American Hearth BF28BM, BI28BM, BP28BM Mantis Bay Window Installation instructions
PDF
Download
Document
Advertisement
Advertisement
™
INSTALLATION INSTRUCTIONS
INSTALLER: Leave this manual with the appliance.
CONSUMER: Retain this manual for future reference.
WARNING
FIRE OR EXPLOSION HAZARD
Failure to follow safety warnings exactly
could result in serious injury, death or
property damage.
² 'RQRWVWRUHRUXVHJDVROLQHRURWKHUÀDPmable vapors and liquids in the vicinity of
this or any other appliance.
— WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch; do
not use any phone in your building.
• Leave the building immediately.
• Immediately call your gas supplier
from a neighbor’s phone. Follow the
gas supplier’s instructions.
• If you cannot reach your gas supplier,
FDOOWKH¿UHGHSDUWPHQW
— Installation and service must be perIRUPHG E\ D TXDOL¿HG LQVWDOOHU VHUYLFH
agency or the gas supplier.
WARNING: If not installed, operated and maintained
in accordance with the manufacturer’s instructions,
this product could expose you to substances in fuel
or from fuel combustion which can cause death or
serious illness.
POWER-VENT
HIGH-EFFICIENCY
FIREPLACE WITH
BAY WINDOW MANTIS MODELS
BF28(B,C,G)M(N,P)-5
BI28(B,C,G)M(N,P)-5
BP28(B,C,G)M(N,P)-5
FIREPLACE MANTIS MODELS
FF28BM(N,P)-3
FI28BM(N,P)-3
FW28BM(N,P)-3
Attention: Check local codes for venting requirements.
This appliance may be installed in
an aftermarket, permanently located,
manufactured home (USA only) or mobile
home, where not prohibited by state or local
codes.
This appliance is only for use with the type
of gas indicated on the rating plate. This
appliance is not convertible for use with other
JDVHVXQOHVVDFHUWL¿HGNLWLVXVHG
WARNING
HOT GLASS WILL
CAUSE BURNS.
DO NOT TOUCH GLASS
UNTIL COOLED.
NEVER ALLOW CHILDREN
TO TOUCH GLASS.
A barrier designed to reduce the risk of burns from the
hot viewing glass is provided with this appliance and shall
be installed for the protection of children and other at-risk
individuals.
Page 1
TABLE OF CONTENTS
SECTION
PAGE
IMPORTANT SAFETY INFORMATION ............................................................................................ 3
SAFETY INFORMATION FOR USERS OF LP-GAS ....................................................................... 4
REQUIREMENTS FOR MASSACHUSETTS ................................................................................... 5
INTRODUCTION .............................................................................................................................. 6
SPECIFICATIONS & ACCESSORIES.............................................................................................. 7
INSTALLATION AND GENERAL SAFETY INFORMATION ............................................................. 8
GAS SUPPLY ................................................................................................................................... 9
VENT CLEARANCES..................................................................................................................... 10
VENTING REQUIREMENTS..................................................................................................... 11-12
VENT ADAPTOR KITS ................................................................................................................... 12
PVVK-CFA FLEX VENT KIT ........................................................................................................... 12
PVVTC TERMINATION CAP VENT KIT......................................................................................... 13
VENT EXAMPLES FOR SINGLE FLUE....................................................................................14-15
PVCA HORIZONTAL COLINEAR DIRECT VENT ADAPTOR ........................................................ 16
COLINEAR TRANSITION VENT KIT ............................................................................................. 17
DIRECT VENT COLINEAR VENT EXAMPLES ........................................................................18-20
PVVK-24H AND PVVK-48H CO-AXIAL VENT KIT....................................................................21-23
ROUGH FRAMING DIMENSIONS ................................................................................................. 24
INSERT INTO MASONRY FIREPLACE ......................................................................................... 25
BAY WINDOW MANTIS CLEARANCE TO COMBUSTIBLES ....................................................... 26
FIREPLACE MANTIS CLEARANCE TO COMBUSTIBLES ........................................................... 27
BAY WINDOW MANTIS SPECIFICATIONS..............................................................................28-29
FIREPLACE MANTIS SPECIFICATIONS .................................................................................30-31
GAS CONNECTION INSTALLATION ............................................................................................. 32
BAY WINDOW MANTIS LOG SET INSTALLATION INSTRUCTIONS ......................................33-34
FIREPLACE MANTIS LOG SET INSTALLATION INSTRUCTIONS .............................................. 35
WIRING .......................................................................................................................................... 36
START UP CHECK LIST ................................................................................................................ 37
LIGHTING INSTRUCTIONS........................................................................................................... 38
START UP AND ADJUSTMENTS .............................................................................................39-40
FRBTC REMOTE INSTRUCTIONS ..........................................................................................41-46
AUTOMATIC HUMIDIFIER OPERATION ....................................................................................... 47
OPTIONAL CONTROLS ................................................................................................................ 48
MAINTENANCE & SERVICE ....................................................................................................49-51
BAY WINDOW MANTIS PARTS LIST .......................................................................................52-53
BAY WINDOW MANTIS PARTS VIEW .....................................................................................54-55
FIREPLACE MANTIS PARTS LIST ................................................................................................ 56
FIREPLACE MANTIS PARTS VIEW .............................................................................................. 57
MASTER PARTS DISTRIBUTOR LIST .......................................................................................... 58
HOW TO ORDER REPAIR PARTS ................................................................................................ 58
WARRANTY ................................................................................................................................... 59
Page 2
30259-9-1115
IMPORTANT SAFETY INFORMATION
THIS IS A HEATING APPLIANCE
Safety markings are frequently used in this manual to designate a degree or level of
seriousness and should not be ignored.
WARNING indicates a potentially hazardous situation that if not avoided, could result in personal injury or death.
CAUTION indicates a potentially hazardous situation that if not avoided, may result
in minor or moderate injury or property damage.
WARNING
This appliance must be installed and repaired by a quali¿HGVHUYLFHSHUVRQZKRLVIDPLOLDUZLWKWKHSURSHULQVWDOODWLRQ DQG RSHUDWLRQ RI WKH 0DQWLV 3RZHU9HQW +LJK (I¿ciency Fireplace. Installers who are not familiar with the
installation of the Mantis and have questions, should contact Empire Comfort Systems, Inc. prior to installing the
appliance to avoid creating a hazardous operating condition.
•
•
•
•
WARNING
Due to high temperatures the appliance should be
ORFDWHG RXW RI WUDI¿F DQG DZD\ IURP IXUQLWXUH DQG
draperies.
•
Children and adults should be alerted to the hazards
of high surface temperatures and should stay away to
avoid burns or clothing ignition.
•
Young children should be carefully supervised when
they are in the same room as the appliance. Toddlers,
young children and others may be susceptible to accidental contact burns. A physical barrier is recommended if there are at risk individuals in the house. To reVWULFWDFFHVVWRD¿UHSODFHRUVWRYHLQVWDOODQDGMXVWDEOH
safety gate to keep away toddlers, young children and
other at risk individuals out of the room and away from
hot surfaces.
A barrier designed to reduce the risk of burns from the
hot viewing glass is provided with this appliance and
shall be installed for the protection of children and other
at-risk individuals.
If the barrier becomes damaged, the barrier shall be
replaced with the manufacturer’s barrier for this appliance.
Any safety screen, guard, or barrier removed for servicing an appliance must be replaced prior to operating the
appliance.
Installation and repair should be done by a QUALIFIED
SERVICE PERSON. The appliance should be inspected beIRUHXVHDQGDWOHDVWDQQXDOO\E\DTXDOL¿HGVHUYLFHSHUVRQ
More frequent cleaning may be required due to excessive
lint from carpeting, bedding materials, etc. It is imperative
that control compartments, burners and circulating air
passageways of the appliance be kept clean.
•
DO NOT put anything around the heater that will
REVWUXFWWKHÀRZRIFRPEXVWLRQDQGYHQWLODWLRQDLU
•
DO keep the appliance area clear and free from
FRPEXVWLEOH PDWHULDO JDVROLQH DQG RWKHU ÀDPPDEOH
vapors and liquids.
•
DO examine venting system periodically and replace
damaged parts.
•
DO make a periodic visual check of burner. Clean and
replace damaged parts.
•
DO NOT use this heater if any part has been under water.
,PPHGLDWHO\FDOODTXDOL¿HGVHUYLFHWHFKQLFLDQWRLQVSHFW
the heater and to replace any part of the control system
and any gas control which has been under water.
DO NOT operate this appliance without the front panel
installed.
&ORWKLQJ RU RWKHU ÀDPPDEOH PDWHULDO VKRXOG QRW EH
placed on or near the appliance.
•
Any safety screen or guard removed for servicing an
appliance, must be replaced prior to operating the
appliance.
•
Keep burner and control compartment clean.
•
For manufactured home (USA only) or mobile home
or residential installation convertible for use with
QDWXUDO JDV DQG OLTXH¿HG SHWUROHXP JDVHV ZKHQ
provision is made for the simple conversion from one
gas to the other.
•
Young children should be carefully supervised when
they are in the same room as the appliance. Toddlers,
young children, and others may be susceptible to accidental contact burns. A physical barrier is recommended if there are at-risk individuals in the house. To
UHVWULFWDFFHVVWRD¿UHSODFHRUVWRYHLQVWDOODQDGMXVWable safety gate to keep toddlers young children, and
other at-risk individuals out of the room and away from
hot surfaces.
1.
•
30259-9-1115
Note to the Installer
The installer must leave instruction manual with owner after
installation.
7KH LQVWDOOHU PXVW KDYH WKH RZQHU ¿OO RXW DQG PDLO
UHJLVWUDWLRQFDUGVXSSOLHGZLWKWKHKHDWHURURQOLQHDWZZZ
HPSLUHFRPIRUWFRP
7KH LQVWDOOHU VKRXOG VKRZ WKH RZQHU KRZ WR VWDUW DQG
RSHUDWHKHDWHUDQGWKHUPRVWDW
7KH LQVWDOOHU PXVW ORFDWH XQLW QHDU D JURXQGHG ZDOO
UHFHSWDFOHIRU9$&SRZHUDQGPXVWSURYLGHJDVVXSSO\
DQGYHQWWKHXQLWSURSHUO\IRUVDIHRSHUDWLRQ
Page 3
SAFETY INFORMATION FOR USERS OF LP-GAS
/3*DV3URSDQHLVDÀDPPDEOHJDVZKLFKFDQFDXVH¿UHVDQG
H[SORVLRQV,QLWVQDWXUDOVWDWHSURSDQHLVRGRUOHVVDQGFRORUOHVV
<RXPD\QRWNQRZDOOWKHIROORZLQJVDIHW\SUHFDXWLRQVZKLFKFDQ
SURWHFW ERWK \RX DQG \RXU IDPLO\ IURP DQ DFFLGHQW 5HDG WKHP
FDUHIXOO\QRZWKHQUHYLHZWKHPSRLQWE\SRLQWZLWKWKHPHPEHUV
RI\RXUKRXVHKROG6RPHGD\WKHUHPD\QRWEHDPLQXWHWRORVH
HYHU\RQH¶VVDIHW\ZLOOGHSHQGRQNQRZLQJH[DFWO\ZKDWWRGR,I
DIWHU UHDGLQJ WKH IROORZLQJ LQIRUPDWLRQ \RX IHHO \RX VWLOO QHHG
PRUHLQIRUPDWLRQSOHDVHFRQWDFW\RXUJDVVXSSOLHU
LP-GAS WARNING ODOR
If a gas leak happens, you should be able to smell the gas because of the odorant put in the LP-Gas.
That’s your signal to go into immediate action!
'R QRW RSHUDWH HOHFWULF VZLWFKHV OLJKW PDWFKHV XVH \RXU
SKRQH'RQRWGRDQ\WKLQJWKDWFRXOGLJQLWHWKHJDV
*HWHYHU\RQHRXWRIWKHEXLOGLQJYHKLFOHWUDLOHURUDUHD'R
that IMMEDIATELY.
&ORVHDOOJDVWDQNRUF\OLQGHUVXSSO\YDOYHV
/3*DVLVKHDYLHUWKDQDLUDQGPD\VHWWOHLQORZDUHDVVXFK
DVEDVHPHQWV:KHQ\RXKDYHUHDVRQWRVXVSHFWDJDVOHDN
NHHSRXWRIEDVHPHQWVDQGRWKHUORZDUHDV6WD\RXWXQWLO
¿UH¿JKWHUVGHFODUHWKHPWREHVDIH
8VH\RXUQHLJKERU¶VSKRQHDQGFDOODWUDLQHG/3*DVVHUYLFH
SHUVRQ DQG WKH ¿UH GHSDUWPHQW (YHQ WKRXJK \RX PD\ QRW
FRQWLQXHWRVPHOOJDVGRQRWWXUQRQWKHJDVDJDLQ'RQRW
UHHQWHUWKHEXLOGLQJYHKLFOHWUDLOHURUDUHD
)LQDOO\OHWWKHVHUYLFHPDQDQG¿UH¿JKWHUVFKHFNIRUHVFDSHG
JDV+DYHWKHPDLURXWWKHDUHDEHIRUH\RXUHWXUQ3URSHUO\
WUDLQHG/3*DVVHUYLFHSHRSOHVKRXOGUHSDLUWKHOHDNWKHQ
FKHFNDQGUHOLJKWWKHJDVDSSOLDQFHIRU\RX
NO ODOR DETECTED - ODOR FADE
6RPHSHRSOHFDQQRWVPHOOZHOO6RPHSHRSOHFDQQRWVPHOOWKH
RGRU RI WKH FKHPLFDO SXW LQWR WKH JDV<RX PXVW ¿QG RXW LI \RX
FDQ VPHOO WKH RGRUDQW LQ SURSDQH 6PRNLQJ FDQ GHFUHDVH \RXU
DELOLW\WRVPHOO%HLQJDURXQGDQRGRUIRUDWLPHFDQDIIHFW\RXU
VHQVLWLYLW\RUDELOLW\WRGHWHFWWKDWRGRU6RPHWLPHVRWKHURGRUVLQ
WKHDUHDPDVNWKHJDVRGRU3HRSOHPD\QRWVPHOOWKHJDVRGRU
RUWKHLUPLQGVDUHRQVRPHWKLQJHOVH7KLQNLQJDERXWVPHOOLQJD
JDVRGRUFDQPDNHLWHDVLHUWRVPHOO
7KHRGRUDQWLQ/3JDVLVFRORUOHVVDQGLWFDQIDGHXQGHUVRPH
FLUFXPVWDQFHV)RUH[DPSOHLIWKHUHLVDQXQGHUJURXQGOHDNWKH
PRYHPHQWRIWKHJDVWKURXJKVRLOFDQ¿OWHUWKHRGRUDQW2GRUDQWV
LQ/3*DVDOVRDUHVXEMHFWWRR[LGDWLRQ7KLVIDGLQJFDQRFFXULI
WKHUHLVUXVWLQVLGHWKHVWRUDJHWDQNRULQLURQJDVSLSHV
7KHRGRUDQWLQHVFDSHGJDVFDQDGVRUERUDEVRUERQWRRULQWR
ZDOOVPDVRQU\DQGRWKHUPDWHULDOVDQGIDEULFVLQDURRP7KDW
ZLOO WDNH VRPH RI WKH RGRUDQW RXW RI WKH JDV UHGXFLQJ LWV RGRU
LQWHQVLW\
/3*DV PD\ VWUDWLI\ LQ D FORVHG DUHD DQG WKH RGRU LQWHQVLW\
FRXOG YDU\ DW GLIIHUHQW OHYHOV 6LQFH LW LV KHDYLHU WKDQ DLU WKHUH
PD\ EH PRUH RGRU DW ORZHU OHYHOV $OZD\V EH VHQVLWLYH WR WKH
VOLJKWHVWJDVRGRU,I\RXGHWHFWDQ\RGRUWUHDWLWDVDVHULRXVOHDN
,PPHGLDWHO\JRLQWRDFWLRQDVLQVWUXFWHGHDUOLHU
SOME POINTS TO REMEMBER
/HDUQ WR UHFRJQL]H WKH RGRU RI /3JDV <RXU ORFDO /3*DV
'HDOHUFDQJLYH\RXD³6FUDWFKDQG6QLII´SDPSKOHW8VHLW
WR¿QGRXWZKDWWKHSURSDQHRGRUVPHOOVOLNH,I\RXVXVSHFW
WKDW \RXU /3*DV KDV D ZHDN RU DEQRUPDO RGRU FDOO \RXU
LP-Gas Dealer.
,I \RX DUH QRW TXDOL¿HG GR QRW OLJKW SLORW OLJKWV SHUIRUP
VHUYLFHRUPDNHDGMXVWPHQWVWRDSSOLDQFHVRQWKH/3*DV
V\VWHP,I\RXDUHTXDOL¿HGFRQVFLRXVO\WKLQNDERXWWKHRGRU
RI/3*DVSULRUWRDQGZKLOHOLJKWLQJSLORWOLJKWVRUSHUIRUPLQJ
VHUYLFHRUPDNLQJDGMXVWPHQWV
6RPHWLPHVDEDVHPHQWRUDFORVHGXSKRXVHKDVDPXVW\
VPHOOWKDWFDQFRYHUXSWKH/3*DVRGRU'RQRWWU\WROLJKW
SLORWOLJKWVSHUIRUPVHUYLFHRUPDNHDGMXVWPHQWVLQDQDUHD
ZKHUHWKHFRQGLWLRQVDUHVXFKWKDW\RXPD\QRWGHWHFWWKH
RGRULIWKHUHKDVEHHQDOHDNRI/3*DV
2GRU IDGH GXH WR R[LGDWLRQ E\ UXVW RU DGVRUSWLRQ RQ ZDOOV
RI QHZ F\OLQGHUV DQG WDQNV LV SRVVLEOH 7KHUHIRUH SHRSOH
VKRXOG EH SDUWLFXODUO\ DOHUW DQG FDUHIXO ZKHQ QHZ WDQNV RU
F\OLQGHUVDUHSODFHGLQVHUYLFH2GRUIDGHFDQRFFXULQQHZ
WDQNVRUUHLQVWDOOHGROGWDQNVLIWKH\DUH¿OOHGDQGDOORZHG
WR VHW WRR ORQJ EHIRUH UH¿OOLQJ &\OLQGHUV DQG WDQNV ZKLFK
KDYH EHHQ RXW RI VHUYLFH IRU D WLPH PD\ GHYHORS LQWHUQDO
UXVWZKLFKZLOOFDXVHRGRUIDGH,IVXFKFRQGLWLRQVDUHVXV-
Page 4
SHFWHGWRH[LVWDSHULRGLFVQLIIWHVWRIWKHJDVLVDGYLVDEOH,I
\RXKDYHDQ\TXHVWLRQDERXWWKHJDVRGRUFDOO\RXU/3JDV
GHDOHU$ SHULRGLF VQLII WHVW RI WKH /3JDV LV D JRRG VDIHW\
PHDVXUHXQGHUDQ\FRQGLWLRQ
,I DW DQ\ WLPH \RX GR QRW VPHOO WKH /3*DV RGRUDQW DQG
\RX WKLQN \RX VKRXOG DVVXPH \RX KDYH D OHDN7KHQ WDNH
WKH VDPH LPPHGLDWH DFWLRQ UHFRPPHQGHG DERYH IRU WKH
RFFDVLRQZKHQ\RXGRGHWHFWWKHRGRUL]HG/3*DV
,I \RX H[SHULHQFH D FRPSOHWH ³JDV RXW´ WKH FRQWDLQHU
LV XQGHU QR YDSRU SUHVVXUH WXUQ WKH WDQN YDOYH RII
LPPHGLDWHO\ ,I WKH FRQWDLQHU YDOYH LV OHIW RQ WKH FRQWDLQHU
PD\ GUDZ LQ VRPH DLU WKURXJK RSHQLQJV VXFK DV SLORW OLJKW
RUL¿FHV ,I WKLV RFFXUV VRPH QHZ LQWHUQDO UXVWLQJ FRXOG
RFFXU ,I WKH YDOYH LV OHIW RSHQ WKHQ WUHDW WKH FRQWDLQHU DV
D QHZ WDQN$OZD\V EH VXUH \RXU FRQWDLQHU LV XQGHU YDSRU
SUHVVXUH E\ WXUQLQJ LW RII DW WKH FRQWDLQHU EHIRUH LW JRHV
FRPSOHWHO\ HPSW\ RU KDYLQJ LW UH¿OOHG EHIRUH LW LV
FRPSOHWHO\HPSW\
30259-9-1115
REQUIREMENTS FOR MASSACHUSETTS
)RUDOOVLGHZDOOKRUL]RQWDOO\YHQWHGJDVIXHOHGHTXLSPHQWLQVWDOOHG
LQHYHU\GZHOOLQJEXLOGLQJRUVWUXFWXUHXVHGLQZKROHRULQSDUWIRU
UHVLGHQWLDO SXUSRVHV LQFOXGLQJ WKRVH RZQHG RU RSHUDWHG E\ WKH
&RPPRQZHDOWKDQGZKHUHWKHVLGHZDOOH[KDXVWYHQWWHUPLQDWLRQ
LV OHVV WKDQ VHYHQ IHHW DERYH ¿QLVKHG JUDGH LQ WKH DUHD RI
WKH YHQWLQJ LQFOXGLQJ EXW QRW OLPLWHG WR GHFNV DQG SRUFKHV WKH
IROORZLQJUHTXLUHPHQWVVKDOOEHVDWLV¿HG
1. INSTALLATION OF CARBON MONOXIDE DETECTORS.
$W WKH WLPH RI LQVWDOODWLRQ RI WKH VLGH ZDOO KRUL]RQWDO YHQWHG
JDVIXHOHGHTXLSPHQWWKHLQVWDOOLQJSOXPEHURUJDV¿WWHUVKDOO
REVHUYHWKDWDKDUGZLUHGFDUERQPRQR[LGHGHWHFWRUZLWKDQ
DODUPDQGEDWWHU\EDFNXSLVLQVWDOOHGRQWKHÀRRUOHYHOZKHUH
WKHJDVHTXLSPHQWLVWREHLQVWDOOHG,QDGGLWLRQWKHLQVWDOOLQJ
SOXPEHU RU JDV¿WWHU VKDOO REVHUYH WKDW D EDWWHU\ RSHUDWHG
RU KDUG ZLUHG FDUERQ PRQR[LGH GHWHFWRU ZLWK DQ DODUP LV
LQVWDOOHGRQHDFKDGGLWLRQDOOHYHORIWKHGZHOOLQJEXLOGLQJRU
VWUXFWXUHVHUYHGE\WKHVLGHZDOOKRUL]RQWDOYHQWHGJDVIXHOHG
HTXLSPHQW,WVKDOOEHWKHUHVSRQVLELOLW\RIWKHSURSHUW\RZQHU
WRVHFXUHWKHVHUYLFHVRITXDOL¿HGOLFHQVHGSURIHVVLRQDOVIRU
WKHLQVWDOODWLRQRIKDUGZLUHGFDUERQPRQR[LGHGHWHFWRUV
D ,Q WKH HYHQW WKDW WKH VLGH ZDOO KRUL]RQWDOO\ YHQWHG JDV
IXHOHGHTXLSPHQWLVLQVWDOOHGLQDFUDZOVSDFHRUDQDWWLF
WKHKDUGZLUHGFDUERQPRQR[LGHGHWHFWRUZLWKDODUPDQG
EDWWHU\ EDFNXS PD\ EH LQVWDOOHG RQ WKH QH[W DGMDFHQW
ÀRRUOHYHO
E ,QWKHHYHQWWKDWWKHUHTXLUHPHQWVRIWKLVVXEGLYLVLRQFDQ
QRW EH PHW DW WKH WLPH RI FRPSOHWLRQ RI LQVWDOODWLRQ WKH
RZQHUVKDOOKDYHDSHULRGRIWKLUW\GD\VWRFRPSO\ZLWK
WKHDERYHUHTXLUHPHQWVSURYLGHGKRZHYHUWKDWGXULQJ
VDLG WKLUW\ GD\ SHULRG D EDWWHU\ RSHUDWHG FDUERQ
PRQR[LGHGHWHFWRUZLWKDQDODUPVKDOOEHLQVWDOOHG
2.
APPROVED CARBON MONOXIDE DETECTORS. Each
FDUERQPRQR[LGHGHWHFWRUDVUHTXLUHGLQDFFRUGDQFHZLWKWKH
DERYHSURYLVLRQVVKDOOFRPSO\ZLWK1)3$DQGEH$16,
8/OLVWHGDQG,$6FHUWL¿HG
6,*1$*( $ PHWDO RU SODVWLF LGHQWL¿FDWLRQ SODWH VKDOO EH
SHUPDQHQWO\ PRXQWHG WR WKH H[WHULRU RI WKH EXLOGLQJ DW D
PLQLPXPKHLJKWRIHLJKWIHHWDERYHJUDGHGLUHFWO\LQOLQH
ZLWK WKH H[KDXVW YHQW WHUPLQDO IRU WKH KRUL]RQWDOO\ YHQWHG
JDV IXHOHG KHDWLQJ DSSOLDQFH RU HTXLSPHQW 7KH VLJQ VKDOO
UHDG LQ SULQW VL]H QR OHVV WKDQ RQHKDOI LQFK LQ VL]H
“GAS VENT DIRECTLY BELOW. KEEP CLEAR OF ALL
OBSTRUCTIONS”.
,163(&7,21 7KH VWDWH RU ORFDO JDV LQVSHFWRU RI WKH VLGH
ZDOO KRUL]RQWDOO\ YHQWHG JDV IXHOHG HTXLSPHQW VKDOO QRW
DSSURYHWKHLQVWDOODWLRQXQOHVVXSRQLQVSHFWLRQWKHLQVSHFWRU
REVHUYHV FDUERQ PRQR[LGH GHWHFWRUV DQG VLJQDJH LQVWDOOHG
LQ DFFRUGDQFH ZLWK WKH SURYLVLRQV RI &05 D through 4.
E (;(037,2167KHIROORZLQJHTXLSPHQWLVH[HPSWIURP
&05DWKURXJK
7KH HTXLSPHQW OLVWHG LQ &KDSWHU HQWLWOHG
³(TXLSPHQW1RW5HTXLUHG7R%H9HQWHG´LQWKHPRVW
FXUUHQWHGLWLRQRI1)3$DVDGRSWHGE\WKH%RDUG
DQG
3URGXFW$SSURYHGVLGHZDOOKRUL]RQWDOO\YHQWHGJDV
IXHOHG HTXLSPHQW LQVWDOOHG LQ D URRP RU VWUXFWXUH
VHSDUDWH IURP WKH GZHOOLQJ EXLOGLQJ RU VWUXFWXUH
XVHGLQZKROHRULQSDUWIRUUHVLGHQWLDOSXUSRVHV
G 0$18)$&785(5
5(48,5(0(176
*$6
EQUIPMENT VENTING SYSTEM NOT PROVIDED.
:KHQ WKH PDQXIDFWXUHU RI D 3URGXFW $SSURYHG VLGH
ZDOO KRUL]RQWDOO\ YHQWHG JDV IXHOHG HTXLSPHQW GRHV QRW
SURYLGHWKHSDUWVIRUYHQWLQJWKHÀXHJDVHVEXWLGHQWL¿HV
³VSHFLDO YHQWLQJ V\VWHPV´ WKH IROORZLQJ UHTXLUHPHQWV
VKDOOEHVDWLV¿HGE\WKHPDQXIDFWXUHU
7KHUHIHUHQFHG³VSHFLDOYHQWLQJV\VWHP´LQVWUXFWLRQV
VKDOO EH LQFOXGHG ZLWK WKH DSSOLDQFH RU HTXLSPHQW
LQVWDOODWLRQLQVWUXFWLRQVDQG
7KH ³VSHFLDO YHQWLQJ V\VWHPV´ VKDOO EH 3URGXFW
$SSURYHG E\ WKH %RDUG DQG WKH LQVWUXFWLRQV IRU
WKDW V\VWHP VKDOO LQFOXGH D SDUWV OLVW DQG GHWDLOHG
installation instruction.
H $ FRS\ RI DOO LQVWDOODWLRQ LQVWUXFWLRQV IRU DOO 3URGXFW
$SSURYHG VLGH ZDOO KRUL]RQWDOO\ YHQWHG JDV IXHOHG
HTXLSPHQW DOO YHQWLQJ LQVWUXFWLRQV DOO SDUWV OLVWV IRU
YHQWLQJLQVWUXFWLRQVDQGRUDOOYHQWLQJGHVLJQLQVWUXFWLRQV
VKDOO UHPDLQ ZLWK WKH DSSOLDQFH RU HTXLSPHQW DW WKH
FRPSOHWLRQRIWKHLQVWDOODWLRQ
Sate of Massachusetts: 7KH LQVWDOODWLRQ PXVW EH PDGH
E\ D OLFHQVHG SOXPEHU RU JDV ¿WWHU LQ WKH &RPPRQZHDOWK RI
Massachusetts.
30259-9-1115
Page 5
INTRODUCTION
WARNING
The safety information listed below must be followed
during the installation, service, and operation of this
product. Failure to following the safety recommendations could result in possible damage to the equipment, serious personal injury, or death.
Additional code information listed below is for reference purposes only and does not necessarily have jurisdiction over
local or state codes. Always consult with local authorities before installing any gas appliance.
Combustion and Ventilation Air
861DWLRQDO)XHO*DV&RGH1)3$$16,=1)*&$LU
IRU&RPEXVWLRQDQG9HQWLODWLRQ
Page 6
Electrical Connections
861DWLRQDO(OHFWULFDO&RGH1(&$16,1)3$
Gas Piping and Gas Pipe Pressure Testing
861)*&DQG1DWLRQDO3OXPELQJ&RGHV
General Installations
86&XUUHQWHGLWLRQRIWKH1)*&DQG1)3$%)RUFRSLHVFRQWDFW WKH 1DWLRQDO )LUH 3URWHFWLRQ $VVRFLDWLRQ ,QF %DWWHU\PDUFK
3DUN 4XLQF\ 0$ RU $PHULFDQ *DV $VVRFLDWLRQ 1
&DSLWRO1::DVKLQJWRQ'&RUZZZ1)3$RUJ
Safety
861)*&1)3$$16,=
30259-9-1115
SPECIFICATIONS & ACCESSORIES
Fireplace Mantis Models
F(F,I,W)28BM(N,P)
Bay Window Mantis Models
B(F,I,P)28(B,C,G)M(N,P)
,QSXW%78+5.:+
5HDU
)URQW
,QSXW%78+5.:+
5HDU
)URQW
Height
´
Height
´
:LGWK
´
:LGWK
´
'HSWK
´
'HSWK
´
*DV,QOHW3LSH
´)ODLU
*DV,QOHW3LSH
´)ODLU
(OHFWULFDO 7KH XQLW FRPHV HTXLSSHG ZLWK D IRRW P SURQJHG FRUG IRU FRQQHFWLRQ WR DQ DSSURYHG
9$&+]$PD[LPXPZDOOUHFHSWDFOH
(OHFWULFDO 7KH XQLW FRPHV HTXLSSHG ZLWK D IRRW P
SURQJHG FRUG IRU FRQQHFWLRQ WR DQ DSSURYHG
9$&+]$PD[LPXPZDOOUHFHSWDFOH
9HQW3LSHLQFKGLDPHWHUVFKHGXOH39&SLSHIHHW
PD[LPXPHTXLYDOHQWOHQJWKZLWKHOERZV
9HQW3LSHLQFKGLDPHWHUVFKHGXOH39&SLSHIHHW
PD[LPXPHTXLYDOHQWOHQJWKZLWKHOERZV
ACCESSORIES
Common To Bay Window and Fireplace Mantis
Part Number
Description
TRW
Wall Thermostat - Wireless Remote
FRBTP
%DWWHU\2SHUDWHG5HPRWHZLWK3URJUDPPDEOH7KHUPRVWDW
PVCA
&ROLQHDU$GDSWHU
PVCT
Colinear Transition Kit
PVVK-CFA
Flex Vent Kit
PVVK-FC
Single Flue Horizontal Vent Kit
PVVK-SV
Single Flue Vertical Vent Kit
PVVTC
9HUWLFDO7HUPLQDWLRQ&DS´
PVVK24H
&RD[LDO+RUL]RQWDO'LUHFW9HQW.LW´
PVVK48H
&RD[LDO+RUL]RQWDO'LUHFW9HQW.LW´
Part Number
Description
CIFPB-1C
&RUQHU)ORRU3DG.LW
CIPFP-1
)ORRU3DG.LW
PV-2H
6OLP7RS&RYHU.LW
PV-4H
6KRUW7RS&RYHU.LW
PVE-1
0HWDO6XUURXQG.LW´
PVE-2
0HWDO6XUURXQG.LW´
PVPK
3HGHVWDO.LW
PVSH
5HDU6KURXG
BFFB28SBL
%D\:LQGRZ)LUHSODFH%DUULHU
Part Number
Description
FWKQ28BL
,Q:DOO6XUURXQG.LWZLWK%DUULHU3LFWXUH)UDPH
FHKQ28BL
,Q:DOO6XUURXQG.LWZLWK%DUULHU/RXYHUOHVV
FIKQ28BL
´:LGH[´7DOO,QVHUW6XUURXQG.LWZLWK%DUULHU
FFKQ28BL
´:LGH[´7DOO)LUHSODFH0DQWHO6XUURXQG.LWZLWK%DUULHU
Bay Window Mantis Only
Fireplace Mantis Only
1RWH$EDUULHULVUHTXLUHGIRURSHUDWLRQRIWKLVDSSOLDQFH
30259-9-1115
Page 7
INSTALLATION AND GENERAL SAFETY INFORMATION
General Information
7KLVVHULHVLVGHVLJQHGFHUWL¿HGLQDFFRUGDQFHZLWK$PHULFDQ1DWLRQDO6WDQGDUG&6$6WDQGDUG=DVD*DV)LUHSODFH+HDWHU
WREHLQVWDOOHGDFFRUGLQJWRWKHVHLQVWUXFWLRQV
Note:
8QGHUQRFLUFXPVWDQFHVVKRXOGWKH¿UHSODFHEHLQVWDOOHG
XQGHUFRQGLWLRQVWKDWZRXOGQRWDOORZIRUHDV\UHPRYDORI
WKH¿UHSODFHWRFDUU\RXWURXWLQHLQVSHFWLRQDQGVHUYLFHWR
WKH¿UHSODFH
Any alteration of the original design, installed other than as
shown in these instructions will be the responsibility of the
person and company making the changes, and will void the
warranty. This product may not be used with any type of gas
other than what is shown on the rating plate.
Note:
:KHUHDPDQWHOVXUURXQGLVEHLQJXVHGRQLQVHUWLQVWDOODWLRQVDQG]HURFOHDUDQFH¿UHSODFHLQVWDOODWLRQVWKHFRPEXVWLRQDLULQWDNHVORWORFDWHGLQWKHWRSPDQWHOVXUURXQG
PXVWQRWEHREVWUXFWHG7KLVZLOODOORZFRPEXVWLRQDLUWR
HQWHUWKURXJKWKHVORWWRWKHFRPEXVWLRQDLULQOHWORFDWHG
DWWKHEDFNRIWKH¿UHSODFH
Note:
'XULQJ LQLWLDO ¿ULQJ RI WKLV XQLW UHVLGXDO RLO IURP WKH
KHDW H[FKDQJHU PD\ EDNH RII DQG VPRNH PD\ RFFXU
3URYLGHDGHTXDWHYHQWLODWLRQWRWKHDUHDZKHUHWKH¿UHSODFHLVLQVWDOOHGWRSUHYHQWWULJJHULQJRIVPRNHDODUPV
5HIHUWRSDJHIRUPRUHGHWDLO
Important
$OO &RUUHVSRQGHQFH VKRXOG UHIHU WR FRPSOHWH 0RGHO 1XPEHU
6HULDO1XPEHUDQGW\SHRIJDV
Installation
,QVWDOODWLRQUHSODFHPHQWJDVSLSLQJJDVXWLOL]DWLRQHTXLSPHQWRU
DFFHVVRULHV DQG WKH UHSDLU DQG VHUYLFH RI WKLV HTXLSPHQW PXVW
EHSHUIRUPHGE\DTXDOL¿HGDJHQF\7KHWHUP³TXDOL¿HGDJHQF\´
PHDQVDQ\LQGLYLGXDO¿UPFRUSRUDWLRQRUFRPSDQ\ZKLFKHLWKHULQ
SHUVRQRUWKURXJKDUHSUHVHQWDWLYHLVHQJDJHGLQDQGLVUHVSRQVLEOHIRUDWKHLQVWDOODWLRQRUUHSODFHPHQWRIJDVSLSLQJRUEWKH
FRQQHFWLRQ LQVWDOODWLRQ UHSDLU RU VHUYLFLQJ RI HTXLSPHQW ZKR LV
H[SHULHQFHG LQ VXFK ZRUN IDPLOLDU ZLWK DOO SUHFDXWLRQV UHTXLUHG
DQGKDVFRPSOLHGZLWKDOOWKHUHTXLUHPHQWVRIWKHDXWKRULW\KDYLQJ
MXULVGLFWLRQ
7KLV LQVWDOODWLRQ PXVW FRQIRUP ZLWK ORFDO FRGHV RU LQ WKH
DEVHQFH RI ORFDO FRGHV WKH 1DWLRQDO )XHO *DV &RGH
1)3$$16,=
7KLV¿UHSODFHZKHQLQVWDOOHGPXVWEHHOHFWULFDOO\JURXQGHG
LQ DFFRUGDQFH ZLWK ORFDO FRGHV RU ,Q WKH DEVHQFH RI ORFDO
FRGHVZLWKWKH1DWLRQDO(OHFWULFDO&RGH$16,1)3$
3URYLGHDGHTXDWHFOHDUDQFHVDURXQGWKH¿UHSODFHIRUVHUYLFLQJDQGHQVXUHWKHUHDUHQRREVWUXFWLRQVWRWKHFRPEXVWLRQDLU
LQWDNHVLWXDWHGDWWKHEDFNRIWKH¿UHSODFH5HIHUWR3DJHV
to 27.
7KH0DQWLV3RZHU9HQW+LJK(I¿FLHQF\)LUHSODFHPXVWEHLQVWDOOHG RQ D ÀDW VROLG FRQWLQXRXV VXUIDFH LH ZRRG PHWDO
FRQFUHWH5RXJKRUXQHYHQVXUIDFHVFDQFDXVHYLEUDWLRQRU
KXPPLQJLQWKH¿UHSODFH
7KLV ¿UHSODFH PXVW EH LQVWDOOHG LQ VXFK D ZD\ WKDW WKH
¿UHSODFHFDQEHUHPRYHGIRUVHUYLFLQJWKHKHDWH[FKDQJHUDQGWKHÀXHWKDWDUHORFDWHGLQWKHUHDUVHFWLRQRIWKH
¿UHSODFH
7KLV¿UHSODFHLVHTXLSSHGZLWKDWKUHHSURQJ>JURXQGLQJ@
plug for your protection against shock hazard and should
be plugged directly into a properly grounded three-prong
receptacle. Do not cut or remove the grounding prong
from this plug. )RUDQXQJURXQGHGUHFHSWDFOHSXUFKDVHDQ
DGDSWHUZLWKWZRSURQJVDQGDZLUHIRUJURXQGLQJ
Page 8
$PDQXIDFWXUHGKRPH86$RQO\RUPRELOHKRPH2(0LQVWDOODWLRQPXVWFRQIRUPZLWKWKH0DQXIDFWXUHG+RPH&RQVWUXFWLRQDQG
6DIHW\6WDQGDUG7LWOH&)53DUWRUZKHQVXFKDVWDQGDUG LV QRW DSSOLFDEOH WKH 6WDQGDUG IRU 0DQXIDFWXUHG +RPH ,QVWDOODWLRQV$16,1&6%&6=RU6WDQGDUGIRU*DV(TXLSSHG
5HFUHDWLRQDO9HKLFOHVDQG0RELOH+RXVLQJ&6$=
Installation on Combustible Flooring
,IWKLV¿UHSODFHLVWREHLQVWDOOHGGLUHFWO\RQFDUSHWLQJWLOHRURWKHU
FRPEXVWLEOHPDWHULDORWKHUWKDQZRRGÀRRULQJWKH¿UHSODFHVKDOO
EHLQVWDOOHGRQDPHWDORUZRRGSDQHOH[WHQGLQJWKHIXOOZLGWKDQG
GHSWKRIWKH¿UHSODFH
7KHEDVHUHIHUUHGWRDERYHGRHVQRWPHDQWKH¿UHSURRIEDVHDV
XVHGRQZRRGVWRYHV7KHSURWHFWLRQLVSULPDULO\IRUUXJVWKDWPD\
EHH[WUHPHO\WKLFNDQGOLJKWFRORUWLOHWKDWFDQGLVFRORU
Installation in Residential Garages
*DVXWLOL]DWLRQHTXLSPHQWLQUHVLGHQWLDOJDUDJHVVKDOOEHLQVWDOOHG
VRWKDWDOOEXUQHUVDQGEXUQHULJQLWLRQGHYLFHVDUHORFDWHGQRWOHVV
WKDQLQFKHVPPDERYHWKHÀRRU7KHHTXLSPHQWVKDOOEH
ORFDWHG RU SURWHFWHG VR LW LV QRW VXEMHFW WR SK\VLFDO GDPDJH E\
vehicles.
Operation of Fireplace During Construction
7KH¿UHSODFHVKDOOQRWEHXVHGGXULQJFRQVWUXFWLRQ
WARNING
'RQRWRSHUDWH¿UHSODFHZLWKWKHJODVVIURQWUHPRYHG
or if it is cracked or broken. Replacement of the glass
VKDOOEHSHUIRUPHGE\DOLFHQVHGRUTXDOL¿HGVHUYLFH
person
30259-9-1115
GAS SUPPLY
$OOJDVSLSLQJPXVWEHLQVWDOOHGLQFRPSOLDQFHZLWKORFDOFRGHVDQG
XWLOLW\ UHJXODWLRQV ,Q WKH DEVHQFH RI ORFDO FRGHV WKH LQVWDOODWLRQ
PXVWFRPSO\ZLWK1)&*1)3$$16,=
Note: 1HYHU XVH SODVWLF SLSH &KHFN WR FRQ¿UP ZKHWKHU \RXU
ORFDOFRGHVDOORZFRSSHUWXELQJRUJDOYDQL]HG
:KHUHSHUPLWWHGÀH[LEOHJDVFRQQHFWRUVPXVWEHFHUWL¿HGWRWKH
IROORZLQJVWDQGDUGV
² $16=$SSOLDQFH&RQQHFWRUVRI&RUUXJDWHG0HWDO7XELQJDQG)LWWLQJV
² $16 = $VVHPEOHG )OH[LEOH $SSOLDQFH &RQQHFWRUV RI
Other Than All-Metal Construction
7KHDERYHFRQQHFWRUVPD\EHXVHGLIDFFHSWDEOHE\WKHDXWKRULW\KDYLQJMXULVGLFWLRQ7KHVWDWHRI0DVVDFKXVHWWVUHTXLUHVWKDWD
ÀH[LEOHDSSOLDQFHFRQQHFWRUFDQQRWH[FHHGWKUHHIHHWLQOHQJWK
Pressure Testing of the Gas Supply System
7RFKHFNWKHLQOHWSUHVVXUHWRWKHJDVYDOYHDLQFK137
SOXJJHGWDSSLQJDFFHVVLEOHIRUWHVWJDXJHFRQQHFWLRQPXVW
EHSODFHGLPPHGLDWHO\XSVWUHDPRIWKHJDVVXSSO\FRQQHFWLRQ
WRWKH¿UHSODFH
7KH¿UHSODFHDQGLWVLQGLYLGXDOVKXWRIIYDOYHPXVWEHGLVFRQQHFWHG IURP WKH JDV VXSSO\ SLSLQJ V\VWHP GXULQJ DQ\ SUHVVXUHWHVWLQJRIWKDWV\VWHPDWWHVWSUHVVXUHVLQH[FHVVRI
SVLJ
7KH¿UHSODFHPXVWEHLVRODWHGIURPWKHJDVVXSSO\SLSLQJV\VWHPE\FORVLQJLWVLQGLYLGXDOPDQXDOVKXWRIIYDOYHGXULQJDQ\
SUHVVXUHWHVWLQJRIWKHJDVVXSSO\SLSLQJV\VWHPDWWHVWSUHVVXUHVHTXDOWRRUOHVVWKDQSVLJ
Recommended Gas Pipe Diameter
3LSH/HQJWK
$GULSOHJVKRXOGEHLQVWDOOHGLQWKHYHUWLFDOJDVVXSSO\SLSHUXQWR
the unit.
Manual Shut-off Valve
6RPHORFDOUHJXODWLRQVUHTXLUHWKHLQVWDOODWLRQRIDPDQXDOVKXWRII
YDOYHDQGJURXQGMRLQWXQLRQH[WHUQDOWRWKH¿UHSODFH7KHVKXWRII
VKRXOGEHDFFHVVLEOHIRUVHUYLFHDQGRUHPHUJHQF\XVH&RQVXOWWKH
ORFDOXWLOLW\RUJDVVXSSOLHUIRUDGGLWLRQDOUHTXLUHPHQWVUHJDUGLQJWKH
SODFHPHQW RI WKH PDQXDO VKXW RII YDOYH &RPSRXQGV XVHG RQ
WKUHDGHGMRLQWVRIJDVSLSLQJVKDOOEHUHVLVWDQWWRWKHDFWLRQRIOLTXH¿HGSHWUROHXPJDVHV
6FKHGXOH3LSH
,QVLGH'LDPHWHU
In Inches
7XELQJ7\SH/
2XWVLGH'LDPHWHU
In Inches
Nat.
L.P.
Nat.
L.P.
0-10 feet
10-40 feet
40-100 feet
100-150 feet
Leak Testing
WARNING - FIRE OR EXPLOSION HAZARD
1HYHU WHVW IRU OHDNV ZLWK DQ RSHQ ÀDPH &KHFN DOO
connections using a commercially available soap soOXWLRQ$ ¿UH RU H[SORVLRQ PD\ UHVXOW FDXVLQJ SURSerty damage, personal injury or loss of life. Failure
to follow the safety warnings exactly could result in
serious injury, death or property damage.
$IWHUJDVSLSLQJWRWKH¿UHSODFHLVFRPSOHWHDOOFRQQHFWLRQVPXVW
EHWHVWHGIRUJDVOHDNV7KLVLQFOXGHVSLSHFRQQHFWLRQVDWWKHPDLQ
JDVYDOYHHPHUJHQF\VKXWRIIYDOYHDQGÀH[LEOHJDVFRQQHFWRUVLI
DSSOLFDEOH7KHVRDSDQGZDWHUVROXWLRQFDQEHDSSOLHGRQHDFK
MRLQWRUXQLRQXVLQJDVPDOOSDLQWEUXVK,IDQ\EXEEOLQJLVREVHUYHG
WKHFRQQHFWLRQLVQRWVHDOHGDGHTXDWHO\DQGPXVWEHUHWLJKWHQHG
5HSHDWWKHWLJKWHQLQJDQGVRDSFKHFNSURFHVVXQWLOWKHEXEEOLQJ
ceases.
Important Note:
When pressure testing the gas supply lines at pressures
greater than ½ psig (14 in. w.c.), the gas supply piping system
PXVWEHGLVFRQQHFWHGIURPWKH¿UHSODFHWRSUHYHQWGDPDJH
to the gas control valve. If the test pressure is less than or
equal to ½ psig (14 in. w.c.), close the manual shut-off valve.
30259-9-1115
Page 9
VENT CLEARANCES
Figure 1
US Installation 1
A=
B=
&OHDUDQFHDERYHDQ\JUDGH
YHUDQGDSRUFKRUEDOFRQ\
LQFP
&OHDUDQFHWRZLQGRZRUGRRU
WKDWPD\EHRSHQHG
LQFPIRUDSSOLDQFHV
%WXKN:LQ
FPIRUDSSOLDQFHV!
%WXKN:DQG
%WXKN:LQFP
IRUDSSOLDQFHV!%WXK
N:
C=
&OHDUDQFHWRSHUPDQHQWO\
FORVHGZLQGRZV
D=
Vertical clearance to ventiODWHGVRI¿WORFDWHGDERYHWKH
terminal within a horizontal
GLVWDQFHRIIWPPIURP
the center line of the terminal
LQFP
&OHDUDQFHWRXQYHQWLODWHG
VRI¿W
LQFP
E=
0
F=
&OHDUDQFHRIRXWVLGHFRUQHU
LQFP
G=
&OHDUDQFHRILQVLGHFRUQHU
LQFP
H=
&OHDUDQFHWRHDFKVLGHRI
FHQWHUOLQHH[WHQGHGDERYH
PHWHUUHJXODWRUDVVHPEO\
IWFP
I=
Clearance to service regulator
vent outlet
IWFP
Page 10
J=
LQFPIRUDSSOLDQFHV
%WXKN:LQ
Clearance to non-mechanical
FPIRUDSSOLDQFHV!
DLUVXSSO\LQOHWWREXLOGLQJRU
%WXKN:DQG
WKHFRPEXVWLRQDLULQOHWWRDQ\
%WXKN:LQFP
RWKHUDSSOLDQFH
IRUDSSOLDQFHV!%WXK
N:
K=
Clearance to a mechanical air
VXSSO\LQOHW
L=
&OHDUDQFHDERYHSDYHG
VLGHZDONRUSDYHGGULYHZD\
ORFDWHGRQSXEOLFSURSHUW\
1RWDSSOLFDEOH
M=
&OHDUDQFHXQGHUYHUDQGD
SRUFKGHFNRUEDOFRQ\
LQFP
1
,QDFFRUGDQFHZLWKWKHFXUUHQW$16,=1)3$1DWLRQDO
)XHO*DV&RGH
$YHQWVKDOOQRWWHUPLQDWHGLUHFWO\DERYHDVLGHZDONRUSDYHG
GULYHZD\WKDWLVORFDWHGEHWZHHQWZRVLQJOHIDPLO\GZHOOLQJV
DQGVHUYHVERWKGZHOOLQJV
3HUPLWWHGRQO\LIYHUDQGDSRUFKGHFNRUEDOFRQ\LVIXOO\RSHQ
RQDPLQLPXPRIWZRVLGHVEHQHDWKWKHÀRRU
*
)RUFOHDUDQFHVQRWVSHFL¿HGLQ$16,=1)3$RU&6$
%UHIHUWRORFDOFRGHV
IWFPDERYHLIZLWKLQ
IWPKRUL]RQWDOO\
30259-9-1115
VENTING REQUIREMENTS
)RUYHQWFOHDUDQFHVVHH)LJXUHSJ
WARNING
7KLV¿UHSODFHPXVWQRWEHYHQWHGZLWKDQ\RWKHUDSSOLDQFHV
even if that appliance is of the condensing type. Common
venting can result in severe corrosion of other appliances
or their venting and can allow combustion gases to escape
WKURXJKVXFKDSSOLDQFHVRUYHQWV'RQRWYHQWWKH¿UHSODFH
LQWRD¿UHSODFHFKLPQH\RUEXLOGLQJFKDVH
WARNING
Upon completion of the installation, carefully inspect the enWLUHÀXHV\VWHPWRDVVXUHLWLVSURSHUO\VHDOHG'2127XVH
DQ\YHQWPDWHULDORWKHUWKDQZKDWLVVSHFL¿HGLQWKLVPDQXDO
/HDNVLQWKHÀXHV\VWHPFDQUHVXOWLQVHULRXVSHUVRQDOLQMXU\
RUGHDWKGXHWRH[SRVXUHRIÀXHSURGXFWVLQFOXGLQJFDUERQ
monoxide.
7KH 0DQWLV LV FODVVL¿HG DV D ³&DWHJRU\ ,9´ DSSOLDQFH ZKLFK UHTXLUHV VSHFLDO YHQWLQJ PDWHULDOV DQG LQVWDOODWLRQ SURFHGXUHV ,QVWDOODWLRQVFDQEH&RQYHQWLRQDOSLSHDQG'LUHFW9HQWSLSH
9HQWLQJPXVWEHFRPSOHWHGZLWKLQFKGLDPHWHUSLSH,QVHOHFWLQJ D ORFDWLRQ IRU LQVWDOODWLRQ LW LV QHFHVVDU\ WR SURYLGH DGHTXDWHFOHDUDQFHVIRUVHUYLFLQJDQGSURSHULQVWDOODWLRQ
$OOYHQWDQGFRPEXVWLRQDLUSLSHVDQG¿WWLQJVPXVWEH6FKHGXOH
39&DQGPHHWWKH$16,$6706WDQGDUG'&HPHQWPXVW
FRQIRUPWR$6706WDQGDUG'
7KHERWWRPRIWKHH[KDXVWYHQWWHUPLQDODQGWKHDLULQWDNHVKDOO
EH ORFDWHG DW OHDVW LQFKHV DERYH JUDGH DQG PXVW EH YHQWHG
RXWVLGH,WLVUHFRPPHQGHGWKHH[KDXVWDQGLQWDNHEHORFDWHG
inches from the maximum snow level.
7KHÀXHSLSHPXVWEHVXSSRUWHGRQKRUL]RQWDOYHQWUXQV7KHÀXH
SLSHQHHGVWREHVXSSRUWHGHYHU\IHHW$OOKRUL]RQWDOUXQVRIWKH
ÀXHPXVWEHSLWFKHGóLQFKSHUIRRWWRZDUGVWKH¿UHSODFH
Note: ,IWKHYHQWUXQGLSVRUVDJVFRQGHQVDWLRQPD\EHFRPH
WUDSSHGDQGFDXVHWKHXQLWWRQRWRSHUDWHSURSHUO\
7KH PLQLPXP YHQW OHQJWK SURWUXGLQJ IURP RXWVLGH WKH ZDOO LV LQFKHV)RUWZRSLSHLQVWDOODWLRQDPLQLPXPGLVWDQFHRILQFKHV
DQGPD[LPXPGLVWDQFHRILQFKHVPXVWEHPDLQWDLQHGEHWZHHQ
WKHSLSHV6HH)LJXUHVDQG
6LQJOH ÀXH RQHSLSH LQVWDOODWLRQV PXVW KDYH D PLQLPXP FOHDUDQFHRILQFKHVRQWKHEDFNRIWKH¿UHSODFHIRUFRPEXVWLRQDLU
Note: If vent length requirements are not followed, the unit
will not operate properly.
Maximum Vent Length is 40 feet with (3) 90° elbows. The
minimum vent length is 12 inches.(DFKHOERZXVHGLQ
WKHYHQWV\VWHPZLOOEHWKHHTXLYDOHQWWRIHHWDQGHDFK
HOERZ LVHTXLYDOHQWWRIHHWZKLFK VKRXOG EHDGGHGWRWKH
overall vent length. See Table 1.
,W LV UHFRPPHQGHG WKDW WKH 0DQWLV 3RZHU9HQW +LJK(I¿FLHQF\
)LUHSODFHEHORFDWHGRQDQH[WHULRUZDOOIRUHDVHRIYHQWLQJ7KH
ÀXHH[KDXVWSLSHDQGLQOHWDLUSLSHVKRXOGEHORFDWHGEHWZHHQZDOO
VWXGV7KHUHTXLUHGRSHQLQJIRUYHQWLQJLVLQFKLQGLDPHWHU
IRULQFK39&SLSH
Figure 2 - Single Flue
Figure 3 - Colinear Direct Vent
Table 1 - Equivalent Vent Length Example
(9/ (TXLYDOHQW9HQW/HQJWK
(9/PXVWEHJUHDWHUWKDQRUHTXDOWR¶andOHVVWKDQRUHTXDOWR¶
EVL = HOERZ
EVL =
+ ¶VWUDLJKWSLSH + HOERZ
¶
+
HOERZ
30259-9-1115
¶
VWUDLJKWSLSH
+
+ ¶VWUDLJKWSLSH
¶
+
HOERZ
¶
VWUDLJKWSLSH
+
HOERZ
+ ¶VWUDLJKWSLSH = ¶
+
¶
+
HOERZ
¶
VWUDLJKWSLSH
= ¶
Page 11
VENTING REQUIREMENTS
Vent Freezing Protection
:KHQ WKH YHQW SLSH LV H[SRVHG WR WHPSHUDWXUHV EHORZ IUHH]LQJ
LHZKHQLWSDVVHVWKURXJKXQKHDWHGVSDFHVFKLPQH\VHWF7KH
SLSHPXVWEHLQVXODWHGZLWKLQFKWKLFNVSRQJHUXEEHULQVXODWLRQ$UPDÀH[W\SHLQVXODWLRQRUHTXLYDOHQW,QVXODWLQJSLSHLVLPSRUWDQWWRDYRLGFRQGHQVDWHLFLQJ
)RUSURSHURSHUDWLRQWKHÀXHH[KDXVWPXVWH[WHQGLQFKHVIURP
WKHRXWVLGHZDOOEHIRUHDSSO\LQJDQHOERZ
Figure 4
VENT ADAPTOR KITS
7KH9HQW$GDSWRU.LWVSURYLGHDWUDQVLWLRQIURPWKH¿UHSODFHWRWKH
ÀXHDQG LQOHW SLSHV7KH 6LQJOH )OXH +RUL]RQWDO 9HQW .LW399.
)&SURYLGHVDWUDQVLWLRQIRUWKHÀXHSLSLQJ1RFHPHQWLVUHTXLUHG
WRDWWDFKWKHDGDSWRUWRWKH¿UHSODFH:KHQLQVWDOOLQJWKHÀXHSLS-
LQJXVHWKHDSSURSULDWHSULPHUDQGFHPHQWWRSHUPDQHQWO\ERQG
WKH MRLQWV DQG SLSHV &ROLQHDU$GDSWRU SDUW QXPEHU 39&$ SURYLGHVDWUDQVLWLRQIRUWKHLQOHWDLUSee Page 16.
Figure 5
Figure 6
PVVK-CFA FLEX VENT KIT
Available from Empire Comfort Systems, Inc.
7KH399.&)$)OH[9HQW.LWLVDÀH[LEOHYHQWKRVHWKDWLV´LQOHQJWK7KHÀH[YHQWNLWZLOOEHXVHGZKHQLQVWDOOLQJD
0DQWLVLQWRDQH[LVWLQJ¿UHSODFH7KHÀH[YHQWNLWFDQEHFXWGRZQEXWFDQRQO\EHFXWIURPRQHHQG
2QFHOHQJWKLVGHWHUPLQHGLQVWDOOWZR[´VFUHZVLQWRWKHDGDSWRUDVVHPEO\WRVHFXUHWKHDGDSWRUDVVHPEO\WR
WKHÀH[KRVH8VLQJ39&FHPHQWFHPHQWDOO39&MRLQWVRIWKHÀH[YHQWNLWWRWKHUHPDLQLQJ39&YHQWUXQ
Page 12
30259-9-1115
PVVTC TERMINATION CAP VENT KIT
Available from Empire Comfort Systems, Inc.
7HUPLQDWLRQ&DS
3997&9HUWLFDOH[KDXVWFDSXVHGZLWK´39&SLSHLQVWDOODWLRQ
7HUPLQDWLRQFDSFDQDOVREHXVHGZLWKFROLQHDUWUDQVLWLRQSODWHPRGHO39&7
5HIHUWR)LJXUHVDQGIRUYHQWLQJH[DPSOHV
30259-9-1115
Page 13
VENT EXAMPLES FOR SINGLE FLUE
+ ¶
9 ¶
¶
7RWDO ¶
Figure 7
Single Flue - Straight Out Back
Min 6” Outside Wall
Min 2” From Fireplace to Wall for Intake Air
Min vent length 12”
)LJXUHGLVSOD\VDVLQJOHÀXHRQHSLSHLQVWDOODWLRQ%HFDXVHWKH
GLVWDQFHIURPWKH¿UHSODFHWRWKH¿UVWHOERZLVPRUHWKDQLQFKHV
WKH¿UVWHOERZPXVWEHFRQVLGHUHGLQWRWKHWRWDOYHQWOHQJWK
7KHHTXLYDOHQWOHQJWKRIWKHVHFRQGHOERZDOVRQHHGVWREH
DGGHGWRWKHWRWDOOHQJWKEXWWKHWKLUGHOERZGRHVQRWVLQFHLWLVWKH
ÀXHWHUPLQDO7KHWRWDOKRUL]RQWDOYHQWOHQJWKRIWKHÀXHV\VWHPLV
IHHWDQGWKHWRWDOYHUWLFDOOHQJWKLVIHHW7KHWZRHOERZV
DUHHTXLYDOHQWWRIHHWEULQJLQJWKHWRWDOWRIHHW
Figure 9
Single Flue - Vertical Vent Run
+ ¶¶ ¶
9 ¶
¶
7RWDO ¶
Figure 8
Single Flue - Horizontal Tall Vent Run
Example Calculation Max Vent Run 40 feet
Page 14
30259-9-1115
VENT EXAMPLES FOR SINGLE FLUE
Determining Minimum Vent Height Above the Roof
WARNING
0DMRU86EXLOGLQJFRGHVVSHFLI\PLQLPXPFKLPQH\DQGRUYHQW
KHLJKW DERYH WKH URRIWRS 7KHVH PLQLPXP KHLJKWV DUH QHFHVVDU\LQWKHLQWHUHVWRIVDIHW\7KHVHVSHFL¿FDWLRQVDUHVXPPDUL]HGLQ)LJXUHVDQG
Determining Minimum Vent Height Above the Roof
Figure 10 - Venting for Existing Fireplace Installation
ROOF PITCH
+0LQ
)ODWWR
´PP
WR
´PP
2YHUWR
´PP
2YHUWR
´PP
2YHUWR
´PP
Figure 11
Single Flue - Vertical Vent Run
with 45 degree elbows
30259-9-1115
Page 15
PVCA HORIZONTAL COLINEAR DIRECT VENT ADAPTOR
&ROLQHDUDGDSWRUWREHXVHGLQFRQMXQFWLRQZLWKVLQJOHÀXHKRUL]RQWDOYHQWNLW399.)&7KHWZRDWWDFKPHQWVDUHXVHGIRUFROLQHDU
GLUHFWYHQWLQVWDOODWLRQ
&ROLQHDUDGDSWRU
$WWDFK FROLQHDU DGDSWRU WR EDFN RI ¿UHSODFH ZLWK WZR screws.
Page 16
:KHQDGDSWHULVFRQQHFWHGFRQWLQXHZLWK\RXUYHQWUXQ
&HPHQWLQJ39&MRLQWLVUHFRPPHQGHGEXWQRWUHTXLUHGRQ
FROLQHDUIUHVKDLULQWDNHDGDSWRU
30259-9-1115
COLINEAR TRANSITION VENT KIT
Available from Empire Comfort Systems, Inc.
Colinear Transition Plate
7KH&ROLQHDU7UDQVLWLRQ.LW3DUWQXPEHU39&7LVDYDLODEOHDQG
FDQ EH XVHG WR VHFXUH WKH ÀXH DQG LQOHW SLSHV IURP WKH 0DQWLV
:KHQ YHQWLQJ YHUWLFDOO\ WKH H[KDXVW SLSH WHUPLQDWLRQ PXVW EH D
PLQLPXPRILQFKHVDERYHWKHDLULQOHW
7KHÀXHFDQEHWHUPLQDWHGZLWKD37UDSRUWZRHOERZV7KH
9HUWLFDO7HUPLQDWLRQ&DS3DUWQXPEHU3997&FDQDOVREHXVHG
WRWHUPLQDWHWKHÀXHSLSHZKHQXVLQJWKH&ROLQHDU7UDQVLWLRQ.LW
Figure 12
Figure 13
Installation of the Colinear Transition Plate
$WWDFK WKH SODWH WR FKLPQH\ FKDVH ÀDW URRI RU RXWVLGH ZDOO
ZLWKIRXUVFUHZV8VHRXWGRRUVHDODQWWRVHDOWKHWUDQVLWLRQ
SODWHWRWKHVXUIDFH
&XW LQOHW DLU SLSH DQG ÀXH H[KDXVW SLSH WR FRUUHFW OHQJWKV
)RUYHUWLFDOWHUPLQDWLRQVWKURXJKWKHURRIRUFKLPQH\WKHDLU
LQWDNH DQG H[KDXVW SLSH WHUPLQDWLRQ PXVW EH D PLQLPXP RI
LQFKHV DERYH WKH URRI OLQH ,W LV UHFRPPHQGHG WKDW WKH
DLULQWDNHDQGH[KDXVWSLSHWHUPLQDWLRQEHLQFKHVDERYH
WKHPD[LPXPH[SHFWHGVQRZOHYHO6HH)LJXUHVDQG
:KHQYHQWLQJYHUWLFDOO\WKHH[KDXVWSLSHWHUPLQDWLRQPXVWEH
DPLQLPXPRILQFKHVDERYHWKHDLULQWDNH$OVRUHIHUWRORFDO
FRGHV )RU KRUL]RQWDO WHUPLQDWLRQ WKURXJK RXWVLGH ZDOOV WKH
PLQLPXPSLSHOHQJWKLVLQFKHVIRUH[KDXVWSLSHWHUPLQDWLRQ
DQGLQFKHVIRUWKHDLULQWDNH
$WWDFKWKHÀXHDQGLQOHWDLUSLSHVWRWKHWUDQVLWLRQSODWH8VH
WKHDSSURSULDWHSULPHUDQGFHPHQWWRSHUPDQHQWO\ERQGWKH
MRLQWVDQGWKHSLSHVWRWKHWUDQVLWLRQSODWH
Note:0XVWPDLQWDLQDPLQLPXP´EHWZHHQH[KDXVWRXWOHWDQGDLULQWDNH
30259-9-1115
Page 17
DIRECT VENT COLINEAR VENT EXAMPLES
Max Vent Run - 40 ft. Equivalent With Three three 90° Elbows
6SHFLDO1RWH7KHYHQWWHUPLQDOHOERZDQG¿UVWHOERZ
off back of the fireplace, when within 6” (15.2 cm), do not contribute to the overall vent length measurement. For each 45°
elbow installed in the run, the length of the run MUST be reduced by 1.5 feet (45 cm). Reduce the length of the run 3 feet
(91.4 cm) for every 90° elbow.
Note:([KDXVWPXVWEHD
PLQLPXPRILQFKHVDERYH
DLULQWDNHLQOHW
:KHQ LQVWDOOLQJ D FROLQHDU KRUL]RQWDO WKH PLQLPXP YHQW OHQJWK
SURWUXGLQJIURPWKHRXWVLGHZDOOLV´FPIRUDLULQWDNHDQG´
for exhaust. See Figure 15.
Note:+RUL]RQWDOGLVFKDUJHHOERZPXVWEHSRLQWHGGRZQZDUG
6HH)LJXUH$OOKRUL]RQWDOUXQVUHTXLUHD´SHUIRRWULVHWRUXQ
FRQGHQVDWLRQEDFNWRWKHILUHSODFH
Note:$OO39&YHQWUXQSLSLQJFDQEHSXUFKDVHGDWDORFDOKDUGZDUHVWRUH6FKHGXOH39&SLSHVKRXOGEHXVHGDQGFHPHQWHG
39&$+RUL]RQWDO&ROLQHDU'LUHFW9HQW$GDSWRU3997&&DS399.&)$ )OH[ .LW DQG 399.6+ +RUL]RQWDO 9HQW$GDSWRU .LW DUH
DYDLODEOHIURP(PSLUH&RPIRUW6\VWHPV,QF
,Q ERWK YHUWLFDO DQG KRUL]RQWDO FROLQHDU GLUHFW YHQW DSSOLFDWLRQV
DFROLQHDUWUDQVLWLRQSODWHPRGHO39&7FDQEHXVHGWRPLQLPL]H
FOHDUDQFHVEHWZHHQLQWDNHDQGH[KDXVWSLSHV
)RUKRUL]RQWDOFROLQHDUGLUHFWYHQWLQJH[KDXVWDQGLQWDNHDLUFDS
SLSHVZLWKHOERZVSRLQWHGGRZQZDUG
Note,IWUDQVLWLRQSODWHPRGHO39&7LVXVHGWKHPHDVXUHPHQW
IRUFHQWHUWRFHQWHURIWKHSLSHVZLOOEH´,IWKHWUDQVLWLRQSODWH
PRGHO39&7LVQRWXVHGWKHPHDVXUHPHQWIRUFHQWHUWRFHQWHU
RIWKHSLSHVFDQEH´WR´PD[LPXP
Figure 15
Figure 14
Calculation example of vent run maximum 40 feet
)LJXUH GLVSOD\V D WZRSLSH LQVWDOODWLRQ %HFDXVH WKH GLVWDQFH
IURP WKH ¿UHSODFH WR WKH ¿UVW HOERZ LV PRUH WKDQ LQFKHV WKH
HTXLYDOHQWOHQJWKDOORZDQFHIRUWKH¿UVWHOERZPXVWEHDGGHG
WRWKHWRWDOYHQWOHQJWK7KHHTXLYDOHQWOHQJWKRIWKHVHFRQG
HOERZ DOVR QHHGV WR EH DGGHG WR WKH WRWDO OHQJWK 7KH WKLUG HOERZDOVRQHHGVWREHLQFOXGHG7KHHTXLYDOHQWOHQJWKRIWKH37UDS
GRHV QRW QHHG WR EH DGGHG VLQFH LW LV WKH WHUPLQDWLRQ7KH WRWDO
KRUL]RQWDOYHQWOHQJWKRIWKHÀXHV\VWHPLVIHHWDQGWKHWRWDO
YHUWLFDOOHQJWKLVIHHW7KHWKUHHHOERZVDUHHTXLYDOHQWWR
IHHWEULQJLQJWKHWRWDOWRIHHW
Note:7KHH[KDXVWPXVWEHDPLQLPXPRILQFKHVDERYHWKHLQOHW
DLUSLSH7KHÀXHPXVWEHDWOHDVWLQFKHVIURPWKHURRIOLQHDQG
LWLVUHFRPPHQGHGWREHDWOHDVWLQFKHVDERYHWKHPD[LPXP
H[SHFWHGVQRZOHYHODVLQGLFDWHGLQ)LJXUHVDQG
Note: 2QKRUL]RQWDOUXQVD39&VXSSRUWFODPSQHHGVWREHLQVWDOOHG HYHU\ IHHW 'R QRW DOORZ ³VDJV´ LQ KRUL]RQWDO YHQW UXQV
ZDWHUZLOOVHWWOHLQWKHSLSH
Page 18
30259-9-1115
DIRECT VENT COLINEAR VENT EXAMPLES
Figure 16
Figure 17
,QGLUHFWYHQWDSSOLFDWLRQVWKHPLQLPXPGLVWDQFHEHWZHHQWKHWZR
SLSHVLVLQFKHVDQGWKHPD[LPXPGLVWDQFHLVLQFKHV7KHÀXH
H[KDXVWDQGDLULQOHWFDQEHWHUPLQDWHGZLWKHLWKHUD37UDSRUWZR
HOERZVDVVKRZQLQ)LJXUHVDQG7KH9HUWLFDO7HUPLQDWLRQ&DSVKRZQRQSDJH3DUWQXPEHU3997&FDQ
DOVREHXVHG
,Q ERWK YHUWLFDO DQG KRUL]RQWDO FROLQHDU GLUHFW YHQW DSSOLFDWLRQV
DFROLQHDUWUDQVLWLRQSODWHPRGHO39&7FDQEHXVHGWRPLQLPL]H
FOHDUDQFHVEHWZHHQLQWDNHDQGH[KDXVWSLSHV
)RU H[KDXVW DQG LQWDNH DLU FDS SLSHV ZLWK DQ\ RI WKH IROORZLQJ
9HUWLFDO WHUPLQDWLRQ FDS PRGHO 3997& 37UDS RU WZR HOERZV:KHQWUDQVLWLRQSODWHPRGHO39&7LVXVHGWZRWHUPLQDWLRQFDSVPRGHO3997&PD\127EHXVHG
Note,IWUDQVLWLRQSODWHPRGHO39&7LVXVHGWKHPHDVXUHPHQW
IRUFHQWHUWRFHQWHURIWKHSLSHVZLOOEH´,IWKHWUDQVLWLRQSODWH
PRGHO39&7LVQRWXVHGWKHPHDVXUHPHQWIRUFHQWHUWRFHQWHU
RIWKHSLSHVFDQEH´WR´PD[LPXP
30259-9-1115
Page 19
DIRECT VENT COLINEAR VENT EXAMPLES
Note:([KDXVWPXVWEHDPLQLPXPRI´DERYHDLULQWDNHLQOHW
Determining Minimum Vent Height Above the Roof
Colinear Direct Vent - Insert Installation
Figure 18
ROOF PITCH
+0LQ
)ODWWR
´PP
WR
´PP
2YHUWR
´PP
2YHUWR
´PP
2YHUWR
´PP
Colinear Direct Vent - Pitched Roof Installation
Figure 19
WARNING
Major U.S. building codes specify minimum chimney and/or
vent height above the rooftop. These minimum heights are
QHFHVVDU\LQWKHLQWHUHVWRIVDIHW\7KHVHVSHFL¿FDWLRQVDUH
summarized in Figures 18 and 19.
Page 20
30259-9-1115
PVVK-24H AND PVVK-48H CO-AXIAL VENT KIT
Available from Empire Comfort Systems, Inc.
Step 1.
Step 2.
Step 3.
,QVWDOOIRDPJDVNHWRQEDFNVLGHRIFRD[LDOGLUHFWYHQW
DGDSWRU
Step 4.
,QVWDOO VLOLFRQH DURXQG FRQQHFWLRQ EHWZHHQ FRD[LDO
DGDSWRUDQGFRD[LDODLULQOHWGXFW
Step 5.
6OLGHFRD[LDOYHQWSLSHVLQWRFRD[LDODGDSWRU
&XWWKH39&FRD[LDOSLSHVDWWKLVWLPH
0LQLPXPKRUL]RQWDOYHQWOHQJWK´FP
0LQLPXPWXEHOHQJWK´FP
Step 6.
'LUHFWYHQWFRD[LDOYHQWLQJLVFRPSOHWHG
$WWDFKFRD[LDOGLUHFWYHQWDGDSWRUDQGJDVNHWVFUHZV
WRWKHUHDURI¿UHSODFH
$WWDFK FRD[LDO DLULQOHW GXFW WR UHDU RI ¿UHSODFH VFUHZV
30259-9-1115
Page 21
PVVK-24H AND PVVK-48H CO-AXIAL VENT KIT (cont.)
Horizontal Venting Maximum 47.5” (1.2 m) with 45° elbows.
Inner 1-1/2 inch pipe and outer 3 inch pipe 45° elbows can be
purchased from a local hardware store.
Figure 23
Figure 20
Direct Vent System Building Exterior View
Figure 21
Maximum Horizontal Venting - 47 1/2” (1.2 m)
Minimum Horizontal Venting - 4” (10.2 cm)
Figure 22
Page 22
30259-9-1115
PVVK-24H AND PVVK-48H CO-AXIAL VENT KIT (cont.)
Figure 24
Minimum Exterior Grade Dimension
Figure 26
Horizontal Venting
Figure 25
Minimum Exterior Grade Dimension - Existing Fireplace
Installation
30259-9-1115
Page 23
ROUGH FRAMING DIMENSIONS
Figure 28
Figure 27
A
Bay Window Mantis with
PV-4H
Short Top Cover Kit
Single Vent
Direct Vent and
Colinear Vent
Co-axial Vent
Flex Vent
´PLQLPXP
´PLQLPXP
´PLQLPXP
´PLQLPXP
B
´PLQLPXP
´PD[LPXPZKHQXVLQJ39(RU39(6XUURXQG.LWV
C
´PLQLPXP´PLQLPXPUHFRPPHQGHGIRUVHUYLFH
´PD[LPXPZKHQXVLQJ39(6XUURXQG.LW
´PD[LPXPZKHQXVLQJ39(6XUURXQG.LW
:KHQXVLQJD´UDGLXVVWUHHWHOORQWKHÀXHH[KDXVWDGG´
A
Bay Window Mantis with
PV-2H
Slim Top Cover Kit
Single Vent
Direct Vent and
Colinear Vent
Co-axial Vent
Flex Vent
´PLQLPXP
´PLQLPXP
´PLQLPXP
´PLQLPXP
B
´PLQLPXP
´PD[LPXPZKHQXVLQJ39(RU39(6XUURXQG.LWV
C
´PLQLPXP´PLQLPXPUHFRPPHQGHGIRUVHUYLFH
´PD[LPXPZKHQXVLQJ39(6XUURXQG.LW
´PD[LPXPZKHQXVLQJ39(6XUURXQG.LW
:KHQXVLQJD´UDGLXVVWUHHWHOORQWKHÀXHH[KDXVWDGG´
A
Single Vent
Direct Vent and
Colinear Vent
Co-axial Vent
Flex Vent
´PLQLPXP
´PLQLPXP
´PLQLPXP
´PLQLPXP
B
´PLQLPXP
´PD[LPXPZKHQXVLQJ)*.46XUURXQG.LW
´PD[LPXPZKHQXVLQJ)).46XUURXQG.LW
´PD[LPXPZKHQXVLQJ),.46XUURXQG.LW
´PD[LPXPZKHQXVLQJ):.46XUURXQG.LW
C
´PLQLPXP´UHFRPPHQGHGIRUVHUYLFH
´PD[LPXPZKHQXVLQJ)*.46XUURXQG.LW
´PD[LPXPZKHQXVLQJ)).46XUURXQG.LW
´PD[LPXPZKHQXVLQJ),.46XUURXQG.LW
´PD[LPXPZKHQXVLQJ):.46XUURXQG.LW
Fireplace Mantis
:KHQXVLQJD´UDGLXVVWUHHWHOORQWKHÀXHH[KDXVWDGG´
Page 24
30259-9-1115
INSERT INTO MASONRY FIREPLACE
Figure 29
A
Bay Window Mantis with PV-4H
Short Top Cover Kit
Single Vent
Direct Vent and
Colinear Vent
Flex Vent
´PLQLPXP
´PLQLPXP
´PLQLPXP
B
´PLQLPXP
´PD[LPXPZKHQXVLQJ39(RU39(6XUURXQG.LWV
C
´PLQLPXP´PLQLPXPUHFRPPHQGHGIRUVHUYLFH
´PD[LPXPZKHQXVLQJ39(6XUURXQG.LW
´PD[LPXPZKHQXVLQJ39(6XUURXQG.LW
:KHQXVLQJD´UDGLXVVWUHHWHOORQWKHÀXHH[KDXVWDGG´
A
Single Vent
Direct Vent and
Colinear Vent
Flex Vent
´PLQLPXP
´PLQLPXP
´PLQLPXP
B
´PLQLPXP
´PD[LPXPZKHQXVLQJ39(RU39(6XUURXQG.LWV
C
´PLQLPXP´PLQLPXPUHFRPPHQGHGIRUVHUYLFH
´PD[LPXPZKHQXVLQJ39(6XUURXQG.LW
´PD[LPXPZKHQXVLQJ39(6XUURXQG.LW
Bay Window Mantis with PV-4H
Slim Top Cover Kit
:KHQXVLQJD´UDGLXVVWUHHWHOORQWKHÀXHH[KDXVWDGG´
A
Single Vent
Direct Vent and
Colinear Vent
Flex Vent
´PLQLPXP
´PLQLPXP
´PLQLPXP
B
´PLQLPXP
´PD[LPXPZKHQXVLQJ)*.46XUURXQG.LW
´PD[LPXPZKHQXVLQJ)).46XUURXQG.LW
´PD[LPXPZKHQXVLQJ),.46XUURXQG.LW
´PD[LPXPZKHQXVLQJ):.46XUURXQG.LW
C
´PLQLPXP´UHFRPPHQGHGIRUVHUYLFH
´PD[LPXPZKHQXVLQJ)*.46XUURXQG.LW
´PD[LPXPZKHQXVLQJ)).46XUURXQG.LW
´PD[LPXPZKHQXVLQJ),.46XUURXQG.LW
´PD[LPXPZKHQXVLQJ):.46XUURXQG.LW
Fireplace Mantis
:KHQXVLQJD´UDGLXVVWUHHWHOORQWKHÀXHH[KDXVWDGG´
30259-9-1115
Page 25
BAY WINDOW MANTIS CLEARANCE TO COMBUSTIBLES
C
C
Figure 31
Figure 30
Freestanding Clearances
A
5HDU:DOOWR)LUHSODFH
´´IRUFRD[LDOYHQWLQJ
B
6LGH:DOOWR)LUHSODFH
´´UHFRPPHQGHGIRUGRRUFOHDUDQFH
C
Corner Installation
´
Co-axial Venting Installation Shown
Single Flue requires surround for combustion air.
Figure 32
Mantel and Ceiling Clearances
Figure 33
Note:
Page 26
7KH0DQWLV3RZHU9HQW+LJK(I¿FLHQF\)LUHSODFHKDVEHHQWHVWHGDQGDSSURYHGIRU]HURFOHDUDQFHWRFRPEXVWLEOHPDWHULDOV,W
LVUHFRPPHQGHGWKDWFOHDUDQFHVDVOLVWHGDERYHVKRXOGEHPDLQWDLQHGWRDOORZIRUUHPRYDORIWKHSURGXFWIRUVHUYLFLQJ
30259-9-1115
FIREPLACE MANTIS CLEARANCE TO COMBUSTIBLES
Figure 34
Figure 36
Figure 35
Insert Clearances
A
5HDU:DOOWR)LUHSODFH
´´IRUFRD[LDOYHQWLQJ
B
6LGH:DOOWR)LUHSODFH
´
C
Corner Installation
´
Mantel and Ceiling Clearances
Figure 37
Note:
7KH0DQWLV3RZHU9HQW+LJK(I¿FLHQF\)LUHSODFHKDVEHHQWHVWHGDQGDSSURYHGIRU]HURFOHDUDQFHWRFRPEXVWLEOHPDWHULDOV,W
LVUHFRPPHQGHGWKDWFOHDUDQFHVDVOLVWHGDERYHVKRXOGEHPDLQWDLQHGWRDOORZIRUUHPRYDORIWKHSURGXFWIRUVHUYLFLQJ
30259-9-1115
Page 27
BAY WINDOW MANTIS SPECIFICATIONS
Bay Window Mantis with Pedestal and Single Flue Adaptor
Figure 38
Bay Window Mantis without pedestal
Figure 39
Bay Window Mantis Insert with Slim and Short Top Cover Kits and Flex Kits.
Figure 40
Page 28
30259-9-1115
BAY WINDOW MANTIS SPECIFICATIONS - (continued)
Bay Window Mantis Fireplace with PVE-1 Mantel Surround with PV-2H Slim Top Cover Kit
Figure 41
Bay Window Mantis Fireplace with PVE-1 Mantel Surround with PV-4H Short Top Cover Kit
Figure 42
Rear View
Figure 43
30259-9-1115
Page 29
FIREPLACE MANTIS SPECIFICATIONS
Figure 44
Figure 45
Figure 46
Fireplace with Flex Vent
Page 30
Figure 47
Fireplace - 42-7/8 inch Louverless Surround Kit
)+.4%/66&RQWDLQVVXUURXQGEUDFNHWVDQGDLUGHÀHFWRU
Figure 48
Fireplace In Wall - 35 Inch Picture Frame Surround
):.4%/&0+366&RQWDLQVVXUURXQGKRRGDQGORZHU
front
Figure 49
Fireplace - 35 Inch Surround Kit
)).4%/&0+366&RQWDLQVVXUURXQGKRRGORZHUIURQW
30259-9-1115
FIREPLACE MANTIS SPECIFICATIONS
Figure 50
Fireplace Mantis with 38 Inch Surround
),.4%/&0+366&RQWDLQVVXUURXQGKRRGORZHUIURQW
Figure 51
Clearance for Access Panel In-Wall Units
See Gas Connection Instructions.
Figure 52
30259-9-1115
Page 31
GAS CONNECTION INSTALLATION
CAUTION
7KHJDVVXSSO\OLQHWRWKH¿UHSODFHPXVWEHLQVWDOOHG
under conditions which will allow for easy removal
RIWKH¿UHSODFHIURPLWVORFDWLRQIRUVHUYLFLQJRIWKH
¿UHSODFH)RU¿UHSODFHLQVHUWLQVWDOODWLRQLQFRUSRUDWH
DORRSLQWRWKHÀH[LEOHJDVOLQH
Under no circumstances should the gas supply line
WRWKH¿UHSODFHEHLQVWDOOHGLQDZD\WKDWZRXOGSUHYHQWWKH¿UHSODFHIURPEHLQJVHUYLFHGRULQVSHFWHG
Figure 53 - Fireplace Mantis
GAS SUPPLY LINE TO FIREPLACE
3XOOWKHIDFWRU\LQVWDOOHGÀH[LEOHJDVOLQHWKURXJKWKHKROHLQ
WKHEDFNSDQHO6HH)LJXUHVDQG
&RQQHFWWKHJDVVXSSO\OLQHWRÀH[LEOHJDVKRVH(QVXUHWKDW
ÀH[LEOHJDVKRVHLVQRWNLQNHGDIWHU¿WWLQJJDVVXSSO\OLQH$Q\
H[FHVVÀH[LEOHOLQHFDQEHSXVKHGEDFNLQWRWKH¿UHSODFH
3ODFH UXEEHU JURPPHW WKDW LV VXSSOLHG LQ KDUGZDUH SDFNHW
RYHUWKHÀH[LEOHJDVOLQHDQGVHFXUHLQWKHKROHLQWKHEDFNRI
WKH¿UHSODFH
Figure 54 - Bay Window Mantis
Gas Connection - In-Wall Units - Fireplace Mantis ONLY
5HPRYH WKH DFFHVV SODWH RQ WKH OHIW VLGH RI WKH FDELQHW E\
removing three screws as shown in Figure 54. Put the screws
DVLGH
3XVKWKHIDFWRU\VXSSOLHGÀH[LEOHJDVOLQHWKURXJKWKHDFFHVV
KROHRQWKHVLGH
5HPRYH WKH NQRFNRXW IURP WKH DFFHVV SODWH DQG LQVHUW WKH
ÀH[LEOHJDVOLQHWKURXJKWKHKROH
6HFXUHWKHDFFHVVSODWHWRWKHFDELQHWZLWKWKUHHVFUHZVUHPRYHGLQ6WHS
$ SODVWLF SXVK LQ SOXJ LV VXSSOLHG LQ WKH KDUGZDUH SDFNDJH
LQVHUWWKHSOXJLQWRWKHLQFKKROHLQWKHEDFNRIWKHXQLW
,QVHUWWKHUXEEHUJURPPHWLQWRWKHKROHLQWKHDFFHVVSODWHWR
SURWHFWWKHÀH[LEOHJDVOLQH
Figure 55
Gas Connection, Fireplace Mantis In-Wall Units
Page 32
30259-9-1115
BAY WINDOW MANTIS LOG SET INSTALLATION INSTRUCTIONS
Log Installation
3URSHUSRVLWLRQLQJRIWKHORJVLVFULWLFDOWRWKHVDIHDQGFOHDQRSHUDWLRQ RI WKH ¿UHSODFH ,I WKH ORJV DUH QRW SODFHG LQ WKH SURSHU
SRVLWLRQWKH¿UHSODFHFDQVRRWRUFUHDWHDQXQVDIHRSHUDWLQJFRQGLWLRQ
3ODFH WKH )URQW /HIW /RJ & LQWR WKH IURQW OHIW FRUQHU RI WKH
¿UHER[DQGSRVLWLRQLQWRWKHQRWFKRQWKHERWWRPOHIWRI/RJ
$6HH)LJXUH
C
CAUTION
Do not handle these logs with your bare hands! Always
wear gloves to prevent skin irritation. After handling the
logs, wash your hands gently with soap and water.
A
Figure 58
Firebox Layout
Figure 56
Installation Sequence
7RDFFHVVWKHORJVHWSDUFHOOLIWRIIWKHWRSSDQHO
3LYRWWKHOHIWDQGULJKWSDQHOVRSHQ
8QKRRN WKH PDLQ GRRU ODWFKHV ORFDWHG RQ WKH ULJKW DQG OHIW
VLGHRIWKH¿UHSODFHWKHQUHPRYHWKHGRRU
3ODFHWKH5HDU5LJKW/RJ%DQGWKH5HDU/HIW/RJ$EHKLQG
WKHUHDUEXUQHUDOOWKHZD\DJDLQVWWKHEDFNRIWKH¿UHER[6HH
Figure 57.
A
B
3ODFHWKH&HQWHU/RJ'RYHUWKHÀDPHVHQVRUVLQWKHPLGGOH
RIWKH¿UHER[/RJ'VKRXOGEHSRVLWLRQHGWRWKHOHIWVLGHRI
WKH¿UHER[6HH)LJXUH
D
B
A
B
C
Figure 59
Figure 57
30259-9-1115
Page 33
BAY WINDOW MANTIS LOG SET INSTALLATION INSTRUCTIONS
3ODFHWKH)URQW5LJKW/RJ(LQWKHULJKWIURQWFRUQHURI¿UHER[,WVKRXOG¿WVQXJLQWRWKHFRUQHU6HH)LJXUH
TOP LEFT LOG (F)
REAR LEFT LOG (A)
TOP RIGHT LOG (G)
REAR RIGHT LOG (B)
E
FRONT LEFT LOG (C)
FRONT RIGHT LOG (E)
CENTER LOG (D)
A
Log Assembly
Figure 62
B
D
C
Figure 60
3ODFHWKH7RS5LJKW/RJ*RQWRWKHSLQVRQ%'DQG(
/RJV7KH³OHJV´RI*/RJZLOOUHVWRQ'DQG(/RJV7KH
SLQVPXVW¿WLQWRWKHKROHVLQWKHERWWRPRI*/RJWRHQVXUH
SURSHUDOLJQPHQWRI%'DQG(/RJV6HH)LJXUH
3ODFHWKH7RS/HIW/RJ)RQWRWKHSLQVRQ$DQG'/RJV
7KH³OHJV´RI)/RJZLOOUHVWRQ'/RJ7KHSLQVPXVW¿WLQWR
WKHKROHVLQWKHERWWRPRI)/RJWRHQVXUHSURSHUDOLJQPHQW
RI$DQG'/RJV6HH)LJXUH
F
G
B
A
D
C
E
Figure 61
9HULI\WKDWWKH5HDU/RJV$DQG%DUHVWLOODJDLQVWWKHEDFN
RIWKH¿UHER[
9HULI\WKDWWKHORJVDUHQRWLQFRQWDFWZLWKWKHÀDPHVHQVRU
,QWHUIHUHQFHZLWKWKHÀDPHVHQVRUZLOOHIIHFWWKHRSHUDWLRQ
3ODFHWKHGRRUDVVHPEO\RQWKH¿UHSODFHDQGVHFXUHZLWKWKH
PDLQ GRRU ODWFKHV ORFDWHG RQ WKH ULJKW DQG OHIW VLGHV RI WKH
¿UHSODFH
&ORVHWKHOHIWDQGULJKWSDQHOV
5HDWWDFKWKHWRSSDQHO
7KHLQVWDOODWLRQRIWKHORJVHWLVFRPSOHWH
Page 34
30259-9-1115
FIREPLACE MANTIS LOG SET INSTALLATION INSTRUCTIONS
Log Installation
3URSHU3RVLWLRQLQJRIWKHORJVLVFULWLFDOWRWKHVDIHDQGFOHDQRSHUDWLRQ RI WKLV ¿UHSODFH ,I WKH ORJV DUH QRW SODFHG LQ WKH SURSHU
SRVLWLRQWKH¿UHSODFHFDQVRRWRUFUHDWHDQXQVDIHRSHUDWLQJFRQGLWLRQ
CAUTION
Do not handle these logs with your bare hands! Always
wear gloves to prevent skin irritation. After handling the
logs, wash your hands gently with soap and water.
Log Placement
3ODFHWKH5HDU/RJ$RQWRWKHSLQVRQWKHUHDUORJVXSSRUW
7KHQRWFKLQWKH5HDU/RJ¿WVRYHUWKHUHDULJQLWHU6HH)LJXUH
63.
3ODFH /HIW /RJ % RQWR WKH SLQ RQ WKH OHIW UHDU ORJ VXSSRUW
VKHOI7KH FKDUUHG SRUWLRQ RI WKH ORJ PXVW IDFH LQZDUG 6HH
Figure 63.
3ODFHWKH0LGGOH/RJ'RQWRWKHSLQVRQWKHIURQWORJVXSSRUW
EHWZHHQWKHIURQWDQGEDFNEXUQHUV6HH)LJXUH
3ODFHWKH5LJKW/RJ&RQWKHULJKWUHDUORJVXSSRUWVKHOI7KH
WRSRIORJUHVWVRQ5HDU/RJ$DQGERWWRPRIORJUHVWVWKH
IURQWORJVXSSRUWVKHOI7KHFKDUUHGSRUWLRQRIORJPXVWIDFH
LQZDUG6HH)LJXUH
3ODFHWKH)URQW5LJKW/RJ)RQWKHULJKWVLGHRI¿UHER[ERWWRP7KHQRWFKLQWKHERWWRPRI)URQW5LJKW/RJ¿WVRYHUWKH
IURQWÀDPHVHQVRU7KHORJVKRXOGEHSRVLWLRQHGIXOO\IRUZDUG
DQGWRWKHULJKWDJDLQVWWKH5LJKW/RJ&6HH)LJXUH
3ODFHWKH)URQW/HIW/RJ(RQOHIWVLGHRIWKH¿UHER[ERWWRP
7KHQRWFKLQERWWRPRI)URQW/HIW/RJ¿WVRYHUWKHIURQW,JQLWHU
7KHORJVKRXOGEHSRVLWLRQHGIXOOIRUZDUGDQGWRWKHOHIW6HH
Figure 64.
3ODFHWKH/HIW7RS/RQJ/RJ*RQWKHSLQVRQ/HIW/RJ%
DQG)URQW/HIW/RJ(7KHXSSHUOHIWOHJRI/HIW7RS/RJZLOO
UHVWRQ5HDU/RJ$7KHXSSHUULJKWOHJRI/HIW7RS/RJZLOO
UHVWRQ0LGGOH/RJ'
3ODFHWKH5LJKW7RS/RJ+RQWKHSLQRQWKH5LJKW/RJ&
7KHERWWRPULJKWOHJRIWKH5LJKW7RS/RJ+ZLOOUHVWRQWKH
)URQW5LJKW/RJ)
9HULI\WKDWWKHORJVDUHQRWLQFRQWDFWZLWKWKHÀDPHVHQVRU
,QWHUIHUHQFH ZLWK WKH ÀDPH VHQVRU ZLOO HIIHFW WKH ¿UHSODFH¶V
RSHUDWLRQ
A
D
F
B
Log Placement
Figure 63
Log Assembly
Figure 65
H
C
E
G
Log Placement
Figure 64
30259-9-1115
Firebox Layout
Figure 66
Page 35
WIRING
WARNING
3RWHQWLDO ULVN RI ¿UH HOHFWULF VKRFN DQG SHUVRQDO
injury. Take precautions to reduce such risks.
CAUTION
Label all wires prior to disconnection when servicing
controls. Wiring errors can cause improper and
dangerous operation. Verify proper operation after
servicing.
7KLV ¿UHSODFH LV HTXLSSHG ZLWK D WKUHHSURQJ >JURXQGLQJ@
plug for your protection against shock hazard and should be
plugged directly into a properly grounded three-prong receptacle. Do not cut or remove the grounding prong from this
plug.)RUDQXQJURXQGHGUHFHSWDFOHDQDGDSWHUZKLFKKDVWZR
SURQJVDQGDZLUHIRUJURXQGLQJFDQEHSXUFKDVHG
3URSHU OLQH YROWDJH SRODULW\ PXVW EH PDLQWDLQHG LQ RUGHU IRU WKH
FRQWUROV\VWHPWRRSHUDWHFRUUHFWO\9HULI\WKHLQFRPLQJQHXWUDOOLQH
LVFRQQHFWHGWRWKHZKLWHZLUHDQGWKHLQFRPLQJ³KRW´OLQHLVFRQQHFWHG WR WKH EODFN ZLUH 7KH ¿UHSODFH ZLOO QRW RSHUDWH SURSHUO\
XQOHVVWKHSRODULW\DQGJURXQGDUHFRUUHFW
Figure 67
Figure 68
Page 36
30259-9-1115
START UP CHECK LIST
WARNING
BEFORE OPERATING THIS Fireplace, CAREFULLY READ THE FOLLOWING.
9HULI\ WKH JDV OLQH VHUYLFH GRHV QRW H[FHHG LQ ZF
DQG LV QRW EHORZ LQ ZF IRU QDWXUDO JDV QRU H[FHHGV
LQZFRULVEHORZLQZFIRU/3JDV
&KHFN DQG LQVSHFW WKH ¿UHSODFH IRU JDV OHDNV ,Q WKH HYHQW
RIJDVOHDNVFXWRIIWKHJDVVXSSO\WRWKH¿UHSODFHLPPHGLDWHO\DQGFDOO\RXUJDVVXSSOLHU9HULI\WKHJDVOLQHKDVEHHQ
SXUJHG
9HULI\WKDWDOOH[KDXVWDQGLQOHWDLUSLSHVDUHXQREVWUXFWHGDQG
SURSHUO\MRLQHG
9LVXDOO\ YHULI\ WKH EXUQHUV DUH IUHH RI GXVW DQG GHEULV
6HH)LJXUHVDQG
&KHFN DQG YHULI\ WKDW ORJV DUH SODFH FRUUHFWO\ 6HH SDJHV
WR7KHORJVPXVWEHLQWKHFRUUHFWSRVLWLRQRUWKH¿UHSODFHZLOOQRWRSHUDWHFRUUHFWO\
'2127OLJKW¿UHSODFHZLWKRXWWKHORJVLQVWDOOHGWKH¿UHSODFH
will not operate properly.
9HULI\WKDWDOOSDQHOVDUHVHFXUHGLQSODFHDQGWKDWWKHJODVV
DVVHPEO\GRRUKDVEHHQORFNHGLQSRVLWLRQ
9HULI\WKHWZREXUQHUVZLWFKHVDUHLQWKH2))SRVLWLRQEHIRUH
DSSO\LQJSRZHUDQGWKHPDLQSRZHUVZLWFK
$IWHUYHULI\LQJDQGFKHFNLQJDOOWKHDERYHSRLQWVSURFHHGWR
lighting instructions. Refer to Page 38.
9HULI\WKDWWKHSRODULW\RIWKHFRQQHFWLRQVDUHFRUUHFWDQGWKH
OLQHYROWDJHSRZHUOHDGVDUHVHFXUH
Note:,IXVLQJDVXUURXQGYHULI\LWLVLQVWDOOHGSHUWKHLQVWUXFWLRQVLQFOXGHGZLWKWKHNLW
30259-9-1115
Page 37
LIGHTING INSTRUCTIONS
FOR YOUR SAFETY READ BEFORE LIGHTING
WARNING: IF YOU DO NOT FOLLOW THESE INSTRUCTIONS EXACTLY, A FIRE OR
EXPLOSION MAY RESULT CAUSING PROPERTY DAMAGE, PERSONAL INJURY, OR LOSS
OF LIFE.
$ %()25( /,*+7,1* VPHOO DOO DURXQG WKH DSSOLDQFH
DUHD IRU JDV %H VXUH WR VPHOO QH[W WR WKH ÀRRU EHFDXVHVRPHJDVLVKHDYLHUWKDQDLUDQGZLOOVHWWOHRQ
WKHÀRRU
WHAT TO DO IF YOU SMELL GAS
'RQRWWU\WROLJKWDQ\DSSOLDQFH
'RQRWWRXFKDQ\HOHFWULFDOVZLWFK
'RQRWXVHDQ\SKRQHLQ\RXUEXLOGLQJ
,PPHGLDWHO\FDOO\RXUJDVVXSSOLHUIURPDQHLJKERU¶V SKRQH )ROORZ WKH JDV VXSSOLHU¶V LQVWUXFtions.
,I\RXFDQQRWUHDFK\RXUJDVVXSSOLHUFDOOWKH¿UH
GHSDUWPHQW
B. Use the on-the-wall switch or remote conWURO VZLWFK WR WXUQ WKH JDV FRQWURO RQRII $Q\ DWWHPSWHG UHSDLUV RU DGMXVWPHQWV VKRXOG EH
SHUIRUPHG E\ D TXDOL¿HG VHUYLFH WHFKQLFLDQ
$SSO\LQJIRUFHRUDWWHPSWHGUHSDLUPD\UHVXOWLQD¿UH
RUH[SORVLRQ
& 'RQRWXVHWKLVDSSOLDQFHLIDQ\SDUWKDVEHHQXQGHU
ZDWHU,PPHGLDWHO\FDOODTXDOL¿HGVHUYLFHWHFKQLFLDQ
WRLQVSHFWWKHDSSOLDQFHDQGWRUHSODFHDQ\SDUWRIWKH
FRQWURO V\VWHP DQG DQ\ JDV FRQWURO ZKLFK KDV EHHQ
XQGHUZDWHU
LIGHTING INSTRUCTIONS
67235HDGWKHVDIHW\LQIRUPDWLRQDERYHRQWKLVODEHO
6HWWKHWKHUPRVWDWLIXVHGWRWKHORZHVWVHWWLQJ
7XUQ RII DOO HOHFWULF SRZHU WR WKH DSSOLDQFH 7XUQ RII
HOHFWULFDOFRQWUROVZLWFKHVWR³2´
7KLVDSSOLDQFHLVHTXLSSHGZLWKDQLJQLWLRQGHYLFHWKDW
DXWRPDWLFDOO\OLJKWVWKHEXUQHU'RQRWWU\WROLJKWWKH
EXUQHUE\KDQG
5HPRYHWKHIURQWDFFHVVSDQHOEHORZWKHJODVVGRRU
E\SXOOLQJERWKVLGHVIRUZDUGVLPXOWDQHRXVO\
7XUQJDVOLQHYDOYHWR³21´
:DLW¿YHPLQXWHVWRFOHDURXWDQ\JDV7KHQVPHOO
IRUJDVLQFOXGLQJQHDUWKHÀRRU,I\RXVPHOOJDV6723
)ROORZ³$´LQWKHVDIHW\LQIRUPDWLRQDERYH,I\RXGR
QRWVPHOOJDVJRWRWKHQH[WVWHS
7XUQRQHOHFWULFSRZHUWRWKHDSSOLDQFH7XUQRQHOHFWULFFRQWUROVZLWFKHVWR³ ´
5HSODFH WKH IURQW DFFHVV SDQHO SUHVV ERWK VLGHV RI
WKHSDQHOXQWLOERWKORFNSRVLWLRQ
6HWWKHUPRVWDWWRGHVLUHGVHWWLQJLIDYDLODEOH
,IWKHDSSOLDQFHZLOOQRWRSHUDWHIROORZWKHLQVWUXFWLRQV
³7278512))*$672$33/,$1&(´DQGFDOO\RXU
VHUYLFHWHFKQLFLDQRUJDVVXSSOLHU
TO TURN OFF GAS TO APPLIANCE
67235HDGWKHVDIHW\LQIRUPDWLRQDERYH
6HWWKHWKHUPRVWDWLIXVHGWRWKHORZHVWVHWWLQJ
7XUQRIIHOHFWULFSRZHUWRWKHDSSOLDQFH
Page 38
5HPRYHIURQWDFFHVVSDQHO
7XUQJDVOLQHYDOYHWR³2))´
5HSODFHIURQWDFFHVVSDQHO
30259-9-1115
START UP AND ADJUSTMENTS
$ :LWKPDLQHOHFWULFDOSRZHUWRWKH¿UHSODFHWXUQHGRIILQVWDOO
$$VL]HG9EDWWHULHVLQWRWKHUHPRWHUHFHLYHU7KHUHPRWH
UHFHLYHU LV ORFDWHG LQVLGH WKH ¿UHSODFH PRXQWHG WR WKH WRS
RIWKHEORZHUKRXVLQJDQGVHFXUHGZLWKKRRNDQGORRSWDSH
6HH)LJXUH6HWXSUHFHLYHUDQGUHPRWHSHULQVWUXFWLRQVRQ
SDJHV
Sequence of Operations – Front and Back Burners
7KH 'LVSOD\ 3DQHO ZLOO EH HQHUJL]HG DQG WKH OLJKWV IRU WKH
IURQWEXUQHUDQGEDFNEXUQHUZLOOÀDVK
7KHLQGXFHUZLOODFWLYDWHLPPHGLDWHO\DQGZLOOSURYHWKHSUHVVXUH VZLWFK ZLWKLQ VHFRQGV 7KLV ZLOO LQLWLDWH WKH LJQLWLRQ
VHTXHQFH
7KHUHDULJQLWHU+6,ZLOOHQHUJL]HDQGVWDUWWRJORZUHG
:LWKLQWRVHFRQGVWKHJDVYDOYHZLOORSHQDQGLJQLWHWKH
UHDUEXUQHU7KHÀDPHVHQVRUZLOOYHULI\WKHÀDPHLVSUHVHQW
ZLWKLQWRVHFRQGV
7KH LJQLWHU IRU WKH IURQW EXUQHU ZLOO HQHUJL]H WR VHFRQGV
DIWHUWKHÀDPHLVHVWDEOLVKHGRQWKHUHDUEXUQHU
7KHJDVYDOYHZLOORSHQWRLJQLWHWKHIURQWEXUQHUZLWKLQWR
VHFRQGV7KHÀDPHVHQVRUZLOOYHULI\WKHÀDPHLVSUHVHQW
ZLWKLQWRVHFRQGV
$VWKH0DQWLVZDUPVXSWKHFLUFXODWLQJEORZHUZLOODFWLYDWH
VWDUWLQJRQ/RZVSHHG7KH/RZ%ORZHU/('ZLOOOLJKWZKHQ
WKHEORZHUWXUQVRQ
$VWKH0DQWLVFRQWLQXHVWRRSHUDWHWKHVSHHGRIWKHFLUFXODWLQJEORZHUZLOOLQFUHDVHDQGWKH/('IRU0HGLXPDQG+LJK
ZLOODSSHDU
Figure 69
% 7XUQRQWKHPDLQHOHFWULFDOSRZHUWRWKH¿UHSODFHDQGWXUQWKH
PDLQEXUQHUVZLWFKWRWKH21SRVLWLRQ6HH)LJXUH9HULI\
SRZHULVRQE\FKHFNLQJLIWKHUHLVSRZHUWRWKHFLUFXLWERDUG
,IWKHXQLWKDVSRZHUWKHSRZHUOLJKWZLOOEHLOOXPLQDWHG
Figure 71
CAUTION
When switching from one burner to the other burner, be
VXUH WR ¿UVW WXUQ ³21´ WKH GHVLUHG EXUQHU EHIRUH WXUQLQJ
“OFF” the burner that is operating. Failure to follow this
VHTXHQFH PD\ UHVXOW LQ WKH ¿UHSODFH QHHGLQJ WR EH UHVHW
See page 49 - Resetting the Fireplace.
Figure 70
& 7XUQRQWKHPDLQJDVVXSSO\
' 7XUQERWKEXUQHUVZLWFKHVRQWRLJQLWHERWKWKHIURQWDQGUHDU
EXUQHUV%XUQHUVZLWFKHVPXVWUHPDLQLQWKH21SRVLWLRQIRU
the remote to function. See Figure 71.
( 7KH'LVSOD\3DQHOERDUGVKRXOGEHHQHUJL]HGDQGWKHSRZHU
OLJKWZLOOEHLOOXPLQDWHG
30259-9-1115
Page 39
START UP AND ADJUSTMENTS
Sequence of Operations – One Burner Only
7KH'LVSOD\3DQHOZLOOEHHQHUJL]HGDQGWKHOLJKWIRUHLWKHU
WKH IURQW EXUQHU RU EDFN EXUQHU ZLOO ÀDVK FRUUHVSRQGLQJ WR
ZKLFKEXUQHUVZLWFKLVDFWLYDWHG
7KHLQGXFHUZLOODFWLYDWHLPPHGLDWHO\DQGZLOOSURYHWKHSUHVVXUH VZLWFK ZLWKLQ VHFRQGV 7KLV ZLOO LQLWLDWH WKH LJQLWLRQ
VHTXHQFH
7KHLJQLWHU+6,ZLOOHQHUJL]HDQGVWDUWWRJORZUHG
:LWKLQWRVHFRQGVWKHJDVYDOYHZLOORSHQDQGLJQLWHWKH
EXUQHU7KHÀDPHVHQVRUZLOOYHULI\WKHÀDPHLVSUHVHQWZLWKLQ
WRVHFRQGV
7KH LJQLWHU IRU WKH IURQW EXUQHU ZLOO HQHUJL]H WR VHFRQGV
DIWHUWKHÀDPHLVHVWDEOLVKHGRQWKHEXUQHU
$VWKH0DQWLVZDUPVXSWKHFLUFXODWLQJEORZHUZLOODFWLYDWH
VWDUWLQJRQ/RZVSHHG7KH/RZ%ORZHU/('ZLOOOLJKWZKHQ
WKHEORZHUWXUQVRQ
$VWKH0DQWLVFRQWLQXHVWRRSHUDWHWKHVSHHGRIWKHFLUFXODWLQJEORZHUPD\LQFUHDVH
High Altitude
7KH0DQWLVFDQEHLQVWDOOHG WRDOWLWXGHV XSWR IHHWLQWKH
86DQGXSWRIHHWLQ&DQDGD7KHLQVWDOODWLRQPXVWPHHW
WKHUHTXLUHPHQWVRIWKH1DWLRQDO)XHO*DV&RGHRUORFDOMXULVGLFWLRQV$KLJKDOWLWXGHNLWLVQHHGHGIRULQVWDOODWLRQDERYHIHHW
6HHWKHLQVWUXFWLRQVSURYLGHGZLWKWKH0DQWLV+LJK$OWLWXGH.LWIRU
GHUDWHLQVWUXFWLRQV
+XPLGL¿HU2SHUDWLRQ
:KHQ WKH ¿UHSODFH KDV EHHQ UXQQLQJ WKH KXPLGL¿HU /('
)LJXUH PD\ WXUQ RQ WR VLJQDO WKDW WKH SXPS KDV EHHQ DFWLYDWHG5HIHUWR3DJH$XWRPDWLF+XPLGL¿HU2SHUDWLRQ
Paint Curing - First Firing
7KH0DQWLV3RZHU9HQW+LJK(I¿FLHQF\)LUHSODFHKDVEHHQSDLQWHGZLWKWKHKLJKTXDOLW\KHDWUHVLVWDQWVLOLFRQSDLQW7RHQVXUHWKDW
WKHSDLQWLVSURSHUO\FXUHGDOORZWKH¿UHSODFHWRRSHUDWHZLWKERWK
EXUQHUVRQIRUDSSUR[LPDWHO\KRXU'XULQJWKHLQLWLDO¿ULQJRIWKH
¿UHSODFHLWLVFRPPRQIRUVPRNHWRDSSHDU
CAUTION
'2127WRXFKWKHVXUIDFHRIWKH¿UHSODFH7KHSDLQW
will soften during the initial operation, and will harden
over time. Once the paint is cured, it will not soften
again.
Figure 72
Shut Down Instructions
7RWXUQWKH¿UHSODFHRIIVLPSO\SXVK³2))´RQWKHUHPRWHRUVZLWFK
WKH EXUQHU VZLWFKHV WR WKH ³2))´ SRVLWLRQ 6HH )LJXUH '2
127FXWWKHPDLQHOHFWULFDOSRZHUWRWKH¿UHSODFH
7KH FLUFXODWLQJ EORZHU ZLOO FRQWLQXH WR RSHUDWH DIWHU WKH EXUQHUV
DUHWXUQHGRII7KHEORZHUZLOOVWRSDXWRPDWLFDOO\RQFHWKH¿UHSODFH
KDVFRROHGGRZQ
7RSUHYHQWWULJJHULQJRIVPRNHDODUPVVXSSO\SURSHUYHQWLODWLRQWRWKHURRPZKHUHWKHXQLWLVLQVWDOOHG
'XULQJLQLWLDO¿ULQJRIORJVDQRGRUZLOORFFXUDVWKHORJVDUH
FXULQJ,WLVDOVRFRPPRQIRUWKHEXUQHUWREXUQZLWKD\HOORZ
ÀDPH
'2 127 FOHDQ WKH ¿UHSODFH ZLWK DQ\ FDXVWLF RU DEUDVLYH
FOHDQLQJVROXWLRQV7KLVZLOOGDPDJHWKHVXUIDFH
$Q\GDPDJHWRWKHSDLQWHGVXUIDFHVVKRXOGEHUHSDLUHGRQO\
ZLWKDXWKRUL]HGSDLQWDYDLODEOHIURP\RXU0DQWLV'HDOHU
Checking Manifold Pressure
%RWK 3URSDQH DQG 1DWXUDO JDV YDOYHV KDYH D EXLOWLQ SUHVVXUH
UHJXODWRULQWKHJDVYDOYH1DWXUDOJDVPRGHOVZLOOKDYHDPDQLIROG
SUHVVXUHRIDSSUR[LPDWHO\LQZFDWWKHYDOYHRXWOHWZLWKWKH
LQOHWSUHVVXUHWRWKHYDOYHDWLQZFWRLQZF3URSDQH
JDV PRGHOV ZLOO KDYH D PDQLIROG SUHVVXUH DSSUR[LPDWHO\ LQ
ZFDW WKH YDOYH RXWOHW ZLWK WKH LQOHW SUHVVXUH WR WKH YDOYH IURP
11.0 in. w.c. to 13.0 in. w.c.
$ LQFK 137 SOXJJHG WDSSLQJ DFFHVVLEOH IRU WHVW JDXJH
FRQQHFWLRQLVORFDWHGRQWKHRXWOHWVLGHRIWKHJDVFRQWURO
Blower Operation
7KHFLUFXODWLQJDLUEORZHUZLOODXWRPDWLFDOO\HQJDJHDQGLQFUHDVH
LQVSHHGGHSHQGLQJRQWKHRSHUDWLRQRIWKHEXUQHUV,QPRVWFLUFXPVWDQFHVWKHFLUFXODWLQJ EORZHUZLOOVWDUWWRPLQXWHVDIWHU
LJQLWLRQRIWKHEXUQHUV
2QFHWKH¿UHSODFHLVWXUQHGRIIRUWKHFDOOIRUKHDWKDVEHHQVDWLV¿HG WKH FLUFXODWLQJ EORZHU ZLOO FRQWLQXH WR UXQ7KH EORZHU ZLOO
DXWRPDWLFDOO\WXUQRIIRQFHWKH¿UHSODFHKDVFRROHGGRZQ
Page 40
30259-9-1115
FRBTC REMOTE INSTRUCTIONS
INTRODUCTION
7KLVUHPRWHFRQWUROV\VWHPZDVGHYHORSHGWRSURYLGHDVDIHUHOLDEOHDQGXVHUIULHQGO\UHPRWHFRQWUROV\VWHPIRUJDV
KHDWLQJDSSOLDQFHV7KLVDOOEDWWHU\V\VWHPRSHUDWHVLQGHSHQGHQWO\RIKRXVHKROGFXUUHQW7KHV\VWHPRSHUDWHVRQUDGLR
IUHTXHQFLHVZLWKDQRQGLUHFWLRQDOVLJQDOV7KH6<67(0¶VRSHUDWLQJUDQJHLVDSSUR[LPDWHO\IHHW7KHV\VWHPRSHUDWHV
RQRQHRIVHFXULW\FRGHVWKDWDUHSURJUDPPHGLQWRWKHWUDQVPLWWHUDWWKHIDFWRU\WKHUHPRWHUHFHLYHU¶VFRGH
PXVWEHPDWFKHGWRWKDWRIWKHWUDQVPLWWHUSULRUWRLQLWLDOXVH
Review COMMUNICATION SAFETY SECTIONXQGHU75$160,77(5VHFWLRQDQGTHERMOSTAT SAFETY SECTION
XQGHU5(027(5(&(,9(5VHFWLRQ7KHVHVLJQDOWHPSHUDWXUHVDIHW\IHDWXUHVVKXWGRZQWKH¿UHSODFHV\VWHPZKHQD
SRWHQWLDOO\XQVDIHFRQGLWLRQH[LVWV
7KHUHPRWHFRQWUROV\VWHPRIIHUVWKHXVHUDEDWWHU\RSHUDWHGUHPRWHFRQWURO
7KHWUDQVPLWWHURSHUDWHVRQ9$$$EDWWHULHV
,WLVUHFRPPHQGHGWKDW$/.$/,1(EDWWHULHVDOZD\VEHXVHGIRUORQJHUEDWWHU\
OLIHDQGPD[LPXPRSHUDWLRQDOSHUIRUPDQFH
%HIRUHXVLQJWKHWUDQVPLWWHULQVWDOOWKH$$$WUDQVPLWWHUEDWWHULHVLQWRWKH
EDWWHU\FRPSDUWPHQW8VHFDXWLRQWKDWEDWWHULHVDUHLQVWDOOHGLQWKHSURSHU
GLUHFWLRQ
KEY SETTINGS
30259-9-1115
212SHUDWHVXQLWWRRQSRVLWLRQ0DQXDOO\21
2))2SHUDWHVXQLWWRRIISRVLWLRQ0DQXDOO\2))
02'(&KDQJHVXQLWIURPPDQXDOPRGHWRWKHUPRVWDW
PRGH
6(76HWVWHPSHUDWXUHLQWKHUPRVWDWPRGH
1.
DISPLAY
,QGLFDWHV&855(17URRPWHPSHUDWXUH
2.
°F OR °C
,QGLFDWHVGHJUHHV)DKUHQKHLWRU&HOVLXV
3.
FLAME
,QGLFDWHVEXUQHUYDOYHLQRSHUDWLRQ
4.
ROOM
,QGLFDWHVUHPRWHLVLQ7+(50267$7RSHUDWLRQ
5.
TEMP
$SSHDUVGXULQJPDQXDORSHUDWLRQ
6.
SET
$SSHDUVGXULQJWLPHWKHRIVHWWLQJWKHGHVLUHGWHPSHUDWXUHLQWKHWKHUPRVWDWRSHUDWLRQ
Page 41
FRBTC REMOTE INSTRUCTIONS
SETTING °F / °C SCALE
7KHIDFWRU\VHWWLQJIRUWHPSHUDWXUHLV°F. To change this setting to °&
¿UVW
• Press the ONNH\DQGWKHOFFNH\RQWKHWUDQVPLWWHUDWWKH
same time this will change from °F to °&)ROORZWKLVVDPHSURFHGXUHWRFKDQJHIURP°&EDFNWR°F.
MANUAL FUNCTION
7RRSHUDWHWKHV\VWHPLQWKHPDQXDO³02'(´GRHVWKHIROORZLQJ
ON OPERATION
Press the ONNH\WKH¿UHSODFHÀDPHZLOOFRPHRQ'XULQJWKLVWLPH
WKH/&'VFUHHQZLOOVKRZ21DIWHUVHFRQGVWKH/&'VFUHHQZLOO
GHIDXOWWRGLVSOD\URRPWHPSHUDWXUHDQGWKHZRUG7(03ZLOOVKRZ
(Flame icon will appear on LCD screen in on mode)
OFF OPERATION
3UHVVWKH2))NH\WKH¿UHSODFHÀDPHZLOOVKXWRII'XULQJWKLVWLPH
WKH/&'VFUHHQZLOOVKRZ2)DIWHUVHFRQGVWKH/&'VFUHHQZLOO
GHIDXOWWRGLVSOD\URRPWHPSHUDWXUHDQGWKHZRUG³7(03´ZLOODOVR
show on the screen.
THERMOSTAT FUNCTION
SETTING DESIRED ROOM TEMPERATURE
7KLVUHPRWHFRQWUROV\VWHPFDQEHWKHUPRVWDWLFDOO\FRQWUROOHGZKHQ
WKHWUDQVPLWWHULVLQWKH7+(50267$7PRGH7KHZRUGROOM must
be displayed on the screen7RVHWWKH7+(50267$702'(DQG
'(6,5('URRPWHPSHUDWXUH
Press the MODENH\XQWLOWKH/&'VFUHHQVKRZVWKHZRUGROOM
WKHQWKHUHPRWHLVLQWKHWKHUPRVWDWLFPRGH
3UHVVDQGKROGWKHSETNH\XQWLOWKHGHVLUHGVHWWHPSHUDWXUHLV
UHDFKHG%\SUHVVLQJDQGKROGLQJWKHVHWNH\WKH/&'VFUHHQVHW
QXPEHUVZLOOLQFUHDVHIURP° to 99° then restart over at 45°1H[W
release the SETNH\7KH/&'VFUHHQZLOOGLVSOD\WKHVHWWHPSHUDWXUH
IRUVHFRQGVDQGWKH/&'VFUHHQZLOOÀDVKWKHVHWWHPSHUDWXUHIRU
VHFRQGVWKHQWKH/&'VFUHHQZLOOGHIDXOWWRGLVSOD\WKHURRPWHPSHUDWXUH
TO CHANGE THE SET TEMPERATURE
3UHVVDQGKROGWKHSETNH\XQWLOWKHGHVLUHGVHWWHPSHUDWXUHLV
UHDFKHG%\SUHVVLQJDQGKROGLQJWKHVHWNH\WKH/&'VFUHHQVHW
QXPEHUVZLOOLQFUHDVHIURP° to 99° then restart over at 45°1H[W
UHOHDVHWKH6(7NH\7KH/&'VFUHHQZLOOGLVSOD\WKHVHWWHPSHUDWXUH
IRUVHFRQGVWKHQZLOOÀDVKWKHVHWWHPSHUDWXUHIRUVHFRQGVWKHQ
WKH/&'VFUHHQZLOOGHIDXOWWRGLVSOD\WKHURRPWHPSHUDWXUH
Press the MODENH\WRGLVHQJDJHWKHWKHUPRVWDWPRGH7KHZRUG
ROOM on the LCD screen will not show when the thermostat is not in
RSHUDWLRQ
127(7KHKLJKHVW6(7WHPSHUDWXUHLV° Fahrenheit (32° CelsiusDQGWKHORZHVWWHPSHUDWXUHLV° Fahrenheit (6° Celsius
Page 42
30259-9-1115
FRBTC REMOTE INSTRUCTIONS
OPERATIONAL NOTES:
7KH7KHUPRVWDW)HDWXUHRQWKHWUDQVPLWWHURSHUDWHVWKH¿UHSODFHZKHQHYHUWKH52207(03(5$785(YDULHVDFHUWDLQ
QXPEHURIGHJUHHVIURPWKH6(77(03(5$785(7KLVYDULDWLRQLVFDOOHGWKH³6:,1*´RU7(03(5$785(',))(5(17,$/7KHQRUPDORSHUDWLQJF\FOHRIDQ¿UHSODFHPD\EHWLPHVSHUKRXUGHSHQGLQJRQKRZZHOOWKHURRPRUKRPHLV
LQVXODWHGIURPWKHFROGRUGUDIWV7KHIDFWRU\VHWWLQJIRUWKH³VZLQJQXPEHU´LV7KLVUHSUHVHQWVDWHPSHUDWXUHYDULDWLRQRI
°F (1°&EHWZHHQ6(7WHPSHUDWXUHDQG5220WHPSHUDWXUHZKLFKGHWHUPLQHVZKHQWKH¿UHSODFHZLOOEHDFWLYDWHG
7KLVIXQFWLRQLVSUHVHWDWWKHIDFWRU\
7KHWUDQVPLWWHUKDV21DQG2))PDQXDOIXQFWLRQVWKDWDUHDFWLYDWHGE\SUHVVLQJHLWKHUEXWWRQRQWKHIDFHRIWKHWUDQVPLWWHU
:KHQDEXWWRQRQWKHWUDQVPLWWHULVSUHVVHGWKHZRUG21RU2))ZLOODSSHDURQWKH/&'VFUHHQWRVKRZZKLOHWKHVLJQDOLV
EHLQJVHQW8SRQLQLWLDOXVHWKHUHPD\EHDGHOD\RIWKUHHVHFRQGVEHIRUHWKHUHPRWHUHFHLYHUZLOOUHVSRQGWRWKHWUDQVPLWWHU
7KLVLVSDUWRIWKHV\VWHP¶VGHVLJQ
REMOTE RECEIVER
CAUTION: THE REMOTE RECEIVER SHOULD BE POSITIONED WHERE
AMBIENT TEMPERATURES DO NOT EXCEED 130° F.
7KHUHPRWHUHFHLYHURSHUDWHVRQ$$VL]H9EDWWHULHV,WLVUHFRPPHQGHGWKDW$/.$/,1(EDWWHULHVEHXVHGIRUORQJHU
EDWWHU\OLIHDQGPD[LPXPPLFURSURFHVVRUSHUIRUPDQFH,03257$171HZRUIXOO\FKDUJHGEDWWHULHVDUHHVVHQWLDOIRUSURSHU
RSHUDWLRQRIWKHUHPRWHUHFHLYHU
7KHUHPRWHUHFHLYHUKRXVHVWKHPLFURSURFHVVRUWKDWUHVSRQGVWRFRPPDQGVIURPWKHWUDQVPLWWHUWRFRQWUROV\VWHPRSHUDWLRQ,WHPLWVRQHEHHSZKHQLWUHFHLYHVDQ21RU2))FRPPDQGPDQXDOO\EXWQREHHSZKHQF\FOLQJRQDQGRIIDXWRPDWLFDOO\LQ7+(50267$7PRGH7KHUHPRWHUHFHLYHUKDVDSRVLWLRQVOLGHVZLWFKIRUVHOHFWLQJWKH02'(RIRSHUDWLRQ21
5(027(2))
•
:LWKWKHVOLGHVZLWFKLQWKH21SRVLWLRQWRZDUGWKH/($51EXWWRQWKHV\VWHPZLOOUHPDLQRQXQWLOWKHVOLGHVZLWFKLV
SODFHGLQWKH2))RU5(027(SRVLWLRQ
:LWKWKHVOLGHVZLWFKLQWKH5(027(SRVLWLRQFHQWHUHGWKHV\VWHPZLOO
RQO\RSHUDWHLIWKHUHPRWHUHFHLYHUUHFHLYHVFRPPDQGV from the transmitter.
:LWKWKHVOLGHVZLWFKLQWKH2))SRVLWLRQDZD\IURPWKH/($51EXWWRQ
WKHV\VWHPLVRII
It is suggested that the slide switch be placed in the off position if
you will be away from your home for an extended period of time. If
the remote receiver is mounted out of children’s reach, placing the
slide switch in the OFF position also functions as a safety “lock-out”
by both turning the system off and rendering the remote receiver
inoperative.
30259-9-1115
Page 43
FRBTC REMOTE INSTRUCTIONS
CP (CHILDPROOF) FEATURE
7KLV(&6UHPRWHFRQWUROLQFOXGHVD&+,/'3522)³/2&.287´IHDWXUHWKDWDOORZVWKHXVHUWR³/2&.287´RSHUDWLRQRIWKH¿UHSODFH
from the TRANSMITTER.
SETTING “LOCK-OUT” –(CP)
7RDFWLYDWHWKH³/2&.287´IHDWXUHSUHVVDQGKROGWKH21EXWWRQDQGWKH02'(EXWWRQDWWKHVDPHWLPHIRUVHFRQGV7KHOHWWHUV
&3ZLOODSSHDULQWKH7(03IUDPHRQWKH/&'VFUHHQ
7RGLVHQJDJHWKH³/2&.287´SUHVVDQGKROGWKH21EXWWRQDQGWKH02'(EXWWRQDWWKHVDPHWLPHIRUVHFRQGVDQGWKHOHWWHUV
&3ZLOOGLVDSSHDUIURPWKH/&'VFUHHQDQGWKHWUDQVPLWWHUZLOOUHWXUQWRLWVQRUPDORSHUDWLQJFRQGLWLRQ
7RYHULI\WKDWWUDQVPLWWHULVLQWKH&3ORFNRXWPRGHSUHVVDQ\NH\DQGWKH/&'VFUHHQZLOOVKRZ³&3´
NOTE,IWKH¿UHSODFHLVDOUHDG\RSHUDWLQJLQWKH21RU7+(50267$702'(6HQJDJLQJWKH³/2&.287´will notFDQFHOWKHRSHUDWLQJ
02'((QJDJLQJWKH³/2&.287´SUHYHQWVRQO\WKHPDQXDORSHUDWLRQRIWKH75$160,77(5,ILQWKHDXWRPRGHVWKH7+(50267$7
RSHUDWLRQZLOOFRQWLQXHWRRSHUDWHQRUPDOO\7RWRWDOO\³/2&.287´WKHRSHUDWLRQRIWKH75$160,77(5¶6RSHUDWLQJVLJQDOVWKHWUDQVPLWWHU¶V02'(PXVWEHVHWWR2))
THERMOSTAT UPDATING FEATURE –TRANSMITTER – (T/S –TX)
7KLV(&6UHPRWHFRQWUROKDVD7+(50267$783'$7,1*)HDWXUHEXLOWLQWRLWVVRIWZDUH7KH7+(50267$783'$7,1*)HDWXUHRSHUDWHVLQWKHIROORZLQJPDQQHUEXWRQO\LQWKH7+(50267$702'(6
The transmitter normally reads the ROOM temperature every 2 minutes checking the ROOM temperature against the SET temperature and then sends a signal to the receiver.
COMMUNICATION – SAFETY – TRANSMITTER – (C/S – TX)
7KLV(&6UHPRWHFRQWUROKDVD&20081,&$7,21±6$)(7<IXQFWLRQEXLOWLQWRLWVVRIWZDUH,WSURYLGHVDQH[WUDPDUJLQRIVDIHW\ZKHQ
WKH75$160,77(5LVRXWRIWKHQRUPDOIRRWRSHUDWLQJUDQJHRIWKHUHFHLYHU
7KH&20081,&$7,21±6$)(7<IHDWXUHRSHUDWHVLQWKHIROORZLQJPDQQHULQall OPERATING MODES±212))7+(50267$7
$WDOOWLPHVDQGLQDOO23(5$7,1*02'(6WKHWUDQVPLWWHUVHQGVDQ5)VLJQDOHYHU\¿IWHHQPLQXWHVWRWKHUHFHLYHULQGLFDWLQJWKDW
WKHWUDQVPLWWHULVZLWKLQWKHQRUPDORSHUDWLQJUDQJHRIIHHW6KRXOGWKHUHFHLYHU127UHFHLYHDWUDQVPLWWHUVLJQDOHYHU\PLQXWHV
WKH,&VRIWZDUHLQWKH5(&(,9(5ZLOOEHJLQD+285PLQXWHFRXQWGRZQWLPLQJIXQFWLRQ,IGXULQJWKLVKRXUSHULRGWKHUHFHLYHU
GRHVQRWUHFHLYHDVLJQDOIURPWKHWUDQVPLWWHUWKHUHFHLYHUZLOOVKXWGRZQWKH¿UHSODFHEHLQJFRQWUROOHGE\WKHUHFHLYHU7KH5(&(,9(5
ZLOOWKHQHPLWDVHULHVRIUDSLG³EHHSV´IRUDSHULRGRIVHFRQGV7KHQDIWHUVHFRQGVRIUDSLGEHHSLQJWKH5(&(,9(5ZLOOFRQWLQXH
WRHPLWDVLQJOH³EHHS´HYHU\VHFRQGVXQWLODWUDQVPLWWHU21RU02'(%XWWRQLVSUHVVHGWRUHVHWWKHUHFHLYHU7KHLQWHUPLWWHQWVHFRQG
EHHSLQJZLOOJRRQIRUDVORQJDVWKHUHFHLYHU¶VEDWWHULHVODVWZKLFKFRXOGEHLQH[FHVVRIRQH\HDU
7R³UHVHW´WKH5(&(,9(5DQGRSHUDWHWKH¿UHSODFH\RXPXVWSUHVVWKHON or MODEEXWWRQRQWKHWUDQVPLWWHU%\WXUQLQJWKHV\VWHP
WR21WKH&20081,&$7,216$)(7<RSHUDWLRQLVRYHUULGGHQDQGWKHV\VWHPZLOOUHWXUQWRQRUPDORSHUDWLRQGHSHQGLQJRQWKH02'(
VHOHFWHGDWWKHWUDQVPLWWHU7KH&20081,&$7,21±6$)(7<IHDWXUHZLOOUHDFWLYDWHVKRXOGWKHWUDQVPLWWHUEHWDNHQRXWRIWKHQRUPDO
RSHUDWLQJUDQJHRUVKRXOGWKHWUDQVPLWWHU¶VEDWWHULHVIDLORUEHUHPRYHG
Page 44
30259-9-1115
FRBTC REMOTE INSTRUCTIONS
THERMOSTAT SAFETY FEATURE – RECEIVER (T/S –RX)
7KLV(&6UHPRWHFRQWUROKDVD7+(50267$76$)(7<IHDWXUHWKDWLVEXLOWLQWRWKHV\VWHP¶V5(&(,9(57KLVIHDWXUHLV
WHPSHUDWXUHDFWLYDWHGDQGSURYLGHVDQH[WUDPDUJLQRIVDIHW\ZKHQWKH5(&(,9(5LVRSHUDWLQJZKHUHDPELHQWWHPSHUDWXUHVH[FHHG°)GHJUHHVLQVLGHWKHUHFHLYHUFDVH
7KH7+(50267$76$)(7<IHDWXUHLQWKH5(&(,9(5RSHUDWHVLQWKHIROORZLQJPDQQHUZKHQWKH¿UHSODFHLVLQRSHUDtion.
7KHUHFHLYHULVWKHUPDOO\SURWHFWHGIURPH[WUHPHKHDWFRQGLWLRQV+HDWFDQKDYHQHJDWLYHHIIHFWRQWKHRSHUDWLRQRIWKH
UHFHLYHU¶VPLFURSURFHVVRUV
)RU5(027(5(&(,9(56WKDWRSHUDWHRQ%$77(5<32:(5WKHVHKHDWFRQGLWLRQVFDQFDXVHEDWWHULHVWRGLVFKDUJH
ZKHQWHPSHUDWXUHVH[FHHG°)6WXGLHVVKRZWKDWDONDOLQHEDWWHULHVZKHQH[SRVHGWRDFRQVWDQWWHPSHUDWXUHRI°)
FDQORVHXSWRRIWKHLURSHUDWLQJSRZHU:KHQWKHEDWWHU\FRROVGRZQLWZLOOSDUWLDOO\UHFKDUJHLWVHOIEXWFRQVWDQWKHDWLQJDQGFRROLQJZLOOUHGXFHWKHEDWWHU\¶VQRUPDOOLIHH[SHFWDQF\
:KHQWKHDPELHQWWHPSHUDWXUHDWWKH7+(50,6725inside the receiver case, reaches 130°)WKH7+(50,6725ZLOODXWRPDWLFDOO\VKXWWKH¿UHSODFHGRZQDQGWKH5(&(,9(5ZLOOEHJLQHPLWWLQJDVHULHVRI³EHHSV´HYHU\VHFRQGV:KHQWKH
DPELHQWWHPSHUDWXUHDWWKH5(&(,9(5GURSVEHWZHHQ°)DQG°)WKHXVHUFDQUHDFWLYDWHWKH¿UHSODFHE\SXVKLQJ
the MODEEXWWRQRQWKHWUDQVPLWWHU7KHZRUG21PXVWGLVSOD\RQWKH/&'VFUHHQ:KHQWKH02'(EXWWRQLVSUHVVHGWR
21WKH7+(50,6725³UHVHWV´LWVHOIDQGWKH¿UHSODFHZLOOEHJLQRSHUDWLQJDJDLQ+RZHYHUWKH³EHHSLQJ´ZLOOFRQWLQXHif
WKHDPELHQWWHPSHUDWXUHUHPDLQVEHWZHHQ°)DQG°F.7KLV³EHHSLQJ´DOHUWVWKHXVHUWKDWWKH5(&(,9(5VKRXOGEH
UHSRVLWLRQHGVRWKHDPELHQWWHPSHUDWXUHGURSVEHORZ°F.
:KHQWKHWHPSHUDWXUHGURSVEHORZ°)WKH³EHHSLQJ´ZLOOFHDVHSURYLGLQJWKHXVHUKDV³UHVHW´WKH7+(50,6725E\
SXVKLQJWKH02'(EXWWRQWR21WRRSHUDWHWKH¿UHSODFHHLWKHUPDQXDOO\RUWKHUPDOO\$OORZVXI¿FLHQWWLPHIRUWKHUHFHLYHU
WRFRROEHORZ°)DQGWKHQSUHVVMODEEXWWRQWRVWRSEHHSLQJ
MATCHING SECURITY CODES
(DFKWUDQVPLWWHUFDQXVHRQHRIXQLTXHVHFXULW\FRGHV,WPD\EHQHFHVVDU\WRSURJUDPWKHUHPRWHUHFHLYHU
WR/($51WKHVHFXULW\FRGHRIWKHWUDQVPLWWHUXSRQLQLWLDOXVHLIEDWWHULHVDUHUHSODFHGRULIDUHSODFHPHQWWUDQVPLWWHULV
SXUFKDVHGIURP\RXUGHDOHURUWKHIDFWRU\:KHQPDWFKLQJVHFXULW\FRGHVEHVXUHVOLGHEXWWRQRQWKHUHFHLYHULVLQWKH5(027(SRVLWLRQWKHFRGHZLOO127³/($51´LIWKHVOLGHVZLWFKLVLQWKH2))SRVLWLRQ3URJUDPWKHUHPRWHUHFHLYHUWR/($51
DQHZVHFXULW\FRGHE\SXVKLQJLQWKH/($51EXWWRQRQWKHWRSRIWKHUHPRWHUHFHLYHUDQGWKHQSUHVVLQJDQ\EXWWRQRQWKH
WUDQVPLWWHU$FKDQJHLQWKHEHHSLQJSDWWHUQDWWKHUHFHLYHULQGLFDWHVWKHWUDQVPLWWHU¶VFRGHKDVEHHQSURJUDPPHGLQWRWKH
UHFHLYHU:KHQDQH[LVWLQJUHFHLYHULVPDWFKHGWRDQHZWUDQVPLWWHUWKHQHZVHFXULW\FRGHZLOORYHUZULWHWKHROGRQH
7KHPLFURSURFHVVRUWKDWFRQWUROVWKHVHFXULW\FRGHPDWFKLQJSURFHGXUHLVFRQWUROOHGE\DWLPLQJIXQFWLRQ,I\RXDUHXQVXFFHVVIXOLQPDWFKLQJWKHVHFXULW\FRGHRQWKH¿UVWDWWHPSWZDLWPLQXWHVEHIRUH
WU\LQJDJDLQWKLVGHOD\DOORZVWKHPLFURSURFHVVRUWRUHVHWLWVWLPHUFLUFXLWU\DQGWU\
XSWRWZRRUWKUHHPRUHWLPHV
TRANSMITTER WALL CLIP
7KHWUDQVPLWWHUFDQEHKXQJRQDZDOOXVLQJWKHFOLSSURYLGHG,IWKHFOLSLVLQVWDOOHG
RQDVROLGZRRGZDOOGULOO´SLORWKROHVDQGLQVWDOOZLWKWKHVFUHZVSURYLGHG,ILWLV
LQVWDOOHGRQDSODVWHUZDOOERDUGZDOO¿UVWGULOOWZR´KROHVLQWRWKHZDOO7KHQXVH
DKDPPHUWRWDSLQWKHWZRSODVWLFZDOODQFKRUVÀXVKZLWKWKHZDOOWKHQLQVWDOOWKH
VFUHZVSURYLGHG
30259-9-1115
Page 45
FRBTC REMOTE INSTRUCTIONS
BATTERY LIFE
/LIHH[SHFWDQF\RIWKHDONDOLQHEDWWHULHVLQWKHWUDQVPLWWHUVKRXOGEHDWOHDVWPRQWKV&KHFNDQGUHSODFHDOOEDWWHULHVDQQXDOO\:KHQWKHWUDQVPLWWHUQRORQJHURSHUDWHVWKHUHPRWHUHFHLYHUIURPDGLVWDQFHLWGLGSUHYLRXVO\LHWKHWUDQVPLWWHU¶V
UDQJHKDVGHFUHDVHGRUWKHUHPRWHUHFHLYHUGRHQRWIXQFWLRQDWDOOWKHEDWWHULHVVKRXOGEHFKHFNHG,WLVLPSRUWDQWWKDWWKH
UHPRWHUHFHLYHUEDWWHULHVDUHIXOO\FKDUJHGDQGSURYLGHVFRQWLQXRXVRXWSXWYROWDJHRIDOHDVWYROWV7KHOHQJWKRIWKHZLUH
EHWZHHQWKHUHPRWHUHFHLYHUDQGJDVYDOYHGLUHFWO\DIIHFWVWKHRSHUDWLQJSHUIRUPDQFHRIWKHUHPRWHV\VWHP7KHORQJHUWKH
ZLUHWKHPRUHEDWWHU\SRZHULVUHTXLUHGWRGHOLYHUVLJQDOVEHWZHHQWKHUHPRWHUHFHLYHUDQGWKHJDVYDOYH5HFRPPHQGHG
OHQJWKLVQRORQJHUWKDQIHHW7KHWUDQVPLWWHUVKRXOGRSHUDWHZLWKDVOLWWOHDVYROWVEDWWHU\SRZHU
TROUBLE SHOOTING
,I\RXHQFRXQWHUSUREOHPVZLWK\RXU¿UHSODFHV\VWHPWKHSUREOHPPD\EHZLWKWKH¿UHSODFHLWVHOIRULWFRXOGEHZLWKWKH(&6
UHPRWH5HYLHZWKH¿UHSODFHPDQXIDFWXUHU¶VRSHUDWLRQPDQXDOWRPDNHVXUHDOOFRQQHFWLRQVDUHSURSHUO\PDGH7KHQFKHFN
WKHRSHUDWLRQRIWKH(&6UHPRWHLQWKHIROORZLQJPDQQHU
0DNHVXUHWKHEDWWHULHVDUHFRUUHFWO\LQVWDOOHGLQWKH5(&(,9(52QHUHYHUVHGEDWWHU\ZLOONHHSUHFHLYHUIURPRSHUDWLQJ
SURSHUO\
&KHFNEDWWHU\LQ7UDQVPLWWHUWRPDNHVXUHFRQWDFWVDUHWRXFKLQJDQGHQGVRIEDWWHU\%HQGPHWDOFRQWDFWVLQIRU
WLJKWHU¿W
%HVXUH5(&(,9(5DQG7UDQVPLWWHUDUHZLWKLQ¶¶RSHUDWLQJUDQJH
.HHS5(&(,9(5IURPWHPSHUDWXUHVH[FHHGLQJ°)%DWWHU\OLIHVKRUWHQHGZKHQDPELHQWWHPSHUDWXUHVDUHDERYH
130° F.
,I5(&(,9(5LVLQVWDOOHGLQWLJKWO\HQFORVHGPHWDOVXUURXQGWKHRSHUDWLQJGLVWDQFHZLOOEHVKRUWHQHG
RECEIVER ADJUSTMENT – RECOMMENDED ADJUSTMENT
127(7KHVOLGHEXWWRQ:KLWHRU%ODFNFRYHUVWKH$'-DFFHVVKROH
ZKHQLQVWDOOHG
$ 7RDGMXVWDWWKHUHFHLYHUXVHDVPDOOVORWWHGVFUHZGULYHU7XUQWKHDGMXVWPHQWVFUHZFRXQWHUFORFNZLVHDERXWGHJUHHVRUDPD[LPXPRIWXUQ
7KLVVKRXOGFRUUHFWWKHGLVWDQFHSUREOHP
% ,I WKDW GRHV QRW FRUUHFW WKH SUREOHP UHWXUQ DGMXVWPHQW VFUHZ WR RULJLQDO
SRVLWLRQDQGWKHQWXUQDGMXVWPHQWVFUHZFORFNZLVH
7KLVDGMXVWPHQWLVOLNHWXQLQJ\RXUUDGLR,I\RXNHHSWXUQLQJ WKHDGMXVWPHQW
VFUHZLQHLWKHUGLUHFWLRQ\RXZLOOJRSDVWWKHSURSHUVHWWLQJWXQLQJ
SPECIFICATIONS
%$77(5,(6 7UDQVPLWWHU9$
5HPRWH5HFHLYHU9HD$$$ONDOLQH)&&,'1R¶VWUDQVPLWWHU./7;UHFHLYHU./5;
2SHUDWLQJ)UHTXHQF\0+=
&DQDGLDQ,6&,'1R¶VWUDQVPLWWHUUHFHLYHU$
Page 46
30259-9-1115
AUTOMATIC HUMIDIFIER OPERATION
7KH0DQWLV3RZHU9HQW+LJK(I¿FLHQF\)LUHSODFHKDVDQDXWRPDWLFKXPLGL¿HUGHVLJQHGLQWRWKH¿UHSODFH$VWKH¿UHSODFHRSHUDWHV
FRQGHQVDWH LV FUHDWHG DQG LV FROOHFWHG LQ D WDQN LQVLGH WKH ¿UHSODFH7KH FRQGHQVDWH SXPS ZLOO WDNH WKH FROOHFWHG FRQGHQVDWH
DQGSXPSLWWRDVWDLQOHVVVWHHOWUD\ZKHUHLWHYDSRUDWHVLQWRWKH
DLUVWUHDPDGGLQJKXPLGLW\WRWKHKHDWHGVSDFH
Note::KHQWKHDXWRPDWLFKXPLGL¿HULVHQJDJHGDQGLVWUDQVIHUULQJ WKH FRQGHQVDWH WKHUH PD\ EH D QRWLFHDEOH KLVVLQJ VRXQG
7KLVLVQRUPDODQGWKHVRXQGVKRXOGSHUVLVWIRUOHVVWKDQVHFRQGV
7KH DPRXQW RI FRQGHQVDWH FUHDWHG ZLOO YDU\ EDVHG RQ VHYHUDO
IDFWRUV LQFOXGLQJ EXW QRW OLPLWHG WR ORFDWLRQ RI ¿UHSODFH DLU WHPSHUDWXUHOHQJWKRIYHQWLQJDQGZKHWKHUWKHYHQWSLSHLVKRUL]RQWDO
RUYHUWLFDO7KHKXPLGL¿HUZLOORSHUDWHLQWHUPLWWHQWO\ZKLOHWKH¿UHSODFHLVRSHUDWLQJ
:KLOHWKHFRQGHQVDWHSXPSLVWUDQVIHUULQJWKHFRQGHQVDWHIURPWKH
WDQNWRWKHWUD\WKHKXPLGL¿HU/('OLJKWZLOOLOOXPLQDWHGXULQJSXPS
RSHUDWLRQ6HH3DJH)LJXUH2QFHWKHFRQGHQVDWHLVWUDQVIHUUHGWKHOLJKWZLOOWXUQRII
30259-9-1115
Figure 73
Page 47
OPTIONAL CONTROLS
Economy Mode (Red Button Operation)
7RXWLOL]HWKLVIHDWXUHDSURJUDPPDEOHFRQWURORUWKHUPRVWDWPXVW
EHFRQQHFWHGWRWKH¿UHSODFH$UHGEXWWRQLVORFDWHGQH[WWRWKH
EXUQHUVZLWFKHVRQWKHIURQWFRQWUROSDQHO6HH)LJXUH7KLVLV
FDOOHGWKHHFRQRP\PRGH
Battery Operated Controls
7KLVXQLWLVHTXLSSHGZLWKDIDFWRU\LQVWDOOHGZLUHOHVVUHPRWH
$OO5HPRWH&RQWUROVDUHDOOEDWWHU\RSHUDWHGGHYLFHV
Optional Battery Operated Control
FRBTP %DWWHU\2SHUDWHG5HPRWHZLWK3URJUDPPDEOH7KHUmostat
TRW
%DWWHU\2SHUDWHG:LUHOHVV5HPRWH:DOO7KHUPRVWDW
Note: These optional controls will work with the factory
installed receiver. No wiring is required.
CAUTION
Figure 74
7RXVHWKLVIHDWXUHERWKEXUQHUVZLWFKHVQHHGWREHLQWKH³21´
SRVLWLRQDQGWKHUHGEXWWRQPXVWEHSUHVVHGVRLWLVLOOXPLQDWHG
7KLV ZLOO LJQLWH WKH IURQW EXUQHU 7KH IURQW EXUQHU ZLOO UHPDLQ RQ
ZKHQWKHUHGEXWWRQLVLOOXPLQDWHGDQGWKHEDFNEXUQHUZLOOF\FOH
ZLWKWKHWKHUPRVWDW7KHUHGEXWWRQDFWVRQO\DVDQRYHUULGHIRUWKH
IURQWEXUQHU
Before connecting any controller, disconnect power
WRWKH¿UHSODFH
To Deactivate
3UHVVWKHUHGEXWWRQVRLWLVQRWLOOXPLQDWHGWKHQWKH¿UHSODFHZLOO
UHWXUQWRQRUPDORSHUDWLRQ
Figure 75
$GMXVWWKHUHPRWHIURPWKHLQVWUXFWLRQVSURYLGHGZLWKWKHUHPRWH
control.
1RWH,IWKH¿UHSODFHZLOOQRWEHXVHGIRUORQJSHULRGVRIWLPH
turn the burner switches to the “OFF” position and turn the
power off at the power source.
Page 48
30259-9-1115
MAINTENANCE & SERVICE
7KH0DQWLVVKRXOGEHLQVSHFWHGDQGVHUYLFHGDQQXDOO\E\DTXDOL¿HGVHUYLFHSHUVRQ7KLVZLOOHQVXUHWKDWWKH¿UHSODFHLVRSHUDWLQJ
VDIHO\ DQG HI¿FLHQWO\ 6KRXOG \RX VXVSHFW DQ\ DEQRUPDO RSHUDWLRQFRQWDFWDVHUYLFHSHUVRQWKDWKDVEHHQWUDLQHGWRVHUYLFHWKLV
SURGXFW
Cleaning the Glass Door
$IWHUWKHLQLWLDOSDLQWFXULQJDVOLJKW¿OPPD\IRUPRQWKHJODVV,WLV
UHFRPPHQGHGWRFOHDQWKHJODVVZLWKJDV¿UHSODFHJODVVFOHDQHU
7KHJODVVZLOOQHHGWREHFOHDQHGSHULRGLFDOO\GXULQJWKH\HDU8VH
FDUHZKHQUHPRYLQJDQGFOHDQLQJWKHJODVV,QWKHHYHQWWKHJODVV
QHHGVUHSODFHGFRQWDFWDTXDOL¿HGVHUYLFHSHUVRQ2QO\JODVVDSSURYHGE\(PSLUH&RPIRUW6\VWHPV,QFPD\EHXVHGDQ\VXEVWLWXWHJODVVHVZLOOYRLGWKHZDUUDQW\
CAUTION
Do not attempt to clean the glass when it is hot. Do
not strike or hit the glass.
Resetting the Fireplace
7RUHVHWWKH¿UHSODFH¿UVWWXUQERWKEXUQHUVZLWFKHVWRWKH2))
SRVLWLRQ9HULI\WKHUHGEXWWRQQH[WWRWKHEXUQHUVLVQRWLOOXPLQDWHG
,ID5HPRWH&RQWUROLV¿WWHGWXUQWKHUHPRWHWRWKH³2))´SRVLWLRQ
7XUQWKHSRZHURIIDWWKHSRZHUVRXUFHIRUPLQXWHV
7XUQWKHSRZHUEDFNRQDQGYHULI\WKH/('OLJKWVRQWKH&RQWURO
3DQHO &LUFXLW 3ODWH DUH LOOXPLQDWHG 7KH EXUQHUV VKRXOG LJQLWH LQ
DSSUR[LPDWHO\VHFRQGV7KHFLUFXODWLQJEORZHUZLOOVWDUWLQWR
PLQXWHV7KHEORZHUPD\FRQWLQXHWRRSHUDWHDIWHUWKHEXUQHUV
DUHWXUQHGRII
WARNING
3RWHQWLDO ULVN RI ¿UH HOHFWULF VKRFN DQG SHUVRQDO LQMXU\
Take precautions to reduce such risks
CAUTION
Label all wires prior to disconnection when servicing
controls. Wiring errors can cause improper and dangerous
operation. Verify proper operation after servicing.
WARNING
'RQRWRSHUDWHWKLV¿UHSODFHZLWKRXWWKHJODVVGRRU
in place. Do not operate if the glass front is broken or
damaged. Do not use the glass door if the gasket is
missing or is damaged.
,I HTXLSSHG WKH 0DQWLV FDQ DOVR EH UHVHW E\ VZLWFKLQJ WKH PDLQ
SRZHUVZLWFKWRWKH³2))´SRVLWLRQIRUPLQXWHV6HH)LJXUH
CAUTION
Be certain the glass is cool before handling.
BAY WINDOW MANTIS MODELS
Removing the Glass Door
5HPRYHWKHWRSRIWKHFDELQHW
2SHQWKHSDQHOVRQWKHOHIWDQGULJKWVLGHV7KHSDQHOVSLYRW
LQSODFH
5HOHDVHWKHWZRGRRUODWFKHVRQERWKWKHOHIWDQGULJKWVLGHV
RIWKH¿UHER[
&DUHIXOO\JUDEWKHJODVVIUDPHDQGSXOOWRZDUGV\RX'RQRW
GDPDJHRUUHPRYHWKHJDVNHWIURPWKHGRRU
Figure 76
FIREPLACE MANTIS MODELS
Removing the Glass Door
5HPRYH WKH ORZHU ORXYHUHG SDQHO E\ OLIWLQJ XS WKHQ SXOOLQJ
out.
5HOHDVHWKHWZRKLQJHFOLSVRQXQGHUVLGHRI¿UHER[
$QJOH WKH ERWWRP RI JODVV DVVHPEO\ DSSUR[LPDWHO\ GHJUHHVRXWIURP¿UHER[*HQWO\SXOOJODVVDVVHPEO\DZD\IURP
¿UHER['RQRWGDPDJHRUUHPRYHWKHJDVNHWIURPWKHGRRU
30259-9-1115
Page 49
MAINTENANCE & SERVICE
Circulating Air Blower
7KHFLUFXODWLQJDLUEORZHUVKRXOGEHFKHFNHGDQGFOHDQHGDQQXDOO\E\DTXDOL¿HGVHUYLFHSHUVRQWRHQVXUHWKDW\RXU¿UHSODFHLV
RSHUDWLQJHI¿FLHQWO\$Q\GLUWRUOLQWFDQDIIHFWWKHRSHUDWLRQRIWKH
EORZHU
Heat Exchanger
7KH KHDW H[FKDQJHU LV ORFDWHG RQ WKH EDFNVLGH RI WKH ¿UHSODFH
7KHKHDWH[FKDQJHUVKRXOGEHLQVSHFWHGDQGFOHDQHGDQQXDOO\E\
DTXDOL¿HGVHUYLFHSHUVRQ
Filter
7KH¿OWHULVORFDWHGRQWKHLQVLGHRIWKHORZHUORXYHUSDQHORQ¿UHSODFHVHTXLSSHGZLWK),.4)).4RU):.46XUURXQGVRURQWKH
LQVLGHERWWRPÀDQJHRIWKHVXUURXQG)+.46XUURXQGV
7R FOHDQ WKH ¿OWHU RQ ¿UHSODFHV HTXLSSHG ZLWK WKH ORZHU ORXYHU
SDQHOVLPSO\UHPRYHWKHSDQHODQGGLVHQJDJHWKH¿OWHUURGIURP
LWVUHWDLQLQJKROHV)LJXUHVDQG
)RU ¿UHSODFHV HTXLSSHG ZLWK ORXYHUOHVV )+. VXUURXQGV WKH HQWLUHVXUURXQGPXVWEHUHPRYHGIURPWKH¿UHSODFH7KLVLVDFFRPSOLVKHG E\ OLIWLQJ DQG UHPRYLQJ WKH VXUURXQG IURP WKH VXSSRUW
EUDFNHWKRRNV5HPRYHWKH¿OWHUUHWDLQHUVDQG¿OWHUVIURPWKHLQVLGHERWWRPÀDQJHE\UHPRYLQJWKHVFUHZKROGLQJWKH¿OWHUUHWDLQHU
LQSODFH)LJXUH
Figure 77
7KH ¿OWHUV PD\ EH ULQVHG ZLWK ZDWHU RU EORZQ FOHDQ ZLWK FRPSUHVVHGDLU
Figure 78
Figure 79
Page 50
30259-9-1115
MAINTENANCE & SERVICE
RECOMMENDED MAINTENANCE
FREQUENCY OF MAINTENANCE
MAINTENANCE ITEM
9HULI\WKHDUHDLVIUHHIURPFRPEXVWLEOHPDWHULDOV
MONTHLY BY
HOMEOWNER
ANNUALLY BY
SERVICE PERSON
X
X
9HULI\WKHFRPEXVWLRQDQGYHQWLODWLRQDLULVQRWUHVWULFWHG
X
9HULI\WKHÀXHDQGLQOHWSLSHVGRQRWKDYHDQ\FUDFNVRUKROHV
X
9HULI\EXUQHUÀDPH
X
&OHDQWKHEORZHUFRPSDUWPHQW
X
&OHDQWKHEXUQHU
X
9HULI\WKHFRQGHQVDWHV\VWHPLVFOHDQDQGOHDNIUHH
X
&OHDQWKH¿OWHU
X
X
Clean the glass
X
X
,IVHUYLFHLVQHHGHGWRWKHFRQGHQVDWHSXPSWKHZLUHVPXVWEHDWWDFKHGLQWKHVDPHRUGHUWKH\ZHUHUHPRYHG)LJXUH,IWKHSXPS
LVUHSODFHGIROORZWKHZLUHFRQQHFWLRQLQVWUXFWLRQODEHORQWKHSXPSFRYHU
Figure 80
30259-9-1115
Page 51
BAY WINDOW MANTIS PARTS LIST
WARNING
Use only manufacturer’s replacement parts. Use of any other parts could cause injury or death.
INDEX
NO.
PART NO. DESCRIPTION
1
27072
REAR PANEL ASSEMBLY
2
21654
%5$&.(73,3($66(0%/<
3
24831
REAR HEAT SHIELD
ASSEMBLY
INDEX
NO.
PART NO. DESCRIPTION
25
21640
BRACKET ASSEMBLY (SPRING
&/,3,1&/8'('
26
21665
RIGHT SIDE DOOR ASSEMBLY
27
21651
TUBING (FIREBOX TO
35(6685(6:,7&+
28
R8835
),77,1*%$5%('+26(
29
22865
,*1,725+27685)$&(
ASSEMBLY
4A
21664
TOP COVER ASSEMBLY
,1&/8'(6
4B
22933
SLIM TOP ASSEMBLY
4C
22934
SHORT TOP ASSEMBLY
5
R8854
BALL STUD
30
21611
%5$&.(7,*1,725
R8807
FLAME SENSOR
6
22693
TOP HEAT SHIELD ASSEMBLY
31
30626
LOG PLATE ASSEMBLY
26089
HEAT EXCHANGER TUBE
$66(0%/<5(48,5(6
32
7
33
22753
SMALL BURNER ASSEMBLY
1$7,1&/8'(6$1'
33
26787
SMALL BURNER ASSEMBLY LP
,1&/8'(6$1'
8
R10337
*$6.(7(1'3/$7(
5(48,5('
9
R9987
)/(;/,1(´
10
26088
SUMP ASSEMBLY
,1&/8'(6
34
22658
LARGE BURNER ASSEMBLY 1$7,1&/8'(6$1'
11
R10299
6:,7&+%,0(7$/,&
34
26801
12
R8795
*$6.(76803
LARGE BURNER ASSEMBLY /3,1&/8'(6$1'
13
29721
HEAT EXCHANGER ASSEMBLY
,1&/8'(6
35
R9831
%86+,1*$,56+877(5
FRONT NAT
14
R10966
78%,1*6803723803
35
R10675
%86+,1*$,56+877(5
FRONT LPG
15
21627
6+,(/'5($5,11(5
16
25227
ELECTRIC PARTS PLATE
36
R10675
%86+,1*$,56+877(5
REAR NAT
17
21667
LEFT SIDE DOOR ASSEMBLY
18
21605
&29(5,1/(7$,5'8&7
36
R10676
%86+,1*$,56+877(5
REAR LPG
19
22780
INLET AIR DUCT ASSEMBLY
37
R8790
%86+,1*%851(5
*$6.(7,1/(7$,5'8&7
38
P208
5($525,),&(/3*
38
P288
5($525,),&(1$7
21641
BRACKET ASSEMBLY
THERMISTER (SPRING CLIP
,1&/8'('
39
P208
)521725,),&(1$7
39
P307
)521725,),&(/3*
22
R4053
&/$03'22586('21
81,7
40
R10796
+2/'(525,),&(
23
22773
THERMISTER ASSEMBLY
41
R7572
JAMB NUT
24
R10488
42
27071
GAS LINE - REAR
20
21
Page 52
R10491
(/%2:5(48,5('
30259-9-1115
BAY WINDOW MANTIS PARTS LIST
WARNING
Use only manufacturer’s replacement parts. Use of any other parts could cause injury or death.
INDEX
NO.
PART NO. DESCRIPTION
43
26128
GAS LINE - FRONT
44
M174
GASKET
45
11269
46
INDEX
NO.
PART NO. DESCRIPTION
PUMP ASSEMBLY
,1&/8'(6
68
29355
GAS LINE BRACKET
69
R10489
AIR PRESSURE SWITCH
R8886
COMPRESSION FITTING
70
R8881
CAPACITOR 3uF
47
R8812
9$/9(1$7
71
R8880
CAPACITOR 4uF
47
R8869
9$/9(/3*
72
R11450
/2*/()75($5
48
R8898
PIPE NIPPLE
73
R11452
/2*723/()7
49
R8825
SOLENOID
74
R11453
/2*7235,*+7
R11451
/2*5,*+75($5
50
R3312
&211(&7250$/(;
75
51
R10072
SHUT-OFF VALVE
76
R11449
/2*&(17(5
52
R10775
CONTROL BOX ASSEMBLY
,1&/8'(6
77
R11447
/2*)5217/()7
78
R11448
/2*)52175,*+7
53
R10043
TRANSFORMER 12-24V
79
R2522
MAIN POWER SWITCH
54
R8804
TRANSFORMER 24V
55
25325
CONDENSATE PUMP COVER
80
R10610
:,5(+$51(660$,132:(5
SWITCH
56
27004
CIRCULATING BLOWER
ASSEMBLY
81
26119
HEADER COVER - OUTLET
82
R10707
),/7(552')52173$1(/
57
21663
'225$66(0%/<%/$&.
83
R10705
),/7(5)52173$1(/
57
22758
'225$66(0%/<&+520(
57
22759
'225$66(0%/<*2/'
NOT
SHOWN
FRBTC
THERMOSTAT
58
26582
FRONT PANEL ASSEMBLY
,1&/8'(6
59
R8840
WIRE HARNESS ASSEMBLY
WITH ECONOMY SWITCH
60
R8809
6:,7&+'28%/(52&.(5
61
R8904
CIRCUIT BOARD
62
25226
63
R10759
RIBBON CABLE
64
R11043
CIRCUIT BOARD WIRE
HARNESS
65
R10182
:,5(+$51(669
66
R10183
WIRE HARNESS 12V
67
R10190
WIRE HARNESS 12V
30259-9-1115
CIRCUIT BOARD PLATE
Page 53
BAY WINDOW MANTIS PARTS VIEW
4A
1
4C
2
4B
3
7
5
5
6
8
13
10
8
12
11
25
15
22
21
81
14
18
22
19
36
28
20
27
17
Page 54
30259-9-1115
BAY WINDOW MANTIS PARTS VIEW
29
30
31
44
9
50
51
40
41
42
46
48
24
49
48
45
38
34
32
36
47
35
37
39
40
41
33
43
46
63
57
82
65
54
70
52
71
64
53
83
62
55
66
59
61
80
56
16
60
58
79
67
68
69
23
73
74
75
72
76
77
30259-9-1115
78
Page 55
FIREPLACE MANTIS PARTS LIST
WARNING
Use only manufacturer’s replacement parts. Use of any other parts could cause injury or death.
INDEX NO. PART NO. DESCRIPTION
1
25207
PANEL - TOP
2
21595
CONDENSATE TRAY
3
25223
LOUVER - TOP
4
30630
REAR BURNER TRAY
5
R9987
6
INDEX NO. PART NO. DESCRIPTION
38
26088
SUMP ASSEMBLY
,1&/8'(6
39
26089
FLEX PIPE ASSEMBLY
5(48,5(6
FLEX LINE
40
29721
HEAT EXCHANGER ASSEMBLY
,1&/8'(6
30633
FRONT BURNER TRAY ASSEMBLY
41
25204
PANEL - BACK
7
25205
PANEL - LEFT SIDE
42
R10796
ORIFICE HOLDER - REAR
8
21605
INLET AIR DUCT COVER
43
R10182
WIRE HARNESS - 120V
9
22780
INLET AIR DUCT ASSEMBLY
44
R10190
WIRE HARNESS - 12V SMALL
10
R10491
INLET AIR DUCT GASKET
45
R10183
WIRE HARNESS - 12V LARGE
11
R8825
SOLENOID
46
22773
12
R10072
GAS SHUT OFF VALVE
47
R11043
WIRE HARNESS - CIRCUIT BOARD
13
R8812
VALVE - NAT
48
R10759
RIBBON CABLE
13
R8869
VALVE - LPG
49
24831
14
26071
GLASS ASSEMBLY
50
25325
15
27004
CIRCULATING BLOWER
ASSEMBLY
51
R11455
REAR LOG
16
R10338
52
RR1456
LEFT LOG
17
25227
53
R10380
RIGHT LOG
R11457
MIDDLE LOG
18
R10775
CONTROL BOX
,1&/8'(6
54
55
R10378
FRONT LEFT LOG
19
R10043
TRANSFORMER 12-24V
56
R10377
FRONT RIGHT LOG
R10383
LEFT TOP LOG
RIGHT TOP LOG
PRESSURE SWITCH
ELECTRICAL PARTS PLATE
THERMISTER ASSEMBLY
REAR HEAT SHIELD ASSEMBLY
CONDENSATE PUMP COVER
20
R8881
CAPACITOR 3uF
57
21
R8880
CAPACITOR 4uF
58
R10382
22
R8804
TRANSFORMER - 24V
59
25216
23
26075
PUMP ASSEMBLY
,1&/8'(6
%5$&.(767$1'2))
5(48,5('
60
R2522
MAIN POWER SWITCH
24
25226
CIRCUIT BOARD PLATE
61
R10610
25
R8809
DOUBLE ROCKER SWITCH
:,5(+$51(660$,132:(5
SWITCH
R8795
GASKET - SUMP
R8840
WIRE HARNESS ASSEMBLY WITH
ECONOMY SWITCH
62
26
63
26119
HEADER COVER - OUTLET
27
R8904
CIRCUIT BOARD
64
R10966
78%,1*6803723803
28
30547
FRONT BURNER ASSEMBLY
65
R10337
29
30546
BACK BURNER ASSEMBLY
*$6.(7(1'3/$7(
5(48,5('
30
R11012
ORIFICE HOLDER - FRONT
16
26117
31
22865
HOT SURFACE IGNITOR
5(48,5('
16
FRBTC
THERMOSTAT
32
R10967
16
R10093
25,),&(1$7
33
25210
AIR DUCT CHANNEL
16
R10094
25,),&(1$7
34
25214
PANEL - RIGHT SIDE
16
R10095
25,),&(00/3
35
25222
'225%5$&.(75(48,5('
16
R10096
25,),&(/3
36
R4053
'225&/$035(48,5('
16
R10299
6:,7&+%,0(7$/,&
37
25225
/$7&+%5$&.(75(48,5('
16
R10705
),/7(5)52173$1(/
16
R10706
),/7(552')52173$1(/
)/$0(6(16255(48,5('
AIR DUCT CHANNEL COVER
PLATE - NAT ONLY
161RW6KRZQ
Page 56
30259-9-1115
FIREPLACE MANTIS PARTS VIEW
59
1
59
7
3
39
2
41
8
35
65
63
5
65
9
35
10
38
31
32
62
4
30
64
37
42
40
49
36
37
6
36
33
31
29
28
32
13
11
12
44
45
50
34
22
14
20
47
21
19
18
61
23
16
43
46
17
48
24
25
27
26
15
60
51
58
53
57
54
56
52
55
30259-9-1115
Page 57
MASTER PARTS DISTRIBUTOR LIST
7R2UGHU3DUWV8QGHU:DUUDQW\SOHDVHFRQWDFW\RXUORFDO(PSLUHGHDOHU6HHWKHGHDOHUORFDWRUDWZZZHPSLUHFRPIRUW
FRP7RSURYLGHZDUUDQW\VHUYLFH\RXUGHDOHUZLOOQHHG\RXUQDPHDQGDGGUHVVSXUFKDVHGDWHDQGVHULDOQXPEHUDQGWKH
QDWXUHRIWKHSUREOHPZLWKWKHXQLW
7R2UGHU3DUWV$IWHUWKH:DUUDQW\3HULRGSOHDVHFRQWDFW\RXUGHDOHURURQHRIWKH0DVWHU3DUWV'LVWULEXWRUVOLVWHGEHORZ
7KLVOLVWFKDQJHVIURPWLPHWRWLPH)RUWKHFXUUHQWOLVWSOHDVHFOLFNRQWKH0DVWHU3DUWVEXWWRQDWZZZHPSLUHFRPIRUWFRP
3OHDVH QRWH 0DVWHU 3DUWV 'LVWULEXWRUV DUH LQGHSHQGHQW EXVLQHVVHV WKDW VWRFN WKH PRVW FRPPRQO\ RUGHUHG 2ULJLQDO
(TXLSPHQWUHSDLUSDUWVIRU+HDWHUV*ULOOVDQG)LUHSODFHVPDQXIDFWXUHGE\(PSLUH&RPIRUW6\VWHPV,QF
Dey Distributing
:LOORZ/DNH%RXOHYDUG
9DGQDLV+HLJKWV01
Victor Division of F. W. Webb Company
200 Locust Street
+DUWIRUG&7
Phone: 651-490-9191
Toll Free: 800-397-1339
Website:ZZZGH\GLVWULEXWLQJFRP
Parts: Heater, Hearth and Grills
Phone: 860-722-2433
Toll Free: 800-243-9360
Fax: 860-293-0479
Toll Free Fax: 800-274-2004
Websites: ZZZIZZHEEFRPZZZYLFWRUPIJFRP
Parts: Heater, Hearth and Grills
East Coast Energy Products
10 East Route 36
:HVW/RQJ%UDQFK1-
Phone: 732-870-8809
Toll Free: 800-755-8809
Fax: 732-870-8811
Website: ZZZHDVWFRDVWHQHUJ\FRP
Parts: Heater, Hearth and Grills
HOW TO ORDER REPAIR PARTS
Parts Not Under Warranty
3DUWVFDQEHRUGHUHGWKURXJK\RXU6HUYLFH3HUVRQ'HDOHURUD0DVWHU3DUWV'LVWULEXWRU6HHWKLVSDJHIRUWKH0DVWHU3DUWV'LVWULEXWRUVOLVW)RUEHVWUHVXOWVWKHservice person or dealerVKRXOGRUGHUSDUWVWKURXJKWKHGLVWULEXWRU3DUWVFDQEHVKLSSHGGLUHFWO\WRWKH
service person/dealer.
Warranty Parts
:DUUDQW\SDUWVZLOOQHHGDSURRIRISXUFKDVHDQGFDQEHRUGHUHGE\\RXU6HUYLFH3HUVRQRU'HDOHU3URRIRISXUFKDVHLVrequired for
ZDUUDQW\SDUWV
$OOSDUWVOLVWHGLQWKH3DUWV/LVWKDYHD3DUW1XPEHU:KHQRUGHULQJSDUWV¿UVWREWDLQWKH0RGHO1XPEHUDQG6HULDO1XPEHUIURPWKH
QDPHSODWHRQ\RXUHTXLSPHQW7KHQGHWHUPLQHWKH3DUW1XPEHUnotWKH,QGH[1XPEHUDQGWKH'HVFULSWLRQRIHDFKSDUWIURPWKHIROORZLQJLOOXVWUDWLRQDQGSDUWOLVW%HVXUHWRJLYHDOOWKLVLQIRUPDWLRQ
$SSOLDQFH0RGHO1XPEHU
3DUW'HVFULSWLRQ
$SSOLDQFH6HULDO1XPEHU
3DUW1XPEHU
7\SHRI*DV3URSDQHRU1DWXUDO
'RQRWRUGHUEROWVVFUHZVZDVKHUVRUQXWV7KH\DUHVWDQGDUGKDUGZDUHLWHPVDQGFDQEHSXUFKDVHGDWDQ\ORFDOKDUGZDUHVWRUH
6KLSPHQWVFRQWLQJHQWXSRQVWULNHV¿UHVDQGDOOFDXVHVEH\RQGRXUFRQWURO
Page 58
30259-9-1115
WARRANTY
(PSLUH&RPIRUW6\VWHPV,QFZDUUDQWLHVWKLV0DQWLV¿UHSODFHWREHIUHHIURPGHIHFWVDWWKHWLPHRISXUFKDVHDQGIRUWKH
SHULRGVVSHFL¿HGEHORZ0DQWLV¿UHSODFHVPXVWEHLQVWDOOHGE\DTXDOL¿HGWHFKQLFLDQDQGPXVWEHPDLQWDLQHGDQGRSHUDWHGVDIHO\LQDFFRUGDQFHZLWKWKHLQVWUXFWLRQVLQWKHRZQHU¶VPDQXDO7KLVZDUUDQW\DSSOLHVWRWKHRULJLQDOSXUFKDVHURQO\
DQGLVQRWWUDQVIHUDEOH$OOZDUUDQW\UHSDLUVPXVWEHDFFRPSOLVKHGE\DTXDOL¿HGJDVDSSOLDQFHWHFKQLFLDQ
Limited Lifetime Parts Warranty – Factory-Installed Glass
,IWKHIDFWRU\LQVWDOOHGJODVVIDLOVEHFDXVHRIGHIHFWLYHZRUNPDQVKLSRUPDWHULDO(PSLUHZLOOUHSDLURUUHSODFHDW
(PSLUH¶VRSWLRQ
Limited Ten-Year Parts Warranty – Combustion Chamber
(PSLUHSURPLVHVWRWKHRZQHUWKDWLIWKHFRPEXVWLRQFKDPEHUVHHSDUWVOLVWIDLOVEHFDXVHRIGHIHFWLYHZRUNPDQVKLSRUPDWHULDOZLWKLQWHQ\HDUVIURPWKHGDWHRISXUFKDVH(PSLUHZLOOUHSDLURUUHSODFHDW(PSLUH¶VRSWLRQ
Limited Five-Year Parts Warranty – All Other Components (Except Thermostats)
6KRXOGDQ\SDUWIDLOEHFDXVHRIGHIHFWLYHZRUNPDQVKLSRUPDWHULDOZLWKLQ¿YH\HDUVIURPWKHGDWHRISXUFKDVH
(PSLUHZLOOUHSDLURUUHSODFHDW(PSLUH¶VRSWLRQ
Limited Two-Year Labor Warranty – All Components (Except Remote Controls, Thermostats)
:LWKLQWZR\HDUVIURPWKHGDWHRISXUFKDVH(PSLUHZLOOSD\UHDVRQDEOHODERUWRKDYHGHIHFWVUHSDLUHGDW(PSLUH¶VRSWLRQ
Limited One-Year Parts Warranty – Remote Controls, Thermostats
6KRXOGDQ\UHPRWHFRQWURORUWKHUPRVWDWIDLOEHFDXVHRIGHIHFWLYHZRUNPDQVKLSZLWKLQRQH\HDUIURPWKHGDWHRI
SXUFKDVH(PSLUHZLOOUHSDLURUUHSODFHDW(PSLUH¶VRSWLRQ
Duties of the Owner
7KHDSSOLDQFHPXVWEHLQVWDOOHGE\WKHVHOOLQJGHDOHURUKLVGHVLJQDWHGLQVWDOOHUDQGRSHUDWHGLQDFFRUGDQFHZLWK
WKHLQVWUXFWLRQVIXUQLVKHGZLWKWKHDSSOLDQFH
$ELOORIVDOHFDQFHOOHGFKHFNRUSD\PHQWUHFRUGVKRXOGEHNHSWWRYHULI\SXUFKDVHGDWHDQGHVWDEOLVKZDUUDQW\
SHULRG
5HDG\DFFHVVWRWKHDSSOLDQFHIRUVHUYLFH
What Is Not Covered
'DPDJHVWKDWPLJKWUHVXOWIURPWKHXVHPLVXVHRULPSURSHULQVWDOODWLRQRIWKLVDSSOLDQFH
7UDYHOGLDJQRVWLFFRVWVDQGIUHLJKWFKDUJHVRQZDUUDQWHGSDUWVWRDQGIURPWKHIDFWRU\
&ODLPVWKDWGRQRWLQYROYHGHIHFWLYHZRUNPDQVKLSRUPDWHULDOV
8QDXWKRUL]HGVHUYLFHRUSDUWVUHSODFHPHQWV
5HPRYDODQGUHLQVWDOODWLRQFRVW
,QRSHUDEOHGXHWRLPSURSHURUODFNRIPDLQWHQDQFH
How To Get Service
7RPDNHDFODLPXQGHUWKLVZDUUDQW\SOHDVHKDYH\RXUUHFHLSWDYDLODEOHDQGFRQWDFW\RXULQVWDOOLQJGHDOHU3URYLGHWKHGHDOHUZLWKWKHPRGHOQXPEHUVHULDOQXPEHUW\SHRIJDVDQGSXUFKDVHYHUL¿FDWLRQ7KHLQVWDOOLQJGHDOHULVUHVSRQVLEOHIRUSURYLGLQJVHUYLFHDQGZLOOFRQWDFWWKHIDFWRU\WRLQLWLDWHDQ\ZDUUDQWHGSDUWVUHSODFHPHQWV(PSLUHZLOOPDNH
UHSODFHPHQWSDUWVDYDLODEOHDWWKHIDFWRU\6KLSSLQJH[SHQVHVDUHQRWFRYHUHG
,IDIWHUFRQWDFWLQJ\RXU(PSLUHGHDOHUVHUYLFHUHFHLYHGKDVQRWEHHQVDWLVIDFWRU\FRQWDFW&RQVXPHU5HODWLRQV
'HSDUWPHQW(PSLUH&RPIRUW6\VWHPV,QF32%R[%HOOHYLOOH,OOLQRLVRUVHQGDQHPDLOWRLQIR#HPSLUHFRPIRUWFRPZLWK³&RQVXPHU5HODWLRQV´LQWKHVXEMHFWOLQH
Your Rights Under State Law
7KLVZDUUDQW\JLYHV\RXUVSHFL¿FOHJDOULJKWVDQG\RXPD\DOVRKDYHRWKHUULJKWVZKLFKYDU\IURPVWDWHWRVWDWH
30259-9-1115
Page 59
EMPIRE
Comfort Systems
(PSLUH&RPIRUW6\VWHPV,QF
)UHHEXUJ$YH%HOOHYLOOH,/
,I\RXKDYHDJHQHUDOTXHVWLRQDERXWRXUSURGXFWVSOHDVHHPDLOXV
DWLQIR#HPSLUHFRPIRUWFRP
,I\RXKDYHDVHUYLFHRUUHSDLUTXHVWLRQSOHDVHFRQWDFW\RXUGHDOHU
www.empirecomfort.com
Page 60
30259-9-1115
">
Advertisement
