Mobile Generator – MMG45FHK Specifications

Mobile Generator – MMG45FHK Specifications
Mobile Generator – MMG45FHK Specifications
ENGINE











Kubota® V3600-T-E3BG - turbocharged, diesel engine
o Prime - 53 hp @ 1800 rpm
o Standby - 58 hp @ 1800 rpm
o 4 cylinder
o 3.6 L displacement
o Interim Tier IV approved
Steel, single wall fuel tank
o 106 gal. capacity
o 31 hr. run time – full load
o Fuel tank built into skid of generator set
Fuel consumption at prime:
o 100% - 3.0 gph (11.4 Lph)
o 75% - 2.3 gph (8.7 Lph)
o 50% - 1.5 gph (5.7 Lph)
Cooling system capable of operating at 120°F ambient
Low coolant shutdown
Radiator and oil drains plumbed to exterior
Rubber vibration dampers isolate engine/generator from frame
Disposable air filter - paper element
Air filter restriction indicator mounted on control panel
60 Hz engine/generator
Electronic isochronous governing
45
ww
w
m
-p
-llc
co
m
Trailer Sold Separately
GENERATOR


Marathon Electric®
o Brushless
o 4 pole
o Class H insulation
Voltage regulation +/- 1% with Marathon SE350 Voltage Regulator
SYSTEM OUTPUT





3 position selector switch
o Single phase – 120 / 240V Zig Zag
o Three phase – 120 / 208V Low Wye
o Three phase – 277 / 480V High Wye
33 kW / 33 kVA – standby, single phase
30 kW / 30 kVA – prime, single phase
35 kW / 44 kVA – standby, three phase
33 kW / 41 kVA – prime, three phase
SYSTEM CONTROLS

Microprocessor-based controller
o Backlit, 128x64 pixel resolution display
o -40°F to 185°F operating temperature range
o Thermostatically controlled LCD heater
Manufactured by Magnum Power Products LLC., a wholly owned subsidiary of Generac Power Systems, Inc.
Phone: 800-926-9768 Fax: 920-361-2214 www.m-p-llc.com
Page 1 of 5
4/12
MG45FHK Generac Specifications Continued:
Six LED indicators w/ lamp test
 Alarm / Fault (Red)
 Ready / Manual (Red)
 Running (Green)
 Warning (Yellow)
 Ready / Auto (Green)
 Supplying Load (Green)
Push buttons for easy operation
o Manual or Auto Start
o Engine Start or Stop
o Alarm Cancel & Fault Reset
o Scrolling Arrows for Diagnostic Information
 System kW output display
 Line output & frequency display
 Engine diagnostic display
 Oil pressure
 Engine temperature
 Fuel level
 Battery
 System hours
 Running hours
 kW hours
 Time to service
o Alarm list – warnings / shutdowns are date & time stamped
 Fuel level: warning – 15%; shutdown – 5%
 Overspeed protection: shutdown – 115%
 Oil pressure: warning – 25 psi; shutdown – 20 psi
 Coolant temperature: warning – 220°F; shutdown – 230°F
 Battery voltage: over – 15VDC; under – 11VDC
 Generator over voltage: warning – 110%; shutdown – 111%
 Generator under voltage: warning – 87%; shutdown – 86%
 Generator over frequency: warning – 105%; shutdown – 110%
 Generator under frequency: warning – 95%; shutdown – 90%
 Over current shutdown
o

ELECTRICAL CONTROLS








Remote start / stop contacts located next to lug box
Lockable control box door with diagnostics window
Lockable lug box with safety switch
o Trips main breaker when lug door is opened
o Disables voltage regulator
Cable entry guides to the lug box
o Restricts access of foreign objects
Output ground connection lug inside lug box
200A main breaker with shunt trip
Convenience receptacles with individual breakers (restricted use in high wye mode)
o (2) 120V 20 Amp GFCI duplex outlets (Nema 5-20R type)
o (2) 125 / 250V 50 Amp, 3 pole, 4 wire twistlock (Non-Nema 6369)
Panel mounted rheostat for voltage adjustment - +/- 10%
Manufactured by Magnum Power ProductsLLC., a wholly owned subsidiary of Generac Power Systems, Inc.
Phone: 800-926-9768 Fax: 920-361-2214 www.m-p-llc.com
Page 2 of 5
4/12
MG45FHK Generac Specifications Continued:

720 CCA wet cell battery
ENCLOSURE








Generac Mobile Power decals
“Flip-Hood” Patented design - aluminum, sound attenuated enclosure
o Easy access for daily maintenance
o Centralized location for all electrical connections/wiring
o UV & fade resistant, high temperature cured, white polyester powder paint
o Insulated and baffled
o 68 dB(A) at 23 feet – prime power
Fully lockable enclosure including doors and fuel fill
Stainless steel hinges on doors
Emergency stop switch located on outside of enclosure
Central lifting point
Multi-lingual operating/safety decals
Document holder with operating manual including AC/DC wiring diagrams
TRAILER








“Flip-Tongue” design
DOT approved tail, side, brake, and directional lights
o Recessed rear lights
Transportation tie downs
Safety chains with spring loaded safety hooks
2” ball hitch
5000 lb. axle with surge brakes
3000 lb. tongue jack with footplate
P205/75R15 tubeless tires – 8 ply
WEIGHTS & DIMENSIONS
Skid mounted
 Dry weight: 2329 lbs (1056 kg)
 Operating weight: 3082 lbs (1398 kg)
 95 x 35 x 52 in
(2.41 x 0.89 x 1.32 m)
Trailer mounted
 Dry weight: 2853 lbs
(1294 kg)
 Operating weight: 3606 lbs
(1636 kg)
 150 x 57 x 67 in
(3.81 x 1.45 x 1.70 m)
WARRANTY

Engine and generator covered under OEM warranty – consult factory for details.
CERTIFICATIONS

CSA certified
Manufactured by Magnum Power ProductsLLC., a wholly owned subsidiary of Generac Power Systems, Inc.
Phone: 800-926-9768 Fax: 920-361-2214 www.m-p-llc.com
Page 3 of 5
4/12
MG45FHK Generac Specifications Continued:
MMG45FHK Options
ENGINE OPTIONS


In-line engine block heater (Kim Hotstart)
Fuel transfer pump
ELECTRICAL CONTROLS OPTIONS



720 CCA gel cell battery
Battery disconnect
Battery charger – 2A trickle
GENERATOR OPTIONS


PMG Generator - critical grade power quality
Super Start Generator - motor starting applications
VOLTAGE OUTPUT OPTIONS




4 position phase switch
 Single phase – 120 / 240V High Wye
 Three phase – 120 / 208V Low Wye
 Three phase – 277 / 480V Zig Zag
 Three phase – 120 / 240V Delta
Dedicated voltage configurations
Buck Transformer kit – Provides 120V at GFCI outlets when in 277/480V
Cam locks
SYSTEM CONTROLS OPTIONS


Analog gauges
Auxiliary strobe/audible indication for soft & hard alarm conditions
COOLANT OPTIONS

60/40 Coolant - cold weather applications
ENCLOSURE OPTIONS



Fire extinguisher
Interior cabinet light
Control panel light
FUEL TANK OPTIONS



36 hr. single wall fuel tank (requires tandem axle trailer)
29 hr. double wall fuel tank
120% Containment
Manufactured by Magnum Power ProductsLLC., a wholly owned subsidiary of Generac Power Systems, Inc.
Phone: 800-926-9768 Fax: 920-361-2214 www.m-p-llc.com
Page 4 of 5
4/12
MG45FHK Generac Specifications Continued:
TRAILER OPTIONS





Single axle trailer w/ electric brakes
Tandem axle trailer w/ surge brakes
Tandem axle trailer w/ electric brakes
6 pin or 7 spade electrical connectors
Spare tire/wheel kit
HITCH OPTIONS



3” lunette ring
2 5/16” ball
Adjustable height options:
 2” ball
 2 5/16” ball
Manufactured by Magnum Power ProductsLLC., a wholly owned subsidiary of Generac Power Systems, Inc.
Phone: 800-926-9768 Fax: 920-361-2214 www.m-p-llc.com
Page 5 of 5
4/12
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertising