Laserjet Printer Cartridge Material Safety Data Sheet

Laserjet Printer Cartridge Material Safety Data Sheet
Material Safety Data Sheet
1.0
Product and Company Identification
Identification of the preparation
HP LaserJet Cartridge
C7115A/X
Company Identification
Hewlett-Packard Company
11311 Chinden Boulevard
Boise, Idaho 83714
United States
Emergency telephone number
Hewlett-Packard Health Effects Line
1-800-457-4209 (USA and Canada)
Intl: +1-503-494-7199 (all other areas)
Singapore: +001-800-332-13321
General information telephone number
1-208-323-2551 (USA and Canada)
Intl: +1-208-323-2551 (all other areas)
Local Contact Information
Ireland
Liffey Park Technology Park
Barnhall Road Leixlip, Co.
Kildare, Ireland
Phone: 01 6150000
United Kingdom
Hewlett-Packard, Ltd.
Cain Road, Amen Corner
Bracknell, Berkshire, RG12 1HN
Phone: 1344 36-0000
Hazard Rating
US NFPA/HMIS
Health
1
Flammability
1
Instability/Reactivity
0
Special
N/A
2.0
Composition/Information on Ingredients
This product is a toner preparation that is used in Hewlett-Packard LaserJet 1000, 1200,
and 3300 printers.
Component/Substance
Styrene Acrylate
Copolymer
Iron Oxide
3.0
CAS Number
% by Weight
Risk Phrases
-
EU
Number
-
45 - 55
-
1317-61-9
215-277-5
40 - 50
-
Hazard Identification
The preparation is not classified according to EU Directive 1999/45/EC
August 1, 2002
Page 1 of 6
HP LaserJet C7115A/X
Material Safety Data Sheet
Routes of Exposure
Inhalation, Ingestion, skin and eyes.
Acute Health Hazards
Inhalation: Minimal respiratory tract irritation may occur with exposure
to large amounts of dust.
Ingestion: Low acute toxicity. Ingestion is a minor route of entry for
intended use of this product.
Skin: Unlikely to cause skin irritation.
Eyes: May cause transient slight irritation.
Prolonged inhalation of excessive amounts of any dust
Chronic Health Hazards
may cause lung damage. Use of this product as intended
does not result in inhalation of excessive amounts of dust.
Refer to section 11.
Carcinogenicity
4.0
First Aid Measures
Inhalation: Move person to fresh air immediately. If symptoms
occur, consult a physician.
Ingestion: Rinse mouth with water. Drink one to two glasses of
water. If symptoms occur, consult a physician
immediately.
Skin: Wash affected areas thoroughly with soap and
water. If irritation persists, consult a physician.
Eyes: Do not rub eyes. Immediately flush with large
amounts of clean, lukewarm water (low pressure) for
at least 5 minutes or until particles are removed. If
irritation persists, consult a physician.
5.0
Fire Fighting Measures
Extinguishing media CO2, water, dry chemical
Unsuitable Extinguishing
Media
Special Firefighting
Procedures
Unusual fire and explosion
hazards
None known
None
Like most organic material in powder form, toner can
form explosive dust-air mixtures when finely
dispersed in air.
Auto-ignition temperature Not available
Flashpoint (method) Not applicable
Hazardous Combustion CO2, CO
Products
August 1, 2002
Page 2 of 6
HP LaserJet C7115A/X
Material Safety Data Sheet
6.0
Accidental release measures
Spill or leak procedures Avoid breathing dust. Minimize the release of
particles. Slowly sweep the material into a bag or
other sealed container. Clean remainder with a
damp cloth or vacuum cleaner. If a vacuum is used,
the motor must be rated as dust explosion-proof.
Fine powder can form explosive dust-air mixtures.
Dispose of waste toner in accordance with local
requirements.
Environmental precautions Do not discharge into drains (See also Section 13,
Disposal Considerations).
7.0
Handling and Storage
Advise on safe handling and Keep material out of reach of children. Avoid
protection against fire inhalation of dust and contact with eyes. Use with
adequate ventilation. Keep away from excessive
heat, sparks, and open flames.
Requirements for storage Keep out of the reach of children. Keep container
rooms and advise on closed and store at room temperature. Keep away
storage compatibility from strong oxidizers.
8.0
Exposure control/ personal protection
Exposure Limit Values
USA OSHA (TWA/PEL): 15 mg/m3 (Total Dust)
5 mg/m3 (Respirable Fraction)
ACGIH (TWA/TLV): 10 mg/m3 (Inhalable Particulate)
3 mg/m3 (Respirable Particulate)
TRGS 900 (Luftgrenzwert): 10 mg/m3 (Einatembare Partikel)
3 mg/m3 (Alveolengängige Fraktion)
Exposure Controls
Respiratory protection Not required under intended use.
Ventilation Good general ventilation should be sufficient under
intended use.
Protective gloves Not required under intended use.
Eye protection Not required under intended use.
Other protective equipment Not required under intended use.
9.0
Physical and chemical properties
pH
Boiling point
Flash point
Melting point
Flammability
August 1, 2002
Not applicable
Not applicable
Not applicable
100 - 150oC (Softening Point)
Non-flammable solid (according to test methods of
EU Directive 92/69/EEC, A10 Flammability (Solids)
Page 3 of 6
HP LaserJet C7115A/X
Material Safety Data Sheet
Explosive properties Toner material, like most organic material in powder
form, is capable of creating a dust explosion.
Oxidizing properties No data available
Vapor Pressure Not applicable
Specific gravity (H2O=1) 1.4 - 1.8
Solubility in water Negligible
Solubility in organic Partially soluble in toluene and xylene.
solvents
Partition coefficient Not applicable
Viscosity Not applicable
Vapor density Not applicable
Evaporation rate Not applicable
Physical state Fine powder
Color Black
Odor Slight plastic odor
Other Decomposition Temperature: >200 o C
10.0
Stability and reactivity
Stability
Incompatibilities
Hazardous decomposition
products
Hazardous polymerization
11.0
Stable under normal storage conditions
Strong oxidizers
CO2, CO
Will not occur
Toxicological information
Refer to Section 3 for potential heath effects and Section 4 for first aid measures
Inhalation: LC50:inh-rat>5mg/L/4 hrs., not harmful.
Ingestion: LD50:orl-rat>5000 mg/kg, not harmful.
Eye Contact: Not classified as irritant, according to OSHA Hazard
Communication Standard (HCS) and EU Directive
67/548/EEC.
Skin Contact: Not classified as irritant, according to OSHA Hazard
Communication Standard (HCS) and EU Directive
67/548/EEC.
Chronic Toxicity: No data available.
Sensitization: Not classified as a sensitizer according to EU
Directive 67/548/EEC and OSHA HCS (US).
Mutagenicity: Negative, does not indicate mutagenic potential
(Ames Test: Salmonella typhimurium)
Carcinogenicity: Not a known or suspected carcinogen according to
any IARC Monograph, NTP, OSHA Regulations
(USA), EU Directive, or Proposition 65 (California).
Reproductive Toxicity: Not classified as toxic according to EU Directive
67/548/EEC, California Prop. 65, or DFG
(Germany).
August 1, 2002
Page 4 of 6
HP LaserJet C7115A/X
Material Safety Data Sheet
12.0
Ecological Information
No data available for ecological and wastewater treatment (sewage) systems. Avoid
spills and dispose of in accordance with applicable laws and regulations.
13.0
Disposal considerations
Do not put toner or toner cartridge into fire; heated toner may cause severe burns. Do
not shred toner cartridge, unless dust-explosion prevention measures are taken. Finely
dispersed particles may form explosive mixtures in air. Dispose of in compliance with
federal, state, and local regulation.
14.0
Transportation information
Not a regulated article under DOT, IATA, ADR, or RID
UN Number
Class
Proper Shipping Name
Packing Group
Special Precautions
15.0
None
None
None
None
None
Regulatory information
All ingredients are listed on TSCA inventory
None
None
All components in this product are compliant with
EU Chemical Inventory regulations.
EU R&S Phrase Information No European Risk Phrases (labeling data)
Dangerous Components None
(CAS No.) wt%
USA Labeling
Symbol Not required
Hazard Warning Not required
Safety Advice Not required
Hazardous Component(s) None
US EPA TSCA Inventory
US EPA TSCA 12(b)
US California Proposition 65
EU Notification
16.0
Other information
Date Prepared:
HP-DMS Document Control
Number:
Revision Information:
EU Information
August 1, 2002
August 1, 2002
09000de78022dae5
This document replaces all prior versions of the MSDS
This MSDS was prepared in compliance with EU
Directive 91/155/EEC as amended by 2001/58/EC and
USA OSHA Hazard Communications regulations
(29CFR1910:1200).
Page 5 of 6
HP LaserJet C7115A/X
Material Safety Data Sheet
DISCLAIMER: This Material Safety Data Sheet (MSDS) is provided without charge to
customers of Hewlett-Packard. Data is the most current known to Hewlett-Packard at
the time of preparation of this MSDS and is believed to be accurate. It should not be
construed as guaranteeing specific properties of the products as described or their
suitability for a particular application.
August 1, 2002
Page 6 of 6
HP LaserJet C7115A/X
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertising