Outdoor LP Gas Barbecue Grill
OWNER’S MANUAL
Outdoor LP Gas Barbecue Grill
Model No. PR7000
WARNING
Table of Contents
FOR YOUR SAFETY:
For Outdoor Use Only
(outside any enclosure)
Important Safeguards . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Page 2
Exploded View & Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
Assembly Instructions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
WARNING
FOR YOUR SAFETY:
1. Improper installation, adjustment, alteration,
service or maintenance can cause injury or
property damage.
2. Read the installation, operation, and
maintenance instructions thoroughly before
installing or servicing this equipment.
3. Failure to follow these instructions could
result in fire or explosion, which could cause
property damage, personal injury, or death.
Installling LP Gas Tank . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Insert LP Gas Tank. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Secure LP Gas Tank. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Connect LP Gas Tank. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Operating Instructions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Checking for Leaks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Operating Main Burners . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Operating Side Burner . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Cleaning and Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Product Registration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Limited Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Save these instructions for future reference.
If you are assembling this unit for someone else,
give this manual to him or her to read and save
for future reference.
Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
The use and installation of this product must conform to local codes. In absence of
local codes, use the National Fuel Gas Code, ANSI Z223.1/NFPA 54, CAN/CGA-B149.1,
Natural Gas and Propane Installation Code.
Manufactured in China for:
S.R. Potten Ltd
1645, 50th Avenue
Lachine, Québec, Canada H8T 3C8
PR7000-OM-109 EF
Outdoor LP Gas Barbecue Grill Model No. PR7000
DANGER
WARNING
FOR YOUR SAFETY
If you smell gas 1. Shut off gas to appliance.
2. Extinguish any open flame.
3. Open lid.
4. If odor continues, keep away from the appliance immediately call your
gas supplier or your fire department.
1. Do not store or use gasoline or other flammable liquids or vapors in the
vincinity of this or any other appliance.
2. An LP cylinder not connected for use shall not be stored in the vicinity
of this or any other appliance.
DANGER: Failure to follow the dangers, warning and cautions in this manual may result in serious bodily injury or death, or in a fire or an explosion
causing damage to property.
WARNING:
This grill is for outdoor use only, and shall not be used in a building,
It is essential to keep the grill’s valve compartment, burners, and
garage, or any other enclosed area.
circulating air passages clean. Inspect grill before each use.
Do NOT operate, light or use this appliance within 8 feet of walls,
Do not alter grill in any manner.
structures or buildings.
Do not use the grill unless it is COMPLETELY assembled and all parts are
This grill is NOT for commercial use.
securely fastened and tightened.
This grill is for use with liquid propane (LP) gas only. The conversion to
This grill should be thoroughly cleaned and inspected on a regular basis.
or attempted use of natural gas in this LP gas grill is dangerous and will
Clean and inspect the hose before each use of the appliance. If there
void your warranty.
is evidence of abrasion, wear, cuts, or leaks, the hose must be replaced
prior to the appliance being put into operation.
LP gas Characteristics:
a. LP gas is flammable and hazardous if handled improperly. Become
Use only the regulator and hose assembly provided. The replacement
aware of the characteristics before using any LP gas product.
regulator and hose assembly shall be that specified by the manufacturer.
b. LP gas is explosive under pressure, heavier than air, and settles and
Use only S.R. Potten, Ltd. factory authorized parts. The use of any part
pools in low areas.
that is not factory authorized can be dangerous. This will also void your
c. LP gas in its natural state has no odor. For your safety, an odorant is
warranty.
added that smells like rotten cabbage.
Do not use this appliance without reading “Operating Instructions” in this
d. Contact with LP gas can cause freeze burns to skin.
manual.
LP gas tank needed to operate. Only tanks marked “propane” may be
Do not touch metal parts of grill until it has completely cooled (about 45
used.
min.) to avoid burns, unless you are wearing protective gear (pot holders,
a. The LP gas supply tank must be constructed and marked in accordance
gloves, BBQ mittens, etc.).
with the Specifications for LP gas Cylinders of the U.S. Department of
When cooking, fire extinguishing materials shall be readily accessible. In
Transportation (DOT) or the National Standard of Canada, CAN/CSAthe event of an oil grease fire, do not attempt to extinguish with water.
B339, Cylinders, Spheres and Tubes for the Transportation of Dangerous
Use type BC dry chemical fire extinguisher or smother with dirt, sand or
Goods; and Commission.
baking soda.
b. LP gas tank must be arranged for vapor withdrawal.
Do not install or use in or on boats or recreational vehicles.
c. The LP gas tank must have a listed overfilling prevention device (OPD).
Do not use grill in high winds.
d. Only use 20-pound cylinders equipped with a cylinder connection
Never lean over the grill when lighting.
device compatible with the connection for outdoor cooking appliances.
Do not leave a lit grill unattended, especially keep children and pets away
e. The LP gas tank must have a tank collar to protect the tank valve.
from grill at all times.
f. Never use an LP gas tank with a damaged body, valve, collar, or footing.
Do not attempt to move grill when in use. Allow the grill to cool before
g. Dented or rusted LP gas tanks may be hazardous and should be
moving or storing.
checked by your LP gas supplier prior to use.
Storage of grill indoors is permissible only if the tank is disconnected,
h. The LP gas tank should not be dropped or handled roughly.
removed from the grill and properly stored outdoors.
i. Tanks must be stored outdoors out of the reach of children and must
Always open grill lid carefully and slowly as heat and steam trapped
not be stored in a building, garage, or any other enclosed area. Your
within grill can severely burn you.
tank must never be stored where temperatures can reach over 125°F.
Do not attempt to disconnect the gas regulator from the tank or any gas
j. Never keep a filled LP gas tank in a hot car or car trunk. Heat will cause
fitting while the grill is in use.
the gas pressure to increase, which may open the relief valve and allow
Always place your grill on a hard non-combustible, level surface. An
gas to escape.
asphalt or blacktop surface may not be acceptable for this purpose.
k. Place dust cap on cylinder valve outlet whenever the cylinder is not in
Move gas hoses as far away as possible from hot surfaces and dripping
use. Only install the type of dust cap on the cylinder valve outlet that
hot grease.
is provided with the cylinder valve. Other types of caps or plugs may
Keep all electrical cords away from a hot grill.
result in leakage of propane.
Do not use grill for indoor cooking or heating. TOXIC fumes can
l. Do not store a spare LP gas tank under or near this appliance.
accumulate and cause asphyxiation.
m. Never fill the tank beyond 80 percent full.
After a period of storage and/or nonuse, check for leaks, burner
n. A fire causing, serious injury or damage to property may occur if the
obstructions and inspect for any abrasion, wear, cuts to the hose.
above is not followed exactly.
Failure to open lid while igniting the grill’s burners, or not waiting 5
Never attempt to attach this grill to the self-contained LP gas system of a
minutes to allow the gas to clear if the grill does not light, may result in
camper trailer, motor home, or house.
an explosive flame-up.
The use of alcohol, or prescription or non-prescription drugs may
If grill is not in use, the gas must be turned off at the supply tank.
impair the consumer’s ability to properly assemble or safely operate the
Never operate grill without heat plates installed.
appliance.
Always use a meat thermometer to ensure food is cooked to a safe
Never use charcoal, lighter fluid, lava rocks, gasoline, kerosene, or
temperature.
alcohol with this product.
This outdoor gas appliance and its individual shutoff valve must be
Your grill has been checked at all factory connections for leaks. Recheck
disconnected from the gas supply piping system during any pressure
all connections, as movement in shipping can loosen connections.
testing of that system at test pressures in excess of 0.5 psi (3.5 kpa).
Check for leaks even if your unit was assembled for you by someone
This outdoor gas appliance must be isolated from the gas supply piping
else.
system by closing its individual manual shutoff valve during any pressure
Do not operate if gas leak is present. Gas leaks may cause a fire or
testing of the gas supply piping system at test pressures equal to or less
explosion.
than 0.5 psi (3.5 kpa).
You must follow all leak-checking procedures before operating. To
Keep any electrical supply cord and the fuel supply hose away from any
prevent fire or explosion hazard when testing for a leak:
heat surface.
a. Always perform leak test before lighting the grill and each time the
To protect against electric shock, do not immerse cord or plugs in water
tank is connected for use.
or other liquid.
b. No smoking. Do not use or permit sources of ignition in the area while
Unplug from the outlet when not in use and before cleaning, Allow to cool
conducting a leak test.
before putting on or taking off parts.
c. Conduct the leak test outdoors in a well-ventilated area.
Do not operate any outdoor cooking gas appliance with a damaged cord,
d. Do not use matches, lighters, or a flame to check for leaks.
plug, or after the appliance malfunctions or has been damaged in any
e. Do not use grill until any and all leaks are corrected.
manner. Contact the manufacture for repair.
If you are unable to stop a leak, disconnect the LP gas supply. Call a
Do not let the cord hang over the edge of a table or touch hot surface.
gas appliance serviceman or your local LP gas supplier.
Do not use an outdoor cooking gas appliance for purposes other than
Do not store or use gasoline or other flammable liquids or vapors within
intended.
25 feet (7.62 m) of this appliance.
When connecting, first connect plug to the outdoor cooking gas appliance
then plug appliance into the outlet.
Do not use in an explosive atmosphere. Keep grill area clear and free
from combustible materials, gasoline and other flammable vapors and
Use only a Ground Fault Interrupter (GFI) protected circuit with this
liquids.
outdoor cooking gas appliance.
Minimum clearance from sides and back of unit to combustible
Never remove the grounding plug or use with an adapter of 2 prongs;
construction, 21 inches from side and 21 inches from back. Do not use
and Use only extension cords with a 3 prong grounding plug, rated for
this appliance under overhead combustible surfaces.
the power of the equipment, and approved for outdoor use with a W-A
marking.
page no.
3
Contact 1.800.667.7313 for assistance. Do not return to place of purchase.
Parts List
Exploded View
1
Lid Assembly
2
Heat Plate Support (2)
3
Body Assembly
4
Warming Rack
5
Cooking Grid (3)
6
Heat Plate
7
Main Burner Control Knob (3)
8
Ignitor Button
1
9
Regulator and Hose Assembly
10
Left Side Shelf
11
Side Burner Grid
12
Left Condiment Holder
13
Grease Cup
14
Hose Clip
7
2
5
10
6
15
9
12
Grease Cup Support
16
Back Cart Support
17
Side Burner
18
Right Side Shelf Assembly
19
Front Cart Support
20
Right Cart Frame
21
Left Cart Frame
22
Right Condiment Holder
23
Side Burner Control Knob Ring
24
Side Burner Control Knob
25
Cart Shelf
26
Left Door
27
Tank Retainer Wire
28
Right Door
29
Lighting Hook
30
Door Magnet
31
Basket
32
Axle
33
Bottom Shelf
34
Leg (2)
35
Hub Cap (2)
36
Wheel (2)
17
13
18
19
21
20
26
22
25
27
28
24
29
23
30
31
32
33
34
36
34
36
35
Hardware
Tools Required for Assembly (Included)
Screw
M4x10 Zinc Plated Phillips Truss Head
3 pcs
Screw
M5x10 Zinc Plated Phillips Truss Head
19 pcs
Screw
M6x16 Zinc Plated Phillips Truss Head
2 pcs
Screw
M6x16 Zinc Plated Phillips Truss Head
22 pcs
Nut
M5 Nickel Plated
4 pcs
Nut
M10 Zinc Plated
2 pcs
Washer
ø4.3 Zinc Plated
2 pcs
Washer
ø5.4 Zinc Plated
18 pcs
Washer
ø6.4 Zinc Plated
18 pcs
Washer
ø6.4 Heat Resistant
4 pcs
Lock Washer
ø4.1 Zinc Plated
2 pcs
Lock Washer
ø5.1 Zinc Plated
18 pcs
Lock Washer
ø6.1 Zinc Plated
18 pcs
Rubber Spacer
ø10.5 x ø17 x 6
AA Battery
11
14
16
8
15
A
B
C
D
E
F
G
H
I
J
K
L
M
N
O
4
3
2 pcs
1 pc
#2 Phillips Head Screwdriver
M5 x M10 Wrench
35
Outdoor LP Gas Barbecue Grill Model No. PR7000
Assembly Instructions
DO NOT RETURN PRODUCT TO STORE.
For assistance call 1.800.667.7313 toll free. Please have your owner’s manual and serial
number available for reference.
1
Assemble Cart Frame
For Easiest Assembly:
• To avoid losing any small components or hardware, assemble your product on a hard level
surface that does not have cracks or openings.
2
Attach Feet, Wheels and Hub Caps
B
E
B
x8
H
L
5
x4
F
H
L
x4
x4
x2
N
x4
x4
x4
x8
6
L
H
x8
Attach Cart Shelf
B
x4
Attach Doors And Basket
x2
page no.
5
Contact 1.800.667.7313 for assistance. Do not return to place of purchase.
• Clear an area large enough to layout all components and hardware.
• When applicable, tighten all hardware connections by hand first. Once the step is completed,
go back and fully tighten all hardware.
3
Assemble Back Cart Support
• Follow all steps in order to properly assemble your product.
4
Attach Front Cart Support and Door Magnet
B
D
x2
I
M
7
H
x2
8
x1
I
M
I
x1
x1
x5
x5
L
Assemble Left Side Shelf
D
D
x2
x2
x2
M
x2
x5
Assemble Right Side Shelf
D
x1
I
M
x1
x1
Outdoor LP Gas Barbecue Grill Model No. PR7000
Assembly Instructions (continued)
9
Attach Side Shelves
10
Attach Grill Body And Attach Heat Plate Supports
C
D
x8
I
M
13
x2
D
x4
M
x4
Insert Heat Plate
14
I
x4
J
x4
x4
x4
Attach Grease Cup and Grease Cup Support
Insert Cooking Grids and Warming Rack
O
x1
page no.
7
Contact 1.800.667.7313 for assistance. Do not return to place of purchase.
11
Attach Side Burner Control Knob Ring, Side Burner
Control Knob, Hose Clip, Main Burner Control Knob
A
x1
B
x1
D
15
I
M
12
Attach Side Burner And Side Burner Grid
x1
x1
x1
Attach Grease Cup and Grease Cup Support
A
x2
G
K
x2
x2
Outdoor LP Gas Barbecue Grill Model No. PR7000
Installing LP Gas Tank
To operate you will need (1) precision-filled standard grill LP gas
tank (20#) with external valve threads.
Operating Instructions
Checking for Leaks
LP Gas
Connection
Burner
venturi
Burner Connections
Insert LP Gas Tank
Place precision filled LP gas tank upright into hole in grill body so it is arranged for vapor
withdrawal.
Make sure the regulator valve and hose connections are
securely fastened to the burner and the tank.
If your unit was assembled for you, visually check the
connection between the burner pipe and orifice. Make
sure the burner pipe fits over the orifice.
WARNING
LP Gas Valve
Main Burners with Orifice
FOR YOUR SAFETY:
Failure to inspect this connection or
follow these instructions could cause
a fire or an explosion which can
cause death, serious bodily injury, or
damage to property.
LP Gas
Connection
LP Gas Valve
with Orifice
Please refer to diagram for proper installation.
If the burner pipe does not rest flush to the orifice,
please contact 1.800.667.7313 for assistance.
Tank/Gas Line Connection
Burner
venturi
Side Burner
Make 2-3 oz.a of leak solution by mixing one part liquid
dishwashing soap with three parts water.
Make sure control knobs are off.
X
Turn LP gas tank ON at valve.
Secure LP Gas Tank
Spoon leak check solution at all “x” locations
Secure tank by sliding tank retainer wire over shoulder of LP gas tank.
If any bubbles appear turn LP gas tank OFF, reconnect
and re-test. If you continue to see bubbles after several
attempts, disconnect LP gas source and contact
1.800.667.7313 for assistance.
X
X
X
X
LP Gas Tank Valve
If no bubbles appear after one minute turn tank OFF,
wipe away solution and proceed.
Operating Main Burners
Lighting
1. Open lid. Attempting to light the burner with the lid
closed may cause an explosion!
2. Make sure there are no obstructions of airflow to the
gas unit. Spiders and insects can nest within and clog
the burner / venturi tube at the orifice. A clogged
burner tube can lead to a fire beneath the appliance.
Control Knob
3. All control knobs must be in the OFF position.
4. Turn on gas at LP gas tank.
5. Push and turn control knob c ounterclockwise to HIGH.
6. Press the electronic igniter button and hold for 5
seconds to light burner.
Connect LP Gas Tank
Before connecting, be sure that there is no debris caught
in the head of the LP gas tank, head of the regulator valve
or in the head of the burner and burner ports.
Connect gas line to tank by turning knob clockwise until it
stops.
7. If ignition does not occur in 5 seconds, turn burner
control knob OFF, wait 5 minutes, and repeat lighting
procedure.
8. If igniter does not light burner, use a lit match
secured with the lighting rod provided to light burners
manually. Access the burners through the cooking grid
and heat plates. Position the lit match near side of the
burner.
Main Burner Lighting Rod Insert
Important: Always use the lighting rod provided when
lighting burners with a match.
Disconnect LP Gas Tank
Before disconnecting make sure the LP gas tank valve OFF.
Disconnect gas line to tank by turning knob
counterclockwise until it is loose.
Note: Place dust cap on cylinder valve outlet whenever the
cylinder is not in use. Only install the type of dust cap on
the cylinder valve outlet that is provided with the cylinder
valve. Other types of caps or plugs may result in leakage
of propane.
9. After lighting, observe the burner flame, make sure
all burner ports are lit and flame height matches
illustration.
Caution
If burner flame goes out during
operation, immediately turn the gas
“OFF” and open lid to let the gas clear
for about 5 minutes before re-lighting.
Main Burner Lighting Rod Placement
Flame
Burner
Turning Off
1. Turn gas off at LP tank.
2. Turn all control knobs clockwise to the OFF position.
Slight
Yellow
Slight
Blue
Dark
Blue
Main burner proper flame height.
page no.
9
Contact 1.800.667.7313 for assistance. Do not return to place of purchase.
First Use
1. Make sure all labels, packaging and protective films have been removed from the grill.
2. Remove manufacturing oils before cooking on this grill for the first time, by operating the
grill for at least 15 minutes on “HIGH” with the lid closed. This will “heat clean” the internal
parts and dissipate odors.
Operating Side Burner
NOTE: Side burner can be used while main burners are
operating.
Never use side burner as a grill.
Lighting
Direct Cooking
Cooking directly over hot burners. Ideal for searing in juices and food requiring less than 25
minutes of grilling time, such as steaks, hamburgers, hot dogs, chicken parts, vegetables and
fruit.
1. Open lid. Attempting to light the burner with the lid
closed may cause an explosion!
1. Open lid and ignite the desired amount of burners per lighting instructions in owner’s
manual.
2. Make sure there are no obstructions of airflow to the
gas unit. Spiders and insects can nest within and clog
the burner / venturi tube at the orifice. A clogged
burner tube can lead to a fire beneath the appliance.
2. Close lid and preheat grill on “HIGH”.
3. Control knob must be in the OFF position.
3. Wear protective gloves and use long handle tongs to place food onto cooking grids above
the lit burners.
4. Turn on gas at LP gas tank.
4. Adjust controls to desired temperature.
5. With lid open or closed, cook until desired internal food temperatures are achieved.
6. Press the electronic igniter button and hold for 5
seconds to light burner.
6. Turn grill OFF by first closing the valve on the propane tank. Burn off remaining gas in lines
by waiting 15 seconds then turn all burner controls to the OFF position. A “poof” sound is
normal as the last of the LP gas is burned.
7. If ignition does not occur in 5 seconds, turn burner
control knob OFF, wait 5 minutes, and repeat lighting
procedure.
Indirect Cooking
Not cooking directly over hot burners. Ideal for slow cooking and foods requiring more than 25
minutes such as most roasts, loins, chops, whole chickens, turkey, fish and baked goods.
8. If igniter does not light burner, use a lit match
secured with the lighting rod provided to light burners
manually. Position the lit match near side of the
burner.
1. Open lid and ignite the desired amount of burners per lighting instructions in owner’s
manual.
Important: Always use the lighting rod provided when
lighting burners with a match.
2. Close lid and preheat grill on “HIGH”.
9. After lighting, please observe the burner flame, make
sure all burner ports are lit and flame height matches
illustration.
3. Wear protective gloves and use long handle tongs to place food onto cooking grids above
the un-lit burners.
4. Adjust controls to desired temperature.
5. With lid closed, cook until desired internal food temperatures are achieved.
6. Turn grill OFF by first closing the valve on the propane tank. Burn off remaining gas in lines
by waiting 15 seconds then turn all burner controls to the OFF position. A “poof” sound is
normal as the last of the LP gas is burned.
For more tips on indirect cooking please see “Tips for Better Cookouts and Longer Grill Life”
Flame
Slight
Yellow
Slight
Blue
Burner
Dark
Blue
Side burner proper flame height.
5. Push and turn control knob counterclockwise to HIGH.
Control Knob
CAUTION: If burner flame goes out during operation,
immediately turn the gas “OFF” and open lid to let the
gas clear for about 5 minutes before re-lighting.
Side Burner Lighting Hook Placement
Turning Off
1. Turn gas off at LP gas tank.
2. Turn control knob clockwise to the OFF position.
Tips for Better Cookouts and Longer Grill Life
1. Use the upper cooking grid (warming rack) for keeping cooked food warm, toasting breads
or cooking delicate foods in aluminum foil pouches.
2. Use the side burner of this appliance like a normal kitchen range for boiling, sautéing or
frying.
Note: A “poof” sound is normal as the last of the LP gas
is burned.
Cooking
1. Light burner.
3. To keep food from sticking to the grids, spray or coat with cooking oil before lighting.
2. Set burner to desired temperature
4. To reduce flare-up keep grill clean, use lean cuts of meat (or trim fat) and avoid cooking on
very high temperatures.
3. Place pan on center of grid.
4. Cook and adjust temperature as needed.
5. Place delicate foods like fish and vegetables in aluminum foil pouches and indirect cook or
place on upper cooking levels (warming rack).
Burner Flame Conditions
Caution
8. When in-direct cooking roasts and larger cuts of meat, place meat onto a roasting rack
inside a heavy gauge metal pan. Place pan over the un-lit burners.
1. All cleaning and maintenance should
be done when grill is cool and with
the fuel supply disconnected.
9. Try water pans to reduce flare-ups and cook juicer meats. Before starting grill remove
cooking grids and place a heavy duty shallow pan directly on heat plates. Fill half way with
water, fruit juices or other flavored liquids. Replace cooking grids and position food over the
loaded pan.
2. DO NOT clean any grill part in a self
cleaning oven. The extreme heat will
damage the finish.
10. Enhance food flavors by using wood chips in smoker boxes or aluminum foil pouches.
Follow the wood manufacturer’s instructions.
11. Rotisseries, grill baskets, vertical poultry holders and other accessories can enhance your
experiences, reduce cooking times and aid in clean-up.
12. Clean cooking grids and racks after every use with a quality grill bush designed for your
grid material. Wear protective gloves and gently remove the build-up while grids are hot.
13. After every use, allow grill to cool. Then protect clean cooking grids with a light coat of
cooking oil, empty grease pan, wipe outside surfaces with a suitable kitchen cleaner and
protect surfaces with a quality cover that is properly fits your grill.
Notices
Use this chart check to see if your
burners need to be cleaned.
1-2 in. /
25.4 - 50.8 mm
7. When direct cooking adjust your burners to different levels so foods can be prepared to
different internal temperatures in the same time frame.
Cleaning and Care
1-2 in. /
25.4 - 50.8 mm
6. To avoid losing natural juices, use long handled tongs or spatulas instead of forks and turn
foods over just once during cooking.
Normal: Soft blue flames with
yellow tips between 1 in. - 2 in.
hight.
1. This grill should be thoroughly cleaned and
inspected on a regular basis.
2. Abrasive cleaners will damage this product.
3. Never use oven cleaner to clean any part of grill.
4. Do not clean any grill part in a self cleaning oven.
The extreme heat will damage the finish.
Needs Cleaning: Noisy with hard
blue flames.
Before Each Use:
1. Keep the grill area clean and free from any
combustible materials, gasoline, and other flammable
vapors and liquids.
2. Do not obstruct the flow of the combustion of LP and
the ventilation air.
Has to be cleaned: Wavy with
yellow flames.
Outdoor LP Gas Barbecue Grill Model No. PR7000
Cleaning and Care (continued)
Limited Warranty
3. Keep the ventilation opening(s) of the LP gas tank area free and clear from debris.
S.R. Potten Ltd. warrants to the original owner of each Grill Mate Gas Grill that it is free from
defects in workmanship and materials under conditions of normal residential use. This limited
warranty applies to Grill Mate Gas Grills purchased and located in Canada. S.R. Potten Ltd. will
repair or replace, at its option, the warranty parts for a period of three (3) years from the date of
original retail purchase.
4. Visually check the burner flames, to make sure your grill is working properly.
5. See cleaning instructions below for proper cleaning instructions.
6. Check and clean the burner/venturi tubes for insects and insect nests. A clogged tube can
lead to a fire beneath the grill.
Cleaning Surfaces
1. Wipe surfaces clean with mild dishwashing detergent or baking soda.
2. For stubborn surfaces use a citrus based degreaser and a nylon scrubbing brush.
3. Rinse clean with water.
Cleaning Main Burner
1. Turn gas off at the control knobs and LP gas tank.
2. Remove cooking grid and heat plates.
3. Remove burner by removing the fasteners securing the burner to the grill bottom.
4. Lift burner up and away from gas valve orifice.
5. Disconnect wire from spark electrode.
6. Clean inlet (venturi) of burner with small bottle brush or compressed air.
The extent of any liability of S.R. Potten Ltd. under this warranty is limited to repair or
replacement of grill parts. The limited warranty period is not extended by such repair or
replacement. S.R. Potten Ltd. is not liable for any labour or other costs related to the removal
and/or installation of any warranty part, installation of replacement parts, product assembly,
and/or delivery costs.
S.R. Potten Ltd. requires reasonable proof of your date of purchase to establish warranty period.
Therefore, you should retain your original sales slip or invoice. You will not need to register your
product.
This limited warranty does not apply to any damage due to transportation, improper installation
or operation, purchaser servicing, accident, abuse, fire, alteration of the product in any way,
act of God, natural disaster, failure to read and/or abide by any product warnings, or use
of unauthorized parts or labour to replace any parts covered under this limited warranty. In
no event, whether as a result of breach of warranty or contract, negligence, strict liability,
or misrepresentation, will S.R. Potten Ltd. be liable for any incidental and/or consequential
damages. S.R. Potten Ltd’s liability on any claim of any kind is limited to the purchase price
of the grill, service or part thereof which gives rise to the claim. Some jurisdictions do not
allow the exclusion or limitation of incidental or consequential damages, so the above
limitation or exclusion may not apply to you.
8. Clean any clogged ports with a stiff wire (such as an opened paper clip)
S.R. Potten Ltd. does not assume, or authorize any other person to assume for S.R. Potten
Ltd. any liability from the sale of this product beyond that expressly set forth in this Limited
Warranty.
9. Inspect burner for any damage (cracks or holes). If damage is found, replace with new
burner.
For Warranty Service, please call our Customer Service Department at 1-800-667-7313,
Monday through Friday, 8:00am to 5:00pm Eastern.
10. Reinstall burner, check to insure that gas valve orifice is correctly positioned inside burner
inlet (venturi). Also check position of spark electrode.
Warranty Restrictions:
• This warranty does not cover surface rust or natural oxidation.
• This warranty is void if grill is used for commercial or rental purposes.
• This warranty applies only when the grill is used in Canada.
•This warranty gives you specific legal rights, and you may also have other rights which
vary from province to province.
7. Remove all food residue and dirt on burner surface.
11. Replace heat plate and cooking grid.
12. Preform leak test.
Cleaning Side Burner
1. Turn gas off at the control knobs and LP gas tank.
2. Remove side burner grid.
3. Remove burner by removing the screws securing the burner to the side shelf.
4. Lift burner up and away from gas valve orifice.
5. Clean inlet (venturi) of burner with small bottle brush or compressed air.
6. Remove all food residue and dirt on burner surface.
7. Clean any clogged ports with a stiff wire (such as an opened paper clip)
8. Inspect burner for any damage (cracks or holes). If damage is found, replace with new
burner.
9. Reinstall burner, check to insure that gas valve orifice is correctly positioned inside burner
inlet (venturi). Also check position of spark electrode.
10. Replace cooking grid.
11. Preform leak test.
Product Registration
You do not need to register your product. Simply keep the proof of purchase for future reference.
S.R. Potten Ltd.
1645 - 50th Avenue
Lachine, Quebec, Canada
H8T 3C8
page no.
Contact 1.800.667.7313 for assistance. Do not return to place of purchase.
11
Troubleshooting
Problem
Possible Cause
Prevention/Cure
Burner will not light using ignitor
Wires or electrode covered with cooking residue.
Clean wire and/or electrode with rubbing alcohol.
Burner will not light with match
Sudden drop in gas flow or reduced flame height
Electrode and burners are wet.
Wipe dry with cloth.
Electrode cracked or broken - sparks at crack.
Replace electrode.
Wire loose or disconnected.
Reconnect wire or replace electrode/wire assembly
Wire is shorting (sparking) between ignitor and electrode.
Replace ignitor wire/electrode assembly
Bad ignitor.
Replace ignitor
No gas flow.
Check if LP cylinder is empty. If LP cylinder is not empty, refer
to “Sudden drop in gas flow (reduced flame height). If empty,
replace or refill.
Coupling nut and regulator not fully connected.
Turning the coupling nut about one-half to three quarters
additional turn until solid stop. Tighten by hand only-do not use
tools.
Obstruction of gas flow.
Clear burner tubes. Check for bent or kinked hose.
Disengagement of burner to valve.
Reengage burner and valve.
Spider webs or insect nest in venturi.
Clean venturi.
Burner ports clogged or blocked.
Clean burner ports.
Out of gas.
Check for gas in the LP cylinder
Excess flow safety device may have been activated.
Turn off knobs, wait 30 seconds and light grill. If flames are still
too low Reset the excessive flow safety device by turning off
knobs and LP cylinder valve. Disconnect regulator. Turn burner
control knobs to HIGH. Wait 1 minute. Turn burner control knobs
off. Reconnect regulator and leak check connections. Turn LP
cylinder valve on slowly, wait 30 seconds and then light grill.
Irregular flame pattern, flame does not run the full length Burner ports are clogged or blocked.
of burner.
Clean burner ports.
Flame is yellow or orange.
New burner may have residual manufacturing oils.
Burn grill for 15 minutes with the lid closed
Spider webs or insect nest in venturi
Clean venturi.
Food residue, grease or seasoning salt on burner.
Clean burner.
Poor alignment of valve to burner venturi.
Assure burner venturi is properly engaged with valve
High or gusting winds
Turn front of grill to face wind or increase flame height to HIGH
setting
Low on LP Gas
Replace or refill LP cylinder
Excess flow valve tripped
Refer to “Sudden drop in gas flow”
Grease buildup.
Clean grill.
Excess fat in meat.
Trim fat from meat before grilling.
Flame blow out
Flare-up
Excessive cooking temperature.
Adjust (lower) temperature accordingly.
Persistent grease fire.
Grease trapped by food buildup around burner system
Turn knobs to OFF. Turn gas off at LP cylinder. Leave lid in
closed position and let fire burn out. After grill cools, remove
and clean all parts.
Flashback (fire in burner tube(s))
Burner and/or burner tubes are blocked
Clean burner and/or burner tubes
Inside of lid is peeling-like paint peeling
The lid is stainless steel, not paint.
Baked on grease buildup has turned to carbon and is flaking
off. Clean thoroughly.
Outdoor LP Gas Barbecue Grill Model No. PR7000
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertising