TA-E1
SERVICE MANUAL
US Model
Canadian Model
AEP Model
UK Model
E Model
Australian Model
SPECIFICATIONS
STEREO PRE AMPLIFIER
MICROFILM
1
SAFETY CHECK-OUT
TABLE OF CONTENTS
After correcting the original service problem, perform the following safety checks before releasing the set to the customer:
Check the antenna terminals, metal trim, “metallized” knobs, screws,
and all other exposed metal parts for AC leakage. Check leakage as
described below.
1. GENERAL ........................................................................... 3
LEAKAGE
The AC leakage from any exposed metal part to earth Ground and
from all exposed metal parts to any exposed metal part having a
return to chassis, must not exceed 0.5 mA (500 microampers). Leakage current can be measured by any one of three methods.
1. A commercial leakage tester, such as the Simpson 229 or RCA
WT-540A. Follow the manufacturers’ instructions to use these
instruments.
2. A battery-operated AC milliammeter. The Data Precision 245
digital multimeter is suitable for this job.
3. Measuring the voltage drop across a resistor by means of a VOM
or battery-operated AC voltmeter. The “limit” indication is 0.75
V, so analog meters must have an accurate low-voltage scale.
The Simpson 250 and Sanwa SH-63Trd are examples of a passive VOM that is suitable. Nearly all battery operated digital
multimeters that have a 2V AC range are suitable. (See Fig. A)
2. ELECTRICAL ADJUSTMENT .................................... 5
3. DIAGRAMS
3-1. Circuit Boards Location ........................................................ 5
3-2. Schematic Diagram – Main Section (1/3) – .......................... 6
3-3. Schematic Diagram – Main Section (2/3) – .......................... 7
3-4. Schematic Diagram – Main Section (3/3) – .......................... 8
3-5. Printed Wiring Board – Main Section – ................................ 9
3-6. Schematic Diagram – Power Section – ............................... 10
3-7. Printed Wiring Board – Power Section – ............................ 11
4. EXPLODED VIEWS
4-1. Top Plate and Back Panel Section ....................................... 12
4-2. Front Panel Section ............................................................. 12
4-3. Bottom Plate Section .......................................................... 13
5. ELECTRICAL PARTS LIST ................................... 14
To Exposed Metal
Parts on Set
0.15µF
1.5kΩ
AC
voltmeter
(0.75V)
MODEL IDENTIFICATION
— BACK PANEL —
Parts No.
Earth Ground
Fig. A. Using an AC voltmeter to check AC leakage.
SAFETY-RELATED COMPONENT WARNING !!
COMPONENTS IDENTIFIED BY MARK ! OR DOTTED LINE
WITH MARK ! ON THE SCHEMATIC DIAGRAMS AND IN
THE PARTS LIST ARE CRITICAL TO SAFE OPERATION.
REPLACE THESE COMPONENTS WITH SONY PARTS
WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS
MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
ATTENTION AU COMPOSANT AYANT RAPPORT
À LA SÉCURITÉ!!
LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE ! SUR
LES DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES
PIÈCES SONT CRITIQUES POUR LA SÉCURITÉ DE
FONCTIONNEMENT. NE REMPLACER CES COMPOSANTS
QUE PAR DES PIÈCES SONY DONT LES NUMÉROS
SONT DONNÉS DANS CE MANUEL OU DANS LES
SUPPLÉMENTS PUBLIÉS PAR SONY.
2
PARTS No.
4-214-526-1π
4-214-526-2π
MODEL
US , CND
AEP, UK, E, AUS
• Abbreviation
CND : Canadian model
AUS : Australian model
SECTION 1
GENERAL
This section is extracted from
instruction manual.
3
4
TA-E1
SECTION 2
ELECTRICAL ADJUSTMENTS
IDLING ADJUSTMENT AND OFFSET VOLTAGE
CHECK
• Perform this adjustment after replacing CP103 and CP104.
• Perform this adjustment more than 10 minutes after supplying
the power.
Connection:
SECTION 3
DIAGRAMS
BALANCE OUTPUT LEVEL ADJUSTMENT
3-1. CIRCUIT BOARDS LOCATION
• Perform this adjustment when replacing CP102.
• Perform this adjustment after the idling adjustment
Connection:
PS board
AF OSC
Oscilloscope
Digital voltmeter
attenuator
LED A board
TP501 (L-CH), TP502 (R-CH)
TP503 (L-CH), TP504 (R-CH)
BALANCED-OUT 2 3 pin
Procedure:
1. Connect the digital voltmeter as shown above.
2. Adjust RV501 (L-CH) and RV502 (R-CH) of the MAIN board
so that the digital voltmeter reads 50 mV ±5 mV. (Idling adjustment)
L-CH
R-CH
TP502 to TP504
AC J board
Set
MAIN board
Measuring
Point
TP501 to TP503
MAIN board
LINE1 input
Adjusting
Point
RV501
RV502
Adjusting
Value
50 mV ± 5 mV
Procedure:
1. Connect as shown above.
2. Rotate the INPUT SELECTOR knob, and set the input source
to LINE 1 .
3. Set the input level so that the oscilloscope waveform level becomes approx 3 V.
4. Adjust RV401 (L-CH) and RV402 (R-CH) so that the two waveform levels on the oscilloscope become equal and their phases
are reversed.
50 mV ± 5 mV
Adjusting Point
L-CH
3. Measure the voltage of both terminals of R221 (L-CH) and R222
(R-CH) of the MAIN board, and check that the voltage is within
2 mV.
(Offset voltage check)
Measuring Point
Specified Value
L-CH
Both terminals of R221
Within 2 mV
R-CH
Both terminals of R222
Within 2 mV
SW L board
SW P board
Adjusting Value
Pin 2 (CH1) and
RV401
Pin 3 (CH2) of CN203
R-CH
Pin 2 (CH1) and
VOL board
LED B board
RV401
Pin 3 (CH2) of CN203
Adjusting Value:
Waveform of
Pin 2 (CH1)
THIS NOTE IS COMMON FOR PRINTED WIRING
BOARDS AND SCHEMATIC DIAGRAMS.
(In addition to this, the necessary note is printed
in each block.)
Waveform of
Pin 3 (CH2)
Phases of waveforms of
Pins 2 and 3 should be reversed
Adjustment Location:
[MAIN board] (Component Side)
OFFSET
VOLTAGE
For schematic diagrams.
For printed wiring boards.
Note:
• All capacitors are in µF unless otherwise noted. pF: µµF
50 WV or less are not indicated except for electrolytics
and tantalums.
• All resistors are in Ω and 1/4 W or less unless otherwise
specified.
•
%
: indicates tolerance.
• 2 : nonflammable resistor.
• 5 : fusible resistor.
• C : panel designation.
Note:
• X : parts extracted from the component side.
®
: Through hole.
•
• b : Pattern from the side which enables seeing.
(The other layers' patterns are not indicated.)
R222 R221
RV402
BALANCE OUT
LEVEL R CH
RV401
BALANCE OUT
LEVEL L CH
Note:
The components identified by mark ! or dotted
line with mark ! are critical for safety.
Replace only with part
number specified.
TP503 TP501 TP504 TP502
RV501
IDLE
L CH
Note:
Les composants identifiés par
une marque ! sont critiques
pour la sécurité.
Ne les remplacer que par une
piéce portant le numéro
spécifié.
S : B+ Line.
T : B– Line.
H : adjustment for repair.
Voltages and waveforms are dc with respect to ground in
playback mode.
• Voltages are taken with a VOM (Input impedance 10 MΩ).
Voltage variations may be noted due to normal production tolerances.
• Signal path.
F : TUNER
•
•
•
•
RV502
IDLE
R CH
5
5
Caution:
Pattern face side:
(Side B)
Parts face side:
(Side A)
Parts on the pattern face side seen from the
pattern face are indicated.
Parts on the parts face side seen from the
parts face are indicated.
TA-E1
3-2. SCHEMATIC DIAGRAM – MAIN SECTION (1/3) –
• Refer to page 9 for Printed Wiring Board.
(Page 8)
(Page 7)
(Page 7)
(Page 7)
(Page 10)
6
6
(Page 7)
TA-E1
3-3. SCHEMATIC DIAGRAM – MAIN SECTION (2/3) –
• Refer to page 9 for Printed Wiring Board.
(Page 6)
(Page 6)
(Page 6)
(Page 8)
(Page 6)
(Page 8)
(Page 10)
(Page 10)
(Page 10)
7
7
TA-E1
3-4. SCHEMATIC DIAGRAM – MAIN SECTION (3/3) –
(Page 6) (Page 7)
(Page 7)
8
8
TA-E1
• Semiconductor
Location
3-5. PRINTED WIRING BOARD – MAIN SECTION –
• Refer to page 5 for Circuit Boards Location.
SW L
BOARD
(Page 11)
SW L
BOARD
(Page 11)
PS
BOARD
VOL
BOARD
(Page 11)
(Page 11)
9
9
Ref. No
Location
D201
D202
D203
D204
D205
D206
D207
D208
D209
D210
D211
D212
D401
D402
D403
D404
D405
D406
D407
D408
D501
D502
D503
D504
D505
D506
B-1
B-1
B-2
B-3
B-4
B-5
B-6
B-8
B-8
B-7
B-10
B-10
I-2
I-2
I-9
I-9
I-8
I-8
I-7
I-7
I-6
I-5
I-4
I-4
I-3
I-4
Q201
Q202
Q203
Q204
Q205
Q206
Q207
Q208
Q209
Q210
Q211
Q212
Q214
Q215
Q216
Q217
Q218
Q219
Q220
Q221
Q222
Q223
Q224
Q225
Q401
Q402
Q403
Q404
Q405
Q406
Q407
Q408
Q409
Q410
Q411
Q412
Q501
Q502
Q503
Q504
Q505
Q506
Q507
Q508
Q509
Q510
Q511
Q512
Q513
Q514
Q515
Q516
Q517
Q518
Q519
Q520
B-1
B-2
B-3
B-3
B-5
B-6
B-6
B-8
B-7
B-7
B-7
B-10
B-1
B-2
B-3
B-4
B-5
B-6
B-7
B-8
B-7
B-7
B-10
B-11
I-2
I-2
I-2
I-2
I-3
I-2
I-10
I-9
I-9
I-9
I-10
I-9
F-5
F-3
I-8
I-7
I-8
I-7
I-8
I-7
I-6
I-5
I-6
I-5
I-6
I-5
I-4
I-3
I-4
I-3
I-4
I-4
TA-E1
3-6. SCHEMATIC DIAGRAM – POWER SECTION –
(Page 6)
(Page 7)
(Page 7)
(Page 7)
10
10
TA-E1
3-7. PRINTED WIRING BOARD – POWER SECTION –
• Refer to page 5 for Circuit Boards Location.
MAIN
BOARD
MAIN
BOARD
(Page 9)
MAIN BOARD
MAIN
BOARD
(Page 9)
(Page 9)
• Semiconductor
Location
Location
C-1
C-1
B-4
B-3
B-3
B-2
C-5
A-5
A-5
D-5
IC701
C-5
Q701
Q702
Q703
Q704
Q705
Q706
Q707
Q708
Q709
Q710
A-4
A-2
A-4
A-2
C-4
B-3
B-5
A-5
A-5
B-5
FH1
Ref. No
D701
D702
D703
D704
D705
D706
D707
D708
D709
D710
FH2
(Page 9)
11
11
SECTION 4
EXPLODED VIEWS
NOTE:
• -XX, -X mean standardized parts, so they may have
some difference from the original one.
• Items marked “*” are not stocked since they are
seldom required for routine service. Some delay
should be anticipated when ordering these items.
• The mechanical parts with no reference number in
the exploded views are not supplied.
The components identified by
mark ! or dotted line with mark
! are critical for safety.
Replace only with part number
specified.
• Hardware (# mark) list and accessories and packing materials are given in the last of this parts list.
• Abbreviation
CND : Canadian model
4-2. FRONT PANEL SECTION
Les composants identifiés par une
marque ! sont critiques pour la
sécurité.
Ne les remplacer que par une
piéce portant le numéro spécifié.
4-1. TOP PLATE AND BACK PANEL SECTION
not supplied
61
#4
60
#4
59
1
63
#4
not supplied
3
#7
3
2
#5
67
58
not supplied
54
#1
64
#5
Supplied
with S601
#7
62
not supplied
65
not supplied
not supplied
#5
#7
#1
not supplied
not supplied
55
3
#1
not supplied
53
12
3
5
11
#4
52
7
not supplied
53
#10
57
#7
#5
Supplied
with RV301
4
not supplied
5
9
11
6
58
56
#10
9
14
#1
not supplied
52
11
#1
66
#1
not supplied
51
11
not supplied
#3
#1
#1
#1
3
#3
FRONT PANEL
13
#3
10
8
8
#2
#2
10
not supplied
Ref. No.
1
2
3
4
4
* 5
6
8
Part No.
Description
4-214-524-01
4-214-525-01
4-988-742-11
4-214-526-13
4-214-526-22
PLATE (L), TOP
PLATE (R), TOP
SCREW (M3X8), HEXAGON SOCKET
PANEL, BACK (US,CND)
PANEL, BACK (EXCEPT US,CND)
3-910-074-01 BOLT (M3)
1-580-375-41 INLET 3P
3
10
not supplied
#2
not supplied
Remark
#2
Ref. No.
7
8
9
10
11
12
13
* 14
10
8
Part No.
not supplied
Description
Remark
4-911-049-21 SCREW (3X8)
4-970-124-11 CUSHION (F50180S)
3-703-685-41 SCREW (A+BV 3X8)
X-4951-584-1
4-974-510-01
X-4951-020-1
X-4951-021-1
3-703-044-26
Ref. No.
Part No.
Description
51
* 52
53
54
55
4-214-521-01
4-986-734-01
4-214-533-01
4-214-620-01
4-214-532-01
PANEL, FRONT
LENS, LED
RETAINER, LENS
SUPPORT (C)
KNOB (VOL)
56
57
58
59
4-214-545-01
X-4950-674-1
4-214-535-01
1-673-516-11
KNOB (SELECTER)
BUTTON ASSY
WINDOW, MIRROR
LED A BOARD (EXCEPT US,CND)
FOOT ASSY
SCREW (+BV 3X8 CU)
PLATE (L) ASSY,ORNAMENTAL SIDE
PLATE (R) ASSY,ORNAMENTAL SIDE
LABEL, CAUTION (US,CND)
12
12
Remark
Ref. No.
Part No.
Description
60
X-4950-854-1 BUTTON ASSY, POWER
61
62
63
64
65
1-673-514-11
1-673-518-11
1-673-513-11
1-673-517-11
1-673-519-11
66
67
3-655-653-21 BAND (TAITON), BINDING
4-221-587-01 TUBE, LIGHT INTERCEPTION
AC J BOARD
SW P BOARD
SW L BOARD
LED B BOARD
VOL BOARD
Remark
4-3. BOTTOM PLATE SECTION
108
109
107
106 109
109
108
108
109
not supplied
#9
112
105
not supplied
#6
110
109
#6
#8 (US, CND) #8 (US, CND)
#7 (EXCEPT, #7 (EXCEPT,
US, CND)
US, CND)
not supplied
T1
not supplied
111
#7
#7
not supplied
111
104
(US, CND)
103
102
not supplied
not supplied
113
113
not supplied
not supplied
113
101
#7
#7
#3 #7
#8
The components identified by mark !
or dotted line with mark ! are critical
for safety.
Replace only with part number specified.
Ref. No.
Part No.
Description
101
102
103
104
105
4-219-714-01
4-214-527-01
4-219-712-01
4-219-713-01
A-4426-207-A
PLATE (A), BOTTOM
PLATE, BOTTOM
PLATE (A), TOP
PLATE (B), TOP
PS BOARD, COMPLETE (US,CND)
Remark
105
* 106
107
108
A-4426-210-A
4-941-237-01
4-902-345-01
2-259-121-01
PS BOARD, COMPLETE (EXCEPT US,CND)
HEAT SINK
HEAT SINK
SCREW, TR
Ref. No.
109
Part No.
Les composants identifiés par une
marque ! sont critiques pour la sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
Description
Remark
4-967-960-01 SCREW (4X8)
* 110
* 111
112
112
113
4-931-964-01
1-641-950-11
A-4426-205-A
A-4426-208-A
4-974-510-01
SCREW (M4X6)
PC BOARD, BOTTOM LID
MAIN BOARD, COMPLETE (US,CND)
MAIN BOARD, COMPLETE (EXCEPT US,CND)
SCREW (+BV 3X8 CU)
! T1
! T1
1-433-981-11 TRANSFORMER, POWER (EXCEPT US,CND)
1-433-982-11 TRANSFORMER, POWER (US,CND)
13
AC J
LED A
LED B
SECTION 5
ELECTRICAL PARTS LIST
MAIN
Note:
The components identified by
mark ! or dotted line with mark
! are critical for safety.
Replace only with part number
specified.
Les composants identifiés par une
marque ! sont critiques pour la
sécurité.
Ne les remplacer que par une
piéce portant le numéro spécifié.
When indicating parts by reference
number, please include the board
name.
Ref. No.
Part No.
• Due to standardization, replacements in the parts list
may be different from the parts specified in the
diagrams or the components used on the set.
• -XX, -X mean standardized parts, so they may have
some difference from the original one.
• Items marked “*” are not stocked since they are
seldom required for routine service. Some delay
should be anticipated when ordering these items.
• RESISTORS
All resistors are in ohms
METAL: Metal-film resistor
METAL OXIDE: Metal Oxide-film resistor
F : nonflammable
Description
Remark
Ref. No.
Part No.
1-673-514-11 AC J BOARD
*********
D601
D602
D603
D604
< CAPACITOR >
1-113-920-11 CERAMIC
0.0022uF 20%
250V
8-719-046-38
8-719-046-38
8-719-046-38
8-719-046-38
DIODE
DIODE
DIODE
DIODE
SEL5821A-TH8F (TAPE MONITOR)
SEL5821A-TH8F (TAPE 1)
SEL5821A-TH8F (TAPE 2)
SEL5821A-TH8F (DIRECT)
A-4426-205-A MAIN BOARD, COMPLETE (US,CND)
*********************
1-564-321-00 PIN, CONNECTOR 2P
A-4426-208-A MAIN BOARD, COMPLETE (EXCEPT US,CND)
*********************
< FUSE >
! F901
! F901
Remark
**************************************************************
< CONNECTOR >
CN902
Description
< DIODE >
1-533-798-11 HOLDER, FUSE
! C901
• SEMICONDUCTORS
In each case, u: µ , for example:
uA...: µ A..., uPA...: µ PA..., uPB...: µ PB...,
uPC...: µ PC..., uPD...: µ PD...
• CAPACITORS
uF : µ F
• COILS
uH : µ H
• Abbreviation
CND : Canadian model
1-532-463-51 FUSE (1A/250)(EXCEPT US,CND)
1-532-742-11 FUSE, GLASS TUBE (1.6A/125V)(US,CND)
4-835-639-00 PLATE, GROUND
< CAPACITOR >
< SWITCH >
! S901
1-771-187-11 SWITCH, AC POWER (U)
**************************************************************
1-673-516-11 LED A BOARD
**********
< CAPACITOR >
C801
C802
1-115-339-11 CERAMIC CHIP
1-115-339-11 CERAMIC CHIP
0.1uF
0.1uF
10%
10%
50V
50V
< CONNECTOR >
CN801
1-691-765-11 PLUG (MICRO CONNECTOR) 3P
C223
C224
C225
C226
C227
1-115-339-11
1-115-339-11
1-115-339-11
1-115-339-11
1-115-339-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
50V
50V
50V
50V
50V
C228
C229
C230
C231
C232
1-115-339-11
1-115-339-11
1-115-339-11
1-115-339-11
1-115-339-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.1uF
0.1uF
0.1uF
10%
10%
10%
10%
10%
50V
50V
50V
50V
50V
C233
C234
C237
C238
C239
1-115-339-11
1-115-339-11
1-163-009-11
1-163-009-11
1-163-009-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.1uF
0.1uF
0.001uF
0.001uF
0.001uF
10%
10%
10%
10%
10%
50V
50V
50V
50V
50V
C240
C241
C242
C243
C244
1-163-009-11
1-163-009-11
1-163-009-11
1-163-009-11
1-163-009-11
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.001uF
0.001uF
0.001uF
0.001uF
0.001uF
10%
10%
10%
10%
10%
50V
50V
50V
50V
50V
C245
C246
C247
C248
C249
1-163-009-11
1-163-009-11
1-125-845-21
1-125-845-21
1-163-009-11
CERAMIC CHIP
CERAMIC CHIP
FILM
FILM
CERAMIC CHIP
0.001uF
0.001uF
47PF
47PF
0.001uF
10%
10%
10%
10%
10%
50V
50V
50V
50V
50V
C250
C401
C402
1-163-009-11 CERAMIC CHIP
1-110-512-51 FILM
1-110-512-51 FILM
0.001uF
1uF
1uF
10%
10%
10%
50V
50V
50V
< DIODE >
D801
8-719-313-40 DIODE SML1516W (U)
**************************************************************
1-673-517-11 LED B BOARD
**********
< CAPACITOR >
C605
C606
C607
C608
14
1-163-021-91
1-163-021-91
1-163-021-91
1-163-021-91
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
CERAMIC CHIP
0.01uF
0.01uF
0.01uF
0.01uF
10%
10%
10%
10%
50V
50V
50V
50V
MAIN
Ref. No.
Part No.
Description
Remark
C403
C404
1-128-200-11 ELECT
1-128-200-11 ELECT
47uF
47uF
20%
20%
50V
50V
C405
C406
C407
C408
C409
1-110-512-51
1-110-512-51
1-128-972-11
1-128-972-11
1-128-973-11
FILM
FILM
ELECT
ELECT
ELECT
1uF
1uF
1000uF
1000uF
470uF
10%
10%
20%
20%
20%
50V
50V
50V
50V
25V
C410
C411
C412
C413
C414
1-128-973-11
1-128-200-11
1-128-200-11
1-128-200-11
1-128-200-11
ELECT
ELECT
ELECT
ELECT
ELECT
470uF
47uF
47uF
47uF
47uF
20%
20%
20%
20%
20%
25V
50V
50V
50V
50V
C419
C420
C421
C422
C423
1-110-512-51
1-110-512-51
1-128-972-11
1-128-972-11
1-128-973-11
FILM
FILM
ELECT
ELECT
ELECT
1uF
1uF
1000uF
1000uF
470uF
10%
10%
20%
20%
20%
50V
50V
50V
50V
25V
C424
C501
C502
C503
C504
1-128-973-11
1-125-850-21
1-125-850-21
1-110-512-51
1-110-512-51
ELECT
FILM
FILM
FILM
FILM
470uF
220PF
220PF
1uF
1uF
20%
5%
5%
10%
10%
25V
50V
50V
50V
50V
C505
C506
C507
C508
C509
1-128-971-11
1-128-971-11
1-128-971-11
1-128-971-11
1-128-973-11
ELECT
ELECT
ELECT
ELECT
ELECT
220uF
220uF
220uF
220uF
470uF
20%
20%
20%
20%
20%
50V
50V
50V
50V
25V
C510
C511
C512
C513
C514
1-128-973-11
1-128-972-11
1-128-972-11
1-110-512-51
1-110-512-51
ELECT
ELECT
ELECT
FILM
FILM
470uF
1000uF
1000uF
1uF
1uF
20%
20%
20%
10%
10%
25V
50V
50V
50V
50V
C515
C516
C517
C518
C519
1-128-973-11
1-128-973-11
1-126-017-11
1-126-017-11
1-110-512-51
ELECT
ELECT
ELECT
ELECT
FILM
470uF
470uF
6800uF
6800uF
1uF
20%
20%
20%
20%
10%
25V
25V
16V
16V
50V
C520
C521
C522
C523
C524
1-110-512-51
1-128-973-11
1-128-973-11
1-128-972-11
1-128-972-11
FILM
ELECT
ELECT
ELECT
ELECT
1uF
470uF
470uF
1000uF
1000uF
10%
20%
20%
20%
20%
50V
25V
25V
50V
50V
C525
C526
1-110-512-51 FILM
1-110-512-51 FILM
1uF
1uF
10%
10%
50V
50V
Ref. No.
CP103
CP104
CN201
CN202
CN203
CN204
CN205
CN206
* CN207
1-766-803-11
1-766-803-11
1-785-548-11
1-785-548-11
1-691-768-11
CONNECTOR (CANON)
CONNECTOR (CANON)
CONNECTOR (RECEPTACLE)
CONNECTOR (RECEPTACLE)
PLUG (MICRO CONNECTOR) 6P
1-691-769-11 PLUG (MICRO CONNECTOR) 7P
1-564-241-11 PIN, CONNECTOR (B4P-VH) 4P
< COMPOSITION CIRCUIT BLOCK >
CP101
CP102
1-233-250-11 ENCAPSULATED COMPONENT
1-418-106-11 AMPLIFIER UNIT
Description
Remark
< DIODE >
D201
D202
D203
D204
D205
8-719-800-76
8-719-800-76
8-719-800-76
8-719-800-76
8-719-800-76
DIODE
DIODE
DIODE
DIODE
DIODE
1SS226
1SS226
1SS226
1SS226
1SS226
D206
D207
D208
D209
D210
8-719-800-76
8-719-800-76
8-719-800-76
8-719-800-76
8-719-800-76
DIODE
DIODE
DIODE
DIODE
DIODE
1SS226
1SS226
1SS226
1SS226
1SS226
D211
D212
D401
D402
D403
8-719-800-76
8-719-800-76
8-719-025-51
8-719-025-51
8-719-025-51
DIODE
DIODE
DIODE
DIODE
DIODE
1SS226
1SS226
02CZ18-TE85L
02CZ18-TE85L
02CZ18-TE85L
D404
D405
D406
D407
D408
8-719-025-51
8-719-025-47
8-719-025-47
8-719-025-47
8-719-025-47
DIODE
DIODE
DIODE
DIODE
DIODE
02CZ18-TE85L
02CZ12-TE85L
02CZ12-TE85L
02CZ12-TE85L
02CZ12-TE85L
D501
D502
D503
D504
D505
8-719-025-51
8-719-025-51
8-719-025-47
8-719-025-47
8-719-025-47
DIODE
DIODE
DIODE
DIODE
DIODE
02CZ18-TE85L
02CZ18-TE85L
02CZ12-TE85L
02CZ12-TE85L
02CZ12-TE85L
D506
8-719-025-47 DIODE 02CZ12-TE85L
< JACK >
J201
J202
J203
J204
J205
< CONNECTOR >
Part No.
1-418-107-11 AMPLIFIER UNIT
1-418-107-11 AMPLIFIER UNIT
1-785-547-11
1-785-547-11
1-785-547-11
1-785-547-11
JACK, PIN (LINE 1, 2 L/R)
JACK, PIN (CD, SACD L/R)
JACK, PIN (DIRECT L/R, TAPE2/MD IN L/R)
JACK, PIN
(TAPE2/MD OUT L/R, TAPE1/DAT IN L/R)
1-785-547-11 JACK, PIN (TAPE1/DAT OUT L/R, PRE OUT L/R)
< BUS BAR >
*
*
*
*
*
JWH201
JWH202
JWH203
JWH204
JWH205
1-569-135-11
1-569-135-11
1-691-275-11
1-569-135-11
1-569-135-11
BAR, BUS 4P
BAR, BUS 4P
BUS BAR
BAR, BUS 4P
BAR, BUS 4P
* JWH206 1-691-275-11 BUS BAR
< TRANSISTOR >
Q201
Q202
Q203
Q204
Q205
8-729-424-08
8-729-424-08
8-729-424-08
8-729-424-08
8-729-424-08
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
UN2111
UN2111
UN2111
UN2111
UN2111
Q206
Q207
Q208
Q209
Q210
8-729-424-08
8-729-424-08
8-729-424-08
8-729-424-08
8-729-424-08
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
UN2111
UN2111
UN2111
UN2111
UN2111
15
MAIN
Ref. No.
Part No.
Description
Part No.
Description
Q211
Q212
Q214
Q215
Q216
8-729-424-08
8-729-424-08
8-729-421-22
8-729-421-22
8-729-421-22
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
UN2111
UN2111
UN2211
UN2211
UN2211
Remark
R211
R212
R213
R214
R215
1-260-032-11
1-260-032-11
1-260-032-11
1-260-032-11
1-260-032-11
CARBON MELF
CARBON MELF
CARBON MELF
CARBON MELF
CARBON MELF
1M
1M
1M
1M
1M
2%
2%
2%
2%
2%
1/8W
1/8W
1/8W
1/8W
1/8W
Q217
Q218
Q219
Q220
Q221
8-729-421-22
8-729-421-22
8-729-421-22
8-729-421-22
8-729-421-22
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
UN2211
UN2211
UN2211
UN2211
UN2211
R216
R217
R218
R219
R220
1-260-032-11
1-260-032-11
1-260-032-11
1-260-020-11
1-260-020-11
CARBON MELF
CARBON MELF
CARBON MELF
CARBON MELF
CARBON MELF
1M
1M
1M
100K
100K
2%
2%
2%
2%
2%
1/8W
1/8W
1/8W
1/8W
1/8W
Q222
Q223
Q224
Q225
Q401
8-729-421-22
8-729-421-22
8-729-421-22
8-729-421-22
8-729-047-96
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
UN2211
UN2211
UN2211
UN2211
2SC3645-S
R221
R222
R223
R224
R225
1-260-032-11
1-260-032-11
1-260-032-11
1-260-032-11
1-260-032-11
CARBON MELF
CARBON MELF
CARBON MELF
CARBON MELF
CARBON MELF
1M
1M
1M
1M
1M
2%
2%
2%
2%
2%
1/8W
1/8W
1/8W
1/8W
1/8W
Q402
Q403
Q404
Q405
Q406
8-729-047-94
8-729-271-31
8-729-216-31
8-729-232-69
8-729-232-69
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SA1415-S
2SC2713-G
2SA1163-G
2SK208-GRT5LSONY-1
2SK208-GRT5LSONY-1
R226
R227
R228
R229
R230
1-260-032-11
1-249-186-11
1-249-186-11
1-259-644-11
1-259-644-11
CARBON MELF
CARBON
CARBON
CARBON
CARBON
1M
100
100
47
47
2%
1%
1%
2%
2%
1/8W
1/3W
1/3W
1W
1W
Q407
Q408
Q409
Q410
Q411
8-729-047-96
8-729-047-94
8-729-271-31
8-729-216-31
8-729-232-69
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC3645-S
2SA1415-S
2SC2713-G
2SA1163-G
2SK208-GRT5LSONY-1
R231
R232
R233
R234
R235
1-259-531-11
1-259-531-11
1-249-186-11
1-249-186-11
1-259-995-11
CARBON
CARBON
CARBON
CARBON
CARBON MELF
100
100
100
100
1K
1%
1%
1%
1%
2%
1/2W
1/2W
1/3W
1/3W
1/8W
Q412
Q501
Q502
Q503
Q504
8-729-232-69
8-729-271-31
8-729-271-31
8-729-047-96
8-729-047-94
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SK208-GRT5LSONY-1
2SC2713-G
2SC2713-G
2SC3645-S
2SA1415-S
R236
! R401
! R402
R403
R404
1-259-995-11
1-202-937-41
1-202-937-41
1-259-999-11
1-259-999-11
CARBON MELF
FUSIBLE
FUSIBLE
CARBON MELF
CARBON MELF
1K
10
10
2.2K
2.2K
2%
5%
5%
2%
2%
1/8W
1/2W
1/2W
1/8W
1/8W
Q505
Q506
Q507
Q508
Q509
8-729-271-31
8-729-216-31
8-729-232-69
8-729-232-69
8-729-047-96
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2713-G
2SA1163-G
2SK208-GRT5LSONY-1
2SK208-GRT5LSONY-1
2SC3645-S
R405
R406
R407
R408
! R409
1-259-987-11
1-259-987-11
1-259-995-11
1-259-995-11
1-202-937-41
CARBON MELF
CARBON MELF
CARBON MELF
CARBON MELF
FUSIBLE
220
220
1K
1K
10
2%
2%
2%
2%
5%
1/8W
1/8W
1/8W
1/8W
1/2W
Q510
Q511
Q512
Q513
Q514
8-729-047-94
8-729-271-31
8-729-216-31
8-729-232-69
8-729-232-69
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SA1415-S
2SC2713-G
2SA1163-G
2SK208-GRT5LSONY-1
2SK208-GRT5LSONY-1
! R410
R411
R412
R413
R414
1-202-937-41
1-259-999-11
1-259-999-11
1-259-987-11
1-259-987-11
FUSIBLE
CARBON MELF
CARBON MELF
CARBON MELF
CARBON MELF
10
2.2K
2.2K
220
220
5%
2%
2%
2%
2%
1/2W
1/8W
1/8W
1/8W
1/8W
Q515
Q516
Q517
Q518
Q519
8-729-232-69
8-729-232-69
8-729-047-96
8-729-047-94
8-729-271-31
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SK208-GRT5LSONY-1
2SK208-GRT5LSONY-1
2SC3645-S
2SA1415-S
2SC2713-G
R415
R416
R501
R502
R503
1-259-995-11
1-259-995-11
1-259-668-61
1-259-668-61
1-259-535-61
CARBON MELF
CARBON MELF
CARBON
CARBON
CARBON
1K
1K
470
470
150
2%
2%
2%
2%
1%
1/8W
1/8W
1W
1W
1/2W
Q520
8-729-216-31 TRANSISTOR
2SA1163-G
R504
R505
R506
R507
R508
1-259-535-61
1-259-668-61
1-259-668-61
1-260-002-11
1-259-991-11
CARBON
CARBON
CARBON
CARBON MELF
CARBON MELF
150
470
470
3.3K
470
1%
2%
2%
2%
2%
1/2W
1W
1W
1/8W
1/8W
R509
R510
R511
R512
R513
1-260-002-11
1-259-991-11
1-259-999-11
1-259-999-11
1-259-987-11
CARBON MELF
CARBON MELF
CARBON MELF
CARBON MELF
CARBON MELF
3.3K
470
2.2K
2.2K
220
2%
2%
2%
2%
2%
1/8W
1/8W
1/8W
1/8W
1/8W
220
10
2%
5%
1/8W
1/2W
< RESISTOR >
R201
R202
R203
R204
R205
1-260-032-11
1-260-032-11
1-260-032-11
1-260-032-11
1-260-032-11
CARBON MELF
CARBON MELF
CARBON MELF
CARBON MELF
CARBON MELF
1M
1M
1M
1M
1M
2%
2%
2%
2%
2%
1/8W
1/8W
1/8W
1/8W
1/8W
R206
R207
R208
R209
R210
1-260-032-11
1-260-032-11
1-260-032-11
1-260-032-11
1-260-032-11
CARBON MELF
CARBON MELF
CARBON MELF
CARBON MELF
CARBON MELF
1M
1M
1M
1M
1M
2%
2%
2%
2%
2%
1/8W
1/8W
1/8W
1/8W
1/8W
Ref. No.
R514
! R515
1-259-987-11 CARBON MELF
1-202-937-41 FUSIBLE
The components identified by mark !
or dotted line with mark ! are critical
for safety.
Replace only with part number specified.
16
Remark
Les composants identifiés par une
marque ! sont critiques pour la sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
MAIN
Ref. No.
Part No.
! R516
! R517
! R518
1-202-937-41 FUSIBLE
1-202-937-41 FUSIBLE
1-202-937-41 FUSIBLE
Description
10
10
10
5%
5%
5%
1/2W
1/2W
1/2W
Remark
R519
R520
R521
R522
R523
1-259-995-11
1-259-995-11
1-259-999-11
1-259-999-11
1-259-987-11
CARBON MELF
CARBON MELF
CARBON MELF
CARBON MELF
CARBON MELF
1K
1K
2.2K
2.2K
220
2%
2%
2%
2%
2%
1/8W
1/8W
1/8W
1/8W
1/8W
R524
R525
R526
! R527
! R528
1-259-987-11
1-259-995-11
1-259-995-11
1-202-937-41
1-202-937-41
CARBON MELF
CARBON MELF
CARBON MELF
FUSIBLE
FUSIBLE
220
1K
1K
10
10
2%
2%
2%
5%
5%
1/8W
1/8W
1/8W
1/2W
1/2W
R529
R530
R531
R532
R533
1-259-999-11
1-259-999-11
1-259-987-11
1-259-987-11
1-259-995-11
CARBON MELF
CARBON MELF
CARBON MELF
CARBON MELF
CARBON MELF
2.2K
2.2K
220
220
1K
2%
2%
2%
2%
2%
1/8W
1/8W
1/8W
1/8W
1/8W
R534
R535
R536
1-259-995-11 CARBON MELF
1-249-162-11 CARBON
1-249-162-11 CARBON
1K
10
10
2%
1%
1%
1/8W
1/3W
1/3W
Ref. No.
Part No.
Description
PS
Remark
< CAPACITOR >
C701
C702
C703
C706
C707
1-136-880-11
1-128-998-11
1-128-998-11
1-128-200-11
1-128-200-11
FILM
ELECT
ELECT
ELECT
ELECT
2.2uF
6800uF
6800uF
47uF
47uF
10%
20%
20%
20%
20%
160V
35V
35V
50V
50V
C708
C709
C710
C711
C716
1-117-775-31
1-117-775-31
1-127-982-11
1-127-981-11
1-130-955-11
FILM
FILM
ELECT
ELECT
FILM
0.1uF
0.1uF
3900uF
3900uF
0.01uF
10%
10%
20%
20%
2%
250V
250V
50V
50V
100V
C717
C718
C719
C720
1-119-847-11
1-119-815-21
1-126-025-11
1-119-804-21
ELECT
ELECT
ELECT
ELECT
2.2uF
2200uF
330uF
1000uF
20%
20%
20%
20%
100V
35V
25V
25V
< CONNECTOR >
CN702
CN704
* CN705
1-564-510-11 PLUG (MICRO CONNECTOR) 6P
1-564-320-00 PIN, CONNECTOR (B2P-VH) 2P
1-564-241-11 PIN, CONNECTOR (B4P-VH) 4P
< DIODE >
< VARIABLE RESISTOR >
RV401
RV402
RV501
RV502
1-224-250-11 RES, ADJ, METAL GLAZE 2.2K
(BALANCED LEVEL LCH)
1-224-250-11 RES, ADJ, METAL GLAZE 2.2K
(BALANCED LEVEL RCH)
1-224-249-11 RES, ADJ, METAL GLAZE 1K (IDLER LCH)
1-224-249-11 RES, ADJ, METAL GLAZE 1K (IDLER RCH)
< RELAY >
RY101
RY102
RY103
RY104
RY105
1-755-062-11
1-755-062-11
1-755-062-11
1-755-062-11
1-755-062-11
RELAY
RELAY
RELAY
RELAY
RELAY
RY106
RY107
RY108
RY109
RY110
1-755-062-11
1-755-062-11
1-755-062-11
1-755-062-11
1-755-062-11
RELAY
RELAY
RELAY
RELAY
RELAY
RY111
RY112
RY113
1-755-062-11 RELAY
1-755-062-11 RELAY
1-755-062-11 RELAY
< TEST PIN >
*
*
*
*
TP501
TP502
TP503
TP504
3-657-235-00
3-657-235-00
3-657-235-00
3-657-235-00
POINT, TEST
POINT, TEST
POINT, TEST
POINT, TEST
**************************************************************
A-4426-207-A PS BOARD, COMPLETE (US,CND)
******************
A-4426-210-A PS BOARD, COMPLETE (EXCEPT US,CND)
*******************
D701
D702
D703
D704
D705
8-719-200-39
8-719-200-40
8-719-025-49
8-719-025-49
8-719-025-49
DIODE
DIODE
DIODE
DIODE
DIODE
C16P20F
C16P20FR
02CZ15-TE85L
02CZ15-TE85L
02CZ15-TE85L
D706
D707
D708
D709
D710
8-719-025-49
8-719-200-82
8-719-025-47
8-719-200-82
8-719-070-64
DIODE
DIODE
DIODE
DIODE
DIODE
02CZ15-TE85L
11ES2
02CZ12-TE85L
11ES2
RBV-602L
< IC >
IC701
8-759-605-03 IC M5F78M24L
< TRANSISTOR >
Q701
Q702
Q703
Q704
Q705
8-729-141-58
8-729-141-10
8-729-271-31
8-729-216-31
8-729-232-69
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SC2275A-Q
2SA985A-Q
2SC2713-G
2SA1163-G
2SK208-GRT5LSONY-1
Q706
Q707
Q708
Q709
Q710
8-729-232-69
8-729-271-31
8-729-424-08
8-729-424-08
8-729-424-08
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
TRANSISTOR
2SK208-GRT5LSONY-1
2SC2713-G
UN2111
UN2111
UN2111
< RESISTOR >
! R701
! R702
R703
R704
R705
1-202-937-41
1-202-937-41
1-259-999-11
1-259-999-11
1-259-987-11
FUSIBLE
FUSIBLE
CARBON MELF
CARBON MELF
CARBON MELF
R706
! R707
R708
1-259-987-11 CARBON MELF
1-202-937-41 FUSIBLE
1-259-995-11 CARBON MELF
The components identified by mark !
or dotted line with mark ! are critical
for safety.
Replace only with part number specified.
10
10
2.2K
2.2K
220
5%
5%
2%
2%
2%
1/2W
1/2W
1/8W
1/8W
1/8W
220
10
1K
2%
5%
2%
1/8W
1/2W
1/8W
Les composants identifiés par une
marque ! sont critiques pour la sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
17
TA-E1
PS
SW L
SW P
VOL
Ref. No.
Part No.
R709
! R710
1-259-995-11 CARBON MELF
1-202-937-41 FUSIBLE
Description
1K
10
2%
5%
1/8W
1/2W
! R711
R712
R713
R717
R718
1-202-937-41
1-260-002-11
1-260-008-11
1-260-020-11
1-260-008-11
FUSIBLE
CARBON MELF
CARBON MELF
CARBON MELF
CARBON MELF
10
3.3K
10K
100K
10K
5%
2%
2%
2%
2%
1/2W
1/8W
1/8W
1/8W
1/8W
R719
R720
R721
1-260-020-11
1-260-002-11
1-260-002-11
1-673-519-11
CARBON MELF
CARBON MELF
CARBON MELF
VOL BIARD
100K
3.3K
3.3K
2%
2%
2%
1/8W
1/8W
1/8W
Ref. No.
Remark
Part No.
Description
Remark
< RESISTOR >
R601
R603
R604
1-260-008-11 CARBON MELF
1-260-008-11 CARBON MELF
1-260-008-11 CARBON MELF
10K
10K
10K
2%
2%
2%
1/8W
1/8W
1/8W
< SWITCH >
S602
1-771-567-11 SWITCH, PUSH (3 KEY)
(TAPE MONITOR, TAPE 1/2, DIRECT)
**************************************************************
1-673-519-11 VOL BOARD
*********
**************************************************************
1-673-513-11 SW L BOARD
*********
< CONNECTOR >
CN301
1-691-770-11 PLUG (MICRO CONNECTOR) 8P
< CAPACITOR >
< VARIABLE RESISTOR >
C601
C609
1-163-009-11 CERAMIC CHIP
1-119-847-11 ELECT
0.001uF
2.2uF
10%
20%
50V
100V
RV301
< CONNECTOR >
CN601
CN602
**************************************************************
1-691-769-11 PLUG (MICRO CONNECTOR) 7P
1-691-768-11 PLUG (MICRO CONNECTOR) 6P
MISCELLANEOUS
*************
< DIODE >
D605
6
! T1
! T1
8-719-800-76 DIODE 1SS226
< TRANSISTOR >
Q601
1-225-742-11 RES, VAR, CARBON 20K/20K
8-729-047-96 TRANSISTOR
1-580-375-41 INLET 3P
1-433-981-11 TRANSFORMER, POWER (EXCEPT US,CND)
1-433-982-11 TRANSFORMER, POWER (US,CND)
**************************************************************
ACCESSORIES & PACKING MATERIALS
*******************************
2SC3645-S
< RESISTOR >
R602
R608
R609
1-260-008-11 CARBON MELF
1-259-978-11 CARBON MELF
1-260-008-11 CARBON MELF
10K
39
10K
2%
2%
2%
1-506-411-21
1-551-631-22
1-551-812-11
1-558-271-11
3-866-956-11
1/8W
1/8W
1/8W
ADAPTOR, AC PLUG 3P-2P(US,CND)
CORD, POWER (EXCEPT US,CND)
CORD, POWER (US,CND)
CORD, CONNECTION (AUDIO, 108cm)
MANUAL, INSTRUCTION (ENGLISH,FRENCH)
< SWITCH >
S601
3-866-956-21 MANUAL, INSTRUCTION (GERMAN,SPANISH,
DUTCH,SWEDISH,ITALIAN,PORTUGUESE)(EXCEPT US,CND)
1-771-566-11 SWITCH, ROTARY (INPUT SELECTOR)
**************************************************************
**************************************************************
1-673-518-11 SW P BOARD
*********
*************
HARDWARE LIST
*************
< CAPACITOR >
C602
C603
C604
1-163-009-11 CERAMIC CHIP
1-163-009-11 CERAMIC CHIP
1-163-009-11 CERAMIC CHIP
0.001uF
0.001uF
0.001uF
10%
10%
10%
50V
50V
50V
#1
#2
#2
#3
#4
7-621-775-10
7-682-566-04
7-682-567-09
7-682-549-04
7-621-770-87
SCREW +B 2.6X4
SCREW +B 4X20
SCREW +B 4X25 (US,CND)
SCREW +B 3X10
SCREW +B 2.6X5
#5
#6
#7
#8
#9
7-621-770-XX
7-682-571-09
7-685-871-09
7-682-550-09
7-682-962-01
SCREW +B 2.6X8
+B 4X45 (EXCEPT US,CND)
SCREW +BVTT 3X6 (S)
SCREW +B 3X12
+PSW 4X10
#10
7-683-255-58 SET SCREW 5X6 HEXAGON SOCKET
< CONNECTOR >
CN606
CN607
1-691-770-11 PLUG (MICRO CONNECTOR) 8P
1-691-768-11 PLUG (MICRO CONNECTOR) 6P
< DIODE >
D606
D607
8-719-025-19 DIODE 02CZ2.2-TE85L
8-719-043-82 DIODE 02CZ5.1Y-TE85L
9-928-912-11
The components identified by mark !
or dotted line with mark ! are critical
for safety.
Replace only with part number specified.
Sony Corporation
Home Audio Company
18
Les composants identifiés par une
marque ! sont critiques pour la sécurité.
Ne les remplacer que par une piéce
portant le numéro spécifié.
99G0989-1
Printed in Japan © 1999. 7
Published by Quality Assurance Dept.
Download PDF

advertising