advertisement
Cover www.groupdynamics-laundry.com [email protected]
Home Laundry
Dryers
Refer to Page 3 for Model Numbers
D277I
Part No. 504010R1
July 2000
www.groupdynamics-laundry.com [email protected]
Table of Contents
Title Page
© Copyright 2000, Alliance Laundry Systems LLC
All rights reserved. No part of the contents of this book may be reproduced or transmitted in any form or by any means without the expressed written consent of the publisher.
504010
1
2 www.groupdynamics-laundry.com [email protected]
Parts Ordering Information
If literature or replacement parts are required, contact the source from whom the machine was purchased or contact Alliance Laundry Systems at (920) 748-3950 for the name and address of the nearest authorized parts distributor.
For technical assistance, call (920) 748-3121.
Nameplate Location
When calling or writing about your product, be sure to mention model and serial numbers. Model and serial numbers are located on nameplate(s) as shown.
NAMEPLATE
D282PE1A
504010
www.groupdynamics-laundry.com [email protected]
Model Identification
Information in this manual is applicable to these dryers:
Model
Number
Manufacturing
Number
LES10AW PLES10AW
LES19AW PLES19AW
LES33AW PLES33AW
LES34AW PLES34AW
LGS10AW PLGS10AW
LGS19AW PLGS19AW
LGS33AW PLGS33AW
LGS34AW PLGS34AW
Electric
Heat
X
X
X
X
Gas
Heat
X
X
X
X
Timer
Model
X
X
X
X
X
X
X
X
Cylinder
Light
X
X
Cylinder
Type
Painted
Painted
Painted
Painted
Painted
Painted
Painted
Painted
504010
3
www.groupdynamics-laundry.com [email protected]
Notes
www.groupdynamics-laundry.com [email protected]
Graphic Panel, Control Hood and Controls
Models LES10A* and LGS10A*
D283PZ3D
* Add Letter To Designate Color. L – Almond W – White
4
504010
www.groupdynamics-laundry.com [email protected]
Graphic Panel, Control Hood and Controls
Models LES10A* and LGS10A*
COMMENTS REF
PART #
DESCRIPTION
* Add Letter To Designate Color. L – Almond W – White
504010
5
www.groupdynamics-laundry.com [email protected]
Graphic Panel, Control Hood and Controls
Models LES19A*, LES33A*, LES34A*, LGS19A*, LGS33A* and LGS34A*
D283PZ3C
* Add Letter To Designate Color. L – Almond W – White
6
504010
www.groupdynamics-laundry.com [email protected]
Graphic Panel, Control Hood and Controls
Models LES19A*, LES33A*, LES34A*, LGS19A*, LGS33A* and LGS34A*
COMMENTS REF
PART #
DESCRIPTION
* Add Letter To Designate Color. L – Almond W – White
504010
7
8 www.groupdynamics-laundry.com [email protected]
Cabinet Top and Control Hood Rear Panel
3
GROUND
WIRE
D286PZ3B
504010
www.groupdynamics-laundry.com [email protected]
Cabinet Top and Control Hood Rear Panel
COMMENTS REF
PART #
DESCRIPTION
* Add Letter To Designate Color. L – Almond W – White
504010
9
10 www.groupdynamics-laundry.com [email protected]
Loading Door
D287PZ3D
504010
www.groupdynamics-laundry.com [email protected]
Loading Door
COMMENTS REF
PART #
DESCRIPTION
* Add Letter To Designate Color. L – Almond W – White
504010
11
12 www.groupdynamics-laundry.com [email protected]
Lower Access Panel, Front Panel and Seal
D288PZ3A
504010
www.groupdynamics-laundry.com [email protected]
Lower Access Panel, Front Panel and Seal
COMMENTS REF
PART #
DESCRIPTION
* Add Letter To Designate Color. L – Almond W – White
504010
13
14 www.groupdynamics-laundry.com [email protected]
Motor, Exhaust Fan and Belt
D289PZ3A
504010
www.groupdynamics-laundry.com [email protected]
Motor, Exhaust Fan and Belt
COMMENTS
Includes items 1 through 25
REF
PART #
510717P
DESCRIPTION
Blower Housing Assembly Kit
Idler Pulley and Lever Assembly
* Add Letter To Designate Color. L – Almond W – White
Does not include thermal protector
Models LES19A*, LES33A*, LGS19A*, LGS33A* and
Models LGS10A*, LGS19A*, LGS33A* and LGS34A*
Models LES10A*, LES19A*, LES33A* and LES34A*
504010
15
16 www.groupdynamics-laundry.com [email protected]
Front Bulkhead, Air Duct, Felt Seal and Cylinder
D290PZ3B
504010
www.groupdynamics-laundry.com [email protected]
Front Bulkhead, Air Duct, Felt Seal and Cylinder
COMMENTS
Cylinder seal to bulkhead
REF
PART #
22506P
DESCRIPTION
Adhesive
* Add Letter To Designate Color. L – Almond W – White
White; Models LES10A*, LES19A*, LES33A*, LES34A*,
LGS10A*, LGS19A*, LGS33A* and LGS34A*
504010
17
www.groupdynamics-laundry.com [email protected]
Rear Bulkhead, Felt Seal, Cylinder Roller and Terminal Block
18
D291PZ3A
504010
www.groupdynamics-laundry.com [email protected]
Rear Bulkhead, Felt Seal, Cylinder Roller and Terminal Block
COMMENTS
Cylinder seal to bulkhead
REF PART #
22506P
DESCRIPTION
Adhesive
Includes (3) 61199 Screws; Electric models
504010
19
www.groupdynamics-laundry.com [email protected]
Heater Duct and Element Assembly
Electric Models
20
D292PZ3A
504010
www.groupdynamics-laundry.com [email protected]
Heater Duct and Element Assembly
Electric Models
COMMENTS REF
PART #
DESCRIPTION
504010
21
22 www.groupdynamics-laundry.com [email protected]
Heater Duct Assembly
Gas Models
D293PZ3A
504010
www.groupdynamics-laundry.com [email protected]
Heater Duct Assembly
Gas Models
COMMENTS REF
PART #
DESCRIPTION
504010
23
24 www.groupdynamics-laundry.com [email protected]
Heater Duct Assembly Replacement
D294PZ3A
504010
www.groupdynamics-laundry.com [email protected]
Heater Duct Assembly Replacement
COMMENTS REF
PART #
DESCRIPTION
504010
25
26 www.groupdynamics-laundry.com [email protected]
Gas Valve, Igniter and Gas Conversion Kits
Gas Models
D303PZ3D
504010
www.groupdynamics-laundry.com [email protected]
Gas Valve, Igniter and Gas Conversion Kits
Gas Models
REF PART #
503763
503769
510425
503910
503922
510443
510403
649P3
DESCRIPTION
Wire Harness
Wire Harness
Wire Harness
Wire Harness
Wire Harness
Wire Harness
Wire Harness
Gas Burner Conversion Kit
650P3
Gas Burner Conversion Kit
* Add Letter To Designate Color. L – Almond W – White
COMMENTS
Models LES19A* and LES33A*
Model LES10A*
Model LGS19A* and LGS33A*
Model LGS10A*
Model LES34A*
Model LGS34A*
Model LGS33A*
Used to convert dryers from Natural/Mixed to L.P. gas
(Liquefied Petroleum)
Used to convert dryers from L.P. to Natural/Mixed gas
504010
27
www.groupdynamics-laundry.com [email protected]
Cabinet, Exhaust Duct and Base
28
D296PZ3A
504010
www.groupdynamics-laundry.com [email protected]
Cabinet, Exhaust Duct and Base
COMMENTS REF
PART #
521P3
528P3
DESCRIPTION
Flexible Venting Kit
Directional Exhaust Kit
* Add Letter To Designate Color. L – Almond W – White
Used to vent dryer out the sides or bottom
504010
29
30 www.groupdynamics-laundry.com [email protected]
Power Cord
Electric Models
D297PZ3B
504010
www.groupdynamics-laundry.com [email protected]
Power Cord
Electric Models
REF
PART #
DESCRIPTION
COMMENTS
504010
31
32 www.groupdynamics-laundry.com [email protected]
Power Cord
Gas Models
GROUND
WIRE
D298PZ3C
504010
www.groupdynamics-laundry.com [email protected]
Power Cord
Gas Models
REF
PART #
DESCRIPTION
COMMENTS
504010
33
34 www.groupdynamics-laundry.com [email protected]
Terminals
D299PZ3A
504010
www.groupdynamics-laundry.com [email protected]
Terminals
REF
PART #
N/A = Part no longer available
DESCRIPTION
COMMENTS
1/4 inch; (1) 12 gauge wire or (2) 18 gauge wires
504010
35
36 www.groupdynamics-laundry.com [email protected]
Terminals
D300PZ3A
504010
REF
PART #
www.groupdynamics-laundry.com [email protected]
Terminals
DESCRIPTION
Barrel Insulated Spade Terminal
Barrel Insulated Spade Terminal
COMMENTS
1/4 inch; (2) 18 gauge wires or (1) 12 gauge wire
3/16 inch; (1) 18 gauge wire; .020 tab
3/16 inch; Thermostat wire; .032 tab
3/16 inch; (2) 18 gauge wires; .020 tab
1/4 inch; (2) 18 gauge wires or (1) 12 gauge wire
(2) 18 gauge wires or (1) 12 gauge wire
1/4 inch; (2) 18 gauge wires or (1) 12 gauge wire
504010
37
38 www.groupdynamics-laundry.com [email protected]
Motor Connection Block and Terminal Extractor Tools
D301PZ3A
504010
www.groupdynamics-laundry.com [email protected]
Motor Connection Block and Terminal Extractor Tools
REF
PART #
DESCRIPTION
COMMENTS
1/4 inch; For (1) 12 gauge wire
1/4 inch; For (1) or (2) 18 gauge wires
For use on gas dryer terminals
For use on electric dryer terminals
504010
39
www.groupdynamics-laundry.com [email protected]
Wire Harnesses and Wires
Individual wires are not available separately. Order complete wire harness or order wire by the foot. See chart below.
MODEL NUMBER
LES10A*
LES19A*, LES33A*
LES34A*
LGS10A*
LGS19A*
LGS33A*
LGS34A*
* Add Letter To Designate Color. L – Almond W – White
WIRE HARNESS
PART NUMBER
503769
503763
503922
503910
510425
510403
510443
Order the individual wire color and gauge by the part number listed below. Order wire by the foot and terminals and connectors as required. It is recommended when applying terminals to wires that the terminals be soldered to the wires.
IMPORTANT: Always replace wires with proper gauge.
PART NUMBER
45001
45380
WIRE GAUGE
18 Gauge Wire
12 Gauge Wire
WIRE COLOR
Black
Orange
Production Literature
Part numbers do not include revision levels.
MODEL NUMBER
LES10A*, LGS10A*
LES19A*, LGS19A*
LES33A*, LGS33A*
OPERATION
PART NUMBER
N/A
504489
504488
LES34A*, LGS34A* N/A
* Add Letter To Designate Color. L – Almond W – White
N/A = Part no longer available
USE AND CARE
PART NUMBER
504023
504490
504490
504023
INSTALLATION
PART NUMBER
503953
504607
504607
503953
40
504010
www.groupdynamics-laundry.com [email protected]
Parts Index
A
Access Cover Plate
510903 .................................................................... 29
Adhesive for Cylinder Seal
22506P.............................................................. 17, 19
Door Catch
510177 .................................................................... 13
Door Hinge
511036 .................................................................... 11
Door Pull
510103*P................................................................. 11
Door Seal
510147 .................................................................... 11
Door Striker
510181 .................................................................... 11
Door Striker Bracket
510127 .................................................................... 11
Door Switch
504570 .................................................................... 13
B
Baffle
503703 .................................................................... 17
Barrel Insulated Spade Terminal
00214 ...................................................................... 37
00215 ...................................................................... 37
Base
510084 .................................................................... 29
Belt
510178 .................................................................... 15
Blower Housing Assembly Kit
510717P.................................................................. 15
Bulb
60954 ...................................................................... 17
Bumper
56128 ...................................................................... 29
Burner Assembly
510149 .................................................................... 27
E
18 Gauge Wire
45001 ...................................................................... 40
End Cap
504008* ................................................................. 5, 7
504009* ................................................................. 5, 7
Exhaust Duct
510137 .................................................................... 29
Exhaust Fan Cover and Housing
510138P ..................................................................15
Exhaust Fan Impeller
510139 .................................................................... 15
C
Cabinet
727P3* .................................................................... 29
Cabinet Top
510029*P .................................................................. 9
Combustion Duct
510131 .................................................................... 23
Connector
90789 ...................................................................... 37
Control Hood Rear Panel
510099 ...................................................................... 9
Cylinder Assembly
510159W................................................................. 17
Cylinder Glide
510187 .................................................................... 17
Cylinder Light Housing
503622 .................................................................... 17
Cylinder Roller
510708P.................................................................. 19
Cylinder Seal
510207P.................................................................. 17
Cylinder Seal Assembly
510207P.................................................................. 19
D
Directional Exhaust Kit
528P3...................................................................... 29
504010
F
Fabric Selector Switch
510212 ......................................................................7
Felt Pad
510189 .................................................................... 17
Flexible Venting Kit
521P3 ...................................................................... 29
Front Bulkhead Assembly
511033W ................................................................. 17
Front Panel
510066* ................................................................... 13
Front Panel Seal
510236 .................................................................... 13
G
Gas Burner Conversion Kit
649P3 ...................................................................... 27
650P3 ...................................................................... 27
Gas Valve Assembly
510506 .................................................................... 27
Glide Bracket
510145 .................................................................... 17
Graphic Panel
504020W ...................................................................7
504022W ...................................................................5
504197W ...................................................................7
504569W ...................................................................7
41
I
www.groupdynamics-laundry.com [email protected]
Ground Clip
00161 ...................................................................... 37
H
Heat Shroud
510101 .................................................................... 23
Heater
61623 ...................................................................... 15
Heater Assembly
510329 .................................................................... 21
Heater Duct Assembly
510025P...................................................... 21, 23, 25
Hold-Down Bracket
510297 ...................................................................... 9
Hold-Down Clip
28835 ...................................................................... 13
503876 ...................................................................... 9
Holding and Booster Coil
58804A.................................................................... 27
Locator
56079 ................................................................ 13, 29
Locknut
56156 ................................................................ 15, 19
Lower Access Panel
510069* ................................................................... 13
Lower Air Duct Assembly
510151 .................................................................... 17
M
Molex Terminal
00188 ...................................................................... 39
Motor Assembly
510508P ..................................................................15
Motor Connection Block
500338 .................................................................... 39
Motor Hub Ring Kit
590P3 ...................................................................... 15
Motor Mounting Bracket
510060 .................................................................... 15
Motor Mounting Clamp
510180 .................................................................... 15
Motor Pulley
500011 .................................................................... 15
Motor Switch
501218 .................................................................... 15
Mounting Bracket
510128 .................................................................... 27
Idler Lever
510133 .................................................................... 15
Idler Pulley
510142 .................................................................... 15
Idler Pulley and Lever Assembly
510158 .................................................................... 15
Igniter and Bracket Assembly
510184 .................................................................... 27
Inner Door Panel and Seal
503643W................................................................. 11
Insulated Spade Terminal
00165 ...................................................................... 37
00234 ...................................................................... 37
00237 ...................................................................... 35
Insulator Sleeve
503670 .................................................................... 35
J
Jam Nut
52566 ...................................................................... 15
O
Outer Door Panel
511013W ................................................................. 11
Outlet Cover
500820 .................................................................... 25
P
Pin Terminal
00116 ...................................................................... 35
00127 ...................................................................... 35
Power Cord
510505 .................................................................... 31
56222 ...................................................................... 33
L
Lampholder
504452 .................................................................... 17
Lead-In Pipe Assembly
510204 .................................................................... 27
Lens
503623 .................................................................... 17
Leveling Leg
510135 .................................................................... 29
Limit Thermostat
504237 .................................................................... 21
510702 .................................................................... 23
Lint Filter
503627 .................................................................... 17
42
R
Rear Bulkhead
510905W ................................................................. 19
Retainer Ring
23748 ................................................................ 15, 19
Ring Terminal #10
00110 ...................................................................... 37
00111 ...................................................................... 37
Roller Bracket
510100 .................................................................... 19
504010
www.groupdynamics-laundry.com [email protected]
S
Screw
20530 ................................................................ 31, 33
23222 ................................................................ 21, 27
31260 ...................................................................... 15
32671 ................................................................ 13, 29
33561 ...................................................................... 15
500226 .................................................................... 17
501086 .............................................................. 5, 7, 9
501285 .............................................................. 17, 19
503661 ........................................ 9, 13, 15, 17, 19, 29
503688 ............................ 9, 19, 21, 23, 25, 27, 29, 31
505295 .................................................................... 11
505870 .................................................................... 17
51782 ................................................................ 23, 27
56124 ...................................................................... 27
61199 ...................................................................... 31
62588 ...................................................................... 17
Seal
510238 .................................................................... 15
Secondary Coil
58804B.................................................................... 27
Sensor
510213 .................................................................... 27
Shaft
56461 ................................................................ 15, 19
Shield
510237 .................................................................... 19
Shoulder Screw
500824 .................................................................... 15
Signal
510211 ...................................................................... 7
Socket Terminal
00117 ...................................................................... 35
00130 ...................................................................... 35
Spade Terminal
00114 ...................................................................... 37
00115 ...................................................................... 37
00121 ...................................................................... 37
00124 ...................................................................... 37
00156 ...................................................................... 37
00189 ...................................................................... 37
00209 ...................................................................... 37
00223 ...................................................................... 37
00245 ...................................................................... 37
00255 ...................................................................... 39
00256 ...................................................................... 39
00321 ...................................................................... 37
Spring
510185 .................................................................... 15
Sticker
24903 ........................................................................ 9
500281 .................................................................... 13
500495 .................................................................... 29
511004 .................................................................... 13
511005 .................................................................... 29
61294 ...................................................................... 29
Strain Relief
38384 ................................................................ 33, 37
Support Control Panel
503901 .................................................................. 5, 7
Switch Knob Assembly
33688 ........................................................................ 7
504010
T
Tab Terminal
00139 ...................................................................... 37
Terminal
00344 ...................................................................... 37
00345 ...................................................................... 37
00346 ...................................................................... 37
00347 ...................................................................... 37
00361 ...................................................................... 37
Terminal Block
510190P ............................................................19, 31
58799 ...................................................................... 37
58800 ...................................................................... 35
Terminal Block Plug
23040 ...................................................................... 35
56266 ...................................................................... 35
56448 ...................................................................... 35
Terminal Block Receptacle
23039 ...................................................................... 35
56265 ...................................................................... 35
56451 ...................................................................... 35
Terminal Extractor Tool
128P4 ...................................................................... 39
190P4 ...................................................................... 39
283P4 ...................................................................... 39
Thermal Fuse
510183 .................................................................... 21
Thermostat
504514 .................................................................... 15
510707P ..................................................................15
Timer
504178 ......................................................................5
505790 ......................................................................7
505792 ......................................................................7
505793P ....................................................................5
505794 ......................................................................7
505797P ....................................................................7
Timer Knob Assembly
510287W ............................................................... 5, 7
Top Cover
505808W ............................................................... 5, 7
Top Hinge
510136 .................................................................... 29
12 Gauge Wire
45380 ...................................................................... 40
U
Upper Air Duct Assembly
750P3 ...................................................................... 17
V
Valve
510205 .................................................................... 27
Washer
52549 ................................................................ 15, 19
43
www.groupdynamics-laundry.com [email protected]
Wire Clip
504034 .................................................................... 35
Wire Harness
503763 .............................................................. 27, 40
503769 .............................................................. 27, 40
503910 .............................................................. 27, 40
503922 .............................................................. 27, 40
510403 .............................................................. 27, 40
510425 .............................................................. 27, 40
510443 .............................................................. 27, 40
510530 .................................................................... 27
Wire Tie
55881 ...................................................................... 35
44
504010
advertisement
* Your assessment is very important for improving the workof artificial intelligence, which forms the content of this project
Related manuals
advertisement
Table of contents
- 1 Cover
- 4 Model Identification
- 2 Table of Contents
- 3 Parts Ordering Information
- 3 Nameplate Location
- 6 Graphic Panel, Control Hood and Controls
- 8 Graphic Panel, Control Hood and Controls
- 10 Cabinet Top and Control Hood Rear Panel
- 12 Loading Door
- 14 Lower Access Panel, Front Panel and Seal
- 16 Motor, Exhaust Fan and Belt
- 18 Front Bulkhead, Air Duct, Felt Seal and Cylinder
- 20 Rear Bulkhead, Felt Seal, Cylinder Roller and Terminal Block
- 22 Heater Duct and Element Assembly Electric Models
- 24 Heater Duct Assembly Gas Models
- 26 Heater Duct Assembly Replacement
- 28 Gas Valve, Igniter and Gas Conversion Kits Gas Models
- 30 Cabinet, Exhaust Duct and Base
- 32 Power Cord Electric Models
- 34 Power Cord Gas Models
- 36 Terminals
- 38 Terminals
- 40 Motor Connection Block and Terminal Extractor Tools
- 42 Wire Harnesses and Wires
- 42 Production Literature
- 43 Parts Index