Service Service Service - Haier Parts and Accessories

Service Service Service - Haier Parts and Accessories
31.5Ǝ&42Ǝ LCD TV
Haier HL32D2&HL42XD2
Service
Service
Service
Horizontal Frequency
31~68 KHz
Table of Contents
Description
Page Description
Page
Table of Contents.......……...................................…........1 6.1 Main Board………………..………………...……….....30
Important Safety Notice......................................……......2 6.2 Power Board…..…………..……….…….…..…..........34
Revision List…………………………………………………3 6.3 Key Board…………………………..……..……….......40
1.General Specification.................................……........4 6.4 IR Board……………………………..……….…….......40
2.Operating Instructions…………………….……..….......6 7.Adjustment..............................................................41
2.1 The Use of Remote Control…….…………...…….......6 8.Block Diagram.…….....................................................42
2.2 To Use the Menus…...………………….….………......7 9.Wiring Diagram.……....................................................43
2.3 Front Panel Control Knobs……………….………......12 10.Schematic Diagram….....……..……..………………...45
2.4 How to Connect…….…………………….…..…….....13 10.1 Main Board…….………...….………………...….......45
3.Input/Output Specification…………....................…....14 10.2 Power Board…….……….…....………...……….......58
4.Mechanical Instructions…………………….................17 10.3 Key Board………….……...….……….………….......67
5.Repair Flow Chart ……………………….…….…….....25 10.4 IR Board……………..……..…………….……….......68
6.PCB Layout ………………..………………....…..........30 11.Exploded View……………………….………….…....69
SAFETY NOTICE
ANY PERSON ATTEMPTING TO SERVICE THIS CHASSIS MUST FAMILIARIZE HIMSELF WITH THE CHASSIS
AND BE AWARE OF THE NECESSARY SAFETY PRECAUTIONS TO BE USED WHEN SERVICING
ELECTRONIC EQUIPMENT CONTAINING HIGH VOLTAGES.
CAUTION: USE A SEPARATE ISOLATION TRANSFOMER FOR THIS UNIT WHEN SERVICING
1
Important Safety Notice
Proper service and repair is important to the safe, reliable operation of all Haier Company Equipment. The service
procedures recommended by Haier and described in this service manual are effective methods of performing
service operations. Some of these service operations require the use of tools specially designed for the purpose.
The special tools should be used when and as recommended.
It is important to note that this manual contains various CAUTIONS and NOTICES which should be carefully read in
order to minimize the risk of personal injury to service personnel. The possibility exists that improper service
methods may damage the equipment. It is also important to understand that these CAUTIONS and NOTICES ARE
NOT EXHAUSTIVE. Haier could not possibly know, evaluate and advise the service trade of all conceivable ways in
which service might be done or of the possible hazardous consequences of each way. Consequently, Haier has not
undertaken any such broad evaluation. Accordingly, a servicer who uses a service procedure or tool which is not
recommended by Haier must first satisfy himself thoroughly that neither his safety nor the safe operation of the
equipment will be jeopardized by the service method selected.
Hereafter throughout this manual, Haier Company will be referred to as Haier.
WARNING
Use of substitute replacement parts, which do not have the same, specified safety characteristics might create
shock, fire, or other hazards.
Under no circumstances should the original design be modified or altered without written permission from Haier.
Haier assumes no liability, express or implied, arising out of any unauthorized modification of design.
Servicer assumes all liability.
FOR PRODUCTS CONTAINING LASER:
DANGER-Invisible laser radiations when open AVOID DIRECT EXPOSURE TO BEAM.
CAUTION-Use of controls or adjustments or performance of procedures other than those specified herein may
result in hazardous radiation exposure.
CAUTION -The use of optical instruments with this product will increase eye hazard.
TO ENSURE THE CONTINUED RELIABILITY OF THIS PRODUCT, USE ONLY ORIGINAL MANUFACTURER'S
REPLACEMENT PARTS, WHICH ARE LISTED WITH THEIR PART NUMBERS IN THE PARTS LIST SECTION OF
THIS SERVICE MANUAL.
Take care during handling the LCD module with backlight unit
-Must mount the module using mounting holes arranged in four corners.
-Do not press on the panel, edge of the frame strongly or electric shock as this will result in damage to the screen.
-Do not scratch or press on the panel with any sharp objects, such as pencil or pen as this may result in damage to
the panel.
-Protect the module from the ESD as it may damage the electronic circuit (C-MOS).
-Make certain that treatment person’s body is grounded through wristband.
-Do not leave the module in high temperature and in areas of high humidity for a long time.
-Avoid contact with water as it may a short circuit within the module.
-If the surface of panel becomes dirty, please wipe it off with a soft material. (Cleaning with a dirty or rough cloth may
damage the panel.)
2
Revision List
Version
Release Date
Revision Instructions
Customer Model
Model
E32AAZNK3WH3N
HL32D2
E32AAZNK3WH3XNX
A00
Mar.29,2010
Initial release
E42AMZNK3WH3N
HL42XD2
E42AMZNK3WH3XNX
3
1. General Specification
* This model complies with the specifications listed below.
* Designs and specifications are subject to change without notice.
* These models may not be compatible with features and/or specifications that may be addedin the future.
Model No.
HL32D2
HL42XD2
DISPLAY
Viewable
31.5W"
Television System
NTSC standard,ATSC standard (8-VSB, Clear-QAM)
VHF: 2 through 13
UHF: 14 through 69
Cable TV: Mild band (A - 8 through A - 1,A through I),
Super band (J through W),
Hyper band (AA through ZZ,AAA, BBB),
Ultra band (65 through 94, 100 through 125)
Channel Coverage
42W"
CONNECTIONS
Tuner input (75ȍ)
AV IN: AV/S-Video and L/R audio input
PC IN:D-SUB and PC Audio (Headphone mini-jack)
Supported scan rate: 640x480@60/72/75Hz,720x400@70Hz,
800x600@56/60/72/75Hz,1024x768@60/70/75Hz,
1280x720@60Hz,1280x768@60Hz
1360x768@60Hz:For HL19D2 / HL32D2 only.
1280x1024@60Hz,1440x900@60Hz,1680x1050@60Hz
1920x1080@60Hz: For HL24XD2 / HL42XD2 only.
Rear Connectors
Recommended: For HL32D2: 1360x768
For HL42XD2: 1920x1080
Component Video and L/R Audio input
Supported resolution: 480i,480p,720p,1080i,1080p
HDMI input Supported scan rates: 480i, 480p, 720p, 1080i, 1080p
Side Connectors
AV/S-Video input
SPDIF
HDMI 1
HDMI 2
Audio out
AV/S-Video input
SPDIF
HDMI 1
HDMI 2
Audio out
AV IN 2
Earphone Output USB PORT
AV IN 2
Earphone Output USB PORT
4
Model No.
HL32D2
HL42XD2
WEIGHT & DIMENSIOIN
Dimensions
with Stand
(W x H x D)
790.5 mm
569.1 mm
239.6 mm
1015.36 mm
703.03 mm
280.50 mm
Dimensions
without Stand
(W x H x D)
790.5 mm
526.8 mm
91.1 mm
1015.36 mm
654.67 mm
97.10 mm
Weight with Stand
Weight without Stand
and Base
12.5 Kg
20.5 Kg
10.6 Kg
17.6 Kg
WALL MOUNTING
VESA-compatible
wall bracket (W x H)
200 x 200 mm
400 x 200 mm
Screw type
Metric 6 x 10 mm
Metric 6 x 10 mm
POWER
Power Consumption
150W
Standby
<1W
Mains Power
120V~60Hz
Audio Power
10W + 10W
Ambient Temperature
5°C - 35°C
250W
10W + 10W
PACKAGE CONTENTS
Supplied Accessories
TV unit x1
Base x1
Screws x 4 (for 32” only)
Power cord x 1
Remote control x1 (with two size AAA alkaline batteries)
User manual x1
English
FCC statement x1
Registration Card x1
5
2. Operating Instructions
2.1 The Use of Remote Control
Power
Press to power ON/OFF(standby) TV.
(Note: 1. TV is never completely power
off unless physically unplugged. 2.
Press to turn on TV after the power on
status, LED had changed to blue and
stopped flashing.)
Fav
Press "Fav" to open or toggle channel
item in Favorite Channel List.
Video
Press repeatedly to choose
S-Video/Composite source mode.
EPG
Press to display the Electronic Program
Guide.
Comp
Press to choose Component source
mode.
CH+ / CH Press + or - to browse through the TV
channels.
PC/HDMI
Press repeatedly to choose VGA
or HDMI source mode.
Mute
Switch the sound ON/OFF.
TV
Press to choose ATSC/NTSC TV
source mode.
Info
Press to show the information about the
input source, TV channel, display
resolution and current time.
Source
Press repeatedly to choose the various
input sources.
0 ~ 9 / – number
Press to enter TV channel number to
select channel (Press ‘-’ to choose the
sub-channel).
VOL+ / VOL
Press + or - to adjust the volume.
Menu
Press to open or exit menu.
PREV CH
Press to display the previous channel.
ġ,Ģ,⦼,⦽,
ENTER
Press to adjust the various function
items on the menu.
Sleep
Press to set the preset time to switch
the TV to standby mode automatically
(off / 5 / 10 / 15/ 30 / 60 / 90 / 120 / 180
/240 mins).
Exit
Press to exit menu or OSD.
V-Chip
Press to lock Parental Control
temporarily. (After setting the restricted
table of MPAA or TV Rating.)
Freeze
Press to freeze the displayed picture.
MTS/SAP
Press to activate the NTSC TV sounds,
such as: Stereo, SAP or Mono tone, and
languages of DTV.
Video Adj
Provide video modes switching.
Audio Adj
Provide audio modes switching.
Wide
Press to choose the display aspect as:
Normal, Zoom1, Wide, Zoom2, or HDMI
PC mode.
C. C.
Press repeatedly to change the
closed caption type as CC On/CC
Off/CC On With Mute.
6
2.2 To Use the Menus
1. Press the Menu button to display or close the main menu.
2. Use the Navigation Ring to move around to select, adjust or confirm an item in the OSD (On Screen Display)
menu.
Press the Menu button to enter the main OSD. Adjust the items including Video menu,Audio menu, Feature menu,
Channel menu, and VGA menu. However, some function items in the menus may only be enabled in the particular
source modes.
CHANNEL MENU
The Channel menu in TV mode shows as below.
1. Tuning Band: Select TV source signal from the Air (antenna) or Cable (CATV).
2. Channel Strength: Show the intensity of the received DTV signal.
3. Auto CH Search: Automatically scan all NTSC / ATSC TV channels and then store in the channel table. In channel
scan process, the OSD can display the number of channels which had been found.
4. Add on CH Search: Add channels which are new found.
5. Channel List: Show the Channel List. User can edit (add/delete) the channel numbers.
6. Channel Labels: Show the NTSC / ATSC TV Channel Labels menu for user modifying channel labels specifically.
7. FAV Channel Setting: Show the Favorite Channel List. User can edit (add/delete) the favorite channels.
VIDEO MENU
The Video menu in most source modes shows as below. It provides several video adjustment items for user fine
tuning the video display.
Only in VGA source mode, the Video menu simply provides Picture mode, Color Temp, Backlight, Aspect Ratio,
Preset items.
1. Picture Mode: Adjust the best picture appearance from selecting the preset value of Vivid, Standard, Eco, Movie,
or Personal.
2. Brightness: Video brightness adjustment, the tuning range is 0 ~ 100.
3. Contrast: Video contrast adjustment, thetuning range is 0 ~ 100.
4. Sharpness: Video sharpness adjustment,the tuning range is 0 ~ 100.
5. Color: Video color chroma adjustment,the tuning range is 0 ~ 100.
6. Tint: Video tint adjustment, the tuning range is R50 ~ G50.
7. Color Temp: Three color temperature modes. (Normal / Warm / Cool)
8. Noise Reduction: Gives four NR effect degrees, such as: Low, Mid, High and Off.
9. Adaptive Contrast: Choose On or Off to adjust the gamma after analyzing the input signal automatically.
10. Backlight: Backlight strength adjustment,the tuning range is 0 ~ 30.
11. Aspect Ratio: Choose the display aspect: Normal, Zoom1, Wide, Zoom2, or HDMI PC mode.
12. Preset: Restore the default video settings.
7
AUDIO MENU
The Audio menu in TV mode shows as below.
It provides audio adjustment for user to modify the audio setting. Audio language setting is only available with ATSC
TV source, the option is disable under other source modes.
Sound Mode: Choose the audio mode: Personal, Music, or Speech.
2. Bass: Bass tone adjustment, the tuning range is 0 ~ 63. (The default state is enabled.)
3. Treble: Treble tone adjustment, the tuning range is 0 ~ 63. (The default state is enabled.)
4. Balance: Audio balance adjustment, the tuning range is L50 ~ R50.
5. Audio Source: Select the audio source from Mono, Stereo, or SAP. (This function works in ATV only.)
6. Audio Language: Change the audio language setting on ATSC TV programs. The number of the supported
audio languages depends on the ATSC TV programs. (English / Français / Español)
7. SPDIF: Digital audio output format. Select from RAW and PCM. (This function works in DTV only.)
8. Speaker: Choose to turn on / off the TV internal speaker. The digital audio output signals and earphone output
signals will not be turned off even though the TV speaker is off. The default setting is On.
9. AVL: Choose On or Off to adjust volume to be consistent across programs and channels automatically.
10. Preset: Restore the default audio settings.
FEATURE MENU
The Feature menu in TV mode shows as below.
This menu gives users the most flexibility to satisfy their generally demands. According to the various requirements
in different source modes, certain features should be hidden (disable) on the menu. The detailed footnotes will be
described clearly below.
1. Menu Language: Select the menu display language. (English / Français / Español)
2. Time: Set current time. The sub-menu includes Time Mode, Time Zone, and Daylight Savings.
[Time Mode] ů Choose from Auto or Manual.
[Time Zone] ů Set current time zone.
[Daylight Savings] ů Set to On or Off.
8
3. Transparency: Adjust the transparency of the on-screen menu from range 0 to 10.
4. Password Setting: Change the 4-numeral parental control password. Three steps are
required for changing the password: Enter Old Password -> Enter New Password ->Confirm New Password. Note:
This item is only available in TV, Composite and S-Video source modes. The default password is ό0 0 0 0ύ.
5. Parental Control: Provide the parental Control (V-chip) function setting. Before entering the Parental Control
sub-menu, user has to key in the password first. Enter the Parental Lock item, then the user can
modify the restricted table about MPAA or TV Rating respectively. While exiting the sub-menu, the parental control
function is working. The inhibitive channels or source signals can be unlock through key in the correct password.
Note: This feature is only available in TV, Composite and S-Video source modes.(The default password is: 0 0 0 0.)
[Button Lock] – Select On or Off to lock or unlock the control buttons on the side panel of the TV. When this
function enables, the control buttons on your TV will be locked and TV only can be controlled by remote control only.
[Block Unrated TV] – When Block Unrated TV is set to on, your TV will block unrated program.
[USA Parental Locks] – Set the parental control level by MPAA or TV Rating.
[Canadian Parental Locks] – Set the parental control level by English Rating or French Rating.
[Open V-Chip] – Open V-Chip is an advanced V-Chip rating system for digital channels that are received.
The rating table will be updated by downloading the RRT5 data for blocking.
9
6. Closed Captions: Select a closed caption options. (Off / On / With Mute)
7. Analog Captions: Select an analog caption options. (CC 1-4 / TEXT 1-4)
8. Digital Captions: Select a digital caption options. (SERVICE 1-6)
9. Digital Captions Setup: Provide numerous options for setting the digital closed caption style in the sub-menu.
[Style] – Set to Automatic or Customer mode. If Custom mode is selected, user can modify the detail styles
described below. The setting result will be shown immediately on the bottom of the submenu OSD. Note: This
feature is only available in Digital TV (ATSC) mode.
[Size] – Digital closed caption font size, which can be set as Automatic, Small, Normal, or Large.
[Font] – Digital closed caption font style,which can be chosen as Automatic, Default,or Font 1 ~ 7.
[Text Color] – Automatic / White / Red / Green / Blue / Yellow / Magenta / Cyan / Black.
[Text Opacity] – Automatic / Solid /Flashing / Transparent / Translucent.
[Background Color] – Automatic /Black / White/ Red / Green / Blue / Yellow /Magenta / Cyan.
[Background Opacity] – Automatic /Solid / Flashing / Transparent / Translucent.
[Edge Effect] – Automatic / None/ Raised / Depressed / Uniform / Left / Shadow / Right Shadow.
[Edge Color] – Automatic / Red / Green / Blue / Yellow / Magenta / Cyan / Black / White.
10. Input Labels: User can edit the input labels.
11. Component Setting: This option only shows and is available in component mode,which provides fine tuning
component display.
[Phase] – Adjust Picture Phase to reduce Horizontal-Line noise. The tuning range is from 0 to 31.
[Preset] – Restore the default component setting values.
12. MultiMedia Menu: This option shows the photos in JPEG formats and plays the music in MP3 formats that stored
in a USB storage device.Note: File number is limited to 1000 files.
JPEG sizes are limited as followed:
For 19"/32": 10928x6114
For 24"/42": 15360x8640
There are two ways to enter JPEG Viewer and MP3 MusicBox interface:ŻŻ After plugging USB storage device into
USB hub, Multimedia List menu will display.
Ż Select MultiMedia Menu in Feature Menu to choose JPEG Viewer or MP3 MusicBox. These two items are
activated only if the USB storage device is plugged into the USB hub.
[JPEG Viewer] ů Press Menu to display control menu. Press Enter to enlarge the selected photo (orange frame) in
browser.
Ż Image Delay: Set display time for each picture in slide show. There are three options: Fast, Slow, and Normal.
Ż Music On Slide Show: Enable background Music during slide show. It will play with the MP3 file sequence in
current folder repeatedly. Music On Slide Show item will be grayed out if there is no MP3 file in current folder.
Ż Start Slide Show: Enter Slide Show mode.
10
Ż Rotate Photo: Rotate selected picture. (0/90/180/270)
•• Back to Upper Folder: Return to the upper folder.
•• Back to Root Folder: Return to root folder.
•• Back To Browser: Return to Browser mode. (Photo page with control menu.)
•• Exit: Exit JPEG Viewer and return to original source. (Browser with Control menu.)
[MP3 MusicBox]
•• ListInfoBar (at the bottom): This part contains play list information as:
“Current Directory”, “Total File(s)”,“Total Folder(s)”, “Current Item” in current directory and Key Help Bar.
•• PlayList (on the right side): This part contains MP3 music files.
••ControlPanel (on the left side):
Bass, Treble, Balance, Volume: Adjust the audio tone.
Mute Screen: This provides an option for enabling (On) or disabling (Off) auto turn-off backlight feature while
playing MP3 media. The setting status is valid in MP3 media player interface only. After setting to On state, backlight
will be turned-off automatically after 10 seconds no any key pressed. Press any key to turn on the TV immediately;
but if there’s no other keys pressed after 10 seconds, it will be turned-off again.
Preset: Resetting MP3 relative audio parameters to the default values.
Exit MP3MusicBox: Exit MP3MusicBox interface.
13. Reset to Default: Restore all the default settings.
VGA MENU
This option only shows and is available in VGA mode, which provides several items for the VGA display fine tuning.
1. H-Position: Adjust the horizontal position of the picture. (0-40)
2. V-Position: Adjust the vertical position of the picture. (0-16)
3. Clock: Adjust picture clock to reduce Vertical-Line noise. (0-16)
4. Phase: Adjust picture phase to reduce Horizontal-Line noise. (0-31)
5. Auto Adjust: Adjust the settings automatically.
6. Preset: Restore the default VGA setting values.
11
2.3 Front Panel Control Knobs
1.
VOL +
VOL +: Press to increase the sound volume level.
2.
VOL -
VOL -: Press to decrease the sound volume level.
3.
CH Ÿ
CH Ÿ: Press to select the next higher Programme number.
4.
CH ź
CH ź: Press to select the next lower Programme number.
5.
MENU
Menu key: Press to open or exit the OSD (on-screen display) menu.
6.
INPUT
Input key: Press to select the input source.
7.
POWER
Power key: Press to turn on / off (standby) the TV set. (Press to turn on TV after the
power on status, LED had changed to the Blue colour and stopped flashing.)
12
2.4 How to Connect
1. HDMI – Connect the primary source for digital video such as a DVD multimedia player or set top box through this
all digital connector.
2. PC IN – Connect the video and audio cables from a computer here.
3. AV IN (AV/S-VIDEO) – Connect the input source for composite video devices, such as a VCR or video game. Use
the white and red connectors to connect the external audio from the same source. The signal being carried by the
S-Video cable and connector, if connected, will take priority over the Video RCA connector (yellow connector).
444 COMPONENT (Y/Pb/Pr with Audio L/R) – Connect the primary source for component video devices such as a
DVD Player or set top box here. Use red for Pr, blue for Pb, green for Y, red for right audio (R) and white for left
audio (L) inputs.
5. ANTENNA/CABLE DIGITAL/ANALOG – Connect to an antenna or digital cable (outof- the-wall, not from Cable
Box) for Digital TV.
6. SPDIF (Optical Digital Audio Out) – When a digital audio signal is associated with the input selected for viewing,
the digital audio will be available on this SPDIF connection to your home theater system.
7. USB PORT – Insert USB storage device to the USB port to view photos or listen to music.
8. Earphone Output – Connect to the headphones. When the headphone is inserted to the plug, all the speakers
will be muted.
Once your equipment is connected, use the following procedure to view the input signal:
Press the Source button on the remote control to select the relevant source to view. (ex: Press Comp
button to select “Component” if you have connected a video recorder to Component socket.)
13
3. Input/Output Specification
3.1 Input Signal Connector
D-SUB
Pin No.
Description
Pin No.
Description
1
Red Video
9
No Pin
2
Green Video
10
Sync GNDʳ
3
Blue Video
11
SDA(Remote Control)
4
SCL(Remote Control)
12
Serial Data for DDC
5
Ground
13
H. Sync
6
Red Ground
14
V. Sync
7
Green Ground
15
Serial Clock for DDC
8
Blue Ground
HDMI
Pin No.
Description
Pin No.
Description
1
TMDS Data2+
11
TMDS Clock Shield
2
TMDS Data2 shield
12
TMDS Clock-
3
TDMS Data2-
13
CEC
4
TMDS Data1+
14
NC
5
TMDS Data1 shield
15
SCL
6
TMDS Data1-
16
SDA
7
TMDS Data0+
17
DDC/CEC Ground
8
TMDS Data0 shield
18
+5V Power
9
TMDS Data0-
19
Hot Plug Detect
10
TMDS Clock+
14
3.2 Input Signal Timing
HL32D2 Analog RGB
VESA MODES
Horizontal
Vertical
Resolution
Total
Nominal
Frequency(KHz)
Sync
Polarity
Nominal
Freq.(Hz)
Sync
Polarity
Nominal
Pixel Clock
(MHz)
640x480@60Hz
800 x 525
31.469
N
59.940
N
25.175
640x480@72Hz
832 x 520
37.861
N
72.809
N
31.500
640x480@75Hz
840 x 500
37.500
N
75
N
31.500
720x400@70Hz
900 x 449
31.469
N
70.087
P
28.322
800x600@56Hz
1024 x 625
35.156
P
56.250
P
36.000
800x600@60Hz
1056 x 628
37.879
P
60.317
P
40.000
800x600@72Hz
1040 x 666
48.077
P
72.188
P
50.000
800x600@75Hz
1056 x 625
46.875
P
75
P
49.500
1024x768@60Hz
1344 x 806
48.363
N
60.004
N
65.000
1024x768@70Hz
1328 x 806
56.476
N
70.069
N
75.000
1024x768@75Hz
1312 x 800
60.023
P
75.029
P
78.750
CVT-0.92M9
1280x720@60Hz
1664 x 748
44.722
N
59.855
P
74.500
WXGA
1280x768@60Hz
1440 x 790
47.396
P
59.995
N
68.250
WXGA
1360x768@60Hz
1720 x 795
75.000
P
60.020
P
162.000
Mode
VGA
DOS
SVGA
XGA
HL42XD2 Analog RGB
Horizontal
Vertical
Resolution
Total
Nominal
Frequency
(KHz)
Sync
Polarity
Nominal
Freq.(Hz)
Sync
Polarity
Nominal Pixel
Clock (MHz)
640x480@60Hz
800 x 525
31.469
N
59.940
N
25.175
640x480@72Hz
832 x 520
37.861
N
72.809
N
31.500
640x480@75Hz
840 x 500
37.5
N
75
N
31.500
720x400@70Hz
900 x 449
31.469
N
70.087
P
28.322
800x600@56Hz
1024 x 625
35.156
P
56.25
P
36.000
800x600@60Hz
1056 x 628
37.879
P
60.317
P
40.000
800x600@72Hz
1040 x 666
48.077
P
72.188
P
50.000
800x600@75Hz
1056 x 625
46.875
P
75
P
49.5
1024x768@60Hz
1344x806
48.363
N
60.004
N
65.000
1024x768@70Hz
1328x806
56.476
N
70.069
N
75.000
1024x768@75Hz
1312x800
60.023
P
75.029
P
78.750
1280x720@60Hz
1664x748
44.772
N
59.855
P
74.5
1280x768@60Hz
1440x790
47.396
P
59.995
N
68.250
1280x1024@60Hz
1688x1066
63.981
P
60.020
P
108.000
1360x768@60Hz
1792x795
47.712
P
60.015
P
85.500
1440x900@60Hz
1600x926
55.469
P
59.901
N
88.750
1680x1050@60Hz
2240x1089
65.290
N
59.954
P
146.25
1600x1200@60Hz
2160x1250
75.000
P
60.000
P
162.00
1920x1080@60Hz
2200x1125
67.500
P
60.000
P
148.500
15
HL32D2 Component
Display performance description
Industry
Code
Input signal
Format
480i
480P
720P
1080i
720 x 480 i
720 x 483 P
1280 x 720 P*
1920 x 1080 i*
Interlace
rate
Partition
2:1
1:1
1:1
2:1
Total
Line Per
Frame
525
525
750
1125
Horizontal
Frequency
(KHz)
15.75
31.50
45
33.75
Sampling
Frequency
(MHz)
13.51
27.03
74.25
74.25
Vertical
Frequency (Hz)
60
60
60
60
ASPECT
16:9
16:9
HL42XD2 Component
Display performance descrip
Industry
Code
Input signal
Format
480i
Interlace
rate
Partition
Total
Line Per
Frame
Horizontal
Frequency
(KHz)
Vertical
Frequency (Hz)
Sampling
Frequency
(MHz)
720x480i
2:1
525
15.75
60
13.51
480P
720x480P
1:1
525
31.50
60
27.03
720P
1280×720P*
1:1
750
45
60
74.25
16:9
1080i
1920×1080i*
2:1
1125
33.75
60
74.25
16:9
1080P
1920x1090P
1:1
1125
67.5
60
148.5
16:9
ASPECT
HL32D2&HL42XD2 HDMI
VESA MODES
Horizontal
Vertical
Mode
Resolution
Total
Nominal
Frequency
(KHz)
Sync
Polarity
Nominal
Freq.
(Hz)
Sync
Polarity
Nominal
Pixel Clock
(MHz)
DOS
720 x 400
900 x 449
31.469
N
70.087
P
28.322
VGA
640 x 480
800 x 525
31.469
N
59.940
N
25.175
SVGA
800 x 600
1056 x 628
37.879
P
60.317
P
40
XGA
1024 x 768
1344 x 806
48.363
N
60.004
N
65
WXGA
1280 x 768
1664 x 798
47.396
P
59.995
N
68.25
CVT-0.92M9
1280 x 720
1664 x 748
44.772
N
59.855
P
74.5
WXGA
1360x768@60Hz
1720 x 795
75.000
P
60.020
P
162.000
1080P
1920 x 1080P
2200 x 1125
67.5
60,
148.5
720P
1280 x 720P
1650 x 750
45.00
60,
74.25
1080i
1920 x 1080i
2200 x 1125
33.75
60,
74.25
480P
720 x 480P
858 x 525
31.50
60,
27.03
480i
720 x 480i
1716 x 525
15.75
60,
13.51
16
4. Mechanical Instructions
Note: Below are only the critical steps of disassembing the HL32D2 and HL42XD2 TV, and may be there is a little
difference for the following pictures with the actual TV, only for your reference.
HL32D2 Front and Rear View
1. Remove the BASE ASS’Y
Unscrew the 4 screws as Fig 1.
Fig 1
2. Remove the REAR COVER ASS’Y
Unscrew the 13 screws as Fig 2.
Fig 2
17
3. Remove all the detachable HARNESS or CABLE.
Disconnect the harness and cable as Fig 3.
Fig 3
4. Remove the MAIN, POWER, INVERTER BOARD and BASE-SUPPORT.
Unscrew the 22 screws as Fig 4.
Fig 4
18
5. Remove the BEZEL and PANEL.
a. Unscrew the 4 screws as Fig 5a.
b. Remove the 4 washers as Fig 5b.
Fig 5a
Fig 5b
The BEZEL.
Fig 5
19
HL42XD2 Front and Rear view
1. Remove the NECK COVER and STAND ASS’Y.
a. Unscrew the 5 screws to remove NECK COVER as Fig 1a.
b. Unscrew the 1 screw to remove STAND ASS’Y as Fig 1b.
Fig 1a
Fig 1b
20
2. Remove the REAR COVER.
Unscrew the 12 screws for rear cover and 3 screws for HDMI commector as Fig 2.
\
Fig 2
3. Remove the all the detachable HARNESS.
Disconnect all the detachable HARNESS as Fig 3.
Fig 3
21
4. Remove the VESA BRACKET LCM.
Unscrew the 2 screws to remove VESA BRACKET LCM as Fig 4.
Fig 4
5. Remove the MAIN, POWER and INVERTER BOARD.
Unscrew the 17 screws as Fig 5.
Fig 5
22
6. Remove the STAND BRACKET and BOLT.
Unscrew the 7 screws and 4 bolts as Fig 6.
Fig 6
7. Remove the BEZEL and PANEL.
Unscrew the 6 screws as Fig 7.
Fig 7
23
The BEZEL.
24
5. Repair Flow Chart
1. No power
No power (LED “Off”)
No
Check the AC input and
the power is “On”?
Power “On”
Yes
Power board output=5V?
Yes
Check the IR board and LED
Replace the IR board
No
Replace the main board
25
No
Replace the power board
2. Can’t start
Can’t start (LED Red)
No
Replace the power board
Power board output᧹24V?
Yes
Yes
Replace the key board
Check the power key is under control?
No
Yes
Replace the IR board
Check the IR receiver is normal?
No
Replace the main board
No
Replace the Power board
26
3. No display
No display (LED Blue)
No
Check TV is under control and power
on/off by remote control and power key?
Replace the main board
Yes
Check the backlight is
“On”?
Yes
No
Check the LVDS cable
Check the B/L
signal is available?
No
Yes
No
Reinsert or replace the
LVDS cable
Panel Vcc = 5 V?
Yes
Replace main board
Power board output᧹24V?
No
No
Yes
Yes
Replace the power board
Replace the main board
Replace the Panel
Replace the Panel
27
4. Sound problem
No sound or sound abnormal
Check the audio source connection
and the TV system are correct˛
No
Reinsert the audio cable or
change the TV system
Yes
Check the TV is muted, adjust the
volume or enter the menu to reset?
No
Check the cable between the
speakers and main board is ok?
No
Replace the cable
Yes
Check the speaker resistance value is in spec
(Remark: The value is marked on the speaker)?
No
Replace the main board
Yes
Replace the speaker
28
5. Remote Control malfunction
OSD is unstable or can’t work normally
No
Key board connected properly?
Reconnect the key board
Yes
No
Buttons are ok?
Replace the button function
Yes
No
Key board is ok?
Replace the key board
Yes
Replace the main board
6. OSD is unstable or can’t work normally
Remote Control malfunction
Yes
Check the remote control battery is
not properly placed or no power?
Replace the battery
No
Yes
Use the other remote controls
Replace the remote control
No
Yes
Whether the IR board is
abnormal?
Replace the IR board
No
Replace the main board
29
6. PCB Layout
6.1 Main Board
715G3269M01001005K
30
31
32
33
6.2 Power Board
HL32D2
715G3332
1
34
715G3645P01W30003S
35
HL42XD2
715G3351
1
36
37
38
715G3358
2
39
6.3 Key Board
715G3293
1
6.4 IR Board
715T3294 1
40
7. Adjustment
It’s no need to adjust the white balance for this model, do ADC only.
Step1: Turn on the TV, press “Menu”, then press number key 1 Æ 9 Æ 9 Æ 9 and “ENTER”, it will achieve the factory
mode. Take the following picture for example:
Step2: Change TV, press the “Current Source” to Component mode and change signal to 1080i mode, press the
“Auto Color”;
Step3: Change TV, press the “Current Source” to PC mode and change signal to PC TIMING 137(1024X768);
Pattern 147 (16 Grays), press the “Auto Color”.
41
Y/C
YPbPr
YPbPr
RGB
S-VIDEO1
YPbPr1
YPbPr2
VGA
TMDS
TMDS
TMDS
HDMI-2
HDMI-3
HDMI-4
VGA AUDIO-R\L
YPbPr2 AUDIO-R\L
YPbPr1 AUDIO-R\L
AV2 AUDIO-R\L
AV1 AUDIO-R\L
TMDS
HDMI-1
AF24BC02
I2C
CVBS
VIDEO2
SiI9185A
TMDS
TMDS
Hsync, Vsync
TPD12S520DBTR
SN74LVC1G17
CVBS
CVBS
VIF
VIDEO1
Tuner
ENV56S02D8F
8. Block Diagram
ZR39775HGCF
LVDS
TL072CDR
Earphone Amplifier
TPA6113A2DR
Audio Amplifier
TPA3121D2PWPR
M24C64
EJTAG
GPIO
FLASH ROM
MX25L3205DMI-12G
DDRII
H5PS5162FFR-25C
LCD PANEL
LINE OUT
R/L
S/PDIF
EAR PHONE
SPEAKER
42
VCC5D
+5VSB
VCC5D
+5VSB
P12V
P12V
P24V
U707 SC4524BSETRT
U704 SC4524BSETRT
U703 G1084-33T43Uf
U706 SC194BM LTRT
U710 SC4525BSETRT
U708 G9084T43U
VCC1V1
D1V8
D3V3
U709 AZ1117D-5.0-E1
D3V3
VCC5D
+5VSB
P12V
P24V
U404 M X25L3205DM I-12G
U401 ZR39775HGCF
U704 SC4524BSETRT
U707 SC4524BSETRT
U703 G1084-33T43Uf
U604 TPA6113A2DR
U405 M 24C64
8.3V
U709 AZ1117D-5.0-E1
FOR PANEL LVDS
FOR TPA3123D2PWPR
U410 H5PS5162FFR-25C
U401 ZR39775HGCF
U401 ZR39775HGCF
For EEPROM
For SPI Flas h
For ZR39775
D1V8
VCC1V1
For Digital Circuit
D3V3
U702 AIC1084-18PE
For TPA6113A2DR
3V3_STB
FOR VGA EDID
For ZORAN s tandby pow e r
U706 SC194BM LTRT
U208 AF24BC02-SI
+5VSB
U708 G9084T43U
U602 TPA3123D2PWPR
FOR Inve rte r
TU201
FOR TUNER+5V
1V8_STB
5VT
For DDR II
For ZR39775
For ZR39775 Core
FOR M CU 1V8_STB 1V8_STB
5VT
U702 AIC1084-18PE
PANEL_5V
3V3_STB
8V3
Inverter & Audio Amplifier
POWER INPUT TYPE +5VSB , P12V, P24V
POWER
BOARD
P12V
P24V
4 Pin
CN01
Key
Board
Inverter
Board
5 Pin
3 Pin
(2nd NC)
12 Pin
5 Pin
CN01
CN901
CN902
IR Board
Power Board
CN802
CN801
HL32D2
CN8802
CN8801
CN8803
43
4 Pin
12 Pin
9. Wiring Diagram
3 Pin
6 Pin
3 Pin
CN606
CN701
CN403
10 Pin
Tuner
TU201
Panel
Speaker R/L
U401
ZR39775HGCF
Scaler IC
CN405
24 Pin
LVDS Cable
4 Pin
CN01
Key
Board
CN8801
CN8802
To panel
6 Pin
3 Pin
CN01
CN901
IR Board
Power Board
5 Pin
3 Pin
(2nd NC)
HL42XD2
CN8803 CN8804 CN8805 CN8806 CN8807 CN8808 CN8809 CN8810
Inveter Board
CN802
CN801
CN903
12 Pin
5 Pin
44
CN606
CN701
4 Pin
12 Pin
CN403
10 Pin
Tuner
TU201
Panel
Speaker R/L
U401
ZR39775HGCF
Scaler IC
CN405
24 Pin
LVDS Cable
TU201
TU_GND
1
2
3
5
6
8
9
10
11
13
14
15
16
17
19
20
21
22
23
24
25
5V :
BB=15mA(MAX)
+B=140mA(MAX)
VB=70mA(MAX)
21
20
19
18
17
16
15
14
13
12 ENV56S02D8F
11
10
9
8
7
6
5
4
3
2
1
TU_GND
NC
BB
AGC
NC
BT Monitor
NC
NC
NC
NC
SCL
SDA
NC
IF AGC
+B
IFD-out1
IFD-out2
IF Monitor
TH1
TH2
TH3
TH4
TUNER
C269
22pF
C268
C264
NC/0.0022uF
22pF
NC/0.0022uF
C217
TUNER_CVBS
0.1uF/16V
C218
R212
C219
NC/22pF
NC/75 1/10W 5%
NC/22pF
C220
TV_CVBS
NC/75 1/10W 5%
R213
TV_CVBS
4
C214
0.001uF
1
2
0.22uH 5%
L201
C210
C204
82pF
0.15uH 5%
L202
SIF_IN
45
Place parts very close to U401
2
0.22uH 5%
5,7
5,7
1
IF_AN
IF_AP
I2C1_SCL
I2C1_SDA
0.001uF
L203
I2C1_SCL
I2C1_SDA
C208
IF_AGC
TUNER_CVBS
R205
R206
2K2 1/10W 5%
2K2 1/10W 5%
R204
R203
0.0022uF
NC/0R05 1/10W 5% SIF_IN
R201
C206
D3V3
0.0022uF
100R 1/10W 5%
100R 1/10W 5%
1uF/25V
C267
C262
C203
2 600 OHM
0.1uF/16V
NC/0.0022uF
C202
2 NC/600 OHM
FB203 1
0.1uF/16V
C201
2 600 OHM
5VT
FB202 1
0.0022uF
0.0022uF
FB201 1
C266
C265
715G3269M01001005K
03) Tuner
10.1 Main Board
10. Schematic Diagram
2
1
NC
C216
NC
C209
8,10 PANEL_CTRL2
1
1
2K 1/10W 5%
NC/20K 1/10W 5%RF_AGC
PARAM0
TP1
TP2
K22
NC/33R 1/10W 5%
Place R211 & C221
close to U401
R233
0.1uF/16V
C221
R211
R210
4K7 1/10W 5%
R209
PANEL_CTRL2
IF_AGC
33R 1/10W 5%
0.1uF 16V 0402
0.1uF 16V 0402
C213
C215
IF_AINN
IF_AINP
3K9 1/10W 5%
0.1uF 16V 0402
0.1uF 16V 0402
0.01uF
SIF_N
SIF_P
R207
C211
C212
C205
R208
D3V3
0.01uF
C207
NC/47R 1/10W 5%
8 DEMOD_RSTN
NC/0.1uF/16VR202
If SIF_IN is not use,
C207 change to 0.01uF
Demodulator
ZR39775HGCF-BD
GOE_N
GWE_N
GPO/GADR1_CLE
STV2/GCS_N0
CPV2/GDAT6
TP/GDAT5
RVS/GDAT7
OE2/GADR0_ALE
STH1/GDAT4
STH2/GDAT3
CPV/GDAT2
OE1/GDAT1
STV1/GDAT0
Guest Bus
U401H
ZR39775HGCF-BD
IF_AGC
IF_DVAL_GPIO
RF_AGC
DEMOD_CLKO
MPEG_FAIL
DMOD_RST_N
SA_DATA
PARAM0
IF_VREFN
IF_VREFP
IF_RBIAS
IF_VINBIAS
IF_VCM
IF_AINN
IF_AINP
SIF_AINN
SIF_AINP
ZR39775HGCF-BD
NC68
No Connect Pins
U401L
V23
V22
U22
V24
W24
W25
W23
W22
Y 26
Y 25
Y 24
Y 23
Y 22
AF7
AA5
AF8
AD8
AC7
AC8
AC6
AE7
AF1
AE1
AD3
AD2
AD1
AF2
AE2
AF4
AE4
U401P
YPbPr2
Input
YPbPr1
Input
1
8
88G
C248
ZD201
5
6
4
5
6
R243
R249
5
6
I/O3 I/O2
VDDGND
I/O4 I/O1
3
2
1
1
1
1
75R 1/10W 1%
75R 1/10W 1%
75R 1/10W 1%
R250
FB220
Pr2
4
R248
FB219
Pb2
VCC5D
FB218
Y2
3
1
1
1
R234
R232
30 OHM
2 30 OHM
2
2 30 OHM
2 30 OHM
2 30 OHM
2 30 OHM
2 30 OHM
2 30 OHM
10K 1/10W 5%
10K 1/10W 5%
AV2_CVBS
75R 1/10W 1%
75R 1/10W 1%
75R 1/10W 1%
1
4
5
6
3
2
1
U204
AZC099-04S
I/O3 I/O2
VDDGND
I/O4 I/O1
R244
2
VCC5D
FB217
Pr1
3
FB216
Pb1
4
R242
0R05 1/10W 5%
0R05 1/10W 5%
2 30 OHM
1
100pF
C249
1
1
AV2_S_DET 8
75R 1/10W 1%
75R 1/10W 1%
FB215
U203
AZC099-04S
VPORT0603100KV05
VPORT0603100KV05
100pF
FB211
AV2_R
3
2
1
FB210
ZD202
1
75R 1/10W 1%
FB209
I/O3 I/O2
VDDGND
I/O4 I/O1
R231
4
5
6
FB208
R226
S2C
R225
AV1_CVBS
2 30 OHM
2 30 OHM
AV1_S_DET 5
Active L
FB207
D3V3
2 30 OHM
10K 1/10W 5%
100R 1/10W 5%
U212
AZC099-04S
1
1
75R 1/10W 1%
75R 1/10W 1%
R217
S2Y
R278
R279
VPORT0603100KV05
ZD207
1
3
2
1
75R 1/10W 1%
R221
FB206
I/O3 I/O2
VDDGND
I/O4 I/O1
AV2_L
CV2
4
5
6
R216
FB205
S1C
U201
AZC099-04S
FB204
Active L
Y1
78 1360S
JACK
CN205
5
1
3
VCC5D
CV1
VCC5D
D3V3
10K 1/10W 5%
100R 1/10W 5%
S1Y
R276
R277
2
78 1360C
JACK
CN204
88G
1
2
3
4
5
6
7
8
9
7813C19C
JACK
CN203
C
7
6
3
5
DIN JACK
88G 100 11 ST
6
2
4
4
78 13932
2
CN202
88G
CN201
JACK
88G
AV2 Input
(Side)
AV1 Input
(Rear)
2
1
04) AV/YPbPr Inputs
2
1
2
1
R237
AV2_Audio_R 11
AV2_Audio_L 11
Y PbPr2_Pr
Y PbPr2_Pb
Y PbPr2_Y
Y PbPr1_Pr
Y PbPr1_Pb
Y PbPr1_Y
10K 1/10W 5%
10K 1/10W 5%
R236
S2_C
S2_Y
S1_C
S1_Y
46
6
6
6
3
VGA_R
VGA_G
VGA_B
TV_CVBS
VGA_R
VGA_G
VGA_B
Y PbPr2_Pr
Y PbPr2_Y
Y PbPr2_Pb
Y PbPr1_Pr
Y PbPr1_Y
Y PbPr1_Pb
AV1_CVBS
AV2_CVBS
TV_CVBS
C224
C225
S2_Y
S2_C
C271
C272
6 VGA_EDID_WP
10 PANEL_CTRL1
VGA_EDID_WP
PANEL_CTRL1
6
6
75R 1/10W 1%
0.22uF
0.22uF
NC/0.22uF
C244
C245
C246
C247
C240
C241
C242
C243
C236
C237
C238
C239
R222
R219
R220
R238
C251
R235
VGA_HSYNC
VGA_VSYNC
NC/75R 1/10W 1%
NC/75R 1/10W 1%
0.22uF
0.22uF
0.22uF
0.22uF
NC/22pF NC/22pF NC/22pF
C270
R281
C230
C231
C232
R268
R280
C222
C223
S1_Y
S1_C
0.22uF
0.22uF
0.22uF
0.01uF
0.22uF
0.22uF
0.22uF
0.01uF
0.22uF
0.22uF
0.22uF
0.01uF
75R 1/10W 1%
75R 1/10W 1%
75R 1/10W 1%
R5
T5
T2
T1
T3
T4
W2
W1
Y1
Y2
U2
U1
V1
V2
AA3
AB3
AB4
AA4
U5
V5
U4
V4
U3
V3
4.7uF/10V
62K OHM 1/10W
0.47uF/16V
C250
W3
K5
L5
M5
N5
L4
AB1
AA2
AA1
AB11
NC/33R 1/10W 5% AE9
VGA_HSY NC
VGA_VSY NC
Place parts very close to U401
ZR39775HGCF-BD
REFNODE_GND_CVBS
REFNODE_GND_G
REFNODE_GND_R
REFNODE_GND_B
REFNODE_GND_Ch
RSET
VCOM
VREFN
VREFP
VGA_SCL_GPIO_P28
VGA_SDA_GPIO_P29
AFE_HS_IN
AFE_VS_IN
VGA_R0
VGA_G0
VGA_B0
SOG_IN0
VIN_R2
VIN_G2
VIN_B2
SOY _IN1
VIN_R1
VIN_G1
VIN_B1
SOY _IN0
CVBS0
CVBS1
CVBS2
CVBS3
SVIDEO2Y
SVIDEO2C
SVIDEO1Y
SVIDEO1C
SVIDEO0Y
SVIDEO0C
Video In I/F
U401F
NC
20
21
22
23
2
5
8
11
17
2
FB501
NC/120OHM
SHLD0
SHLD1
SHLD2
SHLD3
DSHLD0
DSHLD1
DSHLD2
CSHLD0
DDC_GND
NC
VCC5
SCL
SDA
CEC
HPD
TMDSC+
TMDSC-
TMDSD2+
TMDSD2-
TMDSD1+
TMDSD1-
TMDSD0+
TMDSD0-
HDMI
DSHLD0
DSHLD1
DSHLD2
CSHLD0
DDC_GND
NC
VCC5
SCL
SDA
CEC
HPD
TMDSC+
TMDSC-
TMDSD2+
TMDSD2-
TMDSD1+
TMDSD1-
TMDSD0+
TMDSD0-
HDMI
4
5
6
20
21
22
23
2
5
8
11
17
2
FB505
NC/120OHM
1
18
14
DDC1_SCL
DDC1_SDA
HDMI_CEC
HDMI_HPD1
15
16
13
19
4
5
6
14
20
21
22
23
24
25
26
2
5
8
11
17
FB506
120OHM
2
1
18
0.1uF/16V
I/O2 I/O3
GNDVDD
I/O1 I/O4
4
5
6
AZ1045-04SU
3
2
1
U510
NC/1K 1/10W 5%
10K 1/10W 5%
HDMI_CEC
10K 1/10W 5%
DDC0_SCL
DDC0_SDA
HDMI_CEC
HDMI_HPD0
R522
15
16
13
19
R521
HDMI0_CLKP
HDMI0_CLKN
10
12
R520
HDMI0_D2P
HDMI0_D2N
1
3
HDMI0_D2N
HDMI0_D2P
HDMI0_D1N
HDMI0_D1P
VCC5D
HDMI0_D0N
HDMI0_D0P
HDMI0_D1P
HDMI0_D1N
HDMI0_5V
HDMI0_CLKN
HDMI0_CLKP
HDMI0_D0P
HDMI0_D0N
4
6
VCC5D
HDMI1_D2N
HDMI1_D2P
HDMI1_D1N
HDMI1_D1P
7
9
C509
I/O2 I/O3
GNDVDD
I/O1 I/O4
U507
NC/AZ1045-04SU
3
2
C502
1
NC/0.1uF/16V
NC/1K 1/10W 5%
NC/10K 1/10W 5%
NC/10K 1/10W 5%
VCC5D
HDMI1_CLKP
HDMI1_CLKN
R513
10
12
R512
HDMI1_D2P
HDMI1_D2N
1
3
R511
HDMI1_D0N
HDMI1_D0P
HDMI1_5V
HDMI1_D1P
HDMI1_D1N
4
6
VCC5D
HDMI1_CLKN
HDMI1_CLKP
HDMI1_D0P
HDMI1_D0N
Rear HMDI1
88G 340 21 VD
SHLD_GND1
SHLD_GND2
SHLD1
SHLD2
SHLD3
SHLD4
SHLD5
CN503
I/O2 I/O3
GNDVDD
I/O1 I/O4
U503
NC/AZ1045-04SU
3
C501
2
1
NC/0.1uF/16V
HDMI2_D2N
HDMI2_D2P
HDMI2_D1N
HDMI2_D1P
7
9
Side HMDI2
NC
CN502
6
1
14
18
NC/10K 1/10W 5%
NC/1K 1/10W 5%
NC/10K 1/10W 5%
VCC5D
DDC2_SCL
DDC2_SDA
HDMI_CEC
HDMI_HPD2
R503
15
16
13
19
R502
HDMI2_CLKP
HDMI2_CLKN
10
12
HDMI2_5V
HDMI2_D2P
HDMI2_D2N
1
3
R501
HDMI2_D0N
HDMI2_D0P
HDMI2_D1P
HDMI2_D1N
4
6
Side HMDI1
SHLD0
SHLD1
SHLD2
SHLD3
DSHLD0
DSHLD1
DSHLD2
CSHLD0
DDC_GND
NC
VCC5
SCL
SDA
CEC
HPD
TMDSC+
TMDSC-
TMDSD2+
TMDSD2-
TMDSD1+
TMDSD1-
Line-1 NC
Line-2 NC
VDD GND
Line-3 NC
Line-4 NC
10
9
8
7
6
Line-1 NC
Line-2 NC
VDD GND
Line-3 NC
Line-4 NC
10
9
8
7
6
Line-1 NC
Line-2 NC
VDD GND
Line-3 NC
Line-4 NC
U504
10
9
8
7
6
Line-1 NC
Line-2 NC
VDD GND
Line-3 NC
Line-4 NC
10
9
8
7
6
Line-1 NC
Line-2 NC
VDD GND
Line-3 NC
Line-4 NC
10
9
8
7
6
Line-1 NC
Line-2 NC
VDD GND
Line-3 NC
Line-4 NC
U509
10
9
8
7
6
NC/AZ1045-04QU
1
2
3
4
5
NC/AZ1045-04QU
1
2
3
4
5
U508
NC/AZ1045-04QU
1
2
3
4
5
U506
NC/AZ1045-04QU
1
2
3
4
5
NC/AZ1045-04QU
1
2
3
4
5
U502
1
L511
2
1
L512
2
1
L509
2
1
L510
2
1
L507
2
1
L508
2
1
L505
2
1
L506
2
1
L503
2
1
L504
2
1
L501
2
1
L502
2
HDMI0_D1N
4
NC/90 ohm
HDMI0_D1P
3
HDMI0_D2N
4
NC/90 ohm
HDMI0_D2P
3
HDMI0_CLKN
4
NC/90 ohm
HDMI0_CLKP
3
HDMI0_D0N
4
NC/90 ohm
HDMI0_D0P
3
HDMI1_D1N
4
NC/90 ohm
HDMI1_D1P
3
HDMI1_D2N
4
NC/90 ohm
HDMI1_D2P
3
HDMI1_CLKN
4
NC/90 ohm
HDMI1_CLKP
3
HDMI1_D0N
4
NC/90 ohm
HDMI1_D0P
3
HDMI2_D1N
4
NC/90 ohm
HDMI2_D1P
3
HDMI2_D2N
4
NC/90 ohm
HDMI2_D2P
3
HDMI2_CLKN
4
NC/90 ohm
HDMI2_CLKP
3
HDMI2_D0N
4
NC/90 ohm
HDMI2_D0P
3
120OHM
FB502
47
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
NC/BAT54C
ZD501
4K7 1/10W 5%
R509
NC/27K 1/10W 5%
R504
2
R1X0R1X0+
AVCC33
R1X1R1X1+
AGND
R1X2R1X2+
AVCC18
DSDA1
DSCL1
RPWR1
CEC_D
CEC_A
AVCC33
HPD2
AVCC18
R2XCR2XC+
AGND
HD3V3
HDMI_CEC
HD3V3
2
HDMI2_CLKN
HDMI2_CLKP
HDMI_HPD2
DDC1_SDA
DDC1_SCL
HDMI1_5V
HDMI1_D2N
HDMI1_D2P
HDMI1_D1N
HDMI1_D1P
HDMI1_D0N
HDMI1_D0P
1
3V3_STB
3V3_STB
1
U501
NC/AZ1045-04QU
1
2
3
4
5
3
VCC5D
HDMI2_CLKN
HDMI2_CLKP
HDMI2_D0P
HDMI2_D0N
HDMI1_CLKP
HDMI1_CLKN
NC/2SK3018
Q501
HDMI3_CEC
27K 1/10W 5%
R515
3V3_STB
SiI9185ACTU
U505
C504
C505
HD3V3
C506
C511
C512
C513
R536
C508
C514
C515
C516
0.1uF/16V
0.1uF/16V
C507
HD1V8D
10K 1/10W 5%
R519
20
19
18
17
16
15
14
13
12
11
10
9
8
7
6
5
4
3
2
1
HDMI3_5V
AGND
R0XC+
R0XCAVCC18
HPD0
LSCL/PSEL1
LSDA/PSEL0
RESET#
ExtSWING
TXCTXC+
AGND
TX0TX0+
AVCC18
TX1TX1+
AGND
TX2TX2+
HD1V8A
R518
4
AV1_S_DET
0.1uF/16V
C521
R534
R535
R516
B6
A6
B7
A7
D6
HDMI3_CLKP
HDMI3_CLKN
HDMI3_SCL
HDMI3_SDA
HDMI3_HPD
AV1_S_DET
E6
B3
A3
D4
A1
A2
B1
B2
C1
C2
D1
D2
3,7
3,7
8
ZR39775HGCF-BD
GPIO_P20
HDMI2_5VSENSE
HDMI2_SCL
HDMI2_SDA
HDMI2_HPD
HDMI2_CLKP
HDMI2_CLKN
HDMI2_D0P
HDMI2_D0N
HDMI2_D1P
HDMI2_D1N
GPIO_P18
HDMI2 I/F
HDMI2_D2P
HDMI2_D2N
U401D
HDMISW_RSTN
I2C1_SCL
I2C1_SDA
ZR39775HGCF-BD
GPIO_P14
HDMI1_5VSENSE
HDMI1_SCL
HDMI1_SDA
HDMI1_HPD
HDMI1_CLKP
HDMI1_CLKN
HDMI1_D0P
HDMI1_D0N
HDMI1_D1P
HDMI1_D1N
GPIO_P12
HDMI1 I/F
HDMI1_D2P
HDMI1_D2N
U401O
10K 1/10W 5%
R541
HD3V3
C7
A5
B5
HDMI3_D0P
HDMI3_D0N
0R05 1/10W 5%
10K 1/10W 5%
C4
C5
HDMI3_D1P
HDMI3_D1N
33R 1/10W 5% I2C1_SCL
33R 1/10W 5% I2C1_SDA
100R HDMISW_RSTN
1/10W 5%
1V8_STB
R507
R508
2 120OHM
2 120OHM
1K8 1/10W 5%
1K8 1/10W 5%
HDMI3_SCL
HDMI3_SDA
HDMI3_HPD
1K 1/10W 5%
R517
HD3V3
HDMI3_D2N
HDMI3_D2P
HDMI3_D1N
HDMI3_D1P
HDMI3_D0N
HDMI3_D0P
HDMI3_CLKN
HDMI3_CLKP
HDMI_HPD0
HDMI0_CLKP
HDMI0_CLKN
820R 1/10WR 5%
R510
FB503 1
FB504 1
HDMI3_5V
B4
A4
HDMI3_D2P
HDMI3_D2N
Run As 100 Ohm Differential Pairs
HD1V8D
HDMI3_CEC 6
0.1uF/16V
0.1uF/16V
0.1uF/16V
0.1uF/16V
0.1uF/16V
0.1uF/16V
0.1uF/16V
C510
HD1V8A
0.1uF/16V
0.1uF/16V
0.1uF/16V
0.1uF/16V
C503
HDMI2_D0N
HDMI2_D0P
7
9
HDMI_HPD1
HDMI2_D1N
HDMI2_D1P
TMDSD0+
TMDSD0-
HDMI2_D2N
HDMI2_D2P
HDMI
HDMI0_D2P
HDMI0_D2N
CN501
HDMI0_5V
DDC0_SCL
DDC0_SDA
DDC2_SDA
DDC2_SCL
HDMI2_5V
Run As 100 Ohm Differential Pairs
HDMI0_D1P
HDMI0_D1N
05) HDMI Inputs
HDMI0_D0P
HDMI0_D0N
40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
25
24
23
22
21
AGND
R1XC+
R1XCAVCC18
HPD1
I2CSEL/INT
DGND
DVDD18
RPWR0
DSCL0
DSDA0
AVCC18
R0X2+
R0X2AGND
R0X1+
R0X1AVCC33
R0X0+
R0X0-
R2X0R2X0+
AVCC33
R2X1R2X1+
AGND
R2X2R2X2+
AVCC18
DSDA2
DSCL2
RPWR2
DVDD18
DGND
TEST
HPDIN
TSDA
TSCL
TPWR/I2CADDR
AGND
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
DSHLD0
DSHLD1
DSHLD2
CSHLD0
DDC_GND
NC
VCC5
SCL
SDA
CEC
HPD
TMDSC+
TMDSC-
TMDSD2+
TMDSD2-
TMDSD1+
TMDSD1-
TMDSD0+
TMDSD0-
HDMI
8
7
6
5
0.22uF
C256
HDMI4_CLKP
HDMI4_CLKN
DDC4_SCL
R526
DDC4_SDA
R527
HDMI_CEC
HDMI_HPD4_A R525
10
12
15
16
13
19
20
21
22
23
24
25
26
2
5
8
11
17
14
1
ZD502
VPORT0603100KV05
2
2
HDMI4_D2P
HDMI4_D2N
1
3
FB507
120OHM
HDMI4_D1P
HDMI4_D1N
4
6
1
HDMI4_D0P
HDMI4_D0N
R272
+5VSB
R285
100R 1/10W 5%
R264
R282
R273
R283
+5VSB
1K 1/10W 5%
R260
C254
1K 1/10W 5%
R258
NC/47pF
NC/330pF
C253
R538
5
10K 1/10W 5%
R540
Q503
2N7002K
4K7 1/10W 5%
HDMI_CEC
BAT54C
ZD503
22R 1/10W 5%
VGA_EDID_WP
EDID_WP
NC/4K7 1/10W 5%
R539
HDMI_HPD4
VCC5D
R266
4
5
2K2 1/10W 5%
6
2K2 1/10W 5%
R265
ZD203
2
0.1uF/16V
C255
3
2
1
D3V3
D3V3
3
2
3
2
R269
R275
23
22
21
20
HDMI4_CLKN
DDC4_SCL
DDC4_SDA
HDMI_HPD4
29
28
27
32
31
30
35
34
33
38
37
36
CE_REMOTE_OUT
DDC_CLK_OUT
DDC_DAT_OUT
HOTPLUG_DET_OUT
TMDS_CK+
TMDS_GND
TMDS_CK-
TMDS_D0+
TMDS_GND
TMDS_D0-
TMDS_D1+
TMDS_GND
TMDS_D1-
TMDS_D2+
TMDS_GND
TMDS_D2-
NC
ESD_BY P
GND
U511
48
TPD12S520DBTR
CE_REMOTE_IN
DDC_CLK_IN
DDC_DAT_IN
HOTPLUG_DET_IN
TMDS_CK+
TMDS_GND
TMDS_CK-
TMDS_D0+
TMDS_GND
TMDS_D0-
TMDS_D1+
TMDS_GND
TMDS_D1-
TMDS_D2+
TMDS_GND
TMDS_D2-
5V_SUPPLY
LV_SUPPLY
GND
16
17
18
19
13
14
15
10
11
12
7
8
9
4
5
6
1
2
3
+5VSB
3V3_STB
R262
1
1
FB222
FB223
R263
1
FB221
1K 1/10W 5%
3
2
R530
R531
HDMI3_CEC
R286
HDMI4_5V
5
RGB_VSY NC
0.1uF/16V
C261
3
2
3V3_STB
0.1uF/16V
VGA_VSY NC_DET
R532
390R 1/10W 1%
HDMI_3V3
4K7 1/10W 5%
10K 1/10W 5%
HDMI3_CEC
HDMI4_SCL
HDMI4_SDA
HDMI4_HPD
HDMI4_CLKP
HDMI4_CLKN
D3
C3
D7
D8
B11
A11
D9
B10
A10
A9
B9
C8
C9
HDMI4_D1P
HDMI4_D1N
HDMI4_D0P
HDMI4_D0N
B8
A8
HDMI4_D2P
HDMI4_D2N
NC/220R 1/10W 5%
U211
SN74LVC1G17DBVR
4
4
4
4
VGA_HSY NC_DET
VGA_B
VGA_G
VGA_R
U210
SN74LVC1G17DBVR
4
VGA_B
2 30 OHM
3V3_STB
VGA_G
2 30 OHM
C260
VGA_R
2 30 OHM
RGB_HSY NC
HDMI4_SCL
HDMI4_SDA
HDMI4_HPD
7K5 1/10W 5%
7K5 1/10W 5%
R529
3V3_STB
R528
0.1uF/16V
C518
VGA_VSY NC 4
VGA_HSY NC 4
75R 1/10W 1%
75R 1/10W 1%
75R 1/10W 1%
R261
10K 1/10W 5%
R533
R537
HDMI4_CLKN
HDMI4_CLKP
HDMI4_D0N
HDMI4_D0P
HDMI4_D1N
HDMI4_D1P
HDMI4_D2N
HDMI4_D2P
0.1uF/16V
C517
NC/22pF
C259
VGA_VSYNC
NC/22pF
C257
VGA_HSYNC
I/O3 I/O2
VDDGND
I/O4 I/O1
3
2
1
U205
AZC199-04S
33R 1/10W 5%
U209
SN74LVC1G17DBVR
4
4
5
6
0.1uF/16V
C252
33R 1/10W 5%
VCC5D
U207
SN74LVC1G17DBVR
4
EDID_WP
88G 35315F FX
15
6
1
7
2
8
3
9
4
10
5
VGA5V
Run As 100 Ohm Differential Pairs
RGB_VSYNC
0.1uF/16V
C258
RGB_HSYNC
I/O3 I/O2
VDDGND
I/O4 I/O1
U206
AZC199-04S
14
13
12
11
CN206
DB15
220R 1/10W 5%
26
25
24
HDMI4_CLKP
HDMI4_D0N
HDMI4_D0P
HDMI4_D1N
HDMI4_D1P
HDMI4_D2N
HDMI4_D2P
NC/10K 1/10W 5%
3V3_STB
220R 1/10W 5%
VPORT0603100KV05
1
0.1uF/16V
C519
VGA_EDID_WP 4
NC/100R 1/10W 5%
Q502
2N7002K
NC/0.1uF/16V
C263
Q201
NC/MMBT3904
0.1uF/16V
C520
HDMI_HPD4_A
HDMI4_5V
HDMI4_5V
1K 1/10W 5%
7K5 1/10W 5%
7K5 1/10W 5%
10K 1/10W 5%
R284
7
9
18
R271
VGA_SCL
RGB_VSY NC
RGB_HSY NC
R254
UART0_RX
100R 1/10W 5%
UART0_RX
7
R287
R253
10K 1/10W 5%
10K 1/10W 5%
UART0_TX
R256
UART0_TX
7
R251
R252
D3V3
4K7 1/10W 5%
NC
4K7 1/10W 5%
NC/10K 1/10W 5%
1K 1/10W 5%
NC/4K7 1/10W 5%
R274
R270
+5VSB
VGA_SCL
VGA_SDA
Rear HMDI2
88G 340 21 VD
SHLD_GND1
SHLD_GND2
SHLD1
SHLD2
SHLD3
SHLD4
SHLD5
CN504
A0 VCC
A1
WP
A2 SCL
VSS SDA
U208
AT24C02BN-SH-T
1
2
3
4
BAT54C
ZD204
1
+5VSB
2
VGA5V
3
VGA_SDA
1
VGA Input
2
19
17
18
16
06) VGA/HDMI Inputs
3
5
5
5
5
GPIO_P15
GPIO_P16
ZR39775HGCF-BD
HDMI_ATEST
HDMI_REXT
GPIO_P17
HDMI0_5VSENSE
HDMI0_CEC
HDMI0_SCL
HDMI0_SDA
HDMI0_HPD
HDMI0_CLKP
HDMI0_CLKN
HDMI0_D0P
HDMI0_D0N
HDMI0_D1P
HDMI0_D1N
HDMI0_D2P
HDMI0_D2N
HDMI0 I/F
U401G
VGA_VSYNC_DET 8
VGA_HSYNC_DET 8
IRR
UART1_TX
UART1_RX
SPI_DO
SPI_DI
SPI_CLK
SPI_SEL0
SPI_SEL1
SPI_HOLD
CLKIN_SEL
CLKIN_24M
CLKOUT_24M
USB2_DN
USB2_DP
USB2_REXT
USB2_ATEST
ZR39775HGCF-BD
USB
USB_PADN
USB_PADP
CLKIN_25M
CLKOUT_25M
RESET_N
TRIN_RESET_N
MOR_RESET_N
MOR_RESET_N_OUT
SPI
I2C
I2C0_C
I2C0_D
I2C1_C
I2C1_D
TV_I2C2_C
TV_I2C2_D
I2C_MORPH__ENA
UART
UART0_TX
UART0_RX
TRST
TDI_T
TDO_T
JTAG/EJTAG TMS
TCK
TDI_M
TDO_M
TAPSEL
TAPSEL_CAS
SIO I/F
47R 1/10W 5%
AF3
U26
U25
AF26
AE26
AD26
AD25
AB12
AC12
N1
N2
R448
4K7 1/10W 5%
D3V3
SPI_WEN
0.1uF 16V
0402
MOR_RSTN
10K 1/10W 5%
RESET_N
8
Run As 90 Ohm +/-15%
Differential Pairs
SPI_WR
SPI_RD
SPI_CLK
SPI_CS_N
SPI_WEN
SPI_HOLD
33R 1/10W 5%
NC/33R 1/10W 5%
NC/33R 1/10W 5%
33R 1/10W 5%
33R 1/10W 5%
33R 1/10W 5%
33R 1/10W 5%
0.001uF
Crystal X401
35ppm 20ǂ
50ppm 0~70ǂ
6.04 K OHM 1% 1/10W
30PF50V
30PF50V
USB2_DN
USB2_DP
R445
C409
25MHz
499R 1/10W 1%
C408
X401
1M 1/10W 5%
R442
100R 1/10W 5%R440
0.1uF 16V
0402
C412
R439
C405
R441
100R 1/10W 5%
10K 1/10W 5%
R437
R443
3V3_STB
5%
5%
5%
5%
R434
1/10W
1/10W
1/10W
1/10W
47R
47R
47R
47R
3,5
3,5
3V3_STB
D3V3
R410
R411
R412
R413
R415
R416
R417
C4F6
5%
5%
5%
5%
5%
I2C1_SCL
I2C1_SDA
R430
R431
R432
R433
W26
AD7
AB22
AB21
8
6
6
2K2 1/10W
2K2 1/10W
2K2 1/10W
2K2 1/10W
4K7 1/10W
AB24
AC25
AB25
AC24
AC26
AB26
R423
R424
R425
R427
R428
KEY_IR
UART0_TX
UART0_RX
I2C0_SCL
I2C0_SDA
I2C1_SCL
I2C1_SDA
I2C2_SCL
I2C2_SDA
KEY _IR
UART0_TX
UART0_RX
R418
R420
TRSTN
EJTDI
EJTDO
EJTMS
EJTCK
TDI_M
TDO_M
NC/4K7 1/10W 5%
4K7 1/10W 5%
4K7 1/10W 5%
4K7 1/10W 5%
AC16
AC17
AC18
AC19
AC20
AC21
AC22
R22
P22
N22
L22
M22
E16
E14
E18
E15
E17
E19
B25
E13
D13
R401
R409
4
5
6
4K7 1/10W 5%
1
2
90 ohm
L401
4
3
4K7 1/10W 5%
R435
3
2
1
R406
R407
R408
R422
EJTAG_RSTN
F401
VCC5D
NC1
NC2
NC3
NC4
NC5
NC6
NC7
GND
SPI FLASH
32M bit
D
Q
C
S
W
HOLD
NC8
Vcc
3
4
5
6
11
12
13
10
1
2
3
4
49
RClamp0520B.TCT
U407
NC/FUSE
USB5V
MX25L3205DMI-12G
0.1uF/16V
C406
15
8
16
7
9
1
14
2
U404
U404 should be programmed
before soldering on PCB
88G 352
21CL
CONNNECTOR
CN402
NC
HEADER 2X7P S/T 2.5mm
D3V3
EJTAG I/F
NC/VPORT0603100KV05
NC/47R 1/10W 5%
D3V3
RESET_N
I/O3 I/O2
VDDGND
I/O4 I/O1
R429
D3V3
D3V3
R405
NC/4K7 1/10W 5%
4K7 1/10W 5%
1K 1/10W 5%
CN401
1K 1/10W 5%
1K 1/10W 5%
2
1
4
3
6
5
8
7
10
9
12
11
14
13
U402
ZD401
NC/AZC099-04S
R404
2
1
U401C
D3V3
1
D3V3
3
07) SIO I/F
2
5
6
1 2 3 4
USB
Port
8
USB_EN_N
3V3_STB
USB_EN_N
4.7uF 25V
C410
4
3
2
1
VCC
MR
U412
GND
RESET
1
2
G545B2RD1U
5
6
7
8
CN406
NC/CONN
R4D7
C411
0.1uF/16V 4.7uF 25V
C413
10K 1/10W 5%
USB_OC_N
USB_OC_N
VCC5D
3PX2 S/T 2.0mm
6
5
4
2
1
3
USB5V
VCC E0
WC E1
SCL E2
SDA VSS
1
2
3
4
8
100K 1/10W 5%
M24C64-WMN6P
UART0_RX
EN(EN)
OC
IN
NC
IN
OUT
GND
OUT
U408
RESET_N
R4D5
U405
NC/33R 1/10W 5%
KEY_IR
+5VSB
NC
NC
UART0_TX
R402
C4E3
C4D9
0.22uF
8
7
6
5
R436
10K 1/10W 5%
C404
D3V3
G692L293TCUf 2.91V
4
3
EEPROM_WP1
I2C0_SCL
I2C0_SDA
10K 1/10W 5%
R414
VCC5D
8 EEPROM_WP1
NC/TACT SW FWRD H1.5MM
SW401
System MCU RESET
Res_AA6
GPIO_P21
GPIO_P22
GPIO_P23
GPIO_P24
GPIO_P25
GPIO_P26
GPIO_P27
GPIO_P19
GPIO_P13
R459
D5
G4
H3
G3
F4
F5
E1
E2
E3
E4
E5
F1
F2
F3
AB7
AB10
AB9
AB8
U6
V6
K4
AE3
M6
N6
AA6
U24
U23
R23
AB13
AB14
AB16
AC14
33R 1/10W 5%
R462
1
2
3
4
5
6
7
8
9
10
3V3_STB
CONN
10P S/T 2.0mm
33G380210B Y
CN403
0.1uF/16V
C441
4
5
6
R490
I/O3 I/O2
VDDGND
I/O4 I/O1
3
2
1
U409
AZC099-04S
C4F2
0.01uF
0.01uF
C4F4
1
1
1
1
FB420
FB421
FB422
FB410
C4F5
1
1
FB406
FB419
0.001uF 0.001uF
C4E8
C4E7
C4E6
2
2
2
2
R489
R491
NC/300 OHM
300 OHM
300 OHM
120 OHM
2 300 OHM
2 300 OHM
0.01uF
C4E4
LIGHT_SENSOR
LED_B
LED_R
KEY _IR
KEY _IR
LED_R
LED_B
Q402
MMBT3904
KEY _PWR
KEY _IN
Q403
MMBT3906
NC/1uF/16V
C4F9
R480
3V3_STB
D3V3
1
1
7
VCC1V1
1
50
R488
3V3_STB
0.01uF
C4F8
2
BAT54C
120OHM
C422
C423
C424
845R 1/10W 1%
845R 1/10W 1%
G5
G6
H6
J6
AB5
Y3
22pF
C438
AF6
51K 1/10W 5% AC3
0.1uF 16V
AC4
0402
9.1KOHM +-1% 1/10W
R486
C437
ADC 0.4V~2.9V
AC5
AD6
AD5
3V3_CHECK
AD4
R482
1K 1/10W 5% AE5
R483
1K 1/10W 5% AE6
LIGHT_SENSOR
AB6
VDD33-BOD
100uF/16V
KEY_IN
PANEL_PWR_CHECK
C430
4.7uF/10V
C428
P4
1uF/25V 0.1uF 16V 1uF/25V 0.1uF 16V
0402
0402
C421
R471
3V3_STB
ZD402
FB423
120OHM
2
2
R470
1K 1/10W 5%
G2
L6
G1
K6
0
1K 1/10W 5%
3V3_CHECK
R468
120OHM
FB404
FB403
D1V8
D3V3
1K 1/10W 5%
R467
R479
1
SPI
8-Bit NAND-Large Page
SPI
ACOD3_AVDD
ACOD3_AVSS
VDDADC8
AFE_AVSS0
AFE_AVSS1
AFE_AVSS2
AFE_AVSS3
AFE_AVSS4
AFE_AVSS5
AFE_AVSS6
AFE_AVSS7
AFE_AVSS8
AFE_AVSS9
AFE_AVSS10
IF_VDD3P3_0
IF_VDD3P3_1
DM_PLL_VDD
DVDD18
AE10
AE11
AF5
W4
W5
W6
Y4
Y5
Y6
L7
M7
N7
P7
U7
AC1
AC2
AB2
R4
P2
P1
R1
R2
P3
N3
N4
M4
L3
M3
R3
A_GND
C414
R473
C426
C427
1
C432
1
C433
120OHM
FB424
2
C436
120OHM
FB408
C440
120OHM
1uF/25V 0.1uF 16V
C439
1
1uF/25V 0.1uF 16V
FB409
C435
1
1uF/25V 0.1uF 16V 0.01uF
0402
C431
0.1uF 16V
0402
C429
2
C415
1
120OHM
FB407
3V3_STB
2
3V3_STB
2
2
3V3_STB
4.7uF/10V
C420
1V8_STB
1uF/25V
4.7uF/10V
C434
D3V3
1V8_STB
80OHM
FB405
0R05 1/10W 5%
10uF/6.3V
4.7uF/10V 0.1uF 16V 0.001uF
0402
C425
C4E5
R466
4R7 1/10W 5%
1
1
1
0
1
1
0
0
1
1
BOOT0
3V3_STB
BOOT1
4K7 1/10W 5%
4K7 1/10W 5%
1
1V8_STB
2
3V3_STB
4K7 1/10W 5%
0
BOOT2
10uF/6.3V 0.1uF 16V 10uF/6.3V
0402
C419
0.001uF
120OHM
C417
C418
1
1
1
1
BOOT3
FB401
0.01uF
1
C416
8-Bit NAND-Small Page
AVDD3_SYNC1
ZR39775HGCF-BD
RC_OSC_REXT
ADC8_RBIAS
ADC8_VREF
ADC8_INA
ADC8_INB
ADC8_INC
ADC8_IND
ADC8_INE
ADC8_INF
ADC8_ING
VDD33_BOD
AFE_AVSS
PGA_LDO0
Boot Option
R458
R454
BOOT_STRAP0
BOOT_STRAP1
16-Bit NAND-Small Page
NC/CONN
1
2
CN409
R453
BOOT_STRAP3
Bootstrap Configuration
4K7 1/10W 5%
R451
3V3_STB
BOOT_STRAP2
AVDD3_HPLL
AVDD18_HPLL
AVSS_HPLL
LVDSVCRX_VDD33_0
LVDSVCRX_VDD33_1 AVDD3_SY NC
AVDD3_AFE
LVDSVCTX_VDD33_0
LVDSVCTX_VDD33_1
AVDD18_R
AVDD18_G
AVDD18_B
AVDD18_SVIDEO
AVDD18_CVBS
LVDSVCRX_REXT
LVDSVCRX_ATST
LVDSVCTX_REXT
LVDSVCTX_ATST
U401Q
TVM_BOOT
10K 1/10W 5%
R460
NC/10K 1/10W 5%
I2C EEPROM
Boot Option
TVM_BOOT
R452
3V3_STB
TVMicro Bootstrap
Configuration
PANEL_PWR_CHECK
0
1
TEST MPDE
NC/4K7 1/10W 5%
R456
4K7 1/10W 5%
R450
4K7 1/10W 5%
R469
PANEL_POWER
Normal Mode
Debug Mode
State
TEST_MODE
470R 1/10W 5%
470R 1/10W 5%
R481
3V3_STB
100R 1/10W 1%
100R 1/10W 1%
1uF/25V
C407
3K3 1/10W 5%
3K3 1/10W 5%
10K 1/10W 5%
R472
R485
0.001uF 0.001uF 0.001uF
C4F3
3K9 1/10W 1%
10K 1/10W 1%
R487
3V3_STB
R484
VGA_VSYNC_DET 6
VGA_HSYNC_DET 6
LED_2
VGA_VSY NC_DET
NC/0R05 1/10W 5%
VGA_HSY NC_DET
NC/0R05 1/10W 5%
R477
R478
PANEL_CTRL2 3,10
AV2_S_DET 4
AUD_AMP_MUTE 12
PANEL_ON 10,15
USB_EN_N 7
HDMISW_RSTN 5
VGA_HSYNC_DET 6
AUD_SHDN 12
PWR_ON
14
EEPROM_WP1 7
VGA_VSYNC_DET 6
BL_ON_OFF 14
EARPHONE_DET 13
USB_OC_N 7
SPI_WEN
7
LED_1
NC/33R 1/10W 5%PANEL_CTRL2
AV2_S_DET
AUD_AMP_MUTE
PANEL_ON
USB_EN_N
HDMISW_RSTN
LED_2
VGA_HSY NC_DET
AUD_SHDN
PWR_ON
KEY _PWR
EEPROM_WP1
BL_ON_OFF
EARPHONE_DET
USB_OC_N
SPI_WEN
TVM_BOOT
TEST_MODE
LED_1
VGA_VSY NC_DET
R447
33R 1/10W 5%
100R 1/10W 5%
R403
R463
33R 1/10W 5%
R461
4K7 1/10W 5%
33R 1/10W 5%
R457
33R 1/10W 5%
33R 1/10W 5%
DEMOD_RSTN 3
C6
R419
R455
BOOT_STRAP0
BOOT_STRAP1
BOOT_STRAP2
BOOT_STRAP3
D11
D12
E12
E11
AB20
AB19
AB18
AB17
C10
C11
C12
D10
ZR39775HGCF-BD
TEST_G11
TEST_G12
VCLKx2
Vsy nc_in
Hsy nc_in
VID0
VID1
VID2
VID3
VID4
VID5
VID6
VID7
TVMM I/F
U401M
ZR39775HGCF-BD
AFE_XCLK_TEST
AFE_TEST0
AFE_TEST1
AFE_TEST2
AFE_TCLK_IN
AFE_TCLK_OUT
AFE_CLK
AFE_XCLK
AFE_ATCLK0
AFE_ATCLK1
AFE I/F_GPO
U401S
ZR39775HGCF-BD
8051_BOOT
GPIO_P0
GPIO_P1
GPIO_P2
GPIO_P3
GPIO_P4
GPIO_P5
GPIO_P6
GPIO_P7
GPIO_P8
GPIO_P9
GPIO_P10
GPIO_P11
GPIO
1
BOOT_STRAP0
BOOT_STRAP1
BOOT_STRAP2
BOOT_STRAP3
D3V3
2
U401K
3
08) GPIO Block
+
S1_VREF
S0_VREF
NC/0.1uF/16V
C461
R26
L26
K26
S1_UDM
S1_LDM
NC/0.1uF/16V
C454
D1V8
F25
M26
E26
N25
L25
H25
M25
F26
E25
N26
D25
P26
K25
J26
P25
D26
S1_DQ15
S1_DQ14
S1_DQ13
S1_DQ12
S1_DQ11
S1_DQ10
S1_DQ9
S1_DQ8
S1_DQ7
S1_DQ6
S1_DQ5
S1_DQ4
S1_DQ3
S1_DQ2
S1_DQ1
S1_DQ0
S0_ODT
S0_CK_N
S0_CK_P
S0_CKE
S0_RAS_N
S0_CAS_N
S0_WE_N
S0_UDQS_N
S0_UDQS_P
S0_LDQS_N
S0_LDQS_P
ZR39775HGCF-BD
S1_ODT
S1_CK_N
S1_CK_P
S1_CKE
S1_RAS_N
S1_CAS_N
S1_WE_N
S1_UDQS_N
S1_UDQS_P
S1_LDQS_N
S1_LDQS_P
S1_A13
S1_A12
S1_A11
S1_A10
S1_A9
S1_A8
S1_A7
S1_A6
S1_A5
S1_A4
S1_A3
S1_A2
S1_A1
S1_A0
S1_BA2
S1_BA1
S1_BA0
ZR39775HGCF-BD
S1_VREF
S1_UDM
S1_LDM
S1_DQ15
S1_DQ14
S1_DQ13
S1_DQ12
S1_DQ11
S1_DQ10
S1_DQ9
S1_DQ8
S1_DQ7
S1_DQ6
S1_DQ5
S1_DQ4
S1_DQ3
S1_DQ2
S1_DQ1
S1_DQ0
S1 Memory I/F
U401B
150R 1/10W 1%
60.4 OHM 1% 1/10W
60.4 OHM 1% 1/10W
R497
RDRIVER
RDRIVER50
RTERM
S0_VREF
S0_UDM
S0_LDM
NC
R496
B26
A26
A25
A24
A20
A19
S0_A13
S0_A12
S0_A11
S0_A10
S0_A9
S0_A8
S0_A7
S0_A6
S0_A5
S0_A4
S0_A3
S0_A2
S0_A1
S0_A0
S0_BA2
S0_BA1
S0_BA0
S0 Memory I/F
S0_DQ15
S0_DQ14
S0_DQ13
S0_DQ12
S0_DQ11
S0_DQ10
S0_DQ9
S0_DQ8
S0_DQ7
S0_DQ6
S0_DQ5
S0_DQ4
S0_DQ3
S0_DQ2
S0_DQ1
S0_DQ0
R495
0.1uF/16V
C451
0.1uF/16V
C444
S0_UDM
S0_LDM
B15
A21
A14
B22
B20
B17
B21
A15
B14
A22
B13
A23
B19
A18
B23
A13
C4F7
NC/0R05 1/10W 5%
R4A2
0R05 1/10W 5%
R494
D1V8
S0_DQ15
S0_DQ14
S0_DQ13
S0_DQ12
S0_DQ11
S0_DQ10
S0_DQ9
S0_DQ8
S0_DQ7
S0_DQ6
S0_DQ5
S0_DQ4
S0_DQ3
S0_DQ2
S0_DQ1
S0_DQ0
U401A
S1_ODT
D24
S1_CK
S1_CKN
S1_CK
S1_CKE
R4A3
S0_A[0:12]
S1_DQ[0:15]
S0_UDM
S0_LDM
S0_CKE
S0_RASN
S0_CASN
S0_WEN
S0_ODT
S1_CKN
S1_UDM
S1_LDM
S1_CKE
S1_RASN
S1_CASN
S1_WEN
S1_ODT
R3
R7
B3
F3
J8
K8
L8
K2
K7
L7
K3
K9
L2
L3
L1
S1_BA0
S1_BA1
S1_BA2
S1_CK
S1_CKN
M8
M3
M7
N2
N8
N3
N7
P2
P8
P3
M2
P7
R2
S1_A0
S1_A1
S1_A2
S1_A3
S1_A4
S1_A5
S1_A6
S1_A7
S1_A8
S1_A9
S1_A10
S1_A11
S1_A12
R3
R7
B3
F3
J8
K8
L8
K2
K7
L7
K3
K9
L2
L3
L1
S0_BA0
S0_BA1
S0_BA2
S0_CK
S0_CKN
M8
M3
M7
N2
N8
N3
N7
P2
P8
P3
M2
P7
R2
S0_A0
S0_A1
S0_A2
S0_A3
S0_A4
S0_A5
S0_A6
S0_A7
S0_A8
S0_A9
S0_A10
S0_A11
S0_A12
S0_CKN
NC/100R 1/10W 5%
S1_RASN
S1_CASN
S1_WEN
G23
G24
L23
C25
C26
M24
S1_UDQSN
S1_UDQS
S1_LDQSN
S1_LDQS
S1_A13
S1_A12
S1_A11
S1_A10
S1_A9
S1_A8
S1_A7
S1_A6
S1_A5
S1_A4
S1_A3
S1_A2
S1_A1
S1_A0
S1_BA2
S1_BA1
S1_BA0
R498
S0_A[0:12]
100R 1/10W 5%
G26
G25
J25
H26
E24
R24
J24
N23
J23
E23
P23
H23
K24
F24
P24
H24
K23
F23
N24
L24
M23
S0_ODT
C13
S0_CK
S0_CKN
S0_CK
S0_CKE
S0_RASN
S0_CASN
S0_WEN
S0_UDQSN
S0_UDQS
S0_LDQSN
S0_LDQS
S0_A13
S0_A12
S0_A11
S0_A10
S0_A9
S0_A8
S0_A7
S0_A6
S0_A5
S0_A4
S0_A3
S0_A2
S0_A1
S0_A0
S0_BA2
S0_BA1
S0_BA0
B12
A12
C21
D16
C16
D20
A16
B16
B18
A17
C14
C24
C18
D22
D18
D14
D23
D17
C19
C15
C23
C17
D19
D15
C22
C20
D21
S0_DQ[0:15]
NC
NC
UDM
LDM
CK
CK#
CS
CKE
RAS
CAS
WE
ODT
BA0
BA1
NC
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
NC
NC
UDM
LDM
CK
CK#
CS
CKE
RAS
CAS
WE
ODT
BA0
BA1
NC
A0
A1
A2
A3
A4
A5
A6
A7
A8
A9
A10
A11
A12
D1V8
H5PS5162FFR-S6C
U410
VSSDL
J7
VSS
VSS
VSS
VSS
VSS
A3
E3
J3
N1
P9
A1
E1
J9
M9
R1
D1V8
U411
NC/HY5PS561621BFP-25
VDD
VDD
VDD
VDD
VDD
J1
VDDL
VSSDL
J7
VSS
VSS
VSS
VSS
VSS
A3
E3
J3
N1
P9
09) DDRII SDRAM I/F
A1
E1
J9
M9
R1
VDD
VDD
VDD
VDD
VDD
J1
VDDL
A9
C1
C3
C7
C9
E9
G1
G3
G7
G9
VDDQ
VDDQ
VDDQ
VDDQ
VDDQ
VDDQ
VDDQ
VDDQ
VDDQ
VDDQ
VSSQ
VSSQ
VSSQ
VSSQ
VSSQ
VSSQ
VSSQ
VSSQ
VSSQ
VSSQ
A7
B2
B8
D2
D8
E7
F2
F8
H2
H8
A9
C1
C3
C7
C9
E9
G1
G3
G7
G9
VDDQ
VDDQ
VDDQ
VDDQ
VDDQ
VDDQ
VDDQ
VDDQ
VDDQ
VDDQ
VSSQ
VSSQ
VSSQ
VSSQ
VSSQ
VSSQ
VSSQ
VSSQ
VSSQ
VSSQ
51
A7
B2
B8
D2
D8
E7
F2
F8
H2
H8
NC
NC
NC
UDQS
UDQS
LDQS
LDQS
DQ0
DQ1
DQ2
DQ3
DQ4
DQ5
DQ6
DQ7
DQ8
DQ9
DQ10
DQ11
DQ12
DQ13
DQ14
DQ15
VREF
NC
NC
NC
UDQS
UDQS
LDQS
LDQS
DQ0
DQ1
DQ2
DQ3
DQ4
DQ5
DQ6
DQ7
DQ8
DQ9
DQ10
DQ11
DQ12
DQ13
DQ14
DQ15
VREF
S0_VREF
S0_DQ0
S0_DQ1
S0_DQ2
S0_DQ3
S0_DQ4
S0_DQ5
S0_DQ6
S0_DQ7
S0_DQ8
S0_DQ9
S0_DQ10
S0_DQ11
S0_DQ12
S0_DQ13
S0_DQ14
S0_DQ15
S0_UDQS
S0_UDQSN
S0_LDQS
S0_LDQSN
S0_A13
S1_VREF
S1_DQ0
S1_DQ1
S1_DQ2
S1_DQ3
S1_DQ4
S1_DQ5
S1_DQ6
S1_DQ7
S1_DQ8
S1_DQ9
S1_DQ10
S1_DQ11
S1_DQ12
S1_DQ13
S1_DQ14
S1_DQ15
S1_UDQS
S1_UDQSN
S1_LDQS
S1_LDQSN
S1_A13
J2
G8
G2
H7
H3
H1
H9
F1
F9
C8
C2
D7
D3
D1
D9
B1
B9
B7
A8
F7
E8
A2
E2
R8
J2
G8
G2
H7
H3
H1
H9
F1
F9
C8
C2
D7
D3
D1
D9
B1
B9
B7
A8
F7
E8
A2
E2
R8
0.1uF/16V
C443
S1_VREF
NC/0.1uF/16V
C453
NC/0.1uF/16V
C452
D1V8
S0_VREF
0.1uF/16V
C442
D1V8
C446
C447
C448
D1V8
C449
C450
C456
C458
D1V8
0.01uF
C403
0.01uF
C4G3
C459
0.01uF
C4E2
C460
0.01uF
C4G4
C4F1
0.01uF
C4G5
NC/0.1UF16V
NC/0.1UF16V
NC/0.1UF16V
NC/0.1UF16V
NC/0.1UF16V
NC/1uF/16VNC/10UF16V
0402
0402
0402
0402
0402
C455
NC/100R 1/10W 1%
R4A1
C457
0.01uF
0.01uF
NC/100R 1/10W 1%
R499
C402
C401
D1V8
10uF 16V
C4E9
512Mb (32Mx16) DDRII
56G 615 76
H5PS5162FFR-25C
56G 615 67
NANYA
NT5TU32M16CG-25C
0.1uF 16V 0.1uF 16V 0.1uF 16V 0.1uF 16V 0.1uF 16V 1uF/25V
0402
0402
0402
0402
0402
C445
100R 1/10W 1%
R493
100R 1/10W 1%
R492
256Mb (16Mx16) DDRII
56G 615 75
HY5PS561621BFP-25
56G 615 66
NANYA
NT5TU16M16AG-25D
8,15 PANEL_ON
PANEL_ON
NC/LL4148
1K 1/10W 5%
R4B7
D402
R4B8
R4B4
P12V
Q405
MMBT3904
100K 1/10W 5%
24
22
20
18
16
14
12
10
8
6
4
2
S
S
S
G
C488
D
D
D
D
8
7
6
5
0.1uF/16V
C4B9
D3V3
VCC1V1
22uF/25V
1
1
120OHM
FB418
120OHM
FB414
0.001uF
2
52
1uF/25V 0.1uF 16V
0402
C4A3
C4A4
C495
0.01uF
HDMI_3V3
2
4K7 1/10W 5%
R4D6
BL_BR_CTRL
LVDS_D4E_P
LVDS_D3E_P
LVDS_D2E_P
LVDS_D1E_P
LVDS_D0E_P
LVDS_CKE_P
BL_PWM_CTRL
USB_VDD1
C4C3
0.1uF 16V 0.1uF 16V 1uF/25V
0402
0402
C4C2
3V3_STB
ZR39775HGCF-BD
C463
C470
C471
C472
D3V3
1V8_STB
C466
C467
C468
C473
C474
C477
C478
C479
C480
C481
C482
C491
1
120OHM
FB412
C493
1
120OHM
2
2
C497
1
C498
120OHM
C499
2
1
C4A6
C4A7
C4A8
C4A9
C4B1
VCC1V1
C4B2
2
C4B3
120OHM
D3V3
C4B4
AE25
V25
N18
N17
N16
N15
N14
N13
N12
N11
N10
N9
M18
M17
M16
M15
M14
M13
M12
M11
M10
M9
L18
L17
L16
L15
L14
L13
L12
L11
L10
L9
K18
K17
K16
K15
K14
K13
K12
K11
K10
K9
J18
J17
J16
J15
J14
J13
J12
J11
J10
P9
P10
P11
P12
P13
P14
P15
P16
P17
P18
R9
R10
R11
R12
R13
R14
R15
R16
R17
R18
T9
T10
T11
T12
T13
T14
T15
T16
T17
T18
U9
U10
U11
U12
U13
U14
U15
U16
U17
U18
V9
V10
V11
V12
V13
V14
V15
V16
V17
V18
B24
F6
R25
C4B5
C4B6
C4B7
ZR39775HGCF-BD
GND49
GND50
GND51
GND52
GND53
GND54
GND55
GND56
GND57
GND58
GND59
GND60
GND61
GND62
GND63
GND64
GND65
GND66
GND67
GND68
GND69
GND70
GND71
GND72
GND73
GND74
GND75
GND76
GND77
GND78
GND79
GND80
GND81
GND82
GND83
GND84
GND85
GND86
GND87
GND88
GND89
GND90
GND91
GND92
GND93
GND94
GND95
GND96
GND97
GND98
GND99
GND100
S1_GND
USB2_GND
PLL_VSS
GND48
GND47
GND46
GND45
GND44
GND43
GND42
GND41
GND40
GND39
GND38
GND37
GND36
GND35
GND34
GND33
GND32
GND31
GND30
GND29
GND28
GND27
GND26
GND25
GND24
GND23
GND22
GND21
GND20
GND19
GND18
GND17
GND16
GND15
GND14
GND13
GND12
GND11
GND10
GND9
GND8
GND7
GND6
GND5
GND4
GND3
GND2
GND1
GND0
Ground
U401N
C4C6
0.1uF 16V 0.1uF 16V 1uF/25V
0402
0402
C4C8
C4C9
C4D1
C4D2
C4D3
C4D4
C4D5
C4D6
C4D7
C4D8
0.1uF 16V
0.1uF 16V
0.1uF 16V
0.1uF 16V
1uF/25V
0.1uF 16V
0.1uF 16V
0.1uF 16V
0.001uF
1uF/25V 10uF 16V
0402
0402
0402
0402
0402
0402
0402
C4C7
VCC1V1
0.1uF 16V
0.1uF 16V
0.1uF 16V
0.1uF 16V
0.1uF 16V
0.1uF 16V
0.1uF 16V
0.1uF 16V
0.1uF 16V
0.1uF 16V
0.1uF 16V
0.1uF 16V
0402
0402
0402
0402
0402
0402
0402
0402
0402
0402
0402
0402
C4A5
1
C4A2
FB417
0.47UF10V
0402
1uF/25V
C4A1
2
NC/120OHM
FB416
VCC1V1
D3V3
D3V3
C484
1uF/25V 10uF 16V
C483
D1V8
0.1uF 16V
0.1uF 16V
0.1uF 16V
0.1uF 16V
0.1uF 16V
0.1uF 16V
0.1uF 16V
0402
0402
0402
0402
0402
0402
0402
C476
D1V8
0.47UF10V
0.47UF10V
0402
1uF/25V 0402
1uF/25V
C496
C465
0.1uF 16V
0.1uF 16V
10uF 16V
0.1uF 16V
0.1uF 16V
1uF/25V
0402
0402
0402
0402
C469
1uF/25V 0.1uF 16V
0402
FB415
C492
C464
D3V3
0.1uF 16V
0.1uF 16V
0.1uF 16V
0.1uF 16V
0.1uF 16V
0.1uF 16V
0.1uF 16V
0402
0402
0402
0402
0402
0402
0402
C462
1uF/25V 0.1uF 16V
0402 FB413
C490
3V3_STB
D1V8
D3V3
C4C5
1V8_STB
P5
P6
R6
T6
T7
R7
H4
J4
H5
J5
K7
AF25
AC13
AC11
AC15
AB15
V26
E20
E21
E22
F16
F17
F18
F19
F20
F21
F22
G17
G18
G19
G20
G21
G22
H20
H21
H22
J20
J21
J22
K20
K21
G7
G8
G9
G10
G11
H7
H8
J7
Y 16
Y 17
Y 18
Y 19
Y 20
Y 21
AA16
AA17
AA18
AA19
AA20
AA21
AA22
AA23
AA24
AA25
AA26
C4C4
CORE_VDD18_STBY 0
CORE_VDD18_STBY 1
CORE_VDD18_STBY 2
CORE_VDD18_STBY 3
CORE_VDD18_STBY 4
CORE_VDD18_STBY 5
IOVDD_STBY 0
IOVDD_STBY 1
IOVDD_STBY 2
IOVDD_STBY 3
IOVDD_STBY 4
USB_VDD33
HDMI_VDD3P3_0
HDMI_VDD3P3_1 USB2_VDD33
HDMI_VDD3P3_2
HDMI_VDD3P3_3
HDMI_VDD1V_0
HDMI_VDD1V_1
HDMI_VDD1V_2
HDMI_VDD1V_3
PLL_VDD33
M_VDD0
M_VDD1
M_VDD2
M_VDD3
M_VDD4
M_VDD5
M_VDD6
M_VDD7
M_VDD8
M_VDD9
M_VDD10
M_VDD11
M_VDD12
M_VDD13
M_VDD14
M_VDD15
M_VDD16
M_VDD17
M_VDD18
M_VDD19
M_VDD20
M_VDD21
M_VDD22
M_VDD23
IO_VDD0
IO_VDD1
IO_VDD2
IO_VDD3
IO_VDD4
IO_VDD5
IO_VDD6
IO_VDD7
IO_VDD8
IO_VDD9
IO_VDD10
IO_VDD11
IO_VDD12
IO_VDD13
IO_VDD14
IO_VDD15
IO_VDD16
IO_VDD17
IO_VDD18
IO_VDD19
IO_VDD20
IO_VDD21
IO_VDD22
IO_VDD23
IO_VDD24
LDI_VDD33_0
LDI_VDD33_1
Power
CORE_VDD0
CORE_VDD1
CORE_VDD2
CORE_VDD3
CORE_VDD4
CORE_VDD5
CORE_VDD6
CORE_VDD7
CORE_VDD8
CORE_VDD9
CORE_VDD10
CORE_VDD11
CORE_VDD12
CORE_VDD13
CORE_VDD14
CORE_VDD15
CORE_VDD16
CORE_VDD17
CORE_VDD18
CORE_VDD19
CORE_VDD20
CORE_VDD21
CORE_VDD22
CORE_VDD23
CORE_VDD24
CORE_VDD25
CORE_VDD26
CORE_VDD27
CORE_VDD28
CORE_VDD29
CORE_VDD30
CORE_VDD31
CORE_VDD32
CORE_VDD33
CORE_VDD34
CORE_VDD35
CORE_VDD36
CORE_VDD37
CORE_VDD38
CORE_VDD39
CORE_VDD40
CORE_VDD41
CORE_VDD42
CORE_VDD43
CORE_VDD44
CORE_VDD45
CORE_VDD46
CORE_VDD47
CORE_VDD48
CORE_VDD49
CORE_VDD50
CORE_VDD51
CORE_VDD52
U401R
C4C1
E7
E8
F7
F8
E9
E10
F9
F10
F11
F12
F13
F14
F15
G12
G13
G14
G15
G16
L20
L21
M20
M21
N20
N21
P20
P21
R20
R21
T20
T21
T22
T23
T24
U20
U21
V20
V21
W20
W21
V7
W7
Y7
Y8
Y9
Y 10
Y 11
Y 12
Y 13
Y 14
Y 15
AA8
AA9
AA10
AA11
AA12
AA13
AA14
AA15
T25
T26
AA7
VCC1V1
C494
For 32' Sharp Panel,
R4A7 from NC to 1K
PANEL_CTRL1 4
NC/1K 1/10W 5%
R4A7
NC/1K 1/10W 5%
R4A5
D3V3
LVDS_D4O_P
LVDS_D3O_P
LVDS_D2O_P
LVDS_D1O_P
LVDS_D0O_P
LVDS_CKO_P
+ C486
PANEL_POWER
0.1uF/16V
0.001uF
C487
AO4449 -7A/-30V
0R05 1/10W 5%
R4C5
0.47uF/16V
47K 1/10W 5%
R4B6
C4B8
R4B5
1
2
3
4
NC/0R05 1/4W 5%0R05 1/4W 5% Q404
R4B3
PANEL_5V
CN405
CONN
12PX2 S/T 2.0mm
33G8027 24
BL_BR_CTRL 14
2
300 OHM
FB411
BL_BR_CTRL
1
NC/0R05 1/10W 5% BL_PWM_CTRL
0R05 1/10W 5%
LVDS_D4E_N
LVDS_D3E_N
LVDS_D2E_N
LVDS_D1E_N
LVDS_D0E_N
LVDS_CKE_N
23
21
19
17
15
13
11
9
7
5
3
1
NC/1K 1/10W 5%
R4A6
16
14
12
10
8
6
4
2
CN404
NC/CONN
8PX2 S/T 2.0mm
33G8027 16
15
13
11
9
7
5
3
1
NC/1K 1/10W 5%
R4A4
D3V3
LVDS_D4O_N
LVDS_D3O_N
LVDS_D2O_N
LVDS_D1O_N
LVDS_D0O_N
LVDS_CKO_N
PANEL_POWER
3,8 PANEL_CTRL2
10K 1/10W 5%
R4B9
R4C3
R4C2
0.1uF/16V 47K 1/10W 5%
C4E1
0.01uF
C489
1K 1/10W 5%
R4A9
1
AB23
AC23
Place parts very
close to U401
820R 1/10WR 5%
LVDS_D0O_P
3
NC/90 ohm
LVDS_D0O_N
4
LVDS_D1O_P
3
NC/90 ohm
LVDS_D1O_N
4
LVDS_D2O_P
3
NC/90 ohm
LVDS_D2O_N
4
LVDS_D3O_P
3
NC/90 ohm
LVDS_D3O_N
4
LVDS_D4O_P
3
NC/90 ohm
LVDS_D4O_N
4
LVDS_CKE_P
3
NC/90 ohm
LVDS_CKE_N
4
LVDS_CKO_P
3
NC/90 ohm
LVDS_CKO_N
4
LVDS_D0E_P
3
NC/90 ohm
LVDS_D0E_N
4
LVDS_D1E_P
3
NC/90 ohm
LVDS_D1E_N
4
LVDS_D2E_P
3
NC/90 ohm
LVDS_D2E_N
4
LVDS_D3E_P
3
NC/90 ohm
LVDS_D3E_N
4
LVDS_D4E_P
3
NC/90 ohm
LVDS_D4E_N
4
R4A8
TP7
2
L409
1
2
L410
1
2
L411
1
2
L412
1
2
L413
1
2
L402
1
2
L403
1
2
L404
1
2
L405
1
2
L406
1
2
L407
1
2
L408
1
AD19
AD20
AE15
AF15
AD15
AD16
AF16
AE16
AE17
AF17
AD17
AD18
AF18
AE18
AF20
AE20
AE21
AF21
AD21
AD22
AF22
AE22
AE23
AF23
AD23
AD24
AE19
AF19
AF24
AE24
ZR39775HGCF-BD
PWM1
PWM2
LVDS_TXATST
LVDS_REXT
LVDS_D5O_P
LVDS_D5O_N
LVDS_D4O_P
LVDS_D4O_N
LVDS_D3O_P
LVDS_D3O_N
LVDS_D2O_P
LVDS_D2O_N
LVDS_D1O_P
LVDS_D1O_N
LVDS_D0O_P
LVDS_D0O_N
LVDS_D5E_P
LVDS_D5E_N
LVDS_D4E_P
LVDS_D4E_N
LVDS_D3E_P
LVDS_D3E_N
LVDS_D2E_P
LVDS_D2E_N
LVDS_D1E_P
LVDS_D1E_N
LVDS_D0E_P
LVDS_D0E_N
LVDS_CO_P
LVDS_CO_N
LVDS_CE_P
LVDS_CE_N
LVDS I/F
U401J
10) LVDS I/F
STBY
POWER
3
4
1
2
3
4
1
2
3
4
1
2
100pF
C604
ZD603
100pF
C613
ZD605
100pF
A_GND
0.1uF/16V 10uF/16V
C624
C626
0R05 1/10W 5%
0R05 1/10W 5%
0R05 1/10W 5%
FB604
FB605
FB606
0.1uF/16V
C628
100R 1/10W 5%
C625
100pF
560pF
C622
Coaxial
0.1uF/16V
C620
10K 1/10W 5%
R627
VIN
VCC
GND
R607
AV1_Audio_R
AV1_Audio_L
R618
R625
PC_Audio_L
R629
53
10K 1/10W 5%
10K 1/10W 5%
R628
PC_Audio_R
10K 1/10W 5%
10K 1/10W 5%
R624
Y PbPr2_Audio_R
Y PbPr2_Audio_L
10K 1/10W 5%
10K 1/10W 5%
R617
Y PbPr1_Audio_R
Y PbPr1_Audio_L
10K 1/10W 5%
10K 1/10W 5%
R606
SPDIF
Output
10K 1/10W 5%
R626
CN605
10K 1/10W 5%
10K 1/10W 5%
10K 1/10W 5%
10K 1/10W 5%
10K 1/10W 5%
10K 1/10W 5%
R623
R622
R616
R615
R603
R601
FIBER-OPTIC 3P
88G 359 5 JT
3
2
1
100pF
VCC5D
VPORT0603100KV05
VPORT0603100KV05
ZD607
C618
0R05 1/10W 5%
FB603
C617
0R05 1/10W 5%
FB602
ZD608
0R05 1/10W 5%
FB601
0.1uF/16V 10uF/16V
C627
R630
10uF/16V
IEC958O
AD11
12,13
12,13
2 30 OHM
AUDIO_OUT_L 13
AUDIO_OUT_R 13
AMP_LIN
AMP_RIN
1
C623
AUDIO_OUT_L
AUDIO_OUT_R
FB614
2 300 OHM
100pF
C616
100pF
C614
100pF
C605
2 300 OHM
VPORT0603100KV05
VPORT0603100KV05
ZD606
C615
VPORT0603100KV05
VPORT0603100KV05
ZD604
VPORT0603100KV05
VPORT0603100KV05
ZD602
FB608 1
AF10
AF9
AE8
AE12
AE13
AF13
ZD601
FB607 1
AMP_LIN
AMP_RIN
YG
YG
YG
AF12
AF11
AC10
AD14
AE14
AD10
AD9
AD12
88G 30252C
2
1
3
CN604
PHONEJACK
JACK
88T 78 13A37
B
A
CN603
JACK
88T 78 13A37
B
A
CN602
JACK
88T 78 13A37
B
A
ZR39775HGCF-BD
VCM
VREF_AADC
VREF_ADAC
AGNDREF
IEC958_OUT
LINE_OUT2_L
LINE_OUT2_R
LINE_OUT1_L
LINE_OUT1_R
ADATAOUT_0
ADATAOUT_1
ADATAOUT_2
ACLK0
BCLK0
LRCLK0
Audio OUT
U401I
VGA
Audio
Input
YPbPr2
Audio
Input
YPbPr1
Audio
Input
AV1
Audio
Input
CN601
2
1
2
1
2
1
2
1
2
1
2
1
11) Audio Inputs
2
1
2
1
4
4
AV2_Audio_L
AV2_Audio_R
2.2.uF/25V
2.2uF/25V
2.2uF/25V
2.2uF/25V
Y PbPr2_Audio_L C609
Y PbPr2_Audio_R C610
PC_Audio_L
PC_Audio_R
R619
R620
R621
R602
R604
K3
J3
H1
H2
J1
J2
K1
K2
L1
L2
M1
M2
A_GND
Audio IN
ADATAIN_0
ADATAIN_1
ADATAIN_2
LINE_IN6_L
LINE_IN6_R
LINE_IN5_L
LINE_IN5_R
LINE_IN4_L
LINE_IN4_R
LINE_IN3_L
LINE_IN3_R
LINE_IN2_L
LINE_IN2_R
LINE_IN1_L
LINE_IN1_R
ZR39775HGCF-BD
AC9
10K 1/10W 5%
AD13
10K 1/10W 5%
NC/10K 1/10W 5%AF14
10K 1/10W 5%
10K 1/10W 5%
2.2uF/25V
2.2uF/25V
Y PbPr1_Audio_L C607
Y PbPr1_Audio_R C608
C611
C612
2.2uF/25V
2.2uF/25V
C603
C606
AV2_Audio_L
AV2_Audio_R
2.2uF/25V
2.2uF/25V
C601
C602
AV1_Audio_L
AV1_Audio_R
U401E
8
NC
NC
C660
NC/LL4148
NC
R674
D604
NC
AMP_RIN
11,13
R667
AMP_LIN
11,13
R669
A24V
R646
8 AUD_AMP_MUTE
AUD_SHDN
For TPA3123
AUD_SHDN
NC
C640
1uF
C658
NC
R673
NC
C659
NC
NC
560R 1/10W 5%
R658
R668
NC
R655
560R 1/10W 5%
NC
R653
R659
C648
1uF
R651
NC
C632
10K 1/10W 5%
NC
NC/AS431AN-E1
U603
NC
R665
A24V
AMP_RIN
AMP_LIN
Q603
MMBT3904
R650
D3V3
AUD_AMP_MUTE
10K 1/10W 5%
D603
10K 1/10W 5%
R643
R642
NC
D3V3
R641
D3V3
NC
R647
PD_MUTE
NC
R670
1uF
C633
Q605
NC
R666
R662
33NF50V
33NF50V
10K 1/10W 5%
R660
C642
C646
10K 1/10W 5%
R654
Q604
MMBT3904
100K 1/10W 5%
R648
A24V
LL4148
NC
NC
1uF
C650
AMP_SD
C656
PVCCL
SD
PVCCL
MUTE
LIN
RIN
BYPASS
AGND
AGND
PVCCR
VCLAMP
PVCCR
6.2mm
54
3mm
24
23
22
21
20
19
18
17
16
15
14
13
25mm
2
NC/33 OHM
0.1uF 50V
C654
R664
R672
0R05 1/10W 5%
0R05 1/10W 5%
R671
C652
1
1
2
FB610
NC/600 OHM
0 OHM 1/3W
0.001uF
C655
0.001uF
R657
0
1
0
1
13
C645
PD_MUTE
2
FB609
NC/600 OHM
0 OHM 1/3W
R652
PD_MUTE
1
1
0
0
36
32
26
20
GAIN0 GAIN1 GAIN(dB)
1000UF35V
NC/0R05 1/10W 5%
NC/0R05 1/10W 5%
R663
C638
C644 1000UF35V
NC/1uF 0.22uF
C653
LL4148
20K 1/10W 5%
R640
D602
NC/1uF 0.22uF
A24V
2K OHM 1/4W
R661
2K OHM 1/4W
C643
AS431AN-E1
U601
51K 1/10W 5%
R635
10K 1/10W 5%
R634
R656
GAIN0
GAIN1
22uH +-25%
L603
22uH +-25%
L602
16.2mm
O=1.8mm
GAIN0
GAIN1
C649
0.22uF
0.22uF
C636
1uF
NC/33 OHM
0.5 OHM 2W
0.1uF 50V
C631
470UF35V
C629
A24V
680R 1/10W 5%
1K 1/10W 5%
R645
NC
R639
C635
L606
R649
L601
C641
A24V
HEAT SINK
Q90G6119
5
PGNDL
PGNDL
LOUT
BSL
AVCC
AVCC
GAIN0
GAIN1
BSR
ROUT
PGNDR
PGNDR
P12V
P24V
NC
NC
D601
RB160M-60TE25
+
VCC5D
1
R638
A24V
R637
+5VSB
R632
P12V
U602
TPA3121D2PWPR
0.1uF 50V 470UF35V
C657 +
1uF
AMP_BY PASS
C651
AMP_BYPASS
A_MUTE
1
2
3
4
5
6
7
8
9
10
11
12
1uF
0.1uF 50V 470UF35V
C634
AMP_SD
C630
A24V
Q602
MMBT3904
C637 +
AMP_SD
100K 1/10W 5%
R644
100K 1/10W 5%
R636
A24V
A24V
+
12) Audio Amplifier
TH1
25
+
R+
R-
L+
L-
CONN
33G3278 4D
4P S/T 2.5mm
4
3
2
1
CN606
L
R
PD_MUTE
PD_MUTE
+5VSB
R6B5
2
100K 1/10W 5%
100K 1/10W 5%
1
2
3
4
C673
NC
R6A7
1M 1/10W 5%
R6B8
100uF/25V
47K 1/10W 5%
Q613
MMBT3904
R6B4
47K 1/10W 5%
R6A9
330pF
C681
100K 1/10W 5%
R6B6
Q611
MMBT3906
100K 1/10W 5%
Q608
MMBT3906
R6B2
220R 1/10W 5%
47K 1/10W 5%
47K 1/10W 5%
R6A8
R6A4
10uF/25V
220R 1/10W 5%
C682
Q609
2N7002K
0R05 1/10W 5%
R6A1
680K 1/10W 5%
R6B7
680K 1/10W 5%
R6B3
330pF
Q610
2N7002K
2.2uF/25V
55
470pF
C684
FB613
470uF/10V
1
R685
C667
FB611
C668
1
10K 1/10W 5%
R678
D3V3
ZD609
ZD610
2 120 OHM
EARPHONE_DET 8
C669
EAR_R
EAR_DET
EAR_L
YG
Audio
Output
JACK
78 13A37
B
A
CN608
0.1uF/16V
C672
12V_AUD
P12V
100uF/25V
100R 1/10W 5%
+ C675
R693
2SC2412KR
NC/0R05 1/10W 5%
0.1uF/16V
C676
100uF/25V
+ C671
Q607
R688
88G 30211K
PHONEJACK
1
7
6
2
3
4
5
CN607
EarPhone
Output
100pF
100pF
NC/1000pF
47K 1/10W 5%
VPORT0603100KV05
47K 1/10W 5%
VPORT0603100KV05
R684
88T
3
4
1
2
300 OHM
300 OHM
2 30 OHM
330 OHM
L605
FB615
330 OHM
L604
VPORT0603100KV05
VPORT0603100KV05
ZD612
AUDIO_OUT_R
AUDIO_OUT_R 11
FB612
470uF/10V
LINE_OUT_R
NC
ZD611
100K 1/10W 5%
R6A2
470pF
Q614
2N7002K
C666
EarP_R
R696
C665
EarP_L
100K 1/10W 5%
C678
R697
C683
Q612
2N7002K
2.2uF/25V
11,12
12V_AUD
51K 1/10W 5%
R695
C686
NC
Q601
MMBT3904
R690
C674
NC
2.2uF/25V
5
6
7
8
12V_AUD
R683
100K 1/10W 5%
R681
AMP_RIN
47K 1/10W 5%
R6A3
C685
2IN+
2IN-
2OUT
VCC+
TL072CDR
VCC-
1IN+
1IN-
1OUT
U605
1uF/25V
C670
AMP_RIN
5V_HP
1uF/25V
C663
C621
4
3
2
1
Q606
MMBT3904
100K 1/10W 5%
NC
VCC5D
R680
20K 1/10W 5%
470uF/10V
R679
7K5 1/10W 5%
EarP_R
C661
R682
51K 1/10W 5%
R699
+
0.1uF/16V
C619
R633
R692
10uF/25V
+
8
7
6
5
0R05 1/10W 5%
R689
47K 1/10W 5%
100K 1/10W 5%
R698
2
1M 1/10W 5%
R687
100K 1/10W 5%
TPA6113A2DR
VO1
VDD
IN1VO2
By pass
IN2GND Shutdown
U604
EarP_L
D605
5V_HP
NC
RB160M-60TE25
1
R675
100K 1/10W 5%
R694
RB160M-60TE25
R6B1
1
NC
NC
D606
R6A6
R6A5
C680
LINE_OUT_R
2.2uF/25V
C677
NC
R691
12V_AUD
R686
4.7uF 25V
C664
R677
7K5 1/10W 5%
PD_MUTE
C679
AUDIO_OUT_L
LINE_OUT_L
12
1uF/25V
LINE_OUT_L
11 AUDIO_OUT_L
11,12 AMP_LIN
C662
AMP_LIN
R676
20K 1/10W 5%
+
+
+
+
VCC5D
2
1
2
1
13) Earphone/AV Outputs
2
1
2
1
8
12P S/T 2.5mm
33G327812D
CONN
1
2
3
4
5
6
7
8
9
10
11
12
CN701
From
Power
Board
0.001uF
0.1uF 50V
PWR_ON
PWR_ON
470uF 16V
+ C730
10K 1/10W 5%
R718
PWR_ON
0.001uF
Q704
MMBT3904
S
S
S
G
B
C
D
D
D
D
E
PS_ON
1K 1/10W 5%
8
7
6
5
3
IN
VOUT
220uF/25V
+ C749
VIN
2
2
0.01uF
C717
OUT
U702
AIC1084-18PE
GND
1
U703
G1084-33T43Uf
VCC5D
0.1uF/16V
C750
Q701
MMBT3904
3
0.01uF
C722
VCC5D
BL_BR_CTRL 10
BL_ON_OFF 8
R707
+5VSB
AO4449 -7A/-30V
1
2
3
4
0R05 1/10W 5%
R732
0.47uF/16V
C746
Q703
10K 1/10W 5%
Q702
MMBT3904
33K 1/10W 5%
R717
47K 1/10W 5%
R715
+5VSB
22K 1/10W 5%
R713
R711
10K 1/10W 5%
R709
+5VSB
5V
24V
12V
2K2 1/10W 5%
R733
3V3_STB
C729
0.1uF/16V
+5VSB
220uF/35V
+ C721
P24V
220uF/25V
+ C711
C728
33 OHM
L703
C720
C719
2 120 OHM
R704
100R 1/10W 5%
R702
FB701 1
NC/4K7 1/10W 5%
NC/4K7 1/10W 5%
R703
P12V
0.1uF/16V 0.001uF
C710
0.01uF
100pF
C709
C708
C707
100R 1/10W 5%
R701
PS_ON
3V3_STB
GND
1
FB703
1UF/25V
1
2
300 OHM
C731
VCC5D
100uF 16V
+ C713
D3V3
1UF/25V
C724
C733
+ C732
56
3
C740
VOUT
R1
2
1
2
3
4
VCC
VIN
REF
LX
GND PGND
FB
EN
U707
G5627F11U
C747
R719
8
7
6
5
8
7
6
5
R2
560R 1/10W 5%
NC
C770
4.7uH
73G253S 46
NC/0.068uF/16V
C766
10K 1/10W
L704
4.7uH
73G253S 46
8V3
1
3
B
R2
R1
ADJ/GND
INPUT OUTPUT
R2
R1
C765
C761
15K 1/10W 1%
R750
C735
C738
2
100uF/25V
+ C745
5VT
39KOHM +-1% 1/10W
R714
C768
220uF/25V
C739
P24V
5VT
8,10
VCC1V1
8,9,10 D1V8
3,4,6,7,8,10,12,13 D3V3
5,6,7,8,10 3V3_STB
3
4,5,6,7,11,12,13 VCC5D
6,7,12,13 +5VSB
10,12,13,15 P12V
12
220uF 10V
+ C736
220uF16V
+ C702
3V3_STB
0.1uF 50V 10uF 16V
C772
+ C763
VCC1V1
22uF
C762
D1V8
1000pF 0.1uF/16V 22uF
18KOHM +-1% 1/10W
R712
20K 1/10W 1%
R738
24K OHM +-1% 1/10W
R737
C705
Vout = 0.8x(R1+R2)/R2
0R05 1/10W
R749
1000pF
0.01uF
1.8K OHM 1/10W 5%
R736
U709
AZ1117D-5.0-E1
NC/0.068uF/16V
C734
10K 1/10W
L701
R705
R2
R1
B
330P 50V
C773
C771
1N50V
330P 50V
47KOHM +-1% 1/10W
R748
4.7uH
15 OHM 1/10W
R742
10K 1/10W L705
22uF 10V
R741 C744
R735
100uF 16V
+ C743
8V3
0.1uF/16V
100R 1/10W 1%
R716
VCC
VIN
REF
LX
GND PGND
FB
EN
8
7
6
5
Vout = 0.8x(R1+R2)/R2
1UF/25V 0.1uF/16V
C741
1
2
3
4
VCC
VIN
REF
LX
GND PGND
FB
EN
U704
G5627F11U
1
2
3
4
U706
G5692P11U
Vout = 0.8x(R1+R2)/R2
10R 1/10W 5%
R708
Vout = 1.25x(R1+R2)/R1
VIN
C726
10R 1/10W 5%
1UF/25V 0.1uF/16V
U708
G9084T43U
0.1uF/16V
C742
P12V
For Tuner
C769
0.1uF 50V0.1uF 50V
C774
R721
C727
220uF 25V
+ C725
NC/BZT52C6V2-7-F
ZD703
R740
100uF 25V
10R 1/10W 5%
+ C701
4UF7 10V 0.1uF/16V 220uF 25V
C759
4UF7 10V 0.01uF
C723
Standby
2
300 OHM
C718
1
FB704
NC / 33 OHM
L706 2.2uH
0.1uF /50V
C767
+5VSB
FB702
220uF/10V
+ C704
VCC5D
0.1uF/16V
C706
1V8_STB
2
1
14) Power
ADJ
1
R726
+ C751
R724
R730
C758
0R05 1/8W
0R05 1/8W
0R05 1/8W
0R05 1/8W
NC/220pF
1
2
3
4
1
L702
R727
1
73G253S
B
NC/L
2
2
4
NC/220pF
C756
PANEL_POWER
NC/22uF
D6
C6
C7
GPIO_P_11
GPIO_P_12
GPIO_P_13
GPIO_P_14
VGA_VSYNC_DET
GPIO_P_19
AE9
E1
E2
E3
E4
E5
F1
GPIO_P_29
VID0 (TEST_G0)
VID1 (TEST_G1)
VID2 (TEST_G2)
VID3 (TEST_G3)
VID4 (TEST_G4)
VID5 (TEST_G5)
PANEL_CTRL1
AC5
AD6
AD5
AD4
AE5
AE6
AB6
ADC8_INA
ADC8_INB
ADC8_INC
ADC8_IND
ADC8_INE
ADC8_INF
ADC8_ING
ZR39775 ADC # Pad
NO.
Light Sensor
VCC1V1_CHECK
D1V8_CHECK
D3V3_CHECK
PANEL PWR CHECK
Function Key
Function
G3
VCLKx2 (TEST_G10)
57
LED_2
Res_AA6
GPO_6 (AFE_TEST0)
AA6
AB10
AB9
AB8
GPO_5 (AFE_TEST1)
GPO_4 (AFE_TEST2)
PANEL_ON
AUD_AMP_MUTE
U6
V6
GPO_3 (AFE_TCLK_IN)
GPO_2 (AFE_TCLK_OUT)
AE3
K4
AFE_CLK
AFE_XCLK
H3
TEST_G12
USB_EN_N
HDMISW_RESETN
F5
Hsync_in (TEST_G9)
VGA_HSYNC_DET
G4
F4
Vsync_in (TEST_G8)
VGA_VSYNC_DET
TEST_G11
F3
VID7 (TEST_G7)
AV2_S_DET
F2
VID6 (TEST_G6)
PANEL_CTRL2
AB11
GPIO_P_28
AC14
GPIO_P_27
VGA_EDID_WP
NC/12K 1/10W 5%
AB16
GPIO_P_26
AB13
AB14
GPIO_P_24
R23
U23
U24
E6
D5
GPIO_P_25
PWR_ON
KEY_PWR
GPIO_P_23
GPIO_P_22
GPIO_P_21
GPIO_P_20
D4
D7
GPIO_P_17
GPIO_P_18
D9
D8
GPIO_P_15
GPIO_P_16
AUD_SHDN
VGA_HSYNC_DET
AV1_S_DET
EEPROM_WP1
AB17
GPIO_P_10
LED_1
AB18
GPIO_P_9
TEST_MODE
R731
NC/100uF/16V
+ C754
NC/51K 1/10W 5%
R729
C760
ZR39775HGCF ADC Pin Table
R2
R1
NC/SM340ANC/2R2 1/10W 5%
NC/68K 1/10W 5%
R728
ZD704
NC/0.22uF
Vout = 1.0x(R1+R2)/R2
9
BST
SW
FB
IN
COMPRSET
SS/EN GND
C753
For 32' 5V PANEL Power
NC/0.001uFNC/22K 1/10W 5%
C757
NC/0.1uF/16V
9
8
7
6
5
NC/LL4148
R725
NC/0R05 1/4W 5%
AB20
GPIO_P_8
TVM_BOOT
Q706
NC/MMBT3904
AB19
E11
E12
D12
GPIO_P_7
NC/10K 1/10W 5% Q705
NC/MMBT3904
GPIO_P_6
GPIO_P_5
SPI_WEN
PANEL_5V
GPIO_P_3
D11
D10
GPIO_P_2
GPIO_P_4
C12
GPIO_P_1
R723
EARPHONE_DET
BL_ON_OFF
C11
GPIO_P_0
Pad
NO.
C10
ZR39775 GPIO #
USB_OC_N
PANEL_5V_ON
DEMOD_RSTN
Signal
8051
8051
O
LED RED
Amplifier Mute
O
PANEL LVDS Power ON/OFF
O
USB Power Enable
O
O
O
HDMI Switch Reset
VGA Hsync Detect
I
O
VGA Vsync Detect
AV2 S-Video Detect
PANEL Control 2
VGA EEPROM Write Protect
PANEL Control 1
8051
8051
8051
Keypad Power On
Power ON
8051
8051
Amplifier Shutdown
VGA Hsync Detect
AV1 S-Video Detect
System EEPROM Write Protect
8051
8051
8051
8051
8051
8051
8051
8051
8051
8051
VGA Vsync Detect
LED Blue
Debug Mode
TV Micro Bootstrap Config
Flash Write Protect
USB Power Over Current Flag Output
Earphone Detect
Backlight ON/OFF
Reset DeModulator
Function
I
I
I
I
I
O
O
I
I
O
8051
I
8051
8051
8051
8051
MIPS
MIPS
MIPS
MIPS
MIPS
MIPS
MIPS
I/O
TYPE
MIPS
O
I
I
O
I
I
O
O
I/O
ZR39775HGCF GPIO Pin Table
NC/10K 1/10W 5%
R722
P12V
U710
NC/SC4525BSETRT
D702
NC/22K 1/10W 5%
NC/0.1uF/16V
NC/100uF/16V
C752
P12V
PANEL_ON
NC/1K 1/10W 5% C755
R744
R745
R746
R747
PANEL_5V_ON
8,10 PANEL_ON
15) Power & GPIO Table
Note
!
C904
!
4
13mH
1
3 L901 2
NR901
NTCR
1
FUSE
F901
t
1
RV901
NC
!
CN901
2
+
R918
SG902
NC
R928
100K OHM 1/8W
R927
NC
C921
0.1uF
!
C943
0.047uF
Q924
DTC144WKA
R929
10K OHM 1/4W
R919
NC
1
2
3
4
IC903
LD7523PS
OVP
BNO
COMP VCC
(-)LATCH OUT
CS
GND
R942
51KOHM +-5% 1/4W
FB
R941
10K OHM 1/4W
BEAD
2
C944
220pF
8
7
6
5
+
+
BEAD
FB903
MTZJ T-72 16B
R945
1KOHM +-5% 1/4W
ZD940
NC
NC
D942
1
2
6
3
4
3
2
1
R908
R946
0.36 OHM +-5%
C939
0.01uF
IC902
11
10
9
8
7
12
7
8
5
2
R977
100 OHM 1/4W
2
0.33uF
+
0.001uF
C970
R986
+
+
1.8K OHM 1/4W
R965
C945 L
470uF 35V
L951
L
L980
9
10
6
7
T901
POWER X'FMR
C909
0.01uF
C946
470uF/25V
R988
1.8K OHM 1/4W
R971
R980
NC
R979
2KOHM +-1% 1/8W
R978
24K OHM 1% 1/8W
1.8K OHM 1/4W
R967
IC952
AZ431AZ-AE1
+
A5V
R972
R968
A5V
+24V
6.8K OHM 1/4W
+12V
C949
0.1uF
+24V
R958
8.2KOHM +-1% 1/8W
R966
6.8K OHM 1/4W
R987
27KOHM +-1% 1/4W
C948
0.1uF
1.8K OHM 1/4W
L
R957
8.2KOHM +-1% 1/8W
C953
330uF 16V
C951
0.001uF L950
C950
0.001uF
100K OHM 1% 1/8W
R959
R955
1K OHM 1/8W
1K OHM 1/8W
C955
R956
0.22uF/50V
IC950
EL817MC
D950
SBT15006JST
2
47 OHM 1/4W
R952
R950
47 OHM 1/4W
R954
100 OHM 1/4W
1.8K OHM 1/4W
C975
470uF 35V
C905
470pF/250V
C931
+ 100uF/50V
0.001uF
C972
+
5
3
4
2
1
2.2 OHM 1/4W
R931
1.8K OHM 1/4W
0.001uF0.001uF
C952
C973
470uF 35V
SBR20010JST
D972
SBR20010JST
D970
C934
0.1uF
AU02Z
D931
C906
470pF/250V
R951
100 OHM 1/4W C957
58
IC971
AZ431AZ-AE1
R973
100 OHM 1/4W
R975
3.9KOHM +-5% 1/8W
R976
10K OHM 1/4W
IC970
EL817MC
R974
1K OHM 1/4W
C908
0.1uF
C924
0.001uF/250V
+
1N4148
D903
JUMPER
D932
SARS01-V1
D930
C932
R993
1000PF2KV
100K OHM 1/4W
R991
100K OHM 1/4W
C930
NC
R994
R992
100K OHM 1/4W
100K OHM 1/4W
R970
100 OHM 1/4W
C933
R907 10uF/50V
2.2 OHM 1/4W
A6069H
FB/OLP VCC
GND
D/ST
BR
S/OCP D/ST
POWER X'FMR
FB
B+
R962
4.7M OHM 1/4W
R939
10K OHM 1/4W
R948
0.1 ohm
B+
2.2 OHM 1/4W
5 T902
Q903
STP10NK70ZFP
R999
100K OHM 1/4W
R944
10K OHM 1/8W
D906
1N4148
C941
10uF/50V
R998
C907
0.1uF
R997
100K OHM 1/4W
100K OHM 1/4W
SARS01-V1
D940
C940
NC
C935
1000PF2KV
Q921
C925
10nF
B+_390V
KTD1691P
1
3
ZD930
C937
10uF/50V
2
R996
100K OHM 1/4W
+
C920
120uF M 450V
1
R943
22 OHM 1/8W
1R 1/8W 5%
R933
C942
0.1uF
B+
R923
13K OHM 1% 1/8W
R922
680K OHM +-1% 1/4W
R921
680K OHM +-1% 1/4W
VCC
R920
680K OHM +-1% 1/4W
1
FB902
10K OHM 1/8W
R947
4.7K OHM 1/8W
R937
R938
4.7K OHM 1/8W
VCC
R935
1K OHM 1/4W
R936
NC
0.12 OHM 2W
R916
C919
220pF,50V
D910
NC
ZD910
NC
Q901
STP20NM60FP
C911
10nF
RV902
NC
R906
510KOHM +-5% 1/8W
C915
470pF,50V
C918
0.47uF/25V
Q925
KTA1273
2
1
R985
3.6K OHM 1/8W
C922
1uF C923
0.1uF
2K OHM 1/8W
R964
R926
1M OHM 1% 1/4W
R925
1M OHM 1% 1/4W
R924
1M OHM 1% 1/4W
B+_390V
R909
1
R915
470 OHM 1/8W
R914
10K OHM 1/8W
1.5 MOHM +-5% 1/4W
R905
1.5 MOHM +-5% 1/4W
R904
1.5 MOHM +-5% 1/4W
1N4148
D905
D902
FMN-1106S
10 OHM 1/8W
R913
IC901
FAN7529MX
C912
100pF
R911
R932
20K OHM 1/4W
1R 1/8W 5%
310uH
L906
C916 10K OHM 1/8W
R917
NC
56K OHM 1/8W
C917
0.047uF
D901
1N4007-E3/73
C914
47uF/50V
R903
330K OHM 1/4W
C903
680pF
SOCKET
!
C901
0.47uF/275V
SG901
NC
R901
330K OHM 1/4W
!
13mH
0.47uF/275V
4
3
BD901
D10XB60
C913
0.1uF
R910
300K OHM 1/4W
VCC
C910
1uF/450V
1
2
8
2
5
6
7
BEAD
3 L902 2
1
IN5408
2
3
D904
2
1
1
8
7
6
5
VCC
INV
COMP OUT
MOT GND
CS
ZCD
1
2
3
4
2
2
1
FB901
R902
330K OHM 1/4W
NC
N
L
CN903
C902
680pF
2
1
2
1
+
-
4
3
715G3332
3
1
2
3
1
HL32D2
1
2
+
ZD952
1
1K 1/8W 5%
D971
ON/OFF
PDIM
+12V
C978
0.1uF
PS_ON
R981
100 OHM 1/8W
R963
10K OHM 1/8W
R961
10K OHM
+5V
PS_ON
+24V
+5V
R982
1K OHM 1/8W +-5%
R983
1K OHM 1/8W +-5%
1N4148
D951
R984
6.8K OHM 1/4W
R989
Q970
PMBS3904
MTZJ T-72 15B
2
1
C956
0.1uF
C947
0.1uF
MTZJ T-72 30B 1N4148
ZD970
R969
6.8K OHM 1/4W
+12V
2
Q950
PMBS3904
IC951
EL817MC
R960
1K OHM
C954
470uF 16V
4
3
10.2 Power Board
1
2
4
3
3
1
4
3
1
2
3
1
1
2
1
2
3
4
5
6
7
8
9
10
11
12
CONN
CN902
IS2
IS1
1N4148
D807
D804
SCS0520P
DR2
C802
2.2uF 25V X7R
NC
68K OHM 1/8W
C818
47N 50V
1M 1/8W
R831
1M 1/8W
R829
ISEN
Q805
PMBS3904
Q804
PMBS3904
R813
C807
330PF/50V
R820
100K OHM 1/8W
VREF
VS
68K OHM 1/8W
R828
R830
+12V
L
L801
NC
2
Q803
RK7002
R819
1M OHM 1/8W
R809
C815
220pF/25V
1
2
3
4
5
6
7
8
OZ9976GN
16
15
14
13
12
11
10
9
C822
1000pF
59
C816
1500pF
ISEN
DRV1 DRV2
GND
VIN
ZCS
VREF
RT1
ENA
CT
ADIM
LCT
TIMER
PDIMSSTCMP
VSEN ISEN
IC801
C806
0.1uF/50V
C803
1000pF
R833
10K OHM 1/4W +-5%
Q802
AOTF12N50
Q801
AOTF12N50
R832
10K OHM 1/4W +-5%
C823
10nF
R816
51 OHM 1/8W
DR1
C805
470uF/25V
R803
100 OHM 1/8W
+
R802
100 OHM 1/8W
1
SCS0520P
D803 SCS0520P
1
2
D801
R801 0.1 ohm
R817
2.2K OHM 1/8W +-5%
C810
4N7 50V
5
6
9
7
4
!
10
1
T801
50:50:50
B+_390V
R805
R806
62K OHM 1/8W3.3MOHM1/8W
C808
1N 50V
R808
1M OHM 1/8W
1N4148
C817
47N 50V
D806
R812
150K OHM 1/8W
R807
240K OHM 1/8W
PDIM
ON/OFF
D802
SCS0520P
DR1
2
1
2
1
1
2
6
3
R821
9.1K OHM 1/8W
!
9
8
7
11
10
12
C809
1U 25V
D805
BAV70
R822
2
300 OHM 1/8W
C819
NC(C1206)
3
1
R814
51K OHM 1/8W +-5%
R811
1.5M OHM 1/8W
VREF
T802
P:S=42:42
5
R818
1.5K OHM 1/8W +-1%
C812
0.022uF/25V
ENA
DR2
C804
1uF/450V
C801
1uF/450V
R804
R824
R825
R826
680PF/50V
330 OHM 1/8W
C821
510 OHM 1/8W
R827
IS2
IS1
5
4
3
2
1
CN802
2
1
CONN
CONN
N
L
CN801
C814
2.2uF 25V X7R
510 OHM 1/8W
C813
4N7 50V
300 OHM 1/8W
680PF/50V
330 OHM 1/8W
R823
C811
1U 25V
R815
51K
C820
10K OHM 1/8W
R810
100K OHM 1/8W
TA
TB
IS2
VS
IS1
TB
TA
GPIN2
GPIN1
1
1
CONN
IS2
IS1
T8802
POWER X'FMR
C8803
5pF/6KV
2
GPIN4
GPIN3
T8803
POWER X'FMR
C8805
5pF/6KV
P1
T8804
POWER X'FMR
GPIN6
GPIN5
D8804
1N4148
D8802
1N4148
1
1
60
C8812
5pF/6KV
P2
POWER X'FMR
T8805
T8806
POWER X'FMR
D8811
D-BAV99-7-F
R8820
1K OHM 1/8W +-5%
D8819 D-BAV99-7-F
C8824
6N8 50V C8825
6N8 50V
C8813
5pF/6KV
GPIN8
GPIN7
R8812 R8814
510 OHM
510
+-5%
OHM
1/8W
+-5% 1/8W
R8811
510 OHM +-5% 1/8W
D8813
D-BAV99-7-F
R8819
1K OHM 1/8W +-5%
C8816 C8817
6N8 50V
6N8 50V
C8804
5pF/6KV
1
1
D8809
D8815
D-BAV99-7-F D-BAV99-7-F
3
R8818
1K OHM 1/8W +-5%
R8813
3K6 +-1% 1/8W
1N4148
R8823
1K OHM 1/8W +-5%
D8820
1N4148
D8821
R8803
22KOHM +-1% 1/8W
C8818
330pF 50VIS2 C8819
330pF 50V
R8817
3K6 +-1% 1/8W
VS
TA
T8801
POWER X'FMR
TA
R8816
22KOHM +-1% 1/8W
C8802
5pF/6KV
1
2
3
2
1
CN8803
4
6
4
6
4
6
CONN
1
2
2
1
1
CONN
IS2
2
4
6
TB
3
1
2
3
2
P3
1
VS
IS1
2
4
6
CN8802
3
R8806
100 OHM +-5% 1/8W
3
2
2
1
1
6
5
4
3
2
1
1
R8802
100 OHM +-5% 1/8W
1
4
6
P2
1
1
C8808
5pF/6KV
C8820 C8821
6N8 50V 6N8 50V
C8809
5pF/6KV
P3
R8807
1K 1/8W
TB
100KOHM +-5% 1/8W
D8806
R8808 MTZJ T-72 5.1B
T8808
POWER X'FMR
T8807
POWER X'FMR
C8801
1N 50V
R8804
10KOHM +-5% 1/8W
D8817
D-BAV99-7-F
3
D8801
1N4148
2
CN8801
3
4
6
R8801
100 OHM +-5% 1/8W
1
P1
2
2
2
1
1
715G3645P01W30003S
1
4
6
C8822
220pF; 50V
R8805
100K OHM 1/8W
VS
2
1
RV903
NC
1
1
2
NR901
RV901
Varistor
HS2
HEAT SINK (Q901,D901)
1
2
HS1
HEAT SINK (BD901)
F901
FUSE
CN901
3
NC
SG903
NR902
2
C901
0.47uF
1
2
HS4
HEAT SINK (D910)
1
2
HS3
HEAT SINK (IC901)
2 1
R903
300K OHM 1/4W
R902
300K OHM 1/4W
R901
300K OHM 1/4W
4
1
3
2
1
2
HS6
HEAT SINK (D904,D907)
1
2
HS5
HEAT SINK (Q901)
SG902
NC
20.0MH
L901
SG901
NC
61
C903
680pF
C902
680pF
2.0MH
L902
1
4
RV902
NC
1
t
2
3
715G3351
t
C904
0.47uF
4
1
20.0MH
L903
3
2
1
4
-
FB901
BEAD
CN902
NC
2
HL42XD2
1
2
L
N
2
3
1
BD901
D10XB60
+
R+
BO
D802
SCS0520P
2
1
IS2
IS1
R812
180K 1/10W 5%
R856
10
NC
D807
1N4148
D806
1N4148
C808
0.001uF
D803
1N4148
R813
NC
C807
330pF50V
R806
3.3M OHM 1/8W
IFP
+
68K 1/10W 5%
C818
33N 50V
R830
IFP
Q804
PMBS3904
ISEN
1M 1/10W 5%
R831
Q805
PMBS3904
1M 1/10W 5%
R829
R820
100K 1/10W 5%
VREF
D810
1N4148
C817 68K 1/10W 5%
33N 50V
R828
C801
47uF/50V
VREF
Q812
R851
RK7002FD5T116
10M OHM 1/10W
R847
510K 1/10W 5%
C810
VS
12V
L801
3.5uH
R817
1K OHM
12V
C823
R853
NC
(NC)100K 1/10W 5%
VSEN
1
-
+
2
3
R850
U801A
(NC)100K OHM 1/4W
(NC)LM393MX
6
5
(NC)RK7002FD5T116
Q814
Q803
RK7002FD5T116 12V
R855
(NC)1M 1/10W 5%
-
+
62
VSEN
C816
1500PF50V
ISEN
R857
270KOHM +-5% 1/10W
OZ9976GN-C-0-TR
16
15
14
13
12
11
10
9
C812
0.047uF
R818
090107
R821
10K 1/8W 5%
3
D805
BAV70
R814
51K 1/8W 5%
C809
1U 25V
R811
1.5M 1/8W 5%
VREF
1K2 /8W 1%
ENA
DR2
2
1
T2
T1
C819
R822
680pF
220 OHM +-1% 1/10W
R823
NC
C811
R815
NC
R810
100K OHM 1/4W
R804
10K OHM 1/4W +-5%
R845
D808
Q806
R841
200 OHM 1/8W
2SK4086LS
R835
1N4148-B4006
10R 1/8W 5%
10K OHM 1/4W +-5%
R834
1K2 1/4W 5%
Q810
SST2907A
T2
R842
D809
Q807
10R 1/8W 5%
1N4148
2SK4086LS
R846
C821
200 OHM 1/8W
100PF1KV
R836
1K2 1/8W 5%
R837
090107
10K OHM 1/4W +-5%
Q811
SST2907A
DRV1 DRV2
GND
VIN
ZCS
VREF
RT1
ENA
CT
ADIM
LCT
TIMER
PDIMSSTCMP
VSEN ISEN
IC801
C806
0.1uF
10
7
9
6
5
R852
(NC)100K 1/10W 5%
VREF
R816
NC
R819
C815
1M +-5%
1/8W
2N2 50V
R854
U801B
(NC)100K 1/10W(NC)LM393MX
5%
7
T803
R849
100K 1/10W 5%
1
DR1
2
3
4
5
6
7
VSEN
8
+
1
4
C822
2.2uF 25V X7R
C805
470uF 25V
R809
36K OHM 1/8W
Q815
(NC)RK7002FD5T116
RK7002FD5T116
Q813
R848
82K 1/10W 5%
R805
62K OHM 1/8W
D804
SCS0520P
C803
100PF1KV
R833
10K OHM 1/4W +-5% 090107
Q802
2SK4086LS
D801
Q801
1N4148-B4006
2SK4086LS
R832
DR2
10K OHM 1/4W +-5%
Q808
SST2907A
T1
Q809
SST2907A
5 R839
10R 1/8W 5%
R802
1K2 1/4W 5%
6
R840
10R 1/8W 5%
R844
200 OHM 1/8W
7
9
R803
1K2 1/8W 5%
R808
1M 1/8W 5%
ON/OFF
R807
240K 1/10W 5%
PDIM
1
4
T801
R843
200 OHM 1/8W
R801 0.1 ohm
2
1
DR1
B+
8
4
C802
2.2uF 25V X7R
8
4
TA
TB
R825
220 OHM +-1% 1/10WC820
680pF
R826
NC
R824
R827
C814
2.2uF 25V X7R
12
10
11
3
6
5
7
8
9
2
C813
1 T802
1
2
IS2
IS1
CONN
5
4
3
2
1
CN802
CONN
L
N
CN801
1
2
IS2
VS
IS1
TA
TB
HS10
HEAT SINK (Q802)
1
2
HS9
HEAT SINK (Q807)
1
2
HS8
HEAT SINK (Q801)
1
2
HS7
HEAT SINK (Q806)
1
FB902
BEAD
R941
R936
1M 1/4W 5%
R931
1M 1/4W 5%
BNO
OVP
COMP VCC
(-)LATCH OUT
CS
GND
C926
1uF
Q903
DTC144WKA
R938
10K 1/8W 5%
R935
1K 1/8W 5%
Q904
KTA1273-Y - AT/ P
C914
10uF/50V
R926
10K 1/8W 5%
R921
22 OHM 1/4W +-5%
+
D903
JUMPER
R927
1K OHM 1/4W
VCC1
C915
0.1uF
D902
SARS01-V1
R910
100K OHM 1/4W
R905
R906
100K OHM 1/4W 100K OHM 1/4W
C910
2200PF2KV
R909
100K OHM 1/4W
C923
220pF
8
7
6
5
R916
4K7 1/4W 5%
B1+
IC902
LD7523A
R925
51K 1/8W 5%
1
2
3
4
R919
10K OHM 1/4W
C943
0.1NF2KV
R904
4.7 OHM 1W
C922
0.047uF
2
R930
1M 1/4W 5%
R924
3.6K OHM 1/8W
B+
R928
0.27OHM 2W
C924
0.01uF
7
8
9
10
T902
11
POWER X'FMR
12
Q901
STP10NK70ZFP
4
5
6
IC909
EL817MA
63
R918
22R 1/4W 5%
IC903
KIA431A-AT/P
R937
10K 1/8W 5%
C916
0.0022uF
C925
0.33uF/50V
R932
3.9K OHM 1/8W
R929
470 OHM 1/4W
R917
22R 1/4W 5%
D904
FME-210B
2
C917
0.0022uF
+
+
+
R940
2K OHM 1% 1/8W
R933
C919
1000uF 25V
C911
1000uF 35V
3.5uH
R985
R986
C907
C908
L906
D907 1.5 KOHM +-5% 1.5
1/4W
KOHM +-5%
12061/4W
1NF K1206
500V1NF
X7R K 500V X7R
FMX-12SL
2
1.5 KOHM +-5% 1/4W
1.5 KOHM +-5% 1/4W
R908
R907
4
3
3
1
3
1
1
2
3.5uH
L905
C912
470uF 35V
R934
C920
1000uF 25V
+
+
24V
ON/OFF
PDIM
12V
C918
0.1uF
5V
PS_ON
R911
NC
C921
470uF 25V
C913
0.1uF
R922
NC
R912
NC
R913
NC
12V
1
2
3
4
5
6
7
8
9
10
11
12
CN903
R923
NC
R914
NC
24V
R915
NC
1
2
R951
3.3M OHM 1/14W
R948
3.3M OHM 1/14W
VCC1
R942
3.3M OHM 1/14W
Q905
KTD1691/P BY KEC
R954
180K 1/8W
5%
C935
1uF/25V
Vcc
+
1
IC905
EL817MA
Q906
PMBS3904
R944
P:S=50:28
L904
C937
C940
0.1uF
64
2K7 1/8W 5%
R960
R956
NC
PS_ON
C933
0.1uF
R953
51K 1/8W 5%
C928
0.1NF2KV
0.001uF/250V
C939
C938
100pF
Q902
STW20NM60
C934
1uF/25V
R949
10K 1/8W 5%
1
D908
1N5408-E3/73
D901
FMXA-1106S
R947
47 OHM 1/8W
1N4148
D909
IC904
ICE2PCS02G
100R 1/8W 5%
5
R961
10K 1/8W 5%
5V
C936
1000pF
2
7
8
9
C932
0.1uF
3
6
10
11
R959
470R 1/8W 5%
R958
1K 1/8W 5%
R952
220 OHM 1/4W
C931
10uF/50V
0.1OHM2W
R945
0.1OHM2W
R943
C927
1uF/520V
ZD902
MTZJ T-72 16B
D920
SUF305B
4
3
R+
1
2
12
8
7
6
5
GND
GATE
ICOMP
VCC
ISENSEVSENSE
VINS
VCOMP
1
2
3
4
2
3
+
R957
11.5K OHM 1% 1/8W
R955
R950
R946
C929
100uF M 450V
+
C930
100uF M 450V
B+
IC901
A6069H
R966
100K OHM 1/4W
D911
JUMPER
R964
100K OHM 1/4W
R980
C956
560K OHM 1% 1/8W 0.22uF/50V
R976
4.7M OHM 1/4W
R977
1M5 1/4W 1%
R973
1M5 1/4W 1%
C905
R970
NC
1M5 1/4W 1%
R965
100K OHM 1/4W
D919
PR1007
R963
100K OHM 1/4W
8
7
BO
5
S/OCP D/ST
BR
D/ST
GND
FB/OLP VCC
R981
1.2OHM2W
+
C951
0.1uF
1N4148
D915
D913
PR1007
5
470pF/250V
C960
470pF/250V
C906
ZD907
NC
9
10
6
7
C958
NC
+ C953
47uF/50V
Vcc
D914
PR1007
ZD906
NC
C952
47uF/50V
NC
R974
C955
+
D912
SARS01-V1
3
4
2
C942
0.1NF2KV
R967
3.3 OHM 1/4W
C954
10uF/50V
1
2
3
4
T901
POWER X'FMR
EL817MA
IC907
+
65
IC908
KIA431A-AT/P
R983
1K8 1/8W 5%
R975
220 OHM 1/4W
R971
33 OHM 1/4W
C957
0.22uF/25V
R979
1K 1/8W 5%
33 OHM 1/4W
R969
R972
33 OHM 1/4W
0.0022uF
C949
C944
0.0022uF
D910
SBT15006JST
2
33 OHM 1/4W
R968
4
3
1
2
1
3
1
B1+
2
1
1
2
R984
8K2 1/8W 1%
R978
8K2 1/8W 1%
D918
1N4148
C959
0.1uF
Q907
PMBS3904
C962
(NC)0.1uF
3.5uH
L907
ZD905
MTZJ T-72
C961
(NC)0.1uF
+
+
C945
C946
1000uF M 16V
1000uF M 16V
2
1
ZD903
MTZJ T-72 30B
C947
1000uF M 16V
+
2
C963
(NC)0.1uF
12V
ZD904
MTZJ T-72 15B
24V
5V
C948
0.1uF
D917
1N4148
R920
10K 1/8W 5%
R982
56R 1/8W 5%
D916
1N4148
1
2
1
2
3
2
2
5
7
1
3
D8818
BAV99
R8822
0R05 1/8W
C8820 C8821
0.0056uF
0.0056uF
D8812
BAV99
3
5
7
C8808
3pF 6KV
2
2
8
8
D8819
BAV99
5
R8823
0R05 1/8W
C8822 C8823
0.0056uF
0.0056uF
C8809
3pF 6KV
P2
CN8805
CONN
2
1
D8813
C8834 BAV99
560pF50V
5
C8810
3pF 6KV
7
5
2
CN8804
CONN
1
7
C8807
3pF 6KV
2
8
8
C8806
3pF 6KV
2
1
3
P1
1
CN8803
CONN
2
1
3
7
T8804
T8805
POWER X'FMR
POWER X'FMR
2
T8803
POWER X'FMR
2
T8802
POWER X'FMR
1
P7
P6
R8824
0R05 1/8W
D8820 BAV99
R8810
100R 1/8W 5%
R8809
100R 1/8W 5%
CN8806
C8811 CONN
3pF 6KV
D8814
BAV99
R8813
510R 1/8W 5%
C8812
3pF 6KV
T8807
POWER X'FMR
POWER X'FMR
2
1
R8812
510R 1/8W 5%
510R 1/8W 5%
R8811
510R 1/8W 5%
T8806
C8824 C8825
0.0056uF
0.0056uF
P3
2
2
TA
3
5
8
8
CONN
1
TA
3
TB
R8814
C8813
3pF 6KV
P4
C8826 C8827
0.0056uF
0.0056uF
R8825
0R05 1/8W
D8821 BAV99
3
1
2
2
5
7
L
N
1
7
R8808
100R 1/8W 5%
1
2
2
8
8
P5
2
5
7
CONN
R8815
510R 1/8W 5%
R8816
510R 1/8W 5%
R8817
510R 1/8W 5%
CN8807
CONN
D8815
BAV99
2
1
C8814
3pF 6KV
T8809
POWER X'FMR
POWER X'FMR
T8808
2
CN8802
66
R8826
0R05 1/8W
R8830
24K 1/8W 5%
C8801
0.01uF
R8804
10K 1/8W 5%
CN8808
CONN
D8816
BAV99
2
1
C8816
3pF 6KV
T8811
POWER X'FMR
POWER X'FMR
T8810
D8808
1N4148
D8807
1N4148
D8806
1N4148
D8804
1N4148
D8803
1N4148
C8815
3pF 6KV
P5
C8828 C8829
0.0056uF
0.0056uF
D8822 BAV99
3
R8806
100R 1/8W 5%
3
5
7
P4
1
2
2
8
8
R8803
100R 1/8W 5%
2
5
7
P3
2
IS2
R8807
C8817
3pF 6KV
P6
R8827
0R05 1/8W
D8805
MTZJ T-72 5.1B
D8825
1N4148
R8805
100K 1/8W 5%
CN8809
CONN
D8817
BAV99
2
1
C8818
3pF 6KV
T8813
POWER X'FMR
POWER X'FMR
T8812
100K 1/8W 5%
C8830 C8831
0.0056uF
0.0056uF
D8823 BAV99
3
VS
IS1
1
5
7
D8801
1N4148
3
2
2
8
8
D8802
1N4148
1
5
7
R8802
100R 1/8W 5%
2
R8801
100R 1/8W 5%
2
D8824 BAV99
C8832 C8833
0.0056uF
0.0056uF
C8819
3pF 6KV
P7
CN8810
CONN
2
1
C8802
3pF 6KV
T8815
POWER X'FMR
POWER X'FMR
T8814
R8828
0R05 1/8W
5
7
P2
1
2
2
8
8
P1
3
5
7
6
5
4
3
2
1
3
5
D8827
1N4148
R8820
10K 1/8W 5%
TB
10K 1/8W 5%
D8826
1N4148
R8821
R8819
39K 1/8W 5%
R8829
0R05 1/8W
C8805
3pF 6KV
POWER X'FMR
T8816
560PF/50V
560PF/50V
IS2
C8804
C8803
IS1
R8818
39K 1/8W 5%
7
CN8801
1
T8801
POWER X'FMR
1
D8811
BAV99
2
2
2
2
2
8
8
715G3358
1
5
7
VS
1
2
3
4
1
3V3_STB
GND PIN
1
33G8032 4F HR
CONN
CN01
715G3293
10.3 Key Board
C02
PWR-SW
FUNC_KEY
PWR-SW
FUNC_KEY
NC/0.1uF/16VNC/4.7uF/16V
C01
NC
C03
R08
R07
100R 1/10W 1%
750 OHM 1% 1/10W
NC/3.9K OHM 1/10W
R06
3V3_STB
67
NC
C04
SW06
77G 607
2 FD
TACT SW FWRD H1.5MM
SW07
TACT SW FWRD H1.5MM
750 OHM 1% 1/10W
R05
SW05
TACT SW FWRD H1.5MM
1K OHM 1% 1/10W
R04
SW04
TACT SW FWRD H1.5MM
1.8K OHM 1% 1/10W
R03
SW03
TACT SW FWRD H1.5MM
2.7KOHM +-1% 1/10W
R02
SW02
TACT SW FWRD H1.5MM
7.5KOHM +-1% 1/10W
R01
TACT SW FWRD H1.5MM
SW01
Power ON/OFF
Source Select
MENU
CH-
CH+
VOL-
VOL+
~0.53V
~0.91V
~1.29V
~1.72V
~2.12V
~2.59V
715T3294
1
CONN
5
4
3
2
1
CN01
VCC
LED_R
LED_B
IRRV
33T8032 5F HR
10.4 IR Board
0.1uF/16V
C01
15K OHM 1/10W
68
NC/4.7uF/16V
C02
R01
4
RED
VOUT
GND
VCC
U01
14 24 GP
1
2
056G 627503
GP18B38BCE-HB
1
2
3
081G
3
BLUE
LED01
LED
RED
BLUE
HL32D2
11. Exploded View
20
69
HL42XD2
70
HL32D2
No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
Description
BEZEL
SPEAKER
KEY COVER
KEY PAD
IR LENS
POWER LENS
POWER BOARD
32TV-BASE-SUPPORT-G3
32TV-VESA-BKT-G3
PANEL
NA
MAIN BOARD
IO SIDE COVER
REAR COVER
NA
HINGE
BASE
32TV BKT_BASE-1
RUBBER FOOT
REMOTE CONTROL FOR USA HAIER
Q'ty
1
2
1
1
1
1
1
1
2
1
1
1
1
1
1
1
1
1
6
1
Screw Lists
No.
1
2
3
4
5
6
7
8
9
10
11
12
P/N
0D1G1730 8120
0M1G 930 6 47 CR3
0Q1G 930 8 47 CR3
0M1G 940 6120
0M1G 940 6120
0M1G 940 12 47 CR3
0Q1G 940 16 47 CR3
0M1G1730 6120
0M1G1740 10120
0Q1G 940 14 47 CR3
Q01G6070 1
0Q1G 940 16 47 CR3
Description
SCREW FOR MAIN,POWER AND INVERTER BOARD
SCREW FOR IO COVER
SCREW FOR IO COVER
SCREW FOR TV-VESA-BKT
SCREW FOR BASE-SUPPORT
SCREW FOR BASE
SCREW FOR BASE
SCREW FOR MAIN BOARD
SCREW FOR BASE-SUPPORT
SCREW FOR BEZEL/PANEL
SCREW FOR BEZEL/PANEL
SCREW FOR REAR COVER
71
Q'ty
14
2
1
4
5
2
2
2
2
2
2
10
HL42XD2
No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
45
Description
IR BOARD
RUBBER FOOT
SHIELD COVER SIDE
BKT-VESA-BTM
STAND BRACKET
VESA BRACKET LCM
BASE BRACKET A1
INVERTER BOARD
POWER BOARD
MAIN BOARD
KEY BOARD
SPEAKER
PANEL
SHIELD COVER SIDE
KEY HOLDER
KEY PAD
IR LENS
POWER LENS
REAR COVER
NA
NECK COVER
STAND COVER A1
BEZEL 42
BASE COVER A1
IO SIDE COVER
HINGE ASS'Y
BOLT
POWER BOARD SUPPORT
CABLE TIE
TAPE_INSULATING
REMOTE CONTROL FOR USA HAIER
Q'ty
1
10
1
2
1
1
1
1
1
1
1
2
1
1
1
1
1
1
1
1
1
1
1
1
1
1
2
1
1
1
1
Screw Lists
No.
31
32
33
34
35
36
37
38
39
40
41
42
43
44
P/N
001G6021 1
0M1G 930 6 47 CR3
0Q1G 130 8 47 CR3
0Q1G 940 14 47 CR3
0Q1G 940 20 47 CR3
0Q1G 940 30 47 CR3
0M1G 940 5120
0M1G1730 8120
0M1G 940 12 47 CR3
0M1G1830 8120
0M1G1760 12225 CR3
0Q1G1030 6120
0Q1G 930 8 47 CR3
0Q1G 940 10 47 CR3
Description
SCREW FOR SPEAKER
SCREW FOR HDMI
SCREW
SCREW
SCREW
SCREW
SCREW
SCREW
SCREW
SCREW
SCREW
SCREW
SCREW
SCREW
72
Q'ty
4
2
6
4
8
4
5
10
10
5
4
3
4
2
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertising