outdoor table top gas grill
OUTDOOR TABLE TOP
GAS GRILL
MODEL #820-0015
SERIAL # ____________________ MFG. DATE _____________ PURCHASE DATE: ____________
This instructions manual contains important information necessary for the proper assembly and safe use of the appliance.
Read and follow all warnings and instructions before assembling and using the appliance
Follow all warnings and instructions when using the appliance
Keep this manual for future reference
Questions, problems, missing parts? Before returning to your retailer, call our customer service
1
department at 1-866-984-7455, 8 a.m.-5 p.m., PST, Monday-Friday.
Certificate 190299-2265178
Project 2265178
Figure No.(69)
TABLE OF CONTENTS
Table of contents & Warning………...……2
Safety Information…………………............3
Package Contents List……………………..5
Preparation………………………….……....5
Assembly Instructions…………...…………6
Installation Instructions………………….….8
Operation Instructions…………………......10
Care and maintenance……………………..11
Trouble shooting……..……………………..13
Replacement Parts List…………..…..........14
Warranty……….………………………….…15
DANGER
If you smell gas:
1.
2.
3.
4.
Shut off gas to the appliance.
Extinguish any open flame.
Open lid.
If odor continues, keep away from the appliance and immediately call your gas
supplier or local fire department.
Failure to follow these instructions could result in fire or explosion, which could cause
property damage, personal injury or death
DANGER
1.
Never operate this appliance unattended
2.
Never operate this appliance within 10 ft (3 m) of any structure, combustible material
or other gas cylinder
3.
Never operate this appliance within 25 ft (7.5 m) of any flammable liquid
4.
Do not fill cooking vessel beyond maximum fill line.
5.
Heated liquids remain at scalding temperatures long after the cooking process.
Never touch cooking appliance until liquids have cooled to 115ºF (45ºC) or less.
6.
This appliance is not intended for and should never be used as a heater.
Failure to follow these instructions could result in fire, explosion or burn hazard, which
Could cause property damage, personal injury or death
2
SAFETY INFORMATION
Please read the following instructions carefully before attempting to assemble, operate or install the product.
Failure to follow these instructions may result in serious bodily injury and/or property damage. If you have
questions regarding the product please call customer service at 1-866-984-7455, 8 a.m.-5 p.m., PST,
Monday-Friday.
LP- gas supply cylinder to be used must be constructed and marked in accordance with the specifications for
LP-gas cylinders of the U.S Department of Transportation (DOT) or the National Standard of Canada, CANB339, Cylinders, Spheres and Tubes for the Transportation of Dangerous Goods
1.
2.
3.
4.
5.
6.
7.
8.
9.
10.
11.
12.
15.
16.
17.
18.
19.
20.
The installation must conform with local codes or, in the absence of local codes, with the National Fuel
Gas Codes, with the National Fuel Gas Code, ANSI Z223.1/NFPA 54, Storage and Handling of
Liquefied Petroleum Gases, ANSI/NFPA 58, or the Standard for Recreational Vehicles, ANSI
A119.2/NFPA 1192, and the Recreational Vehicle Code, CSA Z240 RV, as applicable.
Table top grill is for outdoor use only. Grill should be operated in a well-ventilated space. Never operate
in an enclosed space, garage or building. Your grill is not intended to be installed in or on recreational
vehicles and / or boats .
Heated liquids remain at scalding temperatures long after the cooking
process. Do not touch the cooking appliance until liquids have cooled to
115°F (45°C) or less.
Do not install or use grill within 24” of combustible
materials from back and sides of grill. Grill shall not be located under
overhead surfaces (closed carport, garage, porch, patio) that can catch fire.
Never attempt to attach this grill to the self-contained LP gas system of a camper trailer or motor home.
It is the responsibility of the assembler/owner to assemble, install and maintain gas grill. Do not let
children and pets operate or play near your table top grill. Failure to follow these instructions could result
in serious personal injury and/ or property damage.
Remove lid before lighting grill. When grill is not in use, turn off control knob on LP gas cylinder.
Carefully follow instructions in this manual for proper assembly and leak testing of your grill. Do not use
grill until leak checked. If leak is detected at any time, it must be stopped and corrected before using
grill further.
Appliance area should be kept clear and free from combustible materials, gasoline, bottled gas in any
from and other flammable vapors and liquids. Do not obstruct flow of combustion and ventilation air.
Never try to light grill with lid closed! Buildup of gases is very dangerous and could cause an explosion
Keep any electrical cord of fuel supply hose away from any heated surfaces
Propane is a flammable gas and improper handling may result in explosion and/or fire and serious
accident or injury.
This appliance will be during and after use. Use insulated oven mitts or gloves for protection from hot
surfaces or splatter from cooking liquids
Do not leave your grill unattended while in operation
Do not use while under the influence of drugs or alcohol.
Do not store any spare LP (propane) cylinder, full or empty, under or near your grill.
Appliance is not intended for commercial use or rental
The cylinder must be disconnected when the appliance is not in use
NATURAL HAZARD • SPIDERS
FACT: Sometimes spiders and other small insects climb into the burner tube. The spiders spin
webs, build nests and lay eggs. The webs or nests can be very small, but they are very strong
and can block the flow of gas. Clean burner prior to use after storing, at the beginning of
grilling season or after a period of one month not being used
3
SAFETY INFORMATION
The Fuel System
Gas grills are used safely by millions of people when following simple safety precautions.
The items in the fuel system are designed for operation with this grill. They must not be replaced with any other
brand. (See parts list for replacement items.)
GAS BURNER: The gas burner is constructed of stainless steel and should not require maintenance other than
inspection for insects/nests inside the air intake slots.
LP GAS REGULATOR CAUTION
The gas pressure regulator provided with this appliance must be used. This regulator is equipped with the
required orifice and is set for the required outlet pressure for this appliance. This combination of orifice size and
pressure regulation specifications provides the cooking performance intended by Nexgrill Table Top Grill.
Substitution of regulator by any other device or any other manufacturer is dangerous and could result in serious
injury.
FUEL SUPPLY HOSE
The hose connected regulator provided with this appliance is 3 feets length. Keep the fuel hose away from any
heated surface(s).
PROPANE FUEL: Warning - propane is a flammable gas. Improper handling may result in an explosion and/or
fire and serious accident or injury. Your grill is designed to operate with propane (LP) gas only and is equipped
with the proper orifice for propane gas.
Caution: Do not connect this grill with any gas supply other than propane. Propane gas is heavier than air and
settles in lower areas. Make certain adequate ventilation is available when using your grill. The gas cylinder may
be stored outside in a well-ventilated area out of the reach of children when the grill is not in use.
The LP gas cylinder shall be used only outdoors in a well-ventilated space and not in a building, garage, or any
other enclosed area. The Nexgrill Table Top Grill may be stored indoor if the LP gas cylinder is removed and
stored outdoor. The LP gas cylinder (not included) is threaded for connection directly to the gas regulator
supplied with this appliance. Care should be taken when threading the cylinder to the regulator to engage
threads correctly to achieve the proper and intended connection. When disconnecting or connecting the gas
cylinder, be careful that the regulator does not strike the grill, the ground, or any other surfaces. Replace the
protective cap over the threaded cylinder connection when removed from grill. If any difficulty occurs when
connecting or disconnecting the cylinder to the regulator assembly, contact your local gas supplier for assistance.
When re-connecting the LP gas cylinder to the regulator, be sure to hand-tighten until snug. This connection
should be inspected for damage and leak tested after each re-connection.
To Leak Test, make a soap solution of one part liquid detergent and one part water. You will need a spray bottle,
brush, or rag to apply the solution to the fitting. Bubbles indicate leaks.
Check all gas supply fittings for leaks before each use. Do not
use the grill until all connections have been checked and do
not leak.
Regulator
Propane
cylinder
4
WARNING
Always operate the grill on a tabletop, no higher than 32
inches.
Place the propane tank on the ground immediately
adjacent to the tabletop, no further than 24 inches from
the grill.
Failure to follow these instructions could cause the
propane tank to overheat and vent propane which could
ignite causing serious personal injuries or property
damage and/or a tripping hazard over the gas hose or
propane tank, pulling the grill off the tabletop causing
serious personal injuries or property damage.
ax
32" max
24
"m
PACKAGE CONTENTS
Part
Description
Quantity
1
Grill
1 set
2
Foldable Leg
2 pcs
3
Knob
2 pcs
4
Cooking grid with hole
1 pc
5
Flame tamer
2 pcs
6
Grease tray
1 pc
1
2
3
4
5
6
PREPARATION
Before beginning assembly, installation or operation of product, make sure all parts are present.
Compare parts with package contents list and diagram above. If any part is missing or damaged, do not
attempt to assemble, install or operate the product. Contact customer service for replacement parts.
• Your Nexgrill Table Top Grill is pre-assembled. The only assembly required is to connect the foldable
legs and place the flame tamers, cooking grid and control knobs into the grill.
• Estimated Assembly Time: 5 minutes.
5
ASSEMBLY INSTRUCTIONS
Fig. 1
1. Remove all the packing materials and move grill
close to a desired location.
2. Take out the two foldable legs, insert them into the
bracket A, B,C,D under firebox as shown in Fig.1.
Note: Expand (using two hands) the legs and they will
slide into the brackets as shown.
A
B
C
D
Fig. 2
3. Unfold the two legs and insert the grease tray as
shown in Fig. 2.
Fig. 3
4. Place the flame tamers and cooking grid in the
firebox as shown in Fig. 3.
6
ASSEMBLY INSTRUCTIONS
Fig. 4
5. Place on the control knobs as shown in
fig. 4. Push and turn the knob and check for
sparks.
Fig. 5
6. Attach the regulator with 3 feets hose to the
propane cylinder by turning the regulator handle
clockwise as shown in Fig. 5. If the outdoor
cooking appliance is not in use, the gas must be
turned “OFF” at the Liquid Propane cylinder.
Check all gas supply fittings for leaks before
each use. Do not use the grill until all
connections have been checked and do not
leak (see “Leak Testing” instructions on page 9).
Fig. 6
7. Place the table top on the desk as shown in Fig.6.
"m
ax
32" max
Note: This table top grill is use with 3 feet gas hose,
suggest to use this grill on the 3 feet high table.
24
Fig. 7
Note: When you are not using the grill, you can
fold the legs and lock them in brackets as
shown in Fig.7.
7
INSTALLATION INSTRUCTIONS
GAS HOOK-UP
Only the pressure regulator and hose assembly supplied with the grill should be used. Any replacement
pressure regulator and hose assembly must be specified by the grill manufacturer. This grill is configured for
Liquid Propane. Do not use a Natural Gas supply.
Total gas consumption (per hour) with all burners set on “HI”:
Main burners
20,000 BTU/Hr.
Total
20,000 BTU/Hr.
The installation of this appliance must conform with local codes or, in the absence of local codes, with
either the National Fuel Gas Code, ANSI Z223.1/NFPA 54, National Gas Propane Installation Code, CSA
B149.1, or Propane Storage and Handling Code, B149.2,or the Standard for Recreation Vehicles, ANSI
A119.2/NFPA 1192, and CSA Z240 RV Series, Recreation Vehicle Code, as applicable.
LIQUID PROPANE CYLINDER REQUIREMENTS
(20-lb Cylinder)
A dented or rusty Liquid Propane cylinder may be hazardous and should be checked by your supplier. Never
use a cylinder with a damaged valve. The Liquid Propane cylinder must be constructed and marked in
accordance with the specifications for Liquid Propane cylinders by the United States Department of
Transportation (DOT) or the National Standard of Canada, CAN/CSA-B339, Cylinders, Spheres and Tubes
for Transportation of Dangerous Goods Commission.
The 20-lb cylinder must have a shut off valve terminating in a valve outlet specified, as applicable, for
connection type QCC1 in the standard for compressed gas cylinder valve outlet and inlet connection
ANSI/CGA-V-1.
Storage of an outdoor cooking gas appliance indoor is permissible only if the cylinder is disconnected and
removed from the outdoor cooking gas appliance. The cylinder system must be arranged for vapor withdrawal.
The cylinder must include a collar to protect the cylinder valve.
Manifold pressure: (operating) 11 inches water column (W.C.), (non-operating) 11.2 inches water column
(W.C.).
The Liquid Propane cylinder must be fitted with an Overfill Protection Device (OPD).
Remove the plastic valve cover from the Liquid Propane cylinder. Make sure the grill gas hoses do not contact
the grease pan or grill firebox when the Liquid Propane cylinder is placed into the cart.
CONNECTING THE LIQUID PROPANE CYLINDER
To connect the Liquid Propane gas supply cylinder:
The cylinder valve should be in the “OFF” position. If not, turn the valve clockwise until it stops.
Make sure the cylinder valve has the proper type-1 external male thread connections per ANSI Z21.81.
Make sure the burner valves are in the “OFF” position.
Inspect the valve connections, port and regulator assembly. Remove debris and inspect the hose for damage.
When connecting the regulator assembly to the valve, use your hand to tighten the nut clockwise until it stops.
Use of a wrench could damage the quick coupling nut and result in a hazardous situation
Open the cylinder valve fully by turning the valve counterclockwise.
Before lighting the grill, use a soap and water solution to check all the connections for leaks.
If a leak is found, turn the cylinder valve “OFF” and do not use the grill until a local Liquid Propane dealer can
make repairs.
WARNING
Never attempt to use damaged or obstructed equipment. See your local Liquid Propane dealer for repair.
8
INSTALLATION INSTRUCTIONS
DISCONNECTING THE LIQUID PROPANE CYLINDER
Turn the grill burner valves “OFF” and make sure the grill is cool.
Turn the Liquid Propane cylinder valve “OFF” by turning clockwise until it stops.
Detach the regulator assembly from the cylinder valve by turning the quick coupling nut counterclockwise.
Place dust cap on cylinder valve outlet whenever the cylinder is not in use. Only install the type of dust cap
on the cylinder valve outlet that is provided with the cylinder valve. Other types of caps or plugs may result
in leakage of propane.
LEAK TESTING
GENERAL
Although gas connections on the grill are leak tested prior to shipment, a complete leak test must be
performed at the installation site. Before each use, check all gas connections for leaks using the
procedures listed below.
If the smell of gas is detected at any time, you should immediately check the entire system for leaks.
BEFORE TESTING
Make sure all packing materials have been removed from the grill, including the burner tie-down straps.
WARNING
Check all gas supply fittings for leaks before each use. Do not use the grill until all connections have
been checked and do not leak. Do not smoke while leak testing. Never leak test with an open flame.
Make a solution of one part liquid detergent and one part water. You will need a spray bottle, brush, or rag to
apply the solution to the fittings. For the initial leak test, make sure the Liquid Propane cylinder is full.
TO TEST
1. Turn the burner valves off.
2. Turn the Liquid Propane cylinder valve counterclockwise to open the valve.
3. Apply the soap solution to all gas fittings. Soap bubbles will appear where a leak is present.
4. If a leak is present, immediately turn the gas supply “OFF” and tighten leaky fittings.
5. Turn the gas back “ON” and recheck.
6. Should the gas continue to leak from any of the fittings, turn the gas supply “OFF” and contact customer
service at 1-866-984-7455.
7. If there is evidence of excessive abrasion or wear, or the hose is cut, it must be replaced prior to the
outdoor cooking gas appliance being put into operation.
Only those parts recommended by the manufacturer should be used on the grill. Substitutions will void the
warranty.
WARNING
Do not store grill indoors unless the cylinder is disconnected. Do not store cylinder in a building,
garage, or any other enclosed area, and keep area, and keep out of reach of children at all times.
INSTALLER FINAL CHECK
Maintain specified clearance of 24 inches from combustible materials and construction.
All internal packaging has been removed.
The hose and regulator are properly connected to the Liquid Propane cylinder.
The unit has been tested and is free of leaks.
The gas supply shutoff valve has been located.
All burners are installed.
Keep the instruction manual for future reference
9
WARNING
The grill and its individual shutoff valve must be disconnected from the gas supply piping system during
any pressure testing of that system at test pressure in excess of 1/2-in.PSI (3.5kpa).
2.
The outdoor cooking gas appliance must be isolated from the gas supply piping system by closing its
individual manual shutoff valve during any pressure testing of the gas supply piping system at test
pressure equal to or less than 1/2-in.PSI (3.5kpa).
1.
WARNING
1. Do not store spare Liquid Propane cylinders under or near this appliance.
2. Never fill the cylinder beyond 80 percent capacity.
3. If the information in item 1&2 is not followed exactly, a fire causing death or serious injury may occur.
OPERATION INSTRUCTIONS
LIGHTING THE GRILL
1. Place the legs in up position.
2. Make sure the propane cylinder is tightly treaded into
the regulator (hand tighten only).
3. Open lid. Always open lid when lighting.
4. Push and turn Main burner knob slowly to IGNITE/HI as show in Fig.8,
burner should light immediately.
5. If ignition does not occur in 3-5 seconds, turn the control knob “OFF”.
Wait 5 minutes before attempting to re-light the grill. If the grill fails to
ignite after the second attempt, call customer service at 1-866-984-7455
for assistance. With burner lit, gently close the lid and allow the grill to
warm up for 20-30 minuets prior to use.
Fig.8
OFF
OFF
I GNITE / H I
IG NITE / HI
LO
LO
Main Burners
Note: If the knob can’t spark insert the match into the lighting rod as show in
Fig.9. Ignite the match and insert though the cooking grids to the burner.
O FF
2
Fig.9
IG NITE / HI
1
3
LO
1.
Push
2.
Turn knob to Ignite/Hi
3.
Adjust flame
TURNING THE GRILL OFF
1.
Turn knob to “OFF” position.
2.
Turn the propane cylinder control knob to the “OFF” position.
Caution: Do not attempt to re-light the grill without following all the lighting instructions.
3.
Allow the grill body to cool at least 30 minutes before attempting to move or transport.
10
OPERATION INSTRUCTIONS
FLAME CHARACTERISTICS
Check for proper burner flame characteristics. Burner flames should be blue and stable with no yellow tips,
excessive noise, or lifting as shown in Fig. 10. The following steps should be followed for correcting the flame
characteristics:
Turn the control knobs and Liquid Propane cylinder valves “OFF.”
Allow the grill and burners to cool.
If the flame is yellow (not enough air), turn the adjustment screw found at
the front of the burner counterclockwise.
If the flame is noisy or lifts away from the burner (too much air), turn the
adjustment screw clockwise.
If these adjustments do not correct the problem, contact customer service
at 1-866-984-7455.
Visually check the burner flames prior to
each use, the flames should look like this
picture, if they do not ,refer to the burner
main tenancy part of this manual.
Fig. 10
USING THE GRILL
1.
2.
3.
4.
Find a level surface to grill on.
Allow the grill to warm up with the lid closed for 5 minutes prior to cooking.
You may cook on the grill in any weather. If the temperature is extremely cold or hot, the cooking
times will be slightly increased or decreased. Keep the grill out of excessive winds when operating.
The cooking times listed below are only suggestions. Cooking times vary depending on thickness of
meats and the desired degree of preparation.
GRILLING
•
Steak – (T-Bone), thick cut, medium doneness: grill 10 minutes on each side on MED setting.
•
Chicken – (Quarters), average size fryer: grill 30 minutes per side on MED setting. Check for doneness.
•
Pork – (Ribs/chops): grill 10-20 minutes per side on MED setting. Check for doneness.
•
Fish – grill 20-30 minutes on LOW setting.
•
Turkey - (Breast): grill 10 minutes per pound or until internal temperature reaches 170°F on MED setting.
CARE AND MAINTENANCE
There is very little care and maintenance needed. The Table Top Grill is designed and made of
materials that will last many years with normal use. Following these instructions will improve the
longevity and quality of cooking. To ensure safe operation of your grill, the area of cooking should
always be kept free of combustible materials of any type, such as gasoline or other flammable vapors or
liquids.
Outside Grill Parts - This is stainless steel. It can be cleaned easily with warm soapy water or any
stainless steel cleaner.
Cooking Grid and Grease Tray – The cooking grid is made of stainless steel. The cooking grid should be
brushed with a steel brush immediately after cooking, while the grill is still warm. The grease tray is also
stainless steel and can be cleaned with a flat scraper such as a putty knife.
Caution: The grease tray must be kept clean and free of heavy buildup for the grill to perform properly
11
and to eliminate flare-ups.
CARE AND MAINTENANCE
Grill Main Burners - Extreme care should be taken when removing a burner. It must be correctly centered
on the orifice before any attempt is made to relight the grill. Frequency of cleaning will depend on how
often you use the grill.
Failure to properly place the burner over the orifice could cause a fire to occur behind and beneath the
valve panel, thereby damaging the grill and making it unsafe to operate.
Before cleaning, make sure the gas supply and control knobs are in the “OFF” position and the burners
have cooled.
To remove the main burners for cleaning:
B
1.
Locate the burner screw at the rear of the firebox.
2.
Remove the screw and lift the burner out of the firebox.
A
To clean the grill burners:
1.
Clean the exterior of the burner with a wire brush. Use a metal scraper
for stubborn stains or debris.
2.
Clear clogged ports with a straightened paper clip. Never use a wooden
toothpick as it may break off and clog the port.
3.
Check and clean burners / venturi tubes for insects and insect nests. A
clogged tube can lead to a fire beneath, and behind the main control panel.
To reinstall the main burners:
1.
Insert the burner over the main burner gas valve (part# 18 on Page 14).
2.
Make sure the orifice spud (A) is inside the burner venturi (B) as shown
in Fig. 11.
3.
Align the burner screw hole with the firebox hole, insert screw and tighten.
Fig.11
Firebox - Use warm soapy water to clean this area. Do not allow grease to build up.
Drain Hole – The drain hole must be kept clear of grease and food particles to allow drippings to drain
properly into the grease tray. This must be done to maintain proper operation of your grill.
General - This grill, like all equipment, will look better and last longer if kept out of the weather when not in
use.
Caution: Do not store propane cylinders in enclosed areas. When using a cover or moving the grill, always
wait until the grill has cooled for at least 30 minutes.
- Not obstructing the flow of combustion and ventilation air.
- A clogged tube can lead to a fire beneath the appliance.
This unit must be kept in an area free from combustible materials, gasoline and other flammable
vapors and liquids.
Make sure all openings into the grill body are free of blockages or debris and there are no objects
or materials blocking the flow of combustion or ventilation. Make sure the legs are in the up
position when using the grill.
Check burner air inlet openings (behind the inlet guard on the right end of the grill body) for insect
nests or blockages. Make sure the slots in the burner tube are clear.
When the grill is not in use, turn the control knob to the “OFF” position and remove the propane
cylinder from the regulator. Remove the regulator from the burner.
For outdoor use only, if stored indoors, detach propane cylinder and store outdoors. Propane
cylinders must be stored out of reach of children.
Important
First-time use: It is important that the grill be lit and allowed to heat up for at least 30 minutes
before any food is placed on the cooking grid. It is normal for some smoke to appear during the
initial operation of the grill. After initial heating, the grill is ready for use. A cooking spray can be
used on the cooking grids to allow easier clean up.
12
CARE AND MAINTENANCE
THIS COOKING APPLIANCE IS FOR OUTDOOR USE ONLY AND SHALL NOT BE USED IN A
BUILDING, GARAGE OR ANY OTHER ENCLOSED AREA.
MOVING INSTRUCTIONS
Caution: Never move the grill with burner lit.
Make sure control knob is in the “OFF” position. Disconnect the propane cylinder from the regulator.
Remove the regulator from the grill. Be sure the grill has completely cooled for at least 30 minutes.
Close the lid and secure the latch. Place the legs in the down position. Use the handle to carry the
grill.
Note: It is best to leave the grease tray in place attached to the bottom of the grill-some grease may
continue to drip from drain hole during transport.
TROUBLE SHOOTING
WARNING Spiders and insects can nest inside the burners of the grill and disrupt gas flow. This very
dangerous condition could cause a fire behind the valve panel, thereby damaging the grill and making it
unsafe for operation. Inspect the grill at least twice a year.
When to Look for Spiders
You should inspect the burners at least twice a year or immediately after any of the following conditions occur:
1. The smell of gas in conjunction with burner flames appearing yellow.
2. The grill does not reach temperature.
3. The grill heats unevenly.
4. The burners make popping noises.
BEFORE CALLING FOR SERVICE
Problems
What To Do
Grill will not light.
•Check to see if the liquid propane cylinder is empty.
•Check burner ports for any blockage. Use a soft
wire brush to clear plugged ports.
•Check the gas orifice on the burner for an
obstruction. If orifice is blocked, clean with a needle
or thin wire. NEVER USE A WOODEN
TOOTHPICK.
Burner flame is yellow or orange in conjunction with
gas odor.
•Check for spiders and insects
•Call customer service at 1-866-984-7455.
Low heat with the control knob on the “HI” setting.
•Make sure the grill area is clear of dust.
•Make sure the burner and orifice are clean.
•Check for spiders and insects.
•Is there adequate gas supply available?
•Is the grill being preheated for 15 minutes?
If the grill does not function properly, use the following checklist before contacting your dealer
for service.
13
REPLACEMENT PARTS LIST
For replacement parts, call our customer service department at 1-866-984-7455, 8 a.m.-5 p.m., PST, MondayFriday.
01
02
03
17
02
04
16
15
05
06
10
07
05
11
08
09
12
Part
Description
14
13
13
Part #
Part
Description
Part #
1
Main Lid
1 pc
10
Main control panel
1 pc
2
Main Lid Screw
2 pcs
11
Control knob bezel
2 pcs
3
Logo
1 pc
12
Control knob
2 pcs
4
Main Lid Handle assembly
1 pcs
13
Foldable Leg
2 pcs
5
Control panel connector
2 pcs
14
Grease tray
1 pcs
6
Gas Valve
2 pcs
15
Main burner(question mark)
2 pcs
7
Main manifold
1 pcs
16
Flame tamer
2 pc
8
Regulator, LP
1 pc
17
Cooking grid
1pcs
9
Lighting rod
1 pc
14
Limited Warranty (Model # 820-0015)
Nexgrill warrants to the original consumer-purchaser only that this product (Model #820-0015) shall be free from defects in workmanship and
materials after correct assembly and under normal and reasonable home use for the periods indicated below beginning on the date of
purchase. The manufacturer reserves the right to require photographic evidence of damage, or that defective parts be returned, postage
and or freight pre-paid by the consumer, for review and examination.
• MAIN BURNERS: 3 year LlMlTED warranty against perforation.
• FLAME TAMERS: 2 year LlMlTED warranty against perforation.
• COOKING GRIDS: 3 Year LIMITED warranty; does not cover dropping, chipping, scratching, or surface damage.
• STAINLESS STEEL PARTS: 3 Year LIMITED warranty against perforation; does not cover cosmetic issues like surface corrosion,
scratches and rust.
• ALL OTHER PARTS: 1 Year LIMITED warranty (Includes, but not limited to, valves, frame, housing, cart, control panel, igniter, regulator,
hoses) *Does not cover chipping, scratching, cracking surface corrosion, scratches or rust.
Upon consumer supplying proof of purchase as provided herein, Manufacturer will repair or replace the parts which are proven defective
during the applicable warranty period. Parts required to complete such repair or replacement shall be free of charge to you except for
shipping costs, as long as the purchaser is within the warranty period from the original date of purchase. The original consumer-purchaser
will be responsible for all shipping charges of parts replaced under the terms of this limited warranty. This limited warranty is applicable in
the United States only, is only available to the original owner of the product and is not transferable. Manufacturer requires reasonable proof
of your date of purchase. Therefore, you should retain your sales receipt and/or invoice. If the unit was received as a gift, please ask the giftgiver to send in the receipt on your behalf, to the below address. Defective or missing parts subject to this limited warranty will not be
replaced without registration or proof of purchase. This limited warranty applies to the functionality of the product ONLY and does not cover
cosmetic issues such as scratches, dents, corrosions or discoloring by heat, abrasive and chemical cleaners or any tools used in the
assembly or installation of the appliance, surface rust, or the discoloration of stainless steel surfaces. Surface rust, corrosion, or powder
paint chipping on metal parts that does not affect the structural integrity of the product is not considered a defect in workmanship or material
and is not covered by this warranty. This limited warranty will not reimburse you for the cost of any inconvenience, food, personal injury or
property damage. If an original replacement part is not available, a comparable replacement part will be sent. You will be responsible for all
shipping charges of parts replaced under the terms of this limited warranty.
ITEMS MANUFACTURER WILL NOT PAY FOR:
•Service calls to your home.
•Repairs when your product is used for other than normal, single-family household or residential use.
•Damage resulting from accident, alteration, misuse, lack of maintenance/cleaning, abuse, fire, flood, acts of God, improper installation, and
installation not in accordance with electrical or plumbing codes or use of products not approved by the manufacturer.
•Any food loss due to product failures.
•Replacement parts or repair labor costs for units operated outside the United States or Canada.
•Pickup and delivery of your product.
•Postage fees or photo processing fees for photos sent in as documentation.
•Repairs to parts or systems resulting from unauthorized modifications made to the product.
•The removal and/or reinstallation of your product.
•Shipping cost, standard or expedited, for warranty/non warranty and replacement parts.
DISCLAIMER OF IMPLIED WARRANTIES; LlMlTATlON OF REMEDIES
Repair or replacement of defective parts is your exclusive remedy under the terms of this limited warranty. Manufacturer will not be
responsible for any consequential or incidental damages arising from the breach of either this limited warranty or any applicable implied
warranty, or for failure or damage resulting from acts of God, improper care and maintenance, grease fire, accident, alteration, replacement
of parts by anyone other than Manufacturer, misuse, transportation, commercial use, abuse, hostile environments (inclement weather, acts
of nature, animal tampering), improper installation or installation not in accordance with local codes or printed manufacturer instructions.
THlS LIMITED WARRANTY IS THE SOLE EXPRESS WARRANTY GIVEN BY THE MANUFACTURER. NO PRODUCT PERFORMANCE
SPECIFICATION OR DESCRIPTION WHEREVER APPEARING IS WARRANTED BY MANUFACTURER EXCEPT TO THE EXTENT SET
FORTH IN THlS LIMITED WARRANTY. ANY IMPLIED WARRANTY PROTECTION ARISING UNDER THE LAWS OF ANY STATE,
INCLUDING IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE OR USE, IS HEREBY
LIMITED IN DURATION TO THE DURATION OF THlS LIMITED WARRANTY.
Neither dealers nor the retail establishment selling this product has any authority to make any additional warranties or to promise remedies in
addition to or inconsistent with those stated above. Manufacturer's maximum liability, in any event, shall not exceed the documented
purchase price of the product paid by the original consumer. This warranty only applies to units purchased from an authorized retailer and or
re-seller. NOTE: Some states do not allow an exclusion or limitation of incidental or consequential damages, so some of the above
limitations or exclusions may not apply to you; this limited warranty gives you specific legal rights as set for herein. You may also have other
rights which vary from state to state.
If you wish to obtain performance of any obligation under this limited warranty, you should write to:
Nexgrill Customer Relations
5270 Edison Ave.
Chino, CA 91710
All consumer returns, parts orders, general questions, and troubleshooting
assistance can be acquired by calling 1-866-984-7455 .
15
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertising