Please read this manual carefully before operating your set and retain it for future reference. P/No.:MFL67107303 www.lg.com CONTENTS INSTALLATION ..........................................3 POWER SOURCE AND TEST - RUNNING ............3 FEATURE CHART.......................................4 OPERATIONS..............................................5 ADVICE ON FOOD STORAGE...................5 CARE AND CLEANING...............................6 MAINTENANCE...........................................6 IMPORTANT WARNINGS .......................7-8 TROUBLE SHOOTING................................9 BEFORE CALLING FOR SERVICE ..........10 2 INSTALLATION 1. Place your chest freezer at a convenient location. 5.Before use, remove all the packing material. The back side of the cabinet should be more than 20cm away from the wall, both flank sides more than 20cm. 2. Avoid placing the near any heat sources, direct sunlight or moisture. 3. Clean your chest freezer thoroughly and wipe off all dust accumulated during transportation. 6.The chest freezer should be put in well-ventilated, dry place. Don’t use it under direct sunshine. The chest freezer should be kept away from water sink, heat source and any volatile,corrosive material. 4. Connect the power supply cord to the outlet. Don't plug other appliances to the same outlet. POWER SOURCE AND TEST RUNNING 1.Specified capacity of the wire is 6A. Section squares of the wire is 0.75mm. Single line or compound lines are all allowed.The fuse of 2.5A specified electric current should be installed. (Power cord should be replaced with the same of 6A and 0.75mm,when it is damaged). 2.Single-phase power supply,50Hz,voltage range187~242V.If the voltage is unstable, please install a voltage stabilizer with capacity above1000W. 3.Avoid turning on and off the power too frequently. If the power is turned off,wait an interval of 5 minutes before turning it on again. 4.When the chest freezer will be out of use for along time,disconnect the power first,then clean it. Please examine the circuit whether it is excellent before reuse. 3 FEATURE CHART 1 2 9 3 5 4 7 6 8 1.Handle 6.Compressor room cover 2.Door 7.Thermostat control panel 3.Basket(1 or 2) 8.Castors 4.Cabinet 9.Glass doors(optional) 5.Lock(optional) 4 OPERATIONS STARTING When your chest freezer is first installed, leave it for 2 or 3 hours for stabilization to normal operating temperature before filling it with food. Delay 5 minutes before restarting if operation has been interrupted. TEMPERATURE CONTROL Power Run Initially, set the chest freezer control at mid position. If you wish a colder temperature,set the desired compartment control to a higher number. The knob should be kept upright normally to adjust the temperature. Power: when the light is on, the power is on. Run: when the light is on, the compressor is working normally. “0” stop the compressor. “7” is the strongest cooling position and is suitable for fast freezing. Do not keep the knob at this point for long. ADVICE ON FOOD STORAGE 1. Never store hot food in the chest freezer. Always wait until cooled off. 2. When storing, cover food with vinyl wrap or store in acontainer with lid. When moisture in the food evaporates, taste and nutrition of the food disappear as well. 3. Never place bottles in the freezer compartment.They may break while freezing. 4. Never refreeze food that has been thawed after being frozen. This would cause the taste and nutrition to disappear. 5. Clean food before yous tore it, so that adjacent food will not be spoiled. 6. There must be space between the foods stored in the cabinet, between the foods and the inner surface of the cabinet, so as to keep good ventilation of cold air and freeze evenly. Do not put in any bottled or canned beverage with freezing point above the temperature in the cabinet when it is below zero. 7. For foods that should be moisture-free or lose water easily, wrap them up with hermetical food bags or fresh films before putting in the cabinet for the sake of avoiding smell-mixing and reducing frosting. 8. Storage of volatile and combustible gases, liquids such as strong alkalies, strong acids, petrol, etc. is forbidden. 5 CARE AND CLEANING Cleaning-Inside ● To clean the inside,use a soft cloth dampered with solution of at ablespoon of baking soda to a quarter of water, or some mild detergent. ● This solution both cleans and neutralizes odors. Rinse with water and wipe dry. Follow the same procedure to clean the interior parts. Cleaning-Outside ● Use a lukewarm solution of mild soap or detergent to clean the durable finish of your chest freezer. Wipe with a clean, dampened cloth, then dry. WARNING Always remove power cord from the wall outlet prior to cleaning in the vicinity of electrical parts. Wipe up excess moisture witha sponge or cloth to prevent water or liquid from getting into any electrical part and causing a electric shock. Do not use flammable or toxic cleaning liquids. MAINTENANCE 1.The chest freezer should be cleaned regularly.When cleaning, turn off the power, take out the foods in the cabinet, clean the inside using water or a little neutral detergent. 2.Do not use boiling water, acid, chemical diluents,petrol and oil,or dirt-removing powder. 3.Dry it after cleaning. 4.Use light soap water when cleaning the door seal, apply a little of talcum powder on it after natural drying to extend its service life. 5.Use soft cloth with water or a little detergent to clean the out surface. Note, keeping the power supply and lower part of connect wires away from water to avoid electricity leakage. 6.Except common breakdowns,those who are not service technician should not take apart and repair the chest freezer on their own so as to avoid worsening the trouble. Unauthorized repair of electrical part such as compressor,temperature controller is forbidden. 7.Defrost for better freezing efficiency when the frost film in the cabinet is 4-5mm thick. 8.When defrosting, turn off the power, take out the frozen foods, open the door for warming and melting Use soft cloth to absorb water and clean it up. 9.Do not use sharp metal tools such as steel brush to clean the frost film when defrosting so as to avoid evaporator damage. 6 IMPORTANT WARNINGS WARNING To reduce the risk of fire, electric shock, or injury to persons when using your product, basic safety precautions should be followed, including the following. Read all instructions before using this appliance. Do not extend or modify the length of the power plug. The dedicated outlet should be used. • Using several devices at one outlet may cause fire. • The electric leakage breaker may damage food and the dispenser may be leaked. It causes electric shock or fire by the electric damage of the power cord or others. Do not allow the power plug to face upward or to be squeezed at the back of the chest freezer. Do not pull out the cord or touch the power plug with wet hands. Water may be flown into or the plug may be damaged, which causes fire or electric shock. • It may cause electric shock or injury. Unplug the power plug when cleaning. When the power cord or the power plug is damaged or the holes of the outlet are loosed, do not use them. • It may cause electric shock or injury. Make sure of grounding. It may cause electric shock or short circuit to make fire. The incorrect grounding may cause breakdown and electric shock. Accessibility of supply plug. Do not install the chest freezer in the wet place or the place which water or rain splashes. The chest freezer should be so positioned that the supply plug is accessible for quick disconnection when accident happens. Deterioration of insulation of electric parts may cause electric leakage. Do not damage, puncture, kink, stretch, or twist the power cord. When gas is leaked, do not touch the chest freezer or the outlet and ventilate the room immediately. A damaged power cord can cause fire or electric shock. Install the chest freezer on the solid and level floor. Do not put bottle in the chest freezer. Installing it on the unstableplace may cause death by falling down the chest freezer when opening or closing the door. It may freeze the contents to break the bottle to cause injury. Avoid the heating devices. It may cause fire. 7 IMPORTANT WARNINGS Do not store the medicine or the academic materials at the chest freezer. Do not place flower vase, cup, cosmetics, medicine or any container with water on the chest freezer. When the material with the strict temperature control is stored, it may be deteriorated or it may make an unexpected reaction to cause any risk. It may cause fire, electric shock or injury by dropping down. Do not insert the hands or the metal stick into the exit of cool air, the cover, the bottom of the chest freezer, the heatproof grill (exhaust hole) at the backside. Do not use or store inflammable materials ether, benzene, alcohol, medicine, LP gas, spray or cosmetics near or in the chest freezer. It may cause electric shock or injury. It may cause explosion or fire. Do not cling to the chest freezer. Do not place the lit candle within the chest freezer to deodorize. It may make the chest freezer fallen down or damage the hands. Especially, do not allow the children to do the above. It may cause explosion or fire. Do not spray water at the outside or the inside of the chest freezer or do not clean it with benzene or thinner. When any strange smell or smoke is detected from the chest freezer, disconnect the power plug immediately and contact to the service center. Deterioration of insulation of electric parts may cause electric shock or fire. It may cause fire. Use the submerged chest freezer after checking it. Do not allow any person except the qualified engineer to disassemble, repair or alter the chest freezer. It may cause electric shock or fire. It may cause injury, electric shock or fire. CAUTION Violating this direction may cause injury or damage house or furniture. Always be careful, please. Do not touch food or containers at the freezer with wet hands. Do not put any living animal in the chest freezer. It may cause frostbite. This appliance is not intended for use by persons (including children) with reduced physical, sensory or mental capabilities, or lack of experience and knowledge, unless they have been given supervision or instruction concerning use of the appliance by a person responsible for their safety. Children should be supervised to ensure that they do not play with the appliance. 8 TROUBLE SHOOTING Breakdown The indicator is not on. The compressor doses not start. Case Removal method The plug isn’t connected to the socket really. Replug it. No power Connect the socket with power. The indicator is on, but the compressor doesn’t work and buzzes only. The power voltage is <187V. The compressor stops a minute after start, and restart after a few minutes, and so repeatedly. The power voltage is >242V. The door is opened too frequently. Reduce open times. The food in the cabinet is too much,and placed improperly. Place food sproperly keep place between them for ventilation of cold air. The frost film is too thick. Take out foods and defrost. The surface of the condenser is too dirty. Stop and clean the condenser. The door seals badly. Adjust the door seal. The chest freezer is placed unstably. Place it stably. The fixing of the chest freezer is loose. Tighten the fixing. There’s contact between pipes. Separate them. The compressor works normally, but the temperature in the cabinet lowers too slowly. The noise is too loud Put a power-regulater more than 1000W power together. 9 BEFORE CALLING FOR SERVICE It is often possible to avoid a service call. Before calling for service,make the following checks. 1. Has a house fuse blown or a circuit breaker tripped on? 2. Has the power cord plug been removed or loosened from the wall outlet? 3. Is the temperature control set to aproper position? 4. Is the appliance placed too closed to a wall or a heat source? 5. Has the door been kept open more than necessary? 6. Is the chest freezer installed on a firm and even place? 7. In case of odor, food with strong odor should be tightly covered or wrapped, and interior may need cleaning. THE FOLLOWING ARE NOT FAULTS: 1. When the chest freezer is working or after is stops for a while,the refrigerant in the pipes is cycling and gives out “running water” sounds. 2.The surface temperature of the compressor may be up 70℃~80℃ when it is working. 3.The back side of step freezer gives out heat. 4. In rainy season,the outer surface of the cabinet may have dew,which makes no defects on normal use. Just dry it with a piece of cloth. 10 10 9 8 • • • • • • • • • • • 7 ● ● ● 6 Power Run 5 1 2 9 3 5 4 7 8 4 6 3 3...................................................................................... 3........................................................ 4............................................................................ 5...................................................................................... 5................................................................ 6............................................................................ 6...................................................................................... 7-8........................................................... 9 .......................................................................... 10 ............................................................... 2 P/NO.:MFL67107303 www.lg.com
advertising