte r Hä ndler, Re pre s e nta nt Due me nt Acré dité , Re pre s e nta nte Autoriza do, We ttige Ve rte ge nwoordiging, Re pre s e nta te
Autoriza do, Ra ppre s e nta nte Autorizza to, Autoris cre t re præ s e nta nt, Auktoris e ra d re pre s e nta nt:
Club Car Ingerso ll Ra nd
Alma Court Building
Le nne ke Mar e la a n 6
B-1932 S int-S te ve ns -Woluwe, Be lgium
_______________________________________________
Ge off S te war t
Augus t 2, 2010
Le a d Engine er , P roduct S a fe ty
Eva ns , Ge orgia , US A
Re gis te re d IS O 9001-2008
2012 through 2014 Precedent Golf Car Owner’s Manual
Page 73
EC Declaration of Conformity
De c la ra tio n o f Co n fo rm ity
Mode l
Code
PR
CF
PF
PY
PX
Mode l
Numbe r
102537101
102537201
102537401
103228901
103229101
Mode l Na me
P re ce de nt i2 Gas
P re ce de nt i2L Gas
P re ce de nt i2 4 P a s s e nge r Gas
P re ce de nt i2 S ignat ure Gas
P re ce de nt i2 4 P a s s e nge r S igna ture
S e ria l numbe rs 1101000001 a nd gre a te r
Four-whe e l gas oline ve hicles in the a bove se rie s tha t be a r the CE ma rk fulfill a ll the re le va nt
pro vis ion s of the following Direc tives
Ens pricht de n Be s timmunge n, Conforme Aux Dire ctive s , Conforme Con La s Dire ctiva s , Voldoe t a a n Richtlijne n, De Acordo com
Dire ctiva , Conforme Alla Dire ttiva , Opfylde r folge nde dire ktive r, Upptylle r folja nde dire ktiv
2006/42/EC
2006/66/EC
Mac hine ry
Ba tter ie s a nd Accumu lat ors a nd Wa s te Ba tte rie s a nd Accumula tors
S ta nda rds us ed for verifica tion
S ta nda rds fur Ube rprufung, S ta nda rd Utilis e e pour Ve rifica tion, Norma s Us a do por Comproba cion, Wa a rde n Aa nge we nd voor
Ve rifica tie , Mode los Utiliza do pa ra Ve rifca ca o, S ta nda rd pe r la Ve rifica , S ta nda rde r Anve ndte Ne mlig Efte rprovning, S ta nda rde n
Anva nd for Be kra fta nde n
N/A
Ma nufac turer
He rs te lle r, Fa brica nt, Fa brica nte , Fa brika nt, Fa brica nte , Fa bbrica nte , P roduce nt, Tillve rka re
Club Car , LLC
4125 Was hington Roa d
Eva ns , Ge orgia 30809
US A
Autho rize d re pres e nta tive a nd pe rs on a uthorize d to compile the te chnica l file
Autoris ierte r Hä ndler, Re pre s e nta nt Due me nt Acré dité , Re pre s e nta nte Autoriza do, We ttige Ve rte ge nwoordiging, Re pre s e nta te
Autoriza do, Ra ppre s e nta nte Autorizza to, Autoris cre t re præ s e nta nt, Auktoris e ra d re pre s e nta nt:
Club Car Inger s oll Ra nd
Alma Court Building
Le nne ke Mare la a n 6
B-1932 S int-S te ve ns -Woluwe, Be lgium
_______________________________________________
Ge off S te wart
Nove mbe r 2, 2010
Le a d Engine er , P roduct S a fe ty
Eva ns , Ge orgia , US A
Re gis te re d IS O 9001-2008
Page 74
2012 through 2014 Precedent Golf Car Owner’s Manual
H:\ECS \ELEC CE CERT 2011.DOC
BC56643
Publication Part Number 103897201
Edition Code 0511H1213G
103897201