Clarion Co., Ltd.
Published by Service Dept.
298-6051-00 Feb.2003 P
50 Kamitoda, Toda-shi, Saitama 335-8511 Japan
Service Dept.: 5-66 Azuma , Kitamoto-shi, Saitama 364-0007 Japan
Tel: +81-48-541-2335 / 2432 FAX: +81-48-541-2703
Printed in Japan
Service Manual
NISSAN Automobile Genuine
AM/FM Radio,6 CD changer,
Cassette Stereo
( PN-2530H )
Model
PN-2530H
(Genuine No.28188 CA000)
Model
PN-2532D
(Genuine No.28188 7Y300)
( PN-2532D )
Model
PN-2548N
(Genuine No.28188 CG000)
( PN-2548N )
Cassette tape player section
SPECIFICATIONS
Reproduction syatem: 4track,2channel,stereo
auto reverse system
FF/REW time:
Less than 110sec.(C-60)
Wow & flutter:
Less than 0.15%(W.R.M.S)
Separation:
More than 35dB
Crosstalk:
More than 45dB
S/N ratio:
normal(120us)
More than 55dB(DOLBY B NR on)
More than 47dB(DOLBY B NR off)
chrome(70us)
More than 57dB(DOLBY B NR on)
More than 49dB(DOLBY B NR off)
FF/REW time:
110sec.(C-60)
Tuner section
Tuning system:
Receive frequency:
PLL synthesizer
AM
530kHz to 1710kHz
FM
87.9MHz to 107.9MHz
Intermediate frequency:
AM
450kHz
FM
10.7MHz
Quieting sensitivity:
AM
Less than 38dBu
FM
Less than 15dBu
Separation:
FM
22+5/-7dB(1kHz)
S/N ratio:
AM
More than 45dB
FM
More than 50dB
Auto stop sensitivity(DX):
AM
42+6/-6dBu
(600kHz)
39+6/-6dBu
(1000kHz,1400kHz)
FM
32+6/-6dBu
CD changer section
Separation:
S/N ratio:
Distortion:
-1-
More than 52dB(20kHz LPF)
More than 80dB
Less than 0.2%(20kHz LPF)
PN-2530H /
2532D / 2548N
Side PWB(B13) section:Tape mechanism
REF No. PART No.
DESCRIPTION
REF No. PART No.
DESCRIPTION
REF No. PART No.
DESCRIPTION
C1
C2
C3
C4
C5
C6
C7
C8
C9
C10
C11
C12
C13
C14
C15
560pF
560pF
560pF
560pF
1uF
0.012uF
0.012uF
0.047uF
0.047uF
560pF
560pF
0.1uF
0.1uF
0.01uF
35V4.7uF
C16
C17
C18
C19
IC1
J1
L1
L2
R1
R2
R3
R4
R5
R6
R7
0.01uF
0.47uF
0.1uF
16V22uF
HA12216F
10P
0.047uH
0.047uH
1/16W 27k ohm
1/16W 27k ohm
1/16W 27k ohm
1/16W 27k ohm
1/16W 180 ohm
1/16W 180 ohm
1/16W 330k ohm
R8
R9
R10
R11
R12
R13
R14
R15
R16
R17
R18
VR1
VR2
1/16W 330k ohm
1/16W 11k ohm
1/16W 11k ohm
1/16W 15k ohm
1/16W 15k ohm
1/16W 18k ohm F
1/16W 15k ohm
1/16W 10k ohm
1/16W 3.9k ohm
1/16W 120k ohm
1/16W 22k ohm
10kohm
10kohm
DESCRIPTION
REF No. PART No.
168-5612-05
168-5612-05
168-5612-05
168-5612-05
178-1055-79
168-1232-05
168-1232-05
168-4732-78
168-4732-78
168-5612-05
168-5612-05
168-1042-78
168-1042-78
168-1032-05
163-4753-50
168-1032-05
178-4745-79
168-1042-78
163-2263-30
051-5204-00
074-0898-10
010-2198-26
010-2198-26
119-2731-10
119-2731-10
119-2731-10
119-2731-10
119-1811-10
119-1811-10
119-3341-10
119-3341-10
119-1131-15
119-1131-15
119-1531-10
119-1531-10
032-0140-80
119-1531-10
119-1031-10
119-3921-10
119-1241-10
119-2231-10
012-6014-56
012-6014-56
Bottom PWB(B14) section:Tape mechanism
REF No. PART No.
IC2
DESCRIPTION
051-1776-00 NJL5801K
REF No. PART No.
SW1
013-3953-01 SPPB32
SW2
DESCRIPTION
013-3951-32 MODE SWITCH
Rear PWB(B15) section:Tape mechanism
REF No. PART No.
P1
J2
DESCRIPTION
076-0368-10 10P
074-1012-20 20P
REF No. PART No.
R19
S1
DESCRIPTION
111-5611-91 1/4WS 560 ohm
013-3906-00 SPPB51
BLOCK DIAGRAM
Main section
MAIN SUB
BL101
AM/FM
TUNER
IC101
TA2083
DIVER-IC
PN-2532D, 2548N
LPF
IC104
LC72191
PLL
TAPE MECHANISM
PRE-AMP
DOLBY-B
APS
M
CD CHANGER MECHANISM
DSP/SSP/DAC/
SPMC
SERVO
DRIVER
2.
3.
6.
7.
CONNECTOR
J601
J1002
J1001
IC102
RDS
SAA6581
IC302
LC75412WH
ELECTRONIC
VOLUME
MUTE
IC401
TA7291F
MOTOR
DRIVER
M
RF AMP
880-1917E (PN-2530H)
880-1917F (PN-2532D, 2548N)
IC403
NJM4558
NAVI AMP
6. NAVI INPUT (+)
5. NAVI INPUT (-)
IC702,704
NJM4556
BUFFER AMP
A.
E.
B.
F.
FR SP L-CH (+)
FR SP L-CH (-)
FR SP R-CH (+)
FR SP R-CH (-)
IC701,703
NJM4556
BUFFER AMP
O.
N.
L.
P.
RR SP L-CH (+)
RR SP L-CH (-)
RR SP R-CH (+)
RR SP R-CH (-)
AUD-DCU
INTERFACE
7. TX (AUD-DCU)
8. RX (DCU-AUD)
IC405
S-80933
RESET
CPU
IC404
M30624MGA
SYSTEM CONTROL
D-RAM
PANEL SW
POWER
SUPPLY
8. GND
PN-2530H /
2532D / 2548N
AMP ON
ANT SIG
BACK UP
ACC
GND
GND
27. GND
28. GND
9. DATA GND
15. GND
16. GND
USED ONLY PN-2458N
J201
L-CH INPUT (+)
IC201
L-CH INPUT (-)
NJM4565V
R-CH INPUT (-)
AUX AMP
R-CH INPUT (+)
1. AUX-ON
4. COMBI-ON
K.
G.
H.
D.
J.
M.
A/C
INTERFACE
AUX / COMBI-ON
INTERFACE
- 20 -
30.
31.
23.
21.
25.
22.
26.
REQ (CD-COMBI)
RX (CD-COMBI)
TX (COMBI-CD)
CD L-CH INPUT (+)
CD L-CH INPUT (-)
CD R-CH INPUT (+)
CD R-CH INPUT (-)
">
