Zanussi | ZBF 760 | Installation and Operation Manual | Zanussi ZBF 760 Installation and Operation Manual

35668-6601
OPERATING AND INSTALLATION MANUAL
ZANUSSI
BUILT-IN OVEN
MODEL
ZBF 760
2
Important Safety Information
These warnings are provided in the interest of safety. You MUST read them
carefully before installing or using the appliance. Your safety is of
paramount importance. If you are unsure about any of the meanings of
these WARNINGS, contact the Customer Care Department
Installation
• The oven must be installed according to the
instructions supplied. Any electrical work must be
undertaken by a qualified electrician/competent
person.
• This oven is heavy and care must be taken when
moving it. Do not try to move the appliance by
pulling the door handle.
• Remove all packaging, both inside and outside
the oven, before using the appliance. After
installation, please dispose of the packaging with
due regard to safety and the environment.
• It is dangerous to alter the specifications or
modify the appliance in any way.
During Use
• This oven has been designed for cooking edible
foodstuffs only and must not be used for any
other purposes.
• Never line any part of the oven with aluminium
foil. Do not allow heatproof cooking material, e.g.
roasting bags, to come into contact with oven
elements.
• Never place plastic or any other material which
may melt in or on the oven.
• Do not place sealed cans or aerosols inside the
oven. They may explode if they are heated.
• Do not hang towels, dishcloths or clothes from
the oven or its handle. They are a safety hazard.
• Do not use this oven if it is in contact with water
and never operate it with wet hands.
• Always cook with the oven door closed.
• Use any oven proof cookware which will
withstand temperatures of 250°C.
• Take great care when heating fats and oils as
they will ignite if they become too hot.
• Always use oven gloves to remove and replace
food in the oven. Similarly always use oven
gloves to remove and replace the grill pan handle,
before and after grilling.
• Always remove the grill pan handle when grilling.
• Ensure that you support the grill pan when
removing it from the oven.
• Take care to follow the recommendations given
for tending the food when grilling.
• Always stand back from the oven when opening
the oven door, to allow any build-up of steam or
heat to release.
• Stand clear when opening the drop down oven
door. Do not allow it to fall open - support the
door using the door handle, until it is fully open.
• Ensure that the anti-tip oven shelves are installed
in the correct way (see instructions).
• Ensure that all control knobs are in the OFF
position when not in use.
• Do not leave cookware containing foodstuffs, e.g.
fat or oil in or on the oven in case it is
inadvertently switched ON.
• When using other electrical appliances, ensure the
cable does not come into contact with the hot
surfaces of the cooking appliance.
Child Safety
• This appliance is designed to be operated by
adults and children under supervision. Young
children must not be allowed to tamper with the
controls or play near or with the appliance.
• Accessible parts, especially around the grill area,
become hot when the cooker is in use. Children
should be kept away until it has cooled.
Maintenance and Cleaning
• Only clean this oven in accordance with the
instructions.
• The oven should be kept clean at all times. A
build-up of fats or other foodstuffs could result in
a fire, especially in the grill pan.
• Always allow the cooling fan to cool the oven
down before switching off at the electrical supply
prior to carrying out any cleaning or maintenance
work.
Service
• You must not attempt to repair the appliance
yourself. Repairs carried out by inexperienced
persons may cause injury or serious
malfunctioning. Refer to your local Zanussi
Service Force Centre. Always insist on genuine
Zanussi spare parts.
Disposal of an old appliance
• Make the appliance unusable, by cutting off the
cable, and remove any door catches, to prevent
small children being trapped inside
It is most important that this instruction book
should be retained with the appliance for future
reference. Should the appliance be sold or
transferred, always ensure that the book is left
with the appliance in order that the new owner
can get to know the functions of the appliance
and the relevant warnings.
3
Contents
For the User
For the Installer
Important safety
information
Technical Data
Page
3
Description
of the appliance
Page
5
Controls
Page
6
The Electronic Timer
Page
7
Before the First Use
Page
9
Using the Fan Oven
Page
9
Cooking Chart
Page 11
Defrosting
Page 13
Grilling
Page 14
Cleaning the Oven
Page 15
Page 20
Electrical Connection Page 20
Installation
Page 21
What happens if something
goes wrong
Page 18
Service and
Spare Parts
Page 19
Peace of Mind
for 24 months
Page 19
Guide to Use the instructions
The following symbols will be found in the text to
guide you throughout the Instructions:
Safety Instructions
☞
i
Step by step instructions for an
operation
Hints and Tips
Enviromental information
4
This appliance complies with the following
E.E.C. Directives:
* 73/23 - 90/683
(Low VoltageDirective);
* 93/68 (General Directives);
* 89/336 (Electromagnetical
Compatibility Directive) .
and subsequent modifications
Description of the Appliance
A
U
T
O
Thermostat
Control Light
°C
Thermostat
Control
Knob
0
50
Electronic
timer
Oven
Function
Control
Knob
100
MAX
TIMER
20
0
150
Grill Element
Oven Light
Fan
Grease Filter
Rating Plate
Removable
handle
Grill Pan Grid
Grill / Roasting pan
Anti-tip shelf (x 2)
5
Controls
OFF
Oven Function Control Knob
Oven Light - The oven light will be on without
any cooking function.
Defrost Setting - This setting is intended to
assist in thawing of frozen food (see page 13).
0
Oven
Light
Grill
Fan ducted cooking - This allows you to roast
or roast and bake simoultaneously using any
shelf, without flavour transference.
Grill - The heat comes only from the top
element.
Fan
Ducted
Cooking
Defrosting
50
OFF
Thermostat Control Knob
100
MAX
20
0
Turn the thermostat control knob clockwise to select
temperatures between 50°C and 250°C (MAX).
150
Electronic Timer
Cookpot
symbol
Minute minder
Cooking duration
End of cooking time
Manual function
Auto
symbol
A
U
T
O
TIMER
Time
setting
Cookpot symbol - This will be displayed when
a program is in operation.
A
U
T
O
Auto symbol - This will be displayed when the
oven has been programmed for automatic
operation.
Time setting knob
6
Programming
controls
The Electronic Timer
The electronic timer can indicate the time of day,
operate as a minute minder and automatically operate
the oven.
Before the oven can be operated, the time of day must
be set on the electronic timer.
Please note that this is a 24 hour clock. For example,
2pm is shown as 14:00.
In case of loss of power, all the settings (time of day,
set program or program in operation), will be
cancelled. When the power is restored, the numbers
on the display will flash, and the timer has to be reset.
☞ TO SET THE TIME OF DAY
Press buttons
and
, and at the same time turn
the time setting knob until the correct time of day is
displayed.
TIMER
☞ TO SET THE MINUTE MINDER
Press button
and at the same time turn the setting
time knob until the duration time is displayed
(maximum 23 hours, 59 minutes).
Our diagram shows the timer set for 45 minutes.
After a few seconds the time of day will show in the
display.
TIMER
To check the number of minutes remaining, press the
button. At the end of the timed period an alarm
will sound. To switch off the alarm press button
.
7
☞ MANUAL FUNCTION
Press button
to set the oven for manual function.
TIMER
☞ TO SET THE TIMER TO
SWITCH OFF ONLY
This is useful if you want to begin cooking
immediately but have the oven switch off
automatically.
1. Set the oven function control knob and the
thermostat control knob on the required settings.
2. Place food in the oven.
and, at the same time, turn the
3. Press button
TIMER
time setting knob until the required cooking
duration is displayed.
Our diagram shows the timer set for 1 hour 10
minutes.
At the end of the cooking time the oven will switch
off, an alarm will sound. To switch off the alarm
press button
.
☞ TO SET THE TIMER TO SWITCH
THE OVEN ON AND OFF
1. Ensure the clock is showing the right time of day.
2. Carry out steps 1, 2 and 3 as explained in "To set
the timer to switch off only".
3. Press button
and at the same time turn the
time setting knob until the end cooking time is
displayed.
Our diagram show the end cooking time set for 7pm.
☞ TO CANCEL A PROGRAMME
1. Press button
and, at the same time, turn the
time setting knob until the cooking duration is set
on "zero".
3. If the end cooking time has been set too, press
button
and at the same time turn the time
setting knob until the end cooking time is set on
"zero".
8
TIMER
Before the First Use
Remove all packaging, both inside and
outside the oven, before using the
appliance.
Before first use, the oven should be heated without
food. During this time, an unpleasant odour may be
emitted. This is quite normal.
☞
1. Set the electronic timer to manual
function.
2. Switch the oven function control knob to
fan cooking .
3. Set the thermostat control knob to MAX.
4. Open a window for ventilation.
5. Allow the oven to run empty for
approximately 45 minutes.
This procedure should be repeated with the grill
function for approximately 5-10 minutes.
Using the Fan Oven
The air inside the oven is heated by the element
around the fan situated behind the back panel. The
fan circulates hot air to maintain an even temperature
inside the oven.
The advantages of cooking with this function are:
✓Faster Preheating
✓Even Heating for Baking
The fan oven has uniform heating on all runner
positions. This means that batches of the same food
can be cooked in the oven at the same time. However,
the top shelf may brown slightly quicker that the
lower one.
This is quite usual. There is no mixing of flavours
between dishes.
As the fan oven quickly reaches temperature, it is not
usually necessary to preheat the oven although you
may find that you need to allow an extra 5-7 minutes
on cooking times. For recipes which require higher
temperatures, best results are achieved if the oven is
preheated first, e.g. bread, pastries, scones, souffles,
etc.
✓Lower Temperatures
Fan oven cooking generally requires lower
temperatures than conventional cooking.
Follow the temperatures recommended in the chart at
page. 11 or remember to reduce temperatures by
about 20-25°C for your own recipes which use
conventional cooking.
FO 0061
9
The oven has four shelf levels, and is supplied with
two anti-tip shelves.
It is important that these shelves are correctly
positioned as shown in the diagram.
4
3
☞ How to Use the Fan Oven
2
1. Turn the oven function control knob to .
2. Turn the thermostat control to the required temperature.
THINGS TO NOTE
• The oven light will come on when the oven
function control knob is set.
• The oven fan will operate continually during
cooking.
• The thermostat control light will remain on until
the correct temperature is reached. It will then
cycle on and off to show the temperature is being
maintained.
Condensation and steam
When food is heated it produces steam in the same
way as a boiling kettle. The oven is vented to allow
some of this steam to escape. However, always stand
back from the cooker when opening the oven door to
allow any build up of steam or heat to release.
If the steam comes into contact with a cool surface on
the outside of the oven, e.g. a trim, it will condense
and produce water droplets. This is quite normal and
is not caused by a fault on the oven.
To prevent discolouration, regularly wipe away
condensation and also soilage from surfaces.
The cooling fan
During cooking the cooling fan will cycle ON and
OFF. This is quite normal.
It may run on after the oven is switched off to keep
the controls cool.
NOTE
The action of the cooling fan will depend on how
long the oven has been used and at what temperature.
It may not switch in at all at lower temperature
settings nor run on where the oven has only been
used for a short time.
10
1
Cooking Chart
This chart is intended as a guide only. It may be necessary to increase or decrease the temperature to suit your
individual requirements. Only experience will enable you to determine the correct setting for your personal
requirements.
Food
Shelf
Cooking
Position Temp (°C)
Biscuits
Bread
Casseroles
Cakes:
Small and queen
Sponges
Madeira
Rich Fruit
Christmas
Meringues
Fish
Fruit Pies and Crumbles
Milk Puddings
Pastry:
Choux
Shortcrust
Flaky
Puff
Plate Tarts
Quiches/Flans
Scones
Roasting: Meat & Poultry
}
180-190
210-220
130-140
160-170
160-170
140-150
130-140
130-140
90-100
170-190
190-200
130-140
Shelf
positions
are not
critical but
ensure that
oven
shelves are
evenly
spaced
when more
than one is
190-200
used.
180
170-180
210-220
160-180
When roasting, ensure the meat is cooked thoroughly, use a meat thermometer if preferred to check the centre
temperature has reached the required temperature (see table below).
MEAT
TEMPERATURES
Beef
Rare - 60°C
Medium - 70°C
Well Done - 80°C
Pork
Well Done - 80°C
Lamb
Medium - 70°C
Well Done - 80°C
Cookware
Baking trays, oven dishes, etc. should not be placed
directly against the grid covering the fan at the back
of the oven, or placed on the oven base.
Do not use baking trays larger than 30 cm x 35 cm
(12 in x 14 in) as they will restrict the circulation of
heat and may affect performance.
The effects of dishes on cooking results
Dishes and tins vary in their thickness, conductivity,
colour, etc. which affects the way they transmit heat
to the food inside them:
A Aluminium, earthenware, oven glassware and
bright shiny utensils reduce cooking and
underneath browning.
B Enamelled cast iron, anodized aluminium,
aluminium with non-stick interior and coloured
exterior and dark, heavy utensils increase cooking
and underneath browning.
11
i Hints and Tips
Runner positions are not critical, but make sure the
shelves are evenly spread.
When cooking more than one dish in the fan oven,
place dishes centrally on the shelves rather than
several dishes on one shelf.
When the oven is full, you may need to allow slightly
longer cooking time.
A shelf may be placed on the floor of the oven. Place
dishes on a shelf in this position rather than on the
oven base, to allow air circulation around the food.
When the oven is full of the same food, e.g. equal
trays of small cakes or equal size victoria sandwich
cakes, then they will be cooked in the same time and
removed from the oven together. When different
sizes of trays or types of food, e.g. biscuits and cakes
are cooked, they will not necessarily be ready
together.
The fan oven can be used to heat foods through
without thawing first, e.g. fruit tarts, mince pies,
sausage rolls, and other small pastry items. Use a
temperature of 190-200°C and allow 20-40 minutes
(depending on the quantity of food in the oven).
The use of too high temperatures can cause uneven
browning. Check with the recommendations for oven
temperatures given in the cooking charts, but be
prepared to adjust the temperature by 10°C if
necessary. Remember to reduce temperatures by
about 20-25°C for your own conventional recipes.
When roasting do use the trivet in the meat tin. Fat
and meat juices will drain into the meat tin below and
can be used to make gravy. The trivet also prevents
splashes of fat from soiling the oven interior.
The meat tin should not be placed on a heated
hotplate as this may cause the enamel to crack.
12
Defrosting
i Hints and Tips
The oven fan operates without heat and circulates the
air, at room temperature, inside the oven. This
increases the speed of defrosting. However, please
note that the temperature of the kitchen will influence
the speed of defrosting.
This function is particularly suitable for delicate food
which could be damaged by heat, e.g. cream filled
gateaux, iced cakes, pastries, bread and other yeast
products.
• Cover food with a lid, aluminium foil or plastic
film to prevent drying out during defrosting.
• ALWAYS COOK THOROUGHLY
IMMEDIATELY AFTER THAWING.
• Frozen food should be placed in a single layer
when ever possible and turned over half way
through the defrosting process.
• Only joints of meat and poultry up to 2 kg. (4 lb.)
are suitable for defrosting in this way.
☞ How to Use Defrosting
1. Turn the oven function control knob to
.
2. Ensure the thermostat control knob is in the OFF
position.
Refer to the following table for approximate
defrosting times.
Defrosting time
(Mins)
Standing time
(Mins)
Chicken 1000 g.
100-140
20-30
Place the chicken on an inverted
saucer on a large plate. Defrost open
and turn at half time or defrost
covered with foil. Remove giblets
as soon as possible.
Meat 1000 g.
100-140
20-30
Defrost open and turn at
half time or cover with foil
Meat 500 g.
90-120
20-30
As above
Trout 150 g.
23-35
10-15
Defrost open
Strawberries 300 g.
30-40
10-20
Defrost open
Butter 250 g.
30-40
10-15
Defrost open
Cream 2 x 200 g.
80-100
10-15
Defrost open (cream is
easy to whip even if parts
of it are still slightly frozen)
60
60
Food
Cake 1400 g.
Notes
Defrost open
The times quoted in the chart should be used as a guide only, as the speed of defrosting will depend on the kitchen
temperature. For example, the colder the ambient temperature, the longer the defrosting time.
13
Grilling
Grilling must be carried out with the oven
door closed. The grill pan handle must be
removed from the pan.
☞ How to Use the Grill
1. Turn the oven control function knob on
COOKING CHART
Cooking time depends on the thickness of the meat
and not on its weight.
Type of food
.
2. Turn the thermostat control knob on the required
temperature.
3. Adjust the grid and grill pan runner position to
allow for different thicknesses of food. Position
the food close to the element for faster cooking
and further away for more gentle cooking.
Preheat the grill on a full setting for a few minutes
before sealing steaks or toasting. Adjust the heat
setting and the shelf as necessary, during cooking
Bacon rashers
2-5
Chicken joints
15 - 20
Gammon rashers
5-8
Lamb chops
6 - 12
Pork chops
10 - 15
Sausages (turning as required)
10 - 12
Steaks (average thickness)
Rare
3-6
Medium 6 - 10
Well done 8 - 12
Toast
1 - 1 1 /2
During cooking, the cooling fan and the thermostat
control light will operate in the same way as
described for the fan oven function.
i Hints and Tips
- Most foods should be placed on the grid in the grill
pan to allow maximum circulation of air to lift the
food out of the fats and juices. Food such as fish,
liver and kidneys may be placed directly on the grill
pan, if preferred
- Food should be thoroughly dried before grilling to
minimise splashing. Brush lean meats and fish lightly
with a little oil or melted butter to keep them moist
during cooking
- Accompaniments such as tomatoes and mushrooms
may be placed underneath the grid when grilling
meats
- When toasting bread, we suggest that the top runner
position is used with the grid in its 'high' position
- The food should be turned over during cooking, as
required.
The grill element is controlled by the thermostat.
During cooking, the grill cycles on and off to prevent
overheating.
14
Mins per side
OI L
Cleaning the Oven
Before cleaning always allow the cooling
fan to cool the cooker down before
switching off at the electricity supply.
The oven should be kept clean at all times.
A build-up of fats or other foodstuffs could
result in a fire, especially in the grill pan.
Cleaning materials
Before using any cleaning materials on your oven,
check that they are suitable and that their use is
recommended by the manufacturer.
Cleaners that contain bleach should NOT be used as
they may dull the surface finishes. Harsh abrasives
should also be avoided.
External cleaning
Regularly wipe over the control panel, oven door and
door seal using a soft cloth well wrung out in warm
water to which a little liquid detergent has been
added.
To prevent damaging or weakening the
door glass panels avoid the use of the
following:
• Household detergent and bleaches
• Impegnated pads unsuitable for nonstick saucepans
• Brillo/Ajax pads or steel wool pads
• Chemical oven pads or aerosols
• Rust removers
• Bath/Sink stain removers
Clean the outer and inner door glass using warm
soapy water. Should the inner door glass become
heavily soiled it is recommended that a cleaning
product such as Hob Brite is used.
DO NOT clean the oven door while the
glass panels are warm. If this precaution is
not observed the glass panel may shatter.
If the door glass panel becomes chipped or
has deep scratches, the glass will be
weakened and must be replaced to prevent
the possibility of the panel shattering.
Contact your local Service Centre who will
be pleased to advise further.
15
Oven Cavity
The enamelled oven cavity is best cleaned whilst the
oven is still warm.
Wipe the oven over with a soft cloth soaked in warm
soapy water after each use. From time to time it will
be necessary to do a more thorough cleaning, using a
proprietary oven cleaner.
If the soilage has become set, after the oven has
cooled down, the following process will help to
soften the splatters to help make cleaning easier.
the grill/ meat pan on the oven shelf
☞ 1. Place
positioned in the lowest runner.
2. Add a few drops of wasing-up liquid to the
pan and fill to about 12 mm. with boiling
water from the kettle.
3. Close the oven door, turn the oven function
and set the thermostat
knob on fan oven
knob on 50°C.
4. After 15 minutes, turn off the thermostat
and allow the fan oven to continue without
heat for a further 5 minutes, when the
temperature of the water will have cooled
down.
5. Carefully remove the pan of water from the
oven and use normal oven cleaners to clean
away soil residues.
6. Leave a little of soapy water to soak into
any burned on spillage on the floor of the
oven for a longer time if necessary.
Oven Shelves
To clean the oven shelves, soak in warm soapy water
and remove stubborn marks with a well wetted soap
impregnated pad. Rinse well and dry with a soft
cloth.
Grease Filter
To prevent a build-up of fats on the fan impellor, the
grease filter must be fitted by clipping it over the
vents in the back panel. Do not use abrasive materials
to clean the seal. The grease filter is dishwasher
proof.
To clean the grease filter
When cooking is completed and the oven has cooled
down, remove the filter by pushing the protruding
tongue on the filter upward, and wash carefully.
Remember to refit the filter before using the oven
again.
16
FO 0018
Replacing The Oven Light
If the oven bulb needs replacing, it must comply with
the following specifications:
- Electric power: 15W,
- Electric rate: 220-240 V (50 Hz),
- Resistant to temperatures of 300°C,
- Connection type: E14.
These bulbs are available from your local Zanussi
Force Service Centre.
To replace the faulty bulb:
FO 0287
1. Ensure the oven is isolated from the electrical
supply.
2. Push in and turn the glass cover anticlockwise.
3. Remove the faulty bulb and replace with the new
one.
4. Refit the glass cover.
5. Restore the electrical supply.
17
If something goes wrong
If the appliance is not working correctly, please carry out the following checks, before contacting your local
Zanussi Service Centre.
SYMPTOM
■ The oven does not come on
SOLUTION
◆ Check the oven is in manual operation and that
both a cooking function and temperature have been
selected.
◆ Check the appliance is wired in properly, and the
socket switch or the switch from the mains supply to
the oven are ON.
■ The oven temperature light does not come on
◆ Select a temperature with the thermostat control
knob
◆ Select a function with the oven function control
knob.
■ The oven light does not come on
◆ Select a function with the oven function control
knob
◆ Check the light bulb, and replace it if necessary
(see "Cleaning the Oven")
■ It takes too much time to finish the dishes, or they
are cooked too fast.
◆ The temperature may need adjusting
◆ Refer to the contents of this booklet, especially to
the chapter “Using the Oven”.
■ Steam and condensation settle on the food and the
oven cavity.
◆ Leave dishes inside the oven no longer than 15-20
minutes after the cooking is completed. See page 10
■ The timer does not work
◆ Check the instructions for the timer.
■ The oven fan is noisy
◆ Check the grease filter is correctly fitted.
◆ Check that shelves and bakeware are not vibrating
in contact with the oven back panel.
If after all these checks, the oven still does not work,
contact your local Zanussi Service Force Centre
quoting your model and serial number, which can be
found on the rating plate.
Please note that it will be necessary to provide proof
of purchase for any in-guarantee service calls.
In-guarantee customers should ensure that the
above checks have been made as the engineer will
make a charge if the fault is not a mechanical or
electrical breakdown.
18
Service and Spare Parts
If you require spare parts or an engineer contact your
local Service Force Centre by telephoning:
0990-929929
For further details, please see the accompanying
Customer Care Booklet.
CUSTOMER CARE DEPARTMENT
For general enquiries concerning your Zanussi
appliance, contact our Customer Relations
Department by letter or telephone as follows:
Customer Care Department
Zanussi House
Hambridge Rd.
Newbury
Berks RG14 5EP
Tel: 01635 - 521313
Peace of Mind for Twenty Four
Months
ZANUSSI GUARANTEE CONDITIONS
EXCLUSIONS
This guarantee is in addition to your statutory
and other legal rights
This guarantee does not cover:
We, Zanussi Ltd., undertake that, if, within
twenty four months of the date of the purchase,
this ZANUSSI appliance or any part thereof is
proved to be defective by reason only of faulty
workmanship or materials, we will, at our
option, repair or replace the same FREE OF
ANY CHARGE for labour, materials or
carriage on condition that:
* The appliance has been correctly installed
and used on the electricity supply stated on
the rating plate.
* The appliance has been used for normal
domestic purposes only, and in accordance
with the manufacturer's operating and
maintenance instructions.
* The appliance has not been serviced,
maintained, repaired, taken apart or
tampered with by any person not authorised
by us.
All service work under this guarantee must be
undertaken by a Zanussi Service Force Centre.
Home visits are made between 8.30 am and
5.30 pm Monday to Friday.
Visits may be available outside these hours in
which case a premium will be charged.
Any appliance or defective part replaced shall
become our property.
* Damage or calls resulting from
transportation, improper use or neglect, the
replacement of any light bulbs or removable
parts of glass or plastic.
* Costs incurred for calls to put right machines
improperly installed or calls to machines
outside the UK and the Republic of Ireland.
* Appliances found to be in use within a
commercial or similar environment, plus
those which are subject to rental agreements.
* Products of Zanussi manufacture which are
NOT marketed by Zanussi Ltd.
* EEC Countries - The standard guarantee is
applicable but subject to the owner's
responsibility and cost to ensure the
appliance meets the standards set by the
country to which the product is taken. The
Zanussi Company in the country concerned
will be pleased to advise further. Sight of
your purchase receipt will be required by
them.
19
Technical Data
DIMENSIONS
OF RECESS
Height
Width
Depth
580 mm.
560-570 mm.
550 mm.
DIMENSIONS
OF THE
OVEN CAVITY
Height
Width
Depth
Oven capacity
320 mm.
420 mm.
390 mm.
53.2 litres
Heating elements rating
Oven element
Grill element
Convenction Fan
Oven Light
Cooling Fan
Total Rating
2.5 kW
1.8 kW
30 W
15 W
25 W
2.570 kW
Electrical Connection
We strongly recommend that all operations
for the installation of your cooker be carried
out by QUALIFIED PERSONNEL to the
relevant British Standards.
The oven is designed to be connected to 240V (50Hz)
electricity supply.
The oven has an easily accessible terminal block
which is marked as follows:
Letter L
Letter N
-
-
Live terminal
Neutral terminal
Earth terminal
THIS APPLIANCE MUST BE EARTHED
The cable used to connect the oven to the electrical
supply must comply to the specifications given
below.
For Uk use only
Models
Rating
Cable cross
section mm2 and
Type of the cable
6 mm2
6242 Y
Fuse
min.
15 A
For Europe use only
Rating
ZBF 760 2570 W
20
The switch must not break the yellow and green earth
cable at any point.
Important
After installation and connecting, the cable must be
placed so that it cannot at any point reach a temperature of more than 50°C above the ambient temperature.
Before the appliance is connected, check that the
main fuse and the domestic installation can support
the load; and that the power supply is properly
earthed.
The manufacturer disclaims any responsibility should
these safety measures not be carried out.
ZBF 760 2570 W
Models
It is necessary that you install a double pole switch
between the appliance and the electricity supply
(mains), with a minimum gap of 3mm between the
switch contacts and of a type suitable for the required
load in compliance with the current rules.
Cable cross
section mm2 and
Type of the cable
2,5 mm2
Ho5 RR-F
Fuse
min.
13 A
Installation
The oven must be installed according to the
instructions supplied. Any electrical work
must be undertaken by a qualified
electrician/competent person, in accordance
with existing rules and regulations.
It is dangerous to alter the specifications or
modify the appliance in any way.
Please ensure that when the appliance is installed it is
easily accessible for the engineer in the event of a
breakdown.
BUILDING IN
The surround or cabinet into which the oven will be
built must comply with these specifications:
- the dimensions must be as shown in the relevant
diagrams;
- the materials must withstand a temperature increase
of at least 60°C above ambient;
- proper arrangements must be made of a continuous
supply of air to the oven to prevent the oven
overheating.
FO 0374
Dimensions of the appliance and recess required are
given in the relevant diagrams.
FO 0381
Securing The Oven To The Cabinet
1. Fit the appliance into the cabinet recess,
2. Open the oven door
3. Secure the oven to the kitchen cabinet with four
wood screws, which fit the holes provided in the
oven frame.
FO 0039
21
Download PDF

advertising