Zanussi | ZDC37202W | User manual | ZANUSSI ZDC37202W User Manual

EN
User manual
Condenser dryer
ZDC 37202W
Contents
Important safety information _ _ _ _ _ _ _ _ _
Environment _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _
Installation _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _
Product description _ _ _ _ _ _ _ _ _ _ _ _ _
Control panel _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _
Before first use _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _
Programme chart _ _ _ _ _ _ _ _ _ _ _ _ _ _ _
2
4
4
7
7
7
7
Sorting and preparing laundry _ _ _ _ _ _ _ _ 8
Daily use _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 9
Cleaning and maintenance _ _ _ _ _ _ _ _ _ 10
What to do if ... _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 11
Technical data _ _ _ _ _ _ _ _ _ _ _ _ _ _ _ 12
Machine settings _ _ _ _ _ _ _ _ _ _ _ _ _ _ 13
Subject to change without notice.
Important safety information
Important! In the interest of your safety
and to ensure the correct use, before
installing and first using the appliance,
read this user manual carefully, including
its hints and warnings. To avoid
unnecessary mistakes and accidents, it is
important to ensure that all people using
the appliance are thoroughly familiar
with its operation and safety features.
Save these instructions and make sure
that they remain with the appliance if it is
moved or sold, so that everyone using it
through its life will be properly informed
on appliance use and safety.
- Please read the instruction book before using this appliance.
General safety
• It is dangerous to alter the specifications or
attempt to modify this product in any way.
• This appliance is not intended for use by
persons (including children) with reduced
physical and sensory conditions or lack of
experience and knowledge, unless they have
been given supervision or instruction concerning use of the appliance by a person responsible for their safety.
• Make sure that small children and pets do
not climb inside the drum. To avoid this,
please check into the drum before using.
• Any objects such as coins, safety pins, nails,
screws, stones or any other hard, sharp material can cause extensive damage and must
not be placed into the machine.
2
• In order to avoid danger of fires caused by
excessive drying, do not use appliance to dry
the following items: Cushions, quilts and the
like (these items accumulate heat).
• Items such as foam rubber (latex foam),
shower caps, waterproof textiles, rubber
backed articles and clothes or pillows fitted
with foam rubber pads should not be dried
in the tumble dryer.
• Always unplug the appliance after use,
cleaning and maintenance.
• Under no circumstances should you attempt
to repair the machine yourself. Repairs carried out by inexperienced persons may
cause injury or serious malfunctioning. Contact your local Service Centre. Always insist
on genuine spare parts.
• Items that have been soiled with substances
such as cooking oil acetone, petrol, kerosene, spot removers, turpentine, waxes and
wax removers should be washed in hot water with an extra amount of detergent before
being dried in the tumble dryer.
• Danger of explosion: Never tumble dry
items that have been in contact with inflammable solvents (petrol, methylated spirits,
dry cleaning fluid and the like). As these
substances are volatile, they could cause an
explosion. Only tumble dry items washed
with water.
• Risk of fire: items that have been spotted
or soaked with vegetable or cooking oil constitute a fire hazard and should not be
placed in the tumble dryer.
www.zanussi.com
• If you have washed your laundry with stain
remover you must execute an extra rinse cycle before loading your tumble dryer.
• Please make sure that no gas lighters or
matches have accidentally been left in pockets of garments incase they are loaded into
appliance
Warning!
• Risk of fire! Never stop a tumble
dry before the end of the drying cycle unless all items are quickly removed and spread out so that the
heat is dissipated.
• Lint must not be allowed to accumulate around the tumble dryer.
• Risk of electric shock! Do not spray down
the appliance with jets of water.
• The final part of a tumble dryer cycle occurs
without heat ( cool down cycle ) to ensure
that the items are left at a temperature that
ensures that items will not be damaged.
• The tumble dryer is not to be used if industrial chemicals have been used for cleaning.
• Ensure you have good ventilation in the installation room to avoid the back flow of
gases into the room from appliances burning
other fuels, including open fires.
Installation
• This appliance is heavy. Care should be taken when moving it.
• When unpacking the appliance, check that it
is not damaged. If in doubt, do not use it and
contact the Service Centre.
• All packaging must be removed before use.
Serious damage can occur to the product
and to property if this is not adhered to. See
relevant section in the user manual.
• Any electrical work required to install this
appliance should be carried out by a qualified electrician or competent person.
• If the machine is situated on a carpeted
floor, please adjust the feet in order to allow
air to circulate freely under the appliance.
www.zanussi.com
• After having installed the appliance, check
that it is not pressing or standing on its electrical supply cable.
• If the tumble dryer is placed on top of a
washing machine, it is compulsory to use the
stacking kit (optional accessory).
Use
• This appliance is designed for domestic use.
It must not be used for purposes other than
those for which it was designed.
• Only wash fabrics which are designed to be
machine dried. Follow the instructions on
each garment label.
• Do not dry unwashed items in the tumble
dryer.
• Do not overload the appliance. See the relevant section in the user manual.
• Clothes which are dripping wet should not
be placed in the dryer.
• Garments which have been in contact with
volatile petroleum products should not be
machine dried. If volatile cleaning fluids are
used, care should be taken to ensure that
the fluid is removed from the garment before
placing in the machine.
• Never pull the power supply cable to remove
the plug from the socket; always take hold of
the plug itself.
• Never use the tumble dryer if the power supply cable, the control panel, the working surface or the base are damaged so that the inside of the tumble dryer is accessible.
• Fabric softeners, or similar products should
be used as specified by the fabric softener
instructions.
• Caution - hot surface : Do not touch the
door light cover surface when the light is
switched on.
(Only dryers equipped with internal drum
light)
Child safety
• This machine is not intended for use by
young children or infirm persons without supervision.
• Children often do not recognise the hazards
associated with electrical appliances. Chil3
dren should be supervised to ensure that
they do not play with the appliance.
Warning!
• Danger of suffocation! The packaging
components (e.g. plastic film, polystyr-
ene) can be dangerous to children Keep them out of children’s reach.
• Keep all detergents in a safe place out of
children’s reach.
• Make sure that children or pets do not climb
inside the drum.
Environment
Recycle the materials with the symbol . Put
the packaging in applicable containers to
recycle it.
Help protect the environment and human
health and to recycle waste of electrical and
electronic appliances. Do not dispose
appliances marked with the symbol with the
household waste. Return the product to your
local recycling facility or contact your municipal
office.
Environmental tips
• In the dryer, laundry becomes fluffy and soft.
Fabric softeners are not therefore needed
when washing.
• Your dryer will function most economically if
you:
– Always keep the ventilation slots on the
base of the dryer unobstructed;
– Use the loading volumes specified in the
programme overview;
– Ensure you have good ventilation in the installation room;
– Clean the micro-fine filter and fine strainer
after each drying cycle;
– Spin the laundry well before drying.
Energy consumption depends on spinning
speed set in washing machine. Higher
spinning speed - lower energy consumption.
Environmental information
The packaging materials are environmentally
friendly and can be recycled. The plastic components are identified by markings, e.g. >PE<,
>PS<, etc. Please dispose of the packaging
materials in the appropriate container at the
community waste disposal facilities.
Warning! When the unit is no longer
being used:
• Pull the plug out of the socket.
• Cut off the cable and plug and dispose of
them.
• Dispose of the door catch. This prevents
children from trapping themselves inside and
endangering their lives.
Installation
Important! The appliance must be moved in
vertical position for transport.
Appliance positioning
• It is recommended that, for your convenience, the machine is positioned close to
your washing machine.
• The tumble dryer must be installed in a clean
place, where dirt does not build up.
• Air must be able to circulate freely all round
the appliance. Do not obstruct the front ven-
4
tilation grille or the air intake grilles at the
back of the machine.
• To keep vibration and noise to a minimum
when the dryer is in use, it should be placed
on a firm, level surface.
• Once in its permanent operating position,
check that the dryer is absolutely level with
the aid of a spirit level. If it is not, raise or
lower the feet until it is.
• The feet must never be removed. Do not restrict the floor clearance by using deep pile
carpets, strips of wood or similar. This might
www.zanussi.com
cause heat built-up which would interfere
with the operation of the appliance.
Important!
• The hot air emitted by the tumble dryer can
reach temperatures of up to 60°C. The appliance must therefore not be installed on
floors which are not resistant to high temperatures.
• When operating the tumble dryer, the room
temperature must not be lower than +5°C
and higher than +35°C, as it may affect the
performance of the appliance.
• Should the appliance be moved, it must be
transported vertically.
• The appliance must not be installed behind
the lockable door, a sliding door a door with
a hinge on the opposite side to that of the
appliance in such a way that a full opening of
the dryer is restricted.
Ensure min. 5cm free space around the appliance.
Removing transport safety packaging
Caution! Before use all parts of the
transport packaging must be removed.
3. Remove foil hose and polystyrene padding
from the machine.
Electrical connection
Details on mains voltage, type of current and
the fuses required should be taken from the
rating plate. The rating plate is fitted near the
loading aperture (see “Product description”
chapter).
Connect the machine to an earthed socket, in
accordance with current wiring regulations.
Warning! The manufacturer declines
any responsibility for damage or
injury through failure to comply with the
above safety precautions.
Should the appliance power supply cable
need to be replaced, this must be carried
out by an authorised service engineer or
a qualified electrician. .
The appliance is supplied with a 13 amp plug
fitted. In the event of having to change the fuse
in the plug supplied, a 13 amp ASTA approved
BS 1363/A fuse must be used.
4
3
1. Open loading door 2. Pull off adhesive
strips from inside machine on top of drum.
1
2
The wires in the mains lead are coloured in accordance with the following code:
1 Blue - Neutral
2 cord clamp
3 Brown - Live
4 Green and Yellow - Earth
The wire coloured green and yellow must be
connected to the terminal marked with the letwww.zanussi.com
5
ter «E» or by the earth symbol
or coloured
green and yellow.
The wire coloured blue must be connected to
the terminal «N» or coloured black.
The wire coloured brown must be connected
to the terminal marked «L» or coloured red.
Upon completion there must be no cut, or stray
strands of wire present and the cord clamp
must be secure over the outer sheath.
Warning! A cut off plug inserted into
a 13 amp socket is a serious safety
(shock) hazard.
Ensure that the cut off plug is disposed
of safely.
Warning! The plug must be
accessible after installing the
machine.
Permanent connection
In the case of permanent connection it is necessary that you install a double pole switch between the appliance and the electricity supply
(mains), with a minimum gap of 3 mm between
the switch contacts and of a type suitable for
the required load in compliance with the current electrical regulations.
The switch must not break the yellow and
green earth cable at any point.
Door reversal
To make it easier to load or unload the laundry,
the door can be reversed.
Warning! The door must only be
reversed by an authorised service
engineer.
Special accessories
• stack kit
Available from your Service Force Centre
or your specialist dealer
These intermediate installation kits can be
used to arrange the dryer and an washing
machine (60 cm wide, front loaded) as a
space-saving washer/dryer stack. The washing machine is at the bottom and the dryer is
at the top.
Read carefully the instructions supplied with
the kit.
• drain kit
Available from your Service Force Centre
or your specialist dealer
Installation kit for direct draining of condensate into a basin, siphon, gully, etc. The condensate tank then no longer has to be
drained, it must however remain in its intended position in the machine.
Read carefully the instructions supplied with
the kit.
• pedestal with the drawer
Available from your Service Force Centre
or your specialist dealer
To situate the dryer in optimal high and have
some additional space to store (e.g. laundry).
Read carefully the instructions supplied with
the kit.
Please contact your local Service Force Centre. The engineer will carry out the door reversal at your cost.
6
www.zanussi.com
Product description
1
6
7
2
8
3
9
10
4
5
1 Worktop
2 Rating Plate
3 Heat exchanger
4 Water reservoir
5 Heat exchanger door
6 Control panel
7 Fluff filters
8 Loading door
9 Ventilation grille
10 Adjustable feet
Control panel
1 Programme knob and
2 Delicate button
1
2
3
4
OFF switch
3 Cotton / Synthetic selection button
4 Function status led: Drying , Anticrease/End , Condenser , Filter , Tank
lights
5 Start/Pause button
5
Before first use
In order to remove any residues which may
have been produced during production, wipe
the dryer drum with a damp cloth or carry out a
brief drying cycle (ca. 30 min.) with damp
cloths in the machine.
COTTON EXTRA
DRY
www.zanussi.com
Time in
minutes
(about)
140
7 kg
Application/properties
Care mark
Programmes
max. load (weight when dry)
Programme chart
Thorough drying of thick or multi- layered fabrics,
e.g. terry towelling items, bathrobes.
7
Time in
minutes
(about)
max. load (weight when dry)
COTTON STRONG
DRY
130
7 kg
Thorough drying of thick or multi- layered fabrics,
e.g. terry towelling items, bathrobes.
COTTON STORAGE DRY 1)
125
7 kg
Thorough drying of fabrics of even thicknesses, e.g.
terry towelling items, knitwear, towels.
COTTON DAMP 1)
110
7 kg
For thin textiles which are still to be ironed, e.g. knitted items, cotton shirts.
COTTON IRON
DRY 1)
85
7 kg
For thin fabrics which are also to be ironed, e.g. knitwear, cotton shirts.
SYNTHETICS EXTRA DRY
50
3 kg
Thorough drying of thick or multi-layered fabrics,
e.g. pullovers, bedding, table linen.
SYNTHETICS
STORAGE DRY 1)
40
3 kg
For thin fabrics which are not ironed, e.g. easy care
shirts, table linen, baby clothes, socks, lingerie with
bones or wires.
SYNTHETICS IRON
DRY
30
3 kg
For thin fabrics which are also to be ironed, e.g. knitwear, cotton shirts.
JEANS
125
7 kg
For leisure clothing, such as jeans, sweat-shirts,
etc., of different material thicknesses (e.g. at the
neck, cuffs and seams).
Care mark
Programmes
Application/properties
1) In accordance with IEC61121
Programme chart in accordance with
IEC61121
The appliance should be tested based on time
controlled programmes.
Sorting and preparing laundry
Sorting laundry
• Sort by fabric type:
– Cotton/linen for programmes in COTTONS programme group.
– Mixtures and synthetics for programmes in
SYNTHETICS programme group.
8
• Sort by care label: The care labels mean:
Drying in the tumble dryer possible in
principle
Drying at normal temperature
www.zanussi.com
Drying at reduced temperature
Drying in the tumble dryer not possible
Important! Do not overload the appliance.
Observe max. loading volume.
Laundry weights
Important! Do not place in the appliance any
wet laundry which is not specified on the care
label as being suitable for tumble-drying.
This appliance can be used for all wet laundry
items which are labelled as suitable for tumbledrying.
• Do not dry new, coloured textiles together
with light-coloured laundry items. Textile colours may bleed.
• Do not dry cotton jersey and knitwear with
the EXTRA DRY programme. Items may
shrink!
Preparing laundry
• To avoid laundry becoming tangled: close
zips, button up duvet covers and tie loose
ties or ribbons (e.g. of aprons).
• Empty pockets. Remove metal items (paper
clips, safety pins, etc).
• Turn items with double-layered fabrics inside
out (e.g. with cotton-lined anoraks, the cotton layer should be outermost). These fabrics will then dry better.
Type of laundry
Weight
Bathrobe
1200 g
Napkin
100 g
Quilt cover
700 g
Sheet
500 g
Pillow case
200 g
Tablecloth
250 g
Towelling towel
200 g
Tea cloth
100 g
Night dress
200 g
Ladies' briefs
100 g
Man's work shirt
600 g
Man's work shirt
200 g
Man's pyjamas
500 g
Blouse
100 g
Men's underpants
100 g
Daily use
Switching machine on
Turn the programme selector to any programme. The machine switches on.
gentle drying with reduced heat of sensitive fabrics
and temperature-sensitive textiles (e.g. acrylic, viscose) marked on care label with:
Operating
COTTONS SYNTHETICS
type of laundry - selection for time controlled programmes
Starting the programme
Press the Start/Pause button.
Drying options
DELICATE
www.zanussi.com
Changing programme
To change a programme which has been selected by mistake once the programme has
started, first turn the programme selector to
off and then set the programme again.
9
Drying cycle complete / removing laundry
Once the drying cycle is complete, the LED
Anti-crease/End is on as well as warning
LED's: Filter and Tank. If the Buzzer button
has been pressed, an acoustic signal sounds
intermittently for about one minute. Remove the
laundry:
1. Open door.
2. Remove visible fluff from the fluff filters. It
is best to use a damp hand for this purpose. (see chapter: Maintenance and
cleaning)
3. Remove laundry.
4.
Turn the programme selector to
off.
Important! after each drying cycle:
- clean the fluff filters
- drain the water reservoir
(see chapter: Maintenance and cleaning)
5.
Close the door.
The drying cycles are automatically followed by an anti-crease phase which lasts
around 30 minutes. The drum rotates at intervals during this phase to protect the laundry
from creases. The laundry can be removed at
any time during the anti-crease phase.
Cleaning and maintenance
Cleaning fluff filters
The filters collect all the fluff which accumulates during drying. To ensure that the dryer
works perfectly, the fluff filters (fine filters and
fluff filters) must be cleaned after each drying
cycle.
II
I
1
2
3
4
5
6
7
I
Caution! Never operate the dryer without
fluff filters or with damaged or blocked
fluff filters.
II
Clean the door seal
Wipe the door seal with a damp cloth immediately after the drying cycle has finished.
Emptying the water reservoir
Empty the water reservoir after every drying cycle.
10
www.zanussi.com
• Do not use sharp objects to clean.
6
7
Cleaning the drum
Caution! The condensed water is not
suitable for drinking or for preparing
foodstuffs.
If the programme has been interrupted as
a result of the water reservoir being full:
Press the Start/Pause button to continue the
drying cycle.
Cleaning condenser
Caution! Do not use abrasives or steel
wool to clean the drum.
Lime in the water or cleaning agents may
form a barely visible lining on the inside of
the drum. The degree to which the laundry has
been dried is then no longer detected reliably.
The laundry is damper than expected when removed from the appliance.
Use a standard domestic cleaner (e.g. vinegarbased cleaner) to wipe down the inside of the
drum and drum ribs.
Clean control panel and housing
Caution! Do not use furniture cleaners or
aggressive cleaning agents to clean the
machine.
Important!
• Never operate the dryer without condenser.
• Clogged condenser cause higher energy
consumption (drying cycle elongation) and
dryer damage.
Use a damp cloth to wipe down the control
panel and housing.
What to do if ...
Troubleshooting by yourself
Problem1)
Dryer does not
work.
Unsatisfactory
drying results.
Possible cause
Remedy
Dryer not connected to mains supply.
Plug in at mains socket. Check fuse in fuse
box (domestic installation).
Loading door opened.
Close loading door
The START PAUSE button not pressed.
Press the START PAUSE button.
Incorrect programme set.
Set suitable programme. 2)
Fluff filters clogged.
Clean fluff filters. 3)
Heat exchanger clogged.
Clean heat exchanger. 3)
www.zanussi.com
11
Max. loading exceeded.
Respect max. loading volume.
Covered ventilation grill.
Uncover ventilation grill in base area.
Residue inside the drum.
Clean the drum inside.
To little free space around the appliance
Ensure min. 5cm free space around the appliance
Loading door
does not close
Filters not locked in place.
Install fine filter and/or snap course filter into place.
Programme inactive
Full water reservoir.
Empty water reservoir3) , press START
PAUSE button.
Drying cycle to
short
Small laundry volume./Too dry laundry for
selected programme.
Select time programme or higher drying level (e.g. EXTRA DRY ).
Fluff filters clogged.
Clean fluff filters.
To high loading volume.
Respect max. loading volume.
Laundry insufficiently spun.
Spun adequately the laundry.
Particularly high room temperature - no machine fault.
Lower the room temperature if possible.
Drying cycle to
long 4)
1) Switch the dryer off. Set programme/time. Press the START PAUSE button.
2) follow program recommendation - see Programme overview chapter
3) see Care and cleaningchapter
4) Note: After around 5 hours the drying cycle ends automatically (see Drying cycle complete section).
Technical data
Dimensions (mm)
Width / Height / Depth
85 x 60 x 58 cm
Max. depth
(with the appliance door open)
1090 mm
Max. width
(with the appliance door open)
950 mm
Electrical connection
Voltage
230-240 V
Frequency
50 Hz
Fuse
13 A
Total power
2350 W
Drum volume
108 l
Weight of the appliance
37 kg
Laundry: max. weight
7 kg
Type of use
Household
Ambient temperature
Energy consumption 1)
Min.
5 °C
Max.
35 °C
kWh/cycle
4,70 kWh
Annual energy consumption 2)
552 kWh
Energy efficiency class
C
12
www.zanussi.com
Power consumption
Left-on mode
0W
Off-mode
0W
1) With reference to EN 61121. 7 kg of cotton and a spin speed at 1000 rpm.
2) Energy consumption per year in kWh, based on 160 drying cycles of the standard cotton programme at full
and partial load, and the consumption of the low-power modes. Actual energy consumption per cycle will
depend on how the appliance is used (REGULATION (EU) No 392/2012).
Machine settings
BUZZER permanent off
1. Turn the programme selector to any programme.
2.
3.
www.zanussi.com
Press simultaneously the Delicate and
Cotton / Synthetic buttons and hold
down for approx. 5 seconds.
The buzzer is by default always off.
13
14
www.zanussi.com
www.zanussi.com
15
136926410-B-092013
www.zanussi.com/shop
Download PDF

advertising