Safety Data Sheet
according to Regulation (EC) No. 1907/2006 (REACH)
Trade name :
Revision date :
Print date :
UNIVERSAL CLEANER
Art. No. 4020
25.11.2015
25.11.2015
Version (Revision) :
2.0.0 (1.0.0)
SECTION 1: Identification of the substance/mixture and of the company/undertaking
1.1
Product identifier
UNIVERSAL CLEANER
Art. No. 4020
1.2
Relevant identified uses of the substance or mixture and uses advised against
Relevant identified uses
1.3
Details of the supplier of the safety data sheet
Supplier (manufacturer/importer/only representative/downstream
user/distributor)
Product Categories [PC] Washing and cleaning products (including solvent based products)
BIOFA Naturprodukte W.Hahn GmbH
Street : Dobelstr.22
Postal code/city : D-73087 Bad Boll
Telephone : +49 (0) 7164-9405-0
Telefax : +49 (0) 7164-9405-94
Information contact :
Respondent department: product safety department
Contact: Mr. Andrew Beuttenmüller
E-mail address of the competent person responsible for the SDS: a.beuttenmueller@biofa.de
.
1.4
Emergency telephone number
During office time 7:30 to 16:30: +49 (0) 7164-9405-0
SECTION 2: Hazards identification
2.1
Classification of the substance or mixture
Classification according to Regulation (EC) No. 1272/2008 [CLP]
2.2
Label elements
2.3
Other hazards
None
None
None known.
Results of PBT and vPvB assessment: Not applicable.
SECTION 3: Composition / information on ingredients
3.2
Mixtures
Hazardous ingredients
None
SECTION 4: First aid measures
Page : 1 / 8
( EN / D )
Safety Data Sheet
according to Regulation (EC) No. 1907/2006 (REACH)
Trade name :
Revision date :
Print date :
4.1
UNIVERSAL CLEANER
Art. No. 4020
25.11.2015
25.11.2015
Version (Revision) :
2.0.0 (1.0.0)
Description of first aid measures
General information
When in doubt or if symptoms are observed, get medical advice. Never give anything by mouth to an unconscious
person or a person with cramps. Remove contaminated, saturated clothing immediately. If unconscious place in
recovery position and seek medical advice.
Following inhalation
Provide fresh air. In case of respiratory tract irritation, consult a physician.
In case of skin contact
Remove contaminated, saturated clothing immediately. Subsequently wash off with: Water
In case of skin reactions, consult a physician.
After eye contact
In case of contact with eyes flush immediately with plenty of flowing water for 10 to 15 minutes holding eyelids apart
and consult an ophthalmologist. If necessary remove contact lenses and continue to flush with plenty of clean, fresh
water.
After ingestion
Call a physician immediately. Put victim at rest, cover with a blanket and keep warm. Do NOT induce vomiting. If
vomiting occurs, be sure to avoid choking. Rinse mouth thoroughly with water.
4.2
Most important symptoms and effects, both acute and delayed
4.3
Indication of any immediate medical attention and special treatment needed
No information available.
In case of accident or unwellness, seek medical advice immediately (show directions for use or safety data sheet if
possible).
SECTION 5: Firefighting measures
5.1
Extinguishing media
Suitable extinguishing media
alcohol resistant foam Carbon dioxide (CO2) Water spray Extinguishing powder
5.2
Special hazards arising from the substance or mixture
"Fire will produce dense black smoke. Exposure to danger decomposition products may cause a health hazard. " In case
of fire may be liberated: Carbon monoxide. Carbon dioxide (CO2) Nitrogen oxides (NOx)
5.3
Advice for firefighters
Use suitable breathing apparatus. Collect contaminated fire extinguishing water separately. Do not allow entering drains
or surface water.
SECTION 6: Accidental release measures
6.1
Personal precautions, protective equipment and emergency procedures
Danger of slipping on spilled product. Provide adequate ventilation. Wear breathing apparatus if exposed to
vapours/dusts/aerosols. See protective measures under point 7 and 8.
6.2
Environmental precautions
Do not allow to enter into surface water or drains. If the product contaminates drains, lakes, rivers or sewers, inform
the appropriate authorities in accordance with local regulations.
6.3
Methods and material for containment and cleaning up
For cleaning up
Page : 2 / 8
( EN / D )
Safety Data Sheet
according to Regulation (EC) No. 1907/2006 (REACH)
Trade name :
Revision date :
Print date :
UNIVERSAL CLEANER
Art. No. 4020
25.11.2015
25.11.2015
Version (Revision) :
2.0.0 (1.0.0)
Larger amounts have to be pumped out. Contain and collect small spillages with non-combustible absorbent materials,
e.g. sand, earth, vermiculite or diatomaceous earth and place in container for disposal according to local regulations
(see section 13). Wash with plenty of water.
6.4
Reference to other sections
See protective measures under point 7 and 8.
SECTION 7: Handling and storage
7.1
Precautions for safe handling
Avoid contact with skin and eyes.
Keep container tightly closed. Never use pressure to empty container. Keep/Store only in original container. Comply with
health and safety regulations.
Do not allow to enter into surface water or drains.
7.2
Conditions for safe storage, including any incompatibilities
Store in accordance with local regulations.
Hints on joint storage
Keep away from: Alkali (lye). Acid Oxidising agent
Storage class : 12
Storage class (TRGS 510) : 12
Further information on storage conditions
Observe label and technical data sheet precautions. Keep only in the original container in a cool, well-ventilated place.
Protect against Heat. Frost Containers which are opened must be carefully resealed and kept upright to prevent
leakage.
7.3
Specific end use(s)
Universal cleaner.
SECTION 8: Exposure controls/personal protection
8.1
Control parameters
8.2
Exposure controls
Appropriate engineering controls
None
Not necessary
Personal protection equipment
Safety data sheet of raw material suppliers or taken by accredited Laboratories or have been dertermined internally
Eye/face protection
Suitable eye protection Eye glasses with side protection
Skin protection
After cleaning apply high-fat content skin care cream.
Hand protection
Tested protective gloves must be worn DIN EN 374
Breakthrough times and swelling properties of the material must be taken into consideration.
Suitable material : NBR (Nitrile rubber)
Thickness of the glove material 0,35 mm
Page : 3 / 8
( EN / D )
Safety Data Sheet
according to Regulation (EC) No. 1907/2006 (REACH)
Trade name :
Revision date :
Print date :
UNIVERSAL CLEANER
Art. No. 4020
25.11.2015
25.11.2015
Version (Revision) :
2.0.0 (1.0.0)
Breakthrough time (maximum wearing time) > 480 min.
NR (natural rubber, natural latex)
Thickness of the glove material 0,5 mm
Breakthrough time (maximum wearing time) > 480 min.
PVC (Polyvinyl chloride)
Thickness of the glove material 0,5 mm
Breakthrough time (maximum wearing time) > 480 min.
Body protection
Personnel should wear impermeable protective work clothing.
Recommended material Natural fibres (e.g. cotton)
Respiratory protection
Not necessary
Environmental exposure controls
See section 7. No additional measures necessary.
SECTION 9: Physical and chemical properties
9.1
Information on basic physical and chemical properties
Appearance
Physical state : liquid
Colour : green
Odour
characteristic
Odour threshold
Not determined
Safety relevant basis data
Melting point/melting range :
Initial boiling point and boiling
range :
Decomposition temperature :
Flash point :
Ignition temperature :
Lower explosion limit :
Upper explosion limit :
Vapour pressure :
Density :
Solvent separation test :
Water solubility :
pH :
Flow time :
Solid content :
Solvent content :
Maximum VOC content (EC) :
Maximum VOC content
(Switzerland) :
No data available
( 1013 hPa )
(
(
(
(
50
20
20
20
°C
°C
°C
°C
>
<
No data available
not applicable
not applicable
not applicable
not applicable
No data available
0,993 - 0,997
not applicable
completely mixable
6,7 - 7,1
20
not determined
0
0,1
<
0,1
)
)
)
)
( 20 °C )
100
<
°C
DIN EN ISO 1523
g/cm3
DIN 53217
s
DIN-cup 4 mm
Wt %
Wt %
Wt %
Self-ignition: Product is not self-igniting.
Page : 4 / 8
( EN / D )
Safety Data Sheet
according to Regulation (EC) No. 1907/2006 (REACH)
Trade name :
Revision date :
Print date :
UNIVERSAL CLEANER
Art. No. 4020
25.11.2015
25.11.2015
Version (Revision) :
2.0.0 (1.0.0)
danger of explosion by solvents: Not applicable
Relative density: Not determined
Vapour density: Not determined
Evaporation rate: Not determined
N-octanol-water partition coefficient: Not determined
9.2
Other information
None
SECTION 10: Stability and reactivity
10.1
Reactivity
No dangerous reactivity under recommended usage, handling and storage.
10.2
Chemical stability
Stable under recommended usage, storage and handling conditions (see section 7).
10.3
Possibility of hazardous reactions
10.4
Conditions to avoid
10.5
Incompatible materials
10.6
Hazardous decomposition products
None known.
Thermal decomposition can lead to the escape of irritating gases and vapours.
Alkali (lye). Acid Oxidising agent.
By combustion and thermal decomposition at high temperatures, the following chemicals can be produced: Carbon
dioxide. Carbon monoxide. Nitrogen oxides (NOx). carbon black.
SECTION 11: Toxicological information
11.1
Information on toxicological effects
Irritant and corrosive effects
Primary irritation to the skin
The product is: Not an irritant.
Irritation to eyes
The product is: Not an irritant.
Irritation to respiratory tract
The product is: Not an irritant.
Sensitisation
not sensitising.
Repeated dose toxicity (subacute, subchronic, chronic)
Toxicological data are not available.
CMR effects (carcinogenicity, mutagenicity and toxicity for reproduction)
Carcinogenicity
Toxicological data are not available.
Germ cell mutagenicity
Toxicological data are not available.
Reproductive toxicity
Toxicological data are not available.
Page : 5 / 8
( EN / D )
Safety Data Sheet
according to Regulation (EC) No. 1907/2006 (REACH)
Trade name :
Revision date :
Print date :
UNIVERSAL CLEANER
Art. No. 4020
25.11.2015
25.11.2015
Version (Revision) :
2.0.0 (1.0.0)
SECTION 12: Ecological information
12.1
Toxicity
12.2
Persistence and degradability
No information available.
The surfactants/soaps contained in this mixture meet the requirements of Detergents Regulation 648/2004/EC
concerning their biodegradability
12.3
Bioaccumulative potential
No indication of bioaccumulation potential.
12.4
Mobility in soil
No data available
12.5
Adsorption/Desorption
Results of PBT and vPvB assessment
12.6
Other adverse effects
This substance does not meet the PBT/vPvB criteria of REACH, annex XIII.
No data available
12.7
Additional ecotoxicological information
Do not allow to enter into surface water or drains.
SECTION 13: Disposal considerations
13.1
Waste treatment methods
Do not allow to enter into surface water or drains.
Product/Packaging disposal
Wastes and empty containers must be classified in accordance with the Waste Catalogue Ordinance.
Waste codes/waste designations according to EWC/AVV
Waste code product
20 01 30
Waste name
Detergents other than those mentioned in 20 01 29*.
Waste treatment options
Appropriate disposal / Package
Packing which cannot be properly cleaned must be disposed of.
Non-contaminated packages may be recycled.
SECTION 14: Transport information
14.1
UN number
14.2
UN proper shipping name
14.3
Transport hazard class(es)
No dangerous goods in sense of this transport regulation.
No dangerous goods in sense of this transport regulation.
No dangerous goods in sense of this transport regulation.
Page : 6 / 8
( EN / D )
Safety Data Sheet
according to Regulation (EC) No. 1907/2006 (REACH)
Trade name :
Revision date :
Print date :
14.4
UNIVERSAL CLEANER
Art. No. 4020
25.11.2015
25.11.2015
Version (Revision) :
2.0.0 (1.0.0)
Packing group
No dangerous goods in sense of this transport regulation.
14.5
Environmental hazards
No dangerous goods in sense of this transport regulation.
14.6
Special precautions for user
None
SECTION 15: Regulatory information
15.1
Safety, health and environmental regulations/legislation specific for the substance or
mixture
EU legislation
Regulation (EC) No. 2037/2000 concerning materials, which cause damage to the ozone layer. Not applicable
Directive 96/82/EC for danger control following severe accidents with dangerous substances Not subject to 96/82/EC
National regulations
Restrictions of occupation
None, if handled according to order.
Störfallverordnung
Not subject to StörfallVO.
Water hazard class (WGK)
Class : nwg (Non-hazardous to water) Classification according to VwVwS
Other regulations, restrictions and prohibition regulations
Betriebssicherheitsverordnung (BetrSichV)
No flammable liquid according to BetrSichV.
Additional information
Giscode : GU 40
15.2
Chemical Safety Assessment
Chemical safety assessments for substances in this preparation were not carried out.
SECTION 16: Other information
16.1
Indication of changes
02. Classification of the substance or mixture · 02. Label elements · 07. Hints on joint storage - Storage class · 08.
Occupational exposure limit values · 14. Transport hazard class(es) - Land transport (ADR/RID) · 14. Transport hazard
class(es) - Sea transport (IMDG) · 14. Transport hazard class(es) - Air transport (ICAO-TI / IATA-DGR) · 15. Water
hazard class (WGK)
16.2
Abbreviations and acronyms
None
16.3
Key literature references and sources for data
Regulation (EC) No. 1907/2006 (REACH), 1272/2008 (CLP) in the current version.
Classification for mixtures and used evaluation method according to regulation (EC) 1272/2008 [CLP] Transport
regulations according ADR, RID, IMDG, IATA in the current version.
Safety data sheet taken from raw material suppliers or taken by accredited Laboratories or have been dertermined
internally
16.4
Classification for mixtures and used evaluation method according to regulation (EC)
1272/2008 [CLP]
Page : 7 / 8
( EN / D )
Safety Data Sheet
according to Regulation (EC) No. 1907/2006 (REACH)
Trade name :
Revision date :
Print date :
UNIVERSAL CLEANER
Art. No. 4020
25.11.2015
25.11.2015
Version (Revision) :
2.0.0 (1.0.0)
No information available.
16.5
Relevant H- and EUH-phrases (Number and full text)
16.6
Training advice
None
None
16.7
Additional information
None
The above information describes exclusively the safety requirements of the product and is based on our present-day
knowledge. The information is intended to give you advice about the safe handling of the product named in this safety data
sheet, for storage, processing, transport and disposal. The information cannot be transferred to other products. In the case of
mixing the product with other products or in the case of processing, the information on this safety data sheet is not necessarily
valid for the new made-up material.
Page : 8 / 8
( EN / D )
Download PDF