PowerScan Series 1 1. INTRODUCTION

PowerScan Series 1 1. INTRODUCTION
PowerScan Series
1.
OBD II / EOBD II /CAN
INTRODUCTION
PowerScan Series for OBD II / EOBD II /CAN is newly developed, specially
designed for car owners or DIYs. With an PowerScan, you may quickly find out
trouble causes of electronically controlled systems on your car by reading the
trouble code (DTC) shown on PowerScan, and checking out trouble causes with
attached MANUAL.
Though so small, it has the same function as special tool of its kind and
applicable to all models since 1996 with a 16-pin diagnostic socket for generic
OBDII protocols (SAE JI850 PWM, SAE JI850 VPW, ISO 9 141-2 ).
Note: PowerScan may automatically reset while being disturbed by strong static
electricity. It is normal.
2. FUNCTIONS
① Reading trouble codes: Read DTCs of powertrain system.
② Clearing trouble codes: Clear the DTCs of powertrain system.
3. OPERATION
① When the “CHECK ENGINE” light is on, stop the car and apply the parking
brake, start the engine then plug the PowerScan into the 16-pin socket ,
usually located under the instrument panel in the car.
② It will display [UIO P-SCAN OBD-CAN], then press the “OK” button. This
process will repeat 4 times. If there is no trouble codes, it will display [- - - - ].
③ Trouble codes will be cleared when press the “Exit” during displaying the
trouble codes,
if successfully, it will display [UIO P-SCAN OBD-CAN]].)
④ FUNCTION for Buttons:
1. "OK": Read fault code
2. "EXIT": Clear EXIT
3. ▲ : Read the next fault code
4. ▼ : Read the previous fault code
5. ← : Back to the first fault code
6.
→: Go to the last fault code
4.SIZE
11cm×5.6cm×2.6cm.
Extension Cable length = 80 cm
5. DTC DEFINITIONS
Please see table A for SAE OBDII DTC definitions, and table B for Manufacturer
OBDII DTC definitions.
1
PowerScan Series
OBD II / EOBD II /CAN
Table A: SAE OBDII DTC Definitions
0001 Fuel Volume Regulator Control Circuit/Open
0002
0003
0004
0005
0006
0007
0008
0009
0010
0011
0012
0013
0014
0015
0020
0021
0022
0023
0024
0025
0030
0031
0032
0033
0034
0035
0036
0037
0038
0042
0043
0044
0050
0051
0052
0056
0057
0058
0062
0063
0064
0065
0066
0067
0070
0071
Fuel Volume Regulator Control Circuit Range/Performance
Fuel Volume Regulator Control Circuit Low
Fuel Volume Regulator Control Circuit High
Fuel Shutoff Valve "A" Control Circuit/Open
Fuel Shutoff Valve "A" Control Circuit Low
Fuel Shutoff Valve "A" Control Circuit High
Engine Position System Performance
Engine Position System Performance
A Camshaft Position Actuator Circuit (Bank 1)
A Camshaft Position - Timing Over-Advanced or System Performance (Bank 1)
A Camshaft Position - Timing Over-Retarded (Bank 1)
B Camshaft Position - Actuator Circuit (Bank 1)
B Camshaft Position - Timing Over-Advanced or System Performance(Bank 1)
B Camshaft Position -Timing Over-Retarded (Bank 1)
A Camshaft Position Actuator Circuit (Bank 2)
A Camshaft Position - Timing Over-Advanced or System Performance(Bank 2)
A Camshaft Position - Timing Over-Retarded (Bank 2)
B Camshaft Position - Actuator Circuit (Bank 2)
B Camshaft Position - Timing Over-Advanced or System Performance(Bank 2)
B Camshaft Position - Timing Over-Retarded (Bank 2)
HO2S Heater Control Circuit (Bank 1 Sensor 1)
HO2S Heater Control Circuit Low (Bank 1 Sensor 1)
HO2S Heater Control Circuit High (Bank 1 Sensor 1)
Turbo Charger Bypass Valve Control Circuit
Turbo Charger Bypass Valve Control Circuit Low
Turbo Charger Bypass Valve Control Circuit High
HO2S Heater Control Circuit (Bank 1 Sensor 2)
HO2S Heater Control Circuit Low (Bank 1 Sensor 2)
HO2S Heater Control Circuit High (Bank 1 Sensor 2)
HO2S Heater Control Circuit (Bank 1 Sensor 3)
HO2S Heater Control Circuit Low (Bank 1 Sensor 3)
HO2S Heater Control Circuit High (Bank 1 Sensor 3)
HO2S Heater Control Circuit (Bank 2 Sensor 1)
HO2S Heater Control Circuit Low (Bank 2 Sensor 1)
HO2S Heater Control Circuit High (Bank 2 Sensor 1)
HO2S Heater Control Circuit (Bank 2 Sensor 2)
HO2S Heater Control Circuit Low (Bank 2 Sensor 2)
HO2S Heater Control Circuit High (Bank 2 Sensor 2)
HO2S Heater Control Circuit (Bank 2 Sensor 3)
HO2S Heater Control Circuit Low (Bank 2 Sensor 3)
HO2S Heater Control Circuit High (Bank 2 Sensor 3)
Air Assisted Injector Control Range/Performance
Air Assisted Injector Control Circuit or Circuit Low
Air Assisted Injector Control Circuit High
Ambient Air Temperature Sensor Circuit
Ambient Air Temperature Sensor Range/Performance
2
PowerScan Series
0072
0073
0074
0075
0076
0077
0078
0079
0080
0081
0082
0083
0084
0085
0086
0100
0101
0102
0103
0104
0105
0106
0107
0108
0109
0110
0111
0112
0113
0114
0115
0116
0117
0118
0119
0120
0121
0122
0123
0124
0125
0126
0127
0128
0130
0131
0132
0133
OBD II / EOBD II /CAN
Ambient Air Temperature Sensor Circuit Low Input
Ambient Air Temperature Sensor Circuit High Input
Ambient Air Temperature Sensor Circuit Intermittent
Intake Valve Control Solenoid Circuit (Bank 1)
Intake Valve Control Solenoid Circuit Low (Bank 1)
Intake Valve Control Solenoid Circuit High (Bank 1)
Exhaust Valve Control Solenoid Circuit (Bank 1)
Exhaust Valve Control Solenoid Circuit Low (Bank 1)
Exhaust Valve Control Solenoid Circuit High (Bank 1)
Intake valve Control Solenoid Circuit (Bank 2)
Intake Valve Control Solenoid Circuit Low (Bank 2)
Intake Valve Control Solenoid Circuit High (Bank 2)
Exhaust Valve Control Solenoid Circuit (Bank 2)
Exhaust Valve Control Solenoid Circuit Low (Bank 2)
Exhaust Valve Control Solenoid Circuit High (Bank 2)
Mass or Volume Air Flow Circuit Malfunction
Mass or Volume Air Flow Circuit Range or Performance Problem
Mass or Volume Air Flow Circuit Low Input
Mass or Volume Air Flow Circuit High Input
Mass or Volume Air Flow Circuit Intermittent
Manifold Absolute Pressure/Barometric Pressure Circuit Malfunction
Manifold Absolute Pressure/Barometric Pressure Circuit Range/Performance Problem
Manifold Absolute Pressure/Barometric Pressure Circuit Low Input
Manifold Absolute Pressure/Barometric Pressure Circuit High Input
Manifold Absolute Pressure/Barometric Pressure Circuit Intermittent
Intake Air Temperature Circuit Malfunction
Intake Air Temperature Circuit Range or Performance Problem
Intake Air Temperature Circuit Low Input
Intake Air Temperature Circuit High Input
Intake Air Temperature Circuit Intermittent
Engine Coolant Temperature Circuit Malfunction
Engine Coolant Temperature Circuit Range/Performance Problem
Engine Coolant Temperature Circuit Low Input
Engine Coolant Temperature Circuit High Input
Engine Coolant Temperature Circuit Intermittent
Throttle Position Sensor/Switch A Circuit Malfunction
Throttle Position Sensor/Switch A Circuit Range/Performance Problem
Throttle Position Sensor/Switch A Circuit Low Input
Throttle Position Sensor/Switch A Circuit High Input
Throttle Position Sensor/Switch A Circuit Intermittent
Insufficient Coolant Temperature for Closed Loop Fuel Control
Insufficient Coolant Temperature for Stable Operation
Intake Air Temperature Too High
Coolant Thermostat (Coolant Temperature Below Thermostat Regulating Temperature)
O2 Sensor Circuit Malfunction (Bank 1 Sensor 1)
O2 Sensor Circuit Low Voltage (Bank 1 Sensor 1)
O2 Sensor Circuit High Voltage (Bank 1Sensor 1)
O2 Sensor Circuit Slow Response (Bank 1 Sensor 1)
3
PowerScan Series
0134
0135
0136
0137
0138
0139
0140
0141
0142
0143
0144
0145
0146
0147
0148
0149
0150
0151
0152
0153
0154
0155
0156
0157
0158
0159
0160
0161
0162
0163
0164
0165
0166
0167
0168
0169
0170
0171
0172
0173
0174
0175
0176
0177
0178
0179
0180
0181
OBD II / EOBD II /CAN
O2 Sensor Circuit No Activity Detected (Bank 1 Sensor 1)
O2 Sensor Heater Circuit Malfunction (Bank 1 Sensor 1)
O2 Sensor Circuit Malfunction (Bank 1 Sensor 2)
O2 Sensor Circuit Low Voltage (Bank 1 Sensor 2)
O2 Sensor Circuit High Voltage (Bank 1 Sensor 2)
O2 Sensor Circuit Slow Response (Bank 1 Sensor 2)
O2 Sensor Circuit No Activity Detected (Bank 1 Sensor 2)
O2 Sensor Heater Circuit Malfunction (Bank 1 Sensor 2)
O2 Sensor Circuit Malfunction (Bank 1 Sensor 3)
O2 Sensor Circuit Low Voltage (Bank 1 Sensor 3)
O2 Sensor Circuit High Voltage (Bank 1 Sensor 3)
O2 Sensor Circuit Slow Response (Bank 1 Sensor 3)
O2 Sensor Circuit No Activity Detected (Bank 1 Sensor 3)
O2 Sensor Heater Circuit Malfunction (Bank 1 Sensor 3)
Fuel Delivery Error
Fuel Timing Error
O2 Sensor Circuit Malfunction (Bank 2 Sensor 1)
O2 Sensor Circuit Low Voltage (Bank 2 Sensor 1)
O2 Sensor Circuit High Voltage (Bank 2 Sensor 1)
O2 Sensor Circuit Slow Response (Bank 2 Sensor 1)
O2 Sensor Circuit No Activity Detected (Bank 2 Sensor 1)
O2 Sensor Heater Circuit Malfunction (Bank 2 Sensor 1)
O2 Sensor Circuit Malfunction (Bank 2 Sensor 2)
O2 Sensor Circuit Low Voltage (Bank 2 Sensor 2)
O2 Sensor Circuit High Voltage (Bank 2 Sensor 2)
O2 Sensor Circuit Slow Response (Bank 2 Sensor 2)
O2 Sensor Circuit No Activity Detected (Bank 2 Sensor 2)
O2 Sensor Heater Circuit Malfunction (Bank 2 Sensor 2)
O2 Sensor Circuit Malfunction (Bank 2 Sensor 3)
O2 Sensor Circuit Low Voltage (Bank 2 Sensor 3)
O2 Sensor Circuit High Voltage (Bank 2 Sensor 3)
O2 Sensor Circuit Slow Response (Bank 2 Sensor 3)
O2 Sensor Circuit No Activity Detected (Bank 2 Sensor 3)
O2 Sensor Heater Circuit Malfunction (Bank 2 Sensor 3)
Fuel Temperature Too High
Incorrect Fuel Composition
Fuel Trim Malfunction (Bank 1)
System too Lean (Bank 1)
System too Rich (Bank 1)
Fuel Trim Malfunction (Bank 2)
System too Lean (Bank 2)
System too Rich (Bank 2)
Fuel Composition Sensor Circuit Malfunction
Fuel Composition Sensor Circuit Range/Performance
Fuel Composition Sensor Circuit Low Input
Fuel Composition Sensor Circuit High Input
Fuel Temperature Sensor A Circuit Malfunction
Fuel Temperature Sensor A Circuit Range/Performance
4
PowerScan Series
0182
0183
0184
0185
0186
0187
0188
0189
0190
0191
0192
0193
0194
0195
0196
0197
0198
0199
0200
0201
0202
0203
0204
0205
0206
0207
0208
0209
0210
0211
0212
0213
0214
0215
0216
0217
0218
0219
0220
0221
0222
0223
0224
0225
0226
0227
0228
0229
OBD II / EOBD II /CAN
Fuel Temperature Sensor A Circuit Low Input
Fuel Temperature Sensor A Circuit High Input
Fuel Temperature Sensor A Circuit Intermittent
Fuel Temperature Sensor B Circuit Malfunction
Fuel Temperature Sensor B Circuit Range/Performance
Fuel Temperature Sensor B Circuit Low Input
Fuel Temperature Sensor B Circuit High Input
Fuel Temperature Sensor B Circuit Intermittent
Fuel Rail Pressure Sensor Circuit Malfunction
Fuel Rail Pressure Sensor Circuit Range/Performance
Fuel Rail Pressure Sensor Circuit Low Input
Fuel Rail Pressure Sensor Circuit High Input
Fuel Rail Pressure Sensor Circuit Intermittent
Engine Oil Temperature Sensor Malfunction
Engine Oil Temperature Sensor Range/Performance
Engine Oil Temperature Sensor Low
Engine Oil Temperature Sensor High
Engine Oil Temperature Sensor Intermittent
Injector Circuit Malfunction
Injector Circuit Malfunction – Cyl. 1
Injector Circuit Malfunction – Cyl. 2
Injector Circuit Malfunction – Cyl. 3
Injector Circuit Malfunction – Cyl. 4
Injector Circuit Malfunction – Cyl. 5
Injector Circuit Malfunction – Cyl. 6
Injector Circuit Malfunction – Cyl. 7
Injector Circuit Malfunction – Cyl. 8
Injector Circuit Malfunction – Cyl. 9
Injector Circuit Malfunction – Cyl. 10
Injector Circuit Malfunction – Cyl. 11
Injector Circuit Malfunction – Cyl. 12
Cold Start Injector 1 Malfunction
Cold Start Injector 2 Malfunction
Engine Shutoff Solenoid Malfunction
Injection Timing Control Circuit Malfunction
Engine Over temperature Condition
Transmission Over Temperature Condition
Engine Over speed Condition
Throttle/Petal Position Sensor or Switch B Circuit Malfunction
Throttle/Petal Position Sensor or Switch B Circuit Range/Performance Problem
Throttle/Petal Position Sensor or Switch B Circuit Low Input
Throttle/Petal Position Sensor/Switch B Circuit High Input
Throttle/Petal Position Sensor/Switch B Circuit Intermittent
Throttle/Petal Position Sensor/Switch C Circuit Malfunction
Throttle/Petal Position Sensor/Switch C Circuit Range/Performance Problem
Throttle/Petal Position Sensor/Switch C Circuit Low Input
Throttle/Petal Position Sensor/Switch C Circuit High Input
Throttle/Petal Position Sensor/Switch C Circuit Intermittent
5
PowerScan Series
0230
0231
0232
0233
0234
0235
0236
0237
0238
0239
0240
0241
0242
0243
0244
0245
0246
0247
0248
0249
0250
0251
0252
0253
0254
0255
0256
0257
0258
0259
0260
0261
0262
0263
0264
0265
0266
0267
0268
0269
0270
0271
0272
0273
0274
0275
0276
0277
OBD II / EOBD II /CAN
Fuel Pump Primary Circuit Malfunction
Fuel Pump Secondary Circuit Low
Fuel Pump Secondary Circuit High
Fuel Pump Secondary Circuit Intermittent
Engine Over boost Condition
Turbocharger Boost Sensor A Circuit Malfunction
Turbocharger Boost Sensor A Circuit Range/Performance
Turbocharger Boost Sensor A Circuit Low
Turbocharger Boost Sensor A Circuit High
Turbocharger Boost Sensor B Malfunction
Turbocharger Boost Sensor B Circuit Range/Performance
Turbocharger Boost Sensor B Circuit Low
Turbocharger Boost Sensor B Circuit High
Turbocharger Waste gate Solenoid A Malfunction
Turbocharger Waste gate Solenoid A
Turbocharger Waste gate Solenoid A Low
Turbocharger Waste gate Solenoid A High
Turbocharger Waste gate Solenoid B Malfunction
Turbocharger Waste gate Solenoid B Range/Performance
Turbocharger Waste gate Solenoid B Low
Turbocharger Waste gate Solenoid B High
Injection Pump Fuel Metering Control “A” Malfunction (Cam/Rotor/Injector)
Injection Pump Fuel Metering Control “A” Range/Performance (Cam/Rotor/Injector)
Injection Pump Fuel Metering Control “A” Low (Cam/Rotor/Injector)
Injection Pump Fuel Metering Control “A” High (Cam/Rotor/Injector)
Injection Pump Fuel Metering Control “A” Intermittent (Cam/Rotor/Injector)
Injection Pump Fuel Metering Control “B” Malfunction (Cam/Rotor/Injector)
Injection Pump Fuel Metering Control “B” Range or Performance (Cam/Rotor/Injector)
Injection Pump Fuel Metering Control “B” Low (Cam/Rotor/Injector)
Injection Pump Fuel Metering Control “B” High(Cam/Rotor/Injector) Range/Performance
Injection Pump Fuel Metering Control “B” Intermittent (Cam/Rotor/Injector)
Cylinder 1 Injector Circuit Low
Cylinder 1 Injector Circuit High
Cylinder 1 Contribution/Balance Fault
Cylinder 2 Injector Circuit Low
Cylinder 2 Injector Circuit High
Cylinder 2 Contribution/Balance Fault
Cylinder 3 Injector Circuit Low
Cylinder 3 Injector Circuit High
Cylinder 3 Contribution/Balance Fault
Cylinder 4 Injector Circuit Low
Cylinder 4 Injector Circuit High
Cylinder 4 Contribution/Balance Fault
Cylinder 5 Injector Circuit Low
Cylinder 5 Injector Circuit High
Cylinder 5 Contribution/Balance Fault
Cylinder 6 Injector Circuit Low
Cylinder 6 Injector Circuit High
6
PowerScan Series
0278
0279
0280
0281
0282
0283
0284
0285
0286
0287
0288
0289
0290
0291
0292
0293
0294
0295
0296
0298
0300
0301
0302
0303
0304
0305
0306
0307
0308
0309
0311
0312
0313
0314
0320
0321
0322
0323
0325
0326
0327
0328
0329
0330
0331
0332
0333
0334
OBD II / EOBD II /CAN
Cylinder 6 Contribution/Balance Fault
Cylinder 7 Injector Circuit Low
Cylinder 7 Injector Circuit High
Cylinder 7 Contribution/Balance Fault
Cylinder 8 Injector Circuit Low
Cylinder 8 Injector Circuit High
Cylinder 8 Contribution/Balance Fault
Cylinder 9 Injector Circuit Low
Cylinder 9 Injector Circuit High
Cylinder 9 Contribution/Balance Fault
Cylinder 10 Injector Circuit Low
Cylinder 10 Injector Circuit High
Cylinder 10 Contribution or Balance Fault
Cylinder 11 Injector Circuit Low
Cylinder 11 Injector Circuit High
Cylinder 11 Contribution/Balance Fault
Cylinder 12 Injector Circuit Low
Cylinder 12 Injector Circuit High
Cylinder 12 Contribution/Range Fault
Engine Oil Over Temperature
Random/Multiple Cylinder Misfire Detected
Cylinder 1 Misfire Detected
Cylinder 2 Misfire Detected
Cylinder 3 Misfire Detected
Cylinder 4 Misfire Detected
Cylinder 5 Misfire Detected
Cylinder 6 Misfire Detected
Cylinder 7 Misfire Detected
Cylinder 8 Misfire Detected
Cylinder 9 Misfire Detected
Cylinder 11 Misfire Detected
Cylinder 12 Misfire Detected
Misfire Detected with Low Fuel
Single Cylinder Misfire (Cylinder not Specified)
Ignition/Distributor Engine Speed Input Circuit Malfunction
Ignition/Distributor Engine Speed Input Circuit Range/Performance
Ignition/Distributor Engine Speed Input Circuit No Signal
Ignition/Distributor Engine Speed Input Circuit Intermittent
Knock Sensor 1 Circuit Malfunction (Bank 1 or Single Sensor)
Knock Sensor 1 Circuit Range/Performance (Bank 1 or Single Sensor)
Knock Sensor 1 Circuit Low Input (Bank 1 or Single Sensor)
Knock Sensor 1 Circuit High Input (Bank 1 or Single Sensor)
Knock Sensor 1 Circuit Intermittent (Bank 1 or Single Sensor)
Knock Sensor 2 Circuit Malfunction (Bank 2)
Knock Sensor 2 Circuit Range/Performance (Bank 2)
Knock Sensor 2 Circuit Low Input (Bank 2)
Knock Sensor 2 Circuit High Input (Bank 2)
Knock Sensor 2 Circuit Intermittent(Bank 2)
7
PowerScan Series
0335
0336
0337
0338
0339
0340
0341
0342
0343
0344
0345
0346
0347
0348
0349
0350
0351
0352
0353
0354
0355
0356
0357
0358
0359
0360
0361
0362
0365
0366
0367
0368
0369
0370
0371
0372
0373
0374
0375
0376
0377
0378
0379
0380
0381
0382
0385
0386
OBD II / EOBD II /CAN
Crankshaft Position Sensor A Circuit Malfunction
Crankshaft Position Sensor A Circuit Range/Performance
Crankshaft Position Sensor A Circuit Low Input
Crankshaft Position Sensor A Circuit High Input
Crankshaft Position Sensor A Circuit Intermittent
Camshaft Position Sensor A Circuit (Bank 1 or Single Sensor)
Camshaft Position Sensor A Circuit Range/Performance (Bank 1 or Single Sensor)
Camshaft Position Sensor A Circuit Low Input (Bank 1 or Single Sensor)
Camshaft Position Sensor A Circuit High Input (Bank 1 or Single Sensor)
Camshaft Position Sensor A Circuit Intermittent (Bank 1 or Single Sensor)
Camshaft Position Sensor A Circuit (Bank 2)
Camshaft Position Sensor A Circuit Range/Performance (Bank 2)
Camshaft Position Sensor A Circuit Low Input (Bank 2)
Camshaft Position Sensor A Circuit High Input (Bank 2)
Camshaft Position Sensor A Circuit Intermittent (Bank 2)
Ignition Coil Primary/Secondary Circuit Malfunction
Ignition Coil A Primary/Secondary Circuit Malfunction
Ignition Coil B Primary/Secondary Circuit Malfunction
Ignition Coil C Primary/Secondary Circuit Malfunction
Ignition Coil D Primary/Secondary Circuit Malfunction
Ignition Coil E Primary/Secondary Circuit Malfunction
Ignition Coil F Primary/Secondary Circuit Malfunction
Ignition Coil G Primary/Secondary Circuit Malfunction
Ignition Coil H Primary/Secondary Circuit Malfunction
Ignition Coil I Primary/Secondary Circuit Malfunction
Ignition Coil J Primary/Secondary Circuit Malfunction
Ignition Coil K Primary/Secondary Circuit Malfunction
Ignition Coil L Primary/Secondary Circuit Malfunction
Camshaft Position Sensor B Circuit (Bank 1)
Camshaft Position Sensor B Circuit Range/Performance (Bank 1)
Camshaft Position Sensor B Circuit Low Input (Bank 1)
Camshaft Position Sensor B Circuit High Input (Bank 1)
Camshaft Position Sensor B Circuit Intermittent (Bank 1)
Timing Reference High Resolution Signal A Malfunction
Timing Reference High Resolution Signal A Too Many Pulses
Timing Reference High Resolution Signal A Too Few Pulses
Timing Reference High Resolution Signal A Intermittent/Erratic Pulses
Timing Reference High Resolution Signal A No Pulses
Timing Reference High Resolution Signal B Malfunction
Timing Reference High Resolution Signal B Too Many Pulses
Timing Reference High Resolution Signal B Too Few Pulses
Timing Reference High Resolution Signal B Intermittent/Erratic Pulses
Timing Reference High Resolution Signal B No Pulses
Glow Plug/Heater Circuit “A” Malfunction
Glow Plug/Heater Indicator Circuit Malfunction
Exhaust Gas Recirculation Flow Malfunction
Crankshaft Position Sensor B Circuit Malfunction
Crankshaft Position Sensor B Circuit Range/Performance
8
PowerScan Series
0387
0388
0389
0390
0391
0392
0393
0394
0400
0401
0402
0403
0404
0405
0406
0407
0408
0409
0410
0411
0412
0413
0414
0415
0416
0417
0418
0419
0420
0421
0422
0423
0424
0425
0426
0427
0428
0429
0430
0431
0432
0433
0434
0435
0436
0437
0438
0439
OBD II / EOBD II /CAN
Crankshaft Position Sensor B Circuit Low Input
Crankshaft Position Sensor B Circuit High Input
Crankshaft Position Sensor B Circuit Intermittent
camshaft Position Sensor B Circuit
Camshaft Position Sensor B circuit Range/Performance (Bank 2)
Camshaft Position Sensor B Circuit Low Input (Bank 2)
Camshaft Position Sensor B Circuit High Input (Bank 2)
Camshaft Position Sensor B Circuit Intermittent (Bank 2)
Exhaust Gas Recirculation Flow Malfunction
Exhaust Gas Recirculation Flow Insufficient Detected
Exhaust Gas Recirculation Flow Excessive Detected
Exhaust Gas Recirculation Circuit Malfunction
Exhaust Gas Recirculation Circuit Range/Performance
Exhaust Gas Recirculation Sensor A Circuit Low
Exhaust Gas Recirculation Sensor A Circuit High
Exhaust Gas Recirculation Sensor B Circuit Low
Exhaust Gas Recirculation Sensor B Circuit High
Exhaust Gas Recirculation Sensor A Circuit
Secondary Air Injection System Malfunction
Secondary Air Injection System Incorrect Flow Detected
Secondary Air Injection System Switching Valve A Circuit Malfunction
Secondary Air Injection System Switching Valve A Circuit Open
Secondary Air Injection System Switching Valve A Circuit Shorted
Secondary Air Injection System Switching Valve B Circuit Malfunction
Secondary Air Injection System Switching Valve B Circuit Open
Secondary Air Injection System Switching Valve B Circuit Shorted
Secondary Air Injection System Relay “A” Circuit Malfunction
Secondary Air Injection System Relay “B” Circuit Malfunction
Catalyst System Efficiency Below Threshold (Bank 1)
Warm Up Catalyst Efficiency Below Threshold (Bank 1)
Main Catalyst Efficiency Below Threshold (Bank 1)
Heated Catalyst Efficiency Below Threshold (Bank 1)
Heated Catalyst Temperature Below Threshold (Bank 1)
Catalyst Temperature Sensor (Bank 1)
Catalyst Temperature Sensor Range/Performance (Bank 1)
Catalyst Temperature Sensor Low Input (Bank 1)
Catalyst Temperature Sensor High Input (Bank 1)
Catalyst Heater Control Circuit (Bank 1)
Catalyst System Efficiency Below Threshold (Bank 2)
Warm Up Catalyst Efficiency Below Threshold (Bank 2)
Main Catalyst Efficiency Below Threshold (Bank 2)
Heated Catalyst Efficiency Below Threshold (Bank 2)
Heated Catalyst Temperature Below Threshold (Bank 2)
Catalyst Temperature Sensor (Bank 2)
Catalyst Temperature Sensor Range/Performance (Bank 2)
Catalyst Temperature Sensor Low Input (Bank 2)
Catalyst Temperature Sensor High Input (Bank 2)
Catalyst Heater Control Circuit (Bank 2)
9
PowerScan Series
0440
0441
0442
0443
0444
0445
0446
0447
0448
0449
0450
0451
0452
0453
0454
0455
0456
0457
0460
0461
0462
0463
0464
0465
0466
0467
0468
0469
0470
0471
0472
0473
0474
0475
0476
0477
0478
0479
0480
0481
0482
0483
0484
0485
0486
0487
0488
0491
OBD II / EOBD II /CAN
Evaporative Emission Control System Malfunction
Evaporative Emission Control System Incorrect Purge Flow
Evaporative Emission Control System Leak Detected (small leak)
Evaporative Emission Control System Purge Control Valve Circuit Malfunction
Evaporative Emission Control System Purge Control Valve Circuit Open
Evaporative Emission Control System Purge Control Valve Circuit Shorted
Evaporative Emission Control System Vent Control Circuit Malfunction
Evaporative Emission Control System Vent Control Circuit Open
Evaporative Emission Control System Vent Control Circuit Shorted
Evaporative Emission Control System Vent Valve/Solenoid Circuit Malfunction
