CANADIAN PRODUCT CATALOG
CANADIAN PRODUCT CATALOG
Quality Products for
Air Conditioning, Refrigeration & Heating
Table of Contents
Total System Protection
1-3
Coil Cleaners and Sprayers
4-10
Indoor Air Quality & ClenAir by Nu-Calgon
11-14
Gas Leak Detectors
15
Refrigeration Oil & Vacuum Pump Oil
16-17
Aerosol Products
18-20
Specialty Products
21
Insulation Products
22-23
Glycol & Closed Systems
24-25
Water Treatment
26-29
Plumbing Products / Water Filtration Maintenance
30
Water Filtration
31-32
Nu-Plus by Everpure
33-37
READY
SET
Compatible with All Refrigerants & Oils
Easiest to Install
SEAL!
Permanent
Takes seconds to inject.
No injection hose or caulk gun needed.
Concentrated formula means
less material in the system.
Total System Protection
Total System Protection
The Next Generation of Refrigerant Leak Sealant
NEW
EasySeal Direct Inject
EasySeal Direct Inject is a new generation of sealants. Its patent pending injection method
makes it easier to install than other sealants. With this new injection system, pumping down
the unit is a thing of the past. EasySeal Direct Inject works with all refrigerants and oils.
Concentrated formula means less material in system. It is perfect for split systems, heat pumps,
microchannel coils, packaged units, and mini splits.
EasySeal Direct Inject
4050-08
A/C EasySeal
A/C EasySeal prevents and seals refrigerant leaks in residential and light commercial ACR systems. It is perfect for those hard-to-find
and expensive-to-fix leaks and works with all refrigerants (except ammonia). It is easily installed with the reusable piercing valve and hose.
A/C EasySeal circulates with the system’s refrigerant, and if a leak should occur, it will quickly and permanently seal the leak and prevent the
system from losing refrigerant and shutting down.
A/C EasySeal
A/C EasySeal-SS
“2+1” Display Pack
A/C EasySeal-XL
A/C Piercing Valve and Hose
3 ounce pressurized can - treats 1.5 to 5 ton systems
1.25 ounce pressurized can - treats fractional to 1.5 ton systems
2 cans of A/C EasySeal and an A/C Piercing Valve and Hose
Treats systems with refrigerant charge of 125 lbs. – 250 lbs.
4050-06
4050-01
4050-02
4050-10
4051-99
A/C EasyDry
This product is a quick and simple way to prevent and eliminate moisture in a system.
A/C EasyDry contains a dehydrating agent that converts system moisture into a natural
organic material that is compatible with and mixes with the lubricant. It is great for preventing
acid formation which is caused by moisture in a system and works with all refrigerants (except
ammonia). Each can will treat up to a 5 ton system and is easily installed with the reusable
piercing valve and hose.
3 ounce pressurized can
A/C Piercing Valve and Hose
4051-06
4051-99
Visitus
usatatwww.nucalgon.com
www.nucalgon.comor
orcall
call1-800-554-5499
1-800-554-5499
Visit
11
Total System Protection
Total System Protection
Endorsed by York®, Goodman®,
Nordyne®, Coleman®, and Daikin®
Rx11-flush®
R x11-flush is a unique solvent engineered specifically for flushing refrigeration and air conditioning systems. R x11-flush is ozone-safe,
non-toxic, and non-flammable. Used exactly like the old R-11 flushing process, its patented HFC based solvent formulation is powerful
enough to flush away sludge, carbon residues, oils, acids, water and other particulate. R x11-flush is ideal for system flushing after
burnouts, during retrofits and for flushing line sets for R-410A conversions. Rx11-flush has been the industry’s standard for over a
decade and contractors agree, it’s the best flush for R-410A retrofits and after compressor burnouts.
Rx11-flush Starter Kit
1 lb. canister
2+1 Display Pack
2 lb. canister
13 lb. canister
26 lb. canister
Contains a 1 lb. canister, Rx11-flush Gun and Hose, and Injection Valve
Recommended for a 3-4 ton system
Contains one Injection Valve and two 2 lb. canisters
Recommended for a 5-7 ton system
Recommended for up to 50 ton system
Recommended for systems over 50 tons
4300-08
4300-09
4300-10
4300-11
4300-15
4300-26
Rx11-flush® Liquid
R x11-flush Liquid is a new and improved chemistry that is the next generation in
flushing technology. It remains a constant boiling solvent and is now stronger, faster
acting and dissolves more oil, moisture and contaminants than any other flush. It is
ideal for line sets, burnouts and other flushing requirements.
19.5 ounce can
Rx11-flush Liquid Starter Kit
4300-30
4300-38
Rx11-flush® Accessories
The R x11-flush product family also includes various support tools. This includes the
Injection Valve for hooking up to a charging hose for flushing and the Flushing Tool
for facilitating line set flushing. In addition, the R x11-flush Gun with a built-in flushing
attachment and the R x11-flush Hose (24˝) are available.
Flushing Tool
Rx11-flush Gun
Rx11-flush Hose (24˝)
Injection Valve
4300-50
4300-51
4300-52
4300-89
(Injection Valve fits Pneu-flush® and pressurized Rx-Acid Scavenger® as well)
2
Total System Protection
Total System Protection
Rx-Acid Scavenger®
The most effective way to neutralize or “scavenge” acid in refrigeration, air conditioning systems. It is perfect for use after burnouts or
during normal on-going system maintenance. In addition, R x-Acid Scavenger can be used with all lubricants: mineral, alkylbenzene
and polyol ester. Now available in a pressurized can for easy injection into charged systems or hermetically sealed systems.
2 fluid ounce unpressurized bottle
3.8 ounce pressurized can
Injection Valve
4301-02
4301-05
4300-89
(Injection Valve fits Rx11-flush® and Pneu-flush® as well)
Phase III® Refrigeration Oil Acid Test Kit
Formulated for use with POEs as well as mineral oils and alkylbenzene. An inexpensive,
disposable test kit that provides proof-positive that acid level in refrigeration oil is either safe
or unsafe. Phase separation makes it easy to see change in color of acid indicator (even if a
leak detection dye has been added to the oil). Just two bottles to work with, it is simple, safe,
accurate, and small enough that you can carry several in your tool box.
1 each
4320-W8
How to Test Oil with Phase III®
1.Pour the solution from the small bottle into
the large bottle. The bottom layer of this
mixture will be purple.
2.Completely fill the small bottle with oil from
the unit being tested. Do this immediately
after the oil is removed from the crankcase
since exposure to air will contaminate the oil
and give a false test result.
4. Wait two to three minutes. A phase separation
will develop as the oil rises to the top of the
mixture and an aqueous layer forms on the
bottom.
5.If the bottom layer:
Stays purple- the oil is satisfactory.
Turns light pink or loses color completelythe oil is contaminated.
3. Pour the oil into the large bottle and shake well.
Good Oil
Bad Oil
A/C Re-New
A/C Re-New is a highly formulated product that has established an outstanding track record
enhancing the performance of air conditioning and refrigeration systems. A/C Re-New aids
with sticky valves, quiets noisy compressors, reduces energy consumption by lowering
starting and running amps, and improves heat transfer in the evaporator and condenser. It’s
great for new and old systems.
1 quart can
4 fluid ounce can
A/C Re-New Injector Tool
4057-54
4057-55
4057-99
Visit us at www.nucalgon.com or call 1-800-554-5499
3
Coil Cleaner Selection Guide
Coil Cleaner Selection Guide
Nu-Calgon Coil Cleaners
Found on Pages 6-7
Nu-Brite®
Foam-Brite® Alka-Brite® Plus
Cal-Brite®
CalClean®
Special HD
CalClean®
•
•
•
•
•
•
•
•
•
TriClean™ 2x Nu-Solve™ NR Tri-Pow’r® HD
EQUIPMENT USED ON
•
Condenser Coils
•
•
•
Evaporator Coils
•
Permanent Filters
•
•
•
•
•
Electronic Air Filters
•
Small Condenser Coils
•
•
•
Small Evaporator Coils
•
Fan Blades, Grilles, Etc.
•
Microchannel Coils
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
FORMULATED TO REMOVE
Greasy Dirt & Oil
•
•
•
Cooking Grease
•
•
•
Lint, Dust, Dirt & Grime
•
•
•
•
•
•
•
•
•
•
•
Tobacco Tars
Oxide (Corrosion) Deposits
•
•
•
•
Cottonwood/ Bugs
•
•
•
•
•
FEATURES & BENEFITS
Product Type
Alkaline Alkaline Alkaline
Aerosol Liquid
Acidic
•
•
•
•
•
Brightening
•
•
•
•
•
Degreasing
•
•
•
•
•
Foaming
Alkaline Alkaline Alkaline Alkaline Alkaline
Aerosol Liquid
•
•
•
•
•
•
•
•*
•*
•*
•
•
•
•
•
Disinfectant
Non-Rinsing (Evaporators)
•
Non-Rinsing (Condensers)
Biodegradable
•
•
USDA Authorized
•
•
•
•
•
•
•
•
EPA Registered
NSF Registered
•
•
•
•
•
•
* Dilution ratios for no rinse applications: Tri-Pow’r HD = 10:1, Special HD CalClean = 40:1, Liquid CalClean = 10:1 (Aerosol CalClean must be rinsed.)
4
Coil Cleaner Selection Guide
Coil Cleaner Selection Guide
Nu-Calgon Coil Cleaners
Found on Pages 8-9
Evap-Powl’r®-C
Cal-Green™
Evap-Green™
Green Clean
Evap-Foam® Blackhawk®
Nu-Blast®
Cal-Blast®
EQUIPMENT USED ON
•
Condenser Coils
Evaporator Coils
•
Permanent Filters
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
Electronic Air Filters
•
Small Condenser Coils
Small Evaporator Coils
•
Fan Blades, Grilles, Etc.
Microchannel Coils
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
Alkaline
Alkaline
Solvent
Solvent
•
•
•
•
•
•
FORMULATED TO REMOVE
Greasy Dirt & Oil
•
•
•
•
Cooking Grease
Lint, Dust, Dirt & Grime
•
•
•
•
Tobacco Tars
Oxide (Corrosion) Deposits
Cottonwood/ Bugs
FEATURES & BENEFITS
Product Type
Alkaline
Alkaline
Alkaline
Alkaline
Foaming
Brightening
•
Degreasing
•
Disinfectant
Non-Rinsing (Evaporators)
•
•
•
•
Non-Rinsing (Condensers)
Biodegradable
•
USDA Authorized
•
•
•
•
•
•
•
•
EPA Registered
NSF Registered
Visit us at www.nucalgon.com or call 1-800-554-5499
5
Coil Cleaners
Coil Cleaners
Nu-Brite®
Nu-Brite is the most effective coil cleaner available today. It foams, brightens, and is an equally effective yet safer alternative to HF acidbased products. It produces a high volume of foam that cleans more effectively than acids, particularly in removing grease. Biodegradable.
The liquid versions are USDA approved and NSF registered.
18 ounce can
1 gallon bottle
2.5 gallon pail
55 gallon drum
4291-18
4291-08 - Canadian #4891-08
4291-05*
4291-01
Foam-Brite®
The ultimate in foaming alkaline cleaners. It provides for excellent cleaning and brightening,
and at the same time provides tremendous foaming to push dirt and grime out of the coil.
Can easily be used in place of the more dangerous HF acid-based products. Biodegradable.
NSF registered.
1 gallon bottle
2.5 gallon pail
55 gallon drum
4178-08
4178-05*
4178-01
Alka-Brite® Plus
A non-acid, alkaline based product for brightening and cleaning air cooled condensers. It
contains the best available detergents to quickly penetrate and remove oxidation, and its
foaming action helps to lift greasy soils out of the coil. Biodegradable. NSF registered.
1 gallon bottle
2.5 gallon pail
55 gallon drum
4120-08
4120-05*
4120-01
Cal-Brite®
Cal-Brite is a low pH cleaner developed for cleaning evaporator coils, air-cooled condensers
and other finned cooling and heating coils. It’s versatility is based upon glycolic acid and other
unique ingredients. It provides moderate foaming and brightening and is safe for use indoors as
well as outdoors. It’s particularly suitable when lime scale must be removed from outdoor coils.
1 gallon bottle
55 gallon drum
4133-08
4133-01
* A 2.5 gallon pail wrench is also available. Part Number ZE64.
6
Coil Cleaners
Coil Cleaners
TriClean 2x™
The new way to clean a condenser coil. Simply connect to hose, clean, and rinse. TriClean 2x is
metal-safe, designed for rapid emulsion of soils from the coil. Restores efficiency and is ideal
for painted fin and microchannel coils.
1 quart sprayer with hose connector
NEW
4372-24
Nu-Solve™ NR
Ready-to-use, non-rinse condenser coil cleaner for situations with limited water availability
for rinsing. Nu-Solve NR is also for other applications where it is desirable to have less diluted
cleaning solution on a commercial roof or when a solvent based aerosol approach is not
practical. Nu-Solve NR effectively emulsifies dirt and grime and provides a benefit of leaving
a protective treatment on the aluminum for added corrosion protection, making the next
cleaning easier.
1 gallon bottle
4295-08
Tri-Pow’r® HD
An outstanding general purpose coil cleaner, providing detergency and degreasing as well as
deodorizing capability. Its positive emulsion technology is very effective against oily grime as
it converts the deposits into a more fluid or liquid form that can be easily rinsed away. It is nonacid, non-toxic, and biodegradable. NSF registered. Also great for microchannel coils.
1 gallon bottle
55 gallon drum
4371-88
4371-81
CalClean®
An alkaline detergent formulated for cleaning evaporator coils, air-cooled condenser coils, metal
filters, fan blades, and other surfaces soiled with grease, dust and dirt. Biodegradable. USDA approved
Aerosol is NSF registered. Also great for microchannel coils.
20 ounce can
1 gallon bottle
2.5 gallon pail
55 gallon drum
4081-75
4135-08 - Canadian #4820-08
4135-06*
4135-01
Special HD CalClean®
The best non-foaming cleaner available. Specifically formulated to remove tobacco tars from
electronic air cleaners as well as the most stubborn deposits from finned coils. USDA approved.
Also great for microchannel coils.
1 gallon bottle
2.5 gallon pail
55 gallon drum
4143-08 - Canadian #4823-08
4143-06*
4143-01
* A 2.5 gallon pail wrench is also available. Part Number ZE64.
Visit us at www.nucalgon.com or call 1-800-554-5499
7
Coil Cleaners
Coil Cleaners
Evap Pow’r®-C
A no rinse product formulated for cleaning evaporator coils. It is metal-safe, and it cleans
and emulsifies even the most stubborn soils and deposits. Biodegradable. USDA approved.
Also great for microchannel coils.
1 gallon bottle
2.5 gallon pail
55 gallon drum
4168-08
4168-05*
4168-01
The following products are part of Nu-Calgon’s Environmentally Friendly Green Select line.
They have been recognized by the EPA’s Design for the Environment program, which tests
and identifies products that are safer for the environment.
Cal-Green™ Condenser Cleaner
Cal-Green is a plant-based, natural condenser cleaner that is powerful enough to remove
dirt, grease, and grime but environmentally safe for use around people, plants, animals, and
aquatic life. This non-foaming, non-toxic concentrate is perfect for cleaning residential or
commercial systems and restores their efficiency while being environmentally responsible.
Also great for microchannel coils.
1 gallon bottle
55 gallon drum
4190-08
4190-01
Evap-Green™ Evaporator Cleaner
Evap-Green is a no rinse product is perfect for numerous heating and air conditioning
applications such as evaporator coils, roof top units, window units, metal filters, fan blades,
and more. Evap-Green uses only natural and renewable resources that are on the EPA’s
Design for the Environment list for safer chemistries. Evap-Green is also biodegradable and
will not harm plants, animals, and aquatic life. Metal-safe - meets OEM guidelines for all
aluminum coils, including microchannel types.
1 gallon bottle
4191-08
55 gallon drum
4191-01
Green Clean
A pleasantly scented, all-purpose, environmental friendly cleaner designed for the rapid
removal of grease and other heavy soils. It can be used right out of the bottle or diluted
for milder jobs. Biodegradable. Also great for microchannel coils.
1 quart spray bottle
1 gallon bottle
55 gallon drum
4186-24
4186-08
4186-01
* A 2.5 gallon pail wrench is also available. Part Number ZE64.
8
Coil Cleaners
Coil Cleaners
Evap Foam No Rinse®
Evap Foam No Rinse is a high performing, heavy duty detergent. It is formulated with
special surfactants and alkaline cleaners that have been developed into a foaming, no rinse
product. Evap Foam is ideal for use on most coils, but it is particularly suited for use on
cooling or evaporator coils. The aerosol can be sprayed either right side up or upside down.
NSF registered.
18 ounce can
NEW
4171-75
Blackhawk®
Blackhawk is an expanding foam coil cleaner. Formulated to deeply penetrate the coil, it liquefies
to quickly remove grease, grime, or oily soils from deep within the coil. Blackhawk’s formulation
is safe and problem-free for cleaning evaporator or condenser coils in an occupied building;
produces no objectional fumes. It is particularly effective on coils on refrigerators, coolers, and
freezers located in restaurants and other commercial establishments. NSF registered.
18 ounce can
4127-75
Nu-Blast®
A no rinse condenser coil cleaner in a convenient aerosol package. Double action of high
pressure blast and solvent cleaning restores design efficiency of condenser coils. It is
non-flammable and non-conductive. No rinse required - cleaning solvent evaporates
completely. Use with adequate ventilation.
18 ounce can
4290-75
Cal-Blast®
Cal-Blast is a no rinse condenser cleaner that will powerfully separate undesirable materials
from the surface, offering maximum cleaning of finned coils. It’s a high performance
aerosol with excellent solvency and blasting spray.
20 ounce can
4132-20
Coil Protectants
Nu-Shield®
Nu-Shield, the newest generation of chemistry for protecting
coils and other surfaces, is a super-hydrophobic (water repelling)
product. The non-conductive formula has numerous applications
in the management of water on non-food, non-potable water
surfaces for the HVAC/R trade. Simply spray it on and watch the
water bead up and roll right off.
9 ounce can
Non-treated : Nu-Shield :
Water Clings Water Repels
4294-75
Cal-Shield®
Cal-Shield is a synergistic liquid formulation based upon DuPont’s Teflon® fluoro-additives. It’s
designed for application on air-cooled condensers, evaporator coils, and other finned heating
and cooling coils. Cal-Shield will shield and protect the coil from adverse conditions.
1 quart spray bottle
1 gallon bottle
4148-32
4148-08
Visit us at www.nucalgon.com or call 1-800-554-5499
9
Sprayers
Sprayers
NEW
Coil Gun®
Coil Gun® Probe
Coil Mate™ Coil Cleaning Hose
A different approach to coil cleaning
- a “hose-end” sprayer that features 5
different mix ratio settings designed for
coil cleaners. Utilizes a 2 quart capacity
bottle and includes a foam wand as well
as “quick disconnect” capability.
The Coil Gun Probe is a time saving
accessory for use with the Coil Gun. Its
90º direction of spray allows cleaning
from inside the coil. It also provides easy
access in tough to reach locations to
discharge debris and emulsified grime in
an outwardly direction from the coil.
Durable 5/8 inch diameter reinforced
hose with Flex-Guard protection. The 50 ft
hose is equipped with solid brass wrench
fittings. The Coil Mate is a necessity when
using the popular Coil Gun® or rinsing an
air cooled coil with water after using a
Nu-Calgon coil cleaner.
Replacement parts are available for all Nu-Calgon sprayers. Contact your local wholesaler.
1 each
4774-0
1 each
4774-1
1 each
61231
No. 50P Poly Sprayer
No. 100P Poly Sprayer
No. 200P HiPressure Poly Sprayer
The No. 50P is constructed of highdensity translucent polyethylene. It
has a half gallon (3 pint) capacity. The
nozzle is adjustable and the flow rate
is controlled by a thumb lever. It comes
with a 7˝ polyethylene pump.
This sprayer is constructed of highdensity translucent polyethylene. It has
a funnel top for easy chemical pouring
and a 1 gallon working capacity. It
comes with a 8˝ polypropylene pump,
brass handle and extension tube with
adjustable nozzle, a wear-resistant hose,
and a pressure relief valve.
The No. 200P HiPressure Poly
Sprayer is constructed of high-density
translucent polyethylene. It has a 2
gallon working capacity, funnel top,
pump handle, and equipped with allbrass hardware. No pumping is required.
Pressurize the sprayer with water
through a “quick disconnect” fitting.
1 each
4770-0
1 each
4770-2
1 each
4771-2
No. 220CP Poly Sprayer
No. 300P Poly Sprayer
Multi-Purpose Sprayer
The No. 220CP Poly Sprayer is
constructed of high-density translucent
polyethylene with a funnel-top that
provides easy chemical pouring. This 2
gallon capacity sprayer features an easy
fill level indicator and comes with an 8˝
pump and a high resin plastic adjustable
nozzle with three feet of hose.
1 each
4771-3
The No. 300P Poly Sprayer is constructed
of high-density translucent polyethylene.
It has a funnel-top and a 3.5 gallon
capacity (3 gallon working capacity). It
comes with a 10˝ Celcon pump, brass
extension tube with adjustable nozzle,
and five feet of vinyl hose.
A 24 ounce capacity sprayer. It is ideal
for small cleaning jobs, such as window
units and water coolers.
10
1 each
4772-0
1 each
4768-W3
Indoor Air Quality
Indoor Air Quality
Gel Tabs - Condensate Drain Pan Treatment
Formulated with a breakthrough technology for treating air conditioning drain pans and lines. Keeps the drain pan from
clogging and eliminates foul and musty odors. When activated by condensation, the tablet will turn to gel and lock into place.
Dissolves continuously and completely with nothing left to remove for up to 3 months. Stack together to increase duration.
3 ton tab (12 in tube)
3 ton tab BULK (200)
5 ton tab (6 in tube)
4185-03
4185-04
4185-05
15 ton tab (1 each)
20 ton tab (1 each)
4185-15
4185-20
Cal-Fresh
Use Cal-Fresh wherever malodors exist as it inhibits odors rather than masking them.
Cal-Fresh is specifically formulated for industrial use in treating odor problems commonly
found in air conditioners, autos, sick rooms, refrigerators, motels, nursing homes, ice makers,
hotels, evaporators, humidifiers, freezers, and trucks. Cal-Fresh is not a masking agent. It
attacks the odor at its source.
1 quart spray bottle
4126-40
Bio-Fresh® Fogger
The Bio-Fresh Fogger is made of a one-piece, seamless heavy-duty copolymer. It uses a 48˝
flexible hose and is adjustable from 0-18 ounces per minute with the respective particle size at
20 to 80 microns. It’s ideal for spraying Cal-Fresh in duct work and large areas.
1 each
4693-0
Pan-Treat®
Pan-Treat condensate tablets control odors and prevent overflows caused by plugged
condensate drain lines, and can also be used in humidifiers. They are very easy to use, as well
as safe, non-corrosive, non-toxic, and biodegradable.
1 bottle (200 tablets)
4296-60
Visit us at www.nucalgon.com or call 1-800-554-5499
11
Indoor Air Quality
ClenAir by Nu-Calgon
PurCool® Strips
PurCool Strips keep A/C and refrigeration condensate drain pans clean and free flowing. Use
PurCool Strips to prevent condensate drain clogs, costly overflows, and corrosion. Just place
them anywhere in the drain pan where the PurCool Strip will contact the condensate water
and enjoy up to six months of economical protection. PurCool Strips will adhere to the drain
pan and will not float or move. Dissolves completely leaving no residue. Safe for metal and
plastic drain pans.
Nu-Calgon
Treats 30 tons - 6 mos. 61040
Treats 10 tons - 6 mos. 61041
Treats 5 tons - 6 mos
61042
ClenAir
2009
2003D
2001D
Nu-Calgon
Treats 3 tons - 6 mos. 61043
3 tons Bulk
61047
ClenAir
1903D
1903D-100
PurCool® Green Commercial Strips
Green product to prevent slime, sludge, odors, and overflows in commercial air handler
condensate pans. Time release formula adheres to pan and fully dissolves over time. No housing
or sock to remove. Unique green formula utilizes plant based suspending and dispersing action
to keep drain pans clean and free flowing. Lasts up to 6 months.
PurCool Commercial Strip 10 ton
PurCool Commercial Strip 30 ton
Nu-Calgon Number
61045
61046
ClenAir Number
PCG10T
PCG30T
PurCool® Green Mini Strip
One Mini Strip treats up to 5 tons. Prevents slime, sludge,
odors and overflows. For prevention of drain pan fouling and
overflow in mini splits, fan coil units, "A"coils, window units,
and other tight drain pan applications. Mini Strips can be cut
and used with multiple evaporators. Time release formula completely dissolves leaving no
residue. Utilizes unique plant based suspending and dispersing action to prevent blockages
from slime and sludge. Lasts up to 6 months!
PurCool Mini Strip
Nu-Calgon Number ClenAir Number
61044
PCG5MS
PurCool® Green Tablet
One tablet treats up to 5 tons. Prevents slime, sludge, odors and overflows. Time release
formula adheres to pan and completely dissolves. It will not float and leaves no residue.
Utilizes unique plant based suspending and dispersing action to prevent blockages from
slime and sludge. Use multiple tablets for larger systems. Lasts up to 6 months!
PurCool Green 1 tablet
PurCool Green Bulk
Nu-Calgon Number ClenAir Number
61051
PCG5T
61052
PCG5T-100
PurCool® Condensate Pan Treatment Tablets
PurCool Tablets utilize a powerful formulation to keep condensate drain pans clean and free
flowing. Use PurCool Tablets to remove sludge and slime in A/C condensate pans to prevent
costly water damage caused by overflows. They will control clogs, build-up, odors, corrosion
in drain pans, and condensate pumps, and humidifiers. Approved for computer room
humidifiers. PurCool Tablets are completely soluble in water and biodegradable and will not
leave any deposits on surfaces.
200 PurCool Tablets
PurCool Shock Tabs
12
Nu-Calgon Number ClenAir Number
61053
PC200
61054
PCST12
Indoor Air Quality
At home, school, work, or play, the quality of the indoor air that we breathe
affects the way we feel. The indoor air handler is the heart of the HVAC system.
The air handler’s cooling/heating coils, and condensate drain pan must be
properly treated and maintained in order for it to supply clean, odor free,
conditioned air to the home or building. ClenAir by Nu-Calgon’s Quality Indoor
Air Program provides the products to treat the cooling/heating coils, condensate
drain pan, and HVAC system air as it passes through the air handler.
Breathe easy with ClenAir!
The Original ClenAir™ Odor Neutralizer
ClenAir’s unique odor neutralizing formula removes odors quickly and permanently. Originally
designed for use in central air systems, on fire and flood restoration jobs and in sewage facilities,
ClenAir is a professional product, yet it leaves no lingering antiseptic or perfume smell. Use
ClenAir gel to combat stubborn odors, even those that have built up over time like cigarette
odor or pet odors. Simply place the gel near the source of the odor or in the return duct of your
central air system. The best product available for musty basements. Great for smoke and water
damage as well as pet odors. Used by heating and air conditioning technicians, professional
duct cleaners, janitors and property management.
Mini Tub
1/2 lb. Tub Display Box
1/2 lb. Tub
1 lb. Tub
3 lb. Tub
Nu-Calgon
ClenAir
61000
61001
61002
61003
61004
CA1500M
1500D
1500
1501
1503
Nu-Calgon
10 lb. Tub
30 lb. Tub
Wall Unit (White)
61005
61006
61007
Gel Brick for Wall Unit (1lb.) 61008
ClenAir
1510
1530
1300
1401
CherryAir® Odor Neutralizer
CherryAir Odor Neutralizer removes odors quickly and permanently leaving a pleasant cherry
fragrance behind. Using unique ClenAir odor neutralizing technology, CherryAir is a true odor
eliminator - not an odor mask like many scented products. CherryAir attacks odors caused by
fuel oil, smoke, pets, mold and mildew, cigarette and cigar smoke, decay, cleaning solvents,
and even skunks!
Mini Tub
1/2 lb. Tub Display Box
1 lb. Tub
Nu-Calgon
ClenAir
61018
61010
61011
CA1800M
1800D
1801
3 lb. Tub
10 lb. Tub
30 lb. Tub
Nu-Calgon
ClenAir
61013
61015
61017
1803
1810
1830
OrangeAir® Odor Neutralizer
OrangeAir Odor Neutralizer uses the unique ClenAir odor neutralizing technology to safely
eliminate odors, leaving a refreshingly crisp orange fragrance behind. OrangeAir is not a mask
or cover-up. It is a true odor eliminator. OrangeAir eliminates odors caused by smoke, pets,
fuel oil, mold, mildew, bacteria, cigarette smoke, water damage, fire damage, stale air, decay,
chemicals, even skunks!
Mini Tub
1/2 lb. Tub Display Box
1 lb. Tub
Nu-Calgon
ClenAir
61028
61020
61021
CA1300M
CA1300D
CA1301
3 lb. Tub
10 lb. Tub
30 lb. Tub
Visit us at www.nucalgon.com or call 1-800-554-5499
Nu-Calgon
ClenAir
61023
61025
61027
CA1303
CA1310
CA1330
13
Indoor Air Quality
ClenAir by Nu-Calgon
HVAC Odor Block®
ClenAir HVAC Odor Block is not a perfume mask or cover-up. The unique ClenAir formula
molecularly reacts with the airborne odor causing compounds and eliminates them and
other indoor pollutants leaving clean, fresh, air behind. The HVAC Odor Block makes it
easy to remove odors and improve the indoor air quality in the entire home or building by
treating the air through the HVAC system.
•
•
•
Eliminates odors and improves indoor air quality.
Treats all home or building air through the HVAC system.
Use in A/C units, furnaces, rooftop units, fan coil units, and air handlers.
Nu-Calgon Number ClenAir Number
61060
1502
61061
CA1015
Residential HVAC Odor Block
Commercial HVAC Odor Block
Side Vent for Carbon Filtration
HVAC Carbon Block® In-Duct Air Purification System
HVAC Carbon Block is an add-on Carbon purifier for all HVAC systems. Improves indoor
air quality by removing odors, indoor air pollutants, and VOC’s. Treats up to 10 tons for
6-9 months.
Nu-Calgon Number
61062
HVAC Carbon Block
ClenAir Number
CACB10
Gases
& Chemicals
HVAC Carbon Block® Removes Many Indoor Air Pollutants Including:
•
•
•
•
•
•
Animal Odors
Food Odors
Ozone
Tobacco Smoke
Formaldehyde
Body Odors
•
•
•
•
•
•
Paint Fumes
Auto Exhaust
Sewer Gases
Burnt Odors
Printer Gases
Chlorine
•
•
•
•
•
•
Turpentine
Cosmetics
Mercaptans
Ammonia
Solvents
Alcohol
•
•
•
•
•
•
Activated
Carbon
Cleaning Chemicals
Acetone
VOC’s
Smog
Mildew
Hospital Odors
Pores
Activated Carbon Adsorbs
Gases & Chemicals
ClenAir Liquid Formula
ClenAir Liquid is a fast acting deodorizing product. It eliminates odors via an oxidation
process while leaving a fresh scent. Applications include HVACR equipment including
evaporator coils, duct work, condensate pans, refrigeration cases, reach-ins, and walk-in
boxes. It can also be poured down drains, garbage disposals, and in trash cans. Spray in
restrooms, locker rooms and on fouled carpeting, upholstery. Used by hospitals, nursing
homes, HVACR technicians.
Nu-Calgon
Unscented Spray 16 oz. 61030
Unscented Liquid 1 gal. 61031
Citrus Spray 16 oz.
61033
14
ClenAir
1600D
1610
1700D
Citrus Liquid 1 gal
CherryAir Spray 16 oz.
CherryAir Liquid 1 gal.
Nu-Calgon
ClenAir
61035
61037
61038
1710
1900D
1910
Cal-Blue® Plus Gas Leak Detector
Cal-Blue Plus is a complete gas leak detector, freeze protected to 5˚F. Its high viscosity
formula enables it to remain in contact with the applied surface for an extended period of
time, allowing it to detect the smallest of leaks. It is also non-corrosive to metal, and it will not
affect ultraviolet or black lights. NSF registered.
6 ounce bottle with dauber
1 quart spray bottle
1 gallon bottle
4182-53
4182-24
4182-08
Cal-Blue® LT Gas Leak Detector
The same high quality formulation as regular Cal-Blue Plus, but has added freeze-protection
to -20˚F. It is the ideal detector for geographical areas that may experience very cold
temperatures. NSF registered.
1 quart spray bottle
1 gallon bottle
4183-24
4183-08
Gas Leak Detector
The original industry leak detector. A high viscosity liquid that forms bubbles when daubed
on a gas leak. Non-corrosive, non-staining, harmless to skin. Detects any type of gas leak such
as air, compressed air, carbon dioxide, nitrogen, natural gas, and refrigerant gases. Freezeprotection to -20˚F. Six ounce plastic bottles have dauber in cap. USDA approved.
6 ounce bottle with dauber
4180-53 - Canadian #4832-C9
Fluorescent Gas Leak Detector
A fluorescent formulation that provides improved visibility and long lasting bubbles.
It is non-corrosive to metals and is freeze protected to 5˚F. Suitable for high and low
temperature applications. Can be used for most refrigerants, natural gas and oxygen
systems. USDA approved.
8 ounce bottle with dauber
1 quart spray bottle
1 gallon bottle
4184-53
4184-24
4184-08
Visit us at www.nucalgon.com or call 1-800-554-5499
15
Gas Leak Detectors
Gas Leak Detectors
Refrigeration Oil & Vacuum Pump Oil
Polyol Ester (POE) Lubricant
Emkarate® RL Lubricant
The Emkarate family of polyol ester refrigeration lubricants are designed specifically for use with HFC refrigerants. They are available
in a range of viscosities. They have excellent thermal and chemical stability, and are compatible with a wide range of elastomers,
polymeric materials, and other materials of construction. Fully miscible and compatible with mineral oils and alkylbenzene lubricants
as well as with CFCs, HCFCs and HFCs.
Emkarate RL
22H
32H
32HB
32-3MAF
46H
68H
68HB
68HP
100E
170H
220H+
220XL
Viscosity
100 SUS
150 SUS
150 SUS
150 SUS
200 SUS
300 SUS
300 SUS
300 SUS
500 SUS
850 SUS
1100 SUS
1100 SUS
1 Quart
4314-44
4314-64
4316-44
1 Gallon
4313-46
4314-46
4314-66
4315-46
4316-46
4316-86
4316-76
4317-66
4318-26
4318-66
5 Gallon
53 Gallon
4314-45
4314-62
4314-65
4314-41
4314-67
4315-41
4316-41
4316-45
4316-85
4316-71
4318-25
4318-65
4318-75
4318-21
4318-61
Mineral Oil
C-3s, C-4s, C-5s Refrigeration Oil
These are mineral naphthenic lubricants manufactured by Calumet Lubricant Company and
available in three viscosities. They are specifically designed for today’s high performance
air conditioning and refrigeration compressors using CFC and HCFC refrigerants. These
compressors run at higher speeds and generate higher temperatures, and as a result, they
require better lubrication. Use of these oils will ensure continued efficient operation, providing
the important properties required from an efficient refrigeration oil.
Nu-Calgon
C-3s
C-4s
C-5s
Viscosity
150 SUS
300 SUS
500 SUS
1 Gallon
4303-07
4304-07
4305-07
5 Gallon
4303-05
4304-05
55 Gallon
4303-01
4304-01
4305-01
Polyvinyl Ether (PVE) Lubricant
Idemitsu Polyvinyl Ether Lubricant
PVE lubricants provide for increased stability and lubrication. They do not hydrolyze in the
presence of moisture, a very important feature in HVAC/R applications. Additionally, they
are compatible with other refrigeration oils and process fluids. PVE lubricants also exhibit
compatibility and performance with frequently used anti-wear additives.
Idemitsu
FVC32D
FVC68D
16
Viscosity
32 SUS
68 SUS
1 Quart
4319-14
4319-24
Zerol® Alkylbenzene Refrigeration Oil
Zerol Refrigeration Oil is recommended for use in all refrigeration and air conditioning
applications using CFC and HCFC refrigerants. It is highly recommended by refrigerant and
compressor manufacturers for use with R-22 and other HCFC blends such as R-409A as it provides
many distinct advantages: excellent miscibility, excellent thermal stability, low temperature
performance compatibility with mineral oils. It is the oil of choice for R-22 and R-502.
Zerol
150
200TD
300
400CA
500
Viscosity
150 SUS
200 SUS
300 SUS
400 SUS
500 SUS
1 Gallon
4310-07
4308-07
4311-07
5 Gallon
4311-05
4311-65
4312-05
55 Gallon
4310-01
4308-01
4311-01
Vacuum Pump Oil
Cal-Vac® Vacuum Pump Oil
Nu-Calgon’s Vacuum Pump Oil is a quality, high-grade lubricant that performs at the deepest
vacuum. It has a very low vapor pressure and it has excellent lubricity for complete surface
protection. It contains no additives or detergents.
1 pint bottle
1 quart bottle
1 gallon bottle
4383-34
4383-24
4383-07
Refrigeration Oil Products
Refrigeration Oil Charging Pump
An oil pump for charging refrigeration oil into a system, even while it’s running. This pump can
be used for 1 gallon, 2.5 gallon, and 5 gallon containers. Incorporates an automatic bleed valve
that keeps pressure equalized inside the container, and includes a tapered rubber adapter that
fits all container openings without the need for additional adaptors.
1 each
4814-40
Oil Refractometer
A precision optical instrument that allows for the rapid and accurate determination of the
refractive index of oil solutions. It will specifically assist in determining the percent residual
of oil remaining in a refrigeration system when converting it to a new refrigeration oil. Such
retrofits require converting the mineral oil to a polyol ester (POE) or polyalkylene glycol (PAG),
an alkylbenzene lubricant (Zerol®) to a POE, or a mineral oil to an alkylbenzene.
1 each
4815-0
CanVerter®
A hand-held pump used to remove or add oil to hermetic compressors. Easy to use; each stroke
pumps 1 ounce of oil.
1 each
4814-0
Visit us at www.nucalgon.com or call 1-800-554-5499
17
Refrigeration Oil & Vacuum Pump Oil
Alkylbenzene Oil
Aerosol Products
Aerosol Coil Cleaners
Evap Foam No Rinse®
Nu-Brite®
Evap Foam No Rinse is a high performing, heavy duty
detergent. It is formulated with special surfactants
and alkaline cleaners that have been developed into a
foaming, no rinse product. Evap Foam is ideal for use on
most coils, but it is particularly suited for use on cooling
or evaporator coils. The aerosol can be sprayed either
right side up or upside down. NSF registered.
Nu-Brite is a very effective degreaser and cleaner on
condenser coils. Its high foaming characteristic will help
push soil deposits out of the coil, leaving it clean and
bright. With proper ventilation, it can also be used as
a kitchen degreaser by emulsifying stubborn, resistive
grease deposits found on coils located in kitchens. Product
should be used where adequate rinsing is possible.
18 ounce can
4171-75
18 ounce can
Cal-Blast®
Nu-Blast®
Cal-Blast is a no rinse condenser cleaner that will
powerfully separate undesirable materials from
the surface, offering maximum cleaning of finned
coils. It’s a high performance aerosol with excellent
solvency and blasting spray.
A no rinse condenser coil cleaner in a convenient aerosol
package. Double action of high pressure blast and
solvent cleaning restores design efficiency of condenser
coils. It is non-flammable and non-conductive. No rinse
required - cleaning solvent evaporates completely. Use
with adequate ventilation.
20 ounce can
4132-20
18 ounce can
NEW
4290-75
Blackhawk®
CalClean®
Blackhawk is an expanding foam coil cleaner. Formulated
to deeply penetrate the coil, it liquefies to quickly
remove grease, grime, or oily soils from deep within
the coil. Blackhawk’s formulation is safe and problemfree for cleaning evaporator or condenser coils in an
occupied building; produces no objectional fumes. It is
particularly effective on coils on refrigerators, coolers,
and freezers located in restaurants and other commercial
establishments. NSF registered.
CalClean is a heavy duty detergent formulation
of surfactants, grease solvents, alkaline cleaners,
corrosion inhibitors, and water conditioners. Ideal
for cleaning window units as well as small evaporator
coils, air cooled condenser coils, metal filters, fan
blades and other surfaces soiled with greasy dust and
dirt. NSF registered.
18 ounce can
18
4291-18
4127-75
20 ounce can
4081-75
BEFORE
AFTER
A/C Shine® Superior Cleaner / Protectant
Nu-Shield™
A/C Shine is specially formulated to clean and protect the
painted metal surfaces of outdoor A/C condensing units.
It sprays on and wipes off quickly and easily without
water. For use on all outdoor unit painted surfaces.
Nu-Shield, the newest generation of chemistry
for protecting coils and other surfaces, is a superhydrophobic (water repelling) product. The nonconductive formula has numerous applications in the
management of water on non-food, non-potable water
surfaces for the HVAC/R trade. Simply spray it on and
watch the water bead up and roll right off.
12 oz.
Nu-Calgon Number
ClenAir Number
61118
ACS12
9 ounce can
4294-75
Aerosol Lubricants
Break-n-Lube™
Food-Grade Silicone
This advanced technology 4-in-1 product is made
with CERFLON® for high performance in a non-drying
penetrating lubricant. It’s highly versatile with the
ability to penetrate, lubricate, displace moisture, and
provide superior resistance to corrosion. It’s especially
formulated to help free rusted parts and assemblies.
Food Grade Silicone sprays a perfect non-stick surface
on ice machine surfaces, vending machines, coin slots,
slicing machines, dairy machinery, and other food
processing and packaging equipment. An excellent
lubricant that prevents binding and sticking. Contains
ingredients approved by the FDA for food contact use.
USDA approved.
12 ounce can
4128-03
11 ounce can
4084-03
V-Belt Dressing
PenetrateHD® Super Penetrating Lubricant
V-Belt Dressing is specially formulated to penetrate and
extend modern V-Belt life. It is particularly effective in
maintaining V-Belt efficiency and performance under
today’s increasing performance requirements. It keeps
belts pliable, prevents slippage, and does away with
squealing and chattering. USDA approved.
Loosens rusted and frozen metal parts. Frees stuck fan blades,
blower shafts, pulleys, rusted nuts and bolts, and any frozen,
rusted, or seized metal part. Unique low surface tension
formula penetrates into the smallest spaces and breaks and
dissolves the bonds of rust and corrosion. Lubricates and
protects metals. Dielectric strength 40,000 volts.
16 ounce can
4086-03
12 ounce can
17 ounce can
12 ounce can - LV*
17 ounce can - LV*
61105
61106
61107
61108
* LV = Low VOC for California
Visit us at www.nucalgon.com or call 1-800-554-5499
19
Aerosol Products
Aerosol Specialty Products
Aerosol Products
Aerosol Adhesives
Spray-n-Bond™
Spray Adhesive
A wide web spray adhesive formulated specifically
for insulation and duct liner applications. Ideal
for porous surfaces, it is waterproof, flexible,
transparent, non-staining, and it can be used for
both temporary or permanent bonds. Formulated
with the environment in mind, it contains no
chlorinated solvents or ozone depleters, and it is
voc-compliant in states such as California.
Spray Adhesive is a fast-drying, all-purpose product
that provides a strong, water-resistant, flexible bond. It
is translucent and does not penetrate or soak material
causing bleed-through. Spray Adhesive is excellent
for labeling, bonding, splicing and sealing paper,
cardboard, cloth, rubber, styrofoam, canvas, leather,
wood, and most plastics.
12 ounce can
12 ounce can
4080-04
4369-75
Aerosol Specialty Products
Pipe-Dri®
Pan-Spray®
Aerosol insulation which provides a moisture barrier
to stop sweating and dripping on refrigeration lines,
air conditioning lines, and other cold surfaces. Quickly
adheres and dries to a hard waterproof coating. PipeDri makes it possible to insulate hard to reach areas.
Pan-Spray is an effective, easy-to-use waterproof
rubberized coating that won’t chip, flake, or peel. It’s ideal
for sealing out rust and corrosion as well as repairing leaky
condensate pans, cooling towers, swamp coolers, roofing,
gutters, and down spouts. Pan Spray is the perfect
solution for emergency and permanent repair.
18 ounce can
16 ounce can - White
16 ounce can - Black
4296-50
4296-51
Pump Protector
Zinc Rich Cold Galvanizing
When corrosion occurs in close-tolerance areas, it can
cause the impeller to stick or bind. Pump Protector
protects seasonally operated pumps against corrosion
during shutdowns by winterizing them. It is safe for all
types of water pumps and requires no special rinsing
at start-up.
Highly resistant to nearly all forms of corrosion. Perfect
for repairing factory galvanized material damaged in
shipment, welding, assembly, etc. Its 95% pure zinc film
fuses itself to iron, steel, or aluminum. Blends well with
hot-dip coating. Meets or exceeds Military Specifications
MIL-P- 26915A, MIL-T- 26433, MIL-P- 21035, MIL-P-46105
and the Preece Test.
10 ounce can
4299-T8
13 ounce can
4087-03
Electrical Contact Cleaner
Degreasing Solvent EF
Cleans, lubricates, and protects electrical contacts
from corrosion, and is safe on most plastics. Cleaning
action quickly removes greases, dust, and oxidation,
restores and maintains precision and efficiency to the
instrument and component. Includes extension tube
for pinpointing application. USDA approved.
A degreasing solvent, specially formulated for cleaning
and degreasing equipment where washing or flushing
is not possible. Simply spray on and wipe off. Penetrates
quick and deep, loosening and liquefying heavy
greases and tar. Non-corrosive and non-staining with a
dielectric strength over 26,000 volts.
11 ounce can
14 once can - LV *
* LV = Low VOC for California
20
4297-75
4082-03
4082-04
14 ounce can
14 ounce can - LV*
* LV = Low VOC for California
4083-75
4083-83
Great Wipes
Great Wipes Industrial Strength Hand Towels are waterless wipes made specifically for the air
conditioning, refrigeration, and plumbing service technician. Each premoistened, heavy duty
towel has strong pumice scrubbing power that conveniently cleans anywhere and anytime.
75 count canister
4185-75
Scrubs-In-A-Bucket® HVAC80
The original Scrubs. Disposable, pumice-performance waterless hand cleaner towels that
effectively and quickly clean hands on a wide variety of industrial soils and greases. Each selfdispensing portable canister contains 80 perforated disposable heavy-duty towels and are
pre-moistened with the famous Scrubs cleaning formulation. Effective yet gentle to the skin.
Use anywhere, anyplace, anytime.
30 count canister
80 count canister
4366-24
4366-87
Quick Seal™ Pipe Repair
A permanent knitted fiberglass impregnated tape that is designed for quick, in-the-field repair
of leaks for all types of pipes. It can be used on both cold or hot water as well as refrigeration,
plumbing, industrial, commercial, and residential applications. It is safe for potable water and
is UL listed. ANSI/NSF Standard 61.
2˝ x 3´ wrap
4˝ x 12´ wrap
4299-10
4299-11
Thermo-Trap®
The industry’s original heat absorbing paste designed to isolate heat encountered in
soldering, welding, and brazing, thereby preventing damage to nearby heat sensitive
controls, or fittings. USDA approved. Biodegradable. Available in paste as well as a gel.
Thermo-Trap Paste
Thermo-Trap Gel
Thermo-Trap Gel
11 ounce tube
1 quart spray bottle
4 fluid ounce spray bottle
4371-36
4371-32
4371-53
Degreasing Solvent EF
A degreasing solvent that is ozone-safe and environmentally friendly. It is a volatile solvent
that provides effective degreasing and cleaning as well as controlled drying with absolutely
no residue. It has a dielectric strength in excess of 26,000 volts.
1 gallon
1 gallon - LV*
4162-07
4162-17
* LV = Low VOC for California
Visible Defects Heat Exchanger Inspection System
The Visible Defects Heat Exchanger Inspection System is a complete kit that enables the
technician to better evaluate the integrity of a heat exchanger. If a crack exists, the specially
formulated fluorescent penetrant visually enhancing the crack allowing the technician to see
the defect easier.
Visible Defects Kit
Visible Defects Replacement Solution
4385-00
4385-06
Visit us at www.nucalgon.com or call 1-800-554-5499
21
Specialty Products
Specialty Products
Insulation Products
Insulation Products
Perma-Wrap™ Foam Insulation Tape
Formulated from the highest quality elastomeric thermal insulation material, and
is manufactured to meet the needs of today’s air conditioning and refrigeration
applications. Its closed cell construction seals out air and moisture, slowing down heat
transfer and providing complete insulation. Used on hot or cold water pipes, chilled
water, and refrigerant lines to prevent sweating and condensation. Service temperatures
as low as -20º F with a high continuous temperature of 160º F and a high intermittent
temperatures of 220º F.
2˝ x 1/8˝ x 30´ roll
2˝ x 1/8˝ x 30´ roll - Dispenser Package
4218-W3
4218-12
Foam-Tite®
An economically priced tape formulated from quality thermal insulation material. It utilizes
closed cell construction and can be used on cold water pipes, chilled water lines and refrigerant
lines to prevent sweating and condensation. It can also be used on hot water lines, for better
insulation against heat loss. Service temperatures of -15º F to 160 º F.
2˝ x 1/8˝ x 30´ roll
4219-12
Cork Tape
Formulated and manufactured for the air conditioning and refrigeration industry, it meets and exceeds
specifications as an insulating material for preventing sweating and condensation on refrigerant lines,
cold pipes, and other commercial refrigeration and a/c systems. Also serves as an excellent insulator on
hot pipes, and used as a gasketing material, a sound-deadening material, and for wrapping valves, tees,
and fittings. Service at temperatures as low as -30º F, as high as 200º F and won’t sag up to 350º F.
2˝ x 1/8˝ x 30´ roll
4217-W3
Cork-Tite®
Designed for all types of climates, insulating cold pipes for all kinds of air conditioners in cars, homes,
freezers, and refrigerators. Helps stop condensation problems and is ideal for retarding heat gain in
cold pipes and preventing heat loss in hot pipes. An effective sound dampening material, it can also
be used for gasketing purposes, sticks to all kinds of dry metals and seals tightly without drying. It is
flexible and does not shrink or melt within the service temperature of -20º F to +200º F.
2˝ x 1/8˝ x 30´ roll
22
4217-12
Insulation Products
Insulation Products
Nu-Foam®
Nu-Foam is an expanding polyurethane prepolymer foam.
It is used as a sealant and insulating product on openings
created for refrigeration, air conditioning and heating tubes
or pipes, duct joints, and other areas where unwanted air
penetration might occur. Contains no CFCs nor any HCFCs,
and is UL classified and fire retardant.
12 ounce can
20 ounce can
4293-04
4293-75
Sealing and Caulking Cords
Sealing and Caulking Cords are nonstaining sealers formulated from the highest quality raw
materials. They are water-resistant, dust-resistant and white in color. In addition, they securely
adhere to most surfaces and provide excellent insulation value. They are available in 3/8˝ preshaped extruded cords, with serrated release paper.
3/8˝ x 25´ roll
4216-27
Thumb-Tite®
This compound is formulated and manufactured for use in many sealing, insulating, and
general maintenance applications. It has excellent adhesion capability and is non-staining,
non-hardening, and unaffected by wide variations in temperature - an excellent thumbing
grade. It is packaged in 2 pound boxes, each box contains two one pound bars.
2 lb. box
4216-92
Foam Tape PE
Foam Tape PE insulation tape provides an economical way to prevent sweating or condensation on
air conditioning, refrigeration, chilled water or other cold lines. It can also be used on hot water lines
for insulation against heat loss and it can be overlapped or the edges can be butted.
2˝ x 1/8˝ x 30´ roll
4219-20
Visit us at www.nucalgon.com or call 1-800-554-5499
23
Glycol
Propylene Glycol
Freez-Kontr’l®
An expanded family of heat transfer fluids (anti-freeze) based upon non-toxic propylene
glycol. All products are fully formulated to provide optimum freeze protection as well
as corrosion protection in chilled water, hydronic and other closed systems. Safe to use
where contact with potable water is possible. (GRAS certified- generally regarded as safe.)
• Freez-Kontr’l - provides greater than -60 ºF freeze protection and
greater than -100 ºF burst protection
• Freez-Kontr’l 95/5 - a fully concentrated (~100%), inhibited propylene glycol product
• Freez-Kontr’l 35 - formulated with 35% propylene glycol for use as a
secondary coolant in supermarket rack applications
• Freez-Kontr’l FG - a certified USP, food grade propylene glycol product
at ~100% concentration. Inhibited. NSF registered.
Freez-Kontr’l
Freez-Kontr’l 95/5
Freez-Kontr’l 35
Freez-Kontr’l FG
1 gallon bottle
5 gallon pail
55 gallon drum
5 gallon pail
55 gallon drum
55 gallon drum
55 gallon drum
4188-07
4188-05
4188-02
4188-06
4188-03
4188-35
4188-04
Burst-Kontr’l® AP-100
A specially formulated propylene glycol heat transfer solution for use in boilers having
aluminum heat exchangers. It has corrosion inhibitors to protect aluminum, copper, solder,
brass, and steel as well. Provides burst protection to -100 º F and freeze protection to -60 º F.
5 gallon pail
4187-15
Ethylene Glycol
Freez-Therm®
An inhibited heat transfer fluid and anti-freeze based upon ethylene glycol. It can be used
in chilled water, hydronic, and other closed systems for both freeze point suppression and
corrosion inhibition. An uninhibited version is also available in drums on special order.
1 gallon bottle
5 gallon pail
55 gallon drum
4189-07
4189-05
4189-01
Glycol Equipment
Glycol Refractometer
An accurate and economical tool for ensuring proper levels of glycol treatment in HVAC
fluid systems. Removes guess work and prevents wasteful over-treatment. It has metal
body with cushioned eyepiece, focus adjustment, and a rubber hand grip. A calibration
screwdriver, calibration fluid, a plastic pipette, optical cleaning cloth, and a rugged carrying
case are included.
1 each
Nu-Calgon Number
61301
ClenAir Number
GLY32
Glycol/ Oil Transfer Pump
Heavy-duty pump designed to transfer Freez-Kontr’l®, Freez-Therm®, or oil products (up to
1000 sus) from Nu-Calgon supplied 55 gallon drums to their application.
1 each
24
4817-10
Winter Treat®
Multi-treatment product for hot water and steam heating boilers and other closed water
systems. It emulsifies and cleans away rust, corrosion deposits sludge, as well as inhibits system
corrosion, foaming, surging, and lime scale. Typical use is one quart per 25 gallons of water.
1 quart bottle
1 gallon bottle
4390-32
4390-08
Ty-lon® B20
A liquid nitrite-borax corrosion inhibitor and dispersant for closed recirculating systems.
It combines corrosion inhibitors, a unique copolymer dispersant, and a color indicator to
facilitate leak detection, into a complete treatment for hot and chilled water closed systems
containing ferrous and non-ferrous metal components.
5 gallon pail
7537-05
Ty-lon® B14A
An all-in-one boiler treatment product that controls scale, corrosion, and condensate line
corrosion in low pressure, low make-up steam heating boilers where 90% or more of the
condensate is returned. It is chromate-free and contains a color indicator for visual determination
of treatment residual. Its balanced formulation provides an energy efficient way of heating.
5 gallon pail
7519-05
System Cleaner
A liquid, heavy-duty industrial alkaline cleaner specifically formulated to emulsify and clean
equipment surfaces and pipe fouled by cutting oils, grease, lubricants, corrosion products,
and other debris.
5 gallon pail
4370-08
Visit us at www.nucalgon.com or call 1-800-554-5499
25
Closed Systems & Steam Boilers
Closed Systems & Steam Boilers
Water Treatment
Scale Removal
Neutralized
Working
Strength
pH Color Indicator
Nu-Calgon’s exclusive “built-in” pH color
indicator tells you when to add more
acid, and it lets you see when the system
is clean. At working strength, the acid
cleaning solution is green or light blue.
When the acid solution is neutralized
and is no longer working, the solution
turns purple and more acid must then
be added. The system is clean when the
green color is retained for 20-45 minutes.
Competitive
Product with
Dangerous Foam
Nu-Calgon
Low-Foaming
Liquid Scale Dissolver
Low-Foaming Performance
To demonstrate its greater low-foam
property, Liquid Scale Dissolver was
added to a beaker containing lime
scale. A leading competitive liquid
product was added to another beaker
containing an equal amount of lime
scale. See the difference! When cleaning
towers and evaporator condensers,
low-foam is the preferred approach
as high foam is dangerous to both
personnel and surroundings.
Liquid Scale Dissolver
A hydrochloric (muriatic) acid formulated to remove calcium scales from cooling towers and other water-cooled equipment. It contains
low-foaming corrosion inhibitors and a built-in pH color indicator to let you know when the acid has been neutralized. pH test paper
is also included. USDA approved.
1 gallon bottle
5 gallon pail
55 gallon drum
4330-08 - Canadian #4845-K8
4330-05 - Canadian #4845-PB
4330-01
Eco-Lyme®
Eco-Lyme is a new chemistry for the HVAC/R market that provides a unique blend of
performance with a desired eco-profile. The product is specially formulated to achieve
descaling behavior of competing hydrochloric acid based chemistry descalers. However, the
active ingredient is substantially safer on equipment metals. Eco-Lyme is ideal for stainless
steel construction to eliminate potential issues of localized corrosion/pitting caused by
repeated use of hydrochloric acid. Eco-Lyme is odorless; making it safer to use in the field.
NSF registered.
1 gallon bottle
5 gallon pail
55 gallon drum
4167-08
4167-05
4167-01
Season Start® “Imperial Grade” Scale Remover
A powdered sulfamic acid formulation that contains the best inhibitors available for
protecting all metals including galvanized metal. It is the best and the safest dry acid cleaner
available. It contains a built-in pH color indicator to let you know when the acid solution has
been neutralized as well as wetting and anti-foaming agents. USDA approved.
10 lb. container
50 lb. pail
4360-88
4360-84
Initial Dosage Recommendation
26
Tons of Horsepower
Liquid Scale Dissolver
Eco-Lyme
Season Start
10
2 gallons
4 gallons
10 lbs.
30
5 gallons
10 gallons
30 lbs.
50
10 gallons
20 gallons
50 lbs.
90
15 gallons
30 gallons
75 lbs.
Vital-Flo® Tankless Water Heater Descaler Kit
The Vital-Flo Tankless Water Heater Descaler Kit is a complete service tool for descaling
tankless water heaters. It consists of a submersible descaler pump, a set of five foot 3/4˝
female hose threaded assemblies, formulated descaler solution packaged in a lidded four
gallon chemical resistant container. The solution is also available separately. NSF registered.
Vital-Flo Kit
Vital-Flo Descaler Solution
4387-01
4387-02
Feeding Equipment
No. 31-TX1 Acid Pump
Compact submersible pump designed for circulating strong acids and cleaning solutions. All
parts are constructed of acid-resistant materials.
1 each
4603-0
HK-31 Hose Kit
An accessory item available for use with the No. 31-TX Acid Pump. Kit includes two 1/2 inch
tubing adapters, two 10 foot sections of 1/2 inch clear plastic tubing and three hose clamps.
1 each
4604-0
Scale Prevention
Season Treat (6R Micromet®)
This patented Micromet® Plate product is contained in a unique flow-through package. The
package design makes it simple to treat small cooling towers and evaporative condensers.
Simply unwrap the package and place it in the sump. One canister treats up to 10 tons for scale
(5 tons for corrosion) for 5 to 6 months.
1 canister
4364-88
Ty-Ion® C70
An all-organic liquid scale, deposit, and corrosion inhibitor for use in open recirculating cooling
water systems, evaporative condensers, and air washer systems. This treatment program is
particularly effective in preventing scale deposits in systems which utilize make-up water with
high scaling potentials.
5 gallon pail
15 gallon pail
55 gallon drum
7597-05
7597-P3
7597-01
No. 340 Liquid Scale Inhibitor
An extremely concentrated scale inhibitor that is effective in hard, highly alkaline water. It is
very stable and does not form any sludge. It is most effective at treatment levels between 10
and 15 parts per million. A constant, accurate feed is accomplished with a Drip Feeder or CMS
Feed Pump. USDA approved.
1 gallon bottle
5 gallon pail
55 gallon drum
4340-08
4340-05
4340-01
To Inhibit Scale Formation
Tons of Refrigeration
or Horsepower
Containers of
Season Treat
Tylon C70
Required per Month
No. 340 Liquid Scale Inhibitor
Required per Month
Bleed-off for Most
Scale-forming Waters
10
1
1/4 gallon
1/4 gallon
1/8 gpm
30
3
2/3 gallon
1/2 gallon
1/3 gpm
50
5
1 gallon
3/4 gallon
1/2 gpm
100
---
2 gallons
1 1/2 gallons
1 gpm
120
---
2 1/2 gallons
2 gallons
1 1/4 gpm
150
---
3 gallons
2 1/2 gallons
1 1/2 gpm
Visit us at www.nucalgon.com or call 1-800-554-5499
27
Water Treatment
Water Heater Scale Removal
Water Treatment
Corrosion Prevention
Cal-Treat® No. 233
A liquid formulation that is used for controlling severe corrosion in evaporative condensers
and cooling tower systems. It is based upon a synergistic formulation of zinc, molybdate, and
organic phosphonate. Provides superior corrosion control and inhibits scale accumulation.
5 gallon pail
4149-05
To Control Corrosion
Cal-Treat No. 233 Required per Month
Bleed-off for Most Corrosive Waters
Capacity of System in Tons of Horsepower
1/3 gallon
1/10 gpm
10
1 gallon
1/4 gpm
30
2 gallons
3/8 gpm
50
3 gallons
1/2 gpm
90
Algae Prevention
Bromicide Tablets
A chlorine-bromine donating organic compound in tablet form. It slowly releases powerful
oxidizing hypohalous acids which prevent algae and slime bacteria fouling in open recirculating
cooling water systems and evaporative coolers. It also has the capability of breaking up and
removing existing biological mass from system surfaces. USDA approved and EPA-registered.
50 lb. pail
4109-M9
Other Water Treatment Products
Humidi-Pro™
Humidi-Pro is designed for humidifiers using up to 25 gallons per day and will inhibit scale for
one season. Install Humidi-Pro on the water line that supplies water directly to the humidifier.
1 each
4190-02
pH-Treat™
pH-Treat is an in-line treatment product specific for the treatment of the acidic nature of
the condensate water produced by today’s high efficiency furnaces. Includes fitting kit for
easy installation.
1 each
4720-06
6Rsp Micromet®
Food-grade phosphate specifically formulated for inhibiting scale in ice machines and other
equipment using low volumes of water. It is used in Nu-Calgon scale controlling cartridges and
requires replacement once every 6 months. Typical dosage is 8 ounces per 500 pounds of ice
(50 gallons of water) a day. USDA approved. NSF registered.
50 lb. pail
28
4265-50
No. 215 and No. 1075 Drip Feeders
Used for feeding No. 340 Liquid Scale Inhibitor, Cal-Treat 233, Ty-Ion C70 and No. 85
Algaecide. Calibrated at the factory to ensure accurate feeding. Provides the benefits of
continuous treatment for small systems without the high cost usually associated with
automatic feeding equipment.
No. 215 Drip Feeder
No. 1075 Drip Feeder
4669-W3
4670-W3
Jug Holders
These should be used when drip feeding any of Nu-Calgon’s liquid water treatment products.
Once secured to the cooling tower or evaporative condenser, they will hold the 1 or 5 gallon
containers in the proper position.
1 gallon holder
5 gallon holder
4606-0
4607-0
CMS III and CMS-IV Cooling Tower Monitor System
For monitoring conditions in cooling towers and evaporative condensers. Provides subsequent
bleed-off and chemical feed. It features a combination monitor and pump engineered into
one-piece digital equipment. Complete system includes a solenoid valve.
CMS III
CMS IV
4608-0
4608-4
No. 20L and No. 100L Feeders
Steel tanks suitable for pressures up to 150 psi and temperatures up to 212º F. Uses 3/4 inch
FNPT connections for installing on bypass to any size line. Use No. 20L Feeder for initial charges
up to 20 pounds (or 2 gallons). Use No. 100L Feeder for initial charges up to 100 pounds (or 10
gallons). Inlet/outlet strainers not included.
No. 20L Feeder
No. 100L Feeder
4628-0
4650-0
Conductivity Meter
A hand held conductivity meter with built-in cell and automatic temperature compensation.
It has an easy to read digital meter (in micromhos, 0-10,000) and dual point calibrations.
1 each
4812-0
Visit us at www.nucalgon.com or call 1-800-554-5499
29
Water Treatment
Other Water Treatment Products
Plumbing Products
Plumbing Products
A/C Drain Sucker®
A/C condensate drain pan overflows are a very common and costly service problem. The overflows are
caused by slime and sludge that builds up and clogs the drain line. The A/C Drain Sucker quickly removes the
clog and the excess water, resolving the overflow problem. The kit includes PurCool® Shock Tablets to clean
and treat the remaining slime and sludge in the pan and lines, and a PurCool® Pan Strip to provide months
of preventive treatment and free flowing drains, and all fittings & hoses for suction or pressure applications.
A/C Drain Sucker Kit A/C Drain Sucker Kit
PurCool Shock Tabs
PurCool Pan Strip - treats 3 tons - 6 mos.
Nu-Calgon Number
61308
61054
61043
ClenAir Number
CADS1
PCST12
1903D
Calci-Solve
Remove scale from lines and clear clogged drains easily and effectively with Calci-Solve. The product includes
a special inhibitor that coats the inside of the pipes with a protective film, allowing the acid in Calci-Solve to
quickly dissolve calcium, magnesium, sodium, lime, rust, and other elements without harming pipes.
1 quart
1 gallon
4134-24
4134-08
Drain Solve
Ideal for condensate pan drains. Drain Solve saves time and money with its ease of use. It eliminates
application concerns associated with more reactive, fuming drain openers. Simply pour it down the drain
and let it work without fear of noxious fumes or reactions. Does not contain sulfuric acid.
1 quart
1 gallon
4165-24
4165-08
Water Filtration - Maintenance
Water Filtration - Maintenance
Nickel-Safe Ice Machine Cleaner
The original Nickel-Safe Ice Machine Cleaner. It is a food-grade citric-phosphoric acid product for removing
scale deposits from ice machines having nickel-plated or tin-plated evaporators, and it is acceptable for
use in all ice machines containing nickel. It mixes to form a green solution which makes rinsing easier.
USDA approved.
16 fluid ounce bottle
1 gallon bottle
4287-34 - Canadian #4841-AB
4287-08 - Canadian #4841-08
Liquid Ice Machine Cleaner
Liquid Ice Machine Cleaner is a food-grade phosphoric acid that is fast acting, yet safe to use. It has been
formulated to remove scale deposits from ice machines and coffee urns. It does not give off any harsh
fumes or contain chlorine or chlorides that would attack stainless steel. USDA approved. NSF registered.
8 fluid ounce bottle
1 gallon bottle
4207-47 - Canadian #4834-C7
4207-08 - Canadian #4834-08
Ice Guard® AP
Ice Guard AP contains advanced nano-titanium technology formulated to inhibit the growth of a wide
variety of slime-forming bacteria and algae found in ice machines. Ice Guard AP provides 3-6 months
protection for machines up to 1200 lbs. of ice per day. Mini Ice Guard AP that is designed to fit in machines
with smaller sumps. It provides 3-4 months protection in machines up to 400 lbs. of ice per day.
Ice Guard® AP
Mini Ice Guard® AP
30
4209-06
4209-05
Water Filtration
Water Filtration - OEM Replacements
CFS Filtration System
A family of replacement cartridges and manifolds designed to service existing CUNO® CFS installations.
A cost-effective water filtration system for food service applications: ice machines, fountain beverages, steam ovens, and drinking water.
These systems offer manifold and sanitary quick change cartridges to fit the existing CUNO CFS brand installations and can also support
new filtration installations. Nu-Plus CFS is the reliable choice for water filtration to prevent unwanted troubles caused by sediment, scale, or
taste & odor existing in CUNO installations.
Sediment – 5 Micron
Sediment – 5 Micron / Phosphate
Carbon Block - .5 Micron
Carbon Block - .5 Micron / Phosphate
Single Head
Twin Head
Triple Head
Twin Series
4623-10
4623-11
4623-12
4623-13
4623-01
4623-02
4623-03
4623-06
The CTL Series
The CTL Series contains a matching product for the Tri-Liminator Filtration System with
specifications that are nearly identical. For example, the CTL’s primary cartridge (C0070) will
replace both the K00070 and K00174 cartridges, and it has more scale control ability than either
of the Tri-Liminator cartridges. Part numbers are easily crossed over: CTL10 replaces the Tri-L10.
CTL 220
Prefilter
Primary Cartridge - CG5-20S
4610-30
4621-43
9108-27
Water Filtration
Micro-Plus® & Micro-Carbon 4
The complete all-in-one treatment for ice machines, coffee urns and
brewers, humidifiers, steamers, etc. The Micro-Plus “in-line” filters
contain 6R Micromet® to control scale, high-grade activated carbon for
eliminating objectionable tastes and odors, and filter discs to remove
silt and sediment down to 20 microns. Available in four sizes with
1/4˝ FPT connections. When properly sized, each filter will last up to 6
months. The Micro-Carbon 4 is available for removing objectionable
tastes and odors.
Micro-Plus 2
Micro-Plus 4
Micro-Plus 8
Micro-Plus 16
Micro-Carbon 4
4615-W3
4612-W3
4613-Y8
4614-Y8
4617-24
Application
Micro-Plus 2
Micro-Plus 4
Micro-Plus 8
Micro-Plus 16
Micro-Carbon 4
Water (per day)
12.5 gallons
25 gallons
50 gallons
100 gallons
50 gallons
Up to 125 lbs.
Up to 250 lbs.
Up to 500 lbs.
Up to 1000 lbs.
---
25 lbs.(1,250 cups)
50 lbs. (2,500 cups)
100 lbs. (5,000 cups)
200 lbs. (10,000 cups)
---
Ice (per day)
Coffee (per week)
Visit us at www.nucalgon.com or call 1-800-554-5499
31
Water Filtration
Water Filtration - NP Series
NP Series Housings
These housings are designed to hold one of the NP Cartridges used to filter water for ice
machines, coffee urns, and other beverage equipment. The NP24DD and NP48DD Housings
can be charged with specific “NP24” or “NP48” cartridges for controlling scale, sediment, or
objectionable tastes and odors. The NP24DD is equipped with 3/8˝ FPT connections and
handles up to 4.0 gpm. The NP48DD is equipped with 1/2˝ FPT connections and can handle
flow rates up to 5.0 gpm.
NP24DD
NP48DD
4704-24
4714-24
6R Micromet®/Carbon Cartridge
A custom cartridge, combining 6R Micromet for scale-control and a carbon block for sediment
(10 microns), taste and odor control.
NP24PC
NP48PC
4706-87
4716-87
Carbon Block Cartridge
The NP24C Cartridge fits the NP24DD Housing while the NP48C fits the NP48DD. These carbon blocks
will remove most objectionable tastes and odors and are rated to remove particulate to 10 microns.
NP24C
NP48C
4701-87
4711-87
Sediment Cartridge
The NP24S (5˝) and the NP48S (10˝) are made from FDA-approved polypropylene construction
and filter to 5 microns. In addition, the 10˝ as well as a 20˝ version are available in bulk packaging.
NP24S
NP48S
20˝ Bulk
4702-87
4712-87
4621-43
6R Micromet® Cartridge
The NP246R Micromet Cartridge contains 1 pound of 6R Micromet, and it fits the NP24DD
Housing. The NP486R Cartridge contains 2 pounds of 6R and fits the NP48DD Housing, with
10 micron filtration.
NP246R
NP486R
4705-87
4715-87
6R Micromet®/Sediment Cartridge
Another custom cartridge within the NP Series, consisting of polypropylene for filtration
(5 microns) and phosphate for scale-control.
NP48PS
4717-87
NP Series Brackets
Some installations may require two or three NP Series housings to meet more than one
specific water-related condition. This custom installation can be accomplished through the
use of one of the NP Series multi-housing brackets.
Two housing brackets
Three housing brackets
NP2BR
NP3BR
Problem to Solve
Cartridge Type
Sediment
“S” Cartridges
4
“C” Cartridges
4
“6R” Cartridges
4
“PC” Cartridges
4
“PS” Cartridges
4
32
Daily Capacities
Taste & Odor
Scale
“48’s”
1800 lbs. (200 gal.)
3600 lbs. (400 gal.)
1800 lbs. (200 gal.)
3600 lbs. (400 gal.)
4
900 lbs. (100 gal.)
1800 lbs. (200 gal.)
4
600 lbs. (65 gal.)
1200 lbs. (135 gal.)
4
4
“24’s”
4
550 lbs. (60 gal.)
QL3B Single System Head
Used with any Nu-Plus® E Series filters. Head includes a water shut-off
valve with mounting bracket and screws. (3/8˝ NPT)
1 each
4621-07
QC7I Heads
Ideal for all Nu-Plus® E Series filters. Head includes a shut off, flushing
valve, and outlet pressure gauge on a box bracket design.
Single Head
Twin Parallel Head
Triple Parallel Head
Quad Parallel Head
4621-01
4621-02
4621-03
4621-04
Systems
Kleensteam CT and Kleensteam II
Everpure’s second generation water treatment system for steam applications.
Kleensteam is a total system delivering high quality filtered water with scale inhibition as well
as deliming capabilities. The dual cartridge design provides enhanced performance for low and
high flow capacity steamers and flexibility for expanding to meet future needs. Kleensteam
also reduces chlorine-induced corrosion. It’s simple to install, operate, and maintain.
Kleensteam CT
Kleensteam II
1.67 gpm max. flow
2.5 gpm max. flow
9797-50
9797-21
Nu-Plus E Series by Everpure High Flow CSR Manifold with Prefilter
Utilizing the nu-MC2 or the nu-XC2 cartridges, this system provides premium quality water to
high flow fountain dispensers, coffee makers and ice machines. New and improved MicroPure II media inhibits the growth of bacteria. High Flow CSR reduces chlorine taste and odor
and other offensive contaminants that can adversely effect the taste of beverages. Precoat
submicron technology reduces dirt and particles as small as 1/2 micron and reduces health
contaminants such as cysts. Additionally, the SRX Housing inhibits scale when it is equipped
with scale-inhibiting IMF-10 ScaleSticks®.
10˝
20˝
High Flow CSR Manifold with Prefilter
Twin
Triple
9294-02
9294-03
9294-22
9294-23
Quad
9294-04
9294-24
Nu-Plus E Series by Everpure Coldrink/Insurice Systems
The Coldrink/Insurice manifolds can be used with any Nu-Plus by Everpure cartridges. I.E. the
MC2 or XC2 for carbonated beverages or i20002 or i40002 for ice machines. Utilize the systems
existing 10" or 20" pre-filter on a single, twin, triple, or quad manifold. Systems come with the
initial EC110 or EC210 pre-filter cartidge. Just purchase the appropriate Nu-Plus by Everpure
cartridge for your application.
10˝
20˝
Coldrink/Insurice Manifold with Prefilter
Single
Twin
Triple
9293-01
9293-02
9293-03
9293-21
9293-22
9293-23
Quad
9293-04
9293-24
*Everpure® is a trademark of Everpure, Inc., Westmont, IL.
Visit us at www.nucalgon.com or call 1-800-554-5499
33
Water Filtration - Nu-Plus® by Everpure®
Nu-Plus® by Everpure® Heads
Water Filtration - Nu-Plus® by Everpure®
Cartridges
nu-i20002 and nu-i40002
Reduces water-related ice machine problems caused by dirt, objectionable tastes and odor
and scale build-up. Pre-coat submicron filtration reduces particles as small as 1/2 micron along
with chlorine and other offensive contaminants. In addition, both cartridges use 6R Micromet®,
a highly acclaimed scale inhibitor that inhibits scale build-up caused by dissolved minerals. NSF
registered under NSF/ANSI Standards 42 and 53.
•
•
•
•
Pre-coat filtration with Micro-Pure® II antibacterial protection
Premier 6R Micromet scale control
Cyst and asbestos fibers reduction
Sanitary quick-change cartridge replacement
nu-i20002
4621-10
Capacity: 9,000 gallons • 750 lbs. for most cubers • 1,500 lbs. for most flakers
nu-i40002
4621-11
Capacity: 12,000 gallons • 1,000 lbs. for most cubers • 2,000 lbs. for most flakers
nu-MC2 and nu-XC2
Reduces chlorine taste, odor and other offensive contaminants that can adversely affect the
taste of fountain beverages. Pre-coat submicron filtration reduces particles as small as 1/2
micron, and it helps retain carbonation in drinks. NSF registered under NSF/ANSI Standards
42 and 53.
•
•
•
•
Pre-coat filtration with Micro-Pure® II antibacterial protection
Reduces objectionable tastes and odors
Cyst and asbestos fibers reduction
Sanitary quick-change cartridge replacement
nu-MC2
Capacity: 9,000 gallons
4621-20
nu-XC2
Capacity: 12,000 gallons
4621-21
BH2 and OCS2 Cartridge
•
•
•
•
•
•
Delivers premium quality water for ice and coffee applications
Designed for applications where the i20002 is too long
Precoat submicron particulate reduction
Inhibits scale formation
Taste & odor reduction
NSF registered under NSF/ANSI Standard 42 and 53.
BH2
4621-12
Capacity: 3,000 gallons or 6,000 pots of coffee • 0.5 gpm max. flow
OCS2
9618-07
Capacity: 1,500 gallons or 3,000 pots of coffee • 0.5 gpm max. flow
OW200L and OW4Plus Cartridge
•
•
•
•
•
•
Ideal for office or residential water systems
Unique filter blend uses activated carbon to reduce chlorine taste, odor, and other
offensive contaminants
Reduces lead to below the Federal Action Level of 10 ppb
Precoat submicron technology reduces dirt and particles as small as 1/2 micron
Inhibits scale build-up in water-using appliances
NSF registered under NSF/ANSI Standards 42 and 53
OW200L
Capacity: 480 gallons
9619-06
OW4PLUS
Capacity: 2,000 gallons
9635-06
*Everpure® is a trademark of Everpure, Inc., Westmont, IL.
34
4CB5, 7CB5, 4CB5-S, and nu-7CB5-S Cartridge
Carbon Block filter finely polishes water for high quality beverages and food applications.
NSF registered under NSF Standard 42.
• Problem-solving cartridge for high particulate or low flow water pressure areas • Taste and odor, chlorine reduction
• Particulate reduction to 5 micron
• 4CB5-S, and nu-7CB5-S cartridges control scale
4CB5
Capacity: 6,000 gallons
4621-32
7CB5
Capacity: 10,000 gallons
9618-16
4CB5-S
Capacity: 6,000 gallons
4621-31
nu-7CB5-S
Capacity: 10,000 gallons
4621-30
4FC5, 7FC5, 4FC5-S, and 7FC5-S Cartridge
New Fiberdyne™ II media with Agion® antimicrobial protection to inhibit potential bacterial
growth. Balanced for optimum performance in varying water qualities. Helps retain the
drink’s carbonation.
• Increased capacity 25,000 gallons
• 2.5 gpm flow rate
• Taste & odor reduction
• 5 Micron Rating
• Particulate Reduction
• Scale Inhibition (4FC5-S and 7FC5-S)
• NSF Standards 42 and 53
4FC5
Capacity: 15,000 gallons
9693-21
7FC5
Capacity: 25,000 gallons
9693-61
4FC5-S
Capacity: 15,000 gallons
9693-31
7FC5-S
Capacity: 25,000 gallons
9693-71
4FC, 7FC, 4FC-S, and 7FC-S Cartridge
New Fiberdyne™ II media with Agion® antimicrobial protection to inhibit potential bacterial
growth. Balanced for optimum performance in varying water qualities. Improves the taste of
fountain drinks and helps retain the drink’s carbonation.
• Taste & odor reduction
• 0.5 Micron Rating
• Particulate reduction
• NSF Standards 42 and 53
• 2.5 gpm flow rate
• Scale Inhibition (4FC-S, and 7FC-S only)
4FC
Capacity: 15,000 gallons
7FC
Capacity: 25,000 gallons
9692-21
4FC-S
Capacity: 15,000 gallons
7FC-S
Capacity: 25,000 gallons
9692-31
9692-61
9692-71
Visit us at www.nucalgon.com or call 1-800-554-5499
35
Water Filtration - Nu-Plus® by Everpure®
Cartridges
Water Filtration - Nu-Plus® by Everpure®
Cartridges
4SI and 7SI Cartridge
Specially designed for ice machines. This cartridge does not include carbon. The cartridge
reduces sediment and particulate down to 1/2 micron and reduces cyst and Giardia. The filter
allows chlorine to pass through which helps reduce slime and bacteria growth inside the ice
machine and ice bin. Ideal for food service operations where baking of bread and pastries is
done on-site.
• Scale inhibition
• 0.5 micron rating
• Particulate reduction
• NSF Std 42 and 53
• Cyst reduction
4SI
Capacity: 15,000 gallons • 2.0 gpm flow rate
7SI
Capacity: 25,000 gallons • 3.5 gpm flow rate
9606-51
9606-01
7CLM Cartridge
Reduces chloramines, chlorine taste and odor and other offensive contaminants that can
adversely affect the taste of beverages. The cartridge reduces particles down to 1/2 micron
and reduces cysts and Giardia. Improves the taste of fountain beverage and helps retain the
drink’s carbonation. NSF registered.
• Chloramine reduction
• Cyst reduction
• Chlorine reduction
• Particulate reduction
7CLM
9693-01
Capacity: 3,600 gallons at 1.7 gpm, 5,500 gallons at 1.33 gpm
7SO Softening Cartridge
A softening cartridge that reduces scale-forming minerals like calcium and magnesium in
hard water situations. It may be used on water having up to 30 grains hardness per gallon, at
flow rates of up to 1/2 gallons per minute. It is a sanitary quick change cartridge that makes
replacement easy. It should be used with an Everpure fine filter cartridge installed in a series
plumbed twin head.
7SO
Capacity: 2,000 grains • 0.5 gpm max. flow
9607-04
Replacement Cartridges for CUNO®
Nu-Plus® CU and Nu-Plus CU-S
The Nu-Plus E Series CU and CU-S cartridges are replacements that are compatible with the
CUNO Series CFS 8000 filter cartridges. Both incorporate a carbon block filter that reduces
objectionable tastes and odors as well as chlorine and other contaminates, providing high
quality beverage and ice. They also reduce extra fine dirt as small as 5 microns. Additionally,
the CU-S provides for the reduction of scale formation.
Nu-Plus CU
4622-20
Capacity: 10,000 gallons (37,850 liters) • 1.5 gpm flow
Replaces CFS-8112, CFS-8720 & CFS-8812
Nu-Plus CU-S
4622-10
Capacity: 10,000 gallons (37,850 liters) • 1.5 gpm flow
Replaces CFS-8112S,CFS-8720S & CFS-8812S
*Everpure® is a trademark of Everpure, Inc., Westmont, IL.
*CUNO® is a trademark of 3M. This product is not manufactured, sponsored, or affiliated with 3M.
36
Nu-Plus® 10˝ and 20˝ Coarse Prefilters
A 10˝ and 20˝ clear housing, each including a 10˝ and 20˝ replaceable prefilter cartridge. Filters
out larger dirt and rust particles thereby extending the life of submicron and carbon block filters.
E-10
E-20
4621-42
4621-44
Optional: Wing Bracket for all multiple filter head systems manufactured after 2003: 4621-45
Nu-Plus® EC110 and EC210
A 10˝ and 20˝, 10 micron nominal filtration cartridge for filtering out larger dirt and rust
particles, extending the life of primary filters. For use in the E-10 and E-20 housings as well as
other 10˝ and 20˝ housings.
EC110 (10˝)
EC210 (20˝)
4621-41
4621-43
SRX Scale Inhibitor Feeder
A complete system for the control of scale in ice, coffee, steam, and combination applications. It
dispenses a controlled amount of HydroBlend™ compound which provides for a more consistent
feed and longer life. The system includes a clear housing and one cartridge
1 each
4621-05
Optional: Wing Bracket for all multiple filter head systems manufactured after 2003: 4621-06
Nu-Plus® IMF-7 and IMF-10
Ice Machine Feeder Scale inhibition cartridge. The translucent cartridge allows for easy visual
monitoring of the product’s usage. The larger IMF-10 will last longer or treat higher volumes
of water.
IMF-7
IMF-10
Replacement for AR-X 7˝ Housing
Replacement for SS-10 Scale Sticks
4621-13
4621-14
4JT Flushing/Sanitizing Cartridge
The preferred way to introduce ScaleKleen™ Scale Remover or other sanitizing solutions
(IMS-II) into all water-using equipment and vending machines. Fits into existing Everpure
heads. Eliminates the need for difficult component disassembly. Easy and convenient to help
you clean and maintain equipment. Approved by NAMA.
1 each
4621-00
ScaleKleen™ Scale Remover
Restores equipment to peak operating efficiency by removing scale build-up. Quickly removes
limescale from coffee brewers. Ideal for deliming steam and ware washing equipment. Great for
office coffee system (OCS) applications. Non-toxic, safe to skin and won’t burn clothing. Sewer
system disposable; can be poured down the drain. Use with 4JT Flushing/Sanitizing Cartridge.
7 ounce packets (24 per case)
2.2 lb. canister (4 per case)
37
4621-17
9798-35
Visit us at www.nucalgon.com or call 1-800-554-5499
37
Water Filtration - Nu-Plus® by Everpure®
Other Filtration Products
Serving Canada with the Finest
Direct Factory Sales Force in the HVACR Industry
1-800-554-5499
1. George Ottlyk - Ext. 4481
[email protected]
2. Rick Pope - Ext. 4483
[email protected]
3. Tony Vecchio - Ext. 4488
[email protected]
4. Patrick Mee - Ext. 4484
[email protected]
Nu-Calgon
2008 Altom Court | St. Louis, MO 63146
phone: 800-554-5499 | fax: 800-221-6302
www.nucalgon.com
(515) 3-308
Calgon is a licensed trade name.
Was this manual useful for you? yes no
Thank you for your participation!

* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project

Download PDF

advertisement