IVAC Manual - Home Depot
40372-01 Rev B
S I M P L Y
A M A Z I N G®
USER’S GUIDE
PROFESSIONAL
GRADE
COMMERCIAL
COMPACTO 6
COMPACTO 9
•IMPORTANT•
SAVE THIS BOOKLET!
Includes:
• Safety Warnings
• Warranty
• Operating Instructions
• Trouble Diagnosis
USA / Canada: 1-800-336-0433
www.commercial.oreck.com
Table of Contents
Maintenance and Customer Service,
Grounding Instructions, Important Safety Instructions . page
IMPORTANT SAFETY
INSTRUCTIONS
2
Parts List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . page
3
Assembly, Operating Instructions . . . . . . . . . . . . . . . . . page
4
General Information, Replacing the Exhaust Filter, . . .
Replacing and Cleaning the Motor Filter, . . . . . . . . . .
Troubleshooting Guide . . . . . . . . . . . . . . . . . . . . . . . . . page
5
Warranty, Replacement Parts . . . . . . . . . . . . . . . . . . . . page
6
When using an electrical appliance, basic
precautions should always be followed,
including the following:
READ ALL INSTRUCTIONS BEFORE
USING THIS VACUUM CLEANER
WARNING
BEFORE OPERATING CLEANER,
READ ALL INSTRUCTIONS IN
THIS MANUAL CAREFULLY.
To reduce the risk of fire,
electric shock, or injury:
• Do not use outdoors or on wet surfaces.
• Do not allow to be used as a toy. Close attention is necessary
when used by or near children.
• Use only as described in this manual. Use only manufacturer’s
recommended attachments.
• Do not leave appliance unattended when plugged in. Unplug from
outlet when not in use and before servicing.
• Connect to a properly grounded outlet only. See: Grounding
Instructions (Compacto 9 only).
• Do not use with damaged cord or plug.
• If vacuum cleaner is not working as it should, has been dropped,
damaged, left outdoors, or dropped into water, return it to a service
center or call customer service at:
USA / Canada: 1-800-336-0433
• Do not pull or carry by cord, use cord as a handle, close door on
cord, or pull cord around sharp edges or corners. Keep cord away
from heated surfaces.
• Do not run vacuum over cord.
• Do not unplug by pulling on cord. To unplug, grasp the plug, not
the cord.
• Do not handle plug or vacuum cleaner with wet hands.
• Do not put any object into openings. Do not use with any opening
blocked; keep free of dust, lint, hair and anything that may reduce
air flow.
• Keep hair, loose clothing, fingers and all parts of body away from
openings and moving parts.
• Do not use to pick up anything that is burning or smoking, such as
cigarettes, matches, or hot ashes.
• Do not use without filter bag assembly in place.
• Turn off all controls before unplugging.
• Use extra care when cleaning on stairs.
• Do not use to pick up flammable or combustible liquids, such as
gasoline or lighter fluid, or use in areas where they may be present.
• Do not use appliance in an enclosed space where flammable,
explosive or toxic vapors are given off by oil base paint, paint thinner,
some mothproofing substances, or in an area where flammable
dust is present.
• Do not pick up toxic material such as chlorine bleach, drain cleaner,
gasoline, etc. with this appliance.
• Use caution when vacuuming over area rug edges and fringe.
• Do not use extension cords or outlets with inadequate current
carrying capacity
Maintenance and Customer Service
Your Oreck vacuum cleaner is a product of precise engineering. The
motor bearings are permanently lubricated and should not be oiled. If
you require additional information or have problems with your Oreck
appliance, you may call ORECK Commercial Customer Service at:
USA / Canada: 1-800-336-0433
Please specify the model number and serial/code number which can
be found on the data plate on the back of the vacuum.
Save your sales or purchase slip. Should your Oreck appliance
require warranty service in the U.S.A., present this slip to the Authorized
Service Center as your proof of purchase date or, in Canada, call
customer service.
Grounding Instructions (Compacto 9 model)
This appliance must be grounded. If it should malfunction or break
down, grounding provides a safe path of least resistance for electrical
current, reducing the risk of electric shock. The cord for this
appliance has an equipment-grounding conductor and a grounding
plug. It must only be plugged into an electrical outlet that is properly
installed and grounded in accordance with all local codes and
ordinances. Do not modify plug provided with appliance.
DANGER: Improper connection of the equipment-grounding
conductor can result in a risk of electrical
Grounding Pin
shock. Check with a qualified electrician
or service person if you are in doubt as
to whether the outlet is grounded.
If not, have a proper outlet installed
Grounded Outlet
by a qualified electrician.
This appliance is for use on a nominal 120-volt circuit. It has a
grounding plug similar to the example shown. Make sure the
appliance is connected to an outlet with the same configuration
as the plug. No adapter should be used with this appliance.
Servicing of Double-Insulated Appliances
SAVE THESE INSTRUCTIONS
(Compacto 6 model)
A double-insulated appliance is marked with one or more of the
following: The words “DOUBLE INSULATION” or “DOUBLE
INSULATED” or the double-insulation symbol (
). In a doubleinsulated appliance, two systems of insulation are provided instead
of grounding. No grounding means is provided on a double-insulated
appliance, nor should a means for grounding be added to the
appliance. Servicing a double-insulated appliance requires extreme
care and knowledge of the system and should be done only by
qualified service personnel. Replacement parts for a double-insulated
appliance must be identical to the parts they replace.
For Commercial Use
2
Parts List
To assist you in identifying components of your vacuum, the parts
have been numbered as follows:
1.
2.
3.
4.
5.
6.
7.
8.
9.
10.
11.
12.
13.
14.
15.
16.
17.
18.
19.
20.
21.
22.
Latch
Disposable Exhaust Filter
Cord Hooks
Cord Strain Relief
Crevice Tool Holder
Normal Use / Quiet Mode (Compacto 9 model)
On / Off Switch
Handle
Power Cord
Intake
Crevice Tool
Dual Purpose Nozzle (Compacto 9 model)
Carpet Nozzle
Upholstery Tool
Dusting Brush
Telescopic Wand
Suction Control
Hose Assembly
Bare Floor Nozzle (Compacto 6 model)
Carpet Height Adjustment (Compacto 9 model)
Motor Inlet Filter (not shown)
Paper Filter Dust Bag (not shown)
2
3
4
1
11
5
Compacto 9
6
8
7
Compacto 6
19
9
10
18
20
12
13
17
16
15
3
14
Assembly
Using the Extension Wand & Accessory Tools
1. Ensure the power cord is
resting in the cord strain
relief.
Extension Wand: Insert the
nozzle firmly into the large end
of the extension wand. To extend
the wand, push the button on
the wand forward and pull the
extension out to the desired
length (fig 5).
1
Should the power cord come
loose from the cord strain
relief reattach it to preserve
the life of the power cord.
To reattach the cord strain
relief, grasp the power cord
4 - 5 inches from the unit.
Pinch power cord together
and slide approximately
1 - 2 inches through hole in
cord strain relief. Carefully
slide power cord over clamp
on the cord strain relief and
pull excess until the power
cord is seated under clamp
(fig 1).
Cord Strain Relief
5
Accessory Tools: The accessory tools can be used either with
or without the extension wand.
To attach an accessory tool with
the extension wand, firmly slide
the small end of the extension
wand directly into the desired
accessory tool. To attach an accessory tool without the extension
wand, firmly slide the nozzle directly into the desired accessory tool.
Clamp
2
For Easy Power Cord Storage
In order to extend the life of the power cord and prevent fracture, grasp
the cord close to the unit and roll the cord from the machine outwards.
When finished, hang the power cord on the cord hooks (fig 6).
2. Insert the hose into the
intake and turn clockwise to
lock hose in place (fig 2).
6
Operating Instructions
Make sure disposable paper filter dust bag is in place. DO NOT operate the
cleaner without a paper filter dust bag. Plug the power cord into an electrical
outlet and press the “On” switch located on top of the unit.
High-Low Switch
This machine is equipped with a normal mode/quiet use switch.
You can use it to control the speed of the suction motor.
SWITCH
SPEED
ACTION
Quiet Mode
Quiet Mode
Noise Reduction
Suction Reduction
Normal Use
Normal
Increase Noise
Increase Suction
Operating Recommendations
1. When inserting a new disposable paper filter dust bag–FIRST
PUFF OUT and OPEN THE BAG.
2. When the disposable filter dust bag is full, REPLACE IT.
3. If at any time the unit does not pick up properly or makes an
unusual noise, STOP OPERATION and service.
4. Although your vacuum will pick up pins, paper clips, and other
small objects, it is recommended that these be removed from the
floor before you vacuum. Failure to do so may result in permanent
damage to the unit.
5. WARNING: Do not use your vacuum cleaner on damp or wet
surfaces. This will cause damage to the vacuum cleaner and is
dangerous to the user. Damage caused by use on wet or damp
surfaces is not covered under warranty.
6. Change the disposable filter dust bag at least once a month–even
if it is not full! The collected dust in the dust bag can cause odor,
attract moisture, and can affect the efficiency of the cleaner.
7. DO NOT run the vacuum cleaner over the cord.
8. Use caution when vacuuming over area rug edges & fringe.
Removing & Replacing the Disposable Dust Filter Bag
1. Release latch on the side of
the unit and remove the top
cover (fig 3).
3
2. Remove hose from intake.
Fold ends of filter bag
together and pull cardboard
tag to automatically close
the bag (fig 4).
4
3. Insert a new filter bag by
sliding the cardboard collar
into the slots located on the
dock until bag is fully
inserted.
4. Replace hose and top cover
and fasten latch.
4
General Information
Replacing and Cleaning the Motor Filter
The performance of your new vacuum cleaner greatly depends upon
care and maintenance. The instructions in this manual will guide you
in performing basic care and maintenance. To obtain the most satisfying
years of service read the instructions and keep them handy for future
reference.
WARNING: Unplug cord from electrical
outlet before servicing.
Compacto 6 model: Slide
permanent motor filter off housing
and vacuum the filter as needed
to prevent blockages and clogs
(fig 8). Replace the filter by
aligning the four notches in the
motor filter with the four notches
in the motor housing and pushing
the motor filter down until it is
completely resting on the motor
housing. Note: DO NOT wet or
soak motor filter to clean;
damage to the unit may occur.
Disposable Paper Filter Dust Bags
Disposable paper filter dust bags play a very important role in the
efficiency of your ORECK vacuum cleaner. The purpose of the filter
bag is to trap dirt, but at the same time it must be porous enough to
allow air to pass through. If the filter bag becomes clogged, no air
can pass through the cleaner and cleaning cannot take place,
regardless of the cleaner’s power.
To keep your cleaner operating at maximum efficiency, change the
dust bag frequently.
Be sure the disposable paper filter dust bag is installed properly.
All paper dust bags are not the same. Your ORECK disposable
dust bags have been designed to be used with the ORECK
cleaner. Using bags other than genuine ORECK disposable bags
will affect the cleaning ability of your cleaner and could cause
damage to it.
8
9
Compacto 9 model: Slide
disposable motor filter off housing
and replace with a NEW filter
(fig 9).
IMPORTANT: Do not use the
unit if motor filter is not installed;
damage to the unit may occur.
General Cleaner Care
At least once a month, check the disposable exhaust filter and
motor filter for clogs. If the filters become clogged, no air can pass
through the cleaner and cleaning cannot take place, regardless of
the cleaner’s power. See “Replacing the Exhaust Filter” and “Replace
and Cleaning the Motor Filter”.
Also wipe the outside of the cleaner with a damp cloth. A little
preventative maintenance will keep your cleaner looking new and
will ensure continued cleaning effectiveness.
Overheating
The temperature of the suction motor is measured constantly. If the
temperature becomes too high, the sensor will switch off the suction
motor. Check whether the suction system is blocked. The sensor will
be automatically switched on again after the sensor and the motor
have cooled down sufficiently. You can now start to use the machine
again.
Troubleshooting Guide
WARNING: Unplug cord from electrical outlet
before servicing.
Replacing the Exhaust Filter
Problem
Vacuum motor is off
WARNING: Unplug cord from electrical
outlet before servicing.
1. Remove and dispose
exhaust filter cartridge from
vacuum cleaner (fig 7).
Note: Compacto 9 models
have a locking mechanism
that must be unlocked
before the exhaust filter
cartridge can be removed.
2. Slide new exhaust filter
cartridge in vacuum cleaner.
7
Possible Source
Not plugged in properly.
No electricity in wall
outlet.
Switch in “off” position.
Sensor temperature
too high.
Low suction
Dust bag full.
Hose not installed
properly
Areas To Check
Be sure plug is firmly
plugged into wall
outlet.
Check electrical
source (fuse or circuit
breaker).
Position switch to “on”
position.
Check for air
obstruction. Let the
motor cool down.
Replace dust bag.
See “Removing and
Replacing Dust Bag”.
Re-install hose.
ALL OTHER SERVICING SHOULD BE DONE BY AN
ORECK AUTHORIZED SERVICE CENTER.
FOR SERVICE CALL
USA / Canada: 1-800-336-0433
5
Whenever calling, please be sure to have your model and serial
number from data plate.
Warranty
Replacement Parts (Sold Separately)
ORECK MANUFACTURING COMPANY: (Oreck Manufacturing
Company gives you the following limited warranty for this product
only if it was originally purchased for commercial use, not resale,
from Oreck or an Oreck Authorized Retail Dealer.)
ITEM
1. Paper Filter Dust Bag (25 pack),
Compacto 6 Model
PK25COMP6DW
2. Paper Filter Dust Bag (25 pack),
Compacto 9 Model
PK25COMP9DW
Oreck will repair or replace, free of charge, to the original purchaser,
any part that is found to be defective in material or workmanship within
one (1) year. This limited warranty applies to commercial use.
USA / Canada: 1-800-336-0433
Drive belts, disposable bags, and other parts subject to normal wear
are not covered by this limited warranty.
This limited warranty does not apply to any part subjected to accident,
abuse, alteration, misuse, damage caused by fire or act of God, or
the use of voltages other than indicated on the serial number plate of
this product or service of this product by other than Oreck or an
Oreck Factory Authorized Service Center.
Oreck does not authorize any person or representative to assume or
grant any other warranty obligation with the sale of this product.
Oreck’s limited warranty is valid only if you retain proof of purchase
from Oreck or an Oreck Authorized Retail Dealer for this product. If
you purchase this product from any other source, your purchase is
“AS IS,” which means Oreck grants you no warranty, and that you,
not Oreck, assume the entire risk of the quality and performance of this
product, including the entire cost of any necessary servicing or repairs
of any defects.
Oreck’s liability for damages to you for any costs whatsoever arising
out of this statement of limited warranty shall be limited to the amount
paid for this product at the time of original purchase. Oreck shall not
be liable for any direct, indirect, consequential or incidental damages
arising out of the use or inability to use this product.
Some states do not allow the exclusion or limitation of incidental or
consequential damages, so the above limitation or exclusion may not
apply to you.
ALL EXPRESSED AND IMPLIED WARRANTIES FOR THIS
PRODUCT, INCLUDING IMPLIED WARRANTIES OF
MERCHANTABILITY AND FITNESS FOR A PARTICULAR
PURPOSE, ARE LIMITED IN DURATION TO THE WARRANTY
PERIOD, AND NO WARRANTIES, WHETHER EXPRESS OR
IMPLIED, WILL APPLY AFTER THIS PERIOD.
Some states do not allow limitations on the duration of implied
warranties, so the above limitation may not apply to you.
This warranty gives you specific legal rights, and you may also have
other rights which vary from state to state.
6
PART #
7
40372-01 REV B
08/06 ECN# R-8472
©2006 Oreck Holdings, LLC. All rights reserved. All word marks, logos, product configurations, and registered
trademarks are owned and used under the authority of Oreck Holdings, LLC. Printed in America.
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertising