Mazda MX-5 Miata 1997 vehicle User manual

1997 Mazda MX-5 Miata
1997 MAZDA MX-5 Miata
1997 MAZDA
MX-5 Miata
BUZZERS, RELAYS & TIMERS
BUZZERS, RELAYS & TIMERS
Component
Component Location
A/C Relay
In right front of engine compartment, near radiator. See Fig. 1 .
Condenser Fan Relay
In right front of engine compartment, near radiator. See Fig. 1 .
Cooling Fan Relay
In main fuse/relay block.
Flasher Unit
Behind left side of dash. See Fig. 2 .
Fuel Pump Relay
Under left side of dash. See Fig. 2 .
Headlamp Relay
On left rear corner of front inner fender panel. See Fig. 1 .
Horn Relay
On left rear corner of front inner fender panel. See Fig. 1 .
INT Relay
Integral with windshield wiper & washer switch.
Main Relay
In left rear corner of engine compartment, in main fuse/relay block.
Power Antenna Relay
In right rear of vehicle, attached to power antenna.
Rear Window Defogger
In center rear of trunk compartment. See Fig. 3 .
Relay
Retractable Headlamp Relay
Behind left side of dash.
In left rear corner of engine compartment, on inner fender panel. See Fig.
TNS Relay
1.
Warning Unit
Behind left side of dash. See Fig. 2 .
CIRCUIT PROTECTION DEVICES
CIRCUIT PROTECTION DEVICES
Component
Component Location
Fuse Block (Front)
Behind left side of dash. See Fig. 2 .
Fuse Block (Rear)
On right rear side of luggage compartment. See Fig. 3 .
Main Fuse Block
On right rear corner of engine compartment, near firewall. See Fig. 1 .
CONTROL UNITS
CONTROL UNITS
Component
ABS Control Module
ABS Control Unit
Cruise Control Module
Daytime Running Lamp (DRL) Control Module
Engine Control Module (ECM)
Component Location
Behind passenger's seat. See Fig. 3 .
In right rear corner of engine compartment.
Under left side of dash above fuse block. See Fig. 2 .
On bracket, behind left side of dash. See Fig. 2 .
Behind passenger's seat. See Fig. 3 .
Microsoft
Sunday, July 05, 2009 1:54:09
1:54:00 PM
Page 1
© 2005 Mitchell Repair Information Company, LLC.
1997 Mazda MX-5 Miata
1997 MAZDA MX-5 Miata
Key Interlock Unit
SAS Unit
Transmission Control Module (TCM)
Behind left side of dash. See Fig. 2 .
Behind center of dash. See Fig. 2 .
Under left side of dash, near fuse block. See Fig. 2 .
MOTORS
MOTORS
Component
Blower Motor
Condenser Fan Motor
Cooling Fan Motor
Cruise Control Actuator
Fuel Pump
Power Antenna Motor
Retractable Headlamp Actuators
Shift Lock Actuator
Windshield Washer Motor
Windshield Wiper Motor
Component Location
Under right side of dash. See Fig. 2 .
In front of engine compartment.
In front of engine compartment.
On left side of engine compartment.
In fuel tank.
In right front of trunk.
Behind respective headlamp.
Under center console, on base of gear selector.
On bottom of washer fluid reservoir.
On right side of firewall.
SENDING UNITS & SENSORS
SENDING UNITS & SENSORS
Component
ABS Wheel Speed Sensor (Left Front)
ABS Wheel Speed Sensor (Left Rear)
ABS Wheel Speed Sensor (Right Front)
ABS Wheel Speed Sensor (Right Rear)
Brake Fluid Level Sensor
Camshaft Position Sensor
Crankshaft Position Sensor
EGR Boost Sensor
EGR Valve Position Sensor
EGR Valve Position Sensor
Engine Coolant Temperature Sensor
Fuel Gauge Sender Unit
Heated Oxygen Sensor (Front)
Heated Oxygen Sensor (Rear)
Input/Turbine Speed Sensor
Mass Air Flow Sensor
Throttle Position (TP) Sensor
Transmission Fluid Temperature Sensor
Component Location
On back of left front wheel spindle assembly. See Fig. 1 .
On back of left rear wheel hub assembly. See Fig. 3 .
On back of right front wheel spindle assembly. See Fig. 1 .
On back of right rear wheel hub assembly. See Fig. 3 .
In brake fluid reservoir. See Fig. 1 .
In center rear of engine compartment. See Fig. 1 .
On front of engine.
On right side of engine compartment.
On right side center, rear of engine compartment.
On right side center, rear of engine compartment. See Fig. 1 .
On rear of engine. See Fig. 1 .
In fuel tank.
In rear of engine compartment. See Fig. 1 .
On underside of vehicle, on exhaust pipe.
On left side of transmission.
On top of air filter housing. See Fig. 1 .
On side of throttle body. See Fig. 1 .
On left side of transmission.
Microsoft
Sunday, July 05, 2009 1:54:00 PM
Page 2
© 2005 Mitchell Repair Information Company, LLC.
1997 Mazda MX-5 Miata
1997 MAZDA MX-5 Miata
Vehicle Speed Sensor (VSS)
Water Temperature Sender Unit
Washer Fluid Level Sensor
On speedometer assembly.
On center of engine. See Fig. 1 .
On washer fluid reservoir. See Fig. 1 .
SOLENOIDS & SOLENOID VALVES
SOLENOIDS & SOLENOID VALVES
Component
AT Interlock Solenoid
EC-AT Solenoid Valve
EGR Solenoid Valve (Vacuum)
EGR Solenoid Valve (Vent)
Fourth Gear Solenoid Valve
Idle Air Control Valve
PRC Solenoid Valve
Purge Solenoid Valve
Component Location
In steering column, near ignition switch. See Fig. 2 .
On left side of transmission.
On right side of engine compartment. See Fig. 1 .
On right side of engine compartment. See Fig. 1 .
On left side of transmission.
On right side, front of engine compartment. See Fig. 1 .
On right side, front of engine. See Fig. 1 .
On right strut tower. See Fig. 1 .
SWITCHES
SWITCHES
Component
Back-Up Lamp Switch (M/T)
Brake Switch
Buckle Switch
Clutch Switch (M/T)
Hold Switch
Key Reminder Switch
Neutral Switch (M/T)
Oil Pressure Switch
"P" Range Switch
Parking Brake Switch
Power Steering Pressure Switch
Refrigerant Pressure Switch
Starter Interlock Switch (M/T)
Thermoswitch
Transmission Range Switch
Component Location
On right side of transmission. See Fig. 1 .
On bracket, above brake pedal. See Fig. 2 .
On driver side seat belt buckle. See Fig. 3 .
On bracket, above clutch pedal. See Fig. 2 .
Under right side of center console.
In steering column, near ignition switch.
On right side of transmission. See Fig. 1 .
On right side of engine. See Fig. 1 .
Under center console, on base of gear selector.
On base of parking brake lever. See Fig. 4 .
On power steering pump assembly.
In front of engine compartment, near radiator support. See Fig. 1 .
On bracket, above clutch pedal. See Fig. 2 .
Under right side of dash.
On left side of transmission.
MISCELLANEOUS
MISCELLANEOUS
Component
Component Location
Microsoft
Sunday, July 05, 2009 1:54:00 PM
Page 3
© 2005 Mitchell Repair Information Company, LLC.
1997 Mazda MX-5 Miata
1997 MAZDA MX-5 Miata
Data Link Connector (DLC)
Data Link Connector (DLC) No. 2
Ignition Coil
Power Connector
Resistor (A/C-Heater)
On left inner fender panel. See Fig. 1 .
Under left side, center of dash, near console. See Fig. 4 .
On center rear of engine compartment.
On left inner fender panel.
Under right side of dash. See Fig. 2 .
CONNECTORS
CONNECTORS
Component
X-06 (White, 1 Pin)
X-07 (White, 1 Pin)
X-08 (White, 3 Pin)
X-09 (Green, 4 Pin)
X-10 (White, 6 Pin)
X-12 (A/T) (White, 4 Pin)
X-12 (M/T) (Black, 1 Pin)
X-13 (Black, 10 Pin)
X-14 (Black, 8 Pin)
X-15 (Gray, 4 Pin)
X-16 (White, 20 Pin)
X-17 (White, 20 Pin)
X-18 (White, 24 Pin)
X-19 (White, 20 Pin)
X-20 (White, 20 Pin)
X-21 (White, 24 Pin)
X-22 (White, 2 Pin)
X-23 (White, 16 Pin)
X-24 (White, 12 Pin)
X-25 (White, 12 Pin)
X-26 (White, 4 Pin)
X-27 (White, 3 Pin)
X-28 (White, 4 Pin)
X-29 (White, 3 Pin)
X-30 (White, 8 Pin)
X-31 (White, 2 Pin)
X-36 (White, 2 Pin)
Component Location
At right rear of engine compartment.
At right rear of engine compartment.
At right rear of engine compartment.
At right rear of engine compartment.
At right rear of engine compartment.
At right rear of engine compartment. See Fig. 1 .
At right rear of engine compartment. See Fig. 1 .
At right rear of engine compartment. See Fig. 1 .
At right rear of engine. See Fig. 1 .
At right rear of engine. See Fig. 1 .
At right kick panel. See Fig. 2 .
At right kick panel. See Fig. 2 .
At right kick panel. See Fig. 2 .
At right kick panel. See Fig. 2 .
At left side of dash. See Fig. 4 .
At left side of dash. See Fig. 4 .
At left side of dash. See Fig. 4 .
At right side of dash. See Fig. 4 .
At left kick panel. See Fig. 2 .
At left kick panel. See Fig. 2 .
At left kick panel. See Fig. 2 .
At left kick panel. See Fig. 2 .
At right kick panel. See Fig. 2 .
At right kick panel. See Fig. 2 .
Forward of right rear wheelwell. See Fig. 3 .
At right front corner of trunk.
At left kick panel.
GROUNDS
GROUNDS
Microsoft
Sunday, July 05, 2009 1:54:00 PM
Page 4
© 2005 Mitchell Repair Information Company, LLC.
1997 Mazda MX-5 Miata
1997 MAZDA MX-5 Miata
Component
G1
G2
G3
G4
G5
G6
G7
G8
G9
G10
G11
Component Location
At left rear corner of engine compartment. See Fig. 1 .
At left side of dash. See Fig. 2 .
At front of engine compartment. See Fig. 1 .
At right upper end of dash. See Fig. 2 .
At right upper end of dash. See Fig. 2 .
At right rear corner of engine compartment. See Fig. 1 .
At right end of dash. See Fig. 4 .
At left end of dash. See Fig. 4 .
At center rear of trunk. See Fig. 3 .
Above left rear wheelwell. See Fig. 3 .
Forward of right rear wheelwell. See Fig. 3 .
COMPONENT LOCATION GRAPHICS
NOTE:
Figures may show multiple component locations. Refer to appropriate table for
proper figure references.
Microsoft
Sunday, July 05, 2009 1:54:00 PM
Page 5
© 2005 Mitchell Repair Information Company, LLC.
1997 Mazda MX-5 Miata
1997 MAZDA MX-5 Miata
Fig. 1: Engine Compartment
Microsoft
Sunday, July 05, 2009 1:54:00 PM
Page 6
© 2005 Mitchell Repair Information Company, LLC.
1997 Mazda MX-5 Miata
1997 MAZDA MX-5 Miata
Fig. 2: Dash
Microsoft
Sunday, July 05, 2009 1:54:00 PM
Page 7
© 2005 Mitchell Repair Information Company, LLC.
1997 Mazda MX-5 Miata
1997 MAZDA MX-5 Miata
Fig. 3: Left Side Of Vehicle
Microsoft
Sunday, July 05, 2009 1:54:00 PM
Page 8
© 2005 Mitchell Repair Information Company, LLC.
1997 Mazda MX-5 Miata
1997 MAZDA MX-5 Miata
Fig. 4: Dash
Microsoft
Sunday, July 05, 2009 1:54:00 PM
Page 9
© 2005 Mitchell Repair Information Company, LLC.
">