Assembly, Installation, Care, Maintenance, and Use Instructions

Assembly, Installation, Care, Maintenance, and Use Instructions
TM
55 INCH MY FIRST TRAMPOLINE
Assembly, Installation, Care, Maintenance, and Use Instructions
USER’S MANUAL
DO NOT ALLOW MORE
THAN ONE PERSON ON
THE TRAMPOLINE AT A
TIME.
!
WARNING
YOU MUST THOROUGHLY READ AND UNDERSTAND ALL INSTRUCTIONS IN THIS MANUAL BEFORE
ASSEMBLING AND USING THIS TRAMPOLINE.
SAVE THIS MANUAL FOR FUTURE REFERENCE.
MAXIMUM WEIGHT OF THE USER SHALL NOT EXCEED 45.4KG/100LB.
THIS PRODUCT IS INTENDED FOR USE BY CHILDREN FROM AGES 3 TO 6.
ADULT ASSEMBLY REQUIRED.
USE UNDER ADULT SUPERVISION.
INTRODUCTION
Thank you for purchasing a Sportspower product! This trampoline was designed and manufactured
with quality materials and craftsmanship, providing fun and exercise in the enjoyment of your own
home.
It is very important that the owners and users of this trampoline have adequate knowledge of
techniques and rules for safe use. In particular, children must be supervised at all times by a
knowledgeable and mature adult while using the trampoline. Take precautions to prevent access to
the trampoline by children when there is no adult supervision. Also restrict access to any
unauthorized users without your consent.
To reduce risks associated with users falling off the trampoline, the trampoline enclosure netting
should be properly installed and used at all times. The trampoline enclosure should be closed during
use to prevent the user from falling off of the trampoline. To close the enclosure, fasten the buckle
and fully close the bottom of the net by using the velcro strip. Your trampoline enclosure netting is
manufactured with UV resistant material. Exposure to harsh elements (sunlight, wind, moisture,
animals, etc) will weaken the netting. Because of this the netting must be inspected prior to every
use as detailed later in this User Manual.
This trampoline is for INDOOR USE ONLY. Ensure proper placement of this product to prevent
injuries. Place the product on a slip-resistant and level surface indoors, such as on carpet or on a
large rubber mat. Do not place the trampoline on smooth or slippery surfaces such as a concrete or
tiled floor. Make sure there are no obstructions beneath, above, or around the product. The
product should not be used in windy conditions as wind can cause unexpected movement of the
product. The product should be properly stored away or disassembled completely when not in use.
Do not use outdoors and avoid windy conditions.
Read all instructions in this manual carefully before assembling or using this product.
manual in a safe place for future reference.
Keep this
! WARNING
The trampoline is for indoor use only.
If the trampoline is used outdoor, DO NOT leave outdoor overnight. ALWAYS move and
store indoor in a proper and safe location.
1
IMPORTANT SAFETY INSTRUCTIONS
BEFORE YOU BEGIN: Review all steps before beginning assembly and read all precautions
before using the trampoline. The owner and supervisors of the trampoline are responsible to
make all users aware of practices specified in these instructions. Save this manual for future
reference.
WARNING!
Read these materials prior to assembling and using this trampoline
WARNING – To reduce the risk of injury to persons:
Read and understand all the instructions and inspect the equipment before using the trampoline. It is
your responsibility to familiarize yourself with the proper use of this equipment and the inherent risks
of jumping on a trampoline, such as falling on your head or neck, pinching, entrapment, or equipment
failure. It is the responsibility of the owner to ensure that all users of the product are fully informed
about the proper use of the equipment and all safety precautions.
Use trampoline only with mature, knowledgeable supervision. Close supervision is necessary when
the trampoline is used by children, or by or near invalids or disabled persons.
DO NOT allow use by anyone weighing over 100lbs (45.4kg)
DO NOT allow more than one person to jump on the trampoline at any one time. Multiple jumpers
increase the risk of serious injury, such as broken head, neck, back or other bones.
DO NOT perform somersaults or flips. This will significantly increase your chances of landing on
your head or neck and can cause serious injuries, such as paralysis or death!
DO NOT jump on trampoline with snow board, skateboard, roller blades, bicycle or any other
equipment not authorized by the trampoline maker.
DO NOT jump off walls or building onto the trampoline. Do not use the trampoline as a springboard
to jump onto other objects.
This product is intended for personal use only. DO NOT use in any commercial, rental, professional
or stunt performance setting.
DO NOT allow children to play or jump on the product during inclement weather (thunderstorms,
tornadoes, hurricanes, or when it is wet or windy). High winds can lift the equipment and cause
serious injury. Move the trampoline into a safe and dry storage location during severe weather
conditions. If you live in an area where there are winds strong enough to move the product, you
should consult a local contractor about ways to secure the product in your location.
DO NOT jump on the trampoline with street shoes or tennis shoes. Users of the trampoline should
not wear sharp or pointed objects and should not bring any sharp or pointed objects into the
trampoline or the area around the trampoline. Any type of sharp or pointed objects should be
removed from persons and kept off the trampoline at all times. Remove all buckles, jewelry, and
other sharp or pointed objects.
DO NOT allow any pets or children onto the trampoline in order to prevent the trampoline mat from
being damaged.
DO NOT use unauthorized Sportspower parts. This may damage the integrity of the product and will
void the manufacturer’s warranty.
Do NOT allow any pets or children to go under the jump mat.
2
ALWAYS ensure adequate overhead clearance. Recommended minimum overhead clearance is
10ft from ground level. Provide clearance for wires, tree limbs and other possible hazards.
ALWAYS place the trampoline on a level surface before assembly and use. This trampoline is for
INDOOR USE ONLY.
Place the product on a slip-resistant and level surface indoors, such
as on carpet or on a large rubber mat.
Do not place the trampoline on smooth or slippery
surfaces such as a concrete or tiled floor. Make sure there are no obstructions beneath,
above, or around the product.
ALWAYS maintain clear space on all sides of the trampoline. Place the trampoline away from walls,
structures, fences and other play equipment. Clear any obstructions beneath or around the
trampoline, for example tree limbs or trunks, wires or other possible hazards.
ALWAYS inspect the trampoline before each use for worn-out mats or enclosures and loose or
missing parts. Make sure the frame padding is correctly and securely positioned. Replace
defective components immediately and/or keep the equipment out of use until repair.
ALWAYS protect enclosure net from extreme temperatures. Extreme temperatures may damage the
net and cause it to tear and cause injury.
ALWAYS make sure that the trampoline enclosure netting is installed and used properly at all
times. The trampoline enclosure should be closed during use to prevent the user from
falling off of the trampoline. To close the enclosure, fasten the buckle and fully close the
bottom of the net by using the velcro strip.
ALWAYS climb on and off the trampoline while mounting or dismounting. DO NOT jump on or off the
trampoline as this can cause serious injuries.
ALWAYS consult your physician before performing any kind of physical activity.
ALWAYS use the trampoline in a well-lit area. Artificial illumination may be required.
ALWAYS properly store away the trampoline and enclosure when not in use and secure from any
authorized use. Trampoline should be taken down and stored away during harsh weather conditions
including extreme heat and snow or freezing temperature. Extreme temperature may cause
damages and tears to the mat and netting and cause injury.
ALWAYS use the trampoline wearing comfortable clothes and socks or barefoot.
NEVER use the trampoline while under the influence of alcohol or drugs.
3
WARNING:
ALWAYS START YOUR JUMP AT THE CENTER OF TRAMPOLINE MAT.
FAILURE TO FOLLOW INSTRUCTIONS AND WARNINGS COULD RESULT IN
SERIOUS INJURY OR DEATH.
WARNING
NO MORE THAN ONE
PERSON AT A TIME ON THE
TRAMPOLINE!
MULTIPLE JUMPERS
INCREASE THE RISK OF
INJURY SUCH AS BROKEN
HEAD, NECK, LEG, OR
BACK.
PARALYSIS OR DEATH CAN
RESULT IF YOU LAND ON
YOUR HEAD OR NECK!
DO NOT PERFORM
SOMERSAULTS (FLIPS) AS
THIS WILL INCREASE YOUR
CHANCES OF LANDING ON
YOUR HEAD OR NECK!
4
Important Warning about Enclosure Netting:
Your trampoline is for indoor use only. However, if the netting is exposed to
the extreme elements including sunlight, heat, cold, wind, rain or wildlife, the
netting must be inspected prior to every use as detailed below.
Please carefully read the following to ensure the enclosure is safe to use.
Please inspect enclosure netting before EACH use for worn or tear by pinching a section of
fabric between fingers and pulling downward. Please see diagram below.
This should be done every month, if it produces a tear or if it produces a continuous ripping
sound, then the net is unsafe and MUST be taken down immediately. STOP USING THE
TRAMPOLINE ENCLOSURE IF YOU FIND WORN OUT AREAS OR TEARS ON THE
NETTING.
It is recommended to replace enclosure netting every SIX MONTHS. New enclosure
nettings can be purchased through SPORTSPOWER’S authorized service center.
! SAFETY TIPS FOR TRAMPOLINE NETTING
Do not attempt to jump over or crawl under the netting.
Do not intentionally bounce off the netting.
Do not hang from, kick, cut or climb on the netting.
Wear clothing free of drawstrings, hooks, loops or anything that could get caught in the
netting.
Enter and exit the enclosure only at the enclosure door or netting opening designated for
that purpose.
A trampoline enclosure installed on a trampoline is raised off the ground. The height of the
enclosure increases the risk of a fall when a jumper is entering or exiting the enclosure.
Young children in particular may have difficulty getting into and out of the enclosure. To
reduce the risk of falling, help young children to get into and out of the enclosure.
Enter and exit the trampoline enclosure only through the opening of the enclosure (the
opening in the netting walls). The trampoline mat and nettings walls of the enclosure are
separate pieces; jumpers, particularly young children, must not exit the enclosure by going
out between the mat and the netting walls. Trying to exit in this way poses a risk of
strangulation from being caught between the trampoline frame and the netting walls.
During use, the enclosure should be closed to prevent the user from falling off of the
trampoline. To close the enclosure, fasten the buckle and fully close the bottom of the net
by using the velcro strip.
Do not attach anything to the netting that is not a Sportspower approved accessory or part of
the trampoline enclosure, as this may cause a strangulation hazard or cause the enclosure
to rip.
FAILURE TO FOLLOW INSTRUCTIONS AND WARNINGS COULD RESULT IN
SERIOUS INJURY OR DEATH.
5
ASSEMBLY AND INSTALLATION INSTRUCTIONS – PARTS LIST
PLEASE KEEP THIS BOOKLET FOR FUTURE REFERENCE
PARTS LIST- Please check and identify all parts before assembly
MAIN PARTS:
1
2
3
Qty: 6 pcs
Qty: 6 pcs
4
5
6
Qty. 6 pcs
7
Qty: 6 pcs
8
Qty: 6 pcs
9
Qty. 6 pcs
10
Qty: 6 pcs
Qty:1 pc
Qty:1 pc
11
12
Qty:1 pc
Qty:1 pc
6
Qty: 6 pcs
HARDWARE:
B
A
M6×36mm
C
M6 X 45mm
BOLT
BOLT
Qty: 12 pcs
Qty: 6 pcs
F
E
Φ6.5*Φ10mm
D
Φ6.5*Φ14mm
M4 X 13mm
BOLT
WASHER
Qty: 36 pcs
Qty: 12 pcs
H
G
M6
SPRING
WASHER
CAP NUT
Qty: 12 pcs
Qty: 18 pcs
7
SPANNER
ALLEN KEY
Qty: 1 pc
Qty: 1 pc
ASSEMBLY AND INSTALLATION INSTRUCTIONS
BEFORE YOU BEGIN: Review all steps before beginning assembly and read all precautions
before using the trampoline. All the tools needed are included with this package. Protective
gloves and eye goggles are recommended to avoid injuries during assembly.
LOCATION OF TRAMPOLINE
For safe use of the trampoline, please assemble the trampoline in a location that meets the
following conditions:
The minimum overhead clearance required is 10 feet.
This trampoline is for INDOOR USE ONLY. Place the product on a slip-resistant and level
surface indoors, such as on carpet or on a large rubber mat. Do not place the trampoline
on smooth or slippery surfaces such as a concrete or tiled floor. Make sure there are no
obstructions beneath, above, or around the product.
Clear any obstructions from beneath the trampoline and maintain clear space around the
trampoline. Do not place the trampoline near walls, fences, other play equipment, etc.
Make sure the trampoline is installed in a well-lit area.
Trampoline should be placed in an area where access can be restricted from unauthorized
use, for example, neighborhood children without your consent and supervision.
.
WARNING
NO MORE THAN ONE
PERSON AT A TIME ON THE
TRAMPOLINE!
MULTIPLE JUMPERS
INCREASE THE RISK OF
INJURY SUCH AS BROKEN
HEAD, NECK, LEG, OR
BACK.
PARALYSIS OR DEATH CAN
RESULT IF YOU LAND ON
YOUR HEAD OR NECK!
DO NOT PERFORM
SOMERSAULTS (FLIPS) AS
THIS WILL INCREASE YOUR
CHANCES OF LANDING ON
YOUR HEAD OR NECK!
FAILURE TO FOLLOW INSTRUCTIONS AND WARNINGS COULD RESULT IN
SERIOUS INJURY OR DEATH.
8
Assembly Instructions
STEP 1 MAIN FRAME ASSEMBLY
Layout Parts (#2) & (#3), as shown in below diagram.
(#2)
(#3)
(#2)
(#3)
STEP 2 MAIN FRAME ASSEMBLY
Insert the small end of Part (#3) to the big end of Part (#2) until you hear "Click".
Repeat the same step for the other tubes.
(#3)
(#2)
9
Step 3 BOTTOM ASSEMBLY
(1) Attach Part (#1) to the Part (#2).
(2) Align the legs.
(3) Secure using the bolts A , D, D , E & F.
E D
F
D
A
(#2)
(#1)
Step 4 FRAME COVER ASSEMBLY
Tie one end of rope Part (#3) to the ring of trampoline mat (#8).
Note: Please make sure two end of loop being locked with Part (#1).
(#8)
Loop
(#1)
Loop
(#2)
(#3)
(#12)
(#1)
(#2)
(#3)
10
(#12)
Step 5 FRAME COVER ASSEMBLY
Insert tube Part (#4) to Part (#1), push downwards until you hear "Click" of
push button into tube hole.
(#4)
(#4)
(#4)
D A
F ED
(#1)
F ED
(#2)
(#1)
D A
(#1)
Step 6 FRAME COVER ASSEMBLY
Put the trampoline pad Part (#9) onto the main frame of the trampoline.
Make sure trampoline pad fully cover the main frame. As shown in below diagram.
(#9)
(#4)
(#1)
11
Step 7 FRAM COVER ASSEMBLY
(1) Using trampoline net Part (#10) through between Part (#4) and Part (#5).
(2) Insert Part (#5) into the Part (#4), until you hear "Click", as shown in below diagram.
(3) Using the Part (#6) through the trampoline net Part (#10), as shown in below diagram.
(#6)
(#10)
(#5)
Enlarged Diagram
Enlarged
Diagram
(#4)
(#1)
12
Step 8 FRAM COVER ASSEMBLY
(1) Insert Part (#6) to the Part (#7), secure with B, D & C, as shown in below diagram.
(2) Insert Part (#5) to Part (#7), secure with D & F, as shown in below diagram.
(#6)
(#7) B
D
(#6)
C
Enlarged Diagram
(#6) (#7)
(#6)
D
F
Enlarged Diagram
(#5)
13
Step 9 FRAM COVER ASSEMBLY
Using the rope Part (#11) to tighten the trampoline net Part (#10).
As shown in enlarged diagram.
Enlarged Diagram
(#8)
(#10)
14
(#12)
(#11)
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertising