Material Safety Data Sheet
MATERIAL
SAFETY DATA SHEET
Page:1/6
MSDS No.:MFP-2652
Product Name: TONER TN216K
Prepared Date:25-May-2009
Revised Date: 19-Aug-2015
1.
PRODUCT AND COMPANY
Product Name: TONER TN216K
used for: C280/C220
IDENTIFICATION
Supplier Identification:
Konica Minolta Business Solutions (Canada), Ltd.
369 Britannia Road East Mississauga, Ontario L4Z 2H5
Telephone: (905)890-6600
Facsimile: (905)283-2511
Emergency Telephone No.
CHEMTREC
Telephone: 1-800-424-9300
WHMIS: This product is NOT subject to the controlled products regulations.
2.
COMPOSITION / INFORMATION ON INGREDIENTS
Substance [ ]
Preparation [ X ]
Major Ingredients:
[Generic Name]
Styrene acrylic resin
Ferrite Iron oxide
.
Manganese oxide
Wax
Carbon black
Wax-2
Amorphous silica
Titanium dioxide
[CAS No.]
+++
1309-37-1
1344-43-0
+++
1333-86-4
+++
7631-86-9
13463-67-7
[%]
65-75
1-10
1-10
1-10
1-10
1-10
1-10
<1
+++: Supplier’s confidential information
Hazardous Ingredients:
Chemical Name: Carbon black (<1%)
CAS No.: 1333-86-4
OSHA Z-Tables(USA): 3.5mg/m3
NTP(USA): Not listed
California Proposition 65(USA): Listed
Symbol(EC): Not listed
DFG-MAK(GER): III 3B
Chemical Name: Titanium dioxide (<1%)
CAS No.: 13463-67-7
OSHA Z-Tables(USA): 15mg/m3
NTP(USA): Not listed
Symbol(EC): Not listed
Chemical Name: Manganese oxide
OSHA Z-Tables(USA): ceiling 5mg/m3
EEC-No.: 215-609-9
ACGIH-TLV(USA): 3.5mg/m3
IARC Monographs: Group 2B
R-Phrase(EC): Not listed
Worksafe-TWA(Austl): 3mg/m3
EEC-No.: 236-675-5
ACGIH-TLV(USA): 10mg/m3
IARC Monographs: Group 2B
R-Phrase(EC): Not listed
Worksafe-TWA(Austl): 10mg/m3
ACGIH-TLV(USA): 0.2mg/m3
Worksafe-TWA(Austl): 1mg/m3
MATERIAL
SAFETY DATA SHEET
Page:2/6
MSDS No.:MFP-2652
Product Name: TONER TN216K
Prepared Date:25-May-2009
Revised Date: 19-Aug-2015
3.
HAZARDS IDENTIFICATION
Emergency Overview:
Black powder (mean dia. is 5-10um by volume ).
Almost oderless.
Classification:
Not classified as dangerous. (1999/45/EC)
Most Important Hazards and Effects of the Products
Ingestion Effect:
None currently known.
Inhalation Effect:
None currently known. Minimal respiratory tract irritation may occur as with exposure
to large amount of any non-toxic dust.
Eye Effect:
None currently known.
Skin Effect:
None currently known.
Chronic Effects:
Prolonged inhalation of excessive dusts may cause lung damage. Use of this
product, as intended, does not result in inhalation of excessive dust.
Environment Hazards: No data are available on the adverse effects of this product on the environment.
Specific Hazards:
Dust explosion(like most finely divided organic powders)
4.
FIRST-AID MEASURES
Ingestion:
Wash out mouth with water. Drink one or two glasses of water. If symptoms occur, get medical
attention.
Inhalation:
Move victim to fresh air immediately. If symptoms occur, get medical attention.
Eye Contact: Immediately flush eyes with plenty of water for 15 minutes. If symptoms occur, get medical
attention.
Skin Contact: Wash with water and mild soap.
5.
FIRE-FIGHTING MEASURES
Suitable Extinguishing Media: CO2, water spray, foam and dry chemical
Extinguishing Media to Avoid: Full water jet
Fire and Explosion Hazards: If dispersed in air, like most finely divided organic powders, may form an explosive
mixture.
Protection of Firefighters:
Use self-contained breathing apparatus(SCBA).
6.
ACCIDENTAL RELEASE MEASURES
Personal Precautions:
None
Environmental Precautions: None
Methods for Cleaning Up: Wear personal protective equipment(See Section 8). Vacuum or sweep material
and place in a bag and hold for waste disposal. Use vacuum equipped with High
Efficiency Particulate Air(HEPA) filter. Vacuum should be electrically bonded and
grounded to dispel static electricity. To avoid dust generation, do not sweep dry.
MATERIAL
SAFETY DATA SHEET
Page:3/6
MSDS No.:MFP-2652
Product Name: TONER TN216K
Prepared Date:25-May-2009
Revised Date: 19-Aug-2015
7.
HANDLING AND STORAGE
Handling
Technical Measures: None
Precautions:
Do not breathe dust. Avoid contact with eyes.
Safe Handling Advice: Try not to disperse the particulates.
Storage
Technical Measures: None
Storage Conditions:
Keep container closed. Store in a cool and dry place. Keep out of reach of children.
Incompatible Products: None
Packaging Materials: Bottles or Cartridge designated by Konica Minolta.
8.
EXPOSURE CONTROLS/PERSONAL PROTECTION
Engineering Measures
Ventilation:
None required with intended use.
Control Parameters(As total dust)
ACGIH-TLV(USA) :
10mg/m3 (Inhalable particles), 3.0 mg/m3 (Respirable particles)
OSHA-PEL(USA):
15mg/m3 (Total dusts),
5.0 mg/m3 (Respirable fraction)
DFG-MAK(GER):
4mg/m3 (Inhalable fraction), 1.5mg/m3 (Respirable fraction)
Worksafe-TWA(Austl.):
10mg/m3
Personal Protective Equipment
Not required under normal conditions. For use other than in normal operating procedures (such as in the
event of large spill), goggles and respirators may be required.
Hygiene Measures:
Wash hands after handling.
9.
PHYSICAL AND CHEMICAL PROPERTIES
Appearance
Physical State: Solid
Color: Black
Form: Powder (mean dia. is 5-10um by volume)
Odor:
Almost oderless
PH
Not applicable
Boiling Point(°C):
Not applicable
Melting Point(°C)/[F]:
Around No data available /[] (Softening Point)
Flash Point(°C):
Not applicable
Ignition Temperature(°C):
No data available
Explosion Properties:
No data available
Vapor Pressure:
Not applicable
Specific Gravity:
1.2
Solubility:
Insoluble in water.
Partition Coefficient, n-Octanol/Water:
Not applicable
MATERIAL
SAFETY DATA SHEET
Page:4/6
MSDS No.:MFP-2652
Product Name: TONER TN216K
Prepared Date:25-May-2009
Revised Date: 19-Aug-2015
10. STABILITY AND REACTIVITY
Stability:
Stable except above 200C(392F).
Hazardous Reactions:
Dust explosion, like most finely divided organic powders.
Conditions to avoid:
Electric discharge, throwing into fire.
Materials to Avoid:
Oxidizing materials.
Hazardous Decomposition Products: CO, CO2, NOx and smoke.
Hazardous Polymerization:
Will not occur.
11. TOXICOLOGICAL INFORMATION
Acute Toxicity:
Ingestion(oral), LD50(mg/kg):
>2500(Rat) *
Dermal, LD50(mg/kg):
No data available
Inhalation, LC50(mg/l):
>5.17(Rat,4hour) *
(This was the highest attainable concentration.)
Eye irritation:
Minimal irritant(Rabbit) *
Skin irritation:
Mild irritant(Rabbit) *
Skin sensitizer:
Non sensitizer (Guinea pig) *
Local Effects: see Chronic Toxicity or Long term Toxicity
Chronic Toxicity or Long Term Toxicity:
In a two-year inhalation study of chronic toxicity and carcinogenicity using a typical toner in rats, there
were no lung changes at all in the lowest exposure level (1mg/m3), the most relevant level to potential
human exposures. A minimal to mild degree of fibrosis was noted in 22% of the animals at the middle
exposure level (4mg/m3), and a mild to moderate degree of fibrosis was observed in 92% of the rats at
the highest exposure level(16mg/m3). The lung changes observed in the higher exposure groups are
interpreted in terms of "lung overloading", a series of generic responses to the presence of large
quantities of respirable, insoluble and relatively benign dusts retained for extended time periods in the
lungs. Lung tumor frequency was unchanged among rats exposed to toner at the three exposure
levels, and for air-only control rats.
Carcinogenicity
The IARC reevaluated carbon black as a Group 2B carcinogen (possible human carcinogen). This
evaluation is given to Carbon Black for which there is inadequate human evidence, but sufficient animal
evidence. The latter is based upon the development of lung tumors in rats receiving chronic inhalation
exposures to free carbon black at levels that induce particle overload of the lung.
Studies performed in animal models other than rats have not demonstrated an association between
carbon black and lung tumors. Moreover, a two-year cancer bioassay using a typical toner preparation
containing carbon black demonstrated no association between toner exposure and tumor development in
rats.
The IARC reevaluated titanium dioxide as a Group 2B carcinogen (possible human carcinogen). In
animal chronic inhalation studies, the tumor formulation observed in only rats with animal chronic
inhalation study are attributed to “lung overloading”, a generic response to excessive amounts of any dust
retained in the lungs for a prolonged interval. Use of this product, as intended, dose not result in inhalation
of excessive dust. Epidemiological study to date have not revealed any evidence of the relation
between exposure to titanium dioxide and diseases of the respiratory tract beyond general effects of dust.
Mutagenicity:
Negative(AMES test)
Teratogenicity:
No data available
(*= Based on data for other Konica Minolta Products with similar ingredients)
MATERIAL
SAFETY DATA SHEET
Page:5/6
MSDS No.:MFP-2652
Product Name: TONER TN216K
Prepared Date:25-May-2009
Revised Date: 19-Aug-2015
12. ECOLOGICAL INFORMATION
No data are available on the adverse effects of this material on the environment.
Ecotoxicity:
No data available
Mobility:
No data available
Persistence and degradability: No data available
Bioaccumulative potential:
No data available
13. DISPOSAL CONSIDERATION
When disposing of the waste or recovered material, consult federal, state and/or local regulations for the proper
disposal method.
14. TRANSPORT INFORMATION
Information on Code and Classifications According to International Regulations
UN Classification: None
Further information: Not a dangerous good under IATA or IMDG.
15. REGULATORY INFORMATION
US Information
Information on the label: Not required
TSCA(Toxic Substances Control Act):
All chemical substances in this product comply with all applicable rules or order under TSCA.
California Proposition 65:
Ingredient carbon black subject to California Proposition 65 is bound in polymer-matrices so that
warnings are not required.
EU Information
Information on the label (1999/45/EC and 67/548/EEC): Not required
Article14 (2.1) of Directive 1999/45/EC is not applicable to this product.
WHMIS(Canada): This product is NOT subject to the controlled products regulations.
16. OTHER INFORMATION
HMIS Rating:
The National Paint and Coating Association(USA): Health: 1 Flammability: 1 Reactivity: 0
Recommended Uses: Toner for Electrophotographic Equipment
Explanation of term: IARC 2B means "possible human carcinogen".
Revision Information: Regular revision on revised date.
Literature References:
ANSI Z400.1-1993
ISO 11014-1
Commission Directive 91/155/EEC
IARC(2010): IARC monographs on the Evaluation of the Carcinogenic Risk of Chemicals to Humans,
Vol. 93, Carbon Black, Titanium Dioxide, and Talc, Lyon, pp. 43-276
H.Muhle, B.Bellmann, O.Creutzenberg, C.Dasenbrock, H.Ernst, R.Kilpper, J.C.MacKenzie, P.Morrow,
U.Mohr, S.Takenaka, and R.Mermelstein(1991)
Pulmonary Response to Toner upon Chronic Inhalation Exposure in Rats. Fundamental and Applied
Toxicology 17, pp.280-299.
NIOSH CURRENT INTELLIGENCE BULLETIN :Evaluation of Health Hazard and Recommendation
for Occupational Exposure to Titanium Dioxide :DRAFT
MATERIAL
SAFETY DATA SHEET
Page:6/6
MSDS No.:MFP-2652
Product Name: TONER TN216K
Prepared Date:25-May-2009
Revised Date: 19-Aug-2015
Restrictions:
The above information is believed to be accurate and represents the best information currently available to
Our Corporation. However, Our Corporation makes no warranty with respect to such information, and Our
Corporation assumes no liability resulting from its use. Users should make their own investigation to
determine the suitability of the information for their particular purposes.
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertising