Titan Bath Control User Guide

Titan Bath Control User Guide
Titan Bath Control Installation and User Guide
for Balboa Generic Configurations
TM
102
42135 E
42135F
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
1
Introduction
Intellectual Property Advisement
All Intellectual property, as defined below, owned by or which is otherwise the property of
Balboa Water Group or its respective suppliers relating to the Balboa Water Group Titan Bath
Control System including but not limited to, accessories, parts, or software relating there to (the
“System”), is proprietary to Balboa Water Group and protected under federal laws, state laws,
and international treaty provisions. Intellectual Property includes, but is not limited to, inventions
(patentable or unpatentable), patents, trade secrets, copyrights, software, computer programs,
and related documentation, and other works of authorship. You may not infringe or otherwise
violate the rights secured by the Intellectual Property. Moreover, you agree that you will not (and
will not attempt to) modify, prepare derivative works of, reverse engineer, decompile, disassemble,
or otherwise attempt to create source code from the software. No title to or ownership in the
Intellectual Property is transferred to you. All applicable rights of the Intellectual Property shall
remain with Balboa Water Group and its suppliers.
Warnings: Danger! Risk of Electric Shock!
End User Warning
• All electrical work must be performed by a qualified
electrician and must conform to all national, state, and local
codes.
• Before making any electrical connections, make certain that
the Main Power breaker from the house breaker box has
been turned off.
• Do not attempt service of this control system. Contact your
dealer or service organization for assistance.
• Do not permit any electric appliance, such as a light,
telephone, radio, or television within 5* (1.5m) of a pool
or spa.
• Follow all owner’s manual power connection instructions.
• Installation must be performed by a licensed electrician and
all grounding connections must be properly installed.
• No user serviceable parts.
• Water temperature in excess of 38˚C may be injurious to
your health.
• Disconnect the electrical power before servicing.
• Keep access door closed
• To ensure continued protection against shock hazard, use
only identical replacement parts when servicing.
This Installation Manual is provided solely to aid qualified spa
service technicians in installing spas with control systems
manufactured by Balboa Water Group. Balboa controls have
absolutely no end user serviceable parts. Balboa Water Group
does not authorize attempts by the spa owner/user to repair or
service any Balboa products. Non-qualified users should never
open or remove covers, as this will expose dangerous voltage
points and other dangerous risks. Please contact your dealer or
authorized repair center for service.
© 2013 Balboa Water Group
2
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
7/14/14
Table of Contents
Introduction to the Titan. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Organization of this Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
A Few Things to Consider Before Getting Started . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Titan Bath Control Behavioral Specs. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Bath Control Information. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Titan Bath Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Variable Speed Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Primary Valve Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Bath Panels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Cables and Display Trims . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Cable Assembly Diagrams: Adapters and Splitters. . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Common Configurations. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Sample 120V Bath Configuration
with a Primary Valve Control Box. . . . . . . . . . . . . . . . . . 14
Sample EU (230V) Bath Configuration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Skeletal View . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Cables & LED Light. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Blower & Air Hose Routing. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .18
Component Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
Installation Overview. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
Installation Instructions for the Titan 6 Button Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
Installation of Temperature Sensor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
Installation of Conductive Water Sensor. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
Solenoid Valves . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
Multiple Solenoid Outputs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Consistency in Valve to Jet Connections. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Solenoid and Wiring Set-up, Balboa Configuration No. 40. . . . . . . . . . . . . . . . . . . . . . . . . 26
Creating a Configuration 40 Bath System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
Bath Setup. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
Installing Multiple Solenoid Valves. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
Codes, Abbreviations, and Terms. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
Using Bath Button Code Configurations. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
System Timer Codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
Light Codes. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
Pump Codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
Blower Codes. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
Valve Codes. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
42135F
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
3
Bath Control Configuration Tables. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33
Generic BWG 6-button panel - P/N 90010 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33
Generic BWG 2-button panel - P/N 90011 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35
Generic BWG 4-button panel w/User - P/N 90012. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36
Generic BWG 4-button panel w/two valves - P/N 90022 . . . . . . . . . . . . . . . . . . . . . . . . . . 37
Generic BWG 4-button panel w/up-down - P/N 90013 . . . . . . . . . . . . . . . . . . . . . . . . . . . 38
Bath Button Panel Configuration. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39
Configuring the 6 Button Bath Panel. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .39
Configuring the 2 Button Bath Panel. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .39
Configuring the 4 Button Bath Panel. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .40
Bath Control User Guides . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41
6 Button Bath Control User Guide. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41
2 Button Bath Control User Guide - Therapy, Light/Aux. . . . . . . . . . . . . . . . . . . . . . . . . . 43
4 Button Bath Control User Guide - Blower, Light, Speed Buttons. . . . . . . . . . . . . . . . . . . . . . 45
4 Button Bath Control User Guide - Blower, Light, User Favorite. . . . . . . . . . . . . . . . . . . . . . 47
4 Button Bath Control User Guide - Therapy, Options . . . . . . . . . . . . . . . . . . . . . . . . . . . 49
4 Button Bath Control User Guide - Therapy, Option, Speed Buttons. . . . . . . . . . . . . . . . . . . . . 51
4 Button Bath Control User Guide - Therapy, Options, User Favorite. . . . . . . . . . . . . . . . . . . . . 53
Error Codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
2 & 6 Button Error Codes. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .55
4 Button Error Codes. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 56
6 Button Bath Panel Cut Out. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57
Index . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58
Index of Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62
4
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
7/14/14
Introduction to the Titan
This manual describes Balboa Water Group’s Titan bath
controls, equipment, and how to configure and install those
controls using Balboa's Configuration Tables.
Although sometimes described as a Titan “system,” Titan’s bath
configurations are created from its many components that can
be mixed and matched to provide a wide variety of functionality.
A Titan system can be as interpreted to mean any one of many
functioning configurations of Balboa’s Titan bath components.
Organization of this Manual
The manual is separated into the following sections:
• The Titan Bath Components: Provides an overview of all
parts associated with Titan Bath products, and provides a
brief description, part number, and function of the part.
• Common Configurations: Illustrates basic placement of
Titan components.
• Component Installation: Describes and illustrates
installation of important electronic components such as the
bath panel, sensors, and solenoids.
• Creating a Configuration 40 Bath System: The Titan
bath collection has the flexibility to allow equipment to be
assembled in many ways. This section illustrates a common
configuration with diagrams and explains how it's put
together.
• Codes, Abbreviations, and Terms: Provides an
introduction to what "codes" are, and explanations
of related terms and abbreviations that help with
configuration tables.
• Bath Control Configuration Tables: A cross reference of
equipment installed.
• Bath Button Panel Configuration: The process of
inputting a configuration number into the panel.
• Bath Control User Guides: Two and six button user
guides provide instructions to operate all equipment
configurations. Because of their design, four button bath
panel user guides are more specialized and have user
specific functions. Each user guide have their unique
document number and revision letter, front and back. Each
user guide can be printed separately as a single, two sided
page. When printed, the user guides do not show page
numbers.
42135F
A Few Things to Consider Before Getting
Started
• Each control box accepts any control panel.
• Each control box accepts water and temp sensors (both are
highly recommended).
• Each control box controls either a single or variable speed
pump or blower.
• For lights, a Variable Speed Control (VSC) is required.
• To have control over pulsating jets, pillow, or related
equipment, a Primary Valve Control (PVC ) is required.
• Only one blower may be assigned per system.
• Titan parts and accessories can be found on either sites:
a) http://www.balboawatergroup.com/
b) http://balboadirect.com/
Component Installation Section
Only installation of major components is described herein. It is
assumed that items such as using, wiring, and routing of Amp
connectors, cables, hoses, for example, are common installation
procedures of bath manufacturing and will not be discussed
here. Installation of air manifolds, fluid dynamics such as
circulation, flow rates, water pressure, and the number and size
of jets in relation to pumps is beyond the scope of this manual.
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
5
Titan Bath Control Behavioral Specs
Titan Bath Controls support 3 panels:
Sensors
• 6-button LED lit icons, and 3-digit LED message display
• 4-button with 4 point LEDs
• 2-button with 3-digit LED message display
It is highly recommended to install a water level sensor. The
sensor affects the pump and blower purge. If there is no water
sensor, the pump can run any time, even when the water level
falls below acceptable levels for safe pump operation. When
there is a water sensor, the pump can only run when there is
water detected. The water temp sensor also cuts off if the
water temperature goes beyond 111 degrees.
6 and 2 Button Panels
On the 6-button panel, button icon LEDs change in brightness.
Under normal operation, a bright button indicates the function is
on. A dim button indicates the function is available but not on. A
blank button indicates the function is not available. Exceptions
in brightness will occur as when powering up, or when selecting
a Configuration.
Off function: If the pump is running and pump-related
equipment like waterfall and/or pillow is running, then turning
off the pump turns the related equipment off also.
4 Button Panel
On the 4-button panel, the 4 point LEDs can indicate Error, On
state, Water Present, and User Preset. When there is an error,
the Error light will indicate such, while the other 3 LEDs will
indicate the error number in binary code. At power up, all 4 LEDs
will briefly display the configuration number in binary code.
Off function: If the pump is running and pump-related
equipment like waterfall and/or pillow is running, turning off the
pump turns the related equipment off at the same time.
System Timer
The System Timer is started any time any water equipment is
turned on. The System Timer defaults to 20 minutes; the user
can change this, in User Preferences mode.
Temperature and Timer Display
On panels with 3-digit displays, the user can select whether
to show the water equipment timer, the temperature, or
both alternating.
The temperature will be displayed in 0.5 steps in C, and full
steps in F. No degree symbol will be shown. The timer value
will be displayed as 2 digits preceded by the letter “t”. If no
temperature sensor is present, only the timer value will be
displayed. The temperature sensor is usable at all times.
The panel will be able to communicate bidirectionally with any
module(s) it is connected to. Each module will acknowledge
its working state and report any errors it can determine. In the
case of an error, an error code will display.
Buttons with Two Options
A user guide may designate a bath button panel as having a
dual function, “Light/Aux” for example on the two button panel.
Depending on the equipment installed, the button configuration
must be inputted according to the equipment shown on the
configuration table (as a pillow, for example). In this case, AUX
would designate the function for the pillow.
User Button
• Until you program it, the User button functions as an “all
off” button. In other words, the default User Preset turns all
equipment off.
• Pressing and holding the User button memorizes the current
state of all equipment as a User Preset. Pressing (but not
holding) the User button recalls the last-memorized User
Preset.
• If it’s programmed as a user button and you want to return it to
an “all off” button again, turn everything off and re-save.
6
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
7/14/14
Bath Control Information
90010
6-BUTTON BATH CONTROL
LED Display
• Shows config. & software at start-up
• Time remaining
• Pump Speed
• Pulse Mode
• Blower Rolling
• Pulse Pattern
• Error and Diagnostic Codes
blower
Press & hold alters speed
Allows for a “purge” cycle
Pump
Turns pump on/off
Press & hold to change speeds
Press twice to start wave mode
User Button
6-BUTTON BATH CONTROL
Therapy | Light | Blower | Massage | User | Massage
massage Button
Change speed
(back jet/pillow)
light Button
Can be controlled independently
of all other features
Massage Button
Change speed
(back jet/pillow)
Display Message Formats
37.5
Con
t29
sp6
42135F
Numbers appear in Fahrenheit or Celsius
depending on Preferences.
pul
PUL refers to Pulse Mode (Blower only).
CON. Allow for entry into the Configuration
Settings.
rol
ROL Rolling means that over several seconds
the blower or pump reduces and then increases
in speed. Then the cycle resumes.
PT3
“PT” refers to pattern of jets pulsating, whether
synchronous or alternating. PT1 is the lowest
speed pattern.
T refers to the time in seconds left remaining
in the therapy session.
SP refers to speed. SP1, for example, indicates
the lowest speed.
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
7
Titan Bath Components
Variable Speed Control
Primary Valve Control
Part No. 90017 (90005 is similar)
Part No. 90018
•
•
•
•
•
•
•
•
•
Panel
12V Light
Water Level Sensor
Temperature Sensor
5 Discrete paired output connectors for valves
Panel
120V Light
Water Level Sensor
Temperature Sensor
J4 Mini DIN 6 Pin*
(Water/Temp Sensor)
J1 Mini DIN 8 Pin
(Panel)
J2 Mini DIN 6 Pin
(Water/Temp Sensors)
J5 Mini DIN 8 Pin*
(Panel)
J3 Mini DIN 4 Pin
(12V Light)
Paired Valve Connectors
Part No.
Bath Controls
Dimensions
90017
Variable Speed Control
7-3/8” x 4-1/4” x 2-3/8” (Mounting holes 6-7/8” +/- 1/8”)
90018
Primary Valve Control
7-3/8” x 4-1/4” x 2-3/8” (Mounting holes 6-7/8” +/- 1/8”)
90005
System Expandable, Var. Sp. (Similar to 90017) 7-3/8” x 4-1/4” x 2-3/8” (Mounting holes 6-7/8” +/- 1/8”)
Connector
Component
Function
J1
Variable Speed Control
Panel Cable (8 Pin)
J2
Variable Speed Control
Sensor Cable (6 Pin)
J3
Variable Speed Control
Light Cable (4 Pin)
J4*
Primary Valve Control
Sensor Cable (6 Pin)*
J5*
Primary Valve Control
Panel Cable (8 Pin)*
Green Conn.
Primary Valve Control
5 Discrete Paired Outputs
*Depending on the model revision, J4 & J5 may be reversed.
8
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
7/14/14
Bath Panels
Part No. 90010
Part No. 90016
Part No. 90011
102
Pump or
Blower
Device
or Valve
Part No. 90015
Part No. 90013-01
Part No.: 90013
Overlay: 12013
Pump
or
Pump or
Blower
Blower
Device
or Valve
Valve
Device
Device
Valve
oror
Valve
Up Up
Down
Down
Part No. 90022
Part No.: 90022
Overlay: 12983
Pump or
Pump or
Blower
vice
Valve
er
Blower
Device
or Valve
or Valve
Pump or
Blower
Valve
Valve
Up
Valve
42135F
Device
Part No.: 90013
Overlay: 12013
Valve
Part No.: 90012
Overlay: 12014
Pump or
Pump or
Blower
Part No. 90012
Device
Part No.: 90022
Overlay: 12983
Blower
Device
or Valve
Device
or Valve
or Valve
Pump or
Blower
Valve
Down
User
Valve
Valve
User
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
9
Cables and Display Trims
Part No. 25569
Cable Bath 8 Pin Mini DIN 6 Ft
Part No. 99642-CW
Display Trim Round
Part No. 25750
Light Adapter Cable 4 Pin DIN
Part No. 99757
6 Button Display Trim
Part No. 25748
Splitter Cable Control Box
10
Part No. 99755
6 Button Display Trim
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
7/14/14
Parts Cross Reference
Part No.
System Bath Panels
Part No.
System Bath Panels
90010
Panel Bath 6 Button O/L 12015
90010
Panel Bath 6 Button O/L 12015
90011
Panel Bath 2 Button O/L 12012
90011
Panel Bath 2 Button O/L 12012
90012
Panel Bath 4 Button O/L 12014
90012
Panel Bath 4 Button O/L 12014
90013-01
Panel Bath 4 Button O/L 12013
90013-01
Panel Bath 4 Button O/L 12013
90022
Panel Bath 4 Button O/L 12983
90022
Panel Bath 4 Button O/L 12983
Bath Panels, Cables & Adapters (alphabetically)
Part No.
Material Description
Overall Length Cable
Type
25652
4-Pin Mini DIN Male to Lamp holder Cable Assembly
22 AWG, 8 Foot Length
4 Pin DIN
59007-V
7 LED Bulb Cluster w/Light Pro (Chromatherapy)
8141-6320
Blower 600W HTR 1HP w/Control 115V
25670
Cable 4 Pin DIN to JUDCO 8ft
10 Foot Length
4 Pin DIN
25751
Cable 6 Pin DIN for Water Level
12 Inch Length
6 Pin DIN
25569
Cable Bath 8 Pin Mini Din 6ft
6 Foot Length
8 Pin DIN
25404
Cable Water Detection Conductive 6 Ft
6 Foot Length
99757-AL
Display Trim, 6 Button, Almond
99757-BC
Display Trim, 6 Button, Biscuit
99757-WH
Display Trim, 6 Button, White
99642-CW
Display Trim, Round
25099
Extendable Bulb Holder EFX
25750
Light Adapter Cable 4 Pin DIN
6 inch Length
32016
Sensor Assy Kit, 24in (Dia. 1/4in), (M7 Temperature)
24 Inch Length
99749
Set (2 Ea) of Conductive Screw
25748
Splitter Cable Control Box
9-1/2 Foot Length Overall Approx.)
25749
Splitter Cable Remote Control
6 Foot Length
42135F
4 Pin DIN
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
11
Cable Assembly Diagrams: Adapters and Splitters
DIN Cables and Splitters
6’ Length
8 Pin DIN
Standard DIN Cable for Control Box or Blower Setup
Material No. 25569
6’ Length to “Y”
8 Pin DIN
Splitter Cable for Control Box and Blower Setup
Material No. 25748
Without 5 Volts
3’ Length to “Y”
8 Pin DIN
1’ Length to “Y”
(Blower)
With 5 Volts
8 Pin DIN
(Control Box)
10’ Length
Solenoid Cable Assembly
12
Material No. 25670
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
7/14/14
DIN Modules and Adapters
22 AWG 8’ Length
4-Pin Mini DIN Male to Lampholder Cable Assembly Material No. 25652
6 Inch Length
4-Pin DIN Spa Light Adapter
Material No. 25750
20 Gauge
8 Foot Length
Extendable Bulb Holder EFX
Material No. 25099
12’ inch Length
6-Pin DIN Water Temperature & Level Sensor
Material No. 25751
Material No. 32016
Sensor Assy Kit (1/4” dia.)
24” Length (with nut)
6’ Length
Water Level Sensor
Material No. 25404
42135F
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
13
Common Configurations
Sample 120V Bath Configuration
with a Primary Valve Control Box
12’ inch Length
6-Pin DIN Water Temperature & Level Sensor
Part No. 90018
Primary Valve Bath Control
Material No. 25751
Part No. 32016
Sensor Assy Kit
(24in, 1/4in dia.)
Part No. 25404
Cable Water Detection
Conductive 6 Ft
Temperature and
Water Level Sensor
120V
Part No. 8141-6320
Blower 600W HTR 1HP
w/Control 115V
To Solenoids
Part No. 90010
6 Button Panel
IR Connection
by placing Control
Boxes side by side
Blower or Pump
14
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
7/14/14
Sample EU (230V) Bath Configuration
IR Connection
by placing Control
Boxes side by side
42135F
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
15
Skeletal View
Balboa - Your Single Source Solution
Balboa’s product line
Control Panel
Blower
Air Control
Manifold
Hydromassage Jets
Electronic Controls
Fittings and Tubing
Air Button
Air Massage Jets
Lights
Bath Pump
16
Suction and Drain
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
7/14/14
Installation and Configurations - Solenoids
(2) One Inlet, Three
Outlet Solenoids
Manifold
Solenoid Filter Tee
Pump
One Inlet, Two Solenoids
42135F
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
17
Cables & LED Light
Blower & Air Hose Routing
Blower plumbing
with manifold lines
Part No. 25099
Extendable Bulb Holder EFX
Part No. 59007-V
7 LED Bulb Cluster w/Light Pro
Part No. B-80335WH
Blower 1InSpg C/V Housing
with
Part No. 92152
Union-Std Nut
18
Part No. 8141-6320
Blower 600W HTR 1HP w/Control 115V
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
7/14/14
Component Installation
Installation Overview
Before you begin putting together your bath system, it’s a good
idea to have in mind a layout of where the bath components
are to be installed. A skeletal illustration of installed bath
components is found in the preceding pages.
An important consideration is the location of the topside bath
button control in relation to other equipment. Do not mount
equipment directly under the control panel mounting location in
order to avoid any potential for water to drip directly onto the
equipment. Create a drip-loop in the control panel wires to help
prevent any water traveling down those wires that may drip
onto the equipment.
All three panels use 8-pin DIN connectors. The 8-pin DIN
connector cables plug into any control box. If two control boxes
are used, the panel cable can be plugged into either control box.
If three control boxes are used, the panel cable must be plugged
into the middle control box.
The control boxes can be paired together and will communicate
with each other via IR signals without external connecting
wires or external dipswitch settings. You can have two of
the same type of control boxes (two variable speed boxes
controlling the bath). It is important, however, to place the
control boxes side by side as close as possible to have the
control boxes communicate properly
Installing Control Boxes, Pumps, and
Blower
When mounting pumps, blowers, and control boxes, they must
be mounted securely because of vibration and start & stop
cycles.
Control Boxes
The panel can be plugged into any of the control boxes. If three
boxes are used, the panel must be plugged into the central
control box. All functions will work providing the following
criteria is observed:
1.
2.
3.
4.
The control boxes must be placed side by side.
The control boxes must be aligned next to each other.)
The panel is configured for the equipment used.
Be sure that the sides facing each other are not obstructed,
i.e., papers, stickers, etc. If obstructed, the IR link will not
communicate.
5. Two of the same control boxes can be used together. In
other words, it’s all right to have two 90017 control boxes
controlling your bath, excluding other types of control
boxes. Or, two 90018 boxes can be used together excluding
90017 boxes. And so on.
6. The connectors of the boxes must face in the same
direction (DIN pin connectors facing all one way; power
cords facing all one way).
Top View of Two Control Boxes
42135F
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
19
Installation Instructions for the Titan 6 Button Panel
Material and Tools Needed:
a) Masking tape
b) Power drill with 3/8” drill bit
c) Jig saw
Installation Note: Be sure that the panel will not be
submerged in the water once the tub is filled.
1. Find an appropriate location to install the topside panel.
The surface should be clean and flat so that the adhesive
on the back of the panel will adhere well. Make sure the
cable length will reach the controller(s). Also, make sure
the panel is positioned for easy viewing by the spa user.
2. Take into consideration all of the equipment that will be
installed onto the bath system. Anticipate how long each
cord is to the equipment installed, that is, from the panel,
to the control box, to the pump, or blower, etc.
3. Once an area has been found for the bath panel, apply a
layer or two of masking tape over the area that will be cut
out. The tape will protect the bath surface from getting
marred by the jig saw.
4. After applying the tape, measure a rectangle as shown
in the illustration. When finished, the hole cut-out will be
1-3/8” x 4-1/4”.
Top view, bath
Titan 6 Button Bath Panel Cut Out Pattern _062512
1 - 3/8”
2.375”
4 - 1/4”
6.375”
Titan 6 button bath panel cut-out template
A full
size diagram
Drill a 3/8” hole
in each
cornerfor printing is located at the
back of this manual.
20
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
7/14/14
Drill a 3/8” hole in each corner
5. Drill four 3/8” holes in each corner, as shown.
6. Cut out the remaining material. Deburr the
cut area if necessary. Without removing the
adhesive from the trim ring, set the trim ring
into the hole to check for fit.
Drill a 3/8” hole in each corner
Installing the Trim Ring & Panel
7. Important: Before installing the assembly, be aware that
depending on the trim ring assembly version, the panel may
go into the trim ring one way only. Check for this before
installing the trim ring and panel. The trim ring cut-out is
opposite the display. See below.
8. If the trim ring fits properly into the hole, is aligned, and
the orientation of the panel is correct, install the trim ring
and panel. Remove the masking tape, make sure the bath
surface is clean for good adhesion, remove the adhesive
backing from the back of the panel trim ring (the adhesive
should be fully exposed), then place the trim ring into the
hole and press down firmly.
9. Plug the 8-pin panel cable into the panel system board, and
clip on the cable retainer. Place the 8-pin cable through the
bath cut-out opening, then place the topside panel into the
cut-out. Press down firmly along the trim ring. It will snap
into place.
10. Route the 8-pin cable to the control box.
Trim ring with adhesive
Step No. 9
Clip on the cable retainer
The trim ring cut-out is opposite the display
42135F
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
21
Installation of Temperature Sensor
Temperature Sensor Mount
(two views)
The temperature sensor mount can be installed onto any 1.5” or
2” pipe. For installation of the temperature sensor, refer to the
diagrams below.
Note:
• Mount temperature sensor before heater.
• Mount the assembly in a position so that it is will not come
in contact with anything that can damage the sensor and
assembly.
Procedure
Part No. 381
1.5” Titan Temp Sensor Saddle Barb
1. Find a suitable location for the temperature sensor. In
relation to water flow, the sensor must be placed before
the heater.
2. Drill a 3/8 inch diameter hole as a receptacle for the temp.
sensor mount.
3. Remove burrs, if any.
4. Before applying any solvents, position the sensor mount
onto the pipe to be sure that the surfaces fit properly
together and make good contact.
5. Prepare the PVC surface. Preferably use a PVC Solvent
primer before applying solvent. Apply the PVC solvent
according to the manufacturer’s instructions. Be careful
not to allow the solvent to get into the holes of the pipe or
sensor mount.
6. Press and hold firmly in place, or affix according the
manufacturer’s instructions.
7. Insert the temperature sensor into the fitting. Tighten the
nut to secure the temperature sensor in place.
8. Plug the sensor into a 6-Pin DIN water temperature sensor
cable (Part No. 25751), and then into a 6-Pin DIN receptacle
on the control box.
Part No. 382
2.0” Titan Temp Sensor Saddle Barb
Part No. 32016
Sensor Assy Kit (24in, 1/4in dia.)
Drill 3/8” hole
Part No. 25751
6-Pin DIN Water Temperature & Level Sensor
22
Cross sectional view.
Installation of Temperature Sensor in Mount
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
7/14/14
Installation of Conductive Water Sensor
The conductive water sensor can be installed low in the tub to
sense the presence of water to facilitate blowing out (purge)
an air injector system. It can also be mounted such that one
connection is in the suction line and the second connection
is installed in the water pressure line to act as a water level
sensor to prevent a pump from operating if the water level is
below a predetermined level.
The connections are attached to the plumbing with conductive
screws. The picture of Part No. 99749 shows the two screws
provided in the kit, with washers.
The picture below shows one of the conductive sensor wire
leads installed. The conductive screw holds the metal washer
against the rubber that contacts and seals the side of the pipe.
The other lead is installed in the same way. The sensor is then
plugged into a 6-Pin DIN water temperature and sensor cable
(Part No. 25751), and then into the control box.
Conductive wire sensor lead installed
Part No. 99749
Set (2 Ea) of Conductive Screw
Part No. 25404
Cable Water Detection Conductive 6 Ft
12’ inch Length
6-Pin DIN Water Temperature & Level Sensor
Material No. 25751
Plug into Bath Control
42135F
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
23
Solenoid Valves
Bath Solenoids
Solenoid valves are used to create pulsating water jets and
regulate jet flow patterns. Solenoid valves must be arranged
and wired properly. The controller box can accommodate five
discrete pairs of a twin (5.08mm spacing) pluggable block. Each
discrete pair (two pins) on the controller body can manage one
or two solenoids.
Note:
• Below are examples of typical red and black wiring
diagrams.
• The outputs of the controller box are non-polarized (AC),
yet the solenoids should be wired and connected in a
consistent pattern.
Part No. 25670 Solenoid Cable Assembly
Red
Black
One pluggable block per one solenoid
Red
(2 wires)
Black
(2 wires)
One pluggable block per two solenoids
24
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
7/14/14
Multiple Solenoid Outputs
Consistency in Valve to Jet Connections
As with solenoid wiring needing consistency, solenoid valves
must also be plumbed to jets in a specific, consistent pattern.
When looking at the diagrams, take note of how many valves
each solenoid assembly has, the number assigned to each
solenoid valve, and the types of jets that are connected to the
specific valve number. The valve number has a direct correlation
to the to the paired valve connectors located on the Primary
Valve Control.
For illustrative purposes, a Titan "Configuration 40"
arrangement of solenoid valves is shown over the next several
pages. It shows the following:
• One valve is used for a waterfall or cleaner
• Two valves are used for either a foot jet, neck jet, or pillow
• Three valves are used for a backjet
Since a pillow uses two jets, a two outlet solenoid can operate
two jets, as each solenoid operates each jet. Backjets typically
have six jets. As shown below, two No. 1 solenoids can operate
the two top jets, two No. 2 solenoids can operate the two
middle jets, and two No. 3 solenoids can operate the two
bottom jets.
Pillow = 2 Jets
4
5
One Inlet,
Two Outlet Solenoid
Back Jet = 6 Jets
1
2
3
One Inlet,
Three Outlet Solenoid
1
2
3
One Inlet,
Three Outlet Solenoid
42135F
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
25
Solenoid and Wiring Set-up, Balboa Configuration No. 40
One Inlet,
Two Outlet Solenoid
4
4
5
5
One Inlet,
Three Outlet Solenoid
1
2
1
3
2
One Inlet,
Three Outlet Solenoid
3
1
2
3
26
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
7/14/14
The pluggable blocks must go into their
designated "Valves Used" slot in the green
paired valve connector on the Primary Valve
Bath Control (No. 90018), numbered 1 - 5.
1
2
3
4
5
42135F
Manufactured
under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
Titan_BWG_Configuration_40_wired_setup_010912_0800.ai
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
27
Creating a Configuration 40 Bath System
A bath "system" is actually a specific bath configuration of the
equipment installed. What type of equipment is installed and
how they're a arranged determines the configuration setup
as seen in the Bath Control Configuration Tables. That specific
configuration number is then assigned through the panel,
which must be inputted in order to have the equipment operate
properly.
Bath Setup
Basic list for a bath setup:
When creating a bath system, one place to begin is to consider
the following:
1. Determine what features you’d like
2. Determine the equipment needed
3. Install the equipment to create the system
4. Configure the bath button per the configuration table
The following pages demonstrate installation of equipment
using Configuration Number 40 (or, C40 in the table). This
configuration was chosen for demonstration purposes; yet,
any configuration could have been used. C40 provides an
opportunity to show how multiple solenoid valves are installed.
C40 Overview
Desired Features
Equipment Needed
Oval bathtub
Tub
6 button bath panel
6 button bath panel w/trim
Pulsating pillow and back jet
PVC (Primary Valve Control is needed to control solenoids)
Pump
Pillow (2 jets)
Backjet (6 jets)
(2) One inlet, three outlet solenoids
(1) One inlet, two outlet solenoid
Blower with heater
Quiet-Flo Blower (8141-6320)
Accessories:
Safety features
Temperature read out
Chromatherapy light (7 LED Bulb Cluster)
Water level detection cable
Water temperature sensor
Installing Multiple Solenoid Valves
Further examples of solenoid valve use are as follows: one
solenoid valve is used for a waterfall or cleaner, two valves are
used to operate either a foot jet, neck jet, or pillow, and three
valves are used for a backjet. According to the Bath Control
Configuration Table indicates that C40 operates a backjet
(button 5) and a pillow (button 6). As noted previously, keep the
following in mind:
• The controller box can accommodate five discrete pairs of a
twin pluggable blocks. 10 solenoid valves can be controlled
from one PVC box. If more solenoid valves are installed,
two valve control boxes (90018) are needed.
28
• If two or more control boxes are connected, whether they
are PVC or VSC, they must be positioned and configured
properly so that they can communicate via the wireless
IR link.
• Although the paired valve connectors on the control boxes
are non-polarized (AC), the solenoids should be wired to the
valves in a consistent pattern.
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
7/14/14
Codes, Abbreviations, and Terms
Using Bath Button Code Configurations
Once the type of equipment to be installed is determined, then it's all a matter of understanding the nomenclature used
and cross referencing that information to the configuration tables.
VSC
Variable Speed Control
PVC
Primary Valve Control
IBC
Integrated Blower Control
Primary
A VSC or PVC connected directly to the panel (Do not confuse a "Primary" Valve Control [PVC] with Primary Location.)
Secondary
A VSC or PVC controlled by the Primary over the IR link
Tertiary
A second VSC or PVC controlled by the Primary over the IR link
Code
Equipment, such as Pumps, Blower, Wfall, Control Box, etc. Often preceded by a "Location" as either P for
Primary, S for Secondary, or T for Tertiary. The prefix of the Code is associated with the Location. The suffix of
the Code is associated with Valves Used.
Source of the signal used to operate equipment. The Location is most often Primary, Secondary, Tertiary, or Blower.
Location
Valves Used Any valve output connector on the Primary Valve Control, numbered 1-5.
System Timer Codes
The System Timer button is used to start the internal Session Timer and enable the other device buttons. The current
implementation requires water to be present on all attached water sensors. If the button is held down while the Session Timer
is running, the remaining time will increment in 5 minute intervals until the maximum session time is reached.
Code
Function
SystemTimer
Starts the session timer and enables other device buttons.
Light Codes
These codes provide On/Off control of a light. Only one light code may be assigned to a panel configuration.
Code
Location
VSC
PVC
PLight
Primary
X
X
SLight
Secondary
X
X
BLight
Blower
42135F
IBC
X
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
29
Codes, Abbreviations, and Terms (cont.)
Pump Codes
•
•
•
•
Pumps are specified as either single or variable speed.
A single-speed pump is truly single speed and does not provide for speed adjustment or Wave mode.
The Plus and Minus codes cannot be assigned to a panel if the associated pump is single-speed.
Two pumps may be assigned to a system, on either a VSC or PVC.
Code
Location
Speeds
Function
PPump
Primary
Single
Turns the pump on and off.
PPumpV
Primary
Variable
Turns the pump on and off. Holding the button ramps the speed. Pressing
twice at startup puts the pump in Wave mode.
PPumpPlus
Primary
(Variable)
Clicking increases the pump speed 1 step. Holding ramps the speed up
until released.
PPumpMinus
Primary
(Variable)
Clicking reduces the pump speed 1 step. Holding ramps the speed down
until released.
SPump
Secondary
Single
Turns the pump on and off.
SPumpV
Secondary
Variable
Holding the button ramps the speed. Pressing twice at startup puts the
pump in Wave mode.
SPumpPlus
Secondary
(Variable)
Clicking increases the pump speed 1 step. Holding ramps the speed up
until released.
SPumpMinus
Secondary
(Variable)
Clicking reduces the pump speed 1 step. Holding ramps the speed down
until released.
TPump
Tertiary
Single
Turns the pump on and off.
TPumpV
Tertiary
Variable
Holding the button ramps the speed. Pressing twice at startup puts the
pump in Wave mode.
TPumpPlus
Tertiary
(Variable)
Clicking increases the pump speed 1 step. Holding ramps the speed up
until released.
TPumpMinus
Tertiary
(Variable)
Clicking reduces the pump speed 1 step. Holding ramps the speed down
until released.
30
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
7/14/14
Blower Codes
•
•
•
•
The system design assumes all blowers are inherently variable speed.
The speed designations ‘single’ and ‘variable’ are used to define how the On/Off button behaves.
The ‘Plus’ and ‘Minus’ functions may be assigned to all blowers regardless of the On/Off button behavior.
Only one blower may be assigned per system.
Code
Location
VSC
PVC
PBlower
Primary
X
X
X
X
PBlowerV
Primary
X
X
X
X
PBlowerNoMode
Primary
X
X
X
PBlowerPlus
Primary
X
X
X
X
PBlowerMinus
Primary
X
X
X
X
SBlower
Secondary
X
X
X
X
SBlowerV
Secondary
X
X
X
X
SBlowerNoMode
Secondary
X
X
X
SBlowerPlus
Secondary
X
X
X
X
SBlowerMinus
Secondary
X
X
X
X
BBlower
Blower
X
X
X
BBlowerV
Blower
X
X
X
BBlowerNoMode
Blower
X
X
BBlowerPlus
Blower
X
X
X
BBlowerMinus
Blower
X
X
X
42135F
IBC
On/Off Wave/Pulse Speed Ramp
Speed Change
X
X
X
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
31
Codes, Abbreviations, and Terms (cont.)
Valve Codes
Back Jet Codes
Valves, referring to solenoids, or solenoid valves, create
pulsations of water from jets. When two or more jets are
arranged in a group, they can be positioned and wired to create
pulsating patterns at varying speeds. Bath buttons that have an
LED readout (two and six button bath panels), allow the user to
regulate pulsating jet patterns and speeds with the following
readouts:
• PT: Pattern of jet pulsations with speed adjustment
(synchronous or alternating). synchronous or alternating.
PT1 is the lowest speed pattern.
• ROL: Rolling means that over several seconds the blower or
pump reduces and then increases in speed. Then the cycle
resumes.
A Back Jet uses three valves and requires the specified box be a
PVC. Two Back Jets may be assigned to a panel configuration.
Because of the many options available for valve set up and hose
routing, setting up pulsating jets is a bit more involved than
other equipment. The "Valves Used" references in the table at
right are necessary for configuration.
While keeping in mind the number of valves needed for the
equipment installed on the system that is being set up, find that
equipment (back jet, pillow, etc.) and then use the "Code" and
"Location" to see what valves are to be used on the PVC, as only
the PVC box has green paired valve connectors.
Once the proper Code and Location is determined, connect the
solenoid wires into the valve control connector(s) on the box.
Code
Location
Valves Used
PBackJet
Primary
1, 2, 3
SBackJet
Secondary
1, 2, 3
Pillow Codes
Pillows are also referred to as Neck Jets or Foot Jets. A pillow
uses two valves and requires the specified box be a PVC. Two
pillows may be assigned to a panel configuration.
Code
Location
Valves Used
PPillow
Primary
1, 2
SPillow
Secondary
4, 5
Waterfall Codes
A Waterfall uses a single valve and requires the specified
box be a PVC. Only one Waterfall may be assigned to a
panel configuration.
Code
Location
Valve Used
PWFall
Primary
3
SWFall
Secondary
4
Cleaner Codes
A Cleaner uses a single valve and requires the specified box be a
PVC. Only one Cleaner may be assigned to a panel configuration.
1
2
Code
Location
Valve Used
PClean3
Primary
3
3
PClean5
Primary
5
4
SClean3
Secondary
3
5
SClean5
Secondary
5
10 Position Valve Control Connector
32
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
7/14/14
Bath Control Configuration Tables
Generic BWG 6-button panel - P/N 90010
Config.
Button 1
Button 2
Button 3*
Button 4
Button 5
Button 6
C01
PPumpV
-
User1
-
-
-
C02
PPumpV
-
User1
PLight
-
-
C03
PPumpV
-
User1
-
PBackJet1
-
C04
PPumpV
-
User1
PLight
PBackJet1
-
C05
PPumpV
-
User1
-
PPillow1
-
C06
PPumpV
-
User1
PLight
PPillow1
-
C07
PPumpV
-
User1
-
PBackJet1
PPillow4
C08
PPumpV
-
User1
PLight
PBackJet1
PPillow4
C09
PPumpV
-
User1
-
PBackJet1
PWFall4
C10
PPumpV
-
User1
PLight
PBackJet1
PWFall4
C11
PPumpV
-
User1
-
PPillow1
PWFall3
C12
PPumpV
-
User1
PLight
PPillow1
PWFall3
C13
PPumpV
-
User1
-
PPillow1
PPillow4
C14
PPumpV
-
User1
PLight
PPillow1
PPillow4
C15
PPumpV
-
User1
SWFall3
PBackJet1
SPillow1
C16
PPumpV
-
User1
PBackJet1
SPillow1
SPillow4
C17
PPump
-
User1
-
PBackJet1
-
C18
PPump
-
User1
PLight
PBackJet1
-
C19
PPump
-
User1
-
PPillow1
-
C20
PPump
-
User1
PLight
PPillow1
-
C21
PPump
-
User1
-
PBackJet1
PPillow4
C22
PPump
-
User1
PLight
PBackJet1
PPillow4
C23
PPump
-
User1
-
PBackJet1
PWFall4
C24
PPump
-
User1
PLight
PBackJet1
PWFall4
C25
PPump
-
User1
-
PPillow1
PWFall3
C26
PPump
-
User1
PLight
PPillow1
PWFall3
C27
PPump
-
User1
-
PPillow1
PPillow4
* Until you program it, the User button functions as an “all off” button.
See "User Button" under "Titan Bath Control Behavioral Specs."
42135F
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
33
Bath Control Configuration Tables (cont.)
Generic BWG 6-button panel - P/N 90010 (cont.)
Config.
Button 1
Button 2
Button 3*
Button 4
Button 5
Button 6
C28
PPump
-
User1
PLight
PPillow1
PPillow4
C29
PPump
-
User1
SWFall3
PBackJet1
SPillow1
C30
PPump
-
User1
PBackJet1
SPillow1
SPillow4
C31
-
BBlowerV
User1
-
-
-
C32
-
BBlowerV
User1
BLight
-
-
C33
PPumpV
BBlowerV
User1
-
-
-
C34
PPumpV
BBlowerV
User1
BLight
-
-
C35
PPumpV
BBlowerV
User1
-
PBackJet1
-
C36
PPumpV
BBlowerV
User1
BLight
PBackJet1
-
C37
PPumpV
BBlowerV
User1
-
PPillow1
-
C38
PPumpV
BBlowerV
User1
BLight
PPillow1
-
C39
PPumpV
BBlowerV
User1
-
PBackJet1
PPillow4
C40
PPumpV
BBlowerV
User1
BLight
PBackJet1
PPillow4
C41
PPumpV
BBlowerV
User1
-
PBackJet1
PWFall4
C42
PPumpV
BBlowerV
User1
BLight
PBackJet1
PWFall4
C43
PPumpV
BBlowerV
User1
-
PPillow1
PWFall3
C44
PPumpV
BBlowerV
User1
BLight
PPillow1
PWFall3
C45
PPumpV
BBlowerV
User1
-
PPillow1
PPillow4
C46
PPumpV
BBlowerV
User1
BLight
PPillow1
PPillow4
C47
PPumpV
BBlowerV
User1
SWFall3
PBackJet1
SPillow1
C48
PPumpV
BBlowerV
User1
PBackJet1
SPillow1
SPillow4
C49
PPump
BBlowerV
User1
-
PBackJet1
-
C50
PPump
BBlowerV
User1
BLight
PBackJet1
-
C51
PPump
BBlowerV
User1
-
PPillow1
-
C52
PPump
BBlowerV
User1
BLight
PPillow1
-
C53
PPump
BBlowerV
User1
-
PBackJet1
PPillow4
C54
PPump
BBlowerV
User1
BLight
PBackJet1
PPillow4
C55
PPump
BBlowerV
User1
-
PBackJet1
PWFall4
C56
PPump
BBlowerV
User1
BLight
PBackJet1
PWFall4
C57
PPump
BBlowerV
User1
-
PPillow1
PWFall3
C58
PPump
BBlowerV
User1
BLight
PPillow1
PWFall3
C59
PPump
BBlowerV
User1
-
PPillow1
PPillow4
C60
PPump
BBlowerV
User1
BLight
PPillow1
PPillow4
C61
PPump
BBlowerV
User1
SWFall3
PBackJet1
SPillow1
C62
PPump
BBlowerV
User1
PBackJet1
SPillow1
SPillow4
* Until you program it, the User button functions as an “all off” button.
See "User Button" under "Titan Bath Control Behavioral Specs."
34
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
7/14/14
Bath Control Configuration Tables (cont.)
Generic BWG 2-button panel - P/N 90011
Overlay: 12012
42135F
Config.
Button 1
Button 2
C01
PPumpV
-
C02
PPumpV
PLight
C03
PPumpV
PBackJet1
C04
PPumpV
PPillow1
C05
PPumpV
PWFall3
C06
PPumpV
BBlowerV
C07
PPump
-
C08
PPump
PLight
C09
PPump
PBackJet1
C10
PPump
PPillow1
C11
PPump
PWFall3
C12
PPump
BBlowerV
C13
BBlowerV
-
C14
BBlowerV
BLight
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
35
Bath Control Configuration Tables (cont.)
Generic BWG 4-button panel w/User - P/N 90012
Group: 1, File: 90012_4Btn1.xml
Part No.: 90012
Overlay: 12014
36
Part No.: 90022
Overlay: 12983
Pump or
Blower
Device
or Valve
Pump or
Blower
Valve
User
Valve
Config.
Button 1
Button 2
Button 3
Button 4
C01
PPumpV
PLight
PBackJet1
User1
C02
PPumpV
PLight
PPillow1
User1
C03
PPumpV
PLight
PWFall3
User1
C04
PPumpV
PPillow4
PBackJet1
User1
C05
PPumpV
PWFall4
PBackJet1
User1
C06
PPumpV
PWFall3
PPillow1
User1
C07
PPumpV
PPillow1
PPillow4
User1
C08
PPump
PLight
PBackJet1
User1
C09
PPump
PLight
PPillow1
User1
C10
PPump
PLight
PWFall3
User1
C11
PPump
PPillow4
PBackJet1
User1
C12
PPump
PWFall4
PBackJet1
User1
C13
PPump
PWFall3
PPillow1
User1
C14
PPump
PPillow1
PPillow4
User1
C15
BBlowerV
BLight
-
User1
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
7/14/14
Generic BWG 4-button panel w/two valves - P/N 90022
Part No.: 90022
Overlay: 12983
42135F
Part No.: 90013
Overlay: 12013
Device
or Valve
Pump or
Blower
Device
or Valve
Pump or
Blower
User
Valve
Valve
Up
Config.
Button 1
Button 2
Button 3
Button 4
C01
PPumpV
PLight
-
-
C02
PPumpV
PLight
PPillow4
PBackJet1
C03
PPumpV
PLight
PPillow1
PWFall3
C04
PPumpV
PLight
PBackJet1
PWFall4
C05
PPumpV
PLight
PPillow1
PPillow4
C06
PPumpV
PBackJet1
SPillow1
SPillow4
C07
PPumpV
SWFall3
SPillow1
PBackJet1
C08
PPump
PLight
-
-
C09
PPump
PLight
PPillow4
PBackJet1
C10
PPump
PLight
PPillow1
PWFall3
C11
PPump
PLight
PBackJet1
PWFall4
C12
PPump
PLight
PPillow1
PPillow4
C13
PPump
PBackJet1
SPillow1
SPillow4
C14
PPump
SWFall3
SPillow1
PBackJet1
C15
BBlowerV
BLight
-
-
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
37
Bath Control Configuration Tables (cont.)
Generic BWG 4-button panel w/up-down - P/N 90013
Group: 3, File: 90013_4Btn3.xml
Part No.: 90013
Overlay: 12013
38
Device
or Valve
Pump or
Blower
Device
or Valve
Valve
Up
Down
Config.
Button 1
Button 2
Button 3
Button 4
C01
BBlower
BLight
BBlowerPlus
BBlowerMinus
C02
BBlower
-
BBlowerPlus
BBlowerMinus
C03
PPumpV
-
PPumpPlus
PPumpMinus
C04
PPumpV
PLight
PPumpPlus
PPumpMinus
C05
PPumpV
PBackJet1
PPumpPlus
PPumpMinus
C06
PPumpV
PPillow1
PPumpPlus
PPumpMinus
C07
PPumpV
PWFall3
PPumpPlus
PPumpMinus
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
7/14/14
Bath Button Panel Configuration
Use the first two buttons for setting up the configurations
Configuring the 6 Button Bath Panel
There are many configurations possible with the Titan 6 and 2
button bath panels. The panel must be programmed after all
of the equipment is installed and connected for the panel and
control boxes to interact effectively.
The process to configure either of these bath panels is the
same. Two buttons are pressed upon startup to provide access
to the Configuration Set-up menu. The 6-button panel is
accessed by using the first two buttons.
Using the 6-button panel as an example, find the set-up that you
have installed using the “Bath Control Configuration Tables” to
find the closest set-up of equipment installed, and the specific
buttons that you’ll want to dedicate to run that equipment. Then
proceed to set up, or input that configuration number into your
panel. Be sure to start from a complete power down. Note:
During the process, the panel times out after 10 seconds. If that
happens, restart the procedure.
3. To increment the configuration number, press B1once.
Press repeatedly until the desired configuration number is
reached. Hold B1 down to automatically cycle through the
configurations.
4. To store the configuration in to the panel’s memory,
press B2. The panel will reboot and a startup sequence
will display. If after the boot up, an Err (Error) displays,
it means that the configuration entered does not match
the equipment installed. Recheck the equipment and
then the table. The Panel Error Codes page should help in
diagnosing the error.
Configuring the 2 Button Bath Panel
The process is the same as programing the 6 button panel
above. The differences will be that you’ll use a different
configuration table, and have fewer configurations available.
The error codes are the same for 2 and 6 button panels.
1. Apply power.
2. All LED’s will light up. Wait until CON displays, then press
the first two buttons and hold. Keep holding until a capital
“C” is displayed followed a decimal point and two digits
indicating the currently selected configuration.
42135F
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
39
Bath Button Panel Configuration (cont.)
Configuring the 4 Button Bath Panel
Four button panels do not have a readout display, but use
LED’s to provide status information during operation. The
LED's are also used to configure the panel. There are three
four button bath panels. Yet, each four button panel is capable
of being configured in many ways. Be sure to reference what
equipment is installed with the button used and then configure
it accordingly after equipment setup.
The panel displays LED's in binary numbers to designate the
configuration number. Below is a table that shows the binary
equivalents to the configuration number.
1. Upon power-up, The four LED’s will blink.
2. Press and hold the 2nd button down for 5-10 seconds. The
LED’s will begin to count in a binary format. (Note: The
counting sequence may not start at one, depending on the
last configuration stored.)
3. Once the configuration that you need is reached, release
the button.
4. The panel will reboot and go through a start up sequence.
The last sequence of numbers after the boot up will show
the binary configuration that had just been programed.
Note: Panel No. 90013 has seven configuration numbers. The
remaining 4 button panels have 15 configurations.
Config. No.
LED Display
Binary No.
1
0001
2
0010
3
0011
4
0100
5
0101
6
0110
7
0111
8
1000
9
1001
10
1010
11
1011
12
1100
13
1101
14
1110
15
1111
After start-up, the four buttons will flash.
Press and hold the second button.
Release the button at the desired configuration.
This is configuration six.
40
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
7/14/14
6 Button Bath Control User Guide
Session Timer
• Turning on a device starts a Session Timer that lasts for 20 minutes. The
Timer can be changed using User Preferences.
• If a temperature sensor is available, the temperature will display for 20
minutes once a Session has started and then during the purge cycle.
• A bright button indicates the function is on.
A dim button indicates the function is available but not on.
Power Up
Upon power up, the Bath Control
goes through a self diagnostic check
that lasts for about 15 seconds. The
LED Display will then show the
water temperature or a blank display,
depending on whether a water
temperature sensor is installed or not.
Therapy Button
• Button press turns Therapy On/Off
• If variable speed is available, press
and hold Therapy button to change
speed
• Pressing twice once running starts
Wave Mode
•
•
•
•
Light Button/Massage Button
• The light can be controlled
independently of all other features
• Some lighting options have unique
operation for color changes; see the
manual for any special light system
that may be installed
• If configured as a Massage Button,
see next panel
42128 A July 29, 2013
Blower Button
“Bubbler”/aeration/aerator
Allows for a “purge” cycle
Within seconds accelerates to high
speed, then adjustments are made
thereafter
Holding changes speed with
auto-reverse capability
Massage Button
• The Therapy (pump) button must be
On to have the Massage run
• When Therapy is turned Off,
Massage is turned off automatically
• Variable speeds: Change speed
with multiple presses (Back Jet and
pillow)
Please see reverse side for more information.
User Button
• If equipped, the Back Jet is
activated
•
Massage Button
• The Therapy (pump) button must be
On to have the Massage run
• When Therapy is turned Off,
Massage is turned off automatically
• Variable speeds: Change speed
with multiple presses (Back Jet and
pillow)
User Preferences
User Preferences allow changes to
certain default settings in the control.
Note:
Previously saved variables will display solid; new
choices will flash.
If the control is displaying User Preferences and no
button is pressed within 10 seconds, the panel exits
User Preferences without saving any new settings.
When Setting User Preferences
Adjusts the variables in each menu
Navigates from one menu to the next
To View and Edit User Preferences, press...
AND
for 5 seconds.
The Session Timer Menu will display the current time-out. Release both buttons.
Each press changes the length of the Session Timer.
Press to show Time/Temp. Display Settings.
Edit t = Time, H = Water Temp., or tH = both.
If no temperature sensor is present, this is fixed at d.t (display timer).
Press again to show the Temperature Display Menu.
Toggle between C = Celsius, or F = Fahrenheit.
Press again to show the Store menu.
Select St.y (Yes) to Save and Exit your new settings, or
St.n (No) to Exit without saving new settings.
Press again to confirm the Store menu choice.
Purge Cycle
(Blower Installations Only)
A Purge Cycle removes standing water
from the plumbing and dries the air
delivery system. This helps maintain a
sanitary plumbing system. The purge
cycle lasts for 1 minute.
• Once a Session has ended, “End” (of session) appears on the display indicating that
the Purge End Use Timer is active and counting down. The purge cycle will
begin after 20 minutes.
a) Pur is then displayed and will last for 1 minute during the purge cycle.
b) Once the Purge Cycle is finished, the system shuts down and the display is blank.
c) Turning on a pump or blower during the End Use Timer will stop the timer and
start a new session.
Display & Messages
• Display shows water display,
pattern changes, speed of devices
used, warning and error messages.
• If all sensors are installed, the
water temperature will display
during a user session. The water
temperature and time remaining
will alternate on the display.
• How the information is displayed
can be adjusted in User
Preferences.
•
Hot Water Detection (only if a temperature sensor is installed)
Water that exceeds 111° F will display: [Temperature] - too - hot.
The panel goes to normal operation when hot water is no longer detected.
•
No Water Detection
If no pump water is detected, the display will flash no - h2o when a button is pressed.
•
System Error Detection
If an error occurs in the bath system, ERR will display.
Additional codes will follow to assist with diagnostics.
•
LED Display:
Con: “Configuration Settings”*
T29: Time remaining in minutes
SP6: “Speed” (SP1 is lowest speed)
PUL: “Pulse” Mode
ROL: “Rolling” (Blower cycles up and down in speed)
PT3: “Pattern” of pulses (PT1 is lowest speed)
• *Note: This is one of dozens of configurations available.
42128 A July 29, 2013
© 2013 Balboa Water Group
2 Button Bath Control User Guide - Therapy, Light/Aux
Therapy
Light/Aux
Power Up
Therapy
• Upon power up, the Bath Control
goes through a self diagnostic
check that lasts for about 15
seconds. The LED Display will
then show the water temperature
or a blank display, depending on
whether a water temperature
sensor is installed or not.
Single Speed
• Press the button to turn Therapy On or Off.
Variable Speed
• Press the button once to turn Therapy On or Off.
• Holding the button ramps the speed to high speed, then ramps down to
lowest speed. The action then repeats. Release on the desired speed.
• Pressing twice at startup puts Therapy in Wave mode.
Session Timer
Light/Aux Button
• Turning on a device starts a
Session Timer that lasts for 20
minutes. The Timer can be changed
using User Preferences (see back).
• If a temperature sensor is available,
the temperature will display for 20
minutes once Session has started
and then during the purge cycle.
Blower (if installed as Aux)
Please see reverse
side for more information.
40939 A July 29, 2013
• The light can be controlled independently of all other features.
• Aux (if used) may be used for Pillow, Waterfall, or Backjet.
Speed
• If the Blower is off, press the Blower button once to turn it on.
• If you press and hold the Blower button, it ramps to and from the highest
to lowest speed. If you press and hold the Blower button again, it
continues to ramp repeatedly. The action then repeats. Release on the
desired speed.
• If the Blower is on, press the Blower button once to turn the Blower Off.
Modes (turn on, beginning with blower off)
• Press the Blower button twice to put the Blower in Pulse mode, or
• Press the Blower button three times to put the Blower in Wave mode.
User Preferences
User Preferences allow changes to
certain default settings in the control.
Note:
Previously saved variables will display solid;
new choices will flash.
If the control is displaying User Preferences
and no button is pressed within 10 seconds,
the panel exits User Preferences without
saving any new settings.
When Setting User Preferences
Navigates from one menu to the next
To View and Edit User Preferences, press...
AND
for 5 seconds.
The Session Timer Menu will display t.30. Release both buttons.
Each press changes the length of the Session Timer.
Press to show Time/Temp. Display Menu.
Edit t = Time, H = Water Temp., or tH = both.
If no temperature sensor is present, this is fixed at d.t (display timer).
Press again to show the Temperature Display Menu.
Toggle between C = Celsius, or F = Fahrenheit.
Press again to show the Store menu.
Select St.y (Yes) to Exit and Save your new settings, or
St.n (No) to Exit without saving new settings.
Press again to confirm the Store menu choice.
102
Adjusts the variables in each menu
Purge Cycle
(Blower Installations Only)
A Purge Cycle removes standing water
from the plumbing and dries the air
delivery system. This helps maintain a
sanitary plumbing system. The purge
cycle lasts for 1 minute.
• Once a Session has ended, “End” (of session) appears on the display indicating that
the Purge End Use Timer is active and counting down. The purge cycle will begin
after 20 minutes.
a) Pur is then displayed and will last for 1 minute during the purge cycle.
b) Once the Purge Cycle is finished, the system shuts down and the display is blank.
c) Turning on a pump or blower during the End Use Timer will stop the timer and start
a new session.
Display & Messages
• Display shows water display,
pattern changes, speed of
devices used, warning and error
messages.
• If all sensors are installed, the
water temperature will display
during a user session. The water
temperature and time remaining
will alternate on the display.
• How the information is
displayed can be adjusted in
User Preferences.
40939 A July 29, 2013
•
Hot Water Detection (only if a temperature sensor is installed)
Water that exceeds 111° F will display: [Temperature] - too - hot.
The panel goes to normal operation when hot water is no longer detected.
•
No Water Detection
If no pump water is detected, the display will flash no - h2o when a button is pressed.
•
System Error Detection
If an error occurs in the bath system, ERR will display.
Additional codes will follow to assist with diagnostics.
•
LED Display:
Con: “Configuration Settings”
T29: Time remaining in minutes
SP6: “Speed” (SP1 is lowest speed)
PUL: “Pulse” Mode
ROL: “Rolling” (Blower cycles up and down in speed)
PT3: “Pattern” of pulses (PT1 is lowest speed)
© 2013 Balboa Water Group
4 Button Bath Control User Guide Blower, Light, Speed Buttons
Blower
Light
Reduce Speed
Increase Speed
Power Up
• Upon power up, the LEDs flash as
the bath control goes through a
self diagnostic check. Once the
LEDs stop flashing, you may use
the control.
Session Timer
• Turning on a device starts a
Session Timer that lasts for
20 minutes.
Optional Heated Quiet-Flo Blower
• Any time the blower turns on, the
heater turns on with it.
40936 A July 29, 2013
Blower
Blower Speed
• If the Blower is off, press the Blower button once to turn the Blower On.
• If the Blower is on, press the Blower button once to turn the Blower Off.
• Click the + or - button to increase or decrease the speed in steps.
• Press and hold the + or - button to increase or decrease the speed smoothly.
Modes (turn on, beginning with blower off)
• Press the Blower button twice to put the Blower in Pulse mode, or
• Press the Blower button three times to put the Blower in Wave mode.
Light
• If you have a light installed, the light can be controlled independently of all
other features.
• Some lighting options have unique operation for color changes. See the
manual for any special light system that may be installed.
Please see reverse side for more information.
LED Definition
Session Timer On
Tells you a device button has been pressed and a
Session Timer is running.
Water Level Detected
Tells you there is still water in the tub. (Sensor
required.)
Error
Tells you that your system needs servicing.
(See Error Codes for Bath Button Displays.)
LED Messages
System Error Detection
• If an error occurs in the bath system, the red ERROR LED will flash.
• In addition, the three remaining LEDs stay lit in a specific on/off pattern that
reveals a diagnostic code of the error. If this should occur, take note which
of the three lights are on or off. This information will help technical support
in diagnosing the error.
System Reset
• Press and hold the two top buttons for 5 seconds to turn all equipment
off. Continue to hold the two top buttons 5 seconds longer to restart the
system.
Purge Cycle
40936 A July 29, 2013
• A Purge Cycle removes standing water from the plumbing and dries the air
delivery system. This helps maintain a sanitary plumbing system.
• Once the bath control thinks you’re finished using the bath, it schedules a
Purge Cycle. The Session Timer LED flashes periodically to indicate that a
Purge Cycle will soon begin.
• Certain actions may cancel the planned Purge Cycle. This is normal.
Otherwise, after a number of minutes, the 1-minute Purge Cycle will begin. At
that point, the Session Timer LED will light continuously.
• When the Purge Cycle ends, all equipment turns off and the Session Timer LED
turns off.
© 2013 Balboa Water Group
4 Button Bath Control User Guide Blower, Light, User Favorite
Blower
Light
User Favorite
Power Up
• Upon power up, the LEDs flash as
the bath control goes through a
self diagnostic check. Once the
LEDs stop flashing, your Therapy
Session is ready to begin.
Session Timer
• Turning on a device starts a
Session Timer that lasts for
20 minutes.
Optional Heated Quiet-Flo Blower
• Any time the blower turns on, the
heater turns on with it.
Blower
Speed
• If the Blower is off, press the Blower button once to turn it on.
• If you press and hold the Blower button, it ramps to and from the highest to
lowest speed. If you press and hold the Blower button again, it continues to
ramp repeatedly. The action then repeats. Release on the desired speed.
• If the Blower is on, press the Blower button once to turn the Blower Off.
Modes (turn on, beginning with blower off)
• Press the Blower button twice to put the Blower in Pulse mode, or
• Press the Blower button three times to put the Blower in Wave mode.
Light
• If you have a light installed, the light can be controlled independently of all
other features.
• Some lighting options have unique operation for color changes.
• See the manual for any special light system that may be installed.
User Favorite
• Used to recall a specific equipment setting.
• When you wish to save an active equipment setting or combination, press and
hold the Favorite button for 2 seconds. The Favorite LED will illuminate.
• When you wish to recall your favorite setting, press (do not hold) the Favorite
button. Within a second or two, the equipment operation will match what you
last saved, and the Favorite LED will illuminate.
• If you then change settings, the Favorite LED will go out (to show that you are
no longer using the settings exactly as you saved them).
40935 A July 29, 2013
Please see reverse side for more information.
LED Definition
Session Timer On
Tells you a device button has been pressed and a Session
Timer is running.
Water Level Detected
Tells you adequate water level has been reached to run the
system. (Sensor required.)
Favorite Setting On
Tells you that your favorite setting is running.
Error
Tells you that your system needs servicing.
(See Error Codes for Bath Button Displays.)
LED Messages
No Therapy Water Detection (Sensor required)
• If no water is detected:
a) The water devices all shut down,
b) The Water Level Detected LED flashes for several seconds before it turns off.
System Error Detection
• If an error occurs in the bath system, the red ERROR LED will flash.
• In addition, the three remaining LEDs stay lit in a specific on/off pattern that
reveals a diagnostic code of the error. If this should occur, take note which of
the three lights are on or off. This information will help technical support in
diagnosing the error.
System Reset
• Press and hold the two top buttons for 5 seconds.
• Continue to hold the two top buttons 5 seconds longer to restart the system.
Purge Cycle
40935 A July 29, 2013
• A Purge Cycle removes standing water from the plumbing and dries the air
delivery system. This helps maintain a sanitary plumbing system.
• Once the bath control thinks you’re finished using the bath, it schedules a
Purge Cycle. The Session Timer LED flashes periodically to indicate that a
Purge Cycle will soon begin.
• Certain actions may cancel the planned Purge Cycle. This is normal.
Otherwise, after a number of minutes, the 1-minute Purge Cycle will begin. At
that point, the Session Timer LED will light continuously.
• When the Purge Cycle ends, all equipment turns off and the Session Timer LED
turns off.
© 2013 Balboa Water Group
4 Button Bath Control User Guide - Therapy, Options
Option 1
Therapy
Option 2
Power Up
• Upon power up, the LEDs flash as
the bath control goes through a self
diagnostic check. Once the LEDs
stop flashing, your Therapy Session
is ready to begin.
Session Timer
• Turning on a device starts a Session
Timer that lasts for 20 minutes.
Optional Heated Quiet-Flo Blower
• Any time the blower turns on, the
heater turns on with it.
Option 3
Therapy
Single Speed
• Press the button to turn Therapy On or Off.
Variable Speed
• Press the button once to turn Therapy On or Off.
• Holding the button ramps the speed to high speed, then ramps down to
lowest speed. The action then repeats. Release on the desired speed.
• Pressing twice at startup puts Therapy in Wave mode.
Massage
• Therapy must be On for Massage to run.
• Press the button once to turn the Massage On. Press it again (repeatedly)
to choose different Massage patterns, or to turn the Massage Off.
• When Therapy is turned Off, Massage is turned off automatically.
Waterfall
• A button press turns the Waterfall On or Off.
• Therapy must be On for Waterfall to run.
• When Therapy is turned Off, Waterfall is turned off automatically.
Blower
(Optional)
Speed
• If the Blower is off, press the Blower button once to turn it on.
• If you press and hold the Blower button, it ramps to and from the highest to
lowest speed. If you press and hold the Blower button again, it continues to
ramp repeatedly. The action then repeats. Release on the desired speed.
• If the Blower is on, press the Blower button once to turn the Blower Off.
Modes (turn on, beginning with blower off)
• Press the Blower button twice to put the Blower in Pulse mode, or
• Press the Blower button three times to put the Blower in Wave mode.
Light (Option 1 only)
• The light can be controlled independently of all other features.
• Aux (if used) may be used for Pillow, Waterfall, or Backjet.
40933 A July 29, 2013
Please see reverse side for more information.
LED Definition
Session Timer On
Tells you a device button has been pressed and a Session
Timer is running.
Water Level Detected
Tells you adequate water level has been reached to run the
system. (Sensor required.)
Favorite Setting On
Tells you that your favorite setting is running.
Error
Tells you that your system needs servicing.
(See Error Codes for Bath Button Displays.)
LED Messages
No Therapy Water Detection (Sensor required)
• If no water is detected:
a) The water devices all shut down,
b) The Water Level Detected LED flashes for several seconds before it turns off.
System Error Detection
• If an error occurs in the bath system, the red ERROR LED will flash.
• In addition, the three remaining LEDs stay lit in a specific on/off pattern that
reveals a diagnostic code of the error. If this should occur, take note which of
the three lights are on or off. This information will help technical support in
diagnosing the error.
System Reset
• Press and hold the two top buttons for 5 seconds.
• Continue to hold the two top buttons 5 seconds longer to restart the system.
Purge Cycle
40933 A July 29, 2013
• A Purge Cycle removes standing water from the plumbing and dries the air
delivery system. This helps maintain a sanitary plumbing system.
• Once the bath control thinks you’re finished using the bath, it schedules a
Purge Cycle. The Session Timer LED flashes periodically to indicate that a
Purge Cycle will soon begin.
• Certain actions may cancel the planned Purge Cycle. This is normal.
Otherwise, after a number of minutes, the 1-minute Purge Cycle will begin. At
that point, the Session Timer LED will light continuously.
• When the Purge Cycle ends, all equipment turns off and the Session Timer LED
turns off.
© 2013 Balboa Water Group
4 Button Bath Control User Guide Therapy, Option, Speed Buttons
Option
Therapy
Reduce Speed
Increase Speed
Power Up
• Upon power up, the LEDs flash as
the bath control goes through a self
diagnostic check. Once the LEDs
stop flashing, your Therapy Session
is ready to begin.
Session Timer
• Turning on a device starts a Session
Timer that lasts for 20 minutes.
Optional Heated Quiet-Flo Blower
• Any time the blower turns on, the
heater turns on with it.
Therapy
Single Speed
• Press the button to turn Therapy On or Off.
Variable Speed
• Press the button once to turn Therapy On or Off.
• Holding the button ramps the speed to high speed, then ramps down to
lowest speed. The action then repeats. Release on the desired speed.
• Pressing twice at startup puts Therapy in Wave mode.
Light (Option 1 only)
• The light can be controlled independently of all other features.
• Aux (if used) may be used for Pillow, Waterfall, or Backjet.
Blower (Optional)
Speed
• If the Blower is off, press the Blower button once to turn it on.
• If you press and hold the Blower button, it ramps to and from the highest
to lowest speed. If you press and hold the Blower button again, it
continues to ramp repeatedly. The action then repeats. Release on the
desired speed.
• If the Blower is on, press the Blower button once to turn the Blower Off.
Modes (turn on, beginning with blower off)
•Press the Blower button twice to put the Blower in Pulse mode, or
•Press the Blower button three times to put the Blower in Wave mode.
40934 A July 29, 2013
Please see reverse side for more information.
LED Definition
Session Timer On
Tells you a device button has been pressed and a Session
Timer is running.
Water Level Detected
Tells you adequate water level has been reached to run the
system. (Sensor required.)
Favorite Setting On
Tells you that your favorite setting is running.
Error
Tells you that your system needs servicing.
(See Error Codes for Bath Button Displays.)
LED Messages
No Therapy Water Detection (Sensor required)
• If no water is detected:
a) The water devices all shut down,
b) The Water Level Detected LED flashes for several seconds before it turns off.
System Error Detection
• If an error occurs in the bath system, the red ERROR LED will flash.
• In addition, the three remaining LEDs stay lit in a specific on/off pattern that
reveals a diagnostic code of the error. If this should occur, take note which of
the three lights are on or off. This information will help technical support in
diagnosing the error.
System Reset
• Press and hold the two top buttons for 5 seconds.
• Continue to hold the two top buttons 5 seconds longer to restart the system.
Purge Cycle
40934 A July 29, 2013
• A Purge Cycle removes standing water from the plumbing and dries the air
delivery system. This helps maintain a sanitary plumbing system.
• Once the bath control thinks you’re finished using the bath, it schedules a
Purge Cycle. The Session Timer LED flashes periodically to indicate that a
Purge Cycle will soon begin.
• Certain actions may cancel the planned Purge Cycle. This is normal.
Otherwise, after a number of minutes, the 1-minute Purge Cycle will begin. At
that point, the Session Timer LED will light continuously.
• When the Purge Cycle ends, all equipment turns off and the Session Timer LED
turns off.
© 2013 Balboa Water Group
4 Button Bath Control User Guide Therapy, Options, User Favorite
Therapy
Option 1
Option 2
User
Favorite
Power Up
• Upon power up, the LEDs flash as
the bath control goes through a self
diagnostic check. Once the LEDs
stop flashing, your Therapy Session
is ready to begin.
Session Timer
• Turning on a device starts a Session
Timer that lasts for 20 minutes.
Therapy
Single Speed
• Press the button to turn Therapy On or Off.
Variable Speed
• Press the button once to turn Therapy On or Off.
• Holding the button ramps the speed to high speed, then ramps down to lowest
speed. The action then repeats. Release on the desired speed.
• Pressing twice at startup puts Therapy in Wave mode.
Option 1 or 2 can be any one of these
Light (Option 1 only)
• If a light is available, it can be controlled independently of all other features.
• Some lighting options have unique operation for color changes.
• See the manual for any special light system that may be installed.
Massage
• Therapy must be On for Massage to run.
• Press the button once to turn the Massage On. Press it again (repeatedly) to
choose different Massage patterns, or to turn the Massage Off.
• When Therapy is turned Off, Massage is turned off automatically.
Waterfall
• A button press turns the Waterfall On or Off.
• Therapy must be On for Waterfall to run.
• When Therapy is turned Off, Waterfall is turned off automatically.
User Favorite
Please see reverse
side for more information.
40937 A July 29, 2013
• Used to recall a specific equipment setting.
• When you wish to save an active equipment setting or combination, press and
hold the Favorite button for 2 seconds. The Favorite LED will illuminate.
• When you wish to recall your favorite setting, press (do not hold) the Favorite
button. Within a second or two, the equipment operation will match what you
last saved, and the Favorite LED will illuminate.
• If you then change settings, the Favorite LED will go out (to show that you are no
longer using the settings exactly as you saved them).
LED Definition
Session Timer On
Tells you a device button has been pressed and a Session
Timer is running.
Water Level Detected
Tells you adequate water level has been reached to run the
system. (Sensor required.)
Favorite Setting On
Tells you that your favorite setting is running.
Error
Tells you that your system needs servicing.
(See Error Codes for Bath Button Displays.)
LED Messages
No Therapy Water Detection (Sensor required)
• If no water is detected:
a) The water devices all shut down,
b) The Water Level Detected LED flashes for several seconds before it turns off.
System Error Detection
• If an error occurs in the bath system, the red ERROR LED will flash.
• In addition, the three remaining LEDs stay lit in a specific on/off pattern that
reveals a diagnostic code of the error. If this should occur, take note which of
the three lights are on or off. This information will help technical support in
diagnosing the error.
System Reset
• Press and hold the two top buttons for 5 seconds.
• Continue to hold the two top buttons 5 seconds longer to restart the system.
40937 A July 29, 2013
© 2013 Balboa Water Group
Error Codes
2 & 6 Button Error Codes
Code
Message 1
Message 2
Message 3
Message 4
Err
E12
no
CFG
Err
E04
no
IbC
Err
E02
no
Ut2
Err
E01
no
Ut1
Err
E05
Ut1
Cnn
Err
E08
IbC
Cnn
Err
E11
Ut
CSU
Err
E09
Ut
tYP
Err
E10
0
CrS
Err
E06
Ut2
Cnn
Err
E07
Ut3
Cnn
Err
E03
no
Ut3
Message
Description
E12 [a] Reload Configuration Table (No Configuration Table) The Panel does not have a configuration table loaded
E04 [b] Missing Blower IBC
The Panel can not communicate with the Blower
E02 [b] Missing Secondary Box (PVC, VSC)
The Primary Box cannot communicate with the Secondary Box
E01 [b] Missing Primary Box (PVC, VSC)
The Panel can not communicate with the Primary Box
E05 [c] Primary Comm lost
The Primary Box has stopped communicating with the Panel
E08 [c] Blower Comm lost
The Blower has stopped communicating with the Panel
E11 [a] ROM checksum fail
Checksum error in the Panel program
E09 [a] Module type error
Module is incorrect type
E10 [a] No zero-cross interrupts
No zero-cross interrupt
E06 [c] Secondary Comm lost
The Secondary box has stopped communicating with the Primary
E07 [c] Expansion Comm lost
The Expansion box has stopped communicating with the Primary
E03 [b] Missing Expansion box
The Primary box cannot communicate with the Expansion box
Codes, Type of Errors
[a] Internal, serious errors that should never occur
[b] Startup errors when a box cannot be located on the IR Link
[c] Runtime errors when a box stops communicating on the IR Link
Notes:
• Ut stands for Under Tub box.
• IbC stands for Integrated Blower Control -- our blower with the box electronics built in.
• Startup and Runtime errors are communication related and will occur if boxes required by the
configuration are missing or communications are lost while running.
42135F
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
55
4 Button Error Codes
Error Code
56
Meaning
E01
Error, NoCommunicationIBC
Message #: 1, 7
E02
Error, NoCommunicationPrimary
Message #: 3, 6
E03
Error, NoCommunicationSecondary
Message #: 2
E06
Error, BadPrimaryOrSecondaryBox
Message #: 8, 9, 10, 11 ( for Boxes)
E07
Error, BadIBC
Message #: 8, 9, 10, 11 ( for Blower)
Code
Message
Description
0
Reload Configuration Table (No Configuration Table)
The configuration table is not downloaded to panel yet
0
Reload Configuration Table (No Active Configuration) The selected configuration number does not exist in the Active
Table
1
Missing Blower IBC
Configuration requires a Blower device (IBC) that does not exist
2
Missing Secondary Box (PVC, VSC)
Configuration requires a secondary device that not exist
3
Missing Primary Box (PVC, VSC)
Configuration requires a primary device that not exist
4
Not Enough Valves
Configuration requires more valves than the boxes can support
5
Swap Boxes
Panel connected to wrong box
6
No Communication Primary
The panel is not receiving messages from the Primary box
(PVC, VSC)
7
No Communication IBC
The Panel is not receiving messages from the IBC
8
ROM checksum fail
The power-up ROM self-test has failed
9
Module type error
The module is unable to detect what type it is
10
No zero-cross interrupts
Module is powered but not receiving AC zero-cross signals
11
Secondary comm lost
The Primary is no longer receiving messages from the
Secondary
99
Invalid error ID
Unknown error
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
7/14/14
42135F
Notes:
The Acrobat Page Setup Dialog is letter size.
To print actual size, set Page Scaling to NONE in the Acrobat print dialog.
6.375”
4.228” (4 7/32”)
(107.38mm)
1.25”
(31.75mm)
Titan 6 Button Bath Panel Cut Out Pattern
2.375”
6 Button Bath Panel Cut Out
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
57
Index
Symbols
3-digit displays . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
3-digit LED . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
4 Button Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
4 point LED . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
6-BUTTON BATH CONTROL . . . . . . . . . . . . . . . . . . . . . . . . . . 7
6 Button Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
6-Pin DIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
6-Pin DIN water temperature sensor . . . . . . . . . . . . . . . . . . 22
7 LED Bulb Cluster . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
8-pin DIN connectors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
10 Position Valve Control Connector . . . . . . . . . . . . . . . . . . 32
40-0000, IPX5 Box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
111 degrees . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
230V . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
90010 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
A
Adapters, Cables & . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
adjustment, speed . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
air injector system . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
air manifolds . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
“all off” . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Amp connectors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
assembly, solenoid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Assembly, Solenoid Cable . . . . . . . . . . . . . . . . . . . . . . . . . . 24
B
back jet . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
Back Jet = 6 Jets . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Back Jet Codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29, 32
Barb, Temp Sensor Saddle . . . . . . . . . . . . . . . . . . . . . . . . . . 22
bath button control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
Bath Panels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
bath set-up . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
Bath Solenoids . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
Behavioral Specs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
blank button indicates . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
block, pluggable . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24, 28
Blower Codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
Blower plumbing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
blower purge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
box, control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
box, controller . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24, 28
boxes can be paired . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
Boxes, Installing Control . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
boxes, same type of control . . . . . . . . . . . . . . . . . . . . . . . . . 19
boxes, two valve control . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
box, middle control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
bright button indicates . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
58
Buttons, User Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
button, User . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Button, User . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
C
cable length . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
Cables & Adapters . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
cable, Water level detection . . . . . . . . . . . . . . . . . . . . . . . . 28
Celsius . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Change, Speed . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
Checksum error . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
Chromatherapy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
Cleaner Codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
cleaner, waterfall or . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
Code . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
code, error . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
Codes, Back Jet . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29, 32
Codes, Blower . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
Codes, Cleaner . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
Codes, Heater . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
Codes, Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
Codes, Panel Error . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39
Codes, Pillow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
codes, Plus and Minus . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
Codes, Pump . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
Codes, Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
Codes, Waterfall . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
communications are lost . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
CON . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7, 39
conductive screw . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
conductive sensor wire . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
conductive water sensor . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
Conductive wire sensor . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
Configuration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
configuration number . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6, 39
Configuration Settings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
configuration tables . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
confuse a "Primary" Valve Control . . . . . . . . . . . . . . . . . . . . 29
Connector, 10 Position Valve Control . . . . . . . . . . . . . . . . . . 32
connectors, 8-pin DIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
connectors, Amp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
connectors, green paired valve . . . . . . . . . . . . . . . . . . . . . . 32
CONTROL, 6-BUTTON BATH . . . . . . . . . . . . . . . . . . . . . . . . . 7
control, bath button . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
control box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
Control, confuse a "Primary" Valve . . . . . . . . . . . . . . . . . . . 29
Control, Integrated Blower . . . . . . . . . . . . . . . . . . . . . . . . . . 55
controller box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24, 28
cross referencing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
7/14/14
D
I
defaults, System Timer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
degrees, 111 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
degree symbol . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Desired Features . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
dim button indicates . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
DIN, 6-Pin . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
discrete . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
Discrete Paired Outputs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Display Message Formats . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
displays, 3-digit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Display, Timer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
document number . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
drip-loop . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
dynamics, fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
IbC . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
IBC . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
If three control boxes are used . . . . . . . . . . . . . . . . . . . . . . 19
If two control boxes are used . . . . . . . . . . . . . . . . . . . . . . . 19
illustration, skeletal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
indicates, blank button . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
indicates, bright button . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
indicates, dim button . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Inlet, One . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Installation of Temperature Sensor in Mount . . . . . . . . . . . 22
Installing Control Boxes . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
Integrated Blower Control . . . . . . . . . . . . . . . . . . . . . . . . . . 55
Internal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
interrupt, zero-cross . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
IPX5 Box 40-0000 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
IR link . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
IR Link . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
IR signals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
E
electrician, qualified . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
equipment, pump-related . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Err . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39
Error . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6, 39
error, Checksum . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
error code . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Error Codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
Error light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
error number . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
errors, Runtime . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
errors, serious . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
errors, Startup . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
Errors, Type of . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
J
jet, back . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
jet, foot . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
jet, neck . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
jet pulsations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
jets, pulsating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
jets, size of . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
L
Fahrenheit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Features, Desired . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
features, Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
flow rates . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
flow, regulate jet . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
fluid dynamics . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
foot jet . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
Formats, Display Message . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
function, Off . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
LED, 3-digit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
LED, 4 point . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
length, cable . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
Light Codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
light, Error . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
line, water pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
link, IR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
Link, IR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
Location . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
location of the topside . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
lost, communications are . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
lowest, PT1 is the . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7, 32
G
M
green paired valve connectors . . . . . . . . . . . . . . . . . . . . . . . 32
guide, user . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
manifold lines . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
manifolds, air . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
middle control box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
Mode, Pulse . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
mode, Wave . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
more solenoid valves . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
Mount, Installation of Temperature Sensor in . . . . . . . . . . . 22
F
H
Heater Codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
hose routing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
42135F
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
59
mount, temperature sensor . . . . . . . . . . . . . . . . . . . . . . . . . 22
Mount, Temperature Sensor . . . . . . . . . . . . . . . . . . . . . . . . 22
multiple solenoid valves . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
N
neck jet . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
nomenclature . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
non-polarized (AC) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24, 28
number, configuration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39
number, document . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
O
off”, “all . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Off function . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
off, User Preset turns all equipment . . . . . . . . . . . . . . . . . . . 6
One Inlet . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
one solenoid valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
On state . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
operation, safe pump . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
or pillow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
Outputs, Discrete Paired . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
out, Temperature read . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
P
paired, boxes can be . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
Panel, 4 Button . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Panel, 6 Button . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
panel cable . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
Panel Error Codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39
Panels, Bath . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
patterns, pulsation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
patterns, regulate pulsating jet . . . . . . . . . . . . . . . . . . . . . . 32
pillow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6, 28
Pillow = 2 Jets . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Pillow Codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
pillow, or . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
pluggable block . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24, 28
plumbing, Blower . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Plus and Minus codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
Preferences . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Preferences, User . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Preset, User . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
pressure, water . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
PT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7, 32
PT1 is the lowest . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7, 32
pulsating jets . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
pulsation patterns . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
pulsations, jet . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
Pulse . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
Pulse Mode . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
60
Pump Codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
pump-related equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
pump, single-speed . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
purge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
purge, blower . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
PVC . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28, 31
Q
qualified electrician . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
R
Ramp, Speed . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
rates, flow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
referencing, cross . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
regulate jet flow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
regulate pulsating jet patterns . . . . . . . . . . . . . . . . . . . . . . 32
ring, trim . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
ROL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
Rolling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7, 32
routing, hose . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
Runtime errors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
S
safe pump operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Safety features . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
same type of control boxes . . . . . . . . . . . . . . . . . . . . . . . . . 19
screw, conductive . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
sensor, 6-Pin DIN water temperature . . . . . . . . . . . . . . . . . 22
sensor, conductive water . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
sensor, Conductive wire . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
sensor, temperature . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6, 22
sensor, water . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
sensor, water level . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Sensor, Water Level . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
sensor, water temp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
serious errors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
session, therapy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Session Timer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
Settings, Configuration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
set-up, bath . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
signals, IR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
single-speed pump . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
size of jets . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
skeletal illustration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
Skeletal View . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
solenoid assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Solenoid Cable Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . 24
Solenoid Filter Tee . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
solenoids . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24, 28, 32
Solenoids, Bath . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
7/14/14
Solenoids, Two . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
solenoid valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
solenoid valves . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
Solenoid valves . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
solenoid wires . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
Specs, Behavioral . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
speed adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
Speed Change . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
Speed Ramp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
speed, SP refers to . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
SP refers to speed . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Startup errors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
symbol, degree . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
System Timer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6, 29
System Timer defaults . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
system, Titan . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
T
tables, configuration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
Tee, Solenoid Filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
temperature . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Temperature . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Temperature read out . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
temperature sensor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6, 22
temperature sensor mount . . . . . . . . . . . . . . . . . . . . . . . . . . 22
Temperature Sensor Mount . . . . . . . . . . . . . . . . . . . . . . . . . 22
Temp Sensor Saddle Barb . . . . . . . . . . . . . . . . . . . . . . . . . . 22
therapy session . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
three valves . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28, 32
Timer Display . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Timer, Session . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
Timer, System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6, 29
timer value . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
timer, water equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
time, T refers to the . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Titan system . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
topside, location of the . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
T refers to the time . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
trim ring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Two Solenoids . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
two valve control boxes . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
two valves . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
Type of Errors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
U
user guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
User Guide Buttons . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
User Preferences . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
User Preset . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
User Preset turns all equipment off . . . . . . . . . . . . . . . . . . . . 6
Ut . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
V
value, timer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Valve Codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
valve, one solenoid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
valves, more solenoid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
valves, multiple solenoid . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
valve, solenoid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
valves, solenoid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
valves, Solenoid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
valves, three . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28, 32
valves, two . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
Valves Used . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27, 32
View, Skeletal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
VSC . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28, 31
W
water equipment timer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
waterfall . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Waterfall . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
Waterfall Codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
waterfall or cleaner . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
Water level detection cable . . . . . . . . . . . . . . . . . . . . . . . . . 28
water level sensor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Water Level Sensor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Water Present . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
water pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
water pressure line . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
water sensor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Water temperature sensor . . . . . . . . . . . . . . . . . . . . . . . . . . 28
water temp sensor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Wave . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
Wave mode . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
wire, conductive sensor . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
wireless . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
wires, solenoid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
Z
zero-cross interrupt . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
used, If three control boxes are . . . . . . . . . . . . . . . . . . . . . . 19
used, If two control boxes are . . . . . . . . . . . . . . . . . . . . . . . 19
Used, Valves . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27, 32
User button . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
User Button . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
42135F
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
61
Index of Components
(2) One Inlet, Three Outlet Solenoids. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
4-Pin Mini DIN Male to Lamp holder Cable Assembly. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
5 Discrete Paired Outputs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
7 LED Bulb Cluster w/Light Pro (Chromatherapy). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
10 Position Valve Control Connector . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
8141-6320 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
25099. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
25404. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
25569. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
25652. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
25670. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
25748. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
25749. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
25750. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
25751. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
32016. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
59007-V . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
90005. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
90010. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
90010. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
90011. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
90011. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
90012. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
90012. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
90013-01. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
90013-01. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
90017. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
90018. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
90022. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
90022. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
99642-CW . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
99749. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
99757-AL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
99757-BC. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
99757-WH . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
900106-BUTTON BATH CONTROL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Blower 600W HTR 1HP w/Control 115V. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Blower or Pump. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Cable 4 Pin DIN to JUDCO 8ft. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
62
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
7/14/14
Index of Components (cont.)
Cable 6 Pin DIN for Water Level. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Cable Bath 8 Pin Mini Din 6ft. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Cable Water Detection Conductive 6 Ft. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Cross sectional view. Installation of Temperature Sensor in Mount. . . . . . . . . . . . . . . . . . . . . . . 22
Display Trim, 6 Button, Almond . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Display Trim, 6 Button, Biscuit. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Display Trim, 6 Button, White. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Display Trim, Round . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Drill a 3/8” hole in each corner. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Extendable Bulb Holder EFX. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Green Conn. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
J1 Mini DIN 8 Pin (Panel). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
J1 Mini DIN 8 Pin (Panel). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
J2 Mini DIN 6 Pin (Water/Temp Sensors). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
J2 Mini DIN 6 Pin (Water/Temp Sensors). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
J3 Mini DIN 4 Pin (12V Light) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
J3 Mini DIN 4 Pin (12V Light). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
J4 Mini DIN 6 Pin* (Water/Temp Sensor). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
J5 Mini DIN 8 Pin* (Panel). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Light Adapter Cable 4 Pin DIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Light Cable (4 Pin) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Manifold . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
One Inlet, Two Solenoids. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
One pluggable block per one solenoid. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
One pluggable block per two solenoids. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
Paired Valve Connectors. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Panel Bath 2 Button O/L 12012. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Panel Bath 2 Button O/L 12012. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Panel Bath 4 Button O/L 12013. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Panel Bath 4 Button O/L 12013. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Panel Bath 4 Button O/L 12014. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Panel Bath 4 Button O/L 12014. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Panel Bath 4 Button O/L 12983. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Panel Bath 4 Button O/L 12983. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Panel Bath 6 Button O/L 12015. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Panel Bath 6 Button O/L 12015. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Panel Cable (8 Pin) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Panel Cable (8 Pin)* . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Part No. 381 1.5” Titan Temp Sensor Saddle Barb . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
42135F
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
63
Index of Components (cont.)
Part No. 382 2.0” Titan Temp Sensor Saddle Barb . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
Part No. 8141-6320 Blower 600W HTR 1HP w/Control 115V. . . . . . . . . . . . . . . . . . . . . . . . . . 14
Part No. 8141-6320 Blower 600W HTR 1HP w/Control 115V. . . . . . . . . . . . . . . . . . . . . . . . . . 18
Part No. 25099 Extendable Bulb Holder EFX . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Part No. 25404 Cable Water Detection Conductive 6 Ft . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Part No. 25404 Cable Water Detection Conductive 6 Ft . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
Part No. 25569 Cable Bath 8 Pin Mini DIN 6 Ft. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Part No. 25670 Solenoid Cable Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
Part No. 25748 Splitter Cable Control Box. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Part No. 25750 Light Adapter Cable 4 Pin DIN. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Part No. 25751 6-Pin DIN Water Temperature & Level Sensor . . . . . . . . . . . . . . . . . . . . . . . . . 22
Part No. 32016 Sensor Assy Kit (24in, 1/4in dia.). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
Part No. 32016 Sensor Assy Kit (24in, 1/4in dia.) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Part No. 59007-V 7 LED Bulb Cluster w/Light Pro . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Part No. 90010 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Part No. 90011 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Part No. 90012 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Part No. 90013-01 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Part No. 90015 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Part No. 90016 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Part No. 90017 (90005 is similar). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Part No. 90018 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Part No. 90018 Primary Valve Bath Control. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Part No. 90022 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Part No. 92152 Union-Std Nut . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Part No. 99642-CWDisplay Trim Round. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Part No. 99749 Set (2 Ea) of Conductive Screw. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
Part No. 99755 6 Button Display Trim . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Part No. 99757 6 Button Display Trim . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Part No. 900106 Button Panel. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Part No. B-80335WH Blower 1InSpg C/V Housing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Part No. IPX5 Box 40-0000 shown; IPX5 Box 20-0000 can be used too. . . . . . . . . . . . . . . . . . . . . . 15
Primary Valve Control. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Primary Valve Control. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Pump . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Sensor Assy Kit, 24in (Dia. 1/4in), (M7 Temperature). . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Sensor Cable (6 Pin) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Sensor Cable (6 Pin)* . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Set (2 Ea) of Conductive Screw. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Solenoid Filter Tee . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
64
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
7/14/14
Splitter Cable Control Box. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Splitter Cable Remote Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Step No. 9 Clip on the cable retainer. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . System Expandable, Var. Sp. (Similar to 90017) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Temperature and Water Level Sensor. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Temperature Sensor Mount (two views) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
The trim ring cut-out is opposite the display. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Top view, bath. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Top View of Two Control Boxes. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . To Solenoids. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Trim ring with adhesive . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Use the first two buttons for setting up the configurations . . . . . . . . . . . . . . . . . . . . . . . . . . Variable Speed Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Variable Speed Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
42135F
11
11
21
8
14
22
21
20
19
14
21
39
8
8
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
65
Tustin, Ca. 92780 (714) 384-0384
66
42135 E Jluy 30, 2013
Manufactured under one or more of these patents. U.S. Patents: 5332944, 5361215, 5550753, 5559720, 5,883,459, 6253227, 6282370, 6590188, 6976052, 6965815, 7030343, 7,417,
834 b2, Canadian Patent: 2342614, Australian patent: 2373248 other patents both foreign and domestic applied for and pending. All material copyright of Balboa Water Group.
7/14/14
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement