type approval certificate - Bachmann electronic GmbH
Page 1 / 5
Certificate number: 23070/B1 BV
File number: AP4121
Product code: 4501H
This certificate is not valid when presented without the
full attached schedule composed of 7 sections
www.veristar.com
TYPE APPROVAL CERTIFICATE
This certificate is issued to
Bachmann electronic GmbH
Feldkirch - AUSTRIA
for the type of product
PROGRAMMABLE LOGIC CONTROL UNITS
M1 series
Requirements:
Bureau Veritas Rules for the Classification of Steel Ships
EC Code: 33
This certificate is issued to attest that BUREAU VERITAS did undertake the relevant approval procedures for the product identified above which
was found to comply with the relevant requirements mentioned above.
This certificate will expire on: 23 Apr 2020
For BUREAU VERITAS,
At BV HAMBURG, on 15 May 2017,
Dirk Hoepfner
This certificate remains valid until the date stated above, unless cancelled or revoked, provided the conditions indicated in the subsequent page(s) are complied
with and the product remains satisfactory in service. This certificate will not be valid if the applicant makes any changes or modifications to the approved product,
which have not been notified to, and agreed in writing with BUREAU VERITAS. Should the specified regulations or standards be amended during the validity of
this certificate, the product(s) is/are to be re-approved prior to it/they being placed on board vessels to which the amended regulations or standards apply. This
certificate is issued within the scope of the General Conditions of BUREAU VERITAS Marine & Offshore Division available on the internet site www.veristar.com.
Any Person not a party to the contract pursuant to which this document is delivered may not assert a claim against BUREAU VERITAS for any liability arising out
of errors or omissions which may be contained in said document, or for errors of judgement, fault or negligence committed by personnel of the Society or of its
Agents in establishment or issuance of this document, and in connection with any activities for which it may provide.
The electronic version is available at: http://www.veristarnb.com/veristarnb/jsp/viewPublicPdfTypec.jsp?id=5gvpwjptph
BV Mod. Ad.E 530 October 2014
This certificate consists of 5 page(s)
Page 2 / 5
Certificate number: 23070/B1 BV
THE SCHEDULE OF APPROVAL
1. PRODUCT DESCRIPTION:
M1 series are programmable logic controller and comprises the following modules:
Module type
Processor
Modules
Digital I/O
Analogue I/O
Model
ME203
ME203/N/E/EN/C/CN
MH212
MH212/S
MPC240
MPC265
MPC270
MPC293
MPE240
MPE265
MPE270
MX207
MX213
MX220
MC205
MC210
DI212
DI216
DI232
DI232/np1
DIO216
DIO216/4
DIO232
DIO248
DIO264
DIO280
DO216
DO232
DO232/48
DOR206
DOR206/230
AI204/1
AI204/2
AI204/4
AI202/SI
AI204/SI
AI208/SI
AIC212
AIO208
AIO216
AIO202/SI
AIO204/SI
AIO208/SI
Description
80386 EX (33MHz)
80386 EX (33MHz) (N: Integrated power supply, E: Ethernet, C: CANopen)
CPU Core 2 DUO (1.2GHz)
CPU Celeron (1.2GHz)
CPU Celeron (400MHz)
CPU Celeron (650MHz)
CPU Pentium III - class (700MHz)
CPU Pentium III - architecture (933MHz)
CPU Celeron (400MHz), 2 PCI slots
CPU Celeron (650MHz), 2 PCI slots
CPU Pentium III (700MHz), 2 PCI slots
CPU x86 Pentium equivalent (66MHz)
CPU x86 Pentium equivalent (133MHz)
CPU x86 Pentium equivalent (200MHz)
CPU Atom E620 (600MHz)
CPU Atom E680 (1,6GHz)
12 inputs, one group, 24VDC
16 inputs, two groups, 24VDC
32 inputs, two groups, 24VDC
32 inputs, four groups, 24VDC
0 to 16 inputs, 0 to 16 outputs, 24VDC
0 to 16 inputs, 0 to 16 outputs, 24VDC
16 to 32 inputs, 0 to 16 outputs, 24VDC
16 to 32 inputs, 16 to 32 outputs, 24VDC
24 to 40 inputs, 24 to 40 outputs, 24VDC
32 to 48 inputs, 32 to 48 outputs, 24VDC
16 outputs, 24VDC
32 outputs, 24VDC
32 outputs, 48VDC
6 outputs for relays
6 relay outputs, 230VAC/1A or 24VDC/0.5A
1 input, +/-10V
2 inputs, +/-10V
4 inputs, +/-10V
2 inputs, 0(4) to 20mA, isolated
4 inputs, 0(4) to 20mA, isolated
8 inputs, 0(4) to 20mA, isolated
9 inputs +/-6V, 3 inputs +/-10V
8 inputs/outputs (configurable)
16 inputs/outputs (configurable)
2 inputs/outputs, isolated (configurable)
4 inputs/outputs, isolated (configurable)
8 inputs/outputs, isolated (configurable)
The electronic version is available at: http://www.veristarnb.com/veristarnb/jsp/viewPublicPdfTypec.jsp?id=5gvpwjptph
BV Mod. Ad.E 530 October 2014
This certificate consists of 5 page(s)
Page 3 / 5
Certificate number: 23070/B1 BV
Module type
Analogue I/O
Model
AIO288
AIO288/1
AO202
AO202/SI
AO204/SI
AO208/I
PTAI216
TI214
TI214/2
General I/O
GIO212
Technology
CNT204
Modules
CNT204/H
CNT204/R
ISI202
ISI202/5
ISI222
ISI222/8
PVA204
PVA208
Interface
FCS214/F/G
Modules
RS204
RS204/T
RS204/R
RS204/2
SWI205/S
Bus Modules
CM202
CS200
CS200/N
DNM201
DPM200
EM303
EM213
FM211, FM221
FM212, FM222
FS211, FS221
FS211/N, FS221/N
FS212, FS222
FS212/N, FS222/N
Decentral CAN DA3284-C
Modules
DIO16-C
DIO32-C
DIO48-C
DIO264-C
TCO204-C
TCO208-C
TCO216-C
Description
8 inputs, 8 outputs, 4 inputs PT100/PT1000, isolated
8 inputs, 8 outputs, 4 inputs PT100/PT1000, non isolated
2 outputs, +/- 10V
2 outputs, 0 to 20mA
4 outputs, 0 to 20mA
8 outputs, 0(4) to 20mA
4 inputs, +/-1V, +/-10V or 0 to 20mA, 12 inputs, PT100/PT1000
14 inputs, PT100/PT1000/J/K
14 inputs, N/S
12 inputs/outputs, isolated (individually configurable)
Counter, 1 INC HTL and 1 INC RS422 and 2 counter or 4 counter
Counter, 2 INC HTL + 2 counter or 4 counter
Counter, 2 INC RS422 + 2 counter or 4 counter
Encoder, 2 INC/SSI, 1MHz, 2 analogue out +/- 10V, 2 INIT
Encoder, 2 INC, 5MHz, 2 analogue out +/- 10V, 2 INIT
Encoder, 2 INC/SSI, 1MHz, 2 analogue out +/- 10V, 2 INIT, 2 TRIGGER
Encoder, 2 INC, 8MHz, 2 analogue out +/- 10V, 2 INIT, 2 TRIGGER
Proportional valve amplifier, current regulated, max.4 unipolar solenoids
Proportional valve amplifier, current regulated, max.8 unipolar solenoids
Switch, 1 fibre optic, 4 RJ45, (F: 10/100Mbit/s, G: 10/100/1000Mbit/s)
Serial interfaces, 4 RS232/422/485
Serial interfaces, 3 RS232/422/485, 1 TTY
Serial interfaces, 3 RS232/422/485, 1 RS232
Serial interfaces, RS232/422/485, 2MBit/s
Ethernet Switch, 5 ports, RJ45
2 CAN bus master
2 CAN bus slave
2 CAN bus slave, integrated power supply
DeviceNet master
2 PROFIBUS connectors
Ethernet master, 3 RJ45, 10/100MBit/s
Ethernet master, 3 RJ45, 10/100MBit/s
FAST bus master, 1 fibre optic interface
FAST bus master, 2 fibre optic interfaces
FAST bus slave, 1 fibre optic interface
FAST bus slave, 1 fibre optic interface, integrated power supply
FAST bus slave, 2 fibre optic interfaces
FAST bus slave, 2 fibre optic interfaces, integrated power supply
8 analogue IN, 4 analogue OUT, 16 digital IN, 16 digital IN/OUT
16 digital inputs/outputs
32 digital inputs/outputs
32 digital inputs/outputs and 16 digital inputs
32 digital inputs/outputs and 32 digital inputs
4 analogue inputs (TC type J or K) and 8 digital outputs, 24VDC
8 analogue inputs (TC type J or K) and 12 digital outputs, 24VDC
16 analogue inputs (TC type J or K) and 24 digital outputs, 24VDC
The electronic version is available at: http://www.veristarnb.com/veristarnb/jsp/viewPublicPdfTypec.jsp?id=5gvpwjptph
BV Mod. Ad.E 530 October 2014
This certificate consists of 5 page(s)
Page 4 / 5
Certificate number: 23070/B1 BV
Module type
Accessories
Model
BS201 to BS216
BS203/S to BS216/S
BS202/ET to BS208/ET
S201
CF200
LM20
LM201
NT250
NT255
PCC201/x
Main characteristics:
Power supply:
Degree of protection:
Firmware version:
Description
Backplanes with 1 to 16 module slots
Backplanes with 1 to 16 module slots for class 1 protective connection
Backplanes with 2 to 8 module slots, for heat dissipation
Backplane with 1 module slot, without bus
CF-Card (64/128/256/512MB, 1/2/4/8GB)
Dummy modules
Dummy modules
Power supply modules, 24VDC
Power supply modules, 24VDC
PC-Card (8/16/32/64MB)
24VDC nominal voltage
IP20
M-Base V4.xx and V3.xx
2. DOCUMENTS AND DRAWINGS:
- Technical Documentation V01/Feb.2009
- Data sheets dated 18.03.2011, 03/2014, 02/2015 and 04/2015 ; PVA20xDoku_13228-000-24 Rev000
- Operating manuals: Benutzerhandbuch M-BASE V4.00, revision 02, dated 28 April 2016
- Software Quality Assurance documents: G130, dated 28.07.2016 ; G135, dated 28.07.2016 ; G142, dated 16.08.2016 ;
G150, dated 07.10.2016 ; G161, dated 11.10.2016 ; G162, dated 11.10.2016 ; G170, dated 29.11.2016;
G180, dated 07.10.2016 ; G194, dated 01.08.2016 ; RLG100-20, REV 000.1, dated 13.02.2013;
RLG100-01, REV 017, dated 11.4.2016 ; RLG100-07, REV 005, dated 27.04.2015 ; RLG100-17, REV 008.1,
dated 15.02.2011 ; RLG100-08, REV002, dated 09.02.2015 ; RLG100-18, REV005.1, dated 09.03.2011
3. TEST REPORTS:
Bachmann:
- 10992 dated 22.July.2009, 30.July.2009, 2x 17.08.2009, 2x 17.Aug.2009, 14.Aug.2009, 4.August.2009 and 16.Oct.2009
- 09144/09 dated 16.Sept.2008 2x 22.Sept.2008 and 11.Sep.2008, SuV010 dated 1.July.2008
- 9942 dated 21.11.01, 10469 dated 14.Jänner 2008, 10631 dated 13.12.2007, 9825 dated 16.9.1999 and 13.12.1999,
10511 dated 29.5.2008,
- 10134 dated 2.4.2002, 9584 dated 09.03.1999, 10123 dated 28.3.2002, 10502/03 dated 22.Sep.2008
- 9483 dated 05.11.1999, 9810 dated 28.03.2001, 10463 dated 08.06.2006, 10814 dated 09.11.2007, 9949 dated 01.12.2000
- 10346 dated 16.09.04, 10741 dated 27.10.2008, 09144/09 dated 23.Sep.2008 and 10992 dated 15.07.2010
- 12482 dated 05 May 2011, 13 June 2011 and 19 Aug 2011
- 12718.00.03/04 dated 29.102014; 12718.00.05/06/11 dated 28.11.2014; 12718.00.10 dated 24.11.2014
- 12718.00.13/14/17/18 dated 30.102014; 12718.00.19 dated 30.10.2014; 12718.00.20 dated 30.10. 2014
- 12718.00.21 dated 22.01.2015 Rev.1
- 13228-000-3,4, dated 01.02.2016, Rev.000; 13228-000-5,6,11, dated 21.03.2016, Rev.000; 13228-000-9, dated 21.03.2016,
Rev.000 ; 13228-000-10, Rev.000, dated 04.02.2016 ; 13228-002-13,14,15,16,17,18, Rev.003, dated 06.06.2016 ;
13228-000-19,20, Rev.000, dated 01.02.2016 ; 13228-000-21, Rev.000, dated 21.01.2016
ZAMM:
- 436-0508 dd.: 2008-05-13, 403-0109 dd.: 2009-01-29, 424-0308 dd.: 2008-03-11 and 453-1109 dd.: 2009-11-03
SGS:
- B0TW0001 dd.: Oct 09.2008
TÜV SÜD:
- 71366028 dated 2010-06-21, 14312-03974-1(Ed. 1) dated 28 July 2011 and 71386807 dated 2011-08-04
- 713051191 dated 2014-11-25; 14312-52016-01 Ed.1 dated 13 Nov 2014
- 713077298, Rev 1, dated 2016-02-16
The electronic version is available at: http://www.veristarnb.com/veristarnb/jsp/viewPublicPdfTypec.jsp?id=5gvpwjptph
BV Mod. Ad.E 530 October 2014
This certificate consists of 5 page(s)
Page 5 / 5
Certificate number: 23070/B1 BV
4. APPLICATION / LIMITATION:
4.1 - Bureau Veritas Rules for the Classification of Steel Ships.
4.2 - Approval valid for ships intended to be granted with the following additional class notations: AUT-UMS, AUT-CCS,
AUT-PORT and AUT-IMS.
4.3 - Bureau Veritas Environmental Category, EC Code: 33.
4.4 - The equipment fulfils the EMC requirements for installation in on bridge or deck by using an interference filter on the
power supply lines as specified in the M-Base V4.xx Operating manual.
4.5 - The product designation of some modules may be followed by "CC" and additional marked with "*" at the front and the
product designation of processor modules may be followed by "W". These features are not relevant for the certificate.
4.6 - Each application and configuration is to be submitted to the Society's examination prior to fitting on board.
4.7 - Data processing system used for machinery protection is to be independent from the control and monitoring system.
4.8 - Depending on the application, submission of documents, Factory Acceptance and On-board Tests are to be performed in
accordance with requirements for programmable electronic systems categories II or III.
4.9 - Only Hardware and Software successfully tested together in compliance with the regulations as referred to in page one,
according to the declaration of the manufacturer is covered by this certificate.
5. PRODUCTION SURVEY REQUIREMENTS:
5.1 - The above products are to be supplied by Bachmann electronic GmbH in compliance with the type described in this
certificate.
5.2 - This type of product is within the category HBV of Bureau Veritas Rule Note NR320 and as such does not require a BV
product certificate.
5.3 - Bachmann electronic GmbH has to make the necessary arrangements to have its works recognised by Bureau Veritas in
compliance with the requirements of NR320 for HBV products :
Bachmann electronic GmbH
Kreuzäckerweg 33
6800 Feldkirch
AUSTRIA
5.4 - Each equipment is to be supplied with manual (s) for installation, use and maintenance.
6. MARKING OF PRODUCT:
- Maker's name or trademark.
- Date of manufacture and/or serial number.
- Equipment type or model identification under which it was type-tested.
- For each application title and version of each software element included in the installed software system shall be either marked
on the equipment or displayed on a panel on command.
7. OTHERS:
7.1 - It is Bachmann electronic GmbH - AUSTRIA responsibility to inform shipbuilders or their sub-contractors of the proper
methods of fitting, use and general maintenance of the approved equipment and the conditions of this approval.
7.2 - This certificate supersedes the Type Approval Certificate N° 23070/B0 BV issued on 23 Apr 2015 by the Society.
*** END OF CERTIFICATE ***
The electronic version is available at: http://www.veristarnb.com/veristarnb/jsp/viewPublicPdfTypec.jsp?id=5gvpwjptph
BV Mod. Ad.E 530 October 2014
This certificate consists of 5 page(s)
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement