AII29191 civic am-fm cd tuner.pmd

HandA-Accessories.com
INSTALLATION
INSTRUCTIONS
PARTS LIST
Pocket Attachment Kit
P/N 08B60-SCV-100
Accessory
Application
AM/FM CD TUNER
CIVIC
2 and 4 DOOR (DX)
Publications No.
All 29191
Issue Date
SEP 2005
AM/FM CD Tuner
P/N 08A02-4E1-100
AM/FM CD tuner
Pocket
2 Self-tapping screws,
4 x 12 mm
Antenna Sub Harness Kit
P/N 08B01-SNA-100
Owner’s Manual
4 Washer-screws,
5 x 8 mm
Antenna sub harness
TOOLS REQUIRED
Phillips screwdriver
Flat-tip screwdriver
10 mm combination wrench
2 Wire ties
Shop towel
Scissors
INSTALLATION
Cushion tape
Customer Information: The information in this
installation instruction is intended for use only by
skilled technicians who have the proper tools,
equipment, and training to correctly and safely add
equipment to your vehicle. These procedures
should not be attempted by “do-it-yourselfers”.
1.
© 2005 American Honda Motor Co., Inc - All Rights Reserved.
AII 29191 (0509)
Disconnect the negative cable from the battery.
08B01-SNA-1000-91
1 of 6
2.
Remove the driver’s dashboard lower cover (eight
clips).
4.
Lower the steering wheel lever and pull the
steering toward you.
COMBINATION
SWITCH
SHOP TOWEL
SHIFT LEVER
STEERING
WHEEL
DRIVER’S
DASHBOARD
LOWER COVER
SHOP
TOWEL
CLIPS (8)
5202121T
3.
Remove the inside cover from the front console
pocket (two tabs).
TILT LEVER
5608031H
FRONT
CONSOLE
POCKET
TABS (2)
5.
To protect the dashboard area, place a shop
towel over the steering wheel and shift lever.
INSIDE
COVER
5202130T
2 of 6
AII 29191 (0509)
© 2005 American Honda Motor Co., Inc - All Rights Reserved.
6.
8.
Remove the instrument panel with the center
panel (one screw, two bolts, nineteen retaining
clips and unplug the vehicle connectors).
Remove the audio cover from the center panel.
AUDIO COVER
CLIPS (19)
INSTRUMENT
PANEL
CENTER PANEL
CENTER PANEL
5421020H
9.
VEHICLE
CONNECTOR
BOLT
Remove the three screws and remove the air
duct from the center panel.
SCREW
5607011H
7.
10. Loosen the four bolts on the right and left audio
brackets.
Remove the center panel from the instrument
panel by releasing the four clips.
SCREW (3)
INSTRUMENT
PANEL
AIR DUCT
BOLT
(Loosen.)
CLIPS (4)
CENTER PANEL
5607020H
CENTER PANEL
© 2005 American Honda Motor Co., Inc - All Rights Reserved.
AII 29191 (0509)
5607030H
3 of 6
Installing the Pocket
14. Unlock the terminal lock on the vehicle 20-pin
connector.
11. Using scissors, cut the cushion tape in half.
TERMINAL LOCK
(Be careful not to break
the terminal lock)
VEHICLE
ANTENNA
CONNECTOR
APPROPRIATE
SLOT
<Harness Side Viewed >
CUSHION TAPE
(Cut in half.)
ANTENNA
SUB
HARNESS
TERMINAL
(YELLOW/GREEN)
(Bend up the tab.)
5405040H
12 Plug the antenna connector into the vehicle
connector, then wrap the piece of cushion tape
around the antenna connectors.
VEHICLE’S 20-PIN
CONNECTOR
13. Secure the antenna sub harness to the vehicle
harness on the steering hanger beam with a wire
tie.
ABOUT
30 mm
5405061H
15. Carefully push the wire terminal (yellow/green) of
the antenna sub harness into the appropriate slot
of the vehicle 20-pin connector. Reattach the
terminal lock.
VEHICLE
ANTENNA
WIRE TIE
VEHICLE
HARNESS
WIRE
TERMINAL
(YELLOW/
GREEN)
ANTENNA
JACK
4 of 6
STEERING
HANGER
BEAM
5405051H
AII 29191 (0509)
© 2005 American Honda Motor Co., Inc - All Rights Reserved.
•
When you install the IN DASH/CASSETTE/
MULTI MEDIA player, go to “Installing the
Player” in the installation instructions
“08B06-SNA-1000-91.”
20. Plug the vehicle 20-pin connector and antenna
jack into the rear of the AM/FM CD tuner.
AM/FM
CD TUNER
16. Position the pocket into the center panel and
install the two 4 x 12 mm self-tapping screws.
POCKET
POCKET
ANTENNA
JACK
Use the
upper hole.
VEHICLE 20-PIN
CONNECTOR
5405070H
21. Connect the vehicle connectors to the center
panel, and reinstall the center panel.
SELF-TAPPING
SCREWS (2)
VEHICLE
CONNECTOR (4)
Insert the tab from the
pocket in these holes.
5405031H
17. Fasten the two bolts on the left audio bracket you
loosened in step 10.
18. Position the AM/FM CD tuner on the pocket and
install the four 5 x 8 mm washer bolts.
AM/FM
CD TUNER
5405080H
CENTER PANEL
BOLT
(Reused)
POCKET
5607040H
WASHER BOLTS (4)
19. Fasten the two bolts on the right audio bracket
you loosened in step 10, and reinstall the air
duct.
© 2005 American Honda Motor Co., Inc - All Rights Reserved.
AII 29191 (0509)
5 of 6
22. Check that all wire harnesses are routed properly
and all connectors are plugged in.
23. Reconnect the negative cable to the battery.
24. Reset the clock.
25. Check the operation of the AM/FM CD tuner as
described in the Owner’s Manual supplied.
26. Reinstall all removed parts.
27. Put the AM/FM CD tuner Owner’s Manual in the
glove box for your customer.
28. Do the ECU idle learn procedure:
•
Make sure all electrical items are turned off.
•
Start the engine. Hold the engine speed at
3,000 rpm with no load (in Park or neutral)
until the radiator fan comes on.
•
Let the engine idle for about 5 minutes with
the throttle fully closed and with all electrical
items off.
NOTE: If the radiator fan comes on during this
step, the time when it is operating must not be
included in the 5 minutes.
NOTE: When the battery is disconnected, the driver’s
window AUTO function is disabled.
•
Start the engine. Push down on the driver’s
window switch until the window is fully open.
•
Pull up on the driver’s window switch to close the
window completely, then hold the switch for 2
seconds or more.
•
Lower and raise the driver’s window to check
operation of the driver’s window AUTO function.
6 of 6
AII 29191 (0509)
© 2005 American Honda Motor Co., Inc - All Rights Reserved.
Download PDF