Fire Magic beim Außenküchen Profi gardelino.de

CHARCOAL
LEGACY GRILL
12 & 14 BUILT-IN SERIES
22 & 24 STAND ALONE SERIES
Front view of charcoal grill
unit (with optional smoker
oven/hood and warming rack)
showing access door open
FOR YOUR SAFETY
Do not store or use gasoline or other flammable vapors and liquids
in the vicinity of this or any other appliance.
INSTALLATION OPENING REQUIREMENTS
12 Series: 19 3/4" depth, 26 1/4" width, 12" height
14 Series: 19 3/4" depth, 32 1/4" width, 12" height
Stand alone charcoal grill
(with optional smoker oven/hood)
The grill serial identification number is
located on the underside of the drip tray
handle. It is recommended that the drip tray
first be removed and cleaned / emptied of its
contents, then turned over to view.
The Fire Magic® stainless steel charcoal grill has the benefit of an adjustable height charcoal pan
allowing you to change the height of the charcoal while cooking and gives you the ability to add fuel
without having to remove the cooking grids. This enables the outdoor chef to be in complete control
of cooking heat at the grilling surface.
combustible
Non-combustible
WARNING
(wall or backsplash)
Built-in models must be installed in masonry or other type of fireproof
enclosure. The unit is not insulated and therefore must be installed
with 18" of side and back clearance from unprotected combustible
materials such as wood, plastic or stucco with wood framing.
The unit must have a minimum of 4" right, left, and rear clearance
from any non-combustible wall (or backsplash) for proper ventilation
and to prevent dangerous overheating. If a smoker hood is
installed, the rear clearance must be 11" to allow the hood to
open.
Do not install this unit under unprotected flammable
surfaces. Do not install or use this appliance inside a
building, garage, or any other enclosed area, including
recreational vehicles or boats.
Carefully unpack your grill and check the parts. If you have
purchased a built-in, simply slide the unit into your grill
opening. Next, fit the crank handle into the hole on the front
right side of the face. Aligning it carefully, screw it into the
nut on the frame (see Fig. 1-1). After installation, crank the
handle in and out to raise and lower the charcoal pan.
Min.
4"
Min.
18"
(Gourmet hood)
(Clearance required for right, left, and rear)
Non-combustible
(wall or backsplash)
Min.
11"
(Smoker hood)
Close access
door when
cranking handle.
Handle
Access
door
Fig. 1-1 Installing the crank handle
ROBERT H. PETERSON CO. • 14724 East Proctor Avenue • City of Industry, CA 91746
REV 4-1703210715
1
L-C2-153
INSTALLATION
WARNING
Improper installation, adjustment, alteration, service, or maintenance can cause injury or property
damage. Refer to this manual. For assistance or additional information, consult a qualified professional
installer or service agency.
CHARCOAL GRILL OVEN (optional)
Fig. 2-1
If you purchased an oven with your charcoal grill it will come pre-assembled
from the factory.
The oven (with the rounded top Fig. 2-1) is easy to remove and replace.
Simply remove the cooking grids and lift the oven off of the grill, then replace
the cooking grids. To reinstall reverse the above process.
The smoker model oven has an angled lid and adjustable air vents to aid in
controlling the rate at which the charcoal burns. The oven may be lifted off
after removing the left and right retaining screws (Fig. 2-2) on the inside of
the oven.
Fig. 2-2
Clean all surfaces with Fire Magic® foaming grill cleaner.
For stainless steel restoration and finish maintenance, see the instructions
enclosed with Fire Magic® products for stainless steel.
Ashes and dripping are removed by sliding the drip tray out from
beneath the grill. You must keep the drip tray heat shield in position for
proper operation.
Retaining screw
USING THE GOURMET STAINLESS STEEL CHARCOAL GRILL
1. Remove the cooking grids and pile your charcoal on the charcoal pan. Avoid spillage.
WARNING: When adding charcoal, spread it across the charcoal pan evenly and DO NOT exceed a height
of 1" above the charcoal pan.
Excessive amounts of charcoal may cause over heating and damage to your grill.
2. Follow the instructions supplied with your charcoal/fuel for lighting.
3. Turning the crank handle raises or lowers the charcoal pan to increase or decrease the grilling heat as you
desire.
4. Lower the charcoal pan and open the access door to add or spread out your coals while cooking.
WARNING
All surfaces of the charcoal unit become HOT during use. Exercise
caution when using this unit, especially when adding charcoal or
cranking the charcoal pan up or down.
EXHAUST REMOVAL
If installed under a patio roof, the grill area should be fully covered by a non-combustible chimney and exhaust
hood. An exhaust fan with a rating of 1,000 CFM or more is necessary to efficiently remove smoke and other
cooking by-products from the covered area.
THIS UNIT SHOULD NOT BE LOCATED IN A FULLY ENCLOSED AREA OF ANY KIND.
REV 4-1703210715
2
L-C2-153
GOURMET BUILT-IN PARTS LIST
CUSTOM I
Item no. Part no.
Description
1.
23729
Gourmet hood (optional)
2.
3542-DS-2 Cooking grids, Diamond Sear (2)
3.
3302-S
Charcoal pan
4.
400363
Liner assembly
5.
3137-06
Face
6.
3900-40
Handle only
7.
23302
Crank
8.
3081
Drip tray
9.
3672S
Gourmet warming rack (optional)
Item no.
1.
2.
3.
4.
5.
6.
7.
8.
9.
Part no.
23733
3543-DS-3
3304-S
400364
3162-06
3900-40
23302
3082
3673S
REGAL I
Description
Gourmet hood (optional)
Cooking grids, Diamond Sear (3)
Charcoal pan (2)
Liner assembly
Face
Handle only
Crank
Drip tray
Gourmet warming rack (optional)
9
1
3
2
4
Replacement parts can be ordered from
your local Fire Magic® dealer.
6
8
5
7
Drip tray
Drip tray
heat shield
Note: 14'' model shown.
REV 4-1703210715
3
L-C2-153
SMOKER BUILT-IN PARTS LIST
CUSTOM I
Item no. Part no.
Description
1.
23759-C
Smoker hood
2.
3542-DS-2 Cooking grids, Diamond Sear (2)
3.
3305
Charcoal shield
4.
3302-S
Charcoal pan
5.
400363
Liner assembly
6.
3137-06
Face
7.
3900-40
Handle only
8.
23302
Crank
9.
3081
Drip tray
10.
3672C
Gourmet warming rack
Item no.
1.
2.
3.
4.
5.
6.
7.
8.
9.
10.
Part no.
23763-C
3543-DS-3
3305
3304-S
400364
3162-06
3900-40
23302
3082
3673C
REGAL I
Description
Smoker hood
Cooking grids, Diamond Sear (3)
Charcoal shield
Charcoal pan (2)
Liner assembly
Face
Handle only
Crank
Drip tray
Gourmet warming rack
1
10
4
3
2
5
Replacement parts can be ordered from
your local Fire Magic® dealer.
7
9
6
8
Drip tray
Drip tray
heat shield
Note: 14'' model shown.
REV 4-1703210715
4
L-C2-153
GOURMET STAND ALONE PARTS LIST
CUSTOM I
Item no. Part no.
Description
1.
23729
Gourmet hood
2.
3542-DS-2 Cooking grids, Diamond Sear (2)
3.
3302-S
Charcoal pan
4.
400365
Liner assembly
5.
25326-015 Shelves
6.
25326-014 Cart base
7.
3400-7
Casters set only
8.
3137-06
Face
9.
3900-40
Handle only
10.
23302
Crank
11.
3081
Drip tray assembly
12.
3672S
Gourmet warming rack (optional)
Item no.
1.
2.
3.
4.
5.
6.
7.
8.
9.
10.
11.
12.
Part no.
23733
3543-DS-3
3304-S
400366
25326-015
25361-014
3400-7
3162-06
3900-40
23302
3082
3673S
Replacement parts can be
ordered from your local
Fire Magic® dealer.
12
1
REGAL I
Description
Gourmet hood
Cooking grids, Diamond Sear (3)
Charcoal pan (2)
Liner assembly
Shelves
Cart base
Casters set only
Face
Handle only
Crank
Drip tray assembly
Gourmet warming rack (optional)
2
5
3
4
6
8
9
11
10
Drip tray
heat shield
7
Drip tray
Note: 24" model shown.
REV 4-1703210715
5
L-C2-153
SMOKER STAND ALONE PARTS LIST
CUSTOM I
Item no. Part no.
Description
1.
23759-C
Smoker hood
2.
3542-DS-2 Cooking grids, Diamond Sear (2)
3.
3305
Charcoal shield
4.
3302-S
Charcoal pan
5.
400365
Liner assembly
6.
25326-015 Shelves
7.
25326-014 Cart base
8.
3400-7
Casters set only
9.
3137-06
Face
10.
3900-40
Handle only
11.
23302
Crank
12.
3081
Drip tray assembly
13.
3672C
Gourmet warming rack
Replacement parts can be
ordered from your local
Fire Magic® dealer.
1
13
3
REGAL I
Item no. Part no.
Description
1.
23763-C
Smoker hood
2.
3543-DS-3 Cooking grids, Diamond Sear (3)
3.
3305
Charcoal shield
4.
3304-S
Charcoal pan (2)
5.
400366
Liner assembly
6.
25326-015 Shelves
7.
25361-014 Cart base
8.
3400-7
Casters set only
9.
3162-06
Face
10.
3900-40
Handle only
11.
23302
Crank
12.
3082
Drip tray assembly
13.
3673C
Gourmet warming rack
2
14
6
4
5
7
9
10
12
11
Drip tray
heat shield
Drip tray
8
Note: 24" model shown.
REV 4-1703210715
6
L-C2-153
ACCESSORIES
GRILL BRUSH (optional)
WARMING RACK (if equipped)
Purchase a Fire Magic® stainless-steel grill brush (sold
separately) to keep your grill cleaner. It comes with
scraper for large particles and a replaceable head with
brass bristles for overall cleaning.
The warming rack (Fig. 7-2) is packed separately.
To install the warming rack, lift the front of the rack up
slightly and insert the rack hangers into the two holes
in the back of the inner oven hood. Then lower the front
of the rack into a level position to lock the rack in place.
To remove the warming rack, lift up on the front of the
rack until the rack hangers pull free from their supporting
holes.
Fig. 7-1
Note: Removing the warming rack before using the
rotisserie will leave more clearance for the
meat being cooked. (if applicable)
Grill brush with replacement head
AIR SHUTTERS (Smoker hoods only)
CAUTION: The air shutters become very hot when
the grill is in use. Use a tool or heatinsulated glove to adjust the air shutters.
The air shutters (Fig. 7-3) on both sides of the smoker
oven can be used to regulate the flow of air to the coals
when the oven is closed.
CHARCOAL SHIELD (if equipped)
The charcoal shield allows meat drippings to drip down
to the drip tray without affecting the charcoal.
Fig. 7-2 Warming rack in place inside oven
Place it over the coals (and beneath the cooking grids)
as shown in Fig. 7-4.
USING AND (UN)LOCKING CASTERS (Stand
alone only)
The shield may also be used for smoking or indirect
cooking methods. Simply set up as shown (using wood
chips if desired), toward one side of the grill. Place the
food on the opposite side of the grill.
The portable cart comes with four (4) casters, two (2)
of which are locking and articulated.
For ease in guiding the cart when pushing, steer from
behind with the articulated casters and lead with the
others.
Before using the grill, always lock the casters by pushing
down on the side of the steel rocker labeled OFF until
the wheel will no longer roll (Fig. 7-6).
Fig. 7-3
Before moving the grill, wait for it to cool, then unlock
the wheels again by pressing the side of the steel rocker
labeled ON until the wheel rolls.
Fig. 7-4
DRIP TRAY
After each use, wait for the
grill to cool and carefully pull
out the charcoal drip tray to
check it. When nearing full,
carefully pull out the drip tray,
lifting with both hands to keep
the tray level until it is safely
discarded.
DIMPLES MUST
FACE DOWNWARD
Fig. 7-5
Note: The charcoal drip tray
has a heatshield to protect from over heating. It
may be necessary to remove the heatshield to
properly clean out the charcoal drip tray. When
reinstalling, the heatshield dimples must face
downward as shown in Fig. 7-5.
Fig. 7-6
Locking the casters
7
NOTES PAGE
Please use this page to record any information that you may want to have at hand.
8
CARE & CLEANING
APPLIANCE MUST BE COMPLETELY COOL WHEN CLEANING. DO NOT
SPRAY ANY CLEANER OR LIQUIDS ON THE APPLIANCE WHEN HOT.
The appliance must be cleaned as often as once a month (depending on
use) to prevent grease build-up and other food deposits.
A clean and well maintained appliance prevents the risk of grease fires.
Reference the GRILL MAINTENANCE AND SAFETY section.
Wipe with
grain
COOKING GRIDS
Before and after each use, clean the cooking grids with a Fire Magic Grill Brush
(sold separately). Before initial use and periodically, it is suggested that the
cooking grids be washed with a mild soap and warm water solution.
Fig. 9-1 Wipe with grain
INTERIOR
Empty the charcoal drip tray and screen of all ash and drippings after each use. Clean the charcoal screen, pan, and the
interior of the grill with a water and mild soap solution.
The inside of the appliance may be cleaned periodically with oven cleaner if desired. Follow the oven cleaner instructions for
proper use.
Be careful not to get oven cleaner on the outside surface of the appliance as it can permanently damage the finish.
EXTERIOR
Stainless steel surfaces when exposed to temperatures produced by the grilling process will change color. The stainless steel
will change color from silver to brown and blue. This can be removed by using stainless steel cleaner.
Clean your appliance by first using stainless steel grill cleaner to remove grease and dirt. Always wipe with the grain (See
Fig. 9-1). Next, apply stainless steel polish and wipe down using polish wipes to restore the stainless steel color.
If your appliance is installed in a seaside (salt air) or poolside (chlorine) location, it will be more susceptible to corrosion and
must be maintained/cleaned more frequently. Do not store chemicals (such as chlorine or fertilizer) near your stainless steel
appliance.
Due to the nature of stainless steel, surface iron oxide deposits may appear. Do not be alarmed – these deposits are removable
with stainless steel cleaner through prompt and periodic maintenance. If not attended to promptly, permanent pitting may occur.
By following these recommendations, you will enjoy the beauty and convenience of your appliance for many years to come.
PROTECTING YOUR APPLIANCE FROM THE WEATHER
An optional cover will protect your appliance when not in use. Allow to cool before covering. Please specify the model number
and serial number of your appliance when ordering a cover.
9
WARRANTY
PETERSON FIRE MAGIC GRILLS AND ACCESSORIES
LIMITED WARRANTY
Robert H. Peterson Co. ("RHP") warrants your Fire Magic® grill to be free from defects in material and workmanship.
Fire Magic® cast stainless-steel burners, stainless-steel cooking grids, and stainless-steel housings are warranted for as long as you own
your Fire Magic® grill -- LIFETIME. (Except as noted below.)
Fire Magic Choice stainless steel tubular burners are warranted for TWENTY (20) YEARS.
Fire Magic® cast brass burners, brass valves, inner liners, manifold assemblies, porcelain housings (including ovens and barbecue faces),
and backburner assemblies (except ignition parts) are warranted for FIFTEEN (15) YEARS.
Fire Magic® Electric Grills, including stainless steel grid, and housings are warranted for TEN (10) YEARS.
Fire Magic® Infra-red burners, flavor grids, Charcoal stainless steel grills, and Smokers are warranted for FIVE (5) YEARS; except for the
charcoal pan, charcoal grid, wood pellet screen, thermometer, and ash tray; which are warranted for ONE (1) YEAR.
Fire Magic® sideburners and all other Fire Magic® grill components (except ignition and electronic parts) are warranted for THREE (3)
YEARS.
Fire Magic® ignition systems (excluding batteries), electronic components (including lights and thermometers), and grill accessories are
warranted for ONE (1) YEAR.
A COPY OF YOUR SALES SLIP FOR PROOF OF PURCHASE IS REQUIRED
This warranty applies to the original purchaser for products which are installed in the United States or Canada and which are operated and maintained
as intended for single family residential usage. This warranty is valid only with proof of purchase, shall commence on the date of purchase, and shall
terminate (both as to original and any replacement products) on the anniversary date of the original purchase of the product stated on the above schedules.
This warranty covers defects in material and workmanship. This warranty does not cover parts which become defective as a result of negligence,
misuse, use not in compliance with the Owner’s Manual/Installation Instructions, accidental damage, improper handling, improper storage, improper
installation, lack of required routine maintenance (as specified in the Owner’s Manual/Installation Instructions), or electrical damage. Product must
be installed as specified in the Owner’s Manual/Installation Instructions by a qualified professional installer. Modifications to products which are not
specifically authorized will void this warranty. Accessories, parts, valves, remotes, etc. when used must be Peterson products or this warranty is void.
Warrantied items will be repaired or replaced at Peterson’s sole discretion. This warranty does not apply to rust, corrosion, oxidation, or discoloration
unless the affected part becomes inoperable.
This warranty does not cover labor or labor related charges, except as provided by separate specific written programs from the Peterson Co. All repair
work must be performed by a qualified professional service person and requires prior approval of Peterson.
Peterson may require the defective product or part to be returned to the factory to determine the cause of failure. Peterson will pay freight charges if
the product or part is determined to be defective. This warranty does not cover breakage in shipment from our (Independent) distributor to its customer
if the damage is determined to have occurred during that shipment.
This warranty specifically excludes liability for indirect, incidental, or consequential damages. Some states and provinces do not allow the exclusion
or limitation of incidental or consequential damages, so the above exclusion may not apply to you. This warranty gives you specified legal rights, and
you may have other rights that vary from state to state or province.
For additional information regarding this warranty, or to place a warranty claim, contact the R. H. Peterson dealer where the product was purchased.
When contacting your Peterson dealer or the R. H. Peterson Co., please provide the following information:
- Your name, address, telephone number, e-mail
- Sales receipt showing where purchased and date purchased
- Model number, serial number of product, date code
- Relevant information: installer, additions, repairs, when defect was first noted
TO REGISTER YOUR PRODUCT ONLINE GO TO: WWW.RHPETERSON.COM,
AND CLICK ON PRODUCT REGISTRATION. THANK YOU FOR YOUR PURCHASE.
Quality Check
Date:_________________
Model#:
_____________________
Serial#:
________________________
Inspector:
_____________________
Workmanship Inspection:
Robert H. Peterson Co. • 14724 East Proctor Avenue • City of Industry, CA 91746
10
___________