NATURAL GAS & POWER
ENERGY SAVINGS COMPANY
On-site electric and thermal power.
OPG Co-Gen 40KW
Standby Power Rating
40kW 49kVA 60Hz
Prime Power Rating*
35kW 44kVA 60Hz
Features
Codes and Standards
• 40kW On-Site Production of Hot Water & Electricity
UL2200, UL508, UL142, UL498
• Manufactured in U.S.A
NFPA70, 99, 110, 37
• Compact design
• Connection ready
NEC700, 701, 702, 708
• Indoor/Outdoor installation
• 5 Year Maintenance Coverage
ISO9001, 8528, 3046, 7637, Pluses #2b, 4
• Network data connection
• Runs 24/7 in parallel with the grid
NEMA ICS10, MG1, 250, ICS6, AB1
• Operates with clean natural gas
• Meets SCAQMD standards
ANSI C62.41
• Sound proof within 70 decibels
IBC 2009, CBC 2010, IBC 2012, ASCE 7-05,
ASCE 7-10, ICC-ES AC-156 (2012)
• Vibration free
• Weather resistant enclosure
Standard Features
ENGINE SYSTEM
General
•
•
•
•
•
•
•
Cooling System
Oil Drain Extension
Air Cleaner
Fan Guard
Stainless Steel Flexible Exhaust Connection
Critical Exhaust Silencer (enclosed only)
Factory Filled Oil
Radiator Duct Adapter (open set only)
•
•
•
•
•
Engine Electrical System
Fuel System
•
•
•
•
•
• Primary and Secondary Fuel Shutoff
• Flexible Fuel Line - NPT Connection
2917 Vail Ave. Commerce, CA 90040 Closed Coolant Recovery System
UV/Ozone Resistant Hoses
Factory-Installed Radiator
Radiator Drain Extension
50/50 Ethylene Glycol Antifreeze
Phone: (310) 409-4616
Battery Charging Alternator
Battery Cables
Battery Tray
Solenoid Activated Starter Motor
Rubber-Booted Engine Electrical Connections
www.orionpowergroup.com
sales@orionpowergroup.com
NATURAL GAS & POWER
ENERGY SAVINGS COMPANY
Standard Features
On-site electric and thermal power.
OPG Co-Gen 40KW
ALTERNATOR SYSTEM
Alternator System
•
•
•
•
•
•
•
•
Generator Set
UL2200 EGNprotect ™
Class H Insulation Material
2/3 Pitch
Skewed Stator
Brusless Excitation
Sealed Bearings
Amortisseur Winding
Full Load Capacity Alternator
•
•
•
•
•
•
•
•
Internal Genset Vibration Isolation
Separation of Circuits - high/low voltage
Separation of Circuits - multiple breakers
Wrapped Exhaust Piping
Standard Factory Testing
2 Year Limited Warranty (Standby Rated Units)
1 Year Warranty (Prime Rated Units)
Silencer mounted in discharge hood (enclosed only)
•
•
•
•
Air discharge hoods for radiator-upward pointing
Stainless steel lift off door hinges
Stainless steel lockable handles
Rhino Coat ™ - Textured polyester powder coat
Enclosure (If selected)
•
•
•
•
Rust-proof fasteners with nylon washers to protect finish
High performance sound-absorbing material
Gasket doors
Stamped air-intake louvers
Standard Features
CONTROL SYSTEM
Control Panel
•
•
•
•
•
•
•
•
•
•
•
•
•
Digital H Control Panel - Dual 4x20 Display
Programmable Crank Limiter
7-Day Programmable Exerciser
Special Applications Programmable PLC
RS-232/485
All-Phase Sensing DVR
Full System Status
Utility Monitoring
Low Fuel Pressure Indication
2-Wire Start Compatible
Power Output (kW)
Power Factor
kW Hours, Total & Last Run
Standard Features
•
•
•
•
•
•
•
•
•
•
•
•
•
Real/Reactive/Apparent Power
All Phase AC Voltage
All Phase Currents
Oil Pressure
Coolant Temperature
Coolant Level
Engine Speed
Battery Voltage
Frequency
Date/Time Fault History (Event log)
Isochronous Governor Control
Waterproof/Sealed Connectors
Audible Alarms and Shutdowns
•
•
•
•
•
•
•
•
•
•
•
•
•
Not in Auto (Flashing Light)
Auto/Off/Manual Switch
E-Stop (Red Mushroom-Type)
NFPA110 Level I and II (Programmable)
Customizable Alarms, Warnings, and Events
Modbus Protocol
Predictive Maintenance Algorithm
Sealed Boards
Password parameter adjustment protection
Single Point Ground
15 Channel Data Logging
0.2 Sec High Speed Data Logging
Alarm information automatically comes up
on the display
ALTERNATOR SYSTEM
Alarms
•
•
•
•
•
Oil Pressure (Pre-Programmable Low Pressure Shutdown)
Coolant Temperature (Pre-Programmed High Temp Shutdown)
Low Fuel Pressure Alarm
Engine Speed (Pre-Programmed Over Speed Shutdown)
Battery Voltage Warning
2917 Vail Ave. Commerce, CA 90040 Phone: (310) 409-4616
•
•
•
•
Alarms & Warnings Time and Date Stated
Alarms & Warnings for Transient and Steady State Conditions
Snap shots of key operation perameters during alarms & warning
Alarms & Warnings Spelled Out (No Alarm Codes)
www.orionpowergroup.com
sales@orionpowergroup.com
NATURAL GAS & POWER
ENERGY SAVINGS COMPANY
On-site electric and thermal power.
OPG Co-Gen 40KW
Configurable Options
ENGINE SYSTEM
General
• Engine Block Heater
• Oil Heater
• Air Filter Restriction Indicator
• Stone Guard (Open Set Only)
• Critical Exhaust Silencer (Open Set Only/Standard on Low
Emissions option)
Engine Electrical System
Alternator System
• 10A UL Battery Charger
• 2.5A UL Battery Charger
• Battery Warmer
•
•
•
•
Generator Set
•
•
•
•
•
•
•
Circuit Breaker Options
Gen-Link Communications Software
Extended Factory Testing (3 Phase Only)
IBC Seismic Certification
8 Position Load Center
2 Year Extended Warranty
5 Year Warranty
5 Year Extended Warranty
Configurable Options
Alternator Upsizing
Anti-Condensation Heater
Tropical Coating
Permanent Magnet Excitation
•
•
•
•
Main Line Circuit Breaker
2nd Main Line Circuit Breaker
Shunt Trip and Auxiliary Contact
Electronic Trip Breakers
ENCLOSURE
Enclosure
•
•
•
•
•
•
Standard Enclosure
Level 1 Sound Attenuation
Level 2 Sound Attenuation
Steel Enclosure
Aluminum Enclosure
150 MPH Wind Kit
•
•
•
•
•
12 VDC Enclosure Lighting Kit
120 VAC Enclosure Lighting Kit
AC/DC Enclsoure Lighting Kit
Door Alarm Switch
Standard Enclosure
Control System
•
•
•
•
•
21-Light Remote Annunciator
Remote Relay Panel (8 or 16)
Oil Temperature Sender with Indication Alarm
Remote E-Stop (Break Glass-Type, Surface Mount)
Remote E-Stop (Red Mushroom-Type, Surface Mount)
•
•
•
•
•
Remote E-Stop (Break Glass-Type, Flush Mount)
Remote Communication-Modem
Remote Communication-Ethernet
10A Run Relay
Ground Fault Indication & Protection Functions
Heat Exchangers
• Stainless Steel
• Double Wall
• Exhaust and Radiator
2917 Vail Ave. Commerce, CA 90040 Phone: (310) 409-4616
www.orionpowergroup.com
sales@orionpowergroup.com
NATURAL GAS & POWER
ENERGY SAVINGS COMPANY
Power
On-site electric and thermal power.
OPG Co-Gen 40KW
Consumption
Related Output
Voltage
Phase/Wires
Power Factor
Input
(Parasitic loads)
kW
ACV
%
Consumption
Radiator Fan Stopped
Radiator Fan Operating
Heater for Cold Region
Voltage
Fuel
Consumption
Low Heating Value
High Htg Value
Natural Gas
Heat Recovery
Hot Water Temp.
Efficiency
Dimensions
Notes
Units
kW
kW
kW
ACV
Units
BTU/h
Therms/h
Consumption
Low Heating Value
Inlet
Outlet
Hot Water Flow Rate
Consumption
Overall Fuel Efficiency
Electrical Generation Efficiency
Exhaust Heat Recovery Ratio
Sound Level
Units
Units
BTU/h
Deg F
Deg F
Gal/Min
Units
%
%
%
Consumption
Units
Radiator Fan Stopped
Radiator Fan Operating
dB(A)
dB(A)
Consumption
Units
Length
Width
Height
Net Weight
Inches
Inches
Inches
Pounds
Model 40
40
208@60Hz or 480@60Hz
3 Phase, 3 Wire
Greater than 95
Model 40
0.31
0.64
0.82
208 or 480
Model 40
376,000
4.10
Model 40
195,614
170- (MIN) 150
185 - (MAX) 195
20
Model 40
82
35
47
Model 40
60 (Ind) 15 (Hotel)
65 (Ind) 20 (Hotel)
Model 40
93.50
45.00
54.00
1,980
1. OPG GO-GEN MODEL 40 SYNCHRONOUS 208 VOLT 3 PHASES UL LISTED NO. MARATHON E 218422
2. EPA + SCAQMD EMMISSION COMPLAINT UNDER 50 HP
3. RATED AT 49 HP
2917 Vail Ave. Commerce, CA 90040 Phone: (310) 409-4616
www.orionpowergroup.com
sales@orionpowergroup.com
Download PDF
Similar pages