Series PVA33N

Series PVA33N
Data Sheet No. PD10051-D
Series PVA33N
Microelectronic Power IC
HEXFET® Power MOSFET Photovoltaic Relay
Single-Pole, Normally-Open
0-300V AC/DC, 150mA
General Description
The PVA33 Series AC Relay (PVA) is a single-pole,
normally open, solid-state replacement for
electromechanical relays used for general purpose
switching of analog signals. It utilizes International
Rectifier’s HEXFET power MOSFETs as the output
switches, driven by an integrated circuit photovoltaic
generator of novel construction. The output switch is
controlled by radiation from a GaAlAs light emitting
diode (LED), which is optically isolated from the
photovoltaic generator.
The PVA33 Series overcomes the limitations of both
conventional electromechanical and reed relays by
offering the solid state advantages of long life, fast
operating speed, low pick up power, bounce-free
operation, low thermal offset voltages and miniature
package. These advantages allow product
improvement and design innovations in many
applications such as process control, multiplexing,
automatic test equipment and data acquisition.
The PVA33 can switch analog signals from
thermocouple level to 300 Volts peak AC or DC
polarity. Signal frequencies into the RF range are
easily controlled and switching rates up to 500Hz are
achievable. The extremely small thermally generated
offset voltages allow increased measurement
accuracies.
These relays are packaged in 8-pin, molded DIP
packages and available with either thru-hole or
surface-mount (“gull-wing”) leads, in plastic shipping
tubes.
Applications
Process Control
Data Acquisition
Test Equipment
Multiplexing and Scanning
Features
Bounce-Free Operation
1010 Off-State Resistance
1,000 V/∝
sec dv/dt
0.2 ∝
V Thermal Offset
5 mA Input Sensitivity
4,000 VRMS I/O Isolation
Solid-State Reliability
UL Recognized
ESD Tolerance:
4000V Human Body Model
500V Machine Model
Part Identification
PVA2352N
PVA3324N
PVA3354N
PVA2352NS
PVA3324NS
PVA3354NS
thru-hole
surface-mount
(gull-wing)
(HEXFET is the registered trademark for International Rectifier Power MOSFETs)
Cra 53 # 50-51 Locales 207-208 Pbx: (4)512 78 30
Fax: (4)512 75 94 e-mail: [email protected] www.suconel.com
Data Sheet No. PD10051-D
Series PVA33N
Microelectronic Power IC
HEXFET® Power MOSFET Photovoltaic Relay
Single-Pole, Normally-Open
Series PVA33N
Electrical Specifications (-40°
C=
TA =
+85°
C unless otherwise specified)
INPUT CHARACTERISTICS
PVA2352N PVA3324N PVA3354N Units
Minimum Control Current (see figures 1 and 2)
For 60mA Continuous Load Current
For 170mA Continuous Load Current
For 100mA Continuous Load Current
-2
5
1
2
2
Maximum Control Current for Off-State Resistance at 25°C
-2
5
DC
[email protected]°C
[email protected]°C
[email protected]°C
10
µA(DC)
2.0 to 25
mA(DC)
7.0
V(DC)
OUTPUT CHARACTERISTICS
PVA2352N PV
A3324N PV
A3354N
Units
Operating Voltage Range
0 to ± 200
Control Current Range (Caution: current limit input LED. See figure 6)
Maximum Reverse Voltage
Maxiumum Load Current 40°C I LED 5mA
0 to ± 300
150
Max. On-state Resistance 25°C (Pulsed) (fig. 4) 50 mA Load, 5mA Control
mA(DC)
24
8
Min. Off-state Resistance @ 25°C (see figure 5)
V(PEAK)
?
10
10 @160VDC 10 @ 240VDC
?
Response Time @25°C (see figures 7 and 8)
Max. T(on) @ 12mA Control, 50 mA Load, 100 VDC
100
µs
Max. T(off) @ 12mA Control, 50 mA Load, 100 VDC
110
µs
Max. Thermal Offset Voltage @ 5.0mA Control
0.2
µvolts
Min. Off-State dv/dt
1000
V/µs
6
pF @ 50V
Typical Output Capacitance (see figure 10)
GENERAL CHARACTERISTICS
(PVA2352N, PVA3324N
and PVA3354N)
Dielectric Strength: Input-Output
4000
V RMS
12
Insulation Resistance: Input-Output @ 90VDC
10 @ 25°C - 50% RH
?
1.0
pF
Maximum Capacitance: Input-Output
Max. Pin Soldering Temperature (1.6mm below seating plane, 10 seconds max.)
Ambient Temperature Range:
Units
+260
Operating
-40 to +85
Storage
-40 to +100
°
C
International Rectifier does not recommend the use of this product in aerospace, avionics, military or life support applications.
Users of this International Rectifier product in such applications assume all risks of such use and indemnify International
Rectifier against all damages resulting from such use.
2
Cra 53 # 50-51 Locales 207-208 Pbx: (4)512 78 30
Fax: (4)512 75 94 e-mail: [email protected] www.suconel.com
Data Sheet No. PD10051-D
Series PVA33N
Microelectronic Power IC
HEXFET® Power MOSFET Photovoltaic Relay
Single-Pole, Normally-Open
Series PVA33N
,
220
220
180
200
I LED > 2mA
Max. Load Current (mA)
Max. Load Current (mA)
200
160
140
120
100
80
I LED =1mA
60
40
20
140
I LED > 5mA
120
100
80
I LED=2mA
60
40
0
0
20
40
60
80
100
0
40
60
80
Ambient Temperature (°C)
Figure 1. Current Derating Curves
(PVA3324N)
Figure 2. Current Derating Curves
(PVA3354N, PVA2352N)
150
100
50
0
-3
-2
-1
-50
0
1
2
3
-100
-150
4
5
Rd(on) (Normalized to 25oC)
200
-4
20
Ambient Temperature (°C)
250
Load Current (mA)
160
20
0
-5
180
5 mA Control
lD = 50 mA
-200
-250
Voltage Drop (V DD)
Ambient Temperature (°C)
Figure 3.Typical On Characteristics
Figure 4. Typical On-Resistance
Cra 53 # 50-51 Locales 207-208 Pbx: (4)512 78 30
Fax: (4)512 75 94 e-mail: [email protected] www.suconel.com
100
Data Sheet No. PD10051-D
Series PVA33N
Microelectronic Power IC
HEXFET® Power MOSFET Photovoltaic Relay
Single-Pole, Normally-Open
IDOff/I DOff 25°C
Input Current (mA)
Series PVA33N
LED Forward Voltage Drop (Volts DC)
Ambient Temperature (°C)
Figure 5. Typical Normalized Off-State Leakage
Figure 6. Input Characteristics
(Current Controlled)
y
(µ S)
)
Delay Time
(∝
1000
Ton
Tdly
100
Toff
10
0
5
10
15
20
I LED (mA)
Figure 7.Typical Delay Times
Figure 8. Delay Time Definitions
Cra 53 # 50-51 Locales 207-208 Pbx: (4)512 78 30
Fax: (4)512 75 94 e-mail: [email protected] www.suconel.com
Data Sheet No. PD10051-D
Series PVA33N
Microelectronic Power IC
HEXFET® Power MOSFET Photovoltaic Relay
Single-Pole, Normally-Open
Series PVA33N
70
Typical Capacitance (pF)
Normalized Transfer Ratio
60
50
40
30
20
10
0
Ambient Temperature °C
0
10
20
30
VDD Drain to Drain Voltage
40
Figure 9. Typical Control Threshold and Transfer Ratio
Figure 10. Typical Output Capacitance
Wiring Diagram
Cra 53 # 50-51 Locales 207-208 Pbx: (4)512 78 30
Fax: (4)512 75 94 e-mail: [email protected] www.suconel.com
50
Data Sheet No. PD10051-D
Series PVA33N
Microelectronic Power IC
HEXFET® Power MOSFET Photovoltaic Relay
Single-Pole, Normally-Open
Series PVA33N
Case Outlines
01-2013 00 (MS-001AB)
01-2019 00
Cra 53 # 50-51 Locales 207-208 Pbx: (4)512 78 30
Fax: (4)512 75 94 e-mail: [email protected] www.suconel.com
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement