RV generator set Quiet Gasoline Series RV QG 5500

RV generator set Quiet Gasoline Series RV QG 5500
RV generator set
Quiet GasolineTM Series
RV QG 5500
Features and benefits








Weight, size and sound level
Quietest in its class.
Exceptionally low vibration levels.
Integrated design with enclosed muffler for easy
installation.
Self-diagnostic capability to simplify
troubleshooting.
Runs one or two air conditioners with power to
spare.
Digital voltage regulation for stability as appliance
loads change.
3-year limited warranty, lifetime drive warranty.
Gasoline or LP fueled.
Weight
279 lbs
(127 kg)
Length
Width
Height
33.6 in
22.2 in
16.7 in
(853 mm)
(563 mm)
(425 mm)
Sound
67 dB(A)
Readings at 10 ft (3 m) half load
- Meets National Park Service sound level requirements (60 dB(A)
@ 50 ft) for national park use.
- Typical installation will further reduce sound level.
Models and ratings
Model
Fuel
Hz
RPM
Watts
Voltage
Amps
Phase Circuit breaker
5.5
5.5
5.5
5.5
5.5
LP vapor
LP vapor
Gasoline
Gasoline
Gasoline
60
60
60
60
60
2400
2400
2400
2400
2400
5500
5500
5500
5500
5500
120
120
120
120
120
45.8
45.8
45.8
45.8
45.8
1
1
1
1
1
HGJAB- 1270
HGJAB-1119
HGJAB-1038
HGJAB-901
HGJAB-6755*
(2) 30 A
(1) 30 A, (1) 20 A HACR
(2) 30 A
(1) 30 A, (1) 20 A HACR
(1) 30 A, (1) 20 A HACR
Ambient conditions for rated power output with muffler and RV enclosure, per ISO 8528-1:
- Temperature: 77° F (25° C)
- Altitude: 500 ft (152.4 m), (99 kPa dry)
Typical power output change based on ambient conditions:
- Temperature: Power output decreases 1% for every 10° F (5.5° C) increase
- Altitude: Power output decreases 3.5% for every 1000 ft (305 m) increase
Ratings represent minimums. Actual performance may be significantly higher based on installation and operating conditions.
* Evaporative spec: For trailer applications required to meet Tier III Evaporative Emissions of the California Air Resources Board.
Effective January 1, 2011, gasoline generator sets on trailers, diesel chassis or any other non-motorized mobile apparatus must have an
EVAP generator set, approved tank, EVAP canister, hoses and fittings all meeting the CARB Tier 3 and EPA phase 3 standards and
specifications. This law applies in all 50 states.
Operating temperature range
Gasoline
Low
High
-20° F (-29° C)
120° F (49° C)
LP
0° F (-18° C)
120° F (49° C)
- Depends upon LP tank capacity, surface area and butane content of LPG.
Cummins®, Onan®, the “C” logo, Performance you rely on.TM and Quiet Gasoline™ are servicemarks and/or registered trademarks of Cummins Inc. Specifications are subject to change without
notice. ©2011 Cummins Power Generation. All Rights Reserved.
A-1425i (5/11)
Standard features
Engine detail




Model: Cummins Onan OHV EH65V gasoline engine
Design: 4-cycle, OHV, 90-degree V-Twin
Compression ratio: 8:1
Displacement: 39.8 in3 (653 cm3)
Maximum power: Gasoline-fueled models: 12.9 bhp
(9.6 kW), LP-fueled models: 10.7 bhp (8.0 kW)
Cooling: Centrifugal blower, generator set mounted for
high effectiveness, pressurized system, vertical flow
Cooling air volume: Air flow includes engine,
generator set control cooling air flow
60 Hz at 500 ft3/min (14.2 m3/min)
50 Hz at 417 ft3/min (11.8 m3/min)
Fuel System: Replaceable dry element air cleaner
- (Gasoline) side-draft carburetor
- Electronic fuel pump with positive fuel shutoff (3 psi), fuel
lift 3 ft (0.9 m)
- Automatic choke with vacuum pull-off
- Combustion air volume at rated load:
14.6 ft3/min (0.41 m3/min)
- (LPG) side-draft mixer with demand regulator
- Combustion air volume at rated load:
14.9 ft3/min (0.42 m3/min)
Ignition system: Electronic magneto type with resistor
plugs
Starting system: Remote, 12 V, 3-wire, negative
ground automotive type starter with steel pinion and ring
gear, automatic start disconnect, connector for remote start
cable, start-stop rocker switch mounted on set control
Lubrication: Full pressure positive displacement lube oil
pump, spin-on, full flow lube oil filter, low oil pressure
shutdown, dipstick
Oil capacity: 2.0 qt (1.9 L) including filter
Cylinder crankcase: Alloy aluminum with iron cylinder
liners cast into the block, aluminum oil base
Cylinder head: Aluminum, OHV




















Mechanical governor adjustable from service side
Cummins Onan OHV engine
Pressurized Thru Flow cooling system
4-point focalized mounting system with vibration
isolators
Universal mounting tray with structural capability to
support the generator set in RV applications
Integral USDA Forest Service-approved spark-arrestor
muffler
Replaceable dry element air cleaner
Integral control box
Instant one-touch stop switch
Automatic choke
Fuel filter
Electric fuel pump (gasoline), electric fuel solenoid
(LPG)
Positive fuel shutoff (3 psi)
Enclosed muffler
Sound-attenuated housing
Remote waterproof connector
Automotive type starter with automatic start
disconnect
Spin-on, full-flow oil filter
Low oil pressure protection
Over/under speed protection
Overcurrent protectors (see Models and ratings
section)
Low power factor field overcurrent protection
120 in (3 m) generator set output leads
Digital voltage regulation
Average fuel consumption:
Gasoline
60 Hz
No load
0.3 Gal/h (1.3 L/h)
Half load
0.6 Gal/h (2.3 L/h)
Full load
0.9 Gal/h (3.6 L/h)
LPG:
60 Hz
No load
0.4 Gal/h (1.8 lb/h) 0.8 kg/h
Half load
0.8 Gal/h (3.3 lb/h) 1.5 kg/h
Full load
1.1 Gal/h (4.6 lb/h) 2.1 kg/h
Alternator details
Design: Cummins Onan revolving field, AC, 2-pole selfexcited, two bearing design
Insulation system and temperature rise: Meets
ANSI/RVIA EGS-1 and CSA TIL RV-06 requirements.
Cooling: Direct drive centrifugal blower. Cast aluminum
housing for excellent heat transfer
Excitation: Capped, digital voltage regulation
Rotor: Laminated electrical steel assembly press-fitted to
shaft, balanced. Heavy insulated copper wire windings;
optimized air gap for improved waveform and motor starting
Stator: Laminated electrical steel assembly, skewed for
improved waveform; heavy insulated copper wire windings
DC brushes: Electrographite; long life
Bearing: Double-sealed pre-lubricated ball bearings
Generator set performance
Air conditioner starting: One 13500 Btu air
conditioner with 3000 W base load or two 11000 Btu air
conditioners with 1500 W base load at 100° F (38° C) at
500 ft (152.4 m) elevation
Frequency and voltage regulation: No load to full
load, frequency <5%, voltage 1.1%
Cummins®, Onan®, the “C” logo, Performance you rely on.TM and Quiet Gasoline™ are servicemarks and/or registered trademarks of Cummins Inc. Specifications are subject to change without
notice. ©2011 Cummins Power Generation. All Rights Reserved.
A-1425i (5/11)
Basic dimensions
Dimensions: in (mm)
Note: This outline drawing is provided for general reference only and is not intended for design or installation. For more information see
Operation and Installation manuals or obtain 500-3234 drawing and wiring diagram from your distributor/dealer.
Accessories
 Remote start/stop rocker switch (P/N 300-5331)
 Remote control with start/stop switch and running time






meter (P/N 300-5332)
Remote control w/start/stop switch and DC voltmeter
(P/N 300-5333)
Remote control plug and wire harness;
10 ft (P/N 338-3489-01), 30 ft (P/N 338-3489-02)
Battery, 12 V, 360 cold cranking amps at 0° F (-18° C)
LPG vapor fuel conversion kit (P/N 148-1161)
Under floor mounting kit (P/N 405-6699)
Installation template (P/N 539-2057)
 Tailpipe kits: 22 in (P/N 155-3481-01),
26 in (P/N 155-3481-02)
 Exhaust tube, straight with flanged end: 3 in
(P/N 155-2610), 7 in (P/N 155-2424), 12.5 in
(P/N 155-2610-01)
 Energy command auto generator start EC-30
(P/N 018-02030)
 Energy command remote start/stop with diagnostics
EC-20 (P/N 018-02020)
 Energy command wireless start/stop EC-15W
(P/N 018-02015)
Cummins®, Onan®, the “C” logo, Performance you rely on.TM and Quiet Gasoline™ are servicemarks and/or registered trademarks of Cummins Inc. Specifications are subject to change without
notice. ©2011 Cummins Power Generation. All Rights Reserved.
A-1425i (5/11)
Testing for RV application
After sale support
- Tested at extremes of temperature -20° F (-29° C) to
120° F (49° C) for starting and operation
- Tested with RV loads, air conditioners, microwaves,
converter, TVs, VCRs
- Tested installed. Cummins-owned RVs used for
product development testing
- Tested in high humidity conditions
- Tested in salt spray conditions
- Tested in heavy airborne dust conditions
- Field test program
- 60 Hz (120 V only) models listed by SGS United States
Testing Company, Inc. per ANSI/RVIA EGS-1 and
CSA-certified per Std. 100 Motors and Generators and
TIL RV-06
- This generator set was designed and manufactured in
facilities certified to ISO 9001
- 60 Hz models meet applicable U.S. EPA and California
emissions standards
Complete line of parts and accessories
Warranty policy
This limited warranty covers virtually everything except
routine maintenance for the first two years you own your
RV generator set, and covers parts and labor on major
power train and generator set parts during the third year.
In addition, it also includes a free 90-day adjustment
policy, which provides that Cummins Inc will make minor
adjustments during the first three months you own it free of charge! Please note: This 3-year limited warranty
applies to RV generator sets used in RV applications
only, and does not apply to RV generator sets used in
commercial mobile applications.
The warranty period for the drive train belt and pulleys on
the HGJ series generator sets used in recreational
vehicles shall be the life of the generator set. For the
original owner, this drive train warranty shall include parts
and labor. For succeeding owners, this power train
warranty shall cover belt and pulley parts only.
!
WARNING:
Do not use this generator set on a boat.
Such use may violate U.S. Coast Guard
regulations, and can result in severe
personal injury or death from fire,
explosion, electrocution, or carbon
monoxide poisoning.
!
Cummins Inc offers replacement and tune-up parts,
accessories, oil and maintenance chemicals - all specially
designed to help keep your Cummins Onan generator set
running at peak performance. Cummins Inc. also provides
genuine Onan Green Label
Parts™ that exactly match
generator set specifications
and will help maximize
power output and extend
the life of your generator
set.
Largest distributor/dealer support network
Cummins Onan generator sets are supported by the
largest and best trained worldwide certified
distributor/dealer network in the industry. This network of
knowledgeable Cummins Onan distributor/dealers will
help you select and install the right generator set and
accessories to meet the requirements of your specific
application. This same network offers a complete selection
of commonly used generator set maintenance parts,
accessories and products plus manuals and specification
sheets. Plus, they can answer your questions regarding
proper operation, maintenance schedules and more.
Manuals: Operation and installation manuals ship with
the generator set. To obtain additional copies or other
manuals for this model, see your Cummins Onan
distributor/dealer and request the following manual
numbers: Operation (A035D009), Installation (A035D005),
Parts (983-0201 I15), Service (A035D011).
To easily locate the nearest Cummins Onan
distributor/dealer in your area, or for more information,
contact us at 1-800-888-6626 (or 763-574-5000), or visit
www.cumminsonan.com.
WARNING:
Back feed to a utility system can cause
electrocution and/or property damage. Do
not connect to any building electrical
except through an approved device or
after building main breaker is open.
Contact your distributor/dealer for more information
Cummins Power Generation
1400 73rd Ave. NE
Minneapolis, MN 55432 USA
Phone 1 763 574 5000
Toll-free 1 800 888 6626
Fax 1 763 574 5298
Email www.cumminsonan.com/contact
www.cumminsonan.com
Cummins®, Onan®, the “C” logo, Performance you rely on.TM and Quiet Gasoline™ are servicemarks and/or registered trademarks of Cummins Inc. Specifications are subject to change without
notice. ©2011 Cummins Power Generation. All Rights Reserved.
A-1425i (5/11)
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement