Civic 2-4dr In Dash Cassette Multimedia Player Attachment Kit.pmd

Civic 2-4dr In Dash Cassette Multimedia Player Attachment Kit.pmd
www.collegehillshonda.com
INSTALLATION
INSTRUCTIONS
Accessory
Application
IN-DASH CD CHANGER
CASSETTE/MULTIMEDIA
PLAYER ATTACHMENT KIT
2009 CIVIC
2- AND 4-DOOR (DX)
Publications No.
AII 40113
Issue Date
AUG 2008
NOTE: The vehicle must be equipped with an AM/FM/
CD tuner and pocket before installing a player.
Multimedia Player (Sold Separately)
P/N 08A06-4E1-200
PARTS LIST
Multimedia player
Player Attachment Kit (Sold Separately)
P/N 08B06-SCV-101
Bus cable
4 Washer-screws, 5 x 8 mm
Small harness clip
Accessory user’s
information manual
Large harness clip
In-Dash CD Changer (Sold Separately)
P/N 08A06-3E1-300
In-Dash CD changer
EPT sealer
2 Washer-screws,
4 x 8 mm
Cassette Player (Sold Separately)
P/N 08A03-5E1-000
6 Washer-screws, 5 x 8 mm
(2 not used)
Washer-screw, 4 x 6 mm
Cassette player
Wire tie
(not used)
4 Washer-screws, 5 x 8 mm
Accessory user’s
information manual
© 2008 American Honda Motor Co., Inc. - All Rights Reserved.
Harness clip
(not used)
Accessory user’s
information manual
AII 40113 (0808)
08B06-SNA-1000-91
1 of 6
www.collegehillshonda.com
4.
TOOLS AND SUPPLIES REQUIRED
Phillips screwdriver
Remove the inside cover from the front console
pocket (two tabs).
Flat-tip screwdriver
8 mm, 10 mm, and 14 mm Combination wrenches
Isopropyl alcohol
Shop towel
SHIFT LEVER
S or 2 POSITION
FRONT
CONSOLE
POCKET
Ratchet
8 mm, 10 mm, and 14 mm Sockets
Shop towel
Scissors
Masking tape
INSTALLATION
Customer Information: The information in this
installation instruction is intended for use only by
skilled technicians who have the proper tools,
equipment, and training to correctly and safely add
equipment to your vehicle. These procedures should
not be attempted by “do-it-yourselfers.”
2 TABS
INSIDE
COVER
5202130T
1.
Make sure you have the anti-theft code for the
audio unit, then write down the frequencies for the
preset buttons.
2.
Disconnect the negative cable from the battery.
3.
Remove the driver's dashboard lower cover (eight
clips).
5.
Lower the tilt lever, and pull the steering wheel
toward you.
COMBINATION
SWITCH
SHOP TOWEL
SHIFT
LEVER
STEERING
WHEEL
SHOP
TOWEL
DASHBOARD
LOWER COVER
TILT LEVER
8 CLIPS
5202121T
5608031H
6.
2 of 6
AII 40113 (0808)
To protect the dashboard area, place a shop towel
over the steering wheel and shift lever.
© 2008 American Honda Motor Co., Inc. - All Rights Reserved.
www.collegehillshonda.com
7.
Apply masking tape to the meter panel as shown,
and remove the instrument panel (one self-tapping
screw, 11 clips, and one connector).
9.
Remove the three screws and the air duct from
the center panel.
3 SCREWS
METER PANEL
AIR DUCT
MASKING TAPE
BOLTS
(Loosen.)
SELF-TAPPING
SCREW
11 CLIPS
8.
CENTER PANEL
10. Loosen the four bolts on the right and left audio
brackets.
Apply masking tape to the instrument panel as
shown, and remove the center panel (two bolts,
ten retaining clips, and unplug the vehicle
connectors).
4 CLIPS
5610041H
5624100B
11. Remove the four washer screws that fasten the
AM/FM/CD tuner to the brackets, and pull the
tuner out toward you.
MASKING TAPE
ASPIRATOR
HOSE
AM/FM/CD TUNER
(Pull out.)
VEHICLE
CONNECTORS
POCKET
(Pull out.)
2 SELF-TAPPING
SCREWS
CENTER PANEL
4 WASHER-SCREWS
5405111H
BOLT
6 CLIPS
© 2008 American Honda Motor Co., Inc. - All Rights Reserved.
5608013H
12. Remove the two self-tapping screws that fasten
the pocket to the brackets, and pull the pocket out
toward you. Save the pocket and the screws for
your customer.
AII 40113 (0808)
3 of 6
www.collegehillshonda.com
Installing the Player
17. Plug the bus cable connectors into the rear of the
AM/FM/CD tuner and player, then secure the bus
cable with the harness clip as shown.
13. Cut the marked area from the edge of the radio
opening. Make sure the edge is smooth and flat,
and remove all burrs.
RADIO
OPENING
Cassette Player
•
Plug the bus cable connectors into the rear of
the AM/FM/CD tuner and cassette player.
•
Secure the small harness clip to the back of
the cassette player with a 4 x 8 mm washerscrew.
(Cut with a
utility knife.)
AM/FM/CD
TUNER
MASKING
TAPE
BUS
CABLE
CENTER PANEL
SMALL
HARNESS
CLIP
CASSETTE
PLAYER
5608022H
14. Position the player in the center panel, and install
four 5 x 8 mm washer-screws.
4 x 8 mm
WASHER-SCREW
2626041K
AM/FM CD TUNER
4 WASHER-SCREWS
(Removed in step 11)
•
Secure the bus cable with the small harness
clip.
AM/FM CD
TUNER
PLAYER
Install in
the lower
hole.
4 5 x 8 mm
WASHER-SCREWS
(Included with the
player)
BUS
CABLE
CASSETTE
PLAYER
SMALL
HARNESS
CLIP
5405092H
15. Position the AM/FM/CD tuner on the player, and
and install the four washer-screws you removed in
step 12.
2626050K
16. Tighten the four bolts on the audio brackets you
loosened in step 10, and reinstall the air duct with
the original screws.
4 of 6
AII 40113 (0808)
© 2008 American Honda Motor Co., Inc. - All Rights Reserved.
www.collegehillshonda.com
Multimedia Player
In-dash CD Changer
•
Plug the bus cable connectors into the rear of
the AM/FM/CD tuner and multimedia player.
•
•
Secure the small harness clip to the back of
the multimedia player with a 4 x 8 mm washerscrew.
Plug one bus cable connector into the rear of
the AM/FM/CD tuner and the other into the
connector from the in-dash CD changer.
•
Secure the large harness clip to the rear of the
in-dash CD changer with the 4 x 6 mm washerscrew included with the in-dash CD changer.
AM/FM CD
TUNER
AM/FM/CD
TUNER
BUS
CABLE
BUS
CABLE
MULTIMEDIA
PLAYER
SMALL
HARNESS CLIP
LARGE
HARNESS
CLIP
4 x 8 mm
WASHER-SCREW
2626061K
•
IN-DASH CD
CHANGER
Secure the bus cable with the small harness
clip.
2626081K
•
AM/FM CD
TUNER
Secure the bus cable connectors to the indash CD changer with the large harness clip.
Get the EPT sealer from the attachment kit.
Wrap the EPT sealer around the screw head in
the area shown.
IN-DASH CD
CHANGER
BUS
CABLE
MULTIMEDIA
PLAYER
4 x 6 mm
WASHER-SCREW
(Included with the
In-Dash CD
Changer.)
AM/FM/CD
TUNER
BUS
CABLE
SMALL
HARNESS
CLIP
LARGE
HARNESS
CLIP
2626070K
EPT SEALER
(Wrap the EPT
sealer around
the screw
head.)
2626091K
© 2008 American Honda Motor Co., Inc. - All Rights Reserved.
AII 40113 (0808)
5 of 6
www.collegehillshonda.com
18. Plug the vehicle 20-pin connector (blue) and
antenna subfeeder into the rear of the AM/FM/CD
tuner.
AM/FM
CD TUNER
20. Check that all wire harnesses are routed properly
and all connectors are plugged in.
21. Reinstall all removed parts. Be sure that all
retaining clips and tabs are securely fastened.
22. Reconnect the negative cable to the battery.
23. Enter the customer's audio unit anti-theft code,
and reset the radio station presets.
24. Reset the clock.
25. Check the operation of the player as described in
the user’s information manual.
PLAYER
ANTENNA
SUB FEEDER
26. Put the accessory user’s information manual in
the glove box for your customer.
VEHICLE 20-PIN
CONNECTOR
(blue)
27. Initialize and test the front window up/down
function.
5405100H
19. Connect the vehicle connectors to the center
panel, and reinstall the center panel.
CENTER PANEL
BOLT
(Reused.)
6 of 6
5405080H
AII 40113 (0808)
© 2008 American Honda Motor Co., Inc. - All Rights Reserved.
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertising