Bass speakers, cargo compartment Bass speakers, cargo

Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
Instruction No
30664381
Version
1.0
Part. No.
Bass speakers, cargo compartment
M3903045
© Volvo Car Corporation
Bass speakers, cargo compartment- 30664381 - V1.0
Page 1 / 16
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
Equipment
A0000162
M3903046
© Volvo Car Corporation
Bass speakers, cargo compartment- 30664381 - V1.0
Page 2 / 16
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
INTRODUCTION
Read through all of the instructions before starting installation.
Notifications and warning texts are for your safety and to
minimise the risk of something breaking during installation.
Ensure that all tools stated in the instructions are available
before starting installation.
Certain steps in the instructions are only presented in the form
of images. Explanatory text is also given for more complicated
steps.
In the event of any problems with the instructions or the
accessory, contact your local Volvo dealer.
1
Turn the ignition key to position 0
Wait at least five minutes before disassembling the connectors
or removing other electrical equipment
Remove the rear floor hatch. First open the hatch, then pull it
backwards.
M8503119
2
Secure the front floor hatch in the open position.
© Volvo Car Corporation
Bass speakers, cargo compartment- 30664381 - V1.0
Page 3 / 16
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
M8503120
3
Remove the storage box from under the rear floor hatch. Turning
the clips on the left and right-hand sides 90°. Lift out the box.
M8503121
4
Cut out the insulation panel as illustrated.
M8503122
5
Slacken off the screw (1) a few turns. Remove the two nuts (2)
from the holder (3) for the battery
Remove the holder
Remove the protective cover (4) from the battery
Disconnect the battery ground lead.
© Volvo Car Corporation
Bass speakers, cargo compartment- 30664381 - V1.0
Page 4 / 16
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
M3100087
6
Unscrew the holder for the spare wheel, jack and tool bag
Remove the jack and tool bag from the holder (it will not be used
again). There is a new holder and securing device for the jack,
too bag and spare wheel in the kit.
M7700278
7
Tighten the spare wheel using the new securing device from the
kit.
M7700279
8
Remove the rubber washer (1) in the rear cross member behind
the spare wheel. The hole is used to secure the subwoofer at
the rear edge.
© Volvo Car Corporation
Bass speakers, cargo compartment- 30664381 - V1.0
Page 5 / 16
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
M8901651
9
If the car has a pre-routed cable harness for the subwoofer,
disconnect the connector (1) from the cable harness at the rear
cross member and continue to point 31. If the car does not have
a pre-routed cable harness, carry out points 10 to 30 first.
M3702197
10
Remove the folding panels on the left and right-hand sides of the
cargo compartment.
M8503006
11
Remove the rear insulating panels on the right and left-hand
sides.
© Volvo Car Corporation
Bass speakers, cargo compartment- 30664381 - V1.0
Page 6 / 16
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
M8503007
12
Remove the left-hand side panel (first remove the cover and the
screw from the front edge)
Pull the top of the panel out until the clips release
Fold the panel inwards. Lift the panel out.
M8503008
13
Fold the left-hand seat cushion (1) in the rear seat forwards
Fold the backrest (2) forwards.
M8502805
14
Remove the left-hand side cushion. First pull the upper edge of
the cushion backwards and then lift it upwards.
© Volvo Car Corporation
Bass speakers, cargo compartment- 30664381 - V1.0
Page 7 / 16
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
A8500151
15
Remove the panel for the D-post loudspeaker. First carefully pry
off the bottom of the panel using a weatherstrip tool
Place the panel to one side
Repeat the operation on the other side.
M8502927
16
Remove the loudspeaker by pulling out the red catch (1). Press in
the interlock (2) and fold the loudspeaker forwards to lift it out
Disconnect the connector from the loudspeaker. Place it to one
side
Repeat the operation on the other side.
M3902958
17
Route the cable harness from the kit under and along the sill trim
© Volvo Car Corporation
Bass speakers, cargo compartment- 30664381 - V1.0
Page 8 / 16
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
panel for the tailgate and the floor supports on the left and righthand sides as illustrated
Ensure that the cable harness is positioned so that the connector
(1) can be connected to the subwoofer.
M3702198
18
Thread a thick cable (1) or similar through the hole for the
loudspeaker behind the D-post panel and out into the cargo
compartment
Tape the cable harness (2) at the cable and pull it up through the
hole for the loudspeaker
Repeat the operation on the other side.
M3702200
19
Connect the existing loudspeaker connector (1) to the
corresponding connector (2) from the new cable harness
The remaining connector (3) is connected to the loudspeaker
Use the foam tape from the kit to tape around the connectors.
This is to prevent rattling
Repeat the operation on the other side.
M3903047
© Volvo Car Corporation
Bass speakers, cargo compartment- 30664381 - V1.0
Page 9 / 16
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
20
Reinstall the loudspeakers on the right and left-hand sides. Install
the guide pins for the loudspeakers in the corresponding holes in
the D-post
Fold the loudspeakers upwards until the catches engage
Slide in the red catch (1).
M3902915
21
Applies to the left-hand loudspeaker
Route the existing cable harness (1) out of the D-post panel.
Press it into place in the clamp (2) for the loudspeaker
Reinstall the loudspeaker grilles on both loudspeakers
Clamp the loudspeaker cables at the existing cable harnesses at
the D-post panel. Use four tie straps from the kit (two on each
side).
M3903048
22
Clamp the cable harness at the existing cable harness at the rear
cross member. Use four tie straps (1) from the kit.
© Volvo Car Corporation
Bass speakers, cargo compartment- 30664381 - V1.0
Page 10 / 16
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
M3702201
23
Remove the fuse holder. First open the lock (1). Then pull the
holder forward and lift it out of the mountings (2).
M3701938
24
Remove the screw (1)
Pull out the cover (2) and the four connectors
Remove the cover from the four connectors by bending the three
hooks to one side.
D3701827
25A
Illustration A
Check the car VIN. This is stamped in the engine compartment on
the top of the bulkhead (1a), and on the VIN plate on the top of
the dashboard (1b).
Illustration B
Check the digit in position 8 on the VIN and check the chassis
number at position 9 on the VIN (see the illustration).
Illustration C
© Volvo Car Corporation
Bass speakers, cargo compartment- 30664381 - V1.0
Page 11 / 16
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
Applies to:
M8903428
25B
-V70 with VIN marking position 8=1 and chassis numbers up to
and including 287166
-V70 with VIN marking position 8=2 and chassis numbers up to
and including 285999
-V70 XC / XC 70 with chassis numbers up to and including
95081
Note!
The wiring is connected to connector D.
Insert a small screwdriver in the socket as illustrated
Twist the screwdriver so that the holders open. At the same
time, press the connector out to the side
Connect the violet (VO) cable to terminal 18
M0300255
25C
Reinstall the connector
Reinstall the cover on the connector
Reconnect the connectors to the fuse holder. Tighten the screw.
Illustration D
Applies to:
-V70 with VIN marking position 8=1 and chassis numbers from
and including 287167
-V70 with VIN marking position 8=2 and chassis numbers from
and including 286000
-V70 XC / XC 70 with chassis numbers from and including 95082
Note!
M3703215
The wiring is connected to connector D.
25D
Insert a small screwdriver in the socket as illustrated
Twist the screwdriver so that the holders open. At the same
time, press the connector out to the side
Connect the violet (VO) cable to terminal 2
Reinstall the connector
Reinstall the cover on the connector
Reconnect the connectors to the fuse holder. Tighten the screw.
© Volvo Car Corporation
Bass speakers, cargo compartment- 30664381 - V1.0
Page 12 / 16
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
M3702202
26
Install the red (R) cable (1) in position 13. Press the cable into the
fuse holder from the reverse
Install a 30 A fuse from the kit in position 13
Reinstall the fuse holder.
M3702203
27
Route the ground lead (1) along the cable harness for the fuse
holder over the wheel arch and on to the rear ground terminal
under the left-hand seat cushion on the rear seat
Clamp the cable at the cable harness for the fuse holder and
wiring. Clamp it at the drainage hose. Use the tie straps (2) from
the kit as illustrated
Hide the ground lead under the insulation panel if possible.
M3702208
28
Fold the insulation panel out of the way
Connect the ground lead (1) to the rear ground terminal (2)
Fold the insulation panel back into place
Reconnect the battery ground lead
Reinstall the protective cover for the battery
Reinstall the left-hand side panel
Reinstall the rear insulation panels
© Volvo Car Corporation
Bass speakers, cargo compartment- 30664381 - V1.0
Page 13 / 16
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
Reinstall the side cushion
Fold the seat cushion and backrest back into place
Reinstall the folding side panels.
M3702209
29
Thread the strap (1) from the kit into the jack and tool bag holder
(2)
Place the tool bag and the jack in the holder. Tighten the tool bag
and the jack in place using the strap.
M8901652
30
Install the jack and tool bag above the spare wheel. Push the jack
and tool bag towards the front of the spare wheel well and
cable duct (1) as illustrated.
M8901653
31
Take the subwoofer and position it in the three mounting points:
the hole in the rear cross member (1), the right-hand mounting
point (2) for the removed storage box and the two pins (3) for
the battery holder
If necessary: Slacken off the knob (4) so that the mounting aligns
on the studs.
© Volvo Car Corporation
Bass speakers, cargo compartment- 30664381 - V1.0
Page 14 / 16
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
M3903049
32
Press the subwoofer into place on the right-hand side of the
cargo compartment. Turn the clip (1) 90º.
Tighten the subwoofer using the knob (2)
Reinstall the holder for the battery. Tighten the screw and the
two nuts.
M3903050
33
Connect the two connectors on the routed cable (1) to the two
connectors from the subwoofer
Press the cable into the cable duct (2).
M3903051
34
Position the mat from the kit over the subwoofer.
© Volvo Car Corporation
Bass speakers, cargo compartment- 30664381 - V1.0
Page 15 / 16
Installation instructions, accessories
Volvo Car Corporation Gothenburg, Sweden
M8901654
35
Fold down the front floor hatch
Reinstall the rear floor hatch.
© Volvo Car Corporation
Bass speakers, cargo compartment- 30664381 - V1.0
Page 16 / 16