installation instructions

installation instructions
INSTALLATION
INSTRUCTIONS
Accessory
Application
CASSETTE PLAYER (EX)
P/N 08A03-5B1-050
2004 ODYSSEY
PARTS LIST
Publications No.
AII 26001
Issue Date
AUG 2003
3.
Cassette player
Remove the console cover:
•
Move the gear selector lever to the 1 position.
•
Using a shop towel wrapped around a small flattip screwdriver, gently pry out and remove the
cover.
•
Reach inside the cover hole, gently pull along the
bottom to release the lower clips, and work
toward the top to release all 10 clips.
•
Pull out on the console panel, unplug the
connectors, and remove the panel.
Owner’s manual
CONNECTOR
5 Washer-screws
CLIPS (10)
Wire tie (not used)
Harness clip
TABS (10)
TOOLS REQUIRED
Phillips screwdriver
Small flat-tip screwdriver
CONSOLE PANEL
INSTALLATION
1.
2.
COVER
Make sure you have the anti-theft code for the
radio, then write down the frequencies for the
preset buttons.
SMALL
FLAT-TIP
SCREWDRIVER
Disconnect the negative cable from the battery.
© 2003 American Honda Motor Co., Inc - All Rights Reserved.
AII 26001 (0308)
08A03-S0X-1001-91
1 of 3
4.
Remove the radio (four bolts, and unplug the
connector and antenna lead).
7.
ANTENNA
LEAD
Position the cassette player on the radio, and
reinstall the left and right radio brackets and four
washer-screws removed in step 5. Use four
5 x 8 mm washer-screws (supplied) to secure the
cassette player to the radio brackets.
WASHER-SCREW
(resued)
5 x 8 mm
WASHERSCREW
CONNECTOR
RADIO
BRACKET
BOLTS (4)
5.
Remove the left and right radio brackets (two
washer-screws for each bracket).
RIGHT RADIO
BRACKET
5 x 8 mm
WASHER-SCREW
WASHERSCREW
(Reuse.)
8.
RADIO
LEFT RADIO
BRACKET
Attach the harness clip to the back of the cassette
player with the remaining 5 x 8 mm washer-screw.
Plug the BUS cable into the rear of the radio/
cassette player; then fold the excess BUS cable
several times, and secure it to the back of the
cassette player with the harness clip.
RADIO/CD PLAYER
POCKET
WASHER-SCREW
(Reuse.)
6.
SELF-TAPPING
SCREW
CASSETTE
PLAYER
BRACKET
Remove the pocket (two self-tapping screws), then
separate the radio and pocket. Set the pocket aside,
it will not be reused.
BUS CABLE
5 x 8 mm
WASHERSCREW
2 of 3
AII 26001 (0308)
HARNESS CLIP
© 2003 American Honda Motor Co., Inc - All Rights Reserved.
9.
Plug the radio connector, and the antenna lead into
the back of the radio/cassette player; then reinstall
the radio in the dash. If the vehicle is equipped with
an optional CD changer, plug the CD changer BUS
cable into the cassette player.
11. Reconnect the negative cable to the battery.
12. Check the operation of the cassette player
according to its Owner's Manual.
13. Enter the radio anti-theft code, and reset the
customer’s radio station presets.
RADIO/CD
PLAYER
14. Reset the clock.
15. Put the cassette player Owner’s Manual in the
glove box.
NOTE: Whenever the battery is disconnected, the
driver's window AUTO function is disabled.
16. Start the engine. Push down on the driver's window
switch until the window is fully open.
17. Pull up on the driver's window switch to close the
window completely, then hold the switch for a
second or two more.
CASSETTE
PLAYER
18. Test the driver's window AUTO function.
19. Do the idle learn procedure.
VEHICLE 20-PIN
CONNECTOR
• Make sure all electrical items are turned off.
CD CHANGER
BUS CABLE
(If equipped)
10. Reinstall the console panel; be careful not to
damage the tabs.
CONNECTOR
•
Start the engine. Hold the engine speed at
3,000 rpm with no load (in Park or Neutral) until
the radiator fan comes on.
•
Let the engine idle for about 5 minutes with the
throttle fully closed and with all electrical items
off.
NOTE: If the radiator fan comes on during this
step, the time when it is operating must not be
included in the 5 minutes.
CLIP
TAB
CONSOLE
PANEL
COVER
© 2003 American Honda Motor Co., Inc - All Rights Reserved.
AII 26001 (0308)
3 of 3
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertising