material safety data sheet
MATERIAL SAFETY DATA SHEET
1.
CHEMICAL PRODUCT AND COMPANY IDENTIFICATION
PART NUMBER
BC2025C
PRODUCT DESCRIPTION
HP 2025 Toner Cyan
SUPPLIER
Clover Technolgies Group
4200 Columbus Street
Ottawa, IL 61350
EMERGENCY TELEPHONE
(815) 431-8100
2.
HAZARDS IDENTIFICATION
Emergency overview
This mixture is fine powder with no or slight plastic-like odor.
This mixture may cause irritation of the respiratory system, eyes, and skin.
This mixture, like most organic powders, can cause a dust explosion if
particles form thick clouds.
Acute health effects
Eye contact:
Irritation may occur by mechanical abrasion.
Skin contact: Minimal skin irritation may occur.
Inhalation:
Slight irritation of respiratory tract may occur with exposure
to large amount of toner dust.
Ingestion:
Ingestion is an unlikely route of entry under normal
Conditions of use.
Other information
This mixture is not classified as hazardous according to the latest
adaptations of EU Directive 1999/45/EC.
3.
COMPOSITION/INFORMATION ON INGREDIENTS
Ingredients
CAS number % in mixture TSCA listed/exempted
Styrene acrylate copolymer
Trade secret 70-90
Yes
Wax
Trade secret 5-15
Yes
Pigment
Trade secret 3-10
Yes
Amorphous silica
Trade secret <5
Yes
Refer to Section 8 for the exposure limits and Section 11 for toxicological information
Page 1 of 7
MATERIAL SAFETY DATA SHEET
4. FIRST AID MEASURES
Immediate medical attention may be required in the unlikely event of extreme
Inhalation, eye contact or unusual reaction due to physical idiosyncrasy of the
person.
Eye Contact:
Do not rub eyes. Immediately rinse with plenty of clean running water until
particles are washed out. If irritation persist, seek medical advice.
Skin Contact:
Wash out particles with plenty of water and soap. If irritation develops, seek
medical advice.
Inhalation:
Provide fresh air immediately. If symptoms occur, seek medical advice.
Ingestion:
Clean mouth out with water. Drink several glasses of water.
If sickness develops, seek medical advice.
5. FIRE-FIGHTING MEASURES
Suitable extinguishing media:
Carbon dioxide, Water, foam, dry chemical
Extinguishing Media which shall not be used: None known.
Special exposure hazards arising from the mixture itself, combustion products, or
resulting gases:
Toner like most organic powders, is capable of creating a dust explosion when
particles are dispersed.
Carbon monoxide and carbon dioxide are hazardous resulting gases.
Special protective equipment for fire-fighters: None known
6. ACCIDENTAL REALEASE MEASURES
Personal precautions:
Avoid dust formation. Do not breathe dust.
Wear personal protective equipment as described in Section 8.
Environmental precautions:
Do not discharge into drains.
Methods for cleaning up:
Eliminate sources of ignition and flammables. Vacuum or sweep the material
Into a sealed container. If a vacuum cleaner is used, it must be dust
Explosion-proof. Dispose of the material in accordance with Federal/
State/local requirements.
7. HANDLING AND STORAGE
.
7.1 Handling
Keep out of reach of children
Page 2 of 7
MATERIAL SAFETY DATA SHEET
Avoid dust formation. Handle in adequately ventilated area.
Do not breathe dust. Do not get in eyes or on skin.
Keep away form excessive heat and sources of ignition such as sparks and
open flames.
Ensure all the equipment is electrically earthed/grounded before beginning
operation.
7.2. Storage
Keep out of the reach of children.
Keep container closed and store at room temperature.
Keep away from excessive heat and sources of ignition.
Do not store with strong oxidizers.
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
8.1 Exposure limit values:
Mixture as particulate not otherwise classified
OSHA PELs (TWA): 15mg/m3 (Total dust), 5 mg/m3 (Respirable fraction)
ACGIH TLV (TWA): 10mg/m3 (Inhalable particulate), 3mg/m3 (Respirable
Particulate)
Amorphous silica
OSHA PELs (TWA):20 mppcf* or 80/%SiO2 mg/m3 (*million particles
per cubic foot)
8.2 Exposure controls
8.2.1 Occupational exposure controls
Good general ventilation should be sufficient under normal conditions of use.
Gloves are recommended.
Protective goggles or safety glasses are recommended.
Personal respiratory mask is not required under normal conditions of use, but a
respirator is needed in case of dust formation
8.2.2 Environmental exposure controls
Not applicable.
9. PHYSICAL AND CHEMICAL PROPERTIES
General information
Appearance:
Fine powder
Odor:
None or slight plastic-like odor
Important health, safety and environmental information:
pH:
Not applicable
Boiling point/boiling range:
Not applicable
Flash point:
Not applicable
Flammability:
Not flammable
Explosive properties:
Not data available
Oxidizing properties:
No data available
Vapor pressure:
Not applicable
Specific gravity:
1.0-1.5 (water=1)
Solubility:
Partially soluble in toluene and tetrahydrofuran
Page 3 of 7
MATERIAL SAFETY DATA SHEET
Water solubility:
Partition coefficient
(n-octanol/water):
Viscosity:
Vapor density:
Evaporation rate:
Negligible
Not applicable
Not applicable
Not applicable
Not applicable
9.3 Other information
None
10. STABILITY AND REACTIVITY
This material is stable under normal conditions of use and storage.
No hazardous polymerization will occur.
No significant reaction will occur with air or water at room temperature.
Condition to avoid
Excessive heat
Dust formation
Materials to avoid
Strong oxidizers, which could vigorously oxidize organic materials in this mixture and
cause a fire in an extreme case.
Hazardous decomposition products
Carbon monoxide and carbon dioxide when combusted.
11. TOXICOLOGICAL INFORMATION
According to the information provided by the suppliers about the substances contained in
this mixture, seriously damaging effect is not expected when this mixture is treated in
accordance with standard industrial practices and Federal/state/local requirements. Refer to
Section 2 for potential health effects and Section 4 for first aid measures.
Acute toxicity
Oral:
LD50 rat > 5,000 mg/kg (OECD 425), not harmful.
(a similar product)
Inhalation:
None of the substances in this mixture is classified for acute
Inhalation toxicity according to EU Directive 67/548/EEC.
Dermal:
No test data available.
None of the substances in this mixture is classified as irritant
according to OSHA Hazard Communication standard 29 CFR
1910.1200 or for acute dermal toxicity according to EU Directive
67/548/EEC.
Eye irritation: No test data available.
None of the substances in this mixture is classified as eye
Page 4 of 7
MATERIAL SAFETY DATA SHEET
irritation EU Directive 67/548/EEC.
Skin irritation: No test data available.
None of the substances in this mixture is classified as a
skin irritant according Io OSHA Hazard Communication Standard
29 CFR 1910.1200 or EU Directive 67/548/EEC
Sensitization: No test data available.
None of the substances in this mixture is classified as a
sensitizer according to OSHA Hazard Communication Standard
29 CFR 1910.1200 or EU Directive 67/548/EEC.
Chronic Toxicity:
No test data available
None of the substances in this mixture is classified as very toxic,
toxic or harmful for chronic effect according to EU Directive
67/548/EEC.
Mutagenicity: Ames test (Salmonella typhimurium, Escherichia coli) negative.
(a similar product)
Carcinogenicity:
No test data available
None of the substances in this mixture is classified for
carcinogenicity according to EU Directive 67/548/EEC.
Reproductive toxicity:
No test data available.
None of the substances in this mixture is classified for
reproductive toxicity according to EU Directive 67/548/EEC.
12. ECOLOGICAL INFORMATION
According to our test results or this or similar mixture and the information provided by
the suppliers about the substances contained in this mixture, this mixture is not
expected to be harmful to ecology.
Ecotoxicity:
No data available
Mobility
No data available
Persistence and degradability
No data available
Bioaccumulative potential
No data available
Results of PBT assessment
Not applicable
Page 5 of 7
MATERIAL SAFETY DATA SHEET
Other adverse effects
None known
13. DISPOSAL CONSIDERATIONS
This mixture may be landfilled or incinerated in compliance with all Federal/state/local
provisions.
Do not dump this product into sewers, on the ground, or into any body of water.
14. TRANSPORTATION INFORMATION
International Transport Information
Not a regulated material under the United State DOT, IMDG, ADR,RID, or
ICAO/IATA.
15. REGULATORY INFORMATION
TSCA:
All the substances in this mixture is listed or exempted in accordance
with TSCA.
CERCLA Reportable Quantity (40 CFR 117,302):
Not applicable to this mixture.
SARA Title III
Section 302 (40 CFR 355):
Not applicable to this mixture.
Section 311/312 (40 CRF 370):
Not applicable to this mixture.
Section 313 (40 CFR 372):
Not applicable to this mixture
Please refer to any other Federal/state/local measures that may be relevant.
16. OTHER INFORMATION
This information is believed to be true and accurate. It represents the best information currently
available to us. We make no warranty, Expressed or implied with regard to such information. We
make no liability resulting from its use. Users should make their own investigations to determine the
suitability for their particular purposes.
REVISION DATE: 2009-10-12
SAFETY DATA SHEET: 2009-10-12
Abbreviations
Page 6 of 7
MATERIAL SAFETY DATA SHEET
ADR
Accord européen relatif au transport international des
marchandises Dangereuses par Route (The European
agreement on cross-border transportation of dangerous
goods by road).
CAS
Chemical Abstracts Service
CERCLA
Comprehensive Environmental Response Compensation and
Liability Act.
CFR
Code of Federal Regulations
DOT
Department of Transportation
EINCES
European Inventory of Existing Commercial Substances
ELINCS
European List of Notified Chemical Substances
EU
European Union
IARC
International Agency of Research on Cancer
IATA
International Air Transport Association
ICAO
International Civil Aviation Organization
IMDG
International Medical Guide of Ships
LD50
Lethal Dose, 50% kill
NTP
National Toxicology Program
OSHA
Occupational Safety and Health Administration
PELs
Permissible Exposure Limits
RID
Réglement International concernant le transport des
marchandises Dangereuses par chemin de fer (the
International regulations covering transportation of dangerous
goods by rail)
SARA
Superfund Amendments and Reauthorization Act of 1986
TSCA
Toxic Substances Control Act
TLV
Threshold Limit Value
TWA
Time Weighted Average
Page 7 of 7
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement