125980881.qxp 2005-03-15 15:25 Page 1 TUMBLE DRYER SECADORA ZTB 220 ELECTRONIC SENSOR A B C D E F G H ZTB 220 J K L A U T O R E V E R S E Unpacking: see page 7 Desembalaje: ver página 21 INSTRUCTION BOOKLET INSTRUCCIONES PARA EL USO 125980881 GB E 125980881.qxp 2005-03-15 15:25 Page 2 Dear customer, Please read these operating instructions carefully and pay particular attention to the safety notes indicated in the first pages. We recommend that you keep this instruction booklet for future reference and pass it on to any future owners. Transport damages After unpacking the machine please check it is not damaged. If in doubt, do not start it but contact your local Service Centre. The symbols you will see on some paragraphs of this booklet have the following meaning: The warning triangle emphasize information that is particularly important for your safety or correct functioning of the appliance. The information marked with this symbol provides additional instructions and practical tips on the use of the appliance. Tips and information about economical and ecological use of the machine are marked with this symbol. Our contribution to the protection of the environment: we use recycled paper. 2 125980881.qxp 2005-03-15 15:25 Page 3 Important safety information ............4 Maintenance and Cleaning................14 External cleaning ................................................14 Disposal ............................................................5 Tips for environmental protection Cleaning the door................................................14 Cleaning the filters ..............................................14 5 Something not working? ....................15 Description of the appliance ..............6 Installation ......................................................7 Unpacking ............................................................7 Positioning ............................................................7 Fitting the vent hose ..........................................7-8 Electrical connection ............................................8 Stacking kit............................................................8 Door reversal ........................................................8 Use ........................................................................9 The control panel ............................................9-10 Programme chart ................................................11 Operating sequence............................................12 Useful hints ........................................................13 Technical specifications DIMENSIONS: Height Width Depth 85 cm 60 cm 58 cm ELECTRICAL CONNECTION: MAX. POWER ABSORBED: MIN. FUSE RATING: 220/230 V/50 Hz 2200 W 10 A MAX. DRYING CAPACITY: Cotton, linen Synthetics 5 kg 2.5 kg CONSUMPTION: Cotton, linen Cotton, linen 3.3 kWh (5 kg store dry) 2.7 kWh (5 kg iron dry) This appliance complies with the following E.E.C. Directives: - 73/23 EEC of 19.2.73 (Low Voltage Directive) and subsequent modifications; - 89/336 EEC of 3.5.89 (Electromagnetic Compatibility Directive) and subsequent modifications. 3 ENGLISH Contents 125980881.qxp 2005-03-15 15:25 Page 4 Important safety information These warnings have been provided in the interest of safety. You MUST read them carefully before installing or using the appliance. prevent fire risks, do not use the appliance if the fluff filters are damaged or without filters. Installation • Any electrical work required to install this appliance should be carried out by a qualified electrician or competent person. • Do not allow fluff to accumulate around the dryer. General safety • Care must be taken to ensure that the appliance does not stand on the electrical supply cable. • It is dangerous to alter the specifications or attempt to modify this product in any way. • If the machine is situated on a carpeted floor, please adjust the feet in order to allow air to circulate freely. • Under no circumstances should you attempt to repair the machine yourself. Repairs carried out by inexperienced persons may cause injury or serious malfunctioning. Contact your local Zanussi Service Centre. Always insist on genuine Zanussi spare parts. • This tumble dryer is designed to be vented through to the open air. It should have its own ventilation system which should not be joined with any other ventilation system connected to any other appliance. Child safety Use • Children are often not aware of how dangerous electrical appliances can be. When the machine is working, children should be carefully supervised and not be allowed to play with the appliance. • This appliance is designed for domestic use only. If the machine is used for any other purposes or is not used correctly, the manufacturer accepts no responsibility for any damage that might occur. • The packaging components (e.g. plastic film, polystyrene) can be dangerous to children - danger of suffocation! Keep them out of children’s reach. • Always unplug the appliance after use. • Clothes which are dripping wet should not be placed in the dryer. • Make sure that children or pets do not climb into the drum. • Danger of explosion: Never tumble dry items that have been in contact with inflammable solvents (petrol, methylated spirits, dry cleaning fluid and the like). As these substances are volatile, they could cause an explosion. Tumble dry only items washed with water. • When the appliance is to be scrapped, cut off the electrical supply cable and destroy the plug with the remaining cable. Disable the door catch in order to prevent children from becoming trapped inside while playing. • Risk of fire: items that have been spotted or soaked with vegetable or cooking oil constitute a fire hazard and should not be placed on the tumble dryer. • If you have washed your laundry with stain remover you must execute an extra rinse cycle before loading your tumble dryer. • Please make sure that no gas lighters have accidentally been left in pockets of garments to be loaded into appliance. • Do not dry canvas shoes or sports shoes, as they could get stuck between the door and the drum, thus blocking this latter. • Leave the door slightly ajar when the appliance is not being used. This will allow the seal to be preserved. • Clean fluff filters after using the tumble dryer. To 4 125980881.qxp 2005-03-15 15:25 Page 5 • • Packaging materials The materials marked with the symbol recyclable. are Old appliance The symbol on the product or on its packaging indicates that this product may not be treated as household waste. Instead it shall be handed over to the applicable collection point for the recycling of electrical and electronic equipment. By ensuring this product is disposed of correctly, you will help prevent potential negative consequences for the environment and human health, which could otherwise be caused by in appropriate waste handling of this product.For more detailed information about recycling of this product, please contact your local city office, your household waste disposal service or the shop where you purchased the product This means that they can be recycled by disposing of them properly in appropriate collection containers. • Machine Use authorised disposal sites for your old appliance. Help to keep your country tidy! Tips for environmental protection To save energy and to help protect the environment, we recommend that you follow these hints: • To utilize the maximum load, laundry which is to be dried ready to put away (store dry) can be dried together with items to be ironed. To do this, select the programme for iron-dry, remove the iron-dry items at the end of the programme and then finishdry the rest of the load. • Try to load the maximum capacity of the machine as small loads are uneconomical. • Always load well spun laundry. The higher the spin speed, the lower the electricity consumption and the shorter the drying times. • Clean the filters regularly to avoid excessive drying times and high electricity consumption. • Do not over-dry laundry, this avoids creasing and saves energy. Select the drying programme according to the type of laundry and the required degree of dryness. • Ventilate the room well. The room temperature should not exceed +35°C during drying. 5 ENGLISH Disposal 125980881.qxp 2005-03-15 15:25 Page 6 Description of the appliance 01 Control panel 02 Fluff filters 03 Rating Plate 1 04 Adjustable feet SOR NIC SEN ELECTRO E R S V E R E T O A U 2 3 2 4 05 Side vent outlets 06 Ring nut 07 Rear vent outlet 7 6 5 6 125980881.qxp 2005-03-15 15:25 Page 7 ENGLISH Installation Warning! Unpacking Slide out the polythene bag with the polystyrene stuffing before using the appliance. Pull off adhesive strips from inside machine on top of drum. P0046 The feet must never be removed. Do not restrict the floor clearance through deeppile carpets, strips of wood or similar. This might cause heat build-up which would interfere with the operation of the appliance. Important When operating the tumble dryer, the room temperature must not exceed 35°C, as it may affect the performance of the appliance. P1106 Fitting the vent hose Positioning To simplify the installation, there is a choice of vent outlets: one at the back, the others in the left and right-hand side. Connect the hose to whichever is the more convenient by pulling the ring nut (A) from the vent outlet at the back, screwing it on to the hose and pushing it firmly back into place. The unused vents should now be sealed with the special snap covers provided. It is recommended that, for your convenience, the machine is positioned close to your washing machine. Whilst drying, the tumble dryer will expel a certain amount of warm, very moist air, and this should be removed from the room as quickly as possible to prevent condensation. In an extremely well ventilated room or close to an open window, this may occur naturally. However, in general, it is better to carry the dryer's exhaust outside via the 100 mm diameter flexible hose supplied with the appliance; ending either temporarily at an open window, or permanently at a fixed ventilation grille, fitted to an exterior wall or window. The tumble dryer must be installed in a clean place, where dirt does not build up. Make sure there are no obstructing items or material near the air-intake louvres provided at the back (e.g. paper, rags etc.). A P1028 A P1027 Advice: If the hose is long and the room temperature low, the moisture might condense to water inside the hose. This is an unavoidable natural phenomenon. To prevent this water from Iying in the hose or flowing back into the tumble dryer, it is advisable to drill a small hole (dia. 3 mm) in the lowest point of the hose and to place a small container below it.(See picture, point B). To keep vibration and noise to a minimum when the dryer is in use, it should be placed on a firm, level surface. Once in its permanent operating position, check that the dryer is absolutely level with the aid of a spirit level. If it is not, raise or lower the feet until it is. 7 125980881.qxp 2005-03-15 15:25 Page 8 Electrical connection This machine is designed to operate on a 220-230 V, single-phase, 50 Hz supply. Check that your domestic electrical installation can take the maximum load required (2.2 kW), also taking into account any other appliances in use. P1056 B Connect the machine to an earthed socket, in accordance with current wiring regulations. Once connected to the dryer, run the vent hose to the desired outlet point, ensuring that the run’s overall length is less than 2 m, and that it contains no more than two bends. As to the outlet itself, if you have decided on a fixed wall/window grille, a good local builder’s merchant should be able to supply you with the necessary fittings and installation advice. The manufacturer declines any responsibility for damage or injury through failure to comply with the above safety precaution. Stacking kit A special stacking kit is available through your dealer, to enable the mounting of the dryer on top of your washing machine. It is important not to connect the vent hose to, for example, a cooker hood, or a chimney or flue pipe designed to carry the exhaust from a fuel burning appliance. P1107 Door reversal P0055 To make it easier to load or unload the laundry the door can be reversed. This operation must be carried out by qualified personnel. Note that to avoid condensation problems, it is essential that the dryer be fitted with the flexible hose to carry its “exhaust” at least beyond the kitchen units; preferable outside the kitchen. Please contact the nearest Zanussi Service Centre. In order to prevent the appliance from overheating, it is important that the steam exhaust is unobstructed. Therefore, in case of a permanent hose fitted to an exterior wall or ceiling, it must be ensured an exhaust capacity of at least 150 m3/h. If the dryer is fitted next to kitchen units, make sure that the vent hose is not squashed. If the hose is partially squashed, drying efficiency will be reduced, resulting in longer drying times and higher energy consumption. If the hose is completely squashed, the safety cut-outs with which the machine is fitted may operate. 8 125980881.qxp 2005-03-15 15:26 Page 9 The control panel ELECTRONIC SENSOR A B C D E F G H J ZTB 220 K L A U T O R E V E R S E 1 2 3 4 5 6 7 8 1 Programme chart 6 Start button This will help you to select the correct programme for drying. Press this button for about 2 seconds to start the dryer after having selected the programme. If the door is opened while the programme is running, this button must be pressed again after closing the door in order to restart the programme from the point at which it was interrupted. This button must also be pressed after a power cut. In both cases light or (depending on the phase in progress) flashes to remind you that the start button needs to be pressed again. 2 Mains-ON light Comes on when the appliance is switched on (ON/OFF button pressed down) and goes out when this button is released. 3 ON/OFF button This button is used to switch the dryer on. At the end of the programme, release this button by pressing it again to switch the dryer off. 7 Programme phase indicator lights 4 Low temperature button These lights indicate the various phases of the programme as they are being performed. Pressing this button allows drying to be performed at a lower temperature, for delicate items. The corresponding pilot light comes on. “Drying” light 5 Buzzer OFF button “Cooling” light A buzzer sounds during the anti-creasing phase. Press this button when selecting the programme if you wish to switch the buzzer off. The corresponding light illuminates. This light indicates that the appliance is in the cooling phase. At the end of drying, there is a 10 minute cooling phase to cool the laundry. This light indicates that the appliance is in the drying phase. If light or is flashing, this means that the Start button needs to be pressed again for the programme to resume. “End of programme” light This light flashes at the end of the cooling phase and during the anti-creasing phase. 9 ENGLISH Use 125980881.qxp 2005-03-15 15:26 Page 10 “Anti-creasing phase” light This light flashes alternately with the light at the end of the drying phase (after cooling) and during the anti-creasing phase. If only light flashes, this means that the anticreasing phase has finished. 8 Programme/Time selector dial Allows you to select electronically controlled or time controlled drying. Turn the dial to the required programme or time. Electronically controlled drying (automatic) The appliance runs these programmes with the help of probes which detect the degree of dampness of the laundry. Simply select the programme according to the type of laundry and degree of drying required. Time controlled drying Can be used to finish off drying if necessary. Select the 60 minute programme for cottons or the 30 minute programme for synthetics. To cancel a programme which is running, turn the programme selector dial to “0”. At the end of drying, turn the selector dial to “0” before removing the laundry. 10 125980881.qxp 2005-03-15 15:26 Page 11 Programme chart Degree of drying required Type of laundry Cotton & linen extra dry ready to wear store dry slightly damp iron dry machine iron dry Synthetics extra dry store dry iron dry Jumpers Baby cycle Jackets, trousers, dresses, skirts. Dry fresh Max-load (1) Programme 5 kg 5 kg 5 kg 5 kg 5 kg 5 kg A B C(*) D E(*) F 2.5 kg 2.5 kg 2.5 kg G H(*) J 1 kg (10 jumpers) K 1 - 4 garments L (*) According to IEC 61121 Standards. • Baby cycle “K” is a special programme for jumpers to be dried “ready to wear”. Time controlled drying Drying time Max-load (1) kg Programme selector dial position Cotton 90 min 5 90’ Cotton 60 min 5 60’ Synthetics 30 min 2.5 30’ Type of laundry (1) Never overfill the drum (do not load large quilts, for example). Drying times vary according to: • The type of laundry • The size of the load • The degree of spinning prior to drying. Fresh & Cool This position on programme selector dial can be used to freshen the laundry (e.g. to remove a persistent odour of moth-balls). Load It is often difficult to estimate the weight of items to be dried. We therefore recommend that you adopt the following guidelines: • cotton, linen: drum full but not too tightly packed; • synthetics: drum no more than half full; • delicate fabrics: drum no more than one third full. 11 ENGLISH Automatic drying (electronic programmes) 125980881.qxp 2005-03-15 15:27 Page 12 Turn the programme selector dial to “0”; light goes out. Operating sequence Before using your tumble dryer for the first time, we recommend to place a few damp cloths inside the appliance and dry for 30 minutes. There may be dust inside a brand new tumble dryer. Release the ON/OFF button (the mains-ON light goes out) and immediately remove the laundry. After each use Drying • Turn the programme selector dial to “0”. 1. Connect the appliance. • Switch the appliance off by releasing the ON/OFF button . The mains-ON light goes out. 2. Open the door. • Clean the filters (see page 14). Important! If the drying programme has to be stopped before it reaches the end, we recommend that you turn the programme selector dial to position (cooling) and wait until the end of this phase before removing the laundry. This will avoid a build-up of heat inside the appliance. P1108 P1104 3. Load the items one at a time, shaking them out loosely. 4. Close the door. Please check the laundry does not get caught between the door and filter. 5. Press the ON/OFF button comes on. Modifying the programme To change a programme which is running, first cancel it by turning the programme selector dial to “0”. Select the new programme and press the Start button . : the mains-ON light 6. Select the drying programme or time. 7. If required, press the low temperature button and/or the buzzer OFF button . 8. Press the Start button for 2 seconds: light comes on and drying starts. The drum turns alternately in both directions during drying. All drying programmes end with a 10 minute cooling phase (light is on). You may remove the laundry after this phase. 9. If the laundry is not removed at the end of the cycle, the dryer performs an anti-creasing phase (duration: 30 minutes maximum). The buzzer sounds every 10 seconds (if the button has not been pressed). Lights and flash alternately. If you do not remove the laundry, the dryer will stop automatically at the end of the anti-creasing phase. Light flashes and the mains-ON light stays on. 12 2005-03-15 15:27 Page 13 • Avoid drying dark clothes with light coloured fluffy items such as towels as they could attract the fluff. Useful hints • Try to load to the maximum capacity of the machine as small loads are uneconomical. For information, here is a list of the average weights of some common laundry items. Sheet • Easy-care items, too, e.g. shirts, should be briefly pre-spun before drying (depending on crease resistance approx. 30 seconds or using the special brief spin programme of your washing machine). 700 - 1000 g Tablecloth • Knitted textiles (knitted underwear) may shrink a little during drying. Please do not overdry items of this type. It is advisable to allow for shrinkage when choosing the size of new purchases. 400 - 500 g Kitchen towel 70 - 120 g Table napkin 50 - 100 g Towelling hand towel Bathrobe • The laundry must be thoroughly spun before tumble drying. • You can also put starched items into your dryer. However, to achieve the desired starched effect, choose the programme “iron dry”. To remove any starch residues, wipe out the internal drum after drying with a moist cloth and then rub it dry. 150 - 250 g 1000 - 1500 g Man’s shirt 200 - 300 g Pillowcase 100 - 200 g Man’s pyjamas 400 - 500 g Ladies’ nightdress 200 - 250 g • To avoid a static charge when drying is completed, use either a fabric softener when you are washing the laundry or a fabric conditioner specifically for tumble dryers. • Remove the laundry when the dryer has finished drying. • If individual items are still damp after drying, set a brief post-drying time, but at least 30 minutes. This will be necessary particularly for multilayered items (e.g. collars, pockets, etc.). • Never tumble dry the following: Particularly delicate items such as net curtains, woollen, silk, fabrics with metal trim, nylon tights, bulky materials such as anoraks, blankets, eiderdowns, sleeping bags, feather quilts and any items containing rubber foam or materials similar to rubber foam. • Always follow the instructions on garment labels: may be tumble dried normal drying (high temperature) delicate drying (low temperature) do not tumble dry • Close pillowcases and covers with fasteners to prevent small laundry items getting tangled inside them. Close press studs, zips and hooks and tie belts and apron strings. • Sort laundry according to type and degree of drying required. • Do not over-dry laundry, this avoids creasing and saves energy. 13 ENGLISH 125980881.qxp 125980881.qxp 2005-03-15 15:27 Page 14 Maintenance and Cleaning You must disconnect the appliance from the electricity supply, before you can carry out any cleaning or maintenance work. If necessary the filters can be cleaned under running water using a brush. In this case remove the filter in the door opening as per picture (it can be positioned with the tooth facing to the left or to the right). External cleaning 650 800 / kg 5 kg 2,5 900 70' - 90' 35' - 50' 1000 / 1200 65' - 85' 30' - 45' Use only soap and water and then dry thoroughly. Important: do not use methylated spirit, diluents or similar products. Cleaning the door P1112 Clean periodically the interior part of the door to remove any fluff from the seals around the filter. Accurate cleaning ensures correct drying. 650 800 / kg 5 kg 2,5 900 70' - 90' 35' - 50' 1000 / 1200 65' - 85' 30' - 45' 800 / 900 80' - 100' 70' 55' - 1000 / 1200 75' - 95' 50' - 65' kg 2,5 kg 1 50' - 60' 30' - 35' E R S V E R E T O A U P1109 Cleaning the filters Your dryer will only function well if the filters are clean. The filters collect all the fluff which accumulates during drying and they must therefore be cleaned at the end of each programme, before removing the laundry, with a damp cloth. 650 800 / kg 5 kg 2,5 P1110 900 70' - 90' 35' - 50' 1000 / 1200 65' - 85' 30' - 45' 800 / 900 80' - 100' 70' 55' - 1000 / 1200 75' - 95' 50' - 65' kg 2,5 kg 1 50' - 60' 30' - 35' E R S V E R E T O A U P1111 The filter in the inner door must be removed for cleaning. Do not be alarmed by the amount of fluff. It is not due to excessive wear caused by the dryer. All fabric loses fluff when drying but it goes un-noticed in the air. In a tumble dryer it simply collects in the filter. 14 800 / 900 80' - 100' 70' 55' - 1000 / 1200 75' - 95' 50' - 65' kg 2,5 kg 1 50' - 60' 30' - 35' E R S V E R E T O A U 125980881.qxp 2005-03-15 15:27 Page 15 ENGLISH Something not working? Before contacting your local Zanussi Service Centre, please make the following checks: Problem Possible cause • The door is open. • The dryer does not work: • The plug is not fitted into the wall socket. • There is no electricity supply from the wall socket. • The selector dial is not set correctly. • The start button has not been depressed. • The filters are clogged. • The dryer does not dry properly: • The selected cycle is not suitable for the laundry. • The laundry has not been spun properly. • The low temperature function selected. has been • Excessive laundry load. • The dryer is not correctly installed. If, after the above checks, there is still a fault, call your local Zanussi Service Centre. Please make sure you give the model and serial number of the appliance. This information can be found on the rating plate (see picture on page 6). 15 125980881.qxp 2005-03-15 15:29 Page 30 From the Electrolux Group. The world’s No. 1 choice. The Electrolux Group is the world's largest producer of powered appliances for kitchen, cleaning and outdoor use. More than 55 million Electrolux Group products (such as refrigerators, cookers, washing machines, vacuum cleaners, chain saws and lawn mowers) are sold each year to a value of approx. USD 14 billion in more than 150 countries around the world.
* Your assessment is very important for improving the work of artificial intelligence, which forms the content of this project