Lopi Clean Face Gas Fireplace User's Manual

Features:

Constitution tm

Clean Face Gas Fireplace

• No grills for a traditional masonry fireplace look.

• Durable, tempered glass with safety screen.

• Screen is removable.

• Fire viewing area 1080 sq. in.

• Realistic, four-piece detailed log set with embers and twigs.

• Digital Home Comfort Control System can be operated by

• the hand-held remote control and the wireless wall control.

• Operate Your Fireplace Green - The Electronic Gas Valve can

• be run for greater efficiency in the “Intermittent Pilot Mode”

• with the gas pilot turned off until you need it or “Standing

• Pilot Mode”,with the gas pilot always on, for reliable cold

• weather operation.

• Natural (NG) or Propane (LP) operation.

• Uses Simpson Duravent 8 5/8” x 6” chimney.

• Seven Year “Real World” Warranty.

Gas Input & Performance:

• Adjustable High Heat System:

• 20,800 – 38,000 Btu's (NG)

• 23,500 – 38,000 Btu's (LP)

• Heater Rated Fireplace: Heats up to 1,000 sq. ft.*

*Heating capacity will vary depending on the temperature zone

you live in.

Maintain a 14” min. width between studs and max. 3 1/2” depth of studs for chimney clearance.

Framing Dimensions:

See Installation Manual or visit www.lopistoves.com under Constitution

1. Hearth Requirements: Extends 10” from face and 49 1/2”

2. wide when installed flush. Not required when raised 6”

2. (See Installation Manual or www.lopistoves.com for details)

2. Non-combustible facing - Two side and two top pieces provided

4. with fireplace.

7

3. Side Wall Clearance: 11”

4. Mantle Clearances: 50” from base of fireplace.

4. Maximum allowed mantle depth: 12”

5. Minimum fireplace enclosure height 60”.

6. Measured from base of fireplace.

6. Minimum framing:

6. 50” wide x 56 3/4” tall x 25” deep.

7. Facing Requirements:

6. Provided fiber board or other non-combustible

6. material must extend from the base of the fireplace to

6 .

the header and to the framing members on both sides

1

2

1

Tested and Certified by OMNI-Test Laboratories Inc. to ANSI Z21.88b

“Vented Gas-Fired Direct Fireplace Heater”.

3

4

4

5

1” to 1

-1/2

” Thick Cement Board

41 1/2”

25

” Min.

Must be installed in accordance with all local codes, if any:if not, follow ANSI Z223.1

and the requirements listed in the Owner’s Manual.

10

” Min.

Note: Improper installation of your gas appliance or failure to operate it in accordance to the guidelines detailed in the Owner’s Manual may negate your warranty. We recommend all Lopi appliances be installed and maintained on an annual basis by your specialty hearth retailer.

6

Your Lopi Authorized Dealer is Located At:

Visit us online at: www.lopifire.com

© Copyright T. I. 10/2007 Printed in U.S.A.

We reserve the right to improve or change our products without prior notification. Consult the Owner’s Manual for complete installation requirements. Photos and illustrations are for descriptive purposes only.

#98800000

Constitution tm

Clean Face Gas Fireplace

Constitution tm

Clean Face Gas Fireplace

The Constitution Clean Face gas fireplace by Lopi is exceptional in design and in performance. With advantages not found anywhere else, it's as close to a traditional masonry style fireplace as you can get, but has the latest in modern fire technology.

With low Btu's, the Constitution is a perfect choice for those who enjoy the aesthetics and comfort provided by a large fire without the excess heat. Others clean face fireplace are merely decorative with almost all the heat escaping up the chimney.

The Constitution is “Heater Rated” delivering a heating capacity of up to 1,000 sq. ft.

Advanced Performance

There's nothing traditional about the Constitution's performance.

You have the ultimate in variety and control with variable flame regulation and heat output. A large, detailed log set cast from real wood logs and a gorgeous flame simulate a traditional wood fire. The built-in flame control center is completely hidden so your only focus is on the fire.

Your Build-Green Fireplace

The Constitution features an Electronic IPI (Intermittent Pilot Ignition)

Gas Valve that allows you to run your fireplace in either “Electronic

Ignition” or “Standing Pilot” modes. The Constitution fireplace makes the ideal choice for those looking for a Green Alternative to over other heat and Clean Face fireplaces that dump a majority of their heat straight up the flue into the environment.

Convenient, Easy Operation

Our Home Comfort™ Control System gives you thermostatic control at your fingertips from anywhere in the room. The hand-held remote and wireless modulating wall control programs all functions including on/off, room temperature and flame height adjustment. Both the remote and wall mounted controls come standard with the fireplace.

Wireless

Modulating

Wall Mounted

Control

Controls ON/OFF and

High/Low Settings

Thermostatic

Modulating

Remote

Control

Controls ON/OFF,

High/Low Settings and Room

Temperature.

The Look of a real Fireplace

The Constitution combines a classic fireplace look with no grills or louvers, and the slim outside trim allows a huge view of the fire (1080 sq. in. ). The Constitution comes with standard black trim that gives your fireplace a finished look and high temperature tempted glass with a mesh safety screen in front of the glass. This safety screen helps prevent children from trying to touch the glass. The screen is removable if desired. The Constitution also allows you the ability to personalize the look of you fireplace with beautiful decorative options.

Standard Black Interior Weathered Straight Brick

Herringbone Brick

Fireplace Interior Options

Your Constitution CF fireplace comes standard with a black firebox interior. While not required, the Constitution CF allows you the ability to make your fireplace look like a real masonry fireplace with the reversible fireback brick liner option. You have the choice of Weathered Brick on one side or Herringbone Brick on the other.

Andirons

Enhance the look of your Constitution CF fireplace even further with a choice of three optional cast andirons. Andirons feature finely cast detail and attach to the existing grate. These beautiful cast iron andirons in a selection of Early American motifs, we give your fireplace that finely detailed finish look that will set your fireplace apart from all others.

Colonial

Andiron

Arabesque

Andiron

Accent Light

Add a warm glow to your fireplace even when it’s turned off!

The accent light adds a glowing backlight behind the flames when the fire is on, and enhances the pattern of the fireback when it’s off.

Wrought Iron

Andiron

Extra Room Power Heat Duct Kit

Add heat to an additional room in your home with the optional

Extra Room Power Heat Duct Kit. This venting option uses a remote fan to pull heat off the fireplace and deliver it to an adjoining room. You can direct this heat upstairs, downstairs or anywhere in your home within 20 feet of the fireplace.

Firescreen

Finish your fireplace with a decorative firescreen. The firescreen features detailed legs and handle for a traditional fireplace look.

Ideal protection from the fireplace if you have small children in your home.

Constitution tm

Clean Face Gas Fireplace

The Constitution Clean Face gas fireplace by Lopi is exceptional in design and in performance. With advantages not found anywhere else, it's as close to a traditional masonry style fireplace as you can get, but has the latest in modern fire technology.

With low Btu's, the Constitution is a perfect choice for those who enjoy the aesthetics and comfort provided by a large fire without the excess heat. Others clean face fireplace are merely decorative with almost all the heat escaping up the chimney.

The Constitution is “Heater Rated” delivering a heating capacity of up to 1,000 sq. ft.

Advanced Performance

There's nothing traditional about the Constitution's performance.

You have the ultimate in variety and control with variable flame regulation and heat output. A large, detailed log set cast from real wood logs and a gorgeous flame simulate a traditional wood fire. The built-in flame control center is completely hidden so your only focus is on the fire.

Your Build-Green Fireplace

The Constitution features an Electronic IPI (Intermittent Pilot Ignition)

Gas Valve that allows you to run your fireplace in either “Electronic

Ignition” or “Standing Pilot” modes. The Constitution fireplace makes the ideal choice for those looking for a Green Alternative to over other heat and Clean Face fireplaces that dump a majority of their heat straight up the flue into the environment.

Convenient, Easy Operation

Our Home Comfort™ Control System gives you thermostatic control at your fingertips from anywhere in the room. The hand-held remote and wireless modulating wall control programs all functions including on/off, room temperature and flame height adjustment. Both the remote and wall mounted controls come standard with the fireplace.

Wireless

Modulating

Wall Mounted

Control

Controls ON/OFF and

High/Low Settings

Thermostatic

Modulating

Remote

Control

Controls ON/OFF,

High/Low Settings and Room

Temperature.

The Look of a real Fireplace

The Constitution combines a classic fireplace look with no grills or louvers, and the slim outside trim allows a huge view of the fire (1080 sq. in. ). The Constitution comes with standard black trim that gives your fireplace a finished look and high temperature tempted glass with a mesh safety screen in front of the glass. This safety screen helps prevent children from trying to touch the glass. The screen is removable if desired. The Constitution also allows you the ability to personalize the look of you fireplace with beautiful decorative options.

Standard Black Interior Weathered Straight Brick

Herringbone Brick

Fireplace Interior Options

Your Constitution CF fireplace comes standard with a black firebox interior. While not required, the Constitution CF allows you the ability to make your fireplace look like a real masonry fireplace with the reversible fireback brick liner option. You have the choice of Weathered Brick on one side or Herringbone Brick on the other.

Andirons

Enhance the look of your Constitution CF fireplace even further with a choice of three optional cast andirons. Andirons feature finely cast detail and attach to the existing grate. These beautiful cast iron andirons in a selection of Early American motifs, we give your fireplace that finely detailed finish look that will set your fireplace apart from all others.

Colonial

Andiron

Arabesque

Andiron

Accent Light

Add a warm glow to your fireplace even when it’s turned off!

The accent light adds a glowing backlight behind the flames when the fire is on, and enhances the pattern of the fireback when it’s off.

Wrought Iron

Andiron

Extra Room Power Heat Duct Kit

Add heat to an additional room in your home with the optional

Extra Room Power Heat Duct Kit. This venting option uses a remote fan to pull heat off the fireplace and deliver it to an adjoining room. You can direct this heat upstairs, downstairs or anywhere in your home within 20 feet of the fireplace.

Firescreen

Finish your fireplace with a decorative firescreen. The firescreen features detailed legs and handle for a traditional fireplace look.

Ideal protection from the fireplace if you have small children in your home.

Features:

Constitution tm

Clean Face Gas Fireplace

• No grills for a traditional masonry fireplace look.

• Durable, tempered glass with safety screen.

• Screen is removable.

• Fire viewing area 1080 sq. in.

• Realistic, four-piece detailed log set with embers and twigs.

• Digital Home Comfort Control System can be operated by

• the hand-held remote control and the wireless wall control.

• Operate Your Fireplace Green - The Electronic Gas Valve can

• be run for greater efficiency in the “Intermittent Pilot Mode”

• with the gas pilot turned off until you need it or “Standing

• Pilot Mode”,with the gas pilot always on, for reliable cold

• weather operation.

• Natural (NG) or Propane (LP) operation.

• Uses Simpson Duravent 8 5/8” x 6” chimney.

• Seven Year “Real World” Warranty.

Gas Input & Performance:

• Adjustable High Heat System:

• 20,800 – 38,000 Btu's (NG)

• 23,500 – 38,000 Btu's (LP)

• Heater Rated Fireplace: Heats up to 1,000 sq. ft.*

*Heating capacity will vary depending on the temperature zone

you live in.

Maintain a 14” min. width between studs and max. 3 1/2” depth of studs for chimney clearance.

Framing Dimensions:

See Installation Manual or visit www.lopistoves.com under Constitution

1. Hearth Requirements: Extends 10” from face and 49 1/2”

2. wide when installed flush. Not required when raised 6”

2. (See Installation Manual or www.lopistoves.com for details)

2. Non-combustible facing - Two side and two top pieces provided

4. with fireplace.

7

3. Side Wall Clearance: 11”

4. Mantle Clearances: 50” from base of fireplace.

4. Maximum allowed mantle depth: 12”

5. Minimum fireplace enclosure height 60”.

6. Measured from base of fireplace.

6. Minimum framing:

6. 50” wide x 56 3/4” tall x 25” deep.

7. Facing Requirements:

6. Provided fiber board or other non-combustible

6. material must extend from the base of the fireplace to

6 .

the header and to the framing members on both sides

1

2

1

Tested and Certified by OMNI-Test Laboratories Inc. to ANSI Z21.88b

“Vented Gas-Fired Direct Fireplace Heater”.

3

4

4

5

1” to 1

-1/2

” Thick Cement Board

41 1/2”

25

” Min.

Must be installed in accordance with all local codes, if any:if not, follow ANSI Z223.1

and the requirements listed in the Owner’s Manual.

10

” Min.

Note: Improper installation of your gas appliance or failure to operate it in accordance to the guidelines detailed in the Owner’s Manual may negate your warranty. We recommend all Lopi appliances be installed and maintained on an annual basis by your specialty hearth retailer.

6

Your Lopi Authorized Dealer is Located At:

Visit us online at: www.lopifire.com

© Copyright T. I. 10/2007 Printed in U.S.A.

We reserve the right to improve or change our products without prior notification. Consult the Owner’s Manual for complete installation requirements. Photos and illustrations are for descriptive purposes only.

#98800000

Constitution tm

Clean Face Gas Fireplace