material safety data sheet - Advanced Protective Products

material safety data sheet - Advanced Protective Products
MATERIAL SAFETY DATA SHEET
Section 1 • Product and Company information
Advanced Protective Products
17 T2 River Road, Fair Lawn, NJ 07410
HMIS CODE
Health: 2
Fire: 2
Reactive: 0
Product code # 327 Fast Dry Rust Destroyer
====================================================================
SECTION 2
INGREDIENTS. HAZARDOUS INGREDIENTS
INGREDIENT
MAX% CAS NO
TLV
PEL STEL CEIL MM HG TEMP
STODDARD SOLVENT
24
8052 41 3 100 PPM 100PPM
2,0 @ 20'C
(f.n) _____________________________________________________________________________________
ALKYD RESIN
15 PROPRIATERY______________________________________________
II IRON OXIDE
15
1309 37 1 5MQ/M2 5MQ/M2
N/A________________
(f,*,n)
CALCIUM CARBONATE
40
1317 65 3
5MG/M4
N/A________________
(*)
WATER
5 ___7732 18 5_________________________________________________
II FEDERAL REGULATORY INFORMATION:
OSHA STATUS: THIS PRODUCT IS HAZARDOUS UNDER THE CRITERIA OF THE FEDERAL
OSHA HAZARD COMMUNICATION STANDARD 20 CFR 1910. 1200.
TSCA STATUS; ON TSCA INVENTORY.
CERCLA REPORTABLE QUANTITY; NONE.
SARA TITLE III:
SECTION 302 EXTREMELY HAZARDOUS SUBSTANCES: NONE
SECTION 311/312:
HAZARD CATEGORIES: NON HAZARDOUS UNDER SECTION 311/312
SECTION 313:
TOXIC CHEMICALS: NONE
f FEDERAL HAZARD UST
* HAZARDOUS ONLY AS OUST WHEN PRODUCT 18 SANDED,
3 SECTION 913 OF THE EMERGENCY PLANNING. & COMMUNITY RIGHT TO KNOW ACT OF
1086 AND OF 40 CFR 372 .
n NEW JER8EY LABEL LAW HAZARDOUS CHEMICAL
================================================================================
Section 3 • Hazards Identification
Routes of Exposure: Inhalation of vapor or spray mist. Eye or skin contact with the product, vapor or mist
spay.
Effects of Exposure:
Eyes: Irritation
Skin; Prolonged or repeat exposure may cause Irritation,
Inhalation: Irritation of the upper respiratory system. May cause the nervous system depression.
Extreme exposure may result in unconsciousness and possibly death
Signs and Symptoms of exposure:
Headache, dizziness, nausea, and loss of coordination are indications of excessive exposure to vapors or
spray
Redness and itching or burning sensation may indicate excessive skin exposure
Medical conditions aggravated by exposure: None generally recognized.
=================================================================================
Section 41 First Aid Measures
Eye Contact: Check for and remove any contact lenses. Immediately flush ayes with running water for at
least 15 minutes keeping eyelids open. Cold water may be used. Do not use an eye ointment Seek medical
attention.
Skin Contact: After contact with skin, wash immediately with plenty of water. Gently and thoroughly wash
the contaminated skin with running water and non abrasive soap. Be particularly careful to clean folds,
crevices, creases, and groin. Cold water may be used. Cover the Irritated skin with an emollient, if irritation
persists, seek medical attention. Wash contaminated clothing before using.
Serious Skin Contact Wash with disinfectant soap and cover the contaminated skin with anti bacterial
cream Seek Immediate medical attention.
Inhalation; Allow the victim to rest in a well ventilated area. Seek immediate medical attention.
Serious Inhalation: Evacuate the victim to a safe area as soon as possible. Loosen tight clothing, such as
collar, tie, belt or waistband; ff breathing is difficult, ad minister oxygen. If the victim is not breathing, perform
mouth to mouth resuscitation. Seek medical attention.
Ingestion: Do not induce vomiting. Examine the lips and mouth to ascertain whether the tissues ere
damaged, a possible indication the toxic was ingested; the absence or such signs, however Is not
conclusive. Loosen tight clothing such as collar, tie, bell or waistband. If victim is not breathing, perform
mouth to mouth mouth resuscitation. Seek, immediate medical attention
==================================================================================
Section 5 1 Fire Fighting Measure
o
Flashpoint; 110 F Flammability Class: Class B3 Combustible Liquid
Extinguishing Media: Carbon Dioxide, dry chemical, foam.
Unusual fire and explosion hazards: Closed containers may explode when exposed to extreme heat
Applications to hot surfaces require special precautions. During emergency conditions overexposure to
decomposition product cause a health hazard. Symptoms may not be immediately apparent, Obtain medical
attention.
Special Fire Fighting Procedures: Full protective equipment including self contained breathing apparatus
should be used. Water spray may be ineffective, if water is used, fog nozzles are preferable. Water can be
used to cool containers to prevent pressure buildup and possible auto ignition or explosion when exposed to
heat.
==================================================================================
Section 6 • Accidental Release Measures
Steps to be taken in case material is released or spilled:
Small Spill: Extinguish possible sources of ignition. Evacuate all unprotected personnel and ventilate area.
Only personnel equipped with proper respiratory, skin/eye protection should enter spill area. Dike area to
contain spill and clean up by absorbing on an inert absorbent or other means. Don't Rush Into sewers or
natural waterways
Large Spill; Contain material as described above and call the local fire or police department for Immediate
emergency assistance.
==================================================================================
Section 7 • Handling and Storage
Precautions: Keep away from heat. Keep away from sources auto Ignition. Contents are Flammable.
Consult NFPA Code. Use approved bonding and grounding procedures. Ground ell equipment containing
material. Do not ingest. Do not breathe gas/fumes/vapor/spray. In case of insufficient ventilation, wear
suitable respiratory equipment. If ingested, seek medical advice immediately and show the container or the
label. Avoid contact with skin and eyes.
Storage: Flammable materials should be stored in a separate safely storage cabinet or room. Keep sway
from heat. Keep away from sources of Ignition. Keep container tightly closed. Keep in a cool, well ventilated
place. Ground all equipment containing material. A refrigerated room would be preferable for material with a
o
o
flash point lower than 37 8 C (100 F)
==================================================================================
Section 8 1 Exposure Controls I Person Protection
Precautions to be taken in use: only with adequate ventilation, if current ventilation practices are not
adequate to maintain airborne concentrations below the established exposure guidelines, additional
ventilation or exhaust systems may be where explosive mixtures may be present, electrical systems safe for
such locations must be employed. Avoid contact with skin and eyes. • Avoid breathing vapor and spray mist.
Wash hands after using
Ventilation: Local exhaust preferable. General exhaust acceptable if the exposure to materials in section 2
is maintained. Applicable exposure limits. Refer to OSHA Standards 1910.94, 1919.107, 1910.108
Respiratory Protection: If personal exposure cannot be controlled below applicable limits by ventilation,
wear a properly fitted organic vapor/particulate respirator approved by NIQSH/MSHA for protection against
materials In Section 2.
Protective Gloves; gloves that are recommended by glove supplier for protection against materials In
Section 2
Eye Protection: Wear safety spectacles with Imperforated side shields
Other Precautions: intentional misuse by deliberately concentrating and Inhaling the contents can be
harmful or fatal.
==================================================================================
Section 9 • Physical and Chemical Properties
Color/Appearance: Red
Boiling Point (F) 212.00
Product Weight/Gallon; 7.69
V.O.C. 474 GRMS/LTR
Specific Gravity: 0,92
% Volatile Volume 51.40
Vapor Density:
Heavier than Air
==================================================================================
Section 10 • Stability and Reactivity
Stability:
Stable
None Known
Conditions to Avoid:
Hazardous decomposition Products of products (by fire) Carbon Dioxide, Carton Monoxide: Will not
occur
================================================================================
================================================================================
Section 12 • Disposal Consideration
Waste Disposal Method: Water must be disposed of in accordance with Federal, State, Provincial and
Local regulation
Container Disposal: Empty containers by removing the top and inverting to allow all free Hewing products
to drain,
To meet regulatory criteria, the container is considered empty when less that 3% remains in the container.
Additional special handling is not typically required and the empty container can be discarded with other
non hazardous trash
Note: Local disposal regulation may be more stringent and require additional restrictions or precautions.
Customers should check with their local disposal company, municipal or state authority. Recycle of metal or
plastic containers may require clean rather than empty containers, In this case the containers can be rinsed
with mineral spirit until the containers are considered generally product free. Waste from this product may be
hazardous as defined under Resource Conservation and Recovery Act (RCRA) 40 CFR 281.
==================================================================================
Section 13 1 Transport Information
DOT classification: CLASS 3: Combustible liquid
=================================================================================
Section 141 Regulatory Information
S ARA 313 (4fl CFR 372.65C) Suppler notification
All chemicals in this product are listed, or are exempt from listing on the TSCA inventory.
==================================================================================
MANUFACTURER DISCLAIMER
The information in this MSDS was obtained from sources which we believe are reliable. However, the
above information is provided without warranty, expressed or implied, regarding its correctness
The conditions or methods in handling, storage, use and disposal of the product are beyond
control and may be beyond our knowledge. For this and other reasons, we do not accept
responsibility and expressly disclaim liability for loss, damage or expense arising out of or in
way connected with the handling, storage, use or disposal of product.
Name: Walter
Landzettel
Title: Technical Director,
Date: December 12, 2012
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement