PSP Series DC to DC Converters
Prices as of April 27, 2016. Check Web site for most current prices.
RHINO PSP Series DC to DC Converters
Both 25W and 60W DC-DC converters
are available in the Rhino PSP DIN rail
series. Wide input ranges of 9.5 to
18VDC and 18 to 75VDC allow these
models to operate from all popular
DC supply voltage systems. With tightly
regulated output voltage these DC-DC
converters provide a reliable power
source for sensitive loads in industrial
process controls, factory automation and
other equipment exposed to a critical
industrial environment. They can be used
to isolate a specific load from the 24
volt bus voltage, and offer easy installation with snap-on DIN rail mounting and
detachable screw terminal blocks.
Features
PSP 25 Watt DC-DC Converters
• Ultra-wide input voltage range
• Output voltage adjustable
• Overload and short circuit protection
• Low ripple and noise
• I/O-isolation 1500 VDC
• Compact, slim plastic case
• Reliable snap-on 35mm DIN rail mount
• Wall-mount bracket included
• 3-year warranty
PSP 60 Watt DC-DC Converters
PSP Series DC-DC Converters
Part Number
PSP24-DC12-1
Input Voltage Input Current Max. @ Output Voltage
Range
Vin, (Iout = 0% / 100%) (Adjustable)
9.5 - 18.0 VDC
80mA / 2.5 A @ 12VDC
PSP05-DC24-5
80mA / 1.3 A @ 24VDC
60mA / 0.7 A @ 48VDC
PSP12-DC24-2
PSP24-DC24-1
18.0 - 75.0 VDC
Output Current
Max
24VDC
1A
5VDC
5A
Output Power
Price
Weight (lbs)
$78.00
0.31
$79.00
0.31
25W
12VDC
2A
$79.00
0.31
24VDC
1A
$75.00
0.31
$92.00
0.59
$95.00
0.59
PSP12-DC24-5
31mA / 2.9 A @ 24VDC
19mA / 1.4 A @ 48VDC
12VDC
5A
PSP24-DC24-2
45mA / 3.1 A @ 24VDC
25mA / 1.54 A @ 48VDC
24VDC
2.5 A
60W
Book 3 (14.3)
www.automationdirect.com/dc-power-supplies
Power Supplies
ePW-61
Prices as of April 27, 2016. Check Web site for most current prices.
RHINO PSP Series DC to DC Converters
General Specifications
Startup Voltage / Undervoltage Shut-down
17.2 VDC / 15.7 VDC (PSP24-DC12-1: 8.4 VDC / 7.6 VDC)
Efficiency (Typical)
86%
Output Voltage Adjustable Range
5VDC model: 5.0 - 5.25 VDC
12VDC models: 12.0 - 15.0 VDC
24VDC models: 24.0 - 28.0 VDC
Overvoltage Protection, Trigger Point
5VDC model: <6.5 V
12VDC models: <24V
24VDC models: <42V
Output Voltage Regulation*
0.5% max
Ripple/Noise (20MHz bandwidth)
<50mV (pk-pk)
Temperature: O
perating
Storage (non-operating)
Derating
-25°C to 70°C max (-13°F to 158°F max)
-25°C to 85°C max, (-13°F to 185°F max)
1.5%/K above 50°C (122°F) for 25W models, 2%/K above 40°C (104°F) for 60W models
Humidity (Non-condensing)
95 % relative humidity max.
Temperature Coefficient
0.02%/K
Switching Frequency
55 – 180kHz depending on load (frequency modulation)
Isolation Voltage (1 min.) – Input/Output
1500VDC
Safety Standards
IEC 60950-1, EN 60950-1 (output SELV), UL 60950-1, EN 60204, CSA 22.2 60950-1-07, EN50178, UL 508
Electromagnetic Compatibility (EMC)
Emissions: EN 61000-6-3; Immunity: EN 61000-6-2
Parallel Operation
No parallel operation
Safety Class
Degree of protection class 1
Environmental Air
No corrosive gases permitted
Enclosure Rating
IP 20 (IEC 60529)
Enclosure Material
Plastic FR2010-110C (UL 94V-0 rated)
Mounting
DIN rails per EN 50022-35x15/7.5 (snap-on with self-locking spring); bracket for wall/chassis mount included
Mounting Orientation
Vertical only
Wiring
12-24 AWG (3.16-0.21 mm²)
Connections
Screw type plug-in connector (standard), Recommended tightening torque 0.5-0.7 Nm (4.5-6.2 in-lb)
Short Circuit Protection
Current limited at 110% typical
MTBF (IEC 61709 @ 25°C)
>2.5 million hours
Agency Approvals**
UL/cUL 508 listed, File E197592; CSA File 229285; CE; Reach; RoHS
* Input variation Vin min to Vin max and load variation 0 to 100%
** To obtain the most current agency approval information, see the Agency Approval Checklist section on the specific part number’s web page at
www.automationdirect.com
Note: All specifications valid at nominal input voltage, full load and +25°C after warm-up time unless otherwise stated.
The unit can be mounted
on a chassis or wall using
the included mounting
bracket.
Book 3 (14.3)
ePW-62
Power Supplies
1-800-633-0405
Prices as of April 27, 2016. Check Web site for most current prices.
RHINO PSP Series DC to DC Converters
Dimensions
mm [inches]
Part Numbers:
PSP24-DC12-1
PSP05-DC24-5
PSP12-DC24-2
PSP24-DC24-1
Input
Output
1
Ground
1
+Vout
2
-Vin
2
-Vout
3
+Vin
1
Ground
1
+Vout
2
-Vin
2
-Vout
3
+Vin
NC No Connect
Part Numbers:
PSP12-DC24-5
PSP24-DC24-2
Input
Output
See our website www.AutomationDirect.com for complete Engineering drawings
Book 3 (14.3)
www.automationdirect.com/dc-power-supplies
Power Supplies
ePW-63
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertising