NISSAN NAVARA

NISSAN NAVARA
NISSAN NAVARA
H60A - D23
PERIODIC MAINTENANCE
The following tables show the normal maintenance schedule.
Depending upon weather and atmospheric conditions, varying road surfaces, individual
driving habits and vehicle usage, additional or more frequent maintenance may be required.
Periodic maintenance beyond the last period shown on the tables requires similar maintenance.
ENGINE AND EMISSION CONTROL MAINTENANCE (M9T DIESEL ENGINE)
Abbreviations: I = Inspect and correct or replace as necessary, R = Replace, E = Check and correct mixture
MAINTENANCE OPERATION
15
(9)
12
30
(18)
24
MAINTENANCE INTERVAL
45
(27)
36
60
(36)
48
75
(45)
60
90
(54)
72
105
(63)
84
120
(54)
96
Intake & exhaust valve clearance
km x 1,000
(mile x 1,000)
Months
See NOTE (1)
Drive belts ★
See NOTE (2)
Timing chain
See NOTE (3)
Engine oil (Use reccommended oil.)
See NOTE (4)
R
R
R
R
R
R
R
R
Engine oil filter (Use Genuine NISSAN engine oil filter or
equivalent.)
See NOTE (4)
R
R
R
R
R
R
R
R
Engine coolant
See NOTE (5)
Perform at kilometers (miles) intervals or
months interval, whichever comes first.
Cooling system
I
E
I
I
I
Fuel lines
Air cleaner filter (Dry paper type) ★
Fuel filter★
I
E
I
D
D
I
I
E
I
I
E
I
R
D
R
D
R
D
D
R
Maintenance items with “★ “ should be performed more frequently according to “Maintenance Under Severe Driving Conditions”.
NOTE:
(1) Periodic maintenance is not required. However, if valve noise increases, chech valve clearance.
(2) Replace every 240,000 km (144,000 miles) or 120 months.
(3) Replace every 300,000 km (180,000 miles).
(4) If the oil replacement indicator is displayed, change the engine oil & filter as soon as possible. After oil replacement, reset the display.
(5) Use Geniune NISSAN Engine Coolant (Blue) or equivalent in its quality, in order to avoid possible aluminium corrosion within the engine cooling system
caused by the use of non-genuine engine coolant. Check and correct the engine coolant mixture ratio every 30,000 km (18,000 miles) or 24 months.
First replacement interval is 150,000 km (90,000 miles) or 96 months. After first replacement, replace every 75,000 km (45,000 miles) or 48 months.
(6) Drain water when water level sensor lamp lights on in combimeter.
I
I
I
I
Clean every 5,000 km (3,000 miles)
R
See NOTE (6)
I
R
D
D
NISSAN NAVARA
H60A - D23
PERIODIC MAINTENANCE
The following tables show the normal maintenance schedule.
Depending upon weather and atmospheric conditions, varying road surfaces, individual
driving habits and vehicle usage, additional or more frequent maintenance may be required.
Periodic maintenance beyond the last period shown on the tables requires similar maintenance.
CHASSIS AND BODY MAINTENANCE
Abbreviations: I = Inspect and correct or replace as necessary, R = Replace, L = Lubricate, T = Tighten, [ ] = Perform maintenance based on mileage only
MAINTENANCE INTERVAL
MAINTENANCE OPERATION
Perform at kilometers (miles) intervals or
months interval, whichever comes first.
km x 1,000
(mile x 1,000)
Months
Brake & clutch fluid (For level & leaks)
15
(9)
12
I
Brake fluid ★
30
(18)
24
I
45
(27)
36
I
R
60
(36)
48
I
75
(45)
60
I
R
90
(54)
72
I
105
(63)
84
I
R
120
(72)
96
I
R
Power steering fluid & lines (For level & leaks)
I
I
I
I
I
I
I
I
Brake & clutch system
I
I
I
I
I
I
I
I
Exhaust system
I
I
I
I
Automatic transmission fluid (For level & leaks) ★
I
I
I
I
I
I
I
I
Manual transmission gear oil (For leaks)
I
I
I
I
I
I
I
I
Transfer fluid (For level & leaks)
I
I
I
I
I
I
R
I
Differential gear oil (For level & leaks) ★
I
I
I
I
I
I
I
R
Steering gear & linkage, axle & suspension parts,
propeller shaft & drive shafts★
I
I
I
I
I
I
I
I
T
T
T
T
T
T
T
T
Brake pads, rotors & other brake components ★
I
I
I
I
I
I
I
I
Brake linings, drums & other brake components ★
I
I
I
I
I
I
I
I
Foot brake, parking brake & clutch (For free play,
stroke & operation)
I
I
I
I
I
I
I
I
Air conditioner filter ★
R
R
R
R
R
R
R
R
Body mountings
See NOTE (1)
Maintenance items with “★“ should be performed more frequently according to “Maintenance Under Severe Driving Conditions”.
NOTE:
(1) It is applicable, when the vehicle is used as a commercial vehicle.
NISSAN NAVARA
H60A - D23
MAINTENANCE UNDER SEVERE DRIVING CONDITIONS
The maintenance intervals shown on the preceding pages are for normal operating conditions.
If the vehicle is operated under severe driving conditions.
Periodic maintenance beyond the last period shown on the tables requires similar maintenance.
ABCDEFGHI J KL M-
Driving under dusty conditions
Repeatedly driving short distances
Towing a trailer or caravan
Extensive idling
Driving in extremely adverse weather conditions or in areas where ambient temperatures are either extremely low or extremely high
Driving in high humidity areas or in mountains
Driving in areas using salt or other corrosive materials
Driving on rough and/or muddy roads or in the desert
Driving with frequent use of braking or in mountainous areas
Frequent off road use or driving in water
Sustained high speed driving
Repeated short journeys, cold engine at low temperature
Low speed driving (Average speed <30 km/h)
Maintenance operation: Inspect = Inspect and correct or replace as necessary.
Maintenance item
Driving condition
Maintenance operation
Maintenance interval
C D .
.
.
.
.
.
.
. M Drive belt
Replace
Every 120,000 km (72,000 miles) or 60 months
A .
.
.
.
.
.
.
.
.
.
.
.
Air cleaner filter
Replace
More frequently
A .
.
.
E
.
.
.
.
.
.
.
.
Fuel filter
Replace
Every 15,000 km (9,000 miles) or 12 months
.
.
.
.
F
.
.
.
.
.
.
.
.
Brake fluid
Replace
Every 15,000 km (9,000 miles) or 12 months
.
. C .
.
.
.
H .
.
.
.
.
Automatic transmission fluid
Replace
Every 30,000 km (18,000 miles) or 24 months
.
.
C .
.
.
.
H .
.
.
.
.
Differential gear oil
Replace
Every 30,000 km (18,000 miles) or 24 months
Replace
Every 7,500 km (4,500 miles) or 6 months
.
.
.
.
. G H .
.
.
.
.
Steering gear & linkage, axle & suspension parts, propeller
shaft, & drive shafts
C .
.
. G H I
.
.
.
.
Brake pads, rotors & other brake components
Replace
Every 7,500 km (4,500 miles) or 6 months
A . C .
.
. G H I
.
.
.
.
Brake linings, drums & other brake components
Replace
Every 7,500 km (4,500 miles) or 6 months
A .
.
.
.
.
.
.
Air conditioner filter
Replace
Every 15,000 km (9,000 miles) or 12 months
.
.
A .
.
.
.
.
.
.
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertising