LG | LSU5UR2A | LG LSU5UR2A Owner’s Manual

WALL
Type "A" screw
5-7mm
Installation Plate
Outdoor
(0.2~0.3")
Indoor
Marking-off line
Thread
Weight
CAUTION
Installation parts you
must purchase
More than
20cm
Installation plate
Sleeve
Bushing-Sleeve
Putty(Gum Type Sealer)
More than
5cm
Bend the pipe as closely
on the wall as possible,
but be careful that it
doesn't break.
(Left and right
are identical)
Air filter
Left rear piping
"D"
Vinyl tape (Wide)
Saddle
Apply after carrying out a
drainahe test.
To carry out the drainage
test, remove the air filters
and pour water into the heat
exchanger.
Right rear piping
"C"
More than
60cm
More than
10cm
More than
10cm
More than 70cm
ø70mm
Hole center
Gas side piping
Liquid side piping
Additional drain pipe
Vinyl tape (Narrow)
Connecting cable: Cooling & Heat pump: 2EA
Cooling only: 1EA
Indoor
unit pipe
Connection
pipe
Vinyl tape
(wide)
Wrap with vinyl tape
Connecting cable
Pipe
Vinyl tape(narrow)
Drain pipe
Indoor unit drain hose
Vinyl tape(narrow)
Adhesive
Smooth all round
Inside is shiny without scratches.
Connecting
cable
= Improper flaring =
Drain hose
Inclined
Even length
all round
Surface Cracked Uneven
damaged
thickness
Flare nut
Indoor unit tubing
Pipings
Tighten the flare nut with a wrench.
Spanner (fixed)
Flare nut
Connection pipe
Torque wrench
Indoor unit tubing
Cap
WARRANTY
CUSTOMER Copy
ASP/ASC/SSD Copy
LG
The LG Air Conditioner comes with 12 months warranty on all parts except front grill & plastic parts and, thereafter 4 year
Additional warranty on the compressor, from the date of purchase of the product, provided always that the warranty card bears
the rubber stamp, date and signature of our Authorized Dealer.
4 Year Additional Warranty on Compressor
The 4 year warranty on Compressor will be continue even after the expiry of 1 year period from the date of purchase. This warranty
covers Compressor only. Gas charging is included only when compressor is defective & inoperative. During the additional warranty
period, it does not cover any part such as condenser coil, evaporator coil, capillary, suction line, electronics parts, etc. Standard
visiting charges will be applicable within the municipal limit of town where LG Electronics India Pvt. Ltd. (LGEIL) has it's Authorized
Service centre, Service outside municipal limit will attract to and fro traveling, other incidental expenses in addition to standard
visiting charges, as prevailing from time to time. During the warranty period, only the parts replaced or repaired shall be free of
costs, but service charges shall always be payable by the customer.
Model :
Name of Customer :
Address :
Terms & Condition
1.
2.
3.
4.
5.
6.
7.
8.
9.
10.
11.
12.
13.
14.
15.
The warranty is confined to the first purchaser of the Air- Conditioner only & is non-transferable.
Installation, Repairs & replacements will be carried out by the dealer (Sales & Service) from whom the product has been
purchased, or through the Authorized Service Centers of LGEIL. In case the customer shifts the place of residence during
warranty period, it is advised to contact Authorized Service Centre directly or call our help line no's (toll free). Any alteration in
the installation position or shifting of the Air- Conditioner from one premises to another should be carried out by the
LG Electronics Customer Care Center or its Authorised Service Franchisee / Sales & Service Dealer only. Such
change if address of the installation must be notified to LG Electronics Customer Care Center.
Repairs under warranty shall be carried out by an authorized service personnel only. The details of centralized help lines are
attached.
For units installed beyond municipal limits of the jurisdiction of company's Authorized Service Center, it is responsibility of the
purchaser to contact the nearest authorized service center and bring the unit to the authorized service center at its own cost
and risk. All expenses incurred in collecting the units or parts thereof from the company's authorized service center, as well as
expenses incurred with deputizing of service personnel/technicians towards conveyance and other incidentals etc. will be
borne by the customer. Local Charges for transportation and handling charges may vary from location to location. Customers
are advised to verify before. In case the customer desires to bring the unit on its own to the Authorized Service Centre, the
same shall be at its own risks & consequences.
The concerned authorized service center will advise the customer whether to effect the repairs at site or at the authorized
service center.
Call registered with the centralized helpline/Authorized service center, wherein only cleaning of the unit/parts in the unit due to
dust accumulation on portions of the unit, are not to be considered as defects.
In case of repairs or replacement of any part/s of the unit, this warranty will thereafter continue and remain in force only for the
unexpired period of the warranty. Replacement of parts would be purely at the discretion of LGEIL alone. In case the
replacement of the entire unit is being made, (subject to the sole discretion of LGEIL), the same model shall be replaced and in
the event such model has been discontinued, it shall be replaced with the model of price equivalent at the time of purchase.
In case of any damage to the product / customer abuse/ repairs by un-authorised personnels/ misuse detected/ by the
Authorized Service Center personnel, the warranty conditions are not applicable and repairs will be done subject to availability
of parts and on a chargeable basis only.
This warranty shall not cover any consequential or resulting liability, damage or loss to property or life arising directly or
indirectly out of any defect in the Air- Conditioner. The company's obligation under this warranty shall be limited to repair or
providing replacement of defective parts only under the warranty period.
The company or its Authorized Service Center reserves the right to retain any part/s or component replaced at its discretion, in
the event of a defect being noticed in the equipment during warranty period.
While the company will make every effort to carry out repairs at the earliest, it however is made expressly clear that the
company is under no obligation to do so in a specified period of time.
Warranty does not cover accessories external to the equipment supplied by the dealer.
If any coloured internal or external components are replaced, there will be commitment to ensure that the shades match with
the original or other components. The replaced shades, patterns, tints may vary from the customer's unit due to continuous
usage of the unit. Any matching components changed at customer's request will be on chargeable basis except the
component which actually needed.
The unit shall be operated with variation of ±10% of rated voltage at 50Hz. Any failure due to voltage / fluctuation beyond
specified tolerance will not be covered under warranty.
Two ( 2 ) free preventive maintenance services ( Labor Only ) will be provided to customer during the first year warranty period.
To avail these free services customer has to register the call at call centre number 1800-180-9999. After expiry of 12 ( Twelve )
months from date of purchase company is not liable for any free services.
This Warranty is not applicable in any of the following cases:
1.
2.
3.
4.
5.
6.
7.
8.
9.
The warranty card is not completed properly at the time of purchase.
The completed warranty card is not presented to authorized service personnel at the time of service of the product.
The product is not operated according to instructions given in the Operating Instruction Booklet.
Defects are caused by improper or reckless use, which shall be determined by the company personnel.
Any repair work is carried out by persons other than authorized service personnel.
Defects are caused by due to causes beyond control like lightening, abnormal voltage, acts of God or while in transit to
service center or purchaser's residence.
The warranty is not valid in case, the serial number is deleted, defected or altered. Damage to the product or any
part/s due to transportation or shifting is not covered by warranty.
a) This warranty will automatically terminate on the expiry of the warranty period of 12 months, even if the AirConditioner may not be in use for any time during the warranty period for any reason
b) The warranty on compressor will automatically terminate on expiry of 4 years (after 1 year warranty period) even if
the Air-Conditioner may not be in use for any time during the said period for any reason.
Only courts in state of Delhi and places where LGEIL has its branch office shall have the jurisdiction for setting any
claims, disputes arising under the warranty.
Contact Number :
Installation Done By :
Installation Done By :
Installation
Contact Number :
2. Is the strength of installation enough
Is the machine installed on proper wooden frame
Yes/No
Yes/No
a) Vibration/abnormal noise observation
If yes provide detail
b) Electric Power Supply Input Volts
E
C
D
N
Outdoor
W
A
L
L
Indoor
B
Spec.
>100mm
>150mm
Yes/No
W
A
L
L
Actual
Return Air Temperature
Supply Air Temperature
Difference
b) Electric Power Supply Input Volts
2. Is the strength of installation enough
Is the machine installed on proper wooden frame
Difference should be
more than 12 Degree C
Checked drainage of condensed water, from
evaporator side to condenser side & from
side to drain outlet, by pouring water at
the base of evaporator coil
Customer Remarks / Signature :
A
F
B
D
Outdoor
W
A
L
L
AC
Top
Indoor
Parameter
A
B
Spec.
>100mm
>150mm
>10mm
C
>10mm
>1200mm
D
>1200mm
>200mm
>1000mm
Installer Sign
L
W
A
L
L
E
>200mm
F
>1000mm
Actual
Return Air Temperature
Supply Air Temperature
Difference
C
C
C
Difference should be
more than 12 Degree C
Checked drainage of condensed water, from
evaporator side to condenser side & from
side to drain outlet, by pouring water at
the base of evaporator coil
Customer Remarks / Signature :
LG Electronics
To be filled by installation Person of ASP/ASC/SSD/Other
Invoice No. and Date :
Yes/No
AC Model :
Sr. No. Unit :
ASP/ASC/SSD Stamp
Sr. No. of the Compressor :
Installer Sign
3850A22066B
To be filled by installation Person of ASP/ASC/SSD/Other
LG
Dealer’s Copy
______A Specify under test run
e) Temperature Reading
E
D
F
If more than 3V,
please consult
electrician for
proper earthing
to the unit
Name of Purchaser :
E
Floor
ASP/ASC/SSD Stamp
N
Name & Address of the Seller (LG / Authorised Dealer) :
______V
E
V
d) Current Drawn by the machine
C
Yes/No
Sr. No. of the Compressor :
Yes/No
ii) Supply between L & E = 230 ± 10% _______V
iii) Supply between L & N = 230 ± 10% _______V
c) Stabilizer Installed
Yes/No
If Yes Make:
Output : ________V
Wall
C
E
Yes/No
Yes/No
5. Installation of unit as per below distance spec
Celling
Sr. No. Unit :
Yes/No
i) Checked for earthing with the unit
______V
(Voltmeter reading must be less than 3 V)
3. Direction of condenser of
North/South/East/West
machine is towards
4. If the direction of the condenser is towards South
Yes/No
or west, proper shade provided to the machine
______A Specify under test run
C
C
C
6. Run the machine for 30 minutes & checked for
the following
a) Vibration/abnormal noise observation
If yes provide detail
Indoor
E
Floor
A
L
AC Model :
Commissioning
1. Is the Capacity of the machine
suitable for the room in which
machine is installed
Room Dimensions
Length Width Height -
e) Temperature Reading
AC
Top
Parameter
If more than 3V,
please consult
electrician for
proper earthing
to the unit
ii) Supply between L & E = 230 ± 10% _______V
iii) Supply between L & N = 230 ± 10% _______V
c) Stabilizer Installed
Yes/No
If Yes Make:
Output : ________V
F
Indoor
______V
E
V
d) Current Drawn by the machine
B
Yes/No
i) Checked for earthing with the unit
______V
(Voltmeter reading must be less than 3 V)
3. Direction of condenser of
North/South/East/West
machine is towards
4. If the direction of the condenser is towards South
Yes/No
or west, proper shade to be provided to the machine
A
Yes/No
Invoice No. and Date :
Name of SSD/ASP/ASC/Other :
Installation
Commissioning
Yes/No 6. Run the machine for 30 minutes & checked for
the following
Wall
Name of Purchaser :
Date of Purchase / Date Of Installation :
1. Is the Capacity of the machine
suitable for the room in which
machine is installed
Room Dimensions
Length Width Height -
Celling
Serial Number:
Address :
Date of Purchase / Date Of Installation :
Name of SSD/ASP/ASC/Other :
5. Installation of unit as per below distance spec
Model :
Name of Customer :
Serial Number:
Customer’s Copy
LG Electronics
Name & Address of the Seller (LG / Authorised Dealer) :
LSU-17
LSU-18
LSU-22
LSU-16
LSU-14
LSU-12
LSU-13
LSU-10
LSU-19
LSU-15
LSU-09
LSU-11
LSU-08
5 5 2 1 1 4
5 5 2 1 1 7
5 5 2 1 1 7
LSU-20
LSU-03
LSU-07
LSU-05
5 5 2 1 1 7
LSU-23
LSU-06
LSU-01
LSU-02
LSU-04
N o t e )
Service Manual
Download PDF