Quality Healthcare Seating Products
Operating Instructions
and Service Manual
VINYL CLEANING INSTRUCTIONS
SPECIFIC CLEANING INSTRUCTIONS
FOR VINYLS:
T09 Natural, T21 Bonnie Blue, T56 Gray, T45 Colonial Blue, T96 Cranberry,
T19 Aquamarine, T43 Tearose, T26 Iced Mint
Also vinyls shown in Champion Vinyl Cards – VINYL SOLUTIONS II , III, and IV
CODE IN PART
CODE IN PART
PATTERN NAME
NUMBER
PATTERN NAME
NUMBER
Cobblestone
CO
Grand Sierra
GS
Colorguard
CG
Harmony
HA
Deco Shell
DE
Mojave
MO
Edo
EO
Rolling Stone
RS
Fleur
FL
Vegas
V
Champion soft vinyl
FS
CAUTION: Other cleaning methods are used at the facility’s own risk.
For cleaning, a soft white cloth is recommended: avoid use of paper towels.
General Cleaning: Your Champion chairs are constructed of vinyl with protective finish, which resists
most stains. The protective finish prevents most staining materials: ink, magic marker and paint from
immediately penetrating the protective coating; so it is important to remove the spill as soon as possible
after the spill to prevent its penetration into vinyl and becoming a permanent stain.
CAUTION: Some fabric dyes have the ability to create a permanent stain. To reduce the
likelihood of a problem from this or any stain, clean as soon as noticed.
VINYL MANUFACTURER’S CLEANING RECOMMENDATIONS:
Cleaners such as Fantastik®, Formula 409® all purpose cleaner and other similar household cleaners and
bleaches for stains such as food, shoe polish, betadine, and lipstick. Use with water and a cloth or soft
brush. Rinse with clear water and dry with a clean cloth.
CAUTION: Limit use of strong active solvent to six rubs. Unlimited use may remove the
PREFIXX® from the vinyl surface.
A solvent-type cleaner to be used with a soft cloth or damp sponge; alcohol, for stains such as magic
marker, spray paint, & grease. Use full strength and dry with a cloth. Rinse with clear water and dry
with a clean cloth.
Strong active solvent cleaners such as nail polish remover (acetone/water) applied with a soft cloth or
damp sponge for such stains as paint, ball point pen and toner. Use with a soft cloth. Rinse with clear
water.
To disinfect a solution of up to 10% bleach and water may be used. Information from the vinyl
manufacturer is meant to establish an upper limit beyond which damage might occur.
Vinyl Cleaning Instructions
2
Rev 1. 022614
SPECIFIC CLEANING INSTRUCTIONS
FOR VINYLS:
Chamea and also vinyls shown in Champion Vinyl Card – VINYL SOLUTIONS II
PATTERN NAME
Avant
Southampton
CODE IN PART
NUMBER
AV
SO
PATTERN NAME
Chamea
CODE IN PART
NUMBER
CHA
CAUTION: Other cleaning methods are used at the facility’s own risk.
For cleaning, a soft white cloth is recommended: avoid use of paper towels.
General Cleaning: Your Champion chairs are constructed of vinyl with BEAUTYGUARD®, which resists
most stains. Staining materials can penetrate over time so it is important to remove the spill as soon as
possible after it occurs. Not only is the clean up easier, it reduces the possibility that it will penetrate the
protective finish and become permanently set in the vinyl. So for the best results, give spills immediate
attention.
VINYL MANUFACTURER’S CLEANING RECOMMENDATIONS:
For most soiling, use a 1:10 solution of household liquid dish soap with warm water applied with a soft
damp cloth. This removes most soiling. If necessary, a solution of liquid cleanser and water applied with
a soft bristle brush. Wipe away the residue with a water-dampened cloth.
WARNING: When solvent type cleaners are being used, care should be exercised. KEEP
AWAY from fire or flame and use in a well ventilated area.
For heavier soiling, dampen a soft white cloth with lighter fluid (Naphtha) and rub gently. Rinse with a
water dampened cloth.
For stains not removed by the above methods: dampen a soft white cloth with a 1:10 solution of
household bleach (sodium hypochlorite) mixed with water. Rub gently. Rinse with a water dampened
cloth to remove the bleach concentration. If necessary, allow this solution of bleach to water to puddle
on the affected area or apply a soaked cloth for approximately 30 minutes. Rinse with a water
dampened cloth to remove any remaining bleach.
To disinfect a solution of up to 10% bleach and water may be used. Information from the vinyl
manufacturer is meant to establish an upper limit beyond which damage might occur.
Vinyl Cleaning Instructions
3
Rev 1. 022614
SPECIFIC CLEANING INSTRUCTIONS
FOR VINYLS:
Vinyls shown in Champion Vinyl Card – VINYL SOLUTIONS II, III, & IV
PATTERN NAME
Classic Twill
Mayfair
Script
Checkmate
CODE IN PART
NUMBER
CT
PATTERN NAME
Kilkenny Tweed or
Oxford
Renaissance
Geomet
Whitney
MA
SR
CM
CODE IN PART
NUMBER
KL
RE
GE
WT
CAUTION: Other cleaning methods are used at the facility’s own risk.
For cleaning, a soft white cloth is recommended: avoid use of paper towels.
General Cleaning: Your Champion chairs are constructed of vinyl with protective finish,
PERMABLOK3®. This finish resists many stains, but staining materials can penetrate over time, so it is
important to remove the spill as soon as possible after it occurs
VINYL MANUFACTURER’S CLEANING RECOMMENDATIONS:
Follow these steps in order.
1)
2)
Remove excess spill with a damp cloth. Clean with a 1:1 mix of Ivory® liquid and water. Rinse
with clean water and dry.
Use a full strength application of cleaners such as Fantastik® spray cleaner or Formula 409®.
Rinse with clean water and dry with a clean cloth.
WARNING: NEVER mix ammonia, or a cleaner with ammonia, with bleach as dangerous
compounds may result.
WARNING: When solvent type cleaners are being used, care should be exercised. KEEP
AWAY from fire or flame and use in a well ventilated area.
3)
Use a 1:1 mix of ammonia and water OR a 1:4 mix of bleach and water. Rinse with clean water
and pat surface dry with a clean cloth.
4)
Use a full strength application of lighter fluid (naphtha). Use a soft cotton cloth saturated with
cleaning material. Rub the stain in circles 10 times, pat dry with a soft cloth and check results.
Rinse thoroughly with clean water and pat the surface dry with a clean cloth.
Use 1:1 mix of isopropyl alcohol and water. If stain persists, use straight alcohol. Rinse with
clean water and pat surface dry with a clean cloth. If stains remain, use a 1:1 mix of acetone
(nail polish remover) and water. Rinse clean and pat the surface dry with a clean cloth.
5)
To disinfect a solution of up to 10% bleach and water may be used. Information from the vinyl
manufacturer is meant to establish an upper limit beyond which damage might occur.
Vinyl Cleaning Instructions
4
Rev 1. 022614
SPECIFIC CLEANING INSTRUCTIONS
FOR VINYLS:
Vinyls shown in Champion Vinyl Card – VINYL SOLUTIONS II
PATTERN NAME
Cumulus
CODE IN PART
NUMBER
CU
PATTERN NAME
Vogue
CODE IN PART
NUMBER
VO
CAUTION: Other cleaning methods are used at the facility’s own risk.
For cleaning, a soft white cloth is recommended: avoid use of paper towels.
General Cleaning: Your Champion chairs are constructed of vinyl with protective finish, MORGUARD™. This finish resists staining materials. Staining materials can penetrate over time, so it is
important to remove the spill as soon as possible after it occurs. Not only is the clean up easier, the
possibility that the spill will penetrate the protective finish and become permanently set in the vinyl is
reduced. So for the best results, give spills immediate attention.
VINYL MANUFACTURER’S CLEANING RECOMMENDATIONS:
Follow these steps in order. If the stain is removed; stop the cleaning process at that point,
after rinsing with clean water and drying the vinyl.
1)
2)
3)
Remove excess spill with a damp cloth. Clean with a mild soap solution. Always rinse with clear
water and dry with a clean cloth. Soap solution may be applied with a cloth or a soft bristle
brush.
For more stubborn stains, use a mild detergent such as Fantastik®, Formula 409®, or Mr.
Clean® according to the manufacturer’s directions. Use a soft cloth or a soft bristle brush to
apply the detergent, always rinse with clear water and dry with a clean cloth.
WARNING: When solvent type cleaners are being used, care should be exercised.
KEEP AWAY from fire or flame and use in a well ventilated area.
If the stain persists, use full strength rubbing alcohol or mineral spirits cautiously. (This means
trying the cleaner in a hidden area first). Work in a small area; apply the cleaner in a circular
motion a few times, rinse with clear water and dry with a clean cloth. Examine the vinyl for
damage before using on the stain.
Caution: Indiscriminate use of strong solvents can damage or discolor vinyl.
4)
Use a full strength application of lighter fluid (naphtha). Use a soft cotton cloth saturated with
cleaning material. Rub the stain in circles 10 times, pat dry with a soft cloth and check results.
Rinse thoroughly with clean water and pat the surface dry with a clean cloth.
5)
Use 1:1 mix of isopropyl alcohol and water. If stain persists, use straight alcohol. Rinse with
clean water and pat surface dry with a clean cloth. If stains remain, use a 1:1 mix of acetone
(nail polish remover) and water. Rinse clean and pat the surface dry with a clean cloth.
To disinfect a solution of up to 10% bleach and water solutions may be used. Information from the
vinyl manufacturer is meant to establish an upper limit beyond which damage might occur.
Vinyl Cleaning Instructions
5
Rev 1. 022614
FOR VINYLS (continued):
Vinyls shown in Champion Vinyl Card – VINYL SOLUTIONS II
PATTERN NAME
Cumulus
CODE IN PART
NUMBER
CU
PATTERN NAME
Vogue
CODE IN PART
NUMBER
VO
CAUTION: Powdered adhesives, abrasive cleaners, steel wool and industrial strength
cleaners are not recommended for MorCare vinyl. Any lacquer solvent will cause immediate
damage to the vinyl. Wax should never be used, as it will cause embrittlement and cracking.
Dilute chlorine beach: never use full strength on vinyl. Always rinse with clear water after
using cleaning solutions.
Certain stains* may become permanent unless removed immediately.
*Ball point ink - Use rubbing alcohol full strength on a soft cloth immediately to remove much of the
stain.
WARNING: NEVER mix ammonia, or a cleaner with ammonia, with bleach as dangerous
compounds may result.
WARNING: When solvent type cleaners are being used, care should be exercised. KEEP
AWAY from fire or flame and use in a well ventilated area.
For these specific items the manufacture recommends:
*Blood - Use a clean cloth soaked in cold water to rub out spots. Use household ammonia, rinsing with
clean wet cloth for persistent spots. Do not use hot water or soap suds this will set the stain.
*Shoe polish – Shoe polish will stain permanently. Use a cloth saturated with mineral spirits or
kerosene rubbing lightly to remove residue. Rinse thoroughly with clean water. Do not smear stain
beyond original source.
*Chewing gum – Rub with a ice cube then scrape off as much as possible with a dull knife. Use a cloth
saturated with mineral spirits rubbing lightly to remove residue. Rinse thoroughly with clean water.
*Grease/Oil – Use a cloth saturated with mineral spirits rubbing lightly to remove residue. Do not
smear stain beyond original source. Work from the outer edge toward the center of the stain. Rinse
thoroughly with clean water.
*Lipstick – Use a cloth saturated with mineral spirits rubbing lightly to remove residue. Do not smear
stain beyond original source. Work from the outer edge toward the center of the stain. Rinse thoroughly
with clean water.
*Latex Paint – wipe off fresh paint, hot soapy water will usually removed dried latex paint.
*Vomit – Remove any residue then use a sponge or cloth saturated with soapy water with a dilute
bleach solutions. Rinse thoroughly with clean water.
*Urine – Remove any residue, then use soapy water with a small amount of household ammonia.
Rinse thoroughly with clean water.
Vinyl Cleaning Instructions
6
Rev 1. 022614
SPECIFIC CLEANING INSTRUCTIONS
FOR FAUX LEATHER:
Faux Leather shown in ENVIROLEATHER (PVC-FREE) CARD
PATTERN NAME
Enviroleather
CODE IN PART
NUMBER
EN
PATTERN NAME
Enviroleather
CODE IN PART
NUMBER
EV
CAUTION: Other cleaning methods are used at the facility’s own risk.
For cleaning, a soft white cloth is recommended: avoid use of paper towels.
General Cleaning: Your Champion chairs are constructed of faux leatherl with a superior finish. This
finish resists staining materials.
MANUFACTURER’S CLEANING RECOMMENDATIONS:
Follow these steps in order. If the stain is removed; stop the cleaning process at that point,
after rinsing with clean water and drying the faux leather.
1)
2)
Remove excess spill with a damp cloth. Clean ordinary dirt, dust smudges and ordinary spills
with a damp cloth.
For water soluble stains such as coffee, mustard, juice, etc. remove with soap and water
solutions, always rinse with clear water and dry with a clean cloth. Soap solutions may be
applied with a cloth or a soft bristle brush.
In general, ball point pen ink stains are difficult to remove. The sooner the ink is cleaned the
better the chance for success. Ink compositions vary and not all ink stains can be removed.
3)
4)
5)
6)
7)
For more stubborn stains, such as ink, grease, shoe polish. Wet a portion of a soft white cloth
with a blend of 50% rubbing alcohol and 50% Wisk® detergent. Another option is rubbing
alcohol and baking soda.
Apply the cleaning solutions to the ink stain and blot up the stain. Do not rub. Blot up all of the
cleaning solutions and repeat step 2 several times either blotting the stain or gently rubbing in a
circular motion. Do not rub vigorously.
Apply a small amount of the cleaning solution with a soft bristle toothbrush and gently brush in a
circular motion. As the ink loosens up blot up the stain with a dry cloth. Repeat this step three
times, using small amounts of cleaning solutions each time.
Extract the cleaning solution with a damp cloth several times to remove the cleaning solutions
(and the blue Wisk® color).
Allow to dry. Check for residual soap and repeat step 4 if necessary.
To disinfect a solution of up to 20% bleach and water may be used. Information from the
manufacturer is meant to establish an upper limit beyond which damage might occur.
Vinyl Cleaning Instructions
7
Rev 1. 022614
SPECIFIC CLEANING INSTRUCTIONS
For vinyls shown in Champion VINYL SOLUTIONS IV card:
CODE IN PART
PATTERN NAME
NUMBER
PATTERN NAME
Rafia
RA
Martini
Lava
LV
Bari
Olympus
OL
Tessuto
CODE IN PART
NUMBER
MR
BAR
TU
CAUTION: Other cleaning methods are used at the facility’s own risk.
VINYL MANUFACTURER’S CLEANING RECOMMENDATIONS:
For easy cleaning of recent soiling, promptly wash with a mild soap solution. For a previously soiled area
that has not yet penetrated the vinyl surface, scrub with a soft brush using a mild, non-abrasive cleaner.
Cleaning frequency depends on use. Please clean and maintain your furniture regularly.
Clean all spills as soon as possible and use the following cleaning procedures in order for best results.
1)
Remove excess spill with a damp cloth. Clean ordinary dirt, dust smudges and ordinary spills
with a damp cloth.
2)
Use straight application of concentrated cleaners such as Formula 409®r Fantastik®. Rinse
with clear water. Wipe with clean cloth.
3)
For more difficult stains, use a 6% mixture of bleach with water. Rinse with clear water and dry.
Never use bleach in full strength to clean vinyl.
Notes: Please be sure to use a soft brush or cloth saturated with cleaning material. Always test
cleaning methods on an inconspicuous area of furniture. If stain persists, stain has probably set.
Although this vinyl is resistant to most common stains, some fabric dyes and ballpoint inks can create a
permanent stain.
To disinfect a solution of up to 20% bleach and water may be used except on Raffia where a 6%
solution may be used. After using bleach solution be sure to rinse area with a soft cloth moistened with
clear water and let dry. Bleach solutions not completely removed can fade the material. Never use
bleach in full strength to clean these materials. Information in regard to the strength of bleach solution
from the vinyl manufacturer is meant to establish an upper limit beyond which damage might occur.
Vinyl Cleaning Instructions
8
Rev 1. 022614
Download PDF

advertising