ZANUSSI ZBX626SS User Manual

Combi-grill
User instructions
7ВХ 626 55
Model no. ZBX 626 SS
Product no. 9496 00611
Serie no.
ZANUSSI
Technical specifications ................. cc... .... 3
Warnings . «citi eee 4-5
Installation . ......... ee. 5-6
Electrical Installation ............................... 7
Maintenance and cleaning ........................... 8
To change the oil ............ iii 8
Useofcontrols ............. inn. 9
Using the deep fat fryer .......................... 10-11
Using the grill .........o_o.-eeereseraoeorranoarerercam. 12
Using the Reset button ............................. 13
Steellid for the fryer ........ 0 44114 0 13
Before calingan engineer ........................... 14
Peace of mind for 24 months ..........aeeea.esoaranos 15
TECHNICAL SPECIFICATIONS
Model name : ZBX 626 SS
Rated input : Grill : 2 X 1000 Watt
Deep fat fryer : 1 x 2000 Watt
Material : Stainless Steel
Grill : Grill top : Cast iron enamelled
Grill briquettes : Lava basalt
Fryer : Cold zone
Draw-off tap with child safety device
Thermostat regulated
Signal Lamps: : 1 - on/off
2 - thermostat
Voltage : 240 М АС
Built-In Measurements : Height : 245 mm.
Width : 270 mm.
Depth : 430 mm.
Product Measurements : Gross/ Net
Height : 340 / 275 mm.
Width 380 / 290 mm.
Depth 610 / 510 mm.
Weight : Gross: 18,0 Kg.
Net : 17,0 Kg.
Gross Volume 0,0788 m*.
Approval : CCA
WARNINGS
It is most important that this
instruction book should be retained
with the appliance for future
reference. Should the appliance be
sold or transferred to another
owner, or should you move house
and leave the appliance in order that
the new owner can get to know the
functioning of the appliance and the
relevant warnings.
These warnings have been provided
in the interest of safety. You MUST
read them carefully before installing
or using the appliance.
m This appliance is designed to be
operated by adults only. Children
should not be allowed to tamper
with the controls or play with or
near the product.
E Any installation work must be
undertaken by a qualified electrician
or compentent person.
mM lt is dangerous to alter the
specifications or to attempt to
modify this product in any way.
E This product will become very hot
with use, and will retain heat for a
long period of time. You must
therefore take care when using the
appliance, supervise children at all
times and do NOT allow them to
touch the combi-grill surface or be
in the vicinity of the appliance until
it has cooled after use.
Eu This product is designed for
domestic use only and should not
be used in a commercial
environment.
Always ensure that all control knobs
are in the ” OFF” position when not
in use.
Take great care when heating fats
and oils as they will ignite if they
become too hot.
For hygiene and safety reasons this
appliance should be kept clean at
all times. A build-up of fats or other
foodstuffs could result in a fire.
This product has been designed for
cooking edible foodstuffs only, and
must not be used for any other
purpose.
Only clean the appliance in
accordance with the instructions
given in this book.
Always isolate the product from the
mains electricity supply before any
maintenance or cleaning work is
carried out.
Ensure that all packaging, both
inside and outside the appliance is
removed before the appliance is
used.
Always remove the handle from the
frying basket after use and before
using the grill.
Care should be taken when moving
the grill elements into the correct
position for deep fat frying.
DO NOT USE the grill and deep fat
fryer simultaneously.
H After cleaning, ensure the drain
channel is not blocked with any
food particles and the lever has
been returned to the “closed”
position.
E Do not hang towels or dishcloths
from the appliance as they are a
safety hazard.
E NEVER pour water into hot oil.
placing a baking tray or fire blanket
over the area. DO NOT USE
WATER.
Eu Under no circumstances should you
attempt to repair the machine
yourself. Repairs carried out by
inexperienced persons may cause
injury or serious malfunctioning.
Contact your local Zanussi Service
Centre. Always insist on genuine
spare parts.
m If the oil ignites, turn off the cooker
hood, and extinguish the fire by
INSTALLATION
EE E TA
LAA
DN NON NOOO
à Minimum
shelf
be 245 mm +
take at least 4
litres.
V7 72272
distance to any
underneath shall
room enough for
a bowl that can
The unit may be mounted in any kitchen
bench which has a thickness of 28-40
mm.
Fixing
Unscrew the fixing brackets just enough
for them to be turned underneath the
bench.
Fasten the brackets to the bench with a
screwdriver.
Cut-out-Measurements
Recess measurements for installation of
several DOMINO appliances:
One rectangular hole should be sawn
out for the hob combination chosen.
The depth of the the cut-out (front to
back) for any unit is 490 mm.
The length of the hole = sum of all
units’ externally measured length, less
20 mm.
Grill 290 mm. +
Cooker hood 145 mm. +
2 palte ceramic hob 290 mm. +
2 burner gas hob 290 mm.
(= 1105 mm.)
LESS 20 mm. = 995 mm.
The units’ total external lengths:
Cokker hood 145 mm.
Grill 290 mm.
2 plate hob ”
2 plate ceramic hob ”
2 burner gas hob ”
4 plate hob 580 mm
4 plate ceramic hob
4 burner gas hob
Minimum distance
to wall: 150 mm. ce
Reinforcement beams
Mounting Of Reinforcement
Beams
À reinforcement beam, with supporting
flanges at each end is included with
each 145 mm. and 290 mm. unit.
For unit combinations, a reinforcement
beam must be used between each unit.
It is not necessary to attach the
reinforcement beam to the worktop, as it
is held in place by a specieally
designed moulding, which is
incorporated in the unit's flanges.
Minimum distance to
wall (non-flammable
`` material): 50 mm.
ELECTRICAL INSTALLATION
dE Earth
Live Neutral
Connections to the unit:
1 phase - neutral - ground
Type of table, min. 1.0 mm? HO5RN-F
The electrical installation must only be
made by a certified electrician.
The electrical installation must be made
according to prevailing regulations for
heavy current installations and comply
with local public regulations.
No attempt must be made to tamper
with the electrical parts of the unit.
The Combi-Grill is supplied with a 1.5
metre power cable with plug and is to
be connected to an external switch with
a contact separation of at least 3 mm in
each pole
The guarantee is annulled in the
case of faulty installation or if the
electrical parts have been tampered
with.
MAINTENANCE AND CLEANING
The grill grate must be cleaned after
every use. The grill grate can be
cleaned with a normal detergent. Any
burnt-on fat should be removed before
placing in the dishwasher.
The grill briquette box can also be
cleaned with a detergent, or in a
dishwasher.
The grill briquettes will absorb and burn
fat during grilling. If the briguettes
become very badly soiled, they may be
boiled in water with a little household
detergent. The pebbles may also be
replaced, and can be purchased from
your local Zanussi Service Centre.
Clean the heating elements with a
household cleaner.
The frying container can be cleaned
with warm water and detergent.
The frying basket can be cleaned in a
dishwasher or in normal washing up
detergent.
The surface of the Combi-grill should be
cleaned with a moist cloth.
TO CHANGE THE OIL
Closed
D
E E de CCR
DO IC
The oil is tapped through the bottom
lever underneath the frying container.
Before draining the oil, remove the
safety shield by pressing the sides and
pulling downwards. The drain cock can
now be turned to the vertical position for
draining the oil.
Important: Always replace the safety
shield after draining.
NB: The oil should only be emptied
when cold. Before emptying the
container, a suitable bowl should be
found which will hold all the oil. After
8
emptying the container, the lever should
be closed, and the handle removed for
safety reasons.
Always see to it that the fryer is
thoroughly cleaned after use as remains
of food may clog the tapping hole.
During cleaning
Close the lever and wash the container
in water. Place a bucket underneath the
lever and empty the container.
Dry thoroughly before refilling with
oil.
USE OF CONTROLS
Pilot lamp for the grill
Pilot lamp for the fryer
Operation of the grill
The grilling temperature is fully
adjustable.
Control for operation of the
grill function
0 The grill is switched off
1 The grill is on Minimum setting
12 The grill is on Maximum setting
Operation of the fryer
The temperature is regulated by a
thermostat and may be set between
120°C and 190°C.
[| Control for operating the fryer
Pilot lamp for the fryer
The pilot lamp will light when the fryer is
switched on and will go out when the set
temperature is achieved. The light will
cycle on and off during cooking.
USING THE DEEP FAT FRYER
Frying
Make sure the heating elements is in
the bottom. Oil is poured into the frying
container.
The ”Min.” mark must be observed.
DO NOT OVERFILL.
This corresponds to an oil content of 1.5
litres. The Maximum amount of oil in the
container is 3.5 litres, which
corresponds to the step in the frying
container. The grill elements are turned
down and the fryer switched on to the
required temperature. For maximum
heat and most frying operations, turn up
to 190°C. Adjust to a lower temperature
as required, depending on the thickness
of the food.
Tips on frying
Set the required temperature and after a
while the correct temperature of the oil
is reached (the pilot lamp for the fryer
switches off).
Lower the frying basket containing the
food into the oil.
NB: Remember that moist foodstuff
should be dried before they are put
in (i.e. seafood, vegetables, fruit and
fish). Do not overfill the basket.
10
After frying, the basket should be lifted
out and shaken carefully to remove
excess oil (the basket may be hung on
the fixing bracket).
In the chart, the approximate times are
given for frying, which may serve as a
guide. The timing may depend on the
finished appearance and personal taste.
If you wish to fry large amounts of food
at the same time, it is best to remove
the basket only after 1-2 minutes so that
the oil may quickly reach the correct
temperature again.
The fried food will become more crispy
this way. If it is not crispy enough (even
if the temperature is correctly set), or if
the oil changes colour to light brown,
the oil should be changed
Frying
1. Preparing the food
Seal the food by coating with fluor, egg
and bread crumbs or batter. Do not use
a basket with batter coated foods as
they will stick.
2. Cooking the food
Lower the food gently into the oil. Do
not add too much food at once or the
temperature of the oil will be reduced
and may result in soggy, greasy food.
Turn the food if necessary; doughnuts
float to the surface so will not brown on
the upperside if not turned. Once
cooked, drain the food on absorbent
paper.
3. Double frying chips
Double frying will ensure good chips.
First fry the chips for a few minutes at
170°C/340°F to seal the outside.
Remove the chips from the oil. Increase
the temperature of the oil to
190°C/375°F to finish cooking and
brown the chips.
Chips may be kept for serveral hours
after the first frying before finishing off
with the second frying.
NB: Make sure that no naked flames
are near the fryer. The oil is hot and
ignites easily. Remember to set the
adjustment knob back to "0” once the
frying is finished.
Foods Quantity Temperature Time
French fries, deep frozen 500 9 180°С 4-6 mins.
French fries, deep frozen 100 g 180°C 8-10 mins.
French fries, fresh 500 9 first 170°C 4-6 mins.
then 180°C 2-4 mins.
Potato chips, fresh 500 д 180°С 3-5 mins.
Potato croquettes, deep frozen 500 g first 170°C 1-2 mins.
then 180°C 3-5 mins.
Chicken joints 2 х 250 д 180°С 8-10 mins.
Turkey steaks 2 x 250 g 180°C 3-5 mins.
Fish fingers, deep frozen 300 g 180°C 4-6 mins.
Fillet of plaice, deep frozen 300 g 170°C 3-5 mins.
Calamari rings, deep frozen 300 g 170°C 3-5 mins.
Breaded veal or pork escollops 200 g 180°C 5-7 mins.
Camembert 4 x + pkt 180°C 2-3 mins.
Parsley 180°C 2-3 mins.
Dumplings 4 170°C 6-8 mins.
Jam doughnuts 4 180°C 6-8 mins.
Banana fritters 2 180°C 3-4 mins.
Vegetable fritters 500 g 180°C 8-10 mins.
11
USING THE GRILL
Operation of the grill
To operate the grill, turn the grill control
knob to the highest setting no 12, then
turn to the required temperature.
The highest number represents the
hottest setting and the lowest, the
coolest setting.
When grilling, the grill grate must
always be in place.
Pre-heat the grill element for approx. 5
mins. on 12. This will result in the grill
briquettes becoming hot. Turn the
control knob to the required setting,
remember the food will obtain heat from
the briquettes.
Spices may be sprinkled directly onto
the meat while it is on the grill.
NOTE: Oil should be applied to food
before it is placed on the grill, to avoid
any unnecessary splashing of excess oil
onto the briquettes below.
Smoke will occur when fat drips onto
the briquettes.
WARNING
The grill briquette box should
always be placed in position and the
grill grate placed on top before the
grill unit is switched on.
Foods Setting/level Cooking Time
Sausages 10 mins.
Lamp cutles 10 mins.
Hamburgers 16, turn every 4 mins.
Spare Ribs 12, after 8 mins. level 9 50, turn every 8 mins.
T-bone steak 10-12 10-12 mins.
Fish in oil 10 mins.
Chicken pieces 10-12 40, turn every 4 mins.
12
USING THE RESET BUTTON
In case of over-heating of the oil, the
built-in thermostat will switch off the
fryer. The thermostat can be reset by
pressing the small blocking tag found to
the right, underneath the fryer, before
the fryer may be used again.
If the overheating thermostat is set off
frequently during use, contact your local
Zanussi Service Force.
RESET
STEELLID FOR THE FRYER
When using the combi-grill as a fryer,
you can place the steellid on top of the
frying container, it will shorten the
preeheatingtime.
13
BEFORE CALLING AN ENGINEER
If the Combi-grill does not work
Check to see whether a fuse has blown.
Check to see whether the relay switch is
off.
If the problem is not with the fuse or the
relay, do not attempt to carry out any
repairs yourself. Instead, contact your
local Zanussi Service Centre whose
telephone number can be found in the
Customer Care Booklet.
Please make sure you give the model
and serial number of the appliance.
Original spare parts can be purchased
from Zanussi Service Centres.
In-guarantee customers should
ensure thar the above checks have
been made as the engineer will
make a charge if the fault is not a
mechanical or electrical breakdown.
Please note that proof of purchase
is required for any in-guarantee
service calls.
14
Service details - adhesive label
When you return your guarantee card to
Zanussi Ltd., you will receive an
” Appliance Guarantee and Maintenance
Record”, together with an adhesive
label containing the telephone number
of your local Zanussi Service Centre.
The label can be adhered to the
machine or adjacent furniture.
PEACE OF MIND FOR 24 MONTHS
Standard guarantee conditions
This guarantee is in addition to your
statutory and other legal rights which
will not be excluded or in any way
diminished by the return of this
guarantee card.
We, Zanussi Ltd., undertake that if,
within twentyfour months of the date of
the purchase, this ZAUNSSI appliance
or any part there of is proved to be
defective by reason only of faulty
workmanship or materials, the company
will, at its option, repair or replace the
same FREE OF ANY CHARGE for
labour, materials or carriage on
condition that:
E The appliance has been correctly
installed and used only on the
electricity supply stated on the
rating plate.
M The appliance has been used for
normal domestic purposes only,
and in accordance with the
manufacturer's operating and
maintenance instructions.
mM The appliance has not been
serviced, maintained, repaired,
taken apart or tampered with by any
person not authorised by us.
All service work under this guarantee
must be undertaken by a Zanussi
Service Centre.
Home visits are made between 8.30am
and 5.30pm Monday to Friday. Visits
may be available outside these hours in
which case a premium will be charged.
Any appliance or defective part replaced
shall become the property of this
company.
Exclusions
This guarantee does not cover:
mM Damage or calls resulting from
transportation improper use or
neglect, the replacement of any
light bulbs or removable parts of
glass or plastic.
® Costs incurred for calls to put right
machines improperly installed or
calls to machines outside the
United Kingdom.
m Appliances found to be in use within
a commercial or similar
environment, plus those which are
the sublect of rental agreements.
E Products of Zanussi manufacture
which are NOT marketed by
Zanussi Lid.
EEC Countries - The standard
guarantee is applicable but subject to
the owner’s responsibility and cost to
ensure the appliance meets the
standards set by the country to which
the product is taken. The Zanussi
Company in the country concerned will
be pleased to advise further. Sight of
your purchase receipt will be required
by them.
15
ZANUSSI
325 87-3590-Rev.2-425