Evaporative Emission Control System Pressure Sensor Malfunction
Evaporative Emission Control System Pressure Sensor Range/Performance
Evaporative Emission Control System Pressure Sensor Low Input
Evaporative Emission Control System Pressure Sensor High Input
Evaporative Emission Control System Pressure Sensor Intermittent
Evaporative Emission Control System Leak Detected (gross leak)
Evaporative Emission Control System Leak Detected (very small leak)
Evaporative Emission Control System Leak Detected (fuel cap loose/off)
Fuel Level Sensor Circuit Malfunction
Fuel Level Sensor Circuit Range/Performance
Fuel Level Sensor Circuit Low Input
Fuel Level Sensor Circuit High Input
Fuel Level Sensor Circuit Intermittent
Purge Flow Sensor Circuit Malfunction
Purge Flow Sensor Circuit Range/Performance
Purge Flow Sensor Circuit Low Input
Purge Flow Sensor Circuit High Input
Purge Flow Sensor Circuit Intermittent
Exhaust Pressure Sensor Malfunction
Exhaust Pressure Sensor Range/Performance
Exhaust Pressure Sensor Low
Exhaust Pressure Sensor High
Exhaust Pressure Sensor Intermittent
Exhaust Pressure Control Valve Malfunction
Exhaust Pressure Control Valve Range/Performance
Exhaust Pressure Control Valve Low
Exhaust Pressure Control Valve High
Exhaust Pressure Control Valve Intermittent
Cooling Fan 1 Control Circuit Malfunction
Cooling Fan 2 Control Circuit Malfunction
Cooling Fan 3 Control Circuit Malfunction
Cooling Fan Rationality Check Malfunction
Cooling Fan Circuit Over Current
Cooling Fan Power/Ground Circuit Malfunction
Exhaust Gas Recirculation Sensor B Circuit
Exhaust Gas Recirculation Throttle Position Control Circuit
Exhaust Gas Recirculation Throttle Position Control Range/Performance
Secondary Air Injection System (Bank 1)
10
PowerScan Series
0492
0500
0501
0502
0503
0505
0506
0507
0508
0509
0510
0512
0513
0515
0516
0517
0520
0521
0522
0523
0524
0530
0531
0532
0533
0534
0540
0541
0542
0544
0545
0546
0547
0548
0549
0550
0551
0552
0553
0554
0560
0561
0562
0563
0564
0565
0566
0567
OBD II / EOBD II /CAN
Secondary Air Injection System (Bank 2)
Vehicle Speed Sensor Malfunction
Vehicle Speed Sensor Range/Performance
Vehicle Speed Sensor Low Input
Vehicle Speed Sensor Intermittent/Erratic/High
Idle Control System Malfunction
Idle Control System RPM Lower Than Expected
Idle Control System RPM Higher Than Expected
Idle Control System Circuit Low
Idle Control System Circuit High
Closed Throttle Position Switch Malfunction
Starter Request Circuit
Incorrect Irnmobilizer Key (Immobilizer pending SAE J1930 approval)
Battery Temperature Sensor Circuit
Battery Temperature Sensor Circuit Low
Battery Temperature Sensor Circuit High
Engine Oil Pressure Sensor/Switch Circuit Malfunction
Engine Oil Pressure Sensor/Switch Circuit Range/Performance
Engine Oil Pressure Sensor/Switch Circuit Low Voltage
Engine Oil Pressure Sensor/Switch Circuit High Voltage
Engine Oil Pressure Too Low
A/C Refrigerant Pressure Sensor Circuit Malfunction
A/C Refrigerant Pressure Sensor Circuit Range/Performance
A/C Refrigerant Pressure Sensor Circuit Low Input
A/C Refrigerant Pressure Sensor Circuit High Input
Air Conditioner Refrigerant Charge Loss
Intake Air Heater Circuit
Intake Air Heater Circuit Low
Intake Air Heater Circuit High
Exhaust Gas Temperature Sensor Circuit (Bank 1)
Exhaust Gas Temperature Sensor Circuit Low (Bank 1)
Exhaust Gas Temperature Sensor Circuit High (Bank 1)
Exhaust Gas Temperature Sensor Circuit (Bank 2)
Exhaust Gas Temperature Sensor Circuit Low (Bank 2)
Exhaust Gas Temperature Sensor Circuit High (Bank 2)
Power Steering Pressure Sensor Circuit Malfunction
Power Steering Pressure Sensor Circuit Range/Performance
Power Steering Pressure Sensor Circuit Low Input
Power Steering Pressure Sensor Circuit High Input
Power Steering Pressure Sensor Circuit Intermittent
System Voltage Malfunction
System Voltage Unstable
System Voltage Low
System Voltage High
Cruise Control Multi-Function Input Signal
Cruise Control On Signal Malfunction
Cruise Control Off Signal Malfunction
Cruise Control Resume Signal Malfunction
11
PowerScan Series
0568
0569
0570
0571
0572
0573
0574
0575
0576
0577
0578
0579
0580
0600
0601
0602
0603
0604
0605
0606
0608
0609
0610
0615
0616
0617
0618
0619
0620
0621
0622
0623
0624
0630
0631
0635
0636
0637
0638
0639
0640
0645
0646
0647
0648
0649
0650
0654
OBD II / EOBD II /CAN
Cruise Control Set Signal Malfunction
Cruise Control Coast Signal Malfunction
Cruise Control Acceleration Signal Malfunction
Cruise Control/Brake Switch A Circuit Malfunction
Cruise Control/Brake Switch A Circuit Low
Cruise Control/Brake Switch A Circuit High
Cruise Control System - Vehicle Speed Too High
Cruise Control Input Circuit
Cruise Control Input Circuit Low
Cruise Control input Circuit High
Through P0580 Reserved for Cruise Control Codes
Cruise Control Related Malfunction
Cruise Control Related Malfunction
Serial Communication Link Malfunction
Control Module Read Only Memory (ROM)
Control Module Programming Error
Internal Control Module Keep Alive Memory (KAM) Error
Internal Control Module Random Access Memory (RAM) Error
Internal Control Module Read Only Memory (ROM) Error
PCM Processor Fault
Control Module VSS Output “A” Malfunction
Control Module VSS Output “B” Malfunction
Control Module Vehicle Options Error
Starter Relay Circuit
Starter Relay Circuit Low
Starter Relay Circuit High
Alternative Fuel Control Module KAM Error
Alternative Fuel Control Module RAM/ROM Error
Generator Control Circuit Malfunction
Generator Lamp “L” Control Circuit Malfunction
Generator Field “F” Control Circuit Malfunction
Generator Lamp Control Circuit
Fuel Cap Lamp Control Circuit
VIN Not Programmed or Mismatch - ECM/PCM
VIN Not Programmed or Mismatch - TCM
Power Steering Control Circuit
Power Steering Control Circuit Low
Power Steering Control Circuit High
Throttle Actuator Control Range/Performance (Bank 1)
Throttle Actuator Control Range/Performance (Bank 2)
Intake Air Heater Control Circuit
A/C Clutch Relay Control Circuit
A/C Clutch Relay Control Circuit Low
A/C Clutch Relay Control Circuit High
Immobilizer Lamp Control Circuit (Immobilizer pending SAE J1930 approval)
Speed Control Lamp Control Circuit
Malfunction Indicator Lamp (MIL) Control Circuit Malfunction
Engine RPM Output Circuit Malfunction
12
PowerScan Series
0655
0656
0660
0661
0662
0663
0664
0665
0700
0701
0702
0703
0704
0705
0706
0707
0708
0709
0710
0711
0712
0713
0714
0715
0716
0717
0718
0719
0720
0721
0722
0723
0724
0725
0726
0727
0728
0730
0731
0732
0733
0734
0735
0736
0737
0738
0739
0740
OBD II / EOBD II /CAN
Engine Hot Lamp Output Control Circuit Malfunction
Fuel Level Output Circuit Malfunction
Intake Manifold Tuning Valve Control Circuit (Bank 1)
Intake Manifold Tuning Valve Control Circuit Low (Bank 1)
Intake Manifold Tuning Valve Control Circuit High (Bank 1)
Intake Manifold Tuning Valve Control Circuit (Bank 2)
Intake Manifold Tuning Valve Control Circuit Low (Bank 2)
Intake Manifold Tuning Valve Control Circuit High (Bank 2)
Transmission Control System Malfunction
Transmission Control System Range/Performance
Transmission Control System Electrical
Torque Converter/Brake Switch B Circuit Malfunction
Clutch Switch Input Circuit Malfunction
Transmission Range Sensor Circuit malfunction (PRNDL Input)
Transmission Range Sensor Circuit Range/Performance
Transmission Range Sensor Circuit Low Input
Transmission Range Sensor Circuit High Input
Transmission Range Sensor Circuit Intermittent
Transmission Fluid Temperature Sensor Circuit Malfunction
Transmission Fluid Temperature Sensor Circuit Range/Performance
Transmission Fluid Temperature Sensor Circuit Low Input
Transmission Fluid Temperature Sensor Circuit High Input
Transmission Fluid Temperature Sensor Circuit Intermittent
Input/Turbine Speed Sensor Circuit Malfunction
Input/Turbine Speed Sensor Circuit Range/Performance
Input/Turbine Speed Sensor Circuit No Signal
Input/Turbine Speed Sensor Circuit Intermittent
Torque Converter/Brake Switch B Circuit Low
Output Speed Sensor Circuit Malfunction
Output Speed Sensor Range/Performance
Output Speed Sensor No Signal
Output Speed Sensor Intermittent
Torque Converter/Brake Switch B Circuit High
Engine Speed input Circuit Malfunction
Engine Speed Input Circuit Range/Performance
Engine Speed Input Circuit No Signal
Engine Speed Input Circuit Intermittent
Incorrect Gear Ratio
Gear 1 Incorrect ratio
Gear 2 Incorrect ratio
Gear 3 Incorrect ratio
Gear 4 Incorrect ratio
Gear 5 Incorrect ratio
Reverse incorrect gear ratio
TCM Engine Speed Output Circuit
TCM Engine Speed Output Circuit Low
TCM Engine Speed Output Circuit High
Torque Converter Clutch Circuit Malfunction
13
PowerScan Series
0741
0742
0743
0744
0745
0746
0747
0748
0749
0750
0751
0752
0753
0754
0755
0756
0757
0758
0759
0760
0761
0762
0763
0764
0765
0766
0767
0768
0769
0770
0771
0772
0773
0774
0775
0776
0777
0778
0779
0780
0781
0782
0783
0784
0785
0786
0787
0788
OBD II / EOBD II /CAN
Torque Converter Clutch Circuit Performance or Stuck Off
Torque Converter Clutch Circuit Stuck On
Torque Converter Clutch Circuit Electrical
Torque Converter Clutch Circuit Intermittent
Pressure Control Solenoid Malfunction
Pressure Control Solenoid Performance or Stuck Off
Pressure Control Solenoid Stuck On
Pressure Control Solenoid Electrical
Pressure Control Solenoid Intermittent
Shift Solenoid A Malfunction
Shift Solenoid A Performance or Stuck Off
Shift Solenoid A Stuck On
Shift Solenoid A Electrical
Shift Solenoid A Intermittent
Shift Solenoid B Malfunction
Shift Solenoid B Performance or Stuck Off
Shift Solenoid B Stuck On
Shift Solenoid B Electrical
Shift Solenoid B Intermittent
Shift Solenoid C Malfunction
Shift Solenoid C Performance or Stuck Off
Shift Solenoid C Stuck On
Shift Solenoid C Electrical
Shift Solenoid C Intermittent
Shift Solenoid D Malfunction
Shift Solenoid D Performance or Stuck Off
Shift Solenoid D Stuck On
Shift Solenoid D Electrical
Shift Solenoid D Intermittent
Shift Solenoid E Malfunction
Shift Solenoid E Performance or Stuck Off
Shift Solenoid E Stuck On
Shift Solenoid E Electrical
Shift Solenoid E Intermittent
Pressure Control Solenoid B
Pressure Control Solenoid B Performance or Stuck Off
Pressure Control Solenoid B Stuck On
Pressure Control Solenoid B Electrical
Pressure Control Solenoid B Intermittent
Shift Malfunction
12 Shift Malfunction
23 Shift Malfunction
34 Shift Malfunction
45 Shift Malfunction
Shift/Timing Solenoid Malfunction
Shift/Timing Solenoid Range/Performance
Shift/Timing Solenoid Low
Shift/Timing Solenoid High
14
PowerScan Series
0789
0790
0791
0792
0793
0794
0795
0796
0797
0798
0799
0801
0803
0804
0805
0806
0807
0808
0809
0810
0811
0812
0813
0814
0815
0816
0817
0818
0820
0821
0822
0823
0824
0825
0830
0831
0832
0833
0834
0835
0836
0837
0838
0839
0840
0841
0842
0843
OBD II / EOBD II /CAN
Shift/Timing Solenoid Intermittent
Normal/Performance Switch Circuit Malfunction
Intermediate Shaft Speed Sensor Circui
Intermediate Shaft Speed Sensor Circuit Range/Performance
Intermediate Shaft Speed Sensor Circuit No Signal
Intermediate Shaft Speed Sensor Circuit Intermittent
Pressure Control Solenoid C
Pressure Control Solenoid C Performance or Stuck off
Pressure Control Solenoid C Stuck On
Pressure Control Solenoid C Electrical
Pressure Control Solenoid C Intermittent
Reverse Inhibit Control Circuit Malfunction
14 Upshift (Skip Shift) Solenoid Control Circuit Malfunction
14 Upshift (Skip Shift) Lamp Control Circuit Malfunction
Clutch Position Sensor Circuit
Clutch Position Sensor Circuit Range/Performance
Clutch Position Sensor Circuit Low
Clutch Position Sensor Circuit High
Clutch Position Sensor Circuit Intermittent
Clutch Position Control Error
Excessive Clutch Slippage
Reverse Input Circuit
Reverse Output Circuit
Transmission Range Display Circuit
Upshift Switch Circuit
Downshift Switch Circuit
Starter Disable Circuit
Driveline Disconnect Switch Input Circuit
Gear Lever X-Y Position Sensor Circuit
Gear Lever X Position Circuit
Gear Lever Y Position Circuit
Gear Lever X Position Circuit Intermittent
Gear Lever Y Position Circuit Intermittent
Gear Lever Push-Pull Switch (Shift Anticipate)
Clutch Pedal Switch A Circuit
Clutch Pedal Switch A Circuit Low
Clutch Pedal Switch A Circuit High
Clutch Pedal Switch B Circuit
Clutch Pedal Switch B Circuit Low
Clutch Pedal Switch B Circuit High
Four Wheel Drive (4WD) Switch Circuit
Four Wheel Drive (4WD) Switch Circuit Range/Performance
Four Wheel Drive (4WD) Switch Circuit Low
Four Wheel Drive (4WD) Switch Circuit High
Transmission Fluid Pressure Sensor/Switch A Circuit
Transmission Fluid Pressure Sensor/Switch A Circuit Range/Performance
Transmission Fluid Pressure Sensor/Switch A Circuit Low
Transmission Fluid Pressure Sensor/Switch A Circuit High
15
PowerScan Series
0844
0845
0846
0847
0848
0849
OBD II / EOBD II /CAN
Transmission Fluid Pressure Sensor/Switch A Circuit Intermittent
Transmission Fluid Pressure Sensor/Switch B Circuit
Transmission Fluid Pressure Sensor/Switch B Circuit Range/Performance
Transmission Fluid Pressure Sensor/Switch B Circuit Low
Transmission Fluid Pressure Sensor/Switch B Circuit High
Transmission Fluid Pressure Sensor/Switch B Circuit Intermittent
Table B: Manufacturer OBDII DTC Definitions
1100
1101
1102
1103
1104
1105
1106
1107
1108
1109
1110
1111
1112
1113
1114
1115
1116
1117
1118
1119
1120
1121
1122
1123
1124
1125
1126
1127
1128
1129
1130
1131
1132
1133
1134
MAF Sensor Intermittent/ Check of all OBDII Systems Not Complete
MAF Sensor Out Of Self Test Range./KOER Not Able To Complete KOER Aborted
MAF Sensor In Range But Lower Than Expected
MAF Sensor In Range But Higher Than Expected
MAF Ground Malfunction
Dual Alternator Upper Fault
Dual Alternator Lower Fault/ Manifold Absolute Pressure (MAP) Sensor Circuit Intermittent
High Voltage
Dual Alternator Lower Circuit Malfunction/ Manifold Absolute Pressure (MAP) Sensor
Circuit Intermittent Low Voltage
Dual Alternator Battery Lamp Circuit Malfunction
IAT - B Sensor Intermittent
IAT Sensor (D/C) Open/Short
Intake Air Temperature (IAT) Sensor Circuit Intermittent High Voltage
Intake Air Temperature (IAT) Sensor Circuit Intermittent Low Voltage
IAT Sensor Open/Short
Engine Coolant Temperature (ECT) Sensor Circuit Intermittent Low Voltage/IAT - B Circuit
Low Input
Engine Coolant Temperature (ECT) Sensor Circuit Intermittent High Voltage/IAT - B Circuit
High Input
Engine Coolant sensor out of range/ECT Sensor Out Of Self Test Range
Engine Coolant Sensor intermittent/ECT Sensor Intermittent
Manifold Absolute Temperature Circuit Low Input
Manifold Absolute Temperature Circuit High Input
Throttle position sensor out of range
Throttle Position (TP) Sensor Circuit Intermittent High Voltage
Throttle Position (TP) Sensor Circuit Intermittent Low Voltage
Throttle Position Sensor In Range But Higher Than Expected
Throttle Position Sensor Out Of Self Test Range
Throttle position sensor intermittent
Throttle Position (Narrow Range) Sensor Circuit Malfunction
Exhaust Not Warm, Downstream O2 Sensor
Upstream Heated O2 Sensors Swapped
Downstream Heated O2 Sensors Swapped
Lack Of HO2S Switch - Adaptive Fuel At Limit
Lack Of HO2S Switch - Sensor Indicates Lean
Lack Of HO2S Switch - Sensor Indicates Rich
HO2S Insufficient Switching Sensor 1
HO2S Transition Time Ratio Sensor 1
16
PowerScan Series
1135
1136
1137
1138
1139
1140
1141
1142
1143
1144
1150
1151
1152
1153
1154
1155
1156
1157
1158
1159
1167
1168
1169
1170
1171
1172
1173
1174
1175
1176
1177
1178
1180
1181
1182
1183
1184
1185
1186
1187
1188
1189
1190
1191
1192
1193
1194
1195
OBD II / EOBD II /CAN
Pedal Position Sensor A Circuit Intermittent
Fan Control Circuit Malfunction
Lack Of HO2S Switch - Sensor Indicates Lean
Lack Of HO2S12 Switch - Sensor Indicates Rich
Water In Fuel Indicator Circuit Malfunction
Water In Fuel Condition
Fuel Restriction Indicator Circuit Malfunction
Fuel Restriction Condition
Air Assist Control Valve Range/Performance
Air Assist Control Valve Circuit Malfunction
Lack Of HO2S21 Switch - Adaptive Fuel At Limit
Lack Of HO2S21 Switch - Sensor Indicates Lean
Lack Of HO2S21 Switch - Sensor Indicates Rich
Bank 2 Fuel Control Shifted Lean
Bank 2 Fuel Control Shifted Rich
Alternative Fuel Controller
Fuel Select Switch Malfunction
Lack Of HO2S22 Switch - Sensor Indicates Lean
Lack Of HO2S22 Switch - Sensor Indicates Rich
Fuel Stepper Motor Malfunction
Invalid Test,throttle not depressed
Fuel Rail Sensor In-Range Low Failure
Fuel Rail Sensor In-Range High Failure
ESO - Engine Shut Off Solenoid Fault
Rotor Sensor Fault
Rotor Control Fault
Rotor Calibration Fault
Cam Sensor Fault
Cam Control Fault
Cam Calibration Fault
Synchronization Fault
(OPEN)
Fuel Delivery System Malfunction - Low
Fuel Delivery System Malfunction - High
Fuel Shut Off Solenoid Malfunction
Engine Oil Temperature Circuit Malfunction
Engine Oil Temperature Out Of Self Test Range
FTS High - Fuel Pump Temperature Sensor High
FTS Low - Fuel Pump Temperature Sensor Low
Variant Selection
Calibration Memory Fault
Pump Speed Signal Fault
Calibration Resistor Out Of Range
Key Line Voltage
Voltage External
EGR Drive Overcurrent
ECU A/D Converter
SCP HBCC Failed To Initialize
17
PowerScan Series
1196
1197
1198
1199
1200
1201
1202
1203
1204
1205
1206
1209
1210
1211
1212
1213
1214
1215
1216
1217
1218
1219
1220
1221
1222
1223
1224
1225
1226
1227
1228
1229
1230
1231
1232
1233
1234
1235
1236
1237
1238
1239
1240
1241
1242
1243
1244
1245
OBD II / EOBD II /CAN
Key Off Voltage High
Key Off Voltage Low
Pump Rotor Control Underfueling
Fuel Level Input Circuit Low
Injector Control Circuit
Injector Circuit Open / Shorted - Cylinder #1
Injector Circuit Open / Shorted - Cylinder #2
Injector Circuit Open / Shorted - Cylinder #3
Injector Circuit Open / Shorted - Cylinder #4
Injector Circuit Open / Shorted - Cylinder #5
Injector Circuit Open / Shorted - Cylinder #6
Injector Control Pressure System Fault
Injector Control Pressure Above Expected Level
Injector Control Pressure Sensor Above / Below Desired
Injector Control Pressure Not Detected During Crank
Start Injector Circuit Malfunction
Pedal Position Sensor B Circuit Intermittent
Pedal Position Sensor C Circuit Low Input
Pedal Position Sensor C Circuit High Input
Pedal Position Sensor C Circuit Intermittent
CID High
CID Low
Series Throttle Control System Malfunction
Traction Control System Malfunction
Traction Control Output Circuit Malfunction
Pedal Demand Sensor B Circuit High Input
Throttle Position Sensor B Out Of Self Test Range
Needle Lift Sensor Malfunction
Control Sleeve Sensor Malfunction
Wastegate Failed Closed (Over Pressure)
Wastegate Failed Open (Under Pressure)
Intercooler Pump Driver Fault
Fuel Pump Low Speed Malfunction
Fuel Pump Secondary Circuit Low, High Speed
Fuel Pump Speed Primary Circuit Malfunction
Fuel Pump Driver Module Off Line
Fuel Pump Driver Module Off Line
Fuel Pump Control Out Of Range
Fuel Pump Control Out Of Range
Fuel Pump Secondary Circuit Malfunction
Fuel Pump Secondary Circuit Malfunction
Speed Fuel Pump Positive Feed Fault
Sensor Power Supply Malfunction
Sensor Power Supply Low Input
Sensor Power Supply High Input
Second Fuel Pump Faulty or Ground Fault
Alternator Load Input Failed High
Alternator Load Input Failed Low
18
PowerScan Series
1246
1247
1248
1249
1250
1251
1252
1253
1254
1255
1256
1257
1258
1259
1260
1261
1262
1263
1264
1265
1266
1267
1268
1269
1270
1271
1272
1273
1274
1275
1276
1277
1278
1280
1281
1282
1283
1284
1285
1286
1287
1288
1289
1290
1291
1292
1293
1294
OBD II / EOBD II /CAN
Alternator Load Input Failed
Turbo Boost Pressure Low
Turbo Boost Pressure Not Detected
Wastegate Control Valve Performance
PRC Solenoid Circuit Malfunction
Air Mixture Solenoid Circuit Malfunction
Pedal Correlation PDS1 and LPDS High
Pedal Correlation PDS1 and LPDS Low
Pedal Correlation PDS2 and LPDS High
Pedal Correlation PDS2 and LPDS Low
Pedal Correlation PDS1 and HPDS
Pedal Correlation PDS2 and HPDS
Pedal Correlation PDS1 and PDS2
Immobilizer to PCM Signal Error
THEFT Detected, Vehicle Immobilzed
Cylinder #1 High To Low Side Short
Cylinder #2 High To Low Side Short
Cylinder #3 High To Low Side Short
Cylinder #4 High To Low Side Short
Cylinder #5 High To Low Side Short
Cylinder #6 High To Low Side Short
Cylinder #7 High To Low Side Short
Cylinder #8 High To Low Side Short
Immobilizer Code Not Programmed
Engine RPM Or Speed Limiter Reached
Cylinder #1 High To Low Side Open
Cylinder #2 High To Low Side Open
Cylinder #3 High To Low Side Open
Cylinder #4 High To Low Side Open
Cylinder #5 High To Low Side Open
Cylinder #6 High To Low Side Open
Cylinder #7 High To Low Side Open
Cylinder #8 High To Low Side Open
Injection Control Pressure Out Of Range Low
Injection Control Pressure Out Of Range High
Excessive Injection Control Pressure
IPR Circuit Failure
Aborted KOER - ICP Failure
Cylinder head over temp sensed
Fuel Pulse In Range But Lower Than Expected
Fuel Pulse In Range But Higher Than Expected
Cylinder Head Temp Sensor Out Of Self Test Range
Cylinder Head Temp Sensor High Input
Cylinder Head Temp Sensor Low Input
Injector High Side Short To GND Or VBATT - Bank 1
Injector High Side Short To GND Or VBATT - Bank 2
Injector High Side Open - Bank 1
Injector High Side Open - Bank 2/Target idle not reached
19
PowerScan Series
1295
1296
1297
1298
1299
1300
1301
1302
1303
1304
1305
1306
1307
1308
1309
1313
1314
1315
1316
1317
1336
1340
1341
1345
1346
1347
1348
1349
1350
1351
1352
1353
1354
1355
1360
1361
1362
1363
1364
1365
1366
1367
1368
1369
1370
1371
1372
OBD II / EOBD II /CAN
Multi-faults - Bank 1 - With Low Side Shorts
Multi-faults - Bank 2 - With Low Side Shorts
Injector High Sides Shorted Together
IDM Failure
Cylinder Head Overtemperature Protection Active
Boost Calibration Fault
Boost Calibration High
Boost Calibration Low
EGR Calibration Fault
EGR Calibration High
EGR Calibration Low
Kickdown Relay Pull - In Circuit Fault
Kickdown Relay Hold Circuit Fault
A/C Clutch Circuit Fault
Misfire Monitor AICE Chip Fault
Misfire Rate Catalyst Damage Fault - Bank 1
Misfire Rate Catalyst Damage Fault - Bank 2
Persistent Misfire
Injector Circuit / IDM Codes Detected
Injector Circuit / IDM Codes Not Updated
Crank / Cam Sensor Range / Performance
Camshaft Position Sensor B Circuit Malfunction
Camshaft Position Sensor B Range / Performance
SGC (Cam Position) Sensor Circuit Malfunction/ Crankshaft Position - Camshaft Position
Correlation
Fuel Level Sensor B Circuit Malfunction
Fuel Level Sensor B Range / Performance
Fuel Level Sensor B Circuit Low
Fuel Level Sensor B Circuit High
Fuel Level Sensor B Intermittent/Bypass Line Monitor
IDM Input Circuit Malfunction/ Ignition Coil Control Circuit High Voltage
Ignition Coil A Primary Circuit Malfunction
Ignition Coil B Primary Circuit Malfunction
Ignition Coil C Primary Circuit Malfunction
Ignition Coil D Primary Circuit Malfunction
Ignition Coil A Secondary Circuit Malfunction
Ignition Control (IC) Circuit Low Voltage
Ignition Coil C Secondary Circuit Malfunction
Ignition Coil D Secondary Circuit Malfunction
Ignition Coil Primary Circuit Failure
Ignition Coil Secondary Circuit Failure
Ignition Spare
Ignition Spare
Ignition Spare
Engine Temperature Light Monitor Failure
Insufficient RMP Increase During Spark Test
Ignition Coil - Cylinder 1 - Early Activation Fault
Ignition Coil - Cylinder 2 - Early Activation Fault
20
PowerScan Series
1373
1374
1375
1376
1380
1381
1382
1383
1384
1385
1386
1387
1388
1389
1390
1391
1392
1393
1394
1395
1396
1397
1398
1399
1400
1401
1402
1403
1404
1405
1406
1407
1408
1409
1411
1413
1414
1415
1416
1417
1418
1419
1420
1421
1422
1423
1424
OBD II / EOBD II /CAN
Ignition Coil - Cylinder 3 - Early Activation Fault
Crankshaft Position (CKP)/Ignition Coil - Cylinder 4 - Early Activation Fault
Ignition Coil - Cylinder 5 - Early Activation Fault
Ignition Coil - Cylinder 6 - Early Activation Fault
Misfire Detected - Rough Road Data Not Available
Variable Cam Timing Overadvanced (Bank #1)/ Misfire Detected - No Communication
with BCM
Variable Cam Timing Solenoid #1 Circuit Malfunction
Variable Cam Timing Overretarded (Bank #1)
VVT Solenoid A Malfunction
Variable Cam Timing Solenoid B Malfunction
Variable Cam Timing Overadvanced (Bank #2)
Variable Cam Timing Solenoid #2 Circuit Malfunction
Variable Cam Timing Overretarded (Bank #2)
Glow Plug Circuit High Side Low Input
Octane Adjust Pin Out Of Self Test Range
Glow Plug Circuit Low Input (Bank #1)
Glow Plug Circuit High Input (Bank #1)
Glow Plug Circuit Low Input (Bank #2)
Glow Plug Circuit High Input (Bank #2)
Glow Plug Monitor Fault (Bank #1)
Glow Plug Monitor Fault (Bank #2)
System Voltage Out Of Self Test Range
VVT Solenoid B Circuit High Input
Glow Plug Circuit High Side, High Input
DPFE Circuit Low Input
DPFE Circuit High Input
EGR Metering Orifice Restricted
DPFE Sensor Hoses Reversed
IAT - B Circuit Malfunction/ Exhaust Gas Recirculation Closed Position Performance
DPFE Sensor Upstream Hose Off Or Plugged
Exhaust Gas Recirculation (EGR) Position Sensor Performance
EGR No Flow Detected
EGR Flow Out Of Self Test Range
EVR Control Circuit Malfunction
SAI System Incorrect Downstream Flow Detected
SAI System Monitor Circuit Low Input
SAI System Monitor Circuit High Input
Air Pump Circuit Malfunction/ (AIR) System Bank 1
Port Air Circuit Malfunction/ (AIR) System Bank 2
Port Air Relief Circuit Malfunction
Split Air #1 Circuit Malfunction
Split Air #2 Circuit Malfunction
Catalyst Temperature Sensor Failure
Catalyst Damage
EGI Temperature Sensor Failure
EGI Functionality Test Failed
EGI Glow Plug Primary Failure
21
PowerScan Series
1425
1426
1427
1428
1429
1430
1433
1434
1435
1436
1437
1438
1439
1440
1441
1442
1443
1444
1445
1446
1447
1448
1449
1450
1451
1452
1453
1454
1455
1456
1457
1460
1461
1462
1463
1464
1465
1466
1467
1468
1469
1470
1471
1472
1473
1474
1475
1476
OBD II / EOBD II /CAN
EGI Glow Plug Secondary Failure
EGI Mini - MAF Failed Out Of Range
EGI Mini - MAF Failed Short Circuit
EGI Mini - MAF Failed Open Circuit
Electric Air Pump Primary Failure
Electric Air Pump Secondary Failure
A/C Refrigerant Temperature Circuit Low
A/C Refrigerant Temperature Circuit High
A/C Refrigerant Temperature Circuit Range/Performance
A/C Evaporator Air Temperature Circuit Low
A/C Evaporator Air Temperature Circuit High
A/C Evaporator Air Temperature Circuit Range/Performance
Floor Temperature Switch Circuit Malfunction
Purge Valve Stuck Open
Evaporative Emission (EVAP) System Flow During Non-Purge Chevrolet Only
Evaporative Emission Control System Leak Detected
Evaporative Emission Control System Control Valve
Purge Flow Sensor Circuit Low Input
Purge Flow Sensor Circuit High Input
Evaporative Vac Solenoid Circuit Malfunction
ELC System Closure Valve Flow Fault
ELC System 2 Fault
Evaporative Check Solenoid Circuit Malfunction
Unable To Bleed Up Fuel Tank Vacuum
Evap Emission Control Sys Vent Control Valve Circuit
Unable To Bleed - Up Vacuum in Tank
Fuel Tank Pressure Relief Valve Malfunction
Evaporative System Vacuum Test Malfunction
Evap Emission Control Sys Leak Detected (Gross Leak/No Flow)
Fuel Tank Temperature Sensor Circuit Malfunction
Unable To Pull Vacuum In Tank
Wide open throttle A/C cutoff relay circuit
A/C pressure sensor circuit voltage low
A/C pressure sensor circuit voltage high
A/C Pressure Sensor Insufficient Pressure Change
A/C Demand Out of Self Test Range
A/C Relay Circuit Malfunction
A/C Refrigerant Temperature Sensor/Circuit Malfunction
A/C Compressor Temperature Sensor Malfunction
SSPOD Open Circuit or Closed Circuit Fault
Low A/C Cycling Period
A/C Cycling Period Too Short
Electrodrive Fan 1 Operational Failure (Driver Side)
Electrodrive Fan 2 Operational Failure (Passenger Side)
Fan Secondary High With Fan(s) Off
Low Fan Control Primary Circuit Malfunction
Fan Relay (Low) Circuit Malfunction
Fan Relay (High) Circuit Malfunction
22
PowerScan Series
1477
1478
1479
1480
1481
1482
1483
1484
1485
1486
1487
1490
1491
1492
1493
1494
1495
1500
1501
1502
1503
1504
1505
1506
1507
1508
1509
1510
1511
1512
1513
1514
1515
1516
1517
1518
1519
1520
1521
1522
1523
1524
1525
1526
1527
1528
1529
1530
OBD II / EOBD II /CAN
Additional Fan Relay Circuit Malfunction
Cooling Fan Driver Fault
High Fan Control Primary Circuit Malfunction
Fan Secondary Low with Low Fan On
Fan Secondary Low With High Fan On
SCP
Power To Fan Circuit Overcurrent
Open Power To Ground VCRM
EGRV Circuit Malfunction
EGRA Circuit Malfunction
EGRCHK Solenoid Circuit Malfunction
Secondary Air Relief Solenoid Circuit Malfunction
Secondary Switch Solenoid Circuit Malfunction
APLSOL Solenoid Circuit Malfunction
RCNT Solenoid Circuit Malfunction
SPCUT Solenoid Circuit Malfunction
TCSPL Solenoid Circuit Malfunction
Vehicle Speed Sensor Intermittent
Vehicle Speed Sensor Out Of Self Test Range
Vehicle Speed Sensor Intermittent Malfunction
Auxillary Speed Sensor Fault
Idle Air Control Circuit Malfunction
Idle Air Control System At Adaptive Clip
Idle Air Control Overspeed Error
Idle Air Control Underspeed Error
Idle Control System Circuit Open
Idle Control System Circuit Shorted
Idle Signal Circuit Malfunction
Idle Switch (Electric Control Throttle) Circuit Malfunction
Intake Manifold Runner Control (Bank 1) Stuck Closed
Intake Manifold Runner Control (Bank 2) Stuck Closed
High Load Neutral/Drive Fault
Electric Current Circuit Malfunction
IMRC Input Error (Bank 1)
IMRC Input Error (Bank 2)
Intake Manifold Runner Control (Stuck Open)
Intake Manifold Runner Control (Stuck Closed)
Intake Manifold Runner Control Circuit Malfunction
Variable Intake Solenoid #1 Circuit Malfunction
Variable Intake Solenoid #2 Circuit Malfunction
IVC Solenoid Circuit Malfunction
Variable Intake Solenoid System
Air Bypass Valve System
Air Bypass System
Accelerate Warmup Solenoid Circuit Malfunction
Subsidiary Throttle Valve Solenoid Circuit Malfunction
SCAIR Solenoid Circuit Malfunction
A/C Clutch Circuit Malfunction
23
PowerScan Series
1531
1532
1533
1534
1535
1536
1537
1538
1539
1540
1549
1550
1565
1566
1567
1568
1571
1572
1573
1574
1575
1576
1577
1578
1579
1580
1581
1582
1583
1584
1585
1586
1587
1588
1589
1600
1601
1602
1603
1604
1605
1606
1607
1608
1609
1610
1611
1612
OBD II / EOBD II /CAN
Invalid Test - Accelerator Pedal Movement
IMCC Circuit Malfunction, Bank B
AAI Circuit Malfunction
Inertia Switch Activated
Blower Fan Speed Circuit Range/Performance
Parking Brake Switch Circuit Failure
Intake Manifold Runner Control (Bank 1) Stuck Open
Intake Manifold Runner Control (Bank 2) Stuck Open
Power To A/C Clutch Circuit Overcurrent
Air Bypass Valve Circuit Malfunction
IMCC Circuit Malfunction, Bank B
PSPS Out Of Self Test Range
Speed Control Command Switch Out of Range High
Speed Control Command Switch Out of Range Low
Speed Control Output Circuit Continuity
Speed Control Unable to Hold Speed
Brake Switch Malfunction
Brake Pedal Switch Circuit Malfunction
Throttle Position Not Available
Throttle Position Sensor Disagreement btwn Sensors
Pedal Position Out of Self Test Range
Pedal Position Not Available
Pedal Position Sensor Disagreement btwn Sensors
ETC Power Less Than Demand
ETC In Power Limiting Mode
Electronic Throttle Monitor PCM Override
Electronic Throttle Monitor Malfunction
Electronic Throttle Monitor Data Available
Electronic Throttle Monitor Cruise Disable
TCU Detected IPE Circuit Malfunction
Throttle Control Unit Malfunction
Throttle Control Unit Throttle Position Malfunction
Throttle Control Unit Modulated Command Malfunction
Throttle Control Unit Detected Loss of Return Spring
TCU Unable To Control Desired Throttle Angle
Loss of KAM Power; Open Circuit
ECM/TCM Serial Communication Error
Immobilizer/ECM Communication Error
EEPROM Malfunction
Code Word Unregestered
Keep Alive Memory Test Failure
ECM Control Relay O/P Circuit Malfunction
MIL O/P Circuit Malfunction
Internal ECM Malfunction
Diagnostic Lamp Driver Fault
SBDS Interactive Codes
SBDS Interactive Codes
SBDS Interactive Codes
24
PowerScan Series
1613
1614
1615
1616
1617
1618
1619
1620
1621
1622
1623
1624
1625
1626
1627
1628
1629
1630
1631
1632
1633
1634
1635
1636
1637
1638
1639
1640
1641
1642
1643
1644
1645
1650
1651
1652
1653
1654
1655
1660
1661
1662
1663
1667
1668
1670
OBD II / EOBD II /CAN
SBDS Interactive Codes
SBDS Interactive Codes
SBDS Interactive Codes
SBDS Interactive Codes
SBDS Interactive Codes
SBDS Interactive Codes
SBDS Interactive Codes
SBDS Interactive Codes
Control Module Long Term Memory Performance/ Immobilizer Code Words Do Not
Match
Immobilizer ID Does Not Match
Immobilizer Code Word/ID Number Write Failure
Anti Theft System
B+ Supply To VCRM Fan Circuit Malfunction
Theft Deterrent Fuel Enable Signal Not Received/ B+ Supply To VCRM A/C Circuit
Malfunction
Module Supply Voltage Out Of Range
Module Ignition Supply Input Malfunction
Internal Voltage Regulator Malfunction
Internal Vref Malfunction
Theft Deterrent Start Enable Signal Not Correct/ Main Relay Malfunction (Power Hold)
Smart Alternator Faults Sensor/Circuit Malfunction
KAM Voltage Too Low
Data Output Link Circuit Failure
Tire / Axle Ratio Out of Acceptable Range
Inductive Signature Chip Communication Error
Can Link ECM/ABSCM Circuit / Network Malfunction
Can Link ECM/INSTM Circuit / Network Malfunction
Vehicle ID Block Corrupted or Not Programmed
Powertrain DTCs Available in Another Module
Fuel Pump Primary Circuit Failure
Fuel Pump Monitor Circuit High Input
Fuel Pump Monitor Circuit Low Input
Fuel Pump Speed Control Circuit Malfunction
Fuel Pump Resistor Switch Circuit Malfunction
PSP Switch Out of Self Test Range
PSP Switch Input Malfunction
IAC Monitor Disabled by PSP Switch Failed On
Power Steering Output Circuit Malfunction
Recirculation Override Circuit Malfunction
Starter Disable Circuit Malfunction
Output Circuit Check Signal High
Output Circuit Check Signal Low
IDM_EN Circuit Failure
Fuel Demand Command Signal Circuit Malfunction
CI Circuit Malfunction
PCM - IDM Communications Error
Electronic Feedback Signal Not Detected
25
PowerScan Series
1680
1681
1682
1683
1684
1685
1686
1687
1688
1689
1690
1691
1692
1693
1694
1700
1701
1702
1703
1704
1705
1706
1707
1708
1709
1711
1712
1713
1714
1715
1716
1717
1718
1720
1721
1722
1723
1724
1725
1726
1727
1728
1729
1730
1731
1732
1733
1734
OBD II / EOBD II /CAN
Metering Oil Pump Malfunction
Metering Oil Pump Malfunction
Metering Oil Pump Malfunction
Metering Oil Pump Temperature Sensor Circuit Malfunction
Metering Oil Pump Position Sensor Circuit Malfunction
Metering Oil Pump Stepping Motor Circuit Malfunction
Metering Oil Pump Stepping Motor Circuit Malfunction
Metering Oil Pump Stepping Motor Circuit Malfunction
Metering Oil Pump Stepping Motor Circuit Malfunction
Oil Pressure Control Solenoid Circuit Malfunction
Wastegate Solenoid Circuit Malfunction
Turbo Pressure Control Solenoid Circuit Malfunction
Turbo Control Solenoid Circuit Malfunction
Turbo Charge Control Circuit Malfunction
Turbo Charge Relief Circuit Malfunction
Transmission Indeterminate Failure (Failed to Neutral)
Reverse Engagement Error
TRS Circuit Intermittent Malfunction
Brake Switch Out Of Self Test Range
Digital TRS Failed to Transition States in KOEO / KOER
Not in P or N During KOEO / KOER
High Vehicle Speed Observed in Park
Transfer Case Neutral Indicator Hard Fault Present
Clutch Switch Circuit Malfunction
PNP Switch Out Of Self Test Range
TFT Sensor Out Of Self Test Range
Trans Torque Reduction Request Signal Malfunction
TFT Sensor In Range Failure Low Value
SSA Inductive Signature Malfunction
SSB Inductive Signature Malfunction
SSC Inductive Signature Malfunction
SSD Inductive Signature Malfunction
TFT Sensor In Range Failure High
Vehicle Speed (Meter) Circuit Malfunction
Gear 1 Incorrect Ratio
Gear 2 Incorrect Ratio
Gear 3 incorrect Ratio
Gear 4 Incorrect Ratio
Insufficient Engine Speed Increase During Self Test
Insufficient Engine Speed Decrease During Self Test
Coast Clutch Solenoid Inductive Signature Malfunction
Transmission Slip Error
4x4 Low Switch Error
Gear Control Malfunction 2,3,5
1-2 Shift Malfunction
2-3 Shift Malfunction
3-4 Shift Malfunction
Gear Control Malfunction
26
PowerScan Series
1735
1736
1737
1738
1739
1740
1741
1742
1743
1744
1745
1746
1747
1748
1749
1751
1754
1755
1756
1760
1761
1762
1765
1767
1768
1769
1770
1775
1776
1777
1778
1779
1780
1781
1782
1783
1784
1785
1786
1787
1788
1789
1790
1791
1792
1793
1794
1795
OBD II / EOBD II /CAN
First Gear Switch Circuit Malfunction
Second Gear Switch Circuit Malfunction
Lockup Solenoid System
Shift Time Error
Slip Solenoid System
Torque Converter Clutch Inductive Signature Malfunction
Torque Converter Clutch Control Error
Torque Converter Clutch Solenoid Failed On
Torque Converter Clutch Solenoid Failied On
Torque Converter Clutch System Performance
Line Pressure Solenoid System
Pressure Control Solenoid A Open Circuit
Pressure Control Solenoid A Short Circuit
EPC Malfunction
Pressure Control Solenoid Failed Low
Shift Solenoid A Performance
Coast Clutch Solenoid Circuit Malfunction
Intermediate Speed Sensor (ISS) Malfunction
Shift Solenoid B Performance
Pressure Control Solenoid A Short Circuit
Shift Solenoid C Performance
Overdrive Band Failed Off
Timing Solenoid Circuit Malfunction
Torque Converter Clutch Circuit Malfunction
Performance / Normal / Winter Mode Input Malfunction
AG4 Transmission Torque Modulation Fault
Clutch Solenoid Circuit Malfunction
Transmission System MIL Fault
Ignition Retard Request Duration Fault
Ignition Retard Request Circuit Fault
Transmission Reverse I/P Circuit Malfunction
TCIL Circuit Malfunction
Trans Control Switch (O/D Cancel) Out of Self Test Range
4X4 Switch Out of Self Test Range
P/ES Circuit Out Of Self Test Range
Transmission Overtemperature Condition
Transmission Mechanical Failure - First And Reverse
Transmission Mechanical Failure - First And Second
3-2 Downshift Error
2-1 Downshift Error
Pressure Control Solenoid B Open Circuit
Pressure Control Solenoid B Short Circuit
TP (Mechanical) Circuit Malfunction
TP (Electric) Circuit Malfunction
Barometer Pressure Circuit Malfunction
Intake Air Volume Circuit Malfunction
Battery Voltage Circuit Malfunction
Idle Switch Circuit Malfunction
27
PowerScan Series
1796
1797
1798
1799
1800
1801
1802
1803
1804
1805
1806
1807
1808
1809
1810
1811
1812
1813
1814
1815
1816
1817
1818
1819
1820
1821
1822
1823
1824
1825
1826
1827
1828
1829
1830
1831
1832
1833
1834
1835
1836
1837
1838
1839
1840
1841
1842
OBD II / EOBD II /CAN
Kick Down Switch Circuit Malfunction
Neutral Switch Circuit Malfunction
Coolant Temperature Circuit Malfunction
Hold Switch Circuit Malfunction
Transmission Clutch Interlock Safety Switch Circuit Failure
Transmission Clutch Interlock Safety Switch Open Circuit
Transmission Clutch Interlock Safety Switch Short Circuit To Battery
Transmission Clutch Interlock Safety Switch Short Circuit To Ground
Transmission 4-Wheel Drive High Indicator Circuit Failure
Transmission 4-Wheel Drive High Indicator Open Circuit
Transmission 4-Wheel Drive High Indicator Short Circuit To Battery
Transmission 4-Wheel Drive High Indicator Short Circuit To Ground
Transmission 4-Wheel Drive Low Indicator Circuit Failure
Transmission 4-Wheel Drive Low Indicator Open Circuit
TFP Valve Position Switch Circuit/ Transmission 4-Wheel Drive Low Indicator Short Circuit
To Battery
Transmission 4-Wheel Drive Low Indicator Short Circuit To Ground
Transmission 4-Wheel Drive Mode Select Circuit Failure
Transmission 4-Wheel Drive Mode Select Open Circuit
Transmission 4-Wheel Drive Mode Select Short Circuit To Battery
Transmission 4-Wheel Drive Mode Select Short Circuit To Ground
Transmission Neutral Safety Switch Circuit Failure
Transmission Neutral Safety Switch Open Circuit
Transmission Neutral Safety Switch Short Circuit To Battery
Transmission Neutral Safety Switch Short Circuit To Ground
Transmission Transfer Case Clockwise Shift Relay Coil Circuit Failure
Transmission Transfer Case Clockwise Shift Relay Coil Open Circuit
Transmission Transfer Case Clockwise Shift Relay Coil Short Circuit To Battery
Transmission Transfer Case Clockwise Shift Relay Coil Short Circuit To Ground
Transmission 4-Wheel Drive Clutch Relay Circuit Failure
Transmission 4-Wheel Drive Clutch Relay Open Circuit
Transmission 4-Wheel Drive Low Clutch Relay Circuit To Battery
Transmission 4-Wheel Drive Low Clutch Relay Circuit To Ground
Transmission Transfer Case Counter Clockwise Shift Relay Coil Circuit Failure
Transmission Transfer Case Counter Clockwise Shift Relay Coil Open Circuit
Transmission Transfer Case Counter Clockwise Shift Relay Coil Short Circuit To Battery
Transmission Transfer Case Counter Clockwise Shift Relay Coil Short Circuit To Ground
Transmission Transfer Case Differential Lock-Up Solenoid Circuit Failure
Transmission Transfer Case Differential Lock-Up Solenoid Open Circuit
Transmission Transfer Case Differential Lock-Up Solenoid Short Circuit To Battery
Transmission Transfer Case Differential Lock-Up Solenoid Short Circuit To Ground
Transmission Transfer Case Front Shaft Speed Sensor Circuit Failure
Transmission Transfer Case Rear Shaft Speed Sensor Circuit Failure
Transmission Transfer Case Shift Motor Circuit Failure
Transmission Transfer Case Shift Motor Open Circuit
Transmission Transfer Case Shift Motor Short Circuit To Battery
Transmission Transfer Case Shift Motor Short Circuit To Ground
Transmission Transfer Case Differential Lock-Up Feedback Switch Circuit Failure
28
PowerScan Series
OBD II / EOBD II /CAN
1843 Transmission Transfer Case Differential Lock-Up Feedback Switch Open Circuit
1844 Transmission Transfer Case Differential Lock-Up Feedback Switch Short Circuit To
Battery
1845 Transmission Transfer Case Differential Lock-Up Feedback Switch Short Circuit To
Ground
1846 Transmission Transfer Case Contact Plate 'A' Circuit Failure
1847 Transmission Transfer Case Contact Plate 'A' Open Circuit
1848 Transmission Transfer Case Contact Plate 'A' Short Circuit To Battery
1849 Transmission Transfer Case Contact Plate 'A' Short Circuit To Ground
1850 Transmission Transfer Case Contact Plate 'B' Circuit Failure
1851 Transmission Transfer Case Contact Plate 'B' Open Circuit
1852 Transmission Transfer Case Contact Plate 'B' Short Circuit To Battery
1853 Transmission Transfer Case Contact Plate 'B' Short Circuit To Ground
1854 Transmission Transfer Case Contact Plate 'C' Circuit Failure
1855 Transmission Transfer Case Contact Plate 'C' Open Circuit
1856 Transmission Transfer Case Contact Plate 'C' Short Circuit To Battery
1857 Transmission Transfer Case Contact Plate 'C' Short Circuit To Ground
1858 Transmission Transfer Case Contact Plate 'D' Circuit Failure
1859 Transmission Transfer Case Contact Plate 'D' Open Circuit
1860 TCC PWM Solenoid Circuit Electrical/ Transmission Transfer Case Contact Plate 'D' Short
Circuit To Battery
1861 Transmission Transfer Case Contact Plate 'D' Short Circuit To Ground
1862 Transmission Transfer Case Contact Plate Power Circuit Failure
1863 Transmission Transfer Case Contact Plate Power Open Circuit
1864 Transmission Transfer Case Contact Plate Power Short To Battery
1865 Transmission Transfer Case Contact Plate Power Short To Ground
1866 Transmission Transfer Case System Concern - Servicing Required
1867 Transmission Transfer Case Contact Plate General Circuit Failure
1868 Transmission Automatic 4-Wheel Drive Indicator (Lamp) Circuit Failure
1869 Transmission Automatic 4-Wheel Drive Indicator (Lamp) Circuit Short To Battery
1870 Transmission Component Slipping/ Transmission Mechanical Transfer Case 4x4 Switch
Circuit Failure
1871 Transmission Mechanical Transfer Case 4x4 Switch Circuit Short To Battery
1872 Transmission Mechanical 4-Wheel Drive Axle Lock Lamp Circuit Failure
1873 Transmission Mechanical 4-Wheel Drive Axle Lock Lamp Circuit Short To Battery
1874 Transmission Automatic Hall Effect Sensor Power Circuit Failure
1875 Transmission Automatic Hall Effect Sensor Power Circuit Short To Battery / 4WD Low
Switch Circuit Electrical
1876 Transmission Transfer Case 2-Wheel Drive Solenoid Circuit Failure
1877 Transmission Transfer Case 2-Wheel Drive Solenoid Circuit Short To Battery
1878 Transmission Transfer Case Disengaged Solenoid Circuit Failure
1879 Transmission Transfer Case Disengaged Solenoid Open Circuit
1880 Transmission Transfer Case Disengaged Solenoid Short to Battery
1881 Engine Coolant Level Switch Circuit Failure, GEM
1882 Engine Coolant Level Switch Circuit Short to Ground
1883 Engine Coolant Level Switch Circuit Failure, GEM
1890 Transmission 4WD Mode Select Return Input Circuit Failure
1891 Transmission Transfer Case Contact Plate Ground Return Open Circuit
1900 OSS Circuit Intermittent Malfunction
29
PowerScan Series
1901
1902
1903
1904
1905
1906
1907
1908
1909
1910
1911
1912
1913
1914
1915
1916
1917
1918
5091
5095
5096
5097
5098
5100
5101
5102
5103
5104
5105
5106
5107
5109
5110
5111
5112
5113
5114
5115
5116
5117
5123
5124
5125
5126
5127
5132
5133
5134
OBD II / EOBD II /CAN
TSS Circuit Intermittent Malfunction
Pressure Control Solenoid B Intermittent Short
Pressure Control Solenoid C Short Circuit
Pressure Control Solenoid C Open Circuit
Pressure Control Solenoid C Intermittent Short
Kickdown Pull Relay Open or Short Circuit to Ground
Kickdown Hold Relay Open or Short Circuit to Ground
Transmission Pressure Circuit Solenoid Open or Short to Ground
Trans Temp Sensor Circuit Open or Shorted to Pwr or Gnd
VFS A Pressure Output Failed LOW
VFS B Pressure Output Failed LOW
VFS C Pressure Output Failed LOW
Pressure Switch A Circuit Malfunction
Manually Shifted Automatic (MSA) Sw Circuit Malf
Reverse Switch Circuit Malfunction
High Clutch Drum Speed Sensor Malfunction
High Clutch Drum Speed Sensor Intermittent
Transmission Range Display Circuit Malfunction
Speed Wheel Sensor All Coherency Failure
ABS Hydraulic Pump Motor Circuit Failure
ABS Hydraulic Pump Motor Circuit Open
ABS Hydraulic Pump Motor Circuit Short To Ground
ABS Hydraulic Pump Motor Circuit Short To Battery
ABS Pump Switch Circuit Failure
ABS Hydraulic Valve Circuit Failure
ABS Acceleration Switch Circuit Failure
ABS Hydraulic Brake Switch Circuit Failure
Traction Control Active Lamp - Circuit Short to Battery
Traction Control Disable Lamp - Circuit Short to Battery
Traction Control Disable Switch Circuit Short to Battery
ABS Function Enabled Input Circuit Failure
Speed Control Actuator Assembly Cable Release Failure
ABS Power Relay Coil Circuit Failure
ABS Power Relay Coil Open Circuit
ABS Power Relay Coil Short Circuit To Ground
ABS Power Relay Coil Short Circuit To Battery
ABS Power Relay Output Short Circuit To Ground
ABS Power Relay Output Short Circuit To Battery
Starter Motor Circuit Failure
RPM Input Circuit Failure
Vehicle Speed Sensor Input Short to Battery
Input shaft speed signal missing/faulted
Brake Fluid Level Sensor Input Circuit Failure
Cruise Control Command Switch Assembly Circuit Failure
Cruise Control Deactivator Brake Switch Circuit Failure
Clutch position ckt short to ground
Clutch position ckt short to battery
Gear Shift position short to ground
30
PowerScan Series
5135
5136
5137
5138
5139
5140
5141
5142
5143
5144
5145
5146
5148
5149
5150
5155
5156
5157
5158
5159
5161
5162
5163
5164
5165
5166
5167
5168
5169
5170
5172
5173
5174
5175
5176
5177
5178
5179
5180
5181
5182
5183
5184
5185
5186
5187
5188
5189
OBD II / EOBD II /CAN
Gear Shift position short to battery
Gear Select position short to ground
ECU is Defective
Gear Select position short to Battery
Wheel Speed Sensor Center Tone Ring Missing Tooth Fault
Hydraulic Base Brake Failure
Wheel Speed Sensor LF Tone Ring Tooth Missing Fault
Wheel Speed Sensor RF Tone Ring Tooth Missing Fault
Wheel Speed Sensor LR Tone Ring Tooth Missing Fault
Wheel Speed Sensor RR Tone Ring Tooth Missing Fault
Speed Wheel Sensor RF Input Circuit Failure
Speed Wheel Sensor RF Circuit Open
Speed Wheel Sensor RF Coherency Fault
Hydraulic Fluid Pressure/ Flow Circuit Failure
Two Speed Rear Axle Input Switch Circuit Short to Vbatt
Speed Wheel Sensor LF Input Circuit Failure
Speed Wheel Sensor LF Circuit Open
Park Brake Actuator Assembly Switch Applied Circuit Failure
Speed Wheel Sensor LF Coherency Fault
Hydraulic Fluid Pressure/ Flow Circuit Short to Gnd
Air Pressure Low Circuit Short to Gnd
Park Brake Switch # 2 Released Circuit Failure
Park Brake Switch # 2 Applied Circuit Short to Gnd
Park Brake Actuator Assembly Switch Circuit Failure
Speed Wheel Sensor RR Input Circuit Failure
Speed Wheel Sensor RR Input Open Circuit
Park Brake Actuator Assembly Switch Released Circuit Short to Gnd
Speed Wheel Sensor RR Coherency Fault
ABS Fluid Dumping Exceeds Maximum Timing
PRNDL Switch Circuit Failure
Park Brake Switch # 1 Applied Circuit Failure
Park Brake Switch # 1 Released Circuit Short to Gnd
Park Brake Switch # 2 Applied Circuit Failure
Speed Wheel Sensor LR Input Circuit Failure
Speed Wheel Sensor LR Circuit Open
Park Brake Actuator Assembly Switch Released Circuit Failure
Speed Wheel Sensor LR Coherency Fault
Speed Control Actuator Assembly Cable Slack Failure
Park Brake Valve Solenoid #1 Sense Input Circuit Failure
Park Brake Valve Solenoid #1 Sense Input Circuit Short to Gound
Park Lamp Flash Relay Circuit Failure
Park Lamp Flash Relay Circuit Short to Battery
ABS System Is Not Operational
ABS Power Relay Output Circuit Failure
ABS Power Relay Output Open Circuit
Brake Fluid Level Sensor Input Open Circuit
Brake Fluid Level Sensor Input Short Circuit To Battery
Brake Fluid Level Sensor Input Short Circuit To Ground
31
PowerScan Series
5190
5191
5192
5193
5194
5195
5196
5197
5198
5199
5200
5201
5202
5203
5204
5205
5206
5207
5208
5209
5210
5211
5212
5213
5214
5215
5216
5217
5218
5219
5220
5221
5222
5223
5224
5225
5226
5227
5228
5229
5230
5231
5232
5233
5234
5235
5236
5237
OBD II / EOBD II /CAN
Speed Wheel Sensor LF Input Short Circuit To Battery
Speed Wheel Sensor LF Input Short Circuit To Ground
Speed Wheel Sensor RF Input Short Circuit To Battery
Speed Wheel Sensor RF Input Short Circuit To Ground
ABS Outlet Valve Coil LF Circuit Failure
ABS Outlet Valve Coil LF Circuit Open
ABS Outlet Valve Coil LF Circuit Short To Battery
ABS Outlet Valve Coil LF Circuit Short To Ground
ABS Inlet Valve Coil LF Circuit Failure
ABS Inlet Valve Coil LF Circuit Open
ABS Inlet Valve Coil LF Circuit Short To Battery
ABS Inlet Valve Coil LF Circuit Short To Ground
ABS Outlet Valve Coil Rear Circuit Failure
ABS Outlet Valve Coil Rear Circuit Open
ABS Outlet Valve Coil Rear Circuit Short To Battery
ABS Outlet Valve Coil Rear Circuit Short To Ground
ABS Inlet Valve Coil Rear Circuit Failure
ABS Inlet Valve Coil Rear Circuit Open
ABS Inlet Valve Coil Rear Circuit Short To Battery
ABS Inlet Valve Coil Rear Circuit Short To Ground
ABS Outlet Valve Coil RF Circuit Failure
ABS Outlet Valve Coil RF Circuit Open
ABS Outlet Valve Coil RF Circuit Short To Battery
ABS Outlet Valve Coil RF Circuit Short To Ground
ABS Inlet Valve Coil RF Circuit Failure
ABS Inlet Valve Coil RF Circuit Open
ABS Inlet Valve Coil RF Circuit Short To Battery
ABS Inlet Valve Coil RF Circuit Short To Ground
Lamp ABS Warning Output Circuit Failure
Lamp ABS Warning Output Circuit Open
Lamp ABS Warning Output Circuit Short To Battery
Lamp ABS Warning Output Circuit Short To Ground
Speed Wheel Mismatch
Lamp Brake Warning Output Circuit Failure
Lamp Brake Warning Output Circuit Open
Lamp Brake Warning Output Circuit Short To Battery
Lamp Brake Warning Output Circuit Short To Ground
Speed Wheel Sensor LR Input Short Circuit To Battery
Speed Wheel Sensor LR Input Short Circuit To Ground
Speed Wheel Sensor Rear Center Coherency Fault
Speed Wheel Sensor Rear Center Input Circuit Failure
Speed Wheel Sensor Rear Center Circuit Open
Speed Wheel Sensor Rear Center Input Short Circuit To Battery
Speed Wheel LF Input Signal Missing
Speed Wheel RF Input Signal Missing
Speed Wheel RR Input Signal Missing
Speed Wheel LR Input Signal Missing
Speed Wheel Rear Input Signal Missing
32
PowerScan Series
5238
5239
5240
5241
5242
5243
5244
5245
5246
5247
5248
5249
5250
5251
5252
5253
5254
5255
5256
5257
5258
5259
5260
5261
5262
5263
5264
5265
5266
5267
5268
5269
5270
5271
5272
5273
5274
5275
5276
5277
5278
5279
5280
5281
5282
5283
5284
5285
OBD II / EOBD II /CAN
ABS Hydraulic Pressure Differential Switch Input Circuit Failure
ABS Hydraulic Pressure Differential Switch Input Open Circuit
ABS Hydraulic Pressure Differential Switch Input Short Circuit To Battery
ABS Hydraulic Pressure Differential Switch Input Short Circuit To Ground
ABS Outlet Valve Coil LR Circuit Failure
ABS Outlet Valve Coil LR Circuit Open
ABS Outlet Valve Coil LR Circuit Short To Battery
ABS Outlet Valve Coil LR Circuit Short To Ground
ABS Outlet Valve Coil RR Circuit Failure
ABS Outlet Valve Coil RR Circuit Open
ABS Outlet Valve Coil RR Circuit Short To Battery
ABS Outlet Valve Coil RR Circuit Short To Ground
ABS Inlet Valve Coil LR Circuit Failure
ABS Inlet Valve Coil LR Circuit Open
ABS Inlet Valve Coil LR Circuit Short To Battery
ABS Inlet Valve Coil LR Circuit Short To Ground
ABS Inlet Valve Coil RR Circuit Failure
ABS Inlet Valve Coil RR Circuit Open
ABS Inlet Valve Coil RR Circuit Short To Battery
ABS Inlet Valve Coil RR Circuit Short To Ground
Speed Wheel LF Comparison Failure
Speed Wheel RF Comparison Failure
Speed Wheel RR Comparison Failure
Speed Wheel LR Comparison Failure
Lamp Warning Relay Circuit Failure
Lamp Warning Relay Circuit Open
Lamp Warning Relay Circuit Short To Battery
Lamp Warning Relay Circuit Short To Ground
ABS Valve Power Relay Circuit Failure
ABS Functions Temporarily Disabled
Motor Relay # 1 Circuit Failure
Motor Relay # 1 Circuit Short to Battery
Motor # 1 Input Circuit Failure
Motor # 1 Input Circuit Short to Gnd
Motor # 2 Input Circuit Failure
Motor # 2 Input Circuit Short to Vbat
Solenoid Relay # 1 Circuit Failure
Solenoid Relay # 1 Circuit Short to Vbatt
Park Brake Actuator Assembly Switch Applied Circuit Short to Gnd
STEERING Wheel Angle 1and 2 Circuit Failure
STEERING Wheel Angle 1and 2 Signal Faulted
Yaw Rate Sensor circuit Failure
Yaw Rate Sensor Signal Fault
Lateral Accelerometer circuit Failure
Lateral Accelerometer Signal Fault
Switch Test Signal Failure
Oil Pressure Switch Failure
Booster Solenoid circuit Failure
33
PowerScan Series
5286
5287
5288
5289
5400
5401
5402
5403
5404
5405
5406
5407
5410
5411
5412
5413
5414
5415
5416
5417
5418
5419
5420
5421
5422
5423
5424
5425
5426
5427
5428
5429
5430
5431
5432
5433
5435
5436
5437
5438
5439
5440
5441
5442
5443
5444
5445
5446
OBD II / EOBD II /CAN
Booster Mechanical Failure
Booster Pedal Force switch circuit Failure
Pressure Transducer Main / Primary Input Circuit Failure
Pressure Transducer Redundant / Secondary Input Circuit Failure
Traction Control Valve RF Circuit Failure
Traction Control Valve RF Circuit Open
Traction Control Valve RF Circuit Short To Ground
Traction Control Valve RF Circuit Short To Battery
Traction Control Valve Rear Circuit Failure
Traction Control Valve Rear Circuit Open
Traction Control Valve Rear Circuit Short To Ground
Traction Control Valve Rear Circuit Short To Battery
Traction Control Valve LF Circuit Failure
Traction Control Valve LF Circuit Open
Traction Control Valve LF Circuit Short To Ground
Traction Control Valve LF Circuit Short To Battery
Incorrect Module Design Level
Incorrect Module Configuration
Damper RF Circuit Short To Battery
Damper RF Circuit Short to Ground
Damper RF Circuit Failure
Damper RF Circuit Open
Hydraulic Fluid Pressure/ Flow Circuit Short to Vbatt
Damper LF Circuit Short To Battery
Damper LF Circuit Short to Ground
Damper LF Circuit Failure
Damper LF Circuit Open
Damper RR Circuit Short to Ground
Damper RR Circuit Short To Battery
Damper RR Circuit Open
Damper RR Circuit Failure
Input-shaft-speed input circuit failure
Damper LR Circuit Open
Damper LR Circuit Short To Battery
Damper LR Circuit Short to Ground
Damper LR Circuit Failure
Accelerometer Rear Circuit Failure
Accelerometer Rear Circuit Signal Is Not Sensed
Accelerometer Rear Circuit Short To Ground
Accelerometer Rear Circuit Short To Battery
Vehicle Acceleration EEC-IV Circuit Failure
Pressure Transducer Main / Primary signal Faulted
Steering Phase A Circuit Signal Is Not Sensed
Steering Phase B Circuit Signal Is Not Sensed
Steering Phase A Circuit Short To Ground
Steering Phase B Circuit Short To Ground
Speed Vehicle Signal Circuit Failure
Brake Switch Circuit Failure
34
PowerScan Series
5447
5448
5449
5450
5451
5452
5453
5454
5455
5456
5457
5458
5459
5460
5461
5462
5463
5464
5465
5466
5467
5468
5469
5495
5496
5497
5498
5499
5500
5501
5502
5503
5504
5505
5506
5507
5508
5510
5511
5512
5513
5699
5700
5701
5702
5703
5704
5705
OBD II / EOBD II /CAN
Traction Control Module Request Circuit Failure
Lamp Adaptive Damping Warning Circuit Failure
Traction Control Motor Coherency Fault
Traction Control Motor Circuit Failure
Traction Control Motor Circuit Open
Traction Control Motor Circuit Short to Battery
Traction Control Motor Circuit Short to Ground
Front Lateral Accelerometer Circuit Failure
Accelerometer Front Circuit Failure
Accelerometer Front Circuit Is Not Sensed
Accelerometer Front Circuit Short To Ground
Accelerometer Front Circuit Short To Battery
Adaptive Mode Switch Circuit Failure
Vehicle Accelerometer Power Circuit Failure
Vehicle Accelerometer Power Circuit Short to Battery
Left Front Vertical Accelerometer Circuit Failure
Right Front Vertical Accelerometer Circuit Failure
Pressure Transducer Redundant / Secondary Signal Faulted
Damper High Side Front Circuit Short To Battery
Damper Circuit Failure
Damper High Side Rear Circuit Short To Battery
Damper Low Side Front Circuit Failure
Damper Low Side Rear Circuit Failure
Traction Control Motor Potentiometer Circuit Failure
Traction Control Motor Potentiometer Circuit Open
Traction Control Motor Potentiometer Circuit Short to Battery
Traction Control Motor Potentiometer Circuit Short to Ground
Transfer Case Contact Plate A Encoder Circuit Failure
Transfer Case Contact Plate B Encoder Circuit Failure
Transfer Case Contact Plate C Encoder Circuit Failure
Transfer Case Contact Plate D Encoder Circuit Failure
Dynamic Stability Control Left Front Valve Malfunction
Dynamic Stability Control Right Front Valve Malfunction
Dynamic Stability Control Left Rear Valve Malfunction
Dynamic Stability Control Right Rear Valve Malfunction
Traction Control of Brake Exceeds Time-Out
Traction Control of Engine Exceeds Time-Out
Right Front Wheel Pressure Reduction Performance Problem
Left Front Wheel Pressure Reduction Performance Problem
Right Rear Wheel Pressure Reduction Performance Problem
Left rear Wheel Pressure Reduction Performance Problem
Left Rear Sensor Circuit Short to Vbat
Left Rear Sensor Circuit Failure
Left Rear Sensor Circuit Fault
RightRear Sensor Circuit Short to Vbat
Right Rear Sensor Circuit Failure
Right Rear Sensor Circuit Fault
Left Rear Center Sensor Circuit Short to Vbat
35
PowerScan Series
5706
5707
5708
5709
5710
5711
5712
5713
5714
5715
5716
5717
5718
5719
5721
5722
5723
5724
5725
5726
5727
5728
5729
5730
5731
5732
5733
5734
5735
5736
5737
5738
5739
5740
5741
5742
5743
5744
5745
5748
5749
5750
5751
5752
5753
5754
5755
5756
OBD II / EOBD II /CAN
Left Rear Center Sensor Circuit Failure
Left Rear Center Sensor Circuit Fault
Right Rear Center Sensor Circuit Short to Vbat
Right Rear Center Sensor Circuit Failure
Right Rear Center Sensor Circuit Fault
Left Front Sensor Circuit Short to Vbat
Left Front Sensor Circuit Failure
Left Front Sensor Circuit Fault
Right Front Sensor Circuit Short to Vbat
Right Front Sensor Circuit Failure
Right Front Sensor Circuit Fault
Left Front Center Sensor Circuit Short to Vbat
Left Front Center Sensor Circuit Failure
Left Front Center Sensor Circuit Fault
Air Suspension Height Sensor Power Circuit Open
Air Suspension Height Sensor Power Circuit Short To Battery
Air Suspension Height Sensor Power Circuit Short To Ground
Air Suspension Height Sensor Power Circuit Failure
Air Suspension Front Pneumatic Failure
Air Suspension Rear Pneumatic Failure
Air Suspension Reservoir Pneumatic Failure
Transfer Case unable to transition between 2H and 4H
Transfer Case unable to transition between 4H and 4L
Reference Voltage Out of Range (+5 v)
Air Suspension LF Corner Up Timeout
Air Suspension LF Corner Down Timeout
Air Suspension RF Corner Up Timeout
Air Suspension RF Corner Down Timeout
Air Suspension LR Corner Up Timeout
Air Suspension LR Corner Down Timeout
Air Suspension RR Corner Up Timeout
Air Suspension RR Corner Down Timeout
Right Front Center Sensor Circuit Short to Vbat
Right Front Center Sensor Circuit Failure
Right Front Center Sensor Circuit Fault
Rear Sounder Circuit Failure
Rear Sounder Circuit Short to Vbatt
Front Sounder Circuit Failure
Front Sounder Circuit Short to Vbatt
Switch input Circuit Short to Gnd
Trailer Input Circuit Failure
Accelerator Position Sensor Out of Range
Vehicle Speed Sensor # 1 Output Circuit Short to Vbatt
Vehicle Speed Sensor # 1 Output Circuit Short to Gnd
Hydraulic Clutch Actuator Valve Signal Fault
Hydraulic Clutch Actuator Valve Circuit Failure
Power Limit Shutdown Fault
Air Suspension Front Height Sensor High (SE) Signal Circuit Failure
36
PowerScan Series
5757
5758
5759
5760
5761
5762
5763
5765
5766
5767
5768
5770
5771
5772
5773
5774
5775
5776
5777
5778
5779
5780
5781
5790
5791
5792
5793
5795
5796
5797
5798
5800
5805
5813
5814
5818
5819
5820
5830
5831
5832
5833
5834
5835
5836
5837
5838
5839
OBD II / EOBD II /CAN
Air Suspension Front Height Sensor High (SE) Signal Circuit Open
Air Suspension Front Height Sensor High (SE) Signal Circuit Short To Battery
Air Suspension Front Height Sensor High (SE) Signal Circuit Short To Ground
Air Suspension Rear Height Sensor High (SE) Signal Circuit Failure
Air Suspension Rear Height Sensor High (SE) Signal Circuit Open
Air Suspension Rear Height Sensor High (SE) Signal Circuit Short To Battery
Air Suspension Rear Height Sensor High (SE) Signal Circuit Short To Ground
Air Suspension Rear Height Sensor Low Signal Circuit Failure
Air Suspension Rear Height Sensor Low Signal Circuit Open
Air Suspension Rear Height Sensor Low Signal Circuit Short To Battery
Air Suspension Rear Height Sensor Low Signal Circuit Short To Ground
Air Suspension Vent Solenoid Output Circuit Failure
Air Suspension Vent Solenoid Output Circuit Open
Air Suspension Vent Solenoid Output Circuit Short To Battery
Air Suspension Vent Solenoid Output Circuit Short To Ground
Coolant Temp Out of Range
DC-DC Converter Failure
Heater System Failure
Vacuum Pressure Circuit Failure
Power Steering Failure
Blower Switch Failure
Temperature Select Failure
Engine Coolant Temperature Signal Missing/Fault
Air Suspension LR Air Spring/Shock Solenoid Output Circuit Failure
Air Suspension LR Air Spring/Shock Solenoid Output Circuit Open
Air Suspension LR Air Spring/Shock Solenoid Output Circuit Short To Battery
Air Suspension LR Air Spring/Shock Solenoid Output Circuit Short To Ground
Air Suspension RR Air Spring/Shock Solenoid Output Circuit Failure
Air Suspension RR Air Spring/Shock Solenoid Output Circuit Open
Air Suspension RR Air Spring/Shock Solenoid Output Circuit Short To Battery
Air Suspension RR Air Spring/Shock Solenoid Output Circuit Short To Ground
Air Suspension Reservoir Solenoid Circuit Failure
Mismatched PCM and/or ABS-TC Module
Air Suspension LR Vent Request Exceeded Max Timing
Air Suspension RR Vent Request Exceeded Max Timing
Air Suspension LR Air Compress Request Exceeded Max Timing
Air Suspension RR Air Compress Request Exceeded Max Timing
Air Suspension RF Air Compress Request Exceeded Max Timing
Air Suspension Compressor Relay Circuit Failure
Air Suspension Compressor Relay Circuit Open
Air Suspension Compressor Relay Circuit Short To Battery
Air Suspension Compressor Relay Circuit Short To Ground
Gauge Drive Current Fault
Current Sense Circuit Failure
Battery Temp out of Range
Battery Heater Circuit Failure
Charging System Fault
Leakage Fault
37
PowerScan Series
5840
5841
5842
5843
5844
5845
5846
5847
5848
5849
5850
5851
5852
5853
5854
5855
5856
5859
5860
5861
5862
5863
5864
5865
5866
5867
5868
5869
5870
5871
5872
5873
5874
5875
5876
5877
5878
5879
5880
5881
5882
5883
5884
5885
5886
5887
5888
5889
OBD II / EOBD II /CAN
Air Suspension Disable Switch Circuit Failure
Air Suspension Disable Switch Circuit Open
Air Suspension Disable Switch Circuit Short To Battery
Air Suspension Disable Switch Circuit Short To Ground
Air Suspension Secondary Front Inflator Solenoid Output Circuit Failure
Air Suspension Front Inflator Solenoid Output Circuit Failure
Air Suspension Front Inflator Solenoid Output Circuit Open
Air Suspension Front Inflator Solenoid Output Circuit Short To Battery
Air Suspension Front Inflator Solenoid Output Circuit Short To Ground
Master Cylinder Pressure Out of Range
Air Suspension Warning Lamp Circuit Failure
Air Suspension Warning Lamp Circuit Open
Air Suspension Warning Lamp Circuit Short To Battery
Air Suspension Warning Lamp Circuit Short To Ground
Motor Temperature Out of Range
Acceleration Position Sensor Conflict
Traction Motor Encoder circuit Failure
PRNDL Input #2 Circuit Failure
PRNDL Input #3 Circuit Failure
PRNDL Input #4 Circuit Failure
Contactor Circuit Failure
External Charging Fault
Battery Module Fault
Air Suspension Rear Inflator Solenoid Output Circuit Failure
Air Suspension Rear Inflator Solenoid Output Circuit Open
Air Suspension Rear Inflator Solenoid Output Circuit Short To Battery
Air Suspension Rear Inflator Solenoid Output Circuit Short To Ground
Air Suspension Gate Solenoid Output Circuit Failure
Air Suspension Gate Solenoid Output Circuit Open
Air Suspension Gate Solenoid Output Circuit Short To Battery
Air Suspension Gate Solenoid Output Circuit Short To Ground
Air Suspension RF Air Spring Solenoid Output Circuit Failure
Air Suspension RF Air Spring Solenoid Output Circuit Open
Air Suspension RF Air Spring Solenoid Output Circuit Short To Battery
Air Suspension RF Air Spring Solenoid Output Circuit Short To Ground
Air Suspension LF Air Spring Solenoid Output Circuit Failure
Air Suspension LF Air Spring Solenoid Output Circuit Open
Air Suspension LF Air Spring Solenoid Output Circuit Short To Battery
Air Suspension LF Air Spring Solenoid Output Circuit Short To Ground
Air Suspension RF Height Sensor Circuit Failure
Air Suspension RF Height Sensor Circuit Open
Air Suspension RF Height Sensor Circuit Short To Battery
Air Suspension RF Height Sensor Circuit Short To Ground
Air Suspension RR Height Sensor Circuit Failure
Air Suspension RR Height Sensor Circuit Open
Air Suspension RR Height Sensor Circuit Short To Battery
Air Suspension RR Height Sensor Circuit Short To Ground
Air Suspension LF Height Sensor Circuit Failure
38
PowerScan Series
5890
5891
5892
5893
5894
5895
5896
5897
5898
5899
5900
5901
5902
5903
5904
5905
5906
5907
5908
5909
5910
5911
5912
5913
5914
5915
5916
5917
5918
5920
5921
5922
5923
5924
5925
5926
5927
5928
5929
5930
5931
5932
5933
5934
5935
5936
5937
5938
OBD II / EOBD II /CAN
Air Suspension LF Height Sensor Circuit Open
Air Suspension LF Height Sensor Circuit Short To Battery
Air Suspension LF Height Sensor Circuit Short To Ground
Air Suspension LR Height Sensor Circuit Failure
Air Suspension LR Height Sensor Circuit Open
Air Suspension LR Height Sensor Circuit Short To Battery
Air Suspension LR Height Sensor Circuit Short To Ground
Steering VAPS II Circuit Loop Failure
Steering VAPS II Circuit Loop Open
Steering VAPS II Circuit Loop Short To Battery
Steering VAPS II Circuit Loop Short To Ground
Ride Control RR Shock Actuator Circuit Failure
Ride Control RR Shock Actuator Circuit Open
Ride Control RR Shock Actuator Circuit Short To Battery
Ride Control RR Shock Actuator Circuit Short To Ground
Ride Control LR Shock Actuator Circuit Failure
Ride Control LR Shock Actuator Circuit Open
Ride Control LR Shock Actuator Circuit Short To Battery
Ride Control LR Shock Actuator Circuit Short To Ground
Ride Control RF Shock Actuator Circuit Failure
Ride Control RF Shock Actuator Circuit Open
Ride Control RF Shock Actuator Circuit Short To Battery
Ride Control RF Shock Actuator Circuit Short To Ground
Ride Control LF Shock Actuator Circuit Failure
Ride Control LF Shock Actuator Circuit Open
Ride Control LF Shock Actuator Circuit Short To Battery
Ride Control LF Shock Actuator Circuit Short To Ground
Steering EVO Out-of-Range Fault
Air Suspension Ride Height Select Switch Circuit Failure
Led #1 Circuit Failure
VAPS Solenoid Actuator Output Circuit Failure
VAPS Solenoid Actuator Output Circuit Open
VAPS Solenoid Actuator Output Circuit Short To Battery
VAPS Solenoid Actuator Output Circuit Short To Ground
VAPS Solenoid Actuator Return Circuit Failure
VAPS Solenoid Actuator Return Circuit Open
VAPS Solenoid Actuator Return Circuit Short To Battery
VAPS Solenoid Actuator Return Circuit Short To Ground
Air Suspension Front Compressor Relay Circuit Failure
Air Suspension Front Compressor Relay Circuit Open
Air Suspension Front Compressor Relay Circuit Short To Battery
Air Suspension Front Compressor Relay Circuit Short To Ground
Solenoid Current Out Of Range
HPU (Hydraulic Pump Unit) Pressurisation Failure
Chime Circuit Failure
Hydraulic Pump Relay Circuit Failure
Steering Wheel Angle Sensor Offset Failure
Invalid Steering Wheel Angle Sensor ID
39
PowerScan Series
5939
5940
5942
5943
5944
5945
5946
5947
5948
5949
5950
5951
5952
5953
5954
5955
5956
5957
5958
5959
5960
5961
5962
5963
6767
OBD II / EOBD II /CAN
Brake Pressure Switch Input Circuit Failure
Brake Pressure Switch Mechanical Failure
Unrecognized Powertrain Configuration
Airbag Deployment Indication Input Fault
Gauge Driver Circuit Fault
Park Switch Indicates Park with Vehicle Moving
Seat Track Position Switch Circuit Open
Seat Track Position Switch Circuit Short to Ground
Seat Track Position Switch Circuit Resistance Out of Range
Accelerometer Sensor Circuit Open
Accelerometer Sensor Circuit Failure
Lateral Accelerometer Sensor Circuit Open
Yaw Rate Sensor Circuit Open
Master Cylinder Pressure Sensor Circuit Open
Master Cylinder Pressure Sensor Circuit Failure
Steering Angle Sensor Circuit Open
Steering Angle Sensor Circuit Failure
Dynamic Stability Control Valve RF Circuit Failure
Dynamic Stability Control Valve LF Circuit Failure
Lateral Accelerometer Sensor Circuit Failure
Driver Brake Apply Circuit Fault
Park Lamp Relay Coil Circuit Failure
Park Lamp Relay Coil Short to Battery
Stability Control Inhibit Warning
Reserved - TBD
40
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement