ADTRAN 4202023L3 User's Manual

ADTRAN 4202023L3 User's Manual
6PDUW6KHOI
8VHU0DQXDO
/$
)HEUXDU\
4202023L1
Smart 16, 2nd, AC Version
4202023L2
Smart 16, 2nd, Dual AC Version
4202023L3
Smart 16, 2nd, DC Version
4202023L4
Smart 16, 2nd, Dual DC Version
([SORUHU%RXOHYDUG
32%R[
+XQWVYLOOH$/
‹$'75$1,QF
$OO5LJKWV5HVHUYHG
3ULQWHGLQ86$
The following conventions are used in this manual.
P
Notes provide additional useful information.
Cautions signify information that could prevent service interruption.
Warnings provide information that could prevent damage to the
equipment or endangerment to human life.
LLL
IMPORTANT SAFETY INFORMATION
When using your telephone equipment, please follow these basic safety precautions to reduce
the risk of fire, electrical shock, or personal injury:
1.
Do not use this product near water, such as near a bath tub, wash bowl, kitchen sink, laundry tub, in a wet basement, or near a swimming pool.
2.
Avoid using a telephone (other than a cordless-type) during an electrical storm. There is a
remote risk of shock from lightning.
3.
Do not use the telephone to report a gas leak in the vicinity of the leak.
4.
Use only the power cord, power supply, and/or batteries indicated in the manual. Do not
dispose of batteries in a fire. They may explode. Check with local codes for special disposal instructions.
SAVE THESE INSTRUCTIONS
LY
Affidavit Requirements for Connection to Digital Services
•
An affidavit is required to be given to the telephone company whenever digital terminal
equipment without encoded analog content and billing protection is used to transmit digital signals containing encoded analog content which are intended for eventual conversion
into voice band analog signal and transmitted on the network.
•
The affidavit shall affirm that either no encoded analog content or billing information is
being transmitted or that the output of the device meets Part 68 encoded analog content or
billing protection specification.
•
End use/customer will be responsible to file an affidavit with the local exchange carrier
when connecting unprotected CPE to a 1.544 Mbps or subrate digital service.
•
Until such time as subrate digital terminal equipment is registered for voice applications,
the affidavit requirements for subrate services are waived.
Y
Affidavit for Connection of Customer Premises Equipment to 1.544 MBPS and/or
Subrate Digital Services
For the work to be performed in the certified territory of ______________ (telco name)
State of ________________________________
County of ______________________________
I, _______________________ (name), ____________________ (business address),
_____________________ (telephone number) being duly sworn, state:
I have the responsibility for the operation and maintenance of the terminal equipment to be
connected to 1.544 Mbps and/or __________________ subrate digital services. The terminal
equipment to be connected complies with Part 68 of the FCC rules except for the encoded analog content and billing protection specification. With respect to encoded analog content and
billing protection:
( ) I attest that all operations associated with the establishment, maintenance and adjustment of
the digital CPE with respect to encoded analog content and billing protection information continuously complies with Part 68 of the FCC rules and Regulations.
( ) The digital CPE does not transmit digital signals containing encoded analog content or billing information which is intended to be decoded within the telecommunications network.
( ) The encoded analog content and billing protection is factory set and is not under the control
of the customer.
I attest that the operator(s) maintainer(s) of the digital CPE responsible for the establishment,
maintenance and adjustment of the encoded analog content and billing information has (have)
been trained to perform these functions by successfully having completed one of the following
(check appropriate blocks):
( ) A. A training course provided by the manufacturer/grantee of the equipment used to encode
analog signals; or
( ) B. A training course provided by the customer or authorized representative, using training
materials and instructions provided by the manufacturer/grantee of the equipment used to
encode analog signals; or
YL
( ) C. An independent training course (e.g., trade school or technical institution) recognized by
the manufacturer/grantee of the equipment used to encode analog signals; or
( ) D. In lieu of the proceeding training requirements, the operator(s)/maintainer(S) is (are)
under the control of a supervisor trained in accordance with _______________ (circle one)
above.
I agree to provide ____________________ (telco’s name) with proper documentation to demonstrate compliance with the information in the preceding paragraph, if so requested.
_____________________ Signature
_____________________ Title
_____________________ Date
Subscribed and sworn to before me
This _________ day of ___________________, 20__
_______________________________________
Notary Public
My commission expires: _________________________
YLL
FCC regulations require that the following information be provided in this manual:
1.
This equipment complies with Part 68 of the FCC rules. There is a label on the equipment
that shows the FCC registration number and Ringer Equivalence Number (REN) for this
equipment, if applicable. If required, this information must be given to the telephone company.
2.
The following information may be required when applying to the local telephone company for leased line facilities.
Service
Type
2.4 kbps Digital Interface
4.8 kbps Digital Interface
9.6 kbps Digital Interface
19.2 kbps Digital Interface
38.4 kbps Digital Interface
56 kbps Digital Interface
64 kbps Digital Interface
Basic Rate ISDN
1.544 Mbps-SF
1.544 Mbps-SF and B8ZS
1.544 Mbps-ESF
1.544 Mbps-ESF and B8ZS
Digital Facility
Interface Code
Service Order
Code
Network
Jacks
04DU5-24
04DU5-48
04DU5-96
04DU5-19
04DU5-38
04DU5-56
04DU5-64
6.0F
6.0F
6.0F
6.0F
6.0F
6.0F
6.0F
RJ-48S
RJ-48S
RJ-48S
RJ-48S
RJ-48S
RJ-48S
RJ-48S
02IS5
6.0N
RJ-49C
04DU9-BN
04DU9-DN
04DU9-1KN
04DU9-1SN
6.0F
6.0F
6.0F
6.0F
RJ-48C
RJ-48C
RJ-48C
RJ-48C
3.
An FCC compliant telephone cord with a modular plug may be provided with this equipment. This equipment is designed to be connected to the telephone network or premises
wiring using a compatible modular jack, which is FCC Part 68 compliant. See installation
instructions for details.
4.
If this equipment causes harm to the telephone network, the telephone company may temporarily discontinue service. If possible, advance notification is given; otherwise, notification is given as soon as possible. The telephone company will advise the customer of the
right to file a complaint with the FCC.
5.
The telephone company may make changes in its facilities, equipment, operations, or procedures that could affect the proper operation of this equipment. If this happens, the telephone company will provide advance notification and the opportunity to make the
necessary modifications to maintain uninterrupted service.
YLLL
6.
If experiencing difficulty with this equipment, please contact ADTRAN for repair and
warranty information. If the equipment is causing harm to the network, the telephone
company may request this equipment to be disconnected from the network until the problem is resolved or it is certain that the equipment is not malfunctioning.
7.
This unit contains no user serviceable parts.
8.
The FCC recommends that the AC outlet to which equipment requiring AC power is to be
installed is provided with an AC surge arrester.
L[
Federal Communications Commission Radio Frequency Interference Statement
This equipment has been tested and found to comply with the limits for a Class A digital
device, pursuant to Part 15 of the FCC Rules. These limits are designed to provide reasonable
protection against harmful interference when the equipment is operated in a commercial environment. This equipment generates, uses, and can radiate radio frequency energy and, if not
installed and used in accordance with the instruction manual, may cause harmful interference
to radio frequencies. Operation of this equipment in a residential area is likely to cause harmful
interference in which case the user will be required to correct the interference at his own
expense.
Shielded cables must be used with this unit to ensure compliance with Class A FCC limits.
Change or modifications to this unit not expressly approved by the party responsible for compliance could void the user’s authority to operate the equipment.
[
Industry Canada Compliance Information
Notice: The Industry Canada label applied to the product (identified by the Industry
Canada logo or the “IC:” in front of the certification/registration number) signifies
that the Industry Canada technical specifications were met.
Notice: The Ringer Equivalence Number (REN) for this terminal equipment is
supplied in the documentation or on the product labeling/markings. The REN assigned
to each terminal device indicates the maximum number of terminals that can be
connected to a telephone interface. The termination on an interface may consist of any
combination of devices subject only to the requirement that the sum of the RENs of all
the devices should not exceed five (5).
Canadian Emissions Requirements
This digital apparatus does not exceed the Class A limits for radio noise emissions
from digital apparatus as set out in the interference-causing equipment standard
entitled “Digital Apparatus,” ICES-003 of the Department of Communications.
Cet appareil nuerique respecte les limites de bruits radioelectriques applicables aux
appareils numeriques de Class A prescrites dans la norme sur le materiel brouilleur:
“Appareils Numeriques,” NMB-003 edictee par le ministre des Communications.
[L
/,0,7('352'8&7:$55$17<
ADTRAN warrants that for five (5) years from the date of shipment to Customer, all products
manufactured by ADTRAN will be free from defects in materials and workmanship. ADTRAN also warrants that products will conform to the applicable specifications and drawings
for such products, as contained in the Product Manual or in ADTRAN's internal specifications
and drawings for such products (which may or may not be reflected in the Product Manual).
This warranty only applies if Customer gives ADTRAN written notice of defects during the
warranty period. Upon such notice, ADTRAN will, at its option, either repair or replace the
defective item. If ADTRAN is unable, in a reasonable time, to repair or replace any equipment
to a condition as warranted, Customer is entitled to a full refund of the purchase price upon
return of the equipment to ADTRAN. This warranty applies only to the original purchaser and
is not transferable without ADTRAN's express written permission. This warranty becomes null
and void if Customer modifies or alters the equipment in any way, other than as specifically
authorized by ADTRAN.
EXCEPT FOR THE LIMITED WARRANTY DESCRIBED ABOVE, THE FOREGOING
CONSTITUTES THE SOLE AND EXCLUSIVE REMEDY OF THE CUSTOMER AND
THE EXCLUSIVE LIABILITY OF ADTRAN AND IS IN LIEU OF ANY AND ALL
OTHER WARRANTIES (EXPRESSED OR IMPLIED). ADTRAN SPECIFICALLY DISCLAIMS ALL OTHER WARRANTIES, INCLUDING (WITHOUT LIMITATION), ALL
WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE. SOME STATES DO NOT ALLOW THE EXCLUSION OF IMPLIED WARRANTIES, SO THIS EXCLUSION MAY NOT APPLY TO CUSTOMER.
In no event will ADTRAN or its suppliers be liable to Customer for any incidental, special,
punitive, exemplary or consequential damages experienced by either Customer or a third party
(including, but not limited to, loss of data or information, loss of profits, or loss of use). ADTRAN is not liable for damages for any cause whatsoever (whether based in contract, tort, or
otherwise) in excess of the amount paid for the item. Some states do not allow the limitation or
exclusion of liability for incidental or consequential damages, so the above limitation or exclusion may not apply to Customer.
[LL
Customer Service, Product Support Information, and Training
ADTRAN will repair and return this product if within five years from the date of shipment the
product does not meet its published specification or the product fails while in service.
A return material authorization (RMA) is required prior to returning equipment to ADTRAN.
For service, RMA requests, training, or more information, use the contact information given
below.
Repair and Return
If you determine that a repair is needed, please contact our Customer and Product Service
(CAPS) department to have an RMA number issued. CAPS should also be contacted to obtain
information regarding equipment currently in house or possible fees associated with repair.
CAPS Department
(256) 963-8722
Identify the RMA number clearly on the package (below address), and return to the following
address:
ADTRAN Customer and Product Service
901 Explorer Blvd. (East Tower)
Huntsville, Alabama 35806
RMA # _____________
Pre-Sales Inquiries and Applications Support
Your reseller should serve as the first point of contact for support. If additional pre-sales support is needed, the ADTRAN Support web site provides a variety of support services such as a
searchable knowledge base, latest product documentation, application briefs, case studies, and
a link to submit a question to an Applications Engineer. All of this, and more, is available at:
http://support.adtran.com
When needed, further pre-sales assistance is available by calling our Applications Engineering
Department.
Applications Engineering (800) 615-1176
[LLL
Post-Sale Support
Your reseller should serve as the first point of contact for support. If additional support is
needed, the ADTRAN Support web site provides a variety of support services such as a searchable knowledge base, updated firmware releases, latest product documentation, service request
ticket generation and trouble-shooting tools. All of this, and more, is available at:
http://support.adtran.com
When needed, further pre-sales assistance is available by calling our Technical Support Center.
Please have your unit serial number available when you call.
Technical Support
(888) 4ADTRAN
Installation and Maintenance Support
The ADTRAN Custom Extended Services (ACES) program offers multiple types and levels of
installation and maintenance services which allow you to choose the kind of assistance you
need. This support is available at:
http://www.adtran.com/aces
For questions, call the ACES Help Desk.
ACES Help Desk
(888) 874-ACES (2237)
Training
The Enterprise Network (EN) Technical Training Department offers training on our most popular
products. These courses include overviews on product features and functions while covering applications of ADTRAN's product lines. ADTRAN provides a variety of training options, including
customized training and courses taught at our facilities or at your site. For more information about
training, please contact your Territory Manager or the Enterprise Training Coordinator:
Training Phone
Training Fax
Training Email
[LY
(800) 615-1176, ext. 7500
(256) 963-6700
[email protected]
7DEOHRI&RQWHQWV
/LVWRI)LJXUHV [YLL
/LVWRI7DEOHV [L[
&KDSWHU ,QWURGXFWLRQ $ERXW7KLV0DQXDO 3URGXFW2YHUYLHZ &KDSWHU ,QVWDOODWLRQ 8QSDFN,QVSHFW3RZHU8S 5HFHLYLQJ,QVSHFWLRQ
$'75$16KLSPHQWV,QFOXGH
&XVWRPHU3URYLGHV 3RZHU8S
,QVWDOODWLRQLQWR&DELQHWRU5DFN
,QVWDOODWLRQRI3RZHU6XSSOLHV ,QVWDOODWLRQRI&RQWUROOHU&DUG &RQQHFWLQJ,QSXW'HYLFHVWRWKH&RQWUROOHU&DUG 97&RQQHFWLRQ
0RGHP&RQQHFWLRQ '$7$0$7(&RQQHFWLRQ 0XOWL6KHOI&RQQHFWLRQ'DLV\&KDLQLQJ
$ODUP&RQQHFWLRQV
)XVHV $&'&3RZHU
&KDSWHU 2SHUDWLRQ /RFDO2SHUDWLRQ 977HUPLQDO 2SHUDWLRQ /
6PDUW6KHOI8VHU0DQXDO
[Y
7DEOHRI&RQWHQWV
&RQQHFWLRQ -XPSHUDQG6ZLWFK6HWWLQJV 0DLQ0HQX 6HOHFW8QLW0HQX $ODUP9LHZ0HQX 8WLOLWLHV0HQX )DFWRU\5HVHW0HQX '$7$0$7( 0DQXDO2SHUDWLRQDQG%XWWRQ)XQFWLRQV /&':LQGRZ (QWHU 1XPHULF.H\SDG 6KLIW 4XLFN &DQFHO 8SDQG'RZQ$UURZV 5HPRWH2SHUDWLRQ 0XOWL6KHOI2SHUDWLRQ'DLV\&KDLQLQJ ,QWHUSUHWLQJ$ODUPVDQG(UURU0HVVDJHV &OHDULQJ'%8$ODUPV '$7$0$7(3URFHGXUH 973URFHGXUH $SSHQGL[$ 3LQRXWV $SSHQGL[% 6SHFLILFDWLRQV ,QGH[ [YL
6PDUW6KHOI8VHU0DQXDO
/
/LVWRI)LJXUHV
)LJXUH 6PDUW6KHOI )LJXUH $ODUP&RQQHFWLRQ )LJXUH 6LQJOH$&9HUVLRQ5HDU3RZHU,QWHUIDFH&DUG/6KHOI )LJXUH 'XDO$&9HUVLRQ/6KHOI )LJXUH 6LQJOH'&9HUVLRQ/6KHOI )LJXUH 'XDO'&9HUVLRQ/6KHOI )LJXUH -XPSHUDQG6ZLWFK/RFDWLRQV
)LJXUH 0DLQ0HQX )LJXUH /RFDO&RQILJXUDWLRQ )LJXUH 6HOHFW8QLW0HQXZLWK(QKDQFHG6HOHFW'LVDEOHG
)LJXUH 6HOHFW8QLW0HQXZLWK(QKDQFHG6HOHFW(QDEOHG
)LJXUH $ODUP0HQX )LJXUH 8WLOLWLHV0HQX )LJXUH )DFWRU\5HVHW0HQX
)LJXUH '$7$0$7( )LJXUH '$7$0$7(8WLOLW\0HQX )LJXUH 5HPRWH&RQILJXUDWLRQ )LJXUH &RQWUROOHU&RQILJXUDWLRQ6ZLWFK3RVLWLRQV )LJXUH 0XOWL6KHOI$SSOLFDWLRQ
)LJXUH &RQWUROOHU&DUG)URQW3DQHO /
6PDUW6KHOI8VHU0DQXDO
[YLL
/LVWRI)LJXUHV
[YLLL
6PDUW6KHOI8VHU0DQXDO
/
/LVWRI7DEOHV
7DEOH
6ZLWFK6KHOI1XPEHULQJ6HWWLQJV 7DEOH
&RQWUROOHU&DUG(UURU0HVVDJHV
7DEOH
/('$ODUP0HVVDJHV
7DEOH$ (,$&RQQHFWRU3LQRXW
7DEOH$ &75/,QDQG&75/2XW&RQQHFWRU3LQRXWV 7DEOH$ $ODUP&RQQHFWLRQ3,QRXW 7DEOH$ '&3RZHU6XSSO\3LQRXW 7DEOH$ 93LQRXW 7DEOH$ $X[LOLDU\3RUW3LQRXW 7DEOH$ 1HWZRUN3LQRXW 7DEOH$ 56$,QWHUIDFH3LQRXW
7DEOH$ 5-/LQH3LQRXW 7DEOH$ 5-/LQH3LQRXW /
6PDUW6KHOI8VHU0DQXDO
[L[
/LVWRI7DEOHV
[[
6PDUW6KHOI8VHU0DQXDO
/
&KDSWHU
,QWURGXFWLRQ
$%2877+,60$18$/
7KLVPDQXDOSURYLGHVWKHLQIRUPDWLRQQHHGHGIRUWKHLQVWDOODWLRQ
DQGRSHUDWLRQRIWKH6PDUW6KHOIVHH)LJXUHRQSDJH
2SHUDWLRQLQVWUXFWLRQVIRUWKHGDWDFRPPXQLFDWLRQGHYLFHVXVHG
ZLWKWKHVKHOIDUHSURYLGHGLQWKHPDQXDOVIXUQLVKHGZLWKWKRVH
SURGXFWV
352'8&729(59,(:
7KH$'75$16PDUW6KHOISURYLGHVFRQYHQLHQWPRXQWLQJIRUXS
WRGDWDFRPPXQLFDWLRQVGHYLFHVIRUODUJHKRVWW\SHDSSOLFDWLRQV
7KHVKHOIFDQEHPRXQWHGLQHLWKHUµRUµUDFNVDQGFDELQHWVE\
XVLQJDVHWRIEUDFNHWVPRXQWHGDORQJVLGHWKHVKHOI
7KH6PDUW6KHOIKDVDQLQWHOOLJHQWFRQWUROOHUFDUGGHVLJQHGWR
FRQILJXUHDQGFRQWURODOOGHYLFHVLQWKHORFDOVKHOI)RUODUJHU
DSSOLFDWLRQVWKHFRQWUROOHUFDQDFFHVVXSWRDGGLWLRQDOVKHOYHV
E\GDLV\FKDLQLQJWKHFRQWUROSRUWV)RU6103DSSOLFDWLRQVWKH
6PDUWHZLWKHPEHGGHG6103LVDYDLODEOHLQVLQJOHDQGGXDO
LQSXWSRZHURSWLRQVSDUWQXPEHUV//
7KHUHDUHWZRFKRLFHVRILQSXWGHYLFHVIRUWKHFRQWUROOHUFDUG
‡
/
$97FRPSDWLEOHWHUPLQDOZKLFKFDQEHFRQQHFWHGWRWKH
(,$LQWHUIDFHORFDWHGDWWKHUHDURIWKHUDFN)RUUHPRWH
DSSOLFDWLRQVDPRGHPFDQEHXVHG
6PDUW6KHOI8VHU0DQXDO
‡
7KHRSWLRQDO'$7$0$7(DKDQGKHOGNH\SDGZLWKD[
/&'GLVSOD\7KLVXQLWSOXJVLQWRWKH5-MDFNRQWKHIURQWRI
WKHFRQWUROOHUFDUG
7KHVKHOIDQGDOOLQVWDOOHGXQLWVDUHLQWHUQDOO\SRZHUHGE\DQ$&RU
'&VXSSO\$QRSWLRQDOVHFRQGSRZHUVXSSO\FDQEHXVHGIRU
EDFNXSSURWHFWLRQ
)LJXUH6PDUW6KHOI
6PDUW6KHOI8VHU0DQXDO
/
&KDSWHU
,QVWDOODWLRQ
813$&.,163(&732:(583
5HFHLYLQJ,QVSHFWLRQ
&DUHIXOO\LQVSHFWWKH6PDUW6KHOIIRUDQ\VKLSSLQJGDPDJHV,I
GDPDJHLVVXVSHFWHGILOHDFODLPLPPHGLDWHO\ZLWKWKHFDUULHUDQG
FRQWDFW$'75$1&XVWRPHU6HUYLFH,ISRVVLEOHNHHSWKHRULJLQDO
VKLSSLQJFRQWDLQHUIRUXVHLQVKLSSLQJWKH6PDUW6KHOIIRUUHSDLU
RUIRUYHULILFDWLRQRIGDPDJHGXULQJVKLSPHQW
$'75$16KLSPHQWV,QFOXGH
7KHIROORZLQJLWHPVDUHLQFOXGHGLQ$'75$1VKLSPHQWVRIWKH
6PDUW6KHOI
/
‡
6PDUWFKDVVLV
‡
&RQWUROOHUFDUG
‡
3RZHUVXSSO\$&RU'&WZRLQFOXGHGLQ/DQG/
‡
%ODQNSRZHUIDFHSODWHRQO\LQ/DQG/
‡
5HDUSDQHOVHJPHQWIRUSRZHULQSXWDQGFRQWUROOHURSHUDWLRQ
‡
0RXQWLQJEUDFNHWVIRUVKHOI
‡
6PDUW6KHOI8VHU0DQXDOSURYLGHGRQ&'
6PDUW6KHOI8VHU0DQXDO
&XVWRPHU3URYLGHV
7KHFXVWRPHUPXVWVXSSO\D3&FDSDEOHRIHPXODWLQJ97RUD
'$7$0$7(SDUWQXPEHU/IRUFRQILJXULQJGHYLFHV
LQVWDOOHGLQWKH6PDUW6KHOI
3RZHU8S
7KHVKHOIDQGLQVWDOOHGXQLWVDUHLQWHUQDOO\SRZHUHGE\DQ$&RU
'&VXSSO\$QRSWLRQDOVHFRQGSRZHUVXSSO\FDQEHXVHGIRU
UHGXQGDQWSURWHFWLRQ
7KHGXDOLQSXWSRZHUVKHOYHV/$&DQG/'&
SURYLGHWKHXVHUJUHDWHUUHGXQGDQF\E\DOORZLQJWKHVKHOIWREH
SRZHUHGE\WZRVHSDUDWH$&RU'&FLUFXLWVVRWKDWVHUYLFHZLOO
QRWEHLQWHUUXSWHGXSRQDVLQJOHFLUFXLWEUHDNHUIDXOW6KHOISRZHU
LQSXWVFDQEHERWK$&RUERWK'&EXWWKH\FDQQRWEHPL[HG
,167$//$7,21,172&$%,1(7255$&.
7KHVHWRIEUDFNHWVVXSSOLHGZLWKWKH6PDUW6KHOIFDQEHXVHGIRU
HLWKHUµRUµDSSOLFDWLRQV)RUµDSSOLFDWLRQVWKHORQJHUVLGH
RIWKHEUDFNHWVKRXOGEHIOXVKZLWKWKHVLGHRIWKHFKDVVLV)RUµ
DSSOLFDWLRQVWKHVKRUWVLGHRIWKHEUDFNHWVKRXOGEHIOXVKZLWKWKH
VLGHRIWKHFKDVVLV
7KHUHDUHWZRVHWVRIPRXQWLQJKROHVIRUWKHEUDFNHWVRQWKHOHIWDQG
ULJKWVLGHVRIWKH6PDUW6KHOI2QHVHWSRVLWLRQVWKHIURQWRIWKH
6PDUW6KHOILQOLQHZLWKWKHIURQWRIWKHUDFN7KHRWKHUVHW
H[WHQGVWKHIURQWRIWKH6PDUW6KHOIEH\RQGWKHIURQWRIWKHUDFN
6PDUW6KHOI8VHU0DQXDO
/
,167$//$7,212)32:(56833/,(6
QGJHQHUDWLRQGXDOSRZHULQWHUIDFHFDUGVVKLSSHGZLWKWKLVVKHOIDUH21/<
IRUXVHLQQGJHQHUDWLRQ6PDUWHVKHOYHV6KRFNKD]DUGPD\UHVXOWIURP
DFFLGHQWDOO\SOXJJLQJDQGJHQHUDWLRQGXDOSRZHULQWHUIDFHFDUGLQWRDVW
JHQHUDWLRQ6PDUWHVKHOI31/WKURXJK/
$IIHFWHG3RZHU,QWHUIDFH&DUGV 6PDUW'XDO,QSXW$& /
6PDUW'XDO,QSXW'& /
6PDUWH'XDO,QSXW$& /
6PDUWH'XDO,QSXW'& /
7KHQGJHQHUDWLRQGXDOSRZHULQWHUIDFHFDUGVDUHKRZHYHUFRPSOHWHO\
VDIHZKHQSURSHUO\LQVWDOOHGLQDQGJHQHUDWLRQ6PDUWHVKHOI
31/WKURXJK/
7KHSRZHUVXSSO\FDQEHLQVWDOOHGLQHLWKHURIWKHWZRVORWVDWWKH
WRSRIWKH6PDUW6KHOI,IRQO\RQHSRZHUVXSSO\LVXVHGWKH
EODQNSRZHUVXSSO\IDFHSODWHIXUQLVKHGZLWKWKHUDFNVKRXOGEH
LQVWDOOHGRYHUWKHXQXVHGVORW
2QO\SHRSOHIDPLOLDUZLWKLQVWDOODWLRQDQGPDLQWHQDQFHRIWKH6PDUW
6KHOIVKRXOGLQVWDOORUUHSODFHWKHSRZHUVXSSOLHV$VKRFNKD]DUGFRXOGEH
SUHVHQWLIDQHPSW\SRZHUVXSSO\VORWLVOHIWXQFRYHUHG
7KH6PDUW6KHOILVIXOO\RSHUDWLRQDOZLWKRQHSRZHUVXSSO\
KRZHYHUDVHFRQGVXSSO\FDQEHDGGHGWRSURYLGHEDFNXSIRUWKH
SRZHUVXSSO\VXEV\VWHP:LWKWKHWZRVXSSO\FRQILJXUDWLRQRQH
RIWKHVXSSOLHVZLOORSHUDWHLQDKRWVWDQGE\PRGHWKH
FRUUHVSRQGLQJRXWSXWRQWKHVWDQGE\VXSSO\ZLOODXWRPDWLFDOO\
SURYLGHWKHSRZHUUHTXLUHGLIDQ\RIWKHIRXURXWSXWVIURPD
VXSSO\IDLOVRUEHJLQVWRRSHUDWHRXWRIVSHFLILFDWLRQV
7KHSRZHUVXSSOLHVFDQEH´KRWVZDSSHGµ
6OLGHWKHSRZHUVXSSO\DORQJWKHFDUGJXLGHVRIRQHRIWKHWRSVORWV
XQWLOLWLVIXOO\VHDWHGLQWKHFRQQHFWRUDQGWKHIDFHSODWHLVIOXVK
/
6PDUW6KHOI8VHU0DQXDO
ZLWKWKHFKDVVLV7LJKWHQWKHVFUHZVRQWKHIURQWRIWKHSRZHU
VXSSO\SDQHO
(DFKSRZHUVXSSO\KDVDJUHHQLQGLFDWRUWKDWLOOXPLQDWHVZKHQWKH
SRZHUVXSSO\RXWSXWYROWDJHV999DQG9DUH
ZLWKLQFRPSOLDQFHWKHSRZHUVXSSO\/('LOOXPLQDWHVUHGWR
LQGLFDWHWKDWDYROWDJHLVRXWRIWROHUDQFH,OOXPLQDWLRQRIDJUHHQ
/('LQGLFDWHVWKDWWKHFRUUHVSRQGLQJYROWDJHVDUHRSHUDWLQJ
SURSHUO\:KHQRSHUDWLRQRIDQ\RIWKHIRXUYROWDJHVGURSVRXWRI
VSHFLILFDWLRQWKHJUHHQ/('ZLOOJRRXWDQGWKHUHG/('ZLOOFRPH
RQ$Q6103WUDSZLOOEHVHQWIURPWKHFRQWUROOHUZKHQWKHSRZHU
VXSSO\GHWHFWVDYROWDJHIDLOXUHFRQGLWLRQ)DLOLQJSRZHUVXSSOLHV
DUHQRWXVHUVHUYLFHDEOHDQGUHTXLUHUHSODFHPHQW
,167$//$7,212)&21752//(5&$5'
7KH6PDUW6KHOIKDVYHUWLFDOVORWVLQWKHIURQWDQGUHDURIWKH
FKDVVLV7KHOHIWPRVWIURQWSRVLWLRQLVUHVHUYHGIRUWKH6PDUW
6KHOIFRQWUROOHUFDUG$OORWKHUIURQWVORWVFDQEHXVHGLQDQ\RUGHU
IRUUDFNPRXQWFDUGV7KH3:5&75/SRZHULQWHUIDFHFDUG
RFFXSLHVWKHVORWEHKLQGWKH6PDUW6KHOIFRQWUROOHUFDUG$OO
RWKHUUHDUVORWVDUHIRU'7(1HWZRUN,QWHUIDFH&DUGV
7KHFRQWUROOHUFDUGVOLGHVLQWRWKHFRUUHVSRQGLQJIURQWVORWXQWLO
FRQWDFWLVPDGHZLWKERWKWKHEDFNSODQHFRQQHFWRUDQGWKHUHDU
SRZHULQWHUIDFHFRQQHFWRUDQGWKHSDQHOLVIOXVKZLWKWKHIURQWRI
WKHFKDVVLV7KHFRQWUROOHUFDUGPD\EHLQVHUWHGDQGUHPRYHGZKLOH
WKH6PDUW6KHOILVUHFHLYLQJSRZHUZLWKRXWDIIHFWLQJWKHGDWD
VHUYLFHRQWKHRWKHUFDUGV
7KHFRQWUROOHUFDUGFDQDSSHDUWREHRSHUDWLRQDOLHUHFHLYLQJSRZHUDQG
\HWQRWEHFRPSOHWHO\FRQQHFWHG7KHSRZHULQWHUIDFHFDUGPXVWEHIXOO\
VHDWHGDQGWKHVFUHZVPXVWEHWLJKWIRUSURSHURSHUDWLRQ
&RQQHFWLQJ,QSXW'HYLFHVWRWKH&RQWUROOHU&DUG
7KHUHDUHWZRFKRLFHVRILQSXWGHYLFHVIRUWKH6PDUWFRQWUROOHU
FDUGD97WHUPLQDORUWKHRSWLRQDO'$7$0$7(SDUWQXPEHU
/
6PDUW6KHOI8VHU0DQXDO
/
97&RQQHFWLRQ
7KHSLQ(,$FRQQHFWRUODEHOOHG'7('&((,$RQWKH
UHDUSRZHULQWHUIDFHRIWKHFRQWUROOHUFDUGSURYLGHVDQLQWHUIDFHIRU
DQDV\QFKURQRXV$6&,,97WHUPLQDOXVHGIRUERWKORFDODQG
UHPRWHFRQILJXUDWLRQ7KHWHUPLQDOPXVWEHVHWWROLQHZUDSRII
IORZFRQWURORIIDQG97PRGH7KHFRQWUROOHUFDUGVHWWLQJVDUH
DVIROORZVDXWREDXGVIURPWRNESVEDXGUDWHELW
FKDUDFWHUVL]HQRSDULW\DQGRQHVWRSELW)RUUHPRWHFRQILJXUDWLRQ
VHHWKHVHFWLRQ0RGHP&RQQHFWLRQ7KHSLQDVVLJQPHQWVIRUWKH(,$
FRQQHFWRUDUHOLVWHGLQ$SSHQGL[$3LQRXWVRQSDJH
0RGHP&RQQHFWLRQ
7KH6PDUW6KHOIDQGDQ\UDFNPRXQWXQLWVLQWKHVKHOIFDQEH
FRQILJXUHGUHPRWHO\XVLQJDPRGHP6HH&KDSWHU2SHUDWLRQRQ
SDJHIRUPRUHGHWDLOHGLQIRUPDWLRQRQUHPRWHRSHUDWLRQ
'$7$0$7(&RQQHFWLRQ
7KHRSWLRQDO'$7$0$7(LVDKDQGKHOGGHYLFHWKDWSOXJVLQWRWKH
5-MDFNRQWKHIURQWRIWKHFRQWUROOHUFDUGRUWKH5-MDFNDWWKH
WRSRIWKHUHDU3:5&75/VHJPHQW
0XOWL6KHOI&RQQHFWLRQ'DLV\&KDLQLQJ
)RUPXOWLVKHOIDSSOLFDWLRQVWKHFRQWUROSRUWLVGDLV\FKDLQHG
WKURXJKWKHWZRVL[SLQPRGXODUMDFNVODEHOOHG&75//,1.
&DEOLQJRIDPXOWLVKHOIV\VWHPLVGHWDLOHGLQ&KDSWHU2SHUDWLRQ
RQSDJH7KLVDSSOLFDWLRQUHTXLUHVDVWUDLJKWWKURXJKFDEOH,I
SUREOHPVDULVHZLWKWKHRSHUDWLRQRIRQHRIWKHVKHOYHVLQWKHFKDLQ
WKHPDOIXQFWLRQLQJVKHOIZLOOEHE\SDVVHGVRWKDWWKHFKDLQZLOOQRW
EHEURNHQ6HH$SSHQGL[$3LQRXWVRQSDJHIRUWKHSLQ
DVVLJQPHQWVIRUWKH&75/,1DQG&75/287FRQQHFWRUV
$ODUP&RQQHFWLRQV
7KHWHUPLQDOVWULSVORFDWHGRQWKHEDFNRIWKH6PDUW6KHOI
FRQWUROOHUFDUGDUHODEHOHG$/$507KH\DUHXVHGIRUDXGLRRU
YLVXDODODUPLQGLFDWRUVSURYLGHGE\WKHXVHU7KHWRSWZRWHUPLQDOV
DUHDVHWDQGWKHERWWRPWZRDUHDVHW7KHWHUPLQDOVDUHDFWLYDWHG
WRJHWKHUZKHQWKHFDUGVLQVHUWHGLQWKHGHVLJQDWHGVORWVHQFRXQWHU
DQDODUPFRQGLWLRQVXFKDVSULPDU\OLQNIDLOXUH
/
6PDUW6KHOI8VHU0DQXDO
7RYHULI\RSHUDWLRQRIWKHWHUPLQDOVWULSPHDVXUHWKHLPSHGDQFH
DFURVVHDFKVHW7KHLPSHGDQFHVKRXOGEHRSHQZKHQWKHVKHOILV
QRWLQDODUPDQGVKRUWHGDSSUR[LPDWHO\RKPZKHQLQDODUP
7KHWZRDODUPVHWVRSHUDWHLGHQWLFDOO\DQGVKRXOGKDYHWKHVDPH
LPSHGDQFH7KHSRZHUVSHFLILFDWLRQVIRUDQ\DODUPVXVHGDUH1(&
&ODVVDQG9'&#P$PD[LPXP)LJXUHVKRZVWKH
DODUPFRQQHFWLRQ
SMART 16
AC
POWER I/F
D
T
E
/
D
C
E
E
I
A
2
3
2
C
T
R
L
Alarm Relay
I
N
L
I
N
K
O
U
T
Power
Source
ALARM
NO
#1
COM
NO
#2
COM
Power
Source
F1
3A
250V
3AG
F2
115VAC/60HZ
2.5 AMP
)LJXUH$ODUP&RQQHFWLRQ
6PDUW6KHOI8VHU0DQXDO
/
)XVHV
7KHUHDUHWZRIXVHVORFDWHGRQWKHUHDUSDQHO)XVHRQH)
FRUUHVSRQGVWRSRZHUVXSSO\OHIWVORWDQGIXVHWZR)
FRUUHVSRQGVWRSRZHUVXSSO\ULJKWVORW6HH6SHFLILFDWLRQVDQG
)HDWXUHVRQSDJHIRUIXVHUDWLQJV
$&'&3RZHU
7KHVLQJOHDQGGXDO$&YHUVLRQVLOOXVWUDWHGLQ)LJXUHRQSDJH
DQGLQ)LJXUHRQSDJHHDFKKDYHFDSWLYHIRRWSRZHUFRUGV
7KHSRZHUFRUGVDUHWHUPLQDWHGE\DWKUHHSURQJSOXJZKLFKFRQ
QHFWVWRDJURXQGHGSRZHUUHFHSWDFOH7KHJURXQGHGSRZHUUHFHS
WDFOHVKRXOGEHLQVWDOOHGQHDUWKHVKHOIDQGEHHDVLO\DFFHVVLEOH7KH
SRZHUUHFHSWDFOHVKRXOGDOVRKDYHVXLWDEOHGLVFRQQHFWGHYLFHVWKDW
DUHSURYLGHGDVSDUWRIWKHEXLOGLQJZLULQJ7KHSRZHUUHFHSWDFOH
VKRXOGEHSURSHUO\JURXQGHG7KHSURWHFWLRQRIWKHWHOHFRPPXQLFD
WLRQVQHWZRUNUHOLHVRQWKHSURWHFWLYHJURXQGLQJRIWKH6PDUW
6KHOI
7KHVLQJOH'&YHUVLRQLOOXVWUDWHGLQ)LJXUHRQSDJH
SURYLGHVDSRVLWLRQVFUHZWHUPLQDOEORFNIRUFRQQHFWLRQWRD9
VRXUFH7KHGXDO'&YHUVLRQLOOXVWUDWHGLQ)LJXUHRQSDJH
SURYLGHVDSRVLWLRQVFUHZWHUPLQDOEORFNIRUFRQQHFWLRQWRERWK
9VRXUFHV3LQRIWKHWHUPLQDOEORFNLVIUDPHJURXQG
7KHQGJHQHUDWLRQGXDOLQSXWSRZHULQWHUIDFHFDUGVDUHQRW
FRPSDWLEOHZLWKWKHVWJHQHUDWLRQ6PDUWHVKHOYHV
//7KHVHGXDOSRZHUFDUGVDUHQGJHQHUDWLRQRQO\
DQGDUHOLVWHGEHORZ
‡ 6PDUW'XDO,QSXW$&/
‡ 6PDUW'XDO,QSXW'&/
‡ 6PDUWH'XDO,QSXW$&/
‡ 6PDUWH'XDO,QSXW'&/
7KHQGJHQHUDWLRQVLQJOHLQSXWSRZHULQWHUIDFHFDUGVDUHIXOO\
FRPSDWLEOHZLWKWKHHDUOLHUVWJHQHUDWLRQ6PDUWHVKHOYHV
7KHVLQJOHLQSXWSRZHUFDUGVDUHOLVWHGEHORZ
‡
‡
‡
‡
/
6PDUW$&/
6PDUW'&/
6PDUWH$&/
6PDUWH'&/
6PDUW6KHOI8VHU0DQXDO
SMART 16
AC
POWER I/F
25-pin EIA-232 connector
interface for asynchronous
ASCII terminal VT100
(local and remote configuration)
D
T
E
/
D
C
E
E
I
A
6-pin modular jacks
for daisy-chaining
shelves together (use
straight through cable)
2
3
2
C
T
R
L
I
N
L
I
N
K
O
U
T
Removable terminal strip for external
alarm circuits or other devices
ALARM
NO
#1
COM
NO
#2
COM
Fuse for left power supply
F1
3A
250V
3AG
F2
Fuse for right power supply
Captive 8-foot power cord
115VAC/60HZ
2.5 AMP
)LJXUH6LQJOH$&9HUVLRQ5HDU3RZHU,QWHUIDFH&DUG
/6KHOI
6PDUW6KHOI8VHU0DQXDO
/
SMART 16
DUAL AC
POWER I/F
25-pin EIA-232 connector
interface for asynchronous
ASCII terminal VT100
(local and remote configuration)
D
T
E
/
D
C
E
E
I
A
2
3
2
6-pin modular jacks
for daisy-chaining
shelves together (use
straight through cable)
C
T
R
L
I
N
L
I
N
K
O
U
T
Removable terminal strip for external
alarm circuits or other devices
ALARM
NO
#1
COM
NO
#2
COM
Fuse for left power supply
F1
3A
250V
3AG
F2
Fuse for right power supply
Captive 8-foot power cord
S
P
L
Y
1
115VAC
60HZ
2.5 AMP
S
P
L
Y
2
QGJHQHUDWLRQGXDOSRZHULQWHUIDFHFDUGVVKLSSHGZLWKWKLVVKHOIDUH21/<
IRUXVHLQQGJHQHUDWLRQ6PDUWHVKHOYHV6KRFNKD]DUGPD\UHVXOWIURP
DFFLGHQWDOO\SOXJJLQJDQGJHQHUDWLRQGXDOSRZHULQWHUIDFHFDUGLQWRDVW
JHQHUDWLRQ6PDUWHVKHOI31/WKURXJK/
$IIHFWHG3RZHU,QWHUIDFH&DUGV 6PDUW'XDO,QSXW$& /
6PDUW'XDO,QSXW'& /
6PDUWH'XDO,QSXW$& /
6PDUWH'XDO,QSXW'& /
7KHQGJHQHUDWLRQGXDOSRZHULQWHUIDFHFDUGVDUHKRZHYHUFRPSOHWHO\
VDIHZKHQSURSHUO\LQVWDOOHGLQDQGJHQHUDWLRQ6PDUWHVKHOI
31/WKURXJK/
)LJXUH'XDO$&9HUVLRQ/6KHOI
/
6PDUW6KHOI8VHU0DQXDO
SMART 16
DC
POWER I/F
25-pin EIA-232 connector
interface for asynchronous
ASCII terminal VT100
(local and remote configuration)
D
T
E
/
D
C
E
E
I
A
6-pin modular jacks
for daisy-chaining
shelves together (use
straight through cable)
2
3
2
C
T
R
L
I
N
L
I
N
K
O
U
T
Removable terminal strip for external
alarm circuits or other devices
ALARM
NO
#1
COM
NO
#2
COM
Fuse for left power supply
F1
5A
250V
3AG
Fuse for right power supply
F2
External DC Power Supply Specs:
Shelf Input=48 VDC, 4 A
48V ,4A
–
+
)LJXUH6LQJOH'&9HUVLRQ/6KHOI
6PDUW6KHOI8VHU0DQXDO
/
SMART 16
DUAL DC
POWER I/F
25-pin EIA-232 connector
interface for asynchronous
ASCII terminal VT100
(local and remote configuration)
D
T
E
/
D
C
E
E
I
A
2
3
2
6-pin modular jacks
for daisy-chaining
shelves together (use
straight through cable)
C
T
R
L
I
N
L
I
N
K
O
U
T
Removable terminal strip for external
alarm circuits or other devices
ALARM
NO
#1
COM
NO
#2
COM
Fuse for left power supply
F1
5A
250V
3AG
F2
Fuse for right power supply
External DC Power Supply Specs:
Shelf Input=48 VDC, 4 A
48V ,4A
–
+
#1
–
+
#2
QGJHQHUDWLRQGXDOSRZHULQWHUIDFHFDUGVVKLSSHGZLWKWKLVVKHOIDUH21/<
IRUXVHLQQGJHQHUDWLRQ6PDUWHVKHOYHV6KRFNKD]DUGPD\UHVXOWIURP
DFFLGHQWDOO\SOXJJLQJDQGJHQHUDWLRQGXDOSRZHULQWHUIDFHFDUGLQWRDVW
JHQHUDWLRQ6PDUWHVKHOI31/WKURXJK/
$IIHFWHG3RZHU,QWHUIDFH&DUGV 6PDUW'XDO,QSXW$& /
6PDUW'XDO,QSXW'& /
6PDUWH'XDO,QSXW$& /
6PDUWH'XDO,QSXW'& /
7KHQGJHQHUDWLRQGXDOSRZHULQWHUIDFHFDUGVDUHKRZHYHUFRPSOHWHO\
VDIHZKHQSURSHUO\LQVWDOOHGLQDQGJHQHUDWLRQ6PDUWHVKHOI
31/WKURXJK/
)LJXUH'XDO'&9HUVLRQ/6KHOI
/
6PDUW6KHOI8VHU0DQXDO
6PDUW6KHOI8VHU0DQXDO
/
&KDSWHU
2SHUDWLRQ
/2&$/23(5$7,21
7KHUHDUHWZRPHWKRGVRIORFDOFRQILJXUDWLRQIRUWKH6PDUW6KHOI
D97WHUPLQDORUD'$7$0$7(SDUWQXPEHU/
3DVVZRUGSDUDPHWHUVDUHVHWWKURXJKWKHWHUPLQDORUWKH
'$7$0$7(
977HUPLQDO
2SHUDWLRQ
7KH6PDUW6KHOIPD\EHFRQILJXUHGE\DWWDFKLQJWKH97
FRPSDWLEOHWHUPLQDORUHTXLYDOHQWWRWKHFRQWUROSRUWRQWKHUHDURI
WKH6PDUW6KHOIFRQWUROOHUFDUG7KHWHUPLQDOPXVWEHVHWWROLQH
ZUDSRIIIORZFRQWURORIIDQG97PRGH7KHFRQWUROOHUFDUG
VHWWLQJVDUHDVIROORZVDXWREDXGVIURPWRNESVEDXGUDWH
ELWFKDUDFWHUVL]HQRSDULW\DQGRQHVWRSELW
&RQQHFWLRQ
7KHFRQQHFWLRQWRDWHUPLQDOLVPDGHWKURXJKWKH(,$SLQ
FRQQHFWRURQWKHUHDU3:5&75/VHJPHQWVHH)LJXUHRQSDJH
7KLVFRQQHFWLRQLVXVHGIRUERWKORFDODQGUHPRWH
FRQILJXUDWLRQ
/
6PDUW6KHOI8VHU0DQXDO
-XPSHUDQG6ZLWFK6HWWLQJV
)RUORFDOFRQILJXUDWLRQ'LUHFW0RGHSODFHWKHMXPSHURQWKH
KHDGHURI-3ODEHOHG'&(,IRQO\RQHVKHOILVEHLQJXVHGWKHVKHOI
PXVWEHFRQILJXUHGDVWKHPDVWHU6:RQ6HH)LJXUHIRU
MXPSHUDQGVZLWFKORFDWLRQV6HH0XOWL6KHOI2SHUDWLRQ'DLV\
&KDLQLQJRQSDJHIRULQIRUPDWLRQRQVZLWFKVHWWLQJVLQD
PXOWLSOHVKHOIFRQILJXUDWLRQ
,IRQO\RQHVKHOILIEHLQJXVHGWKHVKHOIPXVWEHFRQILJXUHGDVWKHPDVWHU
6:RQ
Battery
Fuses
F1
F2
F3
JP3
SW1
O 1 2 3 4 5 6 7 8
N
DCE
JP2
DTE
Switch 1 sets shelf number,
master/slave operation, SNMP,
and battery enable/disable.
Jumpers configure the
card for local (DCE)
or remote (DTE)
operation.
)LJXUH-XPSHUDQG6ZLWFK/RFDWLRQV
6PDUW6KHOI8VHU0DQXDO
/
0DLQ0HQX
$IWHULQLWLDWLQJWHUPLQDOPRGHE\SUHVVLQJWKHFDUULDJHUHWXUQNH\
XQWLOWKH0DLQPHQXDSSHDUVWKHGLVSOD\ZLOOGLYLGHLQWRWKUHH
VHFWLRQVVHH)LJXUHRQSDJH
7KHPDLQZLQGRZZKLFKGLVSOD\VDOORSWLRQVRIDPHQXOHYHO
7KHLQIRUPDWLRQZLQGRZZKLFKOLVWVDOOSRVVLEOHFKRLFHVIRUD
VHOHFWHGRSWLRQ
7KHFRPPDQGOLQHZKLFKGLVSOD\VWKHFXUUHQWVHWWLQJIRUWKH
VHOHFWHGRSWLRQ7KHVHWWLQJFDQEHXSGDWHGE\HQWHULQJWKH
QXPEHUFRUUHVSRQGLQJWRWKHGHVLUHGVHOHFWLRQIROORZHGE\D
FDUULDJHUHWXUQ7KHQHZVHWWLQJZLOOEHXSGDWHGLQWKHPDLQ
ZLQGRZ
)URPWKH0DLQPHQXVHOHFWDXQLWYLHZDODUPVRILQGLYLGXDOXQLWV
DFFHVVDXWLOLW\PHQXRUUHVHWWKHVKHOI
)LJXUH0DLQ0HQX
/
6PDUW6KHOI8VHU0DQXDO
SMART 16
AC
POWER I/F
D
T
E
/
D
C
E
E
I
A
2
3
2
C
T
R
L
I
N
L
I
N
K
O
U
T
ALARM
NO
#1
COM
NO
#2
COM
F1
3A
250V
3AG
F2
115VAC/60HZ
2.5 AMP
)LJXUH/RFDO&RQILJXUDWLRQ
6PDUW6KHOI8VHU0DQXDO
/
6HOHFW8QLW0HQX
7KH6(/(&781,7PHQXLOOXVWUDWHGLQ)LJXUHDSSHDUVDIWHU
VHOHFWLQJ6(/(&781,7IURPWKH0DLQPHQXZLWK(1+$1&('
6(/(&7LQWKH8WLOLWLHVGLVDEOHG
‡
3UHVVWRVHOHFWWKHVKHOIQXPEHUGLVSOD\HGRQWKHIURQWRIWKH
VKHOIFRQWUROOHUFDUG
‡
3UHVVWRVHOHFWWKHVORWQXPEHU
‡
3UHVVWRH[HFXWHWKHFKRLFHVDQGEHJLQFRQILJXULQJWKH
UDFNPRXQWXQLW
)LJXUH6HOHFW8QLW0HQXZLWK(QKDQFHG6HOHFW'LVDEOHG
/
6PDUW6KHOI8VHU0DQXDO
,I(1+$1&('6(/(&7LVHQDEOHGWKHPHQXLQ)LJXUHZLOODSSHDU
)LJXUH6HOHFW8QLW0HQXZLWK(QKDQFHG6HOHFW(QDEOHG
$ODUP9LHZ0HQX
7KH$/$50PHQX)LJXUHDSSHDUVDIWHUVHOHFWLQJ$/$50
9,(:IURPWKH0DLQPHQX7KLVPHQXGLVSOD\VWKHFXUUHQWV\VWHP
VWDWXV6HOHFWDQ\DFWLYHVKHOIDQGVORWQXPEHUWRYLHZLWVVWDWXV
)LJXUH$ODUP0HQX
6PDUW6KHOI8VHU0DQXDO
/
8WLOLWLHV0HQX
7KH87,/,7,(6PHQX)LJXUHDSSHDUVDIWHUVHOHFWLQJ87,/,7,(6
IURPWKH0DLQPHQX
)LJXUH8WLOLWLHV0HQX
)URPWKH87,/,7,(6PHQXSHUIRUPWKHIROORZLQJIXQFWLRQV
7(50,1$/7,0(2870,1 11
6HWKRZPDQ\PLQXWHVRINH\ERDUGLQDFWLYLW\FDQWDNHSODFHEHIRUH
WKHVFUHHQJRHVEODQN
&+$1*(3$66:25'
6HWSULYDWHSDVVZRUGZKLFKZLOOSUHYHQWXQDXWKRUL]HGXVHUVIURP
FRQILJXULQJRUWHVWLQJLQGLYLGXDO'68FDUGV7KHGHIDXOWSDVVZRUG
IRUWKHFRQWUROOHUFDUGLV3$66:25'
3$66:25' ',6(1
(QDEOHRUGLVDEOHSDVVZRUGIXQFWLRQ
6(77,0(
6HWWLPHRIGD\
/
6PDUW6KHOI8VHU0DQXDO
6(7'$7(
6HWWKHGDWH
(',76+(/)6/27'(6&5,37,216
$VVLJQQDPHVWRWKHVKHOYHVDQGVORWV
/$7&+('$8',%/($/$50 ',6(1
(QDEOHRUGLVDEOHWHUPLQDODODUPIXQFWLRQ
(1+$1&('6(/(&7
,IHQDEOHGWKH6HOHFW8QLWPHQXVKRZQLQ)LJXUHZLOOEH
UHSODFHGE\WKHPHQXLQ)LJXUH
6(76103$''5(66
7KHFRQWUROOHUVXSSRUWV61030DQDJHPHQWRILQVWDOOHGFDUGVYLD
WKH$'75$1$GYLVRUVRIWZDUH,IWKLVIHDWXUHLVHQDEOHGDQ6103
DGGUHVVPXVWEHVHOHFWHG
&211(&7,217<3(
)RU6103DSSOLFDWLRQVWKHFRQWUROOHUPXVWNQRZZKHWKHUDGLDO
XSRUGLUHFWFRQQHFWLRQLVEHLQJXVHG
(',761033+21(180%(5
)RU6103GLDOXSRSHUDWLRQWKLVLVWKHSKRQHQXPEHUWKDWWKH
FRQWUROOHUZLOOFDOOWRVHQGDQ6103WUDS
6PDUW6KHOI8VHU0DQXDO
/
)DFWRU\5HVHW0HQX
7KH)$&725<5(6(7PHQX)LJXUHDSSHDUVDIWHUVHOHFWLQJ
)$&725<5(6(7IURPWKH0DLQPHQX
)LJXUH)DFWRU\5HVHW0HQX
'$7$0$7(
7KH'$7$0$7(LOOXVWUDWHGLQ)LJXUHRQSDJHLVDKDQG
KHOGNH\SDGZLWKD[/&'GLVSOD\7KH'$7$0$7(FRQQHFWVWR
WKHSLQPRGXODUMDFNRQWKHIURQWRIWKHFRQWUROOHUFDUG6HH)LJXUH
RQSDJHIRUMDFNORFDWLRQV
:KLOHERWKFRQWUROOHULQSXWGHYLFHV'$7$0$7(DQG97WHUPLQDO
FDQEHLQVWDOOHGDWWKHVDPHWLPHERWKGHYLFHVFDQQRWEHDFWLYHDWWKHVDPH
WLPH
:LWKERWKGHYLFHVLQVWDOOHGWKH'$7$0$7(LVDFWLYHXQWLOWKH
WHUPLQDOPRGHLVVHOHFWHG7RHQWHUWHUPLQDOPRGHZKLOHWKH
'$7$0$7(LVLQVWDOOHGWKH'$7$0$7(PXVWEHLQWKHWRSOHYHO
RILWVPHQXWUHHSUHVV&DQFHOXQWLOWKHPHQXOHYHOLVUHDFKHG7KH
WHUPLQDOPRGHFDQQRWEHDFWLYDWHGZKLOHFRPPXQLFDWLRQEHWZHHQ
/
6PDUW6KHOI8VHU0DQXDO
WKH'$7$0$7(DQGWKHGDWDFRPPXQLFDWLRQSURGXFWLVLQ
SURJUHVV7KHWHUPLQDOPRGHLVLQLWLDWHGE\SUHVVLQJWKHFDUULDJH
UHWXUQNH\XQWLOWKH0DLQPHQXLVGLVSOD\HG:KLOHLQWKHWHUPLQDO
PRGHWKH'$7$0$7(JRHVLQWRVWDQGE\PRGHDQGGLVSOD\VWKH
IROORZLQJPHVVDJH
+2/'&$1&(/.(<
)256(59,&(
&RQWUROFDQEHUHWXUQHGWRWKH'$7$0$7(E\SUHVVLQJ(VFDSH
XQWLOWKHWHUPLQDOPRGHLVH[LWHGRUE\KROGLQJWKH'$7$0$7(·V
&DQFHONH\GRZQ2QFHFRPPXQLFDWLRQZLWKDQLQGLYLGXDO
5DFNPRXQWXQLWKDVEHHQHVWDEOLVKHGPHQXVLGHQWLFDOWRWKRVHRI
WKHVWDQGDORQHYHUVLRQRIWKHSURGXFWDUHGLVSOD\HGRQWKH
'$7$0$7(
Displays menu
items and messages
Use arrows to scroll
through submenu
items
Press before
desired alpha
character selection
Press to select active
(flashing) menu items
DATAMATE
ENTER
CANCEL
A
1
D
4
B
2
E
5
C
3
F
6
7
SHIFT
8
*
0
9
QUICK
#
Press to stop current
activity and return
to previous menu
Use numeric keypad
to activate menu items
and enter parameters
Press to return to the main menu
)LJXUH'$7$0$7(
0DQXDO2SHUDWLRQDQG%XWWRQ)XQFWLRQV
7KHIROORZLQJIXQFWLRQGHVFULSWLRQVDSSO\WRWKH'$7$0$7(7KH
'$7$0$7(·V87,/,7<PHQXLVSURYLGHGLQ)LJXUHRQSDJH
/&':LQGRZ
'LVSOD\VPHQXLWHPVDQGPHVVDJHVLQOLQHVE\FKDUDFWHUV
6PDUW6KHOI8VHU0DQXDO
/
(QWHU
6HOHFWVDFWLYHPHQXLWHPV7RDFWLYDWHDPHQXLWHPSUHVVWKH
QXPEHURIWKHLWHP:KHQWKHPHQXLWHPLVIODVKLQJSUHVV(QWHUWR
VHOHFWLW7KLVDFWLRQGLVSOD\VDVXEPHQXLWHPLIWKHUHLVRQHRUVHWV
WKHFRQILJXUDWLRQSDUDPHWHU7KHGLVSOD\RI&200$1'
$&&(37('LQGLFDWHVDYDOLGRSHUDWLRQ
1XPHULF.H\SDG
7KHQXPHULFNH\SDGFRQWDLQVWKHQXPEHUVWKURXJKDQGDOSKD
FKDUDFWHUV$WKURXJK)ZKLFKDUHXVHGWRDFWLYDWHPHQXLWHPV
1XPEHUVWKURXJKDUHDOVRXVHGWRHQWHUSDUDPHWHUV
6KLIW
$OSKDFKDUDFWHUVDUHHQWHUHGE\SUHVVLQJDQGUHOHDVLQJ6KLIWEHIRUH
HDFKGHVLUHGFKDUDFWHU7RDFWLYDWHDPHQXLWHPGHVLJQDWHGE\DQ
DOSKDFKDUDFWHUUDWKHUWKDQDQXPEHUGLVSOD\WKHPHQXLWHPXVLQJ
WKHXSDQGGRZQDUURZVSUHVV6KLIWDQGWKHQWKHOHWWHU3UHVV
(QWHUWRVHOHFWWKHLWHP
,IDNH\LVSUHVVHGZLWKRXWXVLQJ6KLIWWKHQXPEHUHGLWHPEHFRPHV
DFWLYHLQVWHDGRIWKHDOSKDLWHP,IWKLVKDSSHQVUHSHDWWKHFRUUHFW
SURFHGXUH
4XLFN
'XULQJPRVWRSHUDWLRQVWKH4XLFNNH\UHWXUQVWKHGLVSOD\WRWKH
0DLQPHQX'XULQJDWHVWWKLVNH\UHWXUQVWRWKHWRSRIWKH7(67
PHQX
&DQFHO
7KH&DQFHONH\VWRSVWKHFXUUHQWDFWLYLW\DQGUHWXUQVWRWKH
SUHYLRXVPHQX3UHVV&DQFHOXQWLOWKHGHVLUHGPHQXOHYHOLV
UHDFKHG
8SDQG'RZQ$UURZV
7KHVHDUURZVVFUROOWKURXJKWKHVXEPHQXLWHPVDYDLODEOHLQWKH
FXUUHQWPHQX6XEPHQXLWHPVDSSHDUWZRDWDWLPH:KHQVFUROOHG
WKH\FRQWLQXRXVO\DSSHDUIURPEHJLQQLQJWRHQGLQDIRUZDUG
GRZQDUURZRUUHYHUVHXSDUURZSDWWHUQ
/
6PDUW6KHOI8VHU0DQXDO
6(/(&781,7
87,/,7,(6
6/27 [
<LHOGVLQGLYLGXDO
XQLW¶VPHQX
6(77,0(
7,0(
[[[[[[
6(7'$7(
'$7(
[[[[[[
3257&21),*
32577<3(
%$8'5$7(
6723%,76
3$5,7<
121(
(9(1
2''
;21;2))
21
2))
6(76103$''5
[[[[[[[[
6(73$66:25'
[[[[[[[[
.
%,76
%,76
62)7:$5(5(9
3+21(180%(5
'$7$%,76
7,0(2877,0(5
7,0(5 0,1
7,0(287/,0,7
',$/
',5(&7
62)7:$5(5(9 [
&+(&.680 [[[[
(17(56+(/)$'5
6+(/) [
)$&725<5(6(7
$/$50&/($5
)LJXUH'$7$0$7(8WLOLW\0HQX
6PDUW6KHOI8VHU0DQXDO
/
5(027(23(5$7,21
7KH6PDUW6KHOIDQGDQ\UDFNPRXQWXQLWVLQWKHVKHOIFDQEH
FRQILJXUHGUHPRWHO\XVLQJDPRGHP6HH)LJXUHRQSDJH
)ROORZWKHVHVWHSVWRVHWXSWKLVDSSOLFDWLRQ
$WWKHUHPRWHVLWHSXOOWKHFRQWUROOHUFDUGRXWRIWKHVKHOIDQG
ORFDWHWKH-XPSHU-3ODEHOHG'7(3ODFHWKHSLQMXPSHURQ
WKHKHDGHU
/RFDWHWKH(,$LQWHUIDFHRQWKHEDFNSDQHORIWKHFRQWUROOHU
FDUG&RQQHFWWKHPRGHPWRWKLVLQWHUIDFH
0DNHVXUHWKHVKHOIEDXGUDWHLVQRWFRQILJXUHGDERYH
NESV
6HWWKHGDWDIRUPDWDVIROORZVZRUGOHQJWK ELWVSDULW\ QRQHVWRSELW :KHQWKHFDOOKDVEHHQPDGHDQGWKHORFDOPRGHPKDV
FRQQHFWHGWRWKHUHPRWHXQLWSUHVVWKH(QWHUNH\RQWKH3&
VHYHUDOWLPHVWREULQJWKHVFUHHQXS
%HJLQFRQILJXULQJWKHVKHOIIURPWKHORFDO3&
/
6PDUW6KHOI8VHU0DQXDO
SMART 16
AC
POWER I/F
D
T
E
/
D
C
E
MODEM
E
I
A
2
3
2
C
T
R
L
I
N
L
I
N
K
O
U
T
ALARM
NO
#1
MODEM
COM
NO
#2
COM
F1
3A
250V
3AG
F2
115VAC/60HZ
2.5 AMP
)LJXUH5HPRWH&RQILJXUDWLRQ
6PDUW6KHOI8VHU0DQXDO
/
08/7,6+(/)23(5$7,21'$,6<&+$,1,1*
)RUODUJHUDSSOLFDWLRQVWKHFRQWUROOHUDOORZVDFFHVVWRDGGLWLRQDO
6PDUW6KHOYHV,QWKHVHODUJHUDSSOLFDWLRQVRQHVKHOIFRQWUROOHULV
FRQILJXUHGDVWKHPDVWHUDQGDOORWKHUVKHOIFRQWUROOHUVDUH
FRQILJXUHGDVVXEFRQWUROOHUVVHH)LJXUHDQG)LJXUH7KLV
SDUDPHWHULVVHWWKURXJK6ZLWFK6:WKHSRVLWLRQURFNHU
VZLWFKRQWKHFRQWUROOHUFDUGDVLOOXVWUDWHGLQ)LJXUH6HOHFW
HLWKHUPDVWHU6:RQRUVXEFRQWUROOHU6:RIIE\PRYLQJ
WKHVZLWFKWRWKHGHVLUHGSRVLWLRQ
8VLQJ6:WKURXJK6:VHWWKHVKHOIQXPEHUIURPWR
6ZLWFKVHWWLQJVDUHGHWDLOHGLQ7DEOHRQSDJH7KHLQGLFDWRU
GLVSOD\RQWKHIURQWRIWKHFRQWUROOHUFDUGVKRZVWKHFXUUHQWVKHOI
QXPEHU
SNMP/Telnet
Disable
Battery Master
Shelf Number
Enable Control
Selection
O
N
1
2
3
4
SNMP/Telnet
Enable
5
6
7
8
Battery Sub
Disable Control
)LJXUH&RQWUROOHU&RQILJXUDWLRQ6ZLWFK3RVLWLRQV
/
6PDUW6KHOI8VHU0DQXDO
SMART 16
AC
POWER I/F
D
T
E
/
D
C
E
E
I
A
2
3
2
SHELF 1
Master (SW1-8 on)
C
T
R
L
I
N
L
I
N
K
O
U
T
ALARM
NO
#1
COM
NO
#2
COM
F1
3A
250V
3AG
F2
115VAC/60HZ
2 AMPS
SMART 16
AC
POWER I/F
D
T
E
/
D
C
E
E
I
A
2
3
2
SHELF 2
Subcontoller (SW1-8 off)
C
T
R
L
I
N
L
I
N
K
O
U
T
ALARM
NO
#1
COM
NO
#2
COM
F1
3A
250V
3AG
F2
115VAC/60HZ
2 AMPS
SMART 16
AC
POWER I/F
D
T
E
/
D
C
E
E
I
A
2
3
2
SHELF 3
C
T
R
L
I
N
L
I
N
K
O
U
T
ALARM
Subcontoller (SW1-8 off)
NO
#1
COM
NO
#2
COM
F1
3A
250V
3AG
F2
115VAC/60HZ
2 AMPS
)LJXUH0XOWL6KHOI$SSOLFDWLRQ
6PDUW6KHOI8VHU0DQXDO
/
7DEOH6ZLWFK6KHOI1XPEHULQJ6HWWLQJV
6KHOI 6:
1XPEHU
/
6:
6:
6:
2Q
2Q
2Q
2Q
2II
2Q
2Q
2Q
2Q
2II
2Q
2Q
2II
2II
2Q
2Q
2Q
2Q
2II
2Q
2II
2Q
2II
2Q
2Q
2II
2II
2Q
2II
2II
2II
2Q
2Q
2Q
2Q
2II
2II
2Q
2Q
2II
2Q
2II
2Q
2II
2II
2II
2Q
2II
2Q
2Q
2II
2II
2II
2Q
2II
2II
2Q
2II
2II
2II
2II
2II
2II
2II
6PDUW6KHOI8VHU0DQXDO
,17(535(7,1*$/$506$1'(55250(66$*(6
7KH$/$50PHQXLOOXVWUDWHGLQ)LJXUHSURYLGHVWKHVWDWXV
LQIRUPDWLRQRILQGLYLGXDOXQLWV
)RXULQGLFDWRUVRQWKHIURQWSDQHORIWKHFRQWUROOHUFDUGVKRZDODUP
FRQGLWLRQVLQWKHUDFNDVGHWDLOHGLQ)LJXUH
$GGLWLRQDOHUURUPHVVDJHVDUHGLVSOD\HGLQWKHQXPHULFDOGLVSOD\
RIWKHFRQWUROOHUFDUG7KHFRQGLWLRQVDORQJZLWKWKHQXPEHUVWKDW
UHSUHVHQWWKHPDUHOLVWHGLQ7DEOH
7KHVHDODUPVZLWKWKHH[FHSWLRQRIWKH(DODUPFDQQRWEH
UHVROYHGLQWKHILHOGDQGZLOOUHTXLUHWKHXQLWWREHUHWXUQHGWR
$'75$1IRUVHUYLFHVHHWKHIURQWSDJHVRIWKLVPDQXDOIRUUHSDLU
DQGUHWXUQLQIRUPDWLRQ
7KH(DODUPFDQVRPHWLPHVEHFDXVHGE\DEORZQIXVHLQRQHRI
WKHVKHOIFDUGV7RGHWHUPLQHLIDIXVHLVWKHFDXVHEHJLQWDNLQJRQH
FDUGRXWRIWKHVKHOIXQWLOWKH(PHVVDJHFOHDUV5HSODFLQJWKH
SUREOHPFDUG·VIXVHVKRXOGVROYHWKHSUREOHP,IWKHSUREOHP
FRQWLQXHVFRQWDFW\RXU$'75$1FXVWRPHUVHUYLFHUHSUHVHQWDWLYH
VHHWKHIURQWSDJHVRIWKLVPDQXDO
7DEOH&RQWUROOHU&DUG(UURU0HVVDJHV
(UURU1XPEHU
&RQGLWLRQ
(
520HUURULQWKHFRQWUROOHU
(
5$0HUURULQWKHFRQWUROOHU
(
8$57$IDLOHGLQWKHFRQWUROOHU
(
8$57%IDLOHGLQWKHFRQWUROOHU
(
8$57$IDLOHGLQWKHFRQWUROOHU
(
8$57%IDLOHGLQWKHFRQWUROOHU
(
57&HUURU
6PDUW6KHOI8VHU0DQXDO
/
SMART 16
SHELF
CONTROLLER
Displays assigned shelf number.
Also displays error messages
(see Table 3-2).
SHELF
NUMBER
1
2
ALARM
3
Alarm LEDs. See Table
3-3 for conditions and
solutions.
4
6-pin modular jack used
for DATAMATE connection.
LOCAL
CONTROL
)LJXUH&RQWUROOHU&DUG)URQW3DQHO
/
6PDUW6KHOI8VHU0DQXDO
7DEOH/('$ODUP0HVVDJHV
$ODUP1XPEHU
&RQGLWLRQ
6ROXWLRQ
)DLOXUHLQOHIWSRZHUVXSSO\
5HSODFHSRZHUVXSSO\
)DLOXUHLQULJKWSRZHUVXSSO\
5HSODFHSRZHUVXSSO\
/DWFKHGDODUP'%8KDVEHHQ &OHDUDODUPE\IROORZLQJWKH
DFWLYDWHG
VWHSVLQWKHVHFWLRQ&OHDULQJ
'%8$ODUPV
1RDFWLYLW\LQODVWPVLOOX
PLQDWHVRQVXEFRQWUROOHUVKHOI
RQO\7KHVXEFRQWUROOHUVKHOI
GLGQRWJHWDUHVSRQVHIURPWKH
PDVWHUVKHOI
&KHFNIRUWKHIROORZLQJFRQGL
WLRQV
%DGFDEOH
%DFNSODQHQRWVHDWHGFRU
UHFWO\
&KDLQLQ&KDLQRXWVFKHPH
LQFRUUHFWVHH)LJXUH
&OHDULQJ'%8$ODUPV
7RFOHDU'%8DODUPVIURPWKHFRQWUROOHUFDUG·VIURQWSDQHO
LQGLFDWHGE\$/$50/('SURFHHGZLWKWKHVWHSVOLVWHGEHORZ
'$7$0$7(3URFHGXUH
&OHDUWKH'%8DODUPDVVRFLDWHGZLWKWKH'68FDUG
3UHVV $/$50&/($5IURPWKH0DLQPHQX
973URFHGXUH
&OHDUWKH'%8DODUPDVVRFLDWHGZLWKWKH'68FDUG
6HOHFW $/$509,(:IURPWKH0DLQPHQX
6HOHFWWKHVKHOIQXPEHU
9LHZODWFKHGDODUPV
6HOHFWWKHVORWQXPEHU
&OHDUODWFKHGDODUPV
6PDUW6KHOI8VHU0DQXDO
/
$SSHQGL[$
3LQRXWV
(,$&RQQHFWRU3LQRXW
7KHSLQRXWIRUWKH(,$FRQQHFWRULVIRXQGEHORZ
7DEOH$(,$&RQQHFWRU3LQRXW
3LQ
/
(,$
$$
%$
%%
&$
&%
&&
$%
&)
'%
''
&'
&(
'$
'HVFULSWLRQ
3URWHFWLYH*URXQG3*
7UDQVPLW'DWD7'
5HFHLYH'DWD5'
5HTXHVWWR6HQG56
&OHDUWR6HQG&6
'DWD6HW5HDG\65
6LJQDO*URXQG6*
5HFHLYHG/LQH6LJQDO'HWHFWRU&'
7HVW3RLQW
7HVW3RLQW
7UDQVPLW&ORFN7&
5HFHLYH&ORFN5&
/RFDO/RRSEDFN//
'DWD7HUPLQDO5HDG\75
5HPRWH/RRSEDFN5/
5LQJ,QGLFDWRU5,
([WHUQDO7;&ORFN(7&
7HVW,QGLFDWRU7,
6PDUW6KHOI8VHU0DQXDO
$SSHQGL[$3LQRXWV
&75/,1DQG&75/287&RQQHFWRU3LQRXWV
8VHWKH&75/,1FRQQHFWRUDVDQ56SRUWIRUFRQQHFWLRQWRD
FRPSXWHURUPRGHPFKDLQLQRUDQRWKHU768SURGXFWFKDLQRXW
8VHWKH&75/287FRQQHFWRUWRFRQQHFWWRDQRWKHU6PDUWFKDLQ
LQFRQQHFWRU7KHSLQRXWVDUHIRXQGEHORZ
&RQQHFWRU7\SH
5-
3URGXFW1XPEHU
$03
7DEOH$&75/,QDQG&75/2XW&RQQHFWRU3LQRXWV
&75/,1
&75/287
*1'
*1'
5;&7/,1
7;&7/287
5;&7/,1
7;&7/287
7;&7/,1
5;&7/287
7;&7/,1
5;&7/287
*1'
*1'
'755,DQG&'DUHXVHGZKHQWKHFKDLQLQSRUWLVIXQFWLRQLQJDVD'7(
FRQQHFWHGWRDPRGHP576DQG&76DUHXVHGZKHQWKHFKDLQLQSRUWLVIXQF
WLRQLQJDVD'&(FRQQHFWHGWRD3&RUDWHUPLQDO
6PDUW6KHOI8VHU0DQXDO
/
$SSHQGL[$3LQRXWV
$ODUP&RQQHFWLRQ3LQRXW
7KHSLQRXWIRUWKHDODUPFRQQHFWLRQLVIRXQGEHORZ
7DEOH$$ODUP&RQQHFWLRQ3,QRXW
3LQ
'HVFULSWLRQ
&20
12
&20
12
'&3RZHU6XSSO\
7KHSLQRXWIRUWKH'&SRZHUVXSSO\FRQQHFWLRQLVIRXQGEHORZ
7DEOH$'&3RZHU6XSSO\3LQRXW
3LQ
/
6LQJOH'&,QSXW
)UDPH*QG
95HWXUQ
9
1$
1$
6PDUW6KHOI8VHU0DQXDO
'XDO'&,QSXW
)UDPH*QG
95HWXUQ
9
95HWXUQ
9
$SSHQGL[$3LQRXWV
93LQRXW
7KHSLQRXWIRUWKLVFRQQHFWRULVVKRZQEHORZ
&RQQHFWRU7\SH
9
3URGXFW1XPEHU
$03
7DEOH$93LQRXW
3LQ
&&,77
'HVFULSWLRQ
$
3URWHFWLYHJURXQG3*
%
6LJQDOJURXQG6*
&
5HTXHVWWRVHQG576IURP'7(
'
&OHDUWRVHQG&76WR'7(
(
'DWDVHWUHDG\'65WR'7(
)
5HFHLYHGOLQHVLJQDOGHWHFWRU'&'WR'7(
+
'DWDWHUPLQDOUHDG\'75IURP'7(
-
5LQJLQGLFDWRU5,
/
/RFDOORRSEDFN//
1
5HPRWHORRSEDFN5/
5
5HFHLYHGGDWD5'$WR'7(
7
5HFHLYHGGDWD5'%WR'7(
9
5;FORFN5&$WR'7(
;
5;FORFN5&%WR'7(
3
7UDQVPLWWHGGDWD7'$IURP'7(
6
7UDQVPLWWHGGDWD7'%IURP'7(
<
7;FORFN7&$
$$
7;FORFN7&%
8
([WHUQDO7;FORFN(7&$IURP'7(
:
([WHUQDO7;FORFN(7&%IURP'7(
11.
7HVWPRGH70WR'7(
6PDUW6KHOI8VHU0DQXDO
/
$SSHQGL[$3LQRXWV
$X[LOLDU\3RUW3LQRXW
7KHSLQRXWIRUWKH$X[LOLDU\3RUWLVVKRZQEHORZ
7DEOH$$X[LOLDU\3RUW3LQRXW
3LQ
1DPH
,2
1
Shield
I/O
'HVFULSWLRQ
2
DPR
I
Digit Present
3
ACR
O
Abandon Call and Retry
4
CRQ
I
Call Request
5
PND
O
Present Next Digit
6
PWI
O
Power Indication
7
SG
I/O
Signal Ground
13
DSC
O
Distant Station Connect
14
NB1
I
Digit LSB
15
NB2
I
Digit bit 2
16
NB4
I
Digit bit 3
Shield for cable
17
NB8
I
Digit bit MSB
22
DLO
O
Data Line Occupied
8-12
NC
N/A
No Connection
18-21
NC
N/A
No Connection
23-25
NC
N/A
No Connection
/
6PDUW6KHOI8VHU0DQXDO
$SSHQGL[$3LQRXWV
1HWZRUN3LQRXW
2QWKHUHDUSDQHOWKH6PDUWKDVDQHLJKWSRVLWLRQPRGXODUMDFN
ODEHOHGNETWORK7KLVFRQQHFWRULVXVHGIRUFRQQHFWLQJWRWKH
QHWZRUN7KHSLQRXWLVIRXQGEHORZ
&RQQHFWRU7\SH
862&5-&
3URGXFW1XPEHU $03
7DEOH$1HWZRUN3LQRXW
3LQ
1DPH
'HVFULSWLRQ
55;'$7$5,1*
5HFHLYHGDWDIURPQHWZRUN51*
75;'$7$7,3
5HFHLYHGDWDIURPQHWZRUN7,3
1RW8VHG
57;'$7$5,1*
7UDQVPLWGDWDWRQHWZRUN51*
77';'$7$7,3
7UDQVPLWGDWDWRQHWZRUN7,3
1RW8VHG
6PDUW6KHOI8VHU0DQXDO
/
$SSHQGL[$3LQRXWV
56$,QWHUIDFH3LQRXW
7KHSLQRXWIRUWKH56$LQWHUIDFHLVIRXQGEHORZ
7DEOH$56$,QWHUIDFH3LQRXW
3LQ
1DPH
,2
'HVFULSWLRQ
6KLHOG
I/O
6KLHOGIRUFDEOH
7'$
I
7UDQVPLWWHGGDWD
5'$
O
5HFHLYHGGDWD
576$
I
5HDG\WRVHQG
&76$
O
&OHDUWRVHQG
'65$
O
'DWDVHWUHDG\
6*
I/O
6LJQDOJURXQG
&'$
O
&DUULHUGHWHFW
5&%
2
5HFHLYHFORFNUHWXUQ
&'%
2
&DUULHUGHWHFWUHWXUQ
(7&%
,
([WHUQDOWUDQVPLWFORFNUHWXUQ
7&%
2
7UDQVPLWFORFNUHWXUQ
&76%
2
&OHDUWRVHQGUHWXUQ
7'%
,
7UDQVPLWGDWDUHWXUQ
7&$
2
7UDQVPLWFORFN
5'%
2
5HFHLYHGDWDUHWXUQ
5&$
2
5HFHLYHFORFN
1&
1$
1RFRQQHFWLRQ
576%
,
5HDG\WRVHQGUHWXUQ
'75$
1&
'65%
2
'DWDVHWUHDG\UHWXUQ
'75%
,
'DWDWHUPLQDOUHDG\UHWXUQ
(7&$
1&
/
,
'DWDWHUPLQDOUHDG\
1$
,
1R&RQQHFWLRQ
([WHUQDOWUDQVPLWFORFN
1$
1RFRQQHFWLRQ
6PDUW6KHOI8VHU0DQXDO
$SSHQGL[$3LQRXWV
5-/LQH3LQRXW
7KHSLQRXWIRUWKH5-/LQHLVVKRZQEHORZ
7DEOH$5-/LQH3LQRXW
3LQ
1DPH
'HVFULSWLRQ
1
R1
Transmit Data from DSU to Network-Ring 1
2
T1
Transmit Data from DSU to Network-Tip 1
3-6
-
Not Used
7
T
Receive Data from Network to DSU-Tip
8
R
Receive Data from Network to DSU-Ring
5-/LQH3LQRXW
7KHSLQRXWIRUWKH5-/LQHLVVKRZQEHORZ
7DEOH$5-/LQH3LQRXW
3LQ
1DPH
1-3
-
'HVFULSWLRQ
Not Used
4
T
Network-Tip
5
R
Network-Ring
6-8
-
Not Used
6PDUW6KHOI8VHU0DQXDO
/
$SSHQGL[%
6SHFLILFDWLRQV
63(&,),&$7,216$1')($785(6
7KLVVHFWLRQGHVFULEHVWKHVWDQGDUGVSHFLILFDWLRQVDQGIHDWXUHV
LQFRUSRUDWHGLQWKH6PDUW6KHOI
1HWZRUN&RPSDWLELOLW\
‡ ''6ZLUH6ZLWFKHG7)7,6'1
,QGLFDWRUVDQG&RQWUROV
)DFHSODWH
‡ /('DODUPLQGLFDWRUV
‡
1XPHULFDOGLVSOD\6KHOI$GGUHVV
5DFNPRXQW8QLWV
‡ /('LQGLFDWRUVGHILQHGLQHDFKXQLW·VXVHUPDQXDO
‡
7HVWSXVKEXWWRQV
3RZHU6XSSOLHV
‡ $&DQG'&/('LQGLFDWRUVIRU9999
YROWDJHVRNJUHHQDQGYROWDJHVIDLOUHG
5HDU3DQHO&RQQHFWLRQV
&RQWURO3RUW
‡ '%(,$
&RQWURO,QDQG2XW
‡ 5-SLQ
'$7$0$7(
‡ 5-
/
6PDUW6KHOI8VHU0DQXDO
$SSHQGL[%6SHFLILFDWLRQV
5DFNPRXQW8QLWV
‡ 8SWR9DQG(,$'7(FRQQHFWRUV
‡
8SWR5-QHWZRUNMDFNVIRUQHWZRUNFRQQHFWLRQV
&DSWLYH3RZHU&RUG
‡ $&YHUVLRQVZLWKVLQJOHRUGXDOLQSXWV
6FUHZ7HUPLQDOV
‡ '&YHUVLRQVZLWKVLQJOHRUGXDOLQSXWV
$ODUP
‡ VFUHZWHUPLQDOV
3K\VLFDO
6L]H
‡ µZLGHµKLJKµGHHS
:HLJKW
‡ SRXQGVHPSW\
‡
SRXQGVIXOO
0RXQWLQJ
‡ µUDFNRUFDELQHW
‡
µUDFNRUFDELQHW
3RZHU
,QSXWV
‡ $&YROWDJH9$&“
‡
)UHTXHQF\+]
‡
'&YROWDJH9'&
)XVH5DWLQJV
‡ $&YHUVLRQ$$*
‡
'&YHUVLRQ$$*
5HOD\&RQWDFW5DWLQJV
‡ 1RQLQGXFWLYHORDG
‡
0D[LPXPVZLWFKHGSRZHU:RU9$
‡
0D[LPXPVZLWFKHGFXUUHQWDPSV
‡
0D[LPXPVZLWFKHGYROWDJH9'&RU9$&
‡
8/5DWLQJ$#9'&$#9$&
6PDUW6KHOI8VHU0DQXDO
/
$SSHQGL[%6SHFLILFDWLRQV
3RZHU6XSSO\2XWSXWVWR6KHOI
‡ 9'&#DPSV
‡
9'&#DPSV
‡
9'&#DPSV
‡
9'&#DPSV
(QYLURQPHQWDO
7HPSHUDWXUH
‡ 2SHUDWLQJ2&WR2&2)WR2)
‡
6WRUDJH2&WR2&2)WR2)
5HODWLYH+XPLGLW\
‡ 8SWRQRQFRQGHQVLQJ
$JHQF\$SSURYDOV
‡ 8/DQG&8/
/
‡
)&&3DUW
‡
)&&3DUW
6PDUW6KHOI8VHU0DQXDO
$SSHQGL[%6SHFLILFDWLRQV
6PDUW6KHOI8VHU0DQXDO
/
,QGH[
$
AC version affidavit Y, YL
alarm connections alarm menu alarm messages , alarms clearing DBU alarms &
change password connection connection type contents of shipment controller card
connecting input devices error messages front panel installation CTRL OUT
pin assignments '
daisy chaining , DATAMATE , , arrow keys cancel connection to controller card enter LCD window numeric keypad quick shift DBU alarms
clearing DC version 64202023L1-1
(
edit shelf/slot descriptions Edit SNMP phone number enhanced select , environmental
specifications, equipment included equipment needed error messages controller card )
factory reset menu FCC information [
FCC regulations YLLL
fuse ratings fuses ,
indicators input devices installation cabinet/rack controller card power supply -
jumper locations jumper settings /
latched (audible) alarm LED alarm messages LEDs local configuration , local operation Smart 16 Shelf User Manual
Index-67
Index
0
main menu , modem modem connection mounting multi-shelf connection multi-shelf operation 1
network compatibility 2
operation overview 3
6
safety instructions LY
select unit menu service type information YLLL
set date set SNMP address set time shipment contents Smart 16 Shelf
features specifications switch 1 shelf numbering switch locations switch positions switch settings , password power , power supplies power supply installation power up , 7
5
VT 100 , connection to controller card rear panel connections receipt inspection relay contact ratings remote configuration remote operation Index-68
terminal timeout 8
utilities menu 9
:
warranty [LL
Smart 16 Shelf User Manual
64202023L1-1
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement