Installation Procedure: EVC-E Volvo Penta IPS

Installation Procedure: EVC-E Volvo Penta IPS
Installation Procedure: EVC-E Volvo Penta IPS* Twin
Installation Procedure:
EVC-E Volvo Penta IPS Twin
Document number: 47702213
Release date: 06-2012
IPS 350/400/450/500/600, IPS 800/900, IPS 1050/1200
IMPORTANT! Never cut or modify the
Volvo Penta EVC harnesses. For extra power
supply, use the Volvo Penta relay for external
accessories.
Controls
Flybridge
Typical installation / Main station
Joystick
Steering unit
Buzzer
Steering
wheel hub
Compass (CCU)
NOTE! Minimum two 2.5” displays or one 4” or 7” display.
Maximum two 4” or 7” displays on one helm station.
Dynamic
Positioning
System
interface
To NMEA2000 backbone
7” display
9
10
10
Multilink hub
20 20
4” display
2.5” display
20
Steering
Multifunction panel
(Start/Stop panel)
Dynamic Positioning
System antenna
Multilink minimum requirements:
2.5” display
7” display
To NMEA2000 backbone
Autopilot
4” display
Steering wheel
Joystick
Levers
10
Engine connections
10
IPS 350/400/450/500/600
10
AUX BUS
AUX BUS
DATALINK
SENDERS
DATALINK
DATALINK
SENDERS
SENDERS
10
11
EVC Autopilot
16
10
C
DIAGNOS
Multiple helm
stations
NMEA interface
10
To next station
Multilink hub
AUX BUS
AUX BUS
Joystick
Compass (CCU)
11
20
Use AUX
relay
EVC Autopilot
Chartplotter
Fuse
Helm station
Battery
12 VDC
Multilink hub
10
AUX BUS
To next station
11
Y-connector
ENGINE
CONN.
AUX BUS
AUX-bus termination
18
16
10
Use cable ties to fix cables
NMEA2000 backbone
A
IPS 1050/1200
B
Use template when making
holes in dashboard
11
ADU
IPS 800/900
Autopilot 4”
display
10
9
19
Tilt adjuster
bracket
Lever
connections
Max. 15 mm (0.59”)
dashboard thickness
8
8
Termination
plug
5
20
20
23
Power
cable
20
Termination
plug
5
Steering wheel
Levers
11
11
Helm station
8
24
Female
terminator
22
20
Backbone extension cable
T-connector
24
Male
terminator
Correct!
Termination in the beginning and
at the end of the AUX-bus
Incorrect!
No end termination of the AUX-bus
8
8
Battery Management
Connection locations
Negative terminal
Battery sensor
Remote frequency reciever
with WLAN (RFW)
Lever connections
B
A C
Rudder angle
sender
(not used)
IMPORTANT! This end
of Y-connector must be
connected directly, without
extension, to levers/HCU.
e-Key panel
Diagnose
connection
(VODIA)
25
D11
Connection for
safety lanyard
D11
Connecting multiple Multilink hubs
OK!
Multisensor
1
SUS
2
OK!
Starter motor
2.5” Battery
Management
display
7
7
Reverse
(SECONDARY)
Forward (PRIMARY)
ACP
CPM
ACP – Active Corrosion Protection
4
Docking station
Oil temperature
and pressure
7
Battery sensor
21
To transom unit
Battery sensor
Battery Control Unit (BCU)
21
Buzzer
Battery Control Unit (BCU)
2.5“ Battery
Management
display
Datalink to SUS
Rev. pickup
Oil temperature
and pressure
A: unfused
output
House loads
NOT OK!
7
Reverse
(SECONDARY)
Forward
(PRIMARY)
Continuous
output 20 A
1
SUS
Datalink to SUS
B: fused
output
For information on cable lengths etc.
please refer to Installation manual.
7
IPS 800/900/
1050/1200
5
Termination
plug
To external switches (optional)
To engine connector (AUX)
Termination plug 5
Rev. pickup
Engine
12
Fresh water
and fuel level
senders
IPS 350/400/
450/500/600
Engine
Buzzer
12
Propulsion unit
connections
7
7
7
7
Joystick
Standalone
HCU
Multifunction panel
(Docking station panel)
10
Transom unit
3
7
7
5 Termination plug
11
Stand-alone
HCU connections
To transmission cable
To AUX-bus connection
11
Components and Cables
Cables
e-Key System
Steering
Controls
Steering wheel non tilt adjuster
Levers
“Palm Beach”
In combination with A-CAN
Levers
Built-in HCUs
Joystick
Incl. cables 1.5 m (5 ft.)
Steering wheel tilt adjuster
Steering wheel hub
Incl. cables 2.5 m (8 ft.)
e-Key (standard)
e-Key Remote (optional)
Locking/unlocking
the boat system
Locking/unlocking the boat system.
Controls main circuit breaker and
two aux relays
1 a. Wiring harness
1 b. Wiring harness
1c. Wiring harness
IPS 350-600
Feet Meter Part no.
1.9 0.6 21865860
4.31.321260204
5.61.721260205
6.21.921865861
8.52.621260207
10.23.1 21260208
11.53.5 21395663
IPS 800-900
Feet Meter Part no.
4.31.321851490
5.61.721851491
7.22.221851492
8.52.621851493
10.23.1 21851494
11.53.5 21851495
18 5.5 21851496
IPS 1050-1200
Feet Meter Part no.
4.31.321759842
5.61.721759840
7.22.221758217
8.52.621758219
10.23.1 21758220
11.53.5 21758221
18 5.5 21858754
5. Termination plug
Part no.
21825714
6. Y-split steering, 6-pin
Feet Meter Part no.
1.30.421421941
7. Standard EVC bus
cable, 6-pin*
Feet Meter Part no.
5 1.5 21865234
16 5.0 874789
23 7.0 889550
30 9.0 889551
36 11.0 889552
42 13.0 888013
*) One cable per engine
has to be ordered.
2. Multisensor Y-split*
Feet Meter Part no.
1.90.621825662
*) Wiring harness AUX-bus.
3. BM-display Y-split*
Feet Meter Part no.
1.90.621825656
*) Wiring harness AUX-bus.
8. Y-connector, 6-pin
Feet Meter Part no.
1.60.53588972
9. 7” display cable, 6-pin
Feet Meter Part no.
5.51.721514712*
*) Incl. in display kit
4. CPM Y-split*
Feet Meter Part no.
1.90.621825665
*) Wiring harness AUX-bus.
Components
Multilink hub
6 cable sockets
Stand-alone HCU
e-Key Remote
e-Key
Compass (CCU)
e-Key panel
Ignition, start/stop and
locking/unlocking the boat
system
Multifunction panel
Function configured at startup
Battery Control Unit
2.5” display
Not in combination with
4” or 7” display
Remote frequency reciever
4” display
Color display
Not in combination with
2.5” or 7” display
Battery sensor
with WLAN (RFW)
Multisensor
Hull mounted
Dynamic Positioning
System interface
Multisensor
Transom mounted
ACP Kit
CPM unit, one transom unit
ACP Kit
Transom unit
Dynamic Positioning
System antenna
Autopilot 4” display
Color display
7” display
Color display
Not in combination with 2.5” or 4” display
A-CAN
Analog lever interface
Sender
Fuel level sender
3–180 ohm
Fuel level sender
240–30 ohm
7” display power supply
for 12 V systems
Sender
Water level sender
3–180 ohm
Autopilot interface
NMEA 0183 interface
NMEA 2000 interface
11. Extension cable, 6-pin
Feet Meter Part no.
5 1.5 3889410
10 3.0 3842733
16 5.0 3842734
23 7.0 3842735
30 9.0 3842736
36 11.0 3842737
66 20.0 21172469
131 40.021172470
12. Sender cable, 6-pin
Feet Meter Part no.
16 5.3 3807229
13. Aux. relay cable, 6-pin
Feet Meter Part no.
3.31.021427463
Kit with cable & relay
12V: 21475508
24V: 21475509
14. Extension cable, 6-pin
Feet Meter Part no.
237.021166002
309.021166003
4313
.021166004
15. Extension cable, 6-pin
Feet Meter Part no.
5 1.5 21480272
10. Multilink cable, 6-pin
Feet Meter Part no.
5 1.5 3886666
16. Extension cable, 3-pin
Feet Meter Part no.
3 1.0 874759
10 3.0 3807043
Clear Wake Exhaust
System
Only for IPS800-1200
17. Steering adapter, 12/6-pin
Feet Meter Part no.
0.60.221421945
18. Y-split multilink, 6-pin
Feet Meter Part no.
1.60.53588206
19. Display cable, 5/6-pin
Feet Meter Part no.
5 1.5 21640400
Incl. in display kit
Instruments
20. NMEA 2000 Extension cable
Feet Meter Part no.
1 0.3 21812185
6.6 2 21812194**
13421867150
19 6 21867151
33 10 21867152
21. Battery sensor cable
Feet Meter Part no.
9.8 3 21840060
**) Only in combination with EVC system tachometer
16
10
10
16
NMEA interface
10
Speedometer Unitless **
Diameter 85 mm (3.35”)
110 mm (4.33”)
0–40 1/Hour
0–60 1/Hour
Alarm instrument **
Diameter 52 mm (2.05”)
4-in-1 Gauge **
Diameter 110 mm (4.33”)
Coolant temperature
Voltage
Oil pressure
Fuel level
Coolant temp **
Diameter 52 mm (2.05”)
C°, F°
Fresh water level **
Diameter 52 mm (2.05”)
Voltmeter **
Diameter 52 mm (2.05”)
12 V, 24 V
Turbo pressure **
Diameter 52 mm (2.05”)
bar, psi
Rudder indicator **
Diameter 52 mm (2.05”)
Front ring kit (nut)
Diameter 52 mm (2.05”)
Black/Chrome
Diameter 85 mm (3.25”)
Black/Chrome
Diameter 110 mm (4.33”)
Black/Chrome
Fuel level **
Diameter 52 mm (2.05”)
Front ring kit (clamp)
Diameter 52 mm (2.05”)
Black/Chrome
Diameter 85 mm (3.25”)
Black/Chrome
Engine oil pressure **
Diameter 52 mm (2.05”)
bar, psi
Aux. Dimmer Unit (ADU) **
22. NMEA2000 T-connector
Part no.
21812195**
23. NMEA2000 Powercable
Feet Meter Part no.
6.6 2 21812205**
**) Incl. in Autopilot kit
24. NMEA2000
Termination plugs
Type Part no.
Male 21812196**
Female21812203**
25. e-Key harness
with Safety lanyard
FeetMeter
TypePart no.
5 1.5 Single panel 21693202
5 1.5 Twin panel 21693206
26. e-Key harness
without Safety lanyard
FeetMeter
TypePart no.
5 1.5 Single panel 21693204
5 1.5 Twin panel 21693208
47702213 06-2012
ADU
EVC system tachometer
Diameter 85 mm (3.35”)
110 mm (4.33”)
0–4000 rpm
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertising