Sony | HCD-XGR60 | User's Manual | Sony HCD-XGR60 User's Manual

Sony HCD-XGR60 User's Manual
HCD-XGR6/XGR60
SERVICE MANUAL
US Model
HCD-XGR6
Ver 1.0 2002.02
E Model
HCD-XGR60
• HCD-XGR6/XGR60 are the Amplifier,
CD player, tape deck and tuner in LBTXGR6/XGR60.
PHOTO :HCD-XGR60
Model Name Using Similar Mechanism
NEW
CD
CD Mechanism Type
CDM37B-30BD60C
Section
Base Unit Name
BU-30BD60C
Optical Pick-up Name
A-MAX.3
Model Name Using Similar Mechanism
NEW
TAPE
Section
SPECIFICATIONS
AUDIO POWER SPECIFICATIONS
(LBT-XGR6 USA models only)
POWER OUTPUT AND TOTAL
HARMONIC DISTORTION:
With 6 ohm loads, both channels driven, from
120-10,000 Hz; rated 140 watts per channel
minimum RMS power, with no more than 10%
total harmonic distortion from 250 milli watts
to rated output.
Inputs
DJ MIX RETURN*:
(phono jacks)
Amplifier section
North American models:
LBT-XGR6
Continuous RMS power output (reference)
160 + 160 watts (6 ohms at
1 kHz, 10% THD)
Total harmonic distortion less than 0.07%
(6 ohms at 1 kHz, 70 W)
MIX MIC:
(phone jack)
Other models:
LBT-XGR60
The following measured at AC 120/220/240V, 50 Hz
DIN power output (rated) 150 + 150 watts
(6 ohms at 1 kHz, DIN)
Continuous RMS power output (reference)
200 + 200 watts
(6 ohms at 1 kHz, 10% THD)
GUITAR:
(phone jack)
PHONO IN:
(phono jacks)
GAME INPUT:
(phono jacks)
MD (VIDEO) IN:
(phono jack)
Outputs
DJ MIX SEND*:
(phono jacks)
PHONES:
(stereo phone jack)
sensitivity 250 mV,
impedance 47 kilohms
sensitivity 75 mV,
impedance 470 kilohms
sensitivity 3 mV,
impedance 47 kilohms
sensitivity 1 mV,
impedance 10 kilohms
sensitivity 250 mV,
impedance 47 kilohms
sensitivity 450 mV
(250 mV), impedance
47 kilohms
sensitivity 250 mV,
impedance 1 kilohms
accepts headphones of
8 ohms or more
— Continued on next page —
COMPACT Hi-Fi STEREO SYSTEM
9-873-567-01
Sony Corporation
2002B0200-1
© 2002. 02
Home Audio Company
Published by Sony Engineering Corporation
HCD-XGR6/XGR60
MD (VIDEO) OUT:
(phono jacks)
FRONT SPEAKER:
voltage 250 mV
impedance 1 kilohms
accepts impedance of 6 to
16 ohms
General
Power requirements
North American models:
Mexican model:
Other models:
* North American and Mexican models only
CD player section
System
Compact disc and digital
audio system
Laser
Semiconductor laser
(λ=795 nm), Emission
duration: continuous
Frequency response
2 Hz – 20 kHz (±0.5 dB)
Signal-to-noise ratio
More than 90 dB
Dynamic range
More than 90 dB
CD OPTICAL DIGITAL OUT
(Square optical connector jack, rear panel)
Wavelength:
660 nm
Output level
–18 dBm
Tape player section
Recording system
Frequency response
4-track 2-channel stereo
40 – 13,000 Hz (±3 dB),
using Sony TYPE I cassette
Tuner section
FM stereo, FM/AM superheterodyne tuner
FM tuner section
Tuning range
North American models: 87.5 – 108.0 MHz
(100 kHz step)
Other models:
87.5 – 108.0 MHz
(50 kHz step)
Antenna
FM lead antenna
Antenna terminals
75 ohms unbalanced
Intermediate frequency 10.7 MHz
AM tuner section
Tuning range
Pan- American models:
Other models:
Antenna
Antenna terminals
Intermediate frequency
530 – 1,710 kHz
(with the interval set at 10 kHz)
531 – 1,710 kHz
(with the interval set at 9 kHz)
531 – 1,602 kHz
(with the interval set at 9 kHz)
530 – 1,710 kHz
(with the interval set at 10 kHz)
AM loop antenna
External antenna terminal
450 kHz
Power consumption
U.S.A. models:
LBT-XGR6
Other models:
LBT-XGR60
Dimensions (w/h/d)
Mass :
LBT-XGR6
LBT-XGR60
Supplied accessories:
120 V AC, 60 Hz
120 V AC, 60 Hz
120 V, 220 V or 230 –
240 V AC, 50/60 Hz
Adjustable with voltage
selector
240 watts
180 watts
Approx. 355 x 425 x 451 mm
Approx. 13.0 kg
Approx. 14.7 kg
AM loop antenna (1)
FM lead antenna (1)
Speaker cords (2)
Speaker pads (8)
Remote commander (1)
Batteries (2)
Design and specifications are subject to change without notice.
Notes on chip component replacement
• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be
damaged by heat.
Flexible Circuit Board Repairing
• Keep the temperature of soldering iron around 270˚C
during repairing.
• Do not touch the soldering iron on the same conductor of the
circuit board (within 3 times).
• Be careful not to apply force on the conductor when soldering
or unsoldering.
CAUTION
Use of controls or adjustments or performance of procedures
other than those specified herein may result in hazardous radiation
exposure.
This appliance is classified as a CLASS 1 LASER product. The
CLASS 1 LASER PRODUCT MARKING is located on the rear
exterior.
2
HCD-XGR6/XGR60
SAFETY CHECK-OUT
After correcting the original service problem, perform the
following safety checks before releasing the set to the customer:
Check the antenna terminals, metal trim, “metallized” knobs, screws,
and all other exposed metal parts for AC leakage. Check leakage as
described below.
LEAKAGE
The AC leakage from any exposed metal part to earth ground
and from all exposed metal parts to any exposed metal part having
a return to chassis, must not exceed 0.5 mA (500 microampers).
Leakage current can be measured by any one of three methods.
1.
A commercial leakage tester, such as the Simpson 229 or RCA
WT-540A. Follow the manufacturers’ instructions to use these
instruments.
2.
A battery-operated AC milliammeter. The Data Precision 245
digital multimeter is suitable for this job.
3.
Measuring the voltage drop across a resistor by means of a
VOM or battery-operated AC voltmeter. The “limit” indication
is 0.75 V, so analog meters must have an accurate low-voltage
scale. The Simpson 250 and Sanwa SH-63Trd are examples of
a passive VOM that is suitable. Nearly all battery operated
digital multimeters that have a 2V AC range are suitable. (See
Fig. A)
NOTES ON HANDLING THE OPTICAL PICK-UP
BLOCK OR BASE UNIT
The laser diode in the optical pick-up block may suffer electrostatic
break-down because of the potential difference generated by the
charged electrostatic load, etc. on clothing and the human body.
During repair, pay attention to electrostatic break-down and also
use the procedure in the printed matter which is included in the
repair parts.
The flexible board is easily damaged and should be handled with
care.
NOTES ON LASER DIODE EMISSION CHECK
The laser beam on this model is concentrated so as to be focused on
the disc reflective surface by the objective lens in the optical pickup block. Therefore, when checking the laser diode emission,
observe from more than 30 cm away from the objective lens.
LASER DIODE AND FOCUS SEARCH OPERATION
CHECK
Carry out the “S curve check” in “CD section adjustment” and
check that the S curve waveforms is output three times.
• MODEL IDENTIFICATION
– Rear Panel –
PART No.
To Exposed Metal
Parts on Set
0.15 µF
1.5 kΩ
AC
Voltmeter
(0.75 V)
Earth Ground
Fig. A. Using an AC voltmeter to check AC leakage.
SAFETY-RELATED COMPONENT WARNING!!
MODEL
COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH
MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS
LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE
COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS
APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS
PUBLISHED BY SONY.
•
PARTS No.
US model
4-237-748-0s
E model
4-237-748-2s
E51 model
4-237-748-3s
Mexican model
4-237-748-4s
Argentina model
4-237-748-5s
Abbreviation
E51 : Chilean and Peruvian model
3
HCD-XGR6/XGR60
TABLE OF CONTENTS
1. GENERAL ·········································································· 5
6-14.SCHEMATIC DIAGRAM
2. DISASSEMBY ··································································· 7
3. TEST MODE ···································································· 15
4. MECHANICAL ADJUSTMENTS ····························· 17
5. ELECTRICAL ADJUSTMENTS ······························· 17
6. DIAGRAMS
6-1. CIRCUIT BOARD LOCATION ······································· 21
6-2. BLOCK DIAGRAM – CD SERVO SECTION – ············· 22
BLOCK DIAGRAM
– TUNER/TAPE DECK SECTION – ························ 23
BLOCK DIAGRAM – MAIN SECTION – ····················· 24
BLOCK DIAGRAM – DISPLAY/KEY CONTROL/
POWER SUPPLY SECTION – ··································· 25
6-3. PRINTED WIRING BOARD – BD SECTION – ············· 26
6-4. SCHEMATIC DIAGRAM – BD SECTION – ·················· 27
6-5. PRINTED WIRING BOARD
– MOTOR LED SECTION – ······································ 28
6-6. SCHEMATIC DIAGRAM
– MOTOR LED SECTION – ······································ 28
6-7. SCHEMATIC DIAGRAM
– MIC/GUITAR SECTION – ····································· 29
6-8. PRINTED WIRING BOARD
– MIC/GUITAR SECTION – ······································ 29
6-9. SCHEMATIC DIAGRAM – MAIN (1/3) SECTION – ···· 30
6-10. SCHEMATIC DIAGRAM – MAIN (2/3) SECTION – ···· 31
6-11. SCHEMATIC DIAGRAM – MAIN (3/3) SECTION – ···· 32
6-12.PRINTED WIRING BOARD – MAIN SECTION – ········ 33
6-13.PRINTED WIRING BOARD
– CD-L,CD-R,HEADPHONE,FRONT INPUT,
D-SW SECTION – ··················································· 34
– CD-L,CD-R,HEADPHONE,FRONT INPUT,
D-SW SECTION – ··················································· 35
6-15.PRINTED WIRING BOARD
– PANEL VR SECTION – ·········································· 36
6-16. SCHEMATIC DIAGRAM
– PANEL VR SECTION – ·········································· 37
6-17. PRINTED WIRING BOARD
– PANEL FL,TC-A,TC-B SECTION – ······················· 38
6-18. SCHEMATIC DIAGRAM
– PANEL FL,TC-A,TC-B SECTION – ······················· 39
6-19. PRINTED WIRING BOARD – PA SECTION – ·············· 40
6-20. SCHEMATIC DIAGRAM – PA SECTION – ··················· 41
6-21. PRINTED WIRING BOARD– TRANS,SUB
– TRANS(XGR6,XGR60:MX MODEL) SECTION – 42
6-22. SCHEMATIC DIAGRAM – TRANS,SUB
– TRANS(XGR6,XGR60:MX MODEL) SECTION – 42
6-23. PRINTED WIRING BOARD– TRANS,SUB
– TRANS(XGR60:E,E51,AR MODEL) SECTION – 43
6-24. SCHEMATIC DIAGRAM – TRANS,SUB
– TRANS(XGR60:E,E51,AR MODEL) SECTION – 43
6-25. IC PIN FUNCTION DESCRIPTION ······························· 44
6-26. IC BLOCK DIAGRAMS ·················································· 50
7. EXPLODED VIEWS
7-1.
7-2.
7-3.
7-4.
7-5.
CASE,BACK PANEL SECTION ······································ 53
FRONT PANEL SECTION-1 ············································ 54
FRONT PANEL SECTION-2 ············································ 55
CHASSIS SECTION ························································· 56
CD MECHANISM DECK SECTION
(CDM-30BD60C) ······························································· 57
7-6. BASE UNIT SECTION (BU-30BD60C) ·························· 58
8. ELECTRICAL PARTS LIST ······································· 59
4
HCD-XGR6/XGR60
SECTION 1
GENERAL
This section is extracted from
instruction manual.
Mainunit
ALPHABETICALORDER
A–D
E–G
A EJECTZ/Z B EJECT wh (13)
AMS./> wa (9, 10)
CD SYNC ql (14, 15)
Direct equalizer qh ej (17)
GUITAR/ROCK/JAZZ/DANCE/
GAME
SALSA/REGGAE/TANGO/
SAMBA/MOVIE
DIRECTION eg (13, 14, 15, 20)
DISC SKIP es (9, 10)
DISC 1 to 5 e; (9)
DISPLAY 2 (23)
H–R
EDIT ea (15)
EFFECT 5 (17)
ENTER 5 (8, 15, 17, 19)
FM MODE 8 (12)
FUNCTION qd (7, 9, 10, 14, 20,
22, 26)
GAME qf (22)
GAME INPUT AUDIO L/R wd
(25)
GAME INPUT VIDEO wd (25)
GAME MIXING qg (22)
GROOVE ek (16)
GUITAR DISTORTION wl (21)
GUITAR jack ed (21)
GUITAR LEVEL ef (21)
H SPEED DUB ql (14)
MIC LEVEL ef (20)
MIX GUITAR/KARAOKE wl (20,
21)
MIX MIC jack ed (20)
P FILE 5 (17)
PHONES jack w;
PLAY MODE es (9, 10)
POWER SAVE/DEMO
(STANDBY) 3 (23)
Power stream indicator 6
PUSH OPEN wj (9)
REPEAT es (10)
123 4567890 qa qs
qd
ek
qf
qg
ej
qh
eh
qj
eg
ef
ed
qk
ql
w;
wa
ws
es
ea
wd
e;
wl wk
wjwhwg wf
5
HCD-XGR6/XGR60
This section is extracted from
instruction manual.
BUTTON DESCRIPTIONS
@/1 1
c/CLOCK SET qs
h/H qj eh
x qj eh
.m /M> qj eh
X qk
z REC qk
HX ws
x ws
m /M ws
R/r/T/t (cursor) wk
S–X
SLEEP 0 (18)
SPECTRUM ANALYZER 4 (20)
SUPER WOOFER ek (16)
SUPER WOOFER MODE ek (16)
SURROUND ek (18)
TIMER SELECT qa (16, 19)
TUNER/BAND 9 (11, 12)
TUNER ENTER wf (11)
TUNER MEMORY wf (11)
TUNING MODE 8 (11, 12)
TUNING - /+ 9 (11, 12)
VOLUME control 7 (10)
X-GROOVE wg (16)
Remote control
ALPHABETICALORDER
C–F
CD N qg (9)
CLEAR 4 (10)
CLOCK/TIMER SELECT ws (16,
19)
CLOCK/TIMER SET 1 (8, 15,
19)
DISC SKIP w; (9, 10)
DISPLAY qa (23)
EFFECT 9 (17)
ENTER 0 (8, 15, 17, 19)
FILE SELECT +/- qd (17)
FUNCTION 3 (7, 9, 10, 14, 20,
22, 26)
BUTTON DESCRIPTIONS
P–V
PRESET - /+ ql
SLEEP wa (18)
SURROUND 5 (18)
TUNER/BAND qf (11, 12)
TUNING - /+ qk (11, 12)
VOL +/- 6 (10)
@/1 2
nN 78
R/r/T/t (cursor) qs
x qh
X qj
m/M qk
./> ql
ws
1
wa
2
3
4
w;
ql
qk
qj
qh
qg
qf
qd
5
6
7
8
9
q;
qa
qs
6
HCD-XGR6/XGR60
SECTION 2
DISASSEMBLY
• The equipment can be removed using the following procedure.
Set
Case
Front panel section
Tape mechanism deck
PANEL FL board, TC-A board, TC-B board
PANEL VR board
MIC/GUITAR board, HEADPHONE board
FRONT INPUT board
D-SW board, CD-L board, Lid (CD) assy, CD-R board
Back panel, DC fan, MAIN board
CD mechanism deck (CDM37B-30BD60C)
Base unit-1 (BU-30BD60C)
Base unit-2 (BU-30BD60C)
BD board
Disc table
Note : Follow the disassembly procedure in the numerical order given.
2-1. CASE
3 Five screws (BVTT 3 × 6)
8 Case
7
1 Three screws
(CASE3 TP2)
5
4 Two screws (BVTP 3 × 8)
6
6
5
2 Three screws (CASE3 TP2)
7
HCD-XGR6/XGR60
2-2. FRONT PANEL SECTION
4 Connector (CN903)
3 Connector (CN311)
5 Connector (CN722)
7 Screw (BVTP 3 X 8)
8 Lug
2Flat type wire (CN431)
1 Flat type wire
(CN371)
9 Screw (BVTP 3 X 8)
0 Lug
6 Connector (CN806)
qs Screw (BVTP 3 X 8)
qf Claw
qg Front panel section
qa Connector (B deck)
qd Four screws (BVTP 3 X 8)
2-3. TAPE MECHANISM DECK
1 Flat type wire (15 core)
2 Two screws
(BVTP 2.6 X 8)
3 Two screws
(BVTP 2.6 X 8)
4
5 Tape mechanism deck
Front panel
8
HCD-XGR6/XGR60
2-4. PANEL FL BOARD, TC-A BOARD, TC-B BOARD
qaFour screws (BVTP 2.6 X 8)
w;TC-A board
qsThree screws
(BVTP 2.6 X 8)
1Screw (BVTP 2.6 X 8)
3Bracket (TA)
2Lug
qkPANEL FL board
qhThree claws
qj
qdEight screws
(BVTP 2.6 X 8)
6Connector
(CN812)
qfFour screws
(BVTP 2.6 X 8)
7Connector
(CN704)
qlTwo claws
9Flat type wire
(CN601)
qgFour screws
(BVTP 2.6 X 8)
0Two knobs (MIC)
wsTC-B board
8Connector (CN703)
4Screw
(BVTP 2.6 X 8)
5Bracket (TA)
waTwo claws
Front panel
2-5. PANEL VR BOARD
2Lug
3Bracket (TA)
1Screws
(BVTP 2.6 X 8)
0Eight screws
(BVTP 2.6 X 8)
5Flat type wire
(CN701)
8Two screws
(BVTP 2.6 X 8)
9Lever (EJECT) assy
qaNine screws
(BVTP 2.6 X 8)
qsPANEL VR board
6Preess the two buttons (EJECT)
7
4Knob (VOLUME)
Front panel
9
HCD-XGR6/XGR60
2-6. MIC/GUITAR BOARD, HEADPHONE BOARD
1Connector
(CN812)
2Two screws
(BVTP 2.6 X 8)
3MIC bracket
4MIC/GUITAR board
5Two screws
(BVTP 2.6 X 8)
6HEADPHONE bracket
7HEADPHONE board
Front panel
2-7. FRONT INPUT BOARD
Front panel
FRONT INPUT board
J804
1Four screws
(BVTP 2.6 X 8)
Front panel
3
2Bumper (Panel)
10
4FRONT INPUT board
HCD-XGR6/XGR60
2-8. D-SW BOARD, CD-L BOARD, LID (CD) ASSY, CD-R BOARD
1Screw (BVTP 2.6 X8)
5Two screws
(BVTP 2.6 X 8)
0Spring (CD)
2D-SW board
qaLid (CD) assy
qfTwo screws
(BVTP 2.6 X 8)
6
9Sub panel (CD-L) assy
4Two screws
(BVTP 2.6 X 8)
qlSub panel
(CD-R) assy
qh
8CD-L board
qgTwo screws
(BVTP 2.6 X 8)
7Four screws
(BVTP 2.6 X 8)
3Connector
(CN704)
qsConnector (CN703)
qdKnob
(CD)
qkCD-Rboard
qjFour screws
(BVTP 2.6 X 8)
2-9. BACK PANEL, DC FAN, MAIN BOARD
XGR6, XGR60: MX model
1Flat type wire (CN441)
9Back panel
4Seven screws
(BVTP 3 X 8)
2Jumper plug
3Screw
(BVTP 3 X 8)
qsDC FAN
(M901)
5Two screws
(BVTP 3 X 8)
qaTwo screws
(BVTP 3 X 8)
7Four screws
(BVTP 3 X 8)
6Three screws
(BVTP 3 X 8)
qdFlat type wire
(CN401)
8
0Connector (CN961)
qjMAIN board
qgTwo screws
(BVTP 3 X 8)
qfConnector (CN411)
qhTwo connectors
(CN901, 902)
11
HCD-XGR6/XGR60
2-10. CD MECHANISM DECK (CDM37B-30BD60C)
6Two screws (BVTP 3 X 8)
1Flat type wire
(CN401)
4Three screws
(BVTP 3 X 8)
3Four screws (BVTP 3 X 8)
7
Wire holder
8
2Connector
(CN411)
7
5Two screws
(BVTP 3 X 8)
9remove two cables from
wire holder.
0 Five screws
(BVTP3 × 8)
qa CD mechanism deck
(CDM37B-30BD60)
12
HCD-XGR6/XGR60
2-11. BASE UNIT-1 (BU-30BD60C)
3 base unit
(BU-30BD60C)
2 boss
1 BU fitting screw
2-12. BASE UNIT-2 (BU-30BD60C)
6Base unit (BU-30BD60C)
1Two floating screws (DIA.12)
2Two screws
(BVTP 2.6 X 8)
3Two stoppers
(BU)
4Two coil springs
(insulator)
5Two coil
springs
(insulator)
Holder (BU30) assy
13
HCD-XGR6/XGR60
2-13. BD BOARD
BU-30BD60C
4Flat type wire (CN102)
5BD board
1Remove the two solders.
3Rivet
2Remove the two solders.
2-14. DISC TABLE
Note: When the disc table is installed, adjust the positions of roller cam
and mark B as shown in the figure, then set to the groove of disc
table.
A
3Step screw
1Screw (BVTP 3 × 8)
4Disc table
2Bracket (BU)
A
14
SECTION 3
TEST MODE
[MC Cold Reset]
• The cold reset clears all data including preset data stored in the
RAM to initial conditions. Execute this mode when returning
the set to the customer.
Procedure:
1. Turn the power ON or set to the DEMO mode.
2. Press three buttons of c/CLOCK SET , TUNER ENTER ,
and \/1 simultaneously.
3. The set is reset, and displays “COLD RESET”, then becomes
DEMO mode.
[Change-over the AM Tuning Interval]
• The AM tuning interval can be changed over 9 kHz or 10 kHz.
Procedure:
1. Press the \/1 button to turn the power ON.
2. Select the function “TUNER”, and press the TUNER/BAND
button to select the BAND “AM”.
3. Press the \/1 button to turn the power OFF.
4. Press the ENTER/NEXT and \/1 buttons simultaneously,
and the display on the fluorescent indicator tube changes to
“AM 9 K STEP” or “AM 10 K STEP”, and thus the tuning
interval is changed over.
[CD Ship Mode] (No memory clear)
• This mode moves the optical pick-up to the position durable to
vibration. Use this mode when returning the set to the customer
after repair.
Procedure:
1. Press the \/1 button to turn the power ON.
2. Press the EDIT and \/1 buttons simultaneously.
3. A message “LOCK” is displayed on the fluorescent indicator
tube, and the CD delivery mode is set.
[LED and Fluorescent Indicator Tube All Lit, Key Check
Mode]
Procedure:
1. Press three buttons of c/CLOCK SET , ENTER/NEXT ,
and DISC 2 simultaneously.
2. LEDs and fluorescent indicator tube are all turned on.
3. Press the DISC 1 button, the MODE and DESTINATION are
displayed fluorescent indicator tube.
4. Each time the DISC 1 button is pressed, the MC/GC category
version is displayed in the following order.
5. Press the DISC 2 button, and the key check mode is acti-vated.
NR
MC
GC
CD
CDDM
TC
TM
TA
ST
BDB
CDMA
BDA
CDMB
6. In the key check mode, the fluorescent indicator tube displays
“K 0 J0 V0”. Each time a button is pressed, “K” value in-creases
to “K69”call the button is pressed.However, once a button is
pressed, it is no longer taken into account.
“J” value increases like 1, 2, 3 ... if turn the . AMS >
JOG dial clock-wise,or it decreases like 0, 9, 8 ... if turn the
. AMS > JOG dial counter-clockwise.
“V” value increases like 1, 2, 3 ... if turn the VOLUME dial
clockwise (“+” direction), or it decreases like 0, 9, 8 ... if turn
the VOLUME dial counterclockwise (“–” direction).
7. To release from this mode, press three buttons in the same
manner as step 1, or disconnect the power cord.
HCD-XGR6/XGR60
[Sled Servo Mode] (CD service mode)
• This mode can run the CD sled motor freely. Use this mode, for
instance, when cleaning the pick-up.
Procedure:
1. Select the function “CD”.
2. Press three buttons c/CLOCK SET , TUNER ENTER , and
DISC 5 simultaneously.
3. The Sled Servo mode is selected, if “CD” is blanking on the
fluorescent indicator tube.
4. With the CD in stop status, press M button in CD section to
move the pick-up to outside track, or m button to inside track.
5. To exit from this mode, press \/1 button turn to the power
OFF.
Note:
• Always move the pick-up to most inside track when exiting from
this mode. Otherwise, a disc will not be unloaded.
• Do not run the sled motor excessively, otherwise the gear can
be chipped.
[Change-over of FUNCTION Name]
• The FUNCTION name of external input terminal can be changed
over to VIDEO or MD. With the FUNCTION selected to “MD”,
about 5dB mute is applied to the input gain.
Procedure:
1. Press \/1 button to turn the power OFF.
2. Press \/1 button together with FUNCTION button for
several seconds, and the power is turned on, the display of
fluorescent indicator tube changes to “MD” or “VIDEO”
instantaneously, and thus the FUNCTION is changed over.
[Aging Mode]
This mode can be used for operation check of tape deck section.
Tape deck section work in parallel.
• If an error occurred:
The aging operation stops and display then status.
• If no error occurs:
The aging operation continues repeatedly.
Procedure:
1. Load the tapes into the decks A and B respectively.
2. Press the FUNCTION button to select the function “CD”.
3. Press the PLAY MODE button to set the “ALL DISCS” mode,
and press the REPEAT button to “REPEAT” off.
4. Press three buttons of c/CLOCK SET , TUNER ENTER ,
and DISC 4 simultaneously.
5. The aging mode is activated, if the indicator of disc tray number on the fluorescent indicator tube is blinking.
6. To release from the aging mode, press the \/1 button to turn
the power OFF and operate the cold reset. (Refer to the “MC
Cold Reset”)
1. Display at the Aging Mode
• Display operating state of tape deck section alternately.
• If an error occurred, stop display.
15
HCD-XGR6/XGR60
2. Tape Deck Section
• The sequence during the aging mode is following as below.
• If an error occurred, stop display that step.
3. CD Section
• The sequence during the aging mode is following as below.
• If an error occurred, stop display that step.
Aging mode sequence (Tape deck section):
Aging mode sequence (CD section):
Rewind the tape A
“TAPE A AG-1”
Tray Turn
Shut off
FWD the tape A
“TAPE A AG-2”
DISC 1
chucking
2 minutes
TOC Read
Fast forward the tape A
“TAPE A AG-3”
Shut off or 20 seconds
RVS the tape A
“TAPE A AG-4”
Track 1 Play
2 seconds
2 minutes
Last Track Play
Rewind the tape A
“TAPE A AG-5”
2 seconds
Shut off
FWD the tape B
“TAPE B AG-2”
Tray Tun
2 minutes
Fast forward the tape B
“TAPE B AG-3”
DISC 4
Chucking
Shut off or 20 seconds
RVS the tape B
“TAPE B AG-4”
2 minutes
Rewind the tape B
“TAPE B AG-5”
TOC Read
Track 1 Play
2 seconds
Shut off
Last Track play
Note: “TAPE * AG- * ” is display of each step.
[VACS ON/OFF]
• The volume control by VACS is turned ON/OFF.
Procedure:
1. Press the \/1 button to turn the power ON.
2. Press the PLAY MODE and \/1 buttons simultaneously.
3. The reaction display appears when switcing ON/OFF.
16
HCD-XGR6/XGR60
SECTION 4
MECHANICAL ADJUSTMENTS
Precaution
1. Clean the following parts with a denatured alcohol-moistened
swab:
record/playback heads pinch rollers
erase head
rubber belts
capstan
idlers
2. Demagnetize the record/playback head with a head demagnetizer.
3. Do not use a magnetized screwdriver for the adjustments.
4. After the adjustments, apply suitable locking compound to the
parts adjusted.
5. The adjustments should be performed with the rated power supply voltage unless otherwise noted.
Torque Measurement
Mode
Torque Meter
FWD
CQ-102C
FWD
back tension
FF/REW
CQ-201B
Meter Reading
2.9~6.9 mN•m
(30 to 70 g•cm)
(0.42 – 0.97 oz•inch)
0.19~0.59 mN•m
(2 to 6 g•cm)
(0.03 – 0.08 oz•inch)
7.8~16.7 mN•m
(80 to 170 g•cm)
(1.11 – 2.36 oz • inch)
SECTION 5
ELECTRICAL ADJUSTMENTS
DECK SECTION
0 dB = 0.775 V
Precaution
1. Demagnetize the record/playback head with a head demagnetizer.
2. Do not use a magnetized screwdriver for the adjustments.
3. After the adjustments, apply suitable locking compound to the
parts adjust.
4. The adjustments should be performed with the rated power
supply voltage unless otherwise noted.
5. The adjustments should be performed in the order given in
this service manual. (As a general rule, playback circuit
adjustment should be completed before performing recording
circuit adjustment.)
6. The adjustments should be performed for both L-CH and R-CH.
7. Switches and controls should be set as follows unless otherwise specified.
8. Set to the DOLBY NR OFF.
9. Set to the test mode.
(1) Press the \/1 button to turn the power ON.
(2) Select the function “TAPE A or B”.
(3) Press the button of c/CLOCK SET , TUNER ENTER ,
and DISC 3 simultaneously, to set the tape deck test mode
and displays “TEST MODE” on the fluorescent indicator
tube.
(4) To release from the test mode, press the \/1 button.
• Test Tape
Tape
P-4-A100
WS-48B
P-4-L300
Signal
Used for
10 kHz, – 10 dB
Azimuth Adjustment
3 kHz, 0 dB
Tape Speed Adjustment
315 Hz, 0 dB Playback Level Adjustment
17
HCD-XGR6/XGR60
Record/Playback Head Azimuth Adjustment
DECK A
DECK B
Note: Perform this adjustments for both decks
Procedure:
1. Mode: Playback (FWD)
test tape
P-4-A100
(10 kHz, – 10 dB)
Adjustment Location: Playback Head (Deck A).
Record/Playback/Erase Head (Deck B).
MAIN board
MD (VIDEO) OUT jack (J701)
L-CH, R-CH
level meter
set
+
–
forward
2. Turn the adjustment screw and check output peaks. If the peaks
do not match for L-CH and R-CH, turn the adjustment screw
so that outputs match within 1dB of peak.
test tape
WS-48B
(3 kHz, 0 dB)
within
1dB
L-CH
peak
within
1dB
Output
level
Screw
position
DECK B
frequency counter
set
+
–
MAIN board
MD (VIDEO) OUT jack (J701)
L-CH, R-CH
R-CH
peak
L-CH
peak
Screw
position
R-CH
peak
3. Mode: Playback
test tape
P-4-A100
(10 kHz, – 10 dB)
L-CH
MAIN board
MD (VIDEO) OUT jack (J701)
L-CH
oscilloscope
V
set
1. Insert the WS-48B into the deck B.
2. Press the H button on the deck B.
3. Press the H SPEED DUB button in playback mode.
Then at HIGH speed mode.
4. Adjust RV392 on the LEAF SW board do that frequency
counter reads 6,000 ± 180 Hz.
5. Press the H SPEED DUB button.
Then back to NORMAL speed mode.
6. Adjust RV391 on the LEAF SW board so that frequency
counter reads 3,000 ± 90 Hz.
H
Adjustment Location: MAIN board
Sample value of Wow and Flutter: 0.3% or less W.RMS (JIS)
(WS-48B)
R-CH
R-CH
waveform of oscilloscope
in phase 45 °
good
90 ° 135 ° 180 °
wrong
4. Repeat step 1 to 3 in playback (REV) mode.
5. After the adjustments, apply suitable locking compound to the
pats adjusted.
18
Tape Speed Adjustment
Mode: Playback
reverse
HCD-XGR6/XGR60
REC Bias Adjustment
Procedure:
1. Mode: Record
FUNCTION: VIDEO
AF OSC
REC Level Adjustment
Procedure:
1. Mode: Record
FUNCTION: VIDEO
DECK B
MAIN board
MD(VIDEO) IN jack (J701)
L-CH, R-CH
1) 315 Hz 
50 mV (– 23.8 dB)
2) 10 kHz 
AF OSC
MAIN board
MD (VIDEO) IN jack (J701)
L-CH, R-CH
315 Hz, 50 mV (– 23.8 dB)
blank tape
CS-123
600 Ω
blank tape
CS-123
600 Ω
attenuator
DECK B
attenuator
set
set
2. Mode: Playback
2. Mode: Playback
recorded
portion
recorded
portion
level meter
level meter
set
+
–
set
+
–
MAIN board
CN301 pin 1 (L-CH)
pin 3 (R-CH)
MAIN board
CN301 pin 1 (L-CH)
pin 3 (R-CH)
3. Confirm playback the signal recorded in step 1 become specification values as follows.
If these values are out of specification values, adjust the RV321
(L-CH) and RV322 (R-CH) on the MAIN board to repeat
steps 1and 2.
Adjustment level: The playback output of 10kHz level difference
against 315 Hz reference should ±0.5 dB.
Adjustment Location: MAIN board
3. Confirm playback the signal recorded in step 1 become specification values as follows.
If these values are out of specification values, adjust the RV351
(L-CH) and RV301 (R-CH) on the MAIN board to repeat steps
1 and 2.
Specification values:
CN301 playback level: 47.2 to 53.0 mV (– 24.3 to – 23.3 dB)
Adjustment Location: MAIN board
– MAIN BOARD (Component Side) –
RV392
TAPE SPEED
(HIGH)
1
CN431
18
CN371
RV391
TAPE SPEED
(NORMAL)
15
1
IC501
RV301
REC LEVEL
R-CH
IC301
1
3
CN301
RV351
REC LEVEL
L-CH
RV321
REC BIAS
L-CH
RV322
REC BIAS
R-CH
IN OUT
MD (VIDEO)
19
HCD-XGR6/XGR60
Note: Clear RF signal waveform means that the shape “◊” can be
clearly distinguished at the center of the waveform.
CD SECTION
Note :
1. CD Block is basically designed to operate without adjustment.
Therefore, check each item in order given.
2. Use LUV-P01 (4-999-032-01) unless otherwise indicated.
3. Use an oscilloscope with more than 10M impedance.
4. Clean the object lens by an applicator with neutral detergent
when the signal level is low than specified value with the
following checks.
VOLT/DIV : 200mV
TIME/DIV : 500ns
level : 1.45 ± 0.3Vp-p
E-F Balance (1 Track jump) Check
S-Curve Check
Oscilloscope
BD board
oscilloscope
BD board
TP(FE)
TP(DVC)
TP(TE)
TP(DVC)
Procedure :
1. Connect oscilloscope to TP (FE).
2. Connect between TP (FE) and TP (DVC ( 1.65 V) by lead
wire.
3. Press the \/1 button to turn the power ON.
4. Load a disc (LUV-P01) and actuate the focus search. (In consequence of open and close the disc tray, actuate the focus search)
5. Confirm that the oscilloscope waveform (S-curve) is symmetrical between A and B. And confirm peak to peak level within 2
±0.5 Vp-p.
Procedure:
1. Connect oscilloscope to TP (TE) and TP (DVC) board.
2. Press the \/1 button to turn the power ON.
3. Load a disc (LUV-P01) and playback the number nine track.
4. Press the bB button. (Becomes the 1track jump mode.)
5. Confirm that the level B and A (DC voltage) on the oscilloscope waveform.
center of
waveform
S-curve waveform
B
symmetry
A (DC voltage)
0V
A
B=1.3 ± 0.6Vp-p
within 4 ±1Vp-p
B
symmetry
Specified level: A × 100=less than – 22%
B
6. Adjust RV101 so that A (DC voltage) becomes 0.
6. After check, remove the lead wire connected in step 2.
Note : • Try to measure several times to make sure than the ratio
of A : B or B : A is more than 10 : 7.
• Take sweep time as long as possible and light up the
brightness to obtain best waveform.
Checking Location:
[BD BOARD]
RF Level Check
oscilloscope
BD board
TP(RFDC)
TP(RFAC)
DVC
Procedure :
1. Connect oscilloscope to TP2 (RFDC) and TP1 (RFAC).
2. Press the \/1 button to turn the power ON.
3. Load a disc (LUV-P01) and playback.
4. Confirm that oscilloscope waveform is clear and check RF
signal level is correct or not.
RFAC
FE
SE
TE
RFDC
RV101
20
HCD-XGR6/XGR60
SECTION 6
DIAGRAMS
6-1. CIRCUIT BOARD LOCATION
TRANS board
PANEL FL board
Note on Schematic Diagram:
• All capacitors are in µF unless otherwise noted. pF: µµF
50 WV or less are not indicated except for electrolytics
and tantalums.
• All resistors are in Ω and 1/4 W or less unless otherwise
specified.
• 2 : nonflammable resistor.
• 5 : fusible resistor.
• C : panel designation.
SUB TRANS board
TUNER PACK
(FM/AM TUNER UNIT)
Note:
The components identified by mark 0 or dotted line
with mark 0 are critical for safety.
Replace only with part number specified.
MAIN board
Note on Printed Wiring Boards:
• X : parts extracted from the component side.
•
: Pattern from the side which enables seeing.
(The other layers´ Patterns are not indicated.)
• Indication of transistor.
C
Q
These are omitted.
B E
Q
PANEL VR board
•
•
•
•
PA board
TC-A board
MIC/GUITAR board
•
•
TC-B board
CD-L board
HEADPHONE board
CD-R board
•
•
FRONT INPUT board
•
A : B+ Line.
B : B– Line.
H : adjustment for repair.
Voltages and waveforms are dc with respect to ground
under no-signal conditions.
BD board section
no mark: CD PLAY
Other board section
no mark: TUNER (FM/AM)
(
): TAPE PLAY
<
>: TAPE REC
[
]: CD PLAY
Voltages are taken with a VOM (Input impedance 10 MΩ).
Voltage variations may be noted due to normal production tolerances.
Waveforms are taken with a oscilloscope.
Voltage variations may be noted due to normal production tolerances.
Circled numbers refer to waveforms.
Signal path.
F : TUNER (FM/AM)
E : TAPE PALY (DECK A)
d : TAPE PALY (DECK B)
G : RECORD
J : CD PALY (ANALOG OUT)
c : CD PALY (DIGITAL OUT)
N : MIC INPUT
Abbreviation
AR
: Argentina model
MX
: Mexican model
E51 : Chilean and Peruvian model
SENSOR board
BD board
D-SW board
MOTOR board
LED board
21
21
B C
E
These are omitted.
Q
B
C
E
These are omitted.
HCD-XGR6/XGR60
6-2. BLOCK DIAGRAMS
– CD SERVO SECTION –
XGR6/XGR60: MX
FILTER
PD1
B
6
PD2
7
C
8
D
9
I-V AMP
A
RF
SUMMING
AMP
B
RFAC
RF EQ
AMP
49
C
RFDCO
DC
AMP
∑ A-D
D
I1-6
E
11
I5-10
10
F
E
48
28
29
RFDCI
TE
E I-V AMP
ASYMMETRY
CORRECTION
FILI
CLTV
SEND
16K
RAM
EFM
DEMODULATOR
DIGITAL
PLL
ASYI
D/A
INTERFACE
SERIAL
IN
INTERFACE
SUBCODE
PROCESSOR
DIGITAL
CLV
26
3
12
LASER DIODE
LD
DRIVE
Q101
LD
1
LD
APC LD
AMP
PD
APC PD
AMP
SERVO AUTO
SEQUENCER
14 5 6 7
NC
8
20
1 2
PWM
&
INTEGRATOR
AOUT1
AOUT2
70
AIN1
71
77
AIN2
76
LOUT1
BUFFER
LOUT2
75
SERVO
INTERFACE
XGR60: E,E51,AR
R-CH
CLOCK
GENERATOR
XTAI
TIMING
LOGIC
DOUT
64 15 18
NC NC NC
2
XTAO
66
67
X101
16.9344MHz
60
CD DIGITALOUT
OPTICAL
OPTICAL
TRANSCEIVER
ON : When the optical pick-up
is inner position.
IC451
PWM2
PD
FOCUS/TRACKING COIL DRIVE,
SPINDLE/SLED MOTOR DRIVE
33 SQ-CLK
32 SQ-DATA
IC102
CD-MUTE 5
19 SCOR
M101
SPINDLE
MOTOR
M
15
16
CH4OUTF
CH4OUTR
MOTOR
DRIVE
CH4SIN
34 SENS
25
37 CD-CLK
36 XLT
35 CD-DATA
BUFFER
Q451-454
40 HOLD
CH3OUTR
MOTOR
DRIVE
CH3RIN
24
A/D
CONVERTER
23
28
29
T+
TRACKING
COIL
T-
12
11
CH2OUTF
CH2OUTR
CH2FIN
COIL
DRIVE
CH2RIN
5
30
6
31
32
33
F+
FOCUS
COIL
F-
14
13
CH1FIN
CH1OUTF
CH1OUTR
COIL
DRIVE
CH1RIN
DIGITAL SERVO
PROCESSOR
TFDR
TRDR
FFDR
FRDR
IC202
BU UP/DW SW 48
S201
(UP SWITCH)
D201
(DISC No.)
LED DRIVE
Q201
LED-DISK 47
IC101 (2/2)
SYSTEM CONTROLLER
(CD MECHANISM CONTROL)
SFDR
SRDR
FOCUS/TRACKING/SLED
SERVO DSP
18
CH3FIN
CH3OUTF
TE
FE
RFDC
SE
M
17
FOCUS/TRACKING/SLED
PWM GENERATOR
M102
SLED
MOTOR
DISC TABLE
SENSOR
TBL-SENS 49
PWM1
28 BU-PWM1
PWM2
26 BU-PWM2
PWM3 24
BU-PWM3
40 41 39 43
TABLE MOTOR DRIVER
IC201
IC501 (1/4)
MIRR/DFCT/
FOK
DETECTOR
Q412
FOK
24 NC
MIRR
22 NC
DFCT
23 NC
MTR-CTRL1 44
1
MTR-CTR2 45
9
OUT2
IN2
IN1
MOTOR
DRIVE
OUT1
3
M
M201
(TABLE)
7
Q411
• R-ch is omitted due to same as L-ch.
• SIGNAL PATH
2
TO SERVO INTERFACE
3
: CD PLAY (ANALOG OUT)
MUTE 20
43 XRST
22
A
(Page 24)
TO MIRR/DFCT/
FOK DETECTOR
EMPH
WFCK
GFS
SCLK
COUT
SSTP
9 21 27
NC
R
CD-L
72
S101
(LIMIT)
LD
PD
DIGITAL
FILTER,
NOISE SHAPER
DIGITAL
OUT
SQSO
SQCK
SCOR
SENS
XLON
DATA
XLAT
CLOK
XRST
MDP
SW
RETURN
R-CH
MUTE
Q401
CPU INTERFACE
OPTICAL PICK-UP BLOCK
(A-MAX.3)
DJ MIX
L
PWM1
18
R
R-CH
PCMD
62 NC
BCK
63 NC
LRCK
61 NC
C2PO
19 NC
ASYO
ERROR
CORRECTOR
F I-V AMP
TRACKING
ERROR AMP
RFAC
L
55
PWM3
FE
16
FEI
17
FOCUS
ERROR AMP
F
51
15
56 53
PCO
FILO
54
IC103
INTERNAL BUS
A
J702
IC101 (1/2)
RF AMP,
FOCUS/TRACKING ERROR AMP
CD D+5V
DIGITAL SIGNAL PROCESSOR,
DIGITAL FILTER, D/A CONVERTER
22
: CD PLAY (DIGITAL OUT)
HCD-XGR6/XGR60
–TUNER/TAPE DECK SECTION –
IC341
+
R-CH
AMS DETECT
Q341-343
HPF
MUTE
Q344,345
DECK-A
32
70
PB
HEAD
A
28
B
R-CH
34
PB-OUT1
27
PB-L
26
B
(Page 24)
C
(Page 24)
120
REC/PB SWITCH
IC321
DECK-B
1
2
3
REC(L)
LEVEL
REC-OUT
ALC1
MUTE ON/OFF
21
REC MUTE ON/OFF
BIAS
TRAP
ALC ON/OFF
R-CH
13
12
11
15
14
REC
BIAS(L)
T331
TC A+10
BIAS OSC
Q331,332
ERASE
HEAD
RV351
IC301
R-CH
C322,L321
RV321
DECK A/B SELECT
PB/REC EQUALIZER AMP
SWITCH
Q321,322
NORM/HIGH
R-CH
4
A/B
REC/PB
HEAD
Q334,335
RIPPLE
FILTER
Q333
TC BLOCK
REC(REW)
REC(FWD)
B-PHOTO
A-PHOTO
B-MODE
A-MODE
B-HALF
A-HALF
Q383,384
A TRIG
DRIVE
A-SOL
REC-L
23
SYSTEM CONTROL
(CD MECHANISM CONTROL)
IC501(2/4)
53
58
61
68
66
67
65
50
46
AMS-IN
TC-MUTE
REC-MUTE
ALC
90
89
57
56
91
70
69
51
B-SHUT
A-SHUT
EQ-H/N
PB-A/B
BIAS
REC-B
REC-A
B-PLAY SW
A-PLAY SW
B-HALF
A-HALF
TC-RELAY
A-TRIG
Q381,382
B TRIG
DRIVE
Q385,386
B-SOL
CAP MOTOR
DRIVE
Q387,388
CAP MOTOR
SPEED CONT
CAP M+
MOTOR-L
MOTOR-H
CN371
FM/AM TUNER UNIT
ST-L
ST-LOUT
FM ANT
FM
75Ω
FM ANT
AM ANT
AM
ANTENNA
ST-ROUT
ST-MUTE
STEREO
TUNED
OUT(ST-DIN)
IN(ST-DOUT)
AM ANT
ST-CLK
ST-CE
R-CH
ST-MUTE
STEREO
TUNED
D
(Page 24)
RV391
52 B-TRIG
55 CAPM-CTRL
54 CAPM-H/L
RV931
TAPE SPEED
LOW
RV932
RV392
TAPE SPEED
HIGH
21 ST-MUTE
2 STEREO
3 TUNED
ST-DIN
ST-DOUT
ST-CLK
ST-CE
25
23
27
22
23
23
ST-DIN
ST-DOUT
ST-CLK
ST-CE
• R-ch is omitted due to same as L-ch.
• SIGNAL PATH
: TUNER (FM/AM)
: PLAYBACK (DECK A)
: PLAYBACK (DECK B)
: RECORD
HCD-XGR6/XGR60
– MAIN SECTION –
(Page 25)
DISTORTION
ON/OFF SWITCH
Q880 – 883
DISTORTION
E
GUITAR AMP
IC853
J802
GUITAR
REC-L
MIC OUT
GUITAR AMP
MIC AMP
IC852
IC850 (2/2)
C
(Page 23)
RV601
GUITAR LEVEL
L
J801
MIX MIC
MIC AMP
MD OUT
RV602
MIC LEVEL
(Page 23)
PB-L
INC1
5
INB1
4
INA1
3
IND1
6
ST-L
D
FUNCTION SELECT
SWITCH
7
INPUT
SELECT
SWITCH
PHONO
EQ AMP
IC601
R-CH
R
X0
12
X1
14
X2
15
X3
11
R-CH
L
A
10
MD IN
X
Q181
F OUT2
14
15
L+R
+
VL
IN1
COMMAND
R-CH
19
VOLUME
CONTROL
SPEANA
OUT1
18
M901
(FAN)
22
FAN MOTOR
DRIVE
Q961, 962
R-CH
F
(Page 25)
TM401
FRONT SPEAKER
IMPEDANCE
USE 4 – 16Ω
Q112
D803
+
Q165,166
IC501 (3/4)
–1
R-CH
11 XC-OUT
Q182
X501
32.768kHz
Q113
EQIC-DAT 80
EQIC-CLK 81
10 XC-IN
+
Q111
L
R-CH
R-CH
Q169,170
Q167,168
–2
R-CH
13 X-OUT
L
R
R-CH
X502
16MHz
15 X-IN
DBFB-H/L 94
SW-MODE 97
AUDIO-OUT 1
–
+
J804 (2/2)
GAME
INPUT
AUDIO
M
16 17
SYSTEM CONTROLLER
(CD MECHANISM CONTROL)
B
9
J701 (2/2)
CPU
INTERFACE
21
+
13
R-CH
R
+
SURROUND OR
DPL BUFFER
J701 (1/2)
L
C
A
B
INEX1
IC181
PHONO
IN
RECB1
IC111
MID/
BASS &
TREBLE
R
R-CH
Q805,806
LEVEL SHIFT
24 NC
BB-B1
B
C
A
B
BB-A1
(Page 23)
CD-L
SWOUT
+
8
CLK
A
INPUT SELECT SWITCH,
GRAPHIC EQUALIZER CONTROL,
ELECTRICAL VOLUME
MIC
2
(Page 22)
MUTE
Q701
R-CH
DATA
IC850 (1/2)
R
–
XGR6
71 FUNC-SEL0
72 FUNC-SEL1
14
POWER AMP
IC801
7
8
R-CH
POWER AMP
GAME
INPUT
VIDEO
18
Q802,803
LEVEL SHIFT
J804 (1/2)
LINE-MUTE 82
MUTE
Q114
12
MUTE
Q115
XGR60
R-CH
TC
+10V
-VEE
J721
VIDEO OUT
11
IC801
MUTE
Q805,855
TH831
STANDBY SWITCH
Q803, 804, 834
TEMPERATURE
DETECT SWITCH
Q831, 832
STK-MUTE 83
HP-MUTE 86
DELAY
Q833
EVER +3.9V
1
RESET SIGNAL
GENERATOR
: CD PLAY
: TAPE PLAY
: RECORD
: MIC INPUT
RESET 12
R-CH
IC801
AC-CUT 20
• R-ch is omitted due to same as L-ch.
• SIGNAL PATH
: TUNER (FM/AM)
OVER LOAD
DETECT
Q801, 851
3
RESET
SWITCH
Q801
+
R-CH
PROTECT 88
DC DETECT
SWITCH
Q433, 434
D401
PROTECT SWITCH
Q431
OVER LOAD
DETECT SWITCH
Q432
OVER LOAD
DETECT SWITCH
Q437
PROTECT SWITCH
Q439
FRONT SPEAKER PROTECT
RELAY DRIVE
Q401, 402
FRONT-RELAY 87
HP-IN 95
24
24
RY401
J803
PHONES
HCD-XGR6/XGR60
– DISPLAY/KEY CONTROL/POWER SUPPLY SECTION –
IC601
IC602
VF
GRID DRIVE
Q608,609
1
8
GR-16
GR-9
ALL BAND 75
16
15
14
13
12
11
DET
B.P.F.
E
LINE
IN
SUB POWER
TRANSFORMER
T901
REC
LEVEL
REC IN
DET
TO FLUORESCENT
INDICATOR TUBE
(FL601)
6
XGR6/
XRF60:MX
VF
VF
+VL
–VL
LED SELB 55
POWER AMP (IC801),
PROTECT CIRCUIT
LED SELA 80
LED DRIVER
B+ SWITCH
Q901-904
16 DATA
17 CLK
18 STB
–35V
FL DRIVER (IC601)
B–
CD A+5V (SW) ,
CD D+5V (SW)
CD MECHANISM
DECK SECTION
B+
D700
D801-804
KEY 0 – KEY 5
64 – 69
D603-613
I2C-DATA 60
I2C-CLK 61
59 JOG A
RECT
D833 – 836
B+ SWITCH
Q921
Q922
+5V (LED)
(PANEL SECTION B+)
D+5V (UNSW)
(CD TRAY SECTION B+)
41 OTM-RESET
AU D+5V
M62493FP (IC101) B+
D+5V (SW)
(CD SENSOR SECTION B+)
30 IIC-DATA
29 IIC-CLK
58 JOG B
+5V
REGULATOR
IC921
D-SW 52
S746
LID (CD)
OPEN/CLOSE
57 VOL A
XIN
56 VOL B
XOUT
ROTARY
ENCODER
S700
82
83
+3.9V
REGULATOR
D+3.9V
75 LED-STBY
74 KEY-POWER
73 KEY-ECO
LED
DRIVE
Q601
IC922
LED
3.9V
–VEE
CD-POWER 38
A+10V
X601
4MHz
+10V
REGULATOR
ST +10V
(FM/AM TUNER UNIT B+)
D602
S619
POWER
SAVE
S620
REMOTE CONTROL
1
RECEIVER
IC931
TC+10V
ON/FF
+12V
REGULATOR
FAN MOTOR B+
4
IC961
TC M+9V
(TC MOTOR SECTION B+)
SIRCS
IC603
CD M+7V
(CD MOTOR SECTION B+)
STBY-RELAY 84
25
25
D911-913
XGR60:E,E51,AR
AC IN
RECT
D841 – 844
IC501 (4/4)
ROTARY
ENCODER
S763
RECT
D831
VOLTAGE
SELECTOR
S901
–35V
REGULATOR
Q903, 908
D701-723
RESET 77
+VH
F961
F962
B+ SWITCH
Q602-605
20-29,1-7,9-12
LED DAT 78
LED SCK 76
LED LATCH 79
P1 – P21
15 GR-3
17 GR-1
RECT
D832
F964
–VH
LED
+3.9V
SYSTEM CONTROLLER
CD MECHANISM
CONTROL
S700
VOLUME
RECT
D902 – 905
POWER
TRANSFORMER
T951
DIST 53
S611,612,S741-751
S613-634,S801-809
S601-605,S701-716
S606-610,S752-755
S713-725
(JOG DIAL)
IC901
4
IC701
GRID DRIVE
Q606,Q607
S763
AMS
.>
+5V
REGULATOR
EVER +3.9V
SYSTEM CONTROLLER (IC501) ,
FL DRIVER (IC601) B+
F963
16,14 – 12
10,9,7-2
GR-2 ,GR-4-GR8
GR9-GR15
FLUORESCENT INDICATOR TUBE
FL601
18 – 21,24 – 41
43,44
SEG-1 – SEG-25
BPF-F02 70
BPF-F03 71
BPF-F04 72
BPF-F05 73
BPF-F06 74
NFF02
INF03
NFF04
INF05
F06
F
DISTORTION
BAND-PASS FILTER
(Page 24)
SPEANA
FLUORESCENT INDICATOR TUBE DRIVER,
KEY CONTROL
(Page 24)
+12V
REGULATOR
IC911
RY901
POWER ON/OFF
RELAY DRIVE
Q901
HCD-XGR6/XGR60
6-3.PRINTED WIRING BOARD – BD SECTION – • See page 21 for Circuit Boards Location.
3
2
1
4
OPTICAL PICK-UP
BLOCK
OP ASSY(A-MAX.3)
BD BOARD
JW144
R143
JR124
JR125
A
JR101
R159
R162
C126
JW110
C153
C127
JW118
JW114
1
8
2
JW102
C125
C122
C121
A
R190
C191
JW115
C129
JW124
R181
L101
D101
M
+
C162
E
M102
SLED
MOTOR
MAIN
BOARD
(Page 33)
Q102
C190
FB102
C181
C171
X101
C168
7
CN101
RN101
JR105
R116
JW138
JW116
JW145
JW117
C114
R182
R171
C182
C172
C167
R119
R172
C112
R131
R107
R106
C109
R109
C108 R108
C110
R124
R123
C111
JR122
JR123
JW130
C198
JW123
R183
C103
C185
JW135
R192
RV101
D
JW119
JW120
JW125
JW142
C145
C165
R104
C123
C183
R196
C124
R194
JW134
R114
R193 R147
JW113
JW122
R173
R103
R102
C102
JW140
1
C101
C195
JW139
R191
JR103
JW121
30
JW141
C104
JW112
R118
10
R120
16
JW127
IC
C
R198
C133
R101
R111
JW133
14
JW111
R117
C197
IC103
JW128
JR104
C194
JW129
C192
C193
C184
8
7
1
JW126
1
15
CN102
R105
JW131
15
21
IC102
C196
C131
JW132
22
28
C118
+
M101
SPINDLE
MOTOR
JR102
C143
C130
E
M
–
FB101
C116
B
R149 R148
C117
Q101
JW143
C159
R122
R158
JW136
R144
R195
5
–
JR106
• Semiconductor
JW137
Location
12
(12)
1-680-003-
Ref. No.
E
26
26
Location
D101
D-4
IC101
IC102
IC103
C-2
B-4
C-1
Q101
Q102
B-2
D-4
HCD-XGR6/XGR60
6-4. SCHEMATIC DIAGRAM – BD SECTION – • See page 44 for Waveforms.
• See page 44 for IC Pin Function. • See page 50,51 for IC Block Diagrams.
R196 680
R195 220k
R194 33k
C184
0.01µ B
TP1
RFAC
C194 0.1
F
C133 33p
C193 100 10V
IC103
CH CXA2581N
RF AMP
FE
RV101
E-F
R109 1M
R124
100k
C165
0.1
F
C145
0.1
F
R104
33k
R123
10k
TP2
RFDC
R120
15k
X101
16.9344
TE
CE
RFDC
IGEN
ADIO
AVSS O
AVDDO
ASYI
BIAS
ASYO
RFAC
AVSS3
FILI
FILO
CLTV
PCO
VSS
XVDD
TES1
XTAI
TEST
XTAO
VSS
XVSS
FRDR
AVDD1
FFDR
IC101
CXD3017Q
DIGITAL SERVO
TRDR
LOUT1
DIGITAL SIGNAL
SRDR
AVSS1
PROCESSOR
SFDR
LCH
AIN1
SSTP
LOUT2
MDP
AIN2
FOK
DFCT
C198
100
10V
5L
DOUT
DGND
C191
100
10V
5L
C190
1
F
D101
UDZ-TE-17-3.9B
LOUT
C195
0.1
F
C126
0.1
F
C127
100
10V
5L
C125
0.1
F
ROUT
XRST
DATA
XLT
CLOK
RN101
100
LDON
SQSO
SENS
LD
TF-
C117
100
10V
C196
0.1
F
TP3
VC
.
VCC
C118
1000p
B
C197
0.1
B
C131
100
10V
R122
100k
T+
R149
10
F+
R148
10
C143
0.1
F
R102
100k
SPD1
C159
0.01
B
M102
SLED
MOTOR
M101
SPINDLE
MOTOR
AGND
AVDD
GND
LD GND
R158
27k
R105
1k
R190
220
C121
0.1
F
A
RFC
C153
0.1
F
R117 1k
C122
100
10V
5L
DVDD
VFC
SW
PD
Q101
2SB710-RTX
LD DRIVE
R159
27k
Q102
2SD1664
L101
4.7µH
PWM1
B
R162
100k
PWM3
PWM2
C
BST
SCOR
GFS
C2PO
XUGF
XPCK
WFCK
XLON
ATSK
SCLK
VDD
XLAT
CLOK
MIRR
COUT
SENS
RMUT
LMUT
SQSO
C114
0.1
F
RFG
SE1
LOCK
RCH
AOUT2
AVDD2
DATA
R182 22k
R181 22k
C129
0.01
F
C102
0.1
B
GND
PD1
D
VC
AC_SUM
RFDCO
EQ_IN
RFDCI
PD
DC_OFST
LD
R147 2.4k
R198
0
F
E
VCC
TFDR
AVSS2
SYSM
C182 100p CH
SQCK
C172 100p CH
C101
3300p
B
VCC
PD2
VC
AOUT1
R172 22k
C103
470p
B
I5-10
R144
33k
SW
CEI
CE
R114
160k
VC
XTSL
SPOA
R171 22k
R173
22k
CN101
21P
VDD
FE
SPOB
R119 2.7k
R183
22k
SE
EMPH
C112
1 C167
B 22p
CH
C171
680p
CH
AVDD3
DOUT
C168
33p
CH
FB102
1-500-445-21
C181
680p
CH
LRCK
BCK
C162
100
10V
RV101
47k
R101
1k
FE1
PCMD
XRST
R116
10
C104
470p
B
R103
15k
R193
120k
DVCC
TE_BAL
BALANCE
TE1
FB101
1-500-445-21
R192
33k
DVC
TE
I1-6
C130
0.1
F
RFAC
FEI
CN102
16P
R143
33k
C116
100
10V
TD1
C124 0.47
B
C109 1500p
C123
0.01
B
R107 10k
C111
R131
220
100p CH
R106 1k
B
R191
33k
C108
0.1 R108
3.3k
B
C192
0.1
F
R111 120k
FD2
C110
3300p
B
FD1
C185
1µ
B
TD2
C183
22000p
B
R118 100
SQCK
SCOR
MGND
+7V
27
27
IC102
BA5974FM-E2
MOTOR/CIL
DRIVE
HCD-XGR6/XGR60
6-5.PRINTED WIRING BOARD – MOTOR LED SECTION – • See page 21 for Circuit Boards Location.
6-6.SCHEMATIC DIAGRAM – MOTOR LED SECTION – • See page 56 for IC Block Diagrams.
LED BOARD
SENSOR BOARD
4.8
TABLE MOTOR DRIVER
4.8
TRAY
MOTOR BOARD
B
B
MAIN BOARD
(Page 33)
MAIN BOARD(2/3)
(Page 31)
DISC TABLE SENSOR
4.8
LED DRIVE
28
28
4.8
HCD-XGR6/XGR60
6-7.SCHEMATIC DIAGRAM – MIC/GUITAR SECTION –
6-8.PRINTED WIRING BOARD – MIC/GUITAR SECTION –
• See page 21 for Circuit Boards Location.
3
2
1
4
MIC/GUITAR BOARD
R876
1k
IC853
GUITAR AMP
Q880-883
DISTORTION
ON/OFF SWITCH
R879
1k
R872
2.2k
R882
47k
R880
10k
Q883
DTA124ESA
C881
47p
2
5
R886
390k
IC852(2/2)
NJM4558L
6
1
R869
68k
2
C813
0.022
8
Q882
DTC124ESA
R885
10k
4
3
C815
47p
R891
1M
R883
47k
Q881
DTC124ESA
C802
R867
2.2k
2
47k
R853
1k
R873
2.2k
R852
100k
J801
R856
680k
R857
4.7k
C819
47p
C817
2.2
50V
R856
JW818
E
C817 C803
C822
JW817
8
IC853
1
JW805
CN812
1
6
C816
Q880
NO811 E
JW806
JW820
JW819
JW823
R873
R858
R888
3
JW824
1
R887
Q883
NO802
Q881
E
R885
CLP804
• Semiconductor
Location
29
Ref. No.
Location
IC850
IC852
IC853
B-3
C-4
C-5
Q880
Q881
Q882
Q883
Q884
C-6
D-6
C-6
C-6
B-4
29
MAIN
BOARD
(Page 33)
Q882 E
C884
F
E
C838
E
E
C880
C837
Q884
JW814
8
C821
C824
D
TC–A
BOARD
(Page 38)
8
R857
L
(CHASSIS)
R867
C818
R878
R884
R878
1k
R886
C837
10
50V
IC852
NO802
C881
FL801
JW815
5
JW822
8
C801
10000p
C882
7
IC850(2/2)
NJM4558L
C818
47p
R882
R881
C821
47/16
C819
6
R883
R874
15k
C822
47/16
C
R807
10k
R872
MIC_GND
C803
1
50V
C836
10000p
+10V
MIC-OUT
IC850
MIC
AMP
1
JW481
JW804
C814
R850
R855
R870
1
C815
MIX MIC
NO811
3P
IC850
R891
R809
1k
JW821
C805
1000p
R854
R874
4
R876
R879
R877
1
220p
R854
C810
R850
1k
C816
2.2
50V
R880
DISTORTION
C806
C813
GUITAR
C836
FL801
J802
C802
47p
MIC-VR-IN
R852
C805
C804
0.47
50V
C806
47p
C804
3
JW816
IC850(1/2)
NJM4558L
R855
10k
JW812
C824
2.2
50V
GND
MIC-VR-OUT
C810
ECHO/GUITAR-IN
ECHO/GUITAR-OUT
JW813
B
CN812
8P
CT-S
R809
R807
C801
IC853(2/2)
NJM4558L
JW801
8
5
7
C884
2.2
50V
6
C882
47p
7
R884
470
IC852
GUITAR AMP
R870
220k
R853
R881
47k
A
IC852(1/2)
NJM4558L
3
4
J802
GUITAR
R888
1k
IC853(1/2)
NJM4558L
1
R877
330
C838
10
50V
C814
47p
R887
10k
Q880
2SC2603
C880
2.2
50V
J801
MIX MIC
Q884
2SC2785
1-683-455-
(CHASSIS)
11
(11)
HCD-XGR6/XGR60
6-9.SCHEMATIC DIAGRAM – MAIN (1/3) SECTION –
XGR6,
DJ MIX
XGR60:MX
SEND
XGR60
XGR6
IC601
C607,657
0.033 MF
0.1 MF
PHONO EQ AMP
C604,654
2.2/50V
4.7/50V
R604,654
1K
820
IC601(1/2)
NJM4558M
C655
0.0047
PET
C656
0.0015
PET
R112
10k
R759
1k
R709
1k
C610
100
16V
C705 C755
220p 220p
R127
220k
80
R119
560
IC601(2/2)
NJM4558M
JW751
JW701
R121
680k
R120 R137
100k 100k
XGR6,
XGR60:MX
MODEL
TA-MUTE
Q114,115
AC-MUTE
MUTE
R657
1k
5
C658
10
50V
S
Q113
2SK1825
C657
*
MF
6
C653
100p
R135
0
R129
1M
SWITCH
C123
0.33
MF
EXCEPT
R658
100k
7
R651
1k
R115
47k
Q111,112,113
C613
47
16V
R611
1k
Q611
2SC2603
R122
2.2k
C611
47
16V
C134
0.01
R613
330
C135
47
16V
R125
10k
R173
100k
R614
1k
RECOUT-MUTE
Q115
2SC3623ATP
Q114
2SC3623ATP
L-CH SIG
R612
1k
C612
0.01
R707
47k
C124
2.2
50V
R123
100k
R654
*
C111
10 50V
C132
100 16V
R656
47k
R655
560k
C122
0.33 MF
R118
220k
Q112
2SK1825
R116
47k
R133
4.7k
C119
0.047
C120
4700p
C606
0.0015
PET
C117
0.022
C605
0.0047
PET
C136
10
50V
C110
10 50V
C116
0.022
R606
47k
R132
10k
R130
1M
R134
1M
R117
220k
S
R114
1M
C114
10 50V
R605
560k
S
Q111
2SK1825
R113
1M
C137
3300p
C652
100p
R652
1k
C654
*
50
C121
10
50V
R710 R760
100k 100k
C651
330p
R653
47k
C118
10
50V
R111
2.2k
4
R608
100k
C604
*
50
R609
220
1/10W
C115
10 50V
C601
330p
C607
*
MF
C113
10 50V
C602
100p
MODEL
R
C112
10 50V
C608
10
50V
L
C133
10 50V
R603
47k
1
2
R604
*
R607
1k
R708
1k
R602
1k
R601
1k
R
C609
0.01
8
3
L
RETURN
R758
1k
C603
100p
J702
1P
C138
3300p
Q116,164
R124
10k
R126
10k
R174
10k
R180
10k
R179
10k
MUTE
Q116
2SC3623ATP
Q164
2SC3623ATP
IC181
R-CH SIG
MC14052BFR181
10k
FUNCTION
SELECT
R169
560
R182
10k
SWITCH
R171 680k
Q181,182
INVERTER
C173
0.33
MF
C181 0.1
72
71
M61519FP
R161
2.2k
C169
0.047
C170
4700p
C167
0.022
IC111
Q165,166
Q161,162,163
R128
220k
C168
10
50V
R165
47k
C171
10
50V
81
Q161
2SK1825
R136
0
SWITCH,
Q163
2SK1825
+10V
Q162
2SK1825
R168
220k
R166
47k
INPUT SELECT
Q166
2SC2603
S
DBFB
R176
22k
R167
220k
R175
47k
GRAPHIC
J701
6P
AMP
Q165
DTA124ESA
SWITCH
S
R162
10k
C166
0.022
C160
10 50V
C165
10 50V
C164
10 50V
C163
10 50V
R131
10k
Q181
DTC124ESA
JR181
0
JR182
0
C131
10
50V
C162
10 50V
R757
47k
R138
100k
R170
100k
C172
0.33
MF
C161
10 50V
Q182
DTC124ESA
C183
0.1
R172
2.2k
C174
2.2
50V
EQ CONTROL,
S
ELECTRICAL
L
R
R163
1M
C771 0.1
MD IN
R701
1k
R702
100k
C701
220p
R751
1k
R752
100k
C751
220p
C754
10
50V
C703
10
50V
R704
100k
R703
1k
MD OUT
R
C702
220p
MC1
R178 47k
94
R706
2.2k
L
SPE-SIG
R177 47k
R
97
L
R705
10k
Q701
2SC3623A
MUTE
C182
0.1
C772
0.1
Q167-170
C752
220p
(CHASSIS)
R164
1M
VOLUME
C704
10
50V
PHONO IN
R753
1k
R754
100k
R755
10k
Q751
2SC3623A
MUTE
AMP
C753
10 50V
R756
2.2k
CN722
5P EH-S
VIDEO2
Q167
DTA124ESA
Q169
DTA124ESA
Q168
DTC124ESA
Q170
DTC124ESA
MIC-SIG
JW722
R722
39
ST-R
V.GND
ST-L
V2.AU.L-CH
CD-R
A.GND
CD-L
V2.AU.R-CH
J721
1P
C722
1000
10V
PL A+10V
VIDEO OUT
TCREC-R
R724
10k
C724
470p
TCPB-R
TCPB-L
TCREC-L
C774
0.1
JR723
0
C193
0.1
30
30
HCD-XGR6/XGR60
6-10.SCHEMATIC DIAGRAM – MAIN(2/3) SECTION – • See page 44 for Waveforms.
• See page 46 for IC Pin Function.
MC2
MIC-SIG
MIC
SPE-SIG
VF1
LED 3.9V
CD-L
BPF+10V
CD-R
MC1
D 3.9V
ST-R
VF2
VFDP
75
73
74
25
IN(ST-DOUT)
R401
C403
100
2.2
Q401
50V Q401,402
2SC3623A
MUTE
R405
10k
R402
3.3k
C414
0.1
FB562
CN431
19P
FFC-S
R431
100k
MIC-SIG
SPEANA
23
C406
100p
R583 100
R584 100
85
R585 100
86
R586 100
87
R587 100
88
R588 100
89
R589 100
90
R590 100
R596 4.7k
R595 100
53
XRST
HOLD
CLK-OUT
CD-CLK
HP-IN
XLT
AVSS
CD-DATA
SENS
SQ-CLK
AVCC
2.2k
IIC-DATA
IIC-CLK
ST-CLK
BU-PWM1
BU-PWM2
ST-DIN
ST-DOUT
BU-PWM3
ST-CE
AC-CUT
ST-MUTE
NMI
SCOR
RDS-INT
X-IN
RESET
X-OUT
XC-OUT
XC-IN
CNVSS
XGR60
BYTE
1k
TUNED
AUDIO
-OUT
STEREO
*R594
C599
47 16V
CD-MUTE
SQ-DATA
RDS-DATA
FB599
R548 100
48
R547 100
47
Q451
2SC2603
IC451
TOTX141
45
44
R543 100
R451
10k
R541 100
TP539
40
38
R537 100
R536 100
36
35
34
R534 100
33
R533 100
32
R532 100
R452
10k
Q452
2SA1115
R454
10k
24
JW401
26
JW402
28
FB404
CN401
21P
PWM3
JW403
30
JW404
29
JW405
PWM2
PWM1
C516 0.1
R530 100
R529 100
R528 100k
R527 100
R526 100
R524 100
R525 100
R523 100
R521 100
R522 100
JW518
R519 100
R531
10k
FB402
DSP+5V(SW)
D-0UT
D-GND
R407 0
R408 0
C408
1000
6.3V
43
R516
10k
X502
16MHz
35
JW406
36
JW407
37
JW408
32
JW409
L-CH
A-GND
R-CH
RF+5V(SW)
FB403
X-RST
CD-DATA
X-LAT
CD-CLK
LD-ON
SQ-DATA
SENS
JW410
33
30
29
27
28
25
26
23
24
22
21
34
19
OPTICAL
37
R535 100
4
3
OUT
D.GND
Q454
2SC2603
C407
0.1
R517 10k
R513 0
C512 0.1
R509 10k
R504 100
X501 32.768kHz
R511 330k
R503 100
R502 100
CD
DIGITAL
3.3V
C402
1000
6.3V
FB516
2
D.OUT
43
R540 47k
41
XGR6
C510 C511
18p 22p
LED STBY
C452
L451 47
100µH 16V
JW600
R505
10k
KEY POWER
Q453
2SA1115
C401 0.1
R501
10k
KEY ECO
75
46
CD-POWER
VREF
LED 3.9V
73
74
49
OTM-RESET
SW-MODE
R594 *
C598 0.1
BUFFER
R549
10k
B-TRG
A-TRG
AMS-IN
CAPM-H/L
CAPM-CTRL
A-PLAY SW
TC-MUTE
B-PLAY SW
REC/PB/PASS
REC-MUTE
NR-ON/OFF
VSS
VCC
SOFT-TEST
BIAS
EQ-H/N
MTR-CTRL1
DBFB-H/L
95
R599
10k
PB-A/B
ALC
TC-RELAY
A-HALF
KEY-ECO
FUNC-SEL1
FUNC-SEL0
KEY-POWER
PL-LAT
LED-STBY
VIDEO-MUTE
MTR-CTRL2
FRONT-RELAY
DEST-IN
94
97
HP-MUTE
IC501
M30622MCN-A01FP
SYSTEM
CONTROL
LED 3.9V
50
REC-B
TBL-SENS
REC-A
MODEL-IN
PANEL GND
+10V
R453
10k
REAR-RELAY
B-HALF
JW414
40
B-SHUT
R592 4.7k
EVER 3.3V
GC 3.3V
PROTECT
A-SHUT
R593 0
IIC CLK
SIRCS
Q451-454
LED-DISC
VCC
R598
75k
30
29
PANEL GND
BU UP/DW SW
VSS
R597
75k
RESET
IIC DATA
C431
0.1
STBY-RELAY
SIRCS
R582
10k
41
4
STK-MUTE
R591 100
91
VF
VF
C404
2.2
50V
R403
100
D810
EC10DS2-TE
TP563
83
PL-DAT
EQIC
-CLK
LINE-MUTE
82
84
PL-CLK
EQIC-DAT
R581 100
81
Q402
2SC3623A
C562
0.1
ST +10V
MC3
R406
10k
R404
3.3k
51
52
56
54
57
61
58
66
65
68
69
C563
47
16V
R557 100
R575 100
R573 100
21
R574 100
R580 100
ST-MUTE
67
R570 100 70
2
A-GND
ST-ROUT
VFDP
R410
4.7k
55
80
STER EO
ST-LOUT
R571
15k
R572
15k
3
72
TUNED
R556 100
22
ST+10V
71
ST-CE
TUNER PACK
C405
100p
27
D431 1SS355
ST-L
CN441
11P
ST-CLK
OUT(ST-DIN)
SQ-CLK
19
SCOR
M-GND
Q803
DTA124ESA
82
R807
0
Q802
DTC124ESA
-VEE
R806
10k
C804
1000
6.3
C806
2.2
50V
B.P.
R808
100k
R802 4.7k
D805
D807 1SS355TE-1 1SS355TE-1
C803
R805 R804 0.1
47k 47k MF
R801
470
C802
0.1 MF
Q801
D808
2SC2603 1SS355TE-1
RESET SWITCH
Q802,803
LEVEL SHIFT
D803
1SS355
D802 1SS355
R803
4.7k
D806
1SS355TE-1
M+7V(UNSW)
R412
15k
Q411,412
D809
EC10DS2
TC+10V
C410
470
10V
INVERTER
49
D.GND
TRAY.SENS
+5V
C801
10 50
Q411
DTC124ESA
R413
10k
R414
10k
M.GND
TBL.L
45
IC801
M62703ML
RESET SIGNAL
GENERATOR
TBL.R
44
+7V
LED
Q412
DTC124ESA
D+3.3V
47
48
UP.SW
CN411
9P
CT-S
M +7V
R813
10k
CD A+5V SW
Q805
DTA124ESA
CD D+5V SW
D+5V UNSW
EVER+3.9V
Q806
DTC124ESA
R810
100k
R812
3.3k
Q805,806
TA-MUTE
SHIFT
RECOUT-MUTE
AC-MUTE
LEVEL
31
31
HCD-XGR6/XGR60
6-11. SCHEMATIC DIAGRAM – MAIN (3/3) SECTION – • See page 44 for Waveforms. • See page 51 for IC Block Diagrams.
IC341
HPF
CD D+5V SW
R318
10k
IC341(1/2)
NJM4558M
Q344,345
MUTE
R341
1k
Q345
DTC124ESA
IC341(2/2)
C343
0.022
PET
8
5
7
R343
R319
100k
C349
R320
2.2k
C341
470
10V
R342
1k
2
C344
0.022
PET
47k
R338
22k
3
TC+10V
Q341-343
AMS DETECT
R349
4.7k
Q341
2SC2603
Q342
DTC124ESA
C348
22
50V
R340
10k
EVER+3.9V
Q921
2SB1375
INVERTER
Q922
DTC124ESA
INVERTER
Q343
DTC124ESA
R348
4.7k
M +7V
-VEE
53
R347
10k
C350
1
IC921
µPC7805AHF
+5V REGULATOR
ST +10V
R350
10k
470p
D+5V UNSW
MC3
1
6
C342
0.1
CD A+5V SW
D+3.3V
R339
10k
C347
10
50V
4
R346
10k
C921
2200
16V
C924
47
16V
R922
0
C922
0.1
16V
C923
1000
6.3V
38
Q344
DTC124ESA
PL A+10V
TCREC-R
TCREC-L
EP901
R358
10k
TCPB-L
REC LEVEL
TCPB-R
(L)
RV351
22k
C355
0.1
50V
R351
4.7k
C926
470
6.3V
TP351
SELECT
C903
470
16V
C902
0.1
25V
MIC GND
MIC
C901
4700
25V
C356
2.2
50V
C354
10
50V
DECK A/B
C925
0.1
16V
D911
EC10DS2
+10V
TP352
C351
0.01
PET
D912
EC10DS2
R355
8.2k
C353
0.1
MF
REC/PB EQ AMP
C346
2.2
50V
(CHASSIS)
CN903
3P
CT-S
R353
10k
JR351
0
R352
4.7k
HA12236F
R345
4..7k
IC931
M5F7810L
+10V REGULATOR
R354
2.2k
JR353
0
IC301
IC922
µPC3504AHF
+3.9V REGULATOR
D913
EC10DS2
C352
10
50V
C345
2.2
50V
R344
4.7k
C913
47
16V
L-CH SIG
C357
47 16V
R-CH SIG
TP303
CN301
3P
MOLEX
C312
10 50V
DBFB
C311
100
16V
R308
22k
+10V
FOR
CHECK
BPF+10V
C313
10
50V
C310
470p
R309
2.2k
R311
4.7k
GND
VFDP
VF2
58
VF1
C358
390p
67
TP304
C308
390p
HEAD
LED 3.9V
L301
100µ
61
CN311
3P EH
L-PB
TAPE A
MIC
D 3.9V
MC2
66
R-PB
C301
0.01
PET
TAPE B
GND
R-REC
E-HOT
C306
2.2
50V
84
86
83
88
C912
470
10V
REC LEVEL
(R)
RV301
22k
C911
100
25V
R310
10k
R303
10k
JR301
0
R302
4.7k
C302
10 50V
GND
C305
0.1
50V
C303
0.1
MF
JR303
0
HEAD
C304
10
50V
R301
4.7k
C309
390p
R-PB
TP302
C359
390p
GND
87
TP301
L-PB
L-REC
85
IC911
TA8662N
+12V REGULATOR
C307
47 16V
CN321
8P EH
95
68
R305
8.2k
R304
2.2k
CN902
13P
CN901
13P
A TRIG
DRIVE
Q381
2SB1116
69
R381
680
R387
47k
Q385
2SB1068
R389
3.3k
C381
0.0047
R382
2.2k
Q321
DTC124ESA
C382
0.0047
R385
2.2k
R383
2.2k
R388
3.3k
R386
2.2k
R390
3.3k
R391
1.5k
R392
2.7k
C322
0.00012
PET
L321
27mH
Q382
DTC124ESA
C328
10000p
B
R326
10k
C324
330p
R394
220k
Q384
DTC124ESA
Q386
DTC124ESA
IC961
µPC7812AHF
+12V REGULATOR
RV392
2.2k
Q381,382
C961
0.1
JW962
TAPE SPEED
10k
10k
C327
27p
50V
C332
2.2
50V
Q332
2SC2001
C337
10
50V
R337
3.3k
NC
-VEE
POWER
HP.SW
HP MUTE
VF
VF
D.GND
VF(-35V)
EVER+3.9V
+10V
SW-GND
REC(REW)
50
Q962
2SB1116A-L
CN371
15P
FFC-S
R962
22k
The components identified by mark 0 or dotted line
with mark 0 are critical for safety.
Replace only with part number specified.
Q334
DTC124ESA
TAPE
MECHANISM DECK
32
R963
2.2k
50
57
57
B-SOL
B-MODE
91
91
90
B-PHOTO
B-HALF
70
46
70
46
CAPM+
M-GND
A-HALF
56
89
A-SOL
A-PHOTO
C338
47
16V
Q334,335
SWITCH
A-MODE
PET
18000p
6800p
R330
22k
R336
2.2k
C336
PET
18k
R334
C335
R332
5.6
1/4W
FR
C334
R331
5.6
1/4W
FR
R333
T331
BIAS TRANS
6800p
18k
PET
C333
15000p
PET
REC(FWD)
56
R961
4.7k
65
R335
5.6k
Q331,332
BIAS
OSC
PROTECT
FAN SWITCH
Q961
2SC2603-EF
R378
R375
10k
10k
10k
R377
Q335
2SB1116
Q331
2SC2001
C331
0.01
100V
PET
C962
0.1
Q961,962
Q333
2SD1387
R374
Q333
RIPPLE
FILTER
R371
(R)
MOTOR-L
C326
27p
50V
RV322
220k
10k
REC BIAS
RV321
220k
MOTOR-H
(L)
R372
REC BIAS
M901
FAN+
C963
47
16V
(HIGH)
R325
2.2k
R329
12k
C323
0.00012
PET
CN961
3P
EH-L
FAN+
FAN-
DRIVE
C329
10000p
B
R327
10k
C325
330p
STK POWER
15VGN D
Q387,388
CAP MOTOR
SPEED CONT
B TRIG
L322
27mH
UNR EG+15V
NC
10VGN D
UNR EG+10V
A.GND
LCH-IN
RCH -IN
Q387
DTC124ESA
Q388
2SK1825
R324
2.2k
D382
1SS355
R328
12k
DBFB
(NORMAL)
D381
1SS355
C321
10
50V
R393
10k
TAPE SPEED
RV391
4.7k
R321
10k
F-RELAY
DRIVE
R384
680
Q383
2SB1116
Q321,322
SWITCH
POWER GND
54
55
Q385,386
CAP MOTOR
51
Q383,384
52
Q322
DTA124ESA
PL-RELA Y
PB-REC SWITCH
IC321
µPC1330H
FAN.DE T
IC321
32
HCD-XGR6/XGR60
6-12.PRINTED WIRING BOARD – MAIN SECTION – • See page 21 for Circuit Boards Location.
CD DIGITAL
OUT
OPTICAL
I
10
C350
C304
JR301
R310
C303
C301
JW28
JW27
JW25
C358
C308
JW26
C312
R351
C353
C357
JW586
MIC/GUITAR
BOARD
(Page 29)
3
CN903
JW30 C352
JW46
JR353
R352
CN311
C345
R344
RV301
JW24
C306
R309
C310
JR351
R353
C343
R347
R320
R349
JW341
R381
C313
JW400
JW33
C354 R308
R321
TAPE A
HEAD
C359 C309
E
JW585
C331
C332
Q611
R614
5
C609
8
JW536 R653 R656 R657
C656
C652 R655
R651
R652 C653
R654
C655
C604
C658
R658
1
IC601
C657
4
R603
C602
JR16
R609
R605
C603
C612
C606
C608
JW534
JW531
C607
C605
JW535
JW532
JW533
R759
C755
C705
R710
E
R604
R602 R601
C654
1-683-458-
R760
L
DJ MIX
JW538
R608 R606 R607
C601
C651
R758
JW528
R612
R611
C613
J702
JW539
JW537
R
SEND
TAPE B
HEAD
JW543
JW542
JW541
C610
JW331
R332
Q332
JW527
JW523
JW524
JW516
JW517
JW520
JW521
JW522
C754
PHONO
IN
15
JW556
JW751
JW525
TUNER
PACK
JW540
JW526
JW515
JW513
C753
R751
JW514
14
8
XGR6,XGR60:MX MODEL
R708
JW701
EXCEPT
XGR6,
XGR60:MX MODEL
JW504
JW505
JW506
JW507
JW508
JW512
JW511
C704
33
JW23
JW7
R348
Q383
R383
R384
D381
C311
C355
JW49
JW45
R333
R334
C333
C334
JW304
R709
J701
30 31
R302
C307
JW544
T331
L
MD
(VIDEO)
1
40
E
C335
C336
C326
JW51
C772
IN
11 10
JW29
E
R
OUT
R303
JR303
C302
JW551
JW550
CN441
JW548
1
JW549
2
JW547
JW546
JW545
RV321
Q333
R336
JW53
JW301
JW302
JW373
JW374
JW375
JW376
JW10
JW558
C327
E
E
JW305
JW306
JW307
JW308
JW309
JW310
FRONT INPUT
BOARD
(Page 34)
33
JW321
CN321
1
Q331
R330
E
C338
Q334
C701
R756 R701
R754
R753
Q321
Q322
Q335
RV322
R335
C771
C
C322
JW47
L321
JW371
JW372
JR182
JW510
JW395
C181
E
C752
JR15
R703
E
Q751
R304
E
R702
C751
R752
R305
1
EXCEPT
C611
XGR6,
XGR60:MX MODEL R613
JW501
JW502
JW503
C703
R757 JW398
JW399
JW370
JW367
JW368
JW369
JW365
JW366
JR181
JW394
JW396
JW397
JW574
JW573
R755
16
C346
JR17
C321
JW54
R337
CN152
JW313
JW312
JW311
JW349
JW567
JW577
E
R301
IC301
C351
JW43
IC321
C323
L322
JW303
JW44
R329
R328
C324 C325
JW50
R325
E
JR26
C305
20
21
R355
R354
RV351
JW158
1
CN301
JW42
C337
JW6
J721
VIDEO
OUT
9
R706
R704
JW387
Q182
E
E Q701 R705
JW34
3
R327
C328 C329
R326
JW322
JW415
JW320
JW570
JW569
JW362
JW363
JW364
JW572
JW571
JW361
R182
JW386
C193
R722
R707
JW32
JW31
JW159
R324
JW509
IC181
Q181
R345
R358
JW21
1
Q381
JR30
R372
R371
JW39
JW38
JW37
JW36
C356
JW160
JW48
JW161
JW162
JW9
C774
C724
JW391
JR192
JW12
JW384
R181 JR29
8
R375
JW3
JW14
JW13
JW40
JW41
JW35
JW291
JW292
JW293
JW294
JW555
JW299
JW300
Q344
L301
R579
JW602
JW603
R318
Q345
R319
Q342
R311
C341
R342
8
E
R340
R378
R331
JW165
JW564
JW563
JW166
JW286
JW283
JW284
JW285
JW566
JW565
JW281
JW282
JW326
JW325
JW324
JW360
JW359
C183
R339
JW568
C344
R341
R343
C349
JW554
E Q343
E Q341
R338
R577
R574
R571
R385
R386
Q386
JW557
Q382
R390
JW16
RV391 Q387
RV392
Q384
JW1
R393
JW87
5
C342
R350
JW529
JW530
JW562
JW561
JW86
1
IC341
R382
C348
JW153
JW152
JW151
JW150
JW149
R572
JW148
JW147
JW146 R575
JW145
JW144
JW143
R556 JW142
JW141
R557 JW140
JW139
JW138
R570
R573
C563
JW156
JW155
JW154
C562
R548
JW171 R549
JW170
JW169
JW168
JW167
JW55
JW56
JW57
JW58
JW59
JW60
R377
R346
4
E
R374
JW5
R431
C347
C381
C382
CN371 JR25
JW4
PANEL FL
E
D382
JW2
JW73
JW72
JW71
JW20
JW164
JW295
JW296
JW297
JW289
JW290
JW185
JW184
JW183
JW279
JW280
JW314
JW317
JW316
JW315
JW323
JW327
JW358
JW355
JW389
5
CN722
C722
JW380
JW559
JW379
JW378
JW18
JW17
JW15
R599
R595
FB599
JW95 R505
X501
R511
JW174
JW173
JW172
JW82
JW83
JW84
JW85
JW88
R582
R388
11
BOARD
D (Page
38)
CN431
R391
JW52
JW500
JW377
D810
C431
D431
JW89
JW97
JW96
JW98
C511
C510
R513
X502
JW578
R534
JW178
JW177
JW176
JW175
JW278
JW22
JW318
JW357
JW354
JW356
R133
JW388
1
JR723
M901
FAN
R509
JW69
R804
R516
JW104
JW109
JW118
JW276
JW277
JW263
JW68
JW298
JW353
JW352
JW350
JR23
JR191
C166
JW102
JW107
JW105
JW108
R525
R526
R527
JW580
JW275
JW265
JW332
C133
JW333
C163
JW560
C162
JW347
JW348
C160
JW346
C164
JW345
R136
42
C161
R131
C165
JW344
R161
E
E
JW74
JW75
JW76
JW80
JW81
JW319
IC451
CLP4
R394
JW19
E
R389
E
JR31
JW274
JW264
C112
JW337
C135
R135
IC111
JW385
CN961
Q801 R803
D807
C803
D808
D806
D805
JW110
JW111
Q805
R801
R805
R802
C801
JW121
R523
JW601
R528
JW106
JW116
R521
JW182
JW181
JW180
JW179
R543
C702
E
C961
C110
C137
C138
JW336
C171
C167
C168
C170
C134
JW339
R113
R115
JW340
Q961
JW382
R547
C182
R962
C452
R132
1
21
JW381
Q962
50 51
JW103
JR724
C963
R111
C119
R116
C118
JW584
R165
R137
R114
R170
R171
Q167 E
C132
22
R166
Q169 E
R541
R536
R724
IC961
C111
C131
C169
FB562
R537
JR13
JW961
C172
R162
JW962
JW114
Q168 E
C173
JW575
E
E
R112
R130
R173
E Q161
Q170
C123
R163 R177
R961
R963
R175 E
JW576
Q162
R178
Q165
JW582
R168
C122
30
31
E
E
JW328
JW329
JW330
JW588
C113
C136
E
R164
Q163
JW343
R179
Q166
E
E
R172
R138
JR27
E
R120
R129
R119
R169
C117
C120
R121 E
R128
Q116 Q164
C174
Q113 E
E
R123
C115
C121
Q112 E
R167
Q114
R125
JW581
E
JR20
Q111
R127 R117
C124
R124
JW342
JW587
R176
R122
Q115
JR22 R174 R126
R180
JR21
JW583
IC931
R118 JW338
R134
JW257
EP901
JR1
JW270
JW268
JW266
C903
JW250
C902
C116
R592 R591
R596 R594
R598
R590
JW93 C598 JW92
JR3
R597
R589
JW94
R587
R588
1 100
R586
R585
R584
R583
R581
81
80 R580
IC501
R578
E R392
JW77
JW78
JW79
JW287
JW288
C114
JW254
F
JW262
JW261
JW259
JW258
JW260
C901
JW251
JW252
JW253
R593 JW91
Q385
R387
Q388
JW163
C926
JW249
R501
R532
JW190
JW189
JW188
JW187
JW186
IC922
R451
JW229
JW227
JW579
JW191
CN901
JW414
JW247
JW267
C925
R600
C599
R502
R530
R529
R540
JW134
JW135
JW136
JW137
JW271
JW272
JW273
Q454
IC921
R535
JW133
JW269
C924
Q922
JW553
Q453
R453
JW224
JW223
E
JW246
JW225
JW226
JW255
L451
Q451 E
JW248
JW256
9
E
JW65
JW66
JW67
JR4
JR5
JW518
R533
JW408
JW241
JW242
JW243
JW244
JW245
Q452
E
R531
JW131
JW132
JW409
C512
JW90
R503
C516
JW410
R452
JW100
JW101
FB516
JW62
JW61
JW63
JW64
JW600
R504
JR6
JW99
R517
R522
D809
D803
R806
JR14
JW129
JW130
JW238
JW239
JW240
E
E
R524
E
E
C804
R519
JW127
JW128
Q802
JW228
E
C451
JW126
JW237
C923
R813
R812
JW125
JW233
JW234
JW235
R454
F
C962
JW112
JW407
JW124
R922
JW217
D912
JW221
C921
G
C406
R403
R410
D913
C922
PA
BOARD
(Page 40)
(CHASSIS)
JW192
JW120
JW70
C913
D802
E
JW117
JW122
JW123
JW232
D911
JW222
E
R810 JW119
JR7
JW230
JW231
C911
JW219
JW220
H
R404
Q402
C414
R406
C405
R402
R401
JW215
JW216
E
Q921
D
R808
JW236
JW218
IC801
Q806
R408
FB403
C404
CN902
G
C802
JW196
R405
IC911
C806
JW115
JW214
JW213
JW212
JW401
JW402
JW204
C912
C410
JW406
C408
C403
C407
Q401
JW206
JW205
JW209
JW208
JW207
C
R413
JW113 R807
JW194
E
R414
PA
BOARD
(Page 40)
JW403
C402 C413
R407
R412
E Q412
JW203
E Q803
CN401
JW211
FB404
E Q411
JW202
21
20
2
FB402
JW201
B
1
C401
JW198
JW199
JW200
8
7
TAPE
MECHANISM
DECK
JW193
JW411
9
CN411
6
BD
BOARD
(Page 26)
JW210
JW197
JW404
A
5
JW157
MOTOR
BOARD
(Page 28)
CLP2
1
4
JW405
B
MAIN BOARD
A
3
2
1
RETURN
11
(11)
• Semiconductor
Location
Ref. No.
Location
D381
D382
D431
D802
D803
D805
D806
D807
D808
D809
D810
D911
D912
D913
B-9
B-9
B-7
B-5
B-6
B-5
B-5
B-5
B-6
B-7
B-7
C-3
C-3
C-3
IC111
IC181
IC301
IC321
IC341
IC451
IC501
IC601
IC801
IC911
IC921
IC922
IC931
IC961
F-4
H-7
D-10
E-9
B-10
H-2
C-7
H-10
B-5
C-3
D-3
E-3
F-3
H-2
Q111
Q112
Q113
Q114
Q115
Q116
Q161
Q162
Q163
Q164
Q165
Q166
Q167
Q168
F-3
F-3
F-3
G-2
G-2
G-2
G-3
G-2
G-3
G-2
G-2
G-2
H-3
H-2
Ref. No.
Q169
Q170
Q181
Q182
Q321
Q322
Q331
Q332
Q333
Q334
Q335
Q341
Q342
Q343
Q344
Q345
Q381
Q382
Q383
Q384
Q385
Q386
Q387
Q388
Q401
Q402
Q411
Q412
Q451
Q452
Q453
Q454
Q611
Q701
Q751
Q801
Q802
Q803
Q805
Q806
Q921
Q922
Q961
Q962
Location
H-3
H-2
H-6
H-6
E-9
E-9
F-9
F-9
F-9
F-8
E-8
B-9
C-10
B-10
B-11
B-10
B-9
B-8
B-9
B-8
B-9
B-9
B-8
B-8
B-3
B-4
B-2
B-2
D-4
D-4
D-3
D-4
G-10
H-6
H-7
B-6
B-6
B-5
B-5
B-5
C-3
D-4
H-3
H-3
HCD-XGR6/XGR60
6-13.PRINTED WIRING BOARD – CD-L, CD-R, HEADPHONE, FRONT INPUT, D-SW SECTION – • See page 21 for Circuit Boards Location.
3
2
1
FRONT INPUT BOARD
4
5
6
8
7
D–SW BOARD
J804
GAME INPUT
R
A
AUDIO
L
VIDEO
1-684-683-
S704
(DOOR)
C741
C705
CD–L BOARD
JW798
R725
R721
CD–R BOARD
11
(11)
3
H
C703
> AMS >
TC–A
BOARD
(Page 38)
C702
1
2
S763
TC–B
BOARD
(Page 38)
CN704
R723
NO705
C701
C751
R722
NO706
C752
B
C704
FL730
JW799
R724
I
MAIN
BOARD
(Page 33)
R775
R778
R776
R777
CN703
JW898
C
JW896
NO801
C
JW897
5
1
S746
S747
S748
REPEAT
PLAY
MODE
D
DISC
SKIP
D700
BX
S749
EDIT
S741
DISC 1
R791
J891
PHONES
R790
HEADPHONE BOARD
S752
R771
S742
DISC 2
C892
C891
R891
C893
JW891
E
PA
BOARD
NO802
(Page 40)
1
J
EPT720
(CHASSIS)
1-683-454-
NO801
1-683-450-
x
S743
DISC 3
11
(11)
R783
R784
R773
S754
S755
R774
CLP891
11
(11)
S753
R772
S744
DISC 4
4
F
R782
M
M
S745
DISC 5
1-683-452-
34
34
11
(11)
1-683-453-
11
(11)
HCD-XGR6/XGR60
R777
10k
R776
6.8k
R775
4.7k
S748
S747
S746
R774
3.3k
R773
2.2k
R772
1.5k
S744
S743
D-SW
GND
R778
15k
KEY0
6-14. SCHEMATIC DIAGRAM – CD-L, CD-R, HEADPHONE, FRONT INPUT, D-SW SECTION –
CN704
3P
R771
1.5k
S740
S749
EDIT
REPEAT
PLAY
DISC
S745
DISC4
DISC5
DISC2
DISC3
S741
S742
C741
10000p
(DOOR SW)
DISC1
SKIP
MODE
R784
6.8k
CN703
7P
R782
3.3k
R783
4.7k
JOGA
JOGB
GND
S755
S752
S753
S754
KEY4
LED CD
+5VL
+5VH
JOG
S763
CD-JOG
AMS
R790
22
/
D700
SML79423C
ORG/GREEN
R791
22
C751
10000p
C752
10000p
C701
1000p
R723
47k
C702
1000p
R721
47k
R725
1k
NO801
J804
V2.AU.R-CH
A.GND
R
R722
1k
AUDIO
V2.AU.L-CH
L
GAME INPUT
C703
1
50V
V.GND
R891
100
VIDEO
VIDEO2
JW798
C892
1000p
HP.SW
C891
1000p
J803
EPT720
PHONES
HP-R
JW799
HP.GND
C893
0.1
HP-L
FL730
NO801
NO802
4P
C704
0.1
(CHASSIS)
35
35
C705
100p
R724
75
(CHASSIS)
HCD-XGR6/XGR60
6-15.PRINTED WIRING BOARD – PANEL VR SECTION – • See page 21 for Circuit Boards Location.
3
PANEL VR BOARD
5
D
R707
R708
R710
R712
R713
R714
D702
R709
JW701
R733
S705
ENTER
1
IC701
30
16
D701
S700
VOLUME
R732
R731
15
S701
S703
EFFECT
ON/OFF
JW714
R736
R735
R734
C702
C701
S713
JW740
R711
JW713
EPT701
JW706
S704
P FILE
S706
S709
S708
JW709
S707
GUITAR
DISTORTION
D717
JW710
R719
R742
JW727
R741
C704
JW728
JW726
D712
JW719
D703
JW715
C703
R739
JW720
C
R744
D716
S702
GROOVE
D713
R743
JW704
R738
C708
R740
S721
TUNER
MEMORY
JW717
R725
R703
R704
R702
S722
TUNING
MODE
R701
TUNER
ENTER
R706
C707
R705
D710
JW705
C706
R737
JW733
JW750
S720
D714
JW700
R745
R718
JW734
D704
JW716
JW751
JW732
R724
JW731
D709
C705
JW725
R750
R746
SUPER
WOOFER
S714
D711
D720
S719
FM
MODE
D705
D708
JW718
B
D706
D707
JW722
JW723
R726
SUPER
WOOFER
MODE
SURROUND
D715
20
JW721 JW730
S716
S717
R723
L701
JW724
R749
R720
21 CN701
2
D719
TUNING
–
R721
JW712
1
TUNING
+
R722
S718
7
K
A
TUNINER
/BAND
6
JW707
PANEL FL
BOARD
(Page 38)
4
JW711
2
1
S711
S715
X–GROOVE
JW708
R715
S710
MIX GUITER
/KARAOKE
R747
R716
1-683-44711
(11)
36
36
• Semiconductor
Location
Ref. No.
Location
D701
D702
D703
D704
D705
D706
D707
D708
D709
D710
D711
D712
D713
D714
D715
D716
D717
D719
D720
C-5
C-5
B-5
B-5
B-5
A-4
A-4
B-3
B-3
B-3
C-3
C-3
A-7
A-7
A-6
B-6
C-6
A-2
B-1
IC701
C-4
HCD-XGR6/XGR60
LED P1
LED P2
P2
CN701
21P
P1
LED P4
LED P3
P3
LED P5
P4
P5
P6
LED P6
LED3.9V
LED3.9V
+3.9V VL
+3.9V VH
GND
GND
KEY 3
KEY 5
VOL A
CLK
VOL B
DATA
DATA
CLK
LED P7
LED P8
STB
STB
P7
LED P9
P8
P10
P9
LED P10
6-16. SCHEMATIC DIAGRAM – PANEL VR SECTION –
R705
1k
R725
6.8k
R726
10k
R723
3.3k
R724
4.7k
R722
2.2k
R721
1.5k
R719
1k
R720
1.5k
R718
680
S700
C708
10000p
S721
S722
C707
10000p
R706
1k
S720
S719
TUNING
TUNER
TUNER
MODE
MEMORY
ENTER
S718
FM MODE
S717
TUNING(+)
S715
S716
TUNING(-)
TUNER/BAND
S714
X-GROOVE
S713
SUPER WOOFER
SUPER
WOOFER
MODE
VOLUME
R708
1.5k
R707
1k
S702
S701
C706
0.1
GROOVE
R709
1.5k
R710
2.2k
S703
SURROUND
S704
S705
P FILE
EFFECT
EPT701
R711
3.3k
R713
6.8k
R712
4.7k
S707
S706
R714
10k
S708
R715
15k
S709
R716
22k
S710
ENTER
S711
GUITAR DISTORSION
MIX GUITAR
ON/OFF
/KARAOKE
L701
10µ
SUPER
(CHASSIS)
VU 2
VU 4
D704
SEL5823A
AMBER
D702
SEL5823A
AMBER
VU 6
D706
SEL5823A
AMBER
VU 8
D708
SEL5823A
AMBER
VU 10
D710
SEL5223S
RED
D714
SEL5223S
RED
D712
SEL5223S
RED
TUNER ENTER
ENTER
WOOFER
VU 12
D716
SEL5223S
RED
D720
SEL5223S
RED
C704
47
16
IC701
NJU 3719L
LCD DRIVER
C705
10000p
P11
D719
SEL5423E
RED
P15
GUITAR DISTORTION
P18
TUNER/BAND
P19
R749
22
P14
P8
P15
P7
P20
P16
P6
P17
P5
Vss
P4
P18
P3
P19
P2
P20
P1
P21
CLR
P22
STB
P23
CLK
P24
P10
P9
P8
P7
P6
P5
P4
P3
P2
P1
R702
37
37
R701
10k
100
STB
R703
100
R704
100
CLK
DATA
DATA
C701
1000p
P20
R747
100
P13
P13
P9
P14
D715
SEL5223S
RED
R745
100
P10
P13
P16
Vdd
P12
C703
1000p
R750
100
P17
P12
R743
100
SURROUND
D713
SEL5223S
RED
GROOVE
VU 11
R741
47
P19
P18
R739
22
P11
R737
22
R742
47
D711
SEL5223E
RED
D709
SEL5823A
AMBER
R740
47
VU 9
D707
SEL5823A
AMBER
R735
22
P16
P15
R733
22
R738
22
VU 7
VU 5
R731
22
P14
R736
22
D705
SEL5823A
AMBER
VU 3
VU 1
D701
SEL5823A
AMBER
D703
SEL5823A
AMBER
R734
22
P17
R732
22
R746
100
D717
SEL5223S
RED
R744
100
C702
1000p
P11
P12
HCD-XGR6/XGR60
6-17.PRINTED WIRING BOARD – PANEL FL, TC-A, TC-B SECTION – • See page 21 for Circuit Boards Location.
3
2
1
4
5
6
8
7
9
10
11
JW612
JW608
C603 R643
CN601
JAZZ
R640
R678
10
R810
D802
R815
R680
JW601
JW602
JW603
S603
S811
h
TANGO
1-683-448-
11
(11)
S802
h
S805
M>
NO803
R807
S806
z REC
1-683-449-
Location
S604
R673
I
1
CD–R
BOARD
(Page 34)
D607
NO602
11
(11)
38
R624
S605
MOVIE
8
G
38
• Semiconductor
SAMBA
7
S809
CD
SYNC
R625
R672
R623
x
R806
NX601
1 NO601
1
S803
R805
JW801
JW664
JW665
JW662
D605
1
S813
R626
R671
R820
>M
R808
D613
GAME
S808
H SPEED
DUB
X
S807
R804
S610
h
10 R809
D803
R811
JW669
S804
>M
JW802
R679
S801
R812
R642
R803
D801
DANCE
F
RV802
MIC
LEVEL
REGGAE
D606
R802
D612
R641
8
TC-B BOARD
R801
S609
1
S602
R819
x
R817
MIC/
GUITAR
BOARD
(Page 29)
JW741
E
L
D611
D804
S608
R627
D604
NX602
H
S815
DIERCTION
R677
h
D805
M>
NO805
9
S810
D806
ROCK
R670
S814
R813
S607
SALSA
RV801
GUITAR
LEVEL
CD–L
BOARD
(Page 34)
D610
R639
TC-A BOARD
R814
R676
R638
D
S601
K
R816
PANEL VR
BOARD
(Page 36)
S812
GUITAR
D603
C614
D609
R628
R669
JW604
Q604
S611
SPECTRUM
ANALYZER
E
JW663
S606
R621
R600
L605
R618
D601
R619
L604
Q605
E
Q601
C601
JW600
FB601
C604
C628
C602
JW614
R689
R688
Q602
E
S620
S612
DISPLAY
R686
E
R691
JW609
S619
POWER
SAVE/DEMO
(STANDBY)
JW607
Q603
E
R692
R622
R690
R684
R685
D602
JW606
JW605
C612
JW611
X601
R695
R696
R697
R681
R683
JW626
JW625
JW624
JW627
C605
80 81
L601
R667
Q607
L602
R601
JW610
R666
Q606
R668
JW616
R665
Q608
E
JW613
1
E
100
R605
R700 R616
R615
R614
R613
JW628 R612
JW634
JW633
R654
R655
R656
R657
R658
R659
JW617
R604
C607
R617
50
E
JW618
51
JW629
JW671
JW667
JW668
Q609
R609
R606
R607
JW632
JW631
R693
R694
JW630
R603
R602
R608
R610
JW636
JW635
R645
R644
C619
C617
18
IC603
JW672
R675
C625
JW803
JW660
JW661
R637
JW658
JW657
JW670
JW656
JW655
C
CLOCK SET
JW659
R674
JW619
R698
R699
S615
R653
C618 C616
CN602
10
E
31 30
R620
JW641
C615
R635
R636
2
9 IC602 1
R651
R652
1
C613
R648
R650
R649
R646
JW654
JW642
S613
TIMER
SELECT
R634
GAME D608
MIXING S618
R647
R629
1
S617
GAME
MAIN
BOARD
(Page 33)
JW623
JW622
JW621
JW620
60
IC
D
16
FL601
S614
SLEEP
JW643
17
JW652
R632
R633
JW653
R630
L603
JW644
S616
FUNCTION
JW637
JW645
JW647
JW646
JW651
JW650
JW649
JW648
R631
B
C606
C627
A
JW640
JW639
JW638
PANEL FL BOARD
1
1-683-446-
11
(11)
Ref. No.
Location
D601
D602
D603
D604
D605
D606
D607
D608
D609
D610
D611
D612
D613
D801
D802
D803
D804
D805
D806
C-9
A-11
D-11
D-11
E-11
E-11
F-11
B-1
D-2
D-2
E-2
E-2
F-2
F-4
G-4
F-6
G-6
D-8
E-8
IC601
IC602
IC603
B-7
B-4
A-9
Q601
Q602
Q603
Q604
Q605
Q606
Q607
Q608
Q609
B-10
C-8
C-8
C-8
C-8
A-8
A-8
B-8
B-8
HCD-XGR6/XGR60
6-18.SCHEMATIC DIAGRAM – PANEL FL, TC-A, TC-B SECTION – • See page 44 for Waveforms.
44
43
41
40
39
36
38
37
34
35
32
33
30
31
28
29
26
27
24
25
19
20
18
16
14
13
12
10
7
9
4
6
5
3
21
22
FL TUBE
FL601
2
• See page 48 for IC Pin Function. • See page 52 for IC Block Diagrams.
C628
1
50V
C627
1
50V
Q609
DTC114TLTL2
R665
100k
Q608
DTC114TLTL2
R666
100k
Q606-609
C625
10
50V
73
74
75
70
R655 JW
R654 6.8k
R657 JW
R656 JW
MB90M407AFP-G-112-BND
SEG-23
VSS-IO
INDICATOR TUBE DRIVER,
LED SELA
LED LATCH
LED DAT
RESET
LED SCK
BPF5-F06
BPF3-F04
BPF2-F03
KEY 3
KEY 4
AVSS
KEY 0
ALL BAND
XOUT
VSS-CPU
BPF4-F05
MD0
MD1/VDD-VFT
KEY 5
BPF1-F02
VCC-CPU
XIN
KEY 1
KEY 2
NO USE
VKK
I2C-CLK
AVCC
NO USE
NO USE
JOG A
I2C-DAT
NO USE
NO USE
NO USE
NO USE
VOL A
JOG B
VCC
F06
F05
REC LEVEL
F04
R805
15k
S805
S804
S803
R808
68k
R807
33k
R806
22k
S806
REC
S809
S808
S807
H SPEED
CD
DUB
SYNC
LED P2
KEY2
P1
LED P1
GND
BIAS
RST.C
REC IN
LINE IN
GND
REC NF
R01
LINE NF
R02
KEY CONTROL
LED SELB
VOL B
R648
47k
58
JOG B
59
JOG A
R649
100k
R650
82k
+3.3V VL
+3.3V VH
GND
KEY 4
LED P1
NO803
7P
R699 470
C617 10 16V
R646 100k
R645 330k
R644 330k
C604
47
16V
NO USE
NO USE
SEG-24
SEG-25
MD2
D-SW
R804
10k
R803
6.8k
R802
4.7k
S802
R698
680
C603
10000p
16V
NO USE
NO USE
FLUORESCENT
R603
10k
P3
P2
L601
JW
NO USE
DIST
SOFT TEST
R602 10k
FB601
0µH
NO USE
NO USE
IC601
SEG-21
SEG-22
+3.3VH
+3.3VL
LED P3
S801
NX601
10P
NO USE
SEG-18
SEG-19
SEG-20
NO601
10P
R812
47
KEY 4
GR-16
GR-15
GR-14
GR-13
GR-12
GR-11
GR-10
GR-9
GR-8
GR-7
GR-6
VSS-IO
GR-4
GR-5
GR-2
GR-3
SEG-1
GR-1
SEG-3
SEG-2
NO USE
C606
4.7
50V
KEY 0
D-SW
SEG-5
SEG-4
NO USE
SEG-17
43
44
DIST
D-GND
SEG-6
VDD-FIP
NO USE
SEG-16
41
+3.3VH
+3.3VL
SEG-8
SEG-7
SEG-15
35
36
39
40
KEY 1
LEDP10
SEG-10
SEG-9
33
34
F03
F01
F02
RST
2
4
3
5
6
7
9
12
10
13
14
18
16
20
19
22
21
24
25
27
26
28
30
29
NO USE
37
38
NO602
8P
SEG-12
SEG-11
SEG-14
R801
3.3k
C619
10000p
16V
C618
10
16V
L602
JW
SEG-13
REC
R811
22
L603
47µ
IC602
BA3830F-E2
BANDPASS
FILTER
31
32
R810
22
JOG B
R668
100k
R659 JW
R658 JW
R601
100k
Q606
DTC114TLTL2
D804
SEL5223S
RED
D803
D802
SEL5423E SEL5923A
GREEN ORANGE
D801
SEL5423E
GREEN
R809
22
R653
100k
JOG A
R667
100k
71
72
GRID
DRIVE
Q607
DTC114TLTL2
C616
3300p
16V
R647
82k
C605
10000p
16V
C613
10
50V
X601
R620 4MHz
1M
C615
10
50
IC603
NJL64H400A-1
REMOTE
CONTROL
RECEIVER
CN602
19P
MIC SIG
R643
47
R696 100
R697 100
79
80
77
78
75
76
73
74
71
72
69
70
68
67
D601
1SS133T-77
R651
10k
C601
1000p
50V
C602
47
16V
SPEANA
VFDP
R652
3.3k
77
RESET
60
I2C DATA
61
C612
0.1µF
R619
22k
SIRCS
GC+3.3V
DISPLAY
S613
SLEEP
/CLOCK SET
R633
1.5k
R632
1.5k
R631
1k
R630
680
S614
S616
TIMER SELECT
FUNCTION
S617
GAME
C607
0.1
S810
R634
2.2k
S618
R624
1.5k
R637
470
R638
680
P7
79
S601
78
76
S602
S603
S604
LED STBY
RV801
50k
GAME MIXING
TANGO
SAMBA
JAZZ
ROCK
GAME
DANCE
MOVIE
NO805
9P
56
57
69
R700 470
D605
SEL5423E
GREEN
D607
SEL5423E
GREEN
TANGO
MOVIE
D609
SEL5423E
GREEN
D611
SEL5423E
GREEN
GUITAR
D602
SEL5223S
RED
D613
SEL5423E
GREEN
JAZZ
Q605
2SB1116
R676
22
DANCE
ROCK
R674
22
L604
47µ
R678
22
Q604
2SC2603
R690
1k
S620
I/
Q603
2SB1116
R689
1k
R684
1k
R686
47k
Q602
2SC2603
R685
1k
P4
P5
L605
47µ
P6
P7
P8
GAME MIXING
R672
22
R669
22
P9
P1
R670
22
SAMBA
P2
REGGAE
P3
SALSA
P5
39
R680
330
R683
47k
R688
47k
B+ SWITCH
D612
SEL5423E
GREEN
D610
SEL5423E
GREEN
D608
SEL5423E
GREEN
D606
SEL5423E
GREEN
D604
SEL5423E
GREEN
D603
SEL5423E
GREEN
P6
R679
22
R692
470
POWER SAVE/DEMO
(STANDBY)
GAME
R677
22
R675
22
R673
22
R671
22
S619
POWER
Q602-605
P4
MIC
LEVEL
LEVEL
39
R681
47k
C614
47
16V
Q601
DTC124ESA-TP
LED DRIVE
R691
470
+3.3VL
D-SW
S610
S609
55
REGGAE
RV802
50k
GUITAR
S605
GUITAR
SALSA
S608
S607
S606
KEY 1
LEDP10
D-GND
KEY 0
KEY0
D-SW
R625
1.5k
S815
+3.3VH
MIC-VR-OUT
MIC-VR-IN
GND
R626
1k
S814
DIST
DISTORTION
R627
680
S813
DIRECTION
R642
2.2k
R641
1.5k
R640
1.5k
S812
LED+3.9V
80
R628
470
P9
P8
R639
1k
S811
KEY-ECO
KEY POWER
ANALYZER
R623
2.2k
NX602
8P
LED+3.9V
ECHO/GUITAR-IN
SPECTRUM
R817
15k
R816
10k
R815
6.8k
D GND
R629
470
S615
S612
R814
4.7k
R813
3.3k
D GND
ECHO/GUITAR-OUT
VC
S611
CN601
21P
R636
680
R622
680
R600
1k
R819
22
R820
22
I2C CLK
A+10V
R635
470
D805
SEL5423E
GREEN
EVER3.3V
R617 15k
R615 15k
R616 15k
D806
SEL5423E
GREEN
VF
VF
69
67
68
66
66
65
64
R612 15k
R613 15k
R614 15k
64
65
R695 100
R610 100
R608 100
60
61
66
58
57
59
67
56
57
58
59
R693 10k
R694 10k
R607 10k
53 R605 100
55
56
R606 10k
R621
470
68
64
R604 10k 51
51
52
R609 10k
53
65
52
R618
100
HCD-XGR6/XGR60
6-19.PRINTED WIRING BOARD – PA SECTION – • See page 21 for Circuit Boards Location.
3
2
1
4
5
6
7
XGR60
JW490
JW472
XGR6
JW809
R828
R858 R888
1
R831
R808
R810
CN804
JW410
14
CN803
C851
JW409
F
R851
C813
R820
C852
1
R852
R802
C802
C801
R801
XGR60
XGR6
D402
RY401
R406
JW820
JW821
JW823
JW466 JW813
JW824
R429
E
JW406
JW825
JW822
JW805
F
Q402
R447
R446
R401
JW405
Q401
JW826
R460
E
E
C401
D406
R407
D405
JW75
JW404
JW403
C412
C413
JW402
+
G
–
L
TM401
40
+
–
R
FRONT SPEAKER
40
MAIN
BOARD
(Page 33)
13
JW411
Q832
C804
JW407
R803
JW516
R898
IC801
C814
R833 D804
R832
JW416
JW521
JW524
JW497
JW523
JW520
JW522
R836
Q833
R835
C857
18
1
JW436
R834
Q801
D851
R862
JW504
JW439
D401
JW449
JW494
R837
R853
D805
JW817
D801
E
R807
E
JW419
C854
C803
C815
C832
G
1
Q831
JW412
JW465
Q834
E
JW422
R838
JW512
R824
JW420
JW499
JW511
JW418
JW517
TH831
D803
R823
JW462
JW455
JW456
XGR60
JW519
C812
R857
JW515
R822
JW454
E
Location
JW423
C831
JW421
C811
C807
JW415
C853
JW414
R860
JW460
R827 JW461
JW431
• Semiconductor
JW496
C862
E
R809
JW458
JW459
R432
JW438
JW491
JW441
JW453
R431
JW476
JW452
R814
JW473
JW489
Q851
JW806
JW451
R811
JW475
JW474
R817 JW450
E
C809
C808
JW495
R859
R815
13
JW488
R825
E
C861
R812
(CHASSIS)
R855
JW514
JW513
R804
JW427
JW810
JW429
JW442
JW447
JW446
JW445
JW444
JW443
Q804
Q803
C864
R840
R880
JW440
R866
C847
JW448
R819
R863
R813
JW507
C810
JW477
D
JW816
R816
R861
JW493
C850
JW807
CN904
C432
R821
Q431 E
1
4
E
JW478
Q433
E
JW482
JW481
Q432
R440
Q437
R439
JW480
SUB
TRANS
BOARD
(Page 42,43)
E
R437
R434
M
Q434
JW424
E
C830
JW808
E
E
JW479
E
C433
R806
D852
R805
D802
JW500
R441
D902
R902
JW704
D903
JW426
C895
C891
JW818
CN806
EPT801
E
R868
Q855
JW815
JW811
JW432
JW434
JW435
1
4
R818
JW700
R889
XGR60
C841
Q805
C842
C892
R867
D841
C859 JW509
JW433
D905
D904
11
XGR60
JW
Q901
3
NO702
JW483
Q439
R901
JW701
LP802
+
-
D843
D842
D844
JW430
-
C910
XGR6
D834
C845
C858
R839
–
C902
(CHASSIS)
C906
R916
D836
D833
D831
EPT802
B
R865
C894
C848
HEADPHONE
BOARD
(Page 34)
J
D835
NO701
1 C849
C844
Q908
D853
1
C909
E
C903
C
R905
C904
C863
JW506
R906
D911
JW505
IC901
R915
JW485
R907
E
JW486
D912
JW487
C905
R903
R904
Q903
R864
PA BOARD
A
TRANS
BOARD
(Page 42,43)
N O
JW508
TRANS
BOARD
(Page 42,43)
11
(11)
1-683-443-
MAIN
BOARD
(Page 33)
Ref. No.
Location
D401
D402
D405
D406
D801
D802
D803
D804
D805
D831
D833
D834
D835
D836
D841
D842
D843
D844
D851
D852
D853
D902
D903
D904
D905
D911
D912
C-5
E-6
F-6
F-6
C-5
D-4
D-3
C-6
D-5
B-2
A-4
A-4
A-4
A-4
A-5
A-5
A-5
A-5
C-5
D-4
A-3
C-2
C-1
B-1
B-2
A-2
A-2
IC801
IC901
E-4
B-1
Q401
Q402
Q431
Q432
Q433
Q434
Q437
Q439
Q801
Q803
Q804
Q805
Q831
Q832
Q833
Q834
Q851
Q855
Q901
Q903
Q908
E-6
E-6
C-2
C-2
C-2
C-2
C-2
C-2
C-5
C-3
C-3
B-5
C-6
C-6
C-5
C-5
C-4
B-5
C-1
A-1
B-1
HCD-XGR6/XGR60
6-20.SCHEMATIC DIAGRAM – PA SECTION –
XGR60
XGR6
TM401
IC801
IC801
D405
1SS133T
STK412-040
STK442-130
FRONT
SPEAKER
POWER AMP
POWER AMP
D406
1SS133T
RY401
24V
Q401
DTA1124ESA
JW821
+
L
R407
47k
R406
47k
–
+
35.4
JW820
35.2
R460
10k
34.8
*R401
R429
47k
R818
220
0
-12.4
560
XGR60
1.8k
XGR6
D402
1SS133T
0
R868
220
0
3.1
-12.4
70
35.4
21.5
-35.8
-70.5
-21.8
0
0
0
0
0
0
-68.8
0
69.1
0
0
-67.5
35.4
0
0
-70.5
0
0
0
-68.8
0
69.1
0
0
0
-67.5
Q805
2SC2878AB
MUTE
R
–
R401
*
Q855
2SC2878AB
MUTE
Q402
2SC1841
Q401,402
FRONT SPEAKER PROTECT
RELAY DRIVE
R447
47k
C850
4.7/100
R825
680 2W
R840
56
R888
0.22/5W
C895
4.7/100
1
JW819
C803
220p
33k
XGR60
47k
XGR6
R898
0.22
5W
R827
100k
70
R852
47k
R812
15k
D852
MTZJ-T-77-15A
D801
1SS133T
D802
MTZJ-T-77-15A
100V TF
C808 0.1
C809 0.1
C857 22 100
C807 22 100
100V TF
R851
1k
3
NO702
-70.5
R813
100k
AC-H
C851
10/100
R860
*
*R860
XGR60
P-GND
AC-H
D831
D5SBA204101
33k
XGR60
47k
XGR6
C844
0.1
100V
AC12V
R839
100k
1/4W
C842
3300
80V
R889
100k
1/4W
C892
3300
80V
R863
100k
0
R861
1k
Q433
2SC2603
R431
56k
R817
47k
D401
1SS133T
R437
10k
Q732,437
DETECT
DC DETECT
OVER LOAD
SWITCH
47/100V
XGR60
1/100V
XGR6
C848
0.1
NO701
11P
C909
0.1
D836
11ES2
D833
11ES2
C847
0.1
EPT802
3300/71V
CN904
POWER ON/OFF
RELAY DRIVE
AC_IN
TH831
XGR60
AC_IN
+9V
2.7
18k
XGR60
22k
XGR6
-12.4
TEMPERATURE
R836
1k
DETECT SWITCH
R831
100k
Q901
2SC2603
R901
10k
10.5
R834
10k
C831
10 50
D902
11ES2
C902
0.1
D903
11ES2
D835
11ES2
D834
11ES2
C863
2.2 50V
D842
11ES2
R916
680
3W
R904
1k
R903
10k
Q903
2SB1375
2SA1932
5
1
3
R867
2.2k
R905
10k
R906
100
-30.4
1
2
R907
100
-30.7
-30.7
XGR60
2
C864
10
50V
C905
100
50
3
62.4
R915
22
D912
MTZJ-7-77-5.6
Q903,908
HP-R
HP-SW
3
2
2
1
HP-L
CN804
13P BTB
HP.GND
-VEE
POWER
D.GND
VF
HP-SW
HP-MUTE
VF
D.GND
VF(-35V)
EVER +3.9V
STK POWER
+10V
PROTECT
+UNREG.15V
+UN10V
15V GND
10V GND
POWERGND
POWERGND
CN803
13P
BTB
3
-35V REGULATOR
A.GND
R866
10k
RCH-IN
R865
22k
1
+10V
LCH-IN
D843
11ES2
FAN.DET
D844
11ES2
D841
11ES2
F-RELAY
DBFB
C858
0.1
C859
0.1
PL/SW RELAY
(CHASSIS)
Q908
2SA1115
-31.3
R864
4.7k
C903
100
16
D911
HZS33-1L
XGR6
JW
C849
0.1
C910
47
16V
0
C906
2200
25
D906
1SS133T
C904
10 50
C845
2200
D853
25 1SS133T
3.9
D904
11ES2
D905
11ES2
R835
47k
XGR6
2
IC901
µPC3504AHF
+5V REGULATOR
R902
100k
C830
10
50
Q831
DTC124ESA
22K/22K
5
0.7
9.8
0
Q832
2SC2603
STBY_RY
0
Q831,832
0.6
3300/50V
DETECT
SWITCH
D804
1SS133T
0
C891
*
R434
22k
Q433,434
*R833
JW806
*
*C841,891
VF
3.3
0
Q434
2SC2603
C810
*
*C810
R833
*
VF
3.3
0
R441
33k
0
R432
47k
JW818
C841
*
AC-L
10
Q901
AC-L
S-GND
Q439
2SC2603
PROTECT SWITCH
10
10
Q833
DTA124ESA
DELAY
JW701
*
AC7V
R439
4.7k
Q437
2SC2603
Q432
2SA1115
OVER LOAD
R819
68k
C861
0.047
PE
R832
100k
P-GND
0.7
Q801,851
R859
10
1/2W
AC7V
2
0.6
SWITCH
0
R440
*
3.5
AC12V
PRI-GND
Q431
2SC1841
PROTECT SWITCH
10
XGR60
C894
0.1
100V
XGR6
R816
10k
JW807
*
2
XGR60
47k
10
0
Q804
2SC1841
STANDBY
C862
0.047
PE
9.8
0
C853
220p
22k
XGR6
C432
100 16
R838
33k
JW827
SWITCH
C812
0.047
PE
9.8
(CHASSIS)
XGR60
70.4
D805
1SS133T
C832
47 50
SWITCH
R853
560
0
Q851
2SC1841
EPT801
R821
33k
XGR60
-69.6
Q834
2SC1841
STANDBY
XGR60
2.2/50V
C433
*
R815
22k
2
-70.6
C854
47
50
R806
3.9k
1W
C811
0.047
PE
0
D851
1SS133T
C852
470p
R805
3.9k
1W
Q803
2SA988
STANDBY
R809
10
1/2W
R862
15k
GND
R837
33k
C813
0.01
3.3/50V
70.4
Q801
2SC1841
R857
100
1/4W
*R440
*C433
R814
2.2k
R820
1
R804 33k
JW809
*
C814
1000p
C804
47
50
2
C815
R828 0.47
1M 50V
R824
470
XGR6
R803
560
C413
0.01
R811
1k
R807
100 1/4W
C802
470p
R446
10k
3
D803
1SS133T
R810
*
R802
47k
C412
0.01
R880
56
R823
22k
R858
0.22/5W
*R810
R801
1k
C801
10/100
R855
680/2W
R822
22k
R808
0.22
5W
C401
4.7
50
1
CN806
4P AMP
The components identified by mark 0 or dotted line
with mark 0 are critical for safety.
Replace only with part number specified.
41
41
HCD-XGR6/XGR60
6-21.SCHEMATIC DIAGRAM – TRANS, SUB TRANS SECTION (XGR6, XGR60: MX MODEL) –
• See page 21 for Circuit Boards Location.
3
2
1
4
6-22.SCHEMATIC DIAGRAM – TRANS, SUB TRANS SECTION (XGR6, XGR60: MX MODEL) –
5
1
JW960
JW972
N
JW974
JW976
JW978
AC-H
PA
BOARD
(Page 40)
CN951
JW977
3
A
T951
*1 F963,964
P-GND
POWER
6.3A 125V
XGR6
6.3AL 250V
XGR60:MX
TRANSFORMER
AC-H
XGR60:MX
–
AC12V
AC7V
D832
D5SBA20
JW975
JW986
JW985
PRI-GND
AC7V
C834
0.1
100
F963
*1
O
CN952
1
AC-L
P-GND
PA
BOARD
(Page 40)
AC-L
NOT REPLACEABLE:
BUILT IN TRANSFORMER
F964
*1
S-GND
C893
0.1
100
VF
C963
10000p
XGR60:MX
JW973
2
AC12V
0.33
XGR60:MX
R952
R951
R952
*
F963
JW968
0.33
CN952
EH
F961
T8.0AL
250V
JW965
R953
0.1
JW984
-
C
CN905
R951
JW965
JW983
XGR60:MX
C963
+
TRANS BOARD
JW706
C834
T951
POWER
TRANSFORMER
C961
F964
-
D832
C893
F961
F962
B
XGR60:MX
R953
*
JW979
JW982 JW702
JW981
LP963
JW980
CN951
VH-3P
VF
C961
10000p
*
F962
T8.0AL
250V
* NOT REPLACEABLE:
BUILT IN TRANSFORMER
D
R961
3.3M
CN905
1-683-444-
11
(11)
120V
R961
NEUTRAL
LP961
XGR6
(CHASSIS)
E
SUB TRANS BOARD
MT901
JW948
JW950
T901
SUB
TRANSFORMER
RY901
STANDBY
RELAY
9V
CN902
D901
NO903
1
CN901
2P
AMP
2
JW942
CN902
LP903
4
AC IN
JW946
1-683-445-
C901
0.01
250V
NEUTRAL
LP901
1
F
JW944
JW942
11
(11)
NO903
T901
M
PA
BOARD
(Page 40)
D901
1SS133T
JW945
CN901
JW945
C901
RY901
JW944
JW946
120V
SUB
STBY_RY
+9V
TRANSFORMER
AC IN
AC_IN
AC_IN
The components identified by mark 0 or dotted line
with mark 0 are critical for safety.
Replace only with part number specified.
42
42
HCD-XGR6/XGR60
6-23.PRINTED WIRING BOARD – TRANS, SUB TRANS SECTION (XGR60:E, E51, AR MODEL) –
• See page 21 for Circuit Boards Location.
3
2
1
4
6-24.SCHEMATIC DIAGRAM – TRANS, SUB TRANS SECTION (XGR60:E, E51, AR MODEL) –
5
CN951
1
CN951
VH-3P
JW960
JW972
A
AC-H
T951
N
POWER
TRANSFORMER
AC-H
3
JW974
JW976
P-GND
LP963
JW978
JW977
PA
BOARD
(Page 40)
R953
0.1
JW980
JW982 JW702
JW981
JW984
JW983
JW986
JW985
JW975
F964
T6.3AL
250V
230V
230V
120V
11
(11)
(CHASSIS)
CN902
VH-4P
120V
MT901
JW950
S901
VOLTAGE SELECTOR
120V
220-240V
LP901
JW944
JW941
220V
AC IN
CN901
NO903
4
CN902
1
D901
T901
STBY_RY
SUB
+9V
TRANSFORMER
LP903
4
1
NO903
D901
1SS133T
C901
0.01
250V
JW944
C901
F
RY901
STANDBY
RELAY
9V
JW949
CN901
2P
AMP
RY901
VF
F962
T8.0AL
250V
SUB TRANS BOARD
T901
SUB
TRANSFORMER
VF
C963
10000p
NEUTRAL
CN952
C893
0.1
100
CN905
VH-4P
JW973
LP961
4
AC7V
S-GND
PA
BOARD
(Page 40)
120V
1 CN905
*
220V
PRI-GND
C961
10000p
S901
220-240V
D832
D5SBA20
C834
0.1
100
AC-L
NOT REPLACEABLE:
O
1-683-444-
VOLTAGE SELECTOR
E
AC12V
AC-L
* NOT REPLACEABLE:
BUILT IN TRANSFORMER
R961
AC12V
P-GND
R951
JW971
0.33
AC7V
R952
R953
R952
*
F963
T6.3AL
250V
F963
F951
D
F951
T6.3AL
250V
BUILT IN TRANSFORMER
C
0.33
CN952
EH
F961
T8.0AL
250V
NEUTRAL
–
-
C963
+
T951
POWER
TRANSFORMER
JW706
C834
TRANS BOARD
C961
F964
D832
C893
F962
F961
B
R951
JW971
*
JW979
JW949
1-683-445-
11
(11)
AC_IN
AC_IN
JW941
M
G
AC IN
PA
BOARD
(Page 40)
The components identified by mark 0 or dotted line
with mark 0 are critical for safety.
Replace only with part number specified.
43
43
HCD-XGR6/XGR60
6-25. IC PIN FUNCTIONS
r WAVEFORMS
• IC101 DIGITAL SIGNAL PROCESSOR (CXD3017Q) (BD Board)
– MAIN BOARD –
1
– BD BOARD –
IC501 qa XC-OUT
1
Pin No.
IC101 el
FE
3.0Vp-p
0.15Vp-p
32KHz
VOL/DIV : 1V AC
TIME/DIV : 10µsec
2
IC501 qd
X-OUT
VOL/DIV : 0.1V AC
TIME/DIV : 1msec
2
IC101 ra TE
2.0Vp-p
0.4Vp-p
16MHz
VOL/DIV : 1V AC
TIME/DIV : 50nsec
3
T331 4
TAPE REC only
VOL/DIV : 0.2V AC
TIME/DIV : 0.2msec
3
240Vp-p
IC101 rd RFDC
0.62Vp-p
13µsec
VOL/DIV : 50V AC
TIME/DIV : 10µsec
4
T331 5
TAPE REC only
4
64Vp-p
13µsec
VOL/DIV : 0.2V AC
TIME/DIV : 0.5µsec
VOL/DIV : 50V AC
TIME/DIV : 10µsec
IC101 yj XTAO
0.8Vp-p
16.9344MHz
VOL/DIV : 0.2V AC
TIME/DIV : 50nsec
– PANEL FL BOARD –
1
IC601 is
X OUT
2.4Vp-p
4MHz
VOL/DIV : 1V AC
TIME/DIV : 0.2µsec
44
44
Pin Name
I/O
Description
1
SOSQ
O
Sub-Q serial output
2
SQCK
I
Clock input for SQSO read-out
3
XRST
I
System reset
4
SYSM
I
Muting input
5
DATA
I
Serial date input,supplied from CPU
6
XLAT
I
Latch input,supplied from CPU
7
CLOK
I
Serial date transfer clock input,supplied from CPU
8
SENS
O
SENS output
9
SCLK
I
10
VDD
—
Power supply (+3.3V)
11
ATSK
—
Input pin for anti-shock (Ground)
12
SPOA
—
Ground
13
SPOB
—
Ground
14
XLON
O
Not used (open)
15
WFCK
O
Not used (open)
16
XUGF
O
Not used (open)
17
XPCK
O
Not used (open)
18
GFS
O
Not used (open)
19
2SPO
O
Not used (open)
20
SCOR
O
21
COUT
I/O
Not used (open)
22
MIRR
I/O
Not used (open)
23
DFCT
I/O
Not used (open)
24
FOK
I/O
Not used (open)
25
LOCK
I/O
Not used (open)
26
MDP
O
Output to control spindle motor servo
27
SSTP
I
Input signal to detect disc inner most trak
28
SFDR
O
Sled drive output
29
SRDR
O
Sled drive output
30
TFDR
O
Tracking drive output
31
TRDR
O
Tracking drive output
32
FFDR
O
Focus drive output
33
FRDR
O
Focus drive output
34
VSS
—
Ground
35
TEST
I
TEST pin (connected to ground)
36
TES1
I
TEST pin (connected to ground)
37
XTSL
I
X’tal selection circuit input (connected to ground)
38
VC
I
Center voltage input
39
FE
I
FOCUS error signal input
40
SE
I
Sled error signal input
41
TE
I
Tracking error signal input
42
CE
I
Center servo analog input
43
RFDC
I
RF signal input
44
ADIO
O
Not used (open)
45
AVSS0
—
Analog ground
46
IGEN
47
AVDDO
—
Power supply (+3.3V)
48
ASYO
O
EFM full swing output
49
ASYI
I
Asymmetry comparator voltage input
50
BIAS
I
Asymmetry circuit constant current input
51
RFAC
I
EFM signal input
52
AVSS3
—
I
SENS serial data read-out clock
Sub-code sync output
Power supply pin operational amplifiers
Ground
HCD-XGR6/XGR60
Pin No.
Pin Name
Description
I/O
53
CLTV
I
Control voltage input for master VCO
54
FILO
O
Filter output for master PLL
55
FILI
I
Filter input for master PLL
56
PCO
O
Chage-pump output for master PLL
57
AVDD3
—
Powr supply (+3.3V)
58
VSS
—
Ground
59
VDD
—
Power supply (+3.3V)
60
DOUT
O
CD data output
61
LRCK
O
Not used (open)
62
PCMD
O
Not used (open)
63
BCK
O
Not used (open)
64
EMPH
O
Not used (open)
65
XVDD
—
Power supply (+3.3V)
66
XTAI
I
X’tal oscillator circuit input (16.9344MHz)
67
XTAO
O
X’tal oscillator circuit output (16.9344MHz)
68
XVSS
—
Ground
69
AVDD1
—
Power supply (+3.3V)
70
AOUT1
O
Lch : Analog output
71
AIN1
I
Lch : OPAMP input
72
LOUT1
O
Lch : LINE output
73
AVSS1
—
Ground
74
AVSS2
—
Ground
75
LOUT2
O
Rch : LINE output
76
AIN2
I
Rch : OPAMP input
77
AOUT2
O
Rch : Analog output
78
AVDD2
—
Power supply (+3.3V)
79
RMUT
O
Not used (open)
80
LMUT
O
Not used (open)
45
HCD-XGR6/XGR60
• IC501 M30620MCN-A01FP SYSTEM CONTOL (MAIN Board)
Pin No.
46
Pin Name
Description
I/O
1
AUDIO-OUT
O
2
STEREO
I
Stereo signal input
3
TUNED
I
Tuned signal input
4
SIRCS
I
SIRCS input
5
CD-MUTE
O
CD mute signal output
6
–
—
Not used (open)
7
–
—
8
BYTE
I
MD output mute signal output
Not used (open)
Not used (connected to ground)
9
CNVSS
—
10
XC-IN
I
Not used (Connected to ground with resistor)
Sub clock input
11
XC-OUT
O
Sub clock output
12
RESET
I
System reset input
13
X-OUT
O
Main system clock output (16MHz)
14
VSS
—
15
X-IN
I
16
VCC
—
17
NMI
I
18
RDS-INT
I
Not used (Connected to ground with resistor)
19
SCOR
I
CD Q-Data request input
20
AC-CUT
I
AC cut check signal input
21
ST-MUTE
O
Tuner mute signal output
22
ST-CE
O
Tuner chip enable signal output
23
ST-DOUT
O
Tuner data output
24
BU-PWM3
O
BU PWM 3 (for CD-RW) signal output
Ground
Main system clock input (16MHz)
Power supply (+5V)
Not used (Pull up with resistor)
25
ST-DIN
I
Tuner data input
26
BU-PWM2
O
BU PWM 2 (for CD-RW) signal output
27
ST-CLK
O
Tuner clock signal output
28
BU-PWM1
O
BU PWM 1 (for CD-RW) signal output
29
IIC-CLK
I
IIC serial data clock input
30
IIC-DATA
I
31
–
32
SQ-DATA
I
CD data input
33
SQ-CLK
O
CD data clock output
34
SENS
I
SENS signal input from CXD3017Q
35
CD-DATA
O
CD data output
36
XLT
O
CD latch signal output
37
CD-CLK
O
CD data clock output
38
CD-POWER
O
CD power on/off signal output
39
CLK-OUT
O
Not used (open)
40
HOLD
O
Laser diode control signal output
Other micom reset
—
IIC serial data input
Not used (open)
41
OTM-RESET
O
42
–
—
Not used (open)
43
XRST
O
CD reset signal output
44
MTR-CTRL1
O
CD motor control 1 output
45
MTR-CTRL2
O
CD motor control 2 output
46
REC-A
I
Record tab switch for SIDE-A signal input
47
LED-DISC
O
DISC LED on/off signal output
48
BU UP/DW SW
I
BU up switch signal input
49
TBL-SENS
I
Table sensor signal input
50
REC-B
I
Record tab switch for SIDE-B signal input
51
A-TRG
O
TCM-A trigger output
52
B-TRG
O
TCM-B Trigger output
53
AMS-IN
I
AMS signal input
HCD-XGR6/XGR60
Pin No.
54
Pin Name
CAPM-H/L
I/O
O
Discription
Capstan motor high/low signal output
55
CAPM-CTRL
O
Capstan motor REV/FWD/STOP control signal output
56
A-PLAY
I
TCM-A play switch input
57
B-PLAY
I
TCM-B play switch input
58
TC-MUTE
O
TC line mute signal output
59
REC/PB/PASS
O
Not used (open)
60
NR ON/OFF
O
Not used (open)
61
REC-MUTE
O
REC mute signal output
62
VCC
—
Power supply (+3.3V)
63
SOFT-TEST
O
Soft check output
64
VSS
—
Ground
65
BIAS
O
Bias on/off signal output
66
EQ-H/N
O
EQ high/Normal signal output
67
PB-A/B
O
TC A/B select signal output
68
ALC
O
ALC signal output
69
TC-RELAY
O
TC relay control signal output
70
A-HALF
I
A deck half detection signal input
71
FUNC-SEL0
O
Function select A signal output
72
FUNC-SEL1
O
Function select B signal output
73
KEY-ECO
I
ECO key signal input
74
KEY-POWER
I
Power key signal input
75
LED-STBY
O
Standby LED driver signal output
76
VIDEO-MUTE
O
Video mute signal output
77
PL-LAT
O
Not used (open)
78
PL-DAT
O
Not used (open)
79
PL-CLK
O
Not used (open)
80
EQIC-DAT
O
Serial data output to Audio EQIC
81
EQIC-CLK
O
Serial data clock output to Audio EQIC
82
LINE-MUTE
O
TA LINE mute signal output
83
STK-MUTE
O
Mute signal output to power IC
84
STBY-RELAY
O
Standby relay driver signal output
85
REAR-RELAY
O
Rear speaker relay driver signal output
86
HP-MUTE
O
Headphone mute signal output
87
FRONT-RELAY
O
Front speaker relay driver signal output
88
PROTECT
I
Speaker protection signal input
89
A-SHUT
I
TCM-A reel pulse input
90
B-SHUT
I
TCM-B reel pulse input
91
B-HALF
I
B deck half detection input
92
MODEL-IN
I
Model input
93
DEST-IN
I
Destination input
94
DBFB-H/L
O
DBFB high/low signal output
Headphone detect input
95
HP-IN
I
96
AVSS
—
Ground
97
SW-MODE
O
Super woofer mode signal output
98
VREF
I
Reference voltage input
99
AVCC
—
100
RDS-DATA
I
Power supply (+3.3V)
Not used (Connected to ground)
47
HCD-XGR6/XGR60
• IC601 MB90M407APF-G-112-BND DISPLAY CONTROL (PANEL FL Board)
Pin No.
48
Pin Name
Description
I/O
1
GR-16
O
FLD grid output
2
GR-15
O
FLD grid output
3
GR-14
O
FLD grid output
4
GR-13
O
FLD grid output
5
GR-12
O
FLD grid output
6
GR-11
O
FLD grid output
7
GR-10
O
FLD grid output
8
GR-9
O
FLD grid output
9
GR-8
O
FLD grid output
10
GR-7
O
FLD grid output
11
VSS-IO
—
Ground
12
GR-6
O
FLD grid output
13
GR-5
O
FLD grid output
14
GR-4
O
FLD grid output
15
GR-3
O
FLD grid output
16
GR-2
O
FLD grid output
17
GR-1
O
FLD grid output
18
SEG-1
O
FLD segment output
19
SEG-2
O
FLD segment output
20
SEG-3
O
FLD segment output
21
SEG-4
O
FLD segment output
22
SEG-5
O
FLD segment output
23
VDD-FIP
—
Power supply (+3.3V)
24
SEG-6
O
FLD segment output
25
SEG-7
O
FLD segment output
26
SEG-8
O
FLD segment output
27
SEG-9
O
FLD segment output
28
SEG-10
O
FLD segment output
29
SEG-11
O
FLD segment output
30
SEG-12
O
FLD segment output
31
SEG-13
O
FLD segment output
32
SEG-14
O
FLD segment output
33
SEG-15
O
FLD segment output
34
SEG-16
O
FLD segment output
35
SEG-17
O
FLD segment output
36
SEG-18
O
FLD segment output
37
SEG-19
O
FLD segment output
38
SEG-20
O
FLD segment output
39
SEG-21
O
FLD segment output
40
SEG-22
O
FLD segment output
41
SEG-23
O
FLD segment output
42
VSS-IO
—
Ground
43
SEG-24
O
FLD segment output
44
SEG-25
O
FLD segment output
45
NO USED
O
Not used (open)
46
NO USED
O
Not used (open)
47
NO USED
O
Not used (open)
48
VKK
—
Power supply (-35V)
49
MD0
I
50
MD1/VDD-VFT
I
Not used (pull up with resistor)
51
MD2
I
Not used (pull down with resistor)
52
D-SW
I
CD lid open/close detect signal input
53
DIST
O
Guitar distortion ON/OFF signal output
Not used (pull up with resistor)
HCD-XGR6/XGR60
Pin No.
54
Description
Pin Name
SOFT TEST
I/O
O
Not used (open)
55
LED SELB
O
LED group B select signal output
56
VOL A
I
Volume encoder signal A input
57
VOL B
I
Volume encoder signal B input
58
JOG A
I
AMS jog dial encoder signal A input
59
JOG B
I
AMS jog dial encoder signal B input
60
I2C-DATA
O
IIC serial data output
61
I2C-CLOCK
O
IIC clock signal output
62
AVCC
—
Power supply (+3.3V)
63
AVSS
—
64
KEY0
I
Key input (A/D port)
65
KEY1
I
Key input (A/D port)
66
KEY2
I
Key input (A/D port)
67
KEY3
I
Key input (A/D port)
68
KEY4
I
Key input (A/D port)
69
KEY5
I
Key input (A/D port)
70
BPF1-F02
I
Spectrum analyzer BPF signal input
71
BPF2-F03
I
Spectrum analyzer BPF signal input
72
BPF2-F04
I
Spectrum analyzer BPF signal input
73
BPF2-F05
I
Spectrum analyzer BPF signal input
74
BPF2-F06
I
Spectrum analyzer BPF signal input
75
ALL BAND
I
L+R signal input
76
LED-SCK
O
Serial clock output to LED driver
Reset input
Ground
77
RESET
I
78
LED-DAT
O
Serial data output to LED driver
79
LED-LATCH
O
Latch signal output to LED driver
80
LED-SELA
O
LED group A select signal output
81
VSS-CPU
—
Ground
82
XOUT
O
Crystal oscillator output (4MHz)
83
XIN
84
VCC-CPU
—
Power supply (+3.3V)
85 to 100
NO USED
O
Not used (open)
I
Crystal oscillator input (4MHz)
49
HCD-XGR6/XGR60
6-26. IC BLOCK DIAGRAMS
DOUT
VDD
VSS
AVDD
PCO
FILI
FILO
CLTV
AVSS
RFAC
BIAS
ASYI
ASYO
AVDD
IGEN
AVSS
ADIO
RFDC
CE
TE
IC101 CXD3017Q (BD BOARD)
60
59 58 57
56
55
54
53
52
51
50
49
48
47
46 45 44
43
42
41
Digital
OUT
LRCK 61
PCMD 62
BCK 63
40 SE
D/A
Interface
Digital
PLL
A/D
Converter
Asymmetry
Corrector
OP Amp
Analog SW
39 FE
38 VC
37 XTSL
64
65
66
67
SERVO DSP
XVSS 68
AVDD1 69
Timing
Logic
AOUT1 70
AIN1 71
LOUT1 72
PWM
AVSS1 73
EFM
Demodurator
Over Sampling
Digital Filter
16K
RAM
3rd-Order
Noise Shaper
Servo Auto
Sequencer
PWM
AVSS2 74
75
76
77
78
RMUT 79
LMUT 80
36 TES1
PWM
GENERATOR
34 VSS
35 TEST
FOCUS
SERVO
FOCUS PWM
GENERATOR
TRACKING
SERVO
TRACKING
PWM
GENERATOR
SELED
SERVO
SLED PWM
GENERATOR
32 FFDR
31 TRDR
30 TFDR
29 SRDR
28 SFDR
SERVO
Interface
Sub Code
Processor
LOUT2
AIN2
AOUT2
AVDD2
Clock
Generator
33 FRDR
Error
Corrector
Serial-In
Interface
27 SSTP
Digital
CLV
26 MDP
MIRR
DFCT
FOK
24 FOK
23 DFCT
22 MIRR
21 COUT
25 LOCK
XPCK
GFS
C2PO
20
SCOR
19
WFCK
XUGF
9 10 11 12 13 14 15 16 17 18
ATSK
SPOA
SPOB
XLON
8
VDD
7
SCLK
DATA
6
SENS
5
CLOK
3 4
XRST
SYSM
1
SQSO
2
SQCK
CPU
Interface
XLAT
EMPH
XVDD
XTAI
XTAO
PRFVCC
CH4BIN
CH4SIN'
CH4SIN
CH3FIN
CH3RIN
CAPAIN3
GND
MUTE
POWVCC
CH3OUTR
CH3OUTF
CH4OUTR
CH4OUTF
IC102 BA5974FM-E2 (BD BOARD)
28
27
26
25
24
23
22
21
20
19
18
17
16
15
F
R
R
MUTE
INTERFACE
F
LEVEL SHIFT
THERMAL
SHUTDOWN
F
INTERFACE
F
R
F
R
INTERFACE
50
1
2
3
4
5
6
7
8
9
10
11
12
13
14
CH1RIN
CAPAIN1
CH2FIN
CH2RIN
CAPAIN2
GND
VREFIN
POWVCC
CH2OUTR
CH2OUTF
CH1OUTR
CH1OUTF
R
CH1FIN
R
VREFOUT
F
HCD-XGR6/XGR60
IC103 CXA2581N-T4 (BD BOARD)
30 DC_OFST
RW/ROM
APC
LD 1
29 RFDCI
PD 2
DVCC
VC
28 RFDCO
DVC
VCC
VC
27 VC
EQ IN 3
AC SUM 4
AC
SUM
EQ
26 RFC
25 VFC
24 BST
AC
VCA
23 RFG
EQ
ON/OFF
GND 5
VCC
VOFST
22 VCC
RW/ROM
B
C
A 6
B 7
A
C 8
D
VCC
20 CE
VC
VC
VOFST
D 9
VC
RW/ROM
RW/ROM
F 10
gm
E 11
gm
21 CEI
19 TE_BAL
DVCC RW/ROM
18 TE
APC-OFF(Hi-Z)
RW/ROM
(H/L)
SW 12
RW/ROM
DVCC 13
AVC
DVC
VOFST
DVC
DVC
17 FEI
DVCC
VC
DVC 14
16 FE
DVC
RFAC 15
IC321
µPC1330HA (MAIN BOARD (3/3))
INVERTER
COMPARATER
1
2
3
4
5
6
7
8
9
SW R1
GND
SW P1
CONT
GND
VCC
SW P2
GND
SW R2
51
HCD-XGR6/XGR60
IC201 TA8409 (MOTOR BOARD)
VREF
BLOCK
STANDBY
BLOCK
HEAT
CUT OFF
BLOCK
2
VCC
1
IN2
3
OUT2
5
GND
4
NC
6
VS
8
VREF
7
OUT1
IC602 BA3830F (PANEL FL BOARD)
R02
1
REFERENCE
CURRENT
R01
2
REFERENCE
CURRENT
LINE NF
3
LINE IN
4
–
+
RESET
BAND
PASS
FILTER
DET
REC NF
5
REC IN
6
RESET C
BIAS C
GND
7
8
9
–
+
18 RESET
17
16
15
14
13
12
F01
F02
F03
F04
F05
F06
11 REC LEVEL
10 VCC
52
9
IN1
HCD-XGR6/XGR60
SECTION 7
EXPLODED VIEWS
NOTE:
• -XX, -X mean standardized parts, so they may
have some differences from the original one.
• Items marked “*” are not stocked since they
are seldom required for routine service. Some
delay should be anticipated when ordering these
items.
• The mechanical parts with no reference number
in the exploded views are not supplied.
•
•
Hardware (# mark) list and accessories are
given in the last of this parts list.
Abbreviation
MX : Mexican model
E51 : Chilean and Peruvian model
AR : Argentina model
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
7-1. CASE, BACK PANEL SECTION
3
6
#3
4
#2
XGR6, XGR60:
MX model
#1
7
#1
#1
5
2
#1
#1
#1
#1
not supplied
#1
#1
a
#1
not
supplied
2
M901
a
Chassis section
#1
Front panel section
1
#1
Ref. No.
Part No.
Description
1
2
3
4
4
4-948-236-21
3-363-099-01
4-237-661-11
1-693-572-11
1-693-573-11
CUSHION (107)
SCREW (CASE 3 TP2)
CASE
TUNER (FM/AM) (XGR60:AR,MX)
TUNER (FM/AM) (XGR6)
4
5
6
6
1-693-574-11
1-769-945-11
4-237-748-01
4-237-748-21
TUNER (FM/AM) (XGR60:E,E51)
WIRE (FLAT TYPE) (11 CORE)
PANEL, BACK (XGR6)
PANEL, BACK (XGR60:E)
Remarks
Ref. No.
Part No.
Description
6
4-237-748-31 PANEL, BACK (XGR60:E51)
6
6
7
M901
#1
4-237-748-41
4-237-748-51
1-535-706-21
1-763-072-11
7-685-646-79
#2
#3
7-685-872-09 SCREW +BVTT 3X8 (S)
7-685-871-01 SCREW +BVTT 3X6 (S)
Remarks
PANEL, BACK (XGR60:MX)
PANEL, BACK (XGR60:AR)
PLUG, JUMPER (XGR6,XGR60:MX)
FAN, DC
SCREW +BVTP 3X8 TYPE2 N-S
53
HCD-XGR6/XGR60
7-2. FRONT PANEL SECTION-1
59
56
54
57
55
not supplied
58
53
54
61
60
not supplied
54
62
52
54
54
54
54
63
#1
63 54
65
51
54
not supplied
64
Front panel section-2
Ref. No.
Part No.
Description
51
52
53
54
55
4-237-635-01
A-4727-633-A
1-683-448-11
4-951-620-01
4-237-648-01
KNOB (MIC)
MIC/GUITAR BOARD, COMPLETE
TC-A BOARD
SCREW (2.6X8), +BVTP
COVER (EJECT)
56
57
58
4-237-645-01 LEVER (EJECT-A)
4-237-647-01 LEVER (EJECT-C)
4-237-646-01 LEVER (EJECT-B)
54
Remarks
Ref. No.
Part No.
Description
59
60
4-237-659-01 SPRING (LEVER)
1-796-333-11 DECK, MECHANICAL
61
62
63
64
65
1-773-021-11
1-683-449-11
3-354-963-01
1-683-450-11
1-684-683-11
#1
7-685-646-79 SCREW +BVTP 3X8 TYPE2 N-S
WIRE (FLAT TYPE) (15 CORE)
TC-B BOARD
DAMPER
HEADPHONE BOARD
D-SW BOARD
Remarks
HCD-XGR6/XGR60
7-3. FRONT PANEL SECTION-2
109
114
112
109
not supplied
110
113
FL601
111
108
104
109
109
110
109
106
114
115
not
109 supplied
109
105
#7
109
#7
123
103
109
109
118
107
116
102
117
119
109
109
101
supplied with S763
not supplied
109
120
121
122
109
Ref. No.
Part No.
Description
101
101
102
103
104
4-237-649-01
4-237-649-11
1-683-452-11
X-4954-371-1
4-237-638-01
BUMPER (PANEL) (XGR6)
BUMPER (PANEL) (XGR60)
CD-L BOARD
SUB PANEL (CD-L) ASSY
LID(CD)
105
106
107
108
109
4-237-630-01
4-237-658-01
4-040-472-01
4-237-634-01
4-951-620-01
WINDOW (CD)
SPRING (CD)
LATCH, D.C.
KNOB (VOLUME)
SCREW (2.6X8), +BVTP
110
111
112
113
4-949-935-81
4-225-511-01
A-4727-623-A
1-773-118-11
CUSHION (FL)
HOLDER FL TUBE
PANEL FL BOARD, COMPLETE
WIRE (FLAT TYPE) (19 CORE)
Remarks
Ref. No.
Part No.
Description
114
4-237-639-01 HOLDER (LED 1)
115
116
117
117
118
1-773-178-11
A-4727-624-A
X-4954-360-1
X-4954-378-1
4-224-104-01
WIRE (FLAT TYPE) (23 CORE)
PANEL VR BOARD, COMPLETE
FRONT PANEL ASSY (XGR6)
FRONT PANEL ASSY (XGR60)
DAMPER
119
120
121
122
123
X-4954-372-1
4-237-636-01
1-683-453-11
1-683-454-11
4-237-640-01
SUB PANEL (CD-R) ASSY
KNOB (CD)
CD-R BOARD
FRONT INPUT BOARD
HOLDER (LED 2)
FL601
#7
1-518-794-11 INDICATOR TUBE, FLUORESCENT
7-685-533-19 SCREW +BTP 2.6X6 TYPE2 N-S
Remarks
55
HCD-XGR6/XGR60
not supplied
7-4. CHASSIS SECTION
154
#2
#5
#5
158
F951
#2
T951
F961
#1
156
F962
#1
F963
155
F964
153
159
#4
not supplied
b
b
160
#1
152
not supplied
#1
#1
#1
#1
CDM37B-30BD60C
not supplied
161
151
not supplied
Ref. No.
Part No.
Description
151
152
153
153
154
1-823-750-11
4-235-701-01
A-4727-618-A
A-4727-641-A
1-683-444-11
WIRE (FLAT TYPE) (21 CORE)
DUST COVER
PA BOARD, COMPLETE (XGR60)
PA BOARD, COMPLETE (XGR6)
TRANS BOARD
155
155
0 156
0 156
0 156
3-703-244-00 BUSHING (FBS001), CORD
(XGR6,XGR60:AR,E51)
4-966-266-01 BUSHING (S) (FBS002), CORD (XGR60:E,MX)
1-575-653-11 CORD, POWER (XGR60:MX)
1-777-071-81 CORD, POWER (XGR60:E51)
1-783-820-11 CORD, POWER (XGR6)
0 156
0 156
158
* 159
160
1-783-941-12
1-791-901-11
1-683-445-11
4-988-533-01
A-4440-764-A
160
160
56
Remarks
CORD, POWER (XGR60:AR)
CORD, POWER (XGR60:E)
SUB TRANS BOARD
HOLDER, PWB
MAIN BOARD, COMPLETE (XGR60:AR,E,E51)
A-4676-330-A MAIN BOARD, COMPLETE (XGR60:MX)
A-4727-645-A MAIN BOARD, COMPLETE (XGR6)
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
#1
Ref. No.
Part No.
161
0 F951
0 F961
X-494-122-81 FOOT (F22125H-M)
1-532-506-31 FUSE (6.3A 250V) (XGR60:AR,E,E51)
1-533-949-31 FUSE, CYLINDRICAL (TIME LUG) (8.0A 250V)
(XGR60)
0 F962
1-533-949-31 FUSE, CYLINDRICAL (TIME LUG) (8.0A 250V)
(XGR60)
1-532-506-31 FUSE (6.3A 250V) (XGR60)
1-533-310-11 FUSE, GLASS CYLINDRICAL(DIA.5)
(6.3A 125V) (XGR6)
1-532-506-31 FUSE (6.3A 250V) (XGR60)
1-533-310-11 FUSE, GLASS CYLINDRICAL(DIA.5)
(6.3A 125V)(XGR6)
0 F963
0 F963
0 F964
0 F964
0 T951
0 T951
#1
#2
#4
#5
1-433-606-11
1-435-797-11
7-685-646-79
7-685-872-09
7-685-650-79
Description
TRANSFORMER, POWER (XGR60)
TRANSFORMER, POWER (XGR6)
SCREW +BVTP 3X8 TYPE2 N-S
SCREW +BVTT 3X8 (S)
SCREW +BVTP 3X16 TYPE2 IT-3
7-685-881-09 SCREW +BVTT 4X8 (S)
Remarks
HCD-XGR6/XGR60
7-5. CD MECHANISM DECK SECTION
(CDM-30BD60C)
501
501
509
505
#1
504
507
511
506
510
501
517
502
508
510
503
510
512
M201
502
518
520
518
519
520
516
519
BU-30BD60C
520
514
513
#1
520
522
521
521
524
515
#1
#1
#1
523
Ref. No.
Part No.
Description
501
502
503
504
505
4-987-976-01
4-944-490-01
A-4660-978-A
4-978-421-01
4-978-425-01
SCREW, STEP
BELT (TIMING)
GEAR (PULLEY) ASSY
GEAR (MID)
ROLLER (CAM)
506
507
508
509
510
4-978-420-01
4-237-981-01
X-4953-307-1
4-238-261-01
X-4947-960-1
CAM (HOLDER)
PULLEY (B) (30), CHUCKING
PULLEY (A) ASSY, CHUCKING
TABLE, DISK
ROLLER ASSY
* 511
512
* 513
4-978-583-01 BRACKET (BU)
4-238-260-01 CHASSIS
A-4673-765-A MOTOR BOARD, COMPLETE
Remarks
Ref. No.
Part No.
Description
514
515
4-978-426-01 INDICATOR (NO.)
1-659-059-13 LED BOARD
516
517
518
519
520
1-659-058-13
4-228-414-01
4-951-620-01
4-231-151-01
4-231-451-11
SENSOR BOARD
BRACKET (YOKE)
SCREW (2.6X8), +BVTP
STOPPER (BU)
INSULATOR (BU-30)
521
522
523
524
M201
4-227-045-11
4-227-899-01
4-998-716-01
X-4954-451-1
A-4660-977-A
SPRING (INSULATOR), COIL
SCREW (DIA. 12), FROATING
SCREW, BU FITTING
HOLDER (BU30) ASSY
MOTOR ASSY
#1
7-685-646-79 SCREW +BVTP 3X8 TYPE2 N-S
Remarks
57
HCD-XGR6/XGR60
7-6. BASE UNIT SECTION
(BU-30BD60C)
554
556
555
553
552
551
Ref. No.
551
552
553
554
555
58
Part No.
Description
3-531-576-11
A-4728-678-A
4-233-832-01
4-233-831-01
1-757-710-11
RIVET
BD BOARD, COMPLETE
GEAR (LB)
GEAR (LA)
WIRE (FLAT TYPE) (16 CORE)
Remarks
Ref. No.
556
Part No.
Description
A-4735-188-A BU-30 (60) ASSY
Remarks
NOTE:
Ref. No.
Part No.
Description
• Due to standardization, replacements in the
parts list may be different from the parts
specified in the diagrams or the components
used on the set.
• -XX, -X mean standardized parts, so they
may have some difference from the original
one.
• Items marked “*” are not stocked since they
are seldom required for routine service.
Some delay should be anticipated when
ordering these items.
• CAPACITORS:
uF: µF
• RESISTORS
All resistors are in ohms.
METAL: metal-film resistor
METAL OXIDE: Metal Oxide-film resistor
F: nonflammable
Ref. No.
Part No.
HCD-XGR6/XGR60
SECTION 8
ELECTRICAL PARTS LIST
•
•
•
Remarks Ref. No.
Part No.
COILS
uH: µH
SEMICONDUCTORS
In each case, u: µ, for example:
uA...: µA... , uPA... , µPA... ,
uPB... , µPB... , uPC... , µPC... ,
uPD..., µPD...
Abbreviation
MX : Mexican model
E51 : Chilean and Peruvian model
AR
: Argentina model
Description
Remarks
A-4728-678-A BD BOARD, COMPLETE
*****************
< CAPACITOR >
Ref. No.
Description
0.1uF
100uF
0.1uF
0.1uF
1-164-360-11 CERAMIC CHIP
1-107-826-11 CERAMIC CHIP
1-124-584-00 ELECT
0.1uF
0.1uF
100uF
10%
10%
10%
10%
10%
50V
16V
50V
50V
16V
C196
C197
C198
C109
C110
C111
C112
C114
1-162-965-11
1-162-967-11
1-162-927-11
1-125-837-91
1-164-360-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.0015uF
0.0033uF
100PF
1uF
0.1uF
10%
10%
5%
10%
50V
50V
50V
6.3V
16V
CN101
CN102
C116
C117
C118
C121
C122
1-104-665-11
1-104-665-11
1-162-964-11
1-164-360-11
1-124-584-00
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
100uF
100uF
0.001uF
0.1uF
100uF
20%
20%
10%
10V
10V
50V
16V
10V
C123
C124
C125
C126
C127
1-162-970-11
1-125-891-11
1-164-360-11
1-164-360-11
1-124-584-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.01uF
0.47uF
0.1uF
0.1uF
100uF
10%
10%
C129
C130
C131
C133
C143
1-162-974-11
1-164-360-11
1-104-665-11
1-162-921-11
1-164-360-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.1uF
100uF
33PF
0.1uF
C145
C153
C159
C162
C165
1-164-360-11
1-164-360-11
1-162-970-11
1-104-665-11
1-164-360-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
0.1uF
0.1uF
0.01uF
100uF
0.1uF
C167
C168
C171
C172
C181
1-162-919-11
1-162-921-11
1-115-412-11
1-162-927-11
1-115-412-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
22PF
33PF
680PF
100PF
680PF
5%
5%
5%
5%
5%
50V
50V
25V
50V
25V
C182
C183
C184
C185
C190
1-162-927-11
1-164-227-11
1-162-970-11
1-125-837-91
1-115-156-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
100PF
0.022uF
0.01uF
1uF
1uF
5%
10%
10%
10%
50V
25V
25V
6.3V
10V
C191
1-124-584-00 ELECT
100uF
20%
10V
10%
20%
16V
16V
25V
10V
16V
Remarks
20%
16V
10V
16V
16V
10%
20%
16V
16V
10V
< CONNECTOR >
1-568-864-11 CONNECTOR, FFC 21P
1-793-907-11 CONNECTOR, FFC/FPC 16P
< DIODE >
D101
20%
5%
When indicating parts by reference
number, please include the board
name.
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.0033uF
0.1uF
470PF
470PF
0.1uF
50V
16V
10V
50V
16V
The components identified by
mark 0 or dotted line with mark
0 are critical for safety.
Replace only with part number
specified.
1-164-360-11
1-104-665-11
1-164-360-11
1-164-360-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
20%
Remarks
Part No.
1-162-967-11
1-107-826-11
1-162-962-11
1-162-962-11
1-107-826-11
25V
10V
16V
16V
10V
Description
C192
C193
C194
C195
C101
C102
C103
C104
C108
20%
BD
8-719-083-58 DIODE UDZSTE-173.9B
< FERRITE BEAD >
FB101
FB102
1-500-445-21 FERRITE
1-500-445-21 FERRITE
0UH
0UH
< IC >
IC101
IC102
IC103
8-752-402-31 IC CXD3017Q
8-759-827-41 IC BA5974FM-E2
8-752-089-74 IC CXA2581N-T4
< JUMPER RESISTOR >
JR101
JR102
JR103
JR104
JR105
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
1-216-864-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
0
0
0
0
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
JR106
JR122
JR123
JR124
JR125
1-216-864-11
1-216-296-11
1-216-296-11
1-216-296-11
1-216-296-11
METAL CHIP
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
5%
1/16W
< COIL >
L101
1-469-553-21 INDUCTOR
4.7uH
< TRANSISTOR >
Q101
Q102
8-729-049-31 TRANSISTOR 2SB710A-RTX
8-729-920-85 TRANSISTOR 2SD1664-T100-QR
< RESISTOR >
R101
1-216-821-11 METAL CHIP
1K
5%
1/16W
59
HCD-XGR6/XGR60
BD
CD-L CD-R D-SW
FRONT INPUT
Ref. No.
R102
R103
R104
R105
Part No.
1-216-845-11
1-216-835-11
1-216-839-11
1-216-821-11
Description
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
15K
33K
1K
5%
5%
5%
5%
Remarks
1/16W
1/16W
1/16W
1/16W
R106
R107
R108
R109
R111
1-216-821-11
1-216-833-11
1-216-827-11
1-216-857-11
1-216-846-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
10K
3.3K
1M
120K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R114
R116
R117
R118
R119
1-218-745-11
1-216-001-00
1-216-821-11
1-216-809-11
1-216-826-11
RES-CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
160K
10
1K
100
2.7K
5%
5%
5%
5%
5%
1/10W
1/10W
1/16W
1/16W
1/16W
R120
R122
R123
R124
R131
1-216-835-11
1-216-845-11
1-216-833-11
1-216-845-11
1-216-813-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
15K
100K
10K
100K
220
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R143
R144
R147
R148
R149
1-216-839-11
1-216-839-11
1-218-701-11
1-216-797-11
1-216-797-11
METAL CHIP
METAL CHIP
RES-CHIP
METAL CHIP
METAL CHIP
33K
33K
2.4K
10
10
5%
5%
5%
5%
5%
1/16W
1/16W
1/10W
1/16W
1/16W
R158
R159
R162
R171
R172
1-216-838-11
1-216-838-11
1-216-845-11
1-216-837-11
1-216-837-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
27K
27K
100K
22K
22K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R173
R181
R182
R183
R190
1-216-837-11
1-216-837-11
1-216-837-11
1-216-837-11
1-216-813-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
22K
22K
22K
220
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R191
R192
R193
R194
R195
1-216-839-11
1-216-839-11
1-216-846-11
1-216-839-11
1-216-849-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
33K
33K
120K
33K
220K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R196
R198
1-216-819-11 METAL CHIP
1-216-864-11 METAL CHIP
680
0
5%
5%
1/16W
1/16W
Ref. No.
R773
R774
R775
R776
R777
R778
Part No.
1-249-421-11
1-247-843-11
1-249-425-11
Description
CARBON
CARBON
CARBON
1-249-427-11 CARBON
1-249-429-11 CARBON
1-249-431-11 CARBON
2.2K
3.3K
4.7K
5%
5%
5%
Remarks
1/4W F
1/4W
1/4W F
6.8K
10K
15K
5%
5%
5%
1/4W F
1/4W
1/4W
< SWITCH >
S741
S742
S743
S744
S745
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
SWITCH, KEYBOARD (DISC 1)
SWITCH, KEYBOARD (DISC 2)
SWITCH, KEYBOARD (DISC 3)
SWITCH, KEYBOARD (DISC 4)
SWITCH, KEYBOARD (DISC 5)
S746
S747
S748
S749
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
SWITCH, KEYBOARD (DISC SKIP)
SWITCH, KEYBOARD (REPEAT)
SWITCH, KEYBOARD (PLAY MODE)
SWITCH, KEYBOARD (EDIT)
******************************************************
1-683-453-11 CD-R BOARD
**********
< CAPACITOR >
C751
C752
1-162-306-11 CERAMIC
1-162-306-11 CERAMIC
0.01uF
0.01uF
30%
30%
16V
16V
< CONNECTOR >
CN703
1-785-333-11 PIN, CONNECTOR (LIGHT ANGLE)7P
< DIODE >
D700
8-719-056-13 DIODE SML79423C-TP15 (GX )
< RESISTOR >
R782
R783
R784
R790
R791
1-247-843-11
1-249-425-11
1-249-427-11
1-247-791-91
1-247-791-91
CARBON
CARBON
CARBON
CARBON
CARBON
3.3K
4.7K
6.8K
22
22
5%
5%
5%
5%
5%
1/4W
1/4W F
1/4W F
1/4W
1/4W
< SWITCH >
< NETWORK >
RN101
1-233-576-11 RES, CHIP NETWORK 100
S752
S753
S754
S755
S763
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-473-393-11
SWITCH, KEYBOARD (GX )
SWITCH, KEYBOARD (x )
SWITCH, KEYBOARD (m )
SWITCH, KEYBOARD (M )
ENCODER, ROTARY ( . AMS > )
******************************************************
< VARIABLE RESISTOR >
1-684-683-11 D-SW BOARD
RV101
**********
1-238-602-11 RES, ADJ, CARBON 47K (E-F BALANCE)
< VIBRATOR >
X101
< CAPACITOR >
1-579-280-11 VIBRATOR, CRYSTAL (16.9344MHz)
C741
1-162-306-11 CERAMIC
0.01uF
30%
16V
******************************************************
< SWITCH >
1-683-452-11 CD-L BOARD
*********
S740
1-762-587-11 SWITCH, PUSH (1 KEY) (DOOR)
******************************************************
< CONNECTOR >
1-683-454-11 FRONT INPUT BOARD
* CN704
****************
1-564-719-11 PIN, CONNECTOR (SMALL TYPE) 3P
< CAPACITOR >
< RESISTOR >
R771
R772
60
1-249-419-11 CARBON
1-249-419-11 CARBON
1.5K
1.5K
5%
5%
1/4W F
1/4W F
C701
C702
1-162-294-31 CERAMIC
1-162-294-31 CERAMIC
0.001uF
0.001uF
10%
10%
50V
50V
HCD-XGR6/XGR60
FRONT INPUT
Ref. No.
C703
C704
C705
Part No.
1-126-960-11
1-164-159-21
1-162-282-31
Description
ELECT
CERAMIC
CERAMIC
1uF
0.1uF
100PF
20%
10%
Remarks
50V
50V
50V
< FILTER >
FL730
1-424-228-11 FILTER, NOISE
< JACK >
J804
1-815-310-11 JACK 3P (GAME INPUT)
< RESISTOR >
R721
R722
R723
R724
R725
1-249-437-11
1-249-417-11
1-249-437-11
1-247-804-11
1-249-417-11
CARBON
CARBON
CARBON
CARBON
CARBON
47K
1K
47K
75
1K
5%
5%
5%
5%
5%
1/4W
1/4W F
1/4W
1/4W
1/4W F
******************************************************
1-683-450-11 HEADPHONE BOARD
***************
< CAPACITOR >
C891
C892
C893
1-162-294-31 CERAMIC
1-162-294-31 CERAMIC
1-164-159-21 CERAMIC
0.001uF
0.001uF
0.1uF
10%
10%
50V
50V
50V
< JACK >
J891
1-770-226-11 JACK (LARGE TYPE) (PHONES)
< RESISTOR >
R891
1-247-807-31 CARBON
100
5%
1/4W
******************************************************
*
1-659-059-13 LED BOARD
*********
< DIODE >
D201
8-719-032-98 DIODE SEL5820A (DISC No.)
< TRANSISTOR >
Q201
8-729-119-78 TRANSISTOR 2SC2785-HFE
< RESISTOR >
R201
R202
R203
1-249-433-11 CARBON
1-249-411-11 CARBON
1-249-437-11 CARBON
22K
330
47K
5%
5%
5%
1/4W
1/4W
1/4W
******************************************************
A-4440-764-A MAIN BOARD, COMPLETE (XGR60:AR,E,E51)
A-4676-330-A MAIN BOARD, COMPLETE (XGR60:MX)
A-4727-645-A MAIN BOARD, COMPLETE (XGR6)
*******************
4-875-327-31 HEAT SINK
4-948-236-21 CUSHION (107)
7-685-646-79 SCREW +BVTP 3X8 TYPE2 N-S
< CAPACITOR >
C72
C73
C110
C111
C112
1-136-169-00
1-136-169-00
1-126-795-11
1-126-795-11
1-126-795-11
FILM
FILM
ELECT
ELECT
ELECT
0.22uF
0.22uF
10uF
10uF
10uF
5%
5%
20%
20%
20%
50V
50V
50V
50V
50V
HEADPHONE
LED
MAIN
Ref. No.
C113
C114
C115
C116
C117
Part No.
1-126-795-11
1-126-795-11
1-126-795-11
1-130-487-00
1-130-487-00
Description
ELECT
ELECT
ELECT
MYLAR
MYLAR
10uF
10uF
10uF
0.022uF
0.022uF
20%
20%
20%
5%
5%
Remarks
50V
50V
50V
50V
50V
C118
C119
C120
C121
C122
1-126-795-11
1-130-491-00
1-130-479-00
1-126-795-11
1-136-171-00
ELECT
MYLAR
MYLAR
ELECT
FILM
10uF
0.047uF
0.0047uF
10uF
0.33uF
20%
5%
5%
20%
5%
50V
50V
50V
50V
50V
C123
C124
C131
C132
C133
1-136-171-00
1-126-961-11
1-126-795-11
1-125-972-91
1-126-795-11
FILM
ELECT
ELECT
ELECT
ELECT
0.33uF
2.2uF
10uF
100uF
10uF
5%
20%
20%
20%
20%
50V
50V
50V
16V
50V
C134
C135
C136
C137
C138
1-162-974-11
1-124-589-11
1-126-964-11
1-162-967-11
1-162-967-11
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
CERAMIC CHIP
0.01uF
47uF
10uF
3300pF
3300pF
20%
20%
10%
10%
50V
16V
50V
50V
50V
C160
C161
C162
C163
C164
1-126-795-11
1-126-795-11
1-126-795-11
1-126-795-11
1-126-795-11
ELECT
ELECT
ELECT
ELECT
ELECT
10uF
10uF
10uF
10uF
10uF
20%
20%
20%
20%
20%
50V
50V
50V
50V
50V
C165
C166
C167
C168
C169
1-126-795-11
1-130-487-00
1-130-487-00
1-126-795-11
1-130-491-00
ELECT
MYLAR
MYLAR
ELECT
MYLAR
10uF
0.022uF
0.022uF
10uF
0.047uF
20%
5%
5%
20%
5%
50V
50V
50V
50V
50V
C170
C171
C172
C173
C174
1-130-479-00
1-126-795-11
1-136-171-00
1-136-171-00
1-126-961-11
MYLAR
ELECT
FILM
FILM
ELECT
0.0047uF
10uF
0.33uF
0.33uF
2.2uF
5%
20%
5%
5%
20%
50V
50V
50V
50V
50V
C181
C182
C183
C193
C301
1-164-156-11
1-164-156-11
1-164-156-11
1-164-156-11
1-130-483-00
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
MYLAR
0.1uF
0.1uF
0.1uF
0.1uF
0.01uF
5%
25V
25V
25V
25V
50V
C302
C303
C304
C305
C306
1-126-964-11
1-136-165-00
1-126-964-11
1-136-165-00
1-126-961-11
ELECT
FILM
ELECT
FILM
ELECT
10uF
0.1uF
10uF
0.1uF
2.2uF
20%
5%
20%
5%
20%
50V
50V
50V
50V
50V
C307
C308
C309
C310
C311
1-126-947-11
1-164-392-11
1-164-392-11
1-162-962-11
1-126-933-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
47uF
390PF
390PF
470PF
100uF
20%
10%
10%
10%
20%
16V
50V
50V
50V
16V
C312
C313
C321
C322
C323
1-126-964-11
1-126-964-11
1-126-964-11
1-135-575-11
1-135-575-11
ELECT
ELECT
ELECT
MYLAR
MYLAR
10uF
10uF
10uF
120PF
120PF
20%
20%
20%
5%
5%
50V
50V
50V
50V
50V
C324
C325
C326
C327
C328
1-162-961-11
1-162-961-11
1-162-946-11
1-162-946-11
1-162-974-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
330PF
330PF
27PF
27PF
0.01uF
10%
10%
5%
5%
50V
50V
50V
50V
50V
C329
1-162-974-11 CERAMIC CHIP
0.01uF
50V
61
HCD-XGR6/XGR60
MAIN
Ref. No.
C331
C332
C333
C334
Part No.
1-137-150-11
1-126-961-11
1-130-485-00
1-130-481-00
Description
MYLAR
ELECT
MYLAR
MYLAR
0.01uF
2.2uF
0.015uF
0.0068uF
5%
20%
5%
5%
Remarks
100V
50V
50V
50V
C335
C336
C337
C338
C341
1-130-481-00
1-130-486-00
1-126-964-11
1-126-947-11
1-126-935-11
MYLAR
MYLAR
ELECT
ELECT
ELECT
0.0068uF
0.018uF
10uF
47uF
470uF
5%
10%
20%
20%
20%
50V
50V
50V
16V
10V
C342
C343
C344
C345
C346
1-164-156-11
1-130-487-00
1-130-487-00
1-126-961-11
1-126-961-11
CERAMIC CHIP
MYLAR
MYLAR
ELECT
ELECT
0.1uF
0.022uF
0.022uF
2.2uF
2.2uF
5%
5%
20%
20%
25V
50V
50V
50V
50V
C347
C348
C349
C350
C351
1-126-964-11
1-126-965-11
1-162-962-11
1-137-198-11
1-130-483-00
ELECT
ELECT
CERAMIC CHIP
FILM
MYLAR
10uF
22uF
470PF
1uF
0.01uF
20%
20%
10%
5%
5%
50V
50V
50V
50V
50V
C352
C353
C354
C355
C356
1-126-964-11
1-136-165-00
1-126-964-11
1-136-165-00
1-126-961-11
ELECT
FILM
ELECT
FILM
ELECT
10uF
0.1uF
10uF
0.1uF
2.2uF
20%
5%
20%
5%
20%
50V
50V
50V
50V
50V
C357
C358
C359
C381
C382
1-126-947-11
1-164-392-11
1-164-392-11
1-162-968-11
1-162-968-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
47uF
390PF
390PF
0.0047uF
0.0047uF
20%
10%
10%
10%
10%
16V
50V
50V
50V
50V
C401
C402
C403
C404
C405
1-164-156-11
1-126-916-11
1-126-961-11
1-126-961-11
1-162-927-11
CERAMIC CHIP
ELECT
ELECT
ELECT
CERAMIC CHIP
0.1uF
1000uF
2.2uF
2.2uF
100PF
20%
20%
20%
5%
25V
6.3V
50V
50V
50V
C406
C407
C408
C410
C414
1-162-927-11
1-164-156-11
1-126-916-11
1-126-935-11
1-164-156-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
100PF
0.1uF
1000uF
470uF
0.1uF
C431
C452
C510
C511
C512
1-164-156-11
1-126-947-11
1-162-918-11
1-162-919-11
1-164-156-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
47uF
18PF
22PF
0.1uF
C516
C562
C563
C598
C599
1-164-156-11
1-164-156-11
1-126-947-11
1-164-156-11
1-126-947-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
CERAMIC CHIP
ELECT
C601
C602
C603
C604
1-162-959-11
1-162-927-11
1-162-927-11
1-126-961-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
5%
20%
20%
20%
5%
5%
25V
16V
50V
50V
25V
0.1uF
0.1uF
47uF
0.1uF
47uF
20%
25V
25V
16V
25V
16V
330PF
100PF
100PF
2.2uF
5%
5%
5%
20%
20%
C604
1-126-963-11 ELECT
4.7uF
C605
C606
C607
1-130-479-00 MYLAR
1-130-473-00 MYLAR
1-136-159-00 FILM
0.0047uF 5%
0.0015uF 5%
0.033uF 5%
C607
1-136-165-00 FILM
0.1uF
62
50V
25V
6.3V
10V
25V
20%
5%
50V
50V
50V
50V
(XGR60)
50V
(XGR6)
50V
50V
50V
(XGR60)
50V
(XGR6)
Ref. No.
C608
Part No.
Description
1-126-964-11 ELECT
10uF
C609
C610
C611
C612
C613
1-162-974-11
1-126-933-11
1-126-947-11
1-162-974-11
1-126-947-11
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
ELECT
0.01uF
100uF
47uF
0.01uF
47uF
C651
C652
C653
C654
1-162-959-11
1-162-927-11
1-162-927-11
1-126-961-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
330PF
100PF
100PF
2.2uF
5%
5%
5%
20%
C654
1-126-963-11 ELECT
4.7uF
20%
C655
C656
C657
1-130-479-00 MYLAR
1-130-473-00 MYLAR
1-136-159-00 FILM
0.0047uF 5%
0.0015uF 5%
0.033uF 5%
C657
1-136-165-00 FILM
0.1uF
5%
C658
1-126-964-11 ELECT
10uF
20%
C701
C702
C703
C704
C705
1-162-960-11
1-162-960-11
1-126-964-11
1-126-964-11
1-162-960-11
CERAMIC CHIP
CERAMIC CHIP
ELECT
ELECT
CERAMIC CHIP
220PF
220PF
10uF
10uF
220PF
C722
C724
C751
C752
C753
1-126-926-11
1-162-962-11
1-162-960-11
1-162-960-11
1-126-964-11
ELECT
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
ELECT
1000uF
470PF
220PF
220PF
10uF
C754
C755
1-126-964-11 ELECT
1-162-960-11 CERAMIC CHIP
10uF
220PF
C771
C772
C774
1-164-156-11 CERAMIC CHIP
1-164-156-11 CERAMIC CHIP
1-164-156-11 CERAMIC CHIP
0.1uF
0.1uF
0.1uF
C801
C802
C803
C804
C806
1-126-964-11
1-136-165-00
1-136-165-00
1-126-916-11
1-109-953-11
ELECT
FILM
FILM
ELECT
ELECT
10uF
0.1uF
0.1uF
1000uF
2.2uF
20%
5%
5%
20%
20%
50V
50V
50V
6.3V
50V
C901
C902
C903
C911
C912
1-128-548-11
1-164-156-11
1-126-935-11
1-104-665-11
1-126-935-11
ELECT
CERAMIC CHIP
ELECT
ELECT
ELECT
4700uF
0.1uF
470uF
100uF
470uF
20%
25V
25V
16V
25V
10V
C913
C921
C922
C923
C924
1-126-947-11
1-126-768-11
1-164-156-11
1-126-916-11
1-126-947-11
ELECT
ELECT
CERAMIC CHIP
ELECT
ELECT
47uF
2200uF
0.1uF
1000uF
47uF
20%
20%
C925
C926
C961
C962
C963
1-164-156-11
1-126-935-11
1-164-156-11
1-164-156-11
1-126-947-11
CERAMIC CHIP
ELECT
CERAMIC CHIP
CERAMIC CHIP
ELECT
0.1uF
470uF
0.1uF
0.1uF
47uF
20%
20%
20%
20%
Remarks
50V
50V
16V
16V
50V
16V
50V
50V
50V
50V
(XGR60)
50V
(XGR6)
50V
50V
50V
(XGR60)
50V
(XGR6)
50V
10%
50V
10%
50V
20%
50V
20%
50V
10%
50V
(XGR6,XGR60:MX)
20%
10%
10%
10%
20%
10V
50V
50V
50V
50V
20%
50V
10%
50V
(XGR6,XGR60:MX)
25V
25V
25V
20%
20%
20%
20%
20%
20%
20%
16V
16V
25V
6.3V
16V
25V
6.3V
25V
25V
16V
< CONNECTOR >
* CN301
CN311
CN321
1-568-449-11 HOUSING, CONNECTOR(PC BOARD)3P
1-691-765-11 PLUG (MICRO CONNECTOR) 3P
1-691-770-11 PLUG (MICRO CONNECTOR) 8P
HCD-XGR6/XGR60
MAIN
Ref. No.
CN371
CN401
Part No.
Description
1-784-776-11 CONNECTOR, FFC 15P
1-568-838-11 CONNECTOR, FFC 21P
CN411
CN431
CN441
CN722
CN901
1-785-321-11
1-784-780-11
1-563-614-31
1-691-767-11
1-778-982-21
CN902
CN903
CN961
1-778-982-21 CONNECTOR, BOARD TO BOARD 13P
1-785-315-11 PIN, CONNECTOR (STRAIGHT) 3P
1-564-506-11 PLUG, CONNECTOR 3P
Remarks
PIN, CONNECTOR (STRAIGHT) 9P
CONNECTOR, FFC 19P
CONNECTOR, FLEXIBLE 11P
PLUG (MICRO CONNECTOR) 5P
CONNECTOR, BOARD TO BOARD 13P
Ref. No.
JR5
Part No.
Description
1-216-295-00 SHORT
0
Remarks
JR6
JR7
JR12
JR13
JR14
1-216-295-00
1-216-295-00
1-216-295-00
1-216-296-11
1-216-296-11
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
JR15
JR16
JR17
JR18
JR19
1-216-295-00
1-216-295-00
1-216-295-00
1-216-295-00
1-216-296-11
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
JR20
JR21
JR22
JR23
JR27
1-216-295-00
1-216-295-00
1-216-295-00
1-216-295-00
1-216-295-00
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
JR28
JR29
JR181
JR182
JR191
1-216-296-11
1-216-295-00
1-216-295-00
1-216-295-00
1-216-295-00
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
JR192
JR301
JR303
JR351
JR353
1-216-295-00
1-216-295-00
1-216-295-00
1-216-295-00
1-216-295-00
SHORT
SHORT
SHORT
SHORT
SHORT
0
0
0
0
0
JR721
JR722
JR723
JR910
1-216-295-00
1-216-295-00
1-216-295-00
1-216-296-11
SHORT
SHORT
SHORT
SHORT
0
0
0
0 (XGR6)
< DIODE >
D381
D382
D431
D802
D803
8-719-988-61
8-719-988-61
8-719-988-61
8-719-988-61
8-719-988-61
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355TE-17
1SS355TE-17
1SS355TE-17
1SS355TE-17
1SS355TE-17
D805
D806
D807
D808
D809
8-719-988-61
8-719-988-61
8-719-988-61
8-719-988-61
8-719-210-33
DIODE
DIODE
DIODE
DIODE
DIODE
1SS355TE-17
1SS355TE-17
1SS355TE-17
1SS355TE-17
EC10DS2
D810
D911
D912
D913
8-719-210-33
8-719-210-33
8-719-210-33
8-719-210-33
DIODE
DIODE
DIODE
DIODE
EC10DS2
EC10DS2
EC10DS2
EC10DS2
< FERRITE BEAD >
FB402
FB403
FB404
FB516
FB562
1-414-772-11
1-414-772-11
1-414-772-11
1-414-772-11
1-414-772-11
FERRITE
FERRITE
FERRITE
FERRITE
FERRITE
0UH
0UH
0UH
0UH
0UH
FB599
1-414-772-11 FERRITE
0UH
< IC >
IC111
IC181
IC301
IC321
IC341
6-701-686-01
8-759-009-06
6-701-655-01
8-759-143-54
8-759-100-96
IC
IC
IC
IC
IC
M61519FPD60G
MC14052BFEL
HA12236F
uPC1330HA
NJM4558M-TE2
IC451
IC501
IC601
IC801
IC911
8-749-019-25
6-801-051-01
8-759-100-96
8-759-533-04
8-759-231-09
IC
IC
IC
IC
IC
TOTX141 (CD DIGITAL OUT OPTICAL)
M30620MCN-A01FP
NJM4558M-TE2
M62703ML-E1
TA8662N
IC921
IC922
IC931
IC961
8-759-039-69
6-701-760-01
8-759-604-32
8-759-088-08
IC
IC
IC
IC
uPC7805AHF
uPC3504AHF
M5F7810L
uPC7812AHF
< JACK >
J701
J702
J721
1-691-887-11 JACK, PIN 6P (PHONO IN, MD IN/OUT)
1-573-028-31 JACK, PIN 4P (DJ MIX) (XGR6,XGR60:MX)
1-774-227-11 JACK, PIN 1P (VIDEO OUT)
< JUMPER RESISTOR >
JR1
JR2
JR3
JR4
1-216-295-00
1-216-295-00
1-216-295-00
1-216-295-00
SHORT
SHORT
SHORT
SHORT
0
0
0
0
< COIL >
L301
L321
L322
L331
L451
1-412-032-11
1-410-780-11
1-410-780-11
1-412-033-11
1-412-032-11
INDUCTOR CHIP
INDUCTOR
INDUCTOR
INDUCTOR CHIP
INDUCTOR CHIP
100uH
27mH
27mH
220uH
100uH
< TRANSISTOR >
Q111
Q112
Q113
Q114
Q115
8-729-048-96
8-729-048-96
8-729-048-96
8-729-141-30
8-729-141-30
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SK1825
2SK1825
2SK1825
2SC3623A-LK
2SC3623A-LK
Q116
Q161
Q162
Q163
Q164
8-729-141-30
8-729-048-96
8-729-048-96
8-729-048-96
8-729-141-30
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC3623A-LK
2SK1825
2SK1825
2SK1825
2SC3623A-LK
Q165
Q166
Q167
Q168
Q169
8-729-029-40
8-729-620-05
8-729-029-40
8-729-029-86
8-729-029-40
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTA124ESA
2SC2603-EF
DTA124ESA
DTC124ESA
DTA124ESA
Q170
Q181
Q182
Q321
Q322
8-729-029-86
8-729-029-86
8-729-029-86
8-729-029-86
8-729-029-40
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC124ESA
DTC124ESA
DTC124ESA
DTC124ESA
DTA124ESA
Q331
Q332
8-729-113-07 TRANSISTOR 2SC2001TP-K
8-729-113-07 TRANSISTOR 2SC2001TP-K
63
HCD-XGR6/XGR60
MAIN
Ref. No.
Q333
Q334
Q335
Part No.
8-729-801-93
8-729-029-86
8-729-140-04
Description
TRANSISTOR 2SD1387
TRANSISTOR DTC124ESA
TRANSISTOR 2SB1116A-L
Q341
Q342
Q343
Q344
Q345
8-729-620-05
8-729-029-86
8-729-029-86
8-729-029-86
8-729-029-86
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2603-EF
DTC124ESA
DTC124ESA
DTC124ESA
DTC124ESA
Q381
Q382
Q383
Q384
Q385
8-729-140-04
8-729-029-86
8-729-140-04
8-729-029-86
8-729-116-59
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SB1116A-L
DTC124ESA
2SB1116A-L
DTC124ESA
2SB1068TP
Q386
Q387
Q388
Q401
Q402
8-729-029-86
8-729-029-86
8-729-048-96
8-729-141-30
8-729-141-30
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC124ESA
DTC124ESA
2SK1825
2SC3623A-LK
2SC3623A-LK
Q411
Q412
Q451
Q452
Q453
8-729-029-86
8-729-029-86
8-729-620-05
8-729-119-76
8-729-119-76
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC124ESA
DTC124ESA
2SC2603-EF
2SA1175-HFE
2SA1175-HFE
Q454
Q611
Q701
Q751
Q801
8-729-620-05
8-729-620-05
8-729-141-30
8-729-141-30
8-729-620-05
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2603-EF
2SC2603-EF
2SC3623A-LK
2SC3623A-LK
2SC2603-EF
Q802
Q803
Q805
Q806
Q921
8-729-029-86
8-729-029-40
8-729-029-40
8-729-029-86
8-729-209-60
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC124ESA
DTA124ESA
DTA124ESA
DTC124ESA
2SB1375
Q922
Q961
Q962
8-729-029-86 TRANSISTOR DTC124ESA
8-729-620-05 TRANSISTOR 2SC2603-EF
8-729-140-04 TRANSISTOR 2SB1116A-L
Remarks
Ref. No.
R134
R135
Part No.
Description
1-216-857-11 METAL CHIP
1-216-295-00 SHORT
1M
0
5%
Remarks
1/16W
R136
R137
R138
R161
R162
1-216-295-00
1-216-845-11
1-216-845-11
1-216-825-11
1-216-833-11
SHORT
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
100K
100K
2.2K
10K
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
R163
R164
R165
R166
R167
1-216-857-11
1-216-857-11
1-216-841-11
1-216-841-11
1-216-849-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1M
1M
47K
47K
220K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R168
R169
R170
R171
R172
1-216-849-11
1-216-818-11
1-216-845-11
1-216-855-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220K
560
100K
680K
2.2K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R173
R174
R175
R176
R177
1-216-845-11
1-216-833-11
1-216-841-11
1-216-081-00
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
10K
47K
22K
47K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/10W
1/16W
R178
R179
R180
R181
R182
1-216-841-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
10K
10K
10K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R301
R302
R303
R304
R305
1-216-829-11
1-216-829-11
1-216-833-11
1-216-825-11
1-216-832-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
4.7K
10K
2.2K
8.2K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R308
R309
R310
R311
R318
1-216-081-00
1-216-825-11
1-216-833-11
1-216-829-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
22K
2.2K
10K
4.7K
10K
5%
5%
5%
5%
5%
1/10W
1/16W
1/16W
1/16W
1/16W
R319
R320
R321
R324
R325
1-216-845-11
1-216-825-11
1-216-833-11
1-216-825-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
2.2K
10K
2.2K
2.2K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R326
R327
R328
R329
R330
1-216-833-11
1-216-833-11
1-216-834-11
1-216-834-11
1-216-081-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
12K
12K
22K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/10W
0 R331
0 R332
R333
R334
R335
1-219-787-17
1-219-787-17
1-216-836-11
1-216-836-11
1-216-830-11
FUSIBLE
FUSIBLE
METAL CHIP
METAL CHIP
METAL CHIP
5.6
5.6
18K
18K
5.6K
5%
5%
5%
5%
5%
1/4W
1/4W
1/16W
1/16W
1/16W
R336
R337
R338
R339
R340
1-216-825-11
1-216-827-11
1-216-081-00
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
3.3K
22K
10K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/10W
1/16W
1/16W
< RESISTOR >
R111
R112
R113
R114
R115
1-216-825-11
1-216-833-11
1-216-857-11
1-216-857-11
1-216-841-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
2.2K
10K
1M
1M
47K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R116
R117
R118
R119
R120
1-216-841-11
1-216-849-11
1-216-849-11
1-216-818-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
47K
220K
220K
560
100K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R121
R122
R123
R124
R125
1-216-855-11
1-216-825-11
1-216-845-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
680K
2.2K
100K
10K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R126
R127
R128
R129
R130
1-216-833-11
1-216-849-11
1-216-849-11
1-216-857-11
1-216-857-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
220K
220K
1M
1M
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R131
R132
R133
1-216-833-11 METAL CHIP
1-216-833-11 METAL CHIP
1-216-829-11 METAL CHIP
10K
10K
4.7K
5%
5%
5%
1/16W
1/16W
1/16W
64
The components identified by mark 0 or dotted line
with mark 0 are critical for safety.
Replace only with part number specified.
HCD-XGR6/XGR60
MAIN
Ref. No.
R341
R342
R343
R344
R345
Part No.
1-216-821-11
1-216-821-11
1-216-841-11
1-216-829-11
1-216-829-11
Description
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
47K
4.7K
4.7K
5%
5%
5%
5%
5%
Remarks
1/16W
1/16W
1/16W
1/16W
1/16W
R346
R347
R348
R349
R350
1-216-833-11
1-216-833-11
1-216-829-11
1-216-829-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
4.7K
4.7K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R351
R352
R353
R354
R355
1-216-829-11
1-216-829-11
1-216-833-11
1-216-825-11
1-216-832-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
4.7K
4.7K
10K
2.2K
8.2K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R358
R371
R372
R374
R375
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
10K
10K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R377
R378
R381
R382
R383
1-216-833-11
1-216-833-11
1-216-819-11
1-216-825-11
1-216-825-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
680
2.2K
2.2K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R384
R385
R386
R387
R388
1-216-819-11
1-216-825-11
1-216-825-11
1-216-841-11
1-216-827-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
680
2.2K
2.2K
47K
3.3K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R389
R390
R391
R392
R393
1-216-827-11
1-216-827-11
1-216-823-11
1-216-826-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
3.3K
3.3K
1.5K
2.7K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R394
R401
R402
R403
R404
1-216-849-11
1-216-809-11
1-216-827-11
1-216-809-11
1-216-827-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
220K
100
3.3K
100
3.3K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R405
R406
R407
R408
R410
1-216-833-11
1-216-833-11
1-216-295-00
1-216-295-00
1-216-829-11
METAL CHIP
METAL CHIP
SHORT
SHORT
METAL CHIP
10K
10K
0
0
4.7K
5%
5%
1/16W
1/16W
5%
1/16W
R412
R413
R414
R431
R451
1-216-835-11
1-216-833-11
1-216-833-11
1-216-845-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
15K
10K
10K
100K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R452
R453
R454
R501
R502
1-216-833-11
1-216-833-11
1-216-833-11
1-216-833-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
10K
10K
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R503
R504
R505
R509
R511
1-216-809-11
1-216-809-11
1-216-833-11
1-216-833-11
1-216-851-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
10K
10K
330K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R513
1-216-295-00 SHORT
Ref. No.
R516
R517
R519
R521
Part No.
1-216-833-11
1-216-833-11
1-216-809-11
1-216-809-11
Description
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
10K
10K
100
100
5%
5%
5%
5%
Remarks
1/16W
1/16W
1/16W
1/16W
R522
R523
R524
R525
R526
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R527
R528
R529
R530
R531
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R532
R533
R534
R535
R536
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R537
R540
R541
R542
R543
1-216-809-11
1-216-841-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
47K
100
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R547
R548
R549
R556
R557
1-216-809-11
1-216-809-11
1-216-833-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
10K
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R570
R571
R572
R573
R574
1-216-809-11
1-216-835-11
1-216-835-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
15K
15K
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R575
R580
R581
R582
R583
1-216-809-11
1-216-809-11
1-216-809-11
1-216-833-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
10K
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R584
R585
R586
R587
R588
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
1-216-809-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100
100
100
100
100
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R589
R590
R591
R592
R593
1-216-809-11
1-216-809-11
1-216-809-11
1-216-829-11
1-216-295-00
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
SHORT
100
100
100
4.7K
0
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
R594
1-216-821-11 METAL CHIP
1K
5%
R594
1-216-825-11 METAL CHIP
2.2K
5%
R595
R596
R597
1-216-809-11 METAL CHIP
1-216-829-11 METAL CHIP
1-218-892-11 METAL CHIP
100
4.7K
75K
5%
5%
0.5%
1/16W
(XGR60)
1/16W
(XGR6)
1/16W
1/16W
1/10W
R598
R599
R601
R602
R603
1-218-892-11
1-216-821-11
1-216-821-11
1-216-821-11
1-216-841-11
75K
1K
1K
1K
47K
0.5%
5%
5%
5%
5%
1/10W
1/16W
1/16W
1/16W
1/16W
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
0
65
HCD-XGR6/XGR60
MAIN
MIC/GUITAR
Ref. No.
R604
Part No.
Description
1-216-820-11 METAL CHIP
820
5%
R604
1-216-821-11 METAL CHIP
1K
5%
R605
R606
R607
1-216-854-11 METAL CHIP
1-216-841-11 METAL CHIP
1-216-821-11 METAL CHIP
560K
47K
1K
5%
5%
5%
Remarks
1/16W
(XGR6)
1/16W
(XGR60)
1/16W
1/16W
1/16W
R608
R609
R611
R612
R613
1-216-845-11
1-216-033-00
1-216-821-11
1-216-821-11
1-216-815-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
220
1K
1K
330
5%
5%
5%
5%
5%
1/16W
1/10W
1/16W
1/16W
1/16W
R614
R651
R652
R653
R654
1-216-821-11
1-216-821-11
1-216-821-11
1-216-841-11
1-216-820-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
1K
1K
47K
820
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
(XGR6)
R654
1-216-821-11 METAL CHIP
1K
5%
R655
R656
R657
R658
1-216-854-11
1-216-841-11
1-216-821-11
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
560K
47K
1K
100K
5%
5%
5%
5%
1/16W
(XGR60)
1/16W
1/16W
1/16W
1/16W
R701
R702
R703
R704
R705
1-216-821-11
1-216-845-11
1-216-821-11
1-216-845-11
1-216-833-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
1K
100K
1K
100K
10K
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
R706
R707
R708
1-216-825-11 METAL CHIP
1-216-841-11 METAL CHIP
1-216-821-11 METAL CHIP
2.2K
47K
1K
R709
1-216-821-11 METAL CHIP
1K
R710
1-216-845-11 METAL CHIP
100K
R722
R724
R751
R752
R753
1-216-804-11
1-216-833-11
1-216-821-11
1-216-845-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
39
10K
1K
100K
1K
R754
R755
R756
R757
R758
1-216-845-11
1-216-833-11
1-216-825-11
1-216-841-11
1-216-821-11
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
METAL CHIP
100K
10K
2.2K
47K
1K
5%
1/16W
5%
1/16W
5%
1/16W
5%
1/16W
5%
1/16W
(XGR6,XGR60:MX)
R759
1-216-821-11 METAL CHIP
1K
R760
1-216-845-11 METAL CHIP
100K
R801
R802
R803
1-216-817-11 METAL CHIP
1-216-829-11 METAL CHIP
1-216-829-11 METAL CHIP
470
4.7K
4.7K
5%
1/16W
(XGR6,XGR60:MX)
5%
1/16W
(XGR6,XGR60:MX)
5%
1/16W
5%
1/16W
5%
1/16W
R804
R805
R806
R807
R808
1-216-841-11
1-216-841-11
1-216-833-11
1-216-295-00
1-216-845-11
METAL CHIP
METAL CHIP
METAL CHIP
SHORT
METAL CHIP
47K
47K
10K
0
100K
5%
5%
5%
1/16W
1/16W
1/16W
5%
1/16W
R810
R812
R813
1-216-845-11 METAL CHIP
1-216-827-11 METAL CHIP
1-216-833-11 METAL CHIP
100K
3.3K
10K
5%
5%
5%
1/16W
1/16W
1/16W
Ref. No.
R922
R961
Part No.
Description
1-216-295-00 SHORT
1-216-829-11 METAL CHIP
0
4.7K
Remarks
5%
1/16W
R962
R963
1-216-837-11 METAL CHIP
1-216-825-11 METAL CHIP
22K
2.2K
5%
5%
1/16W
1/16W
< VARIABLE RESISTOR >
RV301
RV321
RV322
RV351
RV391
1-241-765-11
1-241-768-11
1-241-768-11
1-241-765-11
1-238-599-11
RES, ADJ, CARBON 22K (REC LEVEL (R))
RES, ADJ, CARBON 220K (REC BIAS (L))
RES, ADJ, CARBON 220K (REC BIAS (R))
RES, ADJ, CARBON 22K (REC LEVEL (L))
RES, ADJ, CARBON 4.7K (TAPE SPEED
(NORMAL))
RV392
1-238-598-11 RES, ADJ, CARBON 2.2K (TAPE SPEED (HIGH))
< TRANSFORMER >
T331
1-423-980-11 TRANSFORMER, BIAS OSCILLATION
< VIBRATOR >
X501
X502
1-567-098-41 VIBRATOR, CRYSTAL (32.768kHz)
1-781-107-21 VIBRATOR, CERAMIC (16MHz)
******************************************************
A-4727-633-A MIC/GUITAR BOARD, COMPLETE
5%
1/16W
5%
1/16W
5%
1/16W
(XGR6,XGR60:MX)
5%
1/16W
(XGR6,XGR60:MX)
5%
1/16W
(XGR6,XGR60:MX)
5%
5%
5%
5%
5%
1/16W
1/16W
1/16W
1/16W
1/16W
***********************
< CAPACITOR >
C801
C802
C803
C804
C805
1-162-306-11
1-162-215-31
1-126-960-11
1-126-959-11
1-162-294-31
CERAMIC
CERAMIC
ELECT
ELECT
CERAMIC
0.01uF
47PF
1uF
0.47uF
0.001uF
30%
5%
20%
20%
10%
16V
50V
50V
50V
50V
C806
C810
C813
C814
C815
1-162-215-31
1-162-286-21
1-137-372-11
1-162-215-31
1-162-215-31
CERAMIC
CERAMIC
MYLAR
CERAMIC
CERAMIC
47PF
220PF
0.022uF
47PF
47PF
5%
10%
5%
5%
5%
50V
50V
50V
50V
50V
C816
C817
C818
C819
C821
1-126-961-11
1-126-961-11
1-162-215-31
1-162-215-31
1-126-947-11
ELECT
ELECT
CERAMIC
CERAMIC
ELECT
2.2uF
2.2uF
47PF
47PF
47uF
20%
20%
5%
5%
20%
50V
50V
50V
50V
16V
C822
C824
C836
C837
C838
1-126-947-11
1-126-961-11
1-162-306-11
1-126-964-11
1-126-964-11
ELECT
ELECT
CERAMIC
ELECT
ELECT
47uF
2.2uF
0.01uF
10uF
10uF
20%
20%
30%
20%
20%
16V
50V
16V
50V
50V
C880
C881
C882
C884
1-126-961-11
1-162-215-31
1-162-215-31
1-126-961-11
ELECT
CERAMIC
CERAMIC
ELECT
2.2uF
47PF
47PF
2.2uF
20%
5%
5%
20%
50V
50V
50V
50V
< CONNECTOR >
* CN812
1-564-708-11 PIN, CONNECTOR (SMALL TYPE) 6P
< FILTER >
FL801
1-424-228-11 FILTER, NOISE
< IC >
66
IC850
IC852
8-759-505-55 IC NJM4558L
8-759-505-55 IC NJM4558L
HCD-XGR6/XGR60
MIC/GUITAR
Ref. No.
IC853
Part No.
Description
8-759-505-55 IC NJM4558L
Remarks
< JACK >
J801
J802
L201
Part No.
8-729-620-05
8-729-029-86
8-729-029-86
8-729-029-40
8-729-119-78
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
Description
< COIL >
1-408-117-00 INDUCTOR
PA
Remarks
10uH
< RESISTOR >
1-770-226-11 JACK (LARGE TYPE) (MIX MIC)
1-770-226-11 JACK (LARGE TYPE) (GUITAR)
R205
R206
< TRANSISTOR >
Q880
Q881
Q882
Q883
Q884
Ref. No.
MOTOR
1-249-427-11 CARBON
1-249-425-11 CARBON
6.8K
4.7K
5%
5%
1/4W F
1/4W F
< SWITCH >
2SC2603-EF
DTC124ESA
DTC124ESA
DTA124ESA
2SC2785-HFE
S201
1-762-587-11 SWITCH, PUSH (1 KEY) (UP)
******************************************************
A-4727-618-A PA BOARD, COMPLETE (XGR60)
A-4727-641-A PA BOARD, COMPLETE (XGR6)
< RESISTOR >
*****************
R807
R809
R850
R852
R853
1-249-429-11
1-249-417-11
1-249-417-11
1-249-441-11
1-249-417-11
CARBON
CARBON
CARBON
CARBON
CARBON
10K
1K
1K
100K
1K
5%
5%
5%
5%
5%
1/4W
1/4W F
1/4W F
1/4W
1/4W F
R854
R855
R856
R857
R867
1-249-437-11
1-249-429-11
1-247-899-11
1-249-425-11
1-249-421-11
CARBON
CARBON
CARBON
CARBON
CARBON
47K
10K
680K
4.7K
2.2K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W F
1/4W F
R869
R870
R872
R873
R874
1-249-439-11
1-247-887-00
1-249-421-11
1-249-421-11
1-249-431-11
CARBON
CARBON
CARBON
CARBON
CARBON
68K
220K
2.2K
2.2K
15K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W F
1/4W F
1/4W
R876
R877
R878
R879
R880
1-249-417-11
1-249-411-11
1-249-417-11
1-249-417-11
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
330
1K
1K
10K
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W F
1/4W F
1/4W
R881
R882
R883
R884
R885
1-249-437-11
1-249-437-11
1-249-437-11
1-249-413-11
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
47K
47K
47K
470
10K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W F
1/4W
R886
R887
R888
R891
1-247-893-11
1-249-429-11
1-249-417-11
1-247-903-00
CARBON
CARBON
CARBON
CARBON
390K
10K
1K
1M
5%
5%
5%
5%
1/4W
1/4W
1/4W F
1/4W
*******************************************************
*
A-4673-765-A MOTOR BOARD, COMPLETE
7-685-646-79 SCREW +BVTP 3X8 TYPE2 N-S
< CAPACITOR >
C401
C412
C413
C432
C433
1-126-963-11
1-162-306-11
1-162-306-11
1-126-933-11
1-126-962-11
C433
ELECT
CERAMIC
CERAMIC
ELECT
ELECT
4.7uF
0.01uF
0.01uF
100uF
3.3uF
20%
30%
30%
20%
20%
50V
16V
16V
16V
50V
(XGR60)
1-126-961-11 ELECT
2.2uF
20%
C801
C802
C803
C804
1-128-582-11
1-162-290-31
1-162-286-21
1-126-967-11
ELECT
CERAMIC
CERAMIC
ELECT
10uF
470PF
220PF
47uF
20%
10%
10%
20%
50V
(XGR6)
100V
50V
50V
50V
C807
C808
C809
C810
1-128-560-11
1-137-749-11
1-137-749-11
1-128-562-11
ELECT
MYLAR
MYLAR
ELECT
22uF
0.1uF
0.1uF
47uF
20%
C810
1-128-578-11 ELECT
1uF
20%
C811
C812
C813
C814
C815
1-130-491-00
1-130-491-00
1-162-306-11
1-162-294-31
1-126-959-11
MYLAR
MYLAR
CERAMIC
CERAMIC
ELECT
0.047uF
0.047uF
0.01uF
0.001uF
0.47uF
5%
5%
30%
10%
20%
50V
50V
16V
50V
50V
C830
C831
C832
C841
1-107-714-11
1-126-964-11
1-126-967-11
1-127-811-11
ELECT
ELECT
ELECT
ELECT
10uF
10uF
47uF
3300uF
20%
20%
20%
20%
C841
1-127-753-11 ELECT
3300uF
20%
50V
50V
50V
50V
(XGR60)
71V
(XGR6)
C842
1-127-814-11 ELECT
3300uF
20%
C844
1-137-749-11 MYLAR
0.1uF
C845
C847
C848
1-126-943-11 ELECT
1-164-159-21 CERAMIC
1-164-159-21 CERAMIC
2200uF
0.1uF
0.1uF
C849
C850
C851
C852
C853
1-164-159-21
1-107-721-11
1-128-582-11
1-162-290-31
1-162-286-21
0.1uF
4.7uF
10uF
470PF
220PF
20%
********************
*
4-980-385-01 HOLDER (SW)
< CAPACITOR >
C201
C202
C203
1-126-964-11 ELECT
1-164-159-21 CERAMIC
1-126-964-11 ELECT
10uF
0.1uF
10uF
< CONNECTOR >
* CN201
1-568-947-11 PIN, CONNECTOR 9P
< IC >
IC201
8-759-365-94 IC TA8409S
20%
20%
50V
50V
50V
CERAMIC
ELECT
ELECT
CERAMIC
CERAMIC
20%
20%
20%
10%
10%
100V
100V
100V
100V
(XGR60)
100V
(XGR6)
80V
(XGR60)
100V
(XGR60)
25V
50V
50V
50V
100V
100V
50V
50V
67
HCD-XGR6/XGR60
PA
Ref. No.
C854
C857
C858
C859
C861
Part No.
1-126-967-11
1-128-560-11
1-164-159-21
1-164-159-21
1-130-491-00
Description
ELECT
ELECT
CERAMIC
CERAMIC
MYLAR
47uF
22uF
0.1uF
0.1uF
0.047uF
20%
20%
C862
C863
C864
C891
1-130-491-00
1-126-961-11
1-126-964-11
1-127-811-11
MYLAR
ELECT
ELECT
ELECT
0.047uF
2.2uF
10uF
3300uF
5%
20%
20%
20%
C891
1-127-753-11 ELECT
3300uF
20%
C892
1-127-814-11 ELECT
3300uF
20%
C894
1-137-749-11 MYLAR
0.1uF
C895
C902
C903
1-107-721-11 ELECT
1-164-159-21 CERAMIC
1-126-933-11 ELECT
4.7uF
0.1uF
100uF
20%
C904
C905
C906
C909
C910
1-126-964-11
1-126-968-11
1-126-943-11
1-164-159-21
1-126-947-11
10uF
100uF
2200uF
0.1uF
47uF
20%
20%
20%
ELECT
ELECT
ELECT
CERAMIC
ELECT
5%
20%
20%
< CONNECTOR >
CN803
CN804
CN806
CN904
1-778-981-21
1-778-981-21
1-785-316-11
1-785-316-11
Remarks
50V
100V
50V
50V
50V
50V
50V
50V
50V
(XGR60)
71V
(XGR6)
80V
(XGR60)
100V
(XGR60)
100V
50V
16V
50V
50V
25V
50V
16V
(XGR6)
Ref. No.
IC801
IC901
Part No.
Description
8-749-017-16 IC STK442-130 (XGR6)
6-701-760-01 IC uPC3504AHF
Remarks
< TRANSISTOR >
Q401
Q401
Q402
Q431
Q432
8-729-029-40
8-729-140-82
8-729-140-84
8-729-140-84
8-729-119-76
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTA124ESA (XGR60)
2SA988-PAFAEA (XGR6)
2SC1841-PAFAEA
2SC1841-PAFAEA
2SA1175-HFE
Q433
Q434
Q437
Q439
Q801
8-729-620-05
8-729-620-05
8-729-620-05
8-729-620-05
8-729-140-84
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2603-EF
2SC2603-EF
2SC2603-EF
2SC2603-EF
2SC1841-PAFAEA
Q803
Q804
Q805
Q831
Q832
8-729-140-82
8-729-140-84
8-729-231-55
8-729-029-86
8-729-620-05
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SA988-PAFAEA
2SC1841-PAFAEA
2SC2878-AB
DTC124ESA
2SC2603-EF
Q833
Q834
Q851
Q855
Q901
8-729-029-40
8-729-140-84
8-729-140-84
8-729-231-55
8-729-620-05
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTA124ESA
2SC1841-PAFAEA
2SC1841-PAFAEA
2SC2878-AB
2SC2603-EF
Q903
Q908
8-729-048-52 TRANSISTOR 2SA1932(TP)
8-729-119-76 TRANSISTOR 2SA1175-HFE
CONNECTOR, BOARD TO BOARD 13P
CONNECTOR, BOARD TO BOARD 13P
PIN, CONNECTOR (STRAIGHT) 4P
PIN, CONNECTOR (STRAIGHT) 4P
0 R401
1-216-431-11 METAL OXIDE
560
5%
< DIODE >
0 R401
1-216-458-11 METAL OXIDE
1.8K
5%
R406
R407
R429
1-249-437-11 CARBON
1-249-437-11 CARBON
1-249-437-11 CARBON
47K
47K
47K
5%
5%
5%
1W
(XGR60)
2W
(XGR6)
1/4W
1/4W
1/4W
R431
R432
R434
R437
R439
1-249-438-11
1-249-437-11
1-249-433-11
1-249-429-11
1-249-425-11
CARBON
CARBON
CARBON
CARBON
CARBON
56K
47K
22K
10K
4.7K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W F
R440
1-249-433-11 CARBON
22K
5%
1/4W
(XGR60
1/4W
(XGR6)
1/4W
1/4W
1/4W
< RESISTOR >
D401
D402
D405
D406
D801
8-719-991-33
8-719-991-33
8-719-991-33
8-719-991-33
8-719-991-33
DIODE
DIODE
DIODE
DIODE
DIODE
1SS133T-77
1SS133T-77
1SS133T-77
1SS133T-77
1SS133T-77
D802
D803
D804
D805
D831
8-719-110-39
8-719-991-33
8-719-991-33
8-719-991-33
8-719-510-68
DIODE
DIODE
DIODE
DIODE
DIODE
RD15ESB1 (XGR60)
1SS133T-77
1SS133T-77
1SS133T-77
D5SBA204101 (XGR60)
D833
D834
D835
D836
D841
8-719-200-82
8-719-200-82
8-719-200-82
8-719-200-82
8-719-200-82
DIODE
DIODE
DIODE
DIODE
DIODE
11ES2
11ES2
11ES2
11ES2
11ES2
R440
1-249-437-11 CARBON
47K
5%
R441
R446
R447
1-249-435-11 CARBON
1-249-429-11 CARBON
1-249-437-11 CARBON
33K
10K
47K
5%
5%
5%
D842
D843
D844
D851
D852
8-719-200-82
8-719-200-82
8-719-200-82
8-719-991-33
8-719-110-39
DIODE
DIODE
DIODE
DIODE
DIODE
11ES2
11ES2
11ES2
1SS133T-77
MTZJ-T-77-15A (XGR60)
R460
1-249-429-11 CARBON
10K
5%
R801
R802
R803
R804
1-249-417-11
1-249-437-11
1-249-414-11
1-249-435-11
1K
47K
560
33K
5%
5%
5%
5%
D853
D902
D903
D904
D905
8-719-991-33
8-719-200-82
8-719-200-82
8-719-200-82
8-719-200-82
DIODE
DIODE
DIODE
DIODE
DIODE
1SS133T-77
11ES2
11ES2
11ES2
11ES2
R805
1-216-436-00 METAL OXIDE
3.9K
5%
R806
1-216-436-00 METAL OXIDE
3.9K
5%
D911
D912
8-719-982-24 DIODE MTZJ-33A
8-719-109-89 DIODE RD5.6ESB2
1-212-881-11 FUSIBLE
1-220-893-11 METAL
1-260-076-11 CARBON
100
0.22
10
5%
10%
5%
< IC >
IC801
68
8-749-017-05 IC STK412-040 (XGR60)
0 R807
0 R808
R809
CARBON
CARBON
CARBON
CARBON
1/4W
(XGR6)
1/4W F
1/4W
1/4W F
1/4W
1W
(XGR60)
1W
(XGR60)
1/4W
5W
1/2W
The components identified by mark 0 or dotted line
with mark 0 are critical for safety.
Replace only with part number specified.
HCD-XGR6/XGR60
PA
Ref. No.
R810
Part No.
Description
1-249-435-11 CARBON
33K
5%
R810
1-249-437-11 CARBON
47K
5%
R811
R812
R813
1-249-417-11 CARBON
1-249-431-11 CARBON
1-249-441-11 CARBON
1K
15K
100K
5%
5%
5%
R814
R815
R816
1-249-421-11 CARBON
1-249-433-11 CARBON
1-249-429-11 CARBON
2.2K
22K
10K
5%
5%
5%
R817
R818
1-249-437-11 CARBON
1-249-409-11 CARBON
47K
220
5%
5%
1/4W F
1/4W
1/4W
(XGR6)
1/4W
1/4W F
1-249-439-11
1-202-972-61
1-249-435-11
1-249-433-11
1-249-433-11
68K
1
33K
22K
22K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R819
0 R820
R821
R822
R823
CARBON
FUSIBLE
CARBON
CARBON
CARBON
Remarks
1/4W
(XGR60)
1/4W
(XGR6)
1/4W F
1/4W
1/4W
PANEL FL
Ref. No.
R904
Part No.
Description
1-249-417-11 CARBON
1K
5%
R905
R906
R907
R915
0 R916
1-249-429-11
1-247-807-31
1-247-807-31
1-247-791-91
1-215-916-00
10K
100
100
22
680
5%
5%
5%
5%
5%
CARBON
CARBON
CARBON
CARBON
METAL OXIDE
Remarks
1/4W F
1/4W
1/4W
1/4W
1/4W
3W
(XGR60)
< RELAY >
RY401
1-515-920-11 RELAY
< THERMISTOR >
TH831
1-807-796-11 THERMISTOR
< TERMINAL >
TM401
1-537-925-62 TERMINAL BOARD (FRONT SPEAKER)
******************************************************
R824
0 R825
R827
R828
R831
1-249-413-11
1-215-891-11
1-249-441-11
1-247-903-00
1-249-441-11
CARBON
METAL OXIDE
CARBON
CARBON
CARBON
470
680
100K
1M
100K
5%
5%
5%
5%
5%
1/4W F
2W
1/4W
1/4W
1/4W
A-4727-623-A PANEL FL BOARD, COMPLETE
************************
4-225-511-01 HOLDER FL TUBE
4-949-935-81 CUSHION (FL)
*
R832
R833
1-249-441-11 CARBON
1-249-432-11 CARBON
100K
18K
5%
5%
R833
1-249-433-11 CARBON
22K
5%
R834
R835
1-249-429-11 CARBON
1-249-437-11 CARBON
10K
47K
5%
5%
R836
R837
R838
R839
1-249-417-11
1-249-435-11
1-249-435-11
1-249-441-11
1K
33K
33K
100K
5%
5%
5%
5%
R840
1-249-402-11 CARBON
56
R851
R852
R853
0 R855
0 R857
1-249-417-11
1-249-437-11
1-249-414-11
1-215-891-11
1-212-881-11
0 R858
R859
R860
1/4W
1/4W
(XGR60)
1/4W
(XGR6)
1/4W
1/4W
< CAPACITOR >
C601
C602
C603
C604
C605
1-162-294-31
1-126-947-11
1-162-306-11
1-126-947-11
1-162-306-11
CERAMIC
ELECT
CERAMIC
ELECT
CERAMIC
0.001uF
47uF
0.01uF
47uF
0.01uF
10%
20%
30%
20%
30%
50V
16V
16V
16V
16V
C606
C607
C612
C613
C614
1-126-963-11
1-164-159-21
1-162-294-31
1-126-964-11
1-126-947-11
ELECT
CERAMIC
CERAMIC
ELECT
ELECT
4.7uF
0.1uF
0.001uF
10uF
47uF
20%
5%
1/4W F
1/4W
1/4W
1/4W
(XGR60)
1/4W F
10%
20%
20%
50V
50V
50V
50V
16V
1K
47K
560
680
100
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W F
2W
1/4W
C615
C616
C617
C618
C619
1-126-964-11
1-162-303-11
1-126-157-11
1-126-157-11
1-162-306-11
ELECT
CERAMIC
ELECT
ELECT
CERAMIC
10uF
0.0033uF
10uF
10uF
0.01uF
20%
30%
20%
20%
30%
50V
16V
16V
16V
16V
1-220-893-11 METAL
1-260-076-11 CARBON
1-249-435-11 CARBON
0.22
10
33K
10%
5%
5%
C625
C627
C628
1-126-964-11 ELECT
1-126-960-11 ELECT
1-126-960-11 ELECT
10uF
1uF
1uF
20%
20%
20%
50V
50V
50V
R860
1-249-437-11 CARBON
47K
5%
R861
1-249-417-11 CARBON
1K
5%
5W
1/2W
1/4W
(XGR60)
1/4W
(XGR6)
1/4W F
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
CARBON
METAL OXIDE
FUSIBLE
< CONNECTOR >
* CN601
CN602
R862
R863
R864
R865
R866
1-249-431-11
1-249-441-11
1-249-425-11
1-249-433-11
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
15K
100K
4.7K
22K
10K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W F
1/4W
1/4W
R867
1-249-421-11 CARBON
2.2K
5%
R868
R880
0 R888
R889
1-249-409-11
1-249-402-11
1-220-893-11
1-249-441-11
CARBON
CARBON
METAL
CARBON
220
56
0.22
100K
5%
5%
10%
5%
1/4W F
(XGR6)
1/4W F
1/4W F
5W
1/4W
(XGR60)
0 R898
R901
R902
R903
1-220-893-11
1-249-429-11
1-249-441-11
1-249-429-11
METAL
CARBON
CARBON
CARBON
0.22
10K
100K
10K
10%
5%
5%
5%
5W
1/4W
1/4W
1/4W
1-568-865-11 SOCKET, CONNECTOR 23P
1-784-780-11 CONNECTOR, FFC 19P
< DIODE >
D601
D602
D603
D604
D605
8-719-991-33
8-719-058-04
8-719-058-03
8-719-058-03
8-719-058-03
DIODE
DIODE
DIODE
DIODE
DIODE
1SS133T-77
SEL5223S-TP15 (]/1)
SEL5423E-TP15 (SALSA)
SEL5423E-TP15 (REGGAE)
SEL5423E-TP15 (TANGO)
D606
D607
D608
D609
D610
8-719-058-03
8-719-058-03
8-719-058-03
8-719-058-03
8-719-058-03
DIODE
DIODE
DIODE
DIODE
DIODE
SEL5423E-TP15 (SAMBA)
SEL5423E-TP15 (MOVIE)
SEL5423E-TP15 (GAME MIXING)
SEL5423E-TP15 (GUITAR)
SEL5423E-TP15 (ROCK)
The components identified by mark 0 or dotted line
with mark 0 are critical for safety.
Replace only with part number specified.
69
HCD-XGR6/XGR60
PANEL FL
Ref. No.
D611
D612
D613
Part No.
8-719-058-03
8-719-058-03
8-719-058-03
Description
DIODE SEL5423E-TP15 (JAZZ)
DIODE SEL5423E-TP15 (DANCE)
DIODE SEL5423E-TP15 (GAME)
Remarks
Ref. No.
R632
R633
R634
R635
Part No.
1-249-419-11
1-249-419-11
1-249-421-11
1-249-413-11
Description
CARBON
CARBON
CARBON
CARBON
1.5K
1.5K
2.2K
470
5%
5%
5%
5%
Remarks
1/4W F
1/4W F
1/4W F
1/4W F
R636
R637
R638
R639
R640
1-249-415-11
1-249-413-11
1-249-415-11
1-249-417-11
1-249-419-11
CARBON
CARBON
CARBON
CARBON
CARBON
680
470
680
1K
1.5K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R641
R642
R643
R644
R645
1-249-419-11
1-249-421-11
1-249-401-11
1-247-891-00
1-247-891-00
CARBON
CARBON
CARBON
CARBON
CARBON
1.5K
2.2K
47
330K
330K
5%
5%
5%
5%
5%
1/4W F
1/4W F
1/4W F
1/4W
1/4W
R646
R647
R648
R649
R650
1-249-441-11
1-249-440-11
1-249-437-11
1-249-441-11
1-249-440-11
CARBON
CARBON
CARBON
CARBON
CARBON
100K
82K
47K
100K
82K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R651
R652
R653
R654
R665
1-249-429-11
1-247-843-11
1-249-441-11
1-249-427-11
1-249-441-11
CARBON
CARBON
CARBON
CARBON
CARBON
10K
3.3K
100K
6.8K
100K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W F
1/4W
R666
R667
R668
R669
R670
1-249-441-11
1-249-441-11
1-249-441-11
1-247-791-91
1-247-791-91
CARBON
CARBON
CARBON
CARBON
CARBON
100K
100K
100K
22
22
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R671
R672
R673
R674
R675
1-247-791-91
1-247-791-91
1-247-791-91
1-247-791-91
1-247-791-91
CARBON
CARBON
CARBON
CARBON
CARBON
22
22
22
22
22
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R676
R677
R678
R679
R680
1-247-791-91
1-247-791-91
1-247-791-91
1-247-791-91
1-249-411-11
CARBON
CARBON
CARBON
CARBON
CARBON
22
22
22
22
330
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R681
R683
R684
R685
R686
1-249-437-11
1-249-437-11
1-249-417-11
1-249-417-11
1-249-437-11
CARBON
CARBON
CARBON
CARBON
CARBON
47K
47K
1K
1K
47K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W F
1/4W F
1/4W
R688
R689
R690
R691
R692
1-249-437-11
1-249-417-11
1-249-417-11
1-249-413-11
1-249-413-11
CARBON
CARBON
CARBON
CARBON
CARBON
47K
1K
1K
470
470
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R693
R694
R695
R696
R697
1-249-429-11
1-249-429-11
1-247-807-31
1-247-807-31
1-247-807-31
CARBON
CARBON
CARBON
CARBON
CARBON
10K
10K
100
100
100
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R698
R699
R700
1-249-415-11 CARBON
1-249-413-11 CARBON
1-249-413-11 CARBON
680
470
470
5%
5%
5%
1/4W F
1/4W F
1/4W F
< FERRITE BEAD >
FB601
1-412-473-21 INDUCTOR
0UH
< FLUORESCENT INDICATOR TUBE >
FL601
1-518-794-11 INDICATOR TUBE, FLUORESCENT
< IC >
IC601
IC602
IC603
6-801-052-01 IC MB90M407APF-G-112-BND
8-759-083-77 IC BA3830F
8-759-826-34 IC NJL74H400A
< COIL >
L603
F
F
F
F
F
1-410-517-11 INDUCTOR
47uH
< TRANSISTOR >
Q601
Q602
Q603
Q604
Q605
8-729-029-86
8-729-620-05
8-729-140-04
8-729-620-05
8-729-140-04
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
DTC124ESA
2SC2603-EF
2SB1116A-L
2SC2603-EF
2SB1116A-L
Q606
Q607
Q608
Q609
8-729-047-58
8-729-047-58
8-729-047-58
8-729-047-58
TRANSISTOR DTC114TLTL2
TRANSISTOR DTC114TLTL2
TRANSISTOR DTC114TLTL2
TRANSISTOR DTC114TLTL2
< RESISTOR >
R600
R601
R602
R603
R604
1-249-417-11
1-249-441-11
1-249-429-11
1-249-429-11
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
100K
10K
10K
10K
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W
1/4W
1/4W
R605
R606
R607
R608
R609
1-247-807-31
1-249-429-11
1-249-429-11
1-247-807-31
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
100
10K
10K
100
10K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R610
R612
R613
R614
R615
1-247-807-31
1-249-431-11
1-249-431-11
1-249-431-11
1-249-431-11
CARBON
CARBON
CARBON
CARBON
CARBON
100
15K
15K
15K
15K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R616
R617
R618
R619
R620
1-249-431-11
1-249-431-11
1-247-807-31
1-249-433-11
1-247-903-00
CARBON
CARBON
CARBON
CARBON
CARBON
15K
15K
100
22K
1M
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R621
R622
R623
R624
R625
1-249-413-11
1-249-415-11
1-249-421-11
1-249-419-11
1-249-419-11
CARBON
CARBON
CARBON
CARBON
CARBON
470
680
2.2K
1.5K
1.5K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
F
F
F
F
F
R626
R627
R628
R629
R630
1-249-417-11
1-249-415-11
1-249-413-11
1-249-413-11
1-249-415-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
680
470
470
680
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
F
F
F
F
F
R631
1-249-417-11 CARBON
1K
5%
1/4W F
70
< SWITCH >
S601
S602
S603
1-762-875-21 SWITCH, KEYBOARD (SALSA)
1-762-875-21 SWITCH, KEYBOARD (REGGAE)
1-762-875-21 SWITCH, KEYBOARD (TANGO)
F
F
F
F
HCD-XGR6/XGR60
PANEL FL
Ref. No.
S604
S605
Part No.
Description
1-762-875-21 SWITCH, KEYBOARD (SAMBA)
1-762-875-21 SWITCH, KEYBOARD (MOVIE)
Remarks
Ref. No.
L701
S606
S607
S608
S609
S610
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
SWITCH, KEYBOARD (GUITAR)
SWITCH, KEYBOARD (ROCK)
SWITCH, KEYBOARD (JAZZ)
SWITCH, KEYBOARD (DANCE)
SWITCH, KEYBOARD (GAME)
S611
S612
S613
S614
S615
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
SWITCH, KEYBOARD (SPECTRUM ANALYZER)
SWITCH, KEYBOARD (DISPLAY)
SWITCH, KEYBOARD (SLEEP)
SWITCH, KEYBOARD (TIMER SELECT)
SWITCH, KEYBOARD ( c/CLOCK SET)
S616
S617
S618
S619
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
S620
1-410-509-11 INDUCTOR
Remarks
10uH
R701
R702
R703
R704
R705
1-249-429-11
1-247-807-31
1-247-807-31
1-247-807-31
1-249-417-11
CARBON
CARBON
CARBON
CARBON
CARBON
10K
100
100
100
1K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W F
R706
R707
R708
R709
R710
1-249-417-11
1-249-417-11
1-249-419-11
1-249-419-11
1-249-421-11
CARBON
CARBON
CARBON
CARBON
CARBON
1K
1K
1.5K
1.5K
2.2K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R711
R712
R713
R714
R715
1-247-843-11
1-249-425-11
1-249-427-11
1-249-429-11
1-249-431-11
CARBON
CARBON
CARBON
CARBON
CARBON
3.3K
4.7K
6.8K
10K
15K
5%
5%
5%
5%
5%
1/4W
1/4W F
1/4W F
1/4W
1/4W
R716
R718
R719
R720
R721
1-249-433-11
1-249-415-11
1-249-417-11
1-249-419-11
1-249-419-11
CARBON
CARBON
CARBON
CARBON
CARBON
22K
680
1K
1.5K
1.5K
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R722
R723
R724
R725
R726
1-249-421-11
1-247-843-11
1-249-425-11
1-249-427-11
1-249-429-11
CARBON
CARBON
CARBON
CARBON
CARBON
2.2K
3.3K
4.7K
6.8K
10K
5%
5%
5%
5%
5%
1/4W F
1/4W
1/4W F
1/4W F
1/4W
R731
R732
R733
R734
R735
1-247-791-91
1-247-791-91
1-247-791-91
1-247-791-91
1-247-791-91
CARBON
CARBON
CARBON
CARBON
CARBON
22
22
22
22
22
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
< DIODE >
R736
R737
R738
R739
R740
1-247-791-91
1-247-791-91
1-247-791-91
1-247-791-91
1-249-401-11
CARBON
CARBON
CARBON
CARBON
CARBON
22
22
22
22
47
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W F
SWITCH, KEYBOARD (FUNCTION)
SWITCH, KEYBOARD (GAME)
SWITCH, KEYBOARD (GAME MIXING)
SWITCH, KEYBOARD
(POWER SAVE/DEMO(STANDBY))
1-762-875-21 SWITCH, KEYBOARD ( ]/1)
1-577-358-21 VIBRATOR, CERAMIC (4MHz)
******************************************************
A-4727-624-A PANEL VR BOARD, COMPLETE
**********************
< CAPACITOR >
C701
C702
C703
C704
C705
1-162-294-31
1-162-294-31
1-162-294-31
1-126-947-11
1-162-306-11
C706
C707
C708
1-164-159-21 CERAMIC
1-162-306-11 CERAMIC
1-162-306-11 CERAMIC
CERAMIC
CERAMIC
CERAMIC
ELECT
CERAMIC
0.001uF
0.001uF
0.001uF
47uF
0.01uF
10%
10%
10%
20%
30%
50V
50V
50V
16V
16V
0.1uF
0.01uF
0.01uF
30%
30%
50V
16V
16V
< CONNECTOR >
* CN701
Description
< COIL >
< RESISTOR >
< VIBRATOR >
X601
Part No.
PANEL VR
1-568-865-11 SOCKET, CONNECTOR 23P
F
F
F
F
F
F
F
F
F
D701
D702
D703
D704
D705
8-719-058-64
8-719-058-64
8-719-058-64
8-719-058-64
8-719-058-64
DIODE
DIODE
DIODE
DIODE
DIODE
SEL5823A-TP15 (VU1)
SEL5823A-TP15 (VU2)
SEL5823A-TP15 (VU3)
SEL5823A-TP15 (VU4)
SEL5823A-TP15 (VU5)
R741
R742
R743
R744
R745
1-249-401-11
1-249-401-11
1-247-807-31
1-247-807-31
1-247-807-31
CARBON
CARBON
CARBON
CARBON
CARBON
47
47
100
100
100
5%
5%
5%
5%
5%
1/4W F
1/4W F
1/4W
1/4W
1/4W
D706
D707
D708
D709
D710
8-719-058-64
8-719-058-64
8-719-058-64
8-719-058-64
8-719-058-04
DIODE
DIODE
DIODE
DIODE
DIODE
SEL5823A-TP15 (VU6)
SEL5823A-TP15 (VU7)
SEL5823A-TP15 (VU8)
SEL5823A-TP15 (VU9)
SEL5223S-TP15 (VU10)
R746
R747
R749
R750
1-247-807-31
1-247-807-31
1-247-791-91
1-247-807-31
CARBON
CARBON
CARBON
CARBON
100
100
22
100
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
D711
D712
D713
D714
D715
8-719-058-04
8-719-058-04
8-719-058-04
8-719-058-04
8-719-058-04
DIODE
DIODE
DIODE
DIODE
DIODE
SEL5223S-TP15 (VU11)
SEL5223S-TP15 (VU12)
SEL5223S-TP15 (GROOVE)
SEL5223S-TP15 (SUPER WOOFER)
SEL5223S-TP15 (SURROUND)
D716
D717
D719
D720
8-719-058-04
8-719-058-04
8-719-058-03
8-719-058-04
DIODE
DIODE
DIODE
DIODE
SEL5223S-TP15 (ENTER)
SEL5223S-TP15 (GUITAR DISTORSION)
SEL5423E-TP15 (TUNER/BAND)
SEL5223S-TP15 (TUNER ENTER)
< SWITCH >
< IC >
IC701
8-759-373-50 IC NJU3719L
S700
S701
S702
S703
S704
1-473-392-11
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
ENCODER, ROTARY (VOLUME)
SWITCH, KEYBOARD (GROOVE)
SWITCH, KEYBOARD (SURROUND)
SWITCH, KEYBOARD (EFFECT ON/OFF)
SWITCH, KEYBOARD (P FILE)
S705
S706
S707
S708
S709
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
SWITCH, KEYBOARD (ENTER)
SWITCH, KEYBOARD (R)
SWITCH, KEYBOARD (r)
SWITCH, KEYBOARD (t)
SWITCH, KEYBOARD (T)
S710
1-762-875-21 SWITCH, KEYBOARD (MIX GUITAR/KARAOKE)
71
HCD-XGR6/XGR60
PANEL VR
SENSOR
SUB TRANS TC-A
Ref. No.
S711
S713
S714
S715
Part No.
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
Description
Remarks
SWITCH, KEYBOARD (GUITAR DISTORTION)
SWITCH, KEYBOARD (SUPER WOOFER)
SWITCH, KEYBOARD (SUPER WOOFER MODE)
SWITCH, KEYBOARD (X-GROOVE)
S716
S717
S718
S719
S720
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
SWITCH, KEYBOARD (TUNER/BAND)
SWITCH, KEYBOARD (TUNING -)
SWITCH, KEYBOARD (TUNUNG +)
SWITCH, KEYBOARD (FM MODE)
SWITCH, KEYBOARD (TUNER ENTER)
S721
S722
1-762-875-21 SWITCH, KEYBOARD (TUNER MEMORY)
1-762-875-21 SWITCH, KEYBOARD (TUNING MODE)
R819
R820
TRANS
Part No.
Description
1-249-429-11 CARBON
1-249-431-11 CARBON
10K
15K
5%
5%
Remarks
1/4W
1/4W
1-247-791-91 CARBON
1-247-791-91 CARBON
22
22
5%
5%
1/4W
1/4W
< VARIABLE RESISTOR >
RV801
RV802
******************************************************
*
Ref. No.
R816
R817
TC-B
1-659-058-13 SENSOR BOARD
************
1-225-739-11 RES, VAR CARBON 50K (GUITAR LEVEL)
1-225-739-11 RES, VAR CARBON 50K (MIC LEVEL)
< SWITCH >
S810
S811
S812
S813
S814
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
SWITCH, KEYBOARD (G)
SWITCH, KEYBOARD (g)
SWITCH, KEYBOARD (x)
SWITCH, KEYBOARD (.m)
SWITCH, KEYBOARD (M>)
S815
1-762-875-21 SWITCH, KEYBOARD (DIRECTION)
< IC >
IC202
******************************************************
8-749-924-18 PHOTO INTERRUPTER RPI-1391
< RESISTOR >
1-683-449-11 TC-B BOARD
**********
R207
1-249-416-11 CARBON
820
5%
1/4W F
******************************************************
1-683-445-11 SUB TRANS BOARD
D801
D802
D803
D804
**************
< CAPACITOR >
0 C901
1-113-925-11 CERAMIC
0.01uF
20%
1-564-321-00 PIN, CONNECTOR 2P
1-568-106-11 PIN, CONNECTOR 4P (XGR60:AR,E,E51)
1-564-321-21 PIN, CONNECTOR 2P (XGR6,XGR60:MX)
< DIODE >
D901
D901
8-719-058-03
8-719-058-03
8-719-057-97
8-719-058-04
250V
< CONNECTOR >
CN901
CN902
* CN902
< DIODE >
8-719-983-61 DIODE MTZJ-T-72-3.3 (XGR60)
8-719-991-33 DIODE 1SS133T-77 (XGR6)
DIODE
DIODE
DIODE
DIODE
SEL5423E-TP15 (G)
SEL5423E-TP15 (g)
SEL5923A-TP15 (X)
SEL5223S-TP15 (zREC)
< RESISTOR >
R801
R802
R803
R804
R805
1-247-843-11
1-249-425-11
1-249-427-11
1-249-429-11
1-249-431-11
CARBON
CARBON
CARBON
CARBON
CARBON
3.3K
4.7K
6.8K
10K
15K
5%
5%
5%
5%
5%
1/4W
1/4W F
1/4W F
1/4W
1/4W
R806
R807
R808
R809
R810
1-249-433-11
1-249-435-11
1-249-439-11
1-247-791-91
1-247-791-91
CARBON
CARBON
CARBON
CARBON
CARBON
22K
33K
68K
22
22
5%
5%
5%
5%
5%
1/4W
1/4W
1/4W
1/4W
1/4W
R811
R812
1-247-791-91 CARBON
1-249-401-11 CARBON
22
47
5%
5%
1/4W
1/4W F
< RELAY >
0 RY901
1-755-276-11 RELAY, POWER
< SWITCH >
0 S901
< SWITCH >
1-786-055-21 SELECTOR, VOLTAGE (VOLTAGE SELECT)
(XGR60:AR,E,E51)
< TRANSFORMER >
0 T901
0 T901
1-437-331-11 TRANSFORMER, POWER (XGR60)
1-435-826-11 TRANSFORMER, POWER (XGR6)
******************************************************
1-683-448-11 TC-A BOARD
*********
S801
S802
S803
S804
S805
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
SWITCH, KEYBOARD (G)
SWITCH, KEYBOARD (g)
SWITCH, KEYBOARD (x)
SWITCH, KEYBOARD (.m)
SWITCH, KEYBOARD (M>)
S806
S807
S808
S809
1-762-875-21
1-762-875-21
1-762-875-21
1-762-875-21
SWITCH, KEYBOARD (zREC)
SWITCH, KEYBOARD (X)
SWITCH, KEYBOARD (H SPEED DUB)
SWITCH, KEYBOARD (CD SYNC)
******************************************************
< DIODE >
1-683-444-11 TRANS BOARD
***********
D805
D806
R813
R814
R815
72
8-719-058-03 DIODE SEL5423E-TP15 (G )
8-719-058-03 DIODE SEL5423E-TP15 (g )
7-685-646-79 SCREW +BVTP 3X8 TYPE2 N-S
< RESISTOR >
< CAPACITOR >
1-247-843-11 CARBON
1-249-425-11 CARBON
1-249-427-11 CARBON
3.3K
4.7K
6.8K
5%
5%
5%
1/4W
1/4W F
1/4W F
C834
1-137-749-11 MYLAR
0.1uF
100V
The components identified by mark 0 or dotted line
with mark 0 are critical for safety.
Replace only with part number specified.
HCD-XGR6/XGR60
TRANS
Ref. No.
C893
C961
C963
Part No.
1-137-749-11
1-162-306-11
1-162-306-11
Description
MYLAR
CERAMIC
CERAMIC
0.1uF
0.01uF
0.01uF
30%
30%
Remarks
100V
16V
16V
Ref. No.
* CN951
* CN952
1-564-214-11 PIN, CONNECTOR (B3PS-VH) 3P (XGR60)
1-564-526-11 PLUG, CONNECTOR 11P
< DIODE >
D832
8-719-510-68 DIODE D5SBA204101
< FUSE HOLDER >
Description
MISCELLANEOUS
4
4
4
5
1-569-008-21
1-693-572-11
1-693-573-11
1-693-574-11
1-769-945-11
ADAPTOR, CONVERSION (XGR60:E51)
TUNER (FM/AM) (XGR60:AR,MX)
TUNER (FM/AM) (XGR6)
TUNER (FM/AM) (XGR60:E,E51)
WIRE (FLAT TYPE) (11 CORE)
7
60
61
113
115
1-535-706-21
1-796-333-11
1-773-021-11
1-773-118-11
1-773-178-11
PLUG, JUMPER (XGR6,XGR60:MX)
DECK, MECHANICAL
WIRE (FLAT TYPE) (15 CORE)
WIRE (FLAT TYPE) (19 CORE)
WIRE (FLAT TYPE) (23 CORE)
WIRE (FLAT TYPE) (21 CORE)
CORD, POWER (XGR60:MX)
CORD, POWER (XGR60:E51)
CORD, POWER (XGR6)
CORD, POWER (XGR60:AR)
FH951
FH952
FH961
FH962
FH963
1-533-217-31
1-533-217-31
1-533-217-31
1-533-217-31
1-533-217-31
HOLDER, FUSE (XGR60:AR,E,E51)
HOLDER, FUSE (XGR60:AR,E,E51)
HOLDER, FUSE (XGR60)
HOLDER, FUSE (XGR60)
HOLDER, FUSE
151
0 156
0 156
0 156
0 156
1-823-750-11
1-575-653-11
1-777-071-81
1-783-820-11
1-783-941-12
FH964
FH965
FH966
FH967
FH968
1-533-217-31
1-533-217-31
1-533-217-31
1-533-217-31
1-533-217-31
HOLDER, FUSE
HOLDER, FUSE
HOLDER, FUSE
HOLDER, FUSE (XGR60)
HOLDER, FUSE (XGR60)
0 156
556
0 F951
0 F961
1-791-901-11
A-4735-188-A
1-532-506-31
1-533-949-31
0 F962
< RESISTOR >
0 R951
0 R952
0 R953
0 R961
1-219-122-91
1-219-122-91
1-219-591-11
1-219-777-91
FUSIBLE
FUSIBLE
FUSIBLE
CARBON
0.33
0.33
0.1
3.3M
5%
5%
5%
10%
1/4W
1/4W
1/2W
1/2W
(XGR6)
Remarks
*************
0
< CONNECTOR >
Part No.
0 F963
0 F963
0 F964
0 F964
*******************************************************
M201
M901
0 T951
0 T951
CORD, POWER (XGR60:E)
BU-30 (60) ASSY
FUSE (6.3A 250V) (XGR60:AR,E.E51)
FUSE, CYLINDRICAL (TIME LUG) (8.0A 250V)
(XGR60)
1-533-949-31 FUSE, CYLINDRICAL (TIME LUG) (8.0A 250V)
(XGR60)
1-532-506-31 FUSE (6.3A 250V) (XGR60)
1-533-310-11 FUSE, GLASS CYLINDRICAL(DIA.5)
(6.3A 125V)(XGR6)
1-532-506-31 FUSE (6.3A 250V) (XGR60)
1-533-310-11 FUSE, GLASS CYLINDRICAL(DIA.5)
(6.3A 125V)(XGR6)
A-4660-977-A MOTOR ASSY
1-763-072-11 FAN, DC
1-433-606-11 TRANSFORMER, POWER (XGR60)
1-435-797-11 TRANSFORMER, POWER (XGR6)
The components identified by mark 0 or dotted line
with mark 0 are critical for safety.
Replace only with part number specified.
73
HCD-XGR6/XGR60
REVISION HISTORY
Clicking the version allows you to jump to the revised page.
Also, clicking the version at the upper right on the revised page allows you to jump to the next revised
page.
Ver.
1.0
Date
2002. 02
Description of Revision
New
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertising