IGNITION AND ELECTRONICS

IGNITION AND ELECTRONICS
IGNITION AND ELECTRONICS .06
MOPAR PERFORMANCE TERMS AND CONDITIONS
NOTICE
Federal and many state laws prohibit the removal, modification or rendering inoperative
of any part or element of design affecting emissions or safety on motor vehicles used for
transporting persons or property on a public street or highway. Violation may result in a
fine of up to $32,500 per vehicle. Mechanical and/or electronic performance parts listed
in this catalog with a “1” cannot be used on vehicles used on public streets or highways.
These parts may be used only on vehicles used solely in sanctioned off-highway events. No other applications
are intended or implied. Those parts that have been granted an exemption by the California Air Resources Board
(CARB) or meet the EPA requirements of memorandum 1A are legal for highway use in California, New York, and
Massachusetts and are noted as such.
NO PARTS WARRANTY – “AS IS”
Mopar Performance parts beginning with a “P” prefix are sold “as is” unless otherwise noted. This means that
parts sold by Mopar Performance carry no warranty whatsoever. Implied warranties, such as warranties of merchantability, are excluded. (An implied warranty of merchantability means that the part is reasonably fit for the
general purpose for which it was sold). The entire risk as to quality and performance of such parts is with the
buyer. Should such parts prove defective following their purchase, the buyer and not the manufacturer, distributor
or retailer, assumes the entire cost of all necessary servicing or repair. Chrysler, Jeep® , Dodge and Ram vehicle
and parts warranties are voided if the vehicle or parts are used for competition. The addition of performance parts
does not by itself void a vehicle’s warranty. However, added performance parts (parts not originally supplied on
the vehicle from the factory) are not covered by the vehicle’s warranty, and any failure that they may cause is also
not covered by the vehicle’s warranty.
MOPAR PERFORMANCE CRATE ENGINE 90-DAY LIMITED WARRANTY
Mopar Performance Crate Engine Assemblies not used in competition are warranted for “parts only,” AS DELIVERED against defects in materials or workmanship for 90 days from the date of purchase. The following parts, if
defective, will be replaced on an exchange basis for 90 days: engine blocks and all internal parts; cylinder head
assemblies; intake manifold; core plugs; valve covers; oil pan; timing gear; water pump; gaskets and seals. See
your dealer for a copy of the limited warranty, which contains additional terms and limitations.
MOPAR PARTS 12-MONTH LIMITED WARRANTY
Except parts as listed above, certain parts from Mopar Performance sold over the counter or wholesaled are
warranted against defects in workmanship or materials for 12 months/unlimited miles for parts (exchange) only.
These parts are identified in this catalog as having a specific part number structure. Part numbers starting with
“P” are not covered under the 12-month warranty. Other parts listed in this catalog without a “P” prefix part number are covered under the 12-Month Limited Warranty described here. See your dealer for a copy of the limited
warranty, which contains additional terms and limitations. Parts installed on a Chrysler, Plymouth, Jeep® , Dodge
and Ram vehicle by an authorized Chrysler, Jeep® , Dodge and Ram dealer are warranted for 12 months/unlimited
miles for parts (exchange) only. See your dealer for a copy of the limited warranty, which contains additional terms
and limitations.
EMISSIONS STATEMENT
Federal law requires emissions parts on new vehicles to be warranted for at least two years or 24,000 miles,
whichever comes first. Federal and many state laws also prohibit the removal, modification or rendering inoperative any part that affects emissions or safety on motor vehicles used on public streets or highways. Many
Mopar Performance parts are designated for track use or off-road use only. Installation of certain components
may bring the vehicle out of compliance with safety and/or emissions standards. Mopar recommends that
vehicles with parts designated in this fashion not be operated on public roads. Mopar Performance customers
are responsible for complying with applicable state and local environmental regulations. Additionally, certain
performance parts may affect the emissions characteristics of the vehicle. If you install them on the vehicle,
and your vehicle consequently fails a required state or local I/M (inspection and maintenance) emissions
test, including any test required to maintain or renew your vehicle’s registration, or if your vehicle is subject
to an emissions recall, Chrysler Group LLC may not be required to repair your vehicle under the emissions
performance warranty, and you may be required to remove those parts at your own expense in order to obtain
repairs necessary to pass the I/M test or to perform the recall.
NOTE — CALIFORNIA ONLY
The emissions laws and regulations of the state of California apply to all non-racing vehicles operated in
California. Consequently, those parts marked in this catalog with a “1” and appropriately marked on their
packaging may legally be used in California only on a racing vehicle that will never be operated on public
roads.
PARTS ORDERING AND INQUIRIES
The parts in this catalog may be ordered from authorized Chrysler, Jeep® , Dodge and Ram dealerships or the
speed shops carrying the Mopar Performance line of products. When a part ordered has been superseded,
the replacing part will be shipped automatically. The price of the replacing part may differ from the ordered
part. All products, illustrations and specifications are based upon current information at the time of publication
approval. Although descriptions are believed correct, complete accuracy cannot be guaranteed. Chrysler
Group LLC reserves the right to make changes at any time, without notice or obligation, to the information
contained in this printed document, including and without limitation to prices, specifications, equipment,
colors, materials, and to change or discontinue products.
Select images in this catalog are used with permission of Mopar Nationals, Inc., Chrysler Historical Society, and the Walter P. Chrysler Museum.
TABLE OF CONTENTS
ENGINES . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Hemi®, Gen III . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
10
Crate Engines . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Blocks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine Block Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Crankshafts and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .
Vibration Dampers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Pistons and Connecting Rods . . . . . . . . . . . . . . . . . . . . . . .
Camshafts, Lifters, and Hardware . . . . . . . . . . . . . . . . . . . .
Cylinder Heads, Gaskets, and Hardware . . . . . . . . . . . . . .
Valve Covers and Hardware . . . . . . . . . . . . . . . . . . . . . . . .
Intake Manifolds, Hardware, and Gaskets . . . . . . . . . . . . . .
Carburetors and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .
Ignition and Electronics . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Oiling Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Transmission and Drivetrain . . . . . . . . . . . . . . . . . . . . . . . .
Rocker Arms, Shafts, Supports, and Hardware . . . . . . . . . .
10
10
11
12
12
12
12
13
14
14
15
15
17
17
19
Hemi®, Gen II . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
22
Crate Engines . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Blocks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine Installation Components . . . . . . . . . . . . . . . . . . . . .
Engine Block Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Crankshafts and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .
Vibration Dampers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Timing Chain and Sprockets . . . . . . . . . . . . . . . . . . . . . . . .
Pistons and Connecting Rods . . . . . . . . . . . . . . . . . . . . . . .
Camshafts, Lifters, and Hardware . . . . . . . . . . . . . . . . . . . .
Cylinder Heads, Gaskets, and Hardware . . . . . . . . . . . . . .
Valve Covers and Hardware . . . . . . . . . . . . . . . . . . . . . . . .
Valves and Valve Train Hardware . . . . . . . . . . . . . . . . . . . .
Rocker Arms, Shafts, Supports, and Hardware . . . . . . . . . .
Intake Manifolds, Hardware, and Gaskets . . . . . . . . . . . . . .
Oiling Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cooling Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
22
24
25
25
26
26
27
27
28
29
30
32
34
35
37
39
Big Block . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
42
Blocks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine Block Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Crankshafts and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .
Vibration Dampers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Timing Chain and Sprockets . . . . . . . . . . . . . . . . . . . . . . . .
Camshafts, Lifters, and Hardware . . . . . . . . . . . . . . . . . . . .
Cylinder Heads, Gaskets, and Hardware . . . . . . . . . . . . . .
Valve Covers and Hardware . . . . . . . . . . . . . . . . . . . . . . . .
Valves and Valve Train Hardware . . . . . . . . . . . . . . . . . . . .
42
42
42
43
43
44
50
51
53
P. | 4
Rocker Arms, Shafts, Supports, and Hardware . . . . . . . . . .
Intake Manifolds, Hardware, and Gaskets . . . . . . . . . . . . . .
Oiling Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cooling Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
54
56
57
60
Small Block . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
64
Crate Engines . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Blocks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine Block Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Crankshafts and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .
Vibration Dampers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Timing Chain and Sprockets . . . . . . . . . . . . . . . . . . . . . . . .
Camshafts, Lifters, and Hardware . . . . . . . . . . . . . . . . . . . .
Cylinder Heads, Gaskets, and Hardware . . . . . . . . . . . . . .
Valve Covers and Hardware . . . . . . . . . . . . . . . . . . . . . . . .
Valves and Valve Train Hardware . . . . . . . . . . . . . . . . . . . .
Rocker Arms, Shafts, Supports, and Hardware . . . . . . . . . .
Intake Manifolds, Hardware, and Gaskets . . . . . . . . . . . . . .
Oiling Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cooling Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
64
66
69
69
70
71
74
78
82
85
87
90
93
95
RESTORATION . . . . . . . . . . . . . . . . . . . . . . 100
Fuel Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
100
Carburetors and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel Pumps and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .
Vapor Separator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Six Pack Induction Systems . . . . . . . . . . . . . . . . . . . . . . . . .
Air Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel Injection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
100
101
102
102
104
106
Ignition and Electronics . . . . . . . . . . . . . . . . . . . . . . . . . .
108
Distributors and Hardware . . . . . . . . . . . . . . . . . . . . . . . . . .
Electronic Ignition Systems . . . . . . . . . . . . . . . . . . . . . . . . .
Ballast Resistors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ignition Wires and Spark Plugs . . . . . . . . . . . . . . . . . . . . . .
Coils . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Starters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Voltage Regulators . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ignition and Electronics . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Alternators . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
108
109
110
111
112
113
113
114
114
Automatic Transmission . . . . . . . . . . . . . . . . . . . . . . . . . .
116
Flex Plates and Hardware . . . . . . . . . . . . . . . . . . . . . . . . . .
Shifters and Shift Improvement Kits . . . . . . . . . . . . . . . . . . .
Automatic Transmission Components . . . . . . . . . . . . . . . . .
Transmission Overhaul Kits . . . . . . . . . . . . . . . . . . . . . . . . .
Transmission Pans and Hardware . . . . . . . . . . . . . . . . . . . .
116
116
116
118
119
TABLE OF CONTENTS
Torque Converters and Hardware . . . . . . . . . . . . . . . . . . . .
119
Manual Transmission . . . . . . . . . . . . . . . . . . . . . . . . . . . .
122
Flywheels and Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . .
Bell Housing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Clutch Discs, Pressure Plates and Hardware . . . . . . . . . . .
Shifters and Shift Improvement Kits . . . . . . . . . . . . . . . . . . .
122
123
123
125
Drivetrain and Rear Axle Components . . . . . . . . . . . . . .
128
Universal Joint and Yoke Kits . . . . . . . . . . . . . . . . . . . . . . .
Rear Axle Components . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Differential Components . . . . . . . . . . . . . . . . . . . . . . . . . . .
128
129
130
Steering, Suspension, and Brakes . . . . . . . . . . . . . . . . . .
132
Leaf Springs and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .
Frame Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Torsion Bars and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .
Suspension Seals and Bushings . . . . . . . . . . . . . . . . . . . . .
Manual Steering Hardware . . . . . . . . . . . . . . . . . . . . . . . . .
Shocks and Struts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
132
135
135
135
136
136
136
Interior/Body . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
140
Underhood . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Interior . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Grilles and Headlamp Bezels . . . . . . . . . . . . . . . . . . . . . . . .
Hoods and Hood Components . . . . . . . . . . . . . . . . . . . . . .
Handles . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Mirrors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Trunk . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Racks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Bumpers/ Bumperettes . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Lamps and Lenses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Sheetmetal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Wheelhouse . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Valence . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Emblems and Decals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Wheel Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
140
145
147
148
149
150
151
151
151
151
153
154
154
155
158
Transmission Components . . . . . . . . . . . . . . . . . . . . . . . . .
Suspension Upgrades and Components . . . . . . . . . . . . . . .
Air Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Exhaust Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
GTS-R Engine Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Exterior Body Components . . . . . . . . . . . . . . . . . . . . . . . . .
168
169
170
171
171
173
Eight-Cylinder Late Model Vehicles . . . . . . . . . . . . . . . . .
176
Electronic Control Modules . . . . . . . . . . . . . . . . . . . . . . . . .
Air Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Exhaust Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Exterior Body Components . . . . . . . . . . . . . . . . . . . . . . . . .
Interior . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Suspension Upgrades and Components . . . . . . . . . . . . . . .
Drivetrain and Rear Axle Components . . . . . . . . . . . . . . . .
176
176
177
179
180
180
181
Four- and Six-Cylinder Late Model Vehicles . . . . . . . . . .
184
Turbo Service Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Camshafts, Lifters, and Hardware . . . . . . . . . . . . . . . . . . . .
Rocker Arms, Shafts, Supports, and Hardware . . . . . . . . . .
Cylinder Heads, Gaskets, and Hardware . . . . . . . . . . . . . .
Engine Struts and Mounts . . . . . . . . . . . . . . . . . . . . . . . . . .
Pistons and Connecting Rods . . . . . . . . . . . . . . . . . . . . . . .
Intake Manifolds, Hardware, and Gaskets . . . . . . . . . . . . . .
Valve Train Hardware and Components . . . . . . . . . . . . . . .
Valve Covers and Hardware . . . . . . . . . . . . . . . . . . . . . . . .
Suspension Upgrades and Components . . . . . . . . . . . . . . .
Ignition and Electronics . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Air Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Oiling Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Exhaust Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Transaxle Components . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Wheel Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Exterior Body Components . . . . . . . . . . . . . . . . . . . . . . . . .
Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Bearing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
184
185
186
186
186
186
187
187
188
188
192
194
195
196
197
197
198
198
198
RACING . . . . . . . . . . . . . . . . . . . . . . . . . . . . 202
CHRYSLER/DODGE . . . . . . . . . . . . . . . . . . 164
Viper . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
164
Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Viper SRT10 Power Kit . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Valves and Valve Train Hardware . . . . . . . . . . . . . . . . . . . .
Ignition and Electronics . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cooling Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Differential Components . . . . . . . . . . . . . . . . . . . . . . . . . . .
164
164
165
165
166
167
Drag Racing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
202
LC22R Challenger Drag Pak Service Parts . . . . . . . . . . . . .
Blocks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Gear Drives and Service Parts . . . . . . . . . . . . . . . . . . . . . .
Crankshafts and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .
Cylinder Heads, Gaskets, and Hardware . . . . . . . . . . . . . .
Valve Covers and Hardware . . . . . . . . . . . . . . . . . . . . . . . .
Hemi Pro Stock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Race Bodies . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
202
203
207
207
207
208
208
208
P. | 5
TABLE OF CONTENTS
Sprint Car / Midget / Dirt Late Model . . . . . . . . . . . . . . . .
212
Blocks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine Block Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cylinder Heads, Gaskets, and Hardware . . . . . . . . . . . . . .
Intake Manifolds, Hardware, and Gaskets . . . . . . . . . . . . . .
Valve Covers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Camshafts, Lifters, and Hardware . . . . . . . . . . . . . . . . . . . .
Rocker Arms, Shafts, Supports, and Hardware . . . . . . . . . .
Crankshafts and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .
Gear Drives and Service Parts . . . . . . . . . . . . . . . . . . . . . .
Oiling Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Books . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
212
212
213
214
214
215
215
215
216
217
217
NASCAR® / Late Model . . . . . . . . . . . . . . . . . . . . . . . . . . .
Blocks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine Block Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Crankshafts and Hardware . . . . . . . . . . . . . . . . . . . . . . . . .
Camshafts, Lifters, and Hardware . . . . . . . . . . . . . . . . . . . .
Cylinder Heads, Gaskets, and Hardware . . . . . . . . . . . . . .
Exhaust Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Valve Covers and Hardware . . . . . . . . . . . . . . . . . . . . . . . .
Oil, Fuel, and Water Pumps . . . . . . . . . . . . . . . . . . . . . . . . .
NASCAR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Books . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
257
258
258
MISCELLANEOUS . . . . . . . . . . . . . . . . . . . 262
Performance Gauges . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
262
Gauges . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Gauge Pods . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Gauge Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
262
270
270
SilverStar Lighting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
274
220
Lamps . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
274
220
220
221
221
221
223
223
223
223
224
Merchandise . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
278
Diecast . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Posters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Books . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fender Covers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Wheel Covers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Decals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
278
280
281
282
282
283
JEEP/RAM . . . . . . . . . . . . . . . . . . . . . . . . . . 230
Jeep/Ram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
230
Blocks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine Block Hardware . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Timing Chain and Sprockets . . . . . . . . . . . . . . . . . . . . . . . .
Vibration Dampers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Camshafts, Lifters, and Hardware . . . . . . . . . . . . . . . . . . . .
Cylinder Heads, Gaskets, and Hardware . . . . . . . . . . . . . .
Rocker Arms, Shafts, Supports, and Hardware . . . . . . . . . .
Valve Covers and Hardware . . . . . . . . . . . . . . . . . . . . . . . .
Valves and Valve Train Hardware . . . . . . . . . . . . . . . . . . . .
Intake Manifolds, Hardware, and Gaskets . . . . . . . . . . . . . .
Air Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Exhaust Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Oiling Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Suspension Upgrades and Components . . . . . . . . . . . . . . .
Ignition and Electronics . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Automatic Transmission Components . . . . . . . . . . . . . . . . .
Transmission/Transfer Cases . . . . . . . . . . . . . . . . . . . . . . .
Drivetrain and Rear Axle Components . . . . . . . . . . . . . . . .
Axle Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
230
230
230
230
231
231
232
232
232
233
234
238
241
242
252
253
254
255
256
P. | 6
Exterior Body Components . . . . . . . . . . . . . . . . . . . . . . . . .
Hoods and Hood Components . . . . . . . . . . . . . . . . . . . . . .
Off Road Tools and Accessories . . . . . . . . . . . . . . . . . . . . .
IGNITION AND ELECTRONICS
DISTRIBUTORS AND HARDWARE
A. Vacuum Advanced Electronic Distributors
Features a high-performance advance curve and an adjustable vacuum advance
unit. Includes cap and rotor.
1
Distributor, Vacuum Advance, Electronic, 383/400 Big Block
P3690431
1
P3690432
1
P3690430
Distributor, Vacuum Advance, Electronic, 426 Hemi/ 426
Wedge/ 413/ 440 Big Block
Distributor, Vacuum Advance, Electronic, Small Block
B. Distributor, Electronic, Billet Aluminum
One-piece Billet Aluminum Electronic Distributors designed for street, bracket
and oval track applications.
1
Distributor, Billet Aluminum, Electronic, 426 Hemi / "RB"
P5249775
Engines
1
Distributor, Billet Aluminum, Electronic, Small Block
P5249776
C. Hold-Down Clamps, Distributor, Chrome
Under the hood every detail matters, and chrome is the perfect enhancement.
Add to your underhood atmosphere with heavy-duty Chrome Distributor Holddown Clamps and chrome-plated bolts. Sold individually.
Hold-Down Clamp, Distributor, Chrome, 426 Hemi/ Big Block
P4349279
P4349278
A.
B.
C.
D.
E.
F.
P5249776
Hold-Down Clamp, Distributor, Chrome, Small Block
D. Distributor Advance Weight Springs
Use these Distributor Advance Weight Springs to convert stock distributor and
Mopar Performance electronic distributors built prior to 2001 to quick advance
curve. Package contains two springs.
1
Weight Springs, Distributor Advance
P2932675
E. Timing Curve Adjustment Kit
Kit contains six different primary springs, three different secondary springs and
two degree key sets, allowing you to adjust timing to your performance needs.
For use in parts: P3690426, P3690427, P3690428, P3690430, P3690431,
P3690432, P5249775, P5249776, P5249777, P5249778, P5249779, P5249780.
With detailed instructions.
1
Timing Curve Adjustment Kit
P5153446
Note: Timing curve adjustment kit . Fits most Mopar Performance distributors
shipped after September 2004.
F. Distributor Cap and Rotor Sets
P4876255AB Distributor Cap and Rotor, 1992-97 Dodge Truck
P5007856
P. | 108
Magnum/Jeep Engines, 5.2L/5.9L
Distributor Cap and Rotor, for Distributors P3690430–2, 426
Hemi/ Big Block/ Small Block and O.E.M Single Point and
Electronic Distributors
Visit us on the Web! www.mopar.com
¹ Not legal on pollution-controlled vehicles or vehicles registered for highway use.
IGNITION AND ELECTRONICS
DISTRIBUTORS AND HARDWARE
A. Distributor Cap, O.E. Replacement
Replacement for the original tan-colored distributor cap used in Chrysler highperformance V8 muscle cars of the late 1960s and early 1970s (sold individually).
Distributor Cap, Original Replacement, For Single Point
P4529791
Distributors, Big Block/Small Block
B. Intermediate Shaft Bushing
P1737725
Intermediate Shaft Bushing, V6 and V8
C. Pickup Coil and Lead Assembly
Services electronic and mechanical tach drive distributors.
Reluctor and Coil Pick Up, Used with Billet Aluminum
P5153576
Distributors
ELECTRONIC IGNITION SYSTEMS
D. Electronic Ignition Conversion Kits
A.
B.
Now available to convert old point-type ignitions to electronic ignitions. Modern
magnetic impulse ignition systems have many advantages over breaker-type
ignition systems. They require fewer tune-ups, increase secondary voltage,
improve starting, eliminate irregular timing and dwell change with engine speed,
and increase plug life. Packages include vacuum advance electronic distributor
with high-performance advance curve, wiring harness, electronic control unit,
ballast resistor and installation instructions.
1
Electronic Conversion Kit, 383/400 Big Block
P3690427
1
P3690428
1
P3690426
Electronic Conversion Kit, 426 Hemi, 426 Wedge, 413/440
Big Block
Electronic Conversion Kit, Small Block
E. Capacitive Discharge Ignition Controllers
Features a capacitive discharge technology that fires a series of multiple sparks
for 20 degrees of crankshaft rotation when the engine is running under 3,000
rpm. This ensures complete combustion and produces great throttle response
with a smooth idle. There's also an adjustable rev limiter (100 rpm increments)
for overrev protection!
1
Ignition Controller, Capacitive Discharge, V6/V8
P5155516
F. Drag Race Ignition Controller
C.
D.
E.
F.
Questions? Call the Mopar Direct Connection Techline at 1-888-528-HEMI (4364)
¹ Not legal on pollution-controlled vehicles or vehicles registered for highway use.
Features 14,000 rpm capability with built-in rev control (supplied with 7,000,
8,000, 9,000 rpm limits) and 115 millijoule spark energy. Produces 480-volt
output on primary windings and is compatible with two- and three-step module
selectors, timing controls and crank triggers. Can be used with Mopar
Performance coils, P4876732, P4876733 or P4876734.
1
Ignition Controller, MSD 7AL-2, Professional Drag Race, V8
P4876731
P. | 109
R
E
S
T
O
R
A
T
I
O
N
IGNITION AND ELECTRONICS
ELECTRONIC IGNITION SYSTEMS
A. Orange Electronic Control Unit
For general high-performance use up through 6,000 rpm.
1
ECU, Orange Box, Hemi/ Big Block/ Small Block
P4120505
B. Electronic Control Unit, Chrome
For a hotter spark, use this general high-performance control unit (up through
8,000 rpm).
1
ECU, Chrome, Hemi/ Big Block/ Small Block
P4120534
C. Electronic Ignition Update Set
Contains lightweight advance springs to recurve the electronic ignition distributor
for quicker spark advance and high-performance control unit. Kit includes
P4120505 and P2932675 (Orange Electronic Control Unit and Spring Package).
1
Electronic Ignition Update Set, Hemi/ Big Block/ Small Block
P4007968
A.
B.
C.
D.
E.
F.
D. Control Unit Wiring Harness Kit
Use this harness to service a missing or worn ECU-to--distributor harness.
Wiring Harness, Control Unit, For Electronic Ignitions, Hemi/
P3690152
Big Block/ Small Block
E. Ignition Switch
If your ignition switch needs replacing, don't install an old, used piece. Replace it
with a brand-new unit from Mopar. This ignition switch is an exact reproduction
and it perfectly replaces your old unit with no modifications necessary.
Ignition Switch, 1970-74 B/C/E-Body, 1970-76 A-Body
03747092
BALLAST RESISTORS
F. Ballast Resistor, Dual
The sharpest eyes will spot the correct ballast resistor on a restoration project.
This Mopar Ballast Resistor is a reissued factory original as used on 1972 and
later OEM electronic ignitions with four-pin dual ballast resistors.
1
Ballast Resistor, Dual, Restoration
P4529795
G. Ballast Resistors - Electronic Distributor
1
P5206436
1
P2444641
Ballast Resistor, For Electronic Ignition Systems, Using
P4120505 Orange Box and Production Coil, or With
P4120889 Coil, 1 OHM
Ballast Resistor, for Mechanical Advance Distributor, Using
P3690560 and P4876832/33 Coils, 1/4 OHM, Race Only
G.
P. | 110
Visit us on the Web! www.mopar.com
¹ Not legal on pollution-controlled vehicles or vehicles registered for highway use.
IGNITION AND ELECTRONICS
IGNITION WIRES AND SPARK PLUGS
A. Ignition Wire Set - 8 mm
Mopar's custom Ignition Wire Set is specifically made for high-performance use.
It features a suppression core for general high-performance applications. Wires
are blue with the Mopar name imprinted along the wire. Use P4529032, plus
eight insulators and boots (P4120808) on Hemi engines.
Wire Set, Spark Plug, 8 mm, Suppression Core, Hemi/ Big
P4529032
Block/ Small Block
B. Ignition Wire Sets - 8 mm, Pre-Cut
These pre-made Ignition Wire Sets are designed with factory-attached cap and
plug ends. They are constructed with either a radio suppression core for highperformance street use or a metallic core for racing applications. Wrapped in 8
mm heat-resistant insulation to maintain maximum voltage.
Wire Set, Spark Plug, 8 mm, Metallic Core, Big Block
P5007408
P5007407
P5007405
A.
B.
Wire Set, Spark Plug, 8 mm, Radio Suppression Core, Big
Block
Wire Set, Spark Plug, 8 mm, Radio Suppression Core, Small
Block
C. Ignition Wire Sets - 7.5 mm, Pre-Cut
Pre-cut, high-performance 7.5 mm Ignition Wire Sets specifically designed to
maintain compatibility with the onboard computers and electronics found on
production vehicles. Each package contains high-tech-style boot ends at both
the distributor and plug ends of the wire. These blue wires are Imprinted with the
Mopar name and the cylinder number.
Wire Set, Spark Plug, 7.5 mm, 1991–02 4.0L Jeep Engines
P4876436
P4876432
P4876434
P4876437
P4876775
P4876433
Wire Set, Spark Plug, 7.5 mm, 1992-03 5.2L/5.9L Truck
Magnum/Jeep Engines, 2 5/8" Long boot
Wire Set, Spark Plug, 7.5 mm, 1994–02 8.0L Ram
Wire Set, Spark Plug, 7.5 mm, 1996–00 2.5L Dakota and
Wrangler
Wire Set, Spark Plug, 7.5 mm, 426 Hemi
Wire Set, Spark Plug, 7.5 mm, 5.2L/5.9L Truck
Magnum/Jeep Engines (1992-03) 1 7/8" Short boot
D. Ignition Wire Set, Restoration
Just like O.E., carbon suppression wires are manufactured in the right color with
the right lettering and each includes the correct spark plug boot. Set contains
eight ignition secondary wires and one coil wire.
Wire Set, Spark Plug, Orange, 1971 & Prior 383/440 Big
P4529792
Block, Restoration.
Wire Set, Spark Plug, Orange, 340 Small Block, Restoration
P4529797
C.
D.
E. Ignition Wire Separator Set
Includes eight pieces. Fits 7.5 mm wire.
Wire Separator, Spark Plug, Set of eight (8).
P4007667
E.
Questions? Call the Mopar Direct Connection Techline at 1-888-528-HEMI (4364)
¹ Not legal on pollution-controlled vehicles or vehicles registered for highway use.
P. | 111
R
E
S
T
O
R
A
T
I
O
N
IGNITION AND ELECTRONICS
IGNITION WIRES AND SPARK PLUGS
A. Insulator and Boot Kit, Hemi
Kit to service one cylinder (eight required per engine). Use with 8 mm ignition
wire set P4529032.
Insulator and Boot Kit, Hemi
P4120808
B. Plug Tube and Seal Set
Includes eight special spark plug tubes and tube seals, as used on 426 Hemi
engines.
Plug Tube and Seal Set 426/ 472/ 528 Hemi
P4120294
C. Spark Plug Wire Removal Tool
Here's the tool you need for easy removal of spark plug wires without pulling the
wire out of the terminal end and boot.
Spark Plug Wire Removal Tool
P5249718
A.
B.
C.
D.
E.
F.
D. Universal Fit Spark Plug Wire Loom
Works with 7 mm or 8 mm wire. Includes four 1/4" mounting studs (20 tpi). Not
for use with cast aluminum valve covers.
Loom, Spark Plug Wire, Universal Fit
P5007481
E. Spark Plugs
Bosch Motorsports Spark Plugs are specifically designed for optimal
performance of your Mopar engine. Sold in sets of four.
Spark Plug, FR 8 DCX, Hemi/ Small Block
P4876926
P4876927
Spark Plug, WR 9 FC, Big Block
COILS
F. Ignition Coil, Restoration
For you purists out there, Mopar offers this Restoration Ignition Coil. An exact
reproduction of the original factory black unit, right down to the vintage Mopar
logo. If your coil is over ten years old, replace it with this brand-new piece.
Coil, Ignition, Black with Vintage Mopar Logo, 1972-78 Small02495531
Block/Big-Block/Hemi, Restoration
G. Blaster Coils
These high-performance cylindrical Blaster Coils are oil-filled. They feature 100:1
turns ratio, threaded-stud primary connection and conventional "socket-style"
tower. Designed for high-performance street and race applications. Use 1/4-ohm
ballast resistor P2444641 when used with ignition kits P3690426, P3690427,
P3690428.
1
Coil, Blaster, Black, for Controllers P4876728–29, V8
P5155514
1
P5155515
Coil, Blaster, Chrome, for Controllers P4876728–29 and
P4876731 (V8)
G.
P. | 112
Visit us on the Web! www.mopar.com
¹ Not legal on pollution-controlled vehicles or vehicles registered for highway use.
IGNITION AND ELECTRONICS
COILS
A. Ignition Coil, High Performance
For all 12-volt applications. Not recommended for engine speeds over 6,500 rpm.
Use 1-ohm ballast resistor P5206436.
1
Coil, Ignition, Super, Hemi/ Big Block/ Small Block
P4120889
B. Pro Power Coil
Features a unique design shape that is potted with urethane and special
windings for fast rise time characteristics required for high rpm. Designed for
short drag race applications only. Use with Drag Race Ignition Controller
(P4876731).
1
Coil, Blaster, Pro Power, Race V8
P4876734
C. Ignition Coil, Race
Specifically designed to be used with race-only electronic ignition kits. Not
recommended for continued operation at speeds below 3,000 rpm for more than
30-minute periods. Use 1/4-ohm ballast resistor P2444641.
1
Coil, Ignition, Race, V8
P3690560
A.
B.
D. Coil Bracket
Another underhood piece to dress up your engine compartment. Includes a
special clamp screw.
Coil Bracket, Chrome, V8 and 6-cyl
P4286728
STARTERS
E. Lightweight Starters
These specially-designed starter motors with heavy-duty features for V8
applications need no adapters. Weighing approximately 7 lbs. complete, these
units are lighter than the previous Mopar Performance lightweight starter, half the
weight of the original 1960s-70s vintage production starter, and one inch shorter.
May require header/exhaust/block modifications on some applications.
1
P5007860AB Starter, Lightweight, 426 Hemi/ Big Block
1
P5249644AC Starter, Lightweight, Small Block
VOLTAGE REGULATORS
F. Voltage Regulator, Constant Output
C.
D.
E.
F.
Questions? Call the Mopar Direct Connection Techline at 1-888-528-HEMI (4364)
¹ Not legal on pollution-controlled vehicles or vehicles registered for highway use.
To ensure your ignition and electrical systems can provide maximum
performance, install a Mopar Constant Output Voltage Regulator. Voltage is held
at a constant 13.5 volts. For race applications only.
1
Voltage Regulator, Constant Output, 1970 and Newer V8,
P3690731
Race
1
Voltage Regulator, Constant Output, to 1969, Race
P3690732
P. | 113
R
E
S
T
O
R
A
T
I
O
N
IGNITION AND ELECTRONICS
VOLTAGE REGULATORS
A. Voltage Regulators
For restoration or repair, Mopar offers this factory reissue of the Voltage
Regulator as used on muscle cars of the early 1970s. The regulator is black with
the original Mopar part number imprinted in yellow. Contains modern electronics.
1
Voltage Regulator, 1970, Restoration
77R06285
1
1
77R06286
P4529794
Voltage Regulator, 1971, Restoration
Voltage Regulator, Muscle Car, O. E.
B. Tach Adapter
Designed for applications when high-capacitive discharge coils interfere with
tachometer or fuel injection signals. Provides a clear 12-volt square wave signal
output with a 30% duty cycle.
Tachometer Adapter, V8
P4876738
A.
P4529794
C. Tach Adapter
Designed for applications when high-capacitive discharge coils interfere with
tachometer or fuel injection signals. Provides a clear 12-volt square wave signal
output with a 30% duty cycle.
Tachometer Adapter, V8
P4876738
IGNITION AND ELECTRONICS
D. Engine Wiring Harness- 360 Magnum
1
P5153687
Wiring Harness, Service part for 360 Fuel Injection Kits
ALTERNATORS
E. Alternator Brackets
P2206445
B/C.
Alternator Bracket, 426 Hemi/ Big Block
D.
E.
P. | 114
P2206445
Visit us on the Web! www.mopar.com
¹ Not legal on pollution-controlled vehicles or vehicles registered for highway use.
PERFORMANCE CATALOG
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertising