PREMIUM LINE BATTERIES
for Renewable Energy and Backup Power Applications
PRODUCT LINE SHEET
Flooded/wet lead-acid battery
inches (mm)
Maroon (case/cover)
Polypropylene
BATTERY:
DIMENSIONS:
COLOR:
MATERIAL:
Renewable energy applications operate under challenging conditions such as fluctuating or extreme temperatures, remote
locations and the intermittent nature of solar and wind power generation. Designed with a 10-year battery life, Trojan
Battery’s Premium Line of flooded deep-cycle batteries is specifically engineered to withstand the rigorous conditions of
renewable energy applications. The Premium Line incorporates advanced battery features such as Trojan’s DuraGrid™,
MaxGuard® XL separator and Alpha Plus® Paste technologies that provide superior performance, rugged durability and
exceptional long life. Trojan’s product strategy is focused on one simple objective – manufacture the highest quality battery
available in the industry, which is why Trojan’s Premium Line is tested to IEC standards.
PRODUCT SPECIFICATION
ENERGY
(kWh)
CAPACITY A Amp-Hours (AH)
BCI
GROUP
SIZE
TYPE
GC2H
903
48-Hr
Rate
72-Hr
Rate
100-Hr
Rate
100-Hr
Rate
VOLTAGE
2-Hr
Rate
5-Hr
Rate
10-Hr
Rate
20-Hr
Rate
T105-RE
146
185
207
225
240
245
250
1.50
6 VOLT
L16RE-A*
211
267
299
325
346
354
360
2.16
6 VOLT
903
L16RE-B*
241
303
340
370
394
403
410
2.46
903
L16RE-2V*
722
909
1021
1110
1182
1210
1235
2.47
DIMENSIONS B Inches (mm)
TERMINAL
Type
Height C
WEIGHT lbs.
(kg)
Length
Width
5
10-1/4 (260)
7-1/8 (181)
11-3/4 (299)
67 (30)
5
11-5/8 (295)
7 (178)
17-11/16 (450)
115 (52)
6 VOLT
5
11-5/8 (295)
7 (178)
17-11/16 (450)
118 (54)
2 VOLT
5
11-5/8 (295)
7 (178)
17-11/16 (450)
119 (54)
PREMIUM LINE - DEEP-CYCLE FLOODED BATTERIES
A. The amount of amp-hours (AH) a battery can deliver when discharged at a constant rate at 80°F (27°C) and maintain a voltage above 1.75 V/cell.
Capacities are based on peak performance.
B. Dimensions are based on nominal size. Dimensions may vary depending on type of handle or terminal.
C. Dimensions taken from bottom of the battery to the highest point on the battery. Heights may vary depending on type of terminal.
* Polyon™ Case
Trojan’s Premium Line is tested to BCI and IEC 61427 standards.
Page 1 of 2
CHARGING INSTRUCTIONS
OPERATIONAL DATA
CHARGER VOLTAGE SETTINGS (AT 77°F/25°C)
OPERATING TEMPERATURE
Voltage per cell
Absorption charge
2.35-2.45
Float charge
2.20
Equalize charge
2.58
SPECIFIC GRAVITY
-4°F to 113°F (-20°C to +45°C).
At temperatures below 32°F (0°C)
maintain a state of charge greater
than 60%.
Do not install or charge batteries in a sealed or non-ventilated compartment. Constant under or
overcharging will damage the battery and shorten its life as with any battery.
The specific gravity at 100%
state-of-charge is 1.280
Premium Line batteries manufactured prior to March 2012 have 1.260 SG value.
CHARGING TEMPERATURE COMPENSATION
To the Voltage Reading -- Subtract 0.005 volt per cell (VPC) for every 1°C above 25°C or add 0.005 volt per cell for every 1°C below 25°C.
EXPECTED LIFE VS. TEMPERATURE
Chemical reactions internal to the battery are driven by voltage and temperature. The higher the battery temperature, the faster chemical reactions will occur. While
higher temperatures can provide improved discharge performance the increased rate of chemical reactions will result in a corresponding loss of battery life. As a rule
of thumb, for every 10°C increase in temperature the reaction rate doubles. Thus, a month of operation at 35°C is equivalent in battery life to two months at 25°C.
Heat is an enemy of all lead acid batteries, FLA, AGM and gel alike and even small increases in temperature will have a major influence on battery life.
TYPICAL CYCLE LIFE IN A STATIONARY APPLICATION
Number of Cycles
4500
CAPACITY VS. TEMPERATURE
140
4000
120
3500
100
3000
80
2500
60
2000
40
1500
20
1000
0
500
-20
60
50
40
30
20
10
0
0
-10
-20
-30
-40
20%
30%
40%
50%
60%
70%
80%
90%
100%
0%
20%
40%
60%
80%
100%
-40
120%
Depth-of-Discharge
TERMINAL CONFIGURATIONS
5
LT
VENT CAP
Bayonet
L-Terminal
Terminal Height Inches (mm)
1-3/4 (43)
Torque Values in-lb (Nm)
100 – 120 (11 – 14)
Through-hole Diameter (mm)
3/8 (10)
Trojan batteries are available worldwide.
We offer outstanding technical support, provided by full-time application engineers.
12380 Clark Street, Santa Fe Springs, CA 90670 • USA or email re@trojanbattery.com
© 2013 Trojan Battery Company. All rights reserved. Trojan Battery Company is not liable for damages that may result from any information provided in or omitted from this
publication, under any circumstances. Trojan Battery Company reserves the right to make adjustments to this publication at any time, without notices or obligation.
Page 2 of 2
TRJN_PMPLS • PLS0513
call 800.423.6569 or + 1.562.236.3000 or visit www.trojanbatteryRE.